DF300AP/250AP DF300AP DF250AP

Transcription

1 PARTS CATALOGUE DF0AP/0AP DF0AP DF0AP OUTBOARD MOTOR E0/E0 0- ND EDITION

2 This part catalogue supersedes all the following part catalogue with immediate effect Model of catalogue Parts catalogue No. DF0AP/0AP 00B-

3 PREFACE When it becomes necessary to replace parts on SUZUKI OUTBOARD MOTORS, always use SUZUKI GENUINE PARTS which have passed a strict inspection which guarantees quality and performance. This parts catalogue covers the list of all service parts for SUZUKI DF0A/0A production start 0. INSTRUCTIONS FOR QUOTING THE CATALOGUE. DIMENSIONS Dimensions of the parts in this catalogue are indicated in unit millimeters.. ABBREVIATIONS Abbreviations used in this catalogue are as follows: AR : As required NT : Number of teeth ASSY : Assembly OPT : Optional E.NO. : Engine number OS : Over size F.NO. : Frame number STD : Standard D : Diameter of material T : Thickness ID : Inside diameter US : Under size OD : Outside diameter W : Width L : Length W/ : With LH(PORT) : Left hand side X,XX : Transom type RH(STBD) : Right hand side SUS : Stainless steel ~ : Up to E.NO.00P- PTT : Power trim and tilt ~ : From E.NO.00P- x x.... Figures in the description column show the dimensions of parts. ID OD T(or W,L). INNER PARTS OF ASSEMBLY Part name with a dot (.) in front as shown in the description column indicates the component of the assembly also available individually.. MODIFICATION NOTICE A parts bulletin will be sent to you on all occasions when changes in parts occur, including interchangeable modifications between new parts and old ones.. NOTE -. There are some different parts from those of production models among spare parts for the administrative reasons and common use of them with other models. -. In respect of rubber hoses and vinyl tubes, please be sure to use them by cutting off according to the length mentioned on parts catalogue or what is actually required on the vehicle. -. Note that the drawings on the illustration page are for ready reference of spare parts number, not to be used as an assembly manual. When assembling, use "SUZUKI SERVICE MANUAL".. MODEL NAME AND ENGINE NUMBER MODEL DESTINATION TYPE TRANSOM COLOR ENGINE No. DF0AP E0,E0 00P X,XX 0EP,YS 00P-000~ DF0AP E0,E0 00P X,XX 0EP,YS 00P-000~ - (Parts No.) : indicates that the parts number was changed to - and the new parts are interchangeable with the former ones but the former ones are not interchangeable with new ones. - (Parts No.) : indicates that the former and new parts are interchangeable with each other and both are usable. DF0A E DF0A E

4 MILLIMETER INCH CONVERSION CHART How to read millimeters equal 0.0 inch Contents are subject to change without notice or obligation.

5 --

6 --

7 --

8 --

9 --

10 --

11 --

12 --

13 --

14 FIG.A FIG.A (-B-) CYLINDER HEAD J0 HEAD ASSY, CYLINDER STBD -0J00.BOLT, CAM SHAFT HOUSING PIN (X) BOLT 0-J0 HEAD ASSY, CYLINDER PORT -0J00.BOLT, CAM SHAFT HOUSING PIN (X) BOLT -J0 PLUG 0 -J0 GASKET, CYL HEAD STBD -J0 GASKET, CYL HEAD PORT 0-00 GASKET (XX0.) -J00 COVER, PROTECTION ANODE 00-0 O RING (D:.,ID:.) -J0 ANODE, PROTECTION 00-0 BOLT (X) BOLT BOLT BOLT PIN (X.X) 0-J0 COVER, CYL HEAD STBD 0-J0 COVER, CYLINDER HEAD PORT -J00 PLATE, BREATHER STBD -J00 PLATE, BREATHER PORT -J00 GASKET, CYL HEAD COVER STBD -J00 GASKET, CYL HEAD COVER PORT PIN (X) 0-0A SCREW 0-0 BOLT 0-00 BOLT -J00 CAP, OIL FILLER O RING (D:.,ID:.) 0-00 SPARK PLUG (BKRE) NGK -J00 HOOK, ENGINE DF0A_E0_0_A CYLINDER HEAD DF0A_E0_0

15 FIG.A FIG.A (-B-) CYLINDER HEAD BOLT -J0-00 GUIDE, VALVE (OS:0.) OPT -J00 HOOK, ENGINE OPT 0 0 DF0A_E0_0_A CYLINDER HEAD DF0A_E0_0

16 FIG.A 0 0 FIG.A (-B-) CYLINDER BLOCK -J00 HOOK, ENGINE FRONT BOLT -J BLOCK SET, CYLINDER -J00.PLUG, OIL VENTURI -J0.BOLT, CRANKCASE -J0.BOLT, CRANKCASE STUD -J00.BOLT, CYLINDER HEAD -FA0.GASKET, M PLUG 0-00.PLUG (X) WASHER (.XX.) 0-00.PLUG (X) 0-0.NUT 00-.PIN (0.XX) 00-J00.VALVE, PISTON JET O RING (D:.,ID:.) O RING (D:.,ID:.) 0-0A.BOLT 0-00A.BOLT 0-J00.JET, PISTON COOLING O RING (D:.,ID:.) PLUG (/PT,H:.) -J0 COVER, CRANKCASE WTR JKT -J00 GASKET, CRANKCASE WTR JKT COV BOLT -J00 COVER, OIL GALLERY -J00 PLATE, OIL GALLERY -J00 GASKET, OIL GALLERY 00-0A BOLT 00-0 BOLT 0-J00 FILTER ASSY, OIL DF0A_E0_0_A CYLINDER BLOCK DF0A_E0_0

17 FIG.A FIG.A (-B-) CRANKSHAFT 0 -J00-0B0 PISTON 0-J00 RING SET, PISTON -0F00 PIN, PISTON 0-00 CIRCLIP 0-J00 CONNROD ASSY A0 BEARING SET, CONNROD GREEN BEARING SET, CONNROD (US:0.) OPT 0-J00 CRANKSHAFT - 0-J00-0A0 BEARING SET, CRANKSHAFT BLACK - 0-J00-0B0 BEARING SET, CRANKSHAFT NON - 0-J00-0C0 BEARING SET, CRANKSHAFT YELLOW - 0-J00-0D0 BEARING SET, CRANKSHAFT BLUE - 0-J00-0E0 BEARING SET, CRANKSHAFT PINK AA BEARING SET, CRANKSHAFT OPT US:0. RED/BLACK BA BEARING SET, CRANKSHAFT OPT US:0. RED CA BEARING SET, CRANKSHAFT OPT US:0. RED/YELLOW DA BEARING SET, CRANKSHAFT OPT US:0. RED/BLUE EA BEARING SET, CRANKSHAFT OPT US:0. RED/PINK DF0A_E0_0_A CRANKSHAFT DF0A_E0_0

18 FIG.A FIG.A (-B-) CRANKSHAFT - 0- BEARING SET, CRANK THRUST BEARING SET, CRANK THRUST OPT OS:0. 0 -J00 GEAR, DRIVE (NT:) WASHER (0.X0X.) 00-0A BOLT 0-00 OIL SEAL (X0X0) 00-J00-00 PISTON SET (OS:0.0) OPT 0-J00-00.RING SET, PISTON (OS:0.0) OPT 0 DF0A_E0_0_A CRANKSHAFT DF0A_E0_0

19 FIG.A FIG.A (-B-) TIMING CHAIN 0 0 -J0 GEAR, DRIVEN (NT:0) 0-00 BEARING (0X0X) LOWER 0-00 BEARING (0X0X) UPPER 0-0 OIL SEAL (XX) -J00 HOLDER, DRIVEN GEAR O RING (D:.,ID:.) 00-0A BOLT -J00 CHAIN, TIMING ST -J00 CHAIN, TIMING ND 0 0-J00 BASE, TIMING CHAIN GUIDE NO. -J00 GASKET, GUIDE BASE 0- PIN 00-0A BOLT -J00 SHOE, TIMING CHAIN UPPER -J00 SHOE, TIMING CHAIN LOWER -J00 GUIDE, TIMING CHAIN NO. 00-0A BOLT 0-J00 TENSIONER ASSY, TIMING CHAIN -G00.PAD, TIMING CHAIN TENSIONER 0-0J00 SPACER, TIMING CHAIN TENSIONER 00-0A BOLT -J0 ADJUSTER ASSY, TENSIONER -J00 TENSIONER ASSY, STBD -J00 TENSIONER ASSY, PORT 00-00A BOLT 00-00A BOLT DF0A_E0_0_A TIMING CHAIN DF0A_E0_0

20 FIG.A FIG.A (-B-) CAMSHAFT 0-J0 CAMSHAFT, INTAKE STBD 0-J0 CAMSHAFT, INTAKE PORT -J0 CAMSHAFT, EXH STBD -J0 CAMSHAFT, EXH PORT 0-J00 SPROCKET ASSY, CAM TIMING (NT:/) -J00 SPROCKET, EXH CAMSHAFT (NT:) -J00 BOLT, INTAKE CAMSHAFT -J00 BOLT, CAMSHAFT EXHAUST PIN (X) PIN (X) 0-J00 VALVE, OIL CONTROL -J00 GASKET, VALVE 00-0 BOLT -J00 TAPPET - -J00- SHIM, TAPPET (T:.) AR - -J00-0 SHIM, TAPPET (T:.00) AR - -J00- SHIM, TAPPET (T:.) AR - -J00- SHIM, TAPPET (T:.0) AR - -J00- SHIM, TAPPET (T:.) AR - -J00- SHIM, TAPPET (T:.0) AR - -J00- SHIM, TAPPET (T:.) AR - -J00- SHIM, TAPPET (T:.0) AR - -J00- SHIM, TAPPET (T:.) AR -0 -J00-0 SHIM, TAPPET (T:.00) AR - -J00- SHIM, TAPPET (T:.) AR - -J00- SHIM, TAPPET (T:.0) AR - -J00- SHIM, TAPPET (T:.) AR - -J00-0 SHIM, TAPPET (T:.00) AR - -J00- SHIM, TAPPET (T:.) AR - -J00- SHIM, TAPPET (T:.0) AR - -J00- SHIM, TAPPET (T:.) AR - -J00-0 SHIM, TAPPET (T:.00) AR - -J00- SHIM, TAPPET (T:.) AR DF0A_E0_0_A CAMSHAFT DF0A_E0_0

