DRACO 100 BXL-100. Page 1.
|
|
|
- Junior Perkins
- 5 years ago
- Views:
Transcription
1 DRACO 100 BXL-100 Page 1.
2 PARTS ITEM: 01 CYLINDERHEAD 02 CRANKSHAFTPISTON 03 FAN COVERAIR SHROUD 04 AIR CLEANERREED VALVECARBURETOR 05 CRANK CASECOVEROIL PUMP 06 TRANSMISSION 07 KICK SHAFT ASSY.STARTER ClUTCH ASSY. 08 DRIVEN PULLEY (CVT) 09 ENGINE BRACKET 10 GENERATORSTART MOTOR 11 PREARRANGE 12 PREARRANGE 13 MUFFLER 14 FRAME 15 SWING ARM 16 FENDER 17 SEAT 18 FUEL TANKOIL TANK 19 SUSPENSION 20 FRONT WHEEL 21 REAR WHEEL 22 FRONT BRAKE SYSTEM 23 REAR BRAKE SYSTEM 24 HANDLE BAR 25 BUMPERFOOTREST 26 CHAINREAR WHEEL AXLE 27 STEERING CONTENTS Page 2.
3 28 ELECTRICAL EQUIPMENT 29 CARRIER ASSY 30 PACKING CASEEXTERNAL 31 SERVICE KITS,BRAKE CALLIPER 32 CYLINDER+PISTON TOP END KIT N & sign meaning: not available to sale Page 3.
4 01 CYLINDERHEAD 01-1 A2200-B HEAD CYLINDER A2251-B GASKET CYLINDER HEAD I8000-B SPARK PLUG A2100-B CYLINDER A2191-B GASKET CYLINDER I H STUD BOLT (A) I H NUT FLANGE 4 Page 4.
5 02 CRANKSHAFTPISTON 02-1 A3000-B CRANK SHAFT COMP I WOODRUFF KEY I BEARING, BALL, RADIAL I1202-B OIL SEAL I1201-B OIL SEAL B8117-B BOSS A3101-B PISTON A3111-B PIN PISTON (12 40) A3011-B PISTON RING SET I CLIP, PISTON PIN I BEARING, NEEDLE I1100-B BEARING CON-ROD I CIRCLIP EX A5131-B GEAR PUMP DRIVE I KNOCK PIN 1 Page 5.
6 03 FAN COVERAIR SHROUD 03-1 A9620-B AIR SHROUD, CYLINDER A1207-B GROMMET A9610-B COVER COMP FAN A9617-B SEAL SHROUD A9618-B SEAL SHROUD A9616-B CAP FAN COVER I B0 TRUSS I WASHER I C SCREW WASHER I C0 SCREW TAPPING A9510-B FAN I O-RING I H SCREW WASHER H0153-B DEFLECTOR A7910-9FA CABLE ASSY THROT 1 Page 6.
7 04 AIR CLEANERREED VALVE CARBURETOR 04-1 A6201-B GASKET VALVE SEAT A410A-B REED VALVE ASSY A720A-B AIR CLEANER ASSY A7257-B DUCT A7230-B CASE AIR/C A7232-B CAP I TUBE CLIP A7234-B TUBE DRAIN A7205-B WEB AIR/C A7214-B SEAL A7233-B PLATE FIXING CONNECTING TUBE I B0 TRUSS A7231-B COVER AIR/C A7253-B JOIN PIPE AIR CLEANER I TUBE CLIP I C0 SCREW TAPPING A711A-B PIPE INLET ASSY A7110-B PIPE COMP INLET A7256-B BAND CONNECTING TUBE A610A-B CARBURETOR ASSY. # A6111-B BOLT WASHER A6109-B BOLT WASHER A6102-B CARBURETOR COVER A6112-B NUT HEX A6103-B CARBURETOR COVER WASHER KAC31810 THROTTLE VALVE SPRING KAC30310 V CLIP KAC30220 JET NEEDLE ASSY. (#3CR1) N KAC30222 E CLIP N KAC30221 JET NEEDLE (#3CR1) KAC30110 THROTTLE VALVE (#3.0) A6105-B AIR FLOW ADJUSTING SCREW KAC30840 THROTTLE ADJUSTING SCREW KAC30510 SLOW JET (*20) KAC30610 NEEDLE JET (*426 E-1) KAC30485 MAIN JET # A6104-B CARBURETOR BODY 1 1 Page 7.
8 A6118-B O-RING A0001-B NEEDLE VALVE SEAT COMP A6119-B NEEDLE VALVE SEAT N A6119-B NEEDLE VALVE SEAT KAC31120 NEEDLE VALVE ASSY N KAC31120 NEEDLE VALVE ASSY A6120-B PLATE FIXING A6115-B BOLT KAC30910 CHAMBER O-RING KAC31210 FLOAT ASSY A6108-B CARBURETOR CHAMBER KAC31410 DRAIN SCREW A6117-B BOLT WASHER A6106-B RUBBER TUBE A6153-B MANUAL CHOKE VALVE A6152-B SPRING A6113-B O-RING KAC31910 AUTO-BY STARTER A6114-B BOLT WASHER A6101-B CRAB RUBBER CAP I C SCREW WASHER I H FLANGE BOLT, HEX I6001-B BLOT,BREAKING 1 Page 8.
9 05 CRANK CASECOVEROIL PUMP 05-1 A1000-B R L CRANK CASE COMP N A1200-B CRANK CASE (L) N A1100-B CRANK CASE RIGHT A1208-B BUSH A1105-B CAP RUBBER R A1220-B BREATHER COMP N A1206-B BREATHER JOINT N A1221-B HOSE, BREATHER I TUBE CLIP A137A-B BOLT,FLANGE(M6 23.5) A1361-B PLATE I KNOCK PIN I A SCREW PAN A1205-B RUBBER CAP LEFT B1300-B COVER, MISSION B1395-B GASKET, MISSION COVER A1395-B GASKET L COVER I KNOCK PIN I A SCREW PAN A1341-B COVER CRANK CASE L A1342-B SHAFT I A SCREW PAN I A SCREW PAN A5651-B PLUG, OIL I O-RING I H BOLT FLANGE I WASHER A1121-B HOLDER I A SCREW PAN A1393-B GASKET R CRANK CASE I H NUT FLANGE A1362-B ELEMENT A1363-B GUIDE, ELEMENT I CIRCLIP IN A510A-B PUMP ASSY OIL I A SCREW PAN HEAD A135A-B COVER, CRANKCASE ASSY(L) A1351-B COVER, CRANKCASE (L) 1 Page 9.
10 A1352-B DAMPER ENGINE MOUT A1354-B DAMPER ENGINE MOUT A1353-B DAMPER ENGINE MOUT A1356-B DAMPER ENGINE MOUT A1355-B DAMPER ENGINE MOUT 4 1 Page 10.
11 06 TRANSMISSION 06-1 B3420-B COUNTER SHAFT COMP I BEARING, BALL, RADIAL I WASHER I700W SPOKE NIPPLE WASHER B3430-B FINAL SHAFT COMP I BEARING, NEEDLE I BEARING, BALL, RADIAL I1204-B OIL SEAL I CIRCLIP IN I CIRCLIP I WASHER I CIRCLIP EX B3801-B DRIVE CHAIN SPROCKET B3811-A PLATE FIXING I H BOLT 2 Page 11.
12 07 KICK SHAFT ASSY.STARTER ClUTCH ASSY B8250-B SPINDLE COMP KICK START B8281-B SPRING KICK RETURN B8254-B BOSS KICK SPINDLE I WASHER I CIRCLIP EX A1000-5EA RUBBER CAP KICK SHAFT B8300-B KICK CRANK ASSY I WASHER B8115-B BOSS GEAR I BRARING, NEEDLE B8110-B GEAR COMP STARTING CLUTCH B8120-B OUTER COMP ST CLUTCH B823A-B GEAR ASSY STARTER IDLE B8223-B SPG KICK DRIVEN GEAR B8230-B GEAR COMP KICK DRIVEN I WASHER B8100-B GEAR COMP STARTER REDUCTION B8101-B GEAR STARTER REDUCTION I BEARING, NEEDLE B8102-B SHAFT START REDUCTION B8105-B PLATE START REDUCTION I H SCREW WASHER 2 1 Page 12.
