Master Connection Diagram Series C R-Frame Circuit Breaker with DIGITRIP RMS Trip Units

Transcription

1 nstruction Leaflet L29C714L Supersedes L 29C714K Dated 01/12 Circuit Breaker with DGTRP RMS Trip Units

2 nstruction Leaflet L29C714L Circuit Breaker with DGTRP RMS Trip Units LNE NDEX DAGRAMS TRP UNT AND ACCESSORY MOUNTNG LOCATONS TERMNATON DAGRAM REV /750/ CONNECTONS FOR RMS /750/ MOTOR OPERATOR CONNECTON CONTROL 24 RD MASTER CONNECTON DAGRAM Cat No. EOPTOBC 25 RD BREAKER GROUND FAULT AND 26 RD MASTER CONNECTON DAGRAM - RG310+ Trip Unit 27 CD BLOCK CONNECTON A B C D E F G H J K L M N 0 P REFERENCES FRAME NSTRUCTONS RMS 500 AUXLARY SWTCH ALARM SWTCH SHUNT UNDERVOLTAGE RELEASE LOW ENERGY SHUNT MOTOR OPERATOR TERMNAL BLOCK RMS 600 RMS 700 RMS 800 RMS N SERES C FRAME RMS 510 RMS 610 RMS 810 RMS L. NO RD MASTER CONNECTON DAGRAM NDEX 1 EATON CORPORATON

3 Circuit Breaker with DGTRP RMS Trip Units nstruction Leaflet L29C714L STAB N DEDCATED 'b' CONTACT NTERNALLY ON RHS , 910 & MODULE RMS 910 DELECTRC ENERGY SHUNT NOTE: THE MAXMUM NUMBER OF ACCESSORES THAT MAY BE NSTALLED N ANY ONE CRCUT BREAKER S LMTED BY THE NUMBER OF PHYSCAL MOUNTNG POSTONS. RD MASTER CONNECTON DAGRAM TRP UNT AND ACCESSORY MOUNTNG LOCATONS EATON CORPORATON 2

4 nstruction Leaflet L29C714L Circuit Breaker with DGTRP RMS Trip Units TERMNAL BLOCKS TERMNAL BLOCKS Dl- Dl2 FOR TRP UNT FOR ACCESSORY CONNECTONS ONLY CONNECTONS ONLY TYPCAL CUSTOMER CODED TERMNAL CONNECTON LEAD BLOCK TYPCAL LEAD TERMNATON FRONT 0 VEW FXED MOUNTED BREAKER WTH SDE MOUNTED TERMNAL BLOCKS A SECONDARY CONNECTORS SECONDARY CONNECTORS Dl- Dl2 RASED RNG FUR TRP UNT CONNECTONS ONLY FOR ACCESSORY CONNECTONS ONLY <CAVTY NO.l WRNG TERMNATON MALE PN W OR AMP 'MULTMATE' TYPE C v v P/N FEMALE SUCKET AMP 'MULTMATE' A TYPE + P/N HANDCRMP TOOL AMP P/N FOR EXTRACTON AMP P/N R B AS TYPCAL DSCDNNECT PLUG VEWED FROM FRONT OF BREAKER COLOR CODED CUSTOMER SUPPLED FRONT VEW TERMNAL BLOCK DRAWUUT MOUNTED RD MASTER CONNECTON DAGRAM TERMNATON DAGRAM TYPCAL LEAD TERMNATON MOUNTED BREAKER FG. B 3 EATON CORPORATON

5 Circuit Breaker with DGTRP RMS Trip Units nstruction Leaflet L29C714L C R TOP FLUX SHUNT TRP WHT + A 1 RMS WHT BLK WHT BLK WHT SEE 19 AND NOTE 2 ON BREAKERS EQUPPED WTH A FAULT 17 TME 310 TRP UNT. NCLUDE AN D9, CRCUT NOT FOR USE ON SCR RD MASTER CONNECTON DAGRAM RMS NON-GROUND FAULT TRP UNT CONNECTONS A BREAKERS EATON CORPORATON 4

6 nstruction Leaflet L29C714L Circuit Breaker with DGTRP RMS Trip Units L C R TOP END END BASC BREAKER NTERNAL CONNECTONS (PARTAL ONLY) EXTERNAL SHORTNG STRAPS MUST DURNG SHEET 18 AND NOTE SHEET 17 TESTNG AND OPERATNG GFP ZONE NTERLOCKNG C4, N.P. SDE BREAKER RD MASTER CONNECTON DAGRAM RD WTH RMS UNT-GROUND FAULT EXTERNAL CONNECTONS BREAKERS 5 EATON CORPORATON

7 Circuit Breaker with DGTRP RMS Trip Units nstruction Leaflet L29C714L BREAKER FRAME RATNG SENSOR RATNG STYLE FLUX BOTTOM END EXTERNAL SHORTNG STRAPS BE PLACE NO. 14 OR NO. PER AND OPERATNG PER ON NEUTRAL SENSOR CDNNCTONS. NP. SDE BREAKER NEUTRAL SENSOR RATO MUST MATCH SENSORS BREAKER NEUTRAL SO THAT POLARTY RELATONSHP TOWARDS S DENTCAL SHEET 18 AND 1 SHEET 17 FOR NEUTRAL ZONE C4, RD RD MASTER CONNECTON DAGRAM RMS UNT-GROUND FAULT EXTERNAL CONNECTONS RESDUAL BREAKERS EATON CORPORATON 6

8 nstruction Leaflet L29C714L Circuit Breaker with DGTRP RMS Trip Units BREAKER NEUTRAL STYLE FRAME SENSOR RATNG RATNG AMPS AMPS L C R TOP END ELECTRODE GFP T.B. EXTERNAL SHORTNG STRAPS MUST BE N PLACE DURNG NO. 14 OR NO. 12 COPPER WRE PER.L TESTNG AND OPERATNG PER NSTRUCTON NEUTRAL SENSOR SECONDARY SDE BREAKER NEUTRAL SENSOR RATO MUST MATCH N BREAKER FRAME NEUTRAL SENSOR SO THAT POLARTY TOWARDS SOURCE S DENTCAL SHEET 18 AND NUTE 1 ON SHEET 17 FOR FR AND NEUTRAL SENSORS GFP NTERLOCKNG C4, RD MASTER CONNECTON DAGRAM RD WTH RMS UNT-GROUND FAULT EXTERNAL CONNECTONS3PH SOURCE GROUND BREAKERS 7 EATON CORPORATON

9 Circuit Breaker with DGTRP RMS Trip Units nstruction Leaflet L29C714L SOURCE N A B C FLUX TRP ENERGY SHUNT TRP, A \ \ :., A > RESDUAL SENSNG., A.. W ON D7 N A DS TO AND PONT CONNECT D8 ON FOUR PONT GFP GFP SENSNG. TERMNAL BLDCK GROUND SENSNG. ALSO SHEET (SEE SHEET RD MASTER CONNECTON DAGRAM CURRENT SENSOR CONNECTONS FOR (USE RMS) EATON CORPORATON 8

10 nstruction Leaflet L29C714L Circuit Breaker with DGTRP RMS Trip Units A L C R TOP END FLUX SHUNT TRP SHUNT WHT (+) 15. RMS WHT WHT WHT BLK v END BASC BREAKER NTERNAL CONNECTONS CPARTAL ONLY) NOTE: BREAKER MUST BE MARKED: BREAKER RD MASTER CONNECTON DAGRAM 3 POLE RD WTH RMS UNT-NEUTRALPROTECTED CONNECTONS, BREAKERS 9 EATON CORPORATON

11 Circuit Breaker with DGTRP RMS Trip Units nstruction Leaflet L29C714L T A B C D SHUNT TRP 310, 510, 810, , AND 1050 CRCUT A B C D BOTTOM RD MASTER CONNECTON DAGRAM 4 POLE RD WTH RMS UNT NEUTRAL PROTECTED CONNECTONS BREAKERS EATON CORPORATON 10

12 nstruction Leaflet L29C714L Circuit Breaker with DGTRP RMS Trip Units 11 EATON CORPORATON

13 Circuit Breaker with DGTRP RMS Trip Units nstruction Leaflet L29C714L A1 CAT. NO. NO. OF SWTCHES B8 B12 PREFERRED FG. A FG. B b B4 B5 B6 A 7 A 8 A9 A11 A12 b FG. C FG. D A l l A12 b FG. E THE MAXMUM NUMBER ACCESSORES THAT MAY BE NSTALLED N ANY ONE CRCUT BREAKER S LMTED BY THE NUMBER OF PHYSCAL POSTONS. RD MASTER CONNECTON DAGRAM ALARM (SGNAL) LOCKOUT SWTCH CONNECTONS EATON CORPORATON 12

14 nstruction Leaflet L29C714L Circuit Breaker with DGTRP RMS Trip Units A7 A 8 A9 A10 PREFERRED ST WHT FG. A ST A5 A 6 >- WHT FG. C ST THE MAXMUM NUMBER OF TVO SHUNT TRPS MAY BE NSTALLED N ANY ONE CRCUT BREAKER, RD MASTER CONNECTON DAGRAM SHUNT TRP CONNECTONS 13 EATON CORPORATON

15 Circuit Breaker with DGTRP RMS Trip Units nstruction Leaflet L29C714L A9 A10 PREFERRED FG. A FG, B A5 A6 FG. FG. NOTE: THE MAXMUM NUMBER OF TWO UVRS MAY BE NSTALLED N ANY ONE CRCUT BREAKER. RD MASTER CONNECTON DAGRAM RELEASE CONNECTONS EATON CORPORATON 14

16 nstruction Leaflet L29C714L Circuit Breaker with DGTRP RMS Trip Units A 7 AS A9 A10 PREFERRED FG. A FG. B A3 A 4 A5 A6 LEST FG. C LEST THE MAXMUM NJMBER OF ACCESSORES THAT MAY BE NSTALLED ANY ONE CRCUT BREAKER S BY NUMBER POSTONS. RD MASTER CONNECTON DAGRAM Low ENERGY SHUNT 15 EATON CORPORATON

17 Circuit Breaker with DGTRP RMS Trip Units nstruction Leaflet L29C714L CLOSED ND. T A3 r RD FRAME MOTOR OPERATOR 'SUPPLY LEGEND X AUX. RELAY BREAKER AUX. 1 TRANSFORMER MAY BE Y RELAY b BREAKER SWTCH REQURED SUPPLY -ON AND MOTOR CONTACTS SHOWN N OPEN RESET S -MOTOR OPERATOR TERMNAL BLOCK RD MASTER CONNECTON DAGRAM MOTOR OPERATOR CONNECTONS EATON CORPORATON 16

18 nstruction Leaflet L29C714L Circuit Breaker with DGTRP RMS Trip Units ALL RD BREAKERS EQUPPED WTH DGTRP RMS 500, 600, 700, 800, 510, 610, 810, 910, 750, AND 1050 TRP UNTS WTH GFP WLL TRP NEAR NSTANTANEOUSLY ( SEC.) REGARDLESS OF THE TME BAND SETTNG - F DUWNSTREAM NTERLOCK WRNG S NOT EMPLOYED A JUMPER S NOT ADDED BETWEEN CONTROL TERMNALS C4 AND WTH THE JUMPER ADDED, THE BREAKER WLL RESPOND TO THE PRE-SET TME DELAY SETTNG. CONSDER ADDNG THS JUMPER FOR ALL NSTALLATONS WTH GFP ON THE MAN BREAKER ONLY. NSTALLATONS WTH MULTPLE LEVELS OF GFP, SEE SHEET 2. ALL RD BREAKERS EQUPPED WTH RMS 500, 600, 700, 800, 510, 610, 810, 910, 750 AND 1050 TRP UNTS EQUPPED WTH AN ADJUSTABLE: SHORT TMEDELAY SETTNG WLL TRP NEAR NSTANTANEOUSLY ( REGARDLESS OF THE TME BAND SETTNG - F DOWNSTREAM NTERLOCK WRNG S EMPLOYED AND/OR A JUMPER S NOT ADDED BETWEEN CONTROL TERMNALS D9 WTH THE JUMPER ADDED, THE BREAKER WLL RESPOND TO THE PRE-SET TME DELAY SETTNG. FOR SELECTVE CDORDNATDN, NTERLOCK WRNG BE EMPLOYED. SEE SHEET 3, RD - BREAKERS HAVE BEEN DESGNED FOR MAXMUM PROTECTON, COMMUNCATONS AND ACCESSORY UTLZATON. THS REASON ALL LEADS N THE SECONDARY CONTROL BLOCKS MAY NOT BE USED BY A CUSTOMER FOR A PARTCULAR APPLCATON. W ARN N G BREAKER AUTOMATC OPEN AND CLOSE OPERATONS BY NCOM CDMMUNCATON SGNALS (VA TERMNALS AND UNDER SYSTEM OPERATNG OR MANTENANCE PERODS CAUSE SEVERE NJURY DEATH, NSTALL APPROPRATE PERMSSVE MEANS (SEE SHEET AVOD UNDESRED CLDSNG DURNG MANTENANCE OPERATONS AND PRDVDE ADEQUATE EQUPMENT WARNNGS FOR NORMAL PERODS. RD MASTER CONNECTON DAGRAM GENERAL NOTES 17 EATON CORPORATON

19 Circuit Breaker with DGTRP RMS Trip Units nstruction Leaflet L29C714L JUMPER MUST BE ADDED ON EACH DOWN STREAM BREAKER WHERE DELAY PRE-SET REQURED. SEE ALSO NOTE '1 SHEET '17. AND RUN SEPARATE FROM POWER CABLES PER A MAXMUM DSTANCE BETWEEN THE FRST AND LAST ZONE S 250 FEET A OF 20 MAY CONNECTED N PARALLEL ZONE 3 EMPLOYED SELF-NTERLOCK. A MAXMUM OF 20 MAY BE CONNECTED N SGNAL DODES TYPE 1 AS SHOWN N 3 ALTERNATE. OR A MAXMUM OF 5 BREAKERS MAY BE CONNECTED ZONE 3 WHEN EMPLOYED SELF-NTERLOCK. ZONE CONSDERATONS MUST 6 BE ON (DUAL SOURCE) DSTRBUTON SYSTEMS TO OR SEQUENCES. C4 OUTPUT COMMON RD MASTER CONNECTON DAGRAM TYPCAL GROUND FAULT ZONE NTERLOCKNG CONNECTONS FOR RADAL DSTRBUTON SYSTEM (USE WTH RMS EQUPPED WTH GROUND FUNCTON) 18 EATON CORPORATON 18

20 nstruction Leaflet L29C714L Circuit Breaker with DGTRP RMS Trip Units JUMPER MUST BE ADDED ON EACH DOWN STREAM BREAKER WHERE TME DELAY AS PRE-SET S REQURED. NOTE 2 SHEET 17. AND RUN SEPARATE FROM OR COPPER WRE 6 REQURED PER UL-1053 AMAXMUM DSTANCE BETWEENTHE FRST AND LAST ZONE S 250 FEET. A MAXMUM OF 20 MAY BE CONNECTED N PARALLEL ZONE SELF-NTERLOCK. A MAXMUM OF 20 BREAKERS MAY BE CONNECTED N EMPLOYED SELF-NTERLOCK SGNAL DODES OR EQUVALENT AS SHOWN N ZONE 3 ALTERNATE. A MAXMUM OF 5 BREAKERS MAY N PARALLEL N ZONE 3 SELF-NTERLOCK. CONNECTED OUTPUT COMMON RD MASTER CONNECTON DAGRAM SHORT DELAY ZONE NTERLOCKNG CONNECTONS FOR RADAL DSTRBUTON SYSTEM (USE WTH DGTRP RMS EQUPPED WTH SHORT DELAY FUNCTON) 19 EATON CORPORATON

21 Circuit Breaker with DGTRP RMS Trip Units nstruction Leaflet L29C714L EATON CORPORATON 20

22 nstruction Leaflet L29C714L Circuit Breaker with DGTRP RMS Trip Units 21 EATON CORPORATON

23 Circuit Breaker with DGTRP RMS Trip Units nstruction Leaflet L29C714L V V V AS ELECTRC OPERATOR FUNCTON REQURED 700,800, 810, 910, AND F OPERATOR NOT SUPPLED, RED AND REMOTELY CLOSE VA NCOM. SEE SHEET 23. BLUE BE PRESENT BUT CONNECTED. PT MODULE S NOT TYPE RD MASTER CONNECTON DAGRAM CONNECTONS FOR USE RMS 700,800,810,910,750, AND 1050 EATON CORPORATON 22

24 nstruction Leaflet L29C714L Circuit Breaker with DGTRP RMS Trip Units SEE SHEET 17 4 CLOSE (OPTONAL) "WARNNG- (OPTONAL SUPPLY VOLTAGE LEGEND X --ON RELAY a BREAKER AUX 1 CONTROL TRANSFORMER MAY BE Y RELAY b BREAKER AUX REQURED TO MEET SUPPLY REQURMENTS -ON 2 BREAKER A ND OPERATOR SHOWN N OPEN RESET S -MOTOR OPERATOR TERMNAL BLOCK LCS -LATCH CHECK TERMNAL BLOCK RD MASTER CONNECTON DAGRAM MOTOR OPERATOR CONNECTONS 23 EATON CORPORATON

25 Circuit Breaker with DGTRP RMS Trip Units nstruction Leaflet L29C714L EATON CORPORATON 24

26 nstruction Leaflet L29C714L Circuit Breaker with DGTRP RMS Trip Units R 1 PULSED 'ON' VA NC BREAKER OPERATOR S USED) BOTTOM AUTOMATC BY NCOM COMMUNCATON SGNAL (VA O R PERSONAL NSTALL PERMSSVE MEANS (SEE EQUPMENT MANTENANCE OPERATONS OPERATON TYPE COMMUNCATON CONNECTONS USE OF OR CONDUCTORS AND SUPPLED 810, 910, AS STANDARD 700, 910, AS ON 910, 750, F S RED LEADS BUT SUPPLED AND R D MASTER CONNECTON DAGRAM R D BREAKER WTH DGTRP GROUND FAULT AND NCOM HGH 25 EATON CORPORATON

27 Circuit Breaker with DGTRP RMS Trip Units nstruction Leaflet L29C714L EATON CORPORATON 26

28 nstruction Leaflet L29C714L Circuit Breaker with DGTRP RMS Trip Units 27 EATON CORPORATON

29 Circuit Breaker with DGTRP RMS Trip Units nstruction Leaflet L29C714L Notes: EATON CORPORATON 28

30 nstruction Leaflet L29C714L Circuit Breaker with DGTRP RMS Trip Units The instructions for installation, testing, maintenance, or repair herein are provided for the use of the product in general commercial applications and may not be appropriate for use in nuclear applications. Additional instructions may be available upon specific request to replace, amend, or supplement these instructions to qualify them for use with the product in safety-related applications in a nuclear facility. This nstruction Leaflet is published solely for information purposes and should not be considered all-inclusive. f further information is required, you should consult an authorized Eaton sales representative. The sale of the product shown in this literature is subject to the terms and conditions outlined in appropriate Eaton selling policies or other contractual agreement between the parties. This literature is not intended to and does not enlarge or add to any such contract. The sole source governing the rights and remedies of any purchaser of this equipment is the contract between the purchaser and Eaton. NO WARRANTES, EXPRESSED OR MPLED, NCLUDNG WARRANTES OF FTNESS FOR A PARTCULAR PURPOSE OR MERCHANTABLTY, OR WARRANTES ARSNG FROM COURSE OF DEALNG OR USAGE OF TRADE, ARE MADE REGARDNG THE NFORMATON, RECOMMENDATONS, AND DESCRPTONS CONTANED HEREN. n no event will Eaton be responsible to the purchaser or user in contract, in tort (including negligence), strict liability or otherwise for any special, indirect, incidental or consequential damage or loss whatsoever, including but not limited to damage or loss of use of equipment, plant or power system, cost of capital, loss of power, additional expenses in the use of existing power facilities, or claims against the purchaser or user by its customers resulting from the use of the information, recommendations and description contained herein. Eaton Corporation Electrical Sector 1111 Superior Ave. Cleveland, OH United States 877-ETN-CARE ( ) Eaton.com 2011 Eaton Corporation All Rights Reserved Printed in USA Publication No. L29C714L / TBG Part No. 6615C95H12 October 2012 Eaton is a registered trademark of Eaton Corporation. All other trademarks are property of their respective owners.