GA2K Socket (a) GA2A Bulb (a) Cover, Lamp (a) GA2K

Transcription

1 3 Lens (a) w/keyless Entry w/o Keyless Entry L GA2K-51-39XB R/L R GA2K-51-3F1A L GA2K-51-3G1A 4 Gasket (a) R/L GA2K (a) Included w/lens & Body Assy 5 Socket R GA2K L GA2K Bulb Stop/Tail R/L Back-Up R/L Included w/lamp Assy LICENSE LAMP 1 Lamp Assy, License R/L 8BG Lens R/L GA2K A 3 Gasket R/L GA2K Bulb R/L Included w/license Lamp Assy SIDE MARKER LAMP 1 Lamp Assy, Side Marker R GA2A-51-5H0B L GA2A-51-5J0C 2 Lens & Body R GA2A-51-5H1B L GA2A-51-5J1B 3 Socket & Wire R/L GA2A-51-5H2A 4 Bulb R/L Included w/side Marker Lamp Assy HIGH MOUNT STOP LAMP GA2K Taupe GA2K Socket (a) GA2A Bulb (a) Cover, Lamp (a) GA2K GA2K Taupe GA2K (a) Included w/high Mount Stop Lamp Assy 6 Bracket, Lamp GJ REAR BUMPER 1 Cover, Rear (P) Single Tone GAY XA-00 2 Tone GAY XA-00 (P) Paint to Match 2 Fastener, Cover (2/Side) R/L BF Plate, Cover Outer R GA2K-50-2B0A L GA2K-50-2C0A 4 Plate Assy, Cover Center GA2K-50-2AXC 5 Fastener, Plate B A 6 Nut (5) GJ Included w/cover Center Plate Assy 7 Grommet, Plate (5) To HG From C Shield, Splash R GA2K-50-2S1B L GA2K-50-2S5B 9 Nut, Spring (2/Side) R/L FB Retainer, Cover R GA2K-50-3J1A L GA2K-50-3J5A 11 Bracket, Side R/L GA2K-50-3D0 12 Clip, Side (2/Side) R/L GJ Grommet, Side (2/Side) R/L KA78-50-AF4 14 Grommet, Upper R/L GA2A-50-0Z5 15 Absorber, Impact GA2K-50-31XA 16 Bar, Reinforcement GA2K Gasket, Seal (2/Side) R/L G MAZDA MAZDA SECTION INDEX A/C /HEATER/VENTILATION A/C REFRIGERANT CAPACITIES ABS/BRAKES AIR BAG SYSTEM AIR CLEANER BACK WINDOW CENTER CONSOLE CLEAR COAT IDENTIFICATION COOLING COWL & DASH CRUISE CONTROL SYSTEM ELECTRICAL EMISSION SYSTEM ENGINE UNDER COVER ENGINE/TRANS ENGINE/TRANS MOUNTS EXHAUST FRONT BUMPER FRONT DOOR FRONT DRIVE AXLE FRONT FENDER FRONT INNER STRUCTURE FRONT LAMPS FRONT SEAT FRONT STEERING LINKAGE/GEAR FRONT SUSPENSION FUEL TANK GRILLE HOOD INFORMATION LABELS INSTRUMENT PANEL LUGGAGE LID PAINT CODE LOCATION QUARTER PANEL REAR BODY REAR BUMPER REAR DOOR REAR LAMPS REAR SEAT REAR SUSPENSION ROCKER/PILLARS/FLOOR ROOF SEAT BELTS SPECIAL CAUTIONS STEERING PUMP STEERING WHEEL/COLUMN SUNROOF UNDERHOOD DIMENSIONS WHEEL WINDSHIELD SPECIAL CAUTIONS SUPPLEMENTAL RESTRAINT SYSTEM Refer to Procedure Explanation 29 for Supplemental Restraint/Air Bag Special Cautions. SUSPENSION advises that some new fasteners must be used whenever old fasteners are loosened or removed. PAINT CODE LOCATION Paint code located on left lock pillar. CLEAR COAT IDENTIFICATION All colors except Glacier White (Code A2N) are clear coat, Laser Red Pearl Metallic (Code NX) is three stage. INFORMATION LABELS 1 Lamp Assy, High Mount Stop GA2K GA2K Taupe GA2K Mounted on Package Tray 2 Lens (a) GA2K Label, Bolt Caution FS A 173 Page 173 April 22, :32:27 Version

2 MAZDA INFORMATION LABELS Cont d FRONT BUMPER KL B 2 Label, A/C Caution GD7A Label, Emission GD7B A w/o Calif Emission GD7A A GD7D w/o Calif Emission GD7C GD7E A GG2B w/o Calif Emission GG2A GGEF w/o Calif Emission GG2E GJ4H GJ4M GJ4J GJ4N Label, Tire Size/Capacity -00 GD7A To GD7A From GD7E GD7E GD7E GG2E Label, Side Air Bag Caution R/L LC62-57-K91 6 Label, Canada Safety 7 Label, Fuel Economy Canada GG2A GG2C To GJ4H From GG4J GJ4J Canada GG2E GG2G GJ4M GJ4P Label, Theft Deterrent w/theft Deterrent FB Label, Pass Air Bag KB39-57-K93 Located in Glove Box 10 Label, Canada Fuel 11 Label, Premium Fuel TA Label, Vehicle Information B D51 VIN Required to Order-Contact Dealer 13 Label, Temporary Spare English GD1E A French GD7A GG2E To GD7A From GD7E GG2E GD7E GG2E Label, Fan Caution-See Cooling Section 1 Cover, Front (P) GD7A C GGYA-50-03XB-00 (P) Paint to Match 2 Grommet, Screw R/L BC1M-50-0Z5 3 Fastener, Upper R/L GD7E-50-EA1 4 Nut, Clip-On (8) B Bracket, Lwr Reinf GD7A A 6 Nut, Clip-On (2) 9YB Bracket, Reinf Mtg GD7A-50-AB1 8 Holder, License Plate GD7A Dam, Front Air w/ KA79-50-AH1C 10 Insert, Air Dam Screw R/L GJ Reinforcement Assy, Bumper GD7A A 12 Bar, Reinf GD7B Plate, Bolt -Serviced w/bumper Reinf Assy 14 Clip, Plate R/L GD7A-50-EB1 Included w/bumper Reinforcement Assy GRILLE 1 Grille Assy GD7A C GG2A B 2 Clip, Grille (4) B Included w/grille Assy 3 Emblem Assy, Mazda -Serviced w/grille Assy GG2A Clip, Emblem (a) (2) LA Included w/grille Assy (a) Included w/mazda Emblem Assy FRONT LAMPS HEADLAMP 1 Headlamp Assy R GD8A A L GD8A A 2 Lens & Reflector Assy R GD8A-51-0K0 L GD8A-51-0L0 3 Clip, Retaining (a) (5/Side) R/L GA2A-51-0A6 4 Filler, Rear (a) L GD7A-51-0A8 5 Tube, Vent (a) (2/Side) R/L GD7A-51-0K8 (a) Included w/lens & Reflector Assy 6 Housing Assy, Inner Mounting R GD7A-51-03X L GD7A-51-04X 7 Screw, Adjust (b) R/L GA2A Adjuster, Headlamp (b) R HF F2 L HF E2 (b) Included w/inner Mounting Housing Assy 9 Bushing, Lamp Mtg R GA2C-51-0K3 L GA2C-51-0L3 10 Bushing, Adjust Screw R/L GG2A-51-0K3 11 Bushing, Adjusting R/L GA2A-51-0K3A 12 Bulb, Headlamp 60/55 Watt R/L Retainer, Bulb R/L D B1 Included w/headlamp Assy 14 Fastener, Lamp R/L GD7A Hsg, Otr Mtg R GD7A-51-0AXA L GD7A-51-0BXA HEADLAMP 1 Lens & Reflector Assy R GG2A-51-0K0B L GG2A-51-0L0B 2 Clip, Retaining (5/Side) R/L GA2A-51-0A6 3 Filler, Rear L GD7A-51-0A8 4 Tube, Vent (2/Side) R/L GD7A-51-0K8 Included w/lens & Reflector Assy 5 Housing Assy, Inner Mounting R GD7A-51-03X L GD7A-51-04X 6 Screw, Adjust R/L GA2A Adjuster, Headlamp R HF F2 L HF E2 Included w/inner Mounting Housing Assy 8 Bushing, Lamp Mtg R GA2C-51-0K3 L GA2C-51-0L3 9 Bushing, Adjust Screw R/L GG2A-51-0K3 10 Bushing, Adjusting R/L GA2A-51-0K3A 11 Bulb, Headlamp 60/55 Watt R/L Retainer, Bulb R/L D B1 13 Fastener, Lamp R/L GD7A Hsg, Otr Mtg R GG2A-51-0AX L GG2A-51-0BX SIGNAL/MARKER LAMP 1 Lamp Assy, Signal/Marker R GD7A C L GD7A C R GG2A B 174 Labor Times Shown are for Replacement with New OEM Undamaged Parts on New Undamaged Vehicles. Page 174 April 22, :32:29 Version

