Drying Tumblers Stacked 30 Pound Capacity

Transcription

1 Drying Tumblers Stacked 30 Pound Capacity Models Starting Serial No. DTCK Refer to Page 3 for Model Numbers Parts Part No. M412907R7 May 2008

2

3 Table of Contents Title Page Parts Ordering Information... 2 Serial Plate Location... 2 Model Identification... 3 Electronic Control... 4 Coin Drops and Plates... 6 Electro-Mechanical Control... 8 Front Panel Assembly Side Panels Loading Door - Models SCD32DG and STD32DG Loading Door - Models JCD32DG and JTD32DG Lint Drawer Cylinder Drive Shaft Blower Housing and Fan Motor and Belt Guard Thermostat and Burner Gas Valve Gas Valve Coils Junction Box - 120, 208 or 240 Volt/60 Hertz Junction Box Volt/50 Hertz or 220 Volt/60 Hertz Contactor Box Stickers and Labels - Front of Machine Stickers and Labels - Rear of Machine Parts Index Copyright 2008, Alliance Laundry Systems LLC All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed written consent of the publisher. M

4 If literature or replacement parts are required, contact the source from whom the machine was purchased or contact Alliance Laundry Systems at (920) for the name and address of the nearest authorized parts distributor. For technical assistance, call (920) Parts Ordering Information When calling or writing about your product, be sure to mention model and serial numbers. Model and serial numbers are located on serial plate(s) as shown. Serial Plate Location NOTICE WARNING WARNING NOTICE Serial Plate T278P_M M412907

5 Model Identification Information in this manual is applicable to these tumbler models: JCD32DG JTD32DG SCD32DG STD32DG M

6 Electronic Control TMB2126P_M M412907

7 Electronic Control REF PART NO. DESCRIPTION COMMENTS NA Control Panel Overlay Models SCD32DG and STD32DG; Top NA Control Panel Overlay Models SCD32DG and STD32DG; Bottom NA Control Panel Overlay Models JCD32DG and JTD32DG; Top NA Control Panel Overlay Models JCD32DG and JTD32DG; Bottom NA P Control Harness Assembly CD control suffix NA P Main Wire Harness Assembly Lower; 120 Volt/50 or 60 Hertz; Volt/60 Hertz; 240 Volt/50 Hertz NA P Main Wire Harness Assembly Upper; 120, Volt/50 or 60 Hertz; 240 Volt/50 Hertz NA P Microprocessor Wire Harness Models starting Serial No. DTCK941xxxxx Assembly NA 613P3 Microprocessor Wire Harness Kit Models starting Serial No. DTCK through Serial No. DTCK NA P Lock, Key and Nut Kit RL001; Can be used to replace items 1 and 2 NA P Lock, Key and Nut Kit RL002; Can be used to replace items 1 and Coin Drop Key P Microprocessor Door Lock Control Panel Overlay Models SCD32DG and STD32DG; Upper left Control Panel Overlay Models SCD32DG and STD32DG; Lower right Control Panel Overlay Models JCD32DG and JTD32DG; Upper left Control Panel Overlay Models JCD32DG and JTD32DG; Lower right Control Panel Overlay Models SCD32DG and STD32DG; Left overlay with factory installed Munzprufer drop Control Panel Overlay Models SCD32DG and STD32DG; Right overlay with factory installed Munzprufer drop Control Panel Overlay Models JCD32DG and JTD32DG; Left overlay with factory installed Munzprufer drop Control Panel Overlay Models JCD32DG and JTD32DG; Right overlay with factory installed Munzprufer drop Control Panel Door Screw 6 M414050P Control Kit 120 Volt/60 Hertz 6 M411883P Control Kit 240 Volt/50 Hertz Control Housing Seal Lint Drawer Switch Rocker; Replaced items 6 and 7 on models starting Serial No Magnet Models through Serial No Reed Switch Models through Serial No Nut NOTE: Individual wires are not available separately. Order complete harness, or order wire by the foot. When applying terminals to wires, it is recommended that the terminals be soldered to the wires. M

8 Coin Drops and Plates TMB2108P_M M412907

9 Coin Drops and Plates REF PART NO. DESCRIPTION COMMENTS NA N/A Coin Drop Euro;.20 NA Coin Drop Euro;.50 NA P Opto Coupler For factory installed Munzprufer drop NA P Opto Coupler For and Coin Drop Coin Drop Australia 1 N/A Coin Drop Belgium 1 N/A Coin Drop Denmark 1 N/A Coin Drop England 1 N/A Coin Drop France 1 N/A Coin Drop Hong Kong 1 N/A Coin Drop Japan 1 N/A Coin Drop South Africa 1 N/A Coin Drop South Korea 1 N/A Coin Drop Taiwan 1 N/A Coin Drop Thailand P Coin Drop USA; $ P Coin Drop USA; $.25 1 N/A Coin Drop Token; STD M Coin Drop Token; STD N/A Coin Drop Token; STD N/A Coin Drop Front Plate All countries N/A = Part no longer available M

10 Electro-Mechanical Control CD MODELS MT MODELS TMB2097P_M M412907

11 Electro-Mechanical Control REF PART NO. DESCRIPTION COMMENTS NA Jumper Harness Assembly NA P Main Wire Harness Assembly Lower; 120 Volt/50 or 60 Hertz; Volt/60 Hertz; 240 Volt/50 Hertz NA P Main Wire Harness Assembly Upper; 120 Volt/50 Hertz; Volt/60 Hertz; 240 Volt/50 Hertz NA P Microprocessor Wire Harness Assembly NA 613P3 Microprocessor Wire Harness Kit Models starting Serial No. DTCK through Serial No. DTCK P3 Switch Conversion Kit 120 Volt; Includes Rocker Switch and Indicator Light 1 602P3 Switch Conversion Kit 240 Volt; Includes Rocker Switch and Indicator Light 2 N/A Door Overlay Models JCD32DG and JTD32DG; Upper 2 N/A Door Overlay Models JCD32DG and JTD32DG; Lower 2 N/A Door Overlay Models SCD32DG and STD32DG; Upper 2 N/A Door Overlay Models SCD32DG and STD32DG; Lower P Microprocessor Door Lock Control Panel Door Assembly Temperature Knob Models SCD32DG and STD32DG Temperature Knob Models JCD32DG and JTD32DG Control Mounting Bracket Relay Circuit Board Support 4 required P Thermostat Module 10 N/A Coin Meter 220 Volt/50 Hertz 10 N/A Coin Meter Australia: $1/15 minutes; Belgium: 5 franc; England: 20 pence/7.5 minutes; France: 5 franc/6 minutes; Hong Kong: $1/10 minutes; Malaysia; South Africa:.50/15 minutes; Token: STD-118-2; Token: STD-188-5/10; Venezuela 10 N/A Coin Meter Australia:.20/5 minutes; Canada: $.25/7.5 minutes; France: 2 franc 10 M Coin Meter Denmark; Krone/5 minutes 10 M Coin Meter Japan 10 M Coin Meter South Africa 10 M Coin Meter Token; STD M405138P Coin Meter USA; $.25/10 minutes Nut 2 required 12 M Screw 4 required P Temperature Switch Potentiometer 14 M400791P Timer 60 minute 15 M Plate 16 M Graphic Overlay 17 M Knob Timer; Models SCD32DG and STD32DG 17 M Knob Timer; Models JCD32DG and JTD32DG 18 M Screw 3 required N/A = Part no longer available NOTE: Individual wires are not available separately. Order complete harness, or order wire by the foot. When applying terminals to wires, it is recommended that the terminals be soldered to the wires. M

12 Front Panel Assembly TMB2100P_M M412907

13 Front Panel Assembly REF PART NO. DESCRIPTION COMMENTS P Lint Drawer Seal Included with front panel Microprocessor Control Shadow Box 3 N/A Screw Attaches front panel to cabinet 4 M Door Latch Included with front panel 5 M Pop Rivet Included with front panel 6 N/A Front Panel Upper 6 N/A Front Panel Assembly Stainless steel; Upper 7 M Shadow Box Clip 8 N/A Front Panel Lower 8 N/A Front Panel Stainless steel; Lower 9 M Screw Attaches coin vault to cabinet Coin Vault Assembly Pushbutton Switch 12 M Switch Mounting Plate Screw 14 M Pop Rivet Included with front panel * Hinge Bracket Included with front panel Hinge Bracket Stainless steel; Included with front panel 16 M400131P Shadow Box and Clip Coin vault; Includes 4 of item 7 * Add Letter To Designate Color. B - Battina Green H - Harvest Gold K - Red L - Almond P - Turquoise V - Orange W - White X - Electric Blue N/A = Part no longer available M

14 Side Panels TMB2101P_M M412907

15 Side Panels REF PART NO. DESCRIPTION COMMENTS 1 N/A Bracket 2 M Snap Bushing 3 N/A Insulation 4 N/A Bracket 5 N/A Side Panel and Insulation Right Screw 6 N/A Screw Nut Screw 9 M Door Switch Door Switch Bracket 11 M Screw Leveling leg 12 N/A Side Panel and Insulation Left 13 N/A Nut N/A = Part no longer available M

16 Loading Door - Models SCD32DG and STD32DG TMB2102P_M M412907

17 Loading Door - Models SCD32DG and STD32DG REF PART NO. DESCRIPTION COMMENTS Door Assembly 2 M Door Ring Gasket Nut Screw Door Switch Tab 6 M Screw 7 M Screw 8 M Hinge Pin 9 M Door Latch 10 M Pop Rivet * Hinge Bracket Included with front panel Hinge Bracket Stainless steel; Included with front panel 12 M Pop Rivet 13 M402714* Door Hinge Assembly 13 M Hinge Assembly Stainless steel 14 M Washer 15 M400784P Door Glass 16 M Screw Door Handle P Door Glass Seal Kit Door Plug 20 M Screw Screw * Add Letter To Designate Color. B - Battina Green H - Harvest Gold K - Red L - Almond P - Turquoise V - Orange W - White X - Electric Blue M

18 Loading Door - Models JCD32DG and JTD32DG TMB2103P_M M412907

19 Loading Door - Models JCD32DG and JTD32DG REF PART NO. DESCRIPTION COMMENTS 1 M Door Assembly 2 M Door Ring Gasket 3 Q6163 Nut Washer Screw Door Switch Tab 7 M Screw 8 M Screw 9 M Hinge Pin 10 M Door Latch 11 M Pop Rivet * Hinge Bracket Included with front panels Hinge Bracket Stainless steel 13 M Pop Rivet 14 M402714* Door Hinge Assembly 14 M Hinge Assembly Stainless steel 15 M Washer P Door Glass P Door Glass Seal Kit P Replacement Door Handle Kit 19 M Nut 20 M Screw Screw * Add Letter To Designate Color. B - Battina Green H - Harvest Gold K - Red L - Almond P - Turquoise V - Orange W - White X - Electric Blue M

20 Lint Drawer TMB2153P_M M412907

21 Lint Drawer REF PART NO. DESCRIPTION COMMENTS NA P Lock, Key and Nut Kit RL001; Can be used to replace items 1 and 2 NA P Lock, Key and Nut Kit RL002; Can be used to replace items 1 and 2 1 M Panel Key P Lock and Key Lint Screen Frame Assembly Includes frame and lint screen Screw Lint Screen Bracket Blind Rivet Actuator Switch Block P Lint Drawer Seal 9 N/A Lint Drawer Assembly Screw Front Plate Upper; Models SCD32DG and STD32DG 11 N/A Front Plate Upper; Models JCD32DG and JTD32DG Lint Compartment Label Models SCD32DG and STD32DG 12 N/A Lint Compartment Label Models JCD32DG and JTD32DG Lint Drawer Switch Kickplate Extension Front Plate Lower Lint Drawer Overlay Models SCD32DG and STD32DG Lint Drawer Overlay Models JCD32DG and JTD32DG N/A = Part no longer available M

22 Cylinder TMB2145P_M M412907

23 Cylinder REF PART NO. DESCRIPTION COMMENTS P Cylinder and Trunnion Assembly Spring Rib Assembly P Cylinder Assembly P Seal Kit Includes adhesive P Seal Strap Trunnion Assembly Cylinder Bearing Stud Plate Assembly Washer Nut 11 M Nut 12 M Nut 13 M Washer P Support Housing Bearing Assembly 15 M Nut 16 M Washer 17 M Spacer 18 M Felt Pad 19 N/A Sweep Sheet Bumper Kit 20 M Pop Rivet P Sweep Sheet Kit Screw 23 F Nut 4 required Retaining Ring 2 required 25 N/A Washer 2 required 26 N/A Air Duct Roller Support Assembly Roller Shaft 2 required Roller Bearing Assembly 2 required Nut 2 required Roller Shaft Retainer 2 required Bracket Spring 33 N/A Cylinder Rib Rod P Front Seal Kit Includes strap P Front Cylinder Seal Strap N/A = Part no longer available M

24 Drive Shaft T286P_M M412907

25 Drive Shaft REF PART NO. DESCRIPTION COMMENTS Screw Drum Idler Wheel Assembly Screw Nut Cylinder Idler Arm Washer Nut Screw 9 M Washer Nut P Sheave Includes screw 12 M Nut 13 M