Hydraulic Reservoir System

Transcription

1 Hydraulic Reservoir System HRS18 & HRS P Parts Manual Read the Operator's Manual entirely. When you see this symbol, the subsequent instructions and warnings are serious - follow without exception. Your life and the lives of others depend on it! Copyright 2016 Printed 07/15/16 Cover photo may show optional equipment not supplied with standard unit.

2 Table of Contents Section 1: Introduction...4 Using This Manual...4 Manual Replacement Information...4 Manual Revisions...4 Touch-up Paint...4 Hardware Legend...5 Replacement Hardware...5 Serial Numbers...5 Part Number Service Coding...5 Section 2: Hitch & Reservoir...6 Hitch & Reservoir Components...6 Section 3: Drive...8 Driveline ( C) Eurocardan (S/N )...8 Pump Drive Tractor Mount...10 Pump Drive W/Driveline Cooler Oil W/Fan ( C)...14 Hydraulic Valve Options...16 Oil Cooler Components W/Switchbox...18 Oil Cooler Components WO/Switchbox...20 Pump PTO 7.8 CI/REV. ( C)...22 Pump PTO 9.9 CI/REV. ( C)...24 Switchbox W/Harness ( C) S/N Switckbox W/Harness ( C) S/N Valve Manual Control...30 Valve Manual Spool 30 GPM ( C)...32 Valve Pressure Relief 2000 PSI ( C)...34 Valve Relief PTO Control...36 Valve Solenoid Control...38 Valve Solenoid W/Pilot 30 GPM ( C)...40 Section 5: Labels...42 Label Placement Copyright All rights reserved. provides this publication as is without warranty of any kind, either expressed or implied. While every precaution has been taken in the preparation of this manual, assumes no responsibility for errors or omissions. Neither is any liability assumed for damages resulting from the use of the information contained herein. Land Pride reserves the right to revise and improve its products as it sees fit. This publication describes the state of this product at the time of its publication, and may not reflect the product in the future. The illustrations in this manual are not intended for safe and proper assembly or disassembly of equipment. The illustrations are intended for ordering parts only. is registered trademark. All other brands and product names are trademarks or registered trademarks of their respective holders. Printed in the United States of America. 2 HRS18 & HRS23 Hydraulic Reservoir System P 07/15/16

3 C D H L O P S V Cooler Oil W/Fan ( C)...14 Driveline ( C) Eurocardan (S/N )...8 Hitch & Reservoir Components...6 Hydraulic Valve Options...16 Label Placement...42 Oil Cooler Components W/Switchbox...18 Oil Cooler Components WO/Switchbox...20 Pump Drive Tractor Mount...10 Pump Drive W/Driveline...12 Pump PTO 7.8 CI/REV. ( C)...22 Pump PTO 9.9 CI/REV. ( C)...24 Switchbox W/Harness ( C) S/N Switckbox W/Harness ( C) S/N Valve Manual Control...30 Valve Manual Spool 30 GPM ( C)...32 Valve Pressure Relief 2000 PSI ( C)...34 Valve Relief PTO Control...36 Valve Solenoid Control...38 Valve Solenoid W/Pilot 30 GPM ( C)...40 Alphabetized Table of Contents 07/15/16 HRS18 & HRS23 Hydraulic Reservoir System P 3

4 4 HRS18 & HRS23 Hydraulic Reservoir System P 07/15/16

5 07/15/16 HRS18 & HRS23 Hydraulic Reservoir System P 5

6 Hitch & Reservoir Components Section 2: Hitch & Reservoir HRS18 & HRS23 Hydraulic Reservoir System P 07/15/16

7 Hitch & Reservoir Components Section 2: Hitch & Reservoir Ref. Part No. Part Description Comments Revision dwg H H D C C C C C C C C C C C C C C C C C C C C C C C Drawing Image Number PARKING STAND RTA25/35 BLACK TANK WELD SPACER 1 1/4ODX7/32WLX2.12LG DRAIN PLUG 3/4-16 UNF PLATED HHCS 3/8-16X1 GR5 HHCS 3/4-10X4 GR5 NUT HEX 3/4-10 PLT NUT HEX JAM 1/4-20 PLT WASHER LOCK SPRING 1/4 PLT WASHER FLAT 3/8 SAE PLT WASHER LOCK SPRING 3/8 PLT WASHER LOCK SPRING 3/4 PLT PIN WIRE RETAINING 1/4 X 1 3/4 PIN LINCH 7/16 X 1 3/4 PIN HITCH CAT. I-II CP 1 1/16FORB MALE QUICK CP 1 1/16FORB FEMALE QUICK MANUAL STORAGE CONTAINER COVER GASKET HRS VALVE 1 1/4FNPT BALL BRASS HH3/4R FJIC1.06MORB AD 1 1/16MORB 3/4MNPT EL 1 1/4MNPT1 1/4HOSE BARB STL FILTER HEAD FILTER ELEMENT SPIN ON FILLER CAP W/STRAINER ASSY 07/15/16 HRS18 & HRS23 Hydraulic Reservoir System P 7

