LS 138H II. 80 ton (72.57 metric ton) Lattice Boom Crawler Crane. Tube Boom Capacities ( m)

Size: px
Start display at page:

Download "LS 138H II. 80 ton (72.57 metric ton) Lattice Boom Crawler Crane. Tube Boom Capacities ( m)"

Transcription

1 Lattice Crawler Crane 8 ton (72.57 metric ton) Tube Capacities 4 2 ( m) 24 (7.31 m) Live Mast / 2 (6.1 m) Base Section / 5 (1.52m) Tip Extension Duty Cycle Capacities 4 7 ( m) Tube Counterweight Tube Capacities 4 2 ( m) Tube 54 (1.37 m) Wide x 44 (1.12 m) Deep 2 (6.1 m) Open Throat Top Section 24 (7.31 m) Live Mast / Capacities B,, or Counterweight Options 2 2 (6.15 m) Crawler Length II CUTION: This material is supplied for reference use only. Operator must refer to in cab Crane Rating Manual to determine allowable machine lifting capacities and operating procedures. Litho in U.S.. 7/ #6276 (Supersedes #624)

2 OPERTING INSTRUCTIONS GENERL: 1. Rated lifting capacities in pounds as shown on lift charts pertain to this crane as originally manufactured and normally equipped. Modifications to the crane or use of optional equipment other than that specified can result in a reduction of capacity. 2. Construction equipment can be dangerous if improperly operated or maintained. Operation and maintenance of this crane must be in compliance with the information in the Operator s, Parts, and Safety Manuals supplied with this crane. If these manuals are missing, order replacements through the distributor. 3. The operator and other personnel associated with this crane shall read and fully understand the latest applicable merican National Standards Institute (NSI) safety standards for cranes. 4. ll capacities listed in this book are in compliance with SME/NSI B3.5c 1998, SE J987 pril 1994, and SE J765 October 199. LIFT CRNE OPERTION: 1. Capacities shown are in pounds and are not more than 75% of the tipping loads with the crane standing level on firm supporting surface. deduction must be made from these capacities for weight of hook block, hook ball, sling, grapple, load weighing device, etc. When using main hook while jib is attached, reduce capacities by values shown on Capacity Deductions For Lifting Off Main Hook With Jib Installed. When using main hook while 5ft. tip extension is attached, reduce capacities by values shown on Capacity Deductions For Lifting Off Main Hook With 5ft. Tip Extension Installed. See Operator s Manual for all limitations when raising or lowering attachment. 2. The crane capacities in the shaded areas are based on structural strength. The crane capacities in the non shaded areas are based on stability ratings. 3. For recommended reeving, parts of line, wire rope type, and wire rope inspection, see Wire Rope Capacity chart, Operator s Manual, and Parts Manual. 4. ratings in this Crane Rating Manual are based on freely suspended loads and make no allowances for such factors as the effect of the wind, ground conditions, and operating speeds. The operator shall therefore reduce load ratings in order to take these conditions into account. 5. Rated lifting capacities do not account for the effects of wind on a suspended load or boom. Lifting capacities should be considered acceptable for wind speeds less than 2 mph and appropriately reduced for wind speeds greater than 2 mph. Extreme caution should be used when lifting heavy loads or loads with large wind sail area under high wind conditions (over 2 mph). 6. The 24ft. live mast must be used for all capacities in this Crane Rating Manual. 7. The least stable rated condition is over the side. 8. s must be erected and lowered over the end. 9. Do not operate at radii and boom lengths where the Crane Rating Manual lists no capacity. Do not use longer booms or jibs than those listed in this Crane Rating Manual. ny of the above can cause a tipping condition, or boom and jib failure. 1. These capacities apply only to the crane as originally manufactured and normally equipped by Link Belt Construction Equipment Company. FOR OVER END CPCITIES ONLY 1. These capacities can be lifted over either end with the crane standing level on a firm supporting surface with adequate blocking placed under the tread member sprockets/idlers, to prevent rocking. 2. Do not travel with a load. 2

3 WIRE ROPE CPCITY 7/8 5/8 Parts of Type Type Type Type Line DB RB ZB WB Notes 1 22,7 17,52 * 11, ** 13,65 * B 2 45,4 35,4 22, 27,31 Capacities shown are in pounds and working 3 68,1 52,56 33, 4,97 loads must not exceed the ratings on the 4 9,8 7,8 44, 54,62 capacity charts in this 5 113,5 87,6 55, 68,28 Crane Rating Manual. Study Operator s Manual 6 136,2 15,12 66, 81,94 for wire rope inspec- tion procedures ,9 122,64 77, 95, ,6 14,16 88, 19,25 LBCE Type Description DB 6 x 26 (6 x 19 Class) Warrington Seale Extra Improved Plow Steel Preformed Right Lay Regular Lay I.W.R.C. RB 19 x 19 Rotation Resistant Extra Extra Improved Plow Steel Preformed Right Lay Regular Lay. Swaged SF = 5:1 ZB 36 x 7 Class Non Rotating Extra Improved Plow Steel Right Lay Regular Lay S.F. = 5:1 WB 8 Strand Regular Lay * Use of swivel end with 1 part of line is not recommended. ** Swivel end is recommended for operation with 1 part of line. Idler Longitudinal Of Crawler WORKING RES See Note Idler Sprocket 36 Side Drive Sprocket Side Center Of Rotation See Note Note: 1. These Lines Determine The Limiting Position Of ny For Operation Within Working reas Indicated. Drive LIFTOFF CPBILITIES Counterweight () Maximum Maximum + Jib Feet Feet NO (RETRCTED) 9 N/ NO (EXTENDED) 12 N/ (RETRCTED) 14 N/ (EXTENDED) 17 N/ B (EXTENDED) See Note See Note 6 Side Counterweight () Maximum Maximum + Jib Feet Feet NO (RETRCTED) 9 N/ NO (EXTENDED) 12 N/ (RETRCTED) 14 N/ (EXTENDED) 17 N/ B (EXTENDED) NOTES: 1. s should be erected or lowered over the end with no load if possible hook block on ground. (See Note 6). 2. Crane on firm and level surface. 3. Open throat booms 19 and 2 in length require mid point suspension pendants. 4. and jib combination of does require mid point suspension pendants. 5. and jib combination of does not require mid point suspension pendants. 6. For Maximum + Jib Combinations only dequate blocking must be placed under The side frame sprockets/idlers to prevent rocking. (Lift Off only). CPCITY DEDUCTIONS FOR LIFTING OFF MIN BOOM HOOK WITH JIB INSTLLED (OPEN THROT BOOM ONLY) When using main boom hook, while jib is attached, reduce boom capacities by the values in the following chart: Jib Length (ft) Capacity Deduction (lbs) 3 2, 45 2,4 6 3,2 3

4 CPCITY DEDUCTIONS FOR LIFTING OFF MIN BOOM HOOK WITH 5 FOOT TIP EXTENSION INSTLLED When using main boom hook, while 5 foot tip extension is attached, reduce boom capacities by the values in the following chart: Tip Extension (ft) Capacity Deduction (lbs) 5 1,1 2 BSE SECTION CYLINDER LIFTING CPCITIES (WITHOUT COUNTERWEIGHT INSTLLED) Base Section Cylinders (ft) ngle ,5 26, ,5 26, ,5 26, ,5 23, ,5 22, ,5 2, ,5 18,7 NOTES: 1. Rated capacities for 36 rotation. 2. base section supported by make up pendants. 3. Lifting any load with one cylinder is prohibited. Rated capacities are for lifting loads with both cylinders. 4. Gantry can be either in the raised or lowered position when lifting loads with the cylinders in the base section. When the gantry is in the lowered position the backstay links must be pinned. 5. Do not raise boom higher than 55 angle. 6. Do not lower live mast below 3 angle with gantry in lowered position. LIVE MST LIFTING CPCITIES (WITHOUT COUNTERWEIGHT INSTLLED) Live Mast (ft) ngle , 6, , 51, , 44, , 39, , 34, ,4 31, ,7 28, ,4 26, , 24, ,3 22, ,2 2, ,5 19, ,2 18, ,2 17, ,4 16,4 NOTES: 1. Refer to the Operator s Manual. 2. Live mast backstops must be in position and operative. 3. Use rear hoist drum only. Reeve hoist line to drum over live mast cross member. 4. Reeve hoist rope with three (3) parts of 7/8 diameter wire rope. 5. The crane shall be leveled on a firm supporting surface. 6. Capacities are based on 75% stability. 7. See Crane ssembly Component Weights chart for weight of components for crane assembly. 8. Rated capacities for 36 rotation. 9. Gantry can be either in the raised or lowered position when lifting loads with the live mast. When the gantry is in the lowered position the backstay links must be pinned. 1. Do not lower live mast below 3 angle with gantry in lowered position. 4

