QUICK REFERENCE LEVELING SYSTEM IDENTIFICATION MOTORIZED VEHICLES MANUAL LEVER CONTROLLED LEVELING SYSTEMS

Transcription

1 COPOATI COPOATI COPOATI COPOATI COPOATI COPOATI u s f e e f u s s u e f QUICK EFEENCE ING SYSTEM IDENTIFICATI MOTOIZED VEHICLES MANUAL LEVE CTOLLED ING SYSTEMS 100 SEIES - Single lever control for each jack Single slot in the valve bezel plate for each lever Indicator lights are on a plate mounted seperate from the valve UNDESTAND OPEATO S MANUAL BEFOE USING. BLOCK FAME AND TIES SECUELY BEFOE EMOVING TIES O CAWLING UNDE VEHICLE. F VAIATIS OF SEPAATE INDICATO S AULIC F ING AULIC F ING EZE LIGHT SYSTEM EZE LIGHT SYSTEM 100 SEIES - USES SEPAATE LIGHT PANELS AMP WANING F UNDESTAND OPEATO S MANUAL BEFOE USING. BLOCK FAME AND TIES SECUELY BEFOE EMOVING TIES O CAWLING UNDE VEHICLE. NO AMP F WANING UNDESTAND OPEATO S MANUAL BEFOE USING. BLOCK FAME AND TIES SECUELY BEFOE EMOVING TIES O CAWLING UNDE VEHICLE. WITH HW H F WANING LIGHT SYSTEM HCOPOATIH W F WANING LIGHT SYSTEM OLDE STYLE S 110 SEIES - Single lever control for each jack Single slot in the valve bezel plate for each lever Indicator lights are part of the slotted bezal plate covering the valve AULIC ING AULIC ING ING WANING F F 110 SEIES - USE INTEGATED S ING F WANING F UNDESTAND OPEATO S MANUAL BEFOE USING. BLOCK FAME AND TIES BEFOE EMOVING TIES O CAWLING UNDE VEHICLE. NO UNDESTAND OPEATO S MANUAL BEFOE USING. BLOCK FAME AND TIES BEFOE EMOVING TIES O CAWLING UNDE VEHICLE. WITH 200 SEIES - Single joystick control for all four jacks One front and one rear store lever Valve bezel plate has a cross slot Indicator lights are on a plate mounted separate from the valve AULIC ING LEFT FT IGHT OPEATE AULIC ING AULIC ING EA FT EA NO WITH OPEATE "CAUTI" UNDESTAND OPEATO S MANUAL BEFOE USING. BLOCK FAME AND TIES SECUELY BEFOE EMOVING TIES O CAWLING UNDE VEHICLE. 200 SEIES - USES SEPAATE ML4026/MI94.081

2 QUICK EFEENCE ING SYSTEM IDENTIFICATI MOTOIZED VEHICLES MANUAL LEVE CTOLLED ING SYSTEMS (CTINUED) 210/22 SEIES - Single joystick control for all four jacks AULIC ING One front and one rear store lever OPEATE Valve bezel plate has a cross slot FT Indicator lights are on the valve bezel plate 210 has mercury style level sensor 22 has electronic level sensor LEFT EA IGHT FT EA OPEATE UNDESTAND OPEATO S MANUAL BEFOE USING. BLOCK FAME AND TIES SECUELY BEFOE EMOVING TIES O CAWLING UNDE VEHICLE. 210/22 SEIES - USE INTEGATED MANUAL TOUCH PANEL CTOLLED ING SYSTEMS 310 SEIES ( ) - Touch panel heading is " AULIC ING" Control Box is x 4-1/4" x 7-1/2" Touch panel with a rabbit at the bottom is for vehicles with pilot air dump 4-1/2" AULIC ING AULIC ING TOUCH PANEL - NO TOUCH PANEL - WITH 310 SEIES CTOL BOX 7-1/2" 32 SHOTBOAD SEIES ( ) - SHOTBOAD Touch panel heading is " AULIC ING" Touch panel does NOT have " " indicator light Touch panel has four connectors and one 3 amp fuse on the back Control Box has 8" x 11" clear plastic cover TOUCH PANEL - O NO AULIC ING CTOL BOX ELECTICAL SENSO 3AMP MI94.083

3 QUICK EFEENCE ING SYSTEM IDENTIFICATI MOTOIZED VEHICLES MANUAL TOUCH PANEL CTOLLED ING SYSTEMS (CTINUED) 32 LGBOAD SEIES ( PESENT) - LGBOAD Touch panel heading is " AULIC ING" Touch panel has a " " indicator light Touch panel has one five pin connector on the back Control Box has 8" x 11" clear plastic cover TOUCH PANEL - AULIC ING TOUCH PANEL - NO AULIC ING SINGLE CNECTO CTOL BOX ELECTICAL SENSO AUTOMATIC "COMPUTEIZED" ING SYSTEMS 400 SEIES - Panel is equipped with paddle switches Panel is available in standard or BI-Axis Some panels may be labeled A&E 400 Series looks like no other system MASTE MANUAL OPEATI AUTOMATIC ING HOIZTAL EMEGENCY AUTOMATIC VETICAL BLOCK FAME SECUELY BEFOE CHANGING TIES O WOKING UNDE VEHICLE COPOATI LEFT EA LEFT FT IGHT FT IGHT EA MASTE EMEGENCY AUTOMATIC ING HOIZTAL COPOATI AUTOMATIC VETICAL MANUAL OPEATI BLOCK FAME SECUELY BEFOE CHANGING TIE O WOKING UNDE VEHICLE. MANUAL USE LIMITED TO 4 MIN. WITHOUT COOL DOWN. SWITCHES & EZE INDICATOS LEFT SIDE FT IGHT SIDE EA TO PEVENT DAMAGE FOM OVEHEATING DO NOT SWITCH FO MOE THAN TWO OUT OF EVEY FOU MINUTES. LEFT EA LEFT FT IGHT FT IGHT EA JACK DOWN INDICATOS STANDAD BI-AXIS 00 SEIES - Panel heading is COMPUTEIZED ING Used for Air Leveling or combination Air/Hydraulic Leveling Connecting cable between the control box and Touch Panel is a 2" wide, flat, 40 pin ribbon cable Control box is 3-1/2" x 9" x 14-1/2" 9" 14-1/2" COMPUTEIZED ING AI PAK AISE 40 PIN CNECTO 3-1/2" GLASS O BLADE STYLE S MAY BE FOUND IN A 00 SEIES CTOL BOX MI94.08

