SUPERSPORT EDGE Model #S01NB5BS Model #S01NB5BSA Rev. 03. E 2000 Polaris Sales Inc. PARTS MANUAL PN and MICROFICHE PN /00

Size: px

Start display at page:

Download "SUPERSPORT EDGE Model #S01NB5BS Model #S01NB5BSA Rev. 03. E 2000 Polaris Sales Inc. PARTS MANUAL PN and MICROFICHE PN /00"

Joanna Moody
6 years ago
Views:

1 SUPERSPORT EDGE Model #S0NBBS Model #S0NBBSA Rev. 0 E 000 Polaris Sales Inc. PARTS MANUAL PN 0 and MICROFICHE PN 0/00

3 TABLE OF CONTENTS SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA Parts Manual AIR BOX A... BLOWER HOUSING & RECOIL STARTER.. BRAKE... CARBURETOR... CHAINCASE... CHASSIS... CONSOLE... CRANKCASE... CYLINDER... DECALS... DRIVE CLUTCH... DRIVE TRAIN... DRIVEN CLUTCH... ENGINE MOUNTING... EXHAUST SYSTEM... B C D E F B C A C B A A C C A B0 B B B B FRONT SUSPENSION and SKI... A- FRONT TORQUE ARM... B FUEL PUMP... C HOOD... A- HOOD FOAM/FOIL... A0 MAGNETO... C N NOSEPAN... A- OIL PUMP H M O... PART NUMBER INDEX... C0- PISTON and CRANKSHAFT... C RAIL MOUNTING (SUSPENSION)... REAR TORQUE ARM... P R S C B B SEAT and GAS TANK... A STEERING... B STEERING - HANDLEBAR... B- SUSPENSION... B TOOL KIT T... C The illustrations used in this Parts Manual are for reference to replacement parts only. This manual is not to be used for assembly.

4 CHASSIS SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA E 000 Polaris Sales Inc Asm., Chassis (BS) Asm., Chassis (BSA) 00 Stop, Torque 0 Nut 0 Stop, Torque Screw 00 Caplug Screw Rivet 0 Bolt 0 Washer, Spring Lock 0 0 Washer, Flat -0-0 Bumper, Rear (BS) Bumper, Rear (BSA) -0 Flap, Snow 0 Reflector, Red Skirt, Snow, LH Skirt, Snow, RH Extrusion, Clutch Guard 0 Strap Mount, Console, LH (BS) Mount, Console, LH (BSA) Mount, Console, RH (BS) Mount, Console, RH (BSA) A Rivet -0 Footrest, Toe Clip, Upper, LH (BS) Footrest, Toe Clip, Upper, LH (BSA) -0 Footrest, Toe Clip, Upper, RH (BS) Footrest, Toe Clip, Upper, RH (BSA) Support, Footrest, LH (BS) Support, Footrest, LH (BSA) Support, Footrest, RH (BS) Support, Footrest, RH (BSA) Footrest, LH (BS) Footrest, LH (BSA) Footrest, RH (BS) Footrest, RH (BSA) Brace, Tunnel Roll (BS) Brace, Tunnel Roll (BSA) 0 Guard, Belt 00 Plug, Hole 00 Caplug 00 Clip, Rosebud Bolt, Carriage 00 Nut, Speed Washer, Nylon 0 Nut, Nylok /00

5 SEAT AND GAS TANK SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA Cap, Fuel w/gauge Asm., Seat Cushion (Incl. -,)(BS) Cover, Seat (BS) Asm., Seat Cushion (Incl. -,)(BSA) Cover, Seat (BSA) 000 Grommet, Relatch, Bottom 00 Grommet, Relatch, Top 00 Relatch w/hole, Twist Lock Rivet 000 Bulb, Taillight 000 Bulb, Brakelight 0 Lens 0 0 Screw Retainer, Tool Pouch Clip Housing, Taillight Rivet Nut, Weld 0 Washer, Flat Screw 0 Harness, Taillight Nut, Nylok 0 Washer, Flat 0 00 Nut, Speed Bolt, Carriage Cushion, Tank Tape, Foam AR Line, Fuel 000 Clamp, Hose 0 Fitting, 0 Degree 00 Grommet 000 Ring, Compression AR Line, Fuel 00 Pickup, Fuel w/filter 0 0 Asm., Fuel Tank (Incl. -) 00 Fitting, 0 Degree AR Line, Fuel 000 Cable Tie /00 A