13 08 DRIVEN PULLEY (CVT) 08-1 B3411-B SHAFT DRIVE I A WASHER I A SCREW PAN I CIRCLIP EX I BEARING, BALL, RADIAL I1203-B OIL SEAL B301A-B PLATE SUB ASSY DRIVE I1211-B OIL SEAL I1211-B OIL SEAL I O-RING I O-RING B3237-B COLLAR SEAL B3237-B COLLAR SEAL B3233-B SPG DRIVEN FACE B3233-B SPG DRIVEN FACE B2300-B PLATE COMP DRIVE B2300-B PLATE COMP DRIVE I A0 NUT HEX I A0 NUT HEX B2101-B OUTER CLUTCH B2101-B OUTER CLUTCH B3210-B FACE COMP DRIVEN B3210-B FACE COMP DRIVEN B3220-B FACE COMP MOVABLE DRIVE B3225-B PIN GUIDE B3225-B PIN GUIDE B3220-B FACE COMP MOVABLE DRIVE I H NUT FLANGE I BEARING, BALL, RADIAL I O-RING B211A-B FACE ASSY MOVABLE DRIVE B2121-B ROLLER COMP WEIGHT B2110-B FACE COMP MOVABLE DRIVE B2132-B PIECE SLIDE B2131-B PLATE RAMP B2105-B BOSS DRIVE FACE B3100-B BELT DRIVE B2102-B FACE DRIVE 1 Page 13.
14 08-15 B8211-B CLUTCH, ONEWAY I700W SPOKE NIPPLE WASHER I C0 NUT HEX B2103-B WASHER DRIVE FACE 1 Page 14.
15 09 ENGINE BRACKET 09-1 AB000-B ENGINE, ATV A1261-B PIN, PIVOT I H HEX. NUT, SAFETY A1241-B ENGINE BRACKET I H BOLT FLANGE I H0 NUT HEX I WASHER 1 Page 15.
16 10 GENERATORSTART MOTOR 10-1 C1120-B STATOR COMP N C1121-B STATOR N I1205-B OIL SEAL C1110-B FLYWHEEL COMP I WASHER I H NUT FLANGE I A SCREW PAN C1200-B MOTOR START COMP C1220-B CARBON BRUSH COMP N C1221-B POSITIVE CARBON BRUSH N C1222-B NEGATIVE CARBON BRUSH I H FLANGE BOLT, HEX. 2 Page 16.
17 No picture. ITEM AVAIL PART NO. NAME QTY 11 PREARRANGE Page 17.
18 No picture. ITEM AVAIL PART NO. NAME QTY 12 PREARRANGE Page 18.
19 13 MUFFLER 13-1 A830A-5PA MUFFLER ASSY A8291-5AA GASKET ( ) I BOLT,FLANGE I BOLT,FLANGE A7400-5PA AICV COMP A7402-5PA AICV BODY A7403-5PA AICV WEB A7404-5PA AICV FILTER I C5 TAPPING SCREW, PAN A7405-5PA FIXED PLATE, REED VALVE A7406-5PA REED VALVE A7407-5PA SEAL A7408-5PA CAP, AICV I C5 TAPPING SCREW,PAN I BOLT+WASHER A7410-5PA REED VALVE TUBE A7411-5PA REED VALVE TUBE A7411-5PA REED VALVE TUBE A7412-5PA CLIP A7412-5PA CLIP A7420-5PA CONNECTING TUBE ASSY A7421-5PA CONNECTING TUBE A7412-5PA CLIP A7422-5PA CLAMP, TUBE I FLANGE BOLT, HEX. 1 Page 19.
20 14 FRAME 14-1 E0100-9PA FRAME COMP E0350-9PA ENGINE SUSPENSION (L) E0105-9PA SUPPORT BAR,FRONT FENDER E7401-BCA RUBBER,BUFFER E0352-5PA SCREW,TETRAGON ROUND HEAD 14-6 I FLANGE NUT CHECK E0330-9PA ENGINE,REAR SUSPENSION(UP) E0331-9PA PRECAUTION BUSH I A BOLT,FLANGE (M10 37) H7501-APA VIN NO. PLATE H750A-5BA NAIL, PULL E0110-9PA SUPPORT BAR,REAR FENDER I FLANGE BOLT, HEX E0340-9PA ENGINE,REAR SUSPENSION(DOWN) N E0201-4HA BUSH ( ) I G BOLT,FLANGE(M8 135) G7212-5EA RUBBER DAMPER I NUT,FLANGE G7232-5PA RUBBER I WASHER( t) Page 20.
21 15 SWING ARM 15-1 E0200-9PA ARM, SUSPENSION, L.H E0201-9FA BUSH, ARM SUSPENSION E0210-9PA ARM, SUSPENSION, R.H E0201-9FA BUSH, ARM SUSPENSION I BOLT,FLANGE I FLANGE NUT CHECK E220A-9PA SWING ARM SUB ASSY N E2208-5EA SWING ARM OIL LINER E2201-FIA FLANGE BOLT, HEX I HEX. FLANGE NUT, SAFETY I BOLT,FLANGE I BOLT,FLANGE I BOLT,FLANGE E2209-FIA SPACER E2205-5EA OIL SEAL I GREASE VALVE E0209-5EA CAP, GREASE VALVE 1 Page 21.
22 16 FENDER 16-1 F4300-9PA FRONT FENDER(RED) F4300-9PA FRONT FENDER(SILVER) F4300-9PA FRONT FENDER(BLUE) H3500-9PA REAR FENDER(RED) H3500-9PA REAR FENDER(BLUE) H3500-9PA REAR FENDER(SILVER) I TAPPING SCREW, TRUSS H3620-9PA FOOTREST, PLACTIC PART, RIGHT 16-5 H3520-9PA FOOTREST, PLACTIC PART, LEFT 16-6 E3205-5PA COVER,HANDLE BAR UP (BLACK) C3101-FIA INDICATE(RED) H7101-5EE STICKER,OIL PILOT LAMP I SCREW I G HEX. FLANGE NUT, SAFETY F3100-5PA HEAD LIGHT, GUARD(RED) F3100-5PA HEAD LIGHT, GUARD(BLUE) F3100-5PA HEAD LIGHT, GUARD(SILVER) I C TAPPING SCREW, TRUSS C7203-5PA SPEEDOMETER BRACKET ASSY I BOLT+WASHER I BOLT, HEX H7100-5PA LABEL TIRE H7107-5EB EMBLEM, E-TON LOGO(SILVER) E3206-5PA HANDLE COVER,LOWER(BLACK) H7121-5PA STICKER,FRONT FENDER H7103-APA STICKER,DRACO BXL-100(LEFT) H7104-APA STICKER,DRACO BXL- 100(RIGHT) H7124-9PA STICKER,FRONT FRAME COVER(L) H7125-9PA STICKER,FRONT FRAME COVER(R) H3502-5PA PLUG E0117-9EA SCREW, TRUSS Page 22.
23 17 SEAT 17-1 G7200-5PA SEAT ASSY G7201-9PA SEAT FIXER ASSY G7204-9PA BOTTOM COVER ASSY G7205-9PA BOTTOM COVER,SCREW 1 Page 23.
24 18 FUEL TANKOIL TANK 18-1 A7500-5PA FUEL TANK ASSY C780A-FIA METER FUEL LEVER A6701-FIA FUEL COCK ASSY I CROSS BOLT, HEX A7510-9FA FUEL FILTER ASSY A7519-FIA FUEL FILTER A7516-5EA CLIP(A) A7514-9FA FUEL TUBE (A) A7515-9FA FUEL TUBE (B) A7622-9FA RUBBER PAD, FUEL TANK CAP A762A-9FA FUEL TANK CAP ASSY A7620-9FA FUEL TANK CAP A7620-9FA FUEL TANK CAP A7621-9FA TUBE, RUBBER A7621-9FA TUBE, RUBBER I BOLT, HEX E5100-9PA OIL TANK ASSY E5105-9FA OIL TANK CAP ASSY C5410-5EE OIL TANK BUOY E5108-9FA RUBBER PAD A751B-FIA VACUUM TUBE COMP A7518-FIA CLIP A7518-FIA CLIP 2 Page 24.
25 19 SUSPENSION 19-1 E1105-9FA SUSPENSION, FRONT E2400-9PA SUSPENSION, REAR I B BOLT HOLE I PIN, SPLIT 6 Page 25.
26 20 FRONT WHEEL 20-1 D471A-5PA FRONT WHEEL ASSY.,LEFT D4710-5PA FRONT WHEEL TIRE(19 7-8) D4602-5EB WHEEL RIM D471B-5PA FRONT WHEEL ASSY.,RIGHT D4710-5PA FRONT WHEEL TIRE(19 7-8) D4602-5EB WHEEL RIM D4610-5PA BRAKE DRUM, FRONT RIGHT D4612-9FA BOLT,STUD I Z OUTER BEARING( ) I Z INNER BEARING( ) D4624-9FA OUTER OIL SEAL( ) D4623-9FA INNER OIL SEAL( ) D4621-9FA OUTER SPACER ( ) D4620-9FA INNER SPACER( ) D4611-9FA GASKET, ANTIDUST D4611-9EA NUT, FLANGE CHECK(M10) I WASHER I CASTLE NUT I SPLIT PIN D4609-9FA RUBBER CAP D4610-9FA BRAKE DRUM, FRONT D4612-9FA BOLT,STUD C7205-5PA MAGNET D4613-5PA SCREW 1 Page 26.
