Engine Mini-29 v4 VERSION SPARE PARTS MANUAL

Transcription

1 8817 Engine Mini-29 v4 VERSION SPARE PARTS MANUAL

2 PARTS LIST CATALOGUE NORMS TO PLACE AN ORDER: For fast and more efficient service, please specify the following information on spare parts orders that must be preferably done by FAX or as specified below: 1- Engine model: As shown in identification plate 2- Engine serial number: As shown in identification plate and stamped on crankcase 3- Item description + part number + quantity required Spare parts requests must be adressed to: recambios@solediesel.com Telf.: Fax: The components shown in the catalog have: - Figure: Number by which they are represented in scheme - Description: Trade name of the component - Quantity: Total number of parts used in the assembly of the part represented (may differ from the total minimum quantities) Hoses, indicates the total length in meters The diagrams shown in this catalog of spare parts, have only the purpose to identify the piece in question, its representation is not meaningful and may differ from the actual piece. In case of doubt, contact Solé Diesel, or your authorized dealer. The parts i / or references in this catalog are subject to change without notice. SOLÉ, S.A. C-243b, Km, 2 - P.O. BOX Martorell (Barcelona) Spain Download the latest version of this manual HERE

3 Contents Engine Body Repair Kit Water Pump 1/2" Kit 2nd Alternator 14V/90A Cylinder Head Kit Wire Earth Isolated Alternator 14V/7 Rocker Cover and Breather Gearbox TMC-40P Kit Water Leak Sensor & Alarm SP60 12V Valve Drive Sheet 1/2 Timing Parts Sheet 2/2 Other Kits Gear Case Maintenance Kit Motor Bracket Width 185/187 Cranckcase Motor Bracket Width 205 Rear Plate Gearbox TMC-60P Front Water Pomp MINI-17/29 Kit(Spline) Piston & Connectiong Rod Sheet 1/2 Boiler Kit (S) Crankshaft & Flywheel Sheet 2/2 Pression Gauge Kit Oil System Kit de Service Kit Trolling Valve for TM-345/A Oil Pan Engine Brackets Gearbox TMC-60A Exhaust System Sheet 1/2 Exhaust Flange (S) Inlet & Exhaust Sheet 2/2 Dry Exhaust SYStem, Elbow (S) Inlet Kit de Service Kit Dry Exh. Flexible Pipe & Silencer(S) Cooling System Kit Gearbox Power Take-off Pulley Water Pump Kit S-Drive VOLVO 130S Pulley 2B (S) Cooler Pipes Kit S-Drive VOLVO 120S Pulley 2A (S) Cooler Kit S-Drive VOLVO 100S Body, Water Cooler Kit S-Drive SD20 YANMAR Kit Keel Cooling Wet Exhaust Kit GearBox VOLVO MS-2 & MS-2B Kit Keel Cooling & Dry Exhaust (S) 1/2" Pump Water, Set Kit GearBox TMC-40P Version 4/5 1/2" Pump Water, Set Fuel System Kit GearBox RONIM-5 Kit S-Drive VOLVO 110S Kit S-Drive VOLVO 120SB/120SC/120SE Fuel Pipe Kit S-Drive BUKH DV10 & DV20 Injection Nozzle Kit Bobtail SAE-7 Fuel Injection Pump Kit GearBox TM-345/345A Governor Parts Kit GearBox ZF 15 MIV 4 V. Fuel Supply Parts Electrical System Kit Bobtail Kit GearBox TMC-60 MINI-29 Kit S-Drive SELVA Kit Alternator 14V/75A ISKRA Kit GearBox TMC/ZF/PRM Starter Assy Kit S-Drive TECHNO.SP60 Electrical Wiring Deluxe Instrument Panel SVT 20 MINI-17/29 Panel Instruments Panels Price Supplement Panel TE3 MINI-17/29 SVT 30 MINI-17/29 Panel Kit 2nd Panel TE4 MINI-17/29 12V Maintenance Kit Kit Gasket Pipe Rubber Set,Water LINE 4 V. Kit Gasket Electrical System Kit 2nd Alternator 28V/55A Kit Alternator 14V/95A ISKRA Earth Isolated Alternator 14V/95A Kit 1

4 Engine Body D_MIB1_1_1 Cylinder Head A B C A B HANGER,Engine 1 Head Assy,Cylinder 1 Cap,SealING 3 Cap 6 Guide Valve 1 Gasket,Cylinder Head 8 Bolt,cylinder head 3 Bolt,cylinder head [NP] 2 Bolt DIN 933 M Washer GROWER DIN Plug TAPER [NP] Not provided

5 Engine Body D_MIB1_1_2 Rocker Cover and Breather Cover Assy,Rocker 1A Rocker Cover Gasket Nut Washer DIN Cap Oil FILLER Hose BREATHER [NP] Not provided

6 Engine Body D_MIB1_1_3 Valve Drive Cap Stem 2 (*) 1 Not available [NP] 2A Shaft Assy,Rocker 2B Bracket,Rocker Shaft 2C ARM,Rocker Inlet 2D ARM,Rocker Exhaust 2E Pin GROOVED 2F Spring Rocker SHAFT 2G Nut DIN 934 M H CIRClip DIN 471 E-12 2I Screw Adjusting Intake Valve Exhaust Valve Retainer Valve SP LOCK Valve Seal Valve Stem Bolt,Rocker STAY Tappet ROD PUSH Bolt DIN 931 M Washer GROWER DIN Washer Spring,Valve [NP] Not provided

