Angle Broom AP-AB72 & AP-AB PK Parts Manual. Copyright 2018 Printed 07/11/18

Transcription

1 Angle Broom AP-AB72 & AP-AB PK Parts Manual Read the Operator's Manual entirely. When you see this symbol, the subsequent instructions and warnings are serious - follow without exception. Your life and the lives of others depend on it! Copyright 2018 Printed 07/11/18 Cover photo may show optional equipment not supplied with standard unit.

2 Table of Contents Section 1: Introduction...4 Using This Manual...4 Manual Replacement Information...4 Manual Revisions...4 Touch-up Paint...4 Hardware Legend...5 Replacement Hardware...5 Serial Numbers...5 Part Number Service Coding...5 Section 2: Hitch/Broom Components...6 Broom Components 3500 PSI...6 Hitch/Broom Head...8 Section 3: Angling Hydraulic or Manual...10 Hydraulic Angle/Motor Plumbing High Flow 3500 PSI...10 Hydraulic Angle/Motor Plumbing Low/Medium Flow 3500 PSI...12 Manual Angle/Motor Plumbing High Flow 3500 PSI...14 Manual Angle/Motor Plumbing Low/Medium Flow 3500 PSI...16 Section 4: Hydraulics...18 Broom Motor Components 3500 PSI...18 Hydraulic Cylinder ( C) Cross...20 Hydraulic Cylinder ( C) Midway...22 Hydraulic Cylinder ( C) Monarch...24 Hydraulic Motor ( C) White...26 Hydraulic Motor ( C) White...28 Hydraulic Motor 18 Cubic Inch ( C) 3500 PSI...30 Hydraulic Motor 23 Cubic Inch ( C) 3500 PSI...32 Hydraulic Valve Cylinder Control ( C)...34 Hydraulic Valve Flow Control ( C)...36 Section 5: Decals...38 Decal Placement...38 Touch-up Paints...40 Section 6: Options & Accessories...42 Deutsch HD30 14 Pin Plug 73 in. Lg...42 Deutsch HD3014 Pin Plug 10 ft. Lg...44 Dust Deflector...46 Dust Suppression Kit (Water)...48 Hose & Spray Kit...50 Shroud Extension Metal...52 SSP15 Marker Edge...54 Switch & Power Cable ( C)...56 Switch & Wire Harness...58 Switch & Wire Harness ( C)...60 Switch & Wire Harness ( C)...62 Switch & Wire Harness DTP Plug...64 Switch & Wire Harness Tractor Copyright All rights reserved. provides this publication as is without warranty of any kind, either expressed or implied. While every precaution has been taken in the preparation of this manual, assumes no responsibility for errors or omissions. Neither is any liability assumed for damages resulting from the use of the information contained herein. reserves the right to revise and improve its products as it sees fit. This publication describes the state of this product at the time of its publication, and may not reflect the product in the future. The illustrations in this manual are not intended for safe and proper assembly or disassembly of equipment. The illustrations are intended for ordering parts only. is registered trademark. All other brands and product names are trademarks or registered trademarks of their respective holders. Printed in the United States of America. 2 AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

3 Alphabetized Table of Contents B D H K M S Broom Components 3500 PSI...6 Broom Motor Components 3500 PSI...18 Decal Placement...38 Deutsch HD30 14 Pin Plug 73 in. Lg...42 Deutsch HD3014 Pin Plug 10 ft. Lg...44 Dust Deflector...46 Dust Suppression Kit (Water)...48 Hitch/Broom Head...8 Hose & Spray Kit...50 Hydraulic Angle/Motor Plumbing High Flow 3500 PSI..10 Hydraulic Angle/Motor Plumbing Low/Medium Flow 3500 PSI...12 Hydraulic Cylinder ( C) Cross...20 Hydraulic Cylinder ( C) Midway...22 Hydraulic Cylinder ( C) Monarch...24 Hydraulic Motor ( C) White...26 Hydraulic Motor ( C) White...28 Hydraulic Motor 18 Cubic Inch ( C) 3500 PSI...30 Hydraulic Motor 23 Cubic Inch ( C) 3500 PSI...32 Hydraulic Valve Cylinder Control ( C)...34 Hydraulic Valve Flow Control ( C)...36 Touch-up Paints...40 Manual Angle/Motor Plumbing High Flow 3500 PSI...14 Manual Angle/Motor Plumbing Low/Medium Flow 3500 PSI...16 Shroud Extension Metal...52 SSP15 Marker Edge...54 Switch & Power Cable ( C)...56 Switch & Wire Harness...58 Switch & Wire Harness ( C)...60 Switch & Wire Harness ( C)...62 Switch & Wire Harness DTP Plug...64 Switch & Wire Harness Tractor /11/18 AP-AB72 & AP-AB84 Angle Broom PK 3