8 Driveline ( C) Eurocardan (S/N ) Section 3: Drive HRS18 & HRS23 Hydraulic Reservoir System P 07/15/16

9 Driveline ( C) Eurocardan (S/N ) Section 3: Drive Ref. Part No. Part Description Comments Revision dwg C C C C Drawing Image Number DRIVELINE NO CLUTCH EC YOKE ASSEMBLY EC CROSS ASSEMBLY (U JOINT) EC OUTER TUBE YOKE EC 08X DIN ROLL PIN EC OUTER TUBE ( ) 450MM EC INNER TUBE ( ) 450MM EC INNER TUBE YOKE EC 8X55-DIN-1481 O/TUBE R/PIN EC TUBE BEARING EC OUTER TUBE RIGID CONE EC STIFFENING RING EC SOFT CONE EC PIN STOP ROTATION EC OUTER TUBE SHEILD EC INNER TUBE SHEILD EC SOFT LONG CONE EC INNER TUBE RIGID CONE EC TUBE BEARING EC PULL COLLAR KIT DECAL DANGER PTO DRIVELINE DECAL DANGER GUARD MISS PTO DRIVELINE SHIELD SAFETY CHAIN SHIELD KIT, AX3 & AX4 WC ZERK M8 X 1 X 45 DEG S/N /15/16 HRS18 & HRS23 Hydraulic Reservoir System P 9

10 Pump Drive Tractor Mount Section 3: Drive HRS18 & HRS23 Hydraulic Reservoir System P 07/15/16

11 Pump Drive Tractor Mount Section 3: Drive Ref. Part No. Part Description Comments Revision dwg D D C C C C C C C C C C C C C C Drawing Image Number TORQUE ARM CHAIN, TORQUE ARM CLAMP WRM DRV#28 SS( ) CHAIN END LAP REPAIR 1/4 S-HOOK # X 2.00 HHCS 3/8-16X1 1/2 GR5 CLOSED EYE BOLT 3/8-16X3 1/4 NUT HEX 3/8-16 PLT WASHER FLAT 3/8 SAE PLT WASHER LOCK SPRING 3/8 PLT AD 1 1/16MORB 1 1/16MJIC HH1R /16FJIC-90 / MORB PTO PUMP 7.8 CI/REV. PTO PUMP 9.9 CI/REV. EL 1 5/16MORB 1 1/4 HB SUCTION HOSE 31" HRS18 HRS23 07/15/16 HRS18 & HRS23 Hydraulic Reservoir System P 11

12 Pump Drive W/Driveline Section 3: Drive HRS18 & HRS23 Hydraulic Reservoir System P 07/15/16

13 Pump Drive W/Driveline Section 3: Drive Ref. Part No. Part Description Comments Revision dwg D C C C C C C C C C C C C C C C C C Drawing Image Number PUMP TANK MOUNT CLAMP WRM DRV#28 SS( ) HHCS 3/8-16X1 GR5 HHCS 1/2-13X1 1/4 GR5 HHCS 1/2-20X1 GR5 NUT HEX 1/2-13 PLT WASHER FLAT 3/8 SAE PLT WASHER LOCK SPRING 3/8 PLT WASHER LOCK SPRING 1/2 PLT WASHER FLAT 1/2 USS PLT AD 1 1/16MORB 1 1/16MJIC PUMP PTO ADAPTER DRIVELINE NO CLUTCH PTO PUMP 7.8 CI/REV. PTO PUMP 9.9 CI/REV. EL 1 5/16MORB 1 1/4 HB 1 1/4" SUCTION HOSE 21.7" HH3/4R /16FJIC /15/16 HRS18 & HRS23 Hydraulic Reservoir System P 13

14 Cooler Oil W/Fan ( C) No diagram associated with this Parts List 14 HRS18 & HRS23 Hydraulic Reservoir System P 07/15/16

15 Cooler Oil W/Fan ( C) Ref. Part No. Part Description Comments Revision No Parts Listing at This Time 07/15/16 HRS18 & HRS23 Hydraulic Reservoir System P 15