7 Engine Body D_MIB1_1_4 Timing Parts Washer CamShaft Stop Bearing Ball CamShaft KEY CIRClip DIN 471 E Bearing Ball Shaft,fuel injection pump cam Key, Sunk Ball Bearing 6005-C Shaft Fuel Injection Pump [NP] G 1 Gear Oil Pump CIRClip DIN 471 E Plate DISTANCE 14 (*) 1 Not available [NP] Gear Assy,IDLER Z= Gear,Fuel INJ.Pump Z= Bolt DIN 933 M [NP] Not provided

8 Engine Body D_MIB1_1_5 Gear Case Cap SealING (20) Case Gear 2A Plug TAPER 2B (*) 1 Not available [NP] 2C Plug 2D Housing Oil Pump 2E Bolt,W/Washer 2F Plug 2G Washer ,5 [NP] 2H Plunger 2I Spring RELIEF 2J Gear Oil Pump INN 2K Gear Oil Pump OUT Gasket Gear Case [NP] Oil Seal Bolt DIN 933 M Bolt DIN 933 M Bolt DIN 933 M CINCADO 8A Bolt DIN 933 M B Washer GROWER DIN O-Ring D. 11X2, Housing Pump Gear Gasket Housing Cap Oil FILLER 12B O-Ring D. 30X Bolt, w/washer Stud L Nut M Washer GROWER DIN Stud L 54 [NP] Not provided

9 Engine Body D_MIB1_1_6 Cranckcase Adaptor,fuel pump Gasket Cover Block SUB Assy,CYL [NP] 4A Bolt Bearing Cap 4C (*) 1 Not available [NP] 4D Cap Sealing 4E Cap,SealING Plug Taper 1/ Pin Dowel Shaft IDLER Guide Pin Plug, Expansion Bushing Bushing BUSHING,KNOCK Bushing Plug TAPER Seal Side Plate, Front Case, Oil Seal [NP] Gasket Front Plate [NP] Gasket Oil Seal C Seal Oil Shaft Oil Filter Plug TAPER Bolt DIN 933 M A Bolt DIN 933 M B Washer GROWER DIN Bolt DIN 933 M Bolt Stud [NP] Not provided R 1 Gauge Oil LEVEL Bearing Set CRANK STD Bearing Set CRANK +0,

10 Engine Body D_MIB1_1_6 Cranckcase Bearing Set CRANK

11 Engine Body D_MIB1_1_7 Rear Plate Bolt,w/washer Plate REAR Pin KNOCK (8X10)

12 Engine Body D_MIB1_1_8 Piston & Connectiong Rod Piston &Pin Set Piston & Pin Set Piston & Pin Set Ring Set,Piston STD Ring Set,Piston O.S Ring Set,Piston O.S ROD Assy 7A (*) 6 Not available [NP] 7C Nut,connecting rod 7D Bolt,connecting rod Bearing Set,CON-ROD STD Bearing Set,Con-Rod U.S Bearing Set,Con-Rod U.S [NP] Not provided

13 Engine Body D_MIB1_1_9 Crankshaft & Flywheel CrankShaft (up to eng.nº 31854) Pulley CrankShaft Gear CrankShaft Z= Nut Washer DIN C 1 Washer KEY Flywheel Assy 8A (*) 1 Not available [NP] 8B Gear Ring Z=106 [NP] Bolt Flywheel [NP] Not provided

14 Engine Body D_MIB1_1_10 Oil System Filter Oil Element SWITCH Assy Nut DIN 936 M14X1,5 5.6 ZINC SCREEN Assy Oil

15 Engine Body D_MIB1_1_11 Oil Pan PAN Assy,Oil Gasket Oil PAN 3A Bolt DIN 933 M B Washer GROWER DIN Bracket, Pipe Bolt DIN 912 M12-1, Washer DIN REC 1 ExtraCTION,Hose 7A ExtraCTION, hose [NP] 7B Plug 7C Coupling,screw 7D Washer ,5 7E Washer Pump,oil Suction [NP] Not provided

16 Engine Body D_MIB1_1_12 Engine Brackets Bracket Front, Left 08/07/ Washer GROWER DIN Bolt DIN 912 M10-1, RIGHT, front bracket 08/07/ Anti Vibration Mount Type A 50SHA

17 Inlet & Exhaust D_MIB1_2_1 Inlet CABLE Holder Ball Ball JOINT Washer GROWER DIN Nut DIN 934 M Bracket, Engine Control Bolt DIN 933 M Washer DIN Bolt DIN 86 W3/ Clamp,cable BEND Air Filter Assy without filter element 14/02/ Filter Air Complete 15/02/ Cover Assy Intake 12A Pipe Gasket Intake COV Bolt DIN 933 M Bolt DIN 931 M Gasket

18 Cooling System D_MIB1_3_1 Water Pump Pulley Water Pump 3A Bolt DIN 933 M Pump Assy Water Gasket Water Pump Bolt DIN 933 M Bolt DIN 933 M Bolt DIN 931 M Bolt DIN 933 M Thermostat 71º Gasket Water OutL FITTING Thermostat New [NP] Gasket Thermostat Bolt DIN 933 M Bolt DIN 931 M Pipe BYPASS O-Ring D. 9X Copper Washer , Thermo-Switch 97ºC Temperature Sensor Cover Washer GROWER DIN Bolt Bolt DIN 931 M [NP] Not provided