4 4 AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

5 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 5

6 Broom Components 3500 PSI Section 2: Hitch/Broom Components AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

7 Broom Components 3500 PSI Section 2: Hitch/Broom Components Ref. Part No. Part Description Comments Revision Dwg D H H A A A A A A C C C C C C C C C C C C C Drawing Image Number DRUM PLATE ROLLER DRUM 72 ROLLER DRUM 84 BROOM ASSY 72 - POLY BROOM ASSY 72 - WIRE BROOM ASSY 72 - COMB. BROOM ASSY RE - POLY BROOM ASSY RE - WIRE BROOM ASSY RE - COMB. HHCS 1/4-20X1 GR5 WASHER LOCK SPRING 1/4 PLT POLYPROPYLENE BRISTLE WAFER WIRE BRISTLE WAFER COMB BRISTLE WAFER COMB BRISTLE WAFER COMB BRISTLE WAFER COMB BRISTLE WAFER POLY CONVOLUTED WAFER POLY CONVOLUTED WAFER WIRE CONVOLUTED WAFER WIRE CONVOLUTED WAFER WAFER SPACER RING AB72 AB84 AB72 AB72 AB72 AB84 AB84 AB84 2 Ea. in A 2 Ea. in A 2 Ea. in A 2 Ea. in A 2 Ea. in A 2 Ea. in A AB72 34 Ea. Total Unit & 17 on Comb Bristle AB84 40 Ea. Total Unit & 20 on Comb Bristle AB72 34 Ea. Total Unit & 17 on Comb Bristle AB84 40 Ea. Total Unit & 20 on Comb Bristle 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 7

8 Hitch/Broom Head Section 2: Hitch/Broom Components AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

9 Hitch/Broom Head Section 2: Hitch/Broom Components Ref. Part No. Part Description Comments Revision Dwg D H H H H S S S S V H D H D C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C Drawing Image Number BROOM HEAD LUG BROOM HEAD WELDMENT 72 BROOM HEAD WELDMENT 84 SKID ANGLE BROOM HITCH BROOM PIVOT BROOM SHROUD 72 BROOM SHROUD 84 BRUSH MOUNT ARM LH BRUSH MOUNT ARM RH PIVOT PIN ASSY. - BROOM STAND PIVOT PIN BOLT EYE 3/4-10X5 WELDED HYD HOSE CLAMP BRACKET GREASE ZERK 1/4-28 THD FORMING HHCS 1/4-20X3/4 GR5 HHCS 1/4-20X1 GR5 HHCS 5/16-18X3/4 GR5 HHCS 1/4-20X2 1/2 GR5 HHCS 3/8-16X2 3/4 GR5 HHCS 1/4-20X1 1/4 GR5 HHCS 5/16-18X2 FTHD RHSNB 5/8-11X1 3/4 GR5 PLT NUT HEX 5/8-11 PLT NUT HEX 3/4-10 PLT NUT LOCK 3/8-16 NYLON INSERT NUT HEX NYLOCK 5/16-18 PLT NUT HEX FLG TP LK 5/16-18ZNYCR NUT HEX NYLOCK 1/4-20 WASHER LOCK SPRING 1/4 PLT WASHER FLAT 1/4 SAE PLT WASHER FLAT 5/8 USS PLT WASHER LOCK SPRING 5/8 PLT WASHER FLAT 3/4 USS PLT WASHER FLAT 5/16 SAE PLT WASHER FLAT 1 1/4 SAE PLT PIN CLEVIS 5/8 X 2.77 USALBE PIN COTTER 1/8 X 1 1/4 PLT PIN ROLL 1/4 X 2 LG PL PIN WIRE SNAP LOCK 3/8 X 2 1/2 PIN CLEVIS 1 1/4 X 1 3/4 USBL SPRING EXT 2.63ODX10.0X.438W MANUAL STORAGE CONTAINER PLASTIC CAP FOR 3SQ.X1/4WALL BUSHING CYL 1 1/4 X 1 X 1 BUSHING SPINDLE 1 1/2X1 1/4X1 CHAIN WELD 1/4 PROOF X 18 LINK 5/16 X 1 1/4 UTILITY CLEVIS NUT LOCK 1/4-20 PLT AB72 AB84 AB72 AB84 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 9

10 Hydraulic Angle/Motor Plumbing High Flow 3500 PSI Section 3: Angling Hydraulic or Manual AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

11 Hydraulic Angle/Motor Plumbing High Flow 3500 PSI Section 3: Angling Hydraulic or Manual Ref. Part No. Part Description Comments Revision Dwg D D C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C R Drawing Image Number PFC MOUNT HYD HOSE CLAMP BRACKET HHCS 3/8-16X2 3/4 GR5 HHCS 3/8-16X5 GR5 HHCS 5/16-18X2 FTHD NUT LOCK 3/8-16 PLT NUT HEX NYLOCK 5/16-18 PLT NUT HEX FLG TP LK 5/16-18ZNYCR WASHER FLAT 5/16 SAE PLT VALVE, ANGLE BROOM CYL CONTROL VALVE, FLOW CONTROL VALVE 3/4 IN-LINE CHECK CYL 2X6X1.125 WELDED EL 3/4MJIC 3/4MORB TE1 1/16MJIC1 1/16MJIC1 1/16MO OREL 1/16 3/4MJIC 3/4MORB AD 9/16MORB 9/16MJIC AD 1 1/16MORB 1 1/16MJIC EL 1 1/16MJIC 1 1/16MORB CUP 1 1/16FORB MALE QUICK CPLR RPBY C CUP 1 1/16FORB FML QUICK CPLR RPBY C HH5/8R16S FJIC 7/8FJIC HH5/8R16S FJIC 7/8FJIC AD 7/8MORB 7/8MJIC HH5/8R /16FJIC (1 90) HH5/8R16S FJIC 1.06MOR HH5/8R16S FJIC 1.06MOR HH5/8R16S 081 7/8FJIC 1.06FJIC HH5/8R16S 087 7/8FJIC 1.06FJIC HH3/8R /4FJIC 9/16FJIC HH3/8R /4FJIC 9/16FJIC AD 1 1/16FJIC 1 1/16FJIC UNION CORRUGATED LOOM, 3/8 ID Obsolete Obsolete AB72 AB84 AB72 AB84 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 11