3 L GG2A B 2 Lens & Housing R GD7A-51-06XB L GD7A-51-07XB R GG2A-51-06XB L GG2A-51-07XB 3 Bulb (27/8 Watt) R/L NA 4 Socket, Bulb R/L GA2A Included w/signal/marker Lamp Assy 5 Retainer, Lamp R/L G A HOOD 1 Hood GD7A C 2 Hinge, Hood R GD7B A L GD7B A 3 Insulator, Hood GD7A Fastener, Insulator (16) GA2A Weatherstrip Assy, Hood GD7A Rivet, W/Strip (14) J Included w/hood Weatherstrip Assy 7 Seal Assy, Front Hood GD7A Rivet, Seal (7) UB A Included w/front Hood Seal Assy 9 Cushion, Side Hood R/L BC1M Latch, Hood GD7A A 11 Fastener, Hood Release LA Cable & Handle, Release GD7A Clip, Cable (2) D Rod Assy, Prop GD7A Bushing, Rod Pivot G Included w/prop Rod Assy 16 Plate, Rod Retainer B01A Holder, Rod GD7A Cushion, Side Body R/L BC1M Weatherstrip Assy, Rear Hood GD7A Retainer, W/Strip (8) H Included w/rear Hood Weatherstrip Assy COOLING 2.0L ENG 1 Radiator Assy FSD FSD A 2 Cap, Radiator KL Mount, Lower Rad R/L FSD R/L FSD A Included w/radiator Assy 4 Brkt, Upper Rad R FSD A L FSD C 5 Tank Assy, Coolant FSD Cap, Coolant Tank FSD Included w/coolant Tank Assy 7 Hose, Coolant Tank FSD Bracket, Coolant Tank FSD Fan Assy, Main Cooling FSD B 10 Shroud, Fan FSD Blade, Fan FSD Motor, Fan FSD Included w/main Cooling Fan Assy 13 Fan Assy, Auxiliary Cooling w/ A/C FSD A 14 Shroud, Fan FSD Blade, Fan KLG Motor, Fan FSD Included w/auxiliary Cooling Fan Assy 17 Hose, Upper Rad FSD Hose, Lower Rad FSD Cover, Thermostat FS Thermostat KL A-9U 21 Housing, Thermostat FS A 22 Pipe, By-Pass FS C 23 Pipe, By-Pass FSM A FS Hose, By-Pass FS A FS Housing, Outlet FSM ZE FSM ZE 26 Gasket, Outlet Housing FS Pump Assy, Water 8AG Flange, Pump Pulley FS A 29 Gasket, Water Pump FS Included w/water Pump Assy 30 Pulley, Water Pump FS L ENG 1 Radiator Assy KLG Mount, Lower Rad R/L KLG Included w/radiator Assy 3 Bracket, Upper Rad R FSD A L FSD C 4 Tank Assy, Coolant KLG C 5 Cap, Coolant Tank KL Included w/coolant Tank Assy 6 Hose, Coolant Tank KLG Bracket, Coolant Tank FSD Hose, Coolant Tank KLR Clip, Hose KLG MAZDA Fan Assy, Main Cooling FSD B 11 Shroud, Fan FSD Blade, Fan FSD Motor, Fan FSD Included w/main Cooling Fan Assy 14 Fan Assy, Auxiliary Cooling w/ A/C KLG A KLG A 15 Shroud, Fan KLG Blade, Fan KLG Motor, Fan KLG KLG Included w/auxiliary Cooling Fan Assy 18 Hose, Upper Rad KLG Hose, Lower Rad KLG Housing Assy, Outlet KLG ZA 21 Cap, Housing KL Included w/outlet Housing Assy 22 Pipe, Coolant KLG A KLG5-19-9F0 23 Cover, Thermostat KL Thermostat KL A-9U 25 Housing, Thermostat KLG A 26 Pipe, Coolant KL B 27 Housing, Inlet K A 28 Hose, By-Pass KL Pipe, By-Pass KL Pump Assy, Water 8AK O-Ring, Water Pump KL Included w/water Pump Assy 32 Pulley, Water Pump KL L ENG 1 Radiator Assy FS1G A FS1H A 2001 To FS1H A From FS1K FS1K Cap, Radiator KL Mount, Lower Rad R/L KLG R/L FS1H Included w/radiator Assy 4 Brkt, Upper Rad R FSD A L FSD C 5 Tank Assy, Coolant FSD Cap, Coolant Tank FSD Included w/coolant Tank Assy 7 Hose, Coolant Tank FSD Bracket, Coolant Tank FSD Fan Assy, Cooling w/ A/C FS1G B w/o A/C FS1J B 10 Shroud, Fan FS1G Label, Fan Caution B A 2001 To B A From FS1G FS1G Blade, Fan R FS1H Page 175 April 22, :32:30 Version