6 NOSEPAN SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA 0 0 Rivet -0 Hinge, Pivot, Lower, RH Rivet Mount, Shock, Upper, RH Nut, Nylok Washer 0 Screw Rivet Mount, Shock, Upper, LH Bracket, Radius Rod Support 00 Brace, Pan, Lower -0 Hinge, Pivot, Lower, LH Nut, Nylok -00 Bumper, Front Bolt Rivet Nosepan (BS) Nosepan (BSA) Nut, Nylok Washer 0 Screw Rivet Screw 0 Washer, Spring Lock Guide, Hood, LH Guide, Hood, RH /00 A

7 NOSEPAN SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA 0 00 Clip, Speed, U-Type 00 J-Clip, Retainer Foil 00 Tape, Foil Tape, Foil 00 Foil, Nosepan, Front 0 Tape, Foil 0 Foil, Nosepan 0 Tape, Foil 0 0 Rivet Duct, Engine Air Outlet 00 Guard, Clutch 00 Pin, Clutch Guard Rivet 0 Decal - Engine and Clutch 0 Decal - Troubleshooting 0 Reflector, Amber Plug, Hole, Oblong Plate, Backer /00 A

8 HOOD SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA Asm., Hood (Incl. Foam and Foil)(BS) Asm., Hood (Incl. Foam and Foil)(BSA) 0 Asm. Headlamp (Incl. Bulbs) Foam, Headlight Seal, Top 0 Bulb, Headlight 00 Retainer, Headlamp Bulb Foam, Headlight Seal, Bottom Bolt, Adjust Tee 0 Spring, Headlight Adjust 00 Cable Tie 0 00 Knob, Headlight Adjust Foam, Prefilter Plenum, Hood Intake 0 Decal - Suspension Set-Up 0 Cover, Headlight Access 0 0 Screw -0 Hinge, Upper, LH Nut, Nylok 0 Washer, Flat Bolt 0 0 Spacer 0 Bolt -0 Hinge, Upper, RH /00 A

9 HOOD SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA 0 0 Rivet Windshield,, Flared, Smoke 00 Retainer, Windshield 0 Knob, Trip Odometer Asm., Speedometer Bulb, Replacement 00 Cushion, Rubber 00 Bracket, Speedometer/Tachometer 0 Washer, Flat 0 Washer, Split Lock 0 0 Nut 0 Cable, Speedometer 00 Clip, Rosebud 0 Screw Nut, Nylok 00 Cable, Hood Retainer Rivet 00 Clip, Rosebud /00 A

10 DECALS SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA 0 00 Kit - Hood Decals, 0 Supersport (Incl. -,-)(BS) 0 0 Decal - SUPERSPORT, LH Decal - SUPERSPORT, RH 0 Kit - Hood Decals, 0 Supersport 0 Decal - Hood Side, LH (BSA) (Incl. -,-)(BSA) 0 Decal - Hood Side, RH (BSA) 00 Kit - Decal Application Solution 0 Decal - Hood Side, LH (BS) (For Seat Decals) 0 Decal - Hood Side, RH (BS) 00 Decal - Track/Seat, Eng/Fr, LH/RH 00 Decal - POLARIS, Seat 0 Decal - Warning, NO PASSENGER 0 Decal - 0 FAN COOLED 00 Decal - POLARIS, Hood Center Decal - INDY, Trailing Arm, LH (BSA) Decal - INDY, Trailing Arm, RH (BSA) Decal - INDY, Trailing Arm, LH (BS) Decal - INDY, Trailing Arm, RH (BS) A 00 Decal - Warning, English 0 0 Decal - Caution, English/French 00 Decal - Warning, French Decal - EDGE, Tunnel, LH (BSA) Decal - EDGE, Tunnel, RH (BSA) Decal - EDGE, Tunnel, LH (BS) Decal - EDGE, Tunnel, RH (BS) /00