5 MXIMUM LLOWBLE CPCITIES FOR 5 FOOT TIP EXTENSION LIFTING CPCITY TO BE THE SMLLEST OF THE FOLLOWING VLUES: 1. 18, lb (Maximum). 2. The standard crane lift capacity minus 1,1 lb for the boom length, tip extension load radius, and counterweight configuration in use on the crane. NOTES: 1. ll notes are to be adhered to as listed on the standard lift crane capacity charts. 2. Reduce the main boom lift capacities by 1,1 lb when the tip extension is installed. 3. The maximum boom length on which the tip extension can be installed is Do not lift or suspend a load from the boom tip extension and main boom at the same time. DUTY CYCLE NOTES FOR TUBULR BOOM 1. The capacities included in this chart are the maximum allowable, and are based on machine standing level on firm suporting surface under ideal job conditions. 2. Capacities are based on 75% of minimum tipping loads for dragline; 67.5% for clamshell. 3. Capacities are maximum recommended by PCS Standard #4. User must make allowances for soft or uneven supporting surfaces, rapid cycle operations, bucket suction or other unfavorable conditions which may require smaller buckets for most efficient operation. 4. Weight of bucket, plus load must not exceed these capacities. 5. Dragline operation is not recommended with boom angles less than length for dragline/clamshell attachment operation should not exceed Retractable high gantry must be fixed in raised position for all capacities on this chart. 8. These capacities apply to the machine as originally manufactured and normally equipped by Link Belt Construction Equipment Company. DUTY CYCLE CPCITIES TUBULR BOOM Length ngle (ft) (ft) Counterweight Only (ll capacities listed are in pounds) Dragline Clamshell/Magnet , , ,8 15, ,8 15, ,8 15, , , , ,8 15, ,8 15, ,8 15, , , , ,8 15, ,8 15, ,8 15, , , , , ,8 15, ,8 15, , 11, ,3 5

6 WORKING RNGE DIGRM Maximum ngle See Note 2. 8 Height in feet above ground Minimum ngle See Note Main Length Operating radius from centerline of rotation in feet 1. geometry shown is for unloaded condition and crane standing level on firm supporting surface. deflection, subsequent radius and boom angle change must be accounted for when applying load to hook. 2. Maximum and minimum boom angles are equal to the values listed in the capacity chart for each boom length. 6

7 B MIN BOOM CPCITIES 4 FT OPEN THROT TUBE BOOM 36 Rotation ngle B B , 16, 16, 16, 143,3 77, , 16, 16, 153,2 116,9 62, , 16, 157,6 123, 98,6 52, , 16, 145,3 98,1 85,1 45, ,9 151,9 134,8 81,5 74,8 39, ,6 141,6 118,6 69,5 66,6 35, ,6 132,6 13,5 6,5 6, 31, ,7 124,7 91,8 53,5 54,5 28, ,6 117,6 82,3 47,9 49,9 26, ,3 18,7 74,6 43,3 46, 23, ,6 99,5 68,2 39,4 42,6 22, ,4 91,6 62,7 36,2 39,7 2, ,2 65,4 44,5 25,3 29,2 14, ,9 5,5 34,1 19,1 22,9 11, ,8 4,9 27,4 15,1 18,6 8, ,5 34,1 22,7 12,2 15,4 7, MIN BOOM CPCITIES 5 FT OPEN THROT TUBE BOOM 36 Rotation ngle B B ,9 159,9 157,3 123,9 99, 53, ,9 159,9 145,1 98,9 85,5 45, ,7 151,7 134,6 82,1 75,1 4, ,5 141,5 119,1 7, 66,9 35, ,5 132,5 14, 61, 6,3 31, ,6 124,6 92,2 53,9 54,8 28, ,5 117,5 82,7 48,3 5,2 26, ,2 19,1 75, 43,6 46,2 24, ,5 99,8 68,5 39,8 42,8 22, ,3 91,9 63, 36,5 39,9 2, ,2 65,6 44,7 25,5 29,4 14, ,1 5,7 34,3 19,3 23, 11, , 41,1 27,6 15,3 18,7 8, ,7 34,4 22,9 12,4 15,6 7, , 25,5 16,8 8,7 11,4 4,8 MIN BOOM CPCITIES 6 FT OPEN THROT TUBE BOOM ngle B B ,6 149,6 144,8 99,3 85,6 45, ,4 146,4 134,4 82,5 75,3 4, ,2 141,2 119,4 7,4 67, 35, ,3 132,3 14,2 61,3 6,4 31, ,4 124,4 92,4 54,2 54,9 28, ,4 117,4 82,9 48,5 5,3 26, ,1 19,3 75,1 43,8 46,3 24, ,4 99,9 68,7 39,9 42,9 22, ,2 92,1 63,2 36,6 39,9 2, ,2 65,7 44,8 25,6 29,4 14, ,2 5,8 34,4 19,4 23, 11, ,1 41,1 27,7 15,3 18,7 8, ,8 34,4 23, 12,5 15,6 7, ,1 25,6 16,8 8,8 11,4 4, ,6 2,1 13, 6,4 8,7 3,3 MIN BOOM CPCITIES 7 FT OPEN THROT TUBE BOOM 36 Rotation ngle B B ,7 129,7 119,6 7,6 67,1 35, ,8 126,8 14,4 61,4 6,4 32, ,1 124,1 92,6 54,3 54,9 28, ,1 117,1 83, 48,6 5,3 26, ,8 19,4 75,2 43,9 46,3 24, ,2 1, 68,7 4, 42,9 22, , 92,1 63,2 36,7 39,9 2, ,2 65,7 44,8 25,6 29,4 14, ,2 5,8 34,4 19,4 23, 11, ,1 41,1 27,7 15,3 18,7 8, ,8 34,4 23, 12,5 15,6 7, ,1 25,6 16,8 8,8 11,4 4, ,6 2,1 13, 6,4 8,7 3, ,1 16,3 1,3 4,8 6,8 2,2 MIN BOOM CPCITIES 8 FT OPEN THROT TUBE BOOM 36 Rotation ngle B B ,8 116,8 14,5 61,6 6,4 32, ,6 114,6 92,7 54,4 54,9 28, ,4 111,4 83,1 48,7 5,3 26, ,3 19,3 75,3 44, 46,3 24, ,9 1,1 68,8 4,1 42,9 22, ,8 92,2 63,3 36,7 39,9 2, , 65,7 44,8 25,6 29,4 14, ,2 5,7 34,4 19,3 22,9 11, , 41,1 27,6 15,3 18,6 8, ,7 34,3 22,9 12,4 15,5 7, ,1 25,5 16,8 8,7 11,3 4, ,5 2, 12,9 6,4 8,6 3, ,1 16,3 1,3 4,8 6,7 2, ,9 13,5 8,3 3,6 5,3 MIN BOOM CPCITIES 9 FT OPEN THROT TUBE BOOM 36 Rotation ngle B B ,7 14,7 92,7 54,5 54,9 28, ,8 12,8 83,2 48,7 5,2 26, ,2 11,2 75,3 44, 46,2 24, ,6 99,6 68,8 4,1 42,8 22, ,7 92,2 63,3 36,7 39,8 2, ,8 65,7 44,8 25,6 29,3 14, ,2 5,7 34,3 19,3 22,8 11, , 41, 27,5 15,2 18,5 8, ,7 34,2 22,8 12,3 15,4 6, , 25,4 16,7 8,6 11,2 4, ,5 19,9 12,8 6,3 8,5 3, , 16,2 1,2 4,7 6,6 2, ,8 13,4 8,3 3,5 5, ,4 11,3 6,8 2,6 4,1 7