21 FIG.A FIG.A (-B-) CAMSHAFT -0 -J00- SHIM, TAPPET (T:.0) AR - -J00- SHIM, TAPPET (T:.) AR - -J00-0 SHIM, TAPPET (T:.00) AR - -J00- SHIM, TAPPET (T:.) AR - -J00- SHIM, TAPPET (T:.0) AR - -J00- SHIM, TAPPET (T:.) AR - -J00-0 SHIM, TAPPET (T:.00) AR - -J00- SHIM, TAPPET (T:.) AR - -J00- SHIM, TAPPET (T:.0) AR - -J00- SHIM, TAPPET (T:.) AR - -J00-0 SHIM, TAPPET (T:.00) AR - -J00- SHIM, TAPPET (T:.) AR - -J00- SHIM, TAPPET (T:.0) AR - -J00- SHIM, TAPPET (T:.) AR - -J00-0 SHIM, TAPPET (T:.000) AR -J00 VALVE, INTAKE -J0 VALVE, EXHAUST -J0 SPRING, VALVE -G00 RETAINER, VALVE SPRING 0-00 COTTER, VALVE -G0 SEAT, VALVE SPRING 0-00 OIL SEAL (.X.X.) DF0A_E0_0_A CAMSHAFT DF0A_E0_0

22 FIG.A FIG.A (-B-0) INTAKE MANIFOLD 0-J0 MANIFOLD, INTAKE -J00 GASKET, INTAKE MANIFOLD 00-0 STUD BOLT 00-0 BOLT (X) 0-0 NUT 00-0 WASHER (.XX.) DF0A_E0_0_A INTAKE MANIFOLD DF0A_E0_0

23 FIG.A FIG.A (-B-) RING GEAR COVER 0-J0 COVER, RING GEAR -J00.HOSE, BREATHER -J00.UNION, BREATHER -J00.PLATE, RING GEAR COVER 0-J00.ARRESTER, FLAME -J00.SILENCER, UPPER COVER 00-0.CLIP 00-0.BOLT BOLT 0 -J00.SCREW -J00 BRACE, RING GEAR COVER -J0 GUARD, AIR DUCT STBD -J0 GUARD, AIR DUCT PORT BOLT BOLT BOLT 00-0 BOLT -E0 LABEL (S.I.G.P) -J00 LABEL, OIL & CLEARANCE 0 DF0A_E0_0_A RING GEAR COVER DF0A_E0_0

24 FIG.0A FIG.0A (-B-) EXHAUST COVER 0 -J0 COVER, EXHAUST STBD 0-J0 COVER, EXHAUST PORT -J00 GASKET, EXHAUST COVER STBD -J00 GASKET, EXHAUST COVER PORT -J00 COVER, PROTECTION ANODE -J0 ANODE, PROTECTION 00-0 BOLT (X) 00-0 O RING (D:.,ID:.) BOLT BOLT 0 DF0A_E0_0_0A EXHAUST COVER DF0A_E0_0

25 FIG.A FIG.A (-B-) FUEL INJECTOR (DF0A E0) 0 0 -J0 HOSE, FUEL (WAY TO DLVY PIPE) 0-J00 INJECTOR ASSY, FUEL -G00.O RING -B00 INSULATOR, DELIVERY PIPE -J00 PIPE, DELIVERY -J0 HOSE, FUEL (DLVY TO DLVY) -J00 GASKET, DELIVERY PIPE -EA0 UNION, DELIVERY PIPE -J00 UNION, DELIVERY PIPE 0 -J00 PROTECTOR, FUEL HOSE (L:0) 0-0 PLUG (X) CUSHION UNION 00- CLIP 00- CLAMP CLAMP CLAMP BOLT 0-J HOSE, FUEL (PUMP TO FILTER) CLIP CLIP -J00 GUIDE, FUEL HOSE 00-0 BOLT CAP (OD:.) DF0A_E0_0_A FUEL INJECTOR DF0A_E0_0

26 FIG.B FIG.B (-B-) FUEL INJECTOR (DF0A E0) 0 0 -J0 HOSE, FUEL (WAY TO DLVY PIPE) 0-J00 INJECTOR ASSY, FUEL -G00.O RING -B00 INSULATOR, DELIVERY PIPE -J00 PIPE, DELIVERY -J0 HOSE, FUEL (DLVY TO DLVY) -J0 GASKET, DELIVERY PIPE -J00 UNION, DELIVERY PIPE -J00 UNION, DELIVERY PIPE 0 -J00 PROTECTOR, FUEL HOSE (L:0) 0-0 PLUG (X) CUSHION 00-0 UNION 00- CLIP 00- CLAMP CLAMP CLAMP BOLT 0-J HOSE, FUEL (PUMP TO FILTER) CLIP CLIP -J00 GUIDE, FUEL HOSE 00-0 BOLT CAP (OD:.) DF0A_E0_0_B FUEL INJECTOR DF0A_E0_0

27 FIG.C FIG.C (-B-) FUEL INJECTOR (DF0A E0) 0 0 -J0 HOSE, FUEL (WAY TO DLVY PIPE) 0-J00 INJECTOR ASSY, FUEL -G00.O RING -B00 INSULATOR, DELIVERY PIPE -J00 PIPE, DELIVERY -J0 HOSE, FUEL (DLVY TO DLVY) -J00 GASKET, DELIVERY PIPE -EA0 UNION, DELIVERY PIPE -J00 UNION, DELIVERY PIPE 0 -J00 PROTECTOR, FUEL HOSE (L:0) 0-0 PLUG (X) CUSHION UNION 00- CLIP 00- CLAMP CLAMP CLAMP BOLT 0-J HOSE, FUEL (PUMP TO FILTER) CLIP CLIP -J00 GUIDE, FUEL HOSE 00-0 BOLT CAP (OD:.) DF0A_E0_0_C FUEL INJECTOR DF0A_E0_0

28 FIG.D FIG.D (-C-) FUEL INJECTOR (DF0A E0) 0 0 -J0 HOSE, FUEL (WAY TO DLVY PIPE) 0-J00 INJECTOR ASSY, FUEL -G00.O RING -B00 INSULATOR, DELIVERY PIPE -J00 PIPE, DELIVERY -J0 HOSE, FUEL (DLVY TO DLVY) -J0 GASKET, DELIVERY PIPE -J00 UNION, DELIVERY PIPE -J00 UNION, DELIVERY PIPE 0 -J00 PROTECTOR, FUEL HOSE (L:0) 0-0 PLUG (X) CUSHION 00-0 UNION 00- CLIP 00- CLAMP CLAMP CLAMP BOLT 0-J HOSE, FUEL (PUMP TO FILTER) CLIP CLIP -J00 GUIDE, FUEL HOSE 00-0 BOLT CAP (OD:.) DF0A_E0_0_D FUEL INJECTOR DF0A_E0_0

29 FIG.A FIG.A (-C-) FUEL PUMP/FUEL VAPOR SEPARATOR (DF0A E0) PUMP ASSY, FUEL (L) 0-J0 FILTER, FUEL (L) -J0.CAP, FILTER -J0.SEAL, NO. -J0.FILTER ASSY, FUEL -J0.CASE ASSY, FILTER -J00 COVER, FUEL FILTER -J0 HOSE, FUEL (H) -J00 CLAMP, FUEL FILTER HOSE (.X.X00) L:00-> 0-J00 FILTER, FUEL (EPI) CUSHION -0J00 UNION, FUEL HOSE (H) -J00 UNION, WAY 0-00 WASHER 0-J00 COOLER, FUEL 0-0 GASKET (.XX.) UNION UNION 0 00-J00 SEPARATOR ASSY, FUEL VAPOR 0-J00.VALVE ASSY, NEEDLE -J00.GASKET, SEPARATOR 0-J00.FLOAT ASSY 00-J00.PUMP ASSY, FUEL (H) -J00.BUSH, FUEL PUMP -0J00.SPACER, FUEL PUMP -0J00.FILTER, FUEL PUMP -E00.PIN, FLOAT 0-00B.SCREW 0-00.SCREW 0-J00.REGULATOR, FUEL PRESSURE -E00.SCREW -J00.SCREW 00-0 CUSHION DF0A_E0_0_A FUEL PUMP/FUEL VAPOR SEPARATOR DF0A_E0_0

30 FIG.A FIG.A (-C-) FUEL PUMP/FUEL VAPOR SEPARATOR (DF0A E0) -J00 BOLT, COOLER BRACKET HOSE (.X.X00) L:00->0 00- CLIP (ID:.) -J0 HOSE, FUEL (L) -J00 CLIP 0 -J00 CLIP -J00 BRACKET, FUEL COOLER BOLT -J0 HOSE, FUEL (H) -J0 HOSE, FUEL (H) -J00 BRACKET, FUEL FILTER 00-0 BOLT -J00 FILTER, FUEL (L) HOSE (.X.X00) L:00-> -J0 HOSE, FUEL (H) BOLT -J00 BRACKET, CHECK VALVE -J00 VALVE, CHECK -J0 HOSE, FUEL (L) -E0 SCREW, DRAIN -J00 HOSE, DRAIN 0-00B SCREW 00-0 CLIP -J0 PROTECTOR, EVAP HOSE (L:) WASHER (.XX.) WASHER BOLT -J00 BRACKET, VAPOR SEPARATOR 00-0 BOLT 0-00 WASHER BOLT -J00 BRACKET, PURGE VALVE 00-0 BOLT DF0A_E0_0_A FUEL PUMP/FUEL VAPOR SEPARATOR DF0A_E0_0

31 FIG.A 0 FIG.A (-C-) FUEL PUMP/FUEL VAPOR SEPARATOR (DF0A E0) B HOSE (X.X000) L:000-> UP TO VIN A HOSE (X.X) FROM VIN CUSHION CLAMP CLAMP DF0A_E0_0_A FUEL PUMP/FUEL VAPOR SEPARATOR DF0A_E0_0

32 FIG.B FIG.B (-C-) FUEL PUMP/FUEL VAPOR SEPARATOR (DF0A E0) PUMP ASSY, FUEL (L) 0-J0 FILTER, FUEL (L) -J0.CAP, FILTER -J0.SEAL, NO. -J0.FILTER ASSY, FUEL -J0.CASE ASSY, FILTER -J00 COVER, FUEL FILTER -J0 HOSE, FUEL (H) -J00 CLAMP, FUEL FILTER HOSE (.X.X00) L:00-> 0-J0 FILTER, FUEL (EPI) CUSHION -0J00 UNION, FUEL HOSE -J00 UNION, WAY 0-00 WASHER 0-J00 COOLER, FUEL -0J00 GASKET, FUEL COOLER UNION 00-0 UNION -0J00 UNION, FUEL COOLER 0 00-J0 SEPARATOR ASSY, FUEL VAPOR 0-J00.VALVE ASSY, NEEDLE -J0.GASKET, SEPARATOR 0-J00.FLOAT ASSY 00-J0.PUMP ASSY, FUEL (H) -J0.BUSH, FUEL PUMP -0J0.SPACER, FUEL PUMP -0J00.FILTER, FUEL PUMP -E00.PIN, FLOAT -J00.SCREW -E0.SCREW, REGULATOR 0-J00.REGULATOR, FUEL PRESSURE -E00.SCREW -J00.SCREW 00-0 CUSHION DF0A_E0_0_B FUEL PUMP/FUEL VAPOR SEPARATOR DF0A_E0_0