11 HOOD FOAM/FOIL SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA VIEW FROM UNDER HOOD -0 Screen, Nostril Hood, RH -0 Screen, Louver Hood, Front 000 Fastener, U-Type Clip -0 Screen, Louver Hood, Rear -0 Screen, Nostril Hood, LH 0 Foil, Hood, Edge, RH 0 Foil, Hood, Edge, RH 00 Foam, Hood, LH 00 Foam, Hood, Center, Edge /00 A0

12 CONSOLE SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA Screw Washer 000 Regulator Nut, Nylok 00 Cable Tie Console 0 Decal - Ignition, Console 00 Kit - Ignition Switch 00 Clip, Speed U-Type 0 Lever, Choke (Incl. Pin) 000 Cable, Choke Control (Incl. 0,) 0 Guide, Recoil Screw 0 Rivet Nut, Choke 0 Cap w/key NOTE: When ordering ignition key PN 0 be sure to specify if for an A,B,C,D, or E switch. Letter code will be labeled on underside of switch body behind console. Key dot code found on key cap (i.e. one dot = A, two dots= B, etc.). 0 Nut, Ignition 00 Housing, Connector 00 Socket Housing 000 Terminal, Ring 000 Housing 00 Harness, Main /00 A

13 BRAKE SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA Kit - Cover Screws 0 Kit - Cover Asm. (Incl.,) Gasket 00 Kit - Parking Lever Spring 000 Asm., Master Cylinder (Incl.,,,,0,) Screw 0 Kit - Lever and Pivot Pin Screw 0 00 Kit - Clamp Body/Reservoir Switch, Brake Light 0 0 Kit - Cartridge Asm. 00 Asm., Control, LH Button, Switch, HI/LO, LH Control 0 Kit - Pivot Pin 0 Kit - Parking Lever and Spring (Incl. ) 00 Asm., Brake Caliper (Incl.,,) 0 Line, Brake 00 Kit - Clip Spring (Qty. ) 0 Inlet Bolt 0 0 Washer, Spring Lock 0 Washer, Wrought Guide, Rope 0 Bracket, Caliper 0 Piston and Seal (Incl. ) 00 Kit - Seal 0 Kit - Heavy Duty Brake Pad, Type, Small (Incl. ) /00 A

14 FRONT SUSPENSION and SKI SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA A

15 FRONT SUSPENSION and SKI SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA Bolt 0 Bushing, Pivot, Inner Bushing, Shoulder 0 Nut, Nylok 0-0 Rod, Radius, Upper 0 Nut, Jam Nut, Nylok 0 Screw 00 Retainer, Spring, Slotted Spring, Compression Ring, Spring Preload 000 Retainer, Threaded 0 Shock 0 Washer, Flat Cup, Trailing Arm Mount Washer Arm, Steering Washer, Flat 00 Bearing, Spherical 0 0 Ring, Retaining 0 Screw Asm., Trailing Arm, LH (Incl.,0) Asm., Trailing Arm, RH (Incl.,0) Rod End (See Steering Pg B, Ref ) 0 Bushing 00 Fitting, Lubrication Bushing, Torsion Bar Rivet -0 Bar, Torsion Slide, Torsion Bar 0 0 Bushing 0 Bushing, Flanged 00-0 Shaft, Spindle 000 Fitting, Lubrication 0 Stop, Rubber Nut, Nylok 00-0 Ski Screw Plate, Skag Kit - Carbide,, Easy Steer (Incl. Skag and Plate 0-0 Skag 0-0 Shim, Skag Plate Nut 0 Pin, Cotter 00 Bushing 000 Rod End Nut 0-0 Rod, Radius, Lower 0 Nut, FLEXLOC 00 Rod End 0 Bushing, Shoulder 0 Bolt /00 A

