POWER SYSTEMS, INC. Not intended for use in critical life support applications.!
|
|
|
- Olivia Washington
- 5 years ago
- Views:
Transcription
1 POWER SYSTEMS, INC. Owner s Manual Liquid-cooled, Prepackaged Standby Generators Models: 0047, & (40 kw/single-phase w/ 00 Amp Transfer Switch) 00466, & (40 kw/single-phase w/ 00 Amp Transfer Switch California Emissions)! Not intended for use in critical life support applications.! ONLY QUALIFIED ELECTRICIANS OR CONTRACTORS SHOULD ATTEMPT INSTALLATION!! DEADLY EXHAUST FUMES. OUTDOOR INSTALLATION ONLY! This manual should remain with the unit.
2 Mounting Base - Drawing No. 0E84-A BLACK RED TO STARTER SOLENOID To Oil Drain On Oil Pan Generac Power Systems, Inc.
3 Mounting Base - Drawing No. 0E84-A 0C50 ASSEMBLY BASE MOUNTING (DIRECT-COUPLED) 08804T CABLE BATT RED # X LUG SLDLSS #-#8 X 7/64 CU 4 0A4084 MOUNT ENGINE (R&L) 5 0 WASHER LOCK M8-5/ NUT HEX M8-.5 G8 YEL CHR WASHER LOCK / SCREW HHC /8-6 X G SCREW HHC /8-6 X /4 G SCREW HHC M8-.5 X 5 G WASHER FLAT 5/6 ZINC 0748 WASHER SHAKEPROOF EXT 5/6 STL SCREW HHC M-.75 X 85 G DAMPENER VIBRATION 40 BLUE SPACER.49 X.6 X.87 PWDR/ZINC DAMPENER VIBRATION WASHER FLAT M NUT LOCKING M ASSEMBLY GROUNDWIRE 0"// A DAMPENER VIBRATION 50 WHITE 0448 BARBED STRAIGHT / NPT X 5/ CLAMP HOSE # HOSE 5/8 ID TYPE SINGLE ("LG) PLUG STD PIPE / STEEL SQ HD 5 0D49 KIT VARMIT GUARD (FOR N/G, L/P VAPOR OR DUAL FUEL, N/G-LP LIQUID UNITS) 0D49A KIT VARMIT GUARD (FOR L/P LIQUID UNITS) 0D49B KIT VARMIT GUARD (FOR DUAL FUEL N/G-L/P VAPOR UNITS) H CABLE BATT BLK # X WASHER FLAT /8-M0 ZINC WASHER SHAKEPROOF EXT 7/6 STL HOLD DOWN BATTERY 0 04 SCREW HHC /4-0 X G5 047 WASHER FLAT /4 ZINC 0097 WASHER LOCK M6-/4 07 NUT HEX /4-0 STEEL 4 0A400 SCREW HHC M8-.5 X 60 G8.8 FT NUT LOCK FL M BATT VDC 90-AH 7F HOLD DOWN BATTERY NUT LOCK HEX M8-.5 NYL INSRT BOOT BATTERY CABLE Generac Power Systems, Inc.
4 Compartment - Drawing No. 0D BASE FRAME 9 Generac Power Systems, Inc.
5 Compartment - Drawing No. 0D899 0C594 0 ASSEMBLY M6 HINGE 0A59 40 SCREW BHSC M6-.0 X 6 SS 4 0A60 40 SHAKEPROOF INT M6 SS 5 0C5 (A) 5 DOOR SMALL STD. WELD 6 0C57 (A) CORNER POST LH REAR 7 0C58 (A) CORNER POST RH REAR 8 0C55 (A) CORNER POST LH FRONT 9 0C56 (A) CORNER POST RH FRONT 0 0C547 (A) REAR BRACE TOP & BOTTOM 0C550 (A) 4 SIDE BRACE TOP & BOTTOM 0C555 (A) SIDE SUPPORT 0C560 (A) ROOF ONE-PIECE WLDMT 5 0D7904 (A) FRONT BRACE TOP 6 0C6 5 PLATE STRIKER 7 0C SCREW PPHM M4-0.7 X SS PADDLE HANDLE LOCK 0C NUT LOCK HEX M4-0.7 SS NYL INS WASHER FLAT #8 SS RIVET POP /6 X /4 0C4065 (A) DUCT FRONT LH 0C4064 (A) DUCT FRONT RH 4 0C4066 (A) DUCT BOTTOM 5 0C4067 (A) DUCT FRONT PANEL 6 0C47 (A) DUCT FRONT TOP RH 8 0C64A ASSEMBLY COVER ACCESS 9 0C SCREW TH-FRM M6-X6 N WA Z/JS 0 0 WASHER LOCK M8-5/ SCREW HHC M8-.5 X 6 G WASHER FLAT M6-/4 ZINC 0097 WASHER LOCK M6-/ NUT HEX /4-0 STEEL 5 0A FT. GASKET DOOR RUBBER 6 0C9 SCREW SHOULDER 9 0C400 (A) COVER EXHAUST HOLE 4 0C97 4 FASTENER RATCHET /8" STRIP SEALANT /8 X WASHER FLAT 5/6 ZINC OPTIONAL COMPARTMENT MATERIALS:ALL P/N'S WITH AN "A" SUFFIX INDICATEALUMINUM MATERIAL OPTION. Generac Power Systems, Inc.
6 VIEW A-A A A SET EVERY 7 DAYS, AT TIME SET. I M E 888 V PANEL FACE INSIDE. 9 0 Section 7 Exploded Views and Parts Lists (Model No. 0047, & 00475) Guardian Liquid-cooled 40 kw Generator Control Panel 4.L Drawing No. 0D4995-F A Hz 4 4 Generac Power Systems, Inc.
7 (Model No. 0047, & 00475) Guardian Liquid-cooled 40 kw Generator Control Panel 4.L Drawing No. 0D4995-F 0D5488 PANEL BTM & BACK CONTROL PANEL 0D5A CONTROL PANEL, FRONT W/ SILK SCREEN 0D5 PANEL,SIDE COVER CONTROL PANEL ASSY VOLTAGE REGULATOR 60HZ 5 0C84 WASHER LOCK HDPDEUTSCH 6 0C844 NUT, HDP DEUTSCH CIRCT BRK 7 X ETA P RES WW LUG 0R 0% 5W COVER CON PNL TOP (NOT SHOWN) HEATSINK WASHER STEP NYLON RECTIFIER MSC A 600V N06R WASHER MICA NUT HEX #0- STEEL WASHER SHAKEPROOF EXT #0 STL WASHER FLAT #0 ZINC A PP LOGIC ASM 50/60HZ PCB SUPPORT SNAP-IN /4" GROMMET /4 X 5/ X 5/ SWITCH ROCKER DPST 5V SPD SWITCH TOG DPDT 5/0 SP HOLDER FUSE FUSE 5A X AGC LIGHT VDC.0A LED RED PILOT SWITCH SELECTOR 6A AMP/V VOLTMETER DC 8-V HOURMETER VOLTMETER AC AMMETER AC FREQUENCY METER 40V 55-65HZ 0888 DECAL EXERCISE INFO 4 0C DECAL CUST CONN BOX REF. ASSY L.C. ELECT GOV 6 0A968 CAPACITOR FILTER ASY REF BLOCK TERM 0A X 6 X 00V TFMR ASM,CMA 40/V REF BLOCK TERM 0A 0 X 6 X 00V DECAL, TERM. STRIP TIE WRAP 7.4" X." NATL UL VIB MNT.0 X.0 X / SCREW HHC /4-0 X / G NUT HEX /4-0 STEEL WASHER LOCK M6-/ SCREW HHC #0- X / WASHER LOCK # SCREW PPHM #6- X / WASHER LOCK # WASHER FLAT #6 ZINC SCREW PPHM #8- X / WASHER LOCK M WASHER FLAT #8 ZINC NUT HEX #8- STEEL NUT HEX #6- STEEL SCREW PPHM #6- X -/4 60 0C48 4 SCREW PHTT #6- X / ZYC 6 0C 4 SCREW PHTT #6- X 5/8 ZYC 6* 0D54 REF. FUSE & HOLDER LITTEL 7.5A 6* 0A96 REF. FUSE 7.5AXBK/AGC7.5NX W/ SCREW HHTT M5-0.8 X 0 BP 65 0E78 DECAL, WARNING REMOVE FUSE * PART OF CONTROL PANEL WIRE HARNESS Generac Power Systems, Inc. 5
8 (Model No , & ) Guardian Liquid-cooled 40 kw Generator Control Panel Drawing No. 0D6978-C 6 Generac Power Systems, Inc.
