All 1800 Models Price List valid from Jan 2018

Transcription

1 All 1800 Models Price List valid from Jan Fig FRONT AND REAR WINDSHIELD GASKETS UNIT PRICE Windshield rubber seal each $ Windshield rubber seal each $ Windshield rubber seal each $ Rear window seal each $ Rear window seal S/E each $ Rear glass hatch rubber seal 1800ES only each $ Side window seal coupe left S and E models each $ Side window seal coupe right S and E models each $ Trunk rubber seal S and E models each $ Rubber seal for trunk floor for chassi nbr to each $ Trunk drain hose ch meter $ /31 Spring for luggage compartment lid left/right S and E each $ Rubber strip for chrome grille surround 6 1/2 feet each $6.41 MSP8 Mountingkit for chrome grille (includes rubber strip 13319) each $10.80 DOOR SEALS AND DOOR COMPONENTS Door seal rubber (on door) all years each $ Door seal felt/rubber (in body) each $ Door seal plastic/rubber (in body) 1800S/E each $ Door seal plastic/rubber (in body) ES each $ Vent. window rubber gasket (chassis# >10000) left S/E each $ Vent. window rubber gasket (chassis# >10000) right S/E each $ /7 Vent. Window rubber seal left/right ES each $ Rear guide channel for door glass pair $ Front guide channel for door glass pair $ Inner felt scraper for door glass pair $ Window Guide channel kit for 2 doors set $ Clips inner window scraper 5 per side each $ Outer side window rubber seal scraper each $ Clips for outer scrapers ( 5 per side ) each $ Inner door handle vin E and ES each $ Filler strip for elevator channel pair $ Door stop each $ Guide for door stop each $ Cover steering column (dashboard/steering wheel) each $ Lock spring for inner door handle "omega" ch# each $ Lock spring for inner door handle ch# each $ Washer elevator crank later model each $ Lock button black ch each $4.87 Hood parts S Insulation kit hood (4 pieces- BLACK) set $ Hood seal all 1800 $ Rubber strip for splach plate each $ Hood support each $ Rubber cushion Hood stops and doorwindow stop ch each $ Screw for ch each $2.21 Board panels S Board panel set, Jensen trunk (Black) 4 pc set set $ Board panel in trunk, front piece (Black) 1800S each $ Trunk side panel (Black) left 1800S each $ Trunk side panel (Black) right 1800S each $ Board panel set, 1800E model trunk (Black) 5 pc set set $ LOCKS AND OTHER DOOR COMPONENTS

2 1800 Price list Lock cylinder. S/E trunk, ES glass hatch Do "ctrl+f ' to search for an item All models each $ Handle hatch 1800ES each $ Butterfly knob hatch lid 1800ES each $ Base hatch lock ES each $ lock cylinder boot 1800ES each $ Catch hatch lock ES each $ Nut each $ Spacer under handle hatch ES each $ Spacer under handle hatch ES each $ Lock cylinder, door left each $ Lock cylinder, fuel lid each $ Lock cylinder housing for fuel lid w 2 keys each $ Lock set 4 lock cylinders (fuel lid, trunk, doors) SET $ x Key blank for locks above FP each $ Key blank for locks above FR each $ Key blank for locks above FS each $ Ignition lock with 2 keys for 1800S -69 each $ Bushing steering lock each $ Sheer-off screw, steering lock each $ Key blank for Neiman B18 each $ Key blank for ASSA B18 each $ Key blank for ASSA each $ Key Blank for cars with steering locking device E and ES B20 each $ S Gasket set (doors, trunk and fuel lid handles) set $ S Gasket set (doors, trunk and fuel lid handles) set $ ES Gasket set (doors, trunk and fuel lid handles) ES set $ /78 Guide on striker plate LH/RH each $ Rear view mirror (screw mounted) each $ Rear view mirror (stud mounted) each $ Mirror head / each $56.00

3 596 Fig 1: Interior Parts P1800 INTERIOR PARTS Ready to install Headliners :4 Perforated vinyl Jensen head liner each $ :4 Perforated vinyl head liner S/E each $ :4 Non-perforated vinyl headliner S/E each $ :3 Non-perforated vinyl headliner ES each $ FRONT SEAT UPHOLSTERY (Leather, original appearance)

