PARTS CATALOG 0CK50-M01380EN

Transcription

1 PARTS CATALOG 0CK50-M0380EN Last update Nov., 07

2 PREFACE. This Parts Catalog carries Yanmar excavator (crawler back-hoe) VIO50-6A for U.S.A.. (M/# 6050~). Parts catalog history Model Published Remarks st edition Vehicle Engine VIO50-6A(US) 4TNV88C-PBV Oct.,07 3. Your understanding is asking that this parts catalog is not a technical data manual setting forth as servicing procedures, This parts catalog is using simplified illustration. Be sure to use Yanmar Genuine Parts in your maintenance servicing of Yanmar products. Be careful not to use the simple parts available in the market, otherwise their use in repairing causes such as an early breakage, for instance. 0CK50-M0380 VIO50-6A(US)

3 VEHICLE PAINTED COLOR R R 49 R 49 R CABIN Color Code Description Painted Color Paint Part No. 6L Can 4L Can SPRAY R YANMAR Turmeric Yellow YANMAR Navy Gray TOR TOR CK50-M0380 VIO50-6A(US)

4 PICTURESQUE INDEX() MAIN PARTS.LABEL & ACCESSORY Fig.~8 6.OPTIONAL & KIT Fig.00~05 4.HYDRAULIC OIL PIPING 3.ELECTRICAL PARTS 4.AIR CONDITIONER & HEATER Fig.6~87 Fig.~4 Fig.4~5.CANOPY Fig.00~0.CABIN Fig.03~5 REAR 9.AROUND SEAT Fig.83~95.ENGINE RELATED Fig.9~0 RIGHT 0.BONNET Fig.96~99 5.IMPLEMENT Fig.88~99 6.CONTROL EQUIPMENT Fig.59~68 7.FRAME Fig.69~73 8.COVER Fig.74~8 FRONT LEFT 5.TRAVELING Fig.5~57 3.HYDRAULIC OIL EQUIPMENT Fig.6~60 0CK50-M0380 VIO50-6A(US)

5 PICTURESQUE INDEX() HYDRAULIC SECTION HYD.OIL PIPING Fig.6~83 CONTROL PIPING Fig.84~87 BUCKET CYLINDER Fig.4 ARM CYLINDER Fig.,3 HYD. OIL TANK Fig.60 REMOTE CONTROL VALVE Fig.5,53 REAR RIGHT ACCUMULATOR Fig.33 HYD.OIL PUMP Fig.7~0 QUICK COUPLER Fig.30 BOOM CYLINDER Fig. TRAVEL MOTOR Fig.3 SWING CYLINDER Fig.5 TURNING MOTOR Fig.3 -WAY VALVE Fig.54,55 BLADE CYLINDER Fig.6,7 SOLENOID VALVE Fig.56~59 FRONT SWIVEL JOINT Fig.34,35 CONTROL VALVE Fig.36~5 LEFT ANGLE CYLINDER Fig.9 ANGLE BLADE SPEC. BLADE CYLINDER Fig.8 0CK50-M0380 VIO50-6A(US)

6 Fig. No. Fig. Name LABEL & ACCESSORY. LABEL(EXTERIOR). LABEL(BONNET INSIDE) 3. LABEL(CANOPY) 4. LABEL(CANOPY)(ANGLE BLADE SPEC.) 5. LABEL(CABIN) 6. LABEL(CABIN)(ANGLE BLADE SPEC.) 7. LABEL(QUICK COUPLER) 8. TOOL BOX ENGINE RELATED 9. MUFFLER 0. AIR CLEANER. MUFFLER COVER. ACCELERATOR 3. ENGINE MOUNT 4. ENGINE MOUNT(AIR CONDITIONER SPEC.) 5. RADIATOR SHROUD 6. RADIATOR & SUB TANK 7. RADIATOR HOSE 8. DUCT 9. FUEL TANK 0. FUEL PIPING Contents Fig. No. Fig. Name ELECTRICAL PARTS. AROUND THE ENGINE. HARNESS SUPPORT 3. BATTERY(MINUS CABLE) 4. HORN 5. P.T.O.(ANGLE BLADE SPEC.) 6. HARNESS GUIDE 7. STARTER SWITCH 8. AROUND THE SEAT 9. ANGLE BLADE LEVER(ANGLE BLADE SPEC.) 30. PRESSURE SWITCH 3. TRAVEL BUZZER 3. CONTROLLER 33. WORK LAMP 34. INSTRUMENT PANEL(CANOPY) 35. INSTRUMENT PANEL(CABIN)(HEATER SPEC.) 36. INSTRUMENT PANEL(CABIN)(AIR CONDITIONER SPEC.) 37. HARNESS(HEATER) 38. WORK CONTROL 39. QUICK COUPLER(SWITCH BOX) 40. RELAY BRACKET 4. GPS AIR CONDITIONER & HEATER 4. AIR CONDITIONER(UNIT) 0CK50-M0380

7 Fig. No. Fig. Name 43. AIR CONDITIONER(ACCESSORY) 44. AIR CONDITIONER(PIPING) 45. AIR CONDITIONER(ENGINE RELATED) 46. AIR CONDITIONER(CONDENSER RELATED) 47. AIR CONDITIONER(ELECTRIC PARTS) 48. HEATER(UNIT) 49. HEATER(ACCESSORY) 50. HEATER(PIPING) 5. DUCT(AIR CONDITIONER & HEATER) TRAVELING 5. SPROCKET 53. IDLER & ADJUST 54. TRACK ROLLER 55. CARRIER ROLLER 56. IRON CRAWLER 57. RUBBER CRAWLER CONTROL EQUIPMENT 58. TRAVEL PEDAL 59. VALVE MOUNT 60. TRAVEL LEVER 6. SWING PEDAL 6. LINK COVER 63. PEDAL COVER Contents Fig. No. Fig. Name 64. LEVER SPACER 65. BLADE LEVER 66. BLADE LEVER(ANGLE BLADE SPEC.) 67. ARMREST 68. LOCK LEVER & STAND FRAME 69. TRACK FRAME 70. CRAWLER GUARD 7. COUNTER WEIGHT 7. TURNING FRAME 73. TURNING BEARING COVER 74. COVER(MULTI) 75. UPPER COVER() 76. UPPER COVER() 77. COVER(TURNING FRAME) 78. COVER(TRAVEL FRAME) 79. FRAME GUARD(LEFT) 80. FRAME GUARD(RIGHT) 8. COVER(TURNING FRAME)(FRONT - LEFT) 8. COVER(TURNING FRAME)(FRONT - RIGHT) 0CK50-M0380

8 Fig. No. Fig. Name AROUND SEAT 83. STEP(CABIN) 84. STEP(CANOPY) 85. COVER(LEVER) 86. COVER(MONITOR)(CANOPY) 87. COVER(MONITOR)(CABIN)(AIR CONDITIONER SPEC.) 88. COVER(MONITOR)(CABIN)(HEATER SPEC.) 89. SEAT MOUNT 90. COVER(SEAT MOUNT) 9. SEAT 9. SEAT(ACCESSORY) 93. HANDRAIL(LEFT) 94. HANDRAIL(RIGHT) 95. HANDRAIL(RIGHT)(QUICK COUPLER SPEC.) BONNET 96. BONNET(REAR) 97. BONNET(FRONT) 98. BONNET(LEFT) 99. BONNET(RIGHT) CANOPY 00. CANOPY 0. CANOPY MOUNT 0. CANOPY LAMP Contents Fig. No. Fig. Name CABIN 03. WINDOW WASHER 04. CABIN(ASSEMBLY) 05. CABIN DOOR() 06. CABIN DOOR() 07. CABIN(FRONT WINDOW)() 08. CABIN(FRONT WINDOW)() 09. CABIN(GLASS) 0. CABIN(REAR COVER). CABIN(ELECTRIC PARTS). CABIN(ACCESSORY) 3. REARVIEW MIRROR 4. CABIN(PAD) 5. BOX(CABIN HEATER SPEC.) HYDRAULIC OIL EQUIPMENT 6. HYDRAULIC PUMP MOUNT 7. HYDRAULIC PUMP 8. HYDRAULIC PUMP(QUICK COUPLER SPEC.) 9. HYDRAULIC PUMP(E.S.S. SPEC.) 0. HYDRAULIC PUMP(E.S.S. & QUICK COUPLER SPEC.). BOOM CYLINDER. ARM CYLINDER 3. ARM CYLINDER(QUICK COUPLER SPEC.) 0CK50-M0380

