Parts Manual H26 WALK BEHIND SCRUBBER

Transcription

1 Parts Manual H26 WALK BEHIND SCRUBBER

2 Introduction Preface Please be advised explicitly that we cannot accept any legal issues out of the contents of this manual. If repair work has to be performed make sure that only genuine spare parts are used; only genuine spare parts may guarantee a dependable machine. We reserve the right for technical improvement.. Valid as of: 05/2009 Minuteman International Inc. 14N845 US ROUTE 20 PINGREE GROVE, IL U.S.A Proper use The machine is a vacuum scrubbing machine for wet cleaning of hardsurfaced floors. Using the machine beyond this scope of application will be deemed improper use; The manufacturer cannot be held liable for consequential damages; the user alone bears the risk. The term of proper use also includes operation, maintenance and repair work to be performed in compliance with the manufacturer s specifications. The E 24 may only be used by persons that are familiar with the machine and aware of possible hazards involved. If modifications to the machine are made in absence of the manufacturer s prior consent, the latter cannot be held liable for damage resulting from such unauthorized modification. Notes on warranty The terms of the sales contract apply. Damages are not subject to warranty if they are due to non-compliance with the maintenance and service provisions. The maintenance work has to be performed by an authorized Minuteman service center. The following is excluded from warranty: fuses, natural wear, damages caused by overload, inexpert handling and unauthorized modification of the machine. Moreover, any claim for warranty cannot be accepted if damages of the machine are caused by fitting parts or accessories without Minuteman s prior and explicit consent or by noncompliance with the maintenance instructions.

3 For Safety When Servicing or Maintaining Machine Stop on level surface. Disconnect the power to the machine. Avoid moving parts. Do not wear loose jackets, shirts, or sleeves when working on machine. When working aroound machine use protective clothing and safety glasses. Remove metal jewelry. Do not clean machine with a pressure washer. Authorized personnel must perform repairs and maintenance. Use Minuteman supplied replacement parts.

4 Table of Contents CHASSIS, CPL. PART LIFTING PEDAL... 3 BRUSH PRESSURE ADJUSTMENT... 4 CHASSIS, CPL. PART MOTOR AMER MRP-9-D... 7 CHASSIS, CPL. PART WATER SUPPLY WATER SUPPLY SQUEEGEE MECHANISM PART SQUEEGEE MECHANISM PART HOPPER PART HOPPER PART SQUEEGEE OPERATION SUCTION...18 SQUEEGEE LOCK SQUEEGEE 95cm PART SQUEEGEE 95cm PART OPERATION HANDLE CONSOLE ELECTRIC PART RETAINER ELECTRIC PART BATTERY TRAY BATTERY CHARGER 30A TOOL HOLDER LABELING...33 WARRANTY... 34

5 CHASSIS PART 1 Page 1

6 CHASSIS PART 1 CHASSIS PART 1 Item Part Number Description Qty. Notes Grommet Chassis Lens flange screw Washer Nut Washer Hexagon screw Countersunk screw Bushing Lifting pedal Washer Brush pressure adjustment Hexagon bolt Bushing Sheet metal Washer Hexagon nut Hexagon bolt Washer Retainer Micro switch Thread base plate Cable clip Hexagon screw Sheet metal Hexagon bolt Retainer 1 Page 2

7 LIFTING PEDAL LIFTING PEDAL Lifting pedal Washer Rod Cotter pin Hexagon nut Fork yoke Bolt Washer Decal 1 Page 3

8 BRUSH PRESSURE ADJUSTMENT BRUSH PRESSURE ADJUSTMENT Item Part Number Description Qty. Notes Pedal Bolt Fork yoke Hexagon nut Eye bolt Tension spring Hexagon screw Washer Sheet metal Hexagon nut Decal Brush Pressure Washer Decal 1 Page 4

9 CHASSIS PART 2 Page 5

10 CHASSIS PART 2 CHASSIS PART Bearing Amer Washer Hexagon screw Block Hexagon Bolt Hexagon Bolt Washer Hexagon screw Lever Hub Wheel Motor Amer MRP-9-D Block Hexagon screw 8 Tightening torque: 38 Nm protection cap Hexagon nut Washer Washer 4 Page 6

11 MOTOR AMER MRP-9-D MOTOR AMER MRP-9-D Washer Gasket Fitting key Gear box with shaft Motor Covering Carbon brush Bushing Nut 4 10 REF ONLY Brake Flange 2 Not Stocked Parking brake Washer Screw Spring pin Stud screw Mounting clip Micro switch 1 Page 7

