PARTS CATALOG. Maxi-Heat MH Part No SN 0001MXH12 and UP. (308) , (800) (308) (308)

Transcription

1 Maxi-Heat MH 000 N ot fo rr ep ro du ct io n PARTS CATALOG PHONE FAX PARTS DEPT. FAX WEB (08) 99-9, (800) -7 (08) (08) Part No. 0807

2 TABLE OF CONTENTS.0 MAXI-HEAT TRAILER ASSEMBLY Tongue Assembly...(.) Axle...(.) Trailer Assembly (Rear and Right)...(.) Trailer Assembly (Front and Left)...(.) Trailer Interior Electrical/Accessories...(.).0 ENGINE/GENERATOR/CONTROL BOX ASSEMBLY CAT C. Engine and Generator...(.) CAT Control Box...(.) Isuzu TF CE Engine and Generator ( of )...(.) Isuzu TF CE Engine and Generator ( of )...(.) Isuzu Control Box...(.) Battery Installation...(.).0 POLY TANK/FROST FIGHTER ASSEMBLY Poly Tank Assembly...(.) Fuel Line Schematic...(.) Frost Fighter Assembly ( of )...(.) Frost Fighter Assembly ( of )...(.) Burner Assembly...(.) Heater Duct Assembly...(.).0 MAXI-HEAT OPTIONS Duct Box Assembly...(.) Gas Monitoring System...(.) Emergency Air Shutoff CAT C....(.) Shocker Valve CAT C....(.) Shocker Valve Isuzu CE...(.) 0 Allmand Bros., Inc. i

3 Maxi-Heat 000 TABLE OF CONTENTS.0 MAXI-HEAT DECALS Maxi-Heat Decals ( of 8)...(.) Maxi-Heat Decals ( of 8)...(.) Maxi-Heat Decals ( of 8)...(.) Maxi-Heat Decals ( of 8)...(.) Maxi-Heat Decals ( of 8)...(.) Maxi-Heat Decals ( of 8)...(.) Maxi-Heat Decals (7 of 8)...(.7) Maxi-Heat Decals (8 of 8)...(.8) ii 0 Allmand Bros., Inc.

4 . TONGUE ASSEMBLY -/ Allmand Bros., Inc..

5 Maxi-Heat 000. TONGUE ASSEMBLY Item Part No. Part Description Qty. 00P " REVERSIBLE BULLDOG HITCH ASSEMBLY 008 BULLDOG HITCH ONLY 09P -/" REVERSIBLE BULLDOG HITCH ASSEMBLY (OPTIONAL) 09 -/ BULLDOG HITCH ONLY (OPTIONAL) 00 LOCK PIN 00 TUBE MOUNT FOR JACK (WELDED TO TRAILER) 7 00 JACK SIDE CRANK 8 0 PLASTIC JACK CAP " AMBER REFLECTOR SAFETY CHAIN KIT 00 /8- TOPLOCK HEX NUT PL 0700 /8 FLAT WASHER PL 00 /8- X / HEX HEAD CS GR PL. 0 Allmand Bros., Inc.

6 . AXLE 0 Allmand Bros., Inc..

7 Maxi-Heat 000. AXLE Item Part No. Part Description Qty AXLE ASSEMBLY 8000 HUB & BEARING ASSEMBLY 00 AXLE HARDWARE KIT 09 WHEEL & TIRE ASSEMBLY ELECTRICAL BRAKE AXLE ASSEMBLY (OPTIONAL) NS 0 ELECTRICAL BRAKE CONVERSION KIT (OPTIONAL). 0 Allmand Bros., Inc.

8 . TRAILER ASSEMBLY (REAR AND RIGHT) Allmand Bros., Inc..