4 MAZDA COOLING Cont d 2.0L ENG Cont d L FS1G Motor, Fan R/L FS1G Nut, Fan R/L FS1G Included w/cooling Fan Assy 15 Hose, Upper Rad FSD Hose, Lower Rad FSD Cover, Thermostat FS Thermostat KL A-9U 19 Housing, Thermostat FS A 20 Pipe, By-Pass FSM B 21 Pipe, By-Pass FS A 22 Hose, By-Pass FS A 23 Housing, Outlet FSM ZE 24 Gasket, Outlet Housing FS Pump Assy, Water 8AG Flange, Pump Pulley FS A 27 Gasket, Water Pump FS Included w/water Pump Assy 28 Pulley, Water Pump FS L ENG 1 Radiator Assy KLR A 2 Mount, Lower Rad R/L KLR Included w/radiator Assy 3 Bracket, Upper Rad R FSD A L FSD C 4 Tank Assy, Coolant KLG C 5 Cap, Coolant Tank KL Included w/coolant Tank Assy 6 Hose, Coolant Tank KLG Bracket, Coolant Tank FSD Hose, Coolant Tank KLR Clip, Hose K Fan Assy, Cooling w/ A/C KLR B w/o A/C KLS B 11 Shroud, Fan KLR Blade, Fan R FS1G L FS1H Motor, Fan R KLR L FS1G Nut, Fan R/L FS1G-15-T59 15 Label, Fan Caution B A 2001 To B A From FS1G FS1G Included w/cooling Fan Assy 16 Hose, Upper Rad KLG Hose, Lower Rad KLG Housing Assy, Outlet KLG ZA 19 Cap, Housing KL A Included w/outlet Housing Assy 20 Pipe, Coolant KLG A 21 Cover, Thermostat KL Thermostat KL A-9U 23 Housing, Thermostat KLG A 24 Pipe, Coolant KL B 25 Housing, Inlet K A 26 Hose, By-Pass KL Pipe, By-Pass KL Pump Assy, Water 8AK O-Ring, Water Pump KL Included w/water Pump Assy 30 Pulley, Water Pump KL A/C REFRIGERANT CAPACITIES A/C R-134a Refrigerant Capacity -02: 27 Ozs (1.69 Lbs) A/C /HEATER/VENTILATION 1 Condenser GD7A B 2 Bracket, Condenser R/L GD7A Pipe, Compressor GD7A Pipe, Frt Evap GD7A-61-46X 5 Pipe, Center Evap GD7A-61-46Z GG2A-61-46Z GD7A-61-46Z 6 Tube, Orifice GD7A-61-4G9 7 Pipe, Rear Evap GD7A-61-46Z GG2A-61-46Z GD7A-61-46Z 8 Hose, High Pressure GD7A GD7E Hose, Low Pressure GD7A GD7E Bracket, Hose Mount GD7A A 11 Insulator, Bracket UB A 12 Pipe, Low Pressure GD7A A GD7E Receiver/Drier GD7A-61-5A0 14 Compressor Assy GD7A GD7E Compressor -Serviced w/compressor Assy 16 Clutch, Compressor GD7A-61-L10 GD7E-61-L10 Included w/compressor Assy 17 Relay, A/C GD7B Harness, Compressor GD7A Evaporator Assy GD7A D 20 Housing, Upr Evap GD7A-61-J01 21 Housing, Lwr Evap GD7A-61-J02 22 Core, Evap GD7A-61-J10B To GD7A-61-J10B From GD7A-61-J10B GD7A-61-J10B 23 Seal, Blower GA2A-61-J04 24 Seal, Heater GA2A-61-J05 25 Seal, Outer Pipe BJ0E-61-J12B 26 Seal, Inner Pipe GD7A-61-J12 27 Spacer, Pipe GD7A-61-J03 28 Seal, Outer Drain BC1M-61-J06B 29 Seal, Inner Drain GD7A-61-J06 Included w/evaporator Assy 30 Relay, Transfer KC Heater Assy w/rear Heater Ducts GD7A C w/o Rear Heater Ducts GD7C C 32 Housing, Front Heater GD7A-61-A02 33 Housing, Rear Heater GD7A-61-A01 34 Core, Heater GD7A-61-A10 35 Damper, Heater GD7A-61-A1Y 36 Link Set, Temp GD7A-61-A20 37 Actuator, Temp GD7A-61-A60 38 Housing, Right Distribution w/rear Heater Ducts GD7A-61-A04 w/o Rear Heater Ducts GD7C-61-A04 39 Housing, Left Distribution w/rear Heater Ducts GD7A-61-A03 w/o Rear Heater Ducts GD7C-61-A03 40 Damper, Distribution GD7A-61-A1X 41 Link Set, Mode GD7A-61-A30 42 Actuator, Mode GD7A-61-A70 43 Seal, Defroster GD7A-61-A11 44 Seal, Duct GD7A-61-A12 Included w/heater Assy 45 Hose, No. 1 Heater GA2A C GD7E Hose, No. 2 Heater GA2A A GD7E Duct, Air Outlet GA2A Duct, Rear Heater w/rear Heater Ducts GA2K A 49 Pin, Duct Retaining (2) B 50 Duct, Rear Heater R GA2A L GA2A Rivet, Rear Heater Duct R/L G Duct, Blower/Heater w/o A/C GA2A A 53 Pin, Duct Retaining (3) Bracket, Hose GD7A-61-47XA 55 Bracket, Blower GA2B-61-1E0 56 Control Assy, Heater -00 w/ A/C GG2A A w/o A/C GD7B E w/ A/C GG2A A w/o A/C GD7B G 57 Switch, Fan GD7A-61-C50 58 Bulb (3) GA2A-61-C95 Included w/heater Control Assy 59 Blower Assy GD7A A 60 Housing, Upr Blower GD7A-61-B01 61 Housing, Lwr Blower GD7A-61-B02 62 Seal, Intake GD7A-61-B04 63 Door, Blower GD7A-61-B05 64 Link Set, Fresh/Recycle GD7A-61-B20 65 Actuator, Fresh/Recycle GD7A-61-B60 66 Cover, Inner Blower GD7A-61-B Labor Times Shown are for Replacement with New OEM Undamaged Parts on New Undamaged Vehicles. Page 176 April 22, :32:32 Version

5 UNDERHOOD DIMENSIONS MAZDA Blower Unit GD7A-61-B10 68 Resistor, Blower GD7A-61-B15A 69 Harness, Blower GD7A-61-B16 Included w/blower Assy FRONT FENDER FRONT INNER STRUCTURE FRONT 8 Frame Assy, Outer Side (b) R GD7A L GD7A Reinf, Frt Bumper (b) (c) R GA2A L GA2A A (c) Included w/outer Side Frame Assy 10 Bracket, Bumper (b) R/L GA2A A 11 Frame, Rear (b) R GD7A L GD7A Included w/apron Assy (b) Included w/side Frame Assy 12 Cover Assy, Right Engine-See Engine Under Cover Section 13 Cover, Left Engine-See Engine Under Cover Section ELECTRICAL COMPONENTS 1 Fender R GD7A B L GD7A B 2 Liner, Fender R GD7A C L GD7A C 3 Clip, Front Liner (2/Side) R/L BC1D Clip, Center/Rear Liner (13/Side) R/L NA Tape, Frt Fender Seal R/L GA2A Stay, Fender R/L GD7A Insert, Nut R/L Plate, Rear Fender Seal R GD7A L GD7A Retainer, Plate (2/Side) R/L GA2A A 10 Mud Flap Assy, Front R GD7A C L GD7A C 11 Insert, Nut R/L Screw, Tapping R/L 9CN B Included w/front Mud Flap Assy 13 Rivet, Mud Flap R/L B Retainer, Screw R/L B01A Moulding, Side (Adhesive) Chestnut (Code 19X) Dark Green Satin (Code 25J) Dark Tourmaline (Code 11J) Ebony (Code NN) Frost Silver (Code 11M) Laser Red (Code NX) Lichen Green (Code 11H) Light Parchment Gold Code 21C Medium Wedgewood Blue Code 21S New Sahara Gold (Code 11F) New Warm (Code 21R) Perf White Code A2N Sandalwood (Code 11B) R GG2A A-98 L GG2A A-00 R GG2A A-00 L GG2A A-57 R GG2A A-19 L GG2A A-19 R GG2A A-NN L GG2A A-00 R GG2A A-00 L GG2A A-00 R GG2A A-NX L GG2A A-NX R GG2A A-23 L GG2A A R GG2A A-00 L GG2A A R GG2A A-25 L GG2A A-00 R GG2A A-81 L GG2A A-00 R GG2A A-00 L GG2A A-64 R GG2A A-00 L GG2A A-00 R GG2A A-UK L GG2A A-00 R GG2A A-00 L GG2A A-00 1 Support Assy, Radiator GD7A C 2 Bar, Upper Tie GD7A Panel, Shroud R GD7A A L GD7A B 4 Bar, Lower Tie GA2A-53-16XH 5 Bracket, Tie Bar R GA2A-53-16YE L GA2A-54-16YC Included w/radiator Support Assy 6 Brkt, Bumper/Shroud R GD7A-53-12YA L GD7A-54-12YA 7 Hook, Tie-Down R GA2C-53-36X L GA2C-54-36X 8 Plate, Seal R GD7A L GD7A A 9 Retainer, Plate (2/Side) R/L Stay, Hood Latch GD7B-52-15Y 11 Cover, Upper Tie Bar GD7A A 12 Clip, Cover (4) GA5R SIDE 1 Apron Assy R GDYB-53-20Y L GDYB-54-20Y 00 R GDYB-53-20Y L GDYB-54-20Y R GDYB-53-20Y L GDYB-54-20Y 2 Panel Assy, Apron R GDYB-53-21Y L GDYB-54-21Y R GDYB-53-21Y L GDYB-54-21Y 3 Panel, Front Apron (a) R GD7A B L GDYA-54-22Y 4 Panel, Rear Apron (a) R GA2A D L GA2A D 5 Reinf, Upr Frt (a) R GD7A L GD7A Reinf, Apron (a) R GDYA-53-26Z L GD7A-54-26X (a) Included w/apron Panel Assy 7 Frame Assy, Side R GD7A B L GD7A F 1 Fuse/Relay Assy, Harness USA w/traction Control w/o Traction Control GD7B E GD7A E GG2F D GG2B D GG2A D GD7F E To w/traction Control w/o Traction Control From w/traction Control w/o Traction Control To From w/traction Control w/o Traction Control 1999 w/traction Control w/o Traction Control GD7F E GD7B E GG8E A GG8B A GD7A E GG8A A GG8E A GG8B A GG8E A GG8A A 177 Page 177 April 22, :32:34 Version

