Parts Manual Port A Scrub 14 with Power Pack MODEL M14BQP (Battery)

Transcription

1 Parts Manual Port A Scrub 14 with Power Pack MODEL M14BQP (Battery)

2 Introduction Preface Please be advised explicitly that we cannot accept any legal issues out of the contents of this manual. If repair work has to be performed make sure that only genuine spare parts are used; only genuine spare parts may guarantee a dependable machine. We reserve the right for technical improvement.. Valid as of: 05/09 Minuteman International Inc. 14N845 US ROUTE 20 PINGREE GROVE, IL U.S.A Proper use The machine is a vacuum scrubbing machine for wet cleaning of hardsurfaced floors. Using the machine beyond this scope of application will be deemed improper use; The manufacturer cannot be held liable for consequential damages; the user alone bears the risk. The term of proper use also includes operation, maintenance and repair work to be performed in compliance with the manufacturer s specifications. The E 24 may only be used by persons that are familiar with the machine and aware of possible hazards involved. If modifications to the machine are made in absence of the manufacturer s prior consent, the latter cannot be held liable for damage resulting from such unauthorized modification. Notes on warranty The terms of the sales contract apply. Damages are not subject to warranty if they are due to non-compliance with the maintenance and service provisions. The maintenance work has to be performed by an authorized Minuteman service center. The following is excluded from warranty: fuses, natural wear, damages caused by overload, inexpert handling and unauthorized modification of the machine. Moreover, any claim for warranty cannot be accepted if damages of the machine are caused by fitting parts or accessories without Minuteman s prior and explicit consent or by noncompliance with the maintenance instructions.

3 For Safety When Servicing or Maintaining Machine Stop on level surface. Disconnect the power to the machine by pulling the red Battery Connector located under the recovery tank near the batteries. Avoid moving parts. Do not wear loose jackets, shirts, or sleeves when working on machine. Avoid contact with battery acid. Battery acid can cause burns. When working on or around batteries, wear protective clothing and safety glasses. Remove metal jewelry. Do not lay tools or metal objects on top of batteries. Do not clean machine with a pressure washer. Authorized personnel must perform repairs and maintenance. Use Minuteman supplied replacement parts. Page 3

4 TABLE OF CONTENTS FOR SAFETY WHEN SERVICING OR MAINTAINING MACHINE... 3 CHASSIS ASSEMBLY... 5 HANDLE ASSEMBLY... 6 BRUSH CONTROL ASSEMBLY... 8 BRUSH HEAD ASSEMBLY VACUUM MOTOR ASSEMBLY VACUUM MOTOR ASSEMBLY SQUEEGEE ASSEMBLY SQUEEGEE LIFTING ASSEMBLY WATER FEED ASSEMBLY TANK ASSEMBLY BRUSH HEAD MOUNTING ASSEMBLY ELECTRIC ASSEMBLY ELECTRIC ASSEMBLY COVERING ASSEMBLY POWER TROLLEY ASSEMBLY LABELING WARRANTY... 28

5 CHASSIS ASSEMBLY Chassis group Base Frame Assy Seal - Wheel Wheel Bush-Wheel Washer-Main Wheel Hex. Soc. CSK. Head Screw SS M6x Cover Wheel Hex Soc. Head Pin Bush LH&RH- Pillar Handle Knob - Handle Cover Assy - Pillar Hex.Soc.CSK. Head Screw SS M5x Lifting Handle-Frame Optional Washer Washer 8.4x16.0x Hex Head Screw M8x Battery Holder Assy Page 5

6 HANDLE ASSEMBLY Page 6

7 HANDLE ASSEMBLY Handle group CR Pan Head-SS M4x Hex Soc Csk Hd Screw-SS M5x CR CSK Screw SS M5x Hex Soc Csk Hd Screw-SS M6x Self Tap Screw 4.8x Self Tap Screw 4.8x Washer SS x10x Cap Guide Shifter Bottom Switch Cover Bottom Guide Rope Guide Shifter Top Boot Cable Bellow Handle Grommet Switch Cover Plug Handle Cover Shifting Lever Assy Switch Cover Top Steering Assy Controller Board Bracket Channel Bracket Controller Board Handle Weldment Main Switch with Connector Page 7

8 BRUSH CONTROL ASSEMBLY Page 8

9 BRUSH CONTROL ASSEMBLY Brush control group Housing Brush with Insert assy Housing Assy-Gear Support Hinge - Idler End Idler Support Assy Brush Hex. Soc.Hd Cap Screw -SS M6X Brush Motor With Connector Drive Belt 425-5M-15-HTD Cover - With Seal Hex-Soc-Hd-Cap-Screw M6X Washer 6.4X18X Hex. Nylock Nut - St M CRPH-Screw M5X Hex Soc Hd Cap Screw M6x Washer 6.4X12X Domed Cap Nut-SS M Lip-Flash Guard Strip-Flash Guard Knob-SQG Geared Motor Stud-Brush Housing Washer 5.2X10X Weight Motor Hex-Soc-Hd-Cap-Screw M6x30 Page 9