9 Maxi-Heat 000. TRAILER ASSEMBLY (REAR AND RIGHT) Item Part No. Part Description Qty. 8800P MAXI HEAT FRAME WELDMENT 0 FROST FIGHTER ASSEMBLY (IDF 00) 0 x 8 CHIMNEY TUBE 8800 CHIMNEY RAIN CAP 890P REAR DOOR ASSEMBLY 80 POSITIVE DOOR HOLDER 7 00 DOOR LATCH ASSEMBLY (USED FOR ALL HEATER DOORS) GROUND ROD ASSEMBLY RED REFLECTOR 0 00 LICENSE PLATE LAMP WITH BRACKET 08P REAR BUMPER SPACER 800P REAR BUMPER 09 TAIL LIGHT NS 890 TAIL LIGHT WIRING HARNESS 888P OUTER FENDER 07P RIGHT REAR SIDE PANEL 800P AIR INTAKE COVER RED MARKER LIGHT GLASS BULB 8 00 AMBER MARKER LIGHT GLASS BULB NS 887 VIN PACKAGE - INCLUDES 00, 007 (), 000 (), AND 00 () 9 890P SIDE TOP PANEL-RIGHT 0 888P SIDE BOTTOM PANEL-RIGHT 8007P SIDE REAR PANEL-RIGHT 8000P SIDE FRONT PANEL-RIGHT 00 DOOR STOP BUMPER 890P SIDE DOOR ASSEMBLY-RIGHT. 0 Allmand Bros., Inc.

10 . TRAILER ASSEMBLY (FRONT AND LEFT) Allmand Bros., Inc..

11 Maxi-Heat 000. TRAILER ASSEMBLY (FRONT AND LEFT) Item Part No. Part Description Qty. 890P FRONT ROOF PANEL 890P MIDDLE FRONT ROOF PANEL 099P MIDDLE ROOF PANEL (POLY TANK) 09P REAR ROOF PANEL 087P CHIMNEY GRAB 0999P MUFFLER SHIELD 7 090P EXHAUST SHIELD FOAM RUBBER 9 00 DOOR STOP BUMPER P ACCESS PANEL 8907P TOP HEADER-LEFT 8008P DOOR FILLER-LEFT 8009P SIDE BOTTOM PANEL-LEFT 8908P SIDE DOOR ASSEMBLY-LEFT 888P OUTER FENDER 00 AMBER MARKER LIGHT GLASS BULB RED MARKER LIGHT GLASS BULB RED REFLECTOR NS 887 VIN PACKAGE - INCLUDES 00, 007 (), 000 (), AND 00 () P LEFT REAR SIDE PANEL 0 800P AIR INTAKE COVER 800 OUTLET BOX COMPLETE ASSEMBLY 88 MANUAL STORAGE BOX. 0 Allmand Bros., Inc.

12 . TRAILER INTERIOR ELECTRICAL/ACCESSORIES INSIDE FRONT LEFT INSIDE REAR DOOR ENGINE COMPARTMENT HEATER COMPARTMENT OUTLET BOX ASSEMBLY 0 Allmand Bros., Inc..

13 Maxi-Heat 000. TRAILER INTERIOR ELECTRICAL/ACCESSORIES Item Part No. Part Description Qty. 80 INTERLOCK SAFETY SWITCH INTERIOR LAMP FIXTURE SMOKE SPOT TESTER STORAGE SMOKE TESTER COMPLETE ASSEMBLY 08 CANISTER SMOKE TESTER 07P CANISTER MOUNT SMOKE TESTER OUTLET BOX COMPLETE ASSEMBLY 00 OUTLET BOX ONLY CIRCUIT BREAKER SP 0AMP OUTLET BOX RUBBER MOUNT 9 00 /-0 KEPS NUT / CORD (TO HEATER ) 008 / CORD (TO HEATER ) 80 CONNECTOR BODY 0 AMP 0 V (ATTACHES ON HEATER END OF / CORD) 000 /8 -SCREW ROMEX CLAMP 0079 / GENERATOR CORD 0 / CORD GRIP 0 / LOCK NUT / INSULATING BUSHING. 0 Allmand Bros., Inc.

