20" x 24" (0.51 m x 0.61 m). Moun~il1g - crawler: 13' 6" (4.11 m) gauge, 20' 0" (6.10 m) overall length. "AB"

Transcription

1 PCSA Class Refer to Notes page 4. - angle: 4 (1.22 wide, 4 (1.22 deep with open throat top section; with or without boo live ast. Jib -angle: " x 2 (0.51 x Moun~il1g - crawler: 13' 6" (4.11 gauge, ' 0" ( overall length. eoun~en!l!eigms - Refer to charts below. Counterweights "A" "AB" kilogras Poul1ds kilogras, , Maxiu angle boo or boo + jib achine can lift off groundcd unassisted, without load. Counterweight "N' Counterweight "AB" Standard achine equipped Boo Boo + jib Boo Boo + jib with appropriate counterweights Feei eters Feei eters Feei eters Feei eters Over ends Over sides ' <DWith boo live ast and 11,(31.75 diaeter pendants, and hook blocks on ground. Maxiu angle boo and boo + jib achine can lift off ground<d unassisted and travel with, without load. Based on boo horizontal and iniu travel speed on fir, level supporting surface. Counterweight "P(' Counterweight "AB" Standard achine equipped Boo Boo + jib Boo Boo + jib with appropriate counterweights Fee~ eters Feet eters Feet eters Feet eters Over ends Over sides <DWith boo live ast and 11,(31.75 diaeter pendants, and hook blocks on ground. Hook blocks carried at boo and jib points. Based on 100-ton (90.76 etric ton 5-sheave, 2,4Ibs. (1 100 kg hook block and 15-ton (13.6 etric ton single sheave, 4lbs. (7 kg ball with swivel hook. 7n (Supersedes # Printed in U.S.A.

2 LS-338 lifting crane capacities Refer to Notes page 4. Boo - angle: 4 (1.22 wide, 4 Mounting - crawler: 13' 6" (4.11 (1.22 deep with open throat top section; with or without boo live ast. gauge, Length Anale Degree Boo PQlnt height <D Feet eters 1,000' 157,100' 149,800 1,0 115,0 103,0 93,0 85,0 78,0 55,0 42,0 34,100 28,0,0 776' ' ,000' 157,100' 154,0' 152,0' 149,900' 145,800' 132,100 1,0 111,000,800 49,0,0 776' ' 2' 69083' 67995' 661' ,100' 136,0' 132,000' 127,0 113, ,0 91,0 83,0 76,900 54,0 41,900 33,800 28,100, ' 626' 59875' ,0' 136,0' 134,0' 132,0' 1,0' 1, ,100 79,000,800 49,0,0 23, ,0 121,0' 1,0' 115,800' 111,0,800 49,100,0 23,800, ' 662' 9 011' 59059' ,0' 1,900' 112, ,000 91,0 83,0 76,0 54,0 41,0 33,0 27,800,0 15, ' 54387* ' 55112' 532' 527' ' ,800' 108,100' 106,800' 105,0',0 49,000,800,0 23,0,100 15, " 49034' 48444' 477' ,0' 100,900 91,0 83,0 76,0 54,000 41,0 33,0 27,0,0 15,0 12,0 98,800' 91,000 83,100 76,0 53,0 41,100 32,900 27,0,900 15,0 12,100 9, ' ,0' 97,0' 78,800,0 48,800,0,100 23,0, ' "511';;;' 82, ,0,800 32,0 26,900,0 15, , ' 53' 51' 48' 45' 41' 26' 1 7" , BO.O ' 65' 63' 62' ' 57' 45' 28' ,0' 1,0 115,0 103,0 93,0 85,0 78,0 55,0 42,0 34,100 28,0,0 15, ' ' ( ' 1 74' 74' 74' 5" 74' 72' 71 ' 69' 0" 66' 59' 42' ' ,0 103,0 93,0 85,0 78,0 55,0 42,0 34,000 28,100,0 15,800 12,0 80' ( BO BO , ' 1 84' 84' 84' 5" 83' 81 ' 79' 77' 71' 63' 51' 1 32' ,0 93,0 85,0 78,0 55,0 42,0 33,800 28,000,0 15,0 12,0 10, ' 94' 93' 92' 90' 88' 83' 76' 67' 7" 6" 6" , ,100 42,100 33,0 27,800,0 15,0 12,0 9,800 34' ' ( 80 90' (27.43 o Measured 90 vertically BO T' T' Without boo live ast and with iv." (38 diaeter boo pendants. Counterweight "AB" kilogras " to charts page 1. Counterweight "A" kilogras ' ( - Refer With boo live ast and 1W' (32 diaeter boo pendants. Boo Radius Feet eters Counterweights ' 0" ( overatllength. 'O,\\\ fro center of boo head sheave to ground ,1\i Counterwel ~ht "I:' only kilogras 11,SC<: f :-1 J,,,",,-'_ -::-~ -~.~ J 1

