VIRAGE Model #W005197D INT L VIRAGE Model #W005197I Rev. 01. E 2000 Polaris Sales Inc. PARTS MANUAL PN and MICROFICHE PN /00

Transcription

1 VIRAGE Model #W00D INT L VIRAGE Model #W00I Rev. 0 E 000 Polaris Sales Inc. PARTS MANUAL PN and MICROFICHE PN /00

2 TABLE OF CONTENTS VIRAGE W00D and INT L VIRAGE W00I Parts Manual BATTERY BOX... BILGE PUMP... CARBURETOR... COOLING SYSTEM... CRANKCASE... CRANKSHAFT and PISTON... CYLINDER & MANIFOLD... DECALS... DRIVE SYSTEM... B C D E B0 B C B C C C A0 B ELECTRICAL BOX... C- ENGINE AIR INTAKE/HULL AIR INLET... B ENGINE FOGGING SYSTEM... C ENGINE MOUNTING... B EXHAUST SYSTEM... B- FRONT STORAGE COMPARTMENT... A FUEL SYSTEM... A FUEL TANK... A F FUEL/WATER SEPARATOR... C0 H HULL and BODY... A- F M MAGNETO... OIL PUMP... OIL TANK... O P C C A PROPULSION... R B REVERSE... B- SEAT... A SHROUD... A- STARTING MOTOR... C STEERING... B- TOOL KIT WATER INLET S T... W... C B The illustrations used in this Parts Manual are for reference to replacement parts only. This manual is not to be used for assembly.

3 000 VIRAGE WATERCRAFT SPECIFICATIONS CAPACITIES ENGINE Fuel Tank US Gallons (. l) Engine Type Polaris Marine 00 Reserve Fuel Tank N/A Induction Type Case Reed Injection Oil Reservoir Quarts (. l) Exhaust System Water Cooled/Injected CARBURETION Lubrication Oil Type Oil Injection Polaris TC-W or Injection Gas Type Carburetor Type and Number Carburetion Idle Speed Regular Unleaded Octane or Octane Oxygenated -0mm Diaphragm Type 0 0 RPM Number of Cylinders Bore Stroke Displacement Compression Ratio Maximum Power (approx.) mm mm 00cc Effective : HP COOLING Cooling System Type Overheating Warning Water Cooled, Thermostat Pop off Warning Light/RPM Limit Maximum Torque (approx.) RPM Limiter Operation 00 RPM 00 RPM 00 DIMENSIONS Number of Passengers Length, Overall Width, Overall Height, Overall Dry Weight - Persons. (0. cm). ( cm) (.0 cm) 0 lbs. ( kg) Propulsion System Jet Pump Type Transmission Minimum Water Level for Jet Pump Impeller Diameter Impeller Jet Drive Axial Flow, Single Stage Direct Drive feet(0cm). (.0 cm) Blade, Slim Hub Load Limit 00 lbs. ( kg) Hull/Deck Material Deck - FRC, Hull - SMC ELECTRICAL Alternator Output. amps/0 watt at 00 RPM Ignition System CDI Spark Plug Type NGK BPRES Spark Plug Gap.0 (0. mm) Starting System Electric Starter Ignition Timing; RPM Battery V, A Polaris Industries Inc. reserves the right to make changes in design and specifications and/or to make additions or improvements to its products without notice.

4 000 POLARIS VIRAGE PUBLICATION NUMBERS MODEL MODEL # OWNER S MANUAL PARTS MANUAL PARTS MICROFICHE ASSEMBLY INSTRUCTIONS VIRAGE INT L VIRAGE W00D W00I