16 Hydraulic Valve Options HRS18 & HRS23 Hydraulic Reservoir System P 07/15/16

17 Hydraulic Valve Options Ref. Part No. Part Description Comments Revision dwg A A A A A Drawing Image Number OIL COOLER W/O CONTROL OPT HRS OIL COOLER W/CONTROL OPT HRS MANUAL VALVE OPTION HRS NO VALVE OPTION HRS SOLENOID VALVE OPTION HRS 07/15/16 HRS18 & HRS23 Hydraulic Reservoir System P 17

18 Oil Cooler Components W/Switchbox HRS18 & HRS23 Hydraulic Reservoir System P 07/15/16

19 Oil Cooler Components W/Switchbox Ref. Part No. Part Description Comments Revision dwg A D C C C C C C C C C C Drawing Image Number OIL COOLER W/CONTROL OPT HRS * OIL COOLER MOUNT HHCS 5/16-18X3/4 GR5 NUT HEX 5/16-18 PLT WASHER LOCK SPRING 5/16 PLT WASHER FLAT 5/16 SAE PLT OIL COOLER W/FAN ASSY AD 1 1/16MORB 1 1/16MJIC EL 1 1/16MJIC 1 1/16MORB SWITCHBOX AND HARNESS HRS FAN ASSEMBLY, ( c) RPBY HH3/4R FJIC 90 HH3/4R FJIC 90 07/15/16 HRS18 & HRS23 Hydraulic Reservoir System P 19

20 Oil Cooler Components WO/Switchbox HRS18 & HRS23 Hydraulic Reservoir System P 07/15/16

21 Oil Cooler Components WO/Switchbox Ref. Part No. Part Description Comments Revision dwg A D C C C C C C C C C Drawing Image Number OIL COOLER W/O CONTROL OPT HRS * OIL COOLER MOUNT HHCS 5/16-18X3/4 GR5 NUT HEX 5/16-18 PLT WASHER LOCK SPRING 5/16 PLT WASHER FLAT 5/16 SAE PLT OIL COOLER W/FAN ASSY AD 1 1/16MORB 1 1/16MJIC EL 1 1/16MJIC 1 1/16MORB FAN ASSEMBLY, ( c) RPBY HH3/4R FJIC 90 HH3/4R FJIC 90 07/15/16 HRS18 & HRS23 Hydraulic Reservoir System P 21

22 Pump PTO 7.8 CI/REV. ( C) HRS18 & HRS23 Hydraulic Reservoir System P 07/15/16

23 Pump PTO 7.8 CI/REV. ( C) Ref. Part No. Part Description Comments Revision dwg Drawing Image Number HEX HEAD CAP SCREW HEX HEAD CAP SCREW DOWEL PIN TANDEM ROLLER BEARING ROLLER BEARING SNAP RING SNAP RING PTO SHAFT SEAL FRONT PLATE WITH PORT REAR PLATE CAST IRON BODY IDLER SHAFT DRIVE SHAFT 6 TOOTH DRIVE GEAR IDLER GEAR WEAR PLATE (BACK) WEAR PLATE (FRONT) WEAR PLATE O-RING STOCK FRONT PLAT MOLDED SEAL BACK PLATE MOLDED SEAL #12 ORB STEEL PORT PL W/ORING 07/15/16 HRS18 & HRS23 Hydraulic Reservoir System P 23

24 Pump PTO 9.9 CI/REV. ( C) HRS18 & HRS23 Hydraulic Reservoir System P 07/15/16

25 Pump PTO 9.9 CI/REV. ( C) Ref. Part No. Part Description Comments Revision dwg C PMCK-PTO-1A Drawing Image Number PTO PUMP 9.9 CI/REV. * FRONT PLATE WITH PORT WEAR PLATE (FRONT) FRONT PLAT MOLDED SEAL WEAR PLATE O-RING STOCK REAR PLATE WEAR PLATE (BACK) BACK PLATE MOLDED SEAL PTO SHAFT SEAL TANDEM ROLLER BEARING ROLLER BEARING BODY, HC-PTO-1AC IDLER GEAR ASS'Y,HC-PTO-1AC DRIVE GEAR ASS'Y, HC-PTO-1AC DOWEL PIN, HC-PTO-1AC CAP SCREW, HC-PTO-1AC PRINCE SEAL KIT In Kit #16 In Kit #16 In Kit #16 In Kit #16 07/15/16 HRS18 & HRS23 Hydraulic Reservoir System P 25