14 . CAT C. ENGINE AND GENERATOR ENGINE ASSEMBLY n 0 ro du ct io 9 rr ep 8 0 N 0 Allmand Bros., Inc.. 8 ot fo 7 BACK SIDE VIEW 7 ENGINE INSTALLATION GENERATOR INSTALLATION 9

15 Maxi-Heat 000. CAT C. ENGINE AND GENERATOR Item Part No. Part Description Qty. 0 CAT ENGINE C. 0Hz PULL FAN EPA TIER FINAL 087 MUFFLER CAT C. 0 FUEL FILTER CAT C. 00 OIL FILTER CAT C. 080 AIR FILTER CAT C. 09 9kW SAE /7. CUMMINS/CAT GENERATOR 7 0P CAT C. ENGINE MOUNT 8 0P CAT C. BRIDGE PLATE 9 00 GROUND STRAP 0 0 /8- x / HEX HEAD CS GR PL 8 00 /8 SPLITLOCK WASHER /8 FLAT WASHER SAE ZINC 8 08 /- x / HEX HEAD CS GR PL 070 / FLAT WASHER PL 008 /- NYLOCK HEX NUT PL 9 DRAIN VALVE FUMOTO CAT CABLE TIE TUBING VINYL CLEAR x COOLANT RECOVER TANK WITH BRACKET 0 08 HOSE / OVERFLOW COOLANT x /-0 KEPS HEX NUT PL 0078 /-0 x / PH-TRUSS HEAD MS SS 8897 ENGINE ISOLATOR SHOCK MOUNT 0 BLOCK HEATER CAT C. 099 END COVER 0 VOLT CORD NS 0 CORD CONNECTOR / NS 8808 GENERATOR MOUNT PLATE. 0 Allmand Bros., Inc.

16 . CAT CONTROL BOX Allmand Bros., Inc..

17 Maxi-Heat 000. CAT CONTROL BOX Item Part No. Part Description Qty. 000 /-0 x / PH-TRUSS HEAD MS SS 0078 /-0 x / PH-TRUSS HEAD MS SS 00 /-0 KEPS HEX NUT PL 00 #0- x / PH-ROUND HEAD MS SS 00 #0- KEPS HEX NUT PL 00 CAT IGNITION SWITCH W/ KEYS 007 CAT IGNITION KEY 7 00 FUEL GUAGE - BEEDE MH P CAT. CONTROL PANEL POLY TANK TOGGLE SWITCH A V 0 00 HOUR METER 09 0A BREAKER 00 TIMER/AUTO SHUTDOWN 00P CONTROL PANEL COVER. 0 Allmand Bros., Inc.

18 . ISUZU TF CE ENGINE AND GENERATOR ( of ) 7 8 BACK SIDE VIEW 8 9 ENGINE ASSEMBLY ENGINE & GENERATOR INSTALLATION 0 Allmand Bros., Inc..

19 Maxi-Heat 000. ISUZU TF CE ENGINE AND GENERATOR ( of ) Item Part No. Part Description Qty ISUZU ENGINE TF CE PULLER FAN 890 MUFFLER ISUZU 890 MUFFLER GASKET ISUZU FUEL FILTER ISUZU OIL FILTER ISUZU 0 AIR CLEANER RADIAL SEAL AIR FILTER ISUZU kW SAE /7. CUMMINS/ISUZU GENERATOR 9 00 GROUND STRAP 0 08 DRAIN VALVE FOMOTO ISUZU CABLE TIE TUBE OIL DRAIN /8 x. 007 COOLANT RECOVER TANK WITH BRACKET RADIATOR ISUZU 089 RADIATOR MOUNTING BRACKET KIT ISUZU 8897 ENGINE ISOLATOR SHOCK MOUNT 7 9 BLOCK HEATER ISUZU END COVER 0 VOLT CORD 9 0 STARTER ISUZU /-0 x / PH-TRUSS HEAD MS SS 00 /-0 KEPS HEX NUT PL 08 HOSE / ID COOLANT OVERFLOW x HOSE / ID COOLANT OVERFLOW x.0 NS 0 CORD CONNECTOR / NS 0 RADIO FREQUENCY INTERRUPT NS 0 ELECTRONIC BOOST CONTROL NS 07 ELECTRONIC BOOST SYSTEM NS RECTIFIER BRIDGE ISUZU NEWAGE NS 8808 GENERATOR MOUNT PLATE. 0 Allmand Bros., Inc.

20 . ISUZU TF CE ENGINE AND GENERATOR ( of ) Allmand Bros., Inc..