19 Cooling System D_MIB1_3_4 Cooler Pipes 1 M ,75 Water Intake Hose (HQ) D Clamp DIN /9 W Raccord 1/2" Nut M8 5A Washer DIN B Washer GROWER DIN Pump Bracket /2" Pump Water, Set [NP] 22/05/ /2" Pump Water, Set 22/05/ Bolt DIN 931 M Washer GROWER DIN Cover Gasket Water OutL Clamp DIN /9 W Pipe Elbow Pipe O-Ring D. 57X Cooler MANIFOld,mounting stud Washer , Nut DIN 1587 M Elbow,WET Exhaust Hose Gasket, Exhaust Stud,cover Exhaust Manifold Outlet Bend Washer DIN 6798-A Nut DIN 934 M8 [NP] Not provided

20 Cooling System Cooler Body, Water Cooler [NP] 13/06/ Cap Raccord 1/2" Cover, water cooler O-Ring D. 57X2, Stud,cover Washer DIN Washer GROWER DIN Nut DIN 934 M Element,Water Cooler Plug Copper Washer , Plug [NP] Not provided

21 Cooling System C Body, Water Cooler Body, Water Cooler [NP] 13/06/ Cap Plug Copper Washer , Plug Plate "SOLE Diesel" [NP] Bolt [NP] Not provided

22 Cooling System D_MIB1_3_5 Wet Exhaust Elbow,WET Exhaust Gasket Bolt DIN 912 M Washer GROWER DIN

23 Cooling System /2" Pump Water, Set Bolt DIN 933 M5-10 INOX Cover Pump /2" Impeller Gasket Cover Bolt DIN 86 W3/ Cam Wearplate Shaft,Water Pump Spacer CIRClip DIN 472 I Ball Bearing 6002-C Seal O-Ring D. 15X Seal Body,Water Pump Pin,Dowel

24 Cooling System /2" Pump Water, Set Bolt DIN 933 M6-10 INOX Cover Pump O-Ring D. 57x1, /2" Impeller Plate, Friction Shaft,Water Pump Seal O-Ring D. 15X Body, Water Pump 1/2" Seal Ball Bearing 6002-C Spacer CIRClip DIN 472 I

25 Fuel System D_MIB1_4_1 Fuel Pipe Pipe Injection N Pipe Injection N Pipe Injection N Nut Tube Gas-Oil SPILL Injector Gasket Injector Washer 8A Bolt DIN 933 M B Washer GROWER DIN Shim Adjusting T=0,2MM. [NP] [VAR] Shim Adjusting T=0,3MM. [NP] [VAR] Shim Adjusting T=0,3MM. [VAR] Shim Adjusting T=0,4MM. [VAR] Shim Adjusting T=0,6MM. [VAR] Shim Adjusting T=0,7MM. [NP] [VAR] Shim Adjusting T=0,8MM. [VAR] Shim Adjusting T=0,9MM. [VAR] Shim Adjusting T=1,0MM. [NP] [VAR] [NP] Not provided [VAR] Variable according to repair

26 Fuel System D_MIB1_4_2 Injection Nozzle Nozzle & Holder A 1A (*) 3 Not available [NP] 1BA Washer 1,25 [VAR] 1BB Washer 1,30 [VAR] 1BC Washer 1,35 [VAR] 1BD Washer 1,40 [VAR] 1BE Washer 1,45 [VAR] 1BF Washer 1,50 [VAR] 1BG Washer 1,55 [VAR] 1BH Washer 1,60 [VAR] 1BI Washer 1,65 [VAR] 1BJ Washer 1,70 [VAR] 1C Spring, pressure 1D Pin Pressure 1E PIECE DISTANCE 1F Nozzle Assy 1G Nut, Nozzle RETAINING [NP] Not provided [VAR] Variable according to repair

27 Fuel System D_MIB1_4_3 Fuel Injection Pump Housing SUB Assy Holder,DELIVERY O-Ring D. 14X1, Spring Gasket DELIVERY V Valve SUB Assy Element SUB Assy SLEEVE SUB Assy Seat Pump Assy,Fuel Injection Spring Seat 12A Plate Tappet Shim 1,85 [VAR] 12B Plate Tappet Shim 1,90 [VAR] 12C Plate Tappet Shim 1,95 [VAR] 12D Plate Tappet Shim 2,00 [VAR] 12E Plate Tappet Shim 2,05 [VAR] 12F Plate Tappet Shim 2,10 [VAR] 12G Plate Tappet Shim 2,15 [VAR] 12H Plate Tappet Shim 2,20 [VAR] 12I Plate Tappet Shim 2,25 [VAR] 12J Plate Tappet Shim 2,30 [VAR] 12K Plate Tappet Shim 2,35 [VAR] 12L Plate Tappet Shim 2,40 [VAR] 12M Plate Tappet Shim 2,45 [VAR] 12N Plate Tappet Shim 2,50 [VAR] TAPPET Assy Screw Washer,DRAIN Screw Screw, Racord Nipple Swivel Washer,DRAIN Union [NP] Not provided Plate Set Screw,W/Washer [VAR] Variable according to repair RACK Assy Control [NP]