26 Switchbox W/Harness ( C) S/N HRS18 & HRS23 Hydraulic Reservoir System P 07/15/16

27 Switchbox W/Harness ( C) S/N Ref. Part No. Part Description Comments Revision dwg C C Drawing Image Number SWITCHBOX AND HARNESS HRS * FASSE WSHR RBR1ODX1/4IDX1/16TK FASSE NUT JAM 15/32" CHROME CABLE TIE 2 DIA MIN - BLK FASSE SCR THUMB BLK 1/4-20X1/2 FASSE BRKT ALM 3.34 #1591L SW TOG SPDT 3P STAT MICRO BAT FASSE SW PB O P9 SPST MOM RED SW PB 0 P9 SPST MOM WHT RAISED FASSE WIRE RED/BLK 16GA ZIP FASSE TRN RING 1/4" INS 16/14G FASSE GROMMET.5000D SNAP FASSE SW TOG GRP VNYL BLU.187 ENCL DRILL SWBX LBK P92-SWI HARNESS 4CON TR2 20' 07/15/16 HRS18 & HRS23 Hydraulic Reservoir System P 27

28 Switckbox W/Harness ( C) S/N HRS18 & HRS23 Hydraulic Reservoir System P 07/15/16

29 Switckbox W/Harness ( C) S/N Ref. Part No. Part Description Comments Revision dwg C C Drawing Image Number SWITCHBOX AND HARNESS HRS * FASSE WSHR RBR1ODX1/4IDX1/16TK CABLE TIE 2 DIA MIN - BLK FASSE SCR THUMB BLK 1/4-20X1/2 FASSE BRKT ALM 3.34 #1591L FASSE SW TOG DPDT 3P STAT LONG FASSE SWTOG DPDT 3P MOM LONG FASSE SW TOG SPST 2P STAT SHRT FASSE SW TOG BOOT OPN BLK FASSE LAMP 12V 1/2 SNAP RED FASSE WIRE RED/BLK 16GA ZIP FUSE HOLDER ATC INLINE FUSE 10AMP ATC RED FASSE TRN RING 1/4" INS 16/14G FASSE GROMMET.5000D SNAP FASSE SW TOG GRP VNYL RED.187 FASSE SW TOG GRP VNYL BLU.187 FASSE SW TOG GRP VNYL YEL.187 ENCL DRL SWBX 1591CBK LMP2-SW4 HARNESS 4CON TR2 20' 07/15/16 HRS18 & HRS23 Hydraulic Reservoir System P 29

30 Valve Manual Control HRS18 & HRS23 Hydraulic Reservoir System P 07/15/16

31 Valve Manual Control Ref. Part No. Part Description Comments Revision dwg A C C C C C C C Drawing Image Number MANUAL VALVE OPTION HRS * HHCS 3/8-16X2 GR5 NUT HEX 3/8-16 PLT WASHER FLAT 3/8 SAE PLT WASHER LOCK SPRING 3/8 PLT AD 1 1/16MORB 1 1/16MJIC VALVE MANUAL SPOOL 40GPM HH3/4R /16 FJIC 90 07/15/16 HRS18 & HRS23 Hydraulic Reservoir System P 31

32 Valve Manual Spool 30 GPM ( C) No diagram associated with this Parts List 32 HRS18 & HRS23 Hydraulic Reservoir System P 07/15/16

33 Valve Manual Spool 30 GPM ( C) Ref. Part No. Part Description Comments Revision No Parts Listing at This Time 07/15/16 HRS18 & HRS23 Hydraulic Reservoir System P 33

34 Valve Pressure Relief 2000 PSI ( C) No diagram associated with this Parts List 34 HRS18 & HRS23 Hydraulic Reservoir System P 07/15/16

35 Valve Pressure Relief 2000 PSI ( C) Ref. Part No. Part Description Comments Revision No Parts Listing at This Time 07/15/16 HRS18 & HRS23 Hydraulic Reservoir System P 35

36 Valve Relief PTO Control HRS18 & HRS23 Hydraulic Reservoir System P 07/15/16

37 Valve Relief PTO Control Ref. Part No. Part Description Comments Revision dwg A D C C C C C C C C C C C C Drawing Image Number NO VALVE OPTION HRS * RELIEF VALVE MOUNT HHCS 3/8-16X1 GR5 HHCS 1/4-20X1 3/4 GR5 NUT HEX 1/4-20 PLT NUT HEX 3/8-16 PLT WASHER LOCK SPRING 1/4 PLT WASHER FLAT 1/4 SAE PLT WASHER FLAT 3/8 SAE PLT WASHER LOCK SPRING 3/8 PLT TE1 1/16MJIC1 1/16MJIC1 1/16MO AD 1 1/16MORB 1 1/16MJIC 2000 PRESSURE RELIEF VALVE HH3/4R /4 1 1/16FJIC/MOR 07/15/16 HRS18 & HRS23 Hydraulic Reservoir System P 37