12 Hydraulic Angle/Motor Plumbing Low/Medium Flow 3500 PSI Section 3: Angling Hydraulic or Manual AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

13 Hydraulic Angle/Motor Plumbing Low/Medium Flow 3500 PSI Section 3: Angling Hydraulic or Manual Ref. Part No. Part Description Comments Revision Dwg D C C C C C C C C C C C C C C C C C C C C C C C C C C C R Drawing Image Number HYD HOSE CLAMP BRACKET HHCS 3/8-16X5 GR5 HHCS 5/16-18X2 FTHD NUT LOCK 3/8-16 PLT NUT HEX NYLOCK 5/16-18 PLT NUT HEX FLG TP LK 5/16-18ZNYCR WASHER FLAT 5/16 SAE PLT VALVE, ANGLE BROOM CYL CONTROL VALVE 3/4 IN-LINE CHECK CYL 2X6X1.125 WELDED EL 3/4MJIC 3/4MORB OREL 1/16 3/4MJIC 3/4MORB AD 9/16MORB 9/16MJIC AD 1 1/16MORB 1 1/16MJIC CUP 1 1/16FORB MALE QUICK CPLR RPBY C CUP 1 1/16FORB FML QUICK CPLR RPBY C HH5/8R16S FJIC 1.06MOR HH5/8R16S MORB 7/8FJIC HH5/8R16S MORB 7/8FJIC AD 7/8MORB 7/8MJIC HH5/8R16S 081 7/8FJIC 1.06FJIC HH5/8R16S 087 7/8FJIC 1.06FJIC HH3/8R /4FJIC 9/16FJIC HH3/8R /4FJIC 9/16FJIC AD 1 1/16FJIC 1 1/16FJIC UNION EL /16MORB 1 1/16MJIC CORRUGATED LOOM, 3/8 ID Obsolete Obsolete AB72 AB84 AB72 AB84 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 13

14 Manual Angle/Motor Plumbing High Flow 3500 PSI Section 3: Angling Hydraulic or Manual AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

15 Manual Angle/Motor Plumbing High Flow 3500 PSI Section 3: Angling Hydraulic or Manual Ref. Part No. Part Description Comments Revision Dwg D K C H H D C C C C C C C C C C C C C C C C C C C C C C Drawing Image Number PFC MOUNT BROOM TELESCOPING ANGLE ADJ RATCHET JACK ANGLE ADJUSTER BASE END ANGLE ADJUSTER ROD END HYD HOSE CLAMP BRACKET HHCS 3/8-16X2 3/4 GR5 HHCS 3/8-16X5 GR5 HHCS 5/16-18X2 FTHD NUT LOCK 3/8-16 PLT NUT HEX NYLOCK 5/16-18 PLT NUT HEX FLG TP LK 5/16-18ZNYCR WASHER FLAT 5/16 SAE PLT PIN CLEVIS 1 X 2 1/8 USABLE LG PIN, 1/2 X 2 COTTERLESS HITCH VALVE, FLOW CONTROL TE1 1/16MJIC1 1/16MJIC1 1/16MO EL 1 1/16MJIC 1 1/16MORB CUP 1 1/16FORB MALE QUICK CPLR RPBY C CUP 1 1/16FORB FML QUICK CPLR RPBY C HH5/8R16S FJIC 7/8FJIC HH5/8R16S FJIC 7/8FJIC HH5/8R16S FJIC 7/8FJIC HH5/8R16S FJIC 7/8FJIC AD 7/8MORB 7/8MJIC HH5/8R16S FJIC 1.06MOR S/N AP K+ S/N AP K- S/N AP K+ S/N AP K+ S/N AP K+ S/N AP K+ Obsolete Obsolete AB72 AB84 AB72 AB84 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 15

16 Manual Angle/Motor Plumbing Low/Medium Flow 3500 PSI Section 3: Angling Hydraulic or Manual AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