5 SHROUD VIRAGE W00D and INT L VIRAGE W00I E 000 Polaris Sales Inc A

6 SHROUD VIRAGE W00D and INT L VIRAGE W00I 0 Gauge, MFI, Analog/Digital Gasket, MFI Line, Pitot, Formed End 0 Spring, MFI Mounting Asm., Console Latch 0 Kit - MFI Button Replacement 0 Bezel, MFI, Overlay 0- Lid, Console 0 Spring, Torsion, Console 0 Seal, Console Lid 0 Nut Pad, Console 0 Screw Plate, Hook Screw 0 Washer, Lock Washer, Flat Gasket, Mirror, LH Nut, Hex 00 Cable, Choke 0 Nut, Nylok Washer Gasket, Mirror, RH Asm., Mirror, RH (Incl. ) Asm., Mirror, LH (Incl. ) Nut Bracket, Support, Shroud Bolt Grommet, Deck, Wire Harness 0 Strap, Tool Kit, Lower 0-00 Cover, Wire, Shroud Kit, Tool (See Tool Kit Pg. C) 00 Strap, Tool Kit, Upper 0 Ring, Retaining 0 Screw Washer, Lock 0 Washer - Shroud, Steering 0 Bumper, Door/Shroud 0000 Knob, Choke 0000 Screw 0 0 Plate, Latch, Receiver Washer, Flat Screw 0 Screw Gasket, Console Hook Hook, Console Pin, Hinge Hinge, Console /0 A

7 HULL and BODY VIRAGE W00D and INT L VIRAGE W00I Bulkhead A

8 HULL and BODY VIRAGE W00D and INT L VIRAGE W00I -00 Pad, Boarding Platform Pad, Footwell, Rear, LH Pad, Footwell, Rear, RH Pad, Footwell, Center, LH Pad, Footwell, Center, RH Pad, Footwell, Front, LH Pad, Footwell, Front, RH Grommet Grommet 0 Screw 0 Washer Plate, Seat Tongue 0 0 Nut -00 Bumper, Front Rivet -00 Plug, Bumper, Rear Nut, Nylok Washer 0 Washer, Dish, Rubber 00 Strap, Bow Washer Bolt 0-00 Bolt Washer Rail, Rub, Side, LH Rail, Rub, Side, RH Sponson, LH Sponson, RH Pad, Heel, LH Pad, Heel, RH -00 Bumper, Rear 00 Plug, Bilge Screw Hook, Tow Screw 0 Washer Nut 00 Plunger, Latch -00 Handle, Grab 0 Washer, Lock Bucket, Rear Storage /00 A

9 FRONT STORAGE COMPARTMENT VIRAGE W00D and INT L VIRAGE W00I Latch, Door 0- Door, Compartment 0 Asm., Door Hinge 0 Washer 0 Nut Screw 0 Screw Washer, Lock Washer 0 Washer Washer, Lock 0 Screw Seal, Door Rivet 00 Cable, Limiter, Hinge 0 Spring, Gas Boot, Gas Spring 00 Cable Tie 0 Plate, Fire Extinguisher 0 Cover, Fire Extinguisher 00 Asm., Fire Extinguisher Container (Incl. 0 and Container) Container, Fire Extinguisher Rivet Seal, Bucket, Front Bucket, Front Storage /0 A

10 DECALS VIRAGE W00D and INT L VIRAGE W00I RH 0 LH 0 0 Kit - Decals (Incl. All Except Seat Decals) 00 Kit - Vinyl Decal Application (For Seat Decals) 0 Decal - Warning, Rear 0 Decal - Coast Guard, Exemption 0 Decal - POLARIS, Seat 0 Decal - Planet Sound Reduction 0 Decal - Fuel, Off/On 00 Decal - Fire Extinguisher 0 Decal - Star Emblem 0 Decal - Front, RH A0 00 Decal - POLARIS 0 0 Decal - Refueling Warning 0 Decal - Sidewall, RH 0 Decal - Virage 0 Decal - NMMA, Passenger 0 Decal - MFI 000 Dacal - Warning, Reverse System 00 Decal - Reverse 0 Decal - Caution, Capsize 0 Decal - Sidewall, LH 0 Decal - Warning, Seat/Engine 0 0 Decal - Front, LH /00