9 (Model No , & ) Guardian Liquid-cooled 40 kw Generator Control Panel Drawing No. 0D6978-C 0D797 PNL BTM & BACK CNTL PNL D5A CONTROL PANEL FRONT W/ SILK SCREEN 0D5 PANEL SIDE COVER CONTROL PANEL ASSY VOLTAGE REGULATOR 60HZ 5 0C84 WASHER LOCK HDP DEUTSCH 6 0C844 NUT, HDP DEUTSCH 7 0A6 PANEL LEFT SIDE E CIRCT BRK 7 X ETA P RES WW LUG 0R 0% 5W COVER CON PNL TOP (NOT SHOWN) 0E550 CHASSIS, UNIVERSAL HEATSINK WASHER STEP NYLON RECTIFIER MSC A 600V N06R WASHER MICA NUT HEX #0- STEEL WASHER SHAKEPROOF EXT #0 STL WASHER FLAT #0 ZINC A PP LOGIC ASM 50/60HZ PCB SUPPORT SNAP-IN /4" 0A94 GROMMET /4 X 5/ X 5/ SWITCH ROCKER DPST 5V SPD SWITCH TOG DPDT 5/0 SP HOLDER FUSE FUSE 5A X AGC LIGHT VDC.0A LED RED PILOT SWITCH SELECTOR 6A AMP/V VOLTMETER DC 8-V HOURMETER VOLTMETER AC AMMETER AC FREQUENCY METER 40V 55-65HZ 0888 DECAL EXERCISE INFO 4 0C DECAL CUST CONN BOX 5 0D440 CONTROLLER, B-C #DPG-0 6 0A968 CAPACITOR FILTER ASY REF BLOCK TERM 0A X 6 X 00V 8 0A44B COVER PLATE AVR TFMR ASM,CMA 40/V 40 0A44C COVER PLATE EGOV REF BLOCK TERM 0A 0 X 6 X 00V DECAL TERM. STRIP TIE WRAP 7.4" X." NATL UL VIB MNT.0 X.0 X / SCREW HHC /4-0 X / G NUT HEX /4-0 STEEL WASHER LOCK M6-/ SCREW HHC #0- X / WASHER LOCK # SCREW PPHM #6- X / WASHER LOCK # WASHER FLAT #6 ZINC SCREW PPHM #8- X / WASHER LOCK M WASHER FLAT #8 ZINC NUT HEX #8- STEEL NUT HEX #6- STEEL 58 0C48 8 SCREW PHTT #6- X / ZYC 59 0C 4 SCREW PHTT #6- X 5/8 ZYC 60 0A84 4 SCREW SWAGE 8- X / Z/YC 6 0C7 DECAL AVR COVER 6* 0D54 4 FUSE & HOLDER LITTEL 7.5A 6* 0A96 FUSE 7.5AXBK/AGC7.5NX W/ SCREW HHTT M5-0.8 X 0 BP 65 0E78 DECAL, WARNING REMOVE FUSE * PART OF CONTROL PANEL WIRE HARNESS Generac Power Systems, Inc. 7
10 Connection Box Drawing No. 0D8848-B BOTTOM OF CONTROL PANEL REF ALT. LEADS & SENSING WIRE SIEMENS FD POLE 47 (600V) 4 (00A) ALT. LEADS & SENSING WIRE ITEM # CIRCUIT BREAKER LINE SIDE CIRCUIT BREAKER LOAD SIDE RECOMMENDED TERMINAL TIGHTENING TORQUES DESCRIPTION FOR CIRCUIT BREAKER AND NEUTRAL BLOCK RING TERMINALS FROM ALTERNATOR 0 FT-LB NA FASTEN COMPRESSION LUG TO CIRCUIT BREAKER NA.5 FT-LB STRIPPED END OF STRANDED CABLE TO COMPRESSION LUG NA FT-LB 5 NEUTRAL BLOCK FT-LB NA FT-LB 8 Generac Power Systems, Inc.
11 Connection Box Drawing No. 0D8848-B 0685 LOWER PANEL 5 0D5489 COVER LOWER CONNECTION BOX N BUSHING SNAP SB RELAY SOLENOID VDC PNL MNT 9 0D88 DECAL REMOTE START CONNECTION TRANSFORMER 00A TO 5A 5VA 0D549 HARNESS LOWER PANEL 4.L GRDN (048766) REF. BLOCK TERM 0A X 6 X 00V 0985 WASHER FLAT #6 ZINC 0686 COVER LOWER PANEL 5 0D5840 DECAL CUSTOMER CONNECTN FOR TS WASHER LOCK M4 0 0C SCREW PHTT M4-0.7 X 6 ZYC 04 4 SCREW HHC 5/6- X /4 G WASHER FLAT 5/6 ZINC 0 4 WASHER LOCK M8-5/ NUT HEX M8-.5 G8 YEL CHR SCREW HHC /4-0 X /4 G WASHER FLAT /4 ZINC WASHER LOCK M6-/ NUT HEX /4-0 STEEL 40 0D5574 CB 000A P 600V S FD6 LL 4 0D5689 PLATE CB MOUNT S (FD) 90S 4 0D569 COVER CB TERMINALS S (FD P) WASHER LOCK M6-/ SCREW HHC /4-0 X /4 G NUT HEX /4-0 STEEL WASHER FLAT /4 ZINC SCREW SHC /4-0 X 4.5 G8.8 NZ WASHER LOCK / SCREW SHC /8-6 X /4 G5 5 0D5464B NEUTRAL BLOCK 90/00-400A JUNCTION BLOCK / WASHER LOCK # SCREW PHM #0- X 5/8 CAD WASHER LOCK / NUT HEX /8-6 STEEL WASHER FLAT 5/6 ZINC 59 0 WASHER LOCK M8-5/ NUT HEX M8-.5 G8 YEL CHR Generac Power Systems, Inc. 9
12 Generator Drawing No. 0D9490 TO ENGINE FLYWHEEL TO ENGINE FlLYWHEEL ADJUSTMENT NOTE: 5 THREAD IN SENSOR (6) UNTIL CONTACT IS MADE WITH RING GEAR, THEN BACK OFF / TO /4 TURN AND TIGHTEN NUT. CAUTION: DO NOT ROTATE ENGINE DURING THIS ADJUSTMENT SCROLL DETAIL STATOR LEADS 40 Generac Power Systems, Inc.
13 Generator Drawing No. 0D SCREW HHC M-.75 X 5 G WASHER LOCK M 0A840 FLEX PLATE SAE SCREW HHC M8-.5 X 0 G WASHER LOCK M8-5/ D ASSEMBLY MAG PICKUP 7" 7 0C486 ASSEMBLY FAN W/PRESS DISC 0.75 X 8 * 0A60 SCREW HHC M6-.0 X 45 G8.8 9 * 0A60 WASHER FLAT.688 ID X.5 OD 0 * 0A8 KEY SQ /8 X -/ STEEL * 04 COUPLER 90 SAE 00808A ROTOR P DIRECT * 0564 BEARING BALL 6 SEALED 4 * SLIP RING -MACHINED- 5 0A SCREW HHC M4-.0 X 40 G A6 4 WASHER 90 SAE ALT A STATOR AD SAE 0 WASHER FLAT /8-M0 ZINC 07 WASHER LOCK / SCREW HHC /8-6 X -/4 G5 068 CARRIER REAR BEARING 5" 0685 LOWER PANEL WASHER LOCK M NUT HEX M4-.0 G8 YEL CHR SCREW HHTT #0- X /4 CZ WASHER FLAT 5/6 ZINC SCREW HHC M8-.5 X 45 G8.8 FT BRUSH HOLDER ASSEMBLY HOLDER BRUSH SUPPORT 0 0A0 SCREW SWAGE /4-0 X / Z/YC WASHER FLAT /4 ZINC 0746 SCREW HHC /8-6 X -/4 G5 080 TIE WRAP UL 4.6 X.4 NATL SLEEVE RUBBER 5 0A4089 ASSEMBLY SCROLL 90 SAE KIT 0A4089 PARTS 6 0A49 SHROUD ALTERNATOR SHEET METAL 7 0A497 SCREEN SHROUD SAE 8 0A496 BRACKET TENSIONER SAE SCROLL FT TRIM VINYL BLACK /8 GP WASHER LOCK M6-/ SCREW HHC M6-.0 X 5 G SCREW HHC M6-.0 X 6 G A0 SCREW SWAGE /4-0 X / Z/YC * ROTOR REPLACEMENT PARTS Generac Power Systems, Inc. 4
14 Engine Drawing No. 0D6980-B 4 Generac Power Systems, Inc.
15 Engine Drawing No. 0D6980-B 0A9046 ENGINE 4.L GM 0A98A FLYWHL 4.L GM SAE 0700 WASHER STAR M EXT 4 0A60 6 SCREW HHC 7/6-0 X G A STARTER 5.7L/7.4L GM 8 0A9050 BOLT STARTER 4.L WASHER LOCK / NUT HEX M0-.5 G8 YEL CHR 0496 WASHER LOCK M NUT HEX M5-0.8 G8 YEL CHR 0A444 CONNECTOR COIL TO DISTRIBUTOR 4 0A45 DIP STICK 4.L GM 5 0A4 TUBE DIP STICK 4.L " HOSE /4 ID SAE-0R 7 0A440 GASKET THERMOSET SCREW HHC /8-6 X -/4 G A HOUSING THERM IMPREX PLUG STD PIPE /8 SOCKET HEAD HOUSING THERMOSTAT/WATER INLET SENSOR HI COOLANT SHUTDOWN 0A490B HEAT SHIELD RIGHT 4 0A4084 MOUNT ENGINE SCREW HHC /8-6 X G BRACKET SUPPORT SPARK PLUG WIRE 7 05 SCREW HHC /8-6 X /4 G5 8 0 WASHER FLAT /8-M0 ZINC RETAINER PLUG WIRES 0 0A4085 GASKET EXHAUST MANIFOLD 0A98 MANIFOLD RIGHT EXHAUST 0C7947 BOLT U /8-6 X RETAINER SPARK PLUG WIRES 4 0A477 WIRES SPARK PLUG 4.L NUT HEX /8-6 STEEL CONNECTOR C/C VENT PIN DOWEL M0 X SCREW HHC /8-6 X -/ G5 9 0A85 PLATE FLEX GM CASTING ADAPTOR SENSOR COOLANT LEVEL 4 0D44M ASSY MAGPICKUP (/8-4 MALE) (MODEL NLY) THERMOSTAT 5 DEG * 0D KW GUARDIAN WIRE HARNESS (NOT SHOWN FOR MOD ) * 0A408 HARNESS 4.L STD WIRE (NOT SHOWN FOR MOD ) Generac Power Systems, Inc. 4