8 B MIN BOOM CPCITIES 1 FT OPEN THROT TUBE BOOM 36 Rotation ngle B B ,4 93,4 75,3 44, 46, , 92, 68,8 4, 42, ,4 89,4 63,2 36,7 39, ,6 65,6 44,7 25,5 29, ,1 5,6 34,2 19,2 22, ,9 4,9 27,4 15,1 18, ,6 34,1 22,7 12,2 15, ,9 25,3 16,6 8,5 11, ,4 19,8 12,7 6,2 8, ,9 16,1 1,1 4,6 6, ,7 13,3 8,1 3,4 5, ,3 11,2 6,7 2,5 4, ,4 9,5 5,5 3,1 MIN BOOM CPCITIES 11 FT OPEN THROT TUBE BOOM ngle B B 36 Rotation IBIT TED PRO OHI ,1 65,5 44,6 25,4 29, , 5,5 34,1 19,1 22, ,8 4,8 27,3 15, 18, ,5 34, 22,6 12,1 15, ,8 25,2 16,4 8,4 1, ,2 19,7 12,6 6, 8, ,8 15,9 9,9 4,4 6, ,6 13,2 8, 3,3 5, ,2 11,1 6,5 2,4 3, ,3 9,4 5,4 3, ,7 8,1 4,4 2,3 MIN BOOM CPCITIES 12 FT OPEN THROT TUBE BOOM 36 Rotation ngle B B IBIT TED PRO OHI ,6 65,5 44,6 25,4 28, , 5,4 34, 19, 22, ,7 4,7 27,2 14,9 18, ,4 33,9 22,5 12, 15, ,7 25,1 16,3 8,2 1, ,1 19,5 12,4 5,9 8, ,7 15,8 9,8 4,3 6, ,5 13, 7,9 3,1 4, , 1,9 6,4 2,2 3, ,1 9,3 5,2 2, ,6 8, 4,3 2, ,3 6,8 3,5 PR ROH HIB BITE ED MIN BOOM CPCITIES 13 FT OPEN THROT TUBE BOOM 36 Rotation ngle B B ,1 65,1 44,5 28, ,9 5,3 33,9 22, ,6 4,6 27,1 18, ,2 33,8 22,3 14, ,5 24,9 16,2 1, , 19,4 12,3 7, ,5 15,6 9,6 6, ,3 12,9 7,7 4, ,9 1,8 6,3 3, , 9,2 5,1 2, ,5 7,8 4,2 2, ,2 6,7 3, ,1 5,8 2,7 MIN BOOM CPCITIES 14 FT OPEN THROT TUBE BOOM ngle B B IBIT ITED PRO OHI 36 Rotation IBIT TED PRO OHI , 6, 44,4 28, ,7 5,2 33,8 22, ,5 4,4 27, 17, ,1 33,6 22,2 14, ,4 24,8 16, 1, ,8 19,2 12,1 7, ,4 15,5 9,5 5, ,2 12,7 7,6 4, ,7 1,6 6,1 3, ,8 9, 4,9 2, ,3 7,7 4, , 6,6 3, , 5,6 2, ,1 4,8 2, MIN BOOM CPCITIES 15 FT OPEN THROT TUBE BOOM ngle B B PR ROH HIB BITE ED 36 Rotation PR ROH HIB BITE ED ,1 55,1 44, ,2 5, 33, ,4 4,3 26, , 33,5 22, ,2 24,6 15, ,7 19,1 12, ,2 15,3 9, , 12,6 7,4 PROHIBITED ,6 1,5 5, ,7 8,8 4, ,1 7,5 3, ,9 6,4 3, ,8 5,5 2, ,9 4, ,1 4, 8

9 B MIN BOOM CPCITIES 16 FT OPEN THROT TUBE BOOM 36 Rotation ngle B B ,9 47,9 33, , 4,2 26, ,9 33,3 21, ,1 24,5 15, ,5 18,9 11, , 15,1 9, ,8 12,4 7, ,4 1,3 5,8 PROHIBITED ,5 8,7 4, , 7,3 3, ,7 6,2 2, ,7 5,3 2, ,8 4, , 3, ,3 3,2 MIN BOOM CPCITIES 17 FT OPEN THROT TUBE BOOM ngle B B 36 Rotation ,4 42,4 33, ,3 4, 26, , 33,2 21, ,9 24,3 15, ,3 18,8 11, ,9 15, 9, ,7 12,2 7, ,2 1,1 5, ,3 8,5 4, ,8 7,2 3, ,5 6,1 2, ,5 5,1 2, ,6 4, ,8 3, ,1 3, ,5 2,5 PROHIBITED MIN BOOM CPCITIES 19 FT OPEN THROT TUBE BOOM 36 Rotation ngle B B ,9 32, ,5 32, ,7 3, ,7 24, ,6 18, ,2 14, ,3 11, , 9,8 PROHIBITED ,1 8, ,5 6, ,1 5, , 4, , 4, ,1 3, ,1 2,1 MIN BOOM CPCITIES 2 FT OPEN THROT TUBE BOOM ngle B B ,6 28, ,2 27, ,5 21, ,5 17, ,2 14, ,7 11, ,5 9, ,7 7, ,2 6, , 5, ,9 3, ,8 2,8 36 Rotation PROHIBITED MIN BOOM CPCITIES 18 FT OPEN THROT TUBE BOOM ngle B B ,5 37, ,8 36, ,9 33, ,1 24, ,9 18, ,7 14, ,5 12, ,1 1, ,2 8, ,6 7, ,4 5, ,1 5, , 4, ,1 3, ,3 2, ,5 2,4 36 Rotation PROHIBITED 9

10 This page intentionally left blank 1

11 This page intentionally left blank 11

12 Link Belt Construction Equipment Company Lexington, Kentucky Link Belt is a registered trademark. Copyright 2. ll rights reserved. We are constantly improving our products and therefore reserve the right to change designs and specifications. 12

LS 278H. 250 ton (227 metric ton) Hydraulic Lattice Boom Crawler Crane. Tube Boom Capacities ft. ( m)

LS 278H. 250 ton (227 metric ton) Hydraulic Lattice Boom Crawler Crane. Tube Boom Capacities ft. ( m) Hydraulic Lattice Crawler Crane Tube Capacities 60 330 ft. (18.29 100.58 m) 250 ton (227 metric ton) 35 ft. (10.67 m) Live Mast Capacities On Outrigger Jacks On Side Frames 10 ft. (3.05 m) Extension Lifting

More information

LS---208HII. Technical Data. Specifications & Tube Boom Capacities. Crawler Crane 80 Ton (72.57 metric ton)

LS---208HII. Technical Data. Specifications & Tube Boom Capacities. Crawler Crane 80 Ton (72.57 metric ton) 1 5436---25---H8 Technical Data Specifications & Tube Capacities LS -28H II Crawler Crane 8 Ton (72.57 metric ton) CUTION: This material is supplied for reference use only. Operator must refer to in---

More information

LS-208H II. HYLAB Series. Lattice Boom Crawler Crane 80-ton (77.62 mt)

LS-208H II. HYLAB Series. Lattice Boom Crawler Crane 80-ton (77.62 mt) LS-208H II HYLB Series Lattice Crawler Crane 80-ton (77.62 mt) The duty cycle crane with big horsepower, outstanding versatility and bullet-proof hydraulic controls 80-ton (77.57 mt) at 11' (3.35 m) radius

More information

HC-278H II. HYLAB Series. Lattice Boom Truck Crane 300-ton (272 mt)

HC-278H II. HYLAB Series. Lattice Boom Truck Crane 300-ton (272 mt) HC-278H II HYLAB Series Lattice Truck Crane 300-ton (272 mt) 300 tons (272 mt) at a 10' (3.05 m) radius 60' to 330' (18.29-100.58 m) of tube boom 300' + 100' (91.4 + 30.5 m) boom plus jib combination 403.8'

More information

RTC 8050 Series II. 50 ton (45.36 metric tons) Telescopic Boom Rough Terrain Crane

RTC 8050 Series II. 50 ton (45.36 metric tons) Telescopic Boom Rough Terrain Crane Telescopic Boom Rough Terrain Crane RTC 85 Series II 5 ton (45.36 metric tons) Boom and Fly Capacities for this machine are listed by the following sections. Working Range Diagram 35.5 to 6.3 (1.82 18.38

More information

For sales use only CRANE RATING MANUAL. RTC-8090 Series II 5 - Section Boom. Not for crane operations SERIAL NUMBER: XXXX-XXXX

For sales use only CRANE RATING MANUAL. RTC-8090 Series II 5 - Section Boom. Not for crane operations SERIAL NUMBER: XXXX-XXXX SERIAL NUMBER: XXXX-XXXX CRANE RATING MANUAL RTC-8090 Series II 5 - Section Boom For Replacement, Order Part Number: N4P0090 (110509) R Link-Belt is a registered trademark. 1of96 N4P0091 Table Of Contents

More information

Working Weights. Assembly Diagram. Ctwt ABC+A

Working Weights. Assembly Diagram. Ctwt ABC+A 14 5487--- 0607--- P3 Assembly Diagram Link--Belt Working Weights Ctwt AB+A Ctwt ABC+A Ctwt ABCDE + A lb (kg) lb (kg) lb (kg) 315,532 (143 125) 340,377 (154 395) 390,069 (176 935) psi 9.8 10.6 12.2 kg/cm2

More information

CRANE RATING MANUAL HTC

CRANE RATING MANUAL HTC SERIAL NUMBER: CRANE RATING MANUAL 5---Section Boom For Replacement, Order Part Number: N3P0199 (031907) R Link-Belt is a registered trademark. 1of244 N3P0200 Table Of Contents Page Contents 3---4 Operating

More information

LINK-BELT MODEL HTC-8675LB - 75 TON CAPACITY 48 7" (.80m) 41 0" /8" (3.52m) /16" (2.02m) /4" (.34m) 25" 11 0" (.

