To Protect Your Warranty, Use Only ENERPAC Hydraulic Oil.

Transcription

1 Repair Parts Sheet Submerged Pump and Pump Mounted Valves L98 Rev. D 0/ For Date Codes Beginning with the Letter O Pumps Manufactured January 009 and later. To Protect Your Warranty, Use Only ENERPAC Hydraulic Oil. Enerpac recommends that all kit components be installed to insure optimum performance of the repaired unit. TABLE OF CONTENTS SECTION - PRODUCT DATA page Pump Model Code Chart... Specifications... SECTION II - PUMP COMPONENTS Figure - Pressure Switch, PES, WES and WET Models... Figure - Pump and Motor Assembly... - Figure - Unloader Block... 6 Figure - Heat Exchanger... Figure - Vent/Filler Plug Assembly... 8 Figure 6 - Temperature Switch and Terminal Block... 8 Figure - Shroud Assembly... 8 SECTION III - SHROUD ELECTRICAL Shroud and Pendant Replacement Parts Guide Figure 8 - Shroud Electrical Components, PER and WER Models (dual solenoid valve)... - Figure 9 - Shroud Electrical Components, PED and WED Models... - Figure 0 - Shroud Electrical Components, PES, WES and WET Models Figure - Shroud Electrical Components, PEM and WEM Models Figure - Shroud Electrical Components, PEJ and WEJ Models Figure - Remote Pump Pendant Assembly, PER and WER Models... Figure - Dump Pump Pendant Assembly, PED and WED Models... Figure - Jog Pump Pendant Assembly, PEJ and WEJ Models... Figure 6 - Electrical Schematic, PER and WER Models... Figure - Electrical Schematic, PED and WED Models... 6 Figure 8 - Electrical Schematic, PES, WES and WET Models... Figure 9 - Electrical Schematic, PEM and WEM Models... 8 SHROUD ELECTRICAL (Continued) page Figure 0 - Electrical Schematic, PEJ and WEJ Models... 9 SECTION IV - CONTROL VALVES Figure - Valve Bolting Configuration... 0 Figure - Pump Manifold, PEM, PER, PES, PET, WES and WET Models... Figure - Modular Valve Assembly, PER and WER Models... - Figure - Barrel Assemblies and Flow Paths, PER and WER Models... Figure - External Pressure Control Valve, PER and WER Models (optional)... Figure 6 - and -Way Locking Pilot-Operated Check Valves, PER and WER Models (optional)... 6 Figure - Dump Valve, PED and WED Models Figure 8 - -Way Manual Valve, PEJ, PEM, PES, WEJ, WEM, WES and WET Models Figure 9 - -Way Manual Valve, PEJ, PEM, PES, WEJ, WEM, WES and WET Models... - Figure 0 - -Way Manual Valve, PEJ, PEM, PES, WEJ, WEM, WES and WET Models... -

2 SECTION I - PRODUCT DATA PUMP MODEL CODE CHART Position Represents Letter Code Pressure Range P = 0,000 psi W =,000 psi Power Source E = electric motor Pump Type M = manual J = jog R = remote (solenoid) S = pressure switch D = dump Pump Series = / HP Valve Type 0 = no valve (PER only) = dump = -way, -pos., N.O. = -way, pos., tandem center = -way, -pos., tandem center = other, must be specified (PER only) 6 & Reservoir Capacity 0 =. gallon 8 Motor Voltage & Heat Exchanger B = V, phase, 60 Hz* D = V, phase, 60 Hz with heat exchanger* E = 0V, phase, 0 Hz** F = 0V, phase, 0 Hz with heat exchanger** I = 0V, phase, 60 Hz** * Can be operated at 0 Hz if equipped with manual valve. ** Can be operated at 60 Hz if equipped with manual valve. SPECIFICATIONS,000 psi Models 0,000 psi Models (model number beginning with WE ) (model number beginning with PE ) Flow 0 cu.in./min. at 0 to 000 psi 0 cu.in./min. at 0 to 000 psi 0 cu. in./min. at 000 to 000 psi 0 cu.in./min. at 000 to 0,000 psi Electric Motor and Heat B Models - V, phase, 60 Hz* Exchanger D Models - V, phase, 60 Hz with heat exchanger* E Models - 0V, phase, 0 Hz** F Models - 0V, phase, 0 Hz with heat exchanger** I Models - 0V, phase, 60 Hz** Current Draw. Amps at maximum 6. Amps at maximum Relief Valve Adjustment Range 000 to 000 psi maximum 000 to 0,000 psi maximum Oil Capacity. gallon total -. gallon usable Pressure Switches NEMA Classification NEMA NEMA Pressure Range 000 to 000 psi maximum 00 to 0,000 psi maximum Maximum Differential 00 to 00 psi to 00 psi Sound Level 6-0 dba

3 SECTION II - PUMP COMPONENTS,, REF9A Figure - Pressure Switch, PES, WES and WET Models Repair Parts List for Figure - PES 0,000 psi Pump Item Part Number Qty. Description Item Part Number Qty. Description G6L,000 psi Gauge 6 CH8096 Tee B0006 Screw DA9 Bracket B00066 Lock Washer 8 DA8 Nipple B08908 Flat Washer 9 DA0900SR Pressure Switch F0009- Elbow DA00 Fitting All Items listed above included in Repair Parts Kit SUB0000PSK. Repair Parts List for Figure - WES,000 psi Pump Item Part Number Qty. Description Item Part Number Qty. Description GL 0,000 psi Gauge 6 CH8096 Tee F0009- Elbow 9 PSCK Pressure Switch All Items listed above included in Repair Parts Kit SUB000PSK. Repair Parts List for Figure - WET,00 psi Pump Item Part Number Qty. Description Item Part Number Qty. Description GL 6,000 psi Gauge 6 CH8096 Tee F0009- Elbow 9 PSCK Pressure Switch All Items listed above included in Repair Parts Kit SUB6000PSK.

4 See Figure for filter, filler plug, and O-ring. Standard Version 0 6 Torque Specifications: Item -6 ft-lbs Item -0 in-lbs Item in-lbs Item 8 0 in-lbs Dump Version REF0A Figure - Pump and Motor Assembly 99F