16 Engine Drawing No. 0A404-L Generac Power Systems, Inc.
17 Engine Drawing No. 0A404-L 0A9046 ENGINE 4.L GM 0A4084 MOUNT, ENGINE (R & L) 0A49 PULLEY CRANKSHAFT 4 0A440 PULLEY WATER PUMP 5 0A5640 SPACER FAN 50MM 4.L (5KW UNITS ONLY) 0A5640A SPACER FAN 6MM (45KW UNITS ONLY) 6 0A569 FAN 7" REVRS ROT (5KW UNITS ONLY) 0D9A FAN COOLING " DIA REVRS ROT (45KW UNITS ONLY) CAP HOSE CLAMP HOSE # BUSHING REDUCER /4 TO / SCREW HHC 7/6-0 X -/4 G5 00 WASHER LOCK 7/6 0A8584 SWITCH OIL PRESSURE SPACER.5 X.5 X.5 STL/ZINC 4 0A478A BELT SERPENTNE 7.5" 5 0A490A HEAT SHIELD LEFT 6 0A4085 GASKET EXHAUST MANIFOLD 7 0A97 MANIFOLD LEFT EXHAUST 0C7947 BOLT U /8-6 X.50 0A DC ALTERNATOR ASSEMBLY 0 0A780B PULLEY PLOY-V 8 OD. 08 BRACKET ALT. SUPPORT 0C69 BRACKET MOUNTING WELD ASSEMBLY 0A44 PULLEY GROOVED IDLER 4 0C885 PULLEY TENSIONER 5 0A577C SPACER DC ALTERNATOR 4MM WASHER FLAT /8-M0 ZINC ADAPTOR M-.75 /8 NPT BARBED STRAIGHT /8 NPT X 5/ CLAMP HOSE # HOSE 5/8 ID TYPE SINGLE (") 0 8 WASHER LOCK M8-5/ SCREW HHC 5/6- X /4 G5 (45KW) SCREW HHC 5/6-4 X /4 G WASHER LOCK / SCREW HHC /8-6 X G SCREW HHC /8-4 X G SCREW HHC /8-6 X 4 G NUT HEX /8-6 STEEL 9 0A5768 WASHER FLAT HEAVY DUTY WASHER LOCK M SCREW HHC M0-.5 X 5 G C756 BOLT TENSIONER PULLEY NUT HEX M0-.5 G8 YEL CHR 44 0D54 8 SPARK PLUG 5.7L GM WASHER FLAT M D CLAMP VINYL.06 X.406 Z 47 0A FILTER OIL Generac Power Systems, Inc. 45
18 4.L Radiator Drawing No. 0D799-D KIT PART NO. 0D KIT PART NO. 0D "A" TO "A" 0 KIT PART NO. 0D8 46 Generac Power Systems, Inc.
19 4.L Radiator Drawing No. 0D799-D 0D785 RADIATOR COPPER BRASS 0D85 FAN GUARD BOTTOM 0D85 FAN GUARD TOP SCREW HHTT /4-0 X CZ WASHER LOCK M6-/ WASHER FLAT /4 ZINC 7 0D774 VENTURI 4.L " FAN 0D774A VENTURI 4.L 7" FAN 9 0D7870 RADIATOR HOSE LOWER CLAMP HOSE # HOSE /8 ID SINGLE BRAID 0407 CLAMP HOSE # DRAINCOCK HOSE 9/ ID (64" LG) TAPE FOAM X (9" LG) SCREW CRIMPTITE /4-0 X 5/ SCREW HHC /8-6 X G WASHER LOCK / WASHER FLAT /8-M0 ZINC 0D7850 RADIATOR HOSE UPPER BOTTLE COOLANT RECOVERY 0D7975 WATER BOTTLE BRACKET SCREW HHTT M6-.0 X YC C CLAMP HOSE BAND /4 9 0C44 SUPPORT RADIATOR A GRP 0 * 0A6984 BRACKET AIR DUCT TOP/BOT * 0D794 SUPPORT AIR DUCT RH SIDE * 0D794 SUPPORT AIR DUCT LH SIDE * 04 8 SCREW HHC /4-0 X G5 4 * WASHER LOCK M6-/4 5 * WASHER FLAT /4 ZINC 6 ** 0D794 SCREEN FRONT 7 ** SCREW HHTT /4-0 X CZ 8 ** WASHER LOCK M6-/4 9 ** WASHER FLAT /4 ZINC CAP RADIATOR PSI-FOR SERVICE ONLY * OPTIONAL WITH KIT 0D7948 ** OPTIONAL WITH KIT 0D7947 Generac Power Systems, Inc. 47
20 (Model No. 0047, & 00475) 4.L Exhaust Drawing No. 0E0704-A 0.5" DIA. CLAMP ASSEMBLY TO ENGINE TO COMPARTMENT FRONT TO ENGINE A CAP RAIN.50 /.69 0C964 TUBE STRAIGHT 'A' GROUP 0C9650 MUFFLER -/" INLET/OUTLET 4 0C44A CLAMP BAND MUFFLER 6.5" 5 0C46 BRACKET MUFFLER MOUNTING 6 0D5787 TUBE ELBOW 90 DEG.5" 7 0A55B PIPE FLEX.5" 8 0E0699 TUBE, CROSS OVER 9 0E0698 TUBE, 90 ELBOW 0 0C470 BRACKET EXHAUST SHIELD 0C405 SHIELD A-GRP HEAT 0C454 SCREW TH-FRM M6- X 6 N WA Z/JS 0C4A 4 CLAMP BAND.5" 4 0 WASHER LOCK M8-5/ WASHER FLAT 5/6 ZINC 6 0C9748 PLUG M SCREW HHC M8-.5 X 6 G BOLT U /8-6 X WASHER LOCK /8 04 NUT HEX /8-6 STEEL 0E070 SHIELD, CROSSOVER HEAT 0E0700 SHIELD, EXHAUST HEAT WASHER FLAT /8-M0 ZINC 48 Generac Power Systems, Inc.
21 4.L Air Cleaner Drawing No. 0E NUT WING /4-0 NYLK 0A46A PLATE AIR CLEANER TOP 0A467 FILTER AIR.5" CA6 4 0A46B PLATE,AIR CLEANR BOT STUD TH /4-0 X G ZNC FULL 6 07 NUT HEX /4-0 STEEL GROMMET CONNECTOR C/C VENT Generac Power Systems, Inc. 49
22 (Model No. 0047, & 00475) 4.L Nat. Gas Fuel System Drawing No. 0E TO INTAKE MANIFOLD TO STEPPER MOTOR TO VALVE COVER Generac Power Systems, Inc.
23 (Model No. 0047, & 00475) 4.L Nat. Gas Fuel System Drawing No. 0E SUPPORT SOLENOID NAT GAS ELBOW 90D /4NPT NIPPLE PIPE /4 NPT X 4.5 BLK IRN 4 0C7598 ASSY NATURAL GAS SOLENOID NIPPLE PIPE /4 NPT X BUSHING REDUCER TO / REGULATOR NAT GAS LPG VAPOR SUPPORT REGULATOR 9 0C775 BRACKET REGULATOR 4.L SCREW HHTT #0-4 X /4 YC WASHER FLAT 5/6 ZINC 0 8 WASHER LOCK M8-5/ SCREW HHC 5/6- X G PLUG STD PIPE /4 STEEL SQ HD 5 0 WASHER FLAT 9/6 ZINC SCREW HHC M4-.0 X 5 G NIPPLE TOE /4 NPT X CLAMP HOSE # HOSE IN ID LP GAS (4"LG) 0 04 WASHER LOCK M NUT HEX M4- G8 YEL CHR DECAL FUEL INLET NG NIPPLE CLOSE /4 X P CLAMP VINYL.6 X.486 Z 6 0A577C SPACER, D.C. ALT. (9MM LONG) (NOT SHOWN) 7 0D509 DECAL INLET PRESSURE GASKET AIR CLEANER 9 0A76 CARB. REWORK 4.L SCREW HHC /8-6 X G5 07 WASHER LOCK / GASKET CARBURETOR 0 SCREW HHC 5/6- X -/4 G5 4 0A40 ADAPTOR CARBURETOR W/INLET GASKET CARBURETOR ADAPTOR 6 0A644 BARBED ELBOW 90 DEG /8 NPT X /8 7 0A4 VALVE PCV HOSE /8 ID SINGLE BRAID (0") NUT HEX /4-8 STEEL WASHER LOCK M6-/4 4 0A576 ARM THROTTLE-REWORK BALL JOINT PLA.5-8 Generac Power Systems, Inc. 5
24 (Model No , & ) 4.L Nat. Gas Fuel System Drawing No. 0E 8 9 ATTACH TO FAN SCROLL ASSEMBLY P/N 0D TO INTAKE MANIFOLD 8 TO VALVE COVER Generac Power Systems, Inc.