LINK-BELT MODEL HTC-8675LB - 75 TON CAPACITY 48 7 (.80m) 41 0 /8 (3.52m) /16 (2.02m) /4 (.34m) 25 11 0 (. LIFTING CHARTS - Hydraulic Truck Cranes LINK-BELT MODEL - 75 TON CAPACITY 41 0" (12.50m) 48 7" (14.80m) C L Of Rotation 13 8 1/8" (4.17m) 7 0" (2.13m) 4 5/8" (118mm) 11 6 7/8" (3.52m) 6 7 11/16" (2.02m)

More information

truck crane 140 tons link-belt htc-3140lb BOOM LENGTHS: 42 to 195 ft JIB LENGTHS: 38 to 109 ft JIB OFFSETS:

truck crane 140 tons link-belt htc-3140lb BOOM LENGTHS: 42 to 195 ft JIB LENGTHS: 38 to 109 ft JIB OFFSETS: truck crane 140 tons link-belt htc-3140lb BOOM LENGTHS: 42 to 195 ft JIB LENGTHS: 38 to 109 ft JIB OFFSETS: 2-15 - 30-45 NOTES: Technical Data Specifications & Capacities Telescopic Boom Truck Crane 140

More information

For Sales Use Only! HTC 8650 Series II CRANE RATING MANUAL 4 SECTION POWER BOOM SERIAL NUMBER. not for crane operations

For Sales Use Only! HTC 8650 Series II CRANE RATING MANUAL 4 SECTION POWER BOOM SERIAL NUMBER. not for crane operations HTC 8650 Series II CRANE RATING MANUAL 4 SECTION POWER BOOM SERIAL NUMBER For Replacement, Order Part Number: L8P0001 (022603) Link Belt is a registered trademark. Page Contents 3 Operating Instructions

More information

LS 278H. 250 ton (227 metric ton) Hydraulic Lattice Boom Crawler Crane. Tube Boom + Jib Capacities

LS 278H. 250 ton (227 metric ton) Hydraulic Lattice Boom Crawler Crane. Tube Boom + Jib Capacities Hydraulic Lattice Boom Crawler Crane LS 278H 250 ton (227 metric ton) Tube Boom + Capacities 60 300 ft. (18.29 91.44 m) Tube Boom with 30 100 ft. (9.14 30.48 m) of 30 ft. (9.14 m) Open Throat Top Section

More information

HTC-8670LB TELESCOPIC TRUCK CRANE 70-Ton (63.50 mt)

HTC-8670LB TELESCOPIC TRUCK CRANE 70-Ton (63.50 mt) HTC-867LB TELESCOPIC TRUCK CRANE 7-Ton (63.5 mt) 7-ton at a 9-foot radius 94, lbs. gross vehicle weight (fully loaded) 127-foot, full power, four-section boom with quick reeve boom head 67-foot, two-stage,

More information

Lifting Capacities Telescopic Boom All Terrain Crane ATC ton (118 metric ton) Link Belt

Lifting Capacities Telescopic Boom All Terrain Crane ATC ton (118 metric ton) Link Belt Lifting Capacities Telescopic Boom All Terrain Crane ATC 3130 130 ton (118 metric ton) Boom and fly capacities for this machine are listed by the following sections: Fully Extended Outriggers Working Range

More information

LS-308H II. HYLAB Series. Lattice Boom Crawler Crane

LS-308H II. HYLAB Series. Lattice Boom Crawler Crane LS-38H II HYLB Series Lattice Crawler Crane 11-ton (99.79 mt) 11-ton (99.79 mt) at 12' (3.66 m) radius Powerhouse package: - 1-1/8" wire rope, front & rear drums - 37,1 lbs (16 828 kg) allowable line pull

More information

LINK-BELT MODEL HTC TON CAPACITY RANGE DIAGRAM. LIFTING CHARTS - Hydraulic Truck Cranes

LINK-BELT MODEL HTC TON CAPACITY RANGE DIAGRAM. LIFTING CHARTS - Hydraulic Truck Cranes LIFTING CHARTS - Hydraulic Truck Cranes LINK-BELT MODEL HTC-840-40 TON CAPACITY RANGE DIAGRAM NOTE: and fly and jib geometry shown are for unloaded condition and machine standing level on firm supporting

More information

CRANE RATING MANUAL HTC

CRANE RATING MANUAL HTC SERIAL NUMBER: XXXX- XXXX CRANE RATING MANUAL HTC- 8611 TELESCOPIC BOOM TRUCK CRANE - 164.1 SIX SECTION LATCHING BOOM For Replacement, Order Part Number: T2P38 (116) R Link-Belt is a registered trademark.

More information

RT555 TEREX. rough terrain crane 55 ton capacity. range diagram & lifting capacities. Range Diagram ( boom) HOOK BLOCK WEIGHTS

RT555 TEREX. rough terrain crane 55 ton capacity. range diagram & lifting capacities. Range Diagram ( boom) HOOK BLOCK WEIGHTS TEREX RT5 rough terrain crane ton capacity range diagram & lifting capacities DIMENSIONS ARE FOR LARGEST FACTORY FURNISHED HOOK BLOCK AND HOOK & BALL, WITH ANTI-TWO BLOCK ACTIVATED Range Diagram (33-1

More information

T 775. truck crane 75 ton capacity. range diagram & lifting capacities. Range Diagram (40' - 126' boom)

T 775. truck crane 75 ton capacity. range diagram & lifting capacities. Range Diagram (40' - 126' boom) T 7 truck crane ton capacity range diagram & lifting capacities DEFLECTIONS NOT SHOWN 6' - 9" 4' - 8" DIMENSIONS ARE FOR LARGEST FACTORY FURNISHED HOOK BLOCK AND HOOK & BALL, WITH ANTI-TWO BLOCK ACTIVATED

More information

Technical Data. Specifications & Capacities. HSL Crawler Crane. View thousands of Crane Specifications on FreeCraneSpecs.com

Technical Data. Specifications & Capacities. HSL Crawler Crane. View thousands of Crane Specifications on FreeCraneSpecs.com 1 Technical Data Specifications & Capacities HSL Crawler Crane Ton (72.6 metric ton) CAUTION: This material is supplied for reference use only. Operator must refer to in-cab Crane Rating Manual and Operator's

More information

Liftcrane Boom Capacities 999 SERIES 2. Manitowoc Cranes, Inc.

Liftcrane Boom Capacities 999 SERIES 2. Manitowoc Cranes, Inc. Liftcrane Capacities No. 82 or 22EL LIFTING CAPACITIES: Lifting capacities for various boom lengths and operating radii are for freely suspended loads and do not exceed 75% of a static tipping load. Capacities

More information

Lattice Boom Crawler Crane 80 ton (72.6 mt)

Lattice Boom Crawler Crane 80 ton (72.6 mt) Lattice Boom Crawler Crane 80 ton (72.6 mt) Cutting Edge winch package with wet brake design and matching front & rear drums (line pull) 3-piece counterweight system, designed with innovative counterweight

More information

CONSTRUCTION EQUIPMENT LS-238H HYLAB. 150-ton (136 t) Hydraulic Lattice Boom Crawler Crane. Superior Crawler Crane Transportability!

CONSTRUCTION EQUIPMENT LS-238H HYLAB. 150-ton (136 t) Hydraulic Lattice Boom Crawler Crane. Superior Crawler Crane Transportability! R CONSTRUCTION EQUIPMENT HYLAB 150-ton (136 t) Hydraulic Lattice Boom Crawler Crane Superior Crawler Crane Transportability! Dependable Hydraulic Control System No Electronics Maximum Transportability

More information

Technical Data. Specifications & Capacities. HSL Crawler Crane (supersedes 5668)-0115-P Ton ( metric ton)

Technical Data. Specifications & Capacities. HSL Crawler Crane (supersedes 5668)-0115-P Ton ( metric ton) 1 5713 (supersedes 5668)-0115-P3 Technical Data Specifications & Capacities SL Crawler Crane 250 Ton (226. metric ton) CAUTION: This material is supplied for reference use only. Operator must refer to

More information

MODEL CKE2500-II TON CAPACITY

MODEL CKE2500-II TON CAPACITY LIFTING CHARTS - Crawler Cranes KOBELCO MODEL - 275 TON CAPACITY Luffing Jib Working Ranges Boom Angle: 88 125 54.9 m 51.8 m 48.8 m 45.7 m 42.7 m 39.6 m 3 m 33.5 m 30.5 m 57.9 m 120 115 110 105 100 95

More information

Cranes. Range Diagram and Lifting Capacity RT TON LIFTING CAPACITY RANGE DIAGRAM 33' - 110' BOOM