4 QUICK EFEENCE ING SYSTEM IDENTIFICATI MOTOIZED VEHICLES AUTOMATIC "COMPUTEIZED" ING SYSTEMS (CTINUED) 10 SEIES - Panel heading is COMPUTEIZED ING Hydraulic leveling systems only Control Box is x 4-1/4" x 6-1/2" Connecting cable between the Control Box and Touch Panel was a 2" wide, flat, 40 pin ribbon cable (early models) or a 3/8" wide flat 8 wire ribbon cable The hydraulic pump and manifold are separate units connected with a high pressure hose and return line 4-1/2" COMPUTEIZED ING AUTO PAK / PIN CNECTO O 8 WIE CNECTO SEIES CTOL BOX 6-1/2" 600 SEIES - Panel heading is COMPUTEIZED ING Used for Air Leveling or combination Air/Hydraulic Leveling Connecting cable between the control box and Touch Panel is a 3/8" wide, flat, 8 wire ribbon cable Control box is 3-1/2" x 9" x 14-1/2" 9" 14-1/2" AUTOMOTIVE TYPE BLADE S COMPUTEIZED ING AI PAK AISE 8 WIE CNECTO 3-1/2" LY BLADE STYLE S WILL BE FOUND IN A 600 SEIES CTOL BOX 610 SEIES - Panel heading is COMPUTEIZED ING Control Box is x 4-1/2" x 6-1/2" Connecting cable between the Control Box and Touch Panel is a 3/8" wide flat 8 wire ribbon cable The warning switch harness at each jack has one plug only. It may be a one wire or two wire connector The pump and manifold are one assembly 4-1/2" COMPUTEIZED ING AUTO PAK WIE CNECTO SEIES CTOL BOX 6-1/2" MI94.087

5 QUICK EFEENCE ING SYSTEM IDENTIFICATI MOTOIZED VEHICLES AUTOMATIC "COMPUTEIZED" ING SYSTEMS (CTINUED) 610 CENTAL GOUND SEIES - Panel heading is COMPUTEIZED ING Control Box is x 4-1/2" x 7-1/2" Connecting cable between the Control Box and Touch Panel is a 11 pin cable assmebly The warning switch harness at each jack has two plugs. One single wire and one two wire connector The pump and manifold are one assembly 4-1/2" COMPUTEIZED ING PAK 11 PIN CNECTO CENTAL GOUND SEIES CTOL BOX 7-1/2" 62 SEIES - Panel heading is COMPUTEIZED ING Control Box has an 8" x 11" clear plastic cover and is mounted to the pump tray Lower middle green indicator light is labeled " MODE" not "" The jack warning switch plugs are gray Used for hydraulic leveling only COMPUTEIZED ING PAK MODE PESENT PIN CNECTO CTOL BOX ELECTICAL SENSO 62S SEIES - Panel heading is COMPUTEIZED ING Control Box has an 8" x 11" clear plastic cover and is mounted to the pump tray Lower middle green indicator light is labeled " MODE" not "" The jack warning switch plugs are gray Used for hydraulic leveling only Touch Panel has an outline around the manual UP and DOWN arrows COMPUTEIZED ING AUTO AUTO MANUAL EMEGENCY STOP MODE 6 PIN CNECTO MAY NOT BE PESENT PIN CNECTO CTOL BOX ELECTICAL SENSO 2006 MI94.089

6 QUICK EFEENCE ING SYSTEM IDENTIFICATI MOTOIZED VEHICLES AUTOMATIC "COMPUTEIZED" ING SYSTEMS (CTINUED) 680 SEIES - Panel heading is COMPUTEIZED ING Used for Air Leveling or combination Air/Hydraulic Leveling Connecting cable between the control box and Touch Panel is a 2/8" wide, flat, 8 wire ribbon cable Control box is 3-1/2" x 14-1/2" x 19" 14-1/2" COMPUTEIZED ING AI 19" AISE 8 WIE CNECTO CTOL BOX IS 3-1/2" DEEP 2000 SEIES - Panel heading is COMPUTEIZED ING Use for Air Leveling or combination Air/Hydraulic Leveling Control Box has an 8" x 11" clear plastic cover, boxes are stacked Lower middle green indicator light is labeled " MODE" not "" COMPUTEIZED ING AI MODE EMEGENCY STOP AISE MODE PESENT PIN CNECTO CTOL BOX ELECTICAL SENSO MI94.091