6 MAZDA FRONT INNER STRUCTURE Cont d ELECTRICAL COMPONENTS Cont d w/traction Control GG2F D w/o Traction Control GG2B D GG2A D Canada w/traction Control w/o Traction Control 1999 w/traction Control w/o Traction Control w/traction Control w/o Traction Control 2 Block Assy, Main Fuse GD7A GG2A GJ4H Cover, Upper (a) GD7A GG2A GJ4H Cover, Lower (a) GD7A (a) Included w/main Fuse Block Assy 5 Fuse, 40A (3) GD7B-67-S99 6 Fuse, 30A (4) GD7A-67-S99 7 Fuse, 100A FC Fuse, 10A GD7A-67-M20 9 Fuse, 15A (4) GD7A-67-M15 10 Relay, Circuit KLG Relay, Main KLG Included w/harness Fuse/Relay Assy 12 Relay, Horn-See Electrical Section 13 Relay, Headlamp GD7B Relay, Small Lamp GD7B Fuse, 20A (2) GD7A-67-M20 16 Fuse, 60A GD7C-67-S99 17 Bracket, Fuse Block GD7A-67-B1X 18 Bracket, Harness GD7A-67-B1ZA 19 Bracket, Relay GD7A-67-9B1A 20 Relay, Rear Defogger KC Relay, Cooling Fan KC Relay, Additional Fan KC Bracket, Relay GD7A-67-9C1A 24 Relay, Blower Motor KC ABS/BRAKES GD7B A GG2B GD7D GG2D GD7A GG2A GD7C GG2D Booster, Brake GD7A GG2A A CRUISE CONTROL SYSTEM 1 Actuator Assy, Cruise GD7B C 2 Grommet, Actuator KB A4 Included w/cruise Actuator Assy 3 Cable Assy, Cruise GD7B-66-31YC GD7E-66-31YA 4 Cable, Cruise -Serviced w/cruise Cable Assy 5 Clip, Cable BW0G-66-3A7 Included w/cruise Cable Assy 6 Clip, Retaining w/ AS AIR BAG SYSTEM GD7A-57-K70H-90 GD7A-57-K70H-29 GD7D-57-K70A-90 GD7D-57-K70A-29 7 Spring, Locating (4) H Included w/passenger Air Bag Module Assy 8 Bolt, Driver Air Bag (4) B 9 Bolt, Pass Air Bag (4) Clip, Pass Air Bag (2) B C10 SIDE 1 Module, Side Air Bag R GG2A-57-KA0B L GG2A-57-KB0B 2 Sensor, Side Air Bag R GG2A-57-KC0 L GG2A-57-KD0 3 Bracket, Sensor R GG2A-57-KX0 L GG2B-57-KX0 WHEEL STEEL WHEEL FRONT Wheel, Steel G D Cover, Wheel 3 GD7A A 4 GD7E Stem, Valve Nut, Lug A 7 B A ALLOY WHEEL 1 Actuator, Hydraulic GDYG-43-7T0B w/traction Control GDYG-43-7T0B w/o Traction Control GDYE-43-7A0C 2 Control Unit, ABS w/traction Control GD7E-67-6E0B w/o Traction Control GD7E B -Serviced w/hydraulic Actuator 3 Bracket, Actuator/Control GD7E Sensor, Front ABS R GD7E-43-70XD L GD7E-43-73XD 5 Sensor, Rear ABS R GD7E-43-71YD L GD7E-43-72YD 6 Rotor, Front ABS Sensor R/L GA2G A 7 Rotor, Rear ABS Sensor R/L GA2G Cylinder, Brake Master 1 Control Unit, Diagnosis GD7A-57-K30C GG2A-57-K30B 2 Bracket, Control Unit GD7A-57-KX0C 3 Nut, Unit/Brkt (5) B 4 Module, Driver Air Bag To GD7A-57-K00G From GD7D-57-K GD7D-57-K00 GG2A-57-K00B-90 GG2A-57-K00B-29 5 Clockspring GD7A-66-CS0C 6 Module Assy, Passenger Air Bag Wheel, Alloy 1 15x6" 9965-D x6" Cap, Hub GD7F A 4 Stem, Valve Labor Times Shown are for Replacement with New OEM Undamaged Parts on New Undamaged Vehicles. Page 178 April 22, :32:35 Version

7 5 Nut, Lug B A SPARE WHEEL & HARDWARE MAZDA GE4T-34-H90C GE6T-34-H90C GG2A-34-H90B GG2C-34-H90B FRONT DRIVE AXLE 1 Wheel, Spare Type Type Bolt, Spare Wheel T Clamp, Spare Wheel GA5R C 4 Jack GD7A A 5 Bolt, Jack B C 6 Tool Assy Steel Wheels GD7A A Alloy Wheels GD7B A 7 Wrench, Hub GD7A A 8 Bolt, Wheel Alloy Wheels GD7A Included w/tool Assy FRONT SUSPENSION 1 Rotor, Brake R/L GA2Y-33-25XA R/L GD7Y-33-25XA 2 Hub Assy R/L GD7A A 3 Stud, Wheel (5/Side) R/L J00Y Included w/hub Assy 4 Nut, Axle R/L GJ B 5 Plate, Backing R GA2A L GA2A Bearing, Wheel R/L GA2A D-MV 02 R/L GA2A D-MV 7 Ring, Snap R/L GE4T Knuckle, Steering R GG2A A L GG2A A 9 Seal, Oil R/L GA2A Rotor, Frt ABS Sensor-See ABS Section 11 Sensor, Front ABS-See ABS/Brakes Section 12 Caliper Assy, Brake R GB6H-33-98ZA L GB6H-33-99ZA R GDYE-33-98ZR L GDYE-33-99ZR 13 Caliper, Brake R GA2A-33-61XA L GA2A-33-71XA R GDYE-33-98ZR L GDYE-33-99ZR 14 Carrier, Caliper R GB6H-33-28X L GB6H-33-29X R GD7E-33-28X L GD7E-33-29X Included w/brake Caliper Assy 15 Pad Set, Brake GGYA-33-23ZC GGYE-33-23ZC 16 Attachment, Pad (a) GAYA-33-29Z -Serviced w/brake Pad Set 17 Pad, Brake GGYE-33-23ZC Included w/brake Pad Set 18 Hose, Brake R/L B B 19 Strut R GD7A B L GD7A B R GG2A L GG2A Order by Application 20 Seat, Lower Rubber R/L GD7A-34-0A3 21 Spring, Coil R/L GD7B B R/L GD7A B R/L GD7C B R/L GD7B B R/L GD7C B R/L GD7D B R/L GD7A B Order by Application 22 Bumper, Rebound R/L GD7A B R/L GE4V Cover, Lever R/L GD1E Seat, Upper Rubber R/L GA2A Seat, Upper R/L GA2A Bushing, Mtg Rubber R/L GD7A-34-38X 27 Plate, Strut Brg R/L GD7A R/L GG2A Gasket, Mount R/L GA2A Stiffener, Gasket R/L GG2A A 30 Arm Assy, Lower Control R GD7A B L GD7A B R GG2A C L GG2A C 31 Bushing, Front Arm R/L GD7B Boot, Ball Joint R/L G Included w/lower Control Arm Assy 33 Bushing, Rear Arm R GD7A-34-46X L GD7A-34-46Y 34 Damper, Frt Dynamic R/L GE4T Bolt, Arm R/L 9YA A 36 Bushing, Arm R/L GA2A A 37 Nut, Flange R/L B B 38 Washer, Rear Arm R/L Nut, Rear Arm R/L Link, Control Arm R GD1E L GD1E Nut, Link (2/Side) R/L Bar, Stabilizer KA GG2A Bushing, Stabilizer R/L GE4T Brkt, Stab R/L GD7B R/L GE4T A 45 Crossmember, Susp GD7A B GG2A A 46 Member, Transverse 1 Shaft Assy, Axle 2 Joint Assy, Outer Shaft R G R-0A L G R-0A R GG XR-00 L GG XR-00 R G R-0C L G R-0C R G R-00 L G R-00 R/L G A R GG L GG Boot Kit, Outer (a) (a) Included w/outer Shaft Joint Assy 4 Joint Assy, Inner R/L G R/L G R/L G R/L G U R/L G R/L G U R G L G R G L GG R G L G Boot Kit, Inner (b) Included w/axle Shaft Assy (b) Included w/inner Joint Assy 6 Shaft Assy, Inner Right R/L G R/L G U R/L G R/L G U G E G A G B G B 7 Seal, Outer F G Bracket, Bearing G A G A G B G B G B 9 Bearing, Ball G Seal, Inner F G Included w/inner Right Shaft Assy 179 Page 179 April 22, :32:37 Version