Cranes. Range Diagram and Lifting Capacity RT TON LIFTING CAPACITY RANGE DIAGRAM 33' - 110' BOOM Range Diagram and Lifting Capacity Cranes 55 TON LIFTING CAPACITY RANGE DIAGRAM 33' - 110' BOOM Dimensions are for largest factory furnished hook block and hook & ball, with anti-two block activated COUNTER

More information

Cranes. Range Diagram and Lifting Capacity RT TON LIFTING CAPACITY RANGE DIAGRAM 40' - 126'

Cranes. Range Diagram and Lifting Capacity RT TON LIFTING CAPACITY RANGE DIAGRAM 40' - 126' Range Diagram and Lifting Capacity Cranes 80 TON LIFTING CAPACITY RANGE DIAGRAM 40' - 126' BOOM Dimensions are for largest factory furnished hook block and hook & ball, with anti-two block activated COUNTER

More information

Technical Data. Specifications & Capacities. HSL Crawler Crane (supersedes 5776)-1217-U Ton ( metric ton)

Technical Data. Specifications & Capacities. HSL Crawler Crane (supersedes 5776)-1217-U Ton ( metric ton) 1 Technical Data Specifications & Capacities HSL Crawler Crane 250 Ton (226.80 metric ton) CAUTION: This material is supplied for reference use only. Operator must refer to in-cab Crane Rating Manual and

More information

Range Diagram and Lifting Capacity T Cranes RANGE DIAGRAM BOOM

Range Diagram and Lifting Capacity T Cranes RANGE DIAGRAM BOOM Range Diagram and Lifting Capacity T340-1 Cranes RANGE DIAGRAM 30-94 BOOM Dimensions are for largest factory furnished hook block and hook & ball, with anti-two block activated COUNTER WEIGHT BOOM LENGTH

More information

Technical Data. Specifications & Capacities. HSL Crawler Crane 80 Ton (72.6 metric ton) P8

Technical Data. Specifications & Capacities. HSL Crawler Crane 80 Ton (72.6 metric ton) P8 1 Technical Data Specifications & Capacities HSL Crawler Crane Ton (72.6 metric ton) CAUTION: This material is supplied for reference use only. Operator must refer to in--- cab Crane Rating Manual and

More information

Cranes. Range Diagram and Lifting Capacity RT345-1XL 45 TON LIFTING CAPACITY RANGE DIAGRAM 33.75' - 105' BOOM

Cranes. Range Diagram and Lifting Capacity RT345-1XL 45 TON LIFTING CAPACITY RANGE DIAGRAM 33.75' - 105' BOOM Range Diagram and Lifting Capacity RT345-1XL Cranes 45 TON LIFTING CAPACITY RANGE DIAGRAM 33.75' - 105' BOOM DIMENSIONS ARE FOR LARGEST FACTORY FURNISHED HOOK BLOCK AND HOOK & BALL, WITH ANTI-TWO BLOCK

More information

LINK-BELT MODEL 238H5-150 TON CAPACITY

LINK-BELT MODEL 238H5-150 TON CAPACITY TRANSPORTATION SPECS - Crawler Cranes INK-BET MODE 2385-150 TON CAPACITY COMPONENT EIGTS BS. KGS. Boom 70 (1.78m) x 62 (1.57m) Min 50 to Max 260 Complete Crane c/w 50 boom 287,717 130 508 OD (tubular)

More information

40' ' POWERED BOOM: MODE 1 40' - 126' POWERED BOOM: MODE 2

40' ' POWERED BOOM: MODE 1 40' - 126' POWERED BOOM: MODE 2 Range Diagram and Lifting Capacity Cranes 100 TON LIFTING CAPACITY 40' - 97.3' POWERED BOOM: MODE 1 40' - 126' POWERED BOOM: MODE 2 CRANE WORKING CONDITIONS DIMENSIONS ARE FOR LARGEST FACTORY FUR- NISHED

More information

Optional two-piece bi-fold lattice fly can be extended with two optional 15' (4.57 m) fly extensions for up to 85' of fly

Optional two-piece bi-fold lattice fly can be extended with two optional 15' (4.57 m) fly extensions for up to 85' of fly RTC 80100 SERIES II Unveiling the next generation of formed boom design This new boom design not only delivers full power boom and telescoping load capability but also delivers a superior load chart and

More information

Range Diagram and Lifting Capacity T Cranes. View thousands of Crane Specifications on FreeCraneSpecs.com RANGE DIAGRAM BOOM

Range Diagram and Lifting Capacity T Cranes. View thousands of Crane Specifications on FreeCraneSpecs.com RANGE DIAGRAM BOOM Range Diagram and Lifting Capacity Cranes RANGE DIAGRAM 30-94 BOOM Dimensions are for largest factory furnished hook block and hook & ball, with anti-two block activated COUNTER WEIGHT BOOM LENGTH UPPERSTRUCTURE

More information

LS 138H II. 80 ton (72.57 metric ton) Lattice Boom Crawler Crane. Website: Cranes101.com Phone:

LS 138H II. 80 ton (72.57 metric ton) Lattice Boom Crawler Crane. Website: Cranes101.com   Phone: Lattice Boom Crawler Crane 80 ton (72.57 metric ton) II Litho in USA 3/02 #5349 (supersedes #5296) Machine Transport Weights approximate 11 6 (3.54 m) Catwalks Folded 10 6 (3.19 m) Cab Width 11 6 (3.51

More information

LINK-BELT LARGE TELESCOPIC BOOM CRANE SWING CAB (TLL)

LINK-BELT LARGE TELESCOPIC BOOM CRANE SWING CAB (TLL) LOAD CHARTS for Use in CCO Written Examinations LINK-BELT LARGE TELESCOPIC BOOM CRANE SWING CAB (TLL) This load chart has been adapted from the original manufacturer s load chart for use in CCO written

More information

Range Diagram and Lifting Capacity RT230. Cranes 30 TON LIFTING CAPACITY RANGE DIAGRAM 30' - 94' BOOM REDUCTION IN MAIN BOOM CAPACITY

Range Diagram and Lifting Capacity RT230. Cranes 30 TON LIFTING CAPACITY RANGE DIAGRAM 30' - 94' BOOM REDUCTION IN MAIN BOOM CAPACITY Range Diagram and Lifting Capacity Cranes 30 TON LIFTING CAPACITY RANGE DIAGRAM 30' - 94' BOOM Dimensions are for largest factory furnished hook block and hook & ball, with anti-two block activated COUNTER

More information

Big power, big cab. Big, new HYLAB cab. Powerful, reliable, customer proven features. Easy transportability and assembly

Big power, big cab. Big, new HYLAB cab. Powerful, reliable, customer proven features. Easy transportability and assembly Big power, big cab Big, new HYLB cab Totally new cab offers substantially more room and is designed to be highly functional and very comfortable 18, BTU air-conditioning 19, BTU hot water heating Six-way

More information

Range Diagram and Lifting Capacity RT665. Cranes 65 TON LIFTING CAPACITY RANGE DIAGRAM 36' - 111' BOOM REDUCTION IN MAIN BOOM CAPACITY

Range Diagram and Lifting Capacity RT665. Cranes 65 TON LIFTING CAPACITY RANGE DIAGRAM 36' - 111' BOOM REDUCTION IN MAIN BOOM CAPACITY Range Diagram and Lifting Capacity Cranes 65 TON LIFTING CAPACITY RANGE DIAGRAM 36' - 111' BOOM DIMENSIONS ARE FOR LARGEST FACTORY FURNISHED HOOK BLOCK AND HOOK & BALL, WITH ANTI-TWO BLOCK ACTIVATED COUNTER

More information

Series 1300A Hydraulic Crane 30 Ton Load Ratings

Series 1300A Hydraulic Crane 30 Ton Load Ratings Series 13A Hydraulic Crane 3 Ton Load Ratings DANGER AN UNTRAINED OPERATOR SUBJECTS HIMSELF AND OTHERS TO DEATH OR SERIOUS INJURY YOU MUST NOT OPERATE THIS CRANE UNLESS You have been trained in the safe

More information

Liftcrane Boom Capacities 2250 SERIES 3

Liftcrane Boom Capacities 2250 SERIES 3 Liftcrane Capacities 2250 SERIES 3 No. 44 With Long Reach Top LIFTING CAPACITIES: Lifting capacities for various boom lengths and operating radii are for freely suspended loads and do not exceed 75% of

More information

Technical Data. Specifications & Capacities. HSL Crawler Crane (supersedes 5762)-1016-U Ton ( metric ton)

Technical Data. Specifications & Capacities. HSL Crawler Crane (supersedes 5762)-1016-U Ton ( metric ton) 5776 (supersedes 576)-06-U Technical Data Specifications & Capacities HSL Crawler Crane 50 Ton (6.80 metric ton) CAUTION: This material is supplied for reference use only. Operator must refer to in-cab