5 Repair Parts List for Figure Item Part Number Qty. Description Item Part Number Qty. Description DA0098 Cover Plate 8 CR60668 Tube CW080 Reservoir 9 WE000SR Unloader Block,000 psi (See Fig 6) Terminal Block pump CU8608 Screw PE0000SR Unloader Block 0,000 psi E Terminal Block pump 6 F0099- Cable Clamp 0 B0080 O-Ring (See Fig 6) Bolt B908 Socket Head Screw 8 DA900SR Stator CR6688 Sight Tube 9 CR6900SR Rotor CW900SR Tube Fitting 0 CR6008 Thrust Washer B80 O-Ring CR60 Retaining Ring CW08 Screw CW0 Ring 6 CU96906 Oil Level Decal CR686 Spacer CR686900SR Manifold CR96 Key 8 B Lock Washer CR00 Eccentric 9 CR960 Thru Bolt 6 CN990 Connector Assembly 0 F0009- Cap All except PED and WED Y0096 Tee CN990 Connector Assembly, DA90 Clip,000 psi pump PED and WED DA90 Clip,000 psi pump CR60900SR Check Valve Adaptor DA90 Clip 0,000 psi pump 8 B900 O-Ring DA6009 Hole Plug 9 A8009 Fitting B000 O-Ring 0 DA06900SR Filter CR6900SR Piston Block CR90SR Piston Block Assembly: 6 CR0 Spring 0,000 psi pump CU86 Gasket CR90SR,000 psi pump 8 DA08 Screw B06 Back-Up Washer 0 DA8 Square Ring B080 O-Ring DA096 Connector B008 8 Socket Hd. Cap Screw DA968 Tube B09 Elbow B00006 Plug 6 CR60900SR Tube B900 O-Ring CU99 Male Elbow 6 DA696 Gasket Items included in and available only as part of Repair Parts Kit SPK.

6 8 Set at: 0,00 psi (0,000 psi Pump),00 psi (,000 psi Pump) Set at 900-,000 psi Figure - Unloader Block Repair Parts List for Figure Item Part Number Qty. Description Item Part Number Qty. Description WE000SR Unloader Block 000 psi pump PE0000SR Unloader Block 0,000 psi pump CR690 Unloader Body Block CR90 Ball Seat CR600 Compression Spring S6 Gasket CR9006 Plug 6 CR9006 Plug Items included in and available only as part of Repair Parts Kit SPK. B96 Gasket 8 P890W Relief Valve Assembly 9 DA0 U-Cup 0 SJ0006 Back-Up Washer A006 Pipe Plug CR89 Plunger B0006 Ball CR0 Die Spring CR6860 Actuator Stud 6 B00 Jam Nut 6

7 Figure - Heat Exchanger (Pumps with model numbers ending in D or F.) Repair Parts List for Figure Item Part Number Qty. Description Item Part Number Qty. Description Replacement Unit: PAC V Heat Exchanger PAC0 0V Heat Exchanger DA6866 9" Tube DA9 Mounting Bracket B08 Cap Screw B0 Hex Nut B Lock Washer 6 CB099 Hose Clamp DA96900SR Heat Exchanger Assy: V DA9900SR Heat Exchanger Assy: 0V 8 DA6966 " Tube 9 DA009 Fitting 0 B060 O-Ring B06 Hex Nut A8009 Pipe, Steel /" NPT DA609 Tube Fitting, Male DA668 Tube DA668 Tube 6 DA609 Tee Fitting CB6096 Coupling 9 DA0096 Adapter 0 DA609 Male Tube Fitting DC96999 Hose Clamp SUBHEK - Heat Exchanger Repair Kit (contains Items - listed above and a cord bushing) SUB0HEK - 0V Heat Exchanger Repair Kit (contains Items - listed above and a cord bushing) PAC contains: wire assemblies, SUBHEK, and a cord bushing PAC0 contains: wire assemblies, SUB0HEK, and a cord bushing Included with item # Heat Exchanger Assy.

8 6 Item Figure - Vent/Filler Plug Assembly Figure 6 - Temperature Switch and Terminal Block Repair Parts List for Figure Repair Parts List for Figure 6 Part Number Qty. Description Item Part Number Qty. Description 6 CR008 Filter E00000 Terminal Block 9 CR60 Vent DA908 Bolt CR690 O-Ring TS DA80 Temp Switch, 80 F CR690 Decal, Vent Note: Apply gasket sealant between terminal block and pump cover plate. SECTION III - SHROUD ELECTRICAL Note: Shroud features and details will vary, depending on pump model. Figure - Shroud Assembly Notes: See tables on pages 9 through for replacement service shroud and pendant information. Refer to Figures 8 through for shroud assembly electrical components and wiring diagrams. Refer to Figures through for pendant electrical components and wiring diagrams. Refer to Figures 6 through 0 for electrical schematics. The following items are included with a replacement service shroud assembly: Electrical power cord. Shroud housing and power switch. Shroud internal electrical components and wiring (Note: components used will vary depending on pump model). Pendant assembly (only for pump models equipped with pendant). Solenoid valve cables (only for pump models equipped with electric valve). 8

9 Shroud and Pendant Replacement Parts Guide (Continued) Pump models with prefix: PED0, PEJ0, PEJ0, PEJ0, PEM0, PEM0, PEM0, PER0 and PER0. MODEL PUMP DATA SHROUD AND PENDANT PARTS INFORMATION Valve Type Heat Exchanger Voltage Maximum Pressure Replacement Service Shroud Model Number Shroud Replacement Parts List See Figure: Pendant Replacement Parts List See Figure: PED0B Dump NO V 0,000 DD900SR 9 PED0D Dump NO V 0,000 DD900SR 9 PED0E Dump NO 0V 0,000 DD8900SR 9 PEJ0B -Way, -Position NO V 0,000 DD900SR PEJ0D -Way, -Position YES V 0,000 DD900SR PEJ0E -Way, -Position NO 0V 0,000 DD6900SR PEJ0B -Way, -Position NO V 0,000 DD900SR PEJ0D -Way, -Position YES V 0,000 DD900SR PEJ0E -Way, -Position NO 0V 0,000 DD6900SR PEJ0B -Way, -Position NO V 0,000 DD900SR PEJ0D -Way, -Position YES V 0,000 DD900SR PEJ0E -Way, -Position NO 0V 0,000 DD6900SR PEM0B -Way Manual NO V 0,000 DD900SR (no pendant) PEM0D -Way Manual YES V 0,000 DD900SR (no pendant) PEM0E -Way Manual NO 0V 0,000 DD900SR (no pendant) PEM0B -Way Manual NO V 0,000 DD900SR (no pendant) PEM0D -Way Manual YES V 0,000 DD900SR (no pendant) PEM0E -Way Manual NO 0V 0,000 DD900SR (no pendant) PEM0B -Way Manual NO V 0,000 DD900SR (no pendant) PEM0D -Way Manual YES V 0,000 DD900SR (no pendant) PEM0E -Way Manual NO 0V 0,000 DD900SR (no pendant) PEM0E -Way Manual NO 0V 0,000 DD900SR (no pendant) PER0B -Way, -Position NO V 0,000 DD900SR 8 Tandem Center PER0D -Way, -Position YES V 0,000 DD900SR 8 Tandem Center PER0E -Way, -Position NO 0V 0,000 DD900SR 8 Tandem Center PER0B -Way, -Position NO V 0,000 DD9900SR 8 Tandem Center PER0D -Way, -Position YES V 0,000 DD9900SR 8 Tandem Center PER0E -Way, -Position NO 0V 0,000 DD0900SR 8 Tandem Center PER0F -Way, -Position YES 0V 0,000 DD0900SR 8 Tandem Center PER0I -Way, -Position NO 0V 0,000 DD0900SR 8 Tandem Center PES0B -Way, -Position NO V 0,000 DD9900SR 0 (no pendant) Important: The printed circuit board subassembly used on pumps manufactured before January 009 is out of production and is no longer available for purchase. If circuit board is damaged, a complete replacement service shroud of the latest design must be ordered. See tables on pages 9 through for replacement service shroud model numbers. Contact your Enerpac Authorized Service Center for additional electrical upgrade information. 9