16 STEERING - HANDLEBAR SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA B

17 STEERING - HANDLEBAR SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA Pin, Retaining 00 Ring, Retaining 0 00 Lever, Throttle Lever w/heater Block, Throttle/Brake Grip, Handlebar 0 Plug, Overflow Adaptor, Block -0 Handlebar Screw 0 00 Nut, Push-On Emblem, Star Cover, Handlebar 0 Slide, Handlebar Cover 00 Clip, Dart Asm., Control, LH (See Brake Pg. A, Ref. ) 0-0 Block, Handlebar 0-0 Post, Steering Nut, Nylok Bolt, Carriage 0 0 Heater, Grip, Lo/Med/Hi 00-0 Hoop, Steering 00 Clip, Rosebud Bolt, Carriage Nut Rivet 0 Plate, Tie Rod Boot Boot, Tie Rod, LH Boot, Tie Rod, RH 0 Washer, Flat Nut, Nylok 0 00 Bracket, Steering Post Fitting, Lubrication Bushing Bracket, Console Support Screw Holder, Wire 00 Ring, Retaining Screw, Set Washer 00 Switch, Auxiliary Shut-Off 0 Washer /00 B

18 STEERING SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA Rod End, RH 0 Nut -0 Tie Rod Nut, LH 00 Rod End, LH 00 Rod End, RH Rod, Steering Rack -0 Rod, Draglink Nut, Nylok 0 00 Rod End, LH 0 Bushing, Reducer 0 Asm., Pitman Arm (Incl.,,) Spacer, Tube Screw 0 Bearing, Ball 0 Asm., Idler Arm (Incl.,,) /00 B

19 CHAINCASE SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA Seal, Oil Nut 0 Screw 0 Bearing, Ball 0 Ring, Retaining Asm., Tightener Bearing, Chaincase Idler Wheel, Idler Washer, Thrust Pin, Chain Tightener 0 Sprocket, T, /W 0 Washer, Spring 0 Pin, Cotter 0 Nut, FLEXLOC Gasket, Chaincase Cover, Chaincase Screw Dipstick 0 Screw Washer, Spring 0 Sprocket, T, /W 0 Chain, P, /W 0 Plug 0 Nut, Nylok Chaincase Screw /00 B

20 DRIVE TRAIN SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA Bolt 0 Washer, Flat AR Washer, Flat 00 Spacer, Input Shaft Asm., Driven Clutch, R (See Driven Clutch Pg. B, Ref. ) 0 Belt, Drive AR Washer 0 AR Bushing Nut, Nylok 0 0 Washer, Flat Flangette w/grease Zerk 0 Gasket, Jackshaft Bearing Flangette Bolt, Carriage Key 0 Asm., Jackshaft (Incl.,) 0 Ring, Retaining 00 Disc, Brake 0 Bolt, Carriage 00 Sleeve, Seal 0 O-Ring Nut 0 Asm., Drive Shaft (Incl.,,) 0 Asm., Flangette w/screws 00 Bushing, Speedometer, Metal Flangette 00 Key, Speedometer, Square 00 Gasket, Drive Adaptor 0 0 Adaptor, Drive w/zerk /00 B

21 RAIL MOUNTING (SUSPENSION) SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA Asm., Scrolled Wheel (Incl.,) 0 Ring, Retaining ( per Wheel) 0 Bearing ( per Wheel) Nut, Nylok Washer, Flat Cap, Rail Tip Bumper, Front Nut, Nylok Rivet 0 Nut, Nylok Bracket, Rail Reinforcement Liner, Bumper Bumper, Rear Screw Mount, Bumper 0 Bumper, Pivot Arm Spacer Block, Idler Bolt Adjusting 0 Rivet 0 Nut, Jam Screw 0 Asm., Rail, LH (Incl.,,,,) Asm., Rail, RH (Incl.,,,,) 00 Screw 0 Block, Wheel Mount Washer, Spring Screw Screw Screw Washer 0 Spacer Roller, Spring Hi-Fax 0 Bolt Screw /00 B