21 Maxi-Heat 000. ISUZU TF CE ENGINE AND GENERATOR ( of ) Item Part No. Part Description Qty. 089 RADIATOR MOUNTING BRACKET KIT ISUZU 0 STARTER ISUZU 00 AVR BOARD -000 STOP SOLENOID STOP SOLENOID O-RING -000 ALTERNATOR DIODE TEMPERATURE SWITCH OIL PRESSURE SWITCH 9 0 RELAY ASSEMBLY FUEL PUMP. 0 Allmand Bros., Inc.

22 . ISUZU CONTROL BOX Allmand Bros., Inc..

23 Maxi-Heat 000. ISUZU CONTROL BOX Item Part No. Part Description Qty ISUZU CONTROL BOX ASSEMBLY 900 IGNITION SWITCH ISUZU WITHOUT TUMBLER OR KEYS 900 IGNITION TUMBLER WITH KEYS ISUZU 9 IGNITION KEY ISUZU 00 FUEL GUAGE - BEEDE MH HOUR METER 0009 TOGGLE SWITCH A V GLOW LIGHT INDICATOR -000 GLOW PLUG TIMER ISUZU CONTROL BOX COVER. 0 Allmand Bros., Inc.

24 . BATTERY INSTALLATION 7 ATTACH TO STARTER ATTACH TO GROUND 0 Allmand Bros., Inc..

25 Maxi-Heat 000. BATTERY INSTALLATION Item Part No. Part Description Qty BATTERY 8D 070 BATTERY CABLE GA 8 POSITIVE 7098 BATTERY CABLE GA POSITVE 07 J-BOLT BATTERY HOLD DOWN 800 NYLON BATTERY HOLD DOWN 0700 / FLAT WASHER PL 7 00 /-8 KEPS HEX NUT PL. 0 Allmand Bros., Inc.

26 . POLY TANK ASSEMBLY 7 8 FUEL TANK SUPPORT KIT Allmand Bros., Inc..

27 Maxi-Heat 000. POLY TANK ASSEMBLY Item Part No. Part Description Qty BOTTOM 0998 TANK POLY, HEATER 099 TANK POLY, ENGINE 0990 HOLD-DOWN 0998 FIREWALL 0097 GROMMET /8- X -/ CARRIAGE BOLT G /8 FLAT WASHER SAE ZINC /8- NYLOCK HEX NUT PL 0 0 /8- X HEX HEAD CS GR8 PL 00 /8- KEPS HEX NUT PL 00 FUEL SENDER 0 /8- X -/ HEX HEAD CS GR8 PL 000 / X 7/ TRIM LOCK 09 CHAIN MOUNT 08 /8 PUSH NUT / X -/ X.0 FENDER WASHER 8 00 /-0 X -/ HEX HEAD CS GR PL RUBBER SEAL 8" EA /-0 KEPS NUT 00 /-0 NYLOCK NUT 0 FUEL TANK CAP PLASTIC 088 FUEL CAP, LOCKING, VENTED, W/ KEYSET (OPTIONAL) FUEL TANK SUPPORT KIT 08 STIFFENER, POLY TANK 08 SUPPORT CLIP, POLY TANK 070 /8 FLAT WASHER SAE ZINC /8- NYLOCK HEX NUT PL /8- X -/ HEX HEAD CS GR8 PL. 0 Allmand Bros., Inc.

28 . FUEL LINE SCHEMATIC 0 Allmand Bros., Inc..

29 Maxi-Heat 000. FUEL LINE SCHEMATIC Item Part No. Part Description Qty. 00 HOSE SCREW CLAMP /8 0 RETURN FUEL LINE 0 SUPPLY FUEL LINE TO PRE-FILTER 0 SUPPLY FUEL LINE PRE-FILTER TO BURNER 09 CAT FUEL LINE KIT 00 ISUZU FUEL LINE KIT 0009 CLEAR HOSE WITH FITTING. 0 Allmand Bros., Inc.