11 FUEL TANK VIRAGE W00D and INT L VIRAGE W00I Bracket, Strap 0 Washer, Lock Screw Hook, Strap, Narrow 0 Strap, Rubber Tank, Oil (See Oil Tank Pg. A, Ref. ) Hook, Strap 0 Strap, Battery Holddown 0 Cap, Fuel, Ratchet Chain, Bead, Cap Retainer Screw 00 Coupling, End, Fuel Cap Chain Inlet, Fuel Seal, Fuel Inlet Nut, Fuel Inlet 00 Clamp, Hose Hose, Fuel Fill 00 Clamp 0 Asm., Fuel Sender 0 00 Rivet 0 Pad, Fuel Tank Stop Bracket, Fuel Tank Stop 0 Tank, Fuel Pad, Fuel Tank Rivet 0 Seal, Fuel Cap A /00

12 FUEL SYSTEM VIRAGE W00D and INT L VIRAGE W00I 0 SEE NOTE BELOW NOTE: Fuel line from fuel/water separator connects to fuel sender fitting marked ON. 0 Screw 0 Washer, Flat -00 Knob, Fuel Valve, Black Nut, Fuel Valve 0 Valve, Fuel 00 Clamp, Hose 00- AR Line, Fuel Separator, Fuel/Water (See Fuel/Water Separator Pg. C0, Ref. ) A 0 Fitting, Tee 0 0 Grommet, Vent 00 Cable Tie 00 Valve, Check 00 Cable Tie 0 Valve, Vacuum Check Asm., Fuel Sender (See Fuel Tank Pg. A, Ref. ) /

13 SEAT VIRAGE W00D and INT L VIRAGE W00I Screw Washer, Flat Plate, Seat Base Latch 00 Spring, Seat Base Latch Handle, Seat Latch Rivet 0 Strap, Seat Latch 0 Seal, Seat, Rear Asm., Seat, Rear Cover, Seat, Rear 0 0 Screw 0 Screw Washer, Lock Plate, Bottom, Seat Base Latch Handle, Seat Base Latch Plate, Top, Seat Base Latch 00 Asm., Hinge, Seat Screw Screw 00 Cable, Limiter, Hinge 0 0 Rivet Nut 0 Washer, Lock Washer, Flat 00 Plunger, Latch -0-0 Asm., Seat, Main Cover, Seat, Main 0 0 Bumper, Seat -0 Strap, Seat Seal, Seat, Main A 0/

14 OIL TANK VIRAGE W00D and INT L VIRAGE W00I Coupling Screw Rivet 000 Chain Cap, Oil Tank 0 Rivet 0 Inlet, Oil Gasket, Oil Inlet 00 Clamp, Hose 0 00 Elbow, 0 Degree 0 Sender, Oil Level A 00 Cable Tie Conduit 000 Clamp, Hose 000- AR Line, Fuel 00 Filter, Oil 00 Clamp, Hose 00-0 AR Line, Fuel 0 Tank, Oil 0 0 Valve, Check, Vacuum 00 Cable Tie Hose, Oil Fill /00

15 STEERING VIRAGE W00D and INT L VIRAGE W00I Screw Washer, Lock Washer 0-00 Pad, Handlebar -00 Pad, Handlebar, Bottom 0 Screw 0 Clamp, Handlebar -00 Handle, Grab 0 Block, Throttle, Split 0 00 Cable, Throttle 00 Cable Tie 0 Switch, START/STOP/BILGE 00 Lanyard w/whistle Handlebar w/grip Column, Steering B Housing, Steering Bearing, Steering Nut, Nylok Washer 0 Gasket, Steering Housing Screw Clamp, Throttle Block 0 Ring, Retaining 0 Washer 0 Lever, Throttle, Thumb 0 Pin, Retaining Screw Washer, Lock 0 Washer 0 0 Pin, Roll /