28 Fuel System D_MIB1_4_3 Fuel Injection Pump Screw Bracket Stop Wire Pin

29 Fuel System D_MIB1_4_4 Governor Parts Metal,Fuel Wire Bolt High Speed Bolt Stopper WEIGHT Assy,GOverNOR Shaft Assy,sliding Gasket Tie Rod CO ROD TIE Spring,TIE ROD Cover,Governor Gasket Governor Cover [NP] Cap TORQUE Set SE Cover TIE ROD Spring GOverNOR 16 (*) 1 Not available [NP] 16A Nut 16B RACK Set Screw (new) Lever Assy Governor Lever Assy TENSIO Shaft Governor Spring TIE ROD Lever Assy SPEED Lever Governor SP Spring START Pin GROOVED Bolt DIN 933 M Bolt Bolt DIN 933 M Bolt,W/Washer Nut Nut [NP] Not provided Washer GROWER DIN O-Ring D. 7X Cover,Governor Shaft

30 Fuel System D_MIB1_4_5 Fuel Supply Parts Pump MDF Nut Gasket,fuel pump ONE EAR Clamp With INTERIOR Ring Pump Hose Screw,eye Washer 14,2-20-1, Hose Gas-Oil Filter Element Cover,filter f/.smi Washer DIN Bolt DIN 933 M Bypass "T" ONE EAR Clamp With Interior Ring ,04 M. Hose ,31 M. Hose

31 Electrical System Kit Alternator 14V/75A ISKRA Alt. 14V/75A Pulley Plate V-Belt Spacer 17X28X5,5 09/09/ Spacer 8,5X20X Spacer 8,5x20x28 09/09/ Bolt DIN 931 M Washer DIN Washer GROWER DIN Nut DIN 934 M Bolt DIN 933 M Washer DIN Bolt DIN 933 M Bolt DIN 933 M CINCADO Washer DIN Washer GROWER DIN Spacer 6,5X12X Flag Receptable Faston Terminal Insulation Flag Protective 21 TR Ring Terminal 16 Sec. 22 TR Ring Terminal 1.5 Sec

32 Electrical System D_MIB1_5_5 Starter Assy Starter Assy 12 V Bolt DIN 933 M Washer GROWER DIN

33 Electrical System D_MIB1_5_7 Electrical Wiring Panel TE2 MINI-17/ Panel N FuseHolder, panel Fuse 10 A Key,Starter Switch Cover,KEY Key-Locking Tachometer MINI-17/ Integrated Circuit Plate 12V Protection 23/06/ Fuse 0.5A Bulb 12V R 1 Water Gauge 12 V Gasket Panel Glow Relay Relay 6V Washer DIN Bolt DIN 933 M Bolt DIN 933 M Washer DIN Engine Wiring Ext. 3 M. SUPERSEAL R.3 1 MINI-17/29 V3 Electrical Wiring Plate Glow Plug Plug,glow SOLENOID Nut (old) WIRINE

34 Electrical System D_MIB1_5_8 Deluxe Instrument Panel SVT 30 MINI-17/29 Panel (Repl.) [NP] Bulb 12V R 1 VOLTMETER 12 V Tachometer MINI-17/ R 1 Oil Pressure Gauge 12 V Bolt DIN 84 M3-8 INOX Fuse 0.5A Integrated Circuit Plate 12V Protection 23/06/ R 1 Water Gauge 12 V Gasket Panel Key-Locking Cover,KEY Panel N FuseHolder, panel Fuse 10 A Key,Starter Switch [NP] Not provided

35 Electrical System D_ SVT 20 MINI-17/29 Panel Panel N Integrated Circuit Plate 12V Protection Bolt DIN 84 M3-8 INOX MTG Bracket 3" LG GA AMEGA Nut 8-32 W/CapTIVE STAR Washer Connector MTG Bracket Key-Locking SOCKET,WEDGE BASE Bulb 12V Water Gauge 12 V Tachometer MINI-17/26 SVT Cover Plate for Motor Propeller Gasket Panel NS MICRO Relay 12V [NS] NS System Back Panel SVT/MVT 20 12V [NS] 07/12/2016 [NS] Not shown

36 Electrical System D_ SVT 30 MINI-17/29 Panel Bolt DIN 84 M3-8 INOX Key-Locking Connector Nut 8-32 W/CapTIVE STAR Washer SOCKET,WEDGE BASE Bulb 12V Panel N Gasket Panel Cover Plate for Motor Propeller Integrated Circuit Plate 12V Protection MTG Bracket 3" LG GA AMEGA MTG Bracket VOLTMETER 12V Tachometer MINI-17/26 SVT Water Gauge 12 V Oil Pressure Gauge 12V NS MICRO Relay 12V [NS] NS System Back Panel SVT/MVT 30 12V [NS] 07/12/2016 [NS] Not shown