10 Shroud and Pendant Replacement Parts Guide (Continued) Pump models with prefix: PES0, PES0, PES0, WED0, WEJ0, WEJ0, WEM0, WEM0, WEM0, WER00, WER0, WER0, WES0, WES0, WES0 and WET0. MODEL PUMP DATA SHROUD AND PENDANT PARTS INFORMATION Valve Type Heat Exchanger Voltage Maximum Pressure Replacement Service Shroud Model Number Shroud Replacement Parts List See Figure: Pendant Replacement Parts List See Figure: PES0E -Way, -Position NO 0V 0,000 DD0900SR 0 (no pendant) PES0B -Way, -Position NO V 0,000 DD9900SR 0 (no pendant) PES0B -Way, - Position NO V 0,000 DD9900SR 0 (no pendant) PES0E -Way, - Position NO 0V 0,000 DD0900SR 0 (no pendant) PES0F -Way, - Position YES 0V 0,000 DD0900SR 0 (no pendant) WED0B Dump NO V,000 DD900SR 9 WED0E Dump NO 0V,000 DD8900SR 9 WEJ0B -Way, -Position NO V,000 DD900SR WEJ0E -Way, -Position NO 0V,000 DD6900SR WEJ0B -Way, -Position NO V,000 DD900SR WEJ0B -Way, -Position NO V,000 DD900SR WEJ0D -Way, -Position YES V,000 DD900SR WEJ0E -Way, Position NO 0V,000 DD6900SR WEM0B -Way Manual NO V,000 DD900SR (no pendant) WEM0D -Way Manual YES V,000 DD900SR (no pendant) WEM0E -Way Manual NO 0V,000 DD900SR (no pendant) WEM0F -Way Manual YES 0V,000 DD900SR (no pendant) WEM0B -Way Manual NO V,000 DD900SR (no pendant) WEM0F -Way Manual YES 0V,000 DD900SR (no pendant) WEM0B -Way Manual NO V,000 DD900SR (no pendant) WEM0D -Way Manual YES V,000 DD900SR (no pendant) WEM0E -Way Manual NO 0V,000 DD900SR (no pendant) WER00B (no valve) NO 0V,000 DD9900SR 8 WER0B -Way, -Position NO V,000 DD900SR 8 Tandem Center WER0D -Way, -Position YES V,000 DD900SR 8 Tandem Center WER0E -Way, -Position NO 0V,000 DD900SR 8 Tandem Center WER0B -Way, -Position NO V,000 DD9900SR 8 Tandem Center WER0D -Way, -Position YES V,000 DD9900SR 8 Tandem Center WER0F -Way, -Position YES 0V,000 DD0900SR 8 Tandem Center WES0B -Way, -Position NO V,000 DD0900SR 0 (no pendant) WES0D -Way, -Position YES V,000 DD0900SR 0 (no pendant) WES0E -Way, -Position NO 0V,000 DD0900SR 0 (no pendant) WES0B -Way, -Position NO V,000 DD0900SR 0 (no pendant) WES0E -Way, -Position NO 0V,000 DD0900SR 0 (no pendant) WES0B -Way, - Position NO V,000 DD0900SR 0 (no pendant) WES0E -Way, - Position NO 0V,000 DD0900SR 0 (no pendant) WET0B -Way, -Position NO V,00 DD0900SR 0 (no pendant) 0

11 Shroud and Pendant Replacement Parts Guide (Continued) Pump models with prefix: PER0 and WER0 (equipped with custom ordered modular style valve) MODEL PUMP DATA SHROUD AND PENDANT PARTS INFORMATION Valve Type Heat Exchanger Voltage Maximum Pressure WER Series PER Series Replacement Service Shroud Model Number Shroud Replacement Parts List See Figure: Pendant Replacement Parts List See Figure: PER0X-VEA-... -Way, -Position OPTIONAL V,000 0,000 DD9900SR 8 WER0X-VEA-... Open Center 0V,000 0,000 DD0900SR 8 PER0X-VEC-... -Way, -Position OPTIONAL V,000 0,000 DD9900SR 8 WER0X-VEC-... Tandem Center 0V,000 0,000 DD0900SR 8 PER0X-VEF-... -Way, -Position OPTIONAL V,000 0,000 DD0900SR 8 WER0X-VEF-... Tandem Center 0V,000 0,000 DD06900SR 8 Notes: X before dash in model number (see above) will be letter B, D, E, F or I, depending on electrical configuration ordered. Refer to Page for additional information. Model number suffix will vary, dependiing on electrical configuration ordered. Refer to Enerpac catalog for additional information. Important: The printed circuit board subassembly used on pumps manufactured before January 009 is out of production and is no longer available for purchase. If circuit board is damaged, a complete replacement service shroud of the latest design must be ordered. See tables on pages 9 through for replacement service shroud model numbers. Contact your Enerpac Authorized Service Center for additional electrical upgrade information.

12 SEE NOTE AT TOP OF PAGE OPTIONAL HEAT EXCHANGER See Figure for pendant assembly F Alternate wiring arrangement for dual-solenoid PER and WER pumps equipped with Omron contactor relay: E (not used) A D B C A - To terminal BR of circuit breaker BR (item ) B - To terminal SW of switch SW (item ) C - To terminal RA of relay RA (item 9) D - To terminal TB of terminal block TB E - To terminal RA of relay RA (item 9) F - To terminal 8 of transformer TR (item ) Note: Contactor relay manufactured by Omron has a black housing. Contactor relay manufactured by Finder has a clear housing. WARNING: Disconnect power cord from outlet before removing pump shroud or beginning any repairs. Figure 8 - Shroud Electrical Components, PER and WER Models (dual solenoid-valve)

13 Repair Parts List for Figure 8 Item Part Number Qty. Description Symbol DC88 Holder, Fuse SF, PF DC808 Fuse, Primary 0.06 Amp ( V Models) DC8008 Fuse, Primary 0.00 Amp (0 V Models) DC88 Fuse, Secondary 0. Amp (All Models) DD680 Circuit Breaker, Amp ( V Models) BR DC86680 Circuit Breaker, 0 Amp (0 V Models) BR DA880 Transformer, Primary, Dual Voltage TR 6 DA8980 Relay, Motor Starter CA DA80 Capacitor K 8 CU90 Clip, Spring 9 DD6980 Relay, Solenoid, V AC Coil RA, RB 0 E00008 Relay, Motor Contactor, black housing (Omron) CB DD66880 Relay, Motor Contactor, clear housing (Finder) CB EST060 Rocker Switch, On-Off-On SW (See Fig. ) Pendant Assembly (PER 0 Models) (See Fig. ) Pendant Assembly (PER 0 Models) DD6900 Cable, Solenoid, with Plug CR660 Power Cord DD999 Connector, Quick Disconnect, / - E00000 Terminal Block TB - DA80 Temperature Switch, 80 F TS Note: Replacement wires and connectors are not available from Enerpac and must be obtained from local sources. Wire assembly part numbers are provided for reference purposes only.