17 Manual Angle/Motor Plumbing Low/Medium Flow 3500 PSI Section 3: Angling Hydraulic or Manual Ref. Part No. Part Description Comments Revision Dwg K C H H D C C C C C C C C C C C C C Drawing Image Number BROOM TELESCOPING ANGLE ADJ RATCHET JACK ANGLE ADJUSTER BASE END ANGLE ADJUSTER ROD END HYD HOSE CLAMP BRACKET HHCS 5/16-18X2 FTHD NUT HEX NYLOCK 5/16-18 PLT NUT HEX FLG TP LK 5/16-18ZNYCR WASHER FLAT 5/16 SAE PLT PIN CLEVIS 1 X 2 1/8 USABLE LG PIN, 1/2 X 2 COTTERLESS HITCH CUP 1 1/16FORB MALE QUICK CPLR RPBY C CUP 1 1/16FORB FML QUICK CPLR RPBY C HH5/8R16S MORB 7/8FJIC HH5/8R16S MORB 7/8FJIC AD 7/8MORB 7/8MJIC S/N AP K+ S/N AP K- S/N AP K+ S/N AP K+ S/N AP K+ S/N AP K+ Obsolete Obsolete AB72 AB84 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 17

18 Broom Motor Components 3500 PSI Section 4: Hydraulics AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

19 Broom Motor Components 3500 PSI Section 4: Hydraulics Ref. Part No. Part Description Comments Revision Dwg H D H D C C C C C C C C C C C C C C C C Drawing Image Number HEX DRIVE WELDMENT BEARING PLATE STUB SHAFT, BEARING - RE MOTOR MOUNT GREASE ZERK STRAIGHT 1/4-28 HHCS 5/16-18X3/4 GR5 HHCS 3/8-16X1 GR5 HHCS 7/16-14X1 1/2 GR5 HHCS 1/2-13X2 1/4 GR5 NUT LOCK 1/2-13 PLT NUT HEX FLANGE LOC 7/16-14 PLT WASHER LOCK SPRING 5/16 PLT WASHER LOCK SPRING 3/8 PLT WASHER FENDER 5/16 X 1 3/4 HYD MTR 23 CID W/KEY - RE HYD MTR 23 CID W/KEY - RE HYD MTR 18 CID W/KEY - RE RPBY C HUB, HEX 2 1/2X1 1/4 TPRD BORE BRG 4 BOLT CAMLOCK 1.25 BORE S/N K+ S/N K- S/N K+ S/N K- Obsolete 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 19

20 Hydraulic Cylinder ( C) Cross Section 4: Hydraulics AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

21 Hydraulic Cylinder ( C) Cross Section 4: Hydraulics Ref. Part No. Part Description Comments Revision Dwg C 1D D D D D A A A D A A C 1D C Drawing Image Number CYL 3X6X1.25 ROD (TIE ROD) * CROSS, BASE CLEVIS CROSS, O-RING CROSS PISTON 3 BORE CYLINDER CROSS, BACK-UP CROSS, TUBE CROSS, ROD CROSS HEAD 3 BORE CYLINDER WIPER SEAL CROSS CROSS NUT, TIE ROD CROSS U-CUP CROSS,TIE ROD CROSS NUT, PISTON CROSS ROD CLEVIS CROSS SCREW, CAP CROSS NUT, CLEVIS & TIE ROD PIN HAIR COTTER.148 WIRE CROSS CLEVIS PIN CYL SEAL KIT 3 (CROSS) In Seal Kit Item #18 In Seal Kit Item #18 In Seal Kit Item #18 In Seal Kit Item #18 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 21

22 Hydraulic Cylinder ( C) Midway Section 4: Hydraulics AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

23 Hydraulic Cylinder ( C) Midway Section 4: Hydraulics Ref. Part No. Part Description Comments Revision Dwg C 5M4110 2M4410 1M6010-ADI C C 7M4310 2A0014 3R1412 4M4108 6R1162-ADI 2A C 2A C Drawing Image Number CYL 3X6X1.25 ROD (TIE ROD) MW TUBE 3 X 6 CYLINDER MW ROD 1-1/4 DIA X 6 STROKE MIDWAY HARDENED CLEVIS ADI NUT HEX 3/8-16 PLAIN HHCS 3/8-16X1 3/4 GR5 MW TIE ROD 3 X 6 CYLINDER MW TIE ROD NUT MW HEAD 3X1-1/4 ROD PT.E MW O-RING MW WIPER MW O-RING MW PISTON MIDWAY ADI BASE MW PISTON NUT 1-14 MW BACK UP PIN CLEVIS 1 X 3 11/16 GR5 PLT MW PIN CLIP MW O-RING CYL SEAL KIT 3 X 7 MW 3A4104 Only found in seal kit #19 Only found in seal kit #19 Only found in seal kit #19 Only found in seal kit #19 Only found in seal kit #19 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 23

24 Hydraulic Cylinder ( C) Monarch Section 4: Hydraulics AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

25 Hydraulic Cylinder ( C) Monarch Section 4: Hydraulics Ref. Part No. Part Description Comments Revision Dwg C Drawing Image Number CYL 2X6X1.125 WELDED * MON PISTON NUT MON RETAINING RING INT 2.00 MON RETAINING RING EXT 2.00 MON SET SCREW 3/8INC ONE PIECE MON WEAR RING MON WEAR RING MON SEAL ZURCON U-CUP RU MON SEAL ZURCON WYNSEAL 2.00 MON SEAL DUAL MON SEAL WIPER 1.13 WNUC TSS MON CYL HEAD WET-TSS MON PISTON TSS-ISO-WR LION ROD CLEVIS 1 1/8-12UNF MON TUBE WELDT W MON ROD CYL LION PIN CLIP-CLEVIS RPBY C Obsolete 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 25