8 MAZDA FRONT STEERING LINKAGE/GEAR 1 Gear Assy, Steering GG2A R-0A GG2A R-0A GG2A R-0A GG2A R-0A 2 Yoke Set, Support GA2B-32-11XA 3 Nut, Outer Lock (a) GA2B Nut, Inner Lock (a) GB6P (a) -Serviced w/steering Gear Assy 5 Rod, Tie (a) R/L GA2A A R/L GA2A A 6 Boot, Rack (a) R/L GA2B-32-12X 7 Support Kit, Tube (a) GA2B Tube, Pressure (a) R GA2B-32-44Z L GA2B-32-44Y (a) Order by Application 9 Tube, Return GA2B Bushing, Mounting R GA2B L GD7A Bracket, Mounting R GB6P L GA2B R GA2B L GA2B Included w/steering Gear Assy 12 End Assy, Tie Rod R/L 8AG Seal, Dust R/L B Included w/tie Rod End Assy STEERING PUMP 2.0L ENG 14 Hose, Pump Suction GA2A B 15 Hose, Pump Pressure GD7A A 16 Bolt, Banjo Hose, Rack Pressure GB6H B 18 Hose, Rack Return KA B 19 Pipe Assy, Return 88 KA B GD7A Bracket, Return Pipe KA A Included w/return Pipe Assy 21 Hose, Tank Return GD1E A 22 Pipe Assy, Cooler/Return GD7A-32-47X 23 Hose, Cooler Inlet GA2B B 24 Hose, Cooler Outlet GA2B B 25 Bracket, Cooler GA2B A Included w/cooler/return Pipe Assy 26 Tank Assy, Reservoir GA2G-32-69XA 27 Tank Assy GC1M Cap, Tank (a) GA2G Strainer, Tank (a) GA2G Bushing, Tank (a) (2) GA2G (a) Included w/tank Assy 31 Mount, Rubber (2) B Included w/reservoir Tank Assy 2.5L ENG 18 Hose Assy, Suction KA XB 19 Hose, Suction KA B Included w/suction Hose Assy 20 Hose, Pump Suction KA B 21 Hose, Pressure GB6M Bracket, Hose GD7E-32-18X 23 Hose, Return KA A 24 Pipe Assy, Return KA B 25 Clamp, Pipe KA A Included w/return Pipe Assy 26 Cooler Assy, Fluid GD7A-32-47X 27 Hose, Cooler Inlet GA2B B 28 Hose, Cooler Outlet GA2B B 29 Bracket, Cooler GA2B A Included w/fluid Cooler Assy 30 Tank Assy, Reservoir GA2G-32-69XA 31 Tank Assy -Serviced w/reservoir Tank Assy 32 Cap, Tank GA2G Strainer, Tank GA2G Bushing, Tank (2) GA2G Mount, Rubber (2) B Included w/reservoir Tank Assy STEERING WHEEL/COLUMN 1 Pump Assy, Steering GD7A R-0E 2 Pipe, Suction GD7A-32-5M0 3 Sensor, Pressure GE4T Seal Kit, Pump GE4T Shaft Kit, Pump GE4T Included w/steering Pump Assy 6 Pulley, Pump GD7A Bracket, Front Pump GD7A-32-60XA 8 Bracket, Pump GE4T Bolt, Pump Mount GA2B Bracket, Adjusting GE7T-32-61X G14H-32-61X 11 Bolt, Adjusting GA2A Bolt, Locking B B 13 Bracket, Rear Pump GD7A-32-60Y 1 Pump Assy, Steering GD7E R-00 2 Ring, Snap KA Shaft, Pump GA2B Sensor, Pressure GB6H Nipple, Pump GC1M Pipe, Suction GA2G-32-5M0 7 Bracket, Rear GA2E Seal Kit, Pump EA Included w/steering Pump Assy 9 Pulley, Pump GA2F A 10 Pulley & Bracket Assy, Idler K D 11 Pulley Assy, Idler K XA 12 Bearing, Pulley (a) (a) Included w/idler Pulley Assy 13 Collar, Pulley KL Collar, Inner K A 15 Bracket, Idler Pulley EA D 16 Bolt, Adjusting K A 17 Shaft, Pulley KL Included w/idler Pulley & Bracket Assy 1 Wheel Assy, Steering GD7F D GG2D GG2D Urethane w/cruise Control GD7B D w/o Cruise Control GD7A B w/cruise Control GG2B GG2B w/o Cruise Control GG2A GG2A Switch Unit, Cruise GD7A-66-3D1A 3 Cover, Wheel w/cruise Control GG2B GG2B w/o Cruise Control GG2A GG2A Labor Times Shown are for Replacement with New OEM Undamaged Parts on New Undamaged Vehicles. Page 180 April 22, :32:38 Version