37 Maintenance Kit D_ Kit Gasket Washer [NP] Gasket Water Pump [NP] Gasket [NP] Gasket,Cylinder Head Rocker Cover Gasket Gasket Cover [NP] Gasket Oil Seal C Gasket Front Plate Gasket Housing Kit Gasket Gasket Gear Case Gasket Oil PAN [NP] Gasket Gasket Intake COV Gasket Gasket Water Pump Gasket Thermostat Gasket,fuel pump Gasket Governor Cover Gasket Tie Rod CO Washer ,5 [NP] G.1 3 Gasket Fuel Return (Genset) Injector Washer Seal Valve Stem O-Ring D. 11X2, O-Ring O-Ring Gasket Thermostat Seal Side O-Ring D. 57X2, Gasket Gasket Cover [NP] Not provided

38 Maintenance Kit Pipe Rubber Set,Water LINE 4 V Pipe Pipe Hose 4 M ,75 Water Intake Hose (HQ) D

39 Maintenance Kit Kit Gasket Gasket,Cylinder Head 03/11/ Rocker Cover Gasket 03/11/ Gasket Intake COV 03/11/ Gasket, Exhaust 03/11/ Gasket Water OutL 03/11/

40 Maintenance Kit K Repair Kit Water Pump 1/2" /2" Impeller Gasket Cover Seal Seal O-Ring D. 15X2 NS O-Ring D. 57X3 [NS] [NS] Not shown

41 Gearbox TMC-40P D_5033_1 Sheet 1/ P 1 Box Gear Ratio 3: P 1 Cover Shim Washer Spacer Spacer Input Shaft INPUT Shaft Output INTERMEDIATE Shaft Nut Plug Clutch Gear Gear Gear R.2, Gear R.2, Flange Output P 1 Gauge CAGE Plug Oil Seal Bearing, needle Bearing, needle Ball Bearing Bearing Plane Washer Washer , Washer Washer Pin Bolt DIN 933 M [NS] Not shown Bolt DIN 7991 M Bolt DIN 912 M

42 Gearbox TMC-40P D_5033_1 Sheet 1/ Conical Roller Bearing Conical Roller Bearing 30205A NS Kit GasketS [NS]

43 Gearbox TMC-40P D_5033_2 Sheet 2/ Cover P 1 Cover Spring Shaft Plate, IDENTIFICATION ATF Oil Plate Pin Lever PAD Screw Plug,oil drain Oil Seal O-Ring Plane Washer Washer DIN [NP] Washer GROWER DIN [NP] Pin DIN Bolt DIN 912 M Bolt DIN 933 M P 2 Stud STUD Nut DIN 934 M8 8.8 [NP] Nut DIN 985 M8 5.6 [NP] Not provided

44 Gearbox TMC-40P D_5033_3 Maintenance Kit Kit GasketS 2 A ATF Sole Diesel Oil 1L

45 Gearbox TMC-60P D_5036_1 Sheet 1/ Cover Washer Spring Shaft Plate, IDENTIFICATION ATF Oil Plate Pin Lever Plug Plug Pad P 1 Gauge Screw Plug,oil drain Oil Seal O-Ring Washer DIN [NP] Washer GROWER DIN [NP] Pin DIN [NP] Bolt DIN 933 M [NP] Bolt DIN 912 M Bolt DIN 931 M STUD Nut DIN 934 M8 8.8 [NP] Nut DIN 985 M8 5.6 [NP] Not provided

46 Gearbox TMC-60P D_5036_2 Sheet 2/ P 1 Box Cover Spacer Spacer Shim Shim INTERMEDIATE Shaft Shaft Output 13A P 1 Input Shaft 13B P 1 Input Shaft 13C Input Shaft 13D P 1 Input Shaft Nut Nut Plug Clutch 25A Gear 25B Gear 25C Gear 25D Gear 26A Gear 26B Gear 26C Gear 26D Gear Gear Flange Output Nut CAGE Plug Ring A 1 Seal,oil BA [NP] Oil Seal [NP] Not provided Bearing, needle Washer Plane Washer

47 Gearbox TMC-60P D_5036_2 Sheet 2/ Washer , Washer DIN [NP] Washer GROWER DIN [NP] Washer Pin Conical Roller Bearing Conical Roller Bearing J2/Q Nut

48 Gearbox TMC-60P D_5035_3 Kit de Service Gasket Kit 2 A ATF Sole Diesel Oil 1L

49 Gearbox TMC-60A D_5034_1 Sheet 1/ A 1 Box A 1 Cover Spacer Spacer Shim Shim INTERMEDIATE Shaft Shaft Output 12A Input Shaft 12B A 1 Input Shaft Nut Nut Clutch Gear 23A A 1 Gear 23B A 1 Gear A 1 Gear [NP] Flange Output Nut CAGE Plug Ring Seal,oil BA Seal,oil Bearing, needle Washer Washer , Washer DIN Washer GROWER DIN Washer Pin Conical Roller Bearing [NP] Not provided Conical Roller Bearing J2/Q Nut

50 Gearbox TMC-60A D_5034_2 Sheet 2/ Cover Spring Shaft Plate, IDENTIFICATION ATF Oil Plate Pin Lever Plug Pad P 1 Gauge Screw Plug,oil drain Oil Seal O-Ring Plane Washer Washer DIN Washer GROWER DIN Pin DIN Bolt DIN 933 M Bolt DIN 912 M Bolt DIN 931 M STUD Nut DIN 934 M Nut DIN 985 M