14 OPTIONAL HEAT EXCHANGER SEE NOTE AT TOP OF PAGE See Figure for pendant Assembly F Alternate wiring arrangement for PED and WED pumps equipped with Omron contactor relay: E (not used) A D B C A - To terminal BR of circuit breaker BR (item ) B - To terminal SW of switch SW (item ) C - To terminal RB8 of relay RB (item 9) D - To terminal TB of terminal block TB E - To terminal RA of relay RA (item 9) F - To terminal 8 of transformer TR (item ) Note: Contactor relay manufactured by Omron has a black housing. Contactor relay manufactured by Finder has a clear housing. WARNING: Disconnect power cord from outlet before removing pump shroud or beginning any repairs. Figure 9 - Shroud Electrical Components, PED and WED Models

15 Repair Parts List for Figure 9 Item Part Number Qty. Description Symbol DC88 Holder, Fuse PF, SF DC808 Fuse, Primary 0.06 Amp ( V Models) DC8008 Fuse, Primary 0.00 Amp (0 V Models) DC88 Fuse, Secondary 0. Amp (All Models) DD680 Circuit Breaker, Amp ( V Models) BR DC86680 Circuit Breaker, 0 Amp (0 V Models) BR DA880 Transformer, Primary, Dual Voltage TR 6 DA8980 Relay, Motor Starter CA DA80 Capacitor K 8 CU90 Clip, Spring 9 DD680 Relay, Solenoid, V AC Coil RA 0 E00008 Relay, Motor Contactor, black housing (Omron) CB DD66880 Relay, Motor Contactor, clear housing (Finder) CB E00000 Rocker Switch, On-Off Momentary SW (See Fig. ) Pendant Assembly DD960 Cable, Solenoid, with Plug CR660 Power Cord DD999 Connector, Quick Disconnect, / - E00000 Terminal Block TB - DA80 Temperature Switch, 80 F TS Note: Replacement wires and connectors are not available from Enerpac and must be obtained from local sources. Wire assembly part numbers are provided for reference purposes only.

16 OPTIONAL HEAT EXCHANGER SEE NOTE AT TOP OF PAGE Alternate wiring arrangement for PES, WES and WET pumps equipped with Omron contactor relay: A B A - To terminal BR of circuit breaker BR (item ) B - To white or blue wire of pressure switch cable (item ) C - To terminal TB of terminal block TB D - To terminal 8 of transformer TR (item ) D (not used) C Note: Contactor relay manufactured by Omron has a black housing. Contactor relay manufactured by Finder has a clear housing. WARNING: Disconnect power cord from outlet before removing pump shroud or beginning any repairs. Figure 0 - Shroud Electrical Components, PES, WES and WET Models 6

17 Repair Parts List for Figure 0 Item Part Number Qty. Description Symbol DC88 Holder, Fuse PF, SF DC808 Fuse, Primary 0.06 Amp ( V Models) DC8008 Fuse, Primary 0.00 Amp (0 V Models) DC88 Fuse, Secondary 0. Amp (All Models) DD680 Circuit Breaker, Amp ( V Models) BR DC86680 Circuit Breaker, 0 Amp (0 V Models) BR DA880 Transformer, Primary, Dual Voltage TR 6 DA8980 Relay, Motor Starter CA DA80 Capacitor K 8 CU90 Clip, Spring 0 E00008 Relay, Motor Contactor, black housing (Omron) CB DD66880 Relay, Motor Contactor, clear housing (Finder) CB EST060 Rocker Switch, On-Off-On SW DD8960 Cable, Solenoid (PES Models) DD9960 Cable, Solenoid w/plug (WES and WET Models) CR660 Power Cord DD999 Connector, Quick Disconnect, / - E00000 Terminal Block TB - DA80 Temperature Switch, 80 F TS Note: Replacement wires and connectors are not available from Enerpac and must be obtained from local sources. Wire assembly part numbers are provided for reference purposes only.

18 OPTIONAL HEAT EXCHANGER SEE NOTE AT TOP OF PAGE D Alternate wiring arrangement for PEM and WEM pumps equipped with Omron contactor relay: A B A - To terminal BR of circuit breaker BR (item ) B - To terminal SW of switch (item ) C - To terminal TB of terminal block TB D - To terminal 8 of transformer TR (item ) (not used) C Note: Contactor relay manufactured by Omron has a black housing. Contactor relay manufactured by Finder has a clear housing. WARNING: Disconnect power cord from outlet before removing pump shroud or beginning any repairs. Figure - Shroud Electrical Components, PEM and WEM Models 8

19 Repair Parts List for Figure Item Part Number Qty. Description Symbol DC88 Holder, Fuse PF, SF DC808 Fuse, Primary 0.06 Amp ( V Models) DC8008 Fuse, Primary 0.00 Amp (0 V Models) DC88 Fuse, Secondary 0. Amp (All Models) DD680 Circuit Breaker, Amp ( V Models) BR DC86680 Circuit Breaker, 0 Amp (0 V Models) BR DA880 Transformer, Primary, Dual Voltage TR 6 DA8980 Relay, Motor Starter CA DA80 Capacitor K 8 CU90 Clip, Spring 0 E00008 Relay, Motor Contactor, black housing (Omron) CB DD66880 Relay, Motor Contactor, clear housing (Finder) CB E00000 Rocker Switch, On-Off-Momentary SW CR660 Power Cord DD999 Connector, Quick Disconnect, / - E00000 Terminal Block TB - DA80 Temperature Switch, 80 F TS Note: Replacement wires and connectors are not available from Enerpac and must be obtained from local sources. Wire assembly part numbers are provided for reference purposes only. 9

20 OPTIONAL HEAT EXCHANGER Alternate wiring arrangement for PEJ and WEJ pumps equipped with Omron contactor relay: A B A - To terminal BR of circuit breaker BR (item ) B - To terminal SW of switch SW (item ) C - To terminal TB of terminal block TB D - To terminal 8 of transformer TR (item ) See Figure for pendant Assembly D (not used) C Note: Contactor relay manufactured by Omron has a black housing. Contactor relay manufactured by Finder has a clear housing. WARNING: Disconnect power cord from outlet before removing pump shroud or beginning any repairs. Figure - Shroud Electrical Components, PEJ and WEJ Models 0

21 Repair Parts List for Figure Item Part Number Qty. Description Symbol DC88 Holder, Fuse PF, SF DC808 Fuse, Primary 0.06 Amp ( V Models) DC8008 Fuse, Primary 0.00 Amp (0 V Models) DC88 Fuse, Secondary 0. Amp (All Models) DD680 Circuit Breaker, Amp ( V Models) BR DC86680 Circuit Breaker, 0 Amp (0 V Models) BR DA880 Transformer, Primary, Dual Voltage TR 6 DA8980 Relay, Motor Starter CA DA80 Capacitor K 8 CU90 Clip, Spring 0 E00008 Relay, Motor Contactor, black housing (Omron) CB DD66880 Relay, Motor Contactor, clear housing (Finder) CB EST060 Rocker Switch, On-Off-On SW (See Fig. ) Pendant Assembly CR660 Power Cord DD999 Connector, Quick Disconnect, / - E00000 Terminal Block TB - DA80 Temperature Switch, 80 F TS Note: Replacement wires and connectors are not available from Enerpac and must be obtained from local sources. Wire assembly part numbers are provided for reference purposes only.