12 CHASSIS PART 3 Page 8

13 CHASSIS PART 3 CHASSIS PART Water supply Washer Hexagon screw Lens flange screw Bushing Hexagon nut Hexagon screw Washer Retainer Washer Hexagon screw Bushing Sheet metal Pump Case Plastic cover Plastic cover Tab Washer Water supply Hexagon nut Lens flange screw Floating Caster Tension spring Eye bolt Hexagon nut Pivot Squeegee Mechanism Socket head screw Linkage 1 with B 70, B70 CL,B70 CLH, B650/07, MMAN E 26, Phoenix Linkage 1 with B 90, B120, MMAN E28, 30, 33, 33XL, Phoenix Linkage 1 with B90 CL, CLH, Phoenix 28, 30 Page 9

14 WATER SUPPLY WATER SUPPLY Water filter Filter cartridge 1 with o-ring Screw cap Hose clamp PVC hose 300mm Sheet metal Washer Hex. Nut PVC hose 480mm Screwing Sealing band 1 Page 10

15 WATER SUPPLY WATER SUPPLY Screwed angle fitting Hose clamp PVC hose Electrovalve Angle socket PVC hose Hexagon Bolt Washer Retainer 1 used in production prior to March Sealing band Retainer 1 replaced #9, March 2007 Page 11

16 SQUEEGEE MECHANISM PART SQUEEGEE MECHANISM PART Cup head square neck bolt Sheet metal Slide bearing bushing Bushing Slide bearing bushing Shaft Washer Round part Threaded bolt Sheet metal Washer Hexagon nut Hexagon Bolt Slide bearing bushing Edge protection 60mm Excentric 2 Page 12

17 SQUEEGEE MECHANISM PART SQUEEGEE MECHANISM PART Hexagon nut Washer Slide bearing bushing Threaded bolt Draft link Sheet metal Hexagon nut Washer Hose support Hexagon screw 1 Page 13

18 HOPPER PART 1 Page 14

19 HOPPER PART 1 HOPPER PART Fresh water cap Hinge Washer Hexagon screw Lens flange screw Hose support Hose Clamp Angle socket O-ring oil resistant Fresh water tank Foul water hose Hook Hose clamp Edge protection 710mm O-Ring Fillister-head screw Cover Decal Foul Water 1 Page 15

20 HOPPER PART 2 HOPPER PART Cover Cylinder head screw Washer Sealing profile Screw Filter unit Dirt container 1 not stocked, production part number Washer Hexagon screw Suction hose Hose support Lens flange screw 2 Page 16

21 SQUEEGEE OPERATION SQUEEGEE OPERATION Handle Lever Hexagon nut Washer Plain bearing bush Support plate Shaft with cam Thread base plate Micro switch Washer Hexagon bolt Lifting suction unit Lens flange screw 4 Page 17

22 SUCTION Page 18

23 SUCTION SUCTION Insulation mat Hose Hose clamp Connection Hexagon nut Washer Suction motor Carbon brush Buffer Hexagon screw Insulation mat Insulation mat Sheet metal Cable tie Cable tie Washer Hexagon screw Hexagon screw Cover Insulation mat 1 Page 19

24 SQUEEGEE LOCK SQUEEGEE LOCK E-Ring Plain bearing bushing Folding plate Cylinder compression spring Pin 1 Page 20

25 SQUEEGEE 95cm PART 1 SQUEEGEE 95cm PART Rear tension band Sealing strip Suction unit Slot strip Front tension band Bushing Eye bolt Hexagon Nut Lever Hexagon screw Hexagon Nut Pressure piece Front tension band Rear tension band Lock suction unit Lock 1 Page 21

26 SQUEEGEE 95cm PART 2 SQUEEGEE 95cm PART Hexagon screw Washer Pipe Deflector roller Hexagon bolt Washer Fixed castor Fixed castor Distance piece Distance piece Hose 250mm Bracket Washer Star handle Spacer 10 Page 22

27 OPERATION HANDLE OPERATION HANDLE Console Lens flange screw Sheet metal Washer Self tapping screw Round head screw Sliding bock Drive sensor Star handle Lens flange screw Handle bar 1 Page 23

28 CONSOLE CONSOLE Console B70/B Ribbon cable Screw Console Cable key switch Key switch Set (2pc.) key 1 Page 24

29 ELECTRIC PART 1 ELECTRIC PART Lens flange screw Sheet metal Edge protection 60mm Retainer Washer Hexagon nut Cable sleeve Sheet metal Lens flange screw Clamp Clamping plate Bushing Washer Hexagon screw Covering 1 Page 25