30 . FROST FIGHTER ASSEMBLIES ( OF ) UNDER SWITCH COVER INSIDE GENISYS CONTROL HEAT EXCHANGER DETAIL FROST FIGHTER DETAIL GENISYS CONTROL DETAIL 0 Allmand Bros., Inc..

31 Maxi-Heat 000. FROST FIGHTER ASSEMBLIES ( OF ) Item Part No. Part Description Qty FROST FIGHTER ASSEMBLY (IDF 00) STAINLESS STEEL HEAT EXCHANGER ASSEMBLY 88 FLUE COLLAR 88 RETAINER NUT WITH WASHER SET OF 00 FAN MOTOR,. HP BALDOR 008 BURNER ASSEMBLY (IDF 00, CF 800) 88 HIGH SWITCH COVER 7 88B ADJUSTABLE FAN SWITCH 887 ADJUSTABLE TEMPERATURE FEELER SWITCH (LOCATED UNDER 88B) HIGH LIMIT SWITCH 00 PROBE 9 09 GENISYS SYSTEM OIL PRIMARY CONTROL 0 0 GENISYS CONTROL COVER PLASTIC 88 SWITCH RECEPTACLE 880 TOGGLE SWITCH 089 AMP THERMO SWITCH 09 FAN BLOWER RELAY 09 0 AMP RELAY 089 CIRCUIT BREAKER AMP B FIBERGLASS SEAL 8 0 x 8 CHIMNEY TUBE CHIMNEY RAIN CAP. 0 Allmand Bros., Inc.

32 . FROST FIGHTER ASSEMBLIES ( OF ) 7 8 REMOTE THERMOSTAT FILTER DETAIL FUEL PUMP DETAIL Allmand Bros., Inc..

33 Maxi-Heat 000. FROST FIGHTER ASSEMBLIES ( OF ) Item Part No. Part Description Qty. 870 REMOTE THERMOSTAT 0 SUPPLY FUEL LINE TO PRE-FILTER 0 SUPPLY FUEL LINE PRE-FILTER TO BURNER 0009 CLEAR HOSE WITH FITTING 007P MOUNTING BRACKET 00 HEATER PRE-FILTER ASSEMBLY 7 00 FILTER ELEMENT (FOR 00) 8 00 HEATER ELEMENT (FOR 00) 089 HEATER ELEMENT RELAY (ATTACHES TO 00) 9 88A SPIN ON FUEL FILTER AND FILTER HEAD ASSEMBLY 0 88A SPIN ON FUEL FILTER 88A MOUNTING BRACKET (FOR 88A) 08 FUEL SHUTOFF VALVE 8897 ADAPTER NIPPLE (FOR 08) 8877 FUEL GAUGE 8809 FUEL SHUTOFF VALVE (FOR 8877) 880 COMBU VALVE 889B FUEL PUMP 7 00 FAN MOTOR,. HP BALDOR 8 0 CAPACITOR SILVER 9 00 CAPACITOR BLACK FAN BLADE HIGH STATIC (LOCATED UNDER SCREEN) 00 FAN MOTOR MOUNT WITH SCREEN 888B BECKETT TRANSFORMER/IGNITOR 09 GENISYS SYSTEM OIL PRIMARY CONTROL 880 BURNER MOTOR, / HP NS 0 FROST FIGHTER HEATER WIRE HARNESS NS 887 DUAL FUEL HEATER WIRE HARNESS. 0 Allmand Bros., Inc.

34 . BURNER ASSEMBLY ELECTRODE ASSEMBLY DETAIL COMPLETE BURNER ASSEMBLY 0 Allmand Bros., Inc..

35 Maxi-Heat 000. BURNER ASSEMBLY Item Part No. Part Description Qty. 889B A FUEL PUMP 880 BURNER MOTOR, / HP 007 BURNER/BLOWER FAN 88 OIL DELIVERY TUBE 8 00 OIL DELIVERY TUBE 9-/ 888B BECKETT TRANSFORMER/IGNITOR FLEX COUPLING -/ LONG (/ AND / DIAMETER ENDS) BURNER ASSEMBLY (IDF 00, CF 800) HOUSING AIR TUBE COMBINATION (INCLUDES BLAST TUBE, ELECTRODE ASSEMBLY AND AIR DISFFUSER) AIR BAND ASSEMBLY 88B AIR SHUTTER HOUSING 8900 ELECTRODE INSULATOR KIT 000 ELECTRODE ASSEMBLY WITH END CONE 880 COMBU VALVE 09 AIR GUIDE NOZZLE,. GPH 8890A NOZZLE,.0 GPH 8890B NOZZLE,. GPH 8890C NOZZLE,.7 GPH 889 NOZZLE,.0 GPH 889A NOZZLE,. GPH 8 07 KNURLED NUT 9 88B CAD CELL FLAME DETECTOR. 0 Allmand Bros., Inc.