33 FIG.B FIG.B (-C-) FUEL PUMP/FUEL VAPOR SEPARATOR (DF0A E0) -J00 BOLT, COOLER BRACKET HOSE (.X.X00) L:00->0 00- CLIP (ID:.) -J0 HOSE, FUEL (L) -J00 CLIP 0 -J00 CLIP -J00 BRACKET, FUEL COOLER BOLT -J0 HOSE, FUEL (H) -J0 HOSE, FUEL (H) -J00 BRACKET, FUEL FILTER 00-0 BOLT -J00 FILTER, FUEL (L) HOSE (.X.X00) L:00-> -J0 HOSE, FUEL (H) BOLT -J00 BRACKET, CHECK VALVE -J0 VALVE, CHECK -J0 HOSE, FUEL (L) -E0 SCREW, DRAIN -J00 HOSE, DRAIN 0-00B SCREW 00-0 CLIP -J0 PROTECTOR, EVAP HOSE (L:) WASHER (.XX.) WASHER BOLT -J00 BRACKET, VAPOR SEPARATOR 00-0 BOLT 0-00 WASHER BOLT -J00 BRACKET, PURGE VALVE 00-0 BOLT DF0A_E0_0_B FUEL PUMP/FUEL VAPOR SEPARATOR DF0A_E0_0

34 FIG.B 0 FIG.B (-C-) FUEL PUMP/FUEL VAPOR SEPARATOR (DF0A E0) B HOSE (X.X000) L:000-> UP TO VIN A HOSE (X.X) FROM VIN CUSHION CLAMP CLAMP DF0A_E0_0_B FUEL PUMP/FUEL VAPOR SEPARATOR DF0A_E0_0

35 FIG.C FIG.C (-C-) FUEL PUMP/FUEL VAPOR SEPARATOR (DF0A E0) PUMP ASSY, FUEL (L) 0-J0 FILTER, FUEL (L) -J0.CAP, FILTER -J0.SEAL, NO. -J0.FILTER ASSY, FUEL -J0.CASE ASSY, FILTER -J00 COVER, FUEL FILTER -J0 HOSE, FUEL (H) -J00 CLAMP, FUEL FILTER HOSE (.X.X00) L:00-> 0-J00 FILTER, FUEL (EPI) CUSHION -0J00 UNION, FUEL HOSE (H) -J00 UNION, WAY 0-00 WASHER 0-J00 COOLER, FUEL 0-0 GASKET (.XX.) UNION UNION 0 00-J00 SEPARATOR ASSY, FUEL VAPOR 0-J00.VALVE ASSY, NEEDLE -J00.GASKET, SEPARATOR 0-J00.FLOAT ASSY 00-J00.PUMP ASSY, FUEL (H) -J00.BUSH, FUEL PUMP -0J00.SPACER, FUEL PUMP -0J00.FILTER, FUEL PUMP -E00.PIN, FLOAT 0-00B.SCREW 0-00.SCREW 0-J00.REGULATOR, FUEL PRESSURE -E00.SCREW -J00.SCREW 00-0 CUSHION DF0A_E0_0_C FUEL PUMP/FUEL VAPOR SEPARATOR DF0A_E0_0

36 FIG.C FIG.C (-C-0) FUEL PUMP/FUEL VAPOR SEPARATOR (DF0A E0) -J00 BOLT, COOLER BRACKET HOSE (.X.X00) L:00->0 00- CLIP (ID:.) -J0 HOSE, FUEL (L) -J00 CLIP 0 -J00 CLIP -J00 BRACKET, FUEL COOLER BOLT -J0 HOSE, FUEL (H) -J0 HOSE, FUEL (H) -J00 BRACKET, FUEL FILTER 00-0 BOLT -J00 FILTER, FUEL (L) HOSE (.X.X00) L:00-> -J0 HOSE, FUEL (H) BOLT -J00 BRACKET, CHECK VALVE -J00 VALVE, CHECK -J0 HOSE, FUEL (L) -E0 SCREW, DRAIN -J00 HOSE, DRAIN 0-00B SCREW 00-0 CLIP -J0 PROTECTOR, EVAP HOSE (L:) WASHER (.XX.) WASHER BOLT -J00 BRACKET, VAPOR SEPARATOR 00-0 BOLT 0-00 WASHER BOLT -J00 BRACKET, PURGE VALVE 00-0 BOLT DF0A_E0_0_C FUEL PUMP/FUEL VAPOR SEPARATOR DF0A_E0_0

37 FIG.C 0 FIG.C (-C-) FUEL PUMP/FUEL VAPOR SEPARATOR (DF0A E0) B HOSE (X.X000) L:000-> UP TO VIN A HOSE (X.X) FROM VIN CUSHION CLAMP CLAMP DF0A_E0_0_C FUEL PUMP/FUEL VAPOR SEPARATOR DF0A_E0_0

38 FIG.D FIG.D (-C-) FUEL PUMP/FUEL VAPOR SEPARATOR (DF0A E0) PUMP ASSY, FUEL (L) 0-J0 FILTER, FUEL (L) -J0.CAP, FILTER -J0.SEAL, NO. -J0.FILTER ASSY, FUEL -J0.CASE ASSY, FILTER -J00 COVER, FUEL FILTER -J0 HOSE, FUEL (H) -J00 CLAMP, FUEL FILTER HOSE (.X.X00) L:00-> 0-J0 FILTER, FUEL (EPI) CUSHION -0J00 UNION, FUEL HOSE -J00 UNION, WAY 0-00 WASHER 0-J00 COOLER, FUEL -0J00 GASKET, FUEL COOLER UNION 00-0 UNION -0J00 UNION, FUEL COOLER 0 00-J0 SEPARATOR ASSY, FUEL VAPOR 0-J00.VALVE ASSY, NEEDLE -J0.GASKET, SEPARATOR 0-J00.FLOAT ASSY 00-J0.PUMP ASSY, FUEL (H) -J0.BUSH, FUEL PUMP -0J0.SPACER, FUEL PUMP -0J00.FILTER, FUEL PUMP -E00.PIN, FLOAT -J00.SCREW -E0.SCREW, REGULATOR 0-J00.REGULATOR, FUEL PRESSURE -E00.SCREW -J00.SCREW 00-0 CUSHION DF0A_E0_0_D FUEL PUMP/FUEL VAPOR SEPARATOR DF0A_E0_0

39 FIG.D FIG.D (-C-) FUEL PUMP/FUEL VAPOR SEPARATOR (DF0A E0) -J00 BOLT, COOLER BRACKET HOSE (.X.X00) L:00->0 00- CLIP (ID:.) -J0 HOSE, FUEL (L) -J00 CLIP 0 -J00 CLIP -J00 BRACKET, FUEL COOLER BOLT -J0 HOSE, FUEL (H) -J0 HOSE, FUEL (H) -J00 BRACKET, FUEL FILTER 00-0 BOLT -J00 FILTER, FUEL (L) HOSE (.X.X00) L:00-> -J0 HOSE, FUEL (H) BOLT -J00 BRACKET, CHECK VALVE -J0 VALVE, CHECK -J0 HOSE, FUEL (L) -E0 SCREW, DRAIN -J00 HOSE, DRAIN 0-00B SCREW 00-0 CLIP -J0 PROTECTOR, EVAP HOSE (L:) WASHER (.XX.) WASHER BOLT -J00 BRACKET, VAPOR SEPARATOR 00-0 BOLT 0-00 WASHER BOLT -J00 BRACKET, PURGE VALVE 00-0 BOLT DF0A_E0_0_D FUEL PUMP/FUEL VAPOR SEPARATOR DF0A_E0_0

40 FIG.D 0 FIG.D (-C-) FUEL PUMP/FUEL VAPOR SEPARATOR (DF0A E0) B HOSE (X.X000) L:000-> UP TO VIN A HOSE (X.X) FROM VIN CUSHION CLAMP CLAMP DF0A_E0_0_D FUEL PUMP/FUEL VAPOR SEPARATOR DF0A_E0_0

41 FIG.0A 0 0 FIG.0A (-C-) WATER PUMP (DF0A E0) 0-J0 CASE, WATER PUMP -J0 SLEEVE, CASE -J00 SEALING, CASE -J00 IMPELLER, WATER PUMP -J0 PANEL, PUMP CASE UNDER -J00 GASKET, PUMP CASE PANEL -J00 PANEL, WATER PUMP NO. - -J0 TUBE, WATER (UL) W/TRANSOM(X) - -J TUBE, WATER (XX) W/TRANSOM(XX) -J0 BUSH, WATER TUBE UPPER 0 -J00 BUSH, WATER TUBE LOWER -J00 BUSH, WATER PUMP CASE -J00 SPACER, WATER TUBE -L00 FILTER, WATER PORT SIDE -L00 FILTER, WATER STBD SIDE -J00 BOLT, PUMP CASE PANEL 0-0 BOLT (X) 0-00 SCREW (X) PIN (X) KEY GASKET WATER TUBE UPPER 00-J0 WATER PUMP REPAIR KIT OPT -J00.SEALING, CASE OPT -J00.IMPELLER, WATER PUMP OPT -J0.PANEL, PUMP CASE UNDER OPT -J00.GASKET, PUMP CASE PANEL OPT -J00.PANEL, WATER PUMP NO. OPT KEY OPT DF0A_E0_0_0A WATER PUMP DF0A_E0_0

42 FIG.0B 0 0 FIG.0B (-D-) WATER PUMP (DF0A E0) 0-J0 CASE, WATER PUMP -J SLEEVE, CASE -J00 SEALING, CASE -J00 IMPELLER, WATER PUMP -J PANEL, PUMP CASE UNDER -J00 GASKET, PUMP CASE PANEL -J00 PANEL, WATER PUMP NO. - -J0 TUBE, WATER (UL) W/TRANSOM(X) - -J TUBE, WATER (XX) W/TRANSOM(XX) -J0 BUSH, WATER TUBE UPPER 0 -J00 BUSH, WATER TUBE LOWER -J00 BUSH, WATER PUMP CASE -J00 SPACER, WATER TUBE -L00 FILTER, WATER PORT SIDE -L00 FILTER, WATER STBD SIDE -J00 BOLT, PUMP CASE PANEL 0-0 BOLT (X) 0-00 SCREW (X) PIN (X) KEY GASKET WATER TUBE UPPER 00-J0 WATER PUMP REPAIR KIT OPT -J00.SEALING, CASE OPT -J00.IMPELLER, WATER PUMP OPT -J0.PANEL, PUMP CASE UNDER OPT -J00.GASKET, PUMP CASE PANEL OPT -J00.PANEL, WATER PUMP NO. OPT KEY OPT DF0A_E0_0_0B WATER PUMP DF0A_E0_0