51 Gearbox TMC-60A D_5035_3 Kit de Service Gasket Kit 2 A ATF Sole Diesel Oil 1L

52 Kit Gearbox Kit S-Drive VOLVO 130S Flexible Coupling Type A SAE 6, Washer GROWER DIN Bolt DIN 912 M Engine Adaptor Washer DIN 6798-A Bolt DIN 912 M12-1, Washer DIN Bolt DIN 931 M Bolt DIN 933 M

53 Kit Gearbox Kit S-Drive VOLVO 120S Flywheel Supplement Washer GROWER DIN Bolt DIN 933 M Flexible Coupling Type F D. 175 VULKAN Washer GROWER DIN Bolt DIN 933 M Bolt DIN 931 M Washer DIN 6798-A Engine Adaptor Washer DIN 6798-A Bolt DIN 912 M12-1, Spacer, VOLVO Stern Drive 110S Nut DIN 934 M Flywheel

54 Kit Gearbox Kit S-Drive VOLVO 100S Shaft (Cardan 100S) Washer GROWER DIN Bolt DIN 933 M Engine Adaptor Washer DIN 6798-A Bolt DIN 912 M12-1, Bolt DIN 912 M Washer GROWER DIN Support REAR 08/10/ Bolt DIN 933 M

55 Kit Gearbox Kit S-Drive SD20 YANMAR Flywheel Supplement Washer GROWER DIN Bolt DIN 933 M Bolt DIN 933 M Engine Adaptor SAE Washer DIN 6798-A Bolt DIN 912 M12-1, Adaptor SAE6 TO SAE Bolt DIN 912 M Bolt DIN 933 M Washer DIN 6798-A

56 Kit Gearbox Kit GearBox VOLVO MS-2 & MS-2B Flywheel Supplement Washer GROWER DIN Bolt DIN 933 M Flexible Coupling Type F D. 175 VULKAN Washer GROWER DIN Bolt DIN 933 M Bolt DIN 931 M Washer DIN 6798-A Engine Adaptor Washer DIN 6798-A Bolt DIN 912 M12-1, Support REAR 08/10/ Spacer, VOLVO Stern Drive 110S Bolt DIN 912 M Washer GROWER DIN

57 Kit Gearbox Kit GearBox TMC-40P Version 4/ Flexible Coupling Type A SAE 6, Washer GROWER DIN Bolt DIN 912 M Bolt DIN 933 M /03/ Washer DIN 6798-A Engine adaptor Washer DIN 6798-A Bolt DIN 912 M12-1, Support REAR Washer GROWER DIN Bracket, GearBox Control Bolt DIN 912 M Washer DIN Clamp,CABLE Washer DIN /11/ Nut DIN 934 M Coupling,cable Washer DIN Pin DIN-94 1, Bolt DIN 933 M

58 Kit Gearbox Kit GearBox RONIM Flywheel Flexible Coupling Type A SAE 6, Washer GROWER DIN Bolt DIN 912 M Washer DIN 6798-A Bolt DIN 912 M12-1, Bolt DIN 912 M Cover Gasket Support REAR Washer GROWER DIN Bolt DIN 933 M Bolt DIN 933 M

59 Kit Gearbox Kit S-Drive VOLVO 110S Coupling, Drive Spacer, VOLVO Stern Drive 110S Washer GROWER DIN Bolt DIN 933 M Engine Adaptor SAE Washer DIN 6798-A Bolt DIN 912 M12-1, Spacer,VOLVO Stern Drive ADAP.110S Washer GROWER DIN Bolt DIN 912 M Bolt DIN 931 M Bolt DIN 933 M

60 Kit Gearbox Kit S-Drive VOLVO 120SB/120SC/120SE Flywheel Supplement Washer GROWER DIN Bolt DIN 933 M Flexible Coupling Type F D. 175 VULKAN Washer GROWER DIN Bolt DIN 933 M Engine Adaptor Washer DIN 6798-A Bolt DIN 912 M12-1, Spacer, SDRIVE 120BS Washer DIN Bolt DIN 931 M

61 Kit Gearbox Kit S-Drive BUKH DV10 & DV Shaft Washer GROWER DIN Bolt DIN 933 M KEY Washer Engine Adaptor SAE Washer DIN 6798-A Bolt DIN 912 M12-1, BUKH S-Drive DV-20 Adaptor Flange Washer GROWER DIN Bolt DIN 933 M Stud Washer DIN 6798-A Nut DIN 934 M Stud Washer DIN 6798-A Nut DIN 934 M Bolt DIN 933 M

62 Kit Gearbox Kit Bobtail SAE Engine Adaptor SAE Rear Bracket 19/03/ Support 14/11/ Support Washer DIN 6798-A Bolt DIN 912 M12-1, Bolt DIN 933 M Washer GROWER DIN Washer GROWER DIN Bolt DIN 912 M10-1,

63 Kit Gearbox Kit GearBox TM-345/345A Flexible Coupling Type B SAE 6"1/ Washer GROWER DIN Bolt DIN 933 M Engine Adaptor SAE Washer DIN 6798-A Bolt DIN 912 M12-1, Adaptor SAE Clamp,CABLE Washer DIN Bracket,Gear box control Washer DIN Bolt DIN 933 M Pin DIN-94 1, Washer DIN ALLPA.93 1 Coupling,cable 23/05/ Stud Washer DIN Nut DIN 934 M Bracket,TM Oil Cooler Pipe Elbow Clamp DIN /9 W Cover, water cooler D Clamp DIN /12 W Clamp 29/03/ Bolt,Coupling pipe oil Washer , Cooler,oil NS M Water Intake Hose (HQ) D [NS] [VAR] [NS] Not shown [VAR] Variable according to repair