9 Included w/steering Wheel Assy 4 Nut, Steering Wheel Module, Driver Air Bag-See Air Bag System Section 6 Clockspring-See Air Bag System Section 7 Switch Assy, Combination GD7A A -Serviced by Components 8 Cam, Cancelling (a)-serviced w/combination Switch Assy 9 Spring, Cam (a)-serviced w/combination Switch Assy 10 Switch, Dimmer (a) GD7A Switch, Wiper (a) GD7A LX, GD8B (a) Included w/combination Switch Assy 12 Harness, Combination Switch w/immobilizer GD7B-67-SH0C w/o Immobilizer 13 Lock Assy, Ignition w/immobilizer w/o Immobilizer 14 Key, Ignition w/immobilizer (a) GG2B-67-SH0B GD7A-67-SH0C GG2A-67-SH0A GD7B-76-29XA GGYA-76-29X GD7D-76-29X GGYC-76-29X GD7A A GD7C A GE4T-76-2GX BJYV-76-2GX w/o Immobilizer GD7B A (a) Specify Key Code Number 15 Bolt, Shear (2) H Switch, Ignition H A Included w/ignition Lock Assy 17 Bezel, Ignition Lock KC Cover, Upper Column GD7A B GG2A GG2A Cover, Lower Column GD7A B 20 Column Unit, Steering To GG2A GG2A GD7A C From GD7D GD7D Bracket, Column Unit GD7A-32-21YA 22 Shaft, Lower Column GD7A A 23 Joint, Lower GA2A C 24 Plate, Column GA2C A 25 Boot, Lower Shaft GA2C Bracket, Hose w/ GD7C A ENGINE/TRANS 2.0L ENG 1 Pulley, Crankshaft FSB Bolt, Crankshaft FS A 3 Plate, Timing Belt FS Cover, Upper Timing FS C 5 Cover, Lower Timing FS D 6 Belt, Timing FSY Pulley, Camshaft (2) FSD Pulley, Crank Timing FS Pulley, Timing Idler FS A 10 Tensioner, Timing Belt FS B 11 Spring, Tensioner FS Pan, Upper Eng Oil FSY FS F FS G 13 Pan, Lower Eng Oil FS A 14 Dipstick, Engine Oil FS A 15 Tube, Engine Dipstick FS A 16 Sealant, Silicone Pan Pan, Trans Oil FW Gasket, Trans Oil Pan FW L ENG 1 Pulley, Crankshaft KLG Bolt, Crankshaft KL Pulley, Crank Timing KL B 4 Cover, Upper Timing R KL E L KL C 5 Cover Assy, Lower Timing KL F 6 Seal, Upper Timing R KL L KL B 7 Seal, Lower Timing KL B 8 Plug, Timing Cover KL Included w/lower Timing Cover Assy 9 Belt, Timing KL U 10 Pulley, Camshaft R KLG L KLY Pulley, Upper Idler KL A 12 Pulley, Lower Idler KL Pulley Assy, Tensioner KL Bushing, Pulley Pivot (2) KL Included w/tensioner Pulley Assy 15 Bolt, Tensioner Pivot KL Tensioner, Pulley KL B 17 Pan, Engine Oil KL Sealant, Silicone Pan Dipstick, Engine Oil B61P C 20 Tube, Engine Dipstick KL A 21 Cover, Valve FU9B A 22 Gasket, Valve Cover BN A 23 Pan, Trans Oil FU9A-21-51XA 24 Gasket, Trans Oil Pan BN A MAZDA ENGINE/TRANS MOUNTS 1 Mount, Frt Engine GD7B B GG2A A GA2F B 2 Bracket, Side Body GA2A E GA2E A 3 Bracket, Side Eng GA2C-53-37XC 4 Mount, Right Eng GD7A A GD7E A GD7E A GD7G Bracket, Right Eng KB A GD7D C KB A 6 Mount, Left Eng GD7A A KB GA2G A 7 Bracket, Left Eng GA2A B KB GJ4K GA2G A GD7G Mount, Eng/Trans GA2B KB D GD7G GG2G Bracket, Eng/Trans GA2A D GA2C C 10 Mount, Rear GA2E A KB GA2G Damper, Dynamic w/ GA2A A 12 Member, Eng/Trans Supt GD7A Insulator, Frt (2) B Washer, Insulator (2) B A 15 Bolt, Frt Member (2) B Insulator, Rear (2) B Washer, Insulator (2) B Nut, Rear Member (2) H ENGINE UNDER COVER 181 Page 181 April 22, :32:40 Version

10 MAZDA ENGINE UNDER COVER Cont d 1 Cover Assy, Right Engine GA2A Plug, Service Hole Included w/right Engine Cover Assy 3 Cover, Left Engine GA2A A 4 Rivet, Brake Pipe Cover R/L UB AIR CLEANER 1 Cleaner Assy, Air FSD A KLG B 2 Cover, Upper Cleaner FSD7-13-Z01 KLG4-13-Z01 3 Element, Filter FSD7-13-Z40 4 Mount, Rubber (3) FE Spacer, Mounting (3) F Included w/air Cleaner Assy 6 Bracket, Air Cleaner KL Duct Assy, Fresh Air FS1G FSD D KLR KLG D 8 Insulator, Duct (2) FS A 9 Spacer, Duct (2) FS1G Included w/fresh Air Duct Assy 10 Duct, Fresh Air FSD C KLG C 11 Gasket, Air Flow Meter FS KLG Meter, Air Flow FSD KLG Hose, Intake Air FSD A KLG Resonator, Intake Air FS Body Assy, Throttle FSD C KLG B 16 Sensor, Throttle Position FS01-13-SL0 KLG A 17 Valve, Idle Air FSN B KLG Lever, Throttle FSD2-13-W6X Included w/throttle Body Assy EXHAUST 2.0L ENG 1 Manifold, Exhaust FSC B 00 FP w/o Calif Emission FSD FP Shield, Manifold Heat FSC A 00 FP w/o Calif Emission FS B 2001 FP Gasket, Catalyst B6CK ZM ZM Converter, Catalytic B6GD C 00 FS1N FS1N Bracket, Hanger 6 Pipe, Header -00 FS A FS B 00 FSA A w/o Calif Emission FS B 2001 FSA A 7 Converter, Catalytic FSD FS1N w/o Calif Emission FSD FS1N Pipe, Center FS B FSA Muffler, Rear FS A FSA L ENG 1 Manifold, Exhaust -00 R K C L KL F0B 2001 R KLS X L KLS X R KL1J-20-55X L KL1J-20-50X 2002 R L 2 Shield, Manifold Heat R KL A L KL A w/o Calif Emission R KLS L KLS2-13-3K0 R KL A L KLS2-13-3K R KLS A L KLS2-13-3K R L 3 Pipe, Exhaust Header KL KL A w/o Calif Emission KL KL A 4 Converter, Catalytic KLG A KLS w/o Calif Emission KLG A 2001 KLS FS1N Pipe, Center KL KL Muffler, Rear KL B EMISSION SYSTEM 1 Valve, EGR FSY KLG B 2 Pipe, EGR FSC FSJ A w/o Calif Emission FS1G FSJ A K KLS w/o Calif Emission K KLS Valve Assy, Solenoid FSD C -Serviced by Components Valve, Solenoid (a) 4 No. 1 FS No. 2 KL No. 3 Z A (a) Included w/solenoid Valve Assy 7 Sensor Assy, Boost KLG B 8 Sensor, MAP KL A 9 Valve, Solenoid KL Included w/boost Sensor Assy 182 Labor Times Shown are for Replacement with New OEM Undamaged Parts on New Undamaged Vehicles. Page 182 April 22, :32:42 Version

11 10 Valve, Solenoid (2) K Valve, Solenoid FS Bracket, Solenoid KLG A 13 Valve, Solenoid KLG Bracket, Solenoid KLG A 15 Canister, Fuel Vapor JE Hose, Vacuum FSD A FS1G KLG Hose, Evaporation FSD ELECTRICAL ALTERNATOR MAZDA IGNITION 2.5L ENG HORN 1 Alternator Assy FS1G R-00 KLR R-00 2 Pulley, Alternator (a) FS05-18-W11 K W11 3 Regulator, Voltage (a) JE48-18-W70 (a) Included w/alternator Assy 4 Bracket, Alt Mounting FS KL B 5 Bracket, Adjusting FS To FS From FSD FSD Block, Adjusting FP Strap, Upper Alt KL A 8 Idler Assy, Belt K E 9 Collar, Idler Pulley KL Pulley Assy, Idler K YB 11 Bearing, Pulley (a) (a) Included w/idler Pulley Assy 12 Collar, Inner Pulley K A 13 Shaft, Pulley KL Bracket, Idler Pulley KL D 15 Bolt, Adjusting K A Included w/belt Idler Assy 16 Belt, Alternator FS A w/ A/C KLG w/o A/C KLG BATTERY 1 Battery 2 Clamp, Battery GA2A Tray, Battery GD7A Bracket, Battery Tray GD7A-56-03Y 1 Horn, Low Note GD7A A 2 Horn, High Note GD7A Relay, Horn GD7B IGNITION 2.0L ENG 1 Coil, Ignition FSD Wire Set, Ignition A 3 Starter-See Starter Section 4 Module, Powertrain Control w/immobilizer w/o Immobilizer w/immobilizer FSJ R-0K 01 FS8E C FSD R-0J 01 FS8C C FSJ R-0H 01 FS8F E 02 w/o Immobilizer FSE G 01 FS8D E 02 Order by Application 5 Bracket, Lower Module FS Z 6 Bracket, Upper Module FS ZB 1 Coil, Ignition KLG A 2 Wire Set, Ignition A 3 Starter-See Starter Section 4 Module, Powertrain Control -00 w/immobilizer KLM R-0J w/o Immobilizer KLG A 2001 w/immobilizer KL1K C KL1L D w/o Immobilizer KL1H C KL1J D Order by Application 5 Bracket, Lower Module FS Z 6 Bracket, Upper Module FS ZB STARTER Starter 1 FS R-00 2 K R KL R-00 WINDSHIELD 1 Windshield Assy Mazda GJ4H Base, Interior Mirror BW0B Included w/windshield Assy 3 Dam, Windshield GA7B Spacer, Windshield (White) R/L E Moulding Assy, Windshield GD7A-50-6AXF 6 Clip, Windshield R/L GD7A-50-6B8B Included w/windshield Moulding Assy 183 Page 183 April 22, :32:43 Version