More information

Series 1400A Hydraulic Crane 33 Ton

Series 1400A Hydraulic Crane 33 Ton Series 1A Hydraulic Crane 33 Ton Load Ratings DANGER AN UNTRAINED OPERATOR SUBJECTS HIMSELF AND OTHERS TO DEATH OR SERIOUS INJURY YOU MUST NOT OPERATE THIS CRANE UNLESS You have been trained in the safe

More information

Series 1400 Hydraulic Crane 33 Ton Load Ratings

Series 1400 Hydraulic Crane 33 Ton Load Ratings Series 1 Hydraulic Crane 33 Ton Load Ratings! DANGER AN UNTRAINED OPERATOR SUBJECTS HIMSELF AND OTHERS TO DEATH OR SERIOUS INJURY YOU MUST NOT OPERATE THIS CRANE UNLESS You have been trained in the safe

More information

Series 900H Hydraulic Crane 27 Ton Load Ratings

Series 900H Hydraulic Crane 27 Ton Load Ratings Series 0H Hydraulic Crane 27 Ton Load Ratings DNGER N UNTRINED OPERTOR SUBJECTS HIMSELF ND OTHERS TO DETH OR SERIOUS INJURY YOU MUST NOT OPERTE THIS CRNE UNLESS You have been trained in the safe operation

More information

LOAD CHART MANUAL FOR RT55 ROUGH TERRAIN CRANE

LOAD CHART MANUAL FOR RT55 ROUGH TERRAIN CRANE Address:Quantang Indust=rial Park, 2nd Yuanda Road, Changsha Economic and Technological Development Zone, Hunan Province, China Postcode: 410131 Website: www.zoomlion.com LOAD CHART MANUAL FOR RT55 ROUGH

More information

Series 1300 Hydraulic Crane 30 Ton Load Ratings

Series 1300 Hydraulic Crane 30 Ton Load Ratings Series 13 Hydraulic Crane Ton Load Ratings! DANGER AN UNTRAINED OPERATOR SUBJECTS HIMSELF AND OTHERS TO DEATH OR SERIOUS INJURY YOU MUST NOT OPERATE THIS CRANE UNLESS You have been trained in the safe

More information

LOAD CHART MANUAL FOR RT60 ROUGH TERRAIN CRANE

LOAD CHART MANUAL FOR RT60 ROUGH TERRAIN CRANE LOAD CHART MANUAL FOR RT60 ROUGH TERRAIN CRANE Address:Quantang Indust=rial Park, 2nd Yuanda Road, Changsha Economic and Technological Development Zone, Hunan Province, China Postcode: 410131 Website:

More information

OPERATING RADIUS/LIFTING HEIGHT CHART

OPERATING RADIUS/LIFTING HEIGHT CHART LIFTING CHARTS - Rough Terrain Cranes TADANO MODEL - 50 TON CAPACITY OPERATING RADIUS/LIFTING HEIGHT CHART NOTE: Boom and jib geometry shown are for unloaded condition and machine standing level on firm

More information

LOAD CHARTS TMS9000E 85% STABILITY SERIAL NUMBER

LOAD CHARTS TMS9000E 85% STABILITY SERIAL NUMBER LOAD CHARTS TMS9000E 85% STABILITY SERIAL NUMBER TMS9000E - S/N 1 TMS9000E - S/N 2 CONTENTS GENERAL NOTES...11 WEIGHT REDUCTIONS AND WARNING NOTES... 12 COUNTERWEIGHT CONFIGURATIONS... 13-15 LIFTING AREA

More information

Technical Data. Specifications & Capacities. HSL Crawler Crane (supersedes 5603)-0913-P Ton ( metric ton)

Technical Data. Specifications & Capacities. HSL Crawler Crane (supersedes 5603)-0913-P Ton ( metric ton) 565 (supersedes 5)-09-P Technical Data Specifications & Capacities SL Crawler Crane 50 Ton (6. metric ton) CAUTION: This material is supplied for reference use only. Operator must refer to in-cab Crane

More information

AMERICAN MODEL 5299A - 60 TON CAPACITY

AMERICAN MODEL 5299A - 60 TON CAPACITY LIFTING CHARTS - Crawler Cranes AMERICAN MODEL 5299A - 60 TON CAPACITY (POUNDS') FROM POINT 40' 11 80.5 120,000 * 45 ( 12.2 M) 12 79.0 110,020 * 44 15 74.6 81,530 44 20 66.9 52,290 42 25 58.8 38,280 39

More information

TADANO MODEL TR-300XL-3-30 TON CAPACITY WORKING RANGE CHART. LIFTING CHARTS - Rough Terrain Cranes

TADANO MODEL TR-300XL-3-30 TON CAPACITY WORKING RANGE CHART. LIFTING CHARTS - Rough Terrain Cranes LIFTING CHARTS - Rough Terrain Cranes TADANO MODEL - 30 TON CAPACITY WORKING RANGE CHART NOTE: Boom and jib geometry shown are for unloaded condition and machine standing level on firm supporting surface.

More information

LIFTING CHARTS - Crawler Cranes AMERICAN MODEL TON CAPACITY

LIFTING CHARTS - Crawler Cranes AMERICAN MODEL TON CAPACITY LIFTING CHARTS - Crawler Cranes AMERICAN MODEL 9310-225 TON CAPACITY 9310 1 LIFT RATINGS With Tubular and "S-S" Counterweight (135,000 Lbs.) 17 81.4-450,000 76 12 20 78.9-336,000 75 9 25 74.7 195,030 230,290

More information

RTC Technical Data. Specifications & Capacities. Telescopic Boom Rough Terrain Crane 60 ton (54.4 metric ton)

RTC Technical Data. Specifications & Capacities. Telescopic Boom Rough Terrain Crane 60 ton (54.4 metric ton) 5447---0205---E1 1 Technical Data Specifications & Capacities RTC -8060 Telescopic Rough Terrain Crane 60 ton (54.4 metric ton) CAUTION: This material is supplied for reference use only. Operator must

More information

RTC Technical Data. Specifications & Capacities. Telescopic Boom Rough Terrain Crane 60 ton (54.4 metric ton)

RTC Technical Data. Specifications & Capacities. Telescopic Boom Rough Terrain Crane 60 ton (54.4 metric ton) Technical Data Specifications & Capacities RTC -8060 Telescopic Rough Terrain Crane 60 ton (54.4 metric ton) CAUTION: This material is supplied for reference use only. Operator must refer to in--- cab

More information

Liftcrane Boom Capacities Boom No. 58 HL 332,000 lb Crane Counterweight 120,000 lb Carbody Counterweight 360 Degree Rating SERIES 3

Liftcrane Boom Capacities Boom No. 58 HL 332,000 lb Crane Counterweight 120,000 lb Carbody Counterweight 360 Degree Rating SERIES 3 ANSI B30.5 Liftcrane Boom Capacities Boom No. 332,000 lb Crane Counterweight 120,000 lb Carbody Counterweight 360 Degree Rating 16000 SERIES 3 LIFTING CAPACITIES: Lifting capacities for various boom lengths

More information

Specifications Hydraulic Lattice Boom Crawler Crane LS-138H. 75-Ton (68 metric ton) General dimensions Feet meters. General dimensions Feet meters

Specifications Hydraulic Lattice Boom Crawler Crane LS-138H. 75-Ton (68 metric ton) General dimensions Feet meters. General dimensions Feet meters Specifications Hydraulic Lattice Boom Crawler Crane LS-138H 75-Ton (68 metric ton) General dimensions Feet meters General dimensions Feet meters Basic boom length 40' 0" 12.20 Overall width side frames

More information

ATC-822. Hydraulic All-Terrain Crane 22-ton (20 mt)

ATC-822. Hydraulic All-Terrain Crane 22-ton (20 mt) ATC-822 Hydraulic All-Terrain Crane 22-ton (2 mt) 22-ton at 9' (2.74 m) radius 121' (36.88 m) maximum tip height 39,223 lbs (17 791 kg) gross vehicle weight 27.12' - 7.12' (8.27-21.37 m) full power, three-section

More information

LOAD CHART & RIGGING PRACTICE EXERCISES

LOAD CHART & RIGGING PRACTICE EXERCISES LOAD CHART & RIGGING PRACTICE EXERCISES HYDRAULIC LATTICE CRANE Crawler Crane Kobelco CK1600-II 160 Ton CraneSafe Certification Document #: Lattice Hydraulic Crane Practice LCR.LHC.KB1600.160.P1(131009)

More information

250 ton (226.8 mt) Lattice Crawler Crane

250 ton (226.8 mt) Lattice Crawler Crane 250 ton (226.8 mt) Lattice Crawler Crane 365 hp Tier III Engine Transport weight is 87,100lbs with carbody, live mast with self assemble cylinder, and hoist rope HSL counterweight removal system, lowers