26 Hydraulic Motor ( C) White Section 4: Hydraulics AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

27 Hydraulic Motor ( C) White Section 4: Hydraulics Ref. Part No. Part Description Comments Revision Dwg C Image No. HYD MTR 23 CID W/KEY - RE * WH SEAL CARRIER BOLT (9) WH 1-1/4" TAPERED SHAFT WH BALANCE PLATE WH DRIVE LINK WH FORWARD MANIFOLD WH ENDCOVER WH REAR HOUSING BRG WH FRONT HOUSING BRG WH STEEL BALLS (3) WH REAR THRUST BRG WH BEARING SPACER WHITE CHECK VALVE WH ROTOR KIT WHITE SEAL KIT WH BOLT SET KIT WH KEY KIT WHITE SHAFT LOCK NUT WHITE HOUSING WH SEAL CARRIER WH SEAL CARRIER BOLT WASHER(9) WHITE THRUST WASHER WH DUST SEAL BACKUP SHIM BACKUP SEAL SHAFT SEAL SEAL CARRIER SEAL HOUSING SEAL BODY SEAL ENDCOVER SEAL Not shown Available only in Seal Kit Item #14 Available only in Seal Kit Item #14 Available only in Seal Kit Item #14 Available only in Seal Kit Item #14 Available only in Seal Kit Item #14 Available only in Seal Kit Item #14 Available only in Seal Kit Item #14 Available only in Seal Kit Item #14 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 27

28 Hydraulic Motor ( C) White Section 4: Hydraulics AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

29 Hydraulic Motor ( C) White Section 4: Hydraulics Ref. Part No. Part Description Comments Revision Dwg C Image No. HYD MTR 18 CID W/KEY - RE * WH SEAL CARRIER BOLT (9) WH 1-1/4" TAPERED SHAFT WH BALANCE PLATE WH DRIVE LINK WH FORWARD MANIFOLD WH ENDCOVER WH REAR HOUSING BRG WH FRONT HOUSING BRG WH STEEL BALLS (3) WH REAR THRUST BRG WH BEARING SPACER WHITE CHECK VALVE WH ROTOR KIT WHITE SEAL KIT WH BOLTS (7) WH KEY KIT WHITE SHAFT LOCK NUT WHITE HOUSING WH SEAL CARRIER WH SEAL CARRIER BOLT WASHER(9) WHITE THRUST WASHER WH DUST SEAL BACKUP SHIM BACKUP SEAL SHAFT SEAL SEAL CARRIER SEAL HOUSING SEAL BODY SEAL ENDCOVER SEAL Not shown Available only in Seal Kit Item #14 Available only in Seal Kit Item #14 Available only in Seal Kit Item #14 Available only in Seal Kit Item #14 Available only in Seal Kit Item #14 Available only in Seal Kit Item #14 Available only in Seal Kit Item #14 Available only in Seal Kit Item #14 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 29

30 Hydraulic Motor 18 Cubic Inch ( C) 3500 PSI Section 4: Hydraulics AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

31 Hydraulic Motor 18 Cubic Inch ( C) 3500 PSI Section 4: Hydraulics Ref. Part No. Part Description Comments Revision Dwg C P Drawing Image Number RPBY C * WH DUST SEAL WIRE RING METAL BACKUP SHIM HIGH PRESSURE SHIM METAL BACKUP SHIM POLYAMIDE SEAL SHAFT SEAL REAR HOUSING SEAL BODY SEAL END COVER SEAL SEAL CARRIER THRUST WASHER WH FRONT THRUST BRG WH FRONT HOUSING BRG WH WHEEL MOUNT W/7/8" O-RING WH REAR HOUSING BRG WH REAR THRUST BRG WH DRIVE LINK WH FORWARD MANIFOLD WH ROTOR KIT WH BALANCE PLATE WH STEEL BALLS (3) WH ENDCOVER WH BOLTS (7) WH 1-1/4" TAPERED SHAFT WH KEY KIT WHITE NUT KIT WH SEAL KIT Obsolete Found in Item #28 Found in Item #28 Found in Item #28 Found in Item #28 Found in Item #28 Found in Item #28 Found in Item #28 Found in Item #28 Found in Item #28 Found in Item #28 Found in Item #28 Found in Item #28 Includes Items # 14 & 16 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 31

32 Hydraulic Motor 23 Cubic Inch ( C) 3500 PSI Section 4: Hydraulics AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