43 FIG.0C 0 0 FIG.0C (-D-) WATER PUMP (DF0A E0) 0-J0 CASE, WATER PUMP -J0 SLEEVE, CASE -J00 SEALING, CASE -J00 IMPELLER, WATER PUMP -J0 PANEL, PUMP CASE UNDER -J00 GASKET, PUMP CASE PANEL -J00 PANEL, WATER PUMP NO. - -J0 TUBE, WATER (UL) W/TRANSOM(X) - -J TUBE, WATER (XX) W/TRANSOM(XX) -J0 BUSH, WATER TUBE UPPER 0 -J00 BUSH, WATER TUBE LOWER -J00 BUSH, WATER PUMP CASE -J00 SPACER, WATER TUBE -L00 FILTER, WATER PORT SIDE -L00 FILTER, WATER STBD SIDE -J00 BOLT, PUMP CASE PANEL 0-0 BOLT (X) 0-00 SCREW (X) PIN (X) KEY GASKET WATER TUBE UPPER 00-J0 WATER PUMP REPAIR KIT OPT -J00.SEALING, CASE OPT -J00.IMPELLER, WATER PUMP OPT -J0.PANEL, PUMP CASE UNDER OPT -J00.GASKET, PUMP CASE PANEL OPT -J00.PANEL, WATER PUMP NO. OPT KEY OPT DF0A_E0_0_0C WATER PUMP DF0A_E0_0

44 FIG.0D 0 0 FIG.0D (-D-) WATER PUMP (DF0A E0) 0-J0 CASE, WATER PUMP -J SLEEVE, CASE -J00 SEALING, CASE -J00 IMPELLER, WATER PUMP -J PANEL, PUMP CASE UNDER -J00 GASKET, PUMP CASE PANEL -J00 PANEL, WATER PUMP NO. - -J0 TUBE, WATER (UL) W/TRANSOM(X) - -J TUBE, WATER (XX) W/TRANSOM(XX) -J0 BUSH, WATER TUBE UPPER 0 -J00 BUSH, WATER TUBE LOWER -J00 BUSH, WATER PUMP CASE -J00 SPACER, WATER TUBE -L00 FILTER, WATER PORT SIDE -L00 FILTER, WATER STBD SIDE -J00 BOLT, PUMP CASE PANEL 0-0 BOLT (X) 0-00 SCREW (X) PIN (X) KEY GASKET WATER TUBE UPPER 00-J0 WATER PUMP REPAIR KIT OPT -J00.SEALING, CASE OPT -J00.IMPELLER, WATER PUMP OPT -J0.PANEL, PUMP CASE UNDER OPT -J00.GASKET, PUMP CASE PANEL OPT -J00.PANEL, WATER PUMP NO. OPT KEY OPT DF0A_E0_0_0D WATER PUMP DF0A_E0_0

45 FIG.A FIG.A (-D-) THERMOSTAT -J00 HOSE, WATER RETURN STBD -J00 HOSE, WATER RETURN PORT 0-J00 PLATE, CYL BLOCK WTR JKT -J00 GASKET, CYL BLOCK PLATE -J00 PIPE, OUTLET -J00 GASKET, OUTLET PIPE - -0J00-0EP COVER, WATER PRESS VALVE (BLACK) - -0J00-YS COVER, WATER PRESS VALVE (WHITE) 0-E0 VALVE, WATER PRESSURE - 0-0J0 THERMOSTAT (0 DEG) - 0-0J0 THERMOSTAT ( DEG) OPT 0 -J00 COVER, THERMOSTAT -0J00 WAY, WATER HOSE -J00 HOSE ( WAY TO E/H COV) 0-0 BOLT (X) O RING (D:.,ID:.) 00-0 CUSHION HOSE (XX00) L:00-> HOSE (XX00) L:00-> HOSE (XX00) L:00-> HOSE (XX00) L:00-> HOSE (XX00) L:00-> HOSE (XX00) HOSE (XX00) B HOSE (XX000) L:000-> B HOSE (XX000) L:000-> BOLT JOINT, WAY 00-0 CLIP 00-0 CLIP 00-0 CLIP 00- CLAMP CLIP (ID:0) DF0A_E0_0_A THERMOSTAT DF0A_E0_0

46 FIG.A FIG.A (-D-) THERMOSTAT CLIP BOLT BOLT 00-0 BOLT 0 -J00 HOLDER, WATER HOSE 00- CLIP -J0 HOSE, WATER FLUSH CLIP (ID:) CLIP (ID:) -J0 BRACKET, HOSE CLAMP 0 DF0A_E0_0_A THERMOSTAT DF0A_E0_0

47 FIG.A FIG.A (-D-) THROTTLE BODY J00 HOSE, PCV -B00 SEAL, PCV VALVE 00-J0 COLLECTOR ASSY -J00.SPACER, COLLECTOR 0-J0.COVER, COLLECTOR -J00..MARK, EMBLEM V (.0L) -J00.GASKET, COLLECTOR COVER 0-J00.FUNNEL, COLLECTOR 0-H00.SENSOR, MAP O RING (D:.,ID:.) 00-0.BOLT 00-0.BOLT 0-00.SCREW 0-.PIN -J00 BRACKET, COLLECTOR -J0 GASKET, COLLECTOR 0-J00 BODY ASSY, THROTTLE -J0 GASKET, THROTTLE BODY -J00 DAMPER, THROTTLE BODY 0 -J00 GASKET, THROTTLE BODY -J00 GROMMET, THROTTLE BODY 00- CLIP -J00 VALVE, PCV BOLT (X0) GROMMET 00-0 CLAMP CLAMP DF0A_E0_0_A THROTTLE BODY DF0A_E0_0

48 FIG.A FIG.A (-D-) THROTTLE BODY 0-0 BOLT 00-0 BOLT 00-0 BOLT BOLT 0- PIN 0-0 NUT 0-00 NUT 00-0 WASHER (.XX.) DF0A_E0_0_A THROTTLE BODY DF0A_E0_0

49 FIG.A FIG.A (-D-) OIL PUMP -J SPROCKET, OIL PUMP DRIVE (NT:) -J0 SPROCKET, OIL PUMP DRIVEN (NT:) 00-J0 PUMP ASSY, OIL 0-J00 STRAINER, OIL PUMP 0-J00 CHAIN, OIL PUMP DRIVE -J00 TENSIONER, OIL PUMP CHAIN -J00 SPRING, OIL PUMP TENSIONER -J0 BOLT, OIL PUMP TENSIONER 0- SHIM (X0X0.) O RING (D:.,ID:.) 00-0A BOLT 00-0A BOLT 00-0A BOLT 00-0A BOLT BEARING 0 DF0A_E0_0_A OIL PUMP DF0A_E0_0

50 FIG.0A FIG.0A (-D-0) OIL PAN J0-0EP COVER, PROTECTION ANODE (BLACK) - -J0-YS COVER, PROTECTION ANODE (WHITE) - -J0 ANODE, PROTECTION - -J ANODE (MAGNESIUM) OPT 0-J BOLT, ANODE COVER 00-0 BOLT (X) 00-0 O RING (D:.,ID:.) -J00 GASKET, OIL PAN - 0-J0-0EP PAN, OIL (BLACK) - 0-J0-YS PAN, OIL (WHITE) -J0 UNION, OIL PAN - -J00-0EP PIPE, EXHAUST (BLACK) - -J00-YS PIPE, EXHAUST (WHITE) 0 -J0 SEAL, EXHAUST TUBE -J00 TUBE, EXHAUST -J00 GASKET, EXHAUST TUBE -J00 BOLT, EXHAUST PIPE -J00 PIPE, EXHAUST RELEASE 0-0 GASKET (.X0X.) 0-00 PLUG (X.) PIN (X) PIN (X) 00-00A BOLT BOLT (X0) BOLT (0X0) 0-0 BOLT (0X) 0-J00 BOLT, SPEEDOMETER HOSE CLAMP 0-J0 CLAMP, SPEEDOMETER HOSE 0-J00 GAUGE, OIL LEVEL -J00 GUIDE, OIL LEVEL GAUGE O RING (D:.,ID:.) 00-0 BOLT DF0A_E0_0_0A OIL PAN DF0A_E0_0

51 FIG.0A FIG.0A (-D-) CLUTCH SHAFT 0-J00 LEVER, CLUTCH -J00 BUSH, CLUTCH LEVER -J00 HOLDER, CLUTCH LEVER 00-0 WASHER (0X0X) 0-J0 SHAFT, CLUTCH -J0 ARM, CLUTCH SHAFT -J00 ROD, CLUTCH (UL) -J00 LINK, CLUTCH LEVER -00 COVER, CLUTCH ROD WASHER (.XX.) PIN SPRING PIN (0.X0) 0-0 PLUG (X) BALL 0-0 BEARING (XX) 0-00 OIL SEAL (XX) BUSH BUSH E RING SPRING BOLT 0-00 SCREW 0- CIRCLIP -J0 LINK, CLUTCH LEVER NO. -J0 CONNECTOR, REMOCON CABLE -E00 NUT, REMOCON CABLE WASHER (XX) 0-00 CLIP -J0 HOLDER, CLUTCH LEVER 00-0 BOLT -J0 CONNECTOR, REMOCON CABLE NO. -E0 NUT, REMOCON CABLE NO. DF0A_E0_0_0A CLUTCH SHAFT DF0A_E0_0

52 FIG.0A 0 FIG.0A (-D-) CLUTCH ROD (DF0A UP TO VIN., DF0A UP TO VIN.0 - -L00 ROD, SHIFT DRIVE (X) W/TRANSOM(X) - -L0 ROD, SHIFT DRIVE (XX) W/TRANSOM(XX) -L00 YOKE, SHIFTER -0J00 MAGNET, GEAR CASE SPRING PIN (X0) - -L00-0EP HOUSING, SHIFT ROD GUIDE (BLACK) - -L00-YS HOUSING, SHIFT ROD GUIDE (WHITE) -0J00 COVER, SFT GUIDE HSG OIL SEAL 0-00 OIL SEAL (0XX) -L00 SLIDER, SHIFT HORIZONTAL -J00 BOLT, SHIFT ROD HOUSING WASHER (0.XX) -L00 GEAR, SHIFT ROD (NT:) -L00 HOUSING, MAGNET E RING -L00 SEALING, SHIFT ROD GUIDE HSG -L00 HOUSING, SHIFT SLIDER -L00 FILTER, WATER PORT FRONT SIDE -L00 FILTER, WATER STBD FRONT SIDE -J0 ANODE, PROTECTION 00-0 BOLT BOLT (X) PIN (.XX0) 0-00 SCREW (X) 0 DF0A_E0_0_0A CLUTCH ROD DF0A_E0_0