More information

HYDRAULIC CRAWLER CRANE

HYDRAULIC CRAWLER CRANE HYDRAULIC CRAWLER CRANE consolidatedcrane.com Houston, TX 713.641.3330 Max. Lift Capacity: 500,000 lbs Max. Length: 300 ft Max. + Jib Length: 250 ft + 100 ft SPECIFICATIONS FOR CK2500-II CRAWLER CRANE

More information

LIFTING CHARTS - Crawler Cranes AMERICAN MODEL TON CAPACITY

LIFTING CHARTS - Crawler Cranes AMERICAN MODEL TON CAPACITY LIFTING CHARTS - Crawler Cranes AMERICAN MODEL 7250-60 TON CAPACITY 7250 1 LIFT RATINGS With Tubular Hammerhead and "K-F-L-M" Counterweight (34,000 Lbs.) 11 82.8-120000 46 6 12 81.3-120000 46 6 15 77.0-106950

More information

4600 SERIES 3 RINGER SERIES 2. Manitowoc Cranes, Inc. Manitowoc, Wisconsin U.S.A.

4600 SERIES 3 RINGER SERIES 2. Manitowoc Cranes, Inc. Manitowoc, Wisconsin U.S.A. Liftcrane Capacities No. 35 thru 1 Degree Static Machine LIFTING CAPACITIES: Lifting capacities are for a RINGER when operating on a barge. Machine shall be positively secured to prevent shifting. Lifting

More information

Technical Data. Specifications & Capacities. HSL Crawler Crane (supersedes 5775)-0917-T Ton (117.9 metric ton)

Technical Data. Specifications & Capacities. HSL Crawler Crane (supersedes 5775)-0917-T Ton (117.9 metric ton) 1 Technical Data Specifications & Capacities S Crawler Crane 130 Ton (117.9 metric ton) CAUTION: This material is supplied for reference use only. Operator must refer to in-cab Crane Rating Manual and

More information

PRELIMINARY. 230 ton (208.6 mt) Lattice Crawler Crane ENGINE DRUMS LOWER COUNTERWEIGHTS BOOM HOIST ATTACHMENT

PRELIMINARY. 230 ton (208.6 mt) Lattice Crawler Crane ENGINE DRUMS LOWER COUNTERWEIGHTS BOOM HOIST ATTACHMENT ENGINE Mitsubishi 6-cylinder M670-T3 365 hp ydraulic system consists of 7 pumps ydraulic pilot-operated control valves Remote hydraulic oil cooler Full fl ow fi ltration 230 ton (208.6 mt) Lattice Crawler

More information

Specifications. RTC-8040 Series II. 40-ton (36.28 metric ton) Rough Terrain Crane. General dimensions feet meters. Not to Scale

Specifications. RTC-8040 Series II. 40-ton (36.28 metric ton) Rough Terrain Crane. General dimensions feet meters. Not to Scale Specifications Rough Terrain Crane RTC-84 Series II 4-ton (36.28 metric ton) Not to Scale General dimensions feet meters Turning radius (4-wheel steer - centerline of tires) 2' 6.9 Turning radius (2-wheel

More information

LOAD CHART. MANTIS Model 10010MX. 50 Ton Hydraulic Crawler Crane as originally manufactured and equipped by Tadano Mantis Corporation.

LOAD CHART. MANTIS Model 10010MX. 50 Ton Hydraulic Crawler Crane as originally manufactured and equipped by Tadano Mantis Corporation. MANTIS Model 10010MX 111.5 ft STANDARD BOOM LOAD CHART MANTIS Model 10010MX 50 Ton Hydraulic Crawler Crane as originally manufactured and equipped by Tadano Mantis Corporation. with Standard 111.5 ft Main

More information

RT 300 SERIES. Rough Terrain Cranes. simple, available and cost effective FEATURES

RT 300 SERIES. Rough Terrain Cranes. simple, available and cost effective FEATURES RT 300 SERIES Rough Terrain Cranes FEATURES 30-35 tons (27-32 mt) maximum lifting capacity 94 ft. (28.6 m) maximum boom length 147 ft. (44.8 m) maximum tip height Four-section full power, mechanically

More information

HYDRAULIC CRAWLER CRANE CK2500

HYDRAULIC CRAWLER CRANE CK2500 HYDRAULIC CRAWLER CRANE CK2500 WITH OPTIONAL JIB Max. Lifting Capacity: 250 US Tons Max. Boom Length: 300 ft Max. Boom + Jib Length: 250 ft + 100 ft SPECIFICATIONS FOR CK2500 CRAWLER CRANE The Kobelco

More information

LIFTING CHARTS - Conventional Truck Cranes AMERICAN MODEL TON CAPACITY

LIFTING CHARTS - Conventional Truck Cranes AMERICAN MODEL TON CAPACITY LIFTING CHARTS - Conventional Truck Cranes AMERICAN MODEL - 125 TON CAPACITY 1 LIFT RATINGS With Tubular Hammerhead and "K-F-L-M" Counterweight (34,000 lbs.) Min 11 82.8-91090 250000 250000 47 10 12 81.3-87730

More information

Specifications LS-248H II. 200-Ton ( metric ton) Hydraulic Lattice Boom Crawler Crane

Specifications LS-248H II. 200-Ton ( metric ton) Hydraulic Lattice Boom Crawler Crane Specifications Hydraulic Lattice Boom Crawler Crane LS-248H II 200-Ton (181.50 metric ton) Shown with side frame auxiliary counterweights. Not to Scale General dimensions feet meters Basic boom length

More information

MANTIS 6010 LOAD CHART 80'-0 STANDARD BOOM LOAD CHART. MANTIS Model 6010

MANTIS 6010 LOAD CHART 80'-0 STANDARD BOOM LOAD CHART. MANTIS Model 6010 LOAD CHART Limitations and General Conditions. This MANTIS CRANE as manufactured by Tadano Mantis Corporation meets the requirements of ASME B30.5. Structure and stability have been tested in accordance

More information

Load Chart Exercise Workbook

Load Chart Exercise Workbook Load Chart Exercise Workbook (508) 212-4735 Copy Right 2017 For Exam Use Only BRODERSON IC-80-2D RATED LIFTING CAPACITIES IN POUNDS LOAD RADIUS IN FEET 5 6 8 10 12 14 16 18 20 22 24 26 28 30 32 34 ON RUBBER

More information

LIFTING CHARTS - Crawler Cranes AMERICAN MODEL TON CAPACITY

LIFTING CHARTS - Crawler Cranes AMERICAN MODEL TON CAPACITY LIFTING CHARTS - Crawler Cranes AMERICAN MODEL 7260-100 TON CAPACITY 7260 1 LIFT RATINGS with Tubular Chord Hammerhead and "S-S" Counterweight (49,700 lbs.) (15,150 kg.) () From 11 82.8 200000 46 8 12

More information

LOAD CHARTS MANTIS 6010LP 30 TON TELE-BOOM CRAWLER CRANE 1 V FT MAIN BOOM, 20 FT EXTENSION & 20 FT JIB

LOAD CHARTS MANTIS 6010LP 30 TON TELE-BOOM CRAWLER CRANE 1 V FT MAIN BOOM, 20 FT EXTENSION & 20 FT JIB 0 FT MAIN BOOM, FT EXTENSION & FT JIB in in in in 1 LIFTING CAPACITIES IN THOUSANDS OF POUNDS; 3, % OF TIPPING, FIRM & LEVEL GROUND MAIN BOOM with TRACKS FULLY EXTENDED 11,0 lb COUNTERWEIGHT ZERO COUNTERWEIGHT

More information

47,000 Ib ( kg) maximum lifting capacity. 101 (30.78 m) maximum sheave height. 144 (43.89 m) maximum sheave height with (

47,000 Ib ( kg) maximum lifting capacity. 101 (30.78 m) maximum sheave height. 144 (43.89 m) maximum sheave height with ( Boom Truck Crane TRUCK CRANE FEATURES 47,000 Ib (21 319 kg) maximum lifting capacity 101 (30.78 m) maximum sheave height 144 (43.89 m) maximum sheave height with 26-44 (7.92-13.41 m) jib 29-92 (8.84-28.04

More information

RTC ton (90 metric ton)

RTC ton (90 metric ton) Telescopic Boom Rough Terrain Crane RTC 80100 100 ton (90 metric ton) 40 1.63 (12.23 m) 47 10 (14.58 m) C L Rotation 8 6.56 (2.61 m) 13 3.38 (4.05 m) 13 9 (4.19 m) 15 2 (4.62 m) Link Belt 12 2.5 (3.71

More information

MANTIS 200RS LOAD CHART 54'-0 STANDARD BOOM LOAD CHART. MANTIS Model 200RS

MANTIS 200RS LOAD CHART 54'-0 STANDARD BOOM LOAD CHART. MANTIS Model 200RS LOAD CHART Limitations and General Conditions. This MANTIS CRANE as manufactured by SpanDeck, Inc., meets the requirements of ANSI B30.5 (2000), (When specifically equipped). Structure and stability have