33 Hydraulic Motor 23 Cubic Inch ( C) 3500 PSI Section 4: Hydraulics Ref. Part No. Part Description Comments Revision Dwg C P Drawing Image Number HYD MTR 23 CID W/KEY - RE * WH DUST SEAL WIRE RING METAL BACKUP SHIM HIGH PRESSURE SEAL METAL BACKUP SHIM POLYAMIDE SEAL SHAFT SEAL REAR HOUSING SEAL BODY SEAL END COVER SEAL SEAL CARRIER THRUST WASHER WH FRONT THRUST BRG WH FRONT HOUSING BRG WH WHEEL MOUNT W/7/8" O-RING WH REAR HOUSING BRG WH REAR THRUST BRG WH DRIVE LINK WH FORWARD MANIFOLD WH ROTOR KIT WH BALANCE PLATE WH STEEL BALLS (3) WH ENDCOVER WH BOLT SET KIT WH 1-1/4" TAPERED SHAFT WH KEY KIT WHITE NUT KIT WH SEAL KIT Found in Item #28 Found in Item #28 Found in Item #28 Found in Item #28 Found in Item #28 Found in Item #28 Found in Item #28 Found in Item #28 Found in Item #28 Found in Item #28 Found in Item #28 Found in Item #28 Includes Items # 14 & 16 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 33

34 Hydraulic Valve Cylinder Control ( C) Section 4: Hydraulics AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

35 Hydraulic Valve Cylinder Control ( C) Section 4: Hydraulics Ref. Part No. Part Description Comments Revision Dwg C Drawing Image Number VALVE, ANGLE BROOM CYL CONTROL * DELTA ORIFICE PLUG DELTA PRESSURE COMPENSATOR DELTA MANIFOLD DELTA PLUG, #4 SAE, HEX SOC DELTA RELIEF VALVE DELTA 4W3P SOLENOID VALVE DELTA 12VDC COIL 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 35

36 Hydraulic Valve Flow Control ( C) Section 4: Hydraulics AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

37 Hydraulic Valve Flow Control ( C) Section 4: Hydraulics Ref. Part No. Part Description Comments Revision Dwg C Drawing Image Number VALVE, FLOW CONTROL * DELTA VALVE BODY DELTA PRIORITY FLOW CONTROL 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 37

38 Decal Placement Table of Contents Section 5: Decals AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

39 Decal Placement Section 5: Decals Ref. Part No. Part Description Comments Revision Dwg C C C C C C C C C C C R R Drawing Image Number DECAL WARNING PINCH PT/CRUSH DECAL FLAG DECAL GREASE 25HRS BLACK/WHITE DECAL WARNING HYD PRESS LONG DECAL WARNING READ MANUAL DECAL WARNING FLYING OBJ/ENTNG DECAL WARNING EYES & BREATHING DECAL CAUTION MACHINE DAMAGE DECAL KUBOTA 15" DECAL AB72 WHITE DECAL AB84 WHITE 3M CONFORM. ANTI-SLIP 2" WIDE 3M CONFORM. ANTI-SLIP 2" WIDE AB72 AB84 7" Long 18" Long 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 39

40 Touch-up Paints Section 5: Decals No diagram associated with this Parts List 40 AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

41 Touch-up Paints Section 5: Decals Ref. Part No. Part Description Comments Revision C CTU CQT CGL GLOSS BLACK SPRAY CAN GLOSS BLACK TOUCH-UP 5OZ GLOSS BLACK QUART GLOSS BLACK GALLON All Products 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 41

42 Deutsch HD30 14 Pin Plug 73 in. Lg. Section 6: Options & Accessories AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

43 Deutsch HD30 14 Pin Plug 73 in. Lg. Section 6: Options & Accessories Ref. Part No. Part Description Comments Revision Dwg A C C Drawing Image Number DEUTSCH HD30 14 PIN PLUG 73" CABLE TIE.19X DIA 50LB DEUTSCH HD30 14 PIN PLUG 73" 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 43

44 Deutsch HD3014 Pin Plug 10 ft. Lg Section 6: Options & Accessories AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

45 Deutsch HD3014 Pin Plug 10 ft. Lg Section 6: Options & Accessories Ref. Part No. Part Description Comments Revision Dwg A C C Drawing Image Number DEUTSCH HD30 14 PIN PLUG 10' CABLE TIE.19X DIA 50LB DEUTSCH HD30 14 PIN PLUG 10' 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 45

46 Dust Deflector Table of Contents Section 6: Options & Accessories AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

47 Section 6: Options & Accessories Dust Deflector Table of Contents Ref. Part No. Part Description Comments Revision Dwg A A D D D D D D D D C C C C C C C C Drawing Image Number RUBBER DUST DEFLECTOR 72 RUBBER DUST DEFLECTOR * BROOM SHROUD EXTENSION BROOM SHROUD EXTENTION DUST DEFLECTOR BRACKET LH DUST DEFLECTOR BRACKET RH DUST DEFLECTOR STIFFENER 72 DUST DEFLECTOR STIFFENER DEFLECTOR SUPPORT DEFLECTOR SUPPORT HHCS 1/4-20X3/4 GR5 HHCS 5/16-18X3/4 GR5 NUT HEX WHIZ 1/4-20 PLT WASHER FLAT 1/4 SAE PLT WASHER LOCK SPRING 5/16 PLT WASHER FENDER 1/4 X 1 1/2 RUBBER DEFLECTOR RUBBER DEFLECTOR AB72 AB84 AB72 AB84 AB72 AB84 AB72 AB84 AB72 AB84 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 47