25 (Model No , & ) 4.L Nat. Gas Fuel System Drawing No. 0E SUPPORT SOLENOID NAT GAS ELBOW 90D /4NPT NIPPLE PIPE /4 NPT X 4.5 BLK IRN 4 0C7598 ASSY NATURAL GAS SOLENOID NIPPLE PIPE /4 NPT X BUSHING REDUCER TO /4 7 0D758 REGULATOR, N/G (R600S) 8 0E05 SUPPORT REGULATOR 9 0C775 BRACKET REGULATOR 4.L BOLT U 5/6- X WASHER FLAT 5/6 ZINC 0 WASHER LOCK M8-5/ SCREW HHC 5/6- X G PLUG STD PIPE /4 STEEL SQ HD 5 0 WASHER FLAT 9/6 ZINC SCREW HHC M4-.0 X 5 G NIPPLE TOE /4 NPT X CLAMP HOSE # HOSE IN ID LP GAS (44"LG) 0 04 WASHER LOCK M NUT HEX M4- G8 YEL CHR 0C780 MACHINING, CARBURETOR ADAPTOR DECAL FUEL INLET LPG NIPPLE CLOSE /4 X P CLAMP VINYL.6 X.486 Z 6** 0A577C SPACER, D.C. ALT. (9MM LONG) 7 0D509 DECAL INLET PRESSURE GASKET AIR CLEANER 9 0C7650A MIXER (EMISSIONS) NATURAL GAS SCREW HHC /8-6 X G5 07 WASHER LOCK /8 0C7059 GASKET GOVERNOR THROTTLE BODY 0 4 SCREW HHC 5/6- X -/4 G5 4 0A40 ADAPTOR CARBURETOR W/INLET GASKET CARBURETOR ADAPTOR 6 0A644 BARBED ELBOW 90 DEG /8 NPT X /8 7 0A4 VALVE PCV HOSE /8 ID SINGLE BRAID (0") 9 0C7060 GASKET CARBURETOR ADAPTOR 40 0D485 ASSY THROTTLE PF4 WIRE CONN WASHER LOCK #0 4 0C SCREW SHC #0- X 5/8 G8.8 NZ 4 0A66 GASKET CARB IMPCO SCREW PHM SEMS #-4 X 5/8 EX NUT HEX 5/6- STEEL SADDLE -/8 **NOT SHOWN Generac Power Systems, Inc. 5
26 (Model No , & ) Exhaust Drawing No. 0E47-A 54 Generac Power Systems, Inc.
27 (Model No , & ) Exhaust Drawing No. 0E47-A 05990A CAP RAIN.50 /.69 0C964 TUBE STRAIGHT 'A' GROUP 0D408 MUFFLER CATALYST 4.L 4 0D506 4 MOUNTING BAND A-GRP CATALYST 5 0C46 BRACKET MUFFLER MOUNTING 6 0D5787 TUBE ELBOW 90 DEG.5" 7 0A55B PIPE FLEX.5" 8 0E0699 TUBE, CROSS OVER 9 0E0698 TUBE, 90 ELBOW 0 0C470 BRACKET EXHAUST SHIELD 0C405 SHIELD A-GRP HEAT 0C454 SCREW TH-FRM M6- X 6 N WA Z/JS 0C4A 4 CLAMP BAND.5" WASHER LOCK M8-5/ WASHER FLAT 5/6 ZINC NUT HEX M8-.5 G8 YEL CHR SCREW HHC M8-.5 X 6 G BOLT U /8-6 X WASHER LOCK /8 04 NUT HEX /8-6 STEEL 0E070 SHIELD, CROSSOVER HEAT 0E0700 SHIELD, EXHAUST HEAT HOSE VACUUM 5/ (6"LG) 5 0D4 KIT AIR/FUEL RATIO CONTROLLER 6 0D45 BRACKET AIR/FUEL CONTROLLER SCREW HHC M6-.0 X G NUT HEX #8- STEEL WASHER LOCK #8-M WASHER FLAT #8 ZINC SCREW PPHM #8- X / 0498 WASHER FLAT M WASHER LOCK M6-/ NUT HEX M6 X.0 G8 YEL CHR 5 0D8780 DECAL IMPORTANT EXHAUST EMISSION INFO WASHER FLAT /8-M0 ZINC *NOTE: COMPONENT INSTALLED AT WAUKESHA FACILITY Generac Power Systems, Inc. 55
28 (Model No. 0047, & 00475) Electronic Governor Drawing No. 0A65-F ASSEMBLY MOTOR STEPPER 0A49 BRACKET GOVERNOR MOUNTING A CONNECTOR INTERFACE ASSEMBLY LEVER STEPPER MOTOR BALL JOINT / NUT HEX /4-8 STEEL 0446 SCREW HHC M6-.0 X 0 G A HOUSING GOVERNOR CONNECT 09894A COVER CONN HOUSING SCREW FHM # X 5/8 SELF TAP WASHER LOCK M6-/ SCREW TAP HWH #6-5 X /8 ZINC 7 09A TIE WRAP 7.4" X." BLACK UL NEOPRENE LIQUID COATING (NOT SHOWN) 0576 NUT HEX M5-0.8 G8 YEL CHR WASHER LOCK M SCREW PPHM M5-0.8 X ASSEMBLY L.C. ELECTRONIC GOVERNOR NUT HEX /4-8 STEEL 4 0C4 STUD THR /4-8 X -/ G ZINC 56 Generac Power Systems, Inc.
29 Engine Coolant Heater Drawing No. 0E5 TO THERMOSTAT HOUSING 6 7 TO ENGINE BLOCK **0C4905 BARBED EL 45 FITTING **0578 CLAMP HOSE # **07704E CONDUIT FLEX " BLACK (5"LG) 4 ** HOSE 5/8 ID RIA 50F (46"LG) 5 0A68 HOSE PREFORMED BLOCK HEATER CLAMP HOSE # BARBED STR /4 NPT X 5/ SCREW HHC M6-.0 X 0 G WASHER FLAT /4-M6 ZINC A HEATER ENG 000W 0V *0849B HEATER BLOCK 000W 40V BRACKET HEATER W/WELDNUTS WASHER LOCK M6-/ NUT HEX M6 X.0 G8 YEL CHR D CLAMP VINYL.06 X.406 Z (NOT SHOWN) A CONDUIT FLEX.8 ID (4"LG) (NOT SHOWN) (USED ON HEATER CORD) *USED ON 50HZ VOLTAGE GENERATORS ONLY. **USED ON NATURAL GAS & L/P VAPOR UNITS ONLY. Generac Power Systems, Inc. 57
POWER SYSTEMS, INC. Not intended for use in critical life support applications.!
POWER SYSTEMS, INC. Owner s Manual Liquid-cooled, Prepackaged Standby Generators Models: 004373-6 (40 kw/single-phase w/ 00 Amp Transfer Switch) 00466-5 (40 kw/single-phase w/ 00 Amp Transfer Switch California
DANGER ONLY QUALIFIED ELECTRICIANS OR CONTRACTORS SHOULD ATTEMPT INSTALLATION!!
POWER SYSTEMS, INC. Owner s Manual Liquid-cooled, Prepackaged Standby Generators *This Manual Should Remain With The Unit* Models: 00- (0 kw/single-phase w/ 00 Amp Transfer Switch) 00- (0 kw/single-phase
To Oil Drain On Oil Pan.
Guardian Liquid-cooled kw Generators Mounting Base - Drawing No. E97-A 7 8 8 7 7 RED 9 9 8 9 8 9 TO STARTER SOLENOID 7 8 8 9 To Oil Drain On Oil Pan. 7 7 Generac Power Systems, Inc. Section 7 Exploded
1 098671 1 ASSY ROTOR 10KW 098681 1 ASSY ROTOR 15KW 098675 1 ASSY ROTOR 20KW 098936 1 ASSY ROTOR 25KW 2 0A5336A 1 HOUSING BLOWER 3 0A1659 1 SCREEN AIR OUTLET 4 071912 4 SCREW PPHM M5-0.8 X 8 SS 5 049226
BREAKER TRAY BACK/BOTTOM
1 0F7135 1 BREAKER TRAY BACK/BOTTOM 2 0F7022 1 SUPPORT CONTROL PANEL SIDE RH 3 0F7021 1 SUPPORT CONTROL PANEL SIDE LH 4 0F7260 1 COVER CIRCUIT BREAKER 2P 0F7136 1 COVER CIRCUIT BREAKER 3P 5 0F6156 1 PLATE
BREAKER TRAY BACK/BOTTOM
1 0F7135 1 BREAKER TRAY BACK/BOTTOM 2 0F7022 1 SUPPORT CONTROL PANEL SIDE RH 3 0F7021 1 SUPPORT CONTROL PANEL SIDE LH 4 0F7260 1 COVER CIRCUIT BREAKER 2P 0F7136 1 COVER CIRCUIT BREAKER 3P 5 0F6156 1 PLATE
ONLY QUALIFIED ELECTRICIANS OR CONTRACTORS SHOULD ATTEMPT INSTALLATION!!