10 BRUSH HEAD ASSEMBLY Page 10

11 BRUSH HEAD ASSEMBLY Brush head group Housing-Gear Support Bearing RS Sprocket Assy Gear Drive Key Idler - Plain Assy Hex. Soc. Hd Cap Screw - St M6X Bearing 608 2Z Gear-LH Gear-RH O' Ring 36X Pulley-Drive Washer-Bridge Hex-Soc-CSK-Hd-Screw-SS M6X Cover Idler End Spacer-Idler End Idler Pulley - Brush Washer-SS X20X Domed Cap Nut-SS M Oring 6X Knob Idler Cover Pin-Idler End Bracket-Parking W heel Self Tapping Screw 4.8X Circlip Internal Light B Pin-Parking Stand Bracket-Castor Circlip E6.0 (Type C) Washer-Castor Hex-Soc-CSK-Hd-Screw-SS M5X Knob-Parking W heel Wheel-Parking Pin-Wheel Parking W heel Kit NOT SHOWN Brush (PA / Blue) Brush (PP / Black) Brush (SIC / Grey) Page 11

12 VACUUM MOTOR ASSEMBLY 1 Vacuum motor group CRPH Self Tapping Screw - SS 3.5X Washer - SS 4.0X8.0X Guide - Float Float Gasket - Float Hose Assy - Vacuum Hose Assy - Collection Vacuum Motor Sub Assy Gasket - Lip Hose Assy SQG Group Clamp Hose Washer 5.2X10X CRPH Self Tapping Screw Steel (Form F) 4.8x Lip - Valve Clamp Bellow SQG Bellow - Sqg Ring - Bellow Washer - SS 4.3X12X CRPH Screw M4X12 Page 12

13 VACUUM MOTOR ASSEMBLY 2 Vacuum motor assembly Hsg Bottom - V.M Gasket - V.M V.M with Connector Assy Hsg Top - V.M Washer - SS X10X Self Tap Screw 4.8X Carbon Brush Set Page 13

14 SQUEEGEE ASSEMBLY Page 14

15 SQUEEGEE ASSEMBLY Squeegee group Body Sqg Valve Top Valve Bottom Hex. Soc. Hd Cap Screw - SS M5X Lip - Sqg. Inner Lip - Sqg. Outer Strip - Lip Sqg Knob - Sqg Squeegee Rod Sub Assy Guide - Pillar Sqg Bush Top - Pillar Sqg Pin 10 - Pillar Sqg Bush Bottom - Pillar Sqg Spring - Pillar Sqg Locking Clip-SQG Pillar Deflector - Roller W asher - Deflector CSK-Self-Screw 4.2x W heel - Sqg. Assy CRPH-Self-Screw-SS 4.8X W asher - SS 5.2X10X Reference Only 1 Suction Valve Page 15

16 SQUEEGEE LIFTING ASSEMBLY Page 16

17 SQUEEGEE LIFTING ASSEMBLY Squeegee lifting Clip - Clamp Pin 6 - Pillar Sqg Squeegee Front Squeegee Rear Cable Assy - Squeegee Sqg Rod Assy - Front Sqg. Rod Assy - Rear Hex. Socket Head Cap Screw - St M6X Bush-SQG Link W asher - St 6.4X12X Hex. Nylock Nut - St M Hex-Soc-CSK-Hd-Screw M5X Bush9.8-SQG Link U Bracket - Stud Hex-Nut M Stud - Link Adj Hex-Nut M Connector - Link Hook - Spring Hex Head Screw M6X Shifting Lever Assy Page 17

18 WATER FEED ASSEMBLY Water feed system Holder - Nozzle Washer - Nozzle Nozzle Assy Nut - Nozzle Bracket - Pump Vibrating Pump 24V Hose - Nozzle Pump Kit 24V Hose - Pump Body-Filter Filter Cap-Filter Filter Assy Page 18

19 TANK ASSEMBLY Page 19

20 TANK ASSEMBLY Tank group Bottom Housing Cap - V.M Yoke Hinge - Lid (Right) CRPH Self Screw-SS 3.5X Yoke Hinge - Lid (Left) Mounting Plate - Bot. Hsg CRPH Self Screw - SS 3.5X Bracket - Housing CRCSK Screw - St M4X Bottom Housing Assy Tank - Fresh Handle - Fresh Spacer - Tank Tank - Fresh assy Tank - Collection Handle - Collection Cap - Collection Tank Tank - Collection Assy Lid Hook Hinge - Lid Hose Guide Gasket - Fresh Gasket - Collection Holder Float Assembly Top Cover Assy W asher -SS 4.0X8.0X CRPH Self Tapping Screw-SS 3.5X9.5(DIN 7981) CRPH Self Screw-SS 3.5x18 Page 20