16 STEERING VIRAGE W00D and INT L VIRAGE W00I Nut 0 Screw Washer 000 Rod End Nut, Nylok 0 Washer, Steering Seal 0 Ring, Stopper 0 Nut, Steering Cable (Special) 00 Cable, Steering 0 Brace, Steering Cable Washer Bolt Nut 00 Washer Washer, Lock 00 Cover 00 Tube, Guide 00 Rod End Washer 0 Nut 0 Screw Column, Steering (See Steering Pg. B, Ref. ) 0 Nut 0 Bracket, Steering Cable 0/0 B

17 DRIVE SYSTEM VIRAGE W00D and INT L VIRAGE W00I 0 00 Asm., Drive Coupler 0 O-Ring Shroud, Coupler 00 Clamp, Hose 0 Bumper, Drive Shaft 00 Shaft, Drive 00 Fitting, Lubrication 000 Seal, Bearing Asm., Bearing Housing (Incl., ) 0 0 Hose, Bearing Housing Shaft, Housing, Thru-Hull O-Ring Nut, Shaft, Housing B 0/

18 PROPULSION VIRAGE W00D and INT L VIRAGE W00I Bracket, Steering Cable Nut Stud, Mounting, Pump 0 Seal, Water Pipe 0 O-Ring Pipe, Water, Engine 0 Stator, Pump 00 Spacer, Bearing 00 Bearing 00 Seal, Stator Bearing 0 00 Spacer, Impeller Impeller Seal, Impeller/Shaft Extension, Pump 0 Screw 0 Anode, Zinc Washer, Pump Stud Housing, Pump Washer, Flat Nut, Nylok B 0 0 O-Ring 0 O-Ring Seal, Tailcone Screen, Engine Inlet 0 Nozzle, Steering Screw 0 Collar 0 Washer, Lock Washer, Flat Bearing, Steering Nozzle 0 Bolt Nozzle, Stationary Wedge, Pump 0 Screw Cone, Pump 0 O-Ring 00 Shaft, Stub 0 O-Ring /00

19 REVERSE VIRAGE W00D and INT L VIRAGE W00I B

20 REVERSE VIRAGE W00D and INT L VIRAGE W00I -00 Cap Screw Screw 00 Rivet Flange Gasket Plate, Base Bushing 0 Bushing 0 Pinion Bushing Shaft, Cam Washer Screw Reverse, Lock 0 Spring Screw 0 Washer Bracket, Reverse Plate, Forward Handle, Reverse Bracket, Reverse Plate, Rear 0 Rivet Bushing Plunger 0 Plate, Cable 0 Screw Arm, Reverse Washer 0 Screw 0 00 Pin, Cotter Washer 00 Cable, Reverse Nut 00 Washer Washer Seal, Rod Seal, Rod 000 Tube, Guide, Reverse 00 Rod End 0 Nut, Nylok 0 Gate, Reverse, Directional Screw Washer 00 Collar Washer Screw 0 Bracket, Reverse Stop /00 B

21 B EXHAUST SYSTEM VIRAGE W00D and INT L VIRAGE W00I

22 EXHAUST SYSTEM VIRAGE W00D and INT L VIRAGE W00I 00 Fitting, Inlet, Water Washer, Flat Washer, Lock Screw 00 Screw Fitting, Screen, Exhaust (See Cooling System Pg. B, Ref. ) Gasket, Exhaust (See Battery Box Pg. B, Ref. ) 0-0 Asm., Exhaust Pipe 00 Clamp, Hose 0 Hose, Pipe/Silencer 00 Clamp, Hose 0 Strap, Rubber Pad, Foam D-Hook Screw Washer, Lock Washer, Flat 0 Bumper, Rubber Cradle, Silencer Silencer, Exhaust 0 Pad 00 Clamp, Hose Hose 000 Clamp 0 Resonator 0 Pad Hose, Exhaust Washer, Flat Screw 0 0 Plate, Exhaust Seal 0 Seal Fitting, Exhaust Resonator Resonator Washer, Lock Screw 0 0 Washer Nut, Cage 0 Mount, Rubber 0 Screw 0 Screw 0 Nut 0 Bracket Hose, Crossover (Incl. Conduit) Conduit Protector, Seat, LH Protector, Seat, RH /00 B