38 Valve Solenoid Control HRS18 & HRS23 Hydraulic Reservoir System P 07/15/16

39 Valve Solenoid Control Ref. Part No. Part Description Comments Revision dwg A C C C C C C C Drawing Image Number SOLENOID VALVE OPTION HRS * HHCS 3/8-16X2 GR5 NUT HEX 3/8-16 PLT WASHER FLAT 3/8 SAE PLT WASHER LOCK SPRING 3/8 PLT AD 1 1/16MORB 1 1/16MJIC VALVE SOLNOD W/PILOT KIT 40GPM HH3/4R /16 FJIC 90 07/15/16 HRS18 & HRS23 Hydraulic Reservoir System P 39

40 Valve Solenoid W/Pilot 30 GPM ( C) HRS18 & HRS23 Hydraulic Reservoir System P 07/15/16

41 Valve Solenoid W/Pilot 30 GPM ( C) Ref. Part No. Part Description Comments Revision dwg C 1V2136 1V2120 2A A0291 1A0663 1V2062 2A A A0706 1R0037 1V2063 1V3636 2A A A9330 1V0081 1V1725 1A0757 1A9340 1A9341 1A9342 2V0066 Drawing Image Number VALVE SOLENOID 2000PSI 30GPM * BODY MACHINING SPOOL, SOLENOID O-RING STOP WASHER SPRING,CENTER SOLENOID HOUSING(R.H.) 1/8" NPTF PIPE PLUG O-RING O-RING RETAINER RELIEF CARTRIDGE SOLENOID HOUSING(L.H.) BACK PRESSURE CARTRIDGE ASS'Y LOCK WASHER MACHINE SCREW SOLENOID ASS'Y LOAD CHECK POPPET LOAD CHECK PLUG ASS'Y. LOAD CHECK SPRING CABLE SEAL TERMINAL FEMALE SLEEVE CONNECTOR BODY SEAL KIT 07/15/16 HRS18 & HRS23 Hydraulic Reservoir System P 41

42 Label Placement Table of Contents Section 5: Labels HRS18 & HRS23 Hydraulic Reservoir System P 07/15/16

43 Label Placement Section 5: Labels Ref. Part No. Part Description Comments Revision dwg C C C C C C C C C C C C Drawing Image Number DECAL SLOW MOVING VEHICLE DECAL - IMPORTANT, OPEN VALVE DECAL - OIL FILL LINE DECAL WARNING HIGH PRESSURE DECAL CAUTION GENERAL SAFTEY DECAL DANGER CRUSH TRACTOR/IMP RPBY C DECAL LANDPRIDE 10" BROWN/GOLD RPBY C DECAL LANDPRIDE 16" BROWN/GOLD DECAL HRS18 GOLD DECAL, HRS23 GOLD 07/15/16 HRS18 & HRS23 Hydraulic Reservoir System P 43

44 The is a numeric index of all part numbers included in this manual. The index shows what page(s) the part is used on. Part Number Page Part Number Page Part Number Page A A A A A A A A R V V V V V V V , , , , , , , , , , A A A A A V , H H A...17, A...17, A...17, A...17, A...17, D D D D D...19, D , , , , , , , C C...11, C...27, C C C...19, C...7, 13, C C C C...31, C C C C C...19, C...11, 31, 37, C C C C...7, C C...19, C... 7, 11, 13, 31, 37, C... 7, 11, 13, 31, 37, C C C C...19, C C C C...19, C C... 11, 13, 19, 21, 31, 37, C...19, C C C C C C C C C C C C C C C C C...19, C...9, C C C...39, C C , , C C...11, C...11, 13, C...11, C C C C C C...31, C C C...19, C...19, C C C C C C C...7 dwg dwg dwg dwg dwg dwg dwg dwg dwg dwg dwg dwg dwg dwg dwg dwg PMCK-PTO-1A HRS18 & HRS23 Hydraulic Reservoir System P 07/15/16

45 This Page Intentionally Left Blank 07/15/16 HRS18 & HRS23 Hydraulic Reservoir System P 45

46 Great Plains Manufacturing, Inc. Corporate Office: P.O. Box 5060 Salina, Kansas USA