30 RETAINER Page 26

31 RETAINER RETAINER Cable tie Cable tie Webbing Washer Hexagon screw Retainer Edge protection 120mm Hexagon nut Washer Hexagon bolt Solenoid Lens cap Cable sleeve Washer Lens cap Hexagon nut Washer Controller B70 CL Strip fuse Strip fuse Fuse Fuse Edge protection 30mm Cap Fuse 1 Page 27

32 ELECTRIC PART 2 Page 28

33 ELECTRIC PART 2 ELECTRIC PART Covering Lens flange screw Sheet metal Bag Washer Blind rivet Wiring harness W Wiring harness Wiring harness W Wiring harness W Wiring harness W Set of cables Set of cables battery Sheet metal Washer Hexagon nut Hexagon bolt Cable tie Cable tie Sheet metal 1 Page 29

34 BATTERY TRAY BATTERY TRAY Block battery Sheet metal Hexagon nut Washer Retainer 1 Page 30

35 BATTERY CHARGER 30A BATTERY CHARGER 30A On-board charger Power cable Covering Tension band Cable tie Wire harness W Wiring harness W Hose Cable tie 1 Page 31

36 TOOL HOLDER TOOL HOLDER Hexagon nut Washer Mounting Luggage rack Sheet metal 1 not stocked, production part number Hose support Washer Hexagon nut Sheet metal 2 not stocked, production part number Hexagon screw Retainer PVC hose 330mm Page 32

37 LABELING LABELING Decal HACOMATIC B70 CLH 1 not stocked, production part number Decal HAKO silver Decal 1 Page 33

38 Minuteman International Made Simple Commercial Limited Warranty REVISION E EFFECTIVE 1/1/2009 Minuteman International, Inc. warrants to the original purchaser/user that the product is free from defects in workmanship and materials under normal use. Minuteman will, at its option, repair or replace without charge, parts that fail under normal use and service when operated and maintained in accordance with the applicable operation and instruction manuals. All warranty claims must be submitted through and approved by factory authorized repair stations. This warranty does not apply to normal wear, or to items whose life is dependent on their use and care, such as belts, cords, switches, hoses, rubber parts, electrical motor components or adjustments. Parts manufactured by Minuteman are covered by and subject to the warranties and/or guarantees of their manufacturers. Please contact Minuteman for procedures in warranty claims against these manufacturers. Special warning to purchaser -- Use of replacement filters and/or prefilters not manufactured by Minuteman or its designated licensees, will void all warranties expressed or implied. A potential health hazard exists without original equipment replacement. All warranted items become the sole property of Minuteman or its original manufacturer, whichever the case may be. Minuteman disclaims any implied warranty, including the warranty of merchantability and the warranty of fitness for a particular purpose. Minuteman assumes no responsibility for any special, incidental or consequential damages. This limited warranty is applicable only in the U.S.A. and Canada, and is extended only to the original user/purchaser of this product. Customers outside the U.S.A. and Canada should contact their local distributor for export warranty policies. Minuteman is not responsible for costs or repairs performed by persons other than those specifically authorized by Minuteman. This warranty does not apply to damage from transportation, alterations by unauthorized persons, misuse or abuse of the equipment, use of non-compatible chemicals, or damage to property, or loss of income due to malfunctions of the product. If a difficulty develops with this machine, you should contact the dealer from whom it was purchased. This warranty gives you specific legal rights, and you may have other rights which vary from state to state. Some states do not allow the exclusion or limitation of special, incidental or consequential damages, or limitations on how long an implied warranty lasts, so the above exclusions and limitations may not apply to you. Cord Electric Group. Three years parts, two years labor, ninety days travel (Not to exceed two hours) Exceptions. Port-A-Scrub, one year parts, six months labor MPV 13, one year parts V Series Upright Vacuums, One year parts, one year labor MPV 14 and 18, two years parts, one year labor RapidAir blower, one year parts, one year labor Explosion-Proof Vacuum, one year parts, one year labor X12 and X12H, one year parts, one year labor TRS 14, one year parts, one year labor E17/E20 electric scrubbers, one year parts, six months labor Battery Operated Group.. Three years parts, two years labor, ninety days travel (Not to exceed two hours) Exceptions Sweepers, one year parts, one year labor, ninety days travel (Not to exceed two hours) Internal Combustion Group.One year parts, one year labor, ninety day travel (Not to exceed two hours) Exceptions..Mirage propane burnisher, one year parts, one year labor Battery Chargers...One year replacement Replacement Parts..Ninety days Batteries.0-3 months replacement, 4-12 months pro-rate Polypropylene Plastic Tanks Ten years, no additional labor 14N845 U.S. Route 20 Pingree grove, IL Phone: Rev * 05/09