Removal and Replacement
|
|
- Mercy Dennis
- 5 years ago
- Views:
Transcription
1 Page 1 of 10 Home Account Contact ALLDATA Log Out Help DAN GRIMWOOD DAN GRIMWOOD00002 Select Vehicle New TSBs Technician's Reference Component Search: OK 2004 Suzuki Forenza L4-2.0L Conversion Calculator Vehicle Level Transmission and Drivetrain Manual Transmission/Transaxle Service and Repair Removal and Replacement Removal and Replacement Transaxle Assembly Removal and Installation Tools Required: J B Engine Support Fixture Removal 1. Install the engine support fixture J B. 2. Remove the battery and battery tray. 3. Remove the shift linkage assembly. 4. Remove the drive axle shaft. 5. Disconnect the backup lamp switch electrical connector.
2 Page 2 of Disconnect the speedometer speed sensor electrical connector. 7. Remove the pin and the clutch release cylinder pipe. 8. Remove the damping block connection nut and bolt. 9. Remove the three rear mounting bracket bolts.
3 Page 3 of Remove the rear mounting bracket from the transaxle. 11. Remove the two rear damping block retaining bolts. 12. Remove the rear damping block from the front cross member. 13. Remove the two cage retaining bolts. 14. Remove the three transaxle upper mounting bracket bolts.
4 Page 4 of Remove the upper mounting bracket and cage. 16. Remove the three transaxle upper retaining bolts.
5 Page 5 of Support the transaxle with a transaxle support jack. 18. Remove the seven transaxle lower retaining bolts. 19. Remove the transaxle. 20. Slide the transaxle sideways away from the engine block.
6 Page 6 of Lower the transaxle. Installation 1. Support the transaxle with a transaxle support jack. 2. Install the transaxle by inserting the transaxle input shaft into the clutch disc and sliding the transaxle sideways into the engine block.
7 Page 7 of Install the seven transaxle lower retaining bolts. Tighten the transaxle lower retaining bolts (a) to 73 Nm (54 ft. lbs.). Tighten the transaxle lower retaining bolt (b) to 31 Nm (23 ft. lbs.). Tighten the transaxle lower retaining bolts (c) to 21 Nm (15 ft. lbs.). 4. Install the three transaxle upper retaining bolts. Tighten the transaxle upper retaining bolts to 73 Nm (54 ft. lbs.). 5. Install the cage retaining bolt and cage.
8 Page 8 of Install the three transaxle upper mounting bracket bolts and bracket. Tighten the transaxle upper mounting bracket bolts to 48 Nm (35 ft. lbs.). 7. Install the two rear damping block retaining bolts. Tighten the rear damping block retaining bolts to 68 Nm (50 ft. lbs.). 8. Install the rear damping block from the front cross member. 9. Install the three rear mounting bracket bolts and the bracket. Tighten the rear mounting bracket bolts to 90 Nm (66 ft. lbs.).
9 Page 9 of Install the damping block connection nut and bolt. Tighten the damping block connection nut and bolt to 68 Nm (50 ft. lbs.). 11. Connect the clutch release cylinder pipe. 12. Connect the speedometer speed sensor electrical connector.
10 Page 10 of Connect the backup lamp switch electrical connector. 14. Remove the engine support fixture J B. 15. Install the drive axle shaft. 16. Install the shift linkage assembly. 17. Install the battery and battery tray. 18. Inspect the fluid level ALLDATA LLC. All rights reserved. Terms of Use
A/T - 4T65E Harsh Shifts/Shudders/Slips/DTC's Set
Page 1 of 5 Home Account Contact ALLDATA Log Out Help DAN GRIMWOOD DAN GRIMWOOD00002 Select Vehicle New TSBs Technician's Reference Component Search: OK 2000 Pontiac Bonneville V6-3.8L VIN K Conversion
More informationALLDATA Online Chevy Truck TrailBlazer 2WD L6-4.2L VIN S - Service and R... Service and Repair
Page 1 of 7 Home Account Contact ALLDATA Log Out Help PAUL REDEHOFT Select Vehicle New TSBs Technician's Reference Component Search: OK 2003 Chevy Truck TrailBlazer 2WD L6-4.2L VIN S Conversion Calculator
More informationIntake Manifold Replacement
ALLDATA Online - 2001 Cadillac DeVille V8-4.6L VIN 9 - Intake Manifold Replacement Page 1 of 15 Home Account Contact ALLDATA Log Out Help DAN GRIMWOOD DAN GRIMWOOD00002 Select Vehicle New TSBs Technician's
More informationA/T - Harsh/Delayed Upshift/Downshift
Page 1 of 8 Home Account Contact ALLDATA Log Out Help DAN GRIMWOOD DAN GRIMWOOD00002 Select Vehicle New TSBs Technician's Reference Component Search: OK 2003 Hyundai Truck Santa Fe V6-2.7L Conversion Calculator
More informationALLDATA Online Lexus LS 400 V8-4.0L (1UZ-FE) - Front. Front
Page 1 of 18 Home Account Contact ALLDATA Log Out Help PAUL REDEHOFT Select Vehicle New TSBs Technician's Reference Component Search: OK 1991 Lexus LS 400 V8-4.0L (1UZ-FE) Conversion Calculator Vehicle
More informationALLDATA Online Mitsubishi Eclipse GS L4-2350cc 2.4L SOHC MFI - Transaxle Disassembly... Transaxle Disassembly and Reassembly
ALLDATA Online - 2002 Mitsubishi Eclipse GS L4-2350cc 2.4L SOHC MFI - Transaxle Disassembly... Page 1 of 21 Home Account Contact ALLDATA Log Out Help BEST FORD BEST FORD00001 Select Vehicle New TSBs Technician's
More informationALLDATA Online Toyota Camry L4-2.4L (2AZ-FE) - Rear Strut Assembly. Rear Strut Assembly
Page 1 of 11 Home Account Contact ALLDATA Log Out Help PAUL REDEHOFT Select Vehicle New TSBs Technician's Reference Component Search: OK 2004 Toyota Camry L4-2.4L (2AZ-FE) Conversion Calculator Vehicle
More informationVehicle Level Engine, Cooling and Exhaust Engine Cylinder Head Assembly Service and Repair. Service and Repair
Page 1 of 7 Home Account Contact ALLDATA Log Out Help BILL SEIDLES MITSUBISHI Select Vehicle New TSBs Technician's Reference Component Search: OK 2001 Pontiac Sunfire L4-2.2L VIN 4 Conversion Calculator
More informationEngine Controls - Revised DTC 0090 Diagnostics
Page 1 of 7 Home Account Contact ALLDATA Log Out Help DAN GRIMWOOD DAN GRIMWOOD00002 Select Vehicle New TSBs Technician's Reference Component Search: OK 2005 GMC Truck Sierra 2500 2WD V8-6.6L DSL Turbo
More informationFront Door Non-Functional - Latch Replacement
Page 1 of 6 Home Account Contact ALLDATA Log Out Help DAN GRIMWOOD DAN GRIMWOOD00002 Select Vehicle New TSBs Technician's Reference Component Search: OK 2002 Ford Truck Escape 2WD L4-122 2.0L DOHC VIN
More informationEngine Removal and Installation
Page 1 of 5 Home Account Contact ALLDATA Log Out Help TINO TORRES Select Vehicle New TSBs Technician's Reference Component Search: OK 2005 Chrysler Sebring Sedan V6-2.7L VIN R Conversion Calculator Vehicle
More informationFuel Tank Removal and Installation
Page 1 of 7 Home Account Contact ALLDATA Log Out Help DAN GRIMWOOD DAN GRIMWOOD00002 Select Vehicle New TSBs Technician's Reference Component Search: OK 2003 Mazda Protege L4-2.0L DOHC Conversion Calculator
More informationALLDATA Online Mitsubishi Eclipse GS L4-2350cc 2.4L SOHC MFI - Input Shaft. Input Shaft
Page 1 of 16 Home Account Contact ALLDATA Log Out Help BEST FORD BEST FORD00001 Select Vehicle New TSBs Technician's Reference Component Search: OK 2002 Mitsubishi Eclipse GS L4-2350cc 2.4L SOHC MFI Conversion
More informationALLDATA Online Cadillac DeVille V8-4.6L VIN Y - Lower Crankcase Installation. Lower Crankcase Installation
Page 1 of 7 Home Account Contact ALLDATA Log Out Help PAUL REDEHOFT Select Vehicle New TSBs Technician's Reference Component Search: OK 1998 Cadillac DeVille V8-4.6L VIN Y Conversion Calculator Vehicle
More informationService and Repair. Fig. 1 Starter Motor Replacement
Motor / ALLDATA Online - 1995 Pontiac Firebird V6-204 4L VIN S... http://www.motoralldata.com/alldata/motor~v71595976~c21288~... 1 of 3 5/15/2008 10:45 PM Home Account Contact ALLDATA Log Out Help Select
More informationDiesel Engine - Runs Hot Towing or Pulling Grades
ALLDATA Online - 2005 GMC Truck Sierra 3500 4WD V8-6.6L DSL Turbo VIN 2 - Di...Page 1 of 11 Home Account Contact ALLDATA Log Out Help DAN GRIMWOOD DAN GRIMWOOD00002 Select Vehicle New TSBs Technician's
More informationALLDATA Online Hummer H2 V8-6.0L - Brake Pads Replacement - Rear. Brake Pads Replacement - Rear
Page 1 of 5 Home Account Contact ALLDATA Log Out Help PAUL REDEHOFT Select Vehicle New TSBs Technician's Reference Component Search: OK 2005 Hummer H2 V8-6.0L Conversion Calculator Vehicle Level Brakes
More informationAssembly. NOTE: Before beginning assembly, perform/inspect the following:
Page 1 of 31 Home Account Contact ALLDATA Log Out Help DAN GRIMWOOD DAN GRIMWOOD00002 Select Vehicle New TSBs Technician's Reference Component Search: OK 1997 Ford Truck F 150 2WD Pickup V6-4.2L VIN 2
More informationTurn Signal Lamps and/or Indicators Malfunction
Page 1 of 6 Home Account Contact ALLDATA Log Out Help DAN GRIMWOOD DAN GRIMWOOD00003 Select Vehicle New TSBs Technician's Reference Component Search: OK 2008 GMC Truck Acadia FWD V6-3.6L Conversion Calculator
More informationVehicle Level Engine, Cooling and Exhaust Engine Intake Manifold Service and Repair. Service and Repair
Page 1 of 11 Home Account Contact ALLDATA Log Out Help BILL SEIDLES MITSUBISHI Select Vehicle New TSBs Technician's Reference Component Search: OK 2005 Suzuki Verona L6-2.5L Conversion Calculator Vehicle
More informationService and Repair. Removal. Remove the engine cover. Remove the drive belt. Select Vehicle New TSBs Technician's Reference
1 of 7 4/5/2008 9:30 AM Home Account Contact ALLDATA Log Out Help Select Vehicle New TSBs Technician's Reference Component Search: METRO TOYOTA OK 2002 Kia Truck Sedona EX V6-3.5L Vehicle Level Engine,
More informationALLDATA Online Dodge Truck Caravan V L - Front. Front
Page 1 of 10 Home Account Contact ALLDATA Log Out Help PAUL REDEHOFT Select Vehicle New TSBs Technician's Reference Component Search: OK 1994 Dodge Truck Caravan V6-201 3.3L Conversion Calculator Vehicle
More informationALLDATA Online Mazda MX-5 Miata L4-1597cc 1.6L DOHC - Service and Rep... Service and Repair
Page 1 of 8 Home Account Contact ALLDATA Log Out Help PAUL REDEHOFT Select Vehicle New TSBs Technician's Reference Component Search: OK 1992 Mazda MX-5 Miata L4-1597cc 1.6L DOHC Conversion Calculator Vehicle
More informationFuel Injector Replacement (Right Bank) EN Injector Bore and Sleeve Cleaning Kit J Fuel Injector Removal Tool
Page 1 of 7 Home Account Contact ALLDATA Log Out Help DAN GRIMWOOD DAN GRIMWOOD00002 Select Vehicle New TSBs Technician's Reference Component Search: OK 2002 Chevy Truck C 2500 Truck 2WD V8-6.6L DSL Turbo
More informationALLDATA Online Lexus Truck RX 330 FWD V6-3.3L (3MZ-FE) - Headlight As... Page 1 of 10. Headlight Assembly. LH Headlamp Assy Part 1
ALLDATA Online - 2005 Lexus Truck RX 330 FWD V6-3.3L (3MZ-FE) - Headlight As... Page 1 of 10 Home Account Contact ALLDATA Log Out Help PAUL REDEHOFT Select Vehicle New TSBs Technician's Reference Component
More informationALLDATA Online Dodge Truck RAM 1500 Truck 2WD V6-3.7L VIN K - Steeri... Steering Column
Page 1 of 5 Home Account Contact ALLDATA Log Out Help PAUL REDEHOFT Select Vehicle New TSBs Technician's Reference Component Search: OK 2002 Dodge Truck RAM 1500 Truck 2WD V6-3.7L VIN K Conversion Calculator
More informationFT - Function Test. Figure 1
1 of 6 4/8/2008 1:57 AM Home Account Contact ALLDATA Log Out Help Select Vehicle New TSBs Technician's Reference Component Search: METRO TOYOTA OK 1995 Mercedes Benz SL 500 (129.067) V8-5.0L (119.972)
More informationLocations. Select Vehicle New TSBs Technician's Reference Isuzu Truck Rodeo LS 2WD V6-3.2L
1 of 4 5/16/2008 1:06 PM Home Account Contact ALLDATA Log Out Help Select Vehicle New TSBs Technician's Reference Component Search: METRO TOYOTA OK 2001 Isuzu Truck Rodeo LS 2WD V6-3.2L Conversion Calculator
More informationALLDATA Online Chevy Truck S10/T10 P/U 2WD L4-2.2L VIN 4 - Service and... Page 1 of 12. Service and Repair
ALLDATA Online - 2000 Chevy Truck S10/T10 P/U 2WD L4-2.2L VIN 4 - Service and... Page 1 of 12 Home Account Contact ALLDATA Log Out Help PAUL REDEHOFT Select Vehicle New TSBs Technician's Reference Component
More informationAR05.20-P-6020AU Set the Basic Position of Camshafts
1 of 6 4/9/2008 9:57 AM Home Account Contact ALLDATA Log Out Help Select Vehicle New TSBs Technician's Reference Component Search: METRO TOYOTA OK 1999 Mercedes Benz E 320 4MATIC Sedan (210.082) V6-3.2L
More informationALLDATA Online - 1997 Ford Truck F 150 2WD Pickup V8-5.4L SOHC VIN L - Servi... Page 1 of 22 Home Account Contact ALLDATA Log Out Help BILL SEIDLES MITSUBISHI Select Vehicle New TSBs Technician's Reference
More informationPart 1. CAUTION : Release established test pressure before beginning the next test step.
1 of 16 4/29/2008 4:35 PM Home Account Contact ALLDATA Log Out Help Select Vehicle New TSBs Technician's Reference Component Search: METRO TOYOTA OK 1998 Mercedes Benz SL 500 (129.067) V8-5.0L (119.982)
More informationALLDATA Online Chevy Truck S10/T10 Blazer 2WD V6-4.3L VIN W - Intake... Intake Manifold Replacement (Upper)
ALLDATA Online - 2001 Chevy Truck S10/T10 Blazer 2WD V6-4.3L VIN W - Intake... Page 1 of 21 Home Account Contact ALLDATA Log Out Help PAUL REDEHOFT Select Vehicle New TSBs Technician's Reference Component
More informationRemoving and Installing Battery
ALLDATA Online - 2005 Porsche 911 GT3 (996) F6-3.6L - Removing and Installing Bat... Page 1 of 13 Home Account Contact ALLDATA Log Out Help BILL SEIDLES MITSUBISHI Select Vehicle New TSBs Technician's
More informationDISCONNECT CABLE FROM NEGATIVE TERMINAL OF BATTERY DISCONNECT CAM POSITION SENSOR CONNECTOR
1 of 12 4/26/2008 1:50 PM Home Account Contact ALLDATA Log Out Help Select Vehicle New TSBs Technician's Reference Component Search: METRO TOYOTA OK 1987 Toyota Supra L6-3.0L DOHC Turbo (7M-GTE) Conversion
More informationDiagnostic Trouble Code (DTC) Information
1 of 3 7/20/2008 8:35 AM Home Account Contact ALLDATA Log Out Help Select Vehicle New TSBs Technician's Reference Component Search: METRO TOYOTA OK 1999 Mercedes Benz Truck ML 430 (163.172) V8-4.3L (113.942)
More informationFault Symptom Table. Table of symptoms; Indicator and warning lamps, noise in climate control system, odor in the passenger compartment
1 of 3 6/18/2008 7:06 PM Home Account Contact ALLDATA Log Out Help Select Vehicle New TSBs Technician's Reference Component Search: METRO TOYOTA OK 1998 Volvo V70 L5-2.4L VIN 55 B5254S Conversion Calculator
More informationTiming Chain Replacement and Riveting. Numbers in parentheses ( ) indicate a component or tool in the associated illustration.
1 of 5 4/9/2008 6:41 PM Home Account Contact ALLDATA Log Out Help Select Vehicle New TSBs Technician's Reference Component Search: METRO TOYOTA OK 1995 Mercedes Benz E 320 Cabriolet (124 Chassis) L6-3199cc
More informationHeater/Vent Module Replacement
Page 1 of 7 Home Account Contact ALLDATA Log Out Help BILL SEIDLES MITSUBISHI Select Vehicle New TSBs Technician's Reference Component Search: OK 2000 Chevy Truck S10/T10 P/U 2WD V6-4.3L VIN W Conversion
More informationDescription and Operation
Motor / ALLDATA Online - 1997 Jaguar XK-8 Convertible V8-3996cc... 1 of 2 4/10/2008 1:14 AM Home Account Contact ALLDATA Log Out Help Select Vehicle New TSBs Technician's Reference Component Search: METRO
More informationTurbo Boost Pressure Test
1 of 3 6/16/2008 9:07 PM Home Account Contact ALLDATA Log Out Help Select Vehicle New TSBs Technician's Reference Component Search: METRO TOYOTA OK 1992 Volvo 740 L4-2320cc 2.3L SOHC Turbo VIN 87 B230FT
More informationRemoval & Installation of Hydraulic Cylinder For Soft Top Bow
1 of 4 4/29/2008 9:59 PM Home Account Contact ALLDATA Log Out Help Select Vehicle New TSBs Technician's Reference Component Search: METRO TOYOTA OK 1997 Mercedes Benz SL 500 (129.067) V8-5.0L (119.982)
More informationDesign, Function of Electrical Components
1 of 6 4/1/2008 11:15 PM Home Account Contact ALLDATA Log Out Help Select Vehicle New TSBs Technician's Reference Component Search: METRO TOYOTA OK 1992 Mercedes Benz 500SL (129.067) V8-5.0L (119.960)
More informationService and Repair. NOTE: Before proceeding, review all Steering Column and Airbag Warnings and Cautions.
ALLDATA Online - 2003 Chrysler Truck Town & Country V6-3.8L VIN L - Service and... Page 1 of 10 Home Account Contact ALLDATA Log Out Help BILL SEIDLES MITSUBISHI Select Vehicle New TSBs Technician's Reference
More informationService and Repair REPLACING TIMING BELT/IDLER PULLEY/BELT TENSIONER. Special Tools:
1 of 9 6/18/2008 8:48 AM Home Account Contact ALLDATA Log Out Help Select Vehicle New TSBs Technician's Reference Component Search: METRO TOYOTA OK 1999 Volvo V70 XC AWD L5-2.4L Turbo VIN 56 B5254T Vehicle
More informationService and Repair SERVICE POINTS OF REMOVAL. Select Vehicle New TSBs Technician's Reference Mitsubishi 3000GT V6-2972cc 3.
1 of 12 5/4/2008 10:31 PM Home Account Contact ALLDATA Log Out Help METRO TOYOTA Select Vehicle New TSBs Technician's Reference 1992 Mitsubishi 3000GT V6-2972cc 3.0L DOHC Vehicle Level Engine, Cooling
More informationComponent Locations. Figure 1, Limit Switches
1 of 5 4/29/2008 4:26 PM Home Account Contact ALLDATA Log Out Help Select Vehicle New TSBs Technician's Reference Component Search: METRO TOYOTA OK 1998 Mercedes Benz SL 500 (129.067) V8-5.0L (119.982)
More informationRestraints - Rear Seat Belt Won't Retract Properly
1 of 3 4/22/2008 10:21 PM Home Account Contact ALLDATA Log Out Help Select Vehicle New TSBs Technician's Reference Component Search: METRO TOYOTA OK 2003 Mercedes Benz CLK 320 (209.365) V6-3.2L (112.955)
More informationPage 1 of 9 Home Account Contact ALLDATA Log Out Help DAN GRIMWOOD DAN GRIMWOOD00002 Select Vehicle New TSBs Technician's Reference Component Search: OK 1985 Dodge Truck D 350 Pickup V8-360 5.9L VIN I
More informationDTCM - Diagnostic Trouble Code Memory
1 of 5 4/17/2008 11:26 AM Home Account Contact ALLDATA Log Out Help Select Vehicle New TSBs Technician's Reference Component Search: METRO TOYOTA OK 1998 Mercedes Benz SLK 230 (170.447) L4-2.3L SC (111.973)
More informationA22s1 Bow "closed" switch (8) A22s2 Bow "locked" switch (8) A23s1 Bow "closed" switch (8) A23s2 Bow "locked" switch (8) Sized for Print
4 of 10 4/17/2008 8:23 AM A22s1 Bow "closed" switch (8) A22s2 Bow "locked" switch (8) A23s1 Bow "closed" switch (8) A23s2 Bow "locked" switch (8) 5 of 10 4/17/2008 8:23 AM A24s1 Cover "closed" switch (3)
More informationALLDATA Online Honda Civic DX Sedan L4-1668cc 1.7L SOHC MFI - Remova... Removal and Replacement
Page 1 of 5 Home Account Contact ALLDATA Log Out Help PAUL REDEHOFT Select Vehicle New TSBs Technician's Reference Component Search: OK 2002 Honda Civic DX Sedan L4-1668cc 1.7L SOHC MFI Conversion Calculator
More informationVehicle Level Engine, Cooling and Exhaust Cooling System Water Pump Service and Repair Removal. Removal
1 of 7 4/5/2008 11:18 PM Home Account Contact ALLDATA Log Out Help Select Vehicle New TSBs Technician's Reference Component Search: METRO TOYOTA OK 1994 Jeep Truck Wrangler L6-242 4.0L VIN S MFI Conversion
More informationDescription and Operation
1 of 3 5/26/2008 9:01 AM Home Account Contact ALLDATA Log Out Help Select Vehicle New TSBs Technician's Reference Component Search: METRO TOYOTA OK 1997 Mercedes Benz E 300D (210.020) L6-3.0L DSL (606.912)
More informationALLDATA Online Dodge Truck RAM 1500 Truck 4WD V8-5.7L - Service and R... Page 1 of 10. Service and Repair
ALLDATA Online - 2009 Dodge Truck RAM 1500 Truck 4WD V8-5.7L - Service and R... Page 1 of 10 Home Account Contact ALLDATA Log Out Help PAUL REDEHOFT Select Vehicle New TSBs Technician's Reference Component
More informationTesting and Inspection. Diagnostic Procedure Step 1-2
1 of 4 5/22/2008 7:54 AM Home Account Contact ALLDATA Log Out Help Select Vehicle New TSBs Technician's Reference Component Search: METRO TOYOTA OK 2002 Nissan-Datsun Altima 2.5 S L4-2.5L (QR25DE) Vehicle
More informationALLDATA Online Buick Regal V L VIN L SFI - HVAC Blower Motor -... HVAC Blower Motor - Noise/Vibration
Page 1 of 6 Home Account Contact ALLDATA Log Out Help PAUL REDEHOFT Select Vehicle New TSBs Technician's Reference Component Search: OK 1995 Buick Regal V6-231 3.8L VIN L SFI Conversion Calculator Vehicle
More informationALLDATA Online Porsche Cayenne S (9PA) V8-4.5L - Removing and Installing... Removing and Installing Main Headlight
Page 1 of 9 Home Account Contact ALLDATA Log Out Help RACEWAY FORD Select Vehicle New TSBs Technician's Reference Component Search: OK 2004 Porsche Cayenne S (9PA) V8-4.5L Conversion Calculator Vehicle
More informationABS, 4-ETS and EBP BRAKES ANTI-LOCK BRAKE SYSTEM (ABS) 4-WHEEL ELECTRONIC TRACTION CONTROL SYSTEM (4-ETS) ELECTRONIC BRAKE PROPORTIONING (EBP)
1 of 9 4/27/2008 7:52 AM Home Account Contact ALLDATA Log Out Help Select Vehicle New TSBs Technician's Reference Component Search: METRO TOYOTA OK 2002 Mercedes Benz Truck ML 320 (163.154) V6-3.2L (112.942)
More informationA: Removing/Installing Camshaft
1 of 6 4/9/2008 9:39 PM Home Account Contact ALLDATA Log Out Help Select Vehicle New TSBs Technician's Reference Component Search: METRO TOYOTA OK 1995 Mercedes Benz E 320 Cabriolet (124 Chassis) L6-3199cc
More information1 of 5 1/10/2017 5:10 PM
1 of 5 1/10/2017 5:10 PM Shock Module Yoke Replacement ^ Tools Required - J 24319-B Steering Linkage and Tie Rod Puller Removal Procedure 1. Raise and support the vehicle. Refer to Vehicle Lifting. 2.
More informationInstrument Panel Assembly Replacement. Fig. 14 Battery Negative Cable Removal/Installation
Page 1 of 11 Home Account Contact ALLDATA Log Out Help BILL SEIDLES MITSUBISHI Select Vehicle New TSBs Technician's Reference Component Search: OK 2003 Chrysler Truck PT Cruiser L4-2.4L VIN B Conversion
More informationTRANSMISSION REMOVAL & INSTALLATION - A/T
TRANSMISSION REMOVAL & INSTALLATION - A/T 1990 Nissan 240SX 1990 TRANSMISSION SERVICING Nissan Automatic Transmission Axxess, Maxima, Pathfinder, Pickup, Pulsar NX, Sentra, Stanza, 240SX, 300ZX NOTE: For
More informationENGINE ASSEMBLY. COMPONENTS (Part 1)
1 of 32 ENGINE ASSEMBLY COMPONENTS (Part 1) 2 of 32 COMPONENTS (Part 2) 3 of 32 COMPONENTS (Part 3) 4 of 32 COMPONENTS (Part 4) 5 of 32 COMPONENTS (Part 5) 6 of 32 COMPONENTS (Part 6) 7 of 32 COMPONENTS
More informationALLDATA Online Buick Truck Rendezvous V6-3.4L VIN E - Draining and Fillin... Draining and Filling Cooling System
Page 1 of 8 Home Account Contact ALLDATA Log Out Help PAUL REDEHOFT Select Vehicle New TSBs Technician's Reference Component Search: OK 2003 Buick Truck Rendezvous V6-3.4L VIN E Conversion Calculator Vehicle
More information1 of 1 7/1/17, 2:02 PM. Air Cleaner Assembly Replacement ALLDATA, LLC. All Rights Reserved. (Version )
Air Cleaner Housing Service and Repair, Removal and Replacement: Ai... http://repair.alldata.com/alldata/article/display.action?componentid=367... 1 of 1 7/1/17, 2:02 PM Air Cleaner Assembly Replacement
More information1 of 11 4/11/ :35 AM
1 of 11 4/11/2015 11:35 AM Rear Disc Brake Pads Replacement Special Tools * KM-6007 Resetting Tool * KM-6007-30 Adaptor Removal Procedure 2 of 11 4/11/2015 11:35 AM Caution: Refer to Brake Dust Caution
More informationTransmission, disassembling and assembling
Page 1 of 27 34-43 Transmission, disassembling and assembling Disassembly sequence Page 34-55. Transmission overview 1-1st gear 2-2nd gear 3-3rd gear 4-4th gear 5-5th gear 6 - Reverse gear Removing and
More informationFT - Function Test. Roadster Soft Top Opening Sequence Initial stage: Roadster Soft Top closed.
1 of 10 4/26/2008 8:56 AM Home Account Contact ALLDATA Log Out Help Select Vehicle New TSBs Technician's Reference Component Search: METRO TOYOTA OK 1990 Mercedes Benz 500SL (129.067) V8-5.0L (119.960)
More information3/19/2017 9:49 AM. Transmission Replacement. Tools Required ^ J B Cooler Quick Connect Tool ^ J Transmission Jack Adapter
1 of 16 Transmission Replacement Tools Required ^ J 41623-B Cooler Quick Connect Tool ^ J 41160 Transmission Jack Adapter Removal Procedure 1. Remove the upper filler panel. 2. Remove the upper and lower
More information1. Remove the battery tray. For additional information, refer to Battery Tray ( )
Page 1 of 11 Removal 1. Remove the battery tray. For additional information, refer to Battery Tray (86.15.11) 2. Remove the air cleaner. For additional information, refer to Air Cleaner (19.10.05) 3. NOTE
More informationME-SFI Fuel Injection/Ignition System PE07.61-U-2101DD (Sheet 2) Wiring Diagram, Part 1
1 of 5 6/16/2008 9:49 AM Home Account Contact ALLDATA Log Out Help Select Vehicle New TSBs Technician's Reference Component Search: METRO TOYOTA OK 2003 Mercedes Benz E 500 (211.070) V8-5.0L (113.967)
More informationRelease Bearing Replacement
Page 1 of 10 2008 Chevrolet Aveo : Transmissions > Clutch > Repair Instructions > Release Bearing Replacement Release Bearing Replacement RELEASE BEARING REPLACEMENT Tools Required DT 47513 (Image 1) (DW210-030)
More informationTechnical Service Bulletin
2008 Santafe Report a problem with this article Subject Technical Service Bulletin Group Number CHASSIS 10-SS-004 Date REAR HUB BEARING REPLACEMENT 4WD FEBRUARY, 2010 Model 07-09MY SANTA FE (CM) CIRCULATE
More informationDescription and Operation. Fig. 13 Electro-Hydraulic Actuator
1 of 3 10/17/2008 12:35 PM Home Account Contact ALLDATA Log Out Help METRO TOYOTA Select Vehicle New TSBs Technician's Reference Component Search: 1989 Mercedes Benz 420SEL (126 Chassis) V8-4196cc 4.2L
More informationYEAR(S) MODEL(S) ADDITIONAL INFORMATION
T-SB-0007-11 January 7, 2011 Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2009 2011 RAV4 Drive Type(s):, Engine(s):
More informationMAIN CONTROL VALVE BODY. Removal 1. Disconnect the battery cables. 2. Remove the battery and tray.
1 of 17 MAIN CONTROL VALVE BODY Removal 1. Disconnect the battery cables. 2. Remove the battery and tray. 3. Disconnect the breather tube and mass air flow (MAF) / intake air temperature (IAT) sensor.
More informationASE Practice Test A3 Manual Drive Train
Clutch Diagnosis and Repair ASE Practice Test A3 Manual Drive Train 1) Which of the following are the three critical clutch pedal measurements? a. Pedal height, apply pressure, and free play b. Pedal free
More informationAutomatic Transmission/Transaxle: Removal and Replacement Transmission Replacement
2008 Buick Lucerne V8-4.6L Copyright 2013, ALLDATA 10.52 Page 1 Automatic Transmission/Transaxle: Removal and Replacement Transmission Replacement Transmission Replacement Tools Required * J 41623-B Cooler
More informationClutch, Pressure Plate, And Pilot Bearing Replacement
Page 1 of 6 2008 Chevrolet Aveo : Transmissions > Clutch > Repair Instructions > Clutch, Pressure Plate, And Pilot Bearing Replacement Clutch, Pressure Plate, And Pilot Bearing Replacement CLUTCH, PRESSURE
More informationDISASSEMBLY TRANSAXLE DISASSEMBLY AND ASSEMBLY. Part 1 Of 3
2004 Mitsubishi Truck Endeavor V6-3.8L SOHC Vehicle > Transmission and Drivetrain > Automatic Transmission/Transaxle > Service and Repair > Overhaul > F4A5A > Disassembly and Assembly DISASSEMBLY TRANSAXLE
More information05 15A MANUAL TRANSAXLE [F25M-R]
05 15A MANUAL TRANSAXLE [F25M-R] MANUAL TRANSAXLE [F25M-R] LOCATION INDEX................ 05 15A 1 TRANSAXLE OIL INSPECTION [F25M-R]............. 05 15A 2 TRANSAXLE OIL REPLACEMENT [F25M-R].......... 05
More informationManual Transmission/Driveline. Final Review
Manual Transmission/Driveline Final Review 1. The Pressure Plate is a spring-loaded device that presses the clutch disc against the flywheel. 2. The clutch Release Mechanism allows the driver to disengage
More informationMANUAL TRANSMISSION CONTENTS
22-1 MANUAL TRANSMISSION CONTENTS 22109000319 LUBRICANT... 2 SPECIAL TOOLS... 2 ON-VEHICLE SERVICE... 3 Transmission Oil Check... 3 Transmission Oil Replacement... 3 TRANSMISSION CONTROL*... 4 TRANSMISSION
More informationRemoving the power steering gear. General. Tools. The description only applies to left-hand drive vehicles with a chassis front end width of 1,020 mm.
General General The description only applies to left-hand drive vehicles with a chassis front end width of 1,020 mm. IMPORTANT! On vehicles with front axle air suspension, the frame must be supported on
More informationGROUP 32 POWER PLANT MOUNT CONTENTS WARNINGS REGARDING SERVICING OF SUPPLEMENTAL RESTRAINT SYSTEM (SRS) EQUIPPED VEHICLES
32-1 GROUP 32 POWER PLANT MOUNT CONTENTS GENERAL DESCRIPTION......... 32-2 SPECIAL TOOL................. 32-3 ENGINE MOUNTING............. 32-3 REMOVAL AND INSTALLATION........ 32-3 INSPECTION.......................
More information1 of 12 10/5/2015 8:11 AM
1 of 12 10/5/2015 8:11 AM REMOVAL 1. Perform the fuel pressure release procedure See: Fuel Pressure Release > Procedures > Fuel System Pressure Release Procedure. 2. Recover the refrigerant from the refrigerant
More informationProgram SLOs Automotive Mechanics Technology
Program SLOs Automotive Mechanics Technology A.A. Automotive Mechanics Technology Certificates of Achievement Automotive Mechanics Technology, Automotive Engine Performance, Automatic Transmissions/Transaxles,
More information1 of 14 11/19/ :45 AM
1 of 14 11/19/2016 11:45 AM 6F35 Digital Transmission Range (TR) Sensor Removal All vehicles 1. With the vehicle in NEUTRAL, position it on a hoist. 3.0L engine 2. Remove the Air Cleaner (ACL) outlet pipe.
More information22-1 GROUP 22 MANUAL TRANSAXLE CONTENTS MANUAL TRANSAXLE... 22A MANUAL TRANSAXLE OVERHAUL... 22B
22-1 GROUP 22 MANUAL TRANSAXLE CONTENTS............................... 22A OVERHAUL..................... 22B 22A-2 GROUP 22A MANUAL TRANSAXLE CONTENTS GENERAL DESCRIPTION......... 22A-3 DIAGNOSIS 22A-6
More informationALLDATA Online Cadillac DeVille DHS V8-4.6L VIN Y - Recall - Fuel Tank Pr... Recall - Fuel Tank Pressure Sensor Malfunction
Page 1 of 5 Home Account Contact ALLDATA Log Out Help TINO TORRES TINO TORRES00002 Select Vehicle New TSBs Technician's Reference Component Search: OK 2002 Cadillac DeVille DHS V8-4.6L VIN Y Conversion
More information22A-1 CONTENTS MANUAL TRANSAXLE... 22A MANUAL TRANSAXLE OVERHAUL... 22B o00111
MANUAL TRANSAXLE OVERHAUL................. 22B 22A-1 CONTENTS 22109o00111 MANUAL TRANSAXLE............................. 22A ~ TRAN AXLE CONTENTS 22109000180 GENERAL INFORMATION....3 SPECIAL TOOLS....6
More informationMANUAL TRANSAXLE Return to Main Table of Contents
MANUAL TRANSAXLE Return to Main Table of Contents GENERAL... 2 MANUAL TRANSAXLE CONTROL... 12 SHIFT LEVER ASSEMBLY... 14 MANUAL TRANSAXLE... 15 MANUAL TRANSAXLE ASSEMBLY... 17 FIFTH SPEED SYNCHRONIZER
More informationAutomotive Internship
Western Technical College 32404369 Automotive Internship Course Outcome Summary Course Information Description Career Cluster Instructional Level Total Credits 3 Total Hours 162 Student will be responsible
More information2012 NATEF Task Area A 2 Automatic Transmission
2012 NATEF Task Area A 2 Automatic Transmission A. General Transmission & Transaxle Diagnosis B. Transmission & Transaxle Maintenance & Adjustment C. In Vehicle Transmission & Transaxle Repair D. Off Vehicle
More informationDifferential, Disassembling and Assembling Special tools
Differential, Disassembling and Assembling Special tools VAG 1582 Bearing puller VAG 1582/3 Grip piece VW 412 Thrust disc 40-105 Thrust piece VW 401 Thrust plate VW 402 Thrust plate VW 408 A Punch VW 473
More informationAutomotive FORENZA / RENO October 6, 2014 Technical Service Bulletin Engine Bulletin No. TS R1
Service Automotive FORENZA / RENO October 6, 2014 SUBJECT: MODEL(S): YEAR: Revisions: Throttle Position Sensor Replacement Forenza (RQ420) Reno (RQ420) 2006 2008 Forenza 2006 2008 Reno R1-10/08/14. This
More information1 of 9 5/29/2014 6:01 AM
1 of 9 5/29/2014 6:01 AM Torque Converter Clutch Pulse Width Modulation (TCC PWM) Solenoid, TCC Solenoid, and Wiring Harness Tools Required ^ J28458 Seal Protector Retainer Installer Removal Procedure
More informationTRANSMISSION AND TRANSFER CASE
TJ TRANSMISSION AND TRANSFER CASE 21-1 TRANSMISSION AND TRANSFER CASE TABLE OF CONTENTS page MANUAL TRANSMISSION - NSG370...1 AUTOMATIC TRANSMISSION - 42RLE...37 page TRANSFER CASE - NV231...165 TRANSFER
More information1 of 2 5/25/17, 4:57 PM
1 of 2 5/25/17, 4:57 PM Overview - Bumper Cover, Audi Q5 S-Line and Audi SQ5 If the vehicle has lane change assistance, the lane change assistance control module (J769) / (J770) must be recalibrated. 1
More information