POWER SYSTEMS, INC. Owner s Manual Liquid-cooled, Prepackaged Standby Generators Model Numbers (Natural Gas) 004090-2 004091-2 004092-2 004093-2 004094-2 004095-2 004096-2 004097-2 004474-0 (w/ts) (Liquid
ITEM PART NO. QTY. DESCRIPTION ITEM PART NO. QTY. DESCRIPTION
Exploded View Enclosure (15 and 20 kw) Drawing No. 0A7188-D ITEM PART NO. QTY. DESCRIPTION 1 97575 2 BRACE, SIDE 2 A3769 2 DOOR, ENCLOSURE 3 A3768 1 DOOR, ENCLOSURE 4 A5314 1 TOP, ENCLOSURE 5 67042 2 LATCH
1 0F BREAKER TRAY BACK/BOTTOM 2 0F SUPPORT CONTROL PANEL SIDE RH 3 0F SUPPORT CONTROL PANEL SIDE LH 4 0F COVER CIRCUIT
1 0F7135 1 BREAKER TRAY BACK/BOTTOM 2 0F7022 1 SUPPORT CONTROL PANEL SIDE RH 3 0F7021 1 SUPPORT CONTROL PANEL SIDE LH 4 0F7260 1 COVER CIRCUIT BREAKER 2P 0F7136 1 COVER CIRCUIT BREAKER 3P 5 0F6156 1 PLATE
BREAKER TRAY BACK/BOTTOM
1 0F7135 1 BREAKER TRAY BACK/BOTTOM 2 0F7022 1 SUPPORT CONTROL PANEL SIDE RH 3 0F7021 1 SUPPORT CONTROL PANEL SIDE LH 4 0F7260 1 COVER CIRCUIT BREAKER 2P 0F7136 1 COVER CIRCUIT BREAKER 3P 5 0F6156 1 PLATE
ONLY QUALIFIED ELECTRICIANS OR CONTRACTORS SHOULD ATTEMPT INSTALLATION!!
Owner s Manual Liquid-cooled, Prepackaged Standby Generators Model Nos. 00992-0 00992-1 37kW NG, 0kW LP This manual should remain with the unit. ONLY QUALIFIED ELECTRICIANS OR CONTRACTORS SHOULD ATTEMPT
28 Generac Power Systems, Inc. ENGINE BLOCK REAR BEARING CARRIER STARTER BOLT STARTER CONTACTOR HARNESS WIRE TO ENGINE MOUNT
Mounting Base Drawing No. 0E808-A 16 12 13 3 9 35 18 8 36 3 2 3 2 TO ENGINE MOUNT 5 6 7 3 19 16 0 3 35 27 30 16 36 1 18 38 33 18 32 27 22 TO ENGINE BLOCK TO STARTER BOLT TO 31 STARTER CONTACTOR 20 2 20
ONLY QUALIFIED ELECTRICIANS OR CONTRACTORS SHOULD ATTEMPT INSTALLATION!!
Owner s Manual Liquid-cooled, Prepackaged Standby Generators Model Number 00030-0 (1kW) 00028-0 (kw) 00031-0 (2kW) This manual should remain with the unit. ONLY QUALIFIED ELECTRICIANS OR CONTRACTORS SHOULD
CONNECTION BOX 390 SHORT H
1 0F1855 1 CONNECTION BOX 390 H 0F4430 1 CONNECTION BOX 390 SHORT H 2 042568 10 SCREW HHC M6-1.0 X 20 G8.8 3 022473 12 WASHER FLAT 1/4-M6 ZINC 4 022097 10 WASHER LOCK M6-1/4 5 049813 8 NUT HEX M6 X 1.0
ENGINE BLOCK REAR BEARING CARRIER STARTER BOLT STARTER CONTACTOR HARNESS WIRE TO ENGINE MOUNT
0kW Liquid-cooled Generators Mounting Base Drawing No. 0E808-C 2 12 3 9 35 8 3 36 35 2 3 2 ENGINE MOUNT 5 6 7 3 0 3 35 39 27 28 30 36 1 38 33 32 27 22 ENGINE BLOCK STARTER BOLT 31 STARTER CONTACR 37 21
ONLY QUALIFIED ELECTRICIANS OR CONTRACTORS SHOULD ATTEMPT INSTALLATION!!
Owner s Manual Liquid-cooled, Prepackaged Standby Generators Model Nos. 0099-37kW NG, 0kW LP This manual should remain with the unit. ONLY QUALIFIED ELECTRICIANS OR CONTRACRS SHOULD ATTEMPT INSTALLATION!!
G WASHER LOCK M6-1/4
1 0F3137 1 PAN CB CONN BOX 2 0F3188 1 STAND RH CONTROL 3 0F3189 1 STAND LH CONTROL 4 023484N 1 BUSHING SNAP SB-2.5-31 5 *** 0F6366B 1 / 2 XFMR DUAL 120V/16V (FOR 120/240V & 277/480V UNITS) 0F6366A 1 XFMR
3) UL CIRCUIT BREAKER (JD+LD) A 0F COVER JD/LD CB SHRT STAND B DECAL DANGER HIGH VOLTAGE
1 0F3137 1 PAN CB CONN BOX 2 0F3188 1 STAND RH CONTROL 3 0F3189 1 STAND LH CONTROL 4 023484N 1 BUSHING SNAP SB-2.5-31 (3) 5 0F6366B 1 / 2 XFMR DUAL 120V/16V (FOR 120/240V & 277/480V UNITS) 0F6366A 1 XFMR
Commercial-Industrial-Residential Portable Generator System. GT-990 & GT-760 Engine (Page 1) Drawing No. 0E8589E
24 Section 7 Exploded Views and Parts Lists GT-990 & GT-760 Engine (Page 1) Drawing No. 0E8589E Section 7 Exploded Views and Parts Lists GT-990 & GT-760 Engine (Page 1) Drawing No. 0E8589E ITEM PART #
ONLY QUALIFIED ELECTRICIANS OR CONTRACTORS SHOULD ATTEMPT INSTALLATION!
Serial Number QT 3.9L 40kW Model: 005222-0 STANDBY GENERATOR OWNER'S MANUAL A new standard of reliability CAUTION ONLY QUALIFIED ELECTRICIANS OR CONTRACTORS SHOULD ATTEMPT INSTALLATION! This manual should
Section 9 - Exploded Views and Parts Guardian Liquid-cooled 15 kw, 20 kw and 25 kw Generators Governor Assembly Drawing No.
Guardian Liquid-cooled kw, kw and kw Generators Governor Assembly Drawing No. E-B ITEM () NEOPRENE COATING WIRE HARNESS SECURE WIRE HARNESS WITH TIE WRAP AS SHOWN. "A" TO "A" CARBURETOR ARM (REF.) INTAKE
EXPLODED VIEW BASE AND PULLEYS Drawing No
Generac NP-50LPG EXPLODED VIEW BASE AND PULLEYS Drawing No. 95865 20 Generac NP-50LPG REPAIR PARTS BASE AND PULLEYS Drawing No. 95865 ITEM DESCRIPTION PART NO. QTY. ITEM DESCRIPTION PART NO. QTY. 1 BASE,
Section 6 Exploded Views and Parts Lists PRIMEPACT 50 Recreational Vehicle Generator Regulator (Model ) Drawing No.
Regulator (Model 0010-) Drawing No. 0F5-C 5 6 7 1 30 10 9 9 1 16 13 14 17 1 15 19 1 0 3 4 5 6 7 40 Generac Power Systems, Inc. Regulator (Model 0010-) Drawing No. 0F5-C 1 0D5694 1 CASTING, TWIN REGULATOR
Section 10 Exploded Views and Parts Lists
Sheet Metal Drawing No. 0D3150-A 40 Generac Power Systems, Inc. Sheet Metal Drawing No. 0D3150-A 1 --------- 1 SEE ENGINE EXPLODED VIEW of ENGINE 2 099258 1 KEY-WOODRUFF 6 x 22MM 3 067198N 1 BEVELLED WASHER
Section 10 Exploded Views and Parts Lists
Sheet Metal Drawing No. D3-A Generac Power Systems, Inc. Sheet Metal Drawing No. D3-A 1 --------- 1 SEE ENGINE EXPLODED VIEW of ENGINE 9958 1 KEY-WOODRUFF x MM 3 7198N 1 BEVELLED WASHER 789 1 HEX NUT 5
Section 9 Exploded Views and Parts Lists QUIETPACT 50 and 70 Recreational Vehicle Generators Control Panel Drawing No. 0E1701
QUIETPACT 0 and 0 Recreational Vehicle Generators Control Panel Drawing No. 0E101 1 9 11 1 9 10 1 1 1 1 1 1 19 0 0 1 9 0 1 9 0 1 0 9 9 9 0 1 1 Generac Power Systems, Inc. QUIETPACT 0 and 0 Recreational
Appendix 4 Exploded Views and Parts Lists
Enclosure Drawing No. 0D8-F 7 0 4 4 4 6 8 4 7 4 6 44 4 46 8 7 6 47 4 8 0 4 0 8 6 6 4 0 4 7 4 40 TO CARB 4 8 Generac Power Systems, Inc. Enclosure Drawing No. 0D8-F 0D68 TRAY, ENCLOSURE 0D64 PANEL, ENCLOSURE
Appendix 3 Exploded Views and Parts Lists
Engine, Alternator Drive and Starter Assembly Drawing No. 0D5057-A 40 Generac Power Systems, Inc. Engine, Alternator Drive and Starter Assembly Drawing No. 0D5057-A 1 0C5598 1 BEARING CARRIER, FRONT 2
Appendix 4 Exploded Views & Parts Lists. 34 Generac Power Systems, Inc.
Appendix Exploded Views & Parts Lists CENTURION Home Standby Generator Enclosure - Drawing No. E 7 8 7 7 8 7 8 8 7 Generac Power Systems, Inc. Appendix Exploded Views & Parts Lists CENTURION Home Standby
Section 6 Exploded Views and Parts Lists. 42 Generac Power Systems, Inc.