9 Fig. No. Fig. Name 4. BUCKET CYLINDER 5. SWING CYLINDER 6. BLADE CYLINDER 7. BLADE CYLINDER(QUICK COUPLER SPEC.) 8. BLADE CYLINDER(ANGLE BLADE SPEC.) 9. ANGLE CYLINDER(ANGLE BLADE SPEC.) 30. HITCH CYLINDER(QUICK COUPLER) 3. TRAVEL MOTOR 3. TURNING MOTOR 33. ACCUMULATOR 34. SWIVEL JOINT 35. SWIVEL JOINT(ANGLE BLADE SPEC.) 36. CONTROL VALVE(/8) 37. CONTROL VALVE(/8) 38. CONTROL VALVE(3/8) 39. CONTROL VALVE(4/8) 40. CONTROL VALVE(5/8) 4. CONTROL VALVE(6/8) 4. CONTROL VALVE(7/8) 43. CONTROL VALVE(8/8) 44. CONTROL VALVE(/8)(ANGLE BLADE SPEC.) 45. CONTROL VALVE(/8)(ANGLE BLADE SPEC.) 46. CONTROL VALVE(3/8)(ANGLE BLADE SPEC.) 47. CONTROL VALVE(4/8)(ANGLE BLADE SPEC.) 48. CONTROL VALVE(5/8)(ANGLE BLADE SPEC.) Contents Fig. No. Fig. Name 49. CONTROL VALVE(6/8)(ANGLE BLADE SPEC.) 50. CONTROL VALVE(7/8)(ANGLE BLADE SPEC.) 5. CONTROL VALVE(8/8)(ANGLE BLADE SPEC.) 5. REMOTE CONTROL VALVE(RIGHT) 53. REMOTE CONTROL VALVE(LEFT) 54. -WAY VALVE 55. -WAY VALVE(ANGLE BLADE SPEC.) 56. SOLENOID VALVE(P.T.O.)(E.S.S. SPEC.) 57. SOLENOID VALVE(P.T.O. )(ANGLE BLADE SPEC.) 58. SOLENOID VALVE(P.T.O.) 59. SOLENOID VALVE BRACKET(P.T.O. )(ANGLE BLADE SPEC.) 60. HYD. OIL TANK HYDRAULIC OIL PIPING 6. TANK - PUMP & CONTROL VALVE 6. CONTROL VALVE - TURNING MOTOR 63. CONTROL VALVE(FITTING)() 64. CONTROL VALVE(FITTING)() 65. CONTROL VALVE(FITTING)()(ANGLE BLADE SPEC.) 66. CONTROL VALVE(FITTING)()(ANGLE BLADE SPEC.) 67. CONTROL VALVE - RETURN & DRAIN 68. CONTROL VALVE - BOOM BULKHEAD & SWING 69. CONTROL VALVE - BOOM CYLINDER 70. CONTROL VALVE - SWIVEL JOINT 7. CONTROL VALVE - SWIVEL JOINT(ANGLE BLADE SPEC.) 0CK50-M0380

10 Fig. No. Fig. Name 7. TRAVEL FRAME 73. TRAVEL FRAME(ANGLE BLADE SPEC.) 74. ARM CYLINDER & BUCKET CYLINDER 75. P.T.O.(CONTROL VALVE - BOOM) 76. P.T.O.(BOOM - ARM END) 77. P.T.O.(SOLENOID VALVE) 78. P.T.O.(SOLENOID VALVE)(ANGLE BLADE SPEC.) 79. P.T.O.(SOLENOID VALVE & E.S.S.) 80. P.T.O.(SOLENOID VALVE & E.S.S.)(ANGLE BLADE SPEC.) 8. P.T.O.(ANGLE BLADE SPEC.) 8. QUICK COUPLER(HYD. OIL PIPING)() 83. QUICK COUPLER(HYD. OIL PIPING)() 84. CONTROL PIPING() 85. CONTROL PIPING()(ANGLE BLADE SPEC.) 86. CONTROL PIPING() 87. GREASING Contents Fig. No. Fig. Name 95. BUCKET 96. PLUG(IMPLEMENT) 97. BLADE 98. BLADE CYLINDER(QUICK COUPLER SPEC.) 99. BLADE CYLINDER(ANGLE BLADE SPEC.) OPTIONAL & KIT 00. LABEL KIT(FOR CANADA)(OPTIONAL) 0. LABEL KIT(FOR CANADA)(ANGLE BLADE SPEC.)(OPTIONAL) 0. RADIO KIT(OPTIONAL)(WITHOUT RADIO) 03. REMOTE CONTROLLER KIT(OPTIONAL) 04. P.T.O. STOP VALVE CONNECTER KIT(OPTIONAL) 05. ADDITIONAL WEIGHT KIT(OPTIONAL) 0CK50-M0380 IMPLEMENT 88. BOOM BRACKET 89. BOOM 90. ARM 9. BUCKET ARM & LINK 9. QUICK COUPLER(BODY) 93. BUCKET PIN(STD) 94. BUCKET PIN(QUICK COUPLER SPEC.)

11 0CK50-M0380 LABEL & ACCESSORY Fig.. LABEL(EXTERIOR) 0CK50-M0380 Fig. 7B LABEL SET,OUT EX50 D 7B LABEL,PTO SELECT EX LABEL, HYD.OIL LABEL, RESEVOIR LABEL, CYLINDER 6 7A LABEL,SWING AREA US LABEL, ENGINE COVER 8 7A LABEL, ENGINE ROOM LABEL, BOOM 0 7B LABEL, GREASE US LABEL, FUEL LABEL, HOOK A LABEL,YANMAR 560 B 4 7A LABEL,YANMAR 70 B 5 7B LABEL, REFLECTOR M 6 7B LABEL,MODEL VIO50 L 7 7B LABEL,MODEL VIO50 R LABEL, FUEL OIL CAUT 9 7B EMBLEM ASSY,FY L4 Y

12 0CK50-M0380 LABEL & ACCESSORY Fig.. LABEL(BONNET INSIDE) 0CK50-M0380 Fig. 7B LABEL SET,IN US 7A LABEL 3 7A LABEL, SUB TANK 4 7A38-03 LABEL, ANTI-FREEZING 5 7B LABEL,FUSE LABEL, RADIATOR 7 7A LABEL,BATTERY COVER LABEL, BATTERY LABEL, RADIATOR 0 7B LABEL,SILENCER EX 7B LABEL,RESERVOIR EX LABEL LABEL LABEL, AIR CLEANER

13 0CK50-M0380 LABEL & ACCESSORY Fig.3. LABEL(CANOPY) 0CK50-M0380 Fig.3 7B LABEL SET,4P US 50 D LABEL, SUPPORT 3 7B LABEL,BRANDLOGO B LABEL, OPERATION 5 7A LABEL,ACCELERATOR 6 7B LABEL,SW LABEL, CRAWLER TAG ASSY, CAUTION 7B LABEL, PTO SWITCH LABEL, LOCK LABEL, MANUAL LABEL, SLOPE LABEL, TRANSPORT 6 7B LABEL,RELAY BOX STD LABEL, NEUTRAL 8 7A LABEL,PTO EX 9 7B LABEL, DPF EX 0 7B LABEL,OIL/WATER US 7B LABEL,SEAT TILT UP LABEL, STEERING 3 7B LABEL,GREASING EX LABEL, ROPS 5 7B LABEL,FUSE BOX US LABEL, SEAT BELT LABEL, LEVER LOCK 8 7B LABEL,LIFT EX LABEL, -WAY US 30 7B LABEL,SPEC US 50 Remarks * DPF: DPF stands for DIESEL PARTICULATE FILTER. * Not applied for angle blade specification. ()Rubber crawler specification.

14 0CK50-M0380 LABEL & ACCESSORY Fig.4. LABEL(CANOPY)(ANGLE BLADE SPEC.) 0CK50-M0380 Fig.4 7B LABEL SET,4PUSANG50D LABEL, SUPPORT 3 7B LABEL,BRANDLOGO A LABEL,ACCELERATOR 5 7A LABEL,WARNING ANGLE 6 7B LABEL,SW LABEL, CRAWLER TAG ASSY, CAUTION 7B LABEL, PTO SWITCH LABEL, LOCK LABEL, MANUAL LABEL, SLOPE LABEL, TRANSPORT 6 7B LABEL,RELAY BOX STD LABEL, NEUTRAL 8 7A LABEL,PTO EX 9 7B LABEL, DPF EX 0 7B LABEL,OIL/WATER US 7B LABEL,SEAT TILT UP LABEL, STEERING 3 7B LABEL,GREASING EX LABEL, ROPS 5 7B LABEL,FUSE BOX US LABEL, SEAT BELT LABEL, LEVER LOCK 8 7B LABEL,LIFT ANGLE LABEL, -WAY US 30 7B LABEL, OPERATION ANG 3 7B LABEL,SPEC US A 50 Remarks * Exclusive figure for angle blade specification. * DPF: DPF stands for DIESEL PARTICULATE FILTER. ()Rubber crawler specification.