36 . HEATER DUCT ASSEMBLY 8 0 CONNECTING BAND DETAIL 7 (x ) 0 SILICONE LINER DUCT OPTION DUCT OPTION 0 Allmand Bros., Inc..

37 Maxi-Heat 000. HEATER DUCT ASSEMBLY Item Part No. Part Description Qty. 00 x INSULATED END CAP 887 HEATER DUCT x 0 08 HEATER DUCT x 0 SILICONE LINER (OPTIONAL) 00 x INSULATED END CAP 887 HEATER DUCT x 887 SCREW CLAMP SLIP LOCK CONNECTOR CONNECTING BAND. 0 Allmand Bros., Inc.

38 . DUCT BOX ASSEMBLY Allmand Bros., Inc..

39 Maxi-Heat 000. DUCT BOX ASSEMBLY Item Part No. Part Description Qty DUCT STORAGE BOX COMPLETE 88P DUCT BOX BOTTOM PANEL 889P DUCT BOX MOUNT PLATE 070 /8 FLAT WASHER 8 0 /8- X -/ HEX HEAD CS GR 008 /8- NYLOC HEX NUT 88P DUCT BOX LEFT SIDE PANEL /-0 X / CARRIAGE BOLT / FLAT WASHER /-0 KEPS HEX NUT 0 88P DUCT BOX RIGHT SIDE PANEL 88P DUCT BOX FRONT PANEL 00 #0- X / SLOTTED FLAT HEAD #0- NYLOC HEX NUT SS 88P DUCT BOX TOP PANEL 070 DOOR HOLDER 00 #0- X / PH-ROUND HEAD 7 80 HASP HINGE 9 888P DUCT BOX LID /-0 X / CARRIAGE BOLT 7. 0 Allmand Bros., Inc.

40 . GAS MONITORING SYSTEM GAS MONITORING SYSTEM ASSEMBLY A D B 9 C VOLTAGE CONVERTER / GAS MONITOR ASSEMBLY B A SOLAR PANEL ASSEMBLY C D STROBE LIGHT ASSEMBLY REMOTE SENSOR ASSEMBLY Allmand Bros., Inc..

41 Maxi-Heat 000. GAS MONITORING SYSTEM Item Part No. Part Description Qty. 089P ROOF MOUNT BRACKET 08P GAS MONITOR MOUNT BRACKET 0079 VOLTAGE CONVERTER 0 COMBUSTIBLE GAS MONITOR 0 MONITOR WIRE HARNESS (NOT SHOWN, CONNECTS GAS MONITOR TO VOLTAGE CONVERTER) 0 MAIN POWER WIRE HARNESS 08 SENSOR WIRE HARNESS 7 07 IGNITION SWITCH / CORD GRIP (. ID to.7 ID) 9 00 / CORD GRIP (.00 ID to. ID) 0 0 BUSHING REDUCER 709 SOLAR PANEL WATT SW-P 009P REAR SOLAR PANEL BRACKET 008P FRONT SOLAR PANEL BRACKET 09 SOLAR PANEL WIRE HARNESS 0 GROMMET / ID x 0 ID 08P STROBE LIGHT MOUNT BRACKET 7 07 UNIVERSAL HOUSING 8 09 STROBE LIGHT 9 07 STROBE LIGHT WIRE HARNESS 0 00 NIPPLE / x 0P GAS SENSOR MOUNT BRACKET 08 SPLASH SENSOR 00 CORD GRIP / Allmand Bros., Inc.