22 Figure - Remote Pump Pendant Assembly, PER and WER Models Repair Parts List for Figure Item Part Number Quantity Description PER and WER 0 Series PER and WER 0 Series L60 Cord, Electric 0 E009 Terminal, Quick Disconnect, Female E008 Terminal, Quick Disconnect, Female 9 E00 Terminal, Quick Disconnect, Female Flag DA6800 Strain Relief 6 DA90 Body, Pendant E Rocker Switch, MOM-OFF-ON (-Way Valves) A (included with #) - Cover, Dust 8 E Rocker Switch, MOM-OFF-MOM (-Way Valves) 8A (included with #8) - Cover, Dust 9 DC8800 Rivets, Snap, Black Nylon 0 DA0 Plate, Mounting DA68606 Decal, ADV DA8006 Decal, RET Included as part of replacement pendant assembly DD900 (used on PER0 and WER0 Series). Included as part of replacement pendant assembly DD900 (used on PER0 and WER0 Series).

23 8A Figure - Dump Pump Pendant Assembly, PED and WED Models Repair Parts List for Figure Item Part Number Qty. Description Y660 Cord, Electric 0 E009 Terminal, Quick Disconnect, Female 9 E00 Terminal, Quick Disconnect, Female Flag DA6800 Strain Relief 6 CU9890 Body, Pendant 8 CU9 Rocker Switch, MOM-OFF 8A (included w/#8) Cover, Dust Included as part of replacement pendant assembly DD0900.

24 8A Figure - Jog Pump Pendant Assembly, PEJ and WEJ Models Repair Parts List for Figures Item Part Number Qty. Description Y660 Cord, Electric 0 E009 Terminal, Quick Disconnect, Female E008 Terminal, Quick Disconnect, Female 9 E00 Terminal, Quick Disconnect, Female Flag DA6800 Strain Relief 6 CU9890 Body, Pendant 8 CU9 Rocker Switch, MOM-OFF 8A (included with #8) Cover, Dust Included as part of replacementpendant assembly DD900.

25 SF SF TS TS SW SF Secondary Fuse TS TEMP. SWITCH SW ON/OFF/REMOTE Switch TR DC amps / Volts DC amps for 0 volts PF PF TR Brown,. PF Primary Fuse DA TR Primary Secon dary VAC TR VAC TR8 RA RB White Green PN ADVANCE/RETRACT Pendant TR RA RB SA Advance Solenoid or 0 VAC SR Retract Solenoid or 0 VAC Volts OR 0 Volts 60 or 0 Hz.,AC DC88 0. Amps Red,. mm sq., Red Red 6 6 C B A A MOTOR CONTACTOR RA 8 ADVANCE RELAY DC LYF Omron RB 8 RETRACT RELAY Blue Blue RA RB RA8 RB8 RA RB RA6 RB6 Brown,. mm sq., SW SW RA RB Red Black. CB Black Black CB RA Brown RB Brown Blue Black,. mm sq., Black Brown,. Blue,. Red,. mm sq., Red,. mm sq., 8 6 Brown,. TR DA880. TR DA 80. Heat Exchanger Fan Motor, or 0 VAC Primary 0 VAC Pendant Cable DD66880 DC LYF Omron TR 8 Blue,. mm sq., Brown,. mm sq., A A C B WARNING: Disconnect power cord from outlet before removing pump shroud or beginning any repairs. Line Voltage In Figure 6 - Electrical Schematic, PER and WER Models ( and 0 VAC) BR Brown or Black DC86680 ETA 68, 0 Amps for 0 Volts models DD680 ETA 68, Amps for Volts models. BR Circuit Breaker Green or Green-Yellow Blue orwhite BR Brown,. mm sq., CB BR CB TB TB TB CB Brown BLU RED ORG VIO Pump Motor M STARTING WINDING MAIN WINDING MAIN WINDING WHI YEL BLK TB TB TB K Blue,. K TB K CA Blue,. CA CA TB CA Blue,. TB TB Blue,. mm sq., Power Cord. CA

26 Volts OR 0 Volts 60 or 0 Hz.,AC SF Secondary Fuse TS TEMP. SWITCH PF Primary Fuse DA 880. TR Primary Secon VAC dary VAC C B SF SF TS TS SW PF PF TR Brown,. TR TR8 RA SA Advance Solenoid or 0 VAC A A MOTOR CONTACTOR SW ON/OFF/REMOTE Switch PN ADVANCE/DUMP Pendant TR SW SW Red Blue Black. CB Brown CB Brown,. mm sq., Blue Black,. mm sq., Black Red,. mm sq., Red Red Brown,. Blue,. 6 Brown,. TR DA880. TR DC88 0. Amps DA 80. Brown,. mm sq., Red,. mm sq., Heat Exchanger Fan Motor, or 0 VAC DC amps / Volts DC amps for 0 volts Primary 0 VAC TR Pendant Cable White Blue,. mm sq., TR 8 RA ADVANCE RELAY 8 RA Black RA RA8 RB 8 RB AUXILIARY RELAY DC LYF Omron 8 6 RB RB8 RB RB DD66880 DC LYF Omron A A C B Figure - Electrical Schematic, PED and WED Models ( and 0 VAC) WARNING: Disconnect power cord from outlet before removing pump shroud or beginning any repairs. Brown or Black Line Voltage In DC86680 ETA 68, 0 Amps for 0 Volts models DD680 ETA 68, Amps for Volts models. BR Blue orwhite BR Circuit Breaker Green or Green-Yellow BR Brown,. mm sq., CB BR CB TB TB TB CB Brown BLU RED ORG VIO Pump Motor M STARTING WINDING MAIN WINDING MAIN WINDING WHI YEL BLK TB TB TB K Blue,. K TB K CA Blue,. CA CA TB CA Blue,. TB TB Blue,. mm sq., Power Cord. CA 6