27 21 REAR WHEEL 21-1 N D471C-5PA REAR WHEEL ASSY.,LEFT D4711-5PA REAR WHEEL TIRE ASSY N D4601-5FA WHEEL RIM D471D-5PA REAR WHEEL ASSY.,RIGHT D4711-5PA REAR WHEEL TIRE ASSY N D4601-5FA WHEEL RIM D2705-9EA SHAFT CONNECTER WITH BOLTS 21-4 D4611-9EA NUT, FLANGE CHECK(M10) D2309-5EA WASHER I WASHER I CASTLE NUT I SPLIT PIN D4609-5EA RUBBER CAP 2 2 Page 27.
28 22 FRONT BRAKE SYSTEM 22-1 D5351-5PA FRONT BRAKE PANEL COMP., LEFT 22-2 D5352-9FA FRONT BRAKE PANEL COMP., RIGHT 22-3 I BOLT, SOCKET D5120-9FA FRONT BRAKE SHOE COMP. (80) D5141-FIA FRONT BRAKE ARM CAM D5149-5EA FELT SEAL D5410-9FA FRONT BRAKE ARM, LEFT D5411-9FA FRONT BRAKE ARM,RIGHT I BOLT HEX E5450-9PA CABLE, FRONT BRAKE E5452-9FA NUT,ADJUSTING E5457-FIC BRAKE ALLOT ASSY E5458-FIC BRAKE BALANCE ASSY I FLANGE BOLT, HEX E5453-9PA CABLE,FRONT BRAKE ALLOT ASSY D3416-FIC FRONT SPRING BRAKE(L=65) Page 28.
29 23 REAR BRAKE SYSTEM 23-1 D2310-5EE REAR WHEEL BEARING SEAT ASSY 23-2 D2311-5EA SPACER I ZZ BEARING, BALL RADIAL D2313-9EA OIL SEAL G7130-5EE BRAKE CALLIPER G7131-5EE BRAKE SHOE COMP G7131-5EE BRAKE SHOE COMP G7132-5EE BOLT LEAKAGE G7132-5EE BOLT LEAKAGE G7133-BCA CAP LEAKAGE G7133-BCA CAP LEAKAGE G7139-5EE SPRING,PAO G7134-5EE RING,SEAL G7136-5EE PISTON, BRAKE CALIPER G7135-5EE RING,DUST RESISTANT G71C1-5EE BOOT G71C2-5EE BOOT G71C3-5EE BRACKET, CALLIPER D0114-9EA SPACER D3520-FIA BRAKE DISK D3251-5EE BRAKE DISK MOUNTING SEAT E3450-9PA CABLE,BRAKE REAR ASSY D3210-9PA BRAKE OIL TUBE I BOLT FLANGE I BOLT, HEXAGON SOCKET HEAD I BOLT FLANGE I WASHER I BOLT FLANGE I SPRING WASHER D3211-9KA CLIP E0452-9PA CABLE, PEDAL MIDDLE BRAKE ASSY D3200-9PA BRAKE MASTER CYLINDER D3206-9PA BRAKE OIL RESERVOIR D3207-9PA BRAKE RESERVOIR OIL TUBE E0708-9PA PEDAL COMP BRAKE I5016-EGA SPRING Page 29.
30 23-22 I GREASE VALVE E0209-5EA CAP, GREASE VALVE I BOLT FLANGE D3410-9PA BRAKE MASTER CYLINDER BRAKE ARM D3419-9PA RETURN SPRING G7202-9PA SWITCH (FLOOR) E0711-9PA SPRING, BRAKE LAMP SWITCH I B PIN I N E CLIP, EX I K CLIP,E TYPE(15) I K PLAIN WASHER(19x25) I BOLT, SOCKET I SCREW WASHER D3416-FIC FRONT SPRING BRAKE(L=65) 1 1 Page 30.
31 24 HANDLE BAR 24-1 E3100-FIA HANDLE BAR ASSY E3180-9PA LEVEL ASSY., (RIGHT) E3181-9PA LEVEL SET,(RIGHT) E319A-5EA LEVEL ACCELERATE E3174-9PA BRAKE SWITCH ASSY E3170-FIC LEVER ASSY., LEFT E3171-FIA LEVEL,LEFT E3166-5EA GRIP E3112-5EA BOTTOM,HANDLE BAR CLAMP E3110-5EA CAP,HANDEL BAR CLAMP(L) E3111-5EA CAP,HANDEL BAR CLAMP(R) I BOLT, SOCKET I FLANGE NUT CHECK E3113-5FA A MIRRER BRACKET (LEFT) E3114-5FA A MIRROR BRACKET,RIGHT C720A-5PA SPEEDOMETER ASSY C7200-5PA SPEEDOMETER C7207-5PA METER SENSOR I A NUT C7202-5PA FUEL METER ASSY. 1 Page 31.
32 25 BUMPERFOOTREST 25-1 E0700-9PA FOOTREST BAR,LEFT ASSY E0706-9PA FOOTREST BAR,RIGHT ASSY I H BOLT FLANGE I SCREW, OVAL E0400-9PA BUMPER FRONT, ASSY I FLANGE BOLT, HEX E0410-5PA BUMPER REAR ASSY I BOLT,FLANGE E0402-9FA COLLAR,BUMPER I NUT,FLANGE 2 Page 32.
33 26 CHAINREAR WHEEL AXLE 26-1 D0100-9FA DRIVE CHAIN ASSY. (#520,48) D0104-9EA DRIVE CHAIN LINK(#520) D0101-9FA PROTECT COVER D2301-9EA REAR AXLE D0110-9EA DRIVE CHAIN ASSY.(28T) D0111-9EA SPROCKET HOLDER, REAR D0111-9EA SPROCKET HOLDER, REAR D1111-9EA GEAR(28T) D1111-9EA GEAR(28T) D2706-9EA BOLT D2706-9EA BOLT I FLANGE NUT CHECK I FLANGE NUT CHECK D2302-9EA NUT, REAR WHEEL AXLE D0120-9EA ADJUSTER, CHAIN I FLANGE BOLT, HEX D0510-9FA DRIVE CHAIN COVER 1 Page 33.
34 27 STEERING 27-1 E3200-5PA SHAFT ASSY., STEERING I3102-5AC OIL SEAL I C CLIP EX I ZZ BEARING (6002ZZ) D4620-5EA INNER SPACER E3201-5EA OIL SEAL I HEX. FLANGE NUT, SAFETY I PIN, SPLIT E0258-9PA STEERING TIE-ROD ASSY., LEFT E0251-9FA BOLT,STUD E0255-FIA UNIVERSAL JOINT(L) E0256-FIA UNIVERSAL JOINT(R) E0252-5EA NUT (R) E0253-5EA NUT (L) E0259-9PA STEERING TIE-ROD ASSY., RIGHT E0251-9FA BOLT,STUD E0255-FIA UNIVERSAL JOINT(L) E0256-FIA UNIVERSAL JOINT(R) E0252-5EA NUT (R) E0253-5EA NUT (L) E0205-9FA KNUCKLE, LEFT ASSY D5142-9FA SLEEVE,FRONT BRAKE ARM CAM D5144-9FA FRONT BRAKE DRUM E0206-9FA OIL LINER(17) E0215-9FA KNUCKLE, RIGHT ASSY E0211-9FA SLEEVE E0203-9FA CAP I A FLANGE BOLT, HEX I FLANGE NUT CHECK I GREASE VALVE E0209-5EA CAP, GREASE VALVE E3225-5EA PU LINER E3202-9FA HOLDER, STEERING COLUMN E3203-9FA FIX PLATE, STEERING SHAFT I BOLT(M8 55) Page 34.