22 SUSPENSION SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA Nut, Nylok 0 Bushing -0 Arm, Shock Pivot Screw 0 Washer, Flat Spacer, Idler Bushing 0 Wheel Spacer, Idler, Long 0 00 Shaft, Idler Washer Bolt Asm., Idler Wheel Ring, Retaining Bearing Screw Screw 0 Washer, Spring Lock Track Clip, Slide Clip, Guide 00 Shaft, Pivot Arm Asm., Wheel 0 0 Bushing -0 Mount, Shock 0 Shaft Washer, Flat 0 Shaft -0 Arm, Pivot, Rear 00 Fitting, Lubrication /00 B

23 FRONT TORQUE ARM SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA 0 0 Screw 0 Washer, Spring Lock Washer, Flat 0 Shaft -0 Arm, Torque, Front 000 Fitting, 0 Degree Nut, Nylok 0 Shock, Front Track 0 Sleeve 0 00 Retainer, Slotted Spring 0 Shield, Spring 0-0 Spring, Compression 0 Retainer, Spring 0 Retainer, Spring 0 Sleeve Screw 00 Fitting, Lubrication Shaft Washer 0 0 Nut, Nylok Screw Screw Washer, Flat Nut, Nylok Strap, Limiter /00 B

24 REAR TORQUE ARM SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA Arm, Torque, Rear Nut, Nylok 0 Screw Shaft, Arm Bushing Screw 0 Washer, Flat Washer, Flat 0 Washer, Spring Lock 0 Screw Asm., Rear Torque Arm (Incl. ) Spacer 0 Asm., Wheel Washer, Thrust Sleeve, Torsion Spring Roller, Spring, Adjustable 0 00 Clip, Push On Spring, Torsion,./, LH (Std) Spring, Torsion,./, RH (Std) Spring, Torsion,./, LH (Opt) Spring, Torsion,./, RH (Opt) Screw 0 Shaft Bolt Washer, Wave Bushing -0 Rod, Shock Screw 0 Bushing, Nut 0 Sleeve 00 Fitting, Lubrication 00 Shock 0 00 Bushing /00 B

25 DRIVE CLUTCH SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA 0 Bolt 0 Washer, Spring Lock Bearing, Cover 0 Ring, Retaining, Cover 0 Spring, Clutch, Dark Blue/White 0 Button, Guide 0 Washer, Multilube Asm., Roller and Bushing 00 Pin, Roller 0 00 Kit - Drive Clutch Shim Weight/Bushing, Pin, Hardened Weight 0 Bearing, Sleeve 00 Insert, Moveable AR AR AR Spacer (.00mm) Spacer (.0mm) Spacer (.00mm) 0 Nut, FLEXLOC 00 Nut, Jam Asm., Drive Clutch, Basic (Incl. All Less,) /00 B0

26 DRIVEN CLUTCH SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA 0 0 Screw Plate, Vented Driven 0 Bushing, Driven, Large DU 0 0 AR AR AR AR Washer (.0) Washer (.0) Washer (.0) Washer (.0) 00 Pin, Driven, Adjustable Cap, Vented Driven Bolt Cam, Driven, Adjustable Asm., Driven Clutch, Basic 0 W/B 0 0 Button, Ramp 0 Spring, Driven Clutch, Silver/Blue 0 Key 0 Ramp, Driven, D 0 Washer 0 Ring, Retaining /00 B