27 Volts OR 0 Volts 60 or 0 Hz.,AC Line Voltage In SF Secondary Fuse TS TEMP. SWITCH PF Primary Fuse DA 880. TR Primary Secon VAC dary PF PF TR Brown,. TR VAC TR8 C B A A MOTOR CONTACTOR SW ON/OFF/ON Switch Pressure Switch TR SW SF SF TS TS SW Red Black. CB CB Blue Black,. mm sq., Black Red,. mm sq., Red Red Brown,. Blue,. 6 Brown,. mm sq., Heat Exchanger Fan Motor, or 0 VAC Pressure Switch Cable Blue,. mm sq., White Brown,. TR DA880. TR DC88 0. Amps DA 80. DC amps / Volts DC amps for 0 volts Primary 0 VAC TR DC86680 ETA 68, 0 Amps for 0 Volts models DD66880 DD680 ETA 68, Amps for Volts models. TR C B 8 Brown or Black A BR A Figure 8 - Electrical Schematic, PES, WES and WET Models ( and 0 VAC) WARNING: Disconnect power cord from outlet before removing pump shroud or beginning any repairs. Blue orwhite BR Circuit Breaker Green or Green-Yellow BR Brown,. mm sq., CB BR CB TB TB TB CB Brown BLU RED ORG VIO Pump Motor M STARTING WINDING MAIN WINDING MAIN WINDING WHI YEL BLK TB TB TB K Blue,. K TB K CA Blue,. CA CA TB CA Blue,. TB TB Blue,. mm sq., Power Cord. CA

28 DA TR Volts OR 0 Volts 60 or 0 Hz.,AC SF Secondary Fuse TS TEMP. SWITCH PF Primary Fuse Primary Secon VAC dary VAC C B SF SF TS TS SW PF PF TR Brown,. TR TR8 A A MOTOR CONTACTOR SW ON/OFF/REMOTE Switch TR SW SW Red,. mm sq., Red Red Blue,. Red 6 Brown,. TR DA880. TR DC88 0. Amps DA 80. DC amps / Volts DC amps for 0 volts Primary 0 VAC TR A A Black. CB CB Blue Black,. mm sq., Red,. mm sq., DD66880 TR 8 Brown,. mm sq., Heat Exchanger Fan Motor, or 0 VAC Blue,. mm sq., C B Figure 9 - Electrical Schematic, PEM and WEM Models ( and 0 VAC) WARNING: Disconnect power cord from outlet before removing pump shroud or beginning any repairs. Brown or Black Line Voltage In DC86680 ETA 68, 0 Amps for 0 Volts models DD680 ETA 68, Amps for Volts models. BR Blue orwhite BR Circuit Breaker Green or Green-Yellow BR Brown,. mm sq., CB BR CB TB TB TB CB Brown BLU RED ORG VIO Pump Motor M STARTING WINDING MAIN WINDING MAIN WINDING WHI YEL BLK TB TB TB K Blue,. K TB K CA Blue,. CA CA TB CA Blue,. TB TB Blue,. mm sq., Power Cord. CA 8

29 SF Secondary Fuse TS TEMP. SWITCH PF Primary Fuse DA 880. TR Primary Secon VAC dary VAC A C B MOTOR CONTACTOR SF SF TS TS SW PF PF TR Brown,. TR TR8 SW ON/OFF/REMOTE Switch PN ON/ OFF Pendant A TR SW SW Red Black. CB CB Blue Black,. mm sq., Black Red,. mm sq., Red Red Brown,. Blue,. 6 Brown,. TR DA880. TR DC88 0. Amps DA 80. Red,. mm sq., Heat Exchanger Fan Motor, or 0 VAC DC amps / Volts DC amps for 0 volts Primary 0 VAC TR A DD66880 TR Pendant Cable White 8 Blue,. mm sq., Brown,. mm sq., A Volts OR 0 Volts 60 or 0 Hz.,AC Brown or Black Line Voltage In C B DC86680 ETA 68, 0 Amps for 0 Volts models Figure 0 - Electrical Schematic, PEJ and WEJ Models ( and 0 VAC) WARNING: Disconnect power cord from outlet before removing pump shroud or beginning any repairs. DD680 ETA 68, Amps for Volts models. BR Blue orwhite BR Circuit Breaker Green or Green-Yellow BR Brown,. mm sq., CB BR CB TB TB TB CB Brown BLU RED ORG VIO Pump Motor M STARTING WINDING MAIN WINDING MAIN WINDING WHI YEL BLK TB TB TB K Blue,. K TB K CA Blue,. CA CA TB CA Blue,. TB TB Blue,. mm sq., Power Cord. CA 9

30 SECTION IV - CONTROL VALVES Bolting Configuration Pump Manifold Remote Manifold Use Bolt Kit BK Configuration includes: solenoid valve manifold ENERPAC ENERPAC T T Use Bolt Kit BK Configuration includes: solenoid valve adjustable relief valve manifold ENERPAC T ENERPAC ENERPAC T ENERPAC Use Bolt Kit BK Configuration includes: solenoid valve locking (P.O. check) valve manifold ENERPAC T ENERPAC ENERPAC T ENERPAC Use Bolt Kit BK Configuration includes: solenoid valve adjustable relief valve locking (P.O. check) valve manifold ENERPAC T ENERPAC ENERPAC ENERPAC T ENERPAC ENERPAC Torque bolts () to -6 in-lbs (,-, Nm) with lubricated threads. Figure - Valve Bolting Configurations REF 0

31 Figure - Pump Manifold, PEM, PER, PES, PET, WES and WET Models (0, 0 and 0 Series - PER Manifold Shown) Repair Parts List for Figure Item Part Number Qty. Description Item Part Number Qty. Description CR9008 Solenoid Valve Manifold 0 B000 O-Ring CR90908 Manual Valve Manifold A80000 Plug A008 Plug CU90 Valve Body A006 Plug L8608 Set Screw A009 Plug (-Way Valve Only) B0 O-Ring P00 Gasket B908 Screw 6 CB690 Ball Seat 6 B908 Screw CU60900SR Relief Valve Assembly B0006 /8" Dia. Ball 8 CH90 Ball Guide 8 R- Shipping Plug (-Way Valve) 9 A8080 Spring R- Shipping Plug (-Way Valve) Items included in and available only as part of Repair Kit MPK. Items included in and available only as part of Repair Kit MVK.