53 FIG.0B 0 FIG.0B (-D-) CLUTCH ROD (DF0A FROM VIN., DF0A FROM VIN.0) - -L00 ROD, SHIFT DRIVE (X) W/TRANSOM(X) - -L0 ROD, SHIFT DRIVE (XX) W/TRANSOM(XX) -L00 YOKE, SHIFTER -0J00 MAGNET, GEAR CASE SPRING PIN (X0) - -L00-0EP HOUSING, SHIFT ROD GUIDE (BLACK) - -L00-YS HOUSING, SHIFT ROD GUIDE (WHITE) -0J00 COVER, SFT GUIDE HSG OIL SEAL 0-00 OIL SEAL (0XX) -L00 SLIDER, SHIFT HORIZONTAL -J00 BOLT, SHIFT ROD HOUSING WASHER (0.XX) -L00 GEAR, SHIFT ROD (NT:) -L00 HOUSING, MAGNET E RING -L00 SEALING, SHIFT ROD GUIDE HSG -L00 HOUSING, SHIFT SLIDER -L00 FILTER, WATER PORT FRONT SIDE -L00 FILTER, WATER STBD FRONT SIDE -J0 ANODE, PROTECTION 00-0 BOLT BOLT (X) PIN (.XX0) 0-00 SCREW (X) -L00 HOLDER, MAGNET -0 MAGNET, GEAR CASE 0 DF0A_E0_0_0B CLUTCH ROD DF0A_E0_0

54 FIG.0A FIG.0A (-D-) TRANSMISSION (DF0A UP TO VIN., DF0A UP TO VIN.0-0-L SHAFT, DRIVE (X) W/TRANSOM(X) - 0-L SHAFT, DRIVE (XX) W/TRANSOM(XX) -L00 COLLAR, DRIVE SHAFT -J00 SPACER, DRIVE SHAFT BEARING 0-00 NUT 0-00 BEARING (XX) 0-L0 SET GEAR SHIM (T:0.) SHIM (T:0.0) SHIM (T:0.) SHIM (T:0.0) SHIM (T:0.) SHIM (T:0.0) SHIM (T:0.) SHIM (T:0.0) SHIM (T:0.) SHIM (T:0.0) 00-0 NUT 0- WASHER SPACER (.X0X) REAR GEAR SHIM (T:0.0) REAR GEAR SHIM (T:0.) REAR GEAR SHIM (T:0.0) REAR GEAR SHIM (T:0.) REAR GEAR SHIM (T:0.0) REAR GEAR SHIM (T:0.) REAR GEAR SHIM (T:0.0) REAR GEAR SHIM (T:0.) REAR GEAR SHIM (T:0.0) REAR GEAR SHIM (T:0.) REAR GEAR WASHER (0XX) FRONT GEAR WASHER (0XX) REAR GEAR DF0A_E0_0_0A TRANSMISSION DF0A_E0_0

55 FIG.0A FIG.0A (-D-) TRANSMISSION (DF0A UP TO VIN., DF0A UP TO VIN SHIM (T:0.0) REAR GEAR SHIM (T:0.) REAR GEAR SHIM (T:0.0) REAR GEAR SHIM (T:0.) REAR GEAR SHIM (T:0.0) REAR GEAR SHIM (T:0.) REAR GEAR SHIM (T:0.0) REAR GEAR SHIM (T:0.) REAR GEAR SHIM (T:0.0) REAR GEAR SHIM (T:0.) REAR GEAR SHIM (T:0.0) FRONT GEAR SHIM (T:0.) FRONT GEAR SHIM (T:0.0) FRONT GEAR SHIM (T:0.) FRONT GEAR SHIM (T:0.0) FRONT GEAR SHIM (T:0.) FRONT GEAR SHIM (T:0.0) FRONT GEAR SHIM (T:0.) FRONT GEAR SHIM (T:0.0) FRONT GEAR SHIM (T:0.) FRONT GEAR 0-0 BEARING (XX.) 0-L00 SHAFT, PROPELLER -L00 SHIFTER, CLUTCH DOG PIN (X) 0 -L0 PIN, CONNECTOR SPRING -L00 SPRING, DETENT BALL DETENT NO BALL DETENT NO. 0-L HOUSING, PROP SFT BRG -L00.WASHER, REVERSE GEAR THRUST 0-0.BEARING (X0X) 0-00.BEARING (X0X) DF0A_E0_0_0A TRANSMISSION DF0A_E0_0

56 FIG.0A FIG.0A (-E-) TRANSMISSION (DF0A UP TO VIN., DF0A UP TO VIN O RING (D:,ID:0) 0-00.OIL SEAL (XX) CIRCLIP -J0 HOUSING, DRIVE SHAFT BRG O RING (D:.,ID:.) 0-00.OIL SEAL (X0X) CIRCLIP -L00 SPACER, FORWARD THRUST 0-00 BEARING (XX) 0-00 SNAP RING FRONT 0-A CIRCLIP REAR 0 -L00 STOPPER, PROP SFT BRG HSG -L00 WASHER, PROP SFT BRG HSG NO. -L00 WASHER, PROP SFT BRG HSG NO. -L00 SEAL, PROP SFT BRG HSG -L00 BUSH, STOPPER O RING (D:.,ID:.) 0-00 BEARING (.X0X.) REAR 0-0 BEARING (.X0X.) FRONT DF0A_E0_0_0A TRANSMISSION DF0A_E0_0

57 FIG.0B FIG.0B (-E-) TRANSMISSION (DF0A FROM VIN., DF0A FROM VIN.0-0-L SHAFT, DRIVE (X) W/TRANSOM(X) - 0-L SHAFT, DRIVE (XX) W/TRANSOM(XX) -L00 COLLAR, DRIVE SHAFT -J00 SPACER, DRIVE SHAFT BEARING 0-00 NUT 0-00 BEARING (XX) 0-L0 SET, GEAR SHIM (T:0.) SHIM (T:0.0) SHIM (T:0.) SHIM (T:0.0) SHIM (T:0.) SHIM (T:0.0) SHIM (T:0.) SHIM (T:0.0) SHIM (T:0.) SHIM (T:0.0) 00-0 NUT 0- WASHER SPACER (.X0X) REAR GEAR SHIM (T:0.0) REAR GEAR SHIM (T:0.) REAR GEAR SHIM (T:0.0) REAR GEAR SHIM (T:0.) REAR GEAR SHIM (T:0.0) REAR GEAR SHIM (T:0.) REAR GEAR SHIM (T:0.0) REAR GEAR SHIM (T:0.) REAR GEAR SHIM (T:0.0) REAR GEAR SHIM (T:0.) REAR GEAR WASHER (0XX) FRONT GEAR BEARING (0X0X) FRONT GEAR DF0A_E0_0_0B TRANSMISSION DF0A_E0_0

58 FIG.0B FIG.0B (-E-) TRANSMISSION (DF0A FROM VIN., DF0A FROM VIN SHIM (T:0.0) REAR GEAR SHIM (T:0.) REAR GEAR SHIM (T:0.0) REAR GEAR SHIM (T:0.) REAR GEAR SHIM (T:0.0) REAR GEAR SHIM (T:0.) REAR GEAR SHIM (T:0.0) REAR GEAR SHIM (T:0.) REAR GEAR SHIM (T:0.0) REAR GEAR SHIM (T:0.) REAR GEAR - 0- SHIM (T:.00) REAR GEAR - 0- SHIM (T:.0) REAR GEAR - 0- SHIM (T:.0) REAR GEAR - -L00 SHIM (T:.0) FRONT GEAR - -L0 SHIM (T:.) FRONT GEAR - -L0 SHIM (T:.0) FRONT GEAR - -L SHIM (T:.) FRONT GEAR - -L0 SHIM (T:.0) FRONT GEAR - -L0 SHIM (T:.) FRONT GEAR - -L0 SHIM (T:.0) FRONT GEAR - -L0 SHIM (T:.) FRONT GEAR - -L0 SHIM (T:.0) FRONT GEAR -0 -L0 SHIM (T:.) FRONT GEAR - -LA0 SHIM (T:.00) FRONT GEAR - -LB0 SHIM (T:.0) FRONT GEAR - -LC0 SHIM (T:.0) FRONT GEAR 0-0 BEARING (XX.) 0-L0 SHAFT, PROPELLER -L00 SHIFTER, CLUTCH DOG PIN (X) 0 -L0 PIN, CONNECTOR SPRING -L00 SPRING, DETENT DF0A_E0_0_0B TRANSMISSION DF0A_E0_0

59 FIG.0B 0 0 FIG.0B (-E-) TRANSMISSION (DF0A FROM VIN., DF0A FROM VIN BALL DETENT NO BALL DETENT NO. 0-L0 HOUSING, PROP SFT BRG 0-0.BEARING (X0X) 0-00.BEARING (XX) O RING (D:,ID:0) 0-00.OIL SEAL (XX) CIRCLIP -L00 SPACER, PROP SFT BRG HSG -J0 HOUSING, DRIVE SHAFT BRG O RING (D:.,ID:.) 0-00.OIL SEAL (X0X) CIRCLIP -L00 SPACER, THRUST FRONT WASHER, WAVE 0-00 SNAP RING FRONT NUT (M,T:.0) REAR GEAR 0 -L00 STOPPER, PROP SFT BRG HSG -L0 WASHER, PROP SFT BRG HSG NO. -L00 WASHER, PROP SFT BRG HSG NO. -L00 SEAL, PROP SFT BRG HSG -L00 BUSH, STOPPER O RING (D:.,ID:.) -L00 SPACER, BEARING INNER -L00 SPACER, BEARING OUTER BEARING (0X0X0) REAR GEAR R 0-00 BEARING (X00X.) REAR GEAR F 0 DF0A_E0_0_0B TRANSMISSION DF0A_E0_0

60 FIG.A 0 FIG.A (-E-) STARTING MOTOR 00-J0 STARTING MOTOR -0J0.BRUSH SET, PLUS -0J00.SPRING -J0.CASE, GEAR -0J00.PLATE, CENTER -0J00.BRACKET, PLANET GEAR -J00.COVER KIT, DUST -0J0.HOLDER, BRUSH -J00.LEVER, SHIFT 0 0-J00.SWITCH, MAGNET 0-0J00.ARMATURE 0-J00.PINION -J00.SHAFT, PINION -0J00.INTERNAL GEAR -0J00.GEAR, PLANETARY 0-J0.WASHER SET -J00.TERMINAL -J00.CAP, TERMINAL 0-0J00.COVER ASSY, REAR 0 -J00 BAND, STARTING MOTOR -0J0 DAMPER, LOWER -J00 LEAD WIRE BOLT LOWER 00-0 BOLT UPPER 0 DF0A_E0_0_A STARTING MOTOR DF0A_E0_0

61 FIG.A 0 FIG.A (-E-) MAGNETO -J0 FLYWHEEL 00- BOLT (X) PIN (X) 0-J00 COIL, BATTERY CHARGING -J00 HOLDER, STATOR CONNECTING 00-0 BOLT 0-L00 COIL, IGNITION TIMING BOLT (X0) -J00 SENSOR, CAM POSITION 0 -F00.O RING 00-0 BOLT 00-0 BOLT (X) 00-0 CLAMP 00-0 BOLT DF0A_E0_0_A MAGNETO DF0A_E0_0