27 ENGINE MOUNTING SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA Screw 0 Washer 00 Washer, Clutch Retainer, Short 00 O-Ring, Clutch Bolt 00 Spacer, Clutch Bolt 000 Cable, Choke Control 00 Spark Plug, NGK BRES 0 Engine, Short Block ( ECPM00) NOTE: The Short Block assembly contains a crankcase assembly, cylinder and cylinder head assembly, and a piston and crankshaft assembly. Prior authorization is required for warranty consideration. Handle, Recoil 0 Nut, Nylok Washer, Flat 0 Strap, Engine Mount, LH 0 Nut 0 Washer, Interlock 0 Strap, Engine Mount, RH 00 Mount, Engine Spacer, Engine Mount B Screw 0 Washer, Spring Lock 0 Screw 00 Mount, Engine Screw 0 Bracket, Engine Mounting, RH 0 Washer, Flat 00 Nut, FLEXLOC, Thin 0 Bracket, Engine Mounting, LH 00 Spacer, Engine 00 Cable, Throttle 00 Cable Tie Tubing, Convoluted AR Line, Fuel 0000 Clamp, Hose 000 Clamp, Hose AR Line, Fuel Asm., Fuel Pump (See Fuel Pump Pg. C, Ref. ) Conduit, Convoluted 0 Valve, Fuel Shut-Off 0/00

28 AIR BOX SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA 0 0 Foam, Air Box, Chimney Duct, Air Inlet 00 Decal - Adjustable Driven Clutch 0 Decal - Greasing Cover, Air Silencer (Incl. -,,) Foam, Air Box, Plate Plate, Intake 00 Cap, Oil, Vented 0 Plate, Carburetor Adaptor 0 Boot, Carburetor Mount Silencer, Air (Incl.,) Rivet 000 Clamp, Hose 000- AR Line, Fuel 00 Fitting, Oil Sender 0 Grommet, Oil Sender CDI System (See Magneto Pg, C, Ref. ) 0 Screw 0 Strap, Air Box, Top 0 Tube, Intake, Outer 0 Decal - Caution, Air Box 000 Clip, Plastic /00 B

29 EXHAUST SYSTEM SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA Muffler (Tuned Pipe) 0 Spring, Exhaust 0 Retainer, Spring Screw 0 Washer, Spring Lock Washer, Flat Shield, Muffler 0 Boot, Exhaust Gasket, Exhaust (See Cylinder Pg. C, Ref. ) Manifold Screw Nut, Nylok Washer Dampener, Vibration 0 Screw /00 B

30 CRANKCASE SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA 0 0 Stud 00 Asm., Crankcase (Incl. -,,) 0 Pipe, Pulse 000 Pin, Dowel 0 Bolt, Flange 0 Gasket, Aluminum 0 Seal, Oil 0 Bolt and Washer 00 0 Bolt and Washer 0 0 Seal, Oil / C

31 CYLINDER SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA Bolt, Flange 00 Cylinder Head 00 Gasket, Head 0 Gasket, Exhaust 0 Nut, Flange 0 Cover, Cylinder Baffle 0 Cylinder Unit 0 Gasket, Cylinder 0 Screw 0 0 O-Ring 00 Bolt 00 Adaptor (Incl. 0) 0 Band, Adaptor (Incl. ) 0 Screw and Washer 0 Stopper 0 Valve 0 Asm., Reed Valve 0 Plate /00 C

32 PISTON and CRANKSHAFT SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA Clip, Piston Pin 00 Bearing, End, Large 0 Bearing, End, Small Ring, Piston (Standard) Ring, Piston (0.mm/.00 O/S) Ring, Piston (0.0mm/.00 O/S) Piston, Set (Standard) Piston, Set (0.m/.00 O/S) Piston, Set (0.0m/.00 O/S) 0 Pin, Piston 0 Spacer, Crank Pin 0 Crank Pin No. 00 Rod, Connecting C 0 0 Bearing, Ball 0 Spacer 0 Bearing, Ball 0 Crankshaft (PTO Side) 0 Bearing, Ball 0 Crankshaft (Incl. ) 0 0 Asm., Crankshaft (Incl. -,0,-) Crankshaft (MAG Side) 0 Bearing, Ball 00 Nut 00 Washer, Spring Key /00