64 Kit Gearbox Kit GearBox ZF 15 MIV 4 V Flexible Coupling Type A SAE 6, Washer GROWER DIN Bolt DIN 933 M Bolt DIN 933 M Washer DIN 6798-A Engine Adaptor Washer DIN 6798-A Bolt DIN 912 M12-1, REAR, Bracket Washer DIN Nut DIN 934 M Pin DIN-94 1, Washer DIN ALLPA.93 1 Coupling,cable 23/05/ Clamp,CABLE Bracket, GearBox Control Bolt DIN 7991 M Bolt DIN 933 M Washer GROWER DIN REAR, Bracket Bolt DIN 933 M Washer DIN

65 Kit Gearbox Kit Bobtail Support 14/11/ Support Rear Bracket 19/03/ Washer GROWER DIN Bolt DIN 912 M10-1, Bolt DIN 912 M12-1, Washer GROWER DIN

66 Kit Gearbox Kit GearBox TMC-60 MINI Flexible Coupling Type A SAE 6, Washer GROWER DIN Bolt DIN 912 M Bolt DIN 931 M Washer DIN 6798-A Engine adaptor Washer DIN 6798-A Bolt DIN 912 M12-1, Support REAR 08/10/ Washer GROWER DIN Bolt DIN 912 M Bracket, GearBox Control Clamp,CABLE Washer DIN Bolt DIN 933 M ALLPA.93 1 Coupling,cable 23/05/ Washer DIN Pin DIN-94 1, Washer DIN

67 Kit Gearbox Kit S-Drive SELVA Flexible Coupling Type A SAE 6, Washer GROWER DIN Bolt DIN 912 M Bolt DIN 931 M Engine Adaptor SAE Washer DIN 6798-A Bolt DIN 912 M12-1, Adaptor Flange "BW" Washer DIN 6798-A Bolt DIN 933 M Nut DIN 934 M Bolt DIN 933 M

68 Kit Gearbox A.4 Kit GearBox TMC/ZF/PRM Flexible Coupling Type A SAE 6, Washer GROWER DIN Bolt DIN 912 M Bolt DIN 933 M /03/ Washer DIN 6798-A Engine adaptor Washer DIN 6798-A Bolt DIN 912 M12-1, Support REAR 05/12/ Bolt DIN 912 M Washer GROWER DIN Bolt DIN 933 M

69 Kit Gearbox T.4 Kit S-Drive TECHNO.SP Flexible Coupling Type A SAE 6, Washer GROWER DIN Bolt DIN 912 M Engine Adaptor SAE Washer DIN 6798-A Bolt DIN 912 M12-1, BW Bell Housing Washer DIN 6798-A Bolt DIN 933 M Pin DIN-94 1, Washer DIN ALLPA.93 1 Coupling,cable 23/05/ Washer DIN Clamp,CABLE Bolt DIN 931 M Washer DIN 6798-A Bolt DIN 931 M Stud Nut DIN 934 M Bolt DIN 933 M Clamp DIN /9 W4 22 M Water Intake Hose (HQ) D Raccord Exhaust Manifold Outlet Bend Water Trainer 1/2" Pastic Cable Zip Tie 27/02/

70 Instruments Panels Price Supplement Panel TE3 MINI-17/ Panel TE3 MINI-17/ SENDER Holder Pressure Sensor 4 TFH.1M Straight Receptacle 1 Sec. Faston 09/06/ Insulator Cap Faston

71 Instruments Panels RD Kit 2nd Panel TE4 MINI-17/29 12V Panel TE2 MINI-17/ Panel TE4 MINI-17/ T Double Panel DERIVATION

72 Electrical System Kit 2nd Alternator 28V/55A Pulley 2A (S) nd Alternator Bracket Front Bracket Front Bracket Strap, Alternator Washer DIN Bolt DIN 931 M Washer GROWER DIN Nut DIN 934 M Belt Type AX Alternator 28V/55A Nut DIN 985 M Bolt DIN 933 M Pulley Spacer 8,5X25X Washer GROWER DIN Bolt DIN 933 M Bolt DIN 912 M10-1, Washer DIN PAN,alternator L.H. NS Nut DIN 934 M8 8.8 [NS] [NS] Not shown

73 Electrical System Kit Alternator 14V/95A ISKRA BRACE Alt. 14V/95A Belt Type SPZX Pulley Spacer 17X28X Spacer 17X28X5,5 09/09/ Spacer 10,25X25X Spacer 13.5x10.2x11 09/09/ Washer DIN Washer GROWER DIN Bolt DIN 931 M Washer DIN Bolt DIN 933 M Washer DIN Washer GROWER DIN Nut DIN 934 M Washer DIN Bolt DIN 931 M NS TR Ring Terminal 25 Sec. [NS] NS Washer DIN [NS] NS Nut DIN 934 M5 8.8 [NS] NS Nut DIN 934 M6 8.8 [NS] [NS] Not shown