Control Panel Drawing No. 0D4946-A 42 Generac Power Systems, Inc. Control Panel Drawing No. 0D4946-A 1 091526 7 M5-0.8 X 12MM PHILLIPS PAN HD. MACH. SCR. 2 020093 1 BOX, CONTROL TOP 3 0D4226 1 BOX, CONTROL
60 0F ASSY SCROLL 390 X 60MM CPL
1 0F9952 1 ASSY ROTOR 2390 80KB3 CPL 0F3417 1 ASSY ROTOR 390 2P 100K BRSHLS 0F2984 1 ASSY ROTOR 390 2P 150K BRSHLS 2 0F9949 1 ASSY STATOR 80KW 1PH 2P BRSHLS 0F3418 1 ASSY STATOR 390 2P 100K BRSHLS 0F2985
Section 7 Exploded Views and Parts Lists IMPACT-36 plus II Recreational Vehicle Generator Control Panel Drawing No. 0E7560
Control Panel Drawing No. 0E760 10 7 4 8 6 6 49 44 47 8 9 1 1 11 9 40 41 41 8 9 14 1 1 19 6 19 9 1 1 1 4 7 6 14 46 16 17 4 7 8 0 7 0 10 4 4 4 48 0 1 40 Generac Power Systems, Inc. Control Panel Drawing
Section 7 Exploded Views and Parts Lists. 40 Generac Power Systems, Inc.
Control Panel Drawing No. 0E7560 50 10 7 4 8 6 6 49 5 44 47 8 9 1 1 11 9 5 40 41 41 8 9 14 15 1 19 6 19 9 1 1 1 5 4 7 6 14 46 16 17 4 7 8 0 7 0 10 4 45 4 48 51 40 Generac Power Systems, Inc. Control Panel
60 0F ASSY SCROLL 390 X 60MM CPL
1 0F9952 1 ASSY ROTOR 2390 80KB3 CPL 0F3417 1 ASSY ROTOR 390 2P 100K BRSHLS 0F2984 1 ASSY ROTOR 390 2P 150K BRSHLS 2 0F9949 1 ASSY STATOR 80KW 1PH 2P BRSHLS 0F3418 1 ASSY STATOR 390 2P 100K BRSHLS 0F2985
Appendix 4 Exploded Views and Parts Lists PRIMEPACT 50 Recreational Vehicle Generator Base and Pulleys (Model ) Drawing No.
Base and Pulleys (Model 02010-0) Drawing No. A8924-B 42 Generac Power Systems, Inc. Base and Pulleys (Model 02010-0) Drawing No. A8924-B 1 C2368 1 BASE, MOUNTING 2 53407 1 GROUND CABLE 3 46911 4 MOUNT,
H NUT HEX 1/4-20 STEEL
1 0F3137 1 PAN CB CONN BOX 2 0F3188 1 STAND RH CONTROL 3 0F3189 1 STAND LH CONTROL 4 023484N 1 BUSHING SNAP SB-2.5-31 5 0F6366B 1 XFMR DUAL 120V/16V (F OR 120/240V & 277/480V UNITS) 0F6366A 1 XFMR DUAL
Section 6 Exploded Views and Parts Lists IMPACT-36 plus II Recreational Vehicle Generator Control Panel Drawing No. 0E7560
Control Panel Drawing No. 0E0 3 3 3 0 3 0 3 3 3 3 30 3 0 0 33 3 0 3 Generac Power Systems, Inc. 0 Control Panel Drawing No. 0E0 0 M-0. X MM PHILLIPS PAN HD. MACH. SCR. 0003 BOX, CONTROL TOP 3 0E BOX, CONTROL
(1) SUPPLIED WITH ENGINE. (2) APPLY MEDIUM STRENGTH BLUE THREAD LOCKING FLUID TO THE THREADS.
1 0G0408A 1 ENGINE 2.4L G2 0H1619 1 ENGINE 2.4L G2 CERTIFIED 2 046526 6 WASHER LOCK M10 3 039414 4 SCREW HHC M8-1.25 X 35 G8.8 4 0G0149 1 SCREW SHC M14-1.5 X 35 G10.9 5 0E9868A 1 ALTERNATOR DC W/OUT PULLEY
Installation and Owner s Manual
R R Installation and Owner s Manual Air-cooled, Prepackaged Automatic Standby Generators Models: 04389-2 ( kw NG, 7 kw LP) 0445-2 (2 kw NG, 2 kw LP) 04390-2 (3 kw NG, 5 kw LP) GENERAC POWER SYSTEMS, INC.
Home Generator Systems. Illustrated Parts List. Model Rated Watts Home Generator System. Manual No A Rev.
Home Generator Systems Model 01815 12000 Rated Watts Home Generator System Manual No. 193205A Rev. L (05/19/2008) UNIT SCHEMATIC DIAGRAM Copyright 2008 Briggs & Stratton Power Products Group, LLC. All
Installation and Owner s Manual
R R Installation and Owner s Manual Air-cooled Automatic Standby Generators Models: 04758-0 ( kw NG, 7 kw LP) 04759-0 (2 kw NG, 2 kw LP) 0470-0 ( kw NG, 5 kw LP) GENERAC POWER SYSTEMS, INC. Not intended
GROUP D EXPLODED VIEW: ENGINE COMMON PRT 2.4L G2 TURBO 36K DRAWING #: 0H7321 APPLICABLE TO: ITEM PART# QTY. DESCRIPTION
EXPLODED VIEW: ENGINE COMMON PRT 2.4L G2 TURBO 36K DRAWING #: 0H7321 APPLICABLE TO: ITEM PART# QTY. DESCRIPTION 1 0H1619 1 ENGINE 2.4L G2 CERTIFIED 2 046526 6 WASHER LOCK M10 3 039414 4 SCREW HHC M8-1.25
ONLY QUALIFIED ELECTRICIANS OR CONTRACTORS SHOULD ATTEMPT INSTALLATION!!
Owner s Manual Liquid-cooled, Prepackaged Standby Generators Model Number: 00988-7kW NG, 0kW LP Vapor This manual should remain with the unit. ONLY QUALIFIED ELECTRICIANS OR CONTRACTORS SHOULD ATTEMPT
GTV990 Engine Parts Manual. Model: , 1
GTV990 Engine Parts Manual Model: 0009-0, GTV990 OHVI SERIES ENGINE Model 0009-0, Carburetor and Air Intake Drawing 0F0B-F 0 0 9 "A" 9 9 0 "B" 9 0 REF "A" (0E) (0E) 9 0 TO VALVE COVER 9 "B" 9 Model 0009-0,
GROUP A EXPLODED VIEW: EV CONNECTION BOX C1 CPL DRAWING #: 0K7578
PAGE 1 1 056739 1 RELAY SOLENOID 12VDC PNL MNT 2 022097 1 WASHER LOCK M6-1/4 3 022264 4 WASHER LOCK #8-M4 4 022241 2 NUT HEX 3/8-16 STEEL 5 0G3111 1 SCREW HHTT M6-1.0 X 25 ZINC 6 022155 2 WASHER LOCK #6
G WASHER LOCK M6-1/4
1 0F3137 1 PAN CB CONN BOX 2 0F3188 1 STAND RH CONTROL 3 0F3189 1 STAND LH CONTROL 4 023484N 1 BUSHING SNAP SB-2.5-31 5 *** 0F6366B 1 / 2 XFMR DUAL 120V/16V (FOR 120/240V & 277/480V UNITS) 0F6366A 1 XFMR
GROUP D EXPLODED VIEW: EV ENGCOMPRT 2.4L G2 TURBO 60K DRAWING #:0K8908 APPLICABLE TO: ITEM PART# QTY. DESCRIPTION
EXPLODED VIEW: EV ENGCOMPRT 2.4L G2 TURBO 60K DRAWING #:0K8908 APPLICABLE TO: GROUP D ITEM PART# QTY. DESCRIPTION 1 0H1619 1 ENGINE 2.4L G2 CERTIFIED 2 035472 1(REF) CLAMP HOSE #6.43-.78 3 052221 1(REF)
Installation and Owner s Manual
R R Installation and Owner s Manual Air-cooled Automatic Standby Generators Models: 0475-2 ( kw NG, 7 kw LP) 04759-2 (2 kw NG, 2 kw LP) 0470-2 ( kw NG, 5 kw LP) GENERAC POWER SYSTEMS, INC. *This manual
ASSEMBLY, CRANKCASE HOUSING WITH SLEEVE
1 0C5729 1 ASSEMBLY, CRANKCASE HOUSING WITH SLEEVE 2 0E9843 1 SEAL, 38 I.D. CRANKSHAFT 3 090388 3 SCREW, TAPTITE M6-1.0 X 12 YC 4 0C5372 1 ASSEMBLY, BREATHER 5 0C3005 1 GASKET, BREATHER COVER 6 0E3372B
ASSY, CRANKCASE WITH SLEEVE
1 0G7908A 1 ASSY, CRANKCASE WITH SLEEVE 2 0E9843A 1 SEAL, 38 I.D. CRANKSHAFT GREEN 3 0G0919 5 SCREW, HHFCS M6-1.0 X 12 G8.8 4 0G9100 1 ASSEMBLY, BREATHER DUAL BREATHER 5 0C3005 1 GASKET, BREATHER COVER
N/A N/A UL BREAKER BQ2
1 N/A N/A UL BREAKER BQ2 A 0D5543 1 CB 0090A 2P 240V S BQ2 LL 0D5544 1 CB 0100A 2P 240V S BQ2 LL 0A2077 1 CB 0125A 2P 240V S BQ2 LL B 0G4499 1 CB COVER 20-25K 1P (BQ2) C 0G9708 2 SCREW PHTT M4-0.7 X 8
GTV990 Engine Parts Manual. Model:
GTV990 Engine Parts Manual Model: 0000-0 GTV990 OHVI SERIES ENGINE Model 0000-0 Carburetor and Air Intake 1 1 1 1 1 10 9 "A" 1 11 1 1 0 "B" 0 1 REF 9 0 "A" 1 "A" (0E) (0E) 0 TO VALVE COVER 0 "B" 9 1 Model
Section 9 Exploded Views and Parts Lists Recreational Vehicle Generators Control Panel Drawing No. 0E1701
Control Panel Drawing No. E 9 9 9,9 9 9 9 9 9 Control Panel Drawing No. E ITEM PART NO. QTY. DESCRIPTION C SCREW HHC M-. X 9 G. WASHER FLAT /-M ZINC 99 TENSION SPRING WASHER, SPRING CENTER NUT LOCK FL
EXPLODED VIEW: EV CONBOX C2 CPL DRAWING #: 0J8319
PAGE 1 1 0J8300 1 BACK PANEL CONBOX SUPPORT C2 2 0H6265 1 TOP PANEL CONBOX SUPPORT C2 3 0H6160 1 COVER WIRE ENTRY CONBOX 4 057073 2 JUNCTION BLOCK 3/8-16 5 056739 1 RELAY SOLENOID 12VDC PNL MNT (6)6 0H67330ST0R
(1) NOTE: PART OF ENGINE MAKE P/N 0F3902. (2) NOTE: I/N 5 IS PART OF I/N 2. (3) NOTE: I/N 55 IS FOR HOLDING SENSOR TO I/N 50. (4) NOTE: NOT SHOWN
(1) 1 0F3883 1 TUBE HEATER WATER (1) 2 0F1960 1 ENGINE 5.4L FORD 3 0F2842 8 IGNITION COIL ASSY FORD 4 0F2843 1 GASKET THERMOSTAT HOUSING FORD (2) 5 0D5419 1 OIL FILTER FORD V-10 ENGINE (1) 6 0F2849 1 TUBE
This parts list is current as of the above revision date. See for the current revision.