23 ENGINE MOUNTING VIRAGE W00D and INT L VIRAGE W00I Asm., Temperature Switch Ground, Spark Plug 00 Decal - Spark Plug Screw 00 Gasket, Exhaust Decal - Warning (See Cylinder and Manifold Pg. C, Ref. ) Spark Plug, NGK BPRES (See Cylinder and Manifold Pg. C, Ref. ) 0 Plug, Pipe 0 Plate, Front Mount 0 0 Plate, Rear Mount 0 Washer, Lock 0 Screw 0 Plate, Repair 00 Mount, Engine B AR Shim, Engine Mount 0 0 Washer, Lock Screw 00 Bracket, Rear Muffler Washer, Flat 0 Bolt Washer, Flat Nut 0 Washer, Lock Bolt 00 Engine, Short Block NOTE: The Short Block assembly contains a crankcase assembly, cylinder, and cylinder head assembly. 0 Clip, Retainer 0 Bolt /

24 BATTERY BOX VIRAGE W00D and INT L VIRAGE W00I E 000 Polaris Sales Inc. 0 Stud Screw Washer, Flat Bracket, Battery Hold Down Cover, Battery 0 Grommet, Vent 00 Cable Tie 00 Connector AR Hose, Vent Battery, Amp 00 Kit - Battery Bolt 00 Cable, Ground, Battery/Engine 0 Pad, Battery B0 /00

25 COOLING SYSTEM VIRAGE W00D and INT L VIRAGE W00I Clamp, Hose Fitting, Thru-Hull Gasket - Conduit, Flex 0 Hose, Outlet, Pump Fitting, Tee 00 Clamp, Hose 0 Fitting, Screen, Exhaust Hose, Water 0 00 Fitting, Injector, Exhaust 00 Hose, Inlet 00 0 Cable Tie Screw Screw B 0 Asm., Exhaust Manifold Washer, Flat Washer, Lock 00 Screw 0 Gasket, Exhaust 0 00 Fitting, Drain Exhaust - Conduit, Flex Valve, Pop-Off 000 Thermostat, Degrees F. 0 Gasket, Thermostat 00 Cover, Thermostat, Machined 00 Spring, Compression 00 Seal, Thermostat Housing Hose, Water Out 0/

26 WATER INLET VIRAGE W00D and INT L VIRAGE W00I 0 00 Cable Tie Line, Pitot (See Shroud Pg. A, Ref. ) 00 Nut, Hex, Nylon Washer, Flat 0 Gasket, Pitot Washer, Flat Fitting, Pitot 0 Scoop, Inlet O-Ring (See Propulsion Pg. B, Ref. 0) Grate, Inlet Screw Screw Screw 0 Plate, Ride, Long, Angled 000 Insert, Sponson/Ride Plate B 0/

27 BILGE PUMP VIRAGE W00D and INT L VIRAGE W00I 0 0 Elbow 00 Clamp 000- Hose, Water 00 Cable Tie Fitting, Water, Thru-Hull Gasket Hose 0 Asm., Bilge Pump 0 Screw 0 Washer /00 B

28 ENGINE AIR INTAKE/HULL AIR INLET VIRAGE W00D and INT L VIRAGE W00I ENGINE AIR INTAKE 0 HULL AIR INLET 0-00 Plug, Intake Silencer 0 O-Ring Stud 00 Gasket 00 Base, Intake Screw 0 Filter, Intake -00 Cover, Intake 0 Nut Rivet 0 Flange, Air Inlet Gasket 0 Panel Gasket 00 Clamp 0 Duct, Air Inlet 00 Cable Tie /00 B