62 FIG.0A 0 FIG.0A (-E-) RECTIFIER/IGNITION COIL 00-J0 RECTIFIER & REGULATOR 0-J00 O RING, RECTIFIER & REGULATOR 0-J0 HOLDER, ELECTRIC PARTS 00-0 WASHER (.XX.) 0-00 WASHER CUSHION 0-00 BOLT (X) 00-0 CUSHION 00-0 BOLT BOLT 0-J00 COIL ASSY, IGNITION 0-00 BOLT CLIP (ID:) DF0A_E0_0_0A RECTIFIER/IGNITION COIL DF0A_E0_0

63 FIG.A 0 FIG.A (-E-) SENSOR 0-G00 SENSOR, INLET AIR TEMP -J00 GROMMET, AIR TEMP SENSOR 0-J00 BOLT, PTT MOTOR LEAD CLAMP -J0 SENSOR ASSY, EXHAUST TEMP -J0 SENSOR ASSY, CYLINDER TEMP 0-J0 SENSOR ASSY, TRIM 0-J00 SWITCH ASSY, OIL PRESSURE 0-00 SCREW (X0) 00-0 CLAMP 0 0-J0 CLAMP, PTT MOTOR LEAD 00-0 CLAMP (L:) -L00 LEVER, TRIM SENSOR -L0 BRACKET, TRIM SENSOR NUT 0-00 SCREW (X) WASHER (.XX0.) BOLT (X0) -J0 SENSOR, OXYGEN CLAMP 0 -J0 HOLDER, TEMP SENSOR -J00 HOLDER, OIL SENSOR -J00 SENSOR ASSY, OIL TEMP 0 DF0A_E0_0_A SENSOR DF0A_E0_0

64 FIG.A FIG.A (-E-0) HARNESS 0 0-J00 CABLE, STARTER MOTOR 0-00 NUT 0-J0 HARNESS ASSY, WIRING 0-00.FUSE (0A) -J0.CONNECTOR, SELECT TERMINAL -J00.O RING, UPPER COVER -J00.PULLER, FUSE -J00.COVER, FUSE CASE UPPER CUSHION 0 0-F0.RELAY FOR ENG CONTROL UNIT 0-F0.RELAY FOR STARTER MOTOR 0-0.FUSE (A) 0-0.FUSE (A) 0-00.FUSE (0A) 0-00.FUSE (0A) NUT 0-00 WASHER -J00 BRACKET, HARNESS -J0 BRACKET, HARNESS 0 -J00 BRACKET, HARNESS 00-0 BOLT 00-0 CLAMP 00-0 CLAMP (L:) CLIP (ID:0) CLAMP CLIP (ID:.) CLIP (ID:0) 00-0 BOLT 0 DF0A_E0_0_A HARNESS DF0A_E0_0

65 FIG.A 0 0 FIG.A (-E-) PTT SWITCH/ENGINE CONTROL UNIT (DF0A E0) 0-J0 SENSOR ASSY, SHIFT POSITION -0F00.O RING -J00 LEVER, SHIFT SENSOR WASHER (.XX0.) 0-0 BOLT 0-00A WASHER -J00 SWITCH ASSY, NEUTRAL SCREW (X) CLAMP (L:00) 0 -J COVER, SWITCH ASSY 0-J00 SWITCH ASSY, PTT -J00.TAPE, PTT SWITCH -J00 BUSH, PTT SWITCH 00- CLAMP 00-0 BOLT -J SWITCH ASSY, TILT LIMIT 00-0 CLAMP -J00 SCREW, TILT LIMIT CLAMP 0-J RELAY, PTT 0 -J00 HOLDER, PTT RELAY 00-0 BOLT 00-0 CLAMP (L:0) 0-JG UNIT, ENGINE CONTROL -J00 CUSHION, ENGINE CONTROL UNIT 0-J0 ACTUATOR, SHIFT -J00 DAMPER, SHIFT ACTUATOR -J00 BRACKET, SHIFT ACTUATOR 00-0 BOLT 00-0 BOLT 0-F0 RELAY, ACTUATOR 0-F0 RELAY, OXYGEN SENSOR HEATER -0J00 HOLDER, RELAY DF0A_E0_0_A PTT SWITCH/ENGINE CONTROL UNIT DF0A_E0_0

66 FIG.B 0 0 FIG.B (-E-) PTT SWITCH/ENGINE CONTROL UNIT (DF0A E0) 0-J0 SENSOR ASSY, SHIFT POSITION -0F00.O RING -J00 LEVER, SHIFT SENSOR WASHER (.XX0.) 0-0 BOLT 0-00A WASHER -J00 SWITCH ASSY, NEUTRAL SCREW (X) CLAMP (L:00) 0 -J COVER, SWITCH ASSY 0-J00 SWITCH ASSY, PTT -J00.TAPE, PTT SWITCH -J00 BUSH, PTT SWITCH 00- CLAMP 00-0 BOLT -J SWITCH ASSY, TILT LIMIT 00-0 CLAMP -J00 SCREW, TILT LIMIT CLAMP 0-J RELAY, PTT 0 -J00 HOLDER, PTT RELAY 00-0 BOLT 00-0 CLAMP (L:0) 0-JG UNIT, ENGINE CONTROL -J00 CUSHION, ENGINE CONTROL UNIT 0-J0 ACTUATOR, SHIFT -J00 DAMPER, SHIFT ACTUATOR -J00 BRACKET, SHIFT ACTUATOR 00-0 BOLT 00-0 BOLT 0-F0 RELAY, ACTUATOR 0-F0 RELAY, OXYGEN SENSOR HEATER -0J00 HOLDER, RELAY DF0A_E0_0_B PTT SWITCH/ENGINE CONTROL UNIT DF0A_E0_0

67 FIG.C 0 0 FIG.C (-E-) PTT SWITCH/ENGINE CONTROL UNIT (DF0A E0) 0-J0 SENSOR ASSY, SHIFT POSITION -0F00.O RING -J00 LEVER, SHIFT SENSOR WASHER (.XX0.) 0-0 BOLT 0-00A WASHER -J00 SWITCH ASSY, NEUTRAL SCREW (X) CLAMP (L:00) 0 -J COVER, SWITCH ASSY 0-J00 SWITCH ASSY, PTT -J00.TAPE, PTT SWITCH -J00 BUSH, PTT SWITCH 00- CLAMP 00-0 BOLT -J SWITCH ASSY, TILT LIMIT 00-0 CLAMP -J00 SCREW, TILT LIMIT CLAMP 0-J RELAY, PTT 0 -J00 HOLDER, PTT RELAY 00-0 BOLT 00-0 CLAMP (L:0) 0-JH UNIT, ENGINE CONTROL -J00 CUSHION, ENGINE CONTROL UNIT 0-J0 ACTUATOR, SHIFT -J00 DAMPER, SHIFT ACTUATOR -J00 BRACKET, SHIFT ACTUATOR 00-0 BOLT 00-0 BOLT 0-F0 RELAY, ACTUATOR 0-F0 RELAY, OXYGEN SENSOR HEATER -0J00 HOLDER, RELAY DF0A_E0_0_C PTT SWITCH/ENGINE CONTROL UNIT DF0A_E0_0

68 FIG.D 0 0 FIG.D (-E-) PTT SWITCH/ENGINE CONTROL UNIT (DF0A E0) 0-J0 SENSOR ASSY, SHIFT POSITION -0F00.O RING -J00 LEVER, SHIFT SENSOR WASHER (.XX0.) 0-0 BOLT 0-00A WASHER -J00 SWITCH ASSY, NEUTRAL SCREW (X) CLAMP (L:00) 0 -J COVER, SWITCH ASSY 0-J00 SWITCH ASSY, PTT -J00.TAPE, PTT SWITCH -J00 BUSH, PTT SWITCH 00- CLAMP 00-0 BOLT -J SWITCH ASSY, TILT LIMIT 00-0 CLAMP -J00 SCREW, TILT LIMIT CLAMP 0-J RELAY, PTT 0 -J00 HOLDER, PTT RELAY 00-0 BOLT 00-0 CLAMP (L:0) 0-JH UNIT, ENGINE CONTROL -J00 CUSHION, ENGINE CONTROL UNIT 0-J0 ACTUATOR, SHIFT -J00 DAMPER, SHIFT ACTUATOR -J00 BRACKET, SHIFT ACTUATOR 00-0 BOLT 00-0 BOLT 0-F0 RELAY, ACTUATOR 0-F0 RELAY, OXYGEN SENSOR HEATER -0J00 HOLDER, RELAY DF0A_E0_0_D PTT SWITCH/ENGINE CONTROL UNIT DF0A_E0_0

69 FIG.A FIG.A (-E-) KEY LESS START (DF0A E0) - -J00 CUSHION, KLS CONTROLLER UP TO VIN.0 - -J00 CUSHION, KLS CONTROLLER FROM VIN.00 0-F00 HOLDER, KLS CONTROLLER -L00 HARNESS ASSY, KLS CONT -0 TERMINAL, RESIN -L00 HARNESSASSY, KLS CAN L:00+0 -L00 DECAL, KLS - -L00 CONTROLLER ASSY, KLS MHZ UP TO VIN.0 - -L0 CONTROLLER ASSY, KLS MHZ FROM VIN.00 -L00 REMOCON ASSY, KLS MHZ -L00 HOLDER, KLS PARTS LARGE TYPE UP TO VIN.0 0 -L0 HOLDER, KLS PARTS SMALL TYPE FROM VIN J0 BUZZER ASSY 0-L00 RELAY ASSY, KLS 00-0 CLAMP (L:) 0 DF0A_E0_0_A KEY LESS START DF0A_E0_0

70 FIG.B FIG.B (-F-) KEY LESS START (DF0A E0) - -J00 CUSHION, KLS CONTROLLER UP TO VIN.0 - -J00 CUSHION, KLS CONTROLLER FROM VIN.0 0-F00 HOLDER, KLS CONTROLLER -L00 HARNESS ASSY, KLS CONT -0 TERMINAL, RESIN -L00 HARNESSASSY, KLS CAN L:00+0 -L00 DECAL, KLS - -L00 CONTROLLER ASSY, KLS MHZ UP TO VIN.0 - -L0 CONTROLLER ASSY, KLS MHZ FROM VIN.0 -L00 REMOCON ASSY, KLS MHZ -L00 HOLDER, KLS PARTS LARGE TYPE UP TO VIN.0 0 -L0 HOLDER, KLS PARTS SMALL TYPE FROM VIN.0 00-J0 BUZZER ASSY 0-L00 RELAY ASSY, KLS 00-0 CLAMP (L:) 0 DF0A_E0_0_B KEY LESS START DF0A_E0_0