3 LS-338 lifting crane capacities Refer to Notes page 4. WIthout boo live ast Boo With boo lve ast and 1'1 and with 1'h" (38 (32 Boo ~nt diaeter boo pendants. diaeter boo pendants. Radius Anole height <D CounterweIGht "A" Counterwelaht "AB" Counterwel ht "I{' onlv Length Feet eters Degree Feet eters kilogras kilogras kilogras ' , ,0' 39781' 75, ' , , ' , '.84 33, , , ' ' 5" ( ' 28.98, ,900 3, ' , , ' 7" ' r , , ' , ' ' ' 34247' ' , ' r ,0 1 48, ' , ' ' 32.36, , ( ' , , ' , ' , , ' , , ' r ' , ' , ' 315' ' ' , ' 7" ' 1.64, , ' ' , , ( ' ' , ' , ' , '.28 4, , ' , , '.94 54, ,900' 28985' ' 5" ,0' 583' ' ' , , ' 38.94, , ' ' 6" ( ' Not applicable ' , ' , , ' ' ' ' , ' 7" ,900' 242' ' 7" , ,0' 21092' ' ,0 6 39, ' ' 5" ' ' ( ' , , ' , ' , , ' ,0 05 8, ' '.78 2, , ' 5" , , ' 46.86, ,800' 282' ' , ,000' 5' ' ,0 1 38,0' 4' ' 45.36, , ' , , ' , ' ' r , ( ' 39. 6, , ' , , ' , ' , , ' , , ' 5" , , ' <D Measured vertically fro center of boo head sheave to ground. -3-

4 LS-338 lifting crane capacities Notes - lifting crane capacities 1. The capacities included in this chart are the axiu allowable, and are based on achine standing level on fir supporting surface under ideal job conditions. 2. Capacities are based on 75% of iniu tipping loads unless arked with an asterisk (*. a. Asterisk indicates capacities are based on factors other than those which would cause a tipping condition. 3. Capacities are based on freely suspended loads and ake no allowance for such factors as the effect of wind, sudden stopping of loads, supporting surface conditions, and operating speeds. Operator ust reduce load ratings to take such conditions into account. Deduction fro rated capacities ust be ade for weight of jib, hook block, weighted ballhook, sling, spreader bar, or other suspended gear. 4. Lifting capacities shown are based on achine equipped as follows: a. Boo live ast and 1%" (32 diaeter pendants for all boo lengths. b. Without boo live ast but with 1Y:( (38 diaeter pendants - for boos up to 100' (.48 long. c. l%n (32 diaeter pendants ust not be used unless achine is equipped with a boo live ast. 5. When LS-338 is equipped with boo live ast and 111 (38 diaeter pendants instead of l%n (32 diaeter pendants, reduce all lifting capacities shown 0 Ibs. (1 kg. 6. For lifting 1,000 Ibs.( kg with Ya" (22 diaeter rope, eight parts of W' (22 Type "N" hoist rope are required. Check parts of line required for all capacities. 7. Boo live ast is required for all ain boo lengths exceeding 100' (.48, and for boo exceeding ' ( when equipped with jib. 8. When using boo live ast as a short boo, axiu lifting capacity of the boo live ast is 47,000 Ibs. (213 kg at 13' (3.96 iniu radius, 23,000 Ibs. (10434 kg at 28' O (8.53 axiu radius. a. For lifting 47,000 Ibs. (21 3 on boo live ast with Ya" (22 diaeter wire rope, 4 parts of %" ( diaeter Type "N" wire rope are required. Note: Use of live ast as a short boo is intended for achine assebly or disassebly only. It should not be used for general crane service. 9. Main boo length, without jib, ust not exceed 1' ( Jib ust not be ounted on boo longer than 1' ( When handling loads on ain load hoist line with jib ounted on boo, reduce rated boo lifting capacities as follows: ' ( jib - 2,000 Ibs. (907 kg ' ( jib - 2,0 Ibs. (1 089 kg ' (12. jib - 2,800 Ibs. (1 2 kg 12. Least stable position is over side. 13. These capacities apply only to the achine as originally anufactured and norally equipped by FMC Corporation, Cable Crane & Excavator Division.., LS-338 working areas Over side Note: These line. deterine the liiting position of any load for operation within working are Indicated. -4-