35 28 ELECTRICAL EQUIPMENT 28-1 C2100-5PA MAIN WIRE ASSY C1500-9FA BATTERY C1501-9FA FOAM STICK, BATTERY C1502-9FA RUBBER CLAMP, BATTERY(89L) C501A-5PA MAIN SWITCH ASSY C5010-9FA MAIN SWITCH C5010-9FA MAIN SWITCH C5013-9FA MATERIAL KEY (RIGHT CUT) C5013-9FA MATERIAL KEY (RIGHT CUT) C5018-9FA MATERIAL KEY (LEFT CUT) C5018-9FA MATERIAL KEY (LEFT CUT) C5011-FIC FAUCET LOCK C5011-FIC FAUCET LOCK C5013-9FA MATERIAL KEY (RIGHT CUT) C5013-9FA MATERIAL KEY (RIGHT CUT) C5018-9FA MATERIAL KEY (LEFT CUT) C5018-9FA MATERIAL KEY (LEFT CUT) C5201-FIC LEVER HOLDER ASSY I BOLT, HEX I SCREW, PAN HEAD I FLANGE BOLT, HEX C8110-5EE HORN I SCREW PAN I SCREW PAN C051A-5EE IGNITION COIL ASSY C0410-B C.D.I. UNIT ASSY C1600-B RECTIFIER COMP REGULATE C5400-B RESISTOR ASSY C5850-B STARTER RELY ASSY C3451-5PA FRONT TURN LAMP ASSY LEFT F1231-5PA BULB C3401-5PA FRONT TURN LAMP ASSY RIGHT F1231-5PA BULB F1240-5PA REAR TURN LAMP ASSY,LEFT F1231-5FA BULB F1230-5PA REAR TURN LAMP ASSY.,RIGHT F1231-5FA BULB C3700-5BA TAIL LIGHT ASSY 1 Page 35.
36 C5004-5BA LAMP C5004-5BA LAMP C510C-FIA RUBBER PAD I G HEX. FLANGE NUT, SAFETY C830A-5PA FLY RELAY C8302-EGA CUSHION WINKER C8302-EGA CUSHION WINKER C1501-5FA FOAM STICK I SCREW, PAN I8501-5BA BOLT,BROKENABLE E3101-5PA FRONT TURN LAMP FIXED SLICE I C TAPPING SCREW, TRUSS C5850-FIC RELAY 1 Page 36.
37 29 CARRIER ASSY 29-1 E0411-9PA REAR RACK H7113-9FA STICKER, REAR RACK I BOLT,FLANGE I NUT,FLANGE E0402-9FA COLLAR,BUMPER E0413-9PA FRONT RACK ASSY I FLANGE BOLT, HEX I FLANGE BOLT, HEX. 2 Page 37.
38 30 PACKING CASEEXTERNAL 30-1 H9500-5PA PACKING CASE,EXTERNAL C5030-5PA HEAD LIGHT ASSY C5003-5PA BULB C5003-5PA BULB N H9900-5PA OWNER'S MANUAL H8100-5BA1-E000 BACK MIRROR ASSY N H8110-5BA1-E000 BACK MIRROR, RIGHT H8110-5BA1-E000 BACK MIRROR, RIGHT N H8120-5BA1-E000 BACK MIRROR, LEFT H8120-5BA1-E000 BACK MIRROR, LEFT H9020-9FA TOOL SET F1103-BCA ADTUST BOLT I B WASHER C1502-9FA RUBBER CLAMP, BATTERY(89L) H9905-APA CERTIFICATE OF ORIGIN 1 Page 38.
39 No picture. ITEM AVAIL PART NO. NAME QTY 31 SERVICE KITS,BRAKE CALLIPER 31-1 G7137-5EE SERVICE KITS, BRAKE CALIPER G7134-5EE RING,SEAL G7134-5EE RING,SEAL G7135-5EE RING,DUST RESISTANT G7135-5EE RING,DUST RESISTANT G7136-5EE PISTON, BRAKE CALIPER G7136-5EE PISTON, BRAKE CALIPER G7138-5EE BRAKE SHOE ASSY G7131-5EE BRAKE SHOE COMP G7139-5EE SPRING,PAO 1 Page 39.
40 No picture. ITEM AVAIL PART NO. NAME QTY 32 CYLINDER+PISTON TOP END KIT A21AA-B CYLINDER+PISTON TOP END KIT A2100-B CYLINDER A2191-B GASKET CYLINDER A2251-B GASKET CYLINDER HEAD A3011-B PISTON RING SET A3101-B PISTON A3111-B PIN PISTON (12 40) I1100-B BEARING CON-ROD I CIRCLIP EX 2 Page 40.
VIPER 90 RXL-90. Page 1.
VIPER 90 RXL-90 Page. PARTS ITEM: 0 CYLINDER, HEAD 02 CRANKSHAFT, PISTON 03 FAN COVER, AIR SHROUD 04 AIR CLEANER, REED VALVE, CARBURETOR 05 CRANK CASE, COVER, OIL PUMP 06 TRANSMISSION 07 KICK SHAFT ASSY.,
VIPER 50 RXL-50. Page 1.
VIPER 50 RXL-50 Page. PARTS ITEM: 0 CYLINDER, HEAD 02 CRANKSHAFT, PISTON 03 FAN COVER, AIR SHROUD 04 AIR CLEANER, REED VALVE, CARBURETOR 05 CRANK CASE, COVER, OIL PUMP 06 TRANSMISSION 07 KICK SHAFT ASSY.,
RXL-50 PARTS ITEM: 01 CYLINDER, HEAD 02 CRANKSHAFT, PISTON 03 FAN COVER, AIR SHROUD 04 AIR CLEANER, REED VALVE, CARBURETOR 05 CRANK CASE, COVER, OIL P
RXL-50 PARTS ITEM: 01 CYLINDER, HEAD 02 CRANKSHAFT, PISTON 03 FAN COVER, AIR SHROUD 04 AIR CLEANER, REED VALVE, CARBURETOR 05 CRANK CASE, COVER, OIL PUMP 06 TRANSMISSION 07 KICK SHAFT ASSY., STARTER CLUTCH
ATV 90 UTILITY CALIFORNIA GREEN (A2008KUB2BCAG) Page 1 of 58 AIR INTAKE ASSEMBLY
2008 ATV 90 UTILITY CALIFORNIA GREEN (A2008KUB2BCAG) Page 1 of 58 AIR INTAKE ASSEMBLY 2008 ATV 90 UTILITY CALIFORNIA GREEN (A2008KUB2BCAG) Page 2 of 58 AIR INTAKE ASSEMBLY Ref # Part Number Qty S/P/F Description
ATV 50 DVX BLACK-RED (A2008KSA2BUSD) Page 1 of 60 AIR INTAKE ASSEMBLY
2008 ATV 50 DVX BLACK-RED (A2008KSA2BUSD) Page 1 of 60 AIR INTAKE ASSEMBLY 2008 ATV 50 DVX BLACK-RED (A2008KSA2BUSD) Page 2 of 60 AIR INTAKE ASSEMBLY Ref # Part Number Qty S/P/F Description 1 3303-005
ATV 90 UTILITY GREEN (A2006KUB2BUSG) Page 1 of 60 AIR INTAKE ASSEMBLY
2006 ATV 90 UTILITY GREEN (A2006KUB2BUSG) Page 1 of 60 AIR INTAKE ASSEMBLY 2006 ATV 90 UTILITY GREEN (A2006KUB2BUSG) Page 2 of 60 AIR INTAKE ASSEMBLY Ref # Part Number Qty S/P/F Description 1 3303-005
DVX 90 MODEL NUMBER A2008KSB2BUSD (BLACK-RED) MODEL NUMBER A2008KSB2BUSE (BLACK-CAT GREEN) MORE TO GO ON. TM
2008 DVX 90 Illustrated Parts Manual MODEL NUMBER A2008KSB2BUSD (BLACK-RED) MODEL NUMBER A2008KSB2BUSE (BLACK-CAT GREEN) MORE TO GO ON. TM TABLE OF CONTENTS Black-Red (Model No. A2008KSB2BUSD) Black-Cat
Page 2.