15 0CK50-M0380 LABEL & ACCESSORY Fig.5. LABEL(CABIN) 0CK50-M0380 Fig.5 7B LABEL SET,CAB US50 D LABEL, SUPPORT 3 7B LABEL,BRANDLOGO B LABEL, OPERATION 5 7A LABEL,ACCELERATOR 6 7B LABEL,SW LABEL, CRAWLER 8 7B LABEL,AIR SELECT TAG ASSY, CAUTION 7B LABEL,SW A/C 3 7B LABEL, PTO SWITCH LABEL, LOCK 5 7B LABEL,DOOR KEY LOCK LABEL, MANUAL LABEL, SLOPE LABEL,F/W LOWER US LABEL, TRANSPORT 0 7B LABEL,RELAY BOX STD 7B LABEL,RELAY BOX OP LABEL, NEUTRAL 3 7A LABEL,PTO EX 4 7B LABEL, DPF EX 5 7B LABEL,OIL/WATER US 6 7B LABEL,SEAT TILT UP 7 7B LABEL,WARNING A/C US LABEL, STEERING 9 7B LABEL,GREASING EX LABEL, ROPS 3 7B LABEL,FUSE BOX US LABEL, SEAT BELT LABEL, LEVER LOCK 34 7B LABEL,LIFT EX LABEL, WINDOW US LABEL, -WAY US 37 7B LABEL,SPEC US 50 Remarks * DPF: DPF stands for DIESEL PARTICULATE FILTER. * Not applied for angle blade specification. ()Rubber crawler specification. ()Air Conditioner specification.

16 0CK50-M0380 LABEL & ACCESSORY Fig.6. LABEL(CABIN)(ANGLE BLADE SPEC.) 0CK50-M0380 Fig.6 7B LABEL SET,CABUSANG LABEL, SUPPORT 3 7B LABEL,BRANDLOGO A LABEL,ACCELERATOR 5 7A LABEL,WARNING ANGLE 6 7B LABEL,SW LABEL, CRAWLER 8 7B LABEL,AIR SELECT TAG ASSY, CAUTION 7B LABEL,SW A/C 3 7B LABEL, PTO SWITCH LABEL, LOCK 5 7B LABEL,DOOR KEY LOCK LABEL, MANUAL LABEL, SLOPE LABEL,F/W LOWER US LABEL, TRANSPORT 0 7B LABEL,RELAY BOX STD 7B LABEL,RELAY BOX OP LABEL, NEUTRAL 3 7A LABEL,PTO EX 4 7B LABEL, DPF EX 5 7B LABEL,OIL/WATER US 6 7B LABEL,SEAT TILT UP 7 7B LABEL,WARNING A/C US LABEL, STEERING 9 7B LABEL,GREASING EX LABEL, ROPS 3 7B LABEL,FUSE BOX US LABEL, SEAT BELT LABEL, LEVER LOCK 34 7B LABEL,LIFT ANGLE LABEL, WINDOW US LABEL, -WAY US 37 7B LABEL, OPERATION ANG 38 7B LABEL,SPEC US A 50 Remarks * Exclusive figure for angle blade specification. * DPF: DPF stands for DIESEL PARTICULATE FILTER. ()Rubber crawler specification. ()Air Conditioner specification.

17 0CK50-M0380 LABEL & ACCESSORY Fig.7. LABEL(QUICK COUPLER) 0CK50-M0380 Fig.7 7B LABEL SET,Q EX LABEL LABEL, OPERATION LABEL, LOCK LABEL, PIN US LABEL, FINGER LABEL, LOCK PIN 8 7B LABEL,WARNING HITCH 9 7B LABEL,SAND US

18 0CK50-M0380 LABEL & ACCESSORY Fig.8. TOOL BOX 0CK50-M0380 Fig.8 7B TOOLBOX ASSY 7B TOOLBOX ASSY,FRAME 3 7B TOOLBOX ASSY,COVER 4 7A COLLAR BOLT, M0X 5

19 0CK50-M0380 ENGINE RELATED Fig.9. MUFFLER 0CK50-M0380 Fig.9 7B04-30 PIPE ASSY, EXHAUST C 7B04-38 BRACKET ASSY,EXHAUST CLAMP WASHER, WASHER, SPRING BOLT, M8X BOLT, M0X 65 PLATED NUT, M0

20 0CK50-M0380 ENGINE RELATED Fig.0. AIR CLEANER 0CK50-M0380 Fig.0 7B GUIDE ASSY, HOSE B 7B AIR CLEANER ASSY 3 A ELEMENT ASSY, OUTER 4 7B PLUG 5 7B03-57 NUT,AIR CLEANER 6 7B COVER ASSY,AIRCLEANE 7 7B04-50 HOSE, AIRCLEANER A-C 8 7B04-50 HOSE, AIR CLEANER B 9 7B04-56 BRACKET, AIR CLEANER 0 7B BRACKET ASSY, A/C B 7B04-90 GUIDE ASSY,HOSE A 3 7B HOSE,9X WASHER, CLAMP, CLAMP, CLAMP, BOLT, M8X BOLT, M8X BOLT, M8X BOLT, M8X BOLT, M0X 5 3 3

21 0CK50-M0380 ENGINE RELATED Fig.. MUFFLER COVER 0CK50-M0380 Fig. 7B04-60 COVER ASSY,MUFFLER A 3 7B04-65 SHEET,INSULATION A 4 7B COVER ASSY,MUFFLER B 6 7B SHEET,INSULATION B 7 7B04-70 COVER MUFFLER C 7A 7B LABEL,SILENCER EX WASHER, WASHER, WASHER, WASHER, BOLT, M8X BOLT, M8X BOLT, M8X BOLT, M8X BOLT, M8X 0 Remarks ()Attach the No.7A label to this part. ()Label is not illustrated.

22 0CK50-M0380 ENGINE RELATED Fig.. ACCELERATOR 0CK50-M0380 Fig. 7A69-00 VOLUME, ACCEL ASSY 7 7A69-0 KNOB ASSY

23 0CK50-M0380 ENGINE RELATED Fig.3. ENGINE MOUNT 0CK50-M0380 Fig.3 7B04-30 MOUNT, ENGINE RR 7B04-30 MOUNT, ENGINE LF 3 7B MOUNT, ENGINE LR BOLT A STOPPER WASHER BOLT BOLT MOUNT, ENGINE SEAT, SPRING SEAT, SPRING WASHER, SPRING WASHER, SPRING WASHER, SPRING 6

24 0CK50-M0380 ENGINE RELATED Fig.4. ENGINE MOUNT(AIR CONDITIONER SPEC.) 0CK50-M0380 Fig.4 7B04-30 MOUNT, ENGINE RR 7B04-30 MOUNT, ENGINE LF 3 7B MOUNT, ENGINE LR BOLT 8 5 7A STOPPER WASHER BOLT BOLT MOUNT, ENGINE SEAT, SPRING SEAT, SPRING 7 7A WASHER WASHER, SPRING WASHER, SPRING WASHER, SPRING BOLT, 0.90X 50

25 0CK50-M0380 ENGINE RELATED Fig.5. RADIATOR SHROUD 0CK50-M0380 Fig.5 7B GUARD,FAN 7B SHROUD ASSY 4 7A SPONGE 5 7A SPONGE RUBBER PLATE-B,FUEL RUBBER, SEAL RUBBER, SEAL 9 7B COVER, A SHROUD 0 7B COVER, B SHROUD 7B COVER, C SHROUD BOLT, M8X BOLT, M8X BOLT, M8X 6

26 0CK50-M0380 ENGINE RELATED Fig.6. RADIATOR & SUB TANK 0CK50-M0380 Fig.6 7A RADIATOR SUB ASSY CAP, RADIATOR 3 7B SUPPORT ASSY, RAD 4 7B SUPPORT ASSY, RAD 5 7B BRACKET ASSY, OC 6 7B BRACKET ASSY, OC 7 7B BRACKET ASSY, S TANK 8 7B BRACKET ASSY, L RAD 9 7B BRACKET ASSY, U RAD TANK ASSY, SUB BODY, SUB-TANK CAP CLAMP, HOSE GASKET HOSE 7X 5 5A 7A LABEL, SUB TANK BAND, SUB-TANK BRACKET, SUB TANK CUSHION, RADIATOR 9 7B COOLER ASSY, OIL WASHER, BOLT, M6X BOLT, M6X BOLT, M8X BOLT, M8X BOLT, M0X BOLT, M0X BOLT, M8X BOLT, M8X BOLT, M8X 0 Remarks ()Attach the No.5A label to this part. ()Label is not illustrated.