32 NOTE: This plug (Item 9) replaces the solenoid on -position valves See Figures A and B Figure - Modular Valve Assembly, PER and WER Models (0, 0 and 0 Series) Figure A - Seal Assemblies and Springs, Non-Locking -Way Valves Figure B - Seal Assemblies and Springs, All -Way Valves and Locking -Way Valves

33 Repair Parts List for Figure Item Part Number Qty. Description Item Part Number Qty. Description DC80 Clamp Plate B Back-Up, All -Way and Locking -Way Valves B00966 Back-Up, Non-Locking -Way Valve B00990 O-Ring, All -Way and Locking -Way Valves B00990 O-Ring, Non-Locking -Way Valves CN600 Ring, All -Way and Locking -Way Valves CN0 Bearing DA606 Needle Roller 6 See Figure for Flow Path Barrel Assembly B0 O-Ring 8 B08 Cap Screw 9 CN690 Pivot Block 0 CN6600 Spring Guide CN9 Shift Rod DA0 Spring B000 O-Ring, All -Way and Locking -Way Valves CN600 Ring, Non-Locking -Way Valves CN06 Dowel Pin 6 DC90 Mounting Plate DC608 Cap Screw 8 DC0 Comp. Spring, All -Way and Locking -Way Valves DC0 Compression Spring, Non-Locking -Way Valves 9 CN6800 Metal Seal, All -Way and Locking -Way Valves CN6800 Metal Seal, Non-Locking -Way Valves 0 CU86 Valve Stem B0086 Back-Up B000 O-Ring CR9690 Elev. Valve Housing B000 O-Ring, Non-Locking -Way Valves CW86 Spacer B00 O-Ring 6 B090 O-Ring B00890 O-Ring 8 E0000 A/R Solenoid Assembly: V, 60 Hz DA00 A/R Solenoid Assembly: 0V, 60 Hz DA80 A/R Solenoid Assembly: 0/0V, 0 Hz DA060 A/R Solenoid Assembly: VDC 9 CU006 Plug ( Position Valves only) VEP A/R Standard Terminal Plug 0VAC max Items included in and available only as part of Repair Kit MVK. A/R = As Required.

34 Valve Code A, P Valve Code B, G, H Part Number CR8900SR Part Number CR6900SR Description Open Center Description Closed Center Valve Code C, F Valve Code D, M Part Number CR900SR Part Number CR900SR Description Tandem Center Description Float Center Valve Code E Valve Code K Part Number CR80900SR Part Number CR9900SR Description Crossover Center Description Normally Open Center Valve Flow-path Codes Symbol Description Valve Code Symbol Description Valve Code A B P T A B P T A B P T A B P T A B P T A P T -way/-position (/) Open Center -way/-position (/) Closed Center -way/-position (/) Tandem Center -way/-position (/) Float Center -way/-position (/) Crossover Offset -way/-position (/) Tandem Center A B C D E F Figure - Barrel Assemblies and Flow Paths, PER and WER Models A P T A P B P A B P T A P T -way/-position (/) Closed Center -way/-position (/) Normally Closed -way/-position (/) Open Center -way/-position (/) Float Offset -way/-position (/) Normally Open * Requires use of tank port for dump or unloading (valve codes H and K) G H* K* M P

35 Figure - External Pressure Control Valve, PER and WER Models (optional - 0, 0 and 0 Series) Repair Parts List for Figure Item Part Number Qty. Description Item Part Number Qty. Description VS Replacement Valve 9 B00 Spring Pin CW90 Relief Valve Block 0 B00 O-Ring CW90 Valve Seat B6 Back-Up Washer CW0 Piston B90 O-Ring CW0 Spring Guide B06 Back-Up Washer A800 Spring B00890 O-Ring 6 CW90 Valve Body B090 O-Ring CW608 Adjustment Screw 6 A006 Pipe Plug 8 CW00 Valve End Cap Items included in and available only as part of Repair Kit MVK.

36 NOTE: Torque plug (Item ) to 9-0 ft-lbs (-way) 0 (-way) (-way) B (-way) 9 0 (-way only) 6 6 Figure 6 - and -Way Locking Pilot-Operated Check Valves, PER and WER Models (optional - 0, 0 and 0 Series) Repair Parts List for Figure 6 Item Part Number Qty. Description Item Part Number Qty. Description VS -Way P.O. Check 0 CR0 Compression Spring -Way Valve VS6 -Way P.O. Check CR0 Compression Spring -Way Valve CR690 Valve Body B090 O-Ring A006 Pipe Plug -Way Valve B06 Back-Up A006 Pipe Plug -Way Valve CR0 Compression Spring B096 Split Back-Up DA90 Piston -Way Valve B0990 O-Ring CR0 Piston -Way Valve CR006 Plug -Way Valve B090 O-Ring B DA99006 ea. &B Plug -Way Valve 6 B00890 O-Ring 6 CR90 Seat A008 Plug B00806 Ball 8 A860 Spring, -Way Valve 8 B06 Back-Up 9 DA9908 Set Screw 9 B0080 O-Ring 0 C860 Gasket B08 Screw Items included in and available only as part of Repair Kit MVK. 6

37 NOTES:

38 Figure - Dump Valve, PED and WED Models (00 Series) 99 F 8

39 Repair Parts List for Figure Item Part Number Qty. Description Item Part Number Qty. Description DA89900SR Replacement Valve 0V 9 B00 O-Ring DA8900SR Replacement Valve 0V 0 B90 O-Ring A006 Pipe Plug B000 O-Ring R- Plug DA80 0 V. Solenoid P00 Gasket DA80 0 V. Solenoid CB690 Ball Seat B0 O-Ring CU60900SR Relief Valve Assembly DA8090 Seat 6 DA8008 Valve Body DA980 O-Ring A008 Plug 6 DA890 Dump Block 8 B908 Screw B0908 Screw 9 B908 Screw 8 CH90 Ball Guide 0 CU9060 Spring 9 A8080 Spring C860 Gasket 0 B000 O-Ring DA8690 Seat A80000 Plug B0006 Ball CU90 Valve Body DA880 Piston L8608 Set Screw B00 O-Ring B0 O-Ring 6 DSA80990 Valve Seat DA09 Fitting B000 O-Ring 6 DA88900 Cable 8 CA980 Spring B0006 /8" Dia. Ball Items included in and available only as part of Repair Kit DVK. 9

40 , Loctite 0 6 8,9 See Figure A Figure 8A, Relief Valve Assembly 9 Figure 8 - -Way Manual Valve, PEJ, PEM, PES, WEJ, WEM, WES and WET Models (00 Series) 0

41 Repair Parts List for Figure 8 Item Part Number Qty. Description Item Part Number Qty. Description VMP0000D Replacement Valve Y000 Valve Handle B00906 Ball B908 6 Screw B0 O-Ring CN606 Decal B6 Washer 6 A006 Pipe Plug (not shown) C9000 Stem CU90 Valve Body R- Plug 8 A80000 Plug 6 CR90808 Valve Manifold 9 A8080 Spring See Figure 8A Relief Valve Assembly 0 B000 O-Ring 8 P00 Gasket B0 O-Ring 9 CB690 Ball Seat L8608 Set Screw 0 A008 Hex Plug (not shown) CH90 /8" Dia. Ball and Ball B08608 Washer B0006 Guide Assembly A80608 Screw Items included in and available only as part of Repair Kit VMP0000DK.