CXL-150 PARTS ITEM: 01 CRANK CASE, L COVER, SPINDLE ASSY. 02 CRANK SHAFT, PISTON, CYLINDER, TENSIONER 03 OIL PUMP, STARTING MOTOR 04 RIGHT CRANK CASE COVER, GENERATOR 05 COVER HEAD, HEAD, CAM SHAFT, VALVE
B B B
FIG CYLINDER Suzuki Worldwide Motorcycle-ATV Page: of -0B00-00 0-00 0-000 0-00 0-0B0-0B0 0-0 0-0 Head, Cylinder Gasket, Cylinder Head Spark Plug (ngk,bphs) Spark Plug (nd,wfp-u) Cylinder Gasket, Cylinder
SMF / DSF / DTF SMF / DSF / DTF 200
2006 SMF / DSF / DTF 200 1 The drawings in this parts book have been scaled so that parts can be easily recognized. 1 CYLINDER ASSY 2 CYLINDER ASSY Ref # Part # Description 1 410 0001A CYLINDER HEAD COVER
ATV 50 Y-6 YOUTH CAT GREEN (A2004ATA2BUSZ) Page 1 of 50 A-ARM, FLOOR PANEL, AND BUMPER ASSEMBLY
2004 ATV 50 Y-6 YOUTH CAT GREEN (A2004ATA2BUSZ) Page 1 of 50 A-ARM, FLOOR PANEL, AND BUMPER ASSEMBLY 2004 ATV 50 Y-6 YOUTH CAT GREEN (A2004ATA2BUSZ) Page 2 of 50 A-ARM, FLOOR PANEL, AND BUMPER ASSEMBLY
Figure 1. - Cylinder / Cylinder Head
Page 1 of 42 Figure 1. - Cylinder / Cylinder Head Figure 1. Cylinder / Cylinder Head 1 11111-STG-00 Cylinder comp 1 2 11121-STG-00 Head comp, cylinder 1 3 11127-CHP-00 Nut, cylinder head 1 4 11141-ROA-00
HAMMERHEAD GT200. Page 1 of 9
HAMMERHEAD GT200 Figue Part Number Description F1-1 M200-0101 CYLINDER HEAD SUBASSY F1-2 98056-57713-00 SPARK PLUG (C7HSA NGK) F1-3 M150-1001010 CYLINDER HEAD GASKET F1-4 M150-1001004 CARBURETOR INSULATOR
COMPONENT LOCATIONS B C D G F C D F G
E ABCDEF 0000 COMPONENT LOCATIONS O H B C D G F J M L K P I O N B A C D J H A E I F G N M FIG. CYLINDER HEAD ASSY. 0 0 0 PARTS MANUAL CYLINDER HEAD ASSY. M0-00-0 HEAD CYLINDER SUBASSY 0--00 PLUG SPARK(CHSA
DL601 PARTS MANUAL (T-REX 2001)
DL601 PARTS MANUAL (T-REX 2001) TABLE OF CONTENTS ENGINE ASSEMBLIES: CYLINDER... 2 CRANKSHAFT & PISTON... 4 AIR SHROUD & FAN... 6 OIL PUMP... 8 INTAKE HOUSING & AIR FILTER... 10 CARBURETOR... 11 CRANKCASE...
ETON America PARTS CATALOG. Beamer PN-2
ETON America PARTS CATALOG Beamer PN- Table of Contents Beamer PN- PrdImg: \\Nt4serv\EtonData Figure No. 0 03 04 05 06 07 08 09 0 3 4 5 6 7 8 9 0 3 4 9 Content Referance Cylinder, Crankshaft and Piston
Hammerhead Rave 150. Parts Manual. This Vehicle is designed for off-road use only
Hammerhead Rave 0 Parts Manual This Vehicle is designed for off-road use only FIG. CYLINDER HEAD ASSY. 0 0 0 CYLINDER HEAD ASSY. REF NO. PART NO. DESCRIPTION REGD NO. M0-00-0 CYLINDER HEAD SUBASSY 0--00
GTS150. Dune Buggy MINIMUM RECOMMENDED OPERATOR AGE: FOR OFF-ROAD USE ONLY. 10th letter in VIN: D-G
0-06 GTS50 0th letter in VIN: D-G Dune Buggy MINIMUM RECOMMENDED OPERATOR AGE: 6 FOR OFF-ROAD USE ONLY This vehicle is designed and manufactured for off-road use only. USA only: It does not conform to
Description. Copyright 2005 Suzuki Worldwide Motorcycle-ATV. All Rights Reserved.
LT0K (LT0K P) FIG GASKET SET Suzuki Worldwide Motorcycle-ATV Page: of 0 0-0 -00-0B0-0B0 -A0 -E00-000 -0B0 0-000 0-000 0-00 00-00 00-00 00-00 Gasket Set Gasket, Cylinder Head Gasket, Cylinder Gasket, Clutch
01 CYLINDER HEAD COVER 4 02 CRANKSHAFT, PISTON 6 03 FAN, AIR SHROUD 8 04 OIL PUMP (EPA) REED VALVE, AIR CLEANER CARBURETOR 14
Parts Manual 1 2 CONTENTS PAGE 01 CYLINDER HEAD COVER 4 02 CRANKSHAFT, PISTON 6 03 FAN, AIR SHROUD 8 04 OIL PUMP (EPA) 10 05 REED VALVE, AIR CLEANER 12 06 CARBURETOR 14 07 EXHAUST 16 08 CRANKCASE 18 09
90 Y-12 Youth. Model Number A2005H4B2BUSR (Red) Model Number A2005H4B2BUSZ (Cat Green) Illustrated Parts Manual
90 Y-12 Youth Model Number A2005H4B2BUSR (Red) Model Number A2005H4B2BUSZ (Cat Green) Illustrated Parts Manual 2005 TABLE OF CONTENTS 2005 ATV 90 Y-12 Youth Red (Model No. A2005H4B2BUSR) Cat Green (Model
HAMMERHEAD KT150. Illustrated Parts Manual
HAMMERHEAD KT0 Illustrated Parts Manual FIG. CYLINDER HEAD ASSY. 0 0 CYLINDER HEAD ASSY. REF NO. PART NO. DESCRIPTION REGD NO. M0-0-0 CYLINDER HEAD SUBASSY 0--00 SPARK PLUG (CHSA NGK) M0-0 CYLINDER HEAD
D-1: FAN COVER. DESCRIPTION 1 Asm., Shroud, Upper
D-: FAN COVER Asm., Shroud, Upper 9639-000 Screw, Tappinmg 9390-305068-00K 3 Clamp 9689-000 Plug, Rubber 96339-000 5 Elbow, Outlet 9650-000 6 Bolt 96000-06058-08C 3 7 Cover Set, Fly Wheel 9609-00 8 Cap
PARTS CATALOGUE. Rockford Motors inc.
PARTS CATALOGUE Rockford Motors inc. INSTRUCTIONS FOR USING THE PARTS CATALOGUE 1. This catalogue covers all the items of genuine parts and tools of BRIDGESTONE 350 GTR and 350 GTO motorcycles. 2. Please
01 CYLINDER HEADCOVER 4 02 CRANKSHAFT, PISTON 6 03 FAN SHROUD 8 04 OIL PUMP REED VALVE AIR CLEANER CARBURETOR EXHAUST 16
Parts Manual 1 2 CONTENTS PAGE 01 CYLINDER HEADCOVER 4 02 CRANKSHAFT, PISTON 6 03 FAN SHROUD 8 04 OIL PUMP 10 05 REED VALVE AIR CLEANER 12 06 CARBURETOR 14 07 EXHAUST 16 08 CRANKCASE 18 09 STARTER 20 10
ETON America PARTS CATALOG
ETON America PARTS CATALOG Matrix 50 Parts and drawing are subject to change without notice. ETON America reserves the right to substitute parts that have engineering changes that can alter the appearance
90 Utility Model Number A2013KUB2BUSZ SHARE OUR PASSION.
2013 90 Utility Model Number A2013KUB2BUSZ TM SHARE OUR PASSION. TABLE OF CONTENTS 2013 ATV 90 (Model No. A2013KUB2BUSZ) BODY PANEL AND HEADLIGHT ASSEMBLY... 1 FRONT AND REAR RACK ASSEMBLY... 2 FRAME AND
1. COVER COMP CYLINDER HEAD
CONTENTS FIG. 1 COVER COMP CYLINDER HEAD FIG. 2 CAMSHAFT COMP FIG. 3 HOLDER CAMSHAFT COMP FIG. 4 CYLINDER HEAD COMP FIG. 5 CARBURETOR FIG. 6 AIR CLEANER FIG. 7 LEFT CRANKCASE COVER FIG. 8 DRIVE PULLEY
CYLINDER. Ref. Part No. Number Description Qty Remarks
A1 A2 A3 A4 CYLINDER 1 2GU-11111-00-00 HEAD, CYLINDER 1......... 1 2 NGK-B8ES0-00-00 PLUG, SPARK (NGK B8ES)... 2 3 90116-08394-00 BOLT, STUD.............. 8 4 95917-08640-00 BOLT, STUD.............. 2
ETON America PARTS CATALOG
ETON America PARTS CATALOG Parts and drawing are subject to change without notice. ETON America reserves the right to substitute parts that have engineering changes that can alter the appearance of the
CYLINDER. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER 1 2GU-11111-00-00 HEAD, CYLINDER 1......... 1 2 NGK-B8ES0-00-00 NGK B8ES 10PK........... 2 3 90116-08394-00 BOLT, STUD.............. 8 4 95912-08640-00 BOLT, STUD.............. 2 5 90179-08491-00
CYLINDER HEAD. Ref. Part No. Number Description Qty Remarks
A1 A2 A3 A4 CYLINDER HEAD 1 3FA-11110-01-00 CYLINDER HEAD ASSY...... 1 2 90116-06541-00. BOLT, STUD............. 2 3 22F-11134-10-00. GUIDE, EXHAUST VALVE... 2 4 93440-10109-00. CIRCLIP.................