27 0CK50-M0380 ENGINE RELATED Fig.7. RADIATOR HOSE 0CK50-M0380 Fig.7 7B HOSE, CW-T A 7B CLIP, TREE 3 7B HOSE, CW-T B COCK ASSY, -WAY BODY PLUG, DRAIN M O-RING, AP A47-40 HOSE ASSY,FO CLAMP, HOSE CLAMP, HOSE PIPE ASSY, FUEL 8 7B ELBOW, 90 G-5 9 7A O-RING 0 7B ELBOW, 90 G-9 7A O-RING CLAMP, HOSE CLAMP, HOSE CLAMP, HOSE CLAMP, HOSE BOLT, M8X 5

28 0CK50-M0380 ENGINE RELATED Fig.8. DUCT 0CK50-M0380 Fig.8 7B HOLDER ASSY, GREASE 7B PLATE, GREASE GUN 3 7B DUCT ASSY, RADIATOR 5 7A SEAL 6 7B SPONGE, A DUCT 7 7B SPONGE, B DUCT 8 7B SPONGE, C DUCT 9 7B SPONGE, D DUCT 0 7B SPONGE, E DUCT 7B SEAL, 095 7B COVER ASSY, DUCT 3 7A SEAL 4A 7A LABEL,BATTERY COVER 4B LABEL, BATTERY BRACKET, PUMP 6 A HOLDER, ROD BOLT, WING WASHER, PIN, COTTER.5X BOLT, M6X BOLT, M6X BOLT, M8X BOLT, M8X 6 Remarks ()Attach the No.4A & 4B label to this part. ()Label is not illustrated.

29 0CK50-M0380 ENGINE RELATED Fig.9. FUEL TANK 0CK50-M0380 Fig.9 7B TANK KIT,FUEL 7B04-40 TANK ASSY, FUEL OIL CAP, FUEL CAP PACKING, RUBBER PACKING, RUBBER WASHER SPONGE 4 3 7B STRAINER GASKET 3 7B04-40 GAUGE, FUEL SUMP, FUEL 5 7B RUBBER,A FO.STAY 6 7A BRACKET BOLT, M8X SCREW, M5X B CLAMP ASSY, FO 3 7B RUBBER, CLAMP 3 7B04-40 RUBBER,FO TANK 33 7A VALVE, FUEL DRAIN 34 7B03-47 JOINT ASSY, DRAIN PLATE, RUBBER 36 7B STAY ASSY,FO STAY 38 7B RUBBER,A FO.STAY HOSE, DRAIN 40 7A HOSE 4 7B HOSE ASSY, CLAMP, HOSE CLAMP, HOSE WASHER, CLAMP, BOLT, M8X BOLT, M0X BOLT, M0X BOLT, M0X NUT, M0

30 0CK50-M0380 ENGINE RELATED Fig.0. FUEL PIPING 0CK50-M0380 Fig BAND BAND 3 7B GUIDE ASSY, FO HOSE 4 7B BRACKET ASSY, WS 5 7B HOSE ASSY,FO 530 CR 9 7B HOSE ASSY,FO 40 CR 3 7B-4700 HOSE ASSY, B HOSE ASSY,FO 80 CR CLAMP CLAMP, HOSE PUMP, FUEL FEED 4 9E FILTER ASSY, FUEL 5 9E BODY ASSY 6 3 9A PLUG, AIR VENT 7 3 9A O-RING O-RING, AP.0 9 9A CUP(CLEAR 30 9A ELEMENT PLUG, DRAIN 3 9A O-RING 33 9A FLOAT WASHER, WASHER, WASHER, SPRING PIPE, 5X BOLT, M6X BOLT, M8X BOLT, M8X BOLT, M0X BOLT, M8X 95 PLATED

31 0CK50-M0380 ELECTRICAL PARTS Fig.. AROUND THE ENGINE 0CK50-M0380 Fig BAND 7B CABLE ASSY,BATTERY + 4 7B04-60 HARNESS, BATTERY SLO BATTERY 6 7B COVER,BATTERY CR RETAINER, BATTERY ROD 9 7B BRACKET ASSY, FUSE 0 7B HARNESS ASSY,POWERS C FUSE, SLOW BLOW 80A 3 A FUSE, 00A SLOW BLOW 4 A FUSE, SLOW BLOW 60A WASHER, WASHER, WASHER, WASHER, SPRING WASHER, SPRING BOLT, M8X BOLT, M0X BOLT, M0X BOLT, M6X NUT, M NUT, M NUT, M BAND CORD, ENGINE EARTH

32 0CK50-M0380 ELECTRICAL PARTS Fig.. HARNESS SUPPORT 0CK50-M0380 Fig. 7B SUPPORT ASSY,HARNESS WASHER, BOLT, M0X BOLT, M0X 40

33 0CK50-M0380 ELECTRICAL PARTS Fig.3. BATTERY(MINUS CABLE) 0CK50-M0380 Fig.3 7B04-6 CABLE,BATTERY MINUS WASHER, BOLT, M0X 0

34 0CK50-M0380 ELECTRICAL PARTS Fig.4. HORN 0CK50-M0380 Fig HORN BOLT, M6X

35 0CK50-M0380 ELECTRICAL PARTS Fig.5. P.T.O.(ANGLE BLADE SPEC.) 0CK50-M0380 Fig.5 7B HARNESS,PTO Remarks * Exclusive figure for angle blade specification.

36 0CK50-M0380 ELECTRICAL PARTS Fig.6. HARNESS GUIDE 0CK50-M0380 Fig.6 7B GUIDE ASSY, HARNESS BOLT, M0X BOLT, M0X 5

37 0CK50-M0380 ELECTRICAL PARTS Fig.7. STARTER SWITCH 0CK50-M0380 Fig.7 7B WASHER, 0.X3X SWITCH, STARTING NUT, RING WASHER KEY ASSY, SPARE

38 0CK50-M0380 ELECTRICAL PARTS Fig.8. AROUND THE SEAT 0CK50-M0380 Fig BAND BAND BAND BAND BAND 6 7B PLATE ASSY,CON S 7 7B MOUNT,HARNESS S 8 7B04-65 HARNESS ASSY,S.M. A RESISTANCE, W R FUSE, 5A FUSE, 0A FUSE, 0A A FUSE, 5A E DIODE, 090,.5A 7 E DIODE, 090,.5A 8 E MINI FUSE PULLER E DIODE, CLAMP BAND 4 7B BOX ASSY,ELECTRIC 5 7B STAY ASSY,CONNECTOR 6 7B STAY ASSY,RELAY0 7 7B COVER, FUSE 8 7A PLATE ASSY,SWITCH 9 7A SOCKET ASSY 30 7B STAY ASSY,MAIN HNS 3 7B04-76 SEAL, A SWITCH, ENGINE STOP 34 7B SUPPORT ASSY,HARNESS 35 7B CLIP,SWP CONNECTOR 36 7B PLATE ASSY, GPS 37 D SWITCH, PUSH BAND, CLIP 39 A RELAY, ACM3M BAND, BAND, BAND, BAND, BAND, A CLAMP, A CLAMP, GROMMET GROMMET BOLT RELAY, ISO 70A 5 E CLAMP, BAND 5 E CLAMP, BAND 53 E CLAMP, BAND WASHER, BOLT, M6X BOLT, M6X 0 ++ CONTINUE ++

39 0CK50-M0380 ELECTRICAL PARTS Fig.8. AROUND THE SEAT 0CK50-M0380 Fig BOLT, M8X BOLT, M0X BOLT, M6X BOLT, M6X BOLT, M6X BOLT, M6X BOLT, M8X BOLT, M8X BOLT, M8X BOLT, M8X 6 PLATED CLIP, TREE

40 0CK50-M0380 ELECTRICAL PARTS Fig.9. ANGLE BLADE LEVER(ANGLE BLADE SPEC.) 0CK50-M0380 Fig BAND 3 3 7B HARNESS,ANGLE BLADE 3 7B0-750 RELAY,CA C TYPE BOLT, M6X 6 Remarks * Exclusive figure for angle blade specification.