42 Loctite Figure 9 - -Way Manual Valve, PEJ, PEM, PES, WEJ, WEM, WES and WET Models (0 Series)

43 Repair Parts List for Figure 9 Item Part Number Qty. Description Item Part Number Qty. Description VMF0000D -Way, Position Manual 9 A8000 Detent Disc Valve 0 Y00 Handle VMF000D -Way, Position Manual B08608 Washer Valve w/ Locking Center CB80 Spring B608 Socket Hd.Cap Screw B8908 Capscrew -Way Valve B80 O-Ring (8 in. locking valve) B008 Capscrew -Way Valve DA690 Valve Body with Locking Center B0060 O-Ring A80608 Screw B06 6 Back-Up Ring Note: Items 6-8 are for locking center valves only. 6 DA9600 Metal Seal 6 CR60 Guide Spring B690 O-Ring B680 O-Ring 8 B090 Spring Pin 8 CJ660 Compression Spring 9 CH90SR Disc Assembly 9 B00806 Ball 0 CH60 Shaft 0 B00 O-Ring B000 O-Ring B6 Back-Up Washer B06 Back-Up Ring CK98900 Piston Assembly CB88 Needle Bearing B0090 O-Ring CB0 Bearing Plate B6 Back-Up Washer DA6000 Cap Y690 Seat 6 A8090 Spring 6 CL88990SR Body Assembly with Pin B00606 Ball CR6 Gasket 8 B60 Spring Pin 8 Y8900SR Valve Assembly Items included in and available only as part of Repair Kit VMK.

44 Figure 0 - -Way Manual Valve, PEJ, PEM, PES, WEJ, WEM, WES and WET Models (0 Series)

45 Repair Parts List for Figure 0 Item Part Number Qty. Description Item Part Number Qty. Description VMC0000D -Way, Position Manual Valve VMC0600D -Way, Position Manual Valve w/ Locking Center B608 Socket Hd.Cap Screw B80 8 O-Ring DA690 Valve Body B0060 O-Ring CF0 6 Back-Up Ring Items 6 CB0 Metal Seal B690 O-Ring 8 B090 Spring Pin 9 CH90 Disc Assembly 0 CH60 Shaft B000 O-Ring B06 Back-Up Ring CB88 Needle Bearing CB0 Bearing Plate DA6000 Bonnet 6 A8090 Spring B00606 Ball 8 B60 Spring Pin 9 A8000 Detent Disc Items included in and available only as part of Repair Kit VMK. 0 Y00 Handle B08608 Washer CB0 Spring Guide CB80 Spring B8908 Capscrew -Way Valve B008 Capscrew -Way Valve with Locking Center A80608 Truss Head Screw Note: Items 6-8 are for locking center valves only. 6 CR60 Guide Spring B680 O-Ring 8 CJ660 Compression Spring 9 B00806 Ball 0 B00 O-Ring B6 Back-Up Washer Y8900W Piston Assembly B0090 O-Ring B6 Back-Up Washer Y690 Seat 6 CL88890SR Body Assembly CR6 Gasket 8 Y900SR Valve Assembly

46 NOTES: 6

47 NOTES:

48 Enerpac Worldwide Locations internet: Australia and New Zealand Actuant Australia Ltd. P.O. Box 686 Wetherhill Park, NSW 8 Block V Unit Regents Park Estate 9 Park Road Regents Park NSW Australia T F sales-au@enerpac.com Brazil Power Packer do Brasil Ltda. Rua Luiz Lawrie Reid, Diadema (SP) - Brazil T + 68 Toll Free: vendasbrasil@enerpac.com China (Taicang) Actuant (China) Industries Co. Ltd. No. 6 Nanjing East Road, Taicang Economic Dep Zone Jiangsu, China T F Toll Free: sales-cn@enerpac.com France, Switzerland, North Africa and French speaking African countries ENERPAC Une division d Actuant France S.A.S Zone Orlytech Bâtiment 6 allée du commandant Mouchotte CS 0 90 Paray-Vieille-Poste France T F sales-fr@enerpac.com Germany and Austria Actuant GmbH P.O. Box 00 D-00 Düsseldorf Willstätterstrasse D-09 Düsseldorf, Germany T F sales-de@enerpac.com India Actuant India Private Limited No. 0, Bellary Road, Sadashivanagar, Bangalore, Karnataka India T info@enerpac.co.in Italy ENERPAC S.p.A. Via Canova 009 Corsico (Milano) T F sales-it@enerpac.com Japan Applied Power Japan LTD KK Besshocho 8- Kita-ku, Saitama-shi -08, Japan T F sales-jp@enerpac.com Middle East, Egypt and Libya ENERPAC Middle East FZE Plot M00m nd Street Jebel Ali Free Zone North P.O. Box 800, Dubai United Arab Emirates T +9 (0) F +9 (0) 8868 sales-ua@enerpac.com Russia Rep. office Enerpac Russian Federation Admirala Makarova Street 8 Moscow, Russia T F sales-ru@enerpac.com Norway Sales Office Norway Unit, Nydalsveien 8, 08 Oslo P.O. Box 8, Nydalen 0 Oslo Norway T insidesalesnorway@enerpac.com Southeast Asia, Hong Kong and Taiwan Actuant Asia Pte Ltd. 8 Joo Koon Circle Singapore 6909 T F Toll Free: sales-sg@enerpac.com South Korea Actuant Korea Ltd. Ba, Shihwa Industrial Complex Jungwang-Dong, Shihung-Shi, Kyunggi-Do Republic of Korea 9-0 T F +8 0 sales-kr@enerpac.com Spain and Portugal ENERPAC SPAIN, S.L. Avda. Valdelaparra N ª - L8 808 Alcobendas (Madrid), Spain T F sales-es@enerpac.com Sweden, Denmark Finland and Iceland Enerpac Scandinavia AB Kopparlundsvägen, 0 Västerås Sweden T +6 (0) 0 00 scandinavianinquiries@enerpac.com The Netherlands, Belgium, Luxembourg, Central and Eastern Europe, Baltic States, Greece, Turkey and CIS countries ENERPAC B.V. Galvanistraat, 66 AE Ede P.O. Box 809, 60 AB Ede The Netherlands T F sales-nl@enerpac.com Enerpac Integrated Solutions B.V. Spinelstraat, TS Hengelo P.O. Box, 0 AK Hengelo The Netherlands T + 0 F integratedsolutions@enerpac.com South Africa and other English speaking African countries Enerpac Africa Pty Ltd. No. Bauhinia Avenue Cambridge Office Park Block E Highveld Techno Park Centurion 0 Republic of South Africa T: sales-za@enerpac.com United Kingdom and Ireland ENERPAC UK Ltd. Coopies Field Morpeth, Northumberland NE6 6JR, England T sales-uk@enerpac.com USA, Latin America and Caribbean ENERPAC World Headquarters P.O. Box Milwaukee WI 0- USA N86 W00 Westbrook Crossing Menomonee Falls, Wisconsin 0 T F User inquiries: T Distributor inquiries/orders: T F Technical inquiries: techservices@enerpac.com sales-us@enerpac.com All Enerpac products are guaranteed against defects in workmanship and materials for as long as you own them. For the location of your nearest authorized Enerpac Service Center, visit us at