29 ELECTRICAL BOX VIRAGE W00D and INT L VIRAGE W00I Top View C

30 ELECTRICAL BOX VIRAGE W00D and INT L VIRAGE W00I 0 Harness, Main Wire 0 Insulator 0 Nut Washer, Lock Washer Solenoid, Starter (See Magneto Pg. C, Ref. 0) Screw Washer 0 Nut 0 00 Fuse, Amp 00 Fuse, / Amp 0 Latch Pin, Latch Controller, Ignition (See Magneto Pg. C, Ref. ) Strap, Grounding 0 Nut Washer 0 Screw 000 Regulator, Button 0 0 Nut 00 Cable, Battery/Solenoid 00 Cable, Solenoid/Starter O-Ring 00 Boot, Threaded Screw Washer Plate, Stator 0 Decal - RESET ELEC SYSTEM 0 Decal - High Voltage Warning 0 0 Harness,WireStator 0 Harness, Pigtail Cover, Electrical Box Seal 0 Bracket, Coil Coil, Ignition (See Magneto Pg. C, Ref. ) 00 Asm., Terminal Board 0 Breaker, Circuit Asm., Electrical Box, Ignition (Incl.,,,) Grommet 0 0 Cap Screw /0 C

31 CRANKCASE VIRAGE W00D and INT L VIRAGE W00I Kit - Asm., Crankcase (Incl. -,0-) Stud, Cylinder Flange 00 Pin, Dowel 0 Fitting Clamp, Stator Wires Screw 0 Bushing 0 Plug Bushing 0 0 Spring 0 Bushing Screw 0 Screw 0 Asm., Flywheel Cover (Incl. ) 0 Gasket, Flywheel Cover Screw 00 Pin, Dowel O-Ring 0 Asm., Flywheel Housing (Incl.,) 0 Screw 0 Plug Screw / C

32 CYLINDER & MANIFOLD VIRAGE W00D and INT L VIRAGE W00I Decal - Warning 0 Screw 00 Decal - Spark Plug 0 Plug, Pipe 00 Spark Plug, NGK BPRES Screw Screw 0 O-Ring 0 O-Ring 0 0 O-Ring 0 Nut 00 Cylinder 00 Gasket, Carb 0 Screw C 00 Retainer, Vinyl Coated Bracket, Oil Pump Cable 0 0 Screw 0 Manifold, Intake 0 Stuffer, Reed Block 0 0 Asm., Valve, Reed 0 Gasket, Cylinder Base 0 Head, Cylinder Ring, Head -0 Bracket, Head, Twin 0-0 Cover, Head 00 Gasket, Water, Manifold 0-0 Manifold, Outlet, Water 0/

33 CRANKSHAFT and PISTON VIRAGE W00D and INT L VIRAGE W00I Circlip, Piston 00 Pin, Piston Kit - Piston Rings (Std.)( Rings) Kit - Piston Rings (.mm OS) Kit - Piston Rings (.0 mm OS) NOTE: Ifthe number stamped on the head of piston reads ELKO 0/ use the above kits. Kit - Piston Rings (Std.)( Rings) Kit - Piston Rings (.mm OS) Kit - Piston Rings (.0 mm OS) NOTE: Ifthe number stamped on the head of piston reads ELKO a use the above kits. Kit - Piston Asm. (Std.)(Incl.,,) Kit - Piston Asm. (. mm OS)(Incl.,,) Kit - Piston Asm. (.0 mm OS)(Incl.,,) Washer, Thrust Pin, Crankshaft Bearing, Connecting Rod 00 Kit - Connecting Rod Assembly (Incl. -) 00 Bearing, Connecting Rod (0 mm) 0 0 Bearing, Ball 0 Ring, Retaining ( mm) Seal 0 Ring, Retaining ( mm) 0 O-Ring Collar, Crankshaft 0 Bushing 0 Crankweb, PTO 0 Crankweb, Center 0 Labyrinth 0 0 Crankweb, Mag. 0 Kit - Crankshaft, Cylinder (Incl. 0,-0,) Key, Woodruff 00 Seal Washer (See Magneto Pg. C, Ref. ) Nut, Pump Drive (See Magneto Pg. C, Ref. ) Coupler 0/ C