15S-25B Parts List This parts list is current as of the above revision date. See http://www.rheempartslists.net/.pdf for the current revision. Standby Generators Table of Contents Model Explanation...................................................................
Installation and Owner s Manual
Installation and Owner s Manual 7, 10, 13 and 16kW Air-cooled, Automatic Standby Generators C US LISTED Models: 005240, 005280 (6 kw NG, 7 kw LP) 005241, 005281 (9 kw NG, 10 kw LP) 005242, 005282 (13 kw
This parts list is current as of the above revision date. See for the current revision.
NG-LP Parts List This parts list is current as of the above revision date. See http://www.rheempartslists.net/.pdf for the current revision. Standby Generators Table of Contents Model Explanation...................................................................
ITEM PART # EST. WT. FINAL WT. ALL DIMENSIONS AND TOLERANCING PER ASME Y14.5M-1994 UNLESS OTHERWISE SPECIFIED : ALL XX DIM. --- ALL XX.XX DIM.
39 38 33 36 35 34 34 24 62 27, 28, 29 63 3, 33, 34, 35, 36, 40, 62 64 2, 5, 19, 20, 32, 39, 40, 44, 47, 101, 148, 165, 167 65 8, 11, 12, 13 66 4, 5, 6, 55 67 16A, 16B, 17, 18 68 7, 22, 32, 44, 47, 48,
Illustrated Parts List MODEL Reproduction. Not for. 48,000 Watt Home Generator System
Illustrated Parts List MODEL 076035-0 48,000 Watt Home Generator System Rev. A 4/14/2011 Table Of Contents PRODUCT COMPONENTS Main Unit... 4 Alternator... 6 Control Panel... 7 Enclosure... 8 Engine -
Section 7 Exploded Views and Parts Lists
Guardian Air-cooled 7 kw, kw and kw Generators Enclosure Drawing No. D-R PRE PACKAGED UNITS ONLY 8 8 85 77 8 7 8 8 8 7 9 79 8 8 87 8 7 5 7 7 5 7 9 9 75 55 8 9 7 8 5 9 9 5 57 7 9 88 5 5 5 5 9 9 7 9 8 5
GROUP E EXPLODED VIEW: EV FUEL SYSTEM 2.4L G2 DRAWING #: 0G1151 ITEM PART# QTY. DESCRIPTION
EXPLODED VIEW: EV FUEL SYSTEM 2.4L G2 DRAWING #: 0G1151 GROUP E ITEM PART# QTY. DESCRIPTION 1 026915 2 NIPPLE CLOSE 3/4 X 1.375 2 075580 1 FLANGE FUEL INLET 3 0F6390C 1 REGULATOR ASSY 2.4L (25KW) 0F6390B
C15 D5 and D6 (PCC1300 and 1301) CONTENTS
CONTENTS 0100-3920 Engine Accessories (Denso... 5 Radiator) 0100-4025 Engine Accessories (SRF Radiator)... 7 0179-3766 Battery Charger Instl... 9 0179-3771 Miniature Circuit Breaker Instl... 11 0179-3772
Genset. Parts Catalog GHAB. Parts Manual
Genset Parts Manual Parts Catalog To avoid errors or delay in filling your parts order, always give the MODEL, SPEC NO. and SERIAL NO. from the Onan nameplate. For handy reference, insert your nameplate
Parts Manual. RV Generator Set. HDCAA (Spec A D) HDCAB (Spec A D) English Original Instructions (Issue 9)
Parts Manual RV Generator Set HDCAA (Spec A D) HDCAB (Spec A D) English Original Instructions 0-0 9 09 (Issue 9) Introduction This parts catalog applies to the standard generator sets listed below. Parts
This parts list is current as of the above revision date. See for the current revision.
12S-20B Parts List This parts list is current as of the above revision date. See http://www.rheempartslists.net/.pdf for the current revision. Standby Generators Table of Contents Model Explanation...................................................................
1 0G ASSY CRANKCASE WITH SLEEV E
1 0G8548 1 ASSY CRANKCASE WITH SLEEV E 2 0E9843A 1 SEAL, 38 I.D. CRANKSHAFT GREEN 3 0G0919 5 SCREW HHFCS M6-1.0 X 12 G8.8 4 0G9100 1 ASSE MBLY, BREATHER DUAL V ALVE 5 0C3005 1 GASKET, BREATHER COVER 6
C11 D5 and D6 GENSET (PCC0300) CONTENTS
CONTENTS 0100-3984 Engine Accessories (Denso Rad)... 5 0100-4024 Engine Accessories (SRF Rad)... 7 0179-3766 Battery Charger Instl... 9 0179-3771 Miniature Circuit Breaker Instl... 11 0179-3772 Circuit
FORD - Cyl Block and Related Parts
FORD - Cyl Block and Related Parts Ref Description Qty All 302 Qty 351 Qty 351-HP 1 BLOCK ASSEMBLY 1 59-4046 1 59-4047 1 59-4047 2 PLUG - 1½ CUP - BRASS 6 59-4048 6 59-4048 6 59-4048 3 PLUG - OIL PASSAGE
CLASSIC EDGER FIXED FRAME 1/21/13
CLASSIC EDGER FIXED FRAME 30095 STONEKOR LLC -800-633-059 customerservice@stonekor.com www.stonekor.com CLASSIC EDGER FIXED FRAME DECK SUB ASSEMBLY 4 9 4 5 3 6 7 4 0 6 3 33 0 9 3 5 3 8 30 9 8 6 8 7 7 5
14A6816H190 GT-2150 (2003) Page 1 of 28 Carburetor
14A6816H190 GT-2150 (2003) Page 1 of 28 Carburetor 14A6816H190 GT-2150 (2003) Page 2 of 28 Carburetor TC-640221 1 /P Carburetor (Incl 184 of Engine Parts Lists) 1 TC-640216 1 Throttle Shaft & Lever Assembly
Section 8 Exploded Views and Parts Lists
Enclosure Drawing No. F8-B PRE PACKAGED UNITS ONLY 8 8 77 7 8 8 7 9 79 8 87 8 7 5 7 7 5 9 97 9 75 55 8 9 5 9 7 5 8 9 9 5 5 9 5 9 9 57 7 5 5 5 7 5 5 5 9 9 7 9 5 9 8 5 5 5 9 9 7 9 8 Generac Power Systems,
Illustrated Parts List. Reproduction MODEL Not for. 45,000 Watt Liquid Cooled Home Generator System
Illustrated Parts List MODEL 076031-0 45,000 Watt Liquid Cooled Home Generator System Manual Part No. Revision A Rev. Date: 4/14/2011 Table Of Contents PRODUCT COMPONENTS Main Unit... 4 Alternator...