71 FIG.A 0 FIG.A (-F-) CLAMP BRACKET 0 - -J-0EP BRACKET, CLAMP STBD (BLACK) - -J-YS BRACKET, CLAMP STBD (WHITE) - -J0-0EP BRACKET, CLAMP PORT (BLACK) - -J0-YS BRACKET, CLAMP PORT (WHITE) -J0 PLATE, CLAMP BRKT LOWER STBD -J0 PLATE, CLAMP BRKT LOWER PORT 0-00 SCREW (X0) -J SHAFT, CLAMP BRKT -J WASHER, CLAMP BRACKET SHAFT 0-00 NUT BOLT (.X0) BOLT (.X) OPT BOLT (.X) OPT NUT 00- WASHER 00- WASHER -J0 PLATE, TRANSOM 0-00 ZINC SET, PROTECTION 0-0.BOLT (X) -D0 PIN, TILT LOCK 0-00 NUT 0-J0 CAM, TILT LIMIT SWITCH -J00 HOLDER, TILT LIMIT SWITCH BOLT (X) -0 ANODE (MAGNESIUM) OPT -J00 COVER, TILT LIMIT SWITCH -D00 LEAD (CLAMP TO SWIVEL) 0-00 SCREW (X0) DF0A_E0_0_A CLAMP BRACKET DF0A_E0_0

72 FIG.A FIG.A (-F-) SWIVEL BRACKET 0-0 NIPPLE, GREASE SWIVEL BRKT -D00 LEAD (SWIVEL TO MOUNT BRKT) - -J-0EP BRACKET, SWIVEL (BLACK) - -J-YS BRACKET, SWIVEL (WHITE) -J00 WASHER, SWIVEL TO CLAMP BRKT -J00 BUSH, CLAMP SHAFT SWIVEL -E0 BUSH, STEERING - 0-J0-0EP BRACKET, STEERING (BLACK) - 0-J0-YS BRACKET, STEERING (WHITE) 0-00 SCREW (X0) WASHER (.XX) SHIM (.XX0.) AR 0-00 OIL SEAL (XX) CIRCLIP 0-J LEVER, TILT LOCK -J LEVER, TILT LOCK PORT -E0 BUSH, TILT STOPPER ROD -J00 LINK, TILT LOCK LEVER -E0 BRACKET, TILT LOCK SPRING 0-00 SCREW (X0) NUT WASHER (.XX.0) PIN 00-0 SPRING 0-00 SPRING 0 DF0A_E0_0_A SWIVEL BRACKET DF0A_E0_0

73 FIG.A 0 0 FIG.A (-F-) TRIM CYLINDER 000-J0 TRIM ASSY, POWER WITH TILT -J0.BOLT 00-J0.MOTOR ASSY, PTT 00-J0.MANIFOLD ASSY -E0..FILTER 0-J00..O RING SET 0-J0..PISTON / RAM -J0..ROD GUIDE -J00...O RING 0 -J00..CHECK VALVE 00-J0.CYLINDER ASSY 0-J00..O RING SET 0-J00..PISTON, FREE -J00..O RING SET -J0.PLUG -E00.O RING -J0.BOLT, RESERVOIR -J0.MANUAL VALVE -E00.JOINT, DRIVE 0 -J.SHAFT -J00.O RING SET -J00.WASHER, TILT CYL TO MANIF 0-J00.VALVE SET, UP BLOW -J00.COVER -J.BOLT -J00.RESERVOIR TANK -J0 PAD, TRIM CYL RAM -J00 SHAFT, TILT CYL UPPER -J0 NUT, TRIM CYL RAM LOCK WASHER 0-00 BUSH CIRCLIP 0-0 BOLT (0X0) DF0A_E0_0_A TRIM CYLINDER DF0A_E0_0

74 FIG.A FIG.A (-F-) TRIM CYLINDER -D00 LEAD, PTT TO ANODE -D0 LEAD, PTT TO ANODE -D0 LEAD, PTT TO ANODE 0-00 SCREW (X0) 0-00 SCREW (X0) 0-00 SCREW (X0) 0 0 DF0A_E0_0_A TRIM CYLINDER DF0A_E0_0

75 FIG.0A FIG.0A (-F-) PTT MOTOR 00-J0 MOTOR ASSY, PTT -00.SCREW, YOKE -0.O RING -0J00.BRUSH SET, PLUS -00..BRUSH -00.SPRING -0J0.BREAKER -0.HOLDER, BRUSH -J00.ARMATURE 0 -E00.OIL SEAL 0 DF0A_E0_0_0A PTT MOTOR DF0A_E0_0

76 FIG.0A FIG.0A (-F-) ENGINE HOLDER - -J0-0EP HOLDER, ENGINE (BLACK) - -J0-YS HOLDER, ENGINE (WHITE) -J00 SEAL, ENGINE HOLDER OIL -J00 PLUG, WATER -J00 GASKET, WATER PLUG -J00 SEAL, WATER RETURN -J00 GASKET, ENGINE HOLDER -J0 UNION, WATER INDICATOR PIN (X) 00-0 BOLT 0 0-J0 COVER, MOUNT OIL SEAL -0.NIPPLE,GREASE -J0.OIL SEAL -J00.SCRAPER -J00 GASKET, MOUNT OIL SEAL COVER BOLT (X0) PIN (X) 00-0A BOLT - 0-J00-0EP COVER, ENGINE HOLDER (BLACK) - 0-J00-YS COVER, ENGINE HOLDER (WHITE) -J00 GASKET, ENGINE HOLDER COVER BOLT (X) -J00 COVER, ENGINE HOLDER UPPER -J00 SEAL, ENGINE HOLDER UPPER COV 00-0 BOLT BOLT -J0 PLATE, UPPER MOUNT -J0 MOUNT, UPPER BOLT (X0) 0-0 NUT 00-0 WASHER (XX) -J0 COVER, UPPER MOUNT 0-0 BOLT (0X) 0-0 BOLT (0X0) DF0A_E0_0_0A ENGINE HOLDER DF0A_E0_0

77 FIG.0A 0 FIG.0A (-F-) ENGINE HOLDER -J00 STOPPER, UPPER THRUST 0-J00 MOUNT, UPPER THRUST REVERSE 0-0 BOLT (0X0) 0-0 BOLT (0X0) 0-0 BOLT (0X) 0-0 BOLT (0X) 0-0 BOLT (X) WASHER (.XX) 0 0 DF0A_E0_0_0A ENGINE HOLDER DF0A_E0_0

78 FIG.0A FIG.0A (-F-0) DRIVE SHAFT HOUSING (X) J00-0EP HOUSING, DRIVE SHAFT (BLACK) - -J00-YS HOUSING, DRIVE SHAFT (WHITE) 0-0 BOLT (0X) PIN (X) -D0 BUSH, DRIVE SHAFT 0-00 RING 0-00 SCREW (X0) -D00 LEAD, MT BRKT TO HSG 0-00 SCREW (X0) 0-J00 MOUNT, LOWER THRUST 0 0-J00 MOUNT, LOWER BOLT (X0) WASHER (XX) 0-0 NUT WASHER (XX) - -J00-0EP BRACKET, LOWER MOUNT (BLACK) - -J00-YS BRACKET, LOWER MOUNT (WHITE) - -J00-0EP COVER, LOWER MOUNT (BLACK) - -J00-YS COVER, LOWER MOUNT (WHITE) 0-0 BOLT (0X0) -J00 DAMPER, REVERSE STOPPER LOWER 00-0 WASHER (X0X) 0 0-J0 CLAMP, SPEEDOMETER HOSE UP TO VIN.0 FOR DF0A UP TO VIN.0 FOR DF0A 0-J00 BOLT, CLAMP (X) UP TO VIN.0 FOR DF0A UP TO VIN.0 FOR DF0A -J0 ANODE, PROTECTION 0-0 BOLT (X) DF0A_E0_0_0A DRIVE SHAFT HOUSING DF0A_E0_0

79 FIG.0B FIG.0B (-F-) DRIVE SHAFT HOUSING (XX) J00-0EP HOUSING, DRIVE SHAFT (BLACK) - -J00-YS HOUSING, DRIVE SHAFT (WHITE) 0-0 BOLT (0X) PIN (X) -D0 BUSH, DRIVE SHAFT 0-00 RING 0-00 SCREW (X0) - -J00-0EP CASE, EXTENSION (BLACK) - -J00-YS CASE, EXTENSION (WHITE) 00-0 STUD BOLT 00-0 STUD BOLT PIN (X) -D00 LEAD, MT BRKT TO HSG 0-00 SCREW (X0) 0-J00 MOUNT, LOWER THRUST 0-J00 MOUNT, LOWER BOLT (X0) WASHER (XX) 0-0 NUT WASHER (XX) - -J00-0EP BRACKET, LOWER MOUNT (BLACK) - -J00-YS BRACKET, LOWER MOUNT (WHITE) 0- -J00-0EP COVER, LOWER MOUNT (BLACK) 0- -J00-YS COVER, LOWER MOUNT (WHITE) 0-0 BOLT (0X0) -J00 DAMPER, REVERSE STOPPER LOWER 00-0 WASHER (X0X) 0-J0 CLAMP, SPEEDOMETER HOSE UP TO VIN.0 FOR DF0A UP TO VIN.0 FOR DF0A 0-J00 BOLT, CLAMP (X) UP TO VIN.0 FOR DF0A UP TO VIN.0 FOR DF0A -J0 ANODE, PROTECTION 0-0 BOLT (X) DF0A_E0_0_0B DRIVE SHAFT HOUSING DF0A_E0_0

80 FIG.0A 0 0 FIG.0A (-F-) GEAR CASE (DF0A UP TO VIN., DF0A UP TO VIN.0) - 0-L00-0EP CASE, GEAR (BLACK) - 0-L00-YS CASE, GEAR (WHITE) -L00.WASHER, FORWARD GEAR THRUST BUSH (XX) 0-0.BEARING (XX) BEARING (0X00X) BOLT (X0) W/TRANSOM(X) 0-00 BOLT (0X) W/TRANSOM(X) 00-0 WASHER (0.XX) W/TRANSOM(XX) 00-0 WASHER (.XX.) 0 -J0 NUT, EXTENSION BOLT NO. W/TRANSOM(XX) 0-0 NUT W/TRANSOM(XX) PIN (X) - -L00-0EP TAB, TRIM (BLACK) - -L00-YS TAB, TRIM (WHITE) 0-0 BOLT (X) -J0 PLUG, DRAIN 0-00 GASKET (.X.X) -J0 ANODE, PROTECTION 0-0 BOLT (X) -J00 RUBBER, EXHAUST SEAL 0 -J00 PLATE, EXHAUST SEAL -D00 UNION, SPEEDOMETER HOSE B HOSE (XX000) L:000->0 UP TO VIN.0 FOR DF0A UP TO VIN.0 FOR DF0A HOSE (XX00) L:00->0 W/TRANSOM(X) L:00->0 W/TRANSOM(XX) FROM VIN.0 FOR DF0A FROM VIN.0 FOR DF0A UNION CLAMP (L:00) PIN (X) DF0A_E0_0_0A GEAR CASE DF0A_E0_0

