TEST SET, TRANSPONDER SET AN/APM-239A (NSN )

Transcription

1 TECHNICAL MANUAL TM P ORGANIZATIONAL, DIRECT SUPPORT, AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LISTS (INCLUDING DEPOT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS) FOR TEST SET, TRANSPONDER SET AN/APM-239A (NSN ) HEADQUARTERS, DEPARTMENT OF THE ARMY MAY 1977

2

3 *TM P T ECHNICAL M ANUAL HEADQUARTERS DEPARTMENT OF THE ARMY NO P W ASHINGTON. DC, 5 May 1977 ORGANIZATIONAL, DIRECT SUPPORT, AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LISTS (INCLUDING DEPOT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS) FOR TEST SET, TRANSPONDER SET AN/APM-239A (NSN ) Current as of 15 December 1976 REPORTING OF ERRORS You can improve this manual by recommending improvements using DA Form (Test) located in the back of the manual. Simply tear out the self-addressed form, fill it out as shown on the sample, fold it where shown, and drop it in the mail. If there are no blank DA Forms (Test) in the back of your manual, use the standard DA Form 2028 (Recommended Changes to Publications and Blank Forms) and forward to the Commander, US Army Electronics Command, ATTN: DRSELMA-Q, Fort Monmouth, New Jersey In either case a reply will be furnished direct to you. SECTION I H Group SECTION III. Iv. Table of Contents Introduction Repair parts list Test Set, Transponder Set AN/APM-239A Test Set, Transponder Set TS-2681/APM-239A Panel assembly, test set l19067-l Circuit card assembly l Case, Test Set CY-6477/APM-239A Control, Transponder Set C-6280(P)/APX or C-6280A(P)/APX (See TM P for parts) Cable Assembly. Special Purpose. Electrical CX /APM-239A Cable Assembly, Power. Electrical CX /APM-239A Cable Assembly, Special Purpose, Electrical CX /APM-239A Cable Assembly, Special Purpose, Electrical CX /APM-239A Cable Assembly, Special Purpose. Electrical CX /APM-239A Cable Assembly, Special Purpose. Electrical CX /APM-239A Cable Assembly. Radio Frequency CG-3470/APM-239A Cable Assembly, Special Purpose, Electrical CX /APM-239A Cable Assembly, Special Purpose. Electrical CX /APM-239A Special tools list (Not applicable) National stock number and part number index Page Illus. Figure l *This manual supersedes TM P. 2 April 1969.

4

5 TM P SECTION I INTRODUCTION 1. Scope. This manual lists spares and repair parts; special tools; special test, measurement, and diagnostic equipment (TMDE), and other special support equipment required for performance of organizational, direct support, and general support maintenance of the AN/APM-239A. It authorizes the requisitioning and issue of spares and repair parts as indicated by the source and maintenance codes, 2. General This Repair Parts and Special Tools List is divided into the following sections: a. Section II. Repair Parts List. A list of spares and repair parts authorized for use in the performance of maintenance. The list also includes parts which must be removed for replacement of the authorized parts. Parts lists are composed of functional groups in numeric sequence, with the parts in each group listed in figure and item number sequence. b. Section III. Special Tools List, Not applicable. c. Section IV. National Stock Number and Part Number Index. A list, in National item identification number (NUN) sequence, of all National stock numbers (NSN) appearing in the listings, followed by a list, in alphameric sequence, of all part numbers appearing in the listings. National stock numbers and part numbers are cross-referenced to each illustration figure and item number appearance. 3. Explanation of Columns a. Illustration. This column is divided as follows: (1) Figure number. Indicates the figure number of the illustration on which the item is shown. (2) Item number. The number used to identify item called out in the illustration. b. Source, Maintenance, and Recoverability (SMR) Codes. (1) Source code. Source codes indicate the manner of acquiring support items for maintenance, repair or overhaul of end items. Source codes are entered in the first and second positions of the Uniform SMR Code format as follows: Code Definiton PA Item procured and stocked for anticipated or known usage. PD-Support item, excluding support equipment pro- Code Definition cured for initial issue or outfitting and stocked only for subsequent or additional initial issues or outfittings. Not subject to automatic replenishment. XD-A support item that is not stocked. When required, item will be procured through normal supply channels. NOTE Cannibalization or salvage may be used as a source of supply for any items source coded above except those coded XA and aircraft support items as restricted by AR (2) Maintenance code. Maintenance codes are assigned to indicate the levels of maintenance authorized to USE and REPAIR support items. The maintenance codes are entered in the third and fourth positions of the Uniform SMR Code format as follows: (a) The maintenance code entered in the third position will indicate the lowest maintenance level authorized to remove, replace, and use the support item. The maintenance code entered in the third position will indicate one of the following levels of mainte nance: Code ApplicatiouWExphnatum O-Support item is removed, replaced, used at the organizational level. H Support item is removed, replaced, used at the general support level. (b) The maintenance code entered in the fourth position indicates whether the item is to be repaired and identifies the lowest maintenance level with the capability to perform complete repair (i.e., all authorized maintenance functions). This position will contain one of the following maintenance codes: Code Application/Exptanation H The lowest maintenance level capable& complete repair of the support item is the general support level. Z Nonreparable. No repair is authorized (3) Recoverability code. Recoverability codes are assigned to support items to inidicate the disposition action on unserviceable items. The recoverability code is entered in the fifth position of the Uniform SMR Code format as follows. I