42 . EMERGENCY AIR SHUTOFF CAT C. SHUTOFF VALVE ASSEMBLY 7 7 ENGINE INSTALLATION 08_A 0 Allmand Bros., Inc..

43 Maxi-Heat 000. EMERGENCY AIR SHUTOFF CAT C. Item Part No. Part Description Qty SHUTOFF VALVE ASSEMBLY 090 SHUTOFF VALVE ISUZU LE/ CAT C., C. 0900P BRACKET T HANDLE 00 /-0 NYLOCK HEX NUT PL 008 # HOSE CLAMP / FLAT WASHER SAE SS 07 DECAL ENGINE SHUTDOWN TEST /-0 X / PH-TRUSS HEAD MS SS. 0 Allmand Bros., Inc.

44 . SHOCKER VALVE CAT C CONTROL BOX DETAILS _B 0 Allmand Bros., Inc..

45 Maxi-Heat 000. SHOCKER VALVE CAT C. Item Part No. Part Description Qty. 00 #0 CLAMP CUSH 00 # CUSH CLAMP / HOLE 07 WIRING HARNESS SHOCKER VALVE MAXI HEAT 0700 / FLAT WASHER PL 000 / SPLITLOCK WASHER 000 /-0 x /8 HEX CS GR PL #8- x / HEX WASHER HEAD INDT /-0 HEX NUT PL 9 00 #8- NYLOCK HEX NUT SS 0 00 /-0 x HEX HEAD CS GR PL 000 /-8 x / HEX HEAD BOLT 0 0 AMP BREAKER 0009 SWITCH A V 070 SHOCKER VALVE KIT 0P BRACKET, MOUNT AIR CLEANER/SHOCKER 088P BRACKET SHOCKER MOUNT 7 08P REAR COVER CAT CONTROL PANEL WIRE, POWER FEMALE SIDE WIRE, POWER MALE SIDE 0 0 RPM SENSOR, 8MM x. NS 070 SHOCKER SETUP INSTRUCTIONS. 0 Allmand Bros., Inc.

46 . SHOCKER VALVE ISUZU TF CE 8 AIR CLEANER MOUNT DETAIL CONTROL BOX DETAILS _B 0 Allmand Bros., Inc..

47 Maxi-Heat 000. SHOCKER VALVE ISUZU TF CE Item Part No. Part Description Qty. 07P MOUNT AIR CLEANER ISUZU CE 0 HOSE RUBBER AIR SYSTEM 08 T-BOLT CLAMP, -/ STAINLESS STEEL 09 T-BOLT CLAMP, STAINLESS STEEL 08P REAR COVER ISUZU CONTROL 0 0 AMP BREAKER SWITCH A V SHOCKER VALVE KIT 9 07 WIRING HARNESS SHOCKER VALVE MAXI HEAT / FLAT WASHER PL 00 /-0 KEPS HEX NUT PL 00 #8- x / SL-ROUND HEAD MS PL 0700 #8 FLAT WASHER SAE ZC 00 #8- NYLOCK HEX NUT SS 00 #8 CUSH CLAMP / HOLE 00 # CUSH CLAMP / HOLE WIRE, POWER FEMALE SIDE WIRE, POWER MALE SIDE / x 8-/ HEX HEAD CS PL 0 07 MAGNETIC SENSOR / x WITH PLUG NS 070 SHOCKER SETUP INSTRUCTIONS *NOTE: PARTS CALLED OUT IN SAME NUMBER ARE THE ASSEMBLY OF SHOCKER KIT.. 0 Allmand Bros., Inc.

48 . MAXI-HEAT DECALS ( OF 8) RIGHT 0 Allmand Bros., Inc..

49 Maxi-Heat 000. MAXI-HEAT DECALS ( OF 8) Item Part No. Part Description Qty. 0 LARGE ALLMAND BANNER GOLD STANDARD 0 BANNER RIGHT DECAL GOLD STANDARD 0909 ELEVATION (NOZZLE) SETTING NOTICE DECAL. 0 Allmand Bros., Inc.

50 . MAXI-HEAT DECALS ( OF 8) LEFT 0 Allmand Bros., Inc..