ETON America PARTS CATALOG. Matrix R4-150
ETON America PARTS CATALOG w.getitparts.com Matrix R4-50 www.getitparts.com Parts and drawing are subject to change without notice. ETON America reserves the right to substitute parts that have engineering
ETON America PARTS CATALOG
ETON America PARTS CATALOG Yukon II CXL-50 Parts and drawing are subject to change without notice. ETON America reserves the right to substitute parts that have engineering changes that can alter the appearance
ETON America PARTS CATALOG
ETON America PARTS CATALOG Beamer Parts and drawing are subject to change without notice. ETON America reserves the right to substitute parts that have engineering changes that can alter the appearance
X150 National Extreme 150cc Atv (VIN PREFIX RKKG)
Page 1 of 25 Product Information Baja Web > Product Information > Parts Lists > ATV > X150 National Extreme 150cc Atv (VIN PREFIX RKKG) X150 National Extreme 150cc Atv (VIN PREFIX RKKG) Cylinder Head [Image]
CYLINDER HEAD. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER HEAD 1 JN6-11102-00-00 HEAD, CYLINDER.......... 1 2 JN6-11133-10-00. GUIDE, VALVE............ 2 3 JN6-11181-00-00 GASKET, CYLINDER HEAD... 1 4 95817-10070-00 BOLT, FLANGE............ 4 5 99530-14016-00
DVX 300 Euro. Model Number A2012KSF2BEUK SHARE OUR PASSION.
ATV 2012ATV Illustrated Parts Manual DVX 300 Euro Model Number A2012KSF2BEUK TM SHARE OUR PASSION. TABLE OF CONTENTS 2012 ATV DVX 300 Euro (Model No. A2012KSF2BEUK) BODY PANEL AND HEADLIGHT ASSEMBLY...
ETON America PARTS CATALOG
ETON America PARTS CATALOG Viper 70 Parts and drawing are subject to change without notice. ETON America reserves the right to substitute parts that have engineering changes that can alter the appearance
400 4x4 Euro MODEL NUMBER A2008IDG4BEUR (RED) MODEL NUMBER A2008IDG4BEUG (GREEN) MODEL NUMBER A2008IDG4BEUZ (CAT GREEN) MORE TO GO ON.
2008 400 4x4 Euro Illustrated Parts Manual MODEL NUMBER A2008IDG4BEUR (RED) MODEL NUMBER A2008IDG4BEUG (GREEN) MODEL NUMBER A2008IDG4BEUZ (CAT GREEN) MORE TO GO ON. TM TABLE OF CONTENTS 2008 ATV 400 4x4
CYLINDER - CYLINDER HEAD
A1 CYLINDER - CYLINDER HEAD 1 3FA-11110-00-00 CYLINDER HEAD ASSEMBLY. 1 2 95612-06625-00. BOLT, STUD............. 2 3 22F-11134-10-00. GUIDE, EXHAUST VALVE... 2 4 93440-10109-00. CIRCLIP.................
Illustrated Parts Manual. Model Number A2011KSF2BEUZ (Black-Cat Green) A2011KSF2BEOJ (White-Cat Green)
Illustrated Parts Manual 2 1 10 DVX 300 Euro Model Number A2011KSF2BEUZ (Black-Cat Green) A2011KSF2BEOJ (White-Cat Green) S H A R E O U R PAS S IO N. TM TABLE OF CONTENTS 2011 ATV DVX 300 Euro Black-Cat
11/14/ U. Baja Motorsports Inc. P.O. Box Phoenix, AZ Toll Free: PARTS AND PRICES ARE SUBJECT TO CHANGE 1 of 53
250U Toll Free: 888-863-2252 PARTS AND PRICES ARE SUBJECT TO CHANGE 1 of 53 FIG. 1 PNEUMATIC MECHANISM 1-1 250U-100 883099019951 CAMSHAFT 1 1 1-2 250U-101 883099019968 KEY, WOODRUFF 1 1 1-3 250U-102 883099019975
CYLINDER HEAD. Ref. Part No. Number Description Qty Remarks
A1 A2 A3 A4 CYLINDER HEAD 1 1UY-11110-02-00 CYLINDER HEAD ASSY...... 1 2 3Y1-11133-11-00. GUIDE, INTAKE VALVE..... 2 3 93440-12052-00. CIRCLIP................. 2 4 90401-06001-00. BOLT, UNION............
PARTS CATALOGUE POWERMAX-125T REVISED 08/06/04
PARTS CATALOGUE POWERMAX-125T-7 REVISED 08/06/04 ENGINE INDEX FRAME SECTION FIG # FAN COVER/SHROUD E01 SECTION FIG # CYLINDER HEAD E02 CAMSHAFT VALVE E03 SIDE COVER F01 CAM CHAIN TENSIONER E04 R. & L.
Part list for Kawasaki H2, 1972
Part list for Kawasaki H2, 972 . Cylinder head, cylinder. . Cylinder head, cylinder. 9205-049 NUT 0 m/m 2 2 40B400 WASHER-plain 4 m/m 2 3 46E400 WASHER-spring 4 m/m 2 4 92070-036 SPARK PLUG NGK B9 HS 3
X4 (GREEN) (A2000ATF2AUSG) Page 1 of 80 AIR INTAKE ASSEMBLY
2000 300 2X4 (GREEN) (A2000ATF2AUSG) Page 1 of 80 AIR INTAKE ASSEMBLY 2000 300 2X4 (GREEN) (A2000ATF2AUSG) Page 2 of 80 AIR INTAKE ASSEMBLY Ref # Part Number Qty S/P/F Description 1 3570-001 1 /P Intake,
ATV 300 DVX CAT GREEN (A2011KSF2BUSZ) Page 1 of 56 AIR INTAKE ASSEMBLY
2011 ATV 300 DVX CAT GREEN (A2011KSF2BUSZ) Page 1 of 56 AIR INTAKE ASSEMBLY 2011 ATV 300 DVX CAT GREEN (A2011KSF2BUSZ) Page 2 of 56 AIR INTAKE ASSEMBLY Ref # Part Number Qty S/P/F Description 1 3303-705
CYLINDER. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER 1 3R9-11111-00-00 HEAD, CYLINDER 1......... 1 2 1W2-11161-00-00 ABSORBER 1............. 2 3 (1W2-11127-00-00) ABSORBER 3............. 1 4 2X3-11181-00-00 GASKET, CYLINDER HEAD 1. 1 5 90116-08321-00
10th letter in VIN: J
08 0th letter in VIN: J Headlight G Br Speedometer Headlight Light Switch B Br Ignition Switch R B Y/R Brake Light Switch B G/Y Starter Relay Fuse A + G Starter Motor Rear Brake Light G/Y Br G Speed Sensor
CYLINDER. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER 1 J38-11102-00-00 CYLINDER HEAD ASSEMBLY. 1 2 J38-11133-09-00. GUIDE, INTAKE VALVE..... 2 3 99510-12016-00 PIN, DOWEL.............. 2 4 95811-08070-00 BOLT, FLANGE............ 3 5 95811-08045-00
CYLINDER HEAD CONTINUED ON NEXT FRAME. Ref. Part No. Number Description Qty Remarks
A1 A2 A3 A4 CYLINDER HEAD 1 3TB-11101-02-00 CYLINDER HEAD ASSY...... 1 2 4H7-11133-10-00. GUIDE, INTAKE VALVE..... 4 3 93440-12052-00. CIRCLIP................. 4 4 90116-06475-00. BOLT, STUD.............
CYLINDER HEAD CONTINUED ON NEXT FRAME. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER HEAD 1 4JY-11111-00-00 HEAD, CYLINDER 1 (4JY-11111-01-00).......... 1 2 90116-08394-00 BOLT, STUD.............. 5 3 90176-08026-00 NUT, CROWN............. 5 4 90201-08087-00 WASHER, PLATE...........
CYLINDER. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER 1 J38-11102-00-00 CYLINDER HEAD ASSEMBLY. 1 2 J38-11133-09-00. GUIDE, INTAKE VALVE..... 2 3 99510-12016-00 PIN, DOWEL.............. 2 4 95811-08070-00 BOLT, FLANGE............ 3 5 95811-08045-00
BR150S Howhit Baja Reaction 150cc Go Kart (VIN PREFIX L6K)
Page 1 of 16 Product Information Baja Web > Product Information > Parts Lists > GOKART > BR150S Howhit Baja Reaction 150cc Go Kart (VIN PREFIX L6K) BR150S Howhit Baja Reaction 150cc Go Kart (VIN PREFIX
Honda 1975 Parts List ENGINE GROUP Block Ref. 1F 1 11000-377-000 CRANKCASE ASSY. 1 2F 2 11208-333-000 CAP, OIL PATH 1 2F 3 11210-377-000 PAN, OIL 1 2F 4 11291-377-000 PLUG, OIL PATH 1 1E 5 11331-377-000
SSR200 Zongshen 200cc Dirt Bike (VIN PREVIX LZSJ)
Page 1 of 19 Product Information Baja Web > Product Information > Parts Lists > DIRTBIKE > SSR200 Zongshen 200cc Dirt Bike (VIN PREVIX LZSJ) SSR200 Zongshen 200cc Dirt Bike (VIN PREVIX LZSJ) SSR200 Zongshen
CYLINDER HEAD CONTINUED ON NEXT FRAME. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER HEAD 1 4JY-11111-00-00 HEAD, CYLINDER 1 (4JY-11111-01-00).......... 1 2 90116-08394-00 BOLT, STUD.............. 5 3 90176-08026-00 NUT, CROWN............. 5 4 90201-08087-00 WASHER, PLATE...........
ETON America PARTS CATALOG
ETON America PARTS CATALOG Viper 90R everse Parts and drawing are subject to change without notice. ETON America reserves the right to substitute parts that have engineering changes that can alter the
CS340ES. Property of - Not for Resale A1
A1 CYLINDER HEAD - CYLINDER 1 8G8-11111-00-00 HEAD, CYLINDER 1......... 1 2 8G8-11121-00-00 HEAD, CYLINDER 2......... 1 3 NGK-BR9ES-00-00 PLUG, SPARK............. 2 4 8G8-11181-01-00 GASKET, CYLINDER HEAD
400 2x4/4x4 EFT SHARE OUR PASSION ṬM
SHARE OUR PASSION ṬM 400 2x4/4x4 EFT Model Number A2009IDG2BETR (Red - 2x4) Model Number A2009IDG2BETZ (Cat Green - 2x4) Model Number A2009IDG4BETR (Red - 4x4) Model Number A2009IDG4BETG (Green - 4x4)
Bighorn ATV80H Parts Manual(Last Update on 8/9/2013)
Bighorn ATV80H Parts Manual(Last Update on 8/9/2013) 1 HANDLEBAR (FOR USA) Ref# Part# Description Qty Linhai Code Control Code 1 70101 IGNITION SWITCH COVER 1 LH50ATV.2 1 8A002000001 2 60107 THROTTLE CABLE
Tavole Motore 1 E-01 E-02 E-03 E-06 E-04 E-05 E-07 E-08 E-09. Fan cover-shroud. Cylinder-Cam chain Right crank case cover Generator
avole Motore 1 E-01 E-02 E-03 Fan cover-shroud Cylinder head Cam shaft-valve E-04 E-05 E-06 Cylinder-Cam chain Right crank case cover Generator E-07 E-08 E-09 Oil pump Starter motor Left crank case 2 avole
DRIVE FACE P/N DESCRIPTION PART NO. Q TY REMARK 9-1 PLATE KICK RETURN STOPPER FACE ASS Y MOVABLE DRIVE FACE
DRIVEN FACE P/N DESCRIPTION PART NO. Q TY REMARK 10-1 DRIVE FACE ASS Y(B) 22000-158-000 1 10-1-1 SECONDARY FIX SLOT WHEEL 23200-119-000 1 10-1-1-1 FACE ASS Y DRIVEN 23210-119-000 1 10-1-1-2 RADIAL BALL
ABOUT THIS PARTS LIST
ABOUT THIS PARTS LIST THIS PARTS LIST IS COMPILED FOR ALL SERVICE PARTS FOR MODEL MINI ATV 50C.C. SERIES. ANY DIFFERENCE BETWEEN COLOR CHART AND MOTORCYCLE WILL BE REVISED ACCORDING TO MOTORCYCLE. WHEN
CYLINDER HEAD. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER HEAD 1 55V-11101-01-00 CYLINDER HEAD ASSEMBLY. 1 2 30X-11133-10-00. GUIDE, INTAKE VALVE..... 4 3 93440-10109-00. CIRCLIP................. 4 4 99510-08016-00. PIN, DOWEL............. 8 5 90105-06153-00.
10th letter in VIN: H
0 0th letter in VIN: H Headlight G Br Speedometer Headlight Light Switch B Br Ignition Switch R B Y/R Brake Light Switch B G/Y Starter Relay Fuse A + G Starter Motor Rear Brake Light G/Y Br G Speed Sensor
CYLINDER HEAD CONTINUED ON NEXT FRAME. Ref. Part No. Number Description Qty Remarks
A1 A2 A3 A4 CYLINDER HEAD 1 4BD-11101-02-00 CYLINDER HEAD ASSY...... 1 2 93440-10085-00. CIRCLIP................. 2 3 90153-06029-00. SCREW, HEXAGON........ 1 4 90430-06014-00. GASKET................ 1
D-1:CYLINDER HEAD. DESCRIPTION C 4 2 Cover, Cylinder Head 3 Gasket 4 Breather, Crankcase, Lower A
CROSSLAND 300 D-1:CYLINDER HEAD 1 Bolt 96000-060258-08C 4 2 Cover, Cylinder Head 1230950A-000 1 3 Gasket 1230350A-000 1 4 Breather, Crankcase, Lower 1230250A-000 1 5 Screw 93903-1040088-00K 4 6 Gasket,
CYLINDER HEAD CONTINUED ON NEXT FRAME. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER HEAD 1 15A-11110-01-00 CYLINDER HEAD ASSEMBLY. 1 2 93440-10085-00. CIRCLIP................. 2 3 90153-06045-00. SCREW, HEXAGON........ 1 4 90430-06014-00. GASKET................ 1 5 5H0-11133-10-00.
PARTS CATALOGUE AX-100
PARTS CATALOGUE AX-100 2005. REVISED 08/25/04 INDEX ENGINE FRAME SECTION FIG # CYLINDER E01 SECTION FIG # CRANKCASE E02 METER ASSY F01 CRANKCASE COVER E03 HEADLIGHT F02 CRANKSHAFT E04 TURNING SIGNAL F03
SPARE PARTS SMC JUMBO 700. WBC d.o.o., Sticna 127, 1295 Ivancna Gorica, Slovenia-Europe WEB PAGE:
SPARE PARTS SMC JUMBO 700 WBC d.o.o., Sticna 127, 1295 Ivancna Gorica, Slovenia-Europe WEB PAGE: www.atv.si, www.atv-quad.si CYLINDER CYLINDER 1 11111-MAX-00 CYLINDER COMP 2 11121-MAX-00 HEAD COMP, CYLINDER
BR250 Howhit Baja Reaction 250cc Go Kart (VIN PREFIX L6K)
Page 1 of 28 Product Information Baja Web > Product Information > Parts Lists > GOKART > BR250 Howhit Baja Reaction 250cc Go Kart (VIN PREFIX L6K) BR250 Howhit Baja Reaction 250cc Go Kart (VIN PREFIX L6K)
Illustrated Parts Manual. Model Number A2011ICS4BUSG (Green) A2011ICS4BOSG (Green - International)
Illustrated Parts Manual 2 1 10 650 Model Number A2011ICS4BUSG (Green) A2011ICS4BOSG (Green - International) S H A R E O U R PAS S IO N. TM TABLE OF CONTENTS 2011 ATV 650 Green (Model No. A2011ICS4BUSG)
CYLINDER HEAD CONTINUED ON NEXT FRAME. Ref. Part No. Number Description Qty Remarks
A1 A2 A3 A4 CYLINDER HEAD 1 3TB-11101-02-00 CYLINDER HEAD ASSY...... 1 2 4H7-11133-10-00. GUIDE, INTAKE VALVE..... 4 3 93440-12052-00. CIRCLIP................. 4 4 90116-06475-00. BOLT, STUD.............
INDEX REAR SHOCK ABSORBER REAR FENDER HANDLE SWITCH
2005 / 2006 DTF 150 INDEX ENGINE FRAME SECTION FIG # SECTION FIG # CYLINDER HEAD E01 HANDLE BAR F01 CYLINDER E02 STEERING STEM F02 RIGHT CRANKCASE E03 FRONT FENDER F03 RIGHT CRANKCASE 2 E04 FRONT FORK
ATV I l. l u. r a. Parts Manual ARCTIC CAT. 250 cc/300 cc
2000 I l l u st ATV 250 cc/300 cc Model No. A2000ATE2AUSG (250 - Green) Model No. A2000ATE2AUSR (250 - Red) Model No. A2000ATF2AUSG (300 2x4 - Green) Model No. A2000ATF2AUSR (300 2x4 - Red) Model No. A2000ATF4AUSG
PARTS CATALOGUE EARTHLANDER REVISED 02/25/05
PARTS CATALOGUE EARTHLANDER 200 REVISED 02/25/05 INDEX ENGINE FRAME SECTION FIG # SECTION FIG # FAN COVER, SHROUD E01 FRAME F01 CYLINDER HEAD COVER E02 PLASTIC COVERS F02 CAMSHAFT,VALVE, CYLINDER HEA E03
11/14/2008 ENGINE COVERS. Item No.
RT50 Toll Free: 888-863-2252 (BAJA) PARTS AND PRICES ARE SUBJECT TO CHANGE 1 of 38 ENGINE COVERS 1 RT50-100 883099139246 SCREW ST5*16 2 2 2 RT50-101 883099139253 BOLT M6*25 3 3 3 RT50-102 883099139260
CYLINDER HEAD - CYLINDER
A1 CYLINDER HEAD - CYLINDER 1 (1W6-11111-00-00) HEAD, CYLINDER 1......... 1 (2K9-11111-00-00) HEAD, CYLINDER 1......... 1 2 1W3-11181-00-00 GASKET, CYLINDER HEAD 1. 1 500-11181-00-00 GASKET, CYLINDER HEAD
CYLINDER HEAD - CYLINDER
A1 CYLINDER HEAD - CYLINDER 1 8AY-11111-00-00 HEAD, CYLINDER 1......... 1 2 8A7-12499-00-00 JOINT................... 1 3 NGK-BR9ES-00-00 PLUG, SPARK............. 2 4 8AY-11181-00-00 GASKET, CYLINDER HEAD
PARTS MANUAL DVX 300 EU A2015KSF2BEUZ.
PARTS MANUAL DVX 300 EU A2015KSF2BEUZ www.arcticcat.com Contents AIR INTAKE ASSEMBLY [92559] 1 BODY PANEL AND HEADLIGHT ASSEMBLY [300511] 3 CAM CHAIN ASSEMBLY [90409] 5 CARBURETOR ASSEMBLY [300515] 6 CLUTCH
SF90 Pmi Shifter 90cc Go Kart (VIN PREFIX LBFM)
Page 1 of 23 Product Information Baja Web > Product Information > Parts Lists > GOKART > SF90 Pmi Shifter 90cc Go Kart (VIN PREFIX LBFM) SF90 Pmi Shifter 90cc Go Kart (VIN PREFIX LBFM) SF90 Pmi Shifter
Parts Lists - WD90 Fym Wilderness 90cc ATV (VIN PREFIX LE8S)
Page 1 of 20 Product Information Baja Web > Product Information > Parts Lists > ATV > WD90 Fym Wilderness 90cc ATV (VIN PREFIX LE8S) WD90 Fym Wilderness 90cc ATV (VIN PREFIX LE8S) WD90 Fym Wilderness 90cc
SV125EP. Not For Resale
A1 CYLINDER 1 50W-11111-00-00 HEAD, CYLINDER 1......... 1 2 87A-11181-00-00 GASKET, CYLINDER HEAD... 1 3 NGK-BR8HS-00-00 PLUG, SPARK............. 1 4 87A-11311-00-00 CYLINDER 1.............. 1 5 50W-11351-00-00
PREFACE INSTRUCTIONS FOR QUOTING THE CATALOGUE. 1. DIMENSIONS Dimensions of the parts in this catalogue are indicated in unit millimeters.
PREFACE When it becomes necessary to replace parts on SUZUKI MOTORCYCLES, always use SUZUKI GENUINE PARTS which have passed a strict inspection which guarantees quality and performance. This parts catalogue
Master Part List SY250. Rev. 1
Rev. 1 1-1015 Frame 1 1 1 1 1-1017 Frame 1 2-1021 Guard, engine 1 1 1 1 1 1 3-1044 Foot Rest, right side 1 1 1-1045 Foot Rest, right side 1 - S1A-20202-00-00 Foot Rest, right side steel 1 1 4-1054 Foot
WD250 Qj Wilderness 250cc ATV (VIN PREFIX LAWA)
Page 1 of 27 Product Information Baja Web > Product Information > Parts Lists > ATV > WD250 Qj Wilderness 250cc ATV (VIN PREFIX LAWA) WD250 Qj Wilderness 250cc ATV (VIN PREFIX LAWA) WD250 Qj Wilderness
ENGINE 1. ydrax3. Ref No.
A ENGINE JR-900-00-00 A ENGINE ASSEMBLY CYLINDER HEAD JT0--00-00 HEAD, CYLINDER JN--0-00..GUIDE, VALVE JT0--00-00 GASKET, CYLINDER HEAD 90-000-00 BOLT 900-00-00 WASHER, PLATE 990-0-00 PIN, DOWEL 9-0-00
CPI MOTORCYCLE
20040920 34 CPI MOTORCYCLE F1 FRAME BODY ATV 50 35 CPI MOTORCYCLE F1 FRAME BODY ITEM PARTS NO. DESCRIPTION REQD. NO. ATV 50 1 B11-41110-40-00 FRAME COMP. 1 2 S-6123-06002-20 BEARING 6002ZZ 1 3 S-4521-12320-00
CYLINDER. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER 1 J38-11102-00-00 CYLINDER HEAD ASSEMBLY. 1 2 99510-12016-00 PIN, DOWEL.............. 2 3 95811-08070-00 BOLT, FLANGE............ 3 4 95811-08045-00 BOLT, FLANGE............ 3 5 J38-11181-00-00
CYLINDER. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER 1 (3R4-11111-00-00) HEAD, CYLINDER 1......... 1 2 1W3-11181-00-00 GASKET, CYLINDER HEAD 1. 1 3 (CMP-N2G00-00-00) CHAMPION N2G 10PK....... 1 4 90116-08321-00 BOLT, STUD.............. 6 5 90179-08491-00
R th letter in VIN: B-G. Illustrated Parts Manual
0-06 R-50 0th letter in VIN: B-G Illustrated Parts Manual 0 0 0 R-50 Wire Diagram o Turn Signal Switch Ignition Switch Hazard Light Switch Head Light switch G Brake Light Switch G sb o Gr o Gr Gr sb L
CYLINDER - CRANKCASE. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER - CRANKCASE 1 (374-15111-00-00) CRANKCASE 1............ 1 2 374-15121-02-00 CRANKCASE 2............ 1 3 99510-12016-00 PIN, DOWEL.............. 2 4 98580-06550-00 SCREW PAN HEAD (92503-06050).............
CONTENTS ENGINE GROUP
CONTENTS ENGINE GROUP CRANK CASE, L. COVER CRANK SHAFT, PISTON OIL PUMP, START MOTOR RIGHT CRANK CASE COVER HEAD COVER, CAM SHAFT FAN COVER, SHROUD DRIVEN PULLEY (CVT) TRANSMISSION GEAR SHAFT LEVER AIR
hentet hos:
SKY TEAM CORPORATION LTD. 0 CARNIVAL COMMERCIAL BLDG. JAVA ROAD NORTH POINT HONGKONG TEL:00 09 FAX:00 09 EMAIL:SKYTEAM_HK@HOTMAIL.COM HTTP://WWW.SKYTEAM.NET.CN WWW.SKYTEAM.CN Please make reference to this
CYLINDER HEAD CONTINUED ON NEXT FRAME. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER HEAD 1 3BM-11101-01-00 CYLINDER HEAD ASSEMBLY. 1 2 4H7-11133-10-00. GUIDE, INTAKE VALVE..... 2 3 93440-12052-00. CIRCLIP................. 2 4 3BM-11101-11-00 CYLINDER HEAD ASSEMBLY. 1 5 4H7-11133-10-00.
CYLINDER. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER 1 25Y-11111-01-00 HEAD, CYLINDER 1......... 1 2 25Y-11181-00-00 GASKET, CYLINDER HEAD 1. 1 3 NGK-B8EG0-00-00 PLUG, SPARK (NGK B8EG) (94702-00323-00)........... 1 U.R. LM FOR U.S.A. 4 90116-08394-00
REF. NO. DESCRIPTION TOP COWLING 2 MOLDING, AIR DUCT 3 RIVET 4 SEAL 5 HOLDER, CLAMP BAND 6 BOLT, WITH WASHER 7 HOOK
SUZHOU ALLPASS MACHINERY CO.,LTD Add:No.85,Jishui Road,Jinfeng Industrial Park,Mudu Town,Suzhou 215102,Jiangsu,P.R.China T15 SPARE PARTS EXPLODED DRAWING FIG. 1 1 TOP COWLING TOP COWLING 2 MOLDING, AIR