34 CARBURETOR VIRAGE W00D and INT L VIRAGE W00I Jet Block 0 0 Asm., Carburetor 000 Kit - Carb Rebuild (Incl.,,) 00 Screw, Fuel Pump 00 Kit - Fuel Pump Body 00 Kit - Gasket, Fuel Pump 00 Gasket, Carburetor, Upper 00 Screen, Fuel Strainer 00 Kit - Needle Valve 00 Jet, Main, Keihin 00 Jet, Main, Keihin 00 Jet, Pilot, Keihin 0 00 Screw, Jet Block Cover C 00 Cover, Jet Block 000 Kit - Diaphragm, Jet Block 00 Screw, Jet Block 000 Block, Jet 00 O-Ring, Jet Block 00 Collar 00 O-Ring, Valve Seat 00 Kit - Check Valve 00 Kit - Idler Mixture Screw Cap, Limiter 00 Gasket, Lower 00 Kit - Idle Stop Screw 0/

35 OIL PUMP VIRAGE W00D and INT L VIRAGE W00I 00 Cable, Oil Pump 00- Line, Oil 000 Clamp, mm Washer 0 E-Ring O-Ring 0 Screw 00 Pump, Oil (Incl. ) 0/ C

36 MAGNETO VIRAGE W00D and INT L VIRAGE W00I 0 00 Stator, Twin 00 Controller, Ignition Screw 0 00 Solenoid, Starter 0 O-Ring 00 Coil, Ignition Holder, Magnet 00 Clip 00 Asm., Flywheel 00- Wire, Spark Plug Screw 00- Wire, Spark Plug 0 Washer 00 Cable Tie 0 Nut 00 Cap, Spark Plug C /0

37 STARTING MOTOR VIRAGE W00D and INT L VIRAGE W00I Starter, Big Bore 0 Bolt, Through 0 Screw 0 Spring, Brush 0 Asm., Brush (Incl. -) 00 O-Ring 0 Washer 0 Washer, Spring 0 Nut 00 Ring, Rubber 0 00 Asm., Rear Bracket 0 AR Washer, Thrust 0 Washer, Thrust C 00 Asm., Armature 00 Asm., Bendix (Incl. -) 00 Asm., Front Bracket 0 O-Ring 0 Washer 0 Ring, Snap 0 Stopper 0 0 Cover 0 Spring Bushing, Flanged 0 Washer, Thrust 0 Asm., Gear 00 Asm., Gear (Incl. -) 0/

38 FUEL/WATER SEPARATOR VIRAGE W00D and INT L VIRAGE W00I Screw Washer, Lock 0 Washer, Dish Spacer 00 Separator, Fuel/Water (Incl. -) C0 00 O-Ring 0 Element 0 Spring 00 Float /00

39 ENGINE FOGGING SYSTEM INT L VIRAGE W00I 0 0 Kit - Engine Fogging 00 Cable Tie 00 Clamp, Hose 00 Clamp, Hose 0 Fitting, Tee 0 Decal - Engine Primer 00 AR Line, Oil 0 Primer, Engine, Fog Screw (See Fuel/Water Separator Pg. C0, Ref. ) Washer, Lock (See Fuel/Water Separator Pg. C0, Ref. ) Washer, Dish (See Fuel/Water Separator Pg. C0, Ref. ) C Separator, Fuel/Water (See Fuel/Water Separator Pg. C0, Ref. ) 0 Decal - Fogging Oil Only Washer Nut 00 Valve, Check, Vent 0 Fitting, 0 Degree Tank, Oil 0 Gasket, Overflow Cap Cap, Oil Bottle 0 0 Screw Bracket, Oil Tank 0/

40 TOOL KIT VIRAGE W00D and INT L VIRAGE W00I Asm.,ToolKit(Incl.-) Wrench, Spark Plug Wrench, Open End Screwdriver C Manual, Owners, 00 Watercraft Pouch, Tool Kit Wrench, Allen, Plated, / 0/

41 PRINTED IN THE USA PARTS MANUAL PN and MICROFICHE PN /00

42 Changed pages in 0 A cover toc B C x D E F G 0