51 Maxi-Heat 000. MAXI-HEAT DECALS ( OF 8) Item Part No. Part Description Qty. 0 LARGE ALLMAND BANNER GOLD STANDARD 0 BANNER LEFT DECAL GOLD STANDARD HOT SURFACE WARNING DECAL 090 HOT SURFACE WARNING DECAL FRENCH (CSA ONLY) 07 GROUND DECAL 0907 NO STEP DECAL 7 00 DUCT HOSE NOTICE DUCT HOSE NOTICE FRENCH (CSA ONLY). 0 Allmand Bros., Inc.

52 . MAXI-HEAT DECALS ( OF 8) TOP 0 Allmand Bros., Inc..

53 Maxi-Heat 000. MAXI-HEAT DECALS ( OF 8) Item Part No. Part Description Qty DECAL HEATER ENGINE TANK 0077 DECAL HEATER TANK 0078 DECAL HEATER TANK. 0 Allmand Bros., Inc.

54 . MAXI-HEAT DECALS ( OF 8) REAR 0 Allmand Bros., Inc..

55 Maxi-Heat 000. MAXI-HEAT DECALS ( OF 8) Item Part No. Part Description Qty. 0 REAR PANEL DECAL GOLD STANDARD 0088 GENERATIONS DECAL ALLMAND ASSURANCE DECAL 07 MANUFACTURED IN THE USA DECAL. 0 Allmand Bros., Inc.

56 . MAXI-HEAT DECALS ( OF 8) BREAKER BOX CONTROL BOX 0 Allmand Bros., Inc..

57 Maxi-Heat 000. MAXI-HEAT DECALS ( OF 8) Item Part No. Part Description Qty. 090 ELECTRICAL SHOCK DANGER DECAL 0907 ELECTRICAL SHOCK DANGER DECAL FRENCH (CSA ONLY) 0907 LIGHT SWITCH DECAL CONTROL PANEL 0 DIESEL FUEL TANK DESIGNATION. 0 Allmand Bros., Inc.

58 . MAXI-HEAT DECALS ( OF 8) REAR DOOR - OF 0 Allmand Bros., Inc..

59 Maxi-Heat 000. MAXI-HEAT DECALS ( OF 8) Item Part No. Part Description Qty CSA RATING DECAL (CSA) 00 CAUTION STATEMENTS DECAL (CSA) 090 PARTS AND SERVICE CONTACT DECAL CALIFORNIA PROPOSITION WARNING DECAL 0900 GROUND ROD WARNING DECAL 00 GROUND ROD INSTRUCTIONS DECAL (CSA). 0 Allmand Bros., Inc.

60 .7 MAXI-HEAT DECALS (7 OF 8) REAR DOOR - OF 0 Allmand Bros., Inc..7

61 Maxi-Heat MAXI-HEAT DECALS (7 OF 8) Item Part No. Part Description Qty ENGINE START INSTRUCTIONS DECAL OPERATOR INSTRUCTIONS DECAL 090 CARBON DIOXIDE WARNING DECAL 090 POSSIBILITY OF FIRE DECAL 0907 GROUND REQUIREMENT (CSA).7 0 Allmand Bros., Inc.

62 .8 MAXI-HEAT DECALS (8 OF 8) REAR DOOR - OF 0 Allmand Bros., Inc..8

63 Maxi-Heat MAXI-HEAT DECALS (8 OF 8) Item Part No. Part Description Qty NEUTRAL BOND (CSA) 0907 CSA DECAL (CSA) 090 ENGINE START INSTRUCTIONS DECAL FRENCH (CSA ONLY) 090 OPERATOR INSTRUCTIONS DECAL FRENCH (CSA ONLY) 090 DO NOT OPERATE INSIDE DECAL FRENCH (CSA ONLY) 090 DO NOT OPERATE DECAL FRENCH (CSA ONLY).8 0 Allmand Bros., Inc.

64 BRIGHTER. WARMER. SAFER. Allmand Bros., Inc. 0 West th Avenue Holdrege, NE 899 phone: (08) 99-9 toll free: (800) -7 fax: (08) TM Reliability, performance, and integrity since 98-07