6

7

8 TM P Figure 1. Test Set, Transponder Set AN/APM-239A. L

9 SECTION II TM P (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION QTY (A) (B) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART IN NO NO CODE NUMBER NUMBER FSCM USABLE ON CODE U/M UNIT GROUP 00 TEST SET,TRANSPONDER SET AN/APM-239A 1 1 PAOHH TEST SET,TRANSPONDER AN/APM-239A EA PAOZZ PULLER,PRINTED CIRCUIT BOARD EA PAOZZ REMOVAL TOOL,CONNECTOR EA XDHZZ RACK,PRINTED CIRCUIT BOARD EA PAOZZ ADAPTER,TEST MX-8203/APM-239A EA PAOZZ ADAPTER,TEST MX-8207/APM-239A EA PAOZZ ADAPTER,TEST MX-8202/APM-239A EA PAOZZ ADAPTER,TEST MX-8206/APM-239A EA PAOZZ ADAPTER,TEST MX-8205/APM-239A EA PAOZZ ADAPTER,TEST MX-8204/APM-239A EA PAOZZ UG636AU ADAPTER,CONNECTOR EA PAOZZ UG201U ADAPTER,CONNECTOR EA PAOHH CABLE ASSEMBLY,SPECIAL PURPOSE,ELECTRICAL CX-10905/APM-239A EA XDOHH CABLE ASSEMBLY,POWER,ELECTRICAL CX-10926/APM-239A EA PAOHH CABLE ASSEMBLY,SPECIAL PURPOSE,ELECTRICAL CX-10908/APM-239A EA XDOHH CABLE ASSEMBLY,SPECIAL PURPOSE,ELECTRICAL CX-10909/APM-239A EA XDOHH CABLE ASSEMBLY,SPECIAL PURPOSE,ELECTRICAL CX-10907/APM-239A EA XDOHH CABLE ASSEMBLY,SPECIAL PURPOSE,ELECTRICAL CX-10910/APM-239A EA XDOHH CABLE ASSEMBLY,RADIO FREQUENCY CG-3470/APM-239A EA XDOHH CABLE ASSEMBLY,SPECIAL PURPOSE,ELECTRICAL CX-11734/APM-239A EA XDOHH CABLE ASSEMBLY,SPECIAL PURPOSE,ELECTRICAL CX-11735/APM-239A EA 1 5

10 TM1l P Figure 2. 6

11 SECTION II TM P (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION QTY (A) (B) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART IN NO NO CODE NUMBER NUMBER FSCM USABLE ON CODE U/M UNIT 2 1 XDHZZ PLATE,IDENTIFICATION EA XDHZZ CHART,CONTENTS EA PAHHH CASE,TEST SET CY-6477/APM-239A EA XDHZZ 564F KEY,SOCKET HEADSCREW EA PAHHH TEST SET,TRANSPONDER TS-2681/APM-239A EA XDHZZ PLATE,IDENTIFICATION EA PAOZZ F03A250V10A FUSE,CARTRIDGE EA PAOZZ F02A250V1/2A FUSE,CARTRIDGE EA PAOZZ F02A250V2A FUSE,CARTRIDGE EA XDHZZ 332F KEY,SOCKET HEADSCREW EA PDOHH C-6280(P)/APX CONTROL,TRANSPONDER SET OR EA PDOHH C-6280A(P)/APX CONTROL,TRANSPONDER SET EA 1 7

12 TM P 8 Figure 3.

13 SECTION II TM P (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION QTY (A) (B) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART IN NO NO CODE NUMBER NUMBER FSCM USABLE ON CODE U/M UNIT GROUP 01 TEST SET,TRANSPONDER SET TS-2681/APM-239A XDHHH PANEL ASSEMBLY,TEST SET EA PAHZZ JAN1N SEMICONDUCTOR DEVICE,DIODE EA XDHZZ WASHER,NONMETALLIC EA XDHZZ WASHER,NONMETALLIC EA PAHZZ MS TERMINAL,LUG EA XDHZZ MS WASHER,LOCK EA XDHZZ NAS671C NUT,PLAIN,HEXAGON EA XDHZZ MS SCREW,MACHINE EA XDHZZ MS WASHER,FLAT EA PAHZZ REACTOR EA XDHZZ MS WASHER,FLAT EA XDHZZ MS WASHER,LOCK EA XDHZZ MS NUT,PLAIN,HEXAGON EA XDHZZ 191P22492T CAPACITOR,FIXED,PAPER EA PAHZZ TRANSFORMER,POWER,STEP DOWN EA XDHZZ CASE,TEST SET EA PAHZZ TERMINAL,LUG EA PAHZZ MS SCREW,MACHINE EA PAHZZ HP4N CLAMP,LOOP EA PAHZZ HP3N CLAMP,LOOP EA 1 9/(10 BLANK)

14

15 TM P Figure 4. Panel Assembly, Test Set (Sheet 1 of 2). II

16 TM P Figure 4. 12

17 SECTION II TM P (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION QTY (A) (B) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART IN NO NO CODE NUMBER NUMBER FSCM USABLE ON CODE U/M UNIT GROUP 0101 PANEL ASSEMBLY,TEST SET XDHZZ MS SCREW,MACHINE EA XDHZZ MS SCREW,MACHINE EA XDHZZ MS WASHER,LOCK EA XDHZZ MS WASHER,FLAT EA XDHZZ MS SCREW,MACHINE EA PAHZZ CONTACT,ELECTRICAL EA PAHZZ FERRULE,RADIO FREQUENCY EA PAHZZ CONTACT,ELECTRICAL EA PAHZZ CONTACT,ELECTRICAL EA XDHZZ BRASSHT TERMINAL,LUG EA XDHZZ MS WASHER,LOCK EA XDHZZ MS NUT,PLAIN,HEXAGON EA XDHZZ BRASSHT TERMINAL,LUG EA XDHZZ MS NUT,PLAIN,HEXAGON EA XDHZZ AN A BUSHING,CABLE EA XDHZZ AN A BUSHING,CABLE EA PAHZZ MS24266R22B55S CONNECTOR,PLUG,ELECTRICAL EA PAHZZ MS TERMINAL,LUG EA PAHZZ MS TERMINAL,LUG EA PAHZZ MS TERMINAL,LUG EA PAHZZ HP8N CLAMP,LOOP EA XDHZZ MS SCREW,MACHINE EA PAHZZ MS GROMMET,RUBBER EA XDHHH COVER,TEST SET EA PAHZZ HP6N CLAMP,LOOP EA PAHZZ T TERMINAL BOARD EA XDHZZ MS SCREW,MACHINE EA XDHZZ MS WASHER,LOCK EA XDHZZ MS WASHER,FLAT EA XDHZZ MS NUT,PLAIN,HEXAGON EA PAHZZ MS TERMINAL,LUG EA XDHZZ TERMINAL,LUG EA PAHZZ MS TERMINAL,LUG EA PAHZZ CZ24BKF FILTER,RADIO INTERFERENCE EA XDHZZ CHASSIS,ELECTRICAL EQUIPMENT EA XDHZZ CLS NUT,SELF LOCKING EA XDHZZ NAS671C NUT,PLAIN,HEXAGON EA XDHZZ MS WASHER,LOCK EA 1 13

18 SECTION II TM P (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION QTY (A) (B) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART IN NO NO CODE NUMBER NUMBER FSCM USABLE ON CODE U/M UNIT 4 39 XDHZZ MS WASHER,FLAT EA XDHZZ WASHER,NONMETALLIC EA XDHZZ WASHER,NONMETALLIC EA PAHZZ JAN1N2982B SEMICONDUCTOR DEVICE,DIODE EA PAHZZ MS TERMINAL,LUG EA PAHZZ HP3N CLAMP,LOOP EA PAHHH CIRCUIT CARD ASSEMBLY EA PAHZZ SE099E TERMINAL,STUD EA PAHZZ RW68V RESISTOR,FIXED,WIRE WOUND EA PAHZZ CE71C681J CAPACITOR,FIXED,ELECTROLYTIC EA PAHZZ N STRAP,RETAINING EA PAHZZ C3M STRAP,RETAINING EA XDHZZ MS SCREW,MACHINE EA PAHZZ MS CLIP,SPRING,TENSION EA PAHZZ HP9N CLAMP,LOOP EA XDHZZ MS RIVET,TUBULAR EA PAHZZ MS SWITCH,TOGGLE EA PAHZZ UG1094BU CONNECTOR,RECEPTACLE,ELECTRICAL EA XDHZZ TERMINAL,LUG EA PAHZZ MS SWITCH,TOGGLE EA PAHZZ MS25126C SWITCH,TOGGLE EA PAHZZ MS SWITCH,TOGGLE EA PAHZZ SHELL,ELECTRICAL CONNECTOR EA XDHZZ INSERT,ELECTRICAL CONNECTOR EA XDHHH CONNECTOR,RECEPTACLE,ELECTRICAL EA XDHZZ BUSHING,COAXICON EA PAHZZ MS3102A28-21S CONNECTOR,RECEPTACLE,ELECTRICAL EA XDHZZ HANDLE,BOW EA XDHZZ FERRULE,HANDLE EA XDHZZ MS SCREW,MACHINE EA XDHZZ MS WASHER,FLAT EA PAHZZ CONNECTOR,RECEPTACLE,ELECTRICAL EA PAHZZ MS3102A20-27S CONNECTOR,RECEPTACLE,ELECTRICAL EA XDHZZ PLATE,IDENTIFICATION EA PAHZZ MS3102A14S1P CONNECTOR,RECEPTACLE,ELECTRICAL EA XDHHH PANEL,TEST SET EA XDHZZ MS SCREW,MACHINE EA XDHZZ STRIP,RECEPTACLE EA PAHZZ TRANSFORMER,VARIABLE,POWER EA PAHZZ TRANSFORMER,VARIABLE,POWER EA 1 14

19 SECTION II TM P (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION QTY (A) (B) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART IN NO NO CODE NUMBER NUMBER FSCM USABLE ON CODE U/M UNIT 4 79 XDHZZ MS SCREW,MACHINE EA PAHZZ AMMETER EA PAHZZ FERRULE,HANDLE EA PAHZZ MS SWITCH,TOGGLE EA PAHZZ VOLTMETER EA XDHZZ MS SCREW,MACHINE EA PAHZZ HANDLE,BOW EA PAHZZ C8SS SCREW,EXTERNALLY RELIEVED BODY EA XDHZZ 6312CSS NUT,PLAIN,CLINCH EA PAHZZ PAM33MG VA CIRCUIT BREAKER EA 1 C400CPS LH74LC13WT LIGHT,INDICATOR EA PAOZZ MS25252NE2D LAMP,GLOW EA PAOZZ F03A250V10A FUSE,CARTRIDGE EA PAHZZ FHN20G FUSEHOLDER EA CH74LC13RN LENS,INDICATOR LIGHT EA PAOZZ F02A250V1/2D FUSE,CARTRIDGE EA PAOZZ F02A250V2A FUSE,CARTRIDGE EA PAHZZ MS25125DL SWITCH,TOGGLE EA PAOZZ MS K4B KNOB EA PAOZZ MS LIGHT,INDICATOR EA PAHZZ SWITCH,ROTARY EA 1 15

20 TM P Figure 5. Circuit Card Assmnbly

21 SECTION II TM P (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION QTY (A) (B) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART IN NO NO CODE NUMBER NUMBER FSCM USABLE ON CODE U/M UNIT GROUP CIRCUIT CARD ASSEMBLY PAHZZ RC20GF302J RESISTOR,FIXED,COMPOSITION EA XDHZZ ST SPACER,SLEEVE EA XDHZZ TERMINAL,STUD EA PAHZZ RC20GF114J RESISTOR,FIXED,COMPOSITION EA PAHZZ STRAP,RUBBER EA XDHZZ CS13BG226K CAPACITOR,FIXED,ELECTROLYTIC EA PAHZZ JAN2N2219A TRANSISTOR EA PAHZZ RC20GF152J RESISTOR,FIXED,COMPOSITION EA PAHZZ JAN1N SEMICONDUCTOR DEVICE,DIODE EA PAHZZ RC20GF221J RESISTOR,FIXED,COMPOSITION EA PAHZZ RC20GF910J RESISTOR,FIXED,COMPOSITION EA PAHZZ JAN1N SEMICONDUCTOR DEVICE,DIODE EA PAHZZ JAN1N486B SEMICONDUCTOR DEVICE,DIODE EA PAHZZ RW67G RESISTOR,FIXED,WIRE WOUND EA XDHZZ RN70C1722D RESISTOR,FIXED,FILM EA PAHZZ CS13BF336K CAPACITOR,FIXED,ELECTROLYTIC EA PAHZZ RC32G202JR RESISTOR,FIXED,COMPOSITION EA PAHZZ JAN1N754A SEMICONDUCTOR DEVICE,DIODE EA PAHZZ RC20GF471J RESISTOR,FIXED,COMPOSITION EA PAHZZ CS13BC475K CAPACITOR,FIXED,ELECTROLYTIC EA 1 17

22 TM P Figure 6. Case, Test Set C7-6477/APM-239A

23 TMll P Figure 7. Cable Assembly, Special Purpose, Electrical CX-10905/APM-239A. 19

24 TM1l P Figure 8. Cable Assembly, Power, Electrical CX-10926/APM-239A. 20

25 TM P Figure 9. Cable Assembly, Special Purpose, Electrical CX-10908/APM-239A. 21

26 TM P Figure 10. Cable Assembly, Special Purpose, Electrical CX-10909/APM-239A. Group

27 TM P Figure 11. Cable Assembly, Special Purpose, Electrical CX-10907/APM-239A. 23

28 TM P Figure 12. Cable Assembly, Special Purpose, Electrical CX-10910/APM-239A. 24

29 TM1l ~P Figure 13. Cable Assembly, Radio Frequency CG-3470/APM-239A. 25

30 TM P Figure 14. Cable Assembly, Special Purpose, Electrical CX-11734/APM-239A. 26

31 TM P Figure 15. Cable Assembly, Special Purpose, Electrical CX-11735/APM-239A. 27

32 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX TM P NOTE: LATEST NATIONAL STOCK NUMBER AND PART NUMBER ASSIGNMENTS ARE INCLUDED AT END OF INDEX FIGURE ITEM FIGURE ITEM STOCK NUMBER NO NO STOCK NUMBER NO NO

33 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX TM P FIGURE ITEM FIGURE ITEM STOCK NUMBER NO NO STOCK NUMBER NO NO PART FIG ITEM PART FIG ITEM NUMBER FSCM NO NO NUMBER FSCM NO NO AN A MS AN A MS AN A MS AN A MS AN A MS AN A MS AN A MS AN A MS24265R22B55P AN A MS24266R22B55S AN A MS2466R12B12S AN A MS AN3420-8A MS MS CH74LC13RN MS CLS MS CS13BC475K MS CS13BF336K MS25125D CS13BG226K MS25126C CZ24BKF MS25252NE2D C3M MS CBMF17W2S MS CBMF17W2S MS A CBM17W2P MS3057-6A DBM17W2P MS3102A14S1P CB MS3102A20-27S DB MS3102A28-21S CM MS3106A14S-1S DM MS3106A20-27P DM MS3116F18-32S DM MS DM MS DM MS DM MS DM MS DPD MS DPD45-33S1L MS DPJ59C10-34SB MS FHN20G MS F02A250V1/2A MS F02A250V1/2D MS F02A250V2A MS F02A250V2A MS F03A250V10A MS F03A250V10A MS HP3N MS HP3N MS HP4N MS HP6N MS HP8N MS HP9N MS JAN1N MS JAN1N2982B MS JAN1N MS JAN1N486B MS JAN1N754A MS JAN1N MS JAN2N2219A MS LH74LC13WT MS MS MS MS MS MS MS MS MS MS MS MS MS MS MS

34 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX TM P PART FIG ITEM PART FIG ITEM NUMBER FSCM NO NO NUMBER FSCM NO NO MS K4B NAS671C NAS671C NAS671C NAS671C N PAM33MG VAC400CPS RC20GF114J F RC20GF152J RC20GF221J RC20GF302J RC20GF471J SS RC20GF910J CSS RN70C RW67G RW68V SE099E ST S S UG1094BU UG201U UG636AU ZSP BRASSHT BRASSHT P22492T TB F

35 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX TM P LATEST NATIONAL STOCK NUMBER ASSIGNMENTS STOCK NUMBER FIGURE ITEM NO. NO LATEST PART NUMBER ASSIGNMENTS PART NUMBER FSCM FIG. ITEM NO. NO. CE71C681J C-6280(P)/APX C-6280A(P)/APX RC32G202JR /(32 BLANK)

36 TM 1l P By Order of the Secretary of the Army: Official: PAUL T. SMITH Major General, United States Army The Adjutant General BERNARD W. ROGERS General. United States Army Chief of Staff DISTRIBUTION: To be distributed in accordance with DA Form 12-36A, Organizational avionics test equipment literature requirements for AN/APM-239A.,, * U.S. GOVERNMENT PRINTING OFFICE : (1333)

37

38

39

40 This fine document... Was brought to you by me: Liberated Manuals -- free army and government manuals Why do I do it? I am tired of sleazy CD-ROM sellers, who take publicly available information, slap watermarks and other junk on it, and sell it. Those masters of search engine manipulation make sure that their sites that sell free information, come up first in search engines. They did not create it... They did not even scan it... Why should they get your money? Why are not letting you give those free manuals to your friends? I am setting this document FREE. This document was made by the US Government and is NOT protected by Copyright. Feel free to share, republish, sell and so on. I am not asking you for donations, fees or handouts. If you can, please provide a link to liberatedmanuals.com, so that free manuals come up first in search engines: <A HREF= Military and Government Manuals</A> Sincerely Igor Chudov Chicago Machinery Movers