4 665596/97 Upholstery front seat Jensen (lower/upper) Red vinyl pair $ /83 Upholstery front seat Jensen (lower/upper) White vinyl pair $ / Upholstery front seat Jensen (lower/upper) Red pair $1, /09 Upholstery front seat Jensen (lower/upper) Black pair $1, /72 1:6 Front seat (upper/lower) 1800S Brown pair $1, /38 1:6 Front seat (upper/lower) 1800S Red pair $1, /53 1:6 Front seat (upper/lower) 1800S/E-71 Black pair $1, /31 1:6 Front seat (upper/lower) 1800E -71 Red pair $1, /32 1:6 Front seat (upper/lower) 1800E -71 Gold pair $1, /14 1:6 Seat upholstery (lower/upper) 1800ES Black pair $1, /43 1:6 Seat upholstery (lower/upper) 1800ES Blue pair $1, /42 1:6 Seat upholstery (lower/upper) 1800ES Brown pair $1, /65 1:6 Seat upholstery (lower/upper) 1800ES Gold pair $1, Rear coupe kit Jensen (14 pc) Red set $ Rear coupe kit Jensen (14 pc) White set $ Rear coupe kit Jensen (14 pc) Red set $ Rear coupe kit Jensen (14 pc) Black set $ /74 1:7/8 Rear seat upholstery (lower/upper) 1800S Brown pair $ /39 1:7/8 Rear seat upholstery (lower/upper) 1800S Red pair $ /54 1:7/8 Rear seat upholstery (lower/upper) 1800S/E-71 Black pair $ /72 1:7/8 Rear seat upholstery (lower/upper) 1800E -71 Gold pair $ /71 1:7/8 Rear seat upholstery (lower/upper) 1800E -71 Red pair $ /47/51 Rear seat upholstery kit (left/right lower + upper) E/ESLight blue set $ /69/74 Rear seat upholstery kit (left/right lower + upper) E/ES Gold set $ /21/850 Rear seat upholstery kit (left/right lower + upper) E/ES Black set $ /46/50 Rear seat upholstery kit (left/right lower + upper) E/ES Brown set $ Seat foam front seat lower S-E each $ Seat foam front seat upper S-E each $ Seat foam front seat lower E-ES each $ Seat foam front seat upper E-ES each $ A Elastic band Seat bottom front 3.5 meters 11.5 feet each $ B Elastic band Seat back front 3.5 meters 11.5 feet each $ C Elastic band rearseat 4 meters 14 feet each $ Hook for elastic strap each $ Clamp for elastic band-hook each $ Steering wheel cover leather each $ Cover Head rest AZ/P18/ brown each $ L Cover Head rest 1800S brown each $ Carpet set, beige/oak Jensen set $ Carpet set, red Jensen and S set $ /9 Carpet set, red / gray 1800S set $ /12/13/14 Carpet set, brown/black / red / gray E-1971 set $ /16/17 Carpet set, red/blue / brown (E 1972 on order) ES set $ Carpet button, 3-piece 12/car each $ Carpet button, 3-piece set of 12 each $ Accessory carpets, grey (highest loop pile quality) 1800S pair $ Accessory carpets, grey (highest loop pile quality) E/ES pair $ Accessory carpets, red E/ES pair $ B Accessory carpets, red REAR pair $ Accessory rubber mats - Volvo original Black pair $ Accessory rubber mats - Volvo original Gray pair $ Trunk rubber mat Black each $ T Trunk carpet black each $ T Trunk carpet black each $ Carpet under spare wheel ES each $ Fire wall insulation each $ Rubber button black firewall felt 6/car each $ Rubber button set firewall felt set of 6 set $14.75

5 Hat shelf jensen modell Black each $ :1 Dashboard padding - upper each $ :2 Dashboard padding - lower each $ :1 Dashboard padding - upper 1973 each $ :2 Dashboard padding - lower 1973 each $ Anchorage for lower dashboard padding 4/car each $ Speed nut for dashboard 5/car each $ /05 Panel rear pillar (black plastic) ES LH/RH pair $ :5 Sparewheel cover 1800S/E pos.5 Black each $ Gear shift boot each $ Gear shift boot E/ES each $ Gear shifter knob -69 each $ Gear shifter knob E/ES each $ Sill plate outer S/E each $ Screw for sillplate /car each $ Sill plate inner (curved) left S/E each $ Sill plate inner (curved) right S/E each $ Screw for sillplates /10 6/car each $ Sill plate inner (straight) ES each $ Rubber button firewall felt 6/car black each $ Rubber button set firewall felt set of 6 set $ Sun visor rubber retainer 1 per car each $21.18 MS30 Screw kit sun visor bracket each $ Sun visor plastic retainer E, ES, 140, 240 each $15.95 Exact reproduction w. embossings, pocket & emblem /04 1:13 Door panel upper Jensen Red each $ /08 1:13 Door panel upper Jensen White each $ /21 1:13 Door panel upper Jensen Black each $ /93 1:13 Door panel upper Jensen 1963 Red each $ /16 1:13 Door panel upper S/E 1970 Red each $ /61 1:13 Door panel upper S ch# Black each $ /18 1:13 Door panel upper S/E ch# Black each $ /79 1:13 Door panel upper S Brown each $ /03 1:13 Door panel upper E 1971 Red each $ /05 1:13 Door panel upper E Gold each $91.35 = /02 1:15 Door panel lower Jensen Red/silver each $ /06 1:15 Door panel lower Jensen White/Silver each $ /19 1:15 Door panel lower Jensen Black each $ /91 1:15 Door panel lower Jensen 1963 Red each $ /48 1:15 Door panel lower S/E 1970 Red each $ /63 1:15 Door panel lower S/E Black each $ /81 1:15 Door panel lower S Brown each $ /13 1:15 Door panel lower E 1971 Red each $ /15 1:15 Door panel lower E Gold each $ /18 1:11 Side panel rear seat Jensen Red each $ /14 1:11 Side panel rear seat Jensen White each $ /44 1:11 Side panel rear seat Jensen 1963 Red each $ /54 1:11 Side panel rear seat Jensen Black each $ /42 1:11 Side panel rear seat S/E 1970 Red each $ /57 1:11 Side panel rear seat S/E Black each $ /83 1:11 Side panel rear seat S Brown each $ /38 1:11 Side panel rear seat E Red each $91.35