More information

To learn more about this model, call or visit giuffre.com today! GIUFFRE.COM. 34,000 Ib ( kg) maximum lifting capacity

To learn more about this model, call or visit giuffre.com today! GIUFFRE.COM. 34,000 Ib ( kg) maximum lifting capacity Boom Truck Crane TRUCK CRANE FEATURES 34,000 Ib (13 607 kg) maximum lifting capacity 80 (24.38 m) maximum sheave height 120 (36.57 m) maximum sheave height with 24-40 (7.31-12.19 m) jib 27-70 (82.30-21.34

More information

Max. Lifting Capacity: 100 US Tons Max. Boom Length: 200 ft Max. Boom + Jib Length: 190 ft + 60 ft

Max. Lifting Capacity: 100 US Tons Max. Boom Length: 200 ft Max. Boom + Jib Length: 190 ft + 60 ft HYDRAULIC CRAWLER CRANE Max. Lifting Capacity: 100 US Tons Max. Length: 200 ft Max. + Jib Length: 190 ft + 60 ft SPECIFICATIONS FOR CK1000-III CRAWLER CRANE The Kobelco CK1000-III Crawler Crane is designed

More information

Technical Data. Specifications & Capacities. Telescopic Crawler Crane S5. 50 Ton (51mt Export Machine)

Technical Data. Specifications & Capacities. Telescopic Crawler Crane S5. 50 Ton (51mt Export Machine) 1 5646-0314-S5 Technical Data Specifications & Capacities Telescopic Crawler Crane Ton (51mt Export Machine) CAUTION: This material is supplied for reference use only. Operator must refer to in-cab Crane

More information

LS-308H II. HYLAB Series. Lattice Boom Crawler Crane

LS-308H II. HYLAB Series. Lattice Boom Crawler Crane LS-308H II HYLAB Series Lattice Boom Crawler Crane 110-ton (99.79 mt) 110-ton (99.79 mt) at 12' (3.66 m) radius Powerhouse package: - 1-1/8" wire rope, front & rear drums - 37,100 lbs (16 828 kg) allowable

More information

MANITOWOC (Crawler Mount) LOAD CHART

MANITOWOC (Crawler Mount) LOAD CHART For Use in CCO Written Examinations MANITOWOC (Crawler Mount) LOAD CHART LATTICE BOOM CRAWLER CRANE (LBC) These charts have been adapted from the original manufacturer s charts for use in CCO Written Examinations.

More information

LOAD CHART MANUAL FOR RT75 ROUGH TERRAIN CRANE

LOAD CHART MANUAL FOR RT75 ROUGH TERRAIN CRANE Address:Quantang Indust=rial Park, 2nd Yuanda Road, Changsha Economic and Technological Development Zone, Hunan Province, China Postcode: 410131 Website: www.zoomlion.com LOAD CHART MANUAL FOR RT75 ROUGH

More information

ON & OFF THE ROAD OR RAIL REACHNG NEW HEIGHTS AND WORKING HARDER THAN EVER.

ON & OFF THE ROAD OR RAIL REACHNG NEW HEIGHTS AND WORKING HARDER THAN EVER. ON & OFF THE ROAD OR RAIL REACHNG NEW HEIGHTS AND WORKING HARDER THAN EVER. For more than a half-century, the Little Giant Corporation has been a name synonymous with the railroad industry in producing

More information

Working Range Diagram

Working Range Diagram LIFTING CHARTS - Hydraulic Truck Cranes LINK-BELT MODEL - 75 TON CAPACITY Working Range Diagram Working Range Diagram 40 20 2 190 180 61 Fly + 115 170 160 10 8.5 61 Fly + 95 36.5 Fly + 115 150 140 36.5

More information

PRELIMINARY. 45 ton (40.8 mt) Telescopic Crawler Crane STANDARD FEATURES:

PRELIMINARY. 45 ton (40.8 mt) Telescopic Crawler Crane STANDARD FEATURES: PRELIMINARY 45 ton (40.8 mt) Telescopic Crawler Crane STANDARD FEATURES: 33 ft to 105 ft (10.06 m to 32.00 m) full power main boom 197 hp Tier 3 Isuzu 4HK-T3 Main drum available line pull - 19,108 lbs

More information

HC 275 CAL CRANE & EQUIPMENT. Tel: 1 (844) Fax: 1 (510)

HC 275 CAL CRANE & EQUIPMENT. Tel: 1 (844) Fax: 1 (510) CAL CRANE & EQUIPMENT Tel: 1 (844) 882-2415 Fax: 1 (510) 639-53 crane-sales@calcrane.com www.calcrane.com Demag 275 tons (249.5 m) maximum lift capacity Power up/down and freefall on main and auxiliary

More information

LINK-BELT. These charts are not to be used for any other purpose. LOAD CHARTS for Use in CCO Written Examinations

LINK-BELT. These charts are not to be used for any other purpose. LOAD CHARTS for Use in CCO Written Examinations LOAD CHARTS for Use in CCO Written Examinations LINK-BELT TELESCOPIC BOOM CRANE SWING CAB (TLL) These charts have been adapted from the original manufacturer s charts for use in NCCCO Written Examinations.

More information

Off the truck and ready for work! Transports in one load with counterweights

Off the truck and ready for work! Transports in one load with counterweights -ton (51 mt) Telescopic Crawler Crane Off the truck and ready for work! Transports in one load with counterweights 115' 6" (35.2m) maximum main boom tip height Four section, full power boom Remarkable

More information

Lifting Capacities Pounds ( boom)

Lifting Capacities Pounds ( boom) RT6 ( 111 boom) 0 5 1 ON OUTRIGGERS - FULLY EXTENDED LENGTH FT LENGTH FT LENGTH 66 FT OVER OVER OVER FRONT 3 FRONT 3 FRONT 3 REF. (LB) (LB) REF. (LB) (LB) REF. (LB) (LB) 67.1 1,000* 1,000* 74.1,0*,0* 63.6

More information

model 5500 product guide contents 55 ton Lift Capacity Maximum Load Moment 160' Heavy-Duty Boom on Heavy-Duty Boom 213 HP engine 338 fpm line speed

model 5500 product guide contents 55 ton Lift Capacity Maximum Load Moment 160' Heavy-Duty Boom on Heavy-Duty Boom 213 HP engine 338 fpm line speed 55 ton ift Capacity ft-kips,28 Maximum oad Moment product guide ' eavy-duty Fixed Jib ' on eavy-duty 23 P engine 338 fpm line speed 35,000 lb Maximum ine Pull lb Material Rehandling 5,0 Clamshell capacity

More information

Series I300 Hydraulic Crane

Series I300 Hydraulic Crane Series 3 Hydraulic Crane 3 Ton Load Ratings AN UNTRANED OPERATOR SUBJECTS HMSELF AND OTHERS TO DEATH OR SEROUS NJURY YOU MUST NOT OPERATE THS CRANE UNLESS You have been trained in the safe operation of

More information

HC 80. Hydraulic Crawler Crane. simple, available and cost effective FEATURES

HC 80. Hydraulic Crawler Crane. simple, available and cost effective FEATURES HC 80 Hydraulic Crawler Crane FEATURES 80 tons (73 mt) max lift capacity 200 ft. (61 m) max lift crane boom length 170+60 ft. (52+18 m) max lift crane boom & jib length 240 ft. (73 m) max boom & luffing

More information

Lifting Capacities Pounds (30 94 boom)

Lifting Capacities Pounds (30 94 boom) RT335 LENGTH 30-94 FT. ON OUTRIGGERS FULLY EXTENDED LENGTH 30 FT LENGTH 39 FT LENGTH 50 FT ED ED ED 10 63.0 70,000* 70,000* 69.4 46,600* 46,600* 10 12 58.5 60,800* 60,800* 66.2 46,600* 46,600* 71.7 46,600*

More information

250 ton (226.8 mt) Lattice Crawler Crane

250 ton (226.8 mt) Lattice Crawler Crane 250 ton (226.8 mt) Lattice Crawler Crane 365 hp Tier III Engine Transport weight is 87,100lbs with carbody, live mast with self assemble cylinder, and hoist rope HSL counterweight removal system, lowers

More information

Hydraulic Crawler Crane

Hydraulic Crawler Crane Hydraulic Crawler Crane Model : BMS1000 Max. Lifting Capacity: 100 t x 3.8 m Max. Crane Boom Length: 62.6 m BMS1000 CONTENTS 3 SPECIFICATIONS 5 6 8 9 10 11 12 13 14 1 GENERAL DIMENSIONS BOOM AND JIB ARRANGEMENTS

More information