48 Dust Suppression Kit (Water) Section 6: Options & Accessories AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

49 Dust Suppression Kit (Water) Section 6: Options & Accessories Ref. Part No. Part Description Comments Revision Dwg A H D C C C C C C C C C C C C C C C C C C C C C C C C C C R R R R Drawing Image Number DUST SUPPRESSION KIT * WATER TANK LEG WATER TANK ANGLE SINGLE WIRE HOSE CLAMP #14 SINGLE WIRE HOSE CLAMP #9.5 HSBHCS #10-24 X 1 HHCS 3/8-16X1 GR5 HHCS 3/8-16X1 1/4 GR5 HHCS 5/16-18X1 GR5 NUT LOCK 3/8-16 NYLON INSERT WASHER LOCK SPRING 5/16 PLT WASHER FLAT 5/16 USS PLT WASHER FLAT 3/8 USS PLT WASHER FLAT #10 SAE PLT GROMMET,.75IDX1.25ODX.063 WATER TANK 25 GAL. SWITCH & POWER CABLE VALVE - 1/2FNPT SINGLE UN BALL TEE 3/8HB POLYPROP AD 1/2MNPT POLYPROP AD 3/8MNPT X 3/8HB POLYPROP AD 1/2MNPT X 5/8 HB POLYP AD 1/2MNPT X 3/8MNPT POLY EL BLKHD 5/8-16 X 3/8 HB CAP, 5/8-16 POLY NOZZLE AD 3/4FGHT X 1/2FNPT NYLON LINE FILTER, 1/2 FNPT PUMP,12V DC 30PSI MAX WATER NOZZLE TIP, BRASS TK-1.5 HOSE 5/8 PVC HOSE CLEAR PVC 3/8ID X 1/8WL HOSE CLEAR PVC 3/8ID X 1/8WL HOSE CLEAR PVC 3/8ID X 1/8WL Order Length Required Sold per Foot Order Length Required Sold per Foot Order Length Required Sold per Foot Order Length Required Sold per Foot 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 49

50 Hose & Spray Kit Table of Contents Section 6: Options & Accessories AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

51 Hose & Spray Kit Section 6: Options & Accessories Ref. Part No. Part Description Comments Revision Dwg A C C C C C C R R R Drawing Image Number HOSE AND SPRAY KIT * SINGLE WIRE HOSE CLAMP #9.5 GROMMET,.75IDX1.25ODX.063 TEE 3/8HB POLYPROP EL BLKHD 5/8-16 X 3/8 HB CAP, 5/8-16 POLY NOZZLE NOZZLE TIP, BRASS TK-1.5 HOSE CLEAR PVC 3/8ID X 1/8WL HOSE CLEAR PVC 3/8ID X 1/8WL HOSE CLEAR PVC 3/8ID X 1/8WL Order Length Required Sold per Foot Order Length Required Sold per Foot Order Length Required Sold per Foot 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 51

52 Shroud Extension Metal Section 6: Options & Accessories AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

53 Shroud Extension Metal Section 6: Options & Accessories Ref. Part No. Part Description Comments Revision Dwg A A D D D D C C C C C Drawing Image Number METAL SHROUD EXTENSION 72 METAL SHROUD EXTENSION 84 * BROOM SHROUD EXTENSION BROOM SHROUD EXTENTION DUST DEFLECTOR BRACKET LH DUST DEFLECTOR BRACKET RH HHCS 1/4-20X3/4 GR5 HHCS 5/16-18X3/4 GR5 NUT HEX WHIZ 1/4-20 PLT WASHER FLAT 1/4 SAE PLT WASHER LOCK SPRING 5/16 PLT AB72 AB84 AB72 AB84 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 53

54 SSP15 Marker Edge Section 6: Options & Accessories AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

55 SSP15 Marker Edge Section 6: Options & Accessories Ref. Part No. Part Description Comments Revision Dwg A C C Drawing Image Number MARKER ASSY. HHCS 5/16-18X1 GR5 NUT HEX NYLOCK 5/16-18 PLT MARKER STICK 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 55

56 Switch & Power Cable ( C) Section 6: Options & Accessories AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

57 Switch & Power Cable ( C) Section 6: Options & Accessories Ref. Part No. Part Description Comments Revision Dwg C C C Drawing Image Number SWITCH & POWER CABLE * FASSE NUT JAM 15/32" BLK CABLE TIE 2 DIA MIN - BLK FASSE MAG CERAMIC 1"X2"X.5" FASSE SW TOG SPDT 2P STAT SHRT FASSE ENCLOSED COVER 2X2 FASSE GROMMET.5000D SNAP FASSE HRNSS 2 CON 16GA 2WPT /18 FASSE ENCL DRL SWBX SW1-1X1/2" FASSE HRNES 200N 16GA 2YPT/1.5 FASSE HRN 2CON 2PN WPS /18'-6" FUSE, ACT 7.5 BRN FASSE HRN 200N 18GA W/PT 6" 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 57