41 0CK50-M0380 ELECTRICAL PARTS Fig.30. PRESSURE SWITCH 0CK50-M0380 Fig SWITCH, PRESSURE 7A47-76 CONNECTOR, G/8XR/ O-RING, BP A CONNECTOR, G/8XR/ O-RING, BP8.0

42 0CK50-M0380 ELECTRICAL PARTS Fig.3. TRAVEL BUZZER 0CK50-M0380 Fig.3 7B HARNESS,BUZZER 7B BRACKET ASSY,BUZZUR 3 7B BRACKET ASSY 4 7B PLATE,TRAVEL GROMMET BUZZER, BACK GROMMET BOLT, M6X BOLT, M6X BOLT, M8X BOLT, M8X 0

43 0CK50-M0380 ELECTRICAL PARTS Fig.3. CONTROLLER 0CK50-M0380 Fig.3 7B CONTROLLER KIT,WORK BOLT, M6X 0 Remarks ()Spare parts. To install proper information, go to an authorized distributor.

44 0CK50-M0380 ELECTRICAL PARTS Fig.33. WORK LAMP 0CK50-M0380 Fig.33 7B CLAMP 7B HARNESS,WORK LAMP BAND 4 7B LAMP ASSY,WORK 5 7B BULB, V 55W 6 E CLAMP, BAND WASHER, BOLT, M0X 6 9 7B CLAMP WASHER, WASHER, BOLT, M8X BOLT, M0X 6 3 3

45 0CK50-M0380 ELECTRICAL PARTS Fig.34. INSTRUMENT PANEL(CANOPY) 0CK50-M0380 Fig PLUG, PANEL BUZZER 3 7B MONITOR ASSY 4 7B03-76 MONITOR ASSY,UPPER 5 7B SWITCH,LIGHT 6 7B COVER,SWITCH LIGHT 7 7B SWITCH, ECO 8 7B COVER,SWITCH ECO 9 7B SWITCH, AUTO DECEL 0 7B COVER,SWITCH A/D 7B SWITCH, DPF 7B COVER,SWITCH DPF WASHER, WASHER, SPRING BOLT, M6X BOLT, M5X 0 PLATED 4 Remarks * DPF: DPF stands for DIESEL PARTICULATE FILTER.

46 0CK50-M0380 ELECTRICAL PARTS Fig.35. INSTRUMENT PANEL(CABIN)(HEATER SPEC.) 0CK50-M0380 Fig PLUG, PANEL BUZZER 3 7B MONITOR ASSY 4 7B03-76 MONITOR ASSY,UPPER 5 7B SWITCH,LIGHT 6 7B COVER,SWITCH LIGHT 7 7B SWITCH, ECO 8 7B COVER,SWITCH ECO 9 7B SWITCH, AUTO DECEL 0 7B COVER,SWITCH A/D 7B SWITCH,WIPER 7B COVER,SWITCH WIPER 3 7B SWITCH,HEATER 4 7B COVER,SWITCH HEATER 5 7B SWITCH, DPF 6 7B COVER,SWITCH DPF WASHER, WASHER, SPRING BOLT, M6X BOLT, M5X 0 PLATED 4 Remarks * DPF: DPF stands for DIESEL PARTICULATE FILTER.

47 0CK50-M0380 ELECTRICAL PARTS Fig.36. INSTRUMENT PANEL(CABIN)(AIR CONDITIONER SPEC.) 0CK50-M0380 Fig PLUG, PANEL BUZZER 3 7B MONITOR ASSY 4 7B03-76 MONITOR ASSY,UPPER 5 7B SWITCH,LIGHT 6 7B COVER,SWITCH LIGHT 7 7B SWITCH, ECO 8 7B COVER,SWITCH ECO 9 7B SWITCH, AUTO DECEL 0 7B COVER,SWITCH A/D 7B SWITCH,WIPER 7B COVER,SWITCH WIPER 3 7B SWITCH, DPF 4 7B COVER,SWITCH DPF WASHER, WASHER, SPRING BOLT, M6X BOLT, M5X 0 PLATED 4 Remarks * DPF: DPF stands for DIESEL PARTICULATE FILTER.

48 0CK50-M0380 ELECTRICAL PARTS Fig.37. HARNESS(HEATER) 0CK50-M0380 Fig.37 7B HARNESS,HEATER

49 0CK50-M0380 ELECTRICAL PARTS Fig.38. WORK CONTROL 0CK50-M0380 Fig.38 7B HARNESS ASSY,WORKCTL E DIODE, 090,.5A 3 E DIODE, A RELAY, ACM3M BAND, WASHER, BOLT, M0X 0 8 7B CONNECTOR,CAP

50 0CK50-M0380 ELECTRICAL PARTS Fig.39. QUICK COUPLER(SWITCH BOX) 0CK50-M0380 Fig BOX,SWITCH EX D LABEL, SWITCH LABEL, COVER BOX,SWITCH D SWITCH ASSY SWITCH ASSY LAMP, INDICATOR SCREW, TAPPING SCREW, TAPPING PACKING BRACKET CORD CASE,UPPER PIN, SPRING 3.0X SCREW PLUG 9 7B STAY ASSY BOLT, M8X STAPLE

51 0CK50-M0380 ELECTRICAL PARTS Fig.40. RELAY BRACKET 0CK50-M0380 Fig.40 7B04-70 STAY ASSY, RELAY BOLT, M6X

52 0CK50-M0380 ELECTRICAL PARTS Fig.4. GPS 0CK50-M0380 Fig.4 RF CONTROLLER,MOBILE,O 6 7B PARTS ASSY, GPS 7 7B HARNESS ASSY,GPS 8 3 E DIODE, B COVER ASSY,GPS 0 7B PLATE, ANTENNA BOLT 5 5 A RELAY, ACM3M BAND, BAND, GROMMET BOLT, M6X BOLT, M6X 6 8 7B-6590 ANTENNA ASSY,MOBILE Remarks ()To install proper information, go to an authorized distributor. Note : Carrier registration is required when replacing this part. * For more information, contact the service department of the dealer you purchased from. Note : Registration is required when replacing this part. * For more information, contact the service department of the dealer you purchased from.

53 0CK50-M0380 AIR CONDITIONER & HEATER Fig.4. AIR CONDITIONER(UNIT) 0CK50-M0380 Fig.4 7B03-90 AIR CON UNIT 7B BRACKET,AMP 3 7B O-RING 4 7B O-RING 5 7B INSULATOR,HARNESS 6 7B ELBOW,DRAIN 7 7B MOTOR ASSY,BLOWER 8 7B03-90 FILTER, REC 9 7B06-90 BOLT, SOCKET M5X40 0 7B BRACKET, 7B BRACKET, 7B HOLDER,THERMISTOR 3 7B HOSE, HEATER 4 7B SCREW, PAN HEAD 5 7B03-99 HARNESS ASSY, HVAC 6 7B RELAY 7 7B SEAL,CASE 8 7B03-90 CONTROLLER, HVAC 9 7B03-90 SEAL, OUTLET 0 7B COVER, FRONT 7B COVER, BACK 7B CASE ASSY, LOW FRONT 3 7B CASE ASSY, LOW BACK 4 7B MOUNT, RESISTOR 5 7B RETAINER, VALVE 6 7B HOSE, DRAIN 7 7B HOSE, DRAIN 8 7B CLAMP, HOSE 9 7B RESISTOR 30 7B VALVE ASSY, WATER 3 7B CASE ASSY, UP FEMALE 3 7B CASE ASSY, UP MALE 33 7B COVER ASSY, PAF 34 7B SEAL, AC-UNIT 35 7B SEAL, AC-UNIT 36 7B RETAINER, TXV 37 7B VALVE, EXPANSION 38 7B SENSOR, TEMPERATURE 39 7B EVAPORATOR ASSY 40 7B STAY 4 7B HEATER ASSY 4 7B DUCT ASSY 43 7B BRACKET, DUCT 44 7B LEVER ASSY, DOOR 45 7B DOOR ASSY 46 7B KNOB 47 7B SPACER, C 48 7B SPRING 49 7B SCREW, 3X6 50 7B SCREW, 4X0 5 7B SCREW, 4X CONTINUE ++

54 0CK50-M0380 AIR CONDITIONER & HEATER Fig.4. AIR CONDITIONER(UNIT) 0CK50-M0380 Fig.4 5 7B SCREW, 5X5

55 0CK50-M0380 AIR CONDITIONER & HEATER Fig.43. AIR CONDITIONER(ACCESSORY) 0CK50-M0380 Fig JOINT, HOSE 7B STAY ASSY 3 7B BRACKET ASSY, AC F 4 7B GROMMET, HOSE-AC 5 7B GROMMET 6 7B SPONGE, PARTITION 8 7B FILTER, AIR 9 7B SWITCH, BLOWER 0 7B SWITCH, THERMO 7B KNOB 7B03-90 PLATE, FLANGE 3 7B PIPE, HVAC IN 4 7B O-RING 5 7B PIPE, HVAC OUT 6 7B O-RING 7 7B HOSE, DRAIN AC 8 7B SWITCH ASSY 9 7B HOSE, HEATER IN 0 7B HOSE, HEATER ELBOW SCREW, 5X CLAMP, HOSE CLAMP, HOSE CLAMP, CLAMP, BOLT, M8X BOLT, M8X BOLT, M6X 0 PLATED

56 0CK50-M0380 AIR CONDITIONER & HEATER Fig.44. AIR CONDITIONER(PIPING) 0CK50-M0380 Fig BAND BAND CLIP, HOSE JOINT, PIPE 5 7B STAY ASSY, H-PIPE A 6 7B STAY ASSY, H-PIPE B 7 7B PIPE ASSY, HEATER 8 7B CLAMP, HOSE 9 7B HOSE ASSY, COMP-COND 0 7B O-RING 7B HOSE ASSY, R/D-UNIT 7B O-RING 3 7B HOSE ASSY, UNIT-COMP 4 7B O-RING 5 7B HOSE, HEATER B HOSE, HEATER B HOSE, HEATER CLAMP, BOLT, M8X BOLT, M8X BOLT, M8X BOLT, M8X BOLT, M6X 5 PLATED BOLT, M8X 5 PLATED 5 7B GUIDE ASSY, HOSE BOLT, M8X 0

57 0CK50-M0380 AIR CONDITIONER & HEATER Fig.45. AIR CONDITIONER(ENGINE RELATED) 0CK50-M0380 Fig.45 A NUT, M6X5 7A47-00 PULLEY BAND 4 7B COMPRESSOR ASSY PULLEY, TENSION 6 7B BRACKET ASSY, PULLY 7 7B PLATE, PULLY ADJUSTER ASSY BOSS 0 7B BRACKET ASSY, COMP-A 7B BRACKET ASSY, COMP-B 7B COVER, COMPRESSOR V-BELT 4 A WASHER, SPRING COLLAR WASHER, SEAL WASHER, SPRING WASHER, SPRING RING, BEARING, 603UUC BOLT, M8X BOLT, M0X BOLT, M8X BOLT, M8X BOLT, M8X BOLT, M8X 5 PLATED BOLT, M8X 5 PLATED BOLT, M8X 35 PLATED NUT, M NUT, M8

58 0CK50-M0380 AIR CONDITIONER & HEATER Fig.46. AIR CONDITIONER(CONDENSER RELATED) 0CK50-M0380 Fig.46 7B DRIER, RECEIVER 7B DUCT ASSY 4 7A SEAL, B BRACKET ASSY, R/D 6 7B CONDENSER ASSY 7 7B CONDENSER 8 7B BRACKET ASSY, COND 9 7B COVER ASSY, COND FAN 0 7B MOTOR ASSY, FAN BOLT, M6X 6 PLATED BOLT, M6X 60 PLATED NUT, M B PIPE ASSY 5 7B O-RING BOLT, M8X BOLT, M8X BOLT, M8X BOLT, M6X 5 PLATED

59 0CK50-M0380 AIR CONDITIONER & HEATER Fig.47. AIR CONDITIONER(ELECTRIC PARTS) 0CK50-M0380 Fig BAND 4 7B HARNESS ASSY,A/C 3 E DIODE, BAND, 00 3

60 0CK50-M0380 AIR CONDITIONER & HEATER Fig.48. HEATER(UNIT) 0CK50-M0380 Fig.48 7B HEATER ASSY 7B HARNESS ASSY, HEATER 3 7B CASE, UPPER FEMALE 4 7B CASE, UPPER MALE 5 7B COVER, HEATER 6 7B MOTOR ASSY,BLOWER 7 7B03-90 FILTER, REC 8 7B BRACKET, 9 7B BRACKET, 0 7B SCREW, PAN HEAD 7B03-90 SEAL, OUTLET 7B COVER, FRONT 3 7B COVER, BACK 4 7B CASE ASSY, LOW FRONT 5 7B CASE ASSY, LOW BACK 6 7B MOUNT, RESISTOR 7 7B RESISTOR 8 7B SEAL, AC-UNIT 9 7B SEAL, AC-UNIT 0 7B HEATER ASSY 7B DUCT ASSY 7B BRACKET, DUCT 3 7B LEVER ASSY, DOOR 4 7B DOOR ASSY 5 7B KNOB 6 7B SPACER, C 7 7B SPRING 8 7B SCREW, 3X6 9 7B SCREW, 4X0 30 7B SCREW, 4X6 34

61 0CK50-M0380 AIR CONDITIONER & HEATER Fig.49. HEATER(ACCESSORY) 0CK50-M0380 Fig JOINT, HOSE 7B STAY ASSY 3 7B BRACKET ASSY, AC F 4 7B GROMMET, HOSE-HEATER 5 7B SPONGE, PARTITION 7 7B FILTER, AIR 8 7B HOSE, HEATER ELBOW 9 7B HOSE, HEATER IN 0 7B GROMMET GROMMET SCREW, 5X CLAMP, HOSE CLAMP, CLAMP, BOLT, M8X BOLT, M8X 0 4

62 0CK50-M0380 AIR CONDITIONER & HEATER Fig.50. HEATER(PIPING) 0CK50-M0380 Fig BAND 7B CONNECTOR, HEATER VALVE ASSY, HEATER JOINT, PIPE 5 7B STAY ASSY, H-PIPE A 6 7B STAY ASSY, H-PIPE B 7 7B PIPE ASSY, HEATER 8 7B HOSE, HEATER B HOSE, HEATER ENG-T4 0 7B HOSE, HEATER CLAMP, BOLT, M8X BOLT, M8X BOLT, M8X 0

63 0CK50-M0380 AIR CONDITIONER & HEATER Fig.5. DUCT(AIR CONDITIONER & HEATER) 0CK50-M0380 Fig GRILLE 7B DUCT ASSY 3 7B DUCT 4 7B DUCT ASSY, INTAKE 5 7A TRIM 7 7B SEAL, DUCT NUT, M6 9 A RIVET, PUSH 0 A GRILLE ASSY, FRONT BOLT, M8X BOLT, M6X BOLT, M8X 0

64 0CK50-M0380 TRAVELING Fig.5. SPROCKET 0CK50-M0380 Fig.5 7B SPROCKET, BOLT WASHER, SPRING 4

65 0CK50-M0380 TRAVELING Fig.53. IDLER & ADJUST 0CK50-M0380 Fig.53 7B IDLER ASSY 7B IDLER ASSY, B IDLER, B BUSH,IDLER 5 3 7B PIN,0X B SHAFT,IDLER 7 3 7B SEAL,COVER IDLER A 8 3 7B SEAL,COVERIDLER B 9 3 7B SEAL KIT, IDLER 3 7B O-RING 3 7B PLUG 3 7B SPRING ASSY, CRAWL BOLT, MX B CYLINDER ASSY, ADJUS 6 7B O-RING 7 7B RING, BACK UP 8 7B SEAL, DUST 9 7B TUBE ASSY,ADJUST 0 7B PISTON 7B NIPPLE,VALVE

66 0CK50-M0380 TRAVELING Fig.54. TRACK ROLLER 0CK50-M0380 Fig.54 7B ROLLER ASSY, TRACK 8 8 7B PLUG B ROLLER, LOWER B SHAFT ASSY B COVER,SEAL B B RING, SNAP B SEAL KIT, TRACK B BUSH,TRACK ROLLER B O-RING BOLT WASHER, SPRING 6 6 6

67 0CK50-M0380 TRAVELING Fig.55. CARRIER ROLLER 0CK50-M0380 Fig ROLLER ASSY, CARRIER SEAL, OIL ROLLER, CARRIER SHAFT,CARRIER ROLLER CAP, ROLLER WASHER, CARRIER RING, RING, BEARING, BALL 606Z PLUG WASHER, SPRING BOLT, M6X 85 PLATED NUT, M6

68 0CK50-M0380 TRAVELING Fig.56. IRON CRAWLER 0CK50-M0380 Fig.56 7B SHOE ASSY, TRACK 350 7B LINK ASSY, TRACK B LINK, TRACK L B LINK, TRACK R B LINK, MASTER L 6 3 7B LINK, MASTER R 7 3 7B BUSH, TRACK B PIN, TRACK B PIN, MASTER 0 3 7B PIN, CLAMPING 7B BOLT, SHOE B NUT, SHOE B SHOE, TRACK B TRACK, MASTER B LINK, MASTER L 6 7B LINK, MASTER R 7 7B BUSH, TRACK 8 7B BOLT, SHOE 9 7B NUT, SHOE 0 7B SHOE, TRACK 350 Remarks ()Spare parts.

69 0CK50-M0380 TRAVELING Fig.57. RUBBER CRAWLER 0CK50-M0380 Fig.57 7B CRAWLER, RUBBER 350

70 0CK50-M0380 CONTROL EQUIPMENT Fig.58. TRAVEL PEDAL 0CK50-M0380 Fig.58 7B PEDAL ASSY, TRACK L SPRING 3 7B PEDAL ASSY, TRACK FL 4 7B PEDAL ASSY, TRACK RL BUSH WASHER, NUT, M8 9 7B PEDAL ASSY, TRACK R SPRING 7B PEDAL ASSY, TRACK FR 7B PEDAL ASSY, TRACK RR BUSH WASHER, NUT, M BOLT, M8X 30 PLATED

71 0CK50-M0380 CONTROL EQUIPMENT Fig.59. VALVE MOUNT 0CK50-M0380 Fig.59 7B MOUNT ASSY,LINK WASHER, BOLT, M0X BOLT, M0X 5

72 0CK50-M0380 CONTROL EQUIPMENT Fig.60. TRAVEL LEVER 0CK50-M0380 Fig BOOT 7B LEVER ASSY, TRACK L BUSH 5 7B LEVER ASSY, TRACK R BUSH 8 7B SHAFT ASSY GRIP, DRIVE GRIP, DRIVE O-RING ROD ASSY, SPOOL ELBOW 4 C PIN, SNAP WASHER, WASHER, NIPPLE, GREASE PT/ BOLT, M8X NUT, M BOLT, M8X 30 PLATED SCREW, M4X NUT, M PIN

73 0CK50-M0380 CONTROL EQUIPMENT Fig.6. SWING PEDAL 0CK50-M0380 Fig NUT, M8 7B LINK ASSY, SWING BUSH SHAFT, PEDAL 6 7B BRACKET, SWING 7 7B ROD ASSY, B LINK ASSY, PEDAL BUSH, 4X PEDAL, SWING COVER, PEDAL SHAFT PAD 5 A WASHER, 0X36X ROD ASSY BOOT, PEDAL O-RING BOLT ELBOW C PIN, SNAP 6 E BALL, LINK BL8DL WASHER, WASHER, WASHER, SPRING WASHER, SPRING PIN, COTTER.5X O-RING, AP NIPPLE, GREASE PT/ NIPPLE, GREASE B BOLT, M8X BOLT, M0X NUT, M BOLT, M8X 5 PLATED BOLT, M0X 0 PLATED NUT, M PIN

74 0CK50-M0380 CONTROL EQUIPMENT Fig.6. LINK COVER 0CK50-M0380 Fig BRACKET, BOOT 7B COVER, NO ND WASHER, WASHER, BOLT, M8X BOLT, M8X 6

75 0CK50-M0380 CONTROL EQUIPMENT Fig.63. PEDAL COVER 0CK50-M0380 Fig PAD 7B COVER ASSY BOLT, M8X 6 3 3

76 0CK50-M0380 CONTROL EQUIPMENT Fig.64. LEVER SPACER 0CK50-M0380 Fig.64 7B SPACER ASSY, L 7B SPACER ASSY, R BOLT, M6X BOLT, M6X 0

77 0CK50-M0380 CONTROL EQUIPMENT Fig.65. BLADE LEVER 0CK50-M0380 Fig.65 7B LEVER ASSY, BLADE EX BUSH, 4X5 4 7B CABLE, BLADE 5 7B BRACKET ASSY, BLADE 6 7B BOSS ASSY, LINK BUSH, 4X5 9 7B SHAFT ASSY, LINK 0 7B ROD, 30 C PIN, SNAP 6 C PIN, SNAP 6 3 C PIN, SNAP WASHER, WASHER, WASHER, WASHER, WASHER, RING, O-RING, AP BOLT, M8X BOLT, M0X BOLT, M8X BOLT, M8X 5 PLATED NUT, LOCK M PIN 7 7B KNOB ASSY,BLADE SW SCREW, M4X 6 Remarks * Not applied for angle blade specification.

78 0CK50-M0380 CONTROL EQUIPMENT Fig.66. BLADE LEVER(ANGLE BLADE SPEC.) 0CK50-M0380 Fig.66 7B GRIP, ANGLE BLADE 7B LEVER ASSY, ANGLE BUSH, 4X5 5 7B CABLE, BLADE 6 7B BRACKET ASSY, BLADE 7 7B BOSS ASSY, LINK BUSH, 4X5 0 7B SHAFT ASSY, LINK 7B ROD, 30 C PIN, SNAP 6 3 C PIN, SNAP 6 4 C PIN, SNAP BAND, WASHER, WASHER, WASHER, WASHER, WASHER, RING, PIN, SPRING 5.0X O-RING, AP BOLT, M8X BOLT, M0X BOLT, M8X BOLT, M8X 5 PLATED NUT, LOCK M PIN Remarks * Exclusive figure for angle blade specification.

79 0CK50-M0380 CONTROL EQUIPMENT Fig.67. ARMREST 0CK50-M0380 Fig ARMREST 7A GUIDE ASSY 3 7A PLATE, GUIDE BOLT BOLT

80 0CK50-M0380 CONTROL EQUIPMENT Fig.68. LOCK LEVER & STAND 0CK50-M0380 Fig.68 7A GRIP 7B STAND ASSY, LEVER BUSH NIPPLE, GREASE PT/8 6 7B BASE ASSY, LEVER L 7 7A SPRING 8 7B ROD ASSY, GUIDE 9 7B LEVER ASSY, LOCK L 0 7B STAND ASSY, LEVER SPRING, GAS BUSH WASHER, WASHER, RING, RING, E PIN, SPRING 3.5X PIN, SPRING 6.0X PIN, COTTER.0X BOLT, M0X BOLT, M0X 5 3 3

81 0CK50-M0380 FRAME Fig.69. TRACK FRAME 0CK50-M0380 Fig.69 7B FRAME ASSY, LOWER COVER, FRAME BOLT, M0X PLATED GROMMET Remarks * Not applied for angle blade specification.

82 0CK50-M0380 FRAME Fig.70. CRAWLER GUARD 0CK50-M0380 Fig GUARD, CRAWLER WASHER, SPRING BOLT, M6X 35 PLATED Remarks ()Iron crawler specification.

83 0CK50-M0380 FRAME Fig.7. COUNTER WEIGHT 0CK50-M0380 Fig.7 7B WEIGHT ASSY, B SPONGE,WEIGHT WASHER BOLT GROMMET

84 0CK50-M0380 FRAME Fig.7. TURNING FRAME 0CK50-M0380 Fig.7 7A-300 BOLT 7B FRAME ASSY, TURNING 4 7B BUSH, 90X90 5 7B BUSH, 90X5 6 7B MOUNT ASSY, FRAME 7 7B SEAL, B BRACKET ASSY WASHER, SPRING BOLT, MX 40

85 0CK50-M0380 FRAME Fig.73. TURNING BEARING 0CK50-M0380 Fig.73 7B BEARING ASSY, SWING 7B SEAL, BEARING PIN, PARALLEL BOLT A BOLT 0 0

86 0CK50-M0380 COVER Fig.74. COVER(MULTI) 0CK50-M0380 Fig.74 7B STAY ASSY, MULTI 7B STAY ASSY,MULTI A B 3 7B STAY, HOLDER 4 7B COVER ASSY, MULTI 6 7B SEAL, MULTI 7 7B SPONGE 8 7B COVER ASSY, MULTI 0 7B SEAL, MULTI GROMMET 7B COVER ASSY, MULTI 4 7B SEAL, MULTI 5 7B SPONGE GROMMET HOLDER, ROD HOLDER, ROD 9 7B HINGE ASSY,MULTI 0 7B HINGE ASSY,MULTI SHAFT, HINGE SHAFT, HINGE RING, E RING, E BOLT, M0X BOLT, M0X BOLT, M0X BOLT, M0X BOLT, M0X BOLT, M0X BOLT, M0X SCREW, M5X SCREW, M5X0

87 0CK50-M0380 COVER Fig.75. UPPER COVER() 0CK50-M0380 Fig.75 7B COVER ASSY,B BLACK 7B COVER, B BLACK 3 7B PLATE, LOCK 4 7B04-67 STAY, KEY 5 7A PLATE, LOCK 6 7B HOOK ASSY, OP/CL 7 7B PLATE ASSY, HINGE 8 7A LEVER ASSY SPRING, STOPPER 0 7B CYLINDER ASSY, KEY WASHER, BOLT, M8X BOLT, M8X BOLT, M0X NUT, M NUT, M0 7 A WASHER, BELT COVER ROD ASSY, STOPPER WASHER, PIN, COTTER.0X BOLT, M0X 0 3 3

88 0CK50-M0380 COVER Fig.76. UPPER COVER() 0CK50-M0380 Fig.76 7B COVER ASSY, C 3 7B SPONGE, COVER 4 7B SPONGE,B COVER 5 7A SEAL, RUBBER, SEAL 590 6A 7A38-03 LABEL, ANTI-FREEZING 6B LABEL, RADIATOR 6C LABEL, AIR CLEANER 7 7B-630 COVER,UPPER BOLT, M0X BOLT, M0X BOLT, M0X BOLT, M0X 60 Remarks ()Attach the No.6A, 6B & 6C label to this part. ()Label is not illustrated.

89 0CK50-M0380 COVER Fig.77. COVER(TURNING FRAME) 0CK50-M0380 Fig.77 7B COVER,VALVE STAND 7B COVER,OILPAN 3 7B COVER, PUMP 4 7B COVER,RESERVOIR BOLT, M0X 6 PLATED BOLT, M0X 6 PLATED BOLT, M0X 6 PLATED BOLT, M0X 6 PLATED 3 3

90 0CK50-M0380 COVER Fig.78. COVER(TRAVEL FRAME) 0CK50-M0380 Fig.78 7B COVER, MOTOR COVER,UNDER(GRAY:49) TRIM WASHER, BOLT, M0X BOLT, MX 30

91 0CK50-M0380 COVER Fig.79. FRAME GUARD(LEFT) 0CK50-M0380 Fig.79 7B GUARD ASSY, FRAME L 3 7B SPONGE, GUARD L B 4 7B SPONGE, GUARD L B TRIM 5A LABEL, CYLINDER WASHER, BOLT, M0X 5 Remarks ()Attach the No.5A label to this part. ()Label is not illustrated.

92 0CK50-M0380 COVER Fig.80. FRAME GUARD(RIGHT) 0CK50-M0380 Fig.80 7B04-60 GUARD ASSY, FRAME R SEAL 4 7B SPONGE, GUARD R B 5 7B SPONGE, GUARD R B 5A LABEL, CYLINDER WASHER, BOLT, M0X 5 Remarks ()Attach the No.5A label to this part. ()Label is not illustrated.

93 0CK50-M0380 COVER Fig.8. COVER(TURNING FRAME)(FRONT - LEFT) 0CK50-M0380 Fig.8 7B04-60 COVER ASSY, HOSE 7B COVER,L T/F WASHER, BOLT, M0X BOLT, M0X 5 3 3

94 0CK50-M0380 COVER Fig.8. COVER(TURNING FRAME)(FRONT - RIGHT) 0CK50-M0380 Fig.8 7B COVER ASSY,R T/F 3 7B SPONGE, COVER R T/F BOLT, M0X 5

95 0CK50-M0380 AROUND SEAT Fig.83. STEP(CABIN) 0CK50-M0380 Fig.83 7B FLOOR MAT, A CAB 7B FLOOR MAT, B CAB EX 3 7B PLATE, PARTITION 4 7B03-65 STEP ASSY 5 7B STEP, NON SLIP 6 7B STEP ASSY 8 7B SPONGE, STEP A 9 7B COVER 0 7B COVER ASSY, STEP CAB 7B SPONGE, COVER CAB 3 7B SEAL, STEP COVER CAB SHEET, NON SLIP WASHER, BOLT, M6X BOLT, M8X BOLT, M0X BOLT, M0X BOLT, M0X 0

96 0CK50-M0380 AROUND SEAT Fig.84. STEP(CANOPY) 0CK50-M0380 Fig.84 7B FLOOR MAT, A P 7B FLOOR MAT, B 4P EX 3 7B STEP, NON SLIP 4 7B STEP ASSY 6 7B SPONGE, STEP A 7 7B COVER 8 7B STEP ASSY, R 4P 0 7B SPONGE, STEP R CNP WASHER, BOLT, M8X BOLT, M0X BOLT, M0X 0 4

97 0CK50-M0380 AROUND SEAT Fig.85. COVER(LEVER) 0CK50-M0380 Fig BOLT BOLT 3 7B COVER, LEVER L UP D 4 7B COVER, LEVER L LOW D 5 7B COVER, LEVER R D 6 A RIVET, PUSH

98 0CK50-M0380 AROUND SEAT Fig.86. COVER(MONITOR)(CANOPY) 0CK50-M0380 Fig CLIP, TREE SCREW SCREW SCREW NUT, SPEED M6 6 7B GROMMET 7 7B STAY ASSY, INPANE 8 7B COVER, SWITCH P D 9 7B COVER, I/P LOW-P D 0 7B COVER, I/P UP-P D BOLT, M0X SCREW, TAPPING M5X4

99 0CK50-M0380 AROUND SEAT Fig.87. COVER(MONITOR)(CABIN)(AIR CONDITIONER SPEC.) 0CK50-M0380 Fig SCREW SCREW SCREW NUT, SPEED M6 5 7B GROMMET 6 7B STAY ASSY, INPANE 7 7B COVER ASSY, AC D 8 7B SEAL, DUCT 0 A SEAL, DUCT SIDE 0A LABEL, MANUAL 7B PANEL, AC D 7B COVER, SWITCH C D 3 7B COVER ASSY, I/P C D 4 7B SEAL, DUCT 6 A RIVET, PUSH 7 A RIVET, PUSH BOLT, M0X 0 Remarks ()Attach the No.0A label to this part. ()Label is not illustrated.

100 0CK50-M0380 AROUND SEAT Fig.88. COVER(MONITOR)(CABIN)(HEATER SPEC.) 0CK50-M0380 Fig SCREW SCREW SCREW NUT, SPEED M6 5 7B GROMMET 6 7B STAY ASSY, INPANE 7 7B COVER ASSY, AC D 8 7B SEAL, DUCT 0 A SEAL, DUCT SIDE 0A LABEL, MANUAL 7B COVER, SWITCH P D 7B COVER ASSY, I/P C D 3 7B SEAL, DUCT 5 A RIVET, PUSH 6 A RIVET, PUSH BOLT, M0X 0 Remarks ()Attach the No.0A label to this part. ()Label is not illustrated.

101 0CK50-M0380 AROUND SEAT Fig.89. SEAT MOUNT 0CK50-M0380 Fig.89 7B STAY ASSY, COVER 7B COVER ASSY, REAR 3 7B SEAL, COVER A 4 7B SEAL, COVER B 5 7B SEAL, COVER C 7 7B MOUNT ASSY, SEAT 8 7B GROMMET 9 7B SPONGE, REAR 0 7B SPONGE, L 7B SPONGE, SIDE 7B SPONGE, UP 3 7B SPONGE, PARTITION 4 7B SHEET, INSULATION F 5 7B SHEET, INSULATION R 6 7B SEAL, 0X0X40 7 7B SEAL, PLUG RUBBER RUBBER, SEAL RUBBER, SEAL A LABEL, MANUAL 3 7B STAY ASSY, BONNET B 4 7B STAY ASSY, BONNET 5 7B GUIDE ASSY, HOSE WASHER, WASHER, WASHER, BOLT, M8X BOLT, M8X BOLT, M8X BOLT, M0X BOLT, M0X BOLT, M0X BOLT, M0X BOLT, M0X CLIP, TREE GROMMET GROMMET GROMMET Remarks ()Canopy specification. : Attach the No.A label to this part. ()Label is not illustrated.