Haram Captor CR ENGINE SYSTEMS PARTS LIST Nilfisk MODEL /04 revised 10/06 FORM NO BOOK E SECTION
Haram Captor CR 1400 ENGINE SYSTEMS PARTS LIST Nilfisk MODEL 56307000 8/04 revised 10/06 SECTION 15.9.1 04-8 TABLE OF CONTENTS Haram Captor CR 1400 Engine Systems E 15.9.1 1 DESCRIPTION Page Gasoline
Manual Transfer Switch with Load Center Drawing No. 0G0939-B
Manual Transfer Switch with Load Center Drawing No. G99-B Manual Transfer Switch with Load Center Drawing No. G99-B 1 G9 1 BOX LOAD CENTER W/HARDWARE G8 1 CIRCUIT BREAKER INTERLOCK E888 1 CIRCUIT BREAKER
Section 8 Exploded Views and Parts Lists Air-cooled 7 kw, 12 kw and 15 kw Generators Enclosure Drawing No. 0F0080-C
Air-cooled 7 kw, kw and kw Generators Enclosure Drawing No. F8-C PRE PACKAGED UNITS ONLY 8 8 77 7 8 8 7 9 79 8 87 8 7 5 7 99 98 5 9 3 97 9 75 3 55 8 9 35 9 7 5 8 9 3 9 5 5 9 35 9 9 57 7 5 5 5 7 5 35 5
GROUP D EXPLODED VIEW: EV ENGINE COMMON PARTS 5.4L C2 DRAWING #: 0K6527
EXPLODED VIEW: EV ENGINE COMMON PARTS 5.4L C2 DRAWING #: 0K6527 GROUP D ITEM PART# QTY. DESCRIPTION PAGE 1 1 0D9913 16 SCREW SHC M8-1.25 X 35 SS 2 0G7461 1 STARTER MOTOR 12V 3 0F3514 1 SPACER FLEXPLATE
STX-26 Stump Grinder
Form No. 3365-311 Rev B STX-26 Stump Grinder Model No. 23210 Serial No. 310000001 and Up Model No. 23210G Serial No. 310000001 and Up Register at www.toro.com. Original Instructions (EN) *3365-311* B Ordering
STX-26 Stump Grinder
Form No. 3383-656 Rev B STX-26 Stump Grinder Model No. 23208 Serial No. 314000001 and Up Model No. 23208G Serial No. 314000001 and Up Register at www.toro.com. Original Instructions (EN) *3383-656* B Ordering
SECTION 6 PARTS LIST
SECTION FIGURE NO. DESCRIPTION PAGE NO. -1 - - -4-5 - - -8-9 Oven Panels, Window and Legs Exploded Drawing Air Finger Exploded Drawing Control Panel Exploded Drawing Blower and Shroud Exploded Drawing
Section 7 Exploded Views and Parts Lists Guardian Air-cooled 7 kw, 12 kw and 15 kw Generators Enclosure Drawing No. 0D3416-K
Enclosure Drawing No. D-K 85 77 8 8 8 78 8 79 8 7 8 8 8 7 5 87 7 7 5 7 5 A 7 9 8 7 9 9 75 55 5 8 9 5 9 7 9 A 7 7 5 9 8 5 5 8 5 5 9 8 5 5 5 9 8 5 57 9 5 5 9 7 5 7 5 9 58 59 9 9 89 8 9 5 9 9 5 7 7 58 7 9
EX40 16ST, EX40 18LX. Parts List Models: (EX40 16ST), (EX40 18LX) Form No /2015 revised 1/2018 REV F
EX40 16ST, EX40 18LX Parts List Models: 56265504 (EX40 16ST), 56265505 (EX40 18LX) Form No. 56042643 7/2015 revised 1/2018 REV F revised 6/2017 PARTS LIST TABLE OF CONTENTS DESCRIPTION PAGE Base System...
Craftsman Snow Thrower Model PARTS LIST
Craftsman Snow Thrower Model 24.88955 11 13 3 26 24 9 1 18 54 6 25 15 20 23 16 5 14 1 55 9 4 4 28 8 30 2 5 56 35 36 46 3 39 50 53 43 38 48 52 42 51 41 40 49 4 44 31 45 31 21 29 34 9 19 10 32 22 26 Craftsman
Air Intake/Filtration
Air Intake/Filtration Air Intake/Filtration Ref # Part Description Qty 25 048 -S CLEANER, AIR-CANISTER (includes 2-8) 2 25 096 06-S COVER ASSMBLY,AIR CLEANER (includes 3,4) 3 24 462 07-S VALVE, DUST EJECTOR
8/6/2013 LX-30 MACHINES: COPYRIGHT 6/10/10 ALL RIGHTS RESERVED
LX-0 MACHINES: 00 000 STONEKOR LLC -800-6-09 customerservice@stonekor.com www.stonekor.com PAGE LX-0 GRINDER DECK SUB ASSEMBLY 0 6 7 7 9 8 8 9 8 7 6 0 9 7 8 6 7 6 8 0 6 0 PAGE LX-0 GRINDER DECK SUB ASSEMBLY
CATALOG OF REPLACEMENT PARTS
CATALOG OF REPLACEMENT PARTS OV310G MINI RACK OVEN ML-132515 OV310G A product of BAXTER MFG. CO., INC. 19220 STATE ROUTE 162 EAST, ORTING, WA 98360 FORM 43242 Rev. D (January 2018) F-43242 Rev. D (January
CATALOG OF REPLACEMENT PARTS
CATALOG OF REPLACEMENT PARTS MINI RACK OVEN OV310G ML-132515 A product of BAXTER MFG. CO., INC. 19220 STATE ROUTE 162 EAST, ORTING, WA 98360 FORM 43242 (October 2011) Table of Contents 3 ADVANCED CONTROL
Illustrated Parts List MODEL. Reproduction Not for. 30,000 Watt Liquid Cooled Generator Systems
Illustrated Parts List MODEL 30,000 Watt Liquid Cooled Generator Systems IPL No.1757520 Rev. C 2/11/2016 PRODUCT COMPONENTS Table Of Contents PAGES Main Unit... 4 Alternator... 6 Control Panel... 8 Decals
MODELS: (4800), (4300) (4300 AXP), (4800 AXP)
PARTS LIST Advance MODELS: 56303000 (4800), 56303001 (4300) 56303591 (4300 AXP), 56303592 (4800 AXP) 3/04 revised 3/11 04-3 08-11 TABLE OF CONTENTS DESCRIPTION PAGE Chassis System... 2-3 Chassis System
Z-Force 60 KW 53AA5DBJ Page 1 of 57 Air Filter & Muffler
Z-Force 60 KW 53AA5DBJ Page 1 of 57 Air Filter & Muffler Z-Force 60 KW 53AA5DBJ Page 2 of 57 Air Filter & Muffler Ref # Part Number Qty S/P/F Description 11011 KM-11011-7003 1 S CASE-AIR FILTER 11013 KM-11013-7009
C33 D5 and C30 D6 (PCC1300 and 1301) CONTENTS
CONTENTS 0100-3921 Engine-Accessories... 5 0179-3766 Battery Charger Instl... 7 0179-3771 Miniature Circuit Breaker Instl... 9 0179-3772 Circuit Breaker Instl... 11 0179-3773 Transformer Instl... 13 0179-3782
Retriever 5800G/P/D. revised 2/01 Form Number
Retriever 5800G/P/D PARTS LIST Advance MODELS 56482005, 56482010, 56482015 This parts list is for machines after serial number 221134 All models covered in this manual are OBSOLETE revised 2/01 Form Number
Service Parts 4CCFOZ 4/6.5EFOZ 5CCOZ 5/8EOZ. Marine Generator Sets. Models: TP /05c. Specification Series 126
Service Parts Marine Generator Sets Models: 4CCFOZ 4/6.5EFOZ 5CCOZ 5/8EOZ Specification Series 126 TP-5616 9/05c Description Page Introduction... 3 Numbering System Significance... 3 Illustrations... 3
GP-II 10/16/2013 COPYRIGHT 6/10/10 ALL RIGHTS RESERVED
GP-II PAGE GP II DECK SUB ASSEMBLY 3 8 36 3 2 9 6 29 39 3 22 5 38 3 25 39 30 3 6 33 27 2 27 23 0 20 2 26 35 2 27 2 3 7 28 32 2 37 28 9 2 5 0 7 8 3 39 3 PAGE 2 GP II DECK SUB ASSEMBLY ITEM NO. PART NUMBER
Rev.2.06A www.cmadishmachines.com Table of Contents EST-44 1. PARTS MANUAL... 3 1.1. Initial Parts Kit... 3 1.2. Exploded View Drawings... 4 1.2.1. Cabinet Assembly... 4 1.2.2. Control Box Assembly (3
Mid Size Traction Unit
FORM NO. 3318 701 ProLine Mid Size Traction Unit 18 H.P. Kohler Gear Drive Model No. 30183 790001 & Up Parts Catalog 3318 701 ORDERING REPLACEMENT PARTS To order replacement parts, please supply: the part
ES300 Parts List. 7/2015 REV A Form no Models: (240V)
ES00 Parts List 7/2015 REV A Form no. 56042642 Models: 5626550 (240V) TABLE OF CONTENTS DESCRIPTION PAGE Base System... 2- Decal System... 4-5 Handle System... 6-7 Recovery System... 8-9 Solution System-1...
Parts Catalog. Generator Set TGHAA (Spec A C) Printed in U.S.A. Replaces (Spec A) 1 97
Parts Catalog TGHAA Generator Set Printed in U.S.A. 9 00 (Spec A C) 9 Replaces 9 00 (Spec A) 97 To avoid errors or delay in filling your parts order, always give the MODEL, SPEC NO. and SERIAL NO. from
Parts Manual. Home Standby Generator Set. GNAA (Spec A D) GNAB (Spec A D) GNAC (Spec A D) English Original Instructions (Issue 13)
Parts Manual Home Standby Generator Set GNAA (Spec A D) GNAB (Spec A D) GNAC (Spec A D) English Original Instructions -0 00 (Issue ) Introduction This manual applies to the standard Home Standby Generator
PARTS MANUAL P For Models: NL773LW4 and NL773LW4E.
PARTS MANUAL P773-4 For Models: NL773LW4 and NL773LW4E www.northern-lights.com CALIFORNIA Proposition 65 Warning: Breathing Diesel engine exhaust and some of its constituents are known to the State of