58 Switch & Wire Harness Section 6: Options & Accessories AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

59 Switch & Wire Harness Section 6: Options & Accessories Ref. Part No. Part Description Comments Revision Dwg A C C Drawing Image Number SWITCH & WIRE HARNESS CABLE TIE.19X DIA 50LB SWITCH & WIRE HARNESS 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 59

60 Switch & Wire Harness ( C) Section 6: Options & Accessories AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

61 Switch & Wire Harness ( C) Section 6: Options & Accessories Ref. Part No. Part Description Comments Revision Dwg C C Drawing Image Number SWITCH & WIRE HARNESS * FASSE NUT JAM 15/32" BLK CABLE TIE 2 DIA MIN - BLK FASSE MAG CERAMIC 1"X2"X.5" FASSE ENCLOSED COVER 2X2 FASSE GROMMET.5000D SNAP FASSE GROMMET.625OD SNAP FASSE HRNSS 2 CON 15GA 2WPT /9 FASSE ENCL DRL X1/2 FASSE SW ASSY PB MOM O R SW FASSE HRNES 200N 16GA 2YPT/1.5 FASSE HRN 400N 16G 2X2 WPT/9.5 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 61

62 Switch & Wire Harness ( C) Section 6: Options & Accessories AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

63 Switch & Wire Harness ( C) Section 6: Options & Accessories Ref. Part No. Part Description Comments Revision Dwg C Drawing Image Number SWITCH & WIRE HARNESS DTP PLUG * FASSE SCREW #10-32X7/16" ZNC FASSE HEX LOCKNUT NYLON #10-32 FASSE NUT JAM 15/32" BLK FASSE MAG CERAMIC RNS 2.0" DIA FASSE GROMMET.5000D SNAP FASSE GROMMET.625OD SNAP FASSE HRN DTP04-2P 14GA 2WPT/5 FASSE ENCL DRILL CVR 2X2 3/16" FASSE ENCL DRL X1/2 FASSE SW ASSY PB MOM O R SW FASSE HRNES 200N 16GA 2YPT/1.5 FASSE HRN 400N 16G 2X2 WPT/9.5 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 63

64 Switch & Wire Harness DTP Plug Section 6: Options & Accessories AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

65 Switch & Wire Harness DTP Plug Section 6: Options & Accessories Ref. Part No. Part Description Comments Revision Dwg A C C Drawing Image Number SWITCH & WIRE HARNESS DTP PLUG CABLE TIE.19X DIA 50LB SWITCH & WIRE HARNESS DTP PLUG 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 65

66 Switch & Wire Harness Tractor Section 6: Options & Accessories AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

67 Switch & Wire Harness Tractor Section 6: Options & Accessories Ref. Part No. Part Description Comments Revision Dwg A C C C Drawing Image Number SWITCH & WIRE HARNESS TRACTOR CABLE TIE.19X DIA 50LB SWITCH & WIRE HARNESS TRACTOR\BROOM EXTENSION CABLES 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 67

68 Table of Contents The is a numeric index of all part numbers included in this manual. The index shows what page(s) the part is used on. Part Number Page Part Number Page Part Number Page Part Number Page , 29 1D D D D D D D M6010-ADI , 61, , , , 61, , 63 2A A A A A A A A M P...31, , , , 61, , D H D...11, H D H H A S S S V A H A D H D H A D...47, A D H A A A H D...47, D...47, S D D H D H A A A A A D...47, D A A A A A K...15, H...15, H...15, R M , 29, 31, , 29, 31, , , , 29, 31, , 29, 31, , 29, 31, , 29, 31, , 29, 31, , 29, 31, , , , , , 29, 31, , , , , , 29, 31, , D...9, 11, 13, 15, , , , , 29 5M R1162-ADI M C C C...43, 45, 59, 65, C C...57, C...49, C C...9, 47, C...7, C...9, 19, 47, C...19, C C C C C C...49, C...9, 11, C C...11, 13, C...9, 11, 13, 15, C C C...11, 13, C C C C...9, C... 9, 11, 13, 15, 17, C...9, 11, 13, 15, C...47, C C C C...7, C...9, 47, C...19, 47, 49, C C C C C C C...9, 11, 13, 15, C C C C C...15, C C C C C C C...15, C C C C C...21, C...11, 13, C...11, 15, C...11, C...19, C...19, C...11, 13, C...11, C...11, C...11, C...11, C...11, C...11, C...11, 13, 15, C...11, 13, 15, C C C...49, C C C C C C C C CGL CQT CTU C C...59, 61, C C C...49, C C...63, C C...49, C C C C C...49, C...49, C C C C...49, C C C C C...13, C...11, C...11, 13, 15, C C...11, C...11, C...11, C...11, C C...13, C...11, C...11, C C C...19, C...19, C...11, 13, 15, C...11, 13, 15, C C C C C C C...15, C AP-AB72 & AP-AB84 Angle Broom PK 07/11/18

69 (continued) Part Number Page C C C C C C C R R R...49, R...11, 13 Dwg Dwg Dwg Dwg Dwg Dwg , 37 Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg Dwg , 25, 27, 29, 31, 33, 55 07/11/18 AP-AB72 & AP-AB84 Angle Broom PK 69

70