74 Electrical System B Earth Isolated Alternator 14V/95A Kit B 1 Alt.14V/95A Bushing Washer DIN Washer GROWER DIN Nut DIN 934 M Spacer 10,25X25X Bush Bushing Spacer 13.5x10.2x11 09/09/ Washer DIN Washer GROWER DIN Bolt DIN 931 M Washer DIN Bolt DIN 933 M Bolt DIN 931 M Bolt DIN 933 M Washer DIN BRACE Spacer 6,5X12X Spacer 17X28X5,5 09/09/ Pulley Spacer 17X28X Belt Type SPZX 925 NS TFM.6.3.T.5.I 1 Straight Receptacle 6.3 Faston [NS] NS TR Ring Terminal 10 Sec. [NS] NS Washer DIN [NS] NS Nut DIN 934 M5 8.8 [NS] [NS] Not shown

75 Electrical System Kit 2nd Alternator 14V/90A Pulley 2A (S) Right, front bracket 09/10/ Left, front bracket 09/10/ Alternator 14V/90A Pulley Alternator Alternator Bracket Strap, Alternator Washer DIN Washer DIN Washer DIN Washer DIN Bolt DIN 931 M Bolt DIN 933 M Bolt DIN 933 M Nut DIN 934 M Nut DIN 934 M Nut DIN 934 M Bolt DIN 912 M10-1, Washer GROWER DIN Washer GROWER DIN Washer GROWER DIN NS G 1 Belt Type [NS] [NS] Not shown

76 Electrical System Kit Wire Earth Isolated Alternator 14V/ Relay 12 V. Bipolar SUPORT RELAIS 21/01/ Washer DIN Bolt DIN 933 M10-1, Washer DIN Bolt DIN 933 M /11/ Clamp SWITCH, Oil PRESS Washer , Connection M14X1,5 5/8" EXA.22 L= Temperature SENDER Copper Washer , High Coolant, 2 PoleS Ball JOINT CABLE Holder Ball B 1 Alt. 14V/75A Oil Pressure Sensor Adaptor 29/09/ Washer DIN Bolt DIN 933 M Bolt DIN 933 M Nut DIN 934 M DIVIDER Bushing Bushing Spacer 8,5X25X Washer DIN NS Bushing [NS] NS Washer [NS] NS Bolt DIN 933 M [NS] NS Nut DIN 934 M5 8.8 [NS] NS Washer GROWER DIN [NS] NS Pastic Cable Zip Tie [NS] NS Pastic Cable Zip Tie [NS] NS TERMINAL [NS] [NS] Not shown NS Flag Receptable Faston Terminal [NS] NS Insulation Flag Protective [NS]

77 Electrical System Kit Wire Earth Isolated Alternator 14V/7 NS Wire [NS] NS Wire [NS] NS R.2 1 MINI-17/29 E. Wiring EARTH ISOLATED [NS] NS MASS BLACK TO Wiring START [NS]

78 Electrical System Kit Water Leak Sensor & Alarm SP60 12V SPROP60 Water SYStem Alarm SYSTEM Water Alarm Sensor

79 Other Kits Motor Bracket Width 185/ E.1 1 RIGHT, front bracket E.1 1 LEFT, front bracket E 2 Support Rear NS Bolt DIN 931 M [NS] 11/05/2016 [NS] Not shown

80 Other Kits Motor Bracket Width Bracket, Front Left (Width 205) Bracket, Front Right (Width 205) Bracket, Rear (Width 205)

81 Other Kits S Front Water Pomp MINI-17/29 Kit(Spline) Front Water Pump MINI-17/29 Kit Complete

82 Other Kits Boiler Kit (S) NIPPLE,heater Copper Washer , Joint

83 Other Kits Pression Gauge Kit Pressure Tap Flexible Hose F-M G1/4-M16x Presion Gauge 0-10 bar Protective Rubber

84 Other Kits Kit Trolling Valve for TM-345/A Trolling Valve TM-345A Pipe Pipe, rev.oil Cooler Bolt,Coupling pipe oil Washer , Clamp,CABLE Coupling,cable Pin DIN-94 1, Washer DIN Washer DIN

85 Exhaust System Exhaust Flange (S) Exhaust Flange (S)

86 Exhaust System C Dry Exhaust SYStem, Elbow (S) Kit Dry Exhaust With Flexible Pipe (S) Exhaust Manifold Outlet Bend

87 Exhaust System Kit Dry Exh. Flexible Pipe & Silencer(S) Kit Dry Exhaust With Flexible Pipe (S) Nut DIN 934 M C 4 Washer 10/12/ Washer DIN Gasket Bolt DIN 931 M Exhaust Muffler RAINCover

88 Power Take-off Pulley Pulley 2B (S) Pulley 2B Washer GROWER DIN Bolt DIN 931 M10-1,

89 Power Take-off Pulley Pulley 2A (S) Pulley 2A 15/06/ Washer GROWER DIN /06/ Bolt DIN 931 M10-1, /06/

90 Kit Keel Cooling Kit Keel Cooling & Dry Exhaust (S) Cover Oil Pump SH Gasket Water Pump Cover O-Ring D. 57X2, Gasket Exhaust Flange (S) NS Bracket [NS] NS Bolt DIN 933 M12-1, [NS] NS Washer GROWER DIN [NS] [NS] Not shown