21 BRUSH HEAD MOUNTING ASSEMBLY Brush head mounting group Support Plate-Housing Washer 6.4X12X Hex Soc Hd Cap Screw M6X Washer-SS 4.3X9X CR Pan Head-SS M4X Edge Protector B10 Page 21

22 ELECTRIC ASSEMBLY 1 Electric CR CSK Screw M5X CSK-Self-Screw 4.2x Relay Mounting Bracket Top CRPH Self Screw 3.5x Relay Board Assy Relay Board Mounting Bracket Fuse Holder CR Pan Head SS M5X Battery Plug Assy Male Bracket Capacitor Data Cable Assy CR CSK HD Screw ST 4x Channel Relay CRPH Self Screw 3x W asher 4x8x W asher 3.5x7.0x Rubber Bush Page 22

23 ELECTRIC ASSEMBLY 2 Electric Fuse 1A Fuse 35A Fuse 25A Fuse 5A Fuse 50A Fuse Link Cable Cable Assy BM Cable Assy VM Cable Assy Pump Sticker Panel 14B Ferrite Vacuum Motor Ferrite Brush Motor Page 23

24 COVERING ASSEMBLY Covering assembly Washer-Bridge Hex Soc CSK Hd Screw-SS M6X20 Page 24

25 POWER TROLLEY ASSEMBLY Page 25

26 POWER TROLLEY ASSEMBLY Power trolley Hood Seal Inspection glass Screw Lens flange screw Battery Sheet metal Hex.bolt W asher Fixed castor Threaded sheet metal Battery cable Tension band Hexagon screw Charging cable On-board charger - USA Cable tie Cable sleeve Bushing Console Sealing Plug W asher Lens cap W asher Hexagon nut Page 26

27 LABELING Labeling Blind rivet Lable high-pressure cleaner Nameplate Decal "Instruction manual" Protection Decal Page 27

28 Minuteman International Made Simple Commercial Limited Warranty REVISION O EFFECTIVE 4/1/2016 Minuteman International, Inc. warrants to the original purchaser/user that the product is free from defects in workmanship and materials under normal use. Minuteman will, at its option, repair or replace without charge, parts that fail under normal use and service when operated and maintained in accordance with the applicable operation and instruction manuals. All warranty claims must be submitted through and approved by factory authorized repair stations. This warranty does not apply to normal wear, or to items whose life is dependent on their use and care, such as belts, cords, switches, hoses, rubber parts, electrical motor components or adjustments. Parts manufactured by Minuteman are covered by and subject to the warranties and/or guarantees of their manufacturers. Please contact Minuteman for procedures in warranty claims against these manufacturers. Special warning to purchaser -- Use of replacement filters and/or pre-filters not manufactured by Minuteman or its designated licensees, will void all warranties expressed or implied. A potential health hazard exists without original equipment replacement. All warranted items become the sole property of Minuteman or its original manufacturer, whichever the case may be. Minuteman disclaims any implied warranty, including the warranty of merchantability and the warranty of fitness for a particular purpose. Minuteman assumes no responsibility for any special, incidental or consequential damages. This limited warranty is applicable only in the U.S.A. and Canada, and is extended only to the original user/purchaser of this product. Customers outside the U.S.A. and Canada should contact their local distributor for export warranty policies. Minuteman is not responsible for costs or repairs performed by persons other than those specifically authorized by Minuteman. This warranty does not apply to damage from transportation, alterations by unauthorized persons, misuse or abuse of the equipment, use of non-compatible chemicals, or damage to property, or loss of income due to malfunctions of the product. If a difficulty develops with this machine, you should contact the dealer from whom it was purchased. This warranty gives you specific legal rights, and you may have other rights which vary from state to state. Some states do not allow the exclusion or limitation of special, incidental or consequential damages, or limitations on how long an implied warranty lasts, so the above exclusions and limitations may not apply to you. Model Parts Labor Poly Travel** Cord Electric Group 5yrs 3yrs 12yrs 90 days Battery Operated Group 5yrs 3yrs 12yrs 90 days Exceptions. Model Parts Labor Poly Travel** Port A Scrub, all models 1yr 6months 12yrs 90 days A3S Blower 1yr 1yr 0 0 Phenom Dual Motor Upright Vacuums 2yrs 2yrs 0 0 Explosion Proof Vacuum 1yr 1yr 0 0 Propane Burnisher 1yr 1yr 0 90 days **Travel, 2 hours max Stand-alone Battery Chargers: Replacement Parts: Batteries: Polypropylene Plastic Tanks: One year Ninety days 0-3 months full replacement, 4-12 months pro-rate 12yr warranty, no additional labor 14N845 U.S. Route 20 Pingree grove, IL Phone: B Rev A 07/16