5 LS-338 boojib working ranges Boo - angle: 4 (1.22 wide, 4 Jib -angle: " x 2 (0.51 x 0.61 y. (1.22 deep with open throat top section; with or without boo live ast. Mounting - crawler: 13' 6" (4.11 gauge, ' 0" ( overall length. Counterweight - 52,0 Ibs. (23814 kg "AS" only. 2' ( ' (.10 2' ( ' (64.01 w Max Boo Angle 0" jib Angle 0' ( (1' " 0' ( '1::--- 1 I '.... 0' (54.86 }O", 1 $''.q!2. r-. ( r I---. I"---. II 0' (51.82 J~bl..!t I"---. ~ ' -.:r..:: 1' (48.77 ~ ' -~ "I---. II '""- 1' ( v.: I~ I-- 1' (42.67 r-, I -, L 1' ( ' (36.58 ~ II "' -, 4IJo IJ t-- r-, r-, ~ r-, -, I: --- t--.. N r-, "- '\ V 11 t-- r-, II r-, J IV " -, 11 """1-- " "'- 1'\ -, \ lilt-- X ~'-0- V\ 110' ( \.-? II I{'---.. I" ~.'V ~f' 1\ \ \ 100' (.48 ir+-: ~ '~ "\ \ \V 90' ( ' (24.38 ' ( ' ( J I D<- ;f?~:-:~v -, \,."1\ j I-t--.! "'f... ""- ""6'<b_ ~" "\ \ IV 1\ \ I r-, 1 r-, ~'..;: '~~ 1'\ \»: \ \ \ II 1 --I...L r-, ~..fr0- i'" X 1\ Y \ \ 1 "'1 " r..i'%o ~\..V \ V \ 0 IJ ~ I" $..>.9b~:-' \ \ v \ 1\ v rg Y'1(;> e.'j \ \. \ \ v--- -r-... I 2<?fo-: 0 ~~ \ V \ \ \ I r-: 0..z.- ~0,.(,. 1\ \ \ \ X ' ( v-: ; i~ \. \ \ \ \ ~ \ '7 II. ~$-~ V \ \ \,.\- V\ \ ' (12. '6 I <'$'-0-~" v \ \ \~ I V '20 \. \ \ l---""" v ;(1'!.(Z ' ~ ' ~' ~' ~.B',Q'..!!.' k' l~' l~' l,~' \~' 1:~' l,x lill' 12u' ljio' J.&O' z~' 2JP' 2';':'0' 2Jll' 2, ' 0' en en :::= ~ & ~ ~ ::::;..- w.,j::.. Ol!D (J'I!"!'O :...a 5=l ~ P'"!D!'3 ~.....,. P... P!-" en c.nou,;"", N N W W..,. (J'I &!il: en en... ~ to "" 8 g N 1'.01'-10..,. to..,. to..,. 00 w W N -.. "" -.. N en... en 0 (J'I 0 iz'z'z'z' Rotation Operating Radius I...- (1'. \V... I - I V V ~ ' "\ - J V - r '»>." ~...- ' ;\l -5-