12 MAZDA WINDSHIELD Cont d 7 Trim Assy, Pillar Light R GD7A F-80 L GD7A F-80 R GD7A F-27 L GD7A F-27 8 Clip, Trim (7/Side) R/L GJ Included w/pillar Trim Assy 9 Mirror, Rear View KA Visor Assy, Sun 10 w/vanity Mirror w/lamp w/sunroof Light w/o Lamp w/o Sunroof Light 11 w/o Vanity Mirror Light 12 Lens, Visor Lamp (a) (2/Side) 13 Bulb, Visor Lamp (a) (2/Side) R GD7M B-80 L GD7M B R GG2K B-80 L GG2K B R GD7M B-27 L GD7M B R GG2K B-27 L GG2K B R GD7H B-80 L GD7H B R GG2H B-80 L GG2H B R GD7H B-27 L GD7H B R GG2H B-27 L GG2H B R GD7G B-80 L GD7G B R GG2F A-80 L GG2F A R GD7G B-27 L GD7G B R GG2F A-27 L GG2F A R/L KA R/L GG2A R/L KA R/L GG2A-64-4G3 (a) Included w/sun Visor Assy 14 Clip, Inner Visor Light R/L GD7A R/L GD7A WIPER SYSTEM 1 Blade Assy, Wiper R GD7B L GD7A A 2 Insert, Wiper R GD7B L GD7A A Included w/wiper Blade Assy 3 Arm, Wiper R GD7B L GD7A Nut, Wiper Arm R/L Cap, Wiper Nut R/L GD7A Linkage Assy GD7A A 7 Pivot, Wiper R GD7A L GD7A Link, Wiper To Motor GD7A Pivot GD7A Included w/linkage Assy 9 Motor, Wiper GD7A A 10 Nozzle, Washer R GD7B A L GD7A C 11 Tee, Fluid GA2A Connector, Washer Hose M Clip, Hose H C34 14 Tank Assy, Washer w/cold Climate Spec GA2B F w/o Cold Climate Spec GC1M Tank, Washer w/cold Climate Spec GA2B A w/o Cold Climate Spec GC1M Cap, Tank GJ Pump, Washer GA2A Grommet, Pump S Sensor, Level w/cold Climate Spec GB8A Included w/washer Tank Assy 20 Hose, Right Nozzle S Hose, Left Nozzle (a) GD7A (a) Trim to 580mm Length 22 Hose, Nozzle Supply (b) GD7B (b) Trim to 190mm Length 23 Hose, Pump GD7C A COWL & DASH 1 Grille Assy, Cowl R GD7A-50-7R0E L GD7A-50-7S0F 2 Clip, Grille Right (2) GA7B A Left (3) GA7B A Included w/cowl Grille Assy 3 Cap, Screw R/L GA2A Grommet, Screw R/L FD Weatherstrip Assy, Rear Hood-See Hood Section 5 Panel Assy, Cowl GD7A Bracket, Wiper Motor GD7A Included w/cowl Panel Assy 7 Reinf, Cowl Side R GD7A L GD7A Panel, Lower Dash GD7A C 1 Panel, Instrument INSTRUMENT PANEL / / To / / From / / / / 2 End Assy, Dash GD7A N GD7A N GD7A N-29 GD7A N-90 GD7A N-29 GD7A N-90 GD7A N-29 GD7A N-90 GD7A N-29 R GD7A C-29 L GD7A C-29 R GD7A C-80 L GD7A C-80 3 Clip, Dash End (3/Side) R/L H Included w/dash End Assy 4 Grille, Defroster R GD7A A-90 L GD7A A-90 R GD7A A-29 L GD7A A-29 5 Cap, Screw Hole GD7A GD7A Tape, Top GD7A Tape, Cushion R/L GD7A Nut, Expansion (2) GJ Nut, Spring (6) B Cover, Under Dash GD7A B Module Assy, Passenger Air Bag-See Air Bag System Section 11 Fastener, Cover (3) GJ B Panel Assy, Front Trim LX, w/elect Swing Louver w/o Elect Swing Louver 13 Grille, Right Vent LX, w/elect Swing Louver w/o Elect Swing Louver 14 Grille, Center Vent GD7A F GD7D H GG2B A-31 GG2B A-95 GG2A A-31 GG2A A-95 GD7C-64-73XA GD7B-64-73XB GG2B-64-73X-00 GG2B-64-73X-90 GG7A-64-73XB-00 GG7A-64-73XB-90 GD7A-64-83XB GD7B-64-83XB LX, GG2B-64-83X-00 GG2B-64-83X Grille, Left Vent GD7A-64-83XB GG2A-64-83X-00 GG2A-64-83X Housing, Ctr/Right Vent w/elect Swing Louver GD7A-64-93XD w/o Elect Swing Louver GD7A GG2A GG2A Motor, Swing Louver GD7A-66-93XD 17 Housing, Left Vent GD7A-64-81XA 18 Clip, Trim Panel (4) H Included w/front Trim Panel Assy GG2A-64-81X-00 GG2A-64-81X Labor Times Shown are for Replacement with New OEM Undamaged Parts on New Undamaged Vehicles. Page 184 April 22, :32:45 Version