33 BLOWER HOUSING & RECOIL STARTER SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA Baffle, Cylinder, 0 Decal - POLARIS, Engine Shroud 0 Bolt, Flange 0 Decal - 0, Eng. Shroud 0 Bolt, Flange 00 Cap, Cylinder Baffle 0 Bolt, Flange 0 Cylinder Baffle 00 Bolt and Washer Starter, Recoil (Incl. -,) Case, Starter 0 Plug, Rubber 0 Spring, Spiral 0 Reel 0 Spring, Return 0 Ratchet 0 Spring, Friction 0 Plate, Friction 0 Nut, Flange 0 Pulley, Starting Housing, Blower 0 Pin, Straight 0 Band, Wire 0 Bolt and Washer 0 Bolt and Washer 0 AR Rope, Starter /00 C

34 CARBURETOR SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA Top, Chamber, Mixing 0 Spring, Throttle 0 Plate, Throttle Needle, Jet (BGY) 0 Cap, Plunger 0 Spring, Plunger 0 Plunger 000 Spring, Throttle Adjuster 0 Screw, Throttle Stop 0 Hose 00 Screw, Air 00 Spring, Screw, Throttle Stop 00 Pilot Jet (#) 00 Screw and Washer 0000 Clamp, Hose, Red Plug, Trap 00- AR Line, Fuel 00 Fitting, Sediment 0 O-Ring 0 0 Main Jet (#00) 00 Washer 00 Float 0 Cap 000 Gasket, Float Chamber Needle Valve (.) 00 Packing, Needle Valve 00 Arm, Float 0 Pin, Float 0 Asm., Carburetor (Incl. -,-) 0 0 Valve, Check 0 Cap 0 Needle Jet (Q-) 0 0 Throttle Valve (.0) 00 E-Ring /00 C

35 FUEL PUMP SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA Ref. Part No. Qty. Description 0 Screw 00 Asm., Fuel Pump (Incl. -) 00 Diaphragm, Gasket Set / C

36 OIL PUMP SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA 0 0 Vinyl Pipe 0 Clamp, Hose 0 Screw, Air Vent 0 Packing 0 Asm., Oil Pump (Incl. -0,) 0 Spring, Return 0 Collar, Cam Shaft 0 Lever, Control 0 Washer, Spring C 0 00 Nut 0 Screw and Washer 0 Gear, Small 00 Spacer 0 Bushing, Oil Pump AR AR AR 0 O-Ring Spacer (.mm) Spacer (.mm) Spacer (.mm) /

37 MAGNETO SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA 0 Screw and Washer 0 Asm., Flywheel 0 Stator 0 Screw and Washer 0 Cap, Spark Plug 0 Cap, Spark Plug 000 CDI System 00 Coil, Ignition 0 Bolt, Flange /00 C

38 TOOL KIT SUPERSPORT S0NBBS and SUPERSPORT S0NBBSA 00 Kit - Tool (Incl. -) Screwdriver Wrench, 0- Spanner Box Wrench, Special Screwdriver, Flat, Shielded Manual, Owner s, 0 Snowmobile Supplement, Owner s Manual 0 Supersport Edge 00 Strap, Emergency Starter /00 C

39 0

40 PRINTED IN THE USA PARTS MANUAL PN 0 and MICROFICHE PN 0/00

XCF SP EDGE Model #S01NX4FS. E 2000 Polaris Sales Inc. PARTS MANUAL PN and MICROFICHE PN /00

XCF SP EDGE Model #S01NX4FS. E 2000 Polaris Sales Inc. PARTS MANUAL PN and MICROFICHE PN /00 XCF SP EDGE Model #S0NXFS E 000 Polaris Sales Inc. PARTS MANUAL PN and MICROFICHE PN 0/00 TABLE OF CONTENTS XCFSPEDGES0NXFS Parts Manual AIRBOX... A C H HOOD... A- BLOWER HOUSING and RECOIL STARTER. BRAKE...