81 FIG.0A 0 0 FIG.0A (-F-) GEAR CASE (DF0A UP TO VIN., DF0A UP TO VIN.0) - 00-L00 PROPELLER (XX) W/REGULAR ROTATION - 00-L0 PROPELLER (XX.) W/REGULAR ROTATION - 00-L0 PROPELLER (XX0) W/REGULAR ROTATION - 00-L PROPELLER (XX.) W/REGULAR ROTATION - 00-L0 PROPELLER (XX) W/REGULAR ROTATION - 00-L0 PROPELLER (XX.) W/REGULAR ROTATION - 00-L0 PROPELLER (XX) W/REGULAR ROTATION - 00-L0 PROPELLER (XX) OPT W/REGULAR ROTATION - 00-L0 PROPELLER (XX.) OPT W/REGULAR ROTATION -0 0-J00 PROPELLER (X.X) OPT W/REGULAR ROTATION - 0-J0 PROPELLER (X.X0) OPT W/REGULAR ROTATION - 0-J0 PROPELLER (X.X) OPT W/REGULAR ROTATION - 0-J PROPELLER (X.X) OPT W/REGULAR ROTATION - 0-J0 PROPELLER (X.X) OPT W/REGULAR ROTATION - 00-LA0 PROPELLER (XX.) W/COUNTER ROTATION - 00-LB0 PROPELLER (XX0) W/COUNTER ROTATION - 00-LC0 PROPELLER (XX.) W/COUNTER ROTATION - 00-LD0 PROPELLER (XX) W/COUNTER ROTATION - 00-LE0 PROPELLER (XX) W/COUNTER ROTATION DF0A_E0_0_0A GEAR CASE DF0A_E0_0

82 FIG.0A 0 0 FIG.0A (-F-) GEAR CASE (DF0A UP TO VIN., DF0A UP TO VIN.0) LF0 PROPELLER (XX.) OPT W/COUNTER ROTATION - 00-LG0 PROPELLER (XX) OPT W/COUNTER ROTATION - 0-JA0 PROPELLER (X.X0) OPT W/COUNTER ROTATION - 0-JB0 PROPELLER (X.X) OPT W/COUNTER ROTATION - 0-JC0 PROPELLER (X.X) OPT W/COUNTER ROTATION - 0-JD0 PROPELLER (X.X) OPT W/COUNTER ROTATION 0-J0.BUSH SET, PROPELLER - 00-J00 PROPELLER (X.X) OPT W/REGULAR ROTATION - 00-J0 PROPELLER (X.X) OPT W/REGULAR ROTATION - 00-J0 PROPELLER (X.X) OPT W/REGULAR ROTATION - 00-J PROPELLER (X.X) OPT W/REGULAR ROTATION - 00-J0 PROPELLER (X.X) OPT W/REGULAR ROTATION - 00-J0 PROPELLER (X.X) OPT W/REGULAR ROTATION - 00-JA0 PROPELLER (X.X) OPT W/COUNTER ROTATION - 00-JB0 PROPELLER (X.X) OPT W/COUNTER ROTATION - 00-JC0 PROPELLER (X.X) OPT W/COUNTER ROTATION JD0 PROPELLER (X.X) OPT W/COUNTER ROTATION - 00-JE0 PROPELLER (X.X) OPT W/COUNTER ROTATION - 00-JF0 PROPELLER (X.X) OPT W/COUNTER ROTATION 0-J0.BUSH SET, PROPELLER DF0A_E0_0_0A GEAR CASE DF0A_E0_0

83 FIG.0A 0 0 FIG.0A (-F-) GEAR CASE (DF0A UP TO VIN., DF0A UP TO VIN.0) -L0 STOPPER, PROPELLER BUSH -D SPACER, PROPELLER NUT 0-00 NUT 00-0 WASHER (.XX) COTTER PIN (D:.,L:) -L00 PLUG, DRAIN 0-J0 CLAMP UP TO VIN.0 FOR DF0A UP TO VIN.0 FOR DF0A 00-0 BOLT -E00 KIT, PROPELLER NUT OPT 00-L00 KIT, GEAR CASE SEALING OPT NOT ILLUSTRATED DF0A_E0_0_0A GEAR CASE DF0A_E0_0

84 FIG.0B 0 0 FIG.0B (-G-) GEAR CASE (DF0A FROM VIN., DF0A FROM VIN.0) - 0-L0-0EP CASE, GEAR (BLACK) - 0-L0-YS CASE, GEAR (WHITE) BUSH (XX) 0-0.BEARING (XX) BEARING (0X00X) BOLT (X0) W/TRANSOM(X) 0-00 BOLT (0X) W/TRANSOM(X) 00-0 WASHER (0.XX) W/TRANSOM(XX) 00-0 WASHER (.XX.) -J0 NUT, EXTENSION BOLT NO. W/TRANSOM(XX) NUT W/TRANSOM(XX) PIN (X) - -L00-0EP TAB, TRIM (BLACK) - -L00-YS TAB, TRIM (WHITE) 0-0 BOLT (X) -J0 PLUG, DRAIN 0-00 GASKET (.X.X) -J0 ANODE, PROTECTION 0-0 BOLT (X) -J00 RUBBER, EXHAUST SEAL -J00 PLATE, EXHAUST SEAL 0 -D00 UNION, SPEEDOMETER HOSE HOSE (XX00) L:00->0 W/TRANSOM(X) L:00->0 W/TRANSOM(XX) UNION CLAMP (L:00) PIN (X) DF0A_E0_0_0B GEAR CASE DF0A_E0_0

85 FIG.0B 0 0 FIG.0B (-G-) GEAR CASE (DF0A FROM VIN., DF0A FROM VIN.0) - 00-L00 PROPELLER (XX) W/REGULAR ROTATION - 00-L0 PROPELLER (XX.) W/REGULAR ROTATION - 00-L0 PROPELLER (XX0) W/REGULAR ROTATION - 00-L PROPELLER (XX.) W/REGULAR ROTATION - 00-L0 PROPELLER (XX) W/REGULAR ROTATION - 00-L0 PROPELLER (XX.) W/REGULAR ROTATION - 00-L0 PROPELLER (XX) W/REGULAR ROTATION - 00-L0 PROPELLER (XX) OPT W/REGULAR ROTATION - 00-L0 PROPELLER (XX.) OPT W/REGULAR ROTATION -0 0-J00 PROPELLER (X.X) OPT W/REGULAR ROTATION - 0-J0 PROPELLER (X.X0) OPT W/REGULAR ROTATION - 0-J0 PROPELLER (X.X) OPT W/REGULAR ROTATION - 0-J PROPELLER (X.X) OPT W/REGULAR ROTATION - 0-J0 PROPELLER (X.X) OPT W/REGULAR ROTATION - 00-LA0 PROPELLER (XX.) W/COUNTER ROTATION - 00-LB0 PROPELLER (XX0) W/COUNTER ROTATION - 00-LC0 PROPELLER (XX.) W/COUNTER ROTATION - 00-LD0 PROPELLER (XX) W/COUNTER ROTATION - 00-LE0 PROPELLER (XX) W/COUNTER ROTATION LF0 PROPELLER (XX.) OPT W/COUNTER ROTATION - 00-LG0 PROPELLER (XX) OPT W/COUNTER ROTATION - 0-JA0 PROPELLER (X.X0) OPT W/COUNTER ROTATION - 0-JB0 PROPELLER (X.X) OPT W/COUNTER ROTATION - 0-JC0 PROPELLER (X.X) OPT W/COUNTER ROTATION - 0-JD0 PROPELLER (X.X) OPT W/COUNTER ROTATION 0-J0.BUSH SET, PROPELLER DF0A_E0_0_0B GEAR CASE DF0A_E0_0

86 FIG.0B 0 0 FIG.0B (-G-) GEAR CASE (DF0A FROM VIN., DF0A FROM VIN.0) - 00-J00 PROPELLER (X.X) OPT W/REGULAR ROTATION - 00-J0 PROPELLER (X.X) OPT W/REGULAR ROTATION - 00-J0 PROPELLER (X.X) OPT W/REGULAR ROTATION - 00-J PROPELLER (X.X) OPT W/REGULAR ROTATION - 00-J0 PROPELLER (X.X) OPT W/REGULAR ROTATION - 00-J0 PROPELLER (X.X) OPT W/REGULAR ROTATION - 00-JA0 PROPELLER (X.X) OPT W/COUNTER ROTATION - 00-JB0 PROPELLER (X.X) OPT W/COUNTER ROTATION - 00-JC0 PROPELLER (X.X) OPT W/COUNTER ROTATION JD0 PROPELLER (X.X) OPT W/COUNTER ROTATION - 00-JE0 PROPELLER (X.X) OPT W/COUNTER ROTATION - 00-JF0 PROPELLER (X.X) OPT W/COUNTER ROTATION 0-J0.BUSH SET, PROPELLER -L0 STOPPER, PROPELLER BUSH -D SPACER, PROPELLER NUT 0-00 NUT 00-0 WASHER (.XX) COTTER PIN (D:.,L:) -L00 PLUG, DRAIN 00-0 BOLT DF0A_E0_0_0B GEAR CASE DF0A_E0_0

87 FIG.0B 0 0 FIG.0B (-G-) GEAR CASE (DF0A FROM VIN., DF0A FROM VIN.0) -E00 KIT, PROPELLER NUT OPT 00-L00 KIT, GEAR CASE SEALING OPT NOT ILLUSTRATED DF0A_E0_0_0B GEAR CASE DF0A_E0_0

88 FIG.0A FIG.0A (-G-) SIDE COVER - -J0-0EP COVER, OIL PAN STBD (BLACK) - -J0-YS COVER, OIL PAN STBD (WHITE) - -J0-0EP COVER, OIL PAN PORT (BLACK) - -J0-YS COVER, OIL PAN PORT (WHITE) -J00 CUSHION, OIL PAN COV UPPER 0-0 SCREW (X) 0-0 SCREW (X) - -J0-0EP COVER, SIDE STBD (BLACK) - -J0-YS COVER, SIDE STBD (WHITE) - -J0-0EP COVER, SIDE PORT (BLACK) - -J0-YS COVER, SIDE PORT (WHITE) -J0 SEAL, SIDE COVER 00-0-PK CLIP (BLACK) 0 -J00 PLUG, SIDE COVER 0-0 SCREW (X) 0 -J0 HOLDER, SIDE COVER 0-00 CUSHION 00-0 BOLT -J00 SEAL, FRONT PANEL STBD -J00 SEAL, SIDE COVER -J00 PROTECTOR, SIDE COVER - -J0-0EP PANEL, FRONT (BLACK) - -J0-YS PANEL, FRONT (WHITE) 0-0 BOLT (X) WASHER 00-0 CUSHION 0-00 CUSHION -J00 PLUG, WATER -J00 GASKET, WATER PLUG -J00 RUBBER, SIDE COVER -J00 SHAFT, COVER HOOK (FRONT) -J0 SHAFT, COVER HOOK (PORT) -J SHAFT, COVER HOOK (STBD) 0-00 BUSH DF0A_E0_0_0A SIDE COVER DF0A_E0_0