13 MAZDA Panel, Lower Center Elect Radio Man Radio Panel, Left Lower GG2A A-29 GG2A A-80 GG2A A-29 GG2A A-80 GG2B B-29 GG2B B-80 GG2B B-29 GG2B B-80 GD7A C-29 GD7A C Clip, Trim Panel (7) H Cover, Right Control KA G1B-29 KA G1B Cover, Left Control KA G4B-29 KA G4B Fastener, Trim R/L B AC3-00 R/L B AC Panel Assy, Center Trim DX, GD7A G w/wood Trim w/o Wood Trim Dark Dark 26 Pocket, Panel DX, GD7F H GD7F H GG2A GG2A GD7A A GD7F A w/wood Trim GD7F A w/o Wood Trim Dark GG2A Dark GG2A Included w/center Trim Panel Assy 27 Box Assy, Glove GD7A GD7A Latch Assy, Glove Box GD7A A-29 GD7A A Knob, Latch (a) GD7A GD7A (a) Included w/glove Box Latch Assy 30 Box, Glove GD7A GD7A Lid, Glove Box (a) GD7A B-29 GD7A (a) -Serviced w/glove Box Assy 32 Stopper, Glove Box R/L G A 33 Screw, Latch Retainer GD7A Bolster, Knee (a) GD7A-60-K40 (a) -Serviced w/glove Box Assy Included w/glove Box Assy 35 Cylinder, Lock GE4T-64-09YB-00 GE4T-64-09YB-29 GE4T-64-09YB Striker, Latch GD7A Cluster Assy, Instrument (a) GD7B F GD7A F GD7D F GD7C F -Serviced by Components (a) Order by Application 38 Lens, Cluster (b) GD7A Plate, Lens (b) GD7A Cluster, Instrument (a) (b) GD7A B 00 GG2A GG2A A GD7C A 00 GG2C GG2C A (a) Order by Application 41 Knob, Tripmeter (b) GD7A Sheet, Warning (b) R/L GD7A Case, Meter (b) GD7A Plate, Printed Circuit (a) (b) GD7A A GG2A Bulb (b) No. 1 GD7A No. 2 GD7B No. 3 GD7C No. 4 GD7D No. 5 GE1R (b) Included w/instrument Cluster Assy 46 Vent Assy, Right Dash GD7A D-90 GD7A D Grille, Right Vent (a) GD7A-64-73XB-90 GD7A-64-73XB-29 -Serviced w/right Dash Vent Assy 48 Housing, Right Vent (a) GD7A-64-71XC-90 GD7A-64-71XC-29 (a) Included w/right Dash Vent Assy 49 Vent Assy, Left Dash GD7A B-90 GD7A B Clip, Vent GA2A Included w/left Dash Vent Assy 51 Duct, Right Dash GD7A-64-74XC 52 Duct, Left Dash GD7A A 53 Duct, Side Demister R GD7A B L GD7A A 54 Duct, Defrost GD7A A 55 Xmbr, Panel 98 GD7A G GD7B C 56 Bracket, Module KL C 57 Switch, Left Dash w/mirror Switch GD7A Cover, Switch Opening w/o Mirror Switch GD7A B 58 Cover, Switch Hole GE4T A GD8A Resistor Unit GE4T-66-6R0B 60 Switch, Left Column w/traction Control GD7B-66-4T0 Cover, Switch Opening w/o Traction Control GE4T A 61 Switch, Hazard Warning GD7B-66-4H0A 62 Switch, Rear Defrost GD7A Outlet Assy, Power GD7A D GG2B Cap, Outlet GD7A A 65 Socket, Outlet GD7A B 66 Ring, Lighting GD7A A Included w/power Outlet Assy 67 Cover, Radio Blanking GA2K-66-9M0 68 Pocket, Radio B02A-66-9M0A 69 Radio AM-FM-CD GD7C-66-9R0 AM-FM-CD Bose GD7H-79-9R0 w/high Grade Speaker w/cd Changer A01 01 GJ4J-66-AS0 w/o CD Changer A03 01 GJ4K-66-9TX w/o High Grade Speaker 00 GD7C-66-9R0 01 BL8G-66-9R0 CENTER CONSOLE 1 Console Assy, Center GD7A G-29 GD7A G-80 2 Box, Rear Console GD7A Lid Assy, Console GD7A F-29 GD7A F-80 4 Pad, Upper Lid (a) GD7A GD7A Latch, Lid (a) GD7A-64-45YC 6 Hinge, Lid (a) GD7A-64-45XC (a) Included w/console Lid Assy 7 Bracket, Rear Console GD7A Included w/center Console Assy 185 Page 185 April 22, :32:46 Version

14 MAZDA CENTER CONSOLE Cont d Cont d 8 Boot Assy, Brake GD7A-64-43YF-29 GD7A-64-43YF-80 9 Clip, Plate Spring (5) H Boot, Brake GD7A B 11 Plate, Boot GD7A B Included w/brake Boot Assy Trim Assy, Shifter 12 DX, GD7A F GD7F E 13 DX, GD7C E GD7H D 14 Clip, Plate (4) H Ring, Shifter 15 GD7A GD7C A 17 Boot, Shift GD7A A Included w/shifter Trim Assy 18 Fastener, Console () R/L GJ B Bracket, Rear Console GD7A A 20 Bracket, No. 3 Console GD7A Dark GG2A A-95 Dark GG2A A w/wood Trim GG2H w/o Wood Trim Dark GG2C Dark GG2C Clip, Plate (4) J Ring, Shifter 15 GG2A GG2C Boot, Shift w/wood Trim GG2A w/o Wood Trim GG2A A-29 GG2A A-80 Included w/shifter Trim Assy 18 Protector, Shifter Trim GG2C Fastener, Console () R/L GJ B Bracket, Rear Console GD7A A 21 Bracket, No. 3 Console GG2A ROCKER/PILLARS/FLOOR SHEET METAL 1 Pillar, Outer Hinge R GDYA L GDYA Pillar, Outer Center R GDYA L GDYA Panel, Outer Rocker R GDYA L GDYA INTERIOR TRIM 1 Trim Assy, Pillar-See Windshield Section 2 Panel Assy, Cowl Trim R GD7A A-29 L GD7A B-29 R GD7A A-80 L GD7A B-80 3 Cover, Cowl Panel L GD7A A-29 L GD7A A-80 Included w/cowl Trim Panel Assy 4 Fastener, Cowl Trim (2/Side) R/L B AC3-29 R/L B AC Trim Assy, Upper Center Pillar R GD7A B-80 L GD7A B-80 Light R GD7A B-27 L GD7A B-27 6 Clip, Trim (7/Side) R/L GJ Included w/upper Center Pillar Trim Assy 7 Trim, Lower Center Pillar R GD7A D-29 L GD7A D-29 R GD7A D-80 L GD7A D-80 8 Plate Assy, Front Scuff R/L GD7A R/L GD7A Clip, Scuff Plate (4/Side) R/L GA7B-68-AD3 Included w/front Scuff Plate Assy 10 Plate Assy, Rear Scuff R GD7A B-29 L GG2A A-29 R GD7A B-80 L GG2A A Fastener, Plate () R/L GJ B Clip, Scuff Plate (2/Side) R/L GA7B-68-AD3 Included w/rear Scuff Plate Assy 1 Console Assy, Center GG2A E-29 GG2A E-80 GG2F D-29 GG2F D-80 2 Box, Rear Console GG2A A 3 Outlet, Rear Box GG2A Lid Assy, Console 5 Pad, Upper Lid (a) GG2A B-29 GG2A B-80 GG2F A-29 GG2F A-80 GG2A B-29 GG2A B-80 GG2F A-29 GG2F A-80 6 Latch, Lid (a) GG2A-64-45Y 7 Hinge, Lid (a) GG2A-64-45XA 8 Cover, Rear Console (a) GG2A (a) Included w/console Lid Assy 9 Holder, Cup 10 Boot, Brake 11 Plate, Boot GG2A Included w/center Console Assy Trim Assy, Shifter 12 w/wood Trim w/o Wood Trim GG2A-64-39XA-29 GG2A-64-39XA-80 GG2A B-29 GG2A B-80 GG2F A 4 Pillar, Inner Front R GG2A-70-04X L GG2A-71-04X 5 Reinf, Lower Pillar R GD7A A L GD7A A 6 Reinf, Upper Pillar R GD7A A L GD7A A 7 Bracket, Fender R/L GD7A-70-21Y 8 Brkt, Front Pillar (2/Side) R/L T A 9 Pillar, Inner Center R GG2A C L GG2A C 10 Reinf, Center Pillar R GD7A D L GD7A D 11 Brkt, Center Pillar R/L T A 12 Reinf, Rocker R GD7A L GD7A Panel, Inner Rocker R GD7A A L GG2A Pan, Front Floor GD7A A 15 Frame, Floor R GD7A L GD7A Crossmember, Rear Floor GA2A C 13 Carpet, Interior w/rear Heater Duct (Canada) DX, w/o Rear Heater Duct DX, w/high Grade Audio w/o High Grade Audio 14 Fastener, Rear Carpet (6) Dark GD7B F-29 GD7B F-80 GD7F B-29 GD7F C-80 GG2E D-29 GG2E D-80 GG2A D-29 GG2A D-80 G A-00 G A Labor Times Shown are for Replacement with New OEM Undamaged Parts on New Undamaged Vehicles. Page 186 April 22, :32:48 Version