ASTON SERIES SINGLE HYDRONIC Residential Ton Water-to-Water Geothermal Heat Pump

Transcription

1 ASTON SEIES SINLE HYDONI esidential Ton Water-to-Water eothermal Heat Pump Submittal Data English Language IP/Metric Units SD206W 06/16

2 ontractor: Model Nomenclature * 00 A A 1 0 Model Type - Aston Type Water-to-Water Vintage * - Factory Use Only Unit apacity () 018, 02, 00, 00, 060, 0 Future Option A Standard Operation eversible H Heating Only Voltage /60/1 Hot Water eneration & IntelliStart Option 0 No HW, No IntelliStart 2 HW w/o Pump, No IntelliStart 1 No HW, IntelliStart HW w/o Pump, IntelliStart 1 Future Option 0 - Standard ontrols A Aurora Base ontrols (AB) B Aurora Advance ontrols (AB AXB) Aurora Perfromance D Aurora Performance & efrigeration Future Option 0 Standard Future Option 0 Standard oax Option 2 opper N upronickel L Source upronickel & Load opper S Source opper & Load upronickel Future Option 0 None ev.: 18 January 2016 Notes: 1 Available on 00, 00, 060, and 0 only. Hot water generator requires field installed external pump kit and 02 heating only models are available only with copper double-wall vented load coax for potable water, and are not designed to be converted to dedicated cooling units. Flow meter for Performance option is shipped with unit, and must be externally field installed. All Aston Hydronic Series product is safety listed under UL199 thru ETL and performance listed with AHI in accordance with standard The Envision Series is also ENEY STA rated. trademarks of Johnson ontrols, Inc., and are used with permission. SD206W 06/16 2 Page of

3 ontractor: Definitions OP EE FLA FT HD PM H H = oefficient of Performance = Energy Efficiency atio = Entering Load Temperature = Full Load Amps = Feet of Head = allons per Minute = Heating apacity = Heat of Extraction = Heat of ejection KW LA M PD PSI LA T = in KiloWatts = Leaving Load Temperature = Locked otor Amps = Leaving Source Temperature = Maximum ontinuous urrent = Pressure Drop = Pounds per Square Inch = ated Load Amps = Total ooling apacity Performance Standard (AHI/ISO/ASHAE 126-2) The Single Stage Hydronic Series is rated in accordance to the upcoming performance standard AHI/ASHAE/ISO This new standard will have three major categories: Water Loop, round Water, and round Loop. Unit of Measure: The ooling OP The cooling efficiency is measured in EE (US version measured in Btuh per Watt. The Metric version is measured in a cooling OP (Watt per Watt) similar to the traditional OP measurement. Pump orrection alculation Within each model, only one water flow rate is specified for all three groups and pumping Watts are calculated using the following formula. This additional power is added onto the existing power consumption. Pump power correction = (gpm x 0.061) x (Press Drop x 29) / 00 Where gpm is waterflow in gpm and Press Drop is the pressure drop through the unit heat exchanger at rated water flow in feet of head. ISO apacity and Efficiency alculations The following equations illustrate cooling calculations: ISO ooling apacity = ooling apacity (Btuh) x.12 ISO EE Efficiency (W/W) = ISO ooling apacity (Btuh) x.12 / [ Input (Watts) + Pump orrection (Watt)] The following equations illustrate heating calculations: ISO Heating apacity = Heating apacity (Btuh) x.12 ISO OP Efficiency (W/W) = ISO Heating apacity (Btuh) x.12 / [ Input (Watts) + Pump orrection (Watt)] Test onditions onversions Water Flow (lps) = PM x Press Drop (Pascals) = Press Drop (ft hd) x 29 trademarks of Johnson ontrols, Inc., and are used with permission. SD206W 06/16 Page of

4 ontractor: AHI/ISO Performance atings English (IP) Units Model apacity Modulation Flow ate Load pm Source pm ooling 86 Source.6 Load apacity Btuh Water Loop Heat Pump EE Btuh/W Heating 68 Source Load apacity Btuh OP ooling 9 Source.6 Load apacity Btuh round Water Heat Pump EE Btuh/W apacity Btuh Heating 0 Source Load OP Energy Star ompliant 018 Single 16, , , ,00. Yes 02 Single 2, , , ,.8 Yes 00 Single,0 1.,0.8 0,0 2. 9,.9 Yes 00 Single 1 1 9, ,000., ,200. Yes 060 Single 18 18, , , ,200.8 Yes 0 Single , ,.2, 18.0,. No Model apacity Modulation Flow ate Load pm Source pm NOTE: All ratings based upon 208V operation. apacity Btuh ooling Source.6 Load EE Btuh/W round Loop Heat Pump Heating 2 Source Load apacity Btuh OP Energy Star ompliant 018 Single 1, ,00.1 Yes 02 Single 2, ,000.1 Yes 00 Single, ,00.1 Yes 00 Single 1 1 1,00 16.,200.1 Yes 060 Single , ,.1 Yes 0 Single , , No 01/0/12 trademarks of Johnson ontrols, Inc., and are used with permission. SD206W 06/16 Page of

5 ontractor: Performance Data ooling apacity Source Load Flow- PM Load Flow- PM Load Flow- PM EST Flow PM T H EE T H EE T H /20/09 trademarks of Johnson ontrols, Inc., and are used with permission. SD206W 06/16 Page of EE

6 ontractor: Performance Data cont. Heating apacity EST Source Load Flow- PM Load Flow- PM Load Flow- PM Flow PM H OP H OP H OP /19/09 trademarks of Johnson ontrols, Inc., and are used with permission. SD206W 06/16 6 Page of

7 ontractor: 018 DHW - Performance Data cont. Heating Only apacity EST Source Load Flow- PM Load Flow- PM Load Flow- PM Flow PM H OP H OP H OP /28/09 trademarks of Johnson ontrols, Inc., and are used with permission. SD206W 06/16 Page of

8 ontractor: 02 - Performance Data ooling apacity Source Load Flow- PM Load Flow-. PM Load Flow- PM EST Flow PM..... T H EE T H EE T H /20/09 trademarks of Johnson ontrols, Inc., and are used with permission. SD206W 06/16 8 Page of EE

9 ontractor: 02 - Performance Data cont. Heating apacity EST Source Load Flow- PM Load Flow-. PM Load Flow- PM Flow PM H OP H OP H OP /19/09 trademarks of Johnson ontrols, Inc., and are used with permission. SD206W 06/16 9 Page of

10 ontractor: 02 DHW - Performance Data cont. Heating Only apacity EST Source Load Flow- PM Load Flow-. PM Load Flow- PM Flow PM H OP H OP H OP /28/09 trademarks of Johnson ontrols, Inc., and are used with permission. SD206W 06/16 Page of

11 ontractor: 00 - Performance Data ooling apacity Source Load Flow- PM Load Flow-. PM Load Flow- PM EST Flow PM..... T H EE T H EE T H /20/09 trademarks of Johnson ontrols, Inc., and are used with permission. SD206W 06/16 11 Page of EE

12 ontractor: 00 - Performance Data cont. Heating apacity EST Source Load Flow- PM Load Flow-. PM Load Flow- PM Flow PM H OP H OP H OP /1/09 trademarks of Johnson ontrols, Inc., and are used with permission. SD206W 06/16 12 Page of

13 ontractor: 00 - Performance Data ooling apacity Source Load Flow-8 PM Load Flow-11. PM Load Flow-1 PM EST Flow PM T H EE T H EE T H The manufacturer works continually to improve its products. As a result, the design and specifications of each product at the time of order may be changed without notice. Purchaser s approval of this data set signifi es that the equipment is acceptable 8/20/09 under the provisions trademarks of Johnson ontrols, Inc., and are used with permission. SD206W 06/16 1 Page of EE

14 ontractor: 00 - Performance Data cont. Heating apacity EST Source Load Flow-8 PM Load Flow-11. PM Load Flow-1 PM Flow PM H OP H OP H OP /19/09 trademarks of Johnson ontrols, Inc., and are used with permission. SD206W 06/16 1 Page of

15 ontractor: Performance Data ooling apacity Source Load Flow-9 PM Load Flow-1. PM Load Flow-18 PM EST Flow PM T H EE T H EE T H /20/09 trademarks of Johnson ontrols, Inc., and are used with permission. SD206W 06/16 1 Page of EE

16 ontractor: Performance Data cont. Heating apacity EST Source Load Flow-9 PM Load Flow-1. PM Load Flow-18 PM Flow PM H OP H OP H OP /19/09 trademarks of Johnson ontrols, Inc., and are used with permission. SD206W 06/16 16 Page of

17 ontractor: 0 - Performance Data ooling apacity Source Load Flow- PM Load Flow-1. PM Load Flow-19 PM EST Flow PM T H EE T H EE T H /20/09 trademarks of Johnson ontrols, Inc., and are used with permission. SD206W 06/16 1 Page of EE

18 ontractor: 0 - Performance Data cont. Heating apacity EST Source Load Flow- PM Load Flow-1. PM Load Flow-19 PM Flow PM H OP H OP H OP /19/09 trademarks of Johnson ontrols, Inc., and are used with permission. SD206W 06/16 18 Page of

19 ontractor: Dimensional Data A N S T Q P Z W B U I E L K J H Y X V D M F O 2/1/16 Model & 0 Model & 0 Overall abinet Water onnections A B D E F H I Depth Height Width Load Liquid In Load Liquid Out Source Liquid In Source Liquid Out HW In HW Out Load Water FPT Source Water FPT HW Water FPT Electrical Knockouts J K L 1/2 in. / in. / in. cond cond cond Low Voltage Ext Pump Supply in in. 1 in cm mm 2. mm in in. 1 in cm mm 2. mm in in. 1 in. 1/2 in cm mm 2. mm 12. mm..6. in / in. 1-1/ in. 1/2 in cm mm 1.8 mm 12. mm..6. in / in. 1-1/ in. 1/2 in cm mm 1.8 mm 12. mm..6. Water onnections Electrical Knockouts M N O P Q S T U V W X Y Z Load Source Side Side Source HW Low Ext Ext Liquid Liquid HW In Liquid In Out Supply Voltage Pump Pump Supply Out Out Supply Supply Load Liquid In Supply in cm in cm in cm in cm in cm /6/ trademarks of Johnson ontrols, Inc., and are used with permission. SD206W 06/16 19 Page of

20 ontractor: Physical Data Model ompressor (1 each) Scroll Factory harge a, oz [kg].0 [1.2] 8.0 [1.6] 0 [1.98] 68 [1.9] [2.9] [.12] oax & Piping Water Volume - gal [l]*.2 [1.9].89 [.8] 1.0 [.9] 1. [.2] 1.6 [6.1] 1.6 [6.1] Weight - Operating, lb [kg] 191 [86.6] 22 [2.1] 2 [11.] 2 [1.] [16.] [16.] Weight - Packaged, lb [kg] 21 [96.6] 2 [112.0] 0 [18.] 0 [1.2] 60 [16.] 60 [16.] NOTE: * Source or load side only. 8/6/ Electrical Data Unit Model ated Voltage Voltage Min/Max ompressor LA LA LA* Load Pump Source Pump Total Unit FLA Min kt Amp Maximum Fuse/HA /60/1 18/ /60/1 18/ /60/1 18/ /60/1 18/ /60/1 18/ /60/1 18/ Notes:All fuses type D time delay (or HA circuit breaker in USA). 1/1/201 Source pump amps shown are for up to a 1/2 HP pump Load pump amps shown are for small circulators. *With optional IntelliStart trademarks of Johnson ontrols, Inc., and are used with permission. SD206W 06/16 20 Page of

21 ontractor: Pressure Drop Model PM Pressure Drop (psi) * * H/ H/ H/ H/ NOTES: Temperatures are Entering Water Temperatures 8/9/ *Domestic water heating units source side pressure drop and reversible units load and source pressure drop. Vented Only Load Side Model 018H 02H PM Pressure Drop (psi) NOTES: Temperatures are Entering Water Temperatures. Double wall vented coax for heating potable water /1/09 orrection Factor Tables atalog performance can be corrected for antifreeze use. Please use the following table and note the example given. Antifreeze Type Antifreeze % by wt Heating ooling Pressure Load Source Load Source Drop EWT - [ ] 80 [26.] 0 [-1.1] 0 [.0] [2.2] 0 [-1.1] Water Ethylene lycol Propylene lycol Ethanol Methanol WANIN: ray area represents antifreeze concentrations greater than % by weight and should be avoided due to the extreme performance penalty they represent. trademarks of Johnson ontrols, Inc., and are used with permission. SD206W 06/16 21 Page of

22 ontractor: Wiring Schematics Aurora ontrol /60/1 Load Pump /60/1 Pump Source Pump Pump 1/2 hp Total /60/1 Pump PB1 2 1 PB2 2 Violet/White (8) /White (1) A ircuit Breaker LP Violet/White (9) /White (2) A ircuit Breaker OM Violet () N NO /White () Blue S apacitor Tan() ompressor ed Violet (6) T2 T1 L2 L1 A ircuit Breaker A ircuit Breaker () () Blue 20V L1 Field Installed Item Factory Low voltage wiring Factory Line voltage wiring Field low voltage wiring Field line voltage wiring Optional block D Voltage PB traces Junction Quick connect terminal Wire nut Field wire lug round Legend T Thermistor Light emitting diode - reen elay coil apacitor w/ bleed resistor Switch - ondensate overflow Switch - High pressure Switch - Low pressure NOTE LP OM NOTE 6 N NO /White () -T1 - O - K6 - K - HP - LP - VIV - LP - elay ontacts- N.O., N.. Fuse Breaker ompressor ontactor ondensate overflow sensor DHW pump relay Loop pump relay High pressure switch Low pressure switch Vapor Injection Valve Load Pump elay P 2 1 PB1, PB2 - V - SW1 - SW1 - SW2 - FP - OAT - Polarized connector urrent Transducer (T) blocks eversing Valve coil DIP package position AXB TEST MODE AB Board DIP package 8 position AB Board Freeze Protection Outdoor Air Temperature eothermal Tank Thermostat Y1 Aurora Board NOTE 2 HP P EM PWM HP P1 LP LP FP2 FP2 FP1 FP1 SW1 Test EV EV V K1 2 K2 2 LO HI F F F Y1 JW2 - Alarm P2 Factory P Factory PWM FM Hi K Fan K Alarm K Acc K6 Field onnections ES LS ALM AL A c A no A nc P9 LO P1 LO LED1 AUOA BASE ONTOL P11 Factory Fan onnection Off FP1 1 o F/0 o F FP2 1 o F/0 o F Fault V B/O A Dip A Dip LED Dual/Single L Pulse/ontinuous Status eheat/normal Factory Use O/B O/B Y1 Y1 Y2 Field onnections Y2 SW2 W W On 1 LED2 2 Y onfig 6 8 DH DH om1 om2 A-Fuse LED LED EH1 P Factory P6 S8 Exp P S 8 P8 S8 NET EH2 EH1 O N/A (+) (-) (+) (-) Brown (ND) Brown (OAT) ed (TS) ed (ND) OAT OAT Tank Tank OAT Sensor eotank Sensor HZ A+ B+ ND OAT TS ND HydroZone ontroller 2 1 V P O/B --/L NOTE LP 2 VD trademarks of Johnson ontrols, Inc., and are used with permission. SD206W 06/16 22 Page of

23 T T ontractor: Wiring Schematics - cont. Aurora ontrol /60/1 ompressor Blue Notes ap Blue Tan(6) S ed Pink un Winding Active Start IntelliStart 1 - Switch blue and red wires for 208V operation. 2 HydroZone controller is an optional field installed accessory. eversing Valve wires not installed on heating only option FP2 is replaced with a resistor on heating only option Move black/white() wire when HydroZone is not used for pump control 6 When eothermal Storage Tank is wired directly to the Aurora Board HydroZone ontroller may be labeled - - or L. 8 HydroStat ommunicating ontroller is an optional field installed accessory. ommon Unit Supply /60/1 T2 L2 T1 L1 Softstart Option Transformer Yellow NOTE 1 ed 208V 2V /White NOTE V FP1 NOTE FP2 LP HP Yellow Yellow Blue (1) Not Used Violet(1) Blue Blue V Orange Yellow Yellow Orange Blue P2 P1 ES LS ALM AL A OM A NO A N LO O/B Y1 Y2 W DH EH1 2 F AID Tool K-Alarm elay K6-Acc elay reen(11) S8 NET P8 P9 om2 LED Brown (ND) ELWT ELWT Brown (OAT) JW2 F F P HI LO S8 NET - + eo-tank ed (TS) eo-tank ed (ND) K-Fan elay om1 LED P K2- elay NOTE 8 HS + - ND OAT TS ND K-2 elay Aurora Base ontrol (AB) S8 EXP - + P6 O EH1 HydroStat ontroller SW1 Test Mode EV EV FP1 FP1 FP2 FP2 LPS LPS HPS HPS K1-V elay EH2 P Y1 Status LED W P P F1-A PWM FM Fault LED1 P1 Off On FP1 1/0 1 FP2 1/0 2 V B/O Acc Dip Acc Dip Dual/Single 6 L Output Type Future Use 8 SW2 onfig LED2 Y F AB SW2 Accessory elay DESIPTION SW2- SW2- ycle with Blower ON ON ycle with ompressor OFF OFF Water Valve Slow Opening ON OFF ycle with omm. T-stat Hum md OFF ON Event Normal Mode Test Mode andom Start Delay to 80 seconds 1 second ompressor On Delay seconds < 1 second ompressor Minimum On Time 2 minutes seconds ompressor Short ycle Delay minutes 1 seconds Fault ecognition Delay High Pressure Start-Up Bypass Low Pressure Aurora Timing Events Fault ecognition Delay Low Pressure Start-Up Bypass Low Water oil Limit Fault ecognition Delay Low Water oil Limit Fault ecognition Delay ondensate Overflow HydroZone all ecognition Time Less than 1 second Less than 1 second 2 minutes 0 seconds 0 seconds 0 seconds 2 minutes 0 seconds 0 seconds 0 seconds 0 seconds 0 seconds 2 seconds 2 seconds Water Valve Slow Open Delay seconds seconds Aurora LED Flash odes Slow Flash 1 second on and 1 second off Fast Flash milliseconds on and milliseconds off Flash ode milliseconds on and 00 milliseconds off with a 2 second pause before repeating andom Start Delay (Alternating olors) onfiguration LED (LED2, Yellow) Status LED (LED1, reen) Fast Flash No Software Overide OFF onfiguration LED (LED2, Yellow) Fast Flash DIP Switch Overide Slow Flash Fault LED (LED, ed) Fast Flash Fault LED (LED1, ed) Status LED (LED, reen) Normal Mode OFF Normal Mode ON Input Fault Lockout Flash ode 1 ontrol is Non-Functional OFF High Pressure Lockout Flash ode 2 Test Mode Slow Flash Low Pressure Lockout Flash ode Lockout Active Fast Flash Future Use Flash ode Dehumidification Mode Flash ode 2 Freeze Detection FP1 Flash ode Future Use Flash ode eserved Flash ode 6 Future Use Flash ode ondensate Overflow Lockout Flash ode Load Shed Flash ode Over/Under Voltage Shutdown Flash ode 8 ESD Flash ode 6 Future Use Flash ode 9 Future Use Flash ode Future Use Flash ode FP1 and FP2 Sensor Error Flash ode 11 ELWT: Entering Load Water Temperature Sensor eo-tank Sensor trademarks of Johnson ontrols, Inc., and are used with permission. SD206W 06/16 2 Page of LP 2 VD

24 ontractor: Wiring Schematics Aurora Advanced ontrol /60/1 Load Pump /60/1 Pump Ext Pump Pump 1/2 hp Total /60/1 Pump PB1 2 1 PB2 2 Violet/White (8) /White (1) A ircuit Breaker LP Violet/White (9) /White (2) A ircuit Breaker Orange (12) OM Brown (1) Violet () N NO /White () Blue S apacitor Tan() apacitor T ompressor ed ompressor ommon T Violet (6) T2 L2 T1 L1 EFIEATION MONITOIN PESSUE TANSDUE ND 1 OUT 2 White D ed DISH P1 L1 L1 K6 NO OM K NO OM L2 L2 A ircuit Breaker A ircuit Breaker () () Brown T Brown ray T ray Field Installed Flow Meter ND reen OUT 2 2 White D Brown Purple T Purple White T White PEFOMANE MONITOIN NOTE 8 Pump Slave Input/Output Future Use Smart rid Home Automation P16 LAT FLOW LWT EWT P1 P P2 HA2 HA1 SI P S + S OUT IN LOOP VS DATA VS PUMP PUMP SLAVE MOTO X TX Status AXB (Aurora Expansion Board) V+ P8 S8 (+) (-) P6 ZONE (+) (-) P AB (+) (-) K K2 K1 OFF ON Modbus Add. ID 1 Future Use 2 Future Use Acc 2 Dip Acc 2 Dip SW1 P1 P18 P1 P12 P P P11 T2 T1 T2 T1 HW ST SU P STEPPE ANA A2 DH DIV P9 White White Orange Orange Blue Blue ed ed Brown Brown White ed Blue Blue 1 2 T Pink Pink T HOT WATE OPTION Not Used EFIEATION MONITOIN Accessory 2 Output ND OUT D Brown (ND) Brown (OAT) Suction Pressure Transducer Suction Line Temp apacitor T Auxiliary Heat T ed (TS) ompressor ommon T Load Pump T ed (ND) LP OM eothermal Tank Thermostat NOTE 2 HZ A+ B+ ND OAT TS ND N NO NOTE /White () NOTE 6 Aurora Board Y1 HydroZone ontroller -T1 2 1 V P O/B L Blue 20V Notes OAT OAT Tank Tank 1 - Switch blue and red wires for 208V operation. 2 HydroZone controller is an optional field installed accessory. eversing Valve wires not installed on heating only option FP2 is replaced with a resistor on heating only option Move black/white() wire when HydroZone is not used for pump control to LP-N and -T1 6 When eothermal Storage Tank is wired directly to the Aurora Board Low voltage wiring is lass 2 8 Flow Meter is sent with unit, but needs to be field installed outside the unit. 9 HydroStat communicating controller is an optional field installed accessory. OAT Sensor eotank Sensor LP 2 VD trademarks of Johnson ontrols, Inc., and are used with permission. SD206W 06/16 2 Page of

25 T T ontractor: Wiring Schematics Aurora Advanced ontrol /60/1 Unit Supply /60/1 ap Blue Tan(6) Blue ompressor S T2 T1 L2 L1 ed Pink un Winding IntelliStart Active Start ommon Softstart Option Aurora LED Flash odes Slow Flash 1 second on and 1 second off Fast Flash milliseconds on and milliseconds off Flash ode milliseconds on and 00 milliseconds off with a 2 second pause before repeating andom Start Delay (Alternating olors) onfiguration LED (LED2, Yellow) Status LED (LED1, reen) Fast Flash No Software Overide OFF onfiguration LED (LED2, Yellow) Fast Flash DIP Switch Overide Slow Flash Fault LED (LED, ed) Fast Flash Fault LED (LED1, ed) Status LED (LED, reen) Normal Mode OFF Normal Mode ON Input Fault Lockout Flash ode 1 ontrol is Non-Functional OFF High Pressure Lockout Flash ode 2 Test Mode Slow Flash Low Pressure Lockout Flash ode Lockout Active Fast Flash Future Use Flash ode Dehumidification Mode Flash ode 2 Freeze Detection FP1 Flash ode Future Use Flash ode eserved Flash ode 6 Future Use Flash ode ondensate Overflow Lockout Flash ode Load Shed Flash ode Over/Under Voltage Shutdown Flash ode 8 ESD Flash ode 6 Future Use Flash ode 9 Future Use Flash ode Future Use Flash ode FP1 and FP2 Sensor Error Flash ode 11 Transformer Yellow NOTE 1 ed 208V 2V /White NOTE V FP1 NOTE FP2 LP HP (1) Not Used Violet(1) Blue Blue V Yellow Yellow Blue Orange Yellow Yellow Orange Blue Optional Field Installed External Hot Water eneration Pump Wiring Schematic OM K6 elay NO onnects to L2 and NO on AXB Board EH1 2 F P9 JW2 F F P HI LO EV EV FP1 FP1 FP2 FP2 LPS LPS HPS HPS P L2 P2 ES LS ALM AL A OM A NO A N LO O/B Y1 Y2 W DH P1 K-Alarm elay K6-Acc elay om2 LED S8 NET P8 S8 NET - + K-Fan elay om1 LED P K2- elay K-2 elay Aurora Base ontrol (AB) S8 EXP - + P6 O EH1 K1-V elay SW1 Test Mode EH2 P Y1 Status LED F1-A PWM FM Fault LED1 P1 Off On FP1 1/0 1 FP2 1/0 2 V B/O Acc Dip Acc Dip Dual/Single 6 L Output Type Future Use 8 SW2 onfig LED2 Y F DHW Pump AB SW2 Accessory elay DESIPTION SW2- SW2- ycle with Blower ON ON ycle with ompressor OFF OFF Water Valve Slow Opening ON OFF ycle with omm. T-stat Hum md OFF ON Event Normal Mode Test Mode andom Start Delay to 80 seconds 1 second ompressor On Delay seconds < 1 second Water Valve Slow Open Delay seconds seconds ompressor Minimum On Time 2 minutes seconds ompressor Short ycle Delay minutes 1 seconds Fault ecognition Delay High Pressure Start-Up Bypass Low Pressure Aurora Timing Events Fault ecognition Delay Low Pressure Start-Up Bypass Low Water oil Limit Fault ecognition Delay Low Water oil Limit Fault ecognition Delay ondensate Overflow HydroZone all ecognition Time Less than 1 second Less than 1 second 2 minutes 0 seconds 0 seconds 0 seconds 2 minutes 0 seconds 0 seconds 0 seconds 0 seconds 0 seconds 2 seconds 2 seconds AID Tool reen(11) Brown (ND) ELWT ELWT Brown (OAT) eo-tank ed (TS) eo-tank ed (ND) NOTE 9 HS + - ND OAT TS ND HydroStat ontroller ELWT: Entering Load Water Temperature Sensor eo-tank Sensor W P LP 2 VD L1 - O - K6 - K - HP - LP - VIV - LP - Field Installed Item Factory Low voltage wiring Factory Line voltage wiring Field low voltage wiring Field line voltage wiring Optional block D Voltage PB traces Junction Quick connect terminal Wire nut Field wire lug round elay ontacts- N.O., N.. Fuse Breaker ompressor ontactor ondensate overflow sensor DHW pump relay Loop pump relay High pressure switch Low pressure switch Vapor Injection Valve Load Pump elay Legend P 2 T 1 PB1, PB2 - V - SW1 - SW1 - SW2 - FP - OAT - Thermistor Light emitting diode - reen elay coil apacitor w/ bleed resistor Switch - ondensate overflow Switch - High pressure Switch - Low pressure Polarized connector urrent Transducer (T) blocks eversing Valve coil DIP package position AXB TEST MODE AB Board DIP package 8 position AB Board Freeze Protection Outdoor Air Temperature trademarks of Johnson ontrols, Inc., and are used with permission. SD206W 06/16 2 Page of