6 1800 Price list /40 1:11 Side panel rear seat E 1971 Do "ctrl+f ' to search for an item 1971 Gold each $ /96 1:11 Side panel rear seat E Gold each $ /92 1:11 Side panel rear seat E Black each $ /35 1:16 Cowl panel with pocket S Red each $ /50 1:16 Cowl panel with pocket S Black each $ /87 1:16 Cowl panel with pocket S Brown each $ /83 1:16 Cowl panel with pocket E Red each $ /98 1:16 Cowl panel with pocket E Red each $ /200 1:16 Cowl panel with pocket E Black each $ /85 1:16 Cowl panel with pocket E Gold each $ Material kit for recovering Jensen cowl panels Red each $ Material kit for recovering Jensen cowl panels White each $ /28 1:10 C/D post panel Jensen each $ /03 1:10 C/D post panel Jensen 1963 each $ /28 1:10 C/D post panel S Red each $ /30 1:10 C/D post panel S Black each $ /85 1:10 C/D post panel S Brown each $ /22 1:10 C/D post panel E Red each $ /10 1:10 C/D post panel E 1970 Red each $ /12 1:10 C/D post panel E Black each $ /24 1:10 C/D post panel E -71 Gold each $ /78 1:10 C/D post panel E -72 Gold each $ /23 1:10 C/D post panel 1800E, Black -72 Black each $ /44 1:9 Interior wheel arch upholstery S/E S/E-70 Red each $ /59 1:9 Interior wheel arch upholstery S Black each $ /89 1:9 Interior wheel arch upholstery S Brown each $ /48 1:9 Interior wheel arch upholstery E Red each $ /18 1:9 Interior wheel arch upholstery E Black each $ /50 1:9 Interior wheel arch upholstery E 1971 Gold each $ /02 1:9 Interior wheel arch upholstery E 1972 Gold each $ /72 1:18 Door panel ES Light blue each $ /28 1:18 Door panel ES/E 1972 Black each $ /71 1:18 Door panel ES Brown each $ /92 1:18 Door panel ES/E 1972 Gold each $ /64 1:17 Cowl panel ES Light blue each $ /26 1:17 Cowl panel ES/E 1972 Black each $ /63 1:17 Cowl panel ES Brown each $ /82 1:17 Cowl panel ES/E 1972 Gold each $ /76 Side panel rear seat ES Light blue each $ /40 Side panel rear seat ES Black each $ /75 Side panel rear seat ES Brown each $ /94 Side panel rear seat ES Gold each $ /10F 1:14 Door panel arm cover Black left/right pair $ :14 Door panel arm rest complete left black each $ :14 Door panel arm rest complete right black each $ Arm rest chrome trim each $ /79 1:12 padding upper cushion door (black) S/E pair $ Door panel clips each $ Door panel fastener set of 50 each $ Door panel clips set of 25 set $ Door pocket clip each $ Washer for upholstery each $0.36 LIGHTS Lamp housing (bucket) plastic plastic each $ M Lamp housing (bucket) steel steel original each $36.93 MSP9 Screw kit for lamp housing / fender 1/car each $ Outer chrome rim for headlight each $86.67

7 1800 Price list Retainer headlight Do "ctrl+f ' to search for an item each $20.00 MSP10 Screw kit (headlight retainer - inner bucket) 1/car each $ Headlight inner bucket each $ Headlight rubber seal each $ Headlight rim screw each $ Headlight adjusting screw 4/car each $ Headlight adjusting spring 4/car each $ Headlight adjusting spring 2/car each $ S Adjuster screw kit 2/car each $ Headlamp (complete) 2/car each $ Headlight reflector & glass "Volvo" H4 each $ Headlight reflector & glass "LUCAS" assymetrisk each $ Spring clip 7" headlights each $ Bulb for headlamp Lucas 50/40W each $ Headlight wire harness set $ Headlight wire harness set $ Grommet for wiring cable each $ Spotlights pair 5,5" chrome pair $ Fog lights pair 5,5" chrome pair $ Turn signal items Turn signal lens clear -64 each $ Turn signal lens all amber each $ W Turn signal lens clear each $ Base/reflector - single bulb each $ Base/reflector - double bulbs each $ Rubber casing turn signal each $ Outer chrome rim for turn signals each $ Gasket lens - base 2/car each $ Foam gasket glass - base 2/car each $ Turn signal switch each $ turn signal switch 1800E Ch /ES each $ Complete turn signal unit (base / bezel / all clear lens) 2/car set $ Complete turn signal unit (base / bezel / clear /amber lens) 2/car set $ Tail light items Tail light lens ( ) red/amber Red/amber 2/car each $ Tail light lens all red S/E each $ /60 Tail light lens 1800ES left / right Red/yellow each $ Tail light lens 1800E US all red each $ Screw taillight 8/car each $ Tail light Chrome house 1800S and E 2/car each $ Bulb holder rear light double S/E each $ Bulb holder rear light single each $ Rubber gasket rear light chrome house - body each $ Foam gasket rear light lens - base 2/car each $ Foam gasket rear light chrome house - body set of 4 set $ Reflector 2/car each $ Lens side marker Amber each $ Lens side marker Red each $ Bulb holder side marker 4/car each $ gasket side marker front/rear each $19.00 Licence Light License light chrome housing Jensen # each $ License light chrome housing S/E # each $ Gasket chrome housing - body S and E each $ Foam gasket license light housing S and E each $ License plate lamp ES 1973 each $ Lens license plate ES each $ Interior Courtesy lamp lens 2/car each $ Door jamb switch each $25.80

8 1800 Price list High/low beam switch Do "ctrl+f ' to search for an item Bosch each $ R High/low beam switch Repro each $24.00 MS28 Screw kit for bearn switch 1/car each $ Relay/indicator & cigarr lighter Relay for headlights ch each $ Step relay headlights each $ Relay for flashers SA-1967) each $ Relay for flashers h each $ Relay for flashers ch each $ Realy for signal horn ch each $ Fan switch 82 ch ch-3069 each $ Switch interior light chnr each $ Light switch E ch all ES each $ Light switch courtesy lamp/ overdriv (2-pos) each $ Flex Light interior "Map Reading Lamp " Lucas each $ Overdrive switch wand horn o/d each $ Knob for overdive switch/indicator switch each $ Washer each $ Washer each $ Washer - blank each $ Washer between glow element & knob each $ Cigarr lighter knob ch each $ R Cigarr lighter unit - complete each $32.00 BULBS Asymetric headlight Bulb 60/55w 12V each $ Turn signal / Number plate illumination bulb S 12V each $ Turn signal bulb S/E 12V each $ Turn signal / Number plate illumination S/E 12v each $ Taillight / Number plate illumination S/E 12V each $ Turn signal stop-light/reverse light ES 12V each $ Rear light ES 12V each $ License plate light ES and interior light S/E 12V each $ Instrument bayonet style 12V/2W each $ Instrument threaded style 12V/3W each $1.78 ENGINE COMPONENTS Cooling system Radiator unit closed system ch each $ Drain cock radiator unit ch each $ Radiator hose - upper ch each $ Radiator hose - lower (cars w/ oil cooler) ch each $ Radiator hose - lower (cars without oil cooler) ch each $ Radiator hose - upper ch19175-b18b20b each $ Radiator hose - lower cars with oil cooler B18 each $ Radiator hose - lower B20B each $ Radiator hose - upper with clamps B20E/F each $ Radiator hose - lower with clamps B20E/F each $ Hose between expander & radiator m $ Hose clamp radiator hose mm each $ Hose clamp mm radiator hose each $ Water inlet pipe each $ Water inlet pipe B20F US ONLY each $ Fan wing early mod each $ Rubber bushing for radiator 3/car B18/B20 each $ Sleeve radiator mounting 2/car B18/B20 each $ Radiator cap ch each $ Radiator cap (incl gasket) each $15.47

9 Gasket for cap each $ Expansion tank (short neck - fits B18 too) B20 each $ Cap expansion tank long neck B18 each $ Cap expansion tank short neck B20 each $ Gasket for cap each $ Thermostat 160 F 71C B18/20 each $ Thermostat 180 F 82C B18/20 each $ Rubber gasket for thermostat B18/B20 each $ Thermostat housing (Aluminum) each $ Thermostat housing (Aluminum) B18/B20 each $ Water pump with gaskets and seal B18/B20 each $ Gasket kit waterpump B18/B20 set $ Fan belt B18/B20 each $10.00 Carburetors Maintenance service kit carburetor SUH B18 pair $ Rebuild kit carburetor SUH B18 pair $ carburetor needle Zh for SU H6 each $ carburetor needle KF for SU H6 each $ carburetor needle KD for SU H6 each $ carburetor needle DX for SU H6 each $ carburetor needle TZ for SU H6 each $ Gasket set HS6 B18 pair $ Gasket carburetor float bowl SUH6 B18 each $ Gasketat carburetor intake manifold SU and Stromberg each $ Rubber hose - Fuel pump to carburetor meter $ Rubber hose - fuel line 1/4 Id sold per meter meter $ Choke wire, dual carburetors B18/20 each $ Rubber grommet for choke wire (holds cables togheter) each $ Cable retainer 2/car B18 each $ Retainer screw 2/car B18 each $ Clip for cable retainer each $4.53 Air filter Air filter 2 hole B18B/D each $ /81 Air filter blue 3 hole (with/without pipe) Pair B18B/D Pair $ Gasket for airfilter & /81 & B18B/D each $2.22 MS29 Screw kit for /car each $5.13 MS35 Screw kit for /81 1/car each $ Air filter - rectangular for B18B/B20B/B30A SU each $ Gasket for airfilter B20A/B each $ Clamp for airfilter house B20A each $2.58 MS37 Screw kit for /car each $ Air filter insert, round fuel injected engines B20E each $ Distributor cap B18 each $ Distributor cap B each $ Gasket under distributor B18/B20 each $ Spring for distributor cap B18/B20 each $ Vacuum regulator B20E/F each $ Rubber hose to vacuum govenor B18/B20 meter $ Cover on low tension lead (at distrubutor end) B18/B20 each $ Distributor point kit B18B/D each $ Distributor point kit B18B/D each $ Distributor point kit B20B B20E each $ Distributor rotor B18 each $ Distributor rotor B18/B20 each $ Condensor B18 each $8.45

10 1800 Price list Condensor Do "ctrl+f ' to search for an item B20B each $ Condensor B20E each $ Condensor B20F each $10.26 Fuses & cable harnesses Fuse 35A 6/car each $ Fuse box Lucas 4FJ bigger each $ LID Lid for fuse box 4FJ each $ Fuse box Lucas 5FJ smaller each $ Wiring harness P1800/S, LHD cars 1800S each $ Wiring harness P1800/S, LHD cars S each $ K Wire harness 1800S USA late 67 (ch B18 2-ct) 1800S each $ K Wiring harness 1800S USA 1968(ch# LHD B18 2-cct) 1800S each $ k Wiring harness 1800S '69 LHD S $ Main harness 1800E '70 LHD M E $ Main harness E/ES '72 LHD man 1972 each $ Main harness E/ES '72 LHD auto 1972 each $ Injection harness ch E each $ Injection harness ch E/ES each $ Fuel injection rubber protectors (7x2pin,2X4pin,1X3pin) B20E/F set $ Fuel hose kit injector set $4.75 Ignition coils Ignition coil (replaces ) ch B20 each $ Ignition coil 12V (replacement, not original) 12V each $ PX Ignition coil 12V (High effect, Epoxy) 12V each $ Ignition Coil bracket each $ Ignition cable set red similar to original red B18/20 set $ B Ignition cable set gray aftermarket set $ Rubber casing starter cable each $ BOSCH Spark plug kit Bosch B18B/DB20B/D/F set $ Spark plug kit B20E set $ Earth strap battery - body LHD each $ Earth strap engine-body ch B18/20 each $ Battery lead battery-starter motor B18/20 each $ Rubber clamp battery cable each $ Terminal connector kit, distributor. each $28.19 Starter Motor Carbon brush kit starter Bosch B18/B20 set $ Carbon brush kit starter Bosch early B18 set $ Brush spring Bosch early B18 each $ Starter pinion for Bosch B18/B20 each $ Starter pinion for Bosch B18/B20 each $ Generator Carbon brush kit generator Bosch B18/B20 set $ Brush spring Bosch B18/B20 each $ R Voltage regulator 12V D/C aftermarket Bosch 12V each $47.00 MS103 Installation kit V each $0.65 MS104 Installation kit V each $ Front bearing for dynamo B18B each $ Nut for B18B each $ Rear bearing for Generator and clutch pilot B18 B18B each $ Screw gearbox - fly wheel casing 4/car each $ Generator (Rebuilt) B18 each $ STGE Corecharge (NOTE refunded only if bearings are included) each $46.90 MS102 Mounting kit (incl rubber bushings) B18 each $ Bracket for generator B18 each $27.90 Alternator

11 1800 Price list Bracket kit alternator Do "ctrl+f ' to search for an item each $ Carbon brush kit generator BoschB18B/B20 set $ Repair kit for terminal B20 each $ Engine/manifold gaskets,seals & bolts Cylinder head gasket B18 each $ Cylinder head gasket B mm each $ Cylinder head gasket B 20A/B 2 mm each $ Cylinder head gasket B20E/F each $ Manifold gasket B18/B20B carbur cars each $ Manifold gasket B20E and F each $ Manifold outlet gasket single each $ Manifold outlet gasket double outlet each $ Nut for exhaust manifold brass each $ Nut for bolt exhaust manifold steel each $ Bolt for manifold eaxhaust side each $ Bolt for manifold 38 mm long B18 each $ Bolt for manifold 40 mm long each $ Bolt for manifold 42 mm long each $ Bolt for manifold inlet 45mm long 6or8/car B20B/EF each $ Bolt for manifold inlet 50 mm long 3+1/car B20B/EF each $ Manifold washer D=22 /B18/B20 each $ Gudie sleeve 4/car B18/B20 each $ Gasket cover/manifold Sport B18/B20 each $ Exhaust manifold single pipe B18B each $ Drain cock on engine B18/B20 each $ Elbow union for oil pressure hose (on engine) B18/B20 each $ decarbonizing head gasket set B18 $ Cylinder head gasket set -72 B20 $ decarbonizing Cylinder head gasket set -73 B 20 Fuelinjected $ Engine gasket kit B18 $ Engine gasket kit carburated B20 $ Engine gasket kit fuel injected B20 $ Bottom end kit B18/B20 $ Engine rubber mount with nut and washer each $11.00 Engine parts Valve guide in/out 8/car B18 each $ Valve guide intake B20 each $ Valve guide outlet B20 each $ Valve spring 8/car B18/B20 each $ Washer under valve spring 8/car B18 each $ Rockerarm bushing 8/car B18/B20 each $ Intake valve 4/car B18 each $ Exhaust valve 4/car B18 each $ Intake valve, carburetor engine (early type) 4/car B20 each $ Intake valve, carb/ (late) + injection engine 4/car 0B/D/E/F each $ Exhaust valve, carburetor engine 4/car B20 each $ Exhaust valve, injected engine 4/car B20E/F each $ Valve guide in/out 8/car B18 each $ Rod bushings 4/car B18/B20 each $ Nut for rod bushings B18/B20 each $ Nutt for adjuster screw /car B18/B20 each $ Valve stem rubber seal 8/car B18 set $ Valve stem seal 8 per car B each $ Valve collet 16/car B18 each $ Valve collet 16/car B20 each $ Frost plug (42mm diameter) 1/car B18/B20 each $ Frost plug (35 mm) 2/car B18/B20 each $ Frost plug (45 mm) 7/car B18/B20 each $2.40

12 Frost plug B20E/F each $ Timing gear set standard fibre- steel B18/B20 set $ AL Timing gear set (Steel/Aluminum ) B18/B20 set $ Felt oil seal crankshaft felt rear B18/B20 each $ Felt oil seal crankshaft felt front B18/B20 each $ Oil seal crank shaft rear for modern style sealing B18/B20 each $ Oil seal crank shaft front for modern style sealing B18/B20 each $ Retainer for B18/B20 each $ Lock ring for B18/B20 each $ Gasket crankshaft rear B18/B20 each $ Crank shaft rear flange w. rubber seal (converts felt seal to oilseal) B18/B20 set $ Bolt for rear crankshaft B18/B20 each $ Washer behind B18/B20 each $ Woodruff key on crankshaft B18/B20 each $ Fly wheel pilot bearing B16/18/20 each $ Lock ring for B18/B20 each $ Cover plate for B18/B20 each $ Gasket timing gear casing B18/B20 each $ Screw for timing cover 25mm 2/car B18/B20 each $ Screw for timing cover 45mm 7/car B18/B20 each $ Washer 9/car B18/B20 each $ Oil nipple behind timing gear casing 1/car B18/B20 each $ Plug on manifold B18/B20 each $ Main bearing kit (Sizes Std / 0,010" / 0,020"/0,030"/0,040") B18/B20 set $ Rod bearing kit (Sizes Std / 0,010" / 0,020"/0,030"/0,040") B18/B20 set $ Piston w/ rings (Sizes Std / 0,020" / 0,030" / 0,040") B18 each $ /12/04 Piston w/ rings: Std / 0,015" / 0,030") B20 each $ UL Cylinderhead rebuilt each $ Core Charge for cylinder head each $ Head bolt 10/car B18/B20 each $ Piston ring set (Sizes Std / 0,020" / 0,030" / 0.040") B18 set $ /35/36 Piston ring set (Sizes Std / 0,015" / 0,030") B20 set $ Oil pump B18/B20 each $ Oil delivery pipe B18 each $ Oil delivery pipe B20 each $ Distributor drive gear B18/B20 each $ Strainer for oil pump B18/B20 each $ Lock ring for strainer B18/B20 each $ Oil pan gasket B18/B20 each $ /24 Bolt for sump attachment lenght 16mm/19mm B18/B20 each $ Oil filter originalvolvo B18/B20 each $ A Oil filter Aftermarket B18/B20 each $ Oil drain plug 3/4" B18/B20 each $ Cupper gasket drain plug 3/4" B18/B20 each $ Oil drain plug (magnetic) incl B18/B20 each $ Oil filler cap complete (without ventilation cap) B18/B20 each $ Oil filler cap complete (with ventilation cap) B18/B20 each $ Cap Oil filler cap only (without vent hole ) B18/B20 each $ CAP Oil filler cap only (with vent hole ) B18/B20 each $ Gasket oil filler cap B18/B20 each $ Hose for the vented oil filler cap each $ C Valve cover Chromed B18/20 each $ Valve cover gasket B18/20 each $ Screw for valve cover 4/car B18/B20 each $ Seal ring oil trap/breather pipe early mod. di =21 B18/B20 each $ Seal ring oil trap/breather pipe late mod. di = 26 B20 each $3.15

13 1800 Price list Hose crank case ventilation Do "ctrl+f ' to search for an item B18 m $ Hose crank case ventilation B20 m $ Hose between oiltrap & nipple # B18 each $ Hose between oiltrap & nipple # B18 each $ Valve between & B18 each $ Flame shield in oil trap each $ Camshaft & valve lifters Camshaft set (incl lifters) B18/20 (Types available A / C / D / K) set $ Cam bearing kit (3 rings per kit) B18/20 set $ Cam lifter follower 8/car B18/B20 each $ Push rod 8/car B18/B20 each $ Thrust flange 1/car B18/B20 each $ Spacer ring 1/car B18/B20 each $ Nut for camshaft 1/car B18/B20 each $ Woodruff key on camshaft 1/car B18/B20 each $ Engine paint red liter $50.00 FUEL SYSTEM carburetor engine Fuel pump mechanical comes with one spacer gasket each $ Spacer fuel pump (backelite) each $ Gasket engine - fuel pump 2 per car each $ Fuel pump repair kit for the glass bowl pump set $ Rubber gasket fuel pump glasbowl each $ Fuel resistant filler hose (665163) each $ Clamp for /car each $ Gasket for fuel lid all years each $ Fuel tank S/E/ES 1800 each $ Screw for fuel tank 10/car each $ Fuel sender unit all carburated models each $ Gasket tank / sender unit 1/car each $ Screw for fuel sender 6/car each $ Washer for screw /car each $ Filler neck collar each $ Fuel pipe under car "bundy pipe" each $ Union (cap) nut for fuel pipe & fuel tank each $ Clamp to fuel pipe under the car each $ Clamp to fuel pipe under the car single each $ Clamp to fuel pipe under the car single each $ Clamp to fuel pipe under the car double each $ Screw for clamp /89/ each $ Screw for clamp each $ Flexable fuel hose metal line - fuel pump ch each $ Rubber hose - fuel line 1/4 Id sold per meter meter $ Rubber hose, fuel pump - carburetor meter $7.63 Fuel injection Fuel pump electric (reproduction) for E and ES each $ Rubber cushion - fuel pump 2/car each $ Fuel filter ch each $ Fuel filter E /ES each $ Saran filter each $ Plug each $ Repair kit fuel hose fuel injection 1/car set $ Fuel sender unit E and ES each $ Gasket fuel sender unit / tank each $ Screw for fuel sender each $ Washer copper for screw each $0.67

14 1800 Price list Throttle control cable 1800 E and ES Do "ctrl+f ' to search for an item each $ Return spring each $ locking clip each $ Fuel injection rubber protectors (7x2pin,2X4pin,1X3pin) B20E/F set $ Injector (repl & ) E/ES All each $ Rubber seal (large) under injector All each $ Rubber seal ( small ) under injector All each $ Rubber seal under retainer for /car early mod each $ Rubber seal under retainer for /car later mod each $ Pressure regulator each $ Pressure regulator each $ Cold start valve All each Gasket under All each $ Rubber hose from induction manifold All each $ Rubber hose from induction manifold 225mm All meter $ Temperature sender air All each $ Temperature sender coolant All each $ Gasket for All each $ Rubber hose - fuel line 1/4 Id sold per meter All meter $ Fuel hose (rubber) All meter $7.63

15 Fig 2: Heater System 1796

16 HEATER SYSTEM Heater Core each $ :1 Heater control valve each $ :2 Gasket heater valve / firewall each $ :21 Rubber plug heater each $ :3 Rubber button heater element each $ :22 Rubber button heater element 1/car ch-2139 each $ ;24 Hose/protection 1/carch meter $ :4 Rubber gasket for flap each $ :5 Rubber gasket for flap each $ :26 Rubber gasket for casing (square) each $ :6 Rubber gasket between casing & turbine rotor each $5.15 MSP12 Screw kit for heater core each $ Pre heater hose paper black B20 each $ :7 Heater hose each $ :8 Heater hose each $ :9 Heater hose each $ :10 Hose clamps original Sweedish style each $ :11 Drain hose each $ Fan motor with impeller 12V aftermarket -64 each $ G 2:12 Rubber air duct 1 set/carearly mod. set $ :12 Air duct paper/aluminum set $ :13 Air duct intake-defroster each $ :14 Strap for ch each $ :15 Screw for each $ :16 Air outlet grille (on rear wing) E/ES each $ :17 Catch washer E/ES each $ :25 Anchorage 8/car each $ :18 Ventilator gasket each $ :19 Gasket rear casing each $ :20 Gasket air intake each $ Air intake grill each $ Air intake grill each $99.50 GEAR BOX PARTS M Gasket, gear box lid each $ Gasket kit M41 gear box each $ Oil filter BW35,B55 extern with each $46.13 BW35S master repair Kit BW35 each $ Gasket kit BW35 with O-rings each $ Gasket kit BW35 each $ Seal ring gearbox input axle M30/40/41 each $ Seal ring gearbox outgoing axle rear M30/40/41 each $ Synchronizing ring each $ Neadle bearing each $ Neadle bearing each $ Bearing in-put shaft front each $ Bearing out-put shaft rear each $ Bearing out-put shaft rear each $ Spring M30/M40 each $ Locating key 3/car each $ Locating key 3/car each $ Roller for main axle 14/car each $ Counter shaft for laygear -69 each $ Trust washer 2/car -69 each $ Roller for layshaft 48/car M41-69 each $ Spring on ball each $ Countershaft for laygear 1/carM each $ Roller for laygear 42/carM each $3.04

17 Sealring for spedometer gear each $ Solenoid overdrive D-type Type D each $ Bearing overdrive outgoing axle rear Type D each $ Sealring overdrive for gearbox overdrive rear Type D each $ Solenoid overdrive J-Type each $ Sealring overdrive for gearbox overdrive rear J-Type each $ Speedo meter gear for overdive J-type each $ Bearing overdrive rear J-type each $ Gasket kit OD.D-type with O-rings & D type each $ Gasket kit OD.J-type with O-rings & J-Type each $ Gasket right side overdrive D-type each $ Plastic washer kit,magnetic later model D-type each $ Gasket between oilseal and D-type each $ Bushing for gearbox shaft each $ Switch 2 poles each $ Switch reverse switch 3 poles each $ Switch overdrive/ reverse switch on M41 gearbox each $ Copper washer for M41 each $ Gear box rubber mount M41 each $ Gear box rubber mount M410 each $90.14 AUTO TRANSMISSION BW Gasket kit ( 3 gaskets ) each $ Kick down cable each $ Oil drain plug each $ Screw 15/box each $ Oil seal front each $ Oil seal rear each $ Oil seal shifter post each $ Inlet pipe front each $ Spring kit each $ Spring kit each $ Saftey net each $ Bushing each $ Speedometer gear - M41 D-type each $ Sealring for spedometer gear each $ O-ring at speedometer gear each $ Gear box mount each $9.80 INSTRUMENT, SPEEDO CABLES/GEAR BOX Speedometer cable M40 gear box each $ Speedometer cable M41 gear box Left hand drive each $ angle helical gear speedo cable at gearbox end each $ Drive Pin ( ) each $ Oil pressure hose ch each $ Elbow union for oil pressure hose to engine each $ Oil pressure hose ch each $ Clamp for oil pressure hose ch each $ Oil pressure switch each $ Temperature sensor (oil) E/ESch each $ Temperature sensor (water) E/ESch each $ Drive Shaft Universal joint, 3/car each $ Bolt kit universal joints 3/car each $12.95

18 1800 Price list Universal joint Do "ctrl+f ' to search for an item E/ES B20E each $ Bolt kit universal joint E/ES B20E each $ Locking waher universal joint 8/car each $ Grease nipple for universal joint with grease cap each $ Rubber bushing center bearing each $ Rubber bushing center bearing each $ Rubber bushing center bearing B20F each $ Rubber bushing center bearing B20E each $ Propeller shaft bearing 1/car each $ Propeller shaft bearing 1/car each $ Propeller shaft bearing 1/car B20E each $ Rubber dust boot propeller shaft B18/B20F each $ Spring under rubber bushing propeller shaft each $3.52

19 2196 Fig 3: Front Suspension P1800 FRONT SUSPENSION BUSHINGS :1 Tie rod end left each $ :1 Tie rod end right each $ :1A Tie rod complete with ends ( center link ) each $ :2 Ball joint upper with grease nipple 2/car each $ :3 Ball joint upper 2/car each $ :4 Ball joint lower 2/car each $ :42 Rubber protector for ball joint upper ch each $ :43 Washer for ball joint upper 2/car ch each $ :5 Upper Wishbone Aug each $ :6 Rubber bushing upper inner control arm 4/car each $ PU 3:6 Bushing upper inner control arm Polyurethane black each $ :7 Sleeve for /car each $ :8 U-bolt for includes nuts 4/car each $ :9 Locing nut for original U-Bolt /car each $0.77

20 1800 Price list :10 Washer Do "ctrl+f ' to search for an item 2/car each $ :11 Lock nut 4/car each $ :12 Rubber cushion on upper control arm 2/car each $ /06/05 3:13 Adjuster shim upper wishbone 15/0.50/1,00 each $ /70 3:13 Adjuster shim upper wishbone tj 3.00/6,00 each $ /52 3:14 Lower Wishbone LH/RH each $ :6 Rubber bushing lower inner control arm 4/car each $ PU 3:6 Rubber bushing lower inner control arm Polyurethane 4/car each $ :7 Sleeve for /car each $ :8 U-bolt for includes nuts 4/car each $ :9 Locing nut for original U-Bolt /car each $ :10 Washer 2/car each $ :11 Locing nut 4/car each $ :15 Rubber bushing lower inner control arm 4/car each $ :16 Bolt for lower inner control arm 2/car each $ :17 Mnut for bolt /car each $ :18 Rubber cushion on lower contral arm 2/car each $ :20 Bracket for /52 1/car each $ :21 Lower anchorage late type 2/car each $ :22 Bolt for /car each $ :23 Rubber bushing anti sway bar 2/car each $ :24 Clamp for /car each $ :25 Bolt for clamp /car each $ PU Repair kit Sway bar 120/ Polyurethan 2/car each $ :26 Spacer tube anti sway bar 2/car S each $ :27 Bolt anti sway bar 2/car S each $ :28 Washer anti say bar 8/car S each $ :29 Bushing anti sway bar 8/car S each $ :30 Nut 2/ar S each $ Mounting kit sway bar (long bolts washer bushings nuts ) 2/car each $ :31 Steering rod left each $ :31 Steering rod right each $ :31A Dust cover steering rod incl. lock rings 2/car each $ :32 Castellated nut for tie-rod each $ :33 Split pin (stainless) each $ :44 Idler arm bushing 2/car each $ Idler arm bushing /car each $ :45 Idler arm repair kit 1/car set $ :34 Front wheel bearing kit 2/car each $ :35 Grease cap 2/car each $ :41 Thrust washer 2/car each $ B 3:36 grease seal front wheel rubber 2/car each $ :37 Wheel nut 20/car each $ L Locking lug nuts set of each $ :38 Nut 2/car each $ :39 Front spring standard 2/car each $ Sport spring kit lowering linear set set $ Lowering the car with 30 mm (roughly 1 inch) and they are stiffer than the original coil springs They improve the handling substantially and give the car a sportier look. The price is for a set of 4 coil springs :40 Rubber seal, on spacer washer 2/car each $16.80

21 2396 Fig 4: Rear Axle Mounting P1800 Bushings Rear axel :1 Bushing anti roll bar 2/car each $ PU 4:1 Bushing anti roll bar Polyurethane black each $ :2 Bolt 1/car each $ :3 Nut 2/car each $ :4 Washer anti say bar 2/car each $ :28 Torque rod 2/car each $ :29 Washer for support arm /car each $ :30 Rubber cushion torque arm 4/car each $ PU 4:30 Rubber cushion torque arm Polyurethane black each $8.22

22 1800 Price list :6 Rubber bushing front, torque arm Do "ctrl+f ' to search for an item 2/car each $ :31 Bolt 2/car each $ :3 Nut 2/car each $ /43 4:32 Support arm LH/RH each $ :33 Washer for support arm /3 2/car each $ :34 Rubber cushion support arm 4/car each $ PU Rubber cushion support arm Polyurethane black each $ :35 Rubber cushion Spicer rear axel 2/car each $ :5 Torque rod includes bushings 2/car each $ :5 Torque rod W/O bushings 2/car each $ :6 Rubber bushing front, torque arm 2/car each $ :7 Bolt 6/car each $ :8 Nut 4/car each $ :9 Rubber bushing rear, torque arm, 2/car each $ :10 Rubber bushing rear, torque arm, std 2/car each $ :10 Rubber bushing rear, torque arm, 2/car each $ :11 Bolt & nut for /678887/ /car each $ :12 Support arm 2/car each $ :13 Bushing torque rod front & rear 4/car each $ :14 Bushing torque rod front & rear 4/car each $ PU 4:14 Bushing torque rod front & rear Polyurethene 4/car each $ :15 Bolt 6/car each $ :8 Nut 4/car each $ :16 Washer 2/car each $ :17 Limiting strap 2/car each $ :18 Washer damber band stainless steel 2/car upper each $ :19 Washer damber band stainless steel 2/car lower each $5.85 MSA10 4:38 Bolt set damber band 1/car each $ /53 4:20 Shock absorber kit MONROE Front/Rear Oil each $ G/53G 4:20 Gas Front/Rear Gas each $ /293 4:20 Shock absorber kit BILSTEIN Front/RearBILSTEIN each $ :21 Rubber bushing shock absorber 8/car each $ :22 Rear Spring 1800S and E 2/car each $ :22 Rear Spring ES 2/car each $ :23 Spring seat lower 2/car each $ :24 Rubber spacer upper spring seat 2/car each $ :25 Rubber mount for rear spring seat lower 2/car each $ :26 Rubber cushion at spring 2/car each $ :37 Nut for /car each $ :36 Washer for /car each $ :27 Rubber cushion 1/car each $13.38

23 Fig 5: Rear Axle P Fig 5: Rear Axle P1800 Fig 5: Rear Axle P1800