TECHNICAL MANUAL UNIT, DIRECT SUPPORT, AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LIST

Transcription

1 TM P TECHNICAL MANUAL UNIT, DIRECT SUPPORT, AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LIST TRUCK, FORKLIFT, CLEAN BURN DIESEL, FRONT-LOADING, 4000 LB. CAPACITY, M483 CLARK MODEL GPX 25E DIESEL NSN Approved for public release; distribution is unlimited. HEADQUARTERS, DEPARTMENT OF THE ARMY MAY 1996

2 TM P TECHNICAL MANUAL HEADQUARTERS DEPARTMENT OF THE ARMY TM P Washington DC, 1 May 1996 TECHNICAL MANUAL UNIT, DIRECT SUPPORT, REPAIR PARTS AND SPECIAL TOOLS LIST TRUCK, FORKLIFT, CLEAN BURN DIESEL, FRONT-LOADING, 4000 LB. CAPACITY, M483 CLARK MODEL GPX 25E DIESEL NSN Current as of 1 May 1996 Approved for public release; distribution is unlimited. REPORTING ERRORS AND RECOMMENDING IMPROVEMENTS You can help improve. If you find any mistakes or if you know of a way to improve the procedures, please let us know. M Mail your letter, DA Form 2028 (Recommended Changes to Publications and Blank Forms), or DA Form located in the back of this manual direct to: Commander, U.S. Army Tankautomotive and Armaments Command, ATTN: AMSTA-IM-OPIT, Warren, MI A reply will be furnished to you. You may also provide DA Form information to TACOM via datafax or . TACOM s datafax number for AMSTA-IM-OPIT is: (810) and the address is: amsta-immaa@cc.tacom.army.mil TABLE OF CONTENTS Section I. INTRODUCTION... 1 Page Illus/ Figure Section II. REPAIR PARTS LIST Group 01 Engine 0100 Engine Assembly Engine Mounting Crankcase Head Assembly Cylinder Block Assembly Crankshaft and Front Drive Assembly Engine Balancer Assembly Flywheel Assembly End Plate and Starter Adapter Installation Piston and Connecting Rod i

3 TM P Page Illus/ Figure 0105 Valves and Crankcase Cover Timing Gear Cover Oil Sampling Valve Oil Filter and Dipstick Oil Pan and Pump Intake and Exhaust Manifold Group 03 Group 04 Group 05 Group 06 Group 07 Fuel System 0301 Fuel Injection System Fuel Line Installation Fuel Injection Pump Assembly Engine Fuel Lines and Fittings Air Cleaner Installation Air Cleaner Assembly Fuel Tank and Filler Fuel Water Separator Accelerator Linkage Installation Exhaust System 0401 Muffler and Tall Pipe Cooling System 0501 Cooling System Water Pump Assembly Fan and Fan Belt Electrical System 0601 Alternator Mounting Alternator Assembly Starter Assembly Instrument Panel Assembly Directional Control Installation Stop and Tail Light Installation Stop and Tall Light Assembly Pressure Switch and Tall Light Bracket Flood Light Assembly Sending Unit and Warning Switches Horn Installation Battery Installation Chassis Wiring Harness Engine Wiring Installation Transmission 0700 Transaxle Frame Mounting Transaxle Differential Drive Axle Bearing Carrier Torque Converter Transaxle Mounting Transmission Clutches Transmission Housing Transaxle Pinion and Ring Gear Transaxle Pump and Oil Filter Assemblies Transmission Control Valve Assembly Transmission Cooling Lines ii

4 TM P Group 11 Group 12 Group 13 Group 14 Group 15 Group 18 Group 22 Group 24 Page Illus/ Figure Rear Axle 1100 Steering Axle Installation Steering Axle Assembly Brakes 1201 Parking Brake and Linkage Brake Assembly Brake Assembly, Drive Axle Brake Lines and Fittings Brake Pedal and Linkage Wheels and Tracks 1313 Wheel Assembly, Steering Wheel Assembly, Drive Steering 1401 Steering System Assembly Steering Pump Assembly Steering Column Assembly Power Steering Cylinder Assembly Power Steering Lines and Fittings Frame, Towing Attachments, and Drawbars 1501 Frame Assembly Lifting Eyes and Tiedown Installation Counterweight Installation Body, Hood, and Hull 1801 Drivers Overhead Guard Sheet Metal Assembly Insulation Panels Installation Floor Plates Installation Seat Installation Seat Assembly Body Chassis or Hull, and Accessory Items 2201 Nameplates and Decals Hydraulic Lift Components 2401 Hydraulic Pump Mounting Hydraulic Pump Assembly Main Linkage Control Valve Mounting Three Spool Valve Cartridge Main Valve Assembly Valves and Levers Tilt Cylinder Mounting Tilt Cylinder Assembly Carnage and Components Primary Cylinder Assembly Side Shifter Hoses, Kissen Kit Side Shifter Cylinder Side Shifter Assembly Load Back Rest Installation Upright Mounting Upright Chain Assembly Upright Assembly Final Cylinder Assembly iii

5 TM P Page Illus/ Figure Group 94 Section III. Section IV Upright Lines and Fittings Hydraulic Tank Assembly Single Auxiliary Valve Kit Upright Hose Installation Cowl Plumbing Assembly Hydraulic Lines Installation Hydraulic Filter Assembly Tilt Cylinder Lines and Fittings Repair Kits 9401 Repair Kits...KITS-1 Special Tools List 2604 Special Tools Cross Reference Index National Stock Number Index...I- Part Number Index...I- Figure and Item Number Index...I- IV

6 TM P UNIT, DIRECT SUPPORT, AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LIST Section I. INTRODUCTION 1. SCOPE. I This RPSTL lists and authorizes spares and repair parts; special tools, special test, measurement, and diagnostic equipment CTMDE), and other special support equipment required for performance of Unit, Direct Support, and General Support Maintenance of the M483 4K Forklift Truck It authorizes the requisitioning, issue, and disposition of spares, repair parts and special tools as indicated by the source, maintenance, and recoverability (SMR) code. 2. GENERAL. In addition to Section I, Introduction, this Repair Parts and Special Tools List is divided into the following sections: a. Section II. Repair Parts List. A list of spares and repair parts authorized by this RPSTL for use in the performance of maintenance The list also includes parts which must be removed for replacement of the authorized parts. Parts Lists are composed of functional groups in ascending alphanumeric sequence, with the parts in each group listed in ascending figure and item number sequence Bulk materials are listed by item name in FIG BULK at the end of the section. Repair parts kits or sets are listed separately in their own functional group within Section II Repair parts for repairable special tools are also listed In the section. b. Section Ill. Special Tools List. A list of special tools, special TMDE, and other special support equipment authorized by this RPSTL (as indicated by Basis of Issue (BOI) information in DESCRIPTION AND USABLE ON CODE (UOC) column) for the performance of maintenance. c. Section IV. Cross-Reference Indexes. A list, in National item identification number (NIIN) sequence, of all National stock numbered items appearing in the listings, followed by a list in alphanumeric sequence of all part numbers appearing in the listings National stock numbers and part numbers are cross-referenced to each Illustration figure and item number appearance. The figure and item number index lists figure and item numbers in alphanumeric sequence and cross-references NSN, CAGEC, and part numbers. 3. EXPLANATION OF COLUMNS (SECTION II). a. Item No. (Column (1)). Indicates the number used to Identify items called out in the illustration b. SMR Code (Column (2)). The Source, Maintenance, and Recoverability (SMR) code is a 5-position code containing supply/requisitioning information, maintenance category authorization criteria, and disposition instruction, as shown m the following breakout: 1

7 TM P 3. EXPLANATION OF COLUMNS (SECTION II) (CONT). * Complete Repair Maintenance capacity, capability, and authority to perform all corrective maintenance tasks for the "Repair" function In a use/user environment in order to restore serviceability to a failed item. (1) Source Code The source code tells you how to get an item needed for maintenance, repair or overhaul of an end item/equipment Explanations of source codes follows. Code Explanation Stocked items; use the applicable NSN to request/requisition items with these source codes. They are authorized to the category indicated by the code entered in the 3 rd position of the SMR code. ** NOTE Items coded PC are subject to deterioration Items with these codes are not to be requested/requisitioned individually They are part of a kit which is authorized to the maintenance category in the 3rd position of the SMR code The complete kit must be requisitioned and applied. Items with these codes are not to be requested/requisitioned individually They must be made from bulk material which is identified by the part number in the DESCRIPTION AND USABLE ON CODE (UOC) column and listed in the Bulk Material group of the repair parts list in this RPSTL. If the item is authorized to you by the 3rd position of the SMR code, but the source code indicates it is made at a higher level, order the item from the higher level of maintenance. Items with these codes are not to be requested/requisitioned individually The parts that make up the assembled item must be requisitioned or fabricated and assembled at the level of maintenance indicated by the source code If the 3rd position code of the SMR code authorizes you to replace the Item, but the source code indicates it is assembled at a higher level, order the item from the higher level of maintenance. XA- Do not requisition an "XA"- coded item Order its next higher assembly (Also, refer to the NOTE below.) XB- If an XB item is not available from salvage, order it using the CAGEC and part number given. 2

8 TM P 3. EXPLANATION OF COLUMNS (SECTION II) (CONT). XC- XD- Installation drawing, diagram, instruction sheet, field service drawing, that is identified by manufacturer s part number. Item is not stocked Order an "XD"-coded item through normal supply channels using the CAGEC and part number given, if no NSN is available. NOTE Cannibalization or controlled exchange, when authorized, may be used as a source of supply for items with the above source codes, except for those coded "XA". (2) Maintenance Code Maintenance codes tell you the level(s) of maintenance authorized to USE and REPAIR support items. The maintenance codes are entered in the third and fourth positions of the SMR code as follows: (a) maintenance code entered in the third position tells you the lowest maintenance level authorized to remove, replace, and use an item. The maintenance code entered in the third position will indicate authorization to one of the following levels of maintenance. Code Application/Explanation C - Crew or Operator Maintenance done with Unit Maintenance. O - Unit can remove, replace, and use the item. F - Direct Support level can remove, replace, and use the item. H - General Support level can remove, replace, and use the item. L - Specialized Repair Activity can remove, replace, and use the item. D - Depot level can remove, replace, and use the item. (b) The maintenance code entered in the fourth position indicates whether the Item is to be repaired and Identifies the lowest maintenance level with the capability to perform complete repair (i.e., all authorized maintenance functions). (NOTE Some limited repair may be done on the Item at a lower level of maintenance, If authorized by the Maintenance Allocation Chart (MAC) and SMR Codes ). This position will contain on of the following maintenance codes: Code Application/Explanation O - Unit is the lowest level that can do complete repair of the item. F - Direct Support is the lowest level that can do complete repair of the item. H - General Support is the lowest level that can do complete repair of the item. L - Specialized Repair Activity Is the lowest level that can do complete repair of the item. D - Depot level is the lowest level that can do complete repair of the item. Z - Nonreparable. No repair is authorized. 3

9 TM P 3. EXPLANATION OF COLUMNS (SECTION 1) (CONT). B - No repair is authorized (No parts or special tools are authorized for the maintenance of a "B" coded item ) However, the item may be reconditioned by adjusting, lubrication, etc., at the user level. (3) Recoverability Code Recoverability codes are assigned to items to indicate the disposition on unserviceable items The recoverability code is entered in the fifth position of the SMR Code as follows: Code Application/Explanation Z - Nonreparable item. When unserviceable, condemn and dispose of the item at the level of maintenance shown In the 3rd position of the SMR Code. O - Reparable item. When uneconomically reparable, condemn and dispose of the item at Unit level. F - Reparable item. When uneconomically reparable, condemn and dispose of the item at Direct Support level. H - Reparable item When uneconomically reparable, condemn and dispose of the item at General Support level. D - Reparable Item When beyond lower level repair capability, return to Depot Condemnation and disposal of item not authorized at below Depot level. L - Reparable item Condemnation and disposal of item not authorized at Specialized Repair Activity (SRA). A - Item requires special handling or condemnation procedures because of specific reasons (e g, precious metal content, high dollar value, critical material or hazardous material ) Refer to appropriate manuals/directives for specific instructions. c. CAGEC (Column (3)). The Commercial and Government Entity Code (CAGEC) is a 5-digit numeric code which is used to identify the manufacturer, distributor, or Government agency, etc., that supplies the item. d. Part Number (Column (4)). Indicates the primary number used by the manufacturer (individual, company, firm, corporation, or Government activity) which controls the design and characteristics of the item by means of its engineering drawings, specifications standards, and inspection requirements to identify an item or range of items. NOTE When you use a NSN to requisition an Item, the item you receive may have a different part number from the part you ordered. e. Description and Usable on Code (UOC) (Column (5)). This column includes the following information. (1) The Federal item name and, when required, as a minimum description to identify the item. (2) Part number for bulk materials are referenced in this column in the line item entry for the item to be manufactured/fabricated. (3) In the Special Tools List section, the Basis Of Issue (BOI) appears as the last line(s) in the entry for each special tool, special TMDE, and other special support equipment When density of equipment supported exceeds density spread indicated in the BOI, the total authorization is increased proportionately. 4

10 3. EXPLANATION OF COLUMNS (SECTION II) (CONT). TM P (4) The statement "END OF FIGURE" appears just below the last item description m Column 5 for a given figure in Section II f. QTY (Column(6)). The QTY (quantity per figure column) indicates the quantity of the item used the breakout shown on the illustration figure, which is prepared for a functional group, sub functional group, or an assembly. A "V appearing in this column in lieu of a quantity indicates that the quantity is variable and the quantity may vary from application to application. 4. EXPLANATION OF COLUMNS (SECTION IV). a. National Stock Number (NSN) Index. (1) Stock Number column. This column lists the NSN by National Item Identification Number (NIIN) sequence. The NIIN consists of the last nine digits of the NSN, i e. NSN NSN i. ( ) NIIN When using this column to locate an item, ignore the first 4 digits of the NSN However, the complete NSN should be used when ordering Items by stock number (2) FIG column. This column lists the number of the figure where the item is identified/located The figures are in numerical order in Section H. (3) ITEM column. The item number identifies the item associated with the figure listed in the adjacent FIG. column This item is also identified by the NSN listed on the same line. b. Number Index. Part numbers in this index are listed by part number in ascending alphanumeric sequence (i.e., vertical arrangement of letter and number combinations which places the first letter or digit of each group m order A thorough Z, followed by the number 0 through 9 and each following letter or digit in like order). (1) CAGE column. The Commercial and Government Entity Code (CAGEC) is a 5-digit numeric code used to identify the manufacturer, distributor, or Government agency, etc., that supplies the item. (2) PART NUMBER column. Indicates the primary number used by the manufacturer (individual, firm, corporation, or Government activity), which controls the design and characteristics of the item by means of its engineering drawings, specifications and inspection requirements to identify and item or range of items. (3) STOCK NUMBER column. This column lists the NSN for the associated part number and manufacturer identified in the PART NUMBER and CAGEC columns to the left. (4) FIG column. This column lists the number of the figure where the item is identified/located in Sections II and III. (5) ITEM column. This item number is that number assigned to the item as it appears in the figure referenced in the adjacent figure number column. c. Figure and Item Number Index. (1) FIG column. This column lists the number of the figure where the item is identified/located in Sections II and III. 5

11 TM P 4. EXPLANATION OF COLUMNS (SECTION IV) (CONT). (2) ITEM column. This Item number is that number assigned to the item as it appears in the figure referenced in the adjacent figure number column. (3) STOCK NUMBER column. This column lists the NSN for the item. (4) CAGEC column. The Commercial and Government Entity Code (CAGEC) is a 5-digit numeric code used to identify the manufacturer, distributor, or Government agency, etc., that supplies the item. (5) PART NUMBER column. Indicates the primary number used by the manufacturer (individual, company, firm, corporation, or Government activity) which controls the design and characteristics of the item by means of its engineering drawings, specifications standards, and inspection requirements to identify and item or range of items. 5. SPECIAL INFORMATION. a. Usable on Code. The usable on code appears In the lower left corner of the Description column heading. Usable on codes are shown as "UOC... " in the Description Column (justified left) on the last line applicable item description/nomenclature Uncoded Items are applicable to all models Identification of the usable code used in thus publication is: Code GGH Used On Forklift Truck b. Fabrication Instructions. Bulk materials required to manufacture items are listed in the Bulk Material Functional Group of thus RPSTL Part numbers for bulk materials are also referenced in the description column of the line item entry for the item to be manufactured/fabricated Detailed fabrication instructions for items source coded to be manufactured or fabricated are found In TM c. Assembly Instructions. Detailed assembly instructions for items source coded to be assembled from component spare/repair parts are found in TM Items that make up the assembly are listed Immediately following the assembly item entry or reference Is made to an applicable figure. d. Kits. Line item entries for repair parts kits appear in a group in Section II (see table of contents). e. Index Numbers. Items which have the word BULK In the figure column will have an index number shown In the time number column This Index number is a cross-reference between the National Stock Number/Part Number Index and the bulk material list In section II. f. Associated Publications. The publications listed below pertain to the Truck and its components. Publication Short Title To be provided by the Government 6. HOW TO LOCATE REPAIR PARTS. a. When National Stock Number or Part Number is NOT Known. (1) Using the table of contents, determine the assembly group or subassembly group to which the Item belongs This is necessary since figures are prepared for assembly groups and subassembly groups, and listings are divided Into the same groups. 6

12 TM P 6. HOW TO LOCATE REPAIR PARTS (CONT). (2) Find the figure covering the assembly group or subassembly group to which the item belongs. (3) Identify the item on the figure and note the item number. (4) Refer to the Repair Parts List for the figure to find the part number for the item number noted on the figure. (5) Refer to the Part Number Index to find the NSN, if assigned. b. When National Stock Number or Part Number Is Known. (1) Using the Index of National Stock Numbers and Part Numbers, find the pertinent National Stock Number or Part Number The NSN index is In National Item Identification Number (NIIN) sequence (see paragraph 4a (1)) The part numbers in the Part Number index are listed in ascending alphanumenc sequence (see paragraph 4b ) Both indexes cross-reference you to the Illustration figure and item number of the item you are looking for. (2) After finding the figure and item number, verify that the item is the one you are looking for, then locate the item number in the repair parts list for the figure. 7. ABBREVIATIONS. Abbreviations used in this manual are listed in MIL-STD-12. 7

13 TM P FIG. 1 ENGINE ASSEMBLY

14 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 01 ENGINE GROUP 0100 ENGINE ASSEMBLY FIG. 1. ENGINE ASSEMBLY 1 PBFFF U1l32 TMD ENGINE ASSEMBLY COMPLETE... 1 END OF FIGURE 1-1

15 TM P FIG. 2 ENGINE MOUNTING

16 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0100 ENGINE ASSEMBLY FIG. 2. ENGINE MOUNTING 1 PAFZZ CM1240 SCREW, CAP, HEXAGON H PAFZZ CM1440 SCREW, CAP, HEXAGON H PAFZZ WASHER XBFZZ MOUNT, ENGINE LH PAFZZ CM16160 SCREW, CAP, HEXAGON H PAFZZ E10 WASHER, FLAT XBFZZ MOUNT, ENGINE RH PAFZZ MOUNT, RESILIENT XBFZZ MOUNT, ENGINE FRAME PAFZZ WASHER, FLAT PAFZZ M16 NUT, SELF-LOCKING, HE XDFZZ DM10 NUT, PLAIN HEXAGON XBFZZ MOUNT, ENGINE FRAME XDFZZ CM1030 SCREW, CAP, HEXAGON H PAFZZ M12 NUT, PLAIN, HEXAGON... 8 END OF FIGURE 2-1

17 TM P FIG. 3. CRANKCASE HEAD ASSEMBLY

18 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0101 CRANKCASE., BLOCK, CYLINDER HEAD FIG. 3. CRANKCASE HEAD ASSEMBLY 1 PBFHZ 4U132 TM27A06031 CYLINDER HEAD, DIESE PAHZZ 4U132 XM37003 WASHER, FLAT PAHZZ 4U132 XH32134 SCREW.CAP, HEXAGON H XBHZZ 4U132 TM27ZO0402 BRACKET, LIFTING PAHZZ X07689 PLUG, EXPANSION PAHZZ X07606 PLUG EXPANSION PAHZZ CM1040 SCREW, CAP, HEXAGON H PAHZZ MS WASHER, FLAT PAHZZ K2 PLUG. PIPE XAHZZ 4U132 TMD27A00404 HEAD, CYLINDER PAHZZ TMD27A00500 INSERT, COMBUSTION PAHZZ X02583 PLUG, EXPANSION... 4 END OF FIGURE 3-1

19 TM P FIG. 4 CYLINDER BLOCK ASSEMBLY

20 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0101 CRANKCASE BLOCK, CYLINDER HEAD FIG. 4. CYLINDER BLOCK ASSEMBLY 1 PAHZZ 4U132 26XX00110 PLUG, MACHINE THREAD PAHZZ 4U132 26XX00137A PLUG, MACHINE THREAD PAHZZ 4U132 X13304 PLUG, EXPANSION PAHZZ 4U132 X02208 PLUG, EXPANSION PAHZZ K2 PLUG, PIPE PAHZZ 4U132 X07663 PLUG, MACHINE THREAD PAHZZ SEAL, PLAIN PAHZZ 4U132 TM27B00500 CAP AND FILLER PAHZZ 4U132 XM32018 SCREW, CAP, HEXAGON H PAHZZ 4U132 TMD27B00307 CAP, PILLOW BLOCK PAHZZ 4U132 TMD27BO0403 CAP, PILLOW BLOCK PAHZZ 4U132 TMD27B00402 CAP, PILLOW BLOCK PAHZZ 4U132 TM PIN, STRAIGHT, HEADLE PAHZZ 4U132 X17025 PIN, STRAIGHT, HEADLE... 2 END OF FIGURE 4-1

21 TM P FIG. 5 CRANKSHAFT AND FRONT DRIVE ASSEMBLY

22 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0102 CRANKSHAFT FIG. 5. CRANKSHAFT AND FRONT DRIVE ASSEMBLY I PAFZZ 4U132 XM32064 SCREW, CAP, HEXAGON H PAFZZ 4U132 XM37014 WASHER, FLAT XBFZZ 4U132 TM27C00401 PULLEY PAHZZ 4U132 TM27C00408 SLINGER., CRANKCASE PBFZZ 4U132 TM27H00409 GEAR, TIMING PAHZZ 4U132 TM27I00102 BEARING, SLEEVE PBHZZ 4U132 TMD27C00300 CRANKSHAFT, ENGINE PAHZZ GEAR BALANCER PAHZZ PIN, STRAIGHT, HEADED PAHZZ J605 KEY, MACHINE PAFZZ X00666 KEY, CRANKSHAFT... 1 END OF FIGURE 5-1

23 TM P FIG. 6 ENGINE BALANCER ASSEMBLY

24 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0102 CRANKSHAFT FIG. 6. ENGINE BALANCER ASSEMBLY 1 PBHHH 4U132 TM27B06290 BALANCER, ENGINE XBHZZ 4U132 TM WEIGHT PAHLZ 4Ul32 TM27B00319 SHIM SET PAHZZ 4U132 TM270B0315 PIN, GROOVED, HEADLES PAHZZ 4U132 T427B00314 BEARING, ROLLER PAHZZ 4U132 XM17200 PIN, STRAIGHT, HEADLE XDHZZ CM816 SCREW, CAP, HEXAGON H PAHZZ 4U132 TM27B00320 LOCKING PLATE, NUT PAHZZ 4U132 XM32131 SCREW, CAP, HEXAGON H... 4 END OF FIGURE 6-1

25 TM P FIG. 7 FLYWHEEL ASSEMBLY

26 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0103 FLYWHEEL ASSEMBLY FIG. 7. FLYWHEEL ASSEMBLY 1 XBFFF 4U132 TM27C04190 FLYWHEEL ASSY PAFZZ 4U132 TM13C00502 GEAR, SPUR PAFZZ 4U132 XM32114 SCREW, CAP, HEXAGON H... 6 END OF FIGURE 7-1

27 TM P FIG. 8 END PLATE AND STARTER ADAPTER INSTALLATION

28 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0103 FLYWHEEL ASSEMBLY FIG. 8. END PLATE AND STARTER ADAPTER INSTALLATION 1 PAFZZ X14323 WASHER, FLAT PAFZZ SCREW, CAP, HEXAGON H PAFZZ 4U132 XM32021 SCREW, CAP, HEXAGON H PAFZA XX WASHER, FLAT XBFZZ 4U132 TM END PLATE, REAR XBFZZ 4U132 TMD2TMO0409 ADAPTER PLATE, START PAFZZ 4U132 XH32085 SCREW, CAP, HEXAGON H PAFZZ X07005 BUSHING, SLEEVE END OF FIGURE 8-1

29 TM P FIG. 9 PISTON AND CONNECTING ROD

30 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0104 PISTONS 1 CONNECTING RODS FIG. 9. PISTON AND CONNECTING ROD 1 PAHZZ TMD020T00201 RING SET, PISTON PAHZZ 4U132 TMD27A05031E PISTON, INTERNAL PAHZZ TMD02A00300.PIN PISTON PAHZZ 4U132 K800A00203.RING RETAINING PAHZZ 4U132 TMD CONNECTING ROD PAHIZ 4U132 TM27G00303.BUSHING, SLEEVE PAHZZ 4U132 Z SCREW, CAP, HEXAGON H PAHZZ TM20T00102 BEARING SET... 1 END OF FIGURE 9-1

31 TM P FIG. 10 CAMSHAFT, ROCKER ARMS AND PUSHRODS

32 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0105 VALVES, CAMSHAFTS AND TIMING SYSTEM FIG. 10. CAMSHAFT, ROCKER ARMS AND PUSHRODS 1 PAFZZ 4U132 X PLUG, MACHINE THREAD PAFZZ 4U132 X14589 WASHER, FLAT PAFZZ 4U132 TM SPRING, HELICAL COMP PAFZZ 4U132 X00623 PIN COTTER PAFZZ 4U132 XM37005 WASHER, FLAT PAFZZ 4U132 XM32031 SCREW CAP, HEXAGON H PAFZZ 4U132 TM ROCKER ARM, ENGINE PAFZZ 4U132 TM SCREW ADJUSTING, VAL PAFZZ 4U132 TM SUPPORT, PIVOT PAFZZ TM ROD, PUSH PAFZZ TM TAPPET, ENGINE POPPE PAHZZ TM CAMSHAFT.ENGINE PAHZZ 4U132 F400I00246 PLATE, CAMSHAFT PAHZZ 4U132 TMD27H00507 GEAR.CAMSHAFT PAHZZ 4U132 X18498 NUT, SPECIAL XDHZZ CM816 SCREW CAP, HEXAGON H PAHZZ 4U132 XM37012 WASHERLOCK PAHZZ X KEY GEAR PAFZZ 4U132 X17066 PIN, STRAIGHT, HEADLE PAFZZ TM27I00303 SPRING, ROCKER, ARM PAFZZ 4U132 TM27I05150 ROCKER, ARM, ENGINE P PAFZZ 4U132 TM27I05140 ROCKER ARM, ENGINE P... 4 END OF FIGURE 10-1

33 TM P FIG. 11 VALVES AND CRANKCASE COVER

34 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0105 VALVES, CAMSHAFTS AND TIMING SYSTEM FIG. 11. VALVES AND CRANKCASE COVER 1 PAHZZ LOCK, VALVE SPRING R PAFZZ 4U132 XM32072 SCREW.CAP, HEXAGON H PAFZZ 4U132 X14596 WASHER, FLAT PAFZA 4U132 XM39000 SEAL PAFZZ 4U132 TM2TA00610 COVER, ENGINE POPPET PAFZZ GASKET PAFZZ TMD27A00613 GASKET PAFZZ TMD VALVE, POPPET, ENGINE PAFZZ TMD VALVE, POPPET, ENGINE PAFZZ TM GUIDE VALVE PAFZZ TM SEAL, ENGINE TOOL AN PAFZZ TM SPRING.VALVE PAFZZ TM RETAINER,SPRING... 8 END OF FIGURE 11-1

35 TM P FIG. 12 TIMING GEAR COVER

36 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP VALVES, CAMSHAFTS AND TIMING SYSTEM FIG. 12. TIMING GEAR COVER 1 PAFZZ XM32026 SCREW, CAP, HEXAGON H PAFZZ 4U132 XM37001 WASHER, LOCK PAFZZ 4U132 TM27F00234 BRACKET.MOUNTING PAFZZ X14134 WASHER, FLAT PAFZZ 4U132 XM32115 SCREW, C AP HEXAGON H XBFZZ 4U132 TMD27B05141 COVER PAFZZ 4U132 XM32068 SCREW,CAP, HEXAGON H PAFZZ TM GASKET PAFZZ 4U132 XM35000 NUT PAFZZ 4U132 X14590 WASHER, FLAT XDFZZ CM816 SCREW, CAP, HEXAGON H PAFZZ 4U132 X17025 PIN, STRAIGHT, HEADLE PAFZZ X07845 SEAL, PLAIN PAFZZ 4U132 TM27B00300 POINTER, ENGINE TIMI PAFZZ X13012 PIN,STRAIGHT,HEADED... 2 END OF FIGURE 12-1

37 TM P FIG. 13 OIL SAMPLING VALVE

38 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0106 ENGINE LUBRICATION SYSTEM FIG. 13. OIL SAMPLING VALVE 1 PAOZZ FD COCK, DRAIN PAOZZ E19 WASHER PAOZZ F4 ADAPTER, STRAIGHT,TU PAOZZ COUPLING.HOSE PAOZZ HOSE, PREFORMED PAOZZ MS ELBOW, TUBE PAOZZ K4 TEE, TUBE PAOZA F4.PACKING, PREFORMED PAOZZ MS NIPPLE, PIPE PAOZZ F1 TEE PIPE PAOZZ A ELBOW, PIPE TO TUBE PAOZZ HOSE ASSEMBLY, NONME PAOZA MS C02 COUPLING, PIPE... 1 END OF FIGURE 13-1

39 TM P FIG. 14 OIL FILTER AND DIPSTICK

40 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP ENGINE LUBRICATION SYSTEM FIG. 14. OIL FILTER AND DIPSTICK 1 PAFZZ 4U132 TM27L00426 GAGE ROD, LIQUID LEV PAFZZ 4U132 TM27LO0311 ADAPTER, FILLER NECK PAOZZ F600L03750 FILTER ELEMENT FLUI PAOZZ 4U132 TM27L00202 ADAPTER, FLUID FILTE... 1 END OF FIGURE 14-1

41 TM P FIG. 15 OIL PAN AND PUMP

42 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP ENGINE LUBRICATION SYSTEM FIG. 15. OIL PAN AND PUMP 1 XDFZZ CM845 SCREW, CAP, HEXAGON H PAFZZ 4U132 XM37002 WASHERLOCK PAFZZ 4U132 XM32039 SCREW,CAP, HEXAGON H PBFZZ TM27L06090 OIL PUMP ASSEMBLY,E PAFZZ X00692 KEY,PUMP DRIVE PAFZZ X01673 SEAL, ADAPTER PAFZZ 4U132 XM37001 WASHER, LOCK PAFZZ CM1020 SCREW,CAP, HEXAGON H PAFZZ F PLUG, MACHINE THREAD, PAFZZ X GASKET PBFZZ 4U132 TM27B06270 OIL, PAN PAFZZ XM32077 SCREW, CAP, HEXAGON H PAFZZ EM80 WASHER,LOCK XBFZZ 4U132 TM27L06080 TUBE, STRAINER, OIL P... 1 END OF FIGURE 15-1

43 TM P FIG. 16 INTAKE AND EXHAUST MANIFOLD

44 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0108 MANIFOLDS FIG. 16. INTAKE AND EXHAUST MANIFOLD 1 PAFZZ 4U132 XM37005 WASHER,FLAT PAFZZ XXM35002 NUT, MANIFOLD XBFZZ 4U132 TMD27EOO500 MANIFOLD EXHAUST PAFZZ 4U132 XM32039 SCREW,CAP,HEXAGON H PAFZZ 4U132 X06234 DECAL PAFZZ 4U132 TMD27E00502 GASKET PAFZZ 4U132 XM32080 STUD, PLAIN PAFZZ XM32022 STUD, MANIFOLD PAFZZ 4U132 XM37012 WASHER LOCK PAFZZ CM825 SCREW,CAP,HEXAGON H PAFZZ 4U132 TMD27F00408 ADAPTER,ENGINE PAFZZ 4U132 TMD27F00222 GASKET XBFZZ 4U132 TMD27F00601 MANIFOLD,INTAKE... 1 END OF FIGURE 16-1

45 TM P FIG. 17 FUEL INJECTION SYSTEM

46 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP FUEL SYSTEM GROUP CARBURETOR, FUEL INJECTOR FIG. 17. FUEL INJECTION SYSTEM 1 PAFZZ XM HOSE, RETURN PAFZZ XM HOSE,PREFORMED PAFZZ X26138 PLUG, HOSE PAFZZ XM HOSE, PREFORMED PAFZZ TMD20T00203 NOZZLE.FUEL INJECTI XAFZZ TMD20T00204.NOZZLE, FUEL INJ PAFZZ TMD27F00301 SHIELD, HEAT PAFZZ TMD27F00300 GLOW PLUG PAFZZ 4U132 TMD27F05140 TUBE ASSEMBLY SET PAFZZ E10 WASHER, LOCK PAFZZ NUT PBFHH 4U132 TMD27F00228 PUMP, FUEL, METERING PAFZZ CM825 SCREW, CAP, HEXAGON H PAFZZ 4U132 XM37012 WASHER LOCK PAFZZ 4U132 XM37005 WASHER, FLAT PAFZZ 4U132 TMD27B00300 GASKET PAFZZ 4U132 TMD27B00404 ADAPTER, FUEL PUMP PAFZZ X07837 PACKING, PREFORMED PAFZZ 4U132 TMD27F00200 KEY, FEATHER, PUMP PAFZZ TMD27H00403 GEAR, INJECTION PUMP PAFZZ E-5 WASHER LOCK PAFZZ SCREW, CAP, HEXAGON H PAFZZ TMD27HO0402 GEAR, PUMP, DRIVE PAFZZ 4U132 LW LEAD, ELECTRICAL PAFZZ 4U132 XM32139 SCREW, CAP, SOCKET HE... 3 END OF FIGURE 17-1

47 TM P FIG. 18 FUEL LINE INSTALLATION

48 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP FUEL PUMPS FIG. 18. FUEL LINE INSTALLATION 1 PAOZZ HOSE ASSEMBLY, NONME PAOZZ X4X4 ELBOW, PIPE TO TUBE PAOZZ C-L VALVE, TEE PAOZZ DM6 NUT, SELF-LOCKING, EX PAOZZ FITTING, BRASS PAOZZ F6 UNION,TUBE PAOZZ SPACER, SLEEVE PAOZA R1U-2MBN-5FZB-1 HOSE ASSEMBLY, NONME PAOZZ DM6 NUT,PLAIN,HEXAGON PAOZZ TMD27F00424 PUMP, FUEL PAOZZ CM1220 SCREW PAOZZ TUBE ASSEMBLY, METAL PAOZZ X12645 BUSHING, SLEEVE PAOZZ X12644 NUT, PLAIN, HEXAGON PAOZZ ADAPTER, STRAGHT,PI PAOZZ DM10 NUT, PLAIN, HEXAGON XBOZZ TMD20F00401 FILTER, BASE PAOZZ CLIP,FILTER XDOZZ CM1025 SCREW, CAP, HEXAGON H PAOZZ FILTER ELEMENT, FLUI PAOZZ DIN933-M6X SCREW, CAP, HEXAGON H A4C 22 XBOZZ BRACKET, PUMP/FILTER PAOZZ CM635 SCREW, CAP,HEXAGON H PAOZZ PLATE, INSTRUCTION PAOZZ F4 UNION,TUBE PAOZZ HOSE ASSEMBLY, NONME PAOZZ HOSE, NONMETALL IC PAOZZ H6 CLAMP, HOSE PAOZZ TUBEBENT, NMETALLIC PAOZZ AS FILTER, FLUID PAOZZ K40212 PACKING, PREFORMED PAOZZ L TRANSMITTER,LIQUID PAOZZ LOCK, FUEL GAGE... 1 END OF FIGURE 18-1

49 TM P FIG. 19 FUEL INJECTION PUMP ASSEMBLY (PAGE 1 OF 2)

50 TM P FIG. 19 FUEL INJECTION PUMP ASSEMBLY (PAGE 2 OF 2)

51 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0302 FUEL PUMPS FIG. 19. FUEL INJECTION PUMP ASSEMBLY 1 XAHHH PUMP HOUSING ASSY PFHZZ SHAFT,SHOULDERED PAHZZ PACKING, PREFORMED PAHZZ PACKING, PREFORMED PAHZZ BOLT, MACHINE PAHZZ SCREW ASSY., VENT PAHZZ SCREW.TAPPING PFHZZ PLATE, IDENTIFICATIO PAHZZ SCREW, MACHINE XBHZZ COVER, ACCESS PAHZZ GASKET PAHZZ WASHER PAHZZ WASHER PAHZZ RING, RETAINING PAHZZ NUT, PLAIN, HEXAGON PAHZZ CAP, ADJUSTING SCREW PAHZZ SETSCREW PAHZZ PACKING,PREFORMED PAHZZ SPRING.HELICAL,EXTE PAHHA HOOK ASSEMBLY,GOVER PAHZZ LINK FUEL INJECTION PAHZZ WASHER, SPRING TENSI PAHZZ SCREW, MACHINE PAHZZ HOOK GOVERNOR LINKA PAHZZ WASHER,LOCK PAHZZ MS WASHER, LOCK PAHZZ LEAD, IGNITION, ENGIN PAHZZ WASHER, FLAT PAHZZ WASHER,LOCK PAHZZ SCREW, MACHINE PAHZZ WASHER, FLAT PAHZZ FT832 NUT, SELF-LOCKING, HE PAHZZ MS NUT, PLAIN. HEXAGON PAHZZ WASHER, SHOULDERED PAHZZ ADAPTER, STRAIGHT, TU PAHZZ PACK.ING, PREFORMED PAHZZ CAP, COVER SCREW PAHZZ CLIP, COVER SCREW PAHZZ GASKET DAHZZ PARTS KIT, COIL ARM PAHZZ ARM,GOVERNOR PAHZZ SPRING, HELICAL, COMP PAHZZ SEAT, HELICAL COMPRE PAHZZ SPRING,HELICALCOMP PAHZZ SEAT, HELICAL COMPRE PAHZZ LEVER THROTTLE PAHZZ CAM, CONTROL PAHZZ ARM ASSEMBLY,VALVE

52 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 49 PAHZZ VALVE, METERING PAHZZ SHIM PAHZZ SPRING,HELICAL, COMP PAHZZ PACKING, PREFORMED PAHZZ SCREW ASSEMBLY PAHZZ SCREW CAM RING ADVA PAHZZ PACKINGCPREFORMED PAHZZ PLUG, MACHINE THREAD PAHZZ WASHER CONCAVE PAHZZ SPRING, EXPANDER, PIS PAHZZ SEAT, HELICAL COMPRE PAHZZ O-RING PAHZZ SETSCREW PAHZZ NUT, PLAIN, HEXAGON PAHZZ PACKING,PREFORMED PAHZZ PLUG, MACHINE THREAD PAHZZ O-RING PAHZZ SPRING.HELICAL, COMP PAHZZ SPRING,HELICAL, COMP PAHZZ NUT,PLAIN, HEXAGON PAHZZ PACKING, PREFORMED PAHZZ SHAFT, SHOULDERED PAHZZ SHIM PAHZZ PACK ING, PREFORMED PAHZZ SCREW, MACHINE PAHZZ NUT, PLAIN, HEXAGON PAHZZ LEVER, REMOTE CONTRO PAHZZ LEVE R, MANUAL CONTRO PAHZZ SPRING, HELICAL, TORS PAHZZ RETAINER, HELICAL CO PAHZZ SCREW, CAP,SOCKET HE XBHZZ COVER, GOV CONTROL PAHZZ GASKET PAHZZ STUD PAHZZ RETAINER,PACKING PAHZZ PLUG, MACHINE THREAD PAHZZ RING, PISTON PAHZZ PISTON, VALVE PAHZZ WEIGHT, GOVERNOR, FUE PAHZZ RETAINER ASSEMBLY, G PFHHH HEAD AND ROTARY PFHZZ RING,CAM PAHZZ PACKING, PREFORMED PAHZZ PIN,STRAIGHT, HEADLE PAHZZ SHOE SET, CAM ROLLER PAHZZ PLUNGER,ROTOR PAHZZ CONNECTOR, FUEL LINE PAHZZ PACKING,PREFORMED PAHZZ SCREW, MACHINE PAHZZ PLATE, MOUNTING PAHZZ SCREW, VALVE, RETAINI PAHZZ STOP, DELIVERY VALVE

53 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 101 PAHZZ SPRING, HELICAL, COMP PAHZZ VALVEDISTRIBUTING PAHZZ SPRINGLEAF PAHZZ SCREW, SELF-LOCKING PAHZZ RING,RETAINING PAHZZ BEARING, WASHER, THRU PAHZZ SLEEVE, GOVERNOR THR PAHZZ RETAINER,ROTOR,TRAN PAHZZ LINER, TRANSFER PUMP PAHZZ RING,RETAINING PAHZZ PIN PAHZZ VALVE, REGULATING, FL PAHZZ SPRINGHELICAL, COMP XBHZZ CAP, TRANSFER PUMP E PAHZZ SCREEN, FILTER,GOVER PAHZZ PLUG ASSEMBLY, END PUMP PAHZZ PISTON VALVE PAHZZ PACKING, PREFORMED PAHZZ SPRING,HELICAL,COMP PAHZZ BLADE, TRANSFER PUMP PAHZZ PACKING, PREFORMED PAHZZ PIN,STRAIGHT,HEADED... 1 END OF FIGURE 19-3

54 TM P FIG. 20 ENGINE FUEL LINES AND FITTINGS

55 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP FUEL PUMPS FIG. 20. ENGINE FUEL LINES AND... FITTINGS 1 PAOZZ 4U132 TMD27F06120 TUBE ASSEMBLY, METAL PAOZZ H3 CLIP,RETAINING PAOZZ 4U132 TM027F06130 TUBE ASSEMBLY, METAL PAOZZ 4U132 X07739 CLIP,RETAINING PAOZZ WASHER,FLAT PAOZZ 4U132 X00203A WASHER, LOCK PAOZZ DIN933-M6X SCREW,CAP, HEXAGON H A4C 8 PAOZZ IDM6 NUT,PLAIN, HEXAGON PAOZZ 4U132 X07740 RING, RETAINING PAOZZ 4U132 X26179 CONNECTOR, MULTIPLE PAOZZ 4U132 TMD27F00267 CONNECTOR, MULTIPLE PAOZZ 4U132 X12671 CONNECTOR, MULTIPLE PAOZZ 4U132 X26175 CONNECTOR, MULTIPLE... 1 END OF FIGURE 20-1

56 TM P FIG. 21 AIR CLEANER INSTALLATION

57 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP AIR CLEANER FIG. 21. AIR CLEANER INSTALLATION 1 PAOZZ P CLAMP, LOOP PAOZZ DM8 NUT, PLAIN, HEXAGON PAOZZ EM8O WASHER,FLAT PAOZZ GAH HOOD, INLET PAOZZ H40 CLAMP,HOSE PAOZZ HOSE,PREFORMED PAOZZ DUCT ASSEMBLY, AIR C PAOZZ A ID, 2 HOSE, NONMETALLIC LG 9 XBOZZ CLAMP PAOZZ CM625 SCREW CAP, HEXAGON H PAOZZ TUBE, BENT, METALLIC PAOZZ COUPLING.HOSE PAOZZ INDICATOR, FILTER WA PAOZZ K-4 PLUG, PIPE PAOZZ CM830 SCREW, CAP, HEXAGON H PAOZZ CM830 BOLT, SQUARE NECK XBOZZ BRACKET, INTAKE PAOZZ DM6 NUT, PLAIN,HEXAGON PAOZZ HOSE, PREFORMED PAOZZ H36 CLAMP, HOSE... 1 END OF FIGURE 21-1

58 TM P FIG. 22 AIR CLEANER ASSEMBLY

59 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0304 AIR CLEANER FIG. 22. AIR CLEANER ASSEMBLY 1 PAOOZ FWGO AIR CLEANER, INTAKE XBOZZ P CUP... 3 PAOZZ P CLAMP; LOOP PAOZZ P DEFLECTOR, DIRT AND PAOZZ P NUT; PLAIN ;WING XBOZZ P BODY ASSEMBLY PAOZZ P FILTER ELEMENT ;INTA PAOZZ P MARKER; IDENTIFICATI PAOZZ P LABEL... 1 END OF FIGURE 22-1

60 TM P FIG. 23 FUEL TANK AND FILLER

61 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0306 TANKS, LINES, FITTINGS9 HEADERS FIG. 23. FUEL TANK AND FILLER 1 PAOZZ NUT, SELF-LOCKING, EX PAOZZ T CAP, FILLER OPENING PFOZZ SHIELD PAOZZ GROMMET; NONMETALLIC PAOZZ PTIO0020 PUSH ON NUT PAOZZ CLIP; RETAINING PAOZZ IDM10O NUT, PLAIN, HEXAGON PAOZZ TANK; FUEL, ENGINE PAOZZ NS PACKING, PERFORMED PAOZZ MS PLUG, MACHINE THREAD PAOZZ CM1040 BOLT, MACHINE PAOZZ CM1030 BOLT; MACHINE... 1 END Of FIGURE 23-1

62 TM P FIG. 24 FUEL WATER SEPARATOR

63 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0309 FUEL FILTERS FIG. 24. FUEL WATER SEPARATOR 1 PAOZZ HOSE ;ASSEMBLY, NONME PAOZZ X4X4 ELBOW; PIPE TO TUBE PBOZZ A STRAINER; SEDIMENT PAOZZ MS NIPPLE, PIPE... 5 PAOZZ B-02X24 COUPLING, PIPE XBOZZ BRACKET, W/S MTG PAOZZ X12645 BUSHING, SLEEVE PAOZZ X12644 NUT, PLAIN, HEXAGON PAOZZ TU8BE, METALLIC PAOZZ F4 UNION, TUBE... 2 END OF FIGURE 24-1

64 TM P FIG. 25 ACCELERATOR LINKAGE INSTALLATION

65 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0312 ACCELERATOR, THROTTLE OR CHOKE CONTROL FIG. 25. ACCELERATOR LINKAGE INSTALLATION 1 PAOZZ PIN GROOVED, HEADED XBOZZ PEDAL, ACCELERATOR PAOZZ SPRING, PEDAL PAOZZ BUSHING, NONMETALLIC PAOZZ ldm6 NUT, PLAIN, HEXAGON PAOZZ HOUSING, BEARING UNIT PAOZZ BEARING, SLEEVE PAOZZ HOUSING, BEARING UNIT PAOZZ CM616 SCREW, CAP, HEXAGON H PAOZZ LEVER, ACCELERATOR PAOZZ lf310 PIN, COTTER PAOZZ J5204 CLEVIS; ROD E PAOZZ F5062 PIN, STRAIGHT,HEADED PAOZZ LEVER, ACCELERATOR PAOZZ JM32 CLIP, RETAINING PAOZZ D4 NUT; SELF-LOCKING, HE PAOZZ TUBE, METALLIC PAOZZ SPRING, HELICAL, EXTE PAOZZ SPRING, HELICAL, COMP... 1 END OF FIGURE 25-1

66 TM P FIG. 26 MUFFLER AND TAIL PIPE

67 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 04 EXHAUST SYSTEM GROUP 0401 MUFFLER AND PIPES FIG. 26. MUFFLER AND TAIL PIPE 1 PAOZZ TUBE, BENT, METALLIC PAOZZ X18 CLAMP, LOOP PAOZZ DMB NUT; SELF-LOCKING; EX PAOZZ MUFFLER ;EXHAUST PAOZZ PIPE; EXHAUST PAOZZ NUT, PLAIN; HEXAGON PAOZZ FLANGE, EXHAUST PAOZZ STUD MANIFOLD PAOZZ PACKING PAOZZ INSULATOR; PLATE PAOZZ H28 CLAMP; HOSE XBOZZ BRACKET, MUFFLER TG... 1 END OF FIGURE 26-1

68 TM P FIG. 27 COOLING SYSTEM

69 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 05 COOLING SYSTEM GROUP 0501 RADIATOR, EVAPORATIVE COOLER OR HEAT EXCHANGER FIG. 27. COOLING SYSTEM 1 PAOZZ CH1040 SCREW; CAP, HEXAGON H PAOZZ PLUG XBOZZ COVER ASSY, RDTR PAOZZ HOSE, PERFORM PAOZZ RADIATOR; ENGINE COD PAOZZ AX-2642 CAP FILLER OPENING PAOZZ EM60 WASHER; FLAT PAOZZ DIN933-M6XI6-8.8 SCREW, CAP, HEXAGON H A4C 9 PFOZZ SHROUD; FAN; RADIATOR PAOZZ H24 CLAMP, HOSE PAOZZ HOSE, PERFORMED PAOZZ DM8 NUT, SELF-LOCKING, EX PAOZZ H42 CLIP, SPRING TENSION PAOZZ HOSE; NONMETALLIC XBOZZ BRACKET, RESERVOIR PAOZZ TANK, RADIATOR OVER XDOZZ ICM816 SCREW, CAP, HEXAGON H PAOZZ H6 CLAMP, HOSE PAOZZ HOSE, NONMETALLIC PAOZZ CLIP, INSULATEDOE PAOZZ PT PUSH ON NUT XDOZZ DM10 NUT, PLAIN HEXAGON XBOZZ BRKT. RDTR/OIL CLR PAOZZ GROMMET; NON METALLIC PAOZZ COOLER, LUBRICATING PFOZZ CM830 BOLT, SQUARE NECK... 2 END OF FIGURE 27-1

70 TM P FIG. 28 WATER PUMP ASSEMBLY

71 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0504 WATER PUMP FIG. 28. WATER PUMP ASSEMBLY 1 PBOFZ 4U132 TM27K06027 PUMP, COOLING SYSTEM PAFZZ 4U132 XM32106 SCREW; CAP, HEXAGON H XBFZZ 4U132 TM27K00501 COVER PAFZZ 4U132 TN27K00425 PULLEY, GROOVE KFFZZ 4U132 TM27KO0301 GASKET PART OF KIT P/N TM27TO END OF FIGURE 28-1

72 TM P FIG. 29 FAN AND FAN BELT ASSEMBLY

73 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0505 FAN ASSEMBLY FIG. 29. FAN AND FAN BELT ASSEMBLY 1 XBOZZ SPACER; FAN XBDZZ OFUK FAN, 6 BLADE PAOZZ EN80 WASHER; FLAT PAOZZ 4U132 XM32039 SCREW; CAP, HEXAGON H PAOZZ BELT, V END OF FIGURE 29-1

74 TM P FIG. 30 ALTERNATOR MOUNTING

75 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 06 ELECTRICAL SYSTEM GROUP 0601 GENERATORS ALTERNATOR FIG. 30. ALTERNATOR MOUNTING 1 PAOZZ ICM820 SCREW; CAP; HEXAGON H PAOZZ ENBO WASHER; FLAT PAOZZ CM10100 SCREW; CAP, HEXAGON H PAOZZ IDM1O NUT, PLAIN; HEXAGON PAOZZ TUBE METALLIC PAOFF GENERATOR, ALTERNATI... 1 END OF FIGURE 30-1

76 TM P FIG. 31 ALTERNATOR ASSEMBLY

77 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0601 GENERATOR ALTERNATOR FIG. 31. ALTERNATOR ASSEMBLY 1 PAFZZ NUT; PLAINT; HEXAGON PAFZZ WASHER, LOCK PAFZZ PULLEY.; GROOVE PAFZZ IMPELLER. FAN; AXIEL PAFZZ SCREW; MACHINE PAFZZ WASHER, LOCK PAFZZ SPACER; FAN PAFZZ HOUSING; FRONT PAFZZ GASKET PAFZZ SEAL, BEARING... : 1 11 PAFZZ BEARING, SLEEVE PAFZZ PLATE RETAINING, BEA PAFZZ KEY, WOODRUFF PAFZZ ROTOR ASSEMBLY PAFZZ BEARING; BALL, ANNULA PAFZZ STATOR, ENGINE GENER PAFZZ NUT; HEX PAFZZ WASHER LOCK PAFZZ BOLT. SQUARE NECK PAFZZ CONNECTOR RECEPTACL PAFZZ INSULATION SQUARE PAFZZ SEMICONDUCTOR DEVIC PAFZZ B44761F16 INSULATOR, WASHER PAFZZ INSULATION SLEEVING PAFZZ INSULATOR WASHER PAFZZ INSULATOR PAFZZ BOLT, SQUARE NECK PAFZZ SEMICONDUCTOR DEVIC PAFZZ OEDY A02 PACKING PERFORMED XAFZZ HOUSING; REAR PAFZZ INSULATOR. WASHER PAFZZ WASHER, FLAT PAFZZ NUT, PLAIN, HEXAGON PAFZZ BOLT PAFZZ STUD PLAIN PAFZZ WASHER, FLAT PAFZZ BRUSH. ELECTRICAL PAFZZ NUT, PLAIN HEXAGON PFFZZ INSULATOR, WASHER PAFZZ HEAT SINK ELECTRICAL PAFZZ BOLT, SQUARE NECK PAFZZ HOLDER ASSEMBLY, ELE PAFZZ BRUSH, ELECTRICAL PAFZZ SCREW, TAPPING PAFZZ GASKET PAFZZ REGULATOR; VOLTAGE PAFZZ OEDY B13S SCREW; TAPPING PAFZZ SCREW, TAPPING... 2 END OF FIGURE 31-1

78 TM P FIG. 32 STARTER ASSEMBLY

79 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0603 STARTING MOTOR FIG. 32. STARTER ASSEMBLY 1 PAOFF 5T STARTER.; ENGINE PAFZZ 5T SCREW, CAP, HEXAGON H PAFZZ 5T WASHER, FLAT PAFZZ 5T SCREW; CAP HEXAGON H PAFZZ 5T WASHER, SPRING TENS PAFZZ 5T NUT, PLAIN, HEXAGON PAFZZ 5T WASHER, SPRING TENS PAFZZ 5T SWITCH, REED PAFZZ 5T SPRING, HELICAL, COMP PAFZZ 5T BALL, BEARING PAFZZ 5T CLUTCH SUBASSEMBLY XAFZZ 5T HOUSING, STARTER PAFZZ 5T SCREW, CAP; HEXAGON H PAFZZ 5T NUT, PLAIN, HEXAGON PAFZZ 5T ROLLER, CLUTCH PAFZZ 5T RETAINER PAFZZ 5T PIN; INN, STARTER PAFZZ 5T PINION, STARTER PAFZZ 5T BOLT, MACHINE PAFZZ 5T FRAME.; STARTER PAFZZ 5T SEAL PAFZZ 5T ARMATURE ASSEMBLY PAFZZ 5T RETAINER, SNAP PAFZZ 5T BEARING; BALL PAFZZ 5T COVER PAFZZ 5T HOLDER ASSEMBLY PAFZZ 5T SCREW, ASSEMBLED WAS PAFZZ 5T BRUSH, ELECTRICAL PAFZZ 5T BRUSH, ELECTRICAL PAFZZ 5T BUSHING, MACHINE THR XAFZZ 5T YOKE ASSEMBLY START PAFZZ 5T BEARING.; BALL PAFZZ 5T BOLT.; MACHINE... 1 END OF FIGURE 32-1

80 TM P FIG. 33 INSTRUMENT PANEL ASSEMBLY

81 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0607 INSTRUMENT OR ENGINE CONTROL PANEL FIG. 33. INSTRUMENT PANEL ASSEMBLY 1 PAOZZ CN620 SCREW W; CAP SOCKET; HE PAOZZ METER, TIME TOTALIZI PAOZZ GAGE, LIQUID QUANTIT PAOZZ LIGHT, WARNING PAOZZ SWITCH; LOCK, IGNITO PAOZZ KEY, LOCK PAOZZ B4.LIGHT ASSEMBLY, INDI PAOZZ SWITCH.; TOGGLE XBOZZ PANEL. INSTRUMENT PAOZZ BUZZER PAOZZ IDM6 SCREW, CAP HEXAGON PAOZZ CLAMP ;HOSE PAOZZ RELAY; ELECTROMAGNET XBOZZ BRACKET, RELAY PAOZZ G606 SCREW, MACHINE PAOZZ WASHER, FLAT PAOZZ lcn612 SCREW, CAP, SOCKET HE PAOZZ VF4-65Fll RELAY PAOZZ LIGHTING KIT; VEHICU PAOZZ W-L-00111/61 LAMP INCANDESCENT PAOZZ PLATE, MOUNTING PAOZZ LUG NUT, CLIP-ON... 4 END OF FIGURE 33-1

82 TM P FIG. 34 DIRECTIONAL CONTROL INSTALLATION

83 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0608 MISCELLANEOUS ITEMS FIG. 34. DIRECTIONAL CONTROL INSTALLATION 1 PAOZZ DIRECTIONAL SIGNAL PAOZZ COVER; ACCESS PAOZZ GH825 SCREW, CAP, HEXAGON H PAOZZ CL AMP... 1 END OF FIGURE 34-1

84 TM P FIG. 35 STOP AND TAIL LIGHT INSTALLATION

85 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0609 LIGHTS FIG. 35. STOP AND TAIL LIGHT INSTALLATION 1 PAOOO LAMP ASSEMBLY PAOZZ RB25177 TERMINAL, QUICK DISC PBOZZ WIRING HARNESS PAOZZ R104 TERMINAL; LUG PAOZZ RB2573 TERMINAL; QUICK DISC PFOZZ WIRING HARNESS PAOZZ CABLE NIPPLE; ELECTR PAOZZ WIRING HARNESS... 2 END OF FIGURE 35-1

86 TM P FIG. 36 STOP AND TAIL LIGHT ASSEMBLY

87 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0609 LIGHTS FIG. 36. STOP AND TAIL LIGHT ASSEMBLY 1 PAOOO STOP LIGHT; VEHICULA XAOOO BRACKET; MOUNTING PAOZZ WASHER; LOCK PFOZZ NUT; PLAIN, HEXAGON PFOZZ BOLT; MACHINE PAOZZ LAMP, INCANDESCENT PAOZZ LENS, LIGHT... 2 END OF FIGURE 36-1

88 TMlf P FIG. 37 PRESSURE SWITCH AND TAIL LIGHT BRACKET

89 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0609 LIGHTS FIG. 37. PRESSURE SWITCH AND TAIL LIGHT BRACKET 1 PAOZZ SWITCH,PRESSURE XBOZZ BRACKET,TAIL LIGHT PAOZZ TERMINAL,QUICK DISC END OF FIGURE 37-1

90 TM P FIG. 38 FLOOD LIGHT ASSEMBLY

91 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON COOES(UOC) QTY GROUP 0609 LIGHTS FIG. 38. FLOOD LIGHT ASSEMBLY 1 PFOZZ BRACKET,MOUNTING XAOZZ WASHER PAOZZ BOLT,SQUARE NECK XAOZZ BRACKET PAOZZ NUT,SELF-LOCKING,HE XAOZZ BRACKET,DOUBLE ANGL PAOZZ WASHER,LOCK PAOZZ NUT,PLAIN,HEXAGON PAOZZ SCREW,MACHINE PFOZZ WIRING HARNESS XAOZZ BODY,HEADLAMP XAOZZ TERMINAL XAOZZ TERMINAL PAOZZ L4478 LAMP,INCANDESCENT PFOZZ CONE,LOUDSPEAKER... 1 END OF FIGURE 38-1

92 TM P FIG. 39 SENDING UNIT AND WARNING SWITCHES

93 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0610 SENDING UNITS AND WARNING SWITCHES FIG. 39. SENDING UNIT AND WARNING SWITCHES 1 PAOZZ M13321 BOOT,DUST AND MOIST PAOZZ 4U SWITCH,PRESSURE PAOZZ SENSOR,AIR CHARGED PAOZZ GAUGE,TRANS TEMP... 1 END OF FIGURE 39-1

94 TM P FIG. 40 HORN INSTALLATION

95 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0611 HORN,SIREN FIG. 40. HORN INSTALLATION 1 PAOZZ HORN,ELECTRICAL PAOZZ EH60 WASHER,LOCK PAOZZ DIM6 NUT,PLAIN,HEXAGON PAOZZ NUT,PLAIN,HEXAGON XBOZZ BRACKET,HORN PAOZZ CN616 SCREW,CAP,HEXAGON H PAOZZ E14 WASHER,LOCK... 1 END OF FIGURE 40-1

96 TM P FIG. 41 BATTERY INSTALLATION

97 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0612 BATTERIES,STORAGE (WET OR DRY) FIG. 41. BATTERY INSTALLATION 1 PAOZZ NUT,PLAIN,HEXAGON PAOZZ MS WASHER,FLAT PAOZZ RETAINER,BATTERY PAOZZ BOLT,HOOK PAOFA HP BATTERYPSTORAGE PAOZZ BOLT,HOOK... 1 END OF FIGURE 41-1

98 TM P FIG. 42 CHASSIS WIRING HARNESS

99 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGECNUMBERDESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0613 HULL OR CHASSIS WIRING HARNESS FIG. 42. CHASSIS WIRING HARNESS 1 PAOZZ CJV-1113 CLIP,RETAINING PAOZA D SWITCH,PUSH PAOZZ WIRING,HARNESS PAOZZ TUBE,METALLIC PAOZZ WIRING HARNESS PAOZA H38 CLIP,SPECIAL PAOZZ CN820 SCREW,CAP,HEXAGON H... 2 B PAOZZ DN8 NUT,PLAIN,HEXAGON PAOZZ TERMINALPQUICK DISC PAOZZ H31 CLAMP,CABLE,ELECTRI XDOZZ CM1025 SCREW,CAP,HEXAGON H PAOZZ EM100 WASHER,LOCK PAOZZ COIL,ELECTRICAL PAOZZ MS NUT,PLAIN,HEXAGON... 2 END OF FIGURE 42-1

100 TM P FIG. 43 ENGINE WIRING INSTALLATION

101 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGECNUMBERDESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0613 HULL OR CHASSIS WIRING HARNESS FIG. 43. ENGINE WIRING INSTALLATION 1 PAFZZ SWITCH,ROTARY PAOZZ COVERPTERMINAL BOX PAOZZ LEAD,ELECTRICAL PAOZZ CABLE NIPPLE,ELECTR PAOZZ LEAD,ELECTRICAL PAOZZ LEAD,STORAGE BATTER PAOZZ LEAD,STORAGE BATTER PAOZZ PLATE, INSTRUCTION... 1 END OF FIGURE 43-1

102 TM P FIG. 44 TRANSAXLE FRAME MOUNTING

103 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGECNUMBERDESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 07 TRANSMISSION GROUP 0700 TORQUE CONVERTER OR FLUID COUPLING FIG. 44. TRANSAXLE FRAME MOUNTING 1 PAFZZ NUT,SELF-LOCKINGEX PAFZZ SPACER9SLEEVE PAFZZ CM2060 SCREW,CAP,HEXAGON H... 9 END OF FIGURE 44-1

104 TM P FIG. 45 TRANSAXLE DIFFERENTIAL

105 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGECNUMBERDESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0702 OPPOSED OUTPUT FIG. 45. TRANSAXLE DIFFERENTIAL 1 PAHZZ SHIM, PAHZZ SHIM, V 1 PAHZZ SHlM, V 1 PAHZZ SHlM V 2 PAHZZ A CUP,TAPERED ROLLER PBHHH DIFFERENTIAL GEAR U PAHZZ M PIN,SPRING PAHZZ W SHAFT,STRAIGHT XBHZZ CASE, DIFFERENTIAL PAHZZ BEARINMG,WASHER THR PAHZZ GEAR,DIFFERENTIAL PAHZZ GEAR,DIFFERENTIAL PAHZZ BEARING,WASHER THRU PAHZZ C918 SCREW, CAPHEXAGON H PAHZZ EM1426 WASHERFLAT END OF FIGURE 45-1

106 TM P FIG. 46 DRIVE AXLE BEARING CARRIER

107 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGECNUMBERDESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0702 OPPOSED OUTPUT FIG. 46. DRIVE AXLE BEARING CARRIER 1 XBOZZ DIPSTICK XBOZZ TUBE,DIPSTICK KFHZZ K PACKING,PREFORMED PART OF KIT P/N XBHZZ HOUSING,WHL END LH PAOZZ MBGFPN BREATHER XBHZZ HOUSING,WHL END RH PAHZZ SCREW,CAP,HEXAGON H PAHZZ ERNA245 WASHER,LOCK PAHZZ SCREW,CAP PAOZZ B1821BHO50C150N SCREW,CAP,HEXAGON H PFOZZ SHAFT,AXLE,AUTOMOTI... 2 END OF FIGURE 46-1

108 TM P FIG. 47 TORQUE CONVERTER

109 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGECNUMBERDESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0708 TORQUE CONVERTER OR FLUID COUPLING FIG. 47. TORQUE CONVERTER 1 PAHZZ G552 SCREW, CAP PAHZZ MS WASHER,LOCK KFHZZ GASKET, CONTROL V PART OF KIT P/N PAHZZ P9111K BEARING, BALL, ANNULA KFHLZ N SEAL, OIL PART OF KIT P/N PAHZZ CONVERTER ASSEMBLY PAHZZ ADAPTER, CONVERTER PAHZZ E6 WASHER, LOCK PAHZZ MS SCREW CAP, HEXAGON H XBHZZ PLATEVDRIVE PAHZZ E6 WASHER,FLAT PAHZZ H2525M WASHER,LOCK PAHZZ H038C0750 SCREW, CAP, HEXAGON H PAHZZ DISK,VALVE PAHZZ WR44 RING,RETAINING PAHZZ BEARING, WASHER, THRU PAHZZ WR42 RING, RETAINING PFHZZ SUPPORT, STATOR PAHZZ BUSHING, SLEEVE PAHZZ GEAR, IMPELLER PAHZZ SPRING, HELICAL, COMP PAHZZ WASHER, SPLIT... 1 END OF FIGURE 47-1

110 TM P FIG. 48 TRANSAXLE MOUNTING

111 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGECNUMBERDESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0710 TRANSMISSION ASSEMBLY (HYDRATORQUE) FIG. 48. TRANSAXLE MOUNTING 1 PAFZZ EM1019 WASHER, FLAT PAFZZ N7572 SCREW,CAP,HEXAGON H XBOZZ COVER TRANS XBOZZ PLATE, ID PAFHH AXLE ASSEMBLY,VEHIC XBOZZ COVER,SOLENOID PAOZZ CM1820 SCREW,CAP,HEXAGON H PAOZZ DM8 NUT,PLAIN,HEXAGON XDFZZ CM816 SCREW,CAP,HEXAGON H PAFZZ IEM80 WASHER, FLAT PAFZZ WASHER, SPACER... 1 END OF FIGURE 48-1

112 TM P FIG. 49 TRANSMISSION CLUTCHES

113 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGECNUMBERDESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0710 TRANSMISSION ASSEMBLY (HYDRATORQUE) FIG. 49. TRANSMISSION CLUTCHES 1 PAHZZ TRB-2233 SEAT, BEARING PAHZZ NTA2233 RETAINER AND ROLLER PAHHH GEARSPUR PAHZA J228.BEARING, ROLLER,NEED PAHZZ SPACERSLEEVE XAHZZ GEAR, REVERSE CLUTCH PAHZZ RING, RETAINING PAHZZ MS BEARING, ROLLER, THRU PAHZZ PLATE, INTERMEDIATE PAHZZ DISK, CLUTCH PAHZZ DISCOUTER... V 11 PAHZZ RING.RETAINING PAHZZ WASHER, SPRING TENSI PAHZZ PLATEtCLUTCH9PISTON PAHZZ PlSTON, CLUTCH SHAFT KFHZZ SEAL, PLAIN PART OF KIT P/N KFHZZ SEAL.PLAIN PART OF KIT P/N PAHHH SHAFT ASSEMBLY, SHOU PAHZZ G404 SETSCRE XAHZZ TURB[NE ASSY, SHAFT PAHHZ GEAR ASSEMBLY XAHZZ GEAR.FORWARD CLUTCH PAHZA J228 BEARING,ROLLER, NEED PAHZZ SPACER, SLEEVE KFHZZ RING, RETAINING PART OF KIT P/N PAHZZ BH-2210 BEARING NROLLERRNEED PAHZZ SLEEVE, OIL DISTRIBU PAHZZ GEAR,OUTPUT PAHZZ G1007 SETSCRE... 1 END OF FIGURE 49-1

114 TM P FIG. 50 TRANSMISSION HOUSING

115 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGECNUMBERDESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0710 TRANSMISSION ASSEMBLY (HYDRATORQUE) FIG. 50. TRANSMISSION HOUSING 1 PAHZZ TUBE ASSEMBLY, METAL PAHZZ MS51527A5 ELBOW, TUBE TO BOSS KFHZZ K5 SEAL PART OF KIT P/N PAHZZ G612 SCREW, CAP, SOCKET HE PAHZZ E0109 SCREW, ROLLER ASSEMB PAHZZ H2525M WASHER, LOCK PAHZZ PLUG,PIPE PAOZZ HC-1500 PLUG, MACHINE THREAD PAOZZ PLUG,PIPE PAHZZ SCREW, CAP,HEXAGON H PAHZZ TUBE ASSEMBLY.METAL KFHZZ PACKING, PREFORMED PART OF KIT P/N XBHZZ CASE,TRANSMISSION PAOZZ PLUGPIPE, MAGNETIC PAHZZ JM1224 PIN, SPRING KFHZZ GASKETTXMSN CASE PART OF KIT P/N XBHZZ PLATE,SPACER PAHZZ PLUG,PIPE PAHZZ 0B8Y SWITCH,THERMOSTATIC PAHZZ GASKET XBHZZ HOUSING,CONVERTER PAHZZ MS SCREW, CAP, HEXAGON H PAHZZ B1821BH038C200N SCREW.CAP, HEXAGON H... 5 END OF FIGURE 50-1

116 TM P FIG. 51 TRANSAXLE PINION AND RING GEAR

117 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGECNUMBERDESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0710 TRANSMISSION ASSEMBLY (HYDRATORQUE) FIG. 51. TRANSAXLE PINION AND RING GEAR 1 PAHZL RING, RETAINING PAHZZ SHIM SIZE IS V 2 PAHZZ SHIM ISIZE IS V 2 PAHZZ SHIM SIZE IS V 2 PAHZZ SHIM O05151IZE IS V 3 PAHZZ CUP.TAPERED ROLLER PAHHH GEAR SET, BEVEL, MATC XAHZZ SHAFT,PINION XAHZZ GEAR, RING PAHZZ SHIM SIZE IS V 7 PAHZL SHIM SIZE IS V 7 PAHZZ SHIM SIZE IS V 7 PAHZZ SHIM SIZE IS V 8 DAHZZ A CUP, TAPERED ROLLER PAHZZ NTU NUT,SELF-LOCKING HE... 1 END OF FIGURE 51-1

118 TM P FIG. 52 TRANSAXLE PUMP AND OIL FILTER ASSEMBLIES

119 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0710 TRANSMISSION ASSEMBLY (HYDRATORQUE) FIG. 52. TRANSAXLE PUMP AND OIL FILTER ASSEMBLIES 1 PAHZZ BEARING, WASHER, THRU PAHZZ BEARING, ROLLER, NEED PAHZZ GEAR, IDLER PAHZZ SHAFT, STRAIGHT PAHZZ GEAR, PUMP PAHZZ MS RING, RETAINING KFHZZ GASKET, TRANS PUMP PART OF KIT P/N PAHZZ PUMP, TRANSMISSION PAHZZ MS WASHER, LOCK PAHZZ C556 SCREW, CAP, HEXAGON H PAHZZ B1821BH038C350L BOLT, MACHINE PAHZZ H2525M WASHER, LOCK PAHHZ VALVE, REGULATING PAHZZ WS-50.RING, RETAINING PAHZZ SPRING, HELICAL, COMP XAHZZ SLEEVE, REGULATING XAHZZ PISTON, REGULATING PAHZZ FILTER ELEMENT, FLUI PAHZZ RING RETAINING PAHZZ SG-LR BEARING, BALL PAHZZ GEAR AND SHAFT PAHZZ BEARING, BALL, ANNULA... 1 END OF FIGURE 52-1

120 TM P FIG. 53. TRANSMISSION CONTROL VALVE ASSEMBLY

121 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0714 SERVO UNIT, MAIN CONTROL VALVES FIG. 53. TRANSMISSION CONTROL VALVE ASSEMBLY 1 PAHHH VALVE, CONTROL PAHHZ CYLINDER ASSEMBLY PAHZZ FC-6446-P..VALVE, BLEEDER, HYDRA PAHZZ SEAT, BRAKE LINE PAHZZ CAP INCHING SLAVE KFHZZ K PACKING, PREFORNED PART OF KIT P/N PAHZZ S..NUT, ADJUSTING PAHZZ INCHING,PISTON ASSY KFHZA SEAL,PLAIN ENCASED PART OF KIT P/N PAHHZ HOUSING,CYLINDER KFHZZ FILTER PART OF KIT P/N KFHZZ MS PACKING,PREFORMED PART OF KIT P/N XAHZZ HOUSING,VALVE PAHZZ K02.PLUG, PIPE PAHZZ K1.PLUG, PIPE PAHZZ VALVE,CHECK PAHZZ K-012..PACKING,PREFORMED PAHZZ AS PACKING,PREFORMED PAHZZ K6..PACKING,PREFORMED PAHZZ 0C7Z COIL,ELECTRICAL PAHZZ SPRING,HELICALCOP PAHZZ SPOOL,FOREWARD AND PAHZZ F6.PACKING,PREFORMED PAHZZ K1(6.PLUG,MACHINE THREAD PAHZZ SPOOL,MODULAR PAHZZ SPRING,HELICAL,COMP PAHZZ WASHER PAHZZ MS RING,RETAINING PAHZZ VALVE LINEAR,DIRECT PAHZZ SPRING,HELICAL,COMP PAHZZ SPRING,HELICAL,COMP PAHZZ SPRING,HELICAL,COMP PAHZZ PIN.SHOULDER,HEADLE PAHZZ SPOOL.INCHING PAHZZ SPRING,HELICAL,COMP PAHZZ SPRINGCHELICAL,COMP PAHZZ WASHER,FLAT PAHZZ ROD ASSEMBLY PAHZZ SPRING,HELICAL,COP PAHZZ SPRING,HELICAL,CONP PAHZZ JN1010.PIN,SPRING XAHZZ HOUSING,MODULATION PAHZZ PLUG,SPINDLE VALVE PAHZZ G424.SCREW,CAP,SOCKET HE

122 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 45 PAHZZ E4.WASHER, LOCK KFHZZ K30028.PACKING, PREFORMED PART OF KIT P/N PAHZZ K20008.PACKING,PREFORMED KFHZZ K30104.PACKING, PREFORMED PART OF KIT P/N END OF FIGURE 53-2

123 TM P FIG. 54 TRANSMISSION COOLING LINES

124 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 0721 COOLERS, PUMPS, MOTORS FIG. 54. TRANSMISSION COOLING LINES 1 PAOZL HOSE ASSEMBLY, NONME PAOZZ HOSE ASSEMBLY, NONME PAOZZ H50 CLIP, RETAINING PAOZZ VALVEPCHECK PAOZZ E1008 ADAPTERP, STRAIGHT, TU PAOZZ TUBE ASSEMBLY, METAL PAOZZ E1010 TEE, TUBE PAOZZ E1010 ELBOW, TUBE PAOZZ DMB NUT, SELF-LOCKING, EX PAOZZ CM825 SCREW, CAP, HEXAGON H... 2 END OF FIGURE 54-1

125 TM P FIG. 55 STEERING AXLE INSTALLATION

126 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 11 REAR AXLE GROUP 1100 REAR AXLE ASSEMBLY FIG. 55. STEERING AXLE INSTALLATION 1 PFFZZ SHIM PAFZZ CM24120 SCREW, CAP, HEXAGON H XBFFF AXLE ASSY, MOUNT PAFZZ BEARING, SLEEVE XBFZZ AXLE, MOUNT PFFFF AXLE, VEHICULAR, NOND PFFZZ BUSHING BLANK PAFZZ DM24 NUT, SELF-LOCKING, HE... 2 END OF FIGURE 55-1

127 TM P FIG. 56 STEERING AXLE ASSEMBLY

128 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1100 REAR AXLE ASSEMBLY FIG. 56. STEERING AXLE ASSEMBLY 1 XBFZZ CENTER ASSY, AXLE PAFZZ GH506 SCREW, MACHINE PAFZZ HM8 FITTING, LUBRICATION PAFZZ PIN, STRAIGHT, HEADED KFFZZ BEARING, ROLLER, TAPE PART OF KIT P/N KFFZZ SEAL, PLAIN ENCASED PART OF KIT P/N PAFZZ SPINDLE, WHEEL, DRIVI PAFZZ SPINDLE, WHEEL, DRIVI PAFZA SEAL, PLAIN ENCASED PAFZZ LM CONE AND ROLLERS, TA PFFFF HUB, WHEEL, VEHICULAR PAFZZ STUD, PLAIN PAFZZ BRACKET, EYE, NONROTA PAFZZ LM CUP, TAPERED ROLLE PAFZZ B7CI202A.CUP, TAPERED ROLLER PAFZZ LM48548 CONE AND ROLLERS, TA PAFZZ MS PIN, COTTER PAFZZ CAP, GREASE PAFZZ SN10 NUT, PLAIN, SLOTTED, H PAFZA WASHER, FLAT PAFZZ EM200 WASHER, FLAT PAFZZ F518 PIN, COTTER KFFZZ SHIM SET PART OF KIT P/N KFFZZ SHIM SET PART OF KIT P/N KFFZZ SPACER, PLATE PAFZZ CM820 SCREW CAP, HEXAGON H PAFZZ HM8 FITTING, LUBRICATION PAFZZ CAP, PILLOW BLOCK KFFZZ GE20ES-2RS BEARING, PLAIN, SELF-PART OF KIT P/N PAFZZ ARM, PIVOTING WHEEL PAFZZ MS FITTING, LUBRICATION PAFZZ CM1645 SCREW, CAP, HEXAGON H PAFZZ PIN, STRAIGHT, HEADLE... 1 END OF FIGURE 56-1

129 TM P FIG. 57 PARKING BRAKE AND LINKAGE

130 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 12 BRAKES GROUP 1201 HAND BRAKES FIG. 57. PARKING BRAKE AND LINKAGE 1 PAOZZ M8X45 SCREW, CAP, HEXAGON H PAOOZ LEVER, MANUAL CONTRO PAOZZ F312.PIN, COTTER PAOZZ E12.WASHER, FLAT PAOZZ n38.PIN PAOZZ CLAMP PAOZZ MS PINCOTTER PAOZZ PIN, STRAIGHT, HEADED PAOZZ CLAMP PAOZZ G412 SCREW, CAP, SOCKET HE PAOZZ MS NUT, PLAIN, HEXAGON PAOZZ DM8 NUT, PLAIN, HEXAGON... 2 END OF FIGURE 57-1

131 TM P FIG. 58 BRAKE ASSEMBLY

132 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1202 SERVICE BRAKES FIG. 58. BRAKE ASSEMBLY 1 XBOOO BRAKE,SINGLE DISK PAOO BRAKE,SINGLE DISK PAOZZ GM820.SCREW, MACHINE PAOZZ VALVE, BLEEDER HYDRA PAOZZ EM80.WASHER.LOCK PAOZZ CYLINDERHYDRAULIC PAOZZ CM812.SCREW,CAP,HEXAGON H PAOZZ PIVOT PFOZZ LEVER, REMOTE CONTRO PFOZZ LEVER, REMOTE CONTRO PAOZZ BRAKE SHOE SET PAOZZ SPRING, HELICAL, CONP PAOZZ SPRING, HELICAL, COMP PAOZZ SCREW, MACHINE PAOZZ SHIM...V 13 PAOZZ SHIM...V 13 PAOZZ SHIM...V 14 PAOZZ SPRING, HELICAL, COMP PAOZZ ADJUSTOR PAOZZ SPRING, HELICAL, COMP PAOZZ STRUTBRAKE PAOZZ SPRING, HELICAL, COMP PAOZZ PLATE PAOZZ STRAP, PLATE XBOZZ SPIDER PLATE, RH XBOZZ SPIDER PLATE, LH PAOZZ PLUG PAOZZ SCREW, CAP, HEXAGON H... 1 END OF FIGURE 58-1

133 TM P FIG. 59 BRAKE ASSEMBLY, DRIVE AXLE

134 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1202 SERVICE BRAKES FIG. 59. BRAKE ASSEMBLY, DRIVE AXLE 1 XBHZZ PLATE, MOUNTING XBHZZ SPACER PAOZZ D CABLE AND CONDUIT A XDOZZ STUD PAOZZ M WASHER, LOCK XDOZZ NUT, PLAIN, HEXAGON PAOZZ C928CR SCREW, CAP, HEXAGON H PAOZA SEAL PAOZZ JM CONE AND ROLLERS, TA PAOZZ JM CUP, TAPERED ROLLER PAOZZ HUB, WHEEL,VEHICULAR PAOZZ STUD, PLAIN PAOZZ TUBING, NON METALLIC PAOZZ JLM CUP, TAPERED ROLLER PAOZZ SHIM SIZE IS V 15 PAOZZ SHIM SIZE IS V 15 PAOZZ SHIM SIZE IS V 15 PAOZZ SHIM SIZE IS V 16 PAOZZ C514 SCREW, CAP, HEXAGON H PFOZZ PLATE, MOUNTING XBOZZ PLATE, BRG RETAINER PAOZZ JLM CONE AND ROLLERS, TA PAOZZ MS SCREW, CAP, HEXAGON H PAOZZ MS WASHER, LOCK PAOZZ COVER, ACCESS... 2 END OF FIGURE 59-1

135 TM P FIG. 60 BRAKE LINES AND FITTINGS

136 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1204 HYDRAULIC BRAKE SYSTEM FIG. 60. BRAKE LINES AND FITTINGS 1 PAOZZ H CYLINDER, HYDRAULIC PAOZZ H CYLINDER, HYDRAULIC PAOZZ FM14200 SEAL RING, METAL PAOZZ ADAPTER, BRAKE DRUM PAOZZ TUBE ASSEMBLY, METAL PAOZZ TUBE ASSEMBLY, METAL PAOZZ K02 PLUG, PIPE PAOZZ BH031C400N BOLT, MACHINE PAOZZ EM80 WASHER, FLAT PAOZZ FITTING, BRAKE PAOZZ TUBE, METALLIC PAOZZ TUBE ASSEMBLY, METAL PAOZZ TUBE ASSEMBLY, METAL PAOZZ FITTING, BRAKE PAOZZ FM12155 SEAL, PLAIN... 1 END OF FIGURE 60-1

137 TM P FIG. 61 BRAKE PEDAL AND LINKAGE

138 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1204 HYDRAULIC BRAKE SYSTEM FIG. 61. BRAKE PEDAL AND LINKAGE 1 PAOZZ H40 CLAMP, HOSE PAOZZ RESERVOIR, BRAKE FLU PAOZZ HOSE, NONMETALLIC XBOZZ BRACKET, BRAKE MTG PAOZZ HM NUT, SELF-LOCKING, HE PAOZZ KEEPER PAOZZ CM825 SCREW, CAP, HEXAGON H PAOZZ D08 NUT, PLAIN, HEXAGON PAOZZ CM830 SCREW, CAP, HEXAGON H PAOZZ CN36100 SCREW, CAP, HEXAGON H PAOZZ DM10 NUT, PLAIN, HEXAGON XOOZZ CM1025 SCREW, CAP, HEXAGON H PADOO LEVER PEDAL ASSY, RH PAOZZ BUSHING, SLEEVE XAOZZ LEVER, PEDAL RH PAOZZ SHAFT, STRAIGHT PAOOO LEVER PEDAL ASSY, LH XAOZZ LEVER, PEDAL LH PAOZZ BUSHING, SLEEVE PAOZZ PAD, PEDAL PAOZZ UM5009 CLAMPHOSE PAOZZ JH1030 PIN, STRAIGHT, HEADED PAOZZ RING, RETAINING PAOZZ M6 NUT, PLAIN, HEXAGON PAOZZ TEE, HOSE PAOZZ HOSE, NONMETALLIC 3.94 INCHES LONG PAOZZ HOSE, NONMETALLIC 2.25 INCHES LONG... 1 END OF FIGURE 61-1

139 TM P FIG. 62 WHEEL ASSEMBLY, STEERING

140 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 13 WHEELS AND TRACKS GROUP 1313 TIRES, TUBES, TIRE CHAINS FIG. 62. WHEEL ASSEMBLY, STEERING 1 PBOOO TIRE/WHL ASSY PAOZZ TIRE, SOLID PAOZZ AN.WHEEL, PNEUMATIC TIR PAOZZ NUT, PLAIN, CONE SEAT END OF FIGURE 62-1

141 TM P FIG. 63 WHEEL ASSEMBLY, DRIVE

142 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1313 TIRES, TUBES, TIRE CHAINS FIG. 63 WHEEL ASSEMBLY, STEERING 1 PBOOO TIRE/WHL DRIVE PAOOO AN.WHEEL, PNEUMATIC TIR PAOZZ LR12..RING, LOCKING PAOZZ SR12..RING, SIDE PAOZZ RIM, WHEEL, PNEUMATIC PAOZZ TIRE PAOZZ NUT, CAP, DUAL WHEEL END OF FIGURE 63-1

143 TM P FIG. 64 STEERING SYSTEM ASSEMBLY

144 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 14 STEERING GROUP 1401 MECHANICAL STEERING GEAR ASSEMBLY FIG. 64. STEERING SYSTEM ASSEMBLY 1 XDOZZ G1010 SCREW, TAPPING, THREA PAOZZ A1 PLATE ASSEMBLY PAOZA INSULATION, HORN WIR PAOZA NUT PAOZZ STEERING WHEEL PAOZZ MS GROMMET, NONMETALLIC XBOZZ BRACKET, SUPPORT PAOZZ MS SCREW, CAP, HEXAGON H XBOZZ BRACKET, STR COLUMN PAOZZ DM8 NUT, PLAIN, HEXAGON PAOZZ CM820 BOLT, MACHINE PAOZZ NUT, SELF-LOCKING, EX XB0ZZ BRACKET, STR COLUMN PAOZZ CM1025 BOLT, MACHINE PAOZZ SPACER, SLEEVE PAOZZ CM825 SCREW, CAP, HEXAGON H PAOFF VALVE, STEERING SELE PAOZZ CAP, ELECTRICAL PAOZZ SPRING, HELICAL, COMP PAOZZ CONTACT, ELECTRICAL PAOZZ PUSH BUTTON PFOZZ COVER, HORN BUTTON... 1 END OF FIGURE 64-1

145 TM P FIG. 65 STEERING PUMP ASSEMBLY

146 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 1 PAOFF STEERING GEAR KFFZZ SEAL, 25 MM PART OF KIT P/N PAFZZ RING, RETAINING PAFZZ BUSHING, SEAL GLAND KFFZZ SEAL, 47.2 MM PART OF KIT P/N KFFZZ SEAL,QUAD RING PART OF KIT P/N KFFZZ BEARING.RACE PART OF KIT P/N KFFZZ BEARING,NEEDLE THRU PART OF KIT P/N PAFZZ SPRING, CENTERING KFFZZ SEAL, 73.5 MM PART OF KIT P/N KFFZZ PLATE,SPACER PART OF KIT P/N XBFZZ DRIVE XBFZZ GEROTOR XBFZZ SPACER KFFZZ CAP, END PART OF KIT P/N KFFZZ SCREW, CAP, HEX HO PART OF KIT P/N PAFZZ PIN, STRAIGHT, HEADLE XBFZZ RETAINER, CHECK BALL XBFZZ BALL, CHECK KFFZZ SEAL, 7.7 MM PART OF KIT P/N XBFZZ SEAT, CHECK BALL KFFZZ SEAL, 9.3 MM PART OF KIT P/N PAFZZ SCREW, SET... 1 END OF FIGURE 65-1

147 TM P FIG. 66 STEERING COLUMN ASSEMBLY

148 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1401 MECHANICAL STEERING GEAR ASSEMBLY FIG. 66. STEERING COLUMN ASSEMBLY 1 PAOFF HOUSING, STEERING CO PAOZZ CAP, STEERING COLUMN PAOZZ G612.BOLT, MACHINE PAOZZ PARTS KIT, HORN BUTT PAOZZ SCREW... 4 END OF FIGURE 66-1

149 TM P FIG. 67 POWER STEERING CYLINDER ASSEMBLY

150 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1401 MECHANICAL STEERING GEAR ASSEMBLY FIG. 67. POWER STEERING CYLINDER ASSEMBLY 1 PBFFF CYLINDER ASSEMBLY,A PAFZZ DM10.NUT, PLAIN, HEXAGON PAFZZ RETAINER, PACKING PFFZZ STUD,PLAIN XBFZZ TUBE, CYLINDER KFFZZ K40300.PACKING, PREFORMED PART OF KIT P/N PAFZZ RETAINER, PACKING KFFZZ A5 U X5.WIPER, ROD PART OF KIT P/N X6/4 9 KFFZZ BA X6.SEAL, ROD PART OF KIT P/N X KFFZZ K30228.PACKING, PREFORMED PART OF KIT P/N KFFZZ RING, PISTON PART OF KIT P/N PAFZZ ROD, PISTON, LINEAR A... 1 END OF FIGURE 67-1

151 TM P FIG. 68 POWER STEERING LINES AND FITTINGS

152 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1411 HOSES, LINES, AND FITTINGS FIG. 68. POWER STEERING LINES AND FITTINGS 1 PAOZZ HOSE ASSEMBLYPNONE PAOZZ TTO-06X06 ADAPTER, STRAIGHT TU PAOZZ K012.O-RING PAOZA PACKING, PREFORMED PAOZZ FF1868T-06-06S ELBOW, TUBE TO BOSS PAOZZ BK012.O-RING PAOZA K6.PACKING, PREFORMED PAOZZ HOSE ASSEMBLY, NONME PAOZZ TUBE ASSEMBLY, METAL PAOZZ K012.O-RING PAOZA H23 CLAMP, LOOP XDOZZ CM812 SCREW, CAP, HEXAGON H PAOZZ FC COVER, ACCESS PAOZZ CN1035 BOLT MACHINE PAOZZ PT PUSH ON NUT PAOZZ H46 CLAMP, LOOP PAOZZ DM10 NUT,PLAIN,HEXAGON... 1 END OF FIGURE 68-1

153 TM P FIG. 69 FRAME ASSEMBLY

154 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 15 FRAME, TOWING ATTACHMENTS, DRAWBARS, AND ARTICULATION SYSTEMS GROUP 1501 FRAME ASSEMBLY FIG. 69. FRAME ASSEMBLY 1 XAFHH FRAME ASSY... 1 END OF FIGURE 69-1

155 TM P FIG. 70 LIFTING EYES AND TIEDOWN INSTALLATION

156 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1501 FRAME ASSEMBLY FIG. 70. LIFTING EYES AND TIEDOWN INSTALLATION 1 XBOZZ EYE NUT XBOZZ CL-50-SHR TIE DOWN, AIR PAOZZ C1488 SCREW, CAP, HEXAGON H PAOZZ WASHER, FLAT... 2 END OF FIGURE 70-1

157 TM P FIG. 71 COUNTERWEIGHT INSTALLATION

158 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1502 COUNTERWEIGHTS FIG. 71. COUNTERWEIGHT INSTALLATION 1 PAOZZ CM2045 SCREW, CAP, HEXAGON H PAOZZ EN2051 WASHER, FLAT PAOZZ LIO20 NUT, PLAIN, HEXAGON XBOZZ S5585 COUNTERWEIGHT PAOZZ CM20160 SCREW, CAP, HEXAGON H PAOZZ WASHER FLAT... 2 END OF FIGURE 71-1

159 TM P FIG. 72 DRIVERS OVERHEAD GUARD

160 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 18 BODY, CAB, HOOD AND HULL GROUP 1801 BODY, CAB, HOOD, AND HULL ASSEMBLIES FIG. 72. DRIVERS OVERHEAD GUARD 1 XBOZZ DRIVERS ASSY, GUARD PAOZZ CM1235 SCREW, CAP, HEXAGON H XBOZZ PLATE, MTG FR PAOZZ M7403 SCREW, CAP, HEXAGON H XBOZZ PLATE, MTG REAR PAOZZ PAO, SOUND... 1 END OF FIGURE 72-1

161 TM P FIG. 73 SHEET METAL ASSEMBLY (PAGE 1 OF 2)

162 TM P FIG. 73 SHEET METAL ASSEMBLY (PAGE 2 OF 2)

163 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1801 BODY, CAB, HOOD AND HULL ASSEMBLIES FIG. 73. SHEET METAL ASSEMBLY 1 XBOZZ SUPPORT, SEAT ASSY XBOZZ COVER, VALVE MOOZZ TAPE FOAM PAOZZ CM813 SCREW, 9CAP, HEXAGON H XBOZZ DOOR ASSY LEFT PAOZZ MS NUT, PLAIN, HEXAGON PAOZZ BUMPER, NONMETALLIC PAOZZ JM690 PIN, STRAIGHT, HEADED PADZZ PIN, HITCH PAOZZ BUMPER, NONMETALLIC PAOZZ LA TCH PAOZZ SPRING, HELCAL, TORS XBOZZ DOOR ASSY, RIGHT PAOZZ WASHER, FLAT PAOZZ HINGE, DOOR, VEHICULA PAOZZ HINGE, STRAP PAOZZ LUG NUT, SELF-LOCKING PAOZZ PT PUSH ON NUT PAOZZ CM1030 BOLT, MACHINE PAOZZ STUD, LATCH PAOZZ DMH12 NUT PLAIN HEXAGON PAOZZ MS WASHER, FLAT XDOZZ CM1030 SCREW CAP, HEXAGON H PAOZZ NUT, SELF-LOCKING.EX PAOZZ P BUTTON, PLUG PAOZZ SCREW CAP, HEXAGON H XBOZZ PLATE ASSY, FRONT PAOZZ SHIM... V 28 PAOZZ 2L480 SD0352-IT SEAL, NONMETALLIC SP PAOZZ TRIM SEAL PAOZZ SPRING, HELICAL COMP XBOZZ HANDLE PAOZZ MS WASHER FLAT PAOZZ SPACER SLEEVE PAOZZ MS NUT, PL.AIN, HEXAGON PAOZZ A-596 BUMPER NONETALLIC PAOZZ SPRING, HELICAL, TORS XBOZZ ROD PAOZZ LEVER, REMOTE CONTROL PAOZZ CM820 BOLT, MACHINE PAOZZ OH8 NUT, SELF-LOCKING, HE PAOZZ EM100 WASHER, FLAT PAOZZ PT PUSH ON NUT PAOZZ J0910 PIN STRAIGHT, HEADLE PAOZZ SHAFT STRAIGHT PAOZZ LOCK PAOZZ TUBE, SPACER XBOZZ BRACKET, SEAT LATCH

164 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 48 PAOZZ 1CJ86 8N57M6X40 SCREW, CAP, HEXAGON H PAOLZ JM1040 PIN, STRAIGHT, HEADED PAOZZ LAIC PAOZZ M6 SCREW, CAP, HEXAGON PAOZZ MS PIN COTTER PAOZZ JN1260 PIN, STRAIGHT HEAD PAOZZ ICM860 SCREW, CAP, HEXAGON H PAOZZ SPRING PAOZZ EM120 WASHER, FLAT XBOZZ BRACKET. HINGE SEAT PAOZZ CM825 B0LY, MACHINE PAOZZ U CYLINDER ASSEMBLY PAOZZ M8 NUT, PLAIN, HEXAGON PAOZZ EM800 WASHER FLAT PAOZZ X RING, RETAINING PAOZZ PIN, STRAIGHT, HEADED... 2 END OF FIGURE 73-2

165 TM P FIG. 74 INSULATION PANELS INSTALLATION

166 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1801 BODY, CAB HOOD. AND HULL ASSEMBLIES FIG. 74. INSULATION PANELS INSTALLATION 1 PAOZZ INSULATION, ACOUSTIC PAOZZ INSULATION PANEL VE PAOZZ INSULATION, ACOUSTIC PAOZZ INSULATION, ACOUSTIC PAOZZ INSULATION, ACOUSTIC PAOZZ INSULATION, ACOUSTIC... 1 END OF FIGURE 74-1

167 TM P FIG. 75 FLOOR PLATES INSTALLATION

168 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1805 FLOORS SUBFLOORS, AND RELATED COMPONENTS FIG. 75. FLOOR PLATES INSTALLATION 1 XBOZZ DOOR, LOWER LEFT PAOZZ LUGS RETAINER, NUT AND BO XBOZZ PLATE ASSY, FLOOR XBOZZ PLATE. FLOOR FRONT PAOZZ CN825 SCREW, CAP, HEXAGON H PAOZZ CM820 SCREW, CAP, HEXAGON H XBOZZ PLATE, STEP NON SKID PAOZZ M8 NUT, PLAIN, HEXAGON PAOZZ BOLT SELF-LOCKING XBOZZ DOOR LOWER RIGHT PAOZZ LUG NUT, SELF-LOCKING... 1 END OF FIGURE 75-1

169 TM P FIG. 76 SEAT INSTALLATION

170 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1806 UPHOLSTERY SEATS AND CARPETS FIG. 76. SEAT INSTALLATION 1 PAOOO SEAT, VEHICULAR PAOZZ lcn816h SCREW CAP, HEXAGON H PAOZZ NUT SELF-LOCKING, HE PAOZZ E180 WASHER1FLAT... 4 END OF FIGURE 76-1

171 TM P FIG. 77 SEAT ASSEMBLY

172 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 1806 UPHOLSTERY SEATS AND CARPETS FIG. 77. SEAT ASSEMBLY 1 PAOZZ F08490 RETRACTOR, SAFETY BE PAOZZ SPACER PAOZZ CUSHION, BACK REST PAOZZ CUSHION, SEAT, VEHICU XBOZZ SEAT ASSY, FRAME PAOZZ G512 SCREW, MACHINE PAOZZ E0109 SCREW ROLLER ASSEM PAOZZ E6 WASHER, FLAT PAOZZ NUT, SELF-LOCKING, HE PAOZZ SCREW PAOZZ ADJUSTER, VEHICULAR PAOZZ G3110 SCREW, TAPPING PAOZZ SLIDE ASSEMBLY, SEAT PAOZZ DECAL PAOZZ COVER, BACK REST PAOZZ MS WASHER, FLAT PAOZZ G2510 SCREW, TAPPING PAOZZ G3714 SCREW PAOZZ RESTRAINT ASSEMBLY PAOZZ SCREW, MACHINE... 4 END OF FIGURE 77-1

173 TM P FIG. 78 NAMEPLATES AND DECALS

174 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 22 BODY, CHASSIS AND HULL ACCESSORY ITEMS GROUP 2210 DATA PLATES AND INSTRUCTION HOLDERS FIG. 78. NAMEPLATES AND DECALS 1 PAOZZ DECAL PAOZZ DECAL PAOZZ MARKER IDENTIFICATI PFOZZ DECAL PFOLZ DECAL PFOLZ DECAL PFOZZ DECAL PAOZZ MARKER, IDENTIFICATI XBOZZ DECAL XBOZZ PLATE-UL CLASS "OS PAOZZ DECAL PAOZZ PLATE, INSTRUCTION PAOZZ DECAL XBOZZ NAMEPLATE, TRANS OIL XBOZZ NAMEPLATE, ENG OIL XBOZZ PLATE, NAME XBOZZ PLATE-WHEEL LOADING PAOZZ PLATE, INSTRUCTION XBOZZ PLATE, SHIPPING DATA XBOZZ PLATE, SAFETY RATING XBOZZ PLATE, IDENTIFICATIO PAOZZ DECAL PAOZZ DECAL TIEDOWN PAOZZ DECAL... 2 END OF FIGURE 78-1

175 TM P FIG. 79 HYDRAULIC PUMP MOUNTING

176 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 24 HYDRAULIC AND FLUID SYSTEMS GROUP 2401 PUMP AND MOTOR FIG. 79. HYDRAULIC PUMP MOUNTING 1 PAOZZ B GASKET PAOFF K C PUMP PAOZZ CM1640 SCREW, CAP, HEXAGON H... 2 END OF FIGURE 79-1

177 TM P FIG. 80 Hydraulic Pump Assembly

178 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2401 PUMP AND MOTOR FIG. 80. HYDRAULIC PUMP ASSEMBLY 1 PAOZZ K PLUG, CORE XBOZZ K SEAT, PILOT VALVE... 1l _3 KFOZZ K F PACKING, PREFORMED PART OF KIT P/N HH... 4 KFOZZ K K PACKING PREFORMED PART OF KIT P/N OHH... 5 XBOZZ K M VALVE PILOT PAOZZ K OOL SPRING, HELICAL, COMP XAOZZ K BA3 VALVE BODY KFOZZ K PACKING, PREFORMED PART OF KIT P/N OHH... 9 KFOZZ K SEAL, BACKUP PART OF KIT P/N KFOZZ K R SEAL PART OF KIT P/N OHH XBOZZ K Z BUSHING XAOZZ K1076 1PXB250L10H4B1K BODY XBOZZ K UU6 GEAR, DRIVE XBOZZ K BUSHING XAOZZ K C X FLANGE, MOUNTING KFOZZ K T SEAL, SHAFT PART OF KIT P/N OHH KFOZZ K INTERNAL CIRCLIP PART OF KIT P/N OHH XBOZZ K UU6 GEAR, DRIVEN X8OZZ K ZPV PLUG, PRESSURE PAOZZ WASHER LOCK PAOZZ K1076 B X BOLT MACHINE PAOZZ K N BOLT MACHINE XBOZZ K G DAMPING ORIFICE PAOZZ K L FILTER ELEMENT FLUI XBOZZ K C SPOOL PAOZZ K K SPRING HELICAL, COMP KFOZZ K C PACKING, PREFORMED PART OF KIT P/N OHH PAOZZ K SEAT, HELICAL COMPRE KFOZZ K C PACKING, PREFORMED PART OF KIT P/N OHH... END OF FIGURE 80-1

179 TM P FIG. 81 MAIN LINKAGE CONTROL VALVE MOUNTING

180 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2402 MANIFOLD AND/OR CONTROL VALVES FIG. 81. MAIN LINKAGE CONTROL VALVE MOUNTING 1 PAOZZ PIN PAOFF CMC-WAl VALVE, HOLD, BOOM HOI PAOZZ H NIPLE, HOSE PAOZZ CAP, PROTECTIVE, DUST PAOZZ M7785 SCREW, CAP, HEXAGON H XBOZZ BRACKET, MTG... 1 END OF FIGURE 81-1

181 TM P FIG. 82 THREE SPOOL VALVE CARTRIDGE

182 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2402 MANIFOLD AND/OR CONTROL VALVES FIG. 82. THREE SPOOL VALVE CARTRIDGE 1 PAOZZ VALVE, SAFETY RELIEF... 3 END OF FIGURE 82-1

183 TM P FIG. 83 MAIN VALVE ASSEMBLY

184 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2402 MANIFOLD AND/OR CONTROL VALVES FIG. 83. MAIN VALVE ASSEMBLY 1 PAFZZ SCREW, CAP, HEXAGON H PAFZZ PLUG, MACHINE THREAD PAFZZ MS PACKING, PREFORMED PAFZZ SPRING, HELICAL, COMP PAFZZ VALVE, POPPET ENGINE PAFZZ WASHER SLOTTED PAFZZ SLEEVE PAFZZ RETAINER XBFZZ COVER PAFZZ SCREW, CAP, SOCKET HE PAFZZ WASHER, FLAT PAFZZ PACKING9PREFORMED PAFZA PACKING, PREFORMED PAFZZ SPRING. HELICAL, COP PAFZZ MS PLUG, MACHINE THREAD PAFZZ PIN, GROOVED, HEADLES PAFZA PACKING, PREFORMED PAFZZ SCREW, CAP, HEXAGON H XBFZZ CNC SECTION SAV PAFZA PACKING PREFORMED PAFZA PACKING PREFORMED PAFZZ RING RETAINING PAFZZ PACKING, PREFORMED PAFZZ PACKING PREFORMED PAFZZ RETAINER, PACKING PAFZZ FLOW CONTROL, TILT XBFZZ RETAINER PAFZZ SCREW CAP HEXAGON H PAFZZ G804 SCREW, CAP, HEXAGON H PAFZZ RING, WIPER PAFZZ WASHER, FLAT PAFZZ PACKING, PREFORMED PAFZZ SPRING, HELICAL COMP PAFZZ HYDROSTAT PAFZA DISK. VALVE PAFZZ SPRING, HELICAL COP PAFZZ PISTON PAFZZ A PACKING, PREFORMED PAFZZ SHIM SET PAFZZ NUT, PLAIN, HEXAGON... 2 END OF FIGURE 83-1

185 TM P FIG. 84 VALVES AND LEVERS

186 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2403 HYDRAULIC CONTROLS AND/OR MANUAL CONTROLS FIG. 84. VALVES AND LEVERS 1 PAOZZ KNOB PAOZZ CtI620 SCREW, CAP, SOCKET, HE PAOZZ KNOB PAOZZ KNOB PAOZZ LEVER, REMOTE CONTRO PAOZZ LEVER, REMOTE CONTRO XBOZZ BRACKET,LEVER MTG PAOZZ CUP,RETAINING PAOZZ SHAFT,STRAIGHT PAOZZ SCREW,CAP,HEXAGON H PAOZZ DM10 NUT,PLAIN,HEXAGON PAOZZ COVER XBOZZ BRACKET,LEVER,GUIDE PAOZZ CM1025 BOLT, MACHINE PAOZZ SPRING, HELICAL, COMP PAOZZ LEVER, REMOTE CONTRO PAOZZ NUT,SELF-LOCKING,HE... 3 END OF FIGURE 84-1

187 TM P FIG. 85 TILT CYLINDER MOUNTING

188 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2404 TILT CYLINDERS AND TILT CRANK FIG. 85. TILT CYLINDER MOUNTING 1 PAOZZ GE35ES BEARING, PLAIN, SELF PAOZZ SPACER, SLEEVE PAOZZ PIN, HOLLOW PAOZZ CM820 SCREW, TAPPING PAOZZ SPACER, SLEEVE PAOZZ SHIM PAOZZ SHIM XBOZZ ROD END (MACH) PAOZZ NUT SELF-LOCKING, EX PAOZZ HM8 FITTING, LUBRICATION PAOZZ A816-9L BEARING, PLAIN SELF PAOZZ PIN STRAIGHT HEADED PAOZZ SPACER SLEEVE PAOZZ MS SCREW, CAP, HEXAGON H PAOZZ MS WASHER, FLAT PAOZZ CH1680 SCREW, CAP, HEXAGON H PAOZZ PIN RETAINING... 2 END OF FIGURE 85-1

189 TM P FIG. 86 TILT CYLINDER ASSEMBLY

190 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2404 TILT CYLINDERS AND TILT CRANK FIG. 86. TILT CYLINDER ASSEMBLY 1 PAOFZ CYLINDER ASSY TILT KFFZZ 4J413 M700-C5162 WIPER, ROD PART OF KIT P/N KFFZZ 4J413 M300-C5163 CUP, ROD PART OF KIT P/N PAFZZ GLAND PAFZZ BAR. RETAINING KFFZZ SEAL PART OF KIT P/N PAFZZ ROD PISTON, HYDRAULI KFFZZ K30218 PACKING, PREFORMED PART OF KIT P/N KFFZZ TFE-S-11SPL SEAL PISTON PART OF KIT P/N PAFZZ K3 PLUG, SHUTTLE VALVE XAFZZ CASE ASSY INTERIM... 1 END OF FIGURE 86-1

191 TM P FIG. 87 CARRIAGE AND COMPONENTS

192 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2405 MAST COLUMN FIG. 87. CARRIAGE AND COMPONENTS 1 PAFZZ SCREW CAP. SOCKET HE PAFZZ WASHER, FLAT PAFZZ BEARING, BALL ANNULA PAFZZ WASHER, FLAT PAOZZ FORK LIFT TRUCK XBFZZ CARRIAGE PAFZZ SHAFT, SHOULDERED PAFZZ A44174 BEARING, ROLLER, THRU... 2 END OF FIGURE 87-1

193 TM P FIG. 88 PRIMARY CYLINDER ASSEMBLY

194 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2405 MAST COLUMN FIG. 88. PRIMARY CYLINDER ASSEMBLY 1 XAFZZ ROD ASSY PISTON PAFZZ RING, BEARING INNER XAFZZ TUBE ASSY PAFZZ SEAL, RING METAL PAFZZ GLAND PAFZZ SEAL, DOUBLE LIP PAFZA WINDSHIELD WIPER... 1 END OF FIGURE 88-1

195 TM P FIG. 89 SIDE SHIFTER HOSES, KISSEN KIT

196 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2405 MAST COLUMN FIG. 89. SIDE SHIFTER HOSES, KISSEN KIT 1 PAFZZ JS COUPLING, HOSE PAFZZ ADAPTER, STRAIGHT, TU PAFZZ HOSE PREFORMED CUT TO 5 FT PAFZA K3 REDUCER, TUBE PAFZZ K8 O-RING PAFZZ K-5 PLUG TUBE PAFZA K6 PACKING, PREFORMED PAFZZ CM820 SCREW, CAP, HEXAGON H PAFZZ MS PLUG, MACHINE THREAD PAFZZ K8 O-RING PAFZZ MANIFOLD ASSEMBLY PAFZZ TTO-06X06 ADAPTER STRAIGHT TU PAFZA K6 PACKING PREFORMED PAFZZ K012 O-RING... 1 END OF FIGURE 89-1

197 TM P FIG. 90 SIDE SHIFTER CYLINDER

198 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2405 MAST COLUMN FIG. 90. SIDE SHIFTER CYLINDER 1 PAOOO CYLINDER ASSEMBLY PAOZZ WASHER, FLAT PAOZZ ELBOW, TUBE TO BOSS PAOZZ ROD KFOZZ RING, BEARING PART OF KIT P/N KFOZZ SEAL, PISTON PART OF KIT P/N KFOZZ SEAL, ROD PART OF KIT P/N KFOZZ PACKING, PREFORMED PART OF KIT P/N ,... 9 KFOZZ RING, BACK-UP PART OF KIT P/N PAOZZ RETAINER KFOZZ SEAL, WIPER PART OF KIT P/N PAOZZ RING RETAINING PAOZZ RING RETAINING... 2 END OF FIGURE 90-1

199 TM P FIG. 91 SIDE SHIFTER ASSEMBLY

200 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2405 MAST COLUMN FIG. 91. SIDE SHIFTER ASSEMBLY 1 PBO0D E-SS-A052 SIDE SHIFTER ASSEMB PAOZZ BEARING, PLAIN, ROD E PAOZZ BEARING, PLAIN, ROD E PAOZZ NUT, PLAIN HEXAGON PAOZZ HOOK, LOWER PAOZZ WASHER, FLAT PAOZZ SCREW, CAP, HEXAGON H PAOZZ FITTING, LUBRICATION... 2 END OF FIGURE 91-1

201 TM P FIG. 92 LOAD BACK REST INSTALLATION

202 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2405 MAST COLUMN FIG. 92. LOAD BACK REST INSTALLATION 1 XBOZZ LOAD BACK REST PAOZZ WASHER, FLAT PAOZZ SCREW, CAP, HEXAGON H... 2 END OF FIGURE 92-1

203 TM P FIG. 93 UPRIGHT MOUNTING

204 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2405 MAST COLUMN FIG. 93. UPRIGHT MOUNTING 1 PAOZZ BEARING HALF, SLEEVE PAOZZ MS FITTING, LUBRICATION XBOZZ BRACKET, TRUNNION PAOZZ WASHER FLAT PAOZZ CM1280 SCREW, CAP, HEXAGON H... 4 END OF FIGURE 93-1

205 TM P FIG. 94 UPRIGHT CHAIN ASSEMBLY

206 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2405 MAST COLUMN FIG. 94. UPRIGHT CHAIN ASSEMBLY 1 PAOZZ CHAIN ASSEMBLY PAOZZ RING, SNAP PAOZZ MS PIN COTTER PAOZZ DMI6 NUT SELF-LOCKING HE PAOZZ MS PI4NCDTTER PAOZZ DM16 NUT, PLAIN, HEXAGON PAOZZ SPACER, SPHERICAL PAOZZ CHAIN ASSEMBLY SING PAOZZ PIN STRAIGHT HEADED PAOZZ CHAIN ASSEMBLY... 2 END OF FIGURE 94-1

207 TM P FIG. 95 UPRIGHT ASSEMBLY

208 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2405 MAST COLUMN FIG. 95. UPRIGHT ASSEMBLY 1 PAOZZ DECAL XBOZZ RAIL ASSY INNER PAOZZ CH1214 SCREW, CAP HEXAGON H PAOZZ SCREW, CAP, HEXAGON H XBOZZ RETAINER, CHAIN PAOZZ HEAD; PISTON PAOZZ RING; SNAP PBOFZ CYLINDER ASSEMBLY XBOZZ BRACKET, PRIMARY CYL PAOZZ CM816 SCREW, CAP, HEXAGON H PAOZZ T4244 NUT, PLAIN, HEXAGON PAOZZ SHIM PAOZZ BEARING, BALL, ANNULA PAOZZ SPACER; RING PAOZZ CM1220H SCREW, CAP, HEXAGON H XBOZZ RAIL ASSY; INTER XBOZZ RAIL ASSY, OUTER PAOZZ CLAMP XDOZZ ICM1230 SCREW, CAP, HEXAGON H PAOZZ DECAL PAOZZ MARKER; IDENTIFICATION XBOZZ BLOCK; STOP PAOZZ DIN931-M12X10.9 SCREW, CAP; HEXAGON H... 3 A4C 24 PBOFZ CYLINDER ASSEMBLY PAOZZ SHIM PAOZZ DIN961M16X1.5X50 SCREW, CAP, HEXAGON H STL 10.9-B2C END OF FIGURE 95-1

209 TM P FIG. 96 FINAL CYLINDER ASSEMBLY

210 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2405 MAST COLUMN FIG. 96. FINAL CYLINDER ASSEMBLY 1 PAFZZ RING, BEARING, INNER XAFZZ TUBE ASSY PAFZZ K-3 PLUG, PROTECTIVE, DUS XAFZZ ROD ASSY, PISTON PAFZZ SEAL; NONMETALLIC; RO PAFZZ GLAND PAFZZ SEAL, NONMETALLIC, SP PAFZA WINDSHIELD WIPER... 1 END OF FIGURE 96-1

211 TM P FIG. 97 UPRIGHT LINES AND FITTINGS

212 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2406 STRAINERS; FILTERS, LINES AND FITTINGS; ETC. FIG. 97. UPRIGHT LINES AND FITTINGS 1 PAOZZ PULLEY; FLAT PAOZZ RING; SNAP PAOZZ CM1220H SCREW, CAP, HEXAGON H XBOZZ GUARD ASSY PAOZZ CM820 SCREW, CAP, HEXAGON H XBOZZ GUARD ASSY PAOZZ BOLT; U XBOZZ BRACKET, HOSE ANCHOR PAOZZ M6 NUT, PLAIN, HEXAGON PAOZZ FF1852T-0810S ADAPTER; STRAIGHT; TU PAOZZ PACKING, PREFORMED PAOZZ E808 ELBOW PAOZZ K014.O-RING PAOZZ K8.O-RING PAOZZ HOSE ASSEMBLY, NONME PAOZZ MANIFOLD, FEED LINE PAOZZ DMS NUT, PLAIN; HEXAGON PAOZZ VALVE, REGULATING; FL PAOZZ FF1868T1012S ELBOW, BOSS PAOZZ K016 PACKING; PREFORMED PAOZZ K12 O-RING PAOZZ HOSE ASSEMBLY, NONME PAOZZ HOSE ASSEMBLY, NONME PAOZZ 6V SCREW, CAP, HEXAGON H PAOZZ VALVE, CALIBRATED FL PAOZZ HLO-S NIPPLE; TUBE PAOZZ CLAMP PAOZZ H52 CLAMP, HOSE PAOZZ VALVE, FLOW CONTROL PAOZZ BOLT, SHOULDER PAOZZ PULLEY. GROOVE PAOZZ HOSE ASSEMBLY, NONME... 1 END OF FIGURE 97-1

213 TM P FIG. 98 HYDRAULIC TANK ASSEMBLY

214 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2406 STRAINERS, FILTERS, LINES AND FITTINGS, ETC. FIG. 98. HYDRAULIC TANK ASSEMBLY 1 PAOZZ DX1308S BREATHER PAOZZ GAGE ROD, LIQUID LEV XBOZZ TUBE ASSY PAOZZ XP-2526 FILTERING DISK, FLUI PAOZZ N PACKING, PREFORMED PAOZZ MV85643KS418V CLAMP, LOOP PBOZZ TANK, OIL; HYDRAULIC PAOZZ A FILTER; HYDRAULIC PAOZZ FF1852T-1616S ADAPTER, STRAIGHT, TU PAOZZ K16 O-RING PAOZZ K021 PACKING, PREFORMED PAOZZ TUBE ASSEMBLY; METAL PAOZZ CLAMP; HOSE PAOZZ HOSE; NONMETALLIC PAOZZ SPRING; HELICAL, COMP PAOZZ HOSE.; NONMETALLIC PAOZZ NIPPLE, TUBE PAOZZ F10 PACKING; PREFORMED PFOOO ADAPTER, FLUID FILTE PAOZZ CM825 SCREW, CAP, HEXAGON H... 4 END OF FIGURE 98-1

215 TM P FIG. 99 SINGLE AUXILIARY VALVE KIT

216 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2406 STRAINERS FILTERS, LINES AND FITTINGS, ETC. FIG. 99. SINGLE AUXILIARY VALVE KIT 1 PAOZZ FF1852T ADAPTER STRAIGHT, TU PAOZZ F6.PACKING, PREFORMED PAOZZ TUBE ASSEMBLY, METAL PAOZZ TUBE ASSEMBLY, METAL PAOZZ IDM8 NUT; PLAIN, HEXAGON PAOZZ CLAMP PAOZZ ICM820 SCREW, CAP, HEXAGON H... 1 END OF FIGURE 99-1

217 TM P FIG. 100 UPRIGHT HOSE INSTALLATION

218 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2406 STRAINERS, FILTERS, LINES AND FITTINGS, ETC. FIG UPRIGHT HOSE INSTALLATION 1 PFFFF PARTS KIT; HOSE ASSE PAFZZ CM825 SCREW, CAP, HEXAGON H PAFZZ ICM1270 SCREW; CAP; HEXAGON H PAFZZ E22 WASHER, FLAT PAFZZ CN840 SCREW, CAP, HEXAGON H XBFZZ PLATE, PULLEY MTG PAFZZ BUSHING, SLEEVE PAFZZ PULLEY. GROOVE PAFZZ DM12 NUT, SELF-LOCKING; EX PAFZZ GUARD, NYLON XBFZZ BRACKET ASSY; CYL HO XBFZZ BAR; SPACER PAFZZ ICM12180 SCREW; CAP, HEXAGON H PAFZZ JS COUPLING, HOSE PAFZZ TUBE ASSEMBLY; METAL PAFZZ K012 O-RING PAFZZ SPRING; HELICAL, COMP PAFZZ 1W025 03A250K79P125 WASHER; FLAT PAFZZ CM820 SCREW, CAP, HEXAGON H PAFZZ FF S NUT, TUBE COUPLING XBFZZ BRACKET, COMP TUBE XBFZZ PLATE; HOSE ANCHOR PAFZZ ICM850 SCREW; CAP, HEXAGON H PAFZZ BRACKET, HOSE GUIDE PAFZZ PAD; SLIPPER PAFZZ DM8 NUT; SELF-LOCKING; EX... 2 END OF FIGURE 100-1

219 TM P FIG. 101 COWL PLUMBING ASSEMBLY

220 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2406 STRAINERS, FILTERS, LINES AND FITTINGS, ETC. FIG COWL PLUMBING ASSEMBLY 1 PAFZZ JS COUPLING; HOSE PAFZZ HOSE, NONMETALLIC PAFZZ J ELBOW; HOSE PAFZZ GROMMET, NONMETALLIC PAFZZ FF2000T0608S ADAPTER, STRAIGHT; HO PAFZZ BK012 O-RING PAFZZ K014 O-RING... 1 END OF FIGURE 101-1

221 TM P FIG. 102 HYDRAULIC LINES INSTALLATION

222 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2406 STRAINERS, FILTERS, LINES AND FITTINGS, ETC. FIG HYDRAULIC LINES INSTALLATION 1 PAOZZ HOSE, NON METALLIC PAOZZ ADAPTER STRAIGHT; HO PAOZZ MS51525A6 ADAPTER, STRAIGHT; TU PAOZZ F5 PACKING, PREFORMED PAOZZ VALVE; CHECK PAOZZ K012 O-RING PAOZZ F5 PACKING; PREFORMED PAOZZ HOSE ASSEMBLY NONME PAOZZ HOSE ASSEMBLY; NONME PAOZZ FF1868T-0608S ELBOW, TUBE TO BOSS PAOZZ FF1868T-1010S ELBOW, TUBE TO BOSS PAOZZ PACKING; PREFORMED PAOZZ E0109 SCREW, ROLLER ASSEMB PAOZZ J16 COUPLING, TUBE PAOZZ K219 PACKING; PREFORMED PAOZZ H38 CLIP SPECIAL PAOZZ TUBE ASSEMBLY, METAL PAOZZ FF1868T ELBOW, TUBE TO BOSS PAOZZ PACKING; PREFORMED PAOZZ HOSE ASSEMBLY, NONE PAOZZ DM10 NUT, PLAIN, HEXAGON XBOZZ BRACKET, HYD HOSE PAOZZ HOSE ASSEMBLY, NONME PAOZZ H63 CLIP, RETAINING PAOZZ M7166 SCREW, CAP, HEXAGON H PAOZZ CLAMP; HOSE PAOZZ TUBE ASSEMBLY, METAL PAOZZ K40128 PACKING, PREFORMED PAOZZ V M CLAMP, LOOP PAOZZ TUBE ASSEMBLY. METAL PAOZZ FF1868T10125 ELBOW, BOSS PAOZZ U1604 MBEU61512 PACKING, PREFORMED... 2 END OF FIGURE 102-1

223 TM P FIG. 103 HYDRAULIC FILTER ASSEMBLY

224 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2406 STRAINERS, FILTERS, LINES AND FITTINGS, ETC. FIG HYDRAULIC FILTER ASSEMBLY 1 PAOZZ DISK; VALVE PAOZZ SPRING; HELICAL; COMP PAOZZ F9 PACKING; PREFORMED PAOZZ PLUG PAOZZ ADAPTER, FLUID FILTE... 1 END OF FIGURE 103-1

225 TM P FIG. 104 TILT CYLINDER LINES AND FITTINGS

226 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 2406 STRAINERS, FILTERS, LINES AND FITTINGS, ETC. FIG TILT CYLINDER LINES AND FITTINGS 1 PAOZZ FF1868T-0604S ELBOW, TUBE TO BOSS PAOZA F4 PACKING; PREFORMED PAOZZ K5 ADAPTERS; STRAIGHT; TU PAOZZ F5 PACKING; PREFORMED PAOZZ VALVE, CHECK PAOZZ FF1852TO604S ADAPTER, STRAIGHT; TU PAOZZ F5 PACKING; PREFORMED PAOZZ HOSE ASSEMBLY, NONME PAOZZ HOSE ASSEMBLY, NONME PAOZZ HOSE ASSEMBLY, NONME PAOZZ FF1857T0606S ADAPTERS; STRAIGHT, TU PAOZZ F5 PACKING, PREFORMED PAOZZ FF1852T-0406S ADAPTER, STRAIGHT; TU PAOZZ F3 PACKING; PREFORMED PAOZZ E0606 FITTING; TEE PAOZZ F5 PACKING, PREFORMED PAOZZ HOSE ASSEMBLY; NONME PAOZZ FF1868T-0608S ELBOW, TUBE TO BOSS PAOZZ FF1852T-1012S ADAPTER, STRAIGHT, TU PAOZZ F7 PACKING, PREFORMED PAOZZ FF1852T ADAPTER, STRAIGHT; TU PAOZZ F5 PACKING, PREFORMED PAOZZ HOSE ASSEMBLY, NONME PAOZZ HOSE ASSEMBLY, NONME... 1 END OF FIGURE 104-1

227 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP: 94 REPAIR KITS GROUP: 9401 REPAIR KITS FIG. KITS REPAIR KITS 1 PAFZZ 4U132 TM27T01004 PARTS KIT, ENGINE, WA... 1 GASKET ( 1) PAFZZ PARTS KIT, STEERING... BEARING, ROLLER, TAP (4) SEAL, PLAIN, ENCASED (4) SHIM SET (1) PAFZZ SHIM SET... SHIM (4) SHIM (4) BEARING, SPHERICAL (4) PAHZZ SEAL KIT... 1 PACKING, PREFORMED (1) PACKING, PREFORMED (1) GASKET, XMSN CASE (1) SEAL ( 2) SEAL, OIL ( 1) SEAL, PLAIN ( 2) SEAL, PLAIN ( 2) RING, RETAINING ( 4) GASKET, CONTROL V ( 1) SEAL, OIL ( 1) DISK, FILTER ( 1) PACKING, PREFORMED ( 1) PACKING, PREFORMED ( 1) PACKING, PREFORMED ( 1) PACKING, PREFORMED ( 1) GASKET. TRANS. PUMP ( 1) PAFZZ PARTS KIT, SEAL REPL... 1 PACKING, PREFORMED ( 1) SEAL, PISTON ( 1) WIPER, ROD ( 1) CUP, ROD ( 1) SEAL ( 1) PAFZZ PARTS KIT, SEAL REPL... 1 PACKING, PREFORMED ( 1) PACKING, PREFORMED ( 2) SEAL, ROD ( 2) WIPER, ROD ( 2) RING. PISTON ( 1) PAOZZ PARTS KIT, DISC BRAK PAOZZ PARTS KIT, SEAL REPL SEAL, WIPER (2) RING, BACK-UP ( 2) PACKING, PREFORMED ( 2) SEAL, ROD ( 2) RING, BEARING ( 2) SEAL, PISTON ( 1) PAFZZ BEARING KIT, NEEDLE... 1 BEARING, RACE ( 2) BEARING, NEEDLE THR ( 1) KITS-1

228 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY 10 PAFZZ PARTS KIT, SEAL REPL... SEAL, 73.5 MM ( 3) SEAL, 47.2 MM ( 1) SEAL, QUAD RING ( 1) SEAL, 7.7 MM ( 1) SEAL, 9.3 MM ( 1) PAFZZ SPACER KIT... SCREW, CAP, HEX HD ( 7) CAP, END ( 1) PLATE, SPACER ( 1) PAOZZ K OHH SEAL KIT... 1 PACKING, PREFORMED ( 2) SEAL, BACKUP ( 2) SEAL ( 2) SEAL, SHAFT (1) PACKING, PREFORMED (1) PACKING, PREFORMED ( 1) PACKING, PREFORMED ( 1) PACKING, PREFORMED ( 1) INTERNAL CIRCLIP ( 1) PAFZA PARTS KIT, SEAL REPL PAFZA PARTS KIT, SEAL REPL... 1 KITS-2

229 I TM P FIG. 105 SPECIAL TOOLS

230 TM P (1) (2) (3) (4) (5) (6) ITEM SMR PART NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY GROUP 26 TOOLS AND TEST EQUIPMENT GROUP 2604 SPECIAL TOOLS FIG SPECIAL TOOLS 1 PEHZA GAGE ADJUSTMENT PEHZZ WRENCH, BOX... 3 PEHZZ GOVERNOR ASSEMBLY... 4 DEHZZ WRENCH... 5 PEHZZ BUSHING; MACHINE THR... 6 PEHZZ RETRACTOR ASSEMBLY... 7 PEHZZ TESTING EQUIPMENT... 8 PEHZZ l WRENCH; OPEN END... 9 PEHZZ INDICATOR ASSEMBLY PEHZZ RETRACTOR, END PLATE PEHZZ WRENCH; REND CAP PEHZZ INDICATOR, DIAL PEHZZ REMOVER, SHUT OFF CA PEHZZ P90982 COMPRESSOR, PISTON R PEHZZ FIXTURE, PUMP HOLDIN PEHZZ ADAPTER, PRESSURE TE PEHZZ SCREW, LOCATOR... END OF FIGURE 105-1

231 SECTION IV TM P CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM I-1

232 SECTION IV TM P CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM I-2

233 SECTION IV TM P CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM KITS I-3

234 SECTION IV TM P CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM I-4

235 SECTION IV TM P CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM I-5

236 SECTION IV TM P CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM KITS KITS I-6

237 SECTION IV TM P CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM I-7

238 SECTION IV TM P CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM KITS I-8

239 SECTION IV TM P CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM I-9

240 SECTION IV TM P CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM KITS KITS KITS KITS I-10

241 SECTION IV TM P CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM KITS KITS I-11

242 SECTION IV TM P CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM I-12

243 SECTION IV TM P CROSS- REFERENCE-INDEXES NATIONAL STOCK NUMBER INDEX STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM I-13

244 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM A A816-9L AS AS AX A A A5 U X X6/ A BA X X H CJ86 BN57M6X H031C400N H038C0 75D B1821H038C200N BH038C350L BH050C150N B7C1202A CJV CL-50-SHR CMC-D CMC-WA D 1 N9 31-M 12 X A4C D 1N933-M6X A4C D 1N X1.5X STL C DX1308S ERNA FC-6446-P FC FD FF1852T-0406S FF 1852T-0810S FF1852T-1012S FF1852T-1616S FF1852T FF 1852T FF 1852T FF 1857T FF 1868T-0404S FF1868T-06-06S FF1868T-0604S I-14

245 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM CAGEC PART NUMBER STOCK NUMBER FIG. ITEM FF186BT-0608S FF186BT-1010S FF1868T1012S FF 2000T0608S FF S FWG F F U132 F F600L GAH GE20ES-2RS GE 35ES HC H H H H2525M JLM JLM JM JM J U132 K800A LN LM LM LR LUGS LU LUGC U132 LW L U1604 MBE MBGFPM MI MS C MS MS MS MS MS MS MS I-15

246 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM CAGEC PART NUMBER STOCK NUMBER FIG. ITEM MS MS MS MS MS MS MS MS M MS MS MS MS MS MS MS MS MS MS MS MS51525A MS51527A MS MS MS MS MS MS MS MV85643KS418V J413 M300-C J413 M700-C NTA PT PT P P P P P P I-16

247 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM CAGEC PART NUMBER STOCK NUMBER FIG. ITEM P P P P P9111K RB R L4B0 SD352-IT SN SR TFE-S-11SPL TMD20F TMD20T TMD20T TMD20T U132 TMD TMD27A U132 TMD27A TMD27A TM027A U132 TMD27A05031E U132 TMD U132 TND U132 TMD U132 TMD U132 TMD U132 TMD U132 TMD27C U132 TMD27E U132 TMD27E U132 TMD27F U132 TMD27F U132 TMD27F U132 TMD27F TMD27F TMD27F U132 TMD27F TMD27F U132 TMD27F U132 TMD27F U132 TMD27F U132 TMD27F TMD27H TMD27H U132 TMD27H TM TMD TMD U132 TMD27M U132 TMD U132 TM13C I-17

248 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM TM20T U132 TM27A U132 TM27A U132 TM U132 TM U132 TM U132 TM U132 TM U132 TM U132 TM27B TM U132 TM U132 TM27B U132 TM U132 TM U132 TM27C U132 TM27C U132 TM27C U132 TM27F U132 TM27G U132 TM27H U132 TM TM TM TM TM U132 TM U132 TM TM U132 TM TM TM U 132 TM U132 TM U132 TM U132 TN27K U132 TM27K U132 TM27K U132 TM27K U132 TM27L U132 TM27L U132 TM27L U132 TM27L TM27L U132 TM27T KITS 1 4U132 TM27Z TR UM VF4-65F V M W-L-00111/ I-18

249 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM WR WR IS W X U132 XM U132 XM U132 XM XM XM U132 XM U132 XM U132 XM U132 XM U132 XM Xn U132 XM U132 XM U132 XM U132 XM U132 XM U132 XM U132 XM U132 Xn U132 XN U132 XM U132 XM U132 XM U132 XM U132 XM U132 XM XM XM XN U132 XM XP U132 X00203A X00599D U132 X X X X U132 X X I-19

250 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM 4U132 X X B X U132 X X U132 X U132 X U132 X X X X X U132 X X U132 X X X U132 X U132 X U132 X U132 X U132 X X X X U132 X U132 X X U132 Z T T T T T T T T T T T T T T T W025 03A250K79P I-20

251 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM 0EDY S F V CM CM CM CM CM CM CM CM CM CM CM CM CM CM CM816H CM CM CM CM CM DM DM M DM DM I-21

252 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM DM EM EM F F F HM JS J K1076 1PXB250L10H481K EM EM I-22

253 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM I-23

254 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM T X GM XX E JM JM JN JM J I-24

255 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM SEN EM E K T P C C C C928CR M EM EM EM C EN I-25

256 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM EM EM F BG KITS KITS KITS KITS J M M N M N FM FM JM J I-26

257 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM SCG-LR T K C-L E FT T I-27

258 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM I-28

259 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM I-29

260 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM HP K K XXM I-30

261 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM I-31

262 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM E E E G G K K K K K E U132 26XX U132 26XX00137A Cn E E I-32

263 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM I-33

264 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM I-34

265 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM I-35

266 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM I-36

267 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM CM CM CM CM CM CM CM I-37

268 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM CM CM CM CM1220H CM CM CM CM CM CM CM CM I-38

269 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM CM CM CM CM CM CM GM G HM CM CM CM CM H H H H H R H H FUK I-39

270 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM U G A KITS F F K G A L BA CM E F JM R1U-2 MBN-5FZB M M DM F K K K K I-40

271 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM K C K C X A D, LG DM DM M D H H H H H H EDY A A K K N X4X M I-41

272 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM E E-SS-A KITS D K G K I-42

273 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM K K K K K NTU EM E H J K K K K B8Y C7Z KITS KITS KITS I-43

274 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM AN E AN CM CM CM G E E E K U K K K K K HL0-S T D G G TT0-06X G K UU K K R K HH KITS 12 K UU K I-44

275 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM K Z K K L K G K C B 0 25 K K M 80 5 K BA K X K N EM JM K T T F F F F F F F G I-45

276 SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX PART NUMBER INDEX TM P CAGEC PART NUMBER STOCK NUMBER FIG. ITEM 5T K ZPV KITS KITS 14 K B F G G K K 80 4 K F 80 3 K B 80 8 K C K C M8X T T T T T T T T T T T T K T K L 80 6 K K K I-46

277 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER KITS U132 TM27T01004 KITS KITS KITS KITS KITS KITS KITS KITS KITS KITS 12 K HH KITS KITS U132 TMD Cm CN CM E DM D CM DM U132 TM27A U132 X U132 XM U132 TM27Z X X C MS K U132 TMD27A TMD27A X U132 26XX U132 26XX00137A U 132 X U132 X K U132 X U132 TM U132 XM U132 TMD I-47

278 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER U132 TMD U132 TMD U132 TM U132 X U132 XM U132 XM U132 TM27C U132 TM27C U132 TM27H U132 TM U132 TMD27C J X U132 TM U132 TM U132 TM U132 TH U132 TM U132 XN CM U132 TM U132 XM U132 TM27C U132 TM13C U 132 XM X U132 XM XX U132 TM27B U132 TMD U132 XM X TMD20T U132 TMD27A05031E TMD27A U132 K800A U132 TMD U132 TM27G U132 Z TM20T U132 X U132 X U132 TM U132 X U132 XM U132 XM U132 TM U132 TM I-48

279 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER U132 TM TM TM TMD U132 F U132 TD27H X CM U132 XM X00599D U132 X TM U132 TM U132 TM U132 XM U132 X U 132 XM U132 TM27A TM027A TMD TMD TM TM TM TM XM U132 XM U132 TM27F X U132 XM U132 TMD U132 XM TM U132 XM U132 X CM U132 X X U132 TM X FD E F MS51521B K F MS I-49

280 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER F A MS C U132 TM27L U132 TM27L F600L U132 TM27L CM U132 XM U132 XM TM27L X X U132 XM CM F X U132 TN XM EM U132 TM27L U132 XM XXM U132 TM 027E U132 XM U132 X U132 TMD27E U132 XM XM U132 XM CM U132 TMD27F U132 TMD27F U132 TMD27F XM XM X XM TMD20T TM 020T TN027F TMD27F U132 TMD27F E U132 TMD27F CM U132 XM U132 XN U132 TND I-50

281 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER U132 TMD X U132 TMD27F TMD27H E Tn027H U132 LW U132 XM X4X C-L DM F R1U-2MBN-SFZB DM TMD27F CM X X M TMD20F CM DIN933-M6X A4C CM F H AS K L I-51

282 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER MS FT MS I-52

283 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER I-53

284 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER U132 TMD27F H U132 TMD27F U132 X U132 X00203A DIN933-M6X A4C DM U132 X U132 X U132 TMD27F U132 X U132 X P DM EM GAH H A ,2-1-2 LG CM K CM CM D H FWG P P I-54

285 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER P P P P P P T PT DMN M M CN CM X4X A MS X X X F DM CM F J F JM X MD I-55

286 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER H CM AX EM D 1N933-M6X A4C H M H CM H PT M CM U132 TM27K U132 XM U132 TM27K U132 TM27K U132 TM27K FUK EM U132 XM CM EM CM DM I-56

287 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER F EDY A EDY B T T T I-57

288 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER T T T T T T T T T T T ST T T T T T T T T T T T T T ST T T T T CM B DN G CM VF4-65F W-L-00111/ I-58

289 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER LUG GM RB R R L M U EM DM CM E D MS I-59

290 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER HP CJV H CM H H CM EM MS Cn A MS W C EM K MSGFPM I-60

291 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER ERNA B1821BH050C150N G MS P9111K N E MS E H2525M B1821BH038C075D WR WR EM H CM DM CM EM TRB NTA J MS I-61

292 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER G J BH G MS51527A K G E H2525N HC JM Y MS B18218H038C200N

293 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER A NTU MS MS C B18218H038C35 0L H2525M WS SG-LR FC-6446-P K S MS K K K AS K C7Z F K I-63

294 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER MS J G E K K K H E E E DM CN CM M GM HM LM I-64

295 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER LM B7C1202A LN MS SN EM F CM HM GEZ 0ES-2RS MS CM M8X F E MS G MS M GM EM CM I-65

296 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER MS C928CR JM JM JLM C JLM MS MS H H FM K BH031C400N EM FM H40 I-66

297 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER M CM H CM CH DM CM UM JM M AN AN LR SR G A MS MS DM CM CM1025 I-67

298 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER CM G DM K A5 U X5 8X6/ BA X6 0X K I-68

299 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER TTO-06X K K FF1868T-06-06S K K K H CM FC CM PT H DM CL-50-SHR C Cn EM DM CM CM M CM M JM LUG PT I-69

300 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER CM DM M CM P L480 SD352-IT MS MS A CM DM EM PT J CJ86 BN57M6X JM IDM MS JM CM EM CM U DM EM X I-70

301 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER LUGS CM CM DM LUG CM816H DM EM F G E E G MS G G I-71

302 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER K C CM K D 80 2 K K F 80 4 K K 80 5 K M 80 6 K L 80 7 K BA K K K R K Z K1076 1PXB250L10H481K K UU K K C X K T K K UU K ZPV B K X K N K G K L K C K K K C K K C CNC-WA H M I-72

303 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER MS MS CMC G A CN DM I-73

304 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER CM GE35ES CM HM A816-9L MS MS CN J413 M700-C J413 M300-C K TFE-S-11SPL K A JS K3 I-74

305 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER K K K CM MS K TT0-06X K K E-SS-A MS CM MS M MS DM I-75

306 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER CM M CM T CM1220H CM DIN931-M12X10.9- A4C DIN961M16X1.5X50 -STL 10.9-B2C K CM1220H CM DM FF1852T-0810S E K K DM8 I-76

307 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER FF1868T K K V HLO-S H DX1308S XP N MV85643KS418V A FF1852T-1616S K K F CM FF1852T F DM CM CM CM E CM DM12 I-77

308 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER CM J K W025 03A250K79P CM FF S CM DM IJS J FF2000T0608S K K MS51525A F K F FF1868T-0608S FF1868T-1010S E J K H FF1868T-0404S DM H M I-78

309 SECTION IV TM P CROSS REFERENCE INDEXES FIGURE AND ITEM NUMBER INDEX FIG. ITEM STOCK NUMBER CAGEC PART NUMBER K V M FF1868T1012S U1604 MBEU F FF1868T-0604S F K F FF1852T0604S F FF1857T0606S F FF1852T-0406S F E F FF1868T FF1852T-1012S F FF1852T F P I-79

310

311

312

313 PIN:

314 This fine document... Was brought to you by me: Liberated Manuals -- free army and government manuals Why do I do it? I am tired of sleazy CD-ROM sellers, who take publicly available information, slap watermarks and other junk on it, and sell it. Those masters of search engine manipulation make sure that their sites that sell free information, come up first in search engines. They did not create it... They did not even scan it... Why should they get your money? Why are not letting you give those free manuals to your friends? I am setting this document FREE. This document was made by the US Government and is NOT protected by Copyright. Feel free to share, republish, sell and so on. I am not asking you for donations, fees or handouts. If you can, please provide a link to liberatedmanuals.com, so that free manuals come up first in search engines: <A HREF= Military and Government Manuals</A> Sincerely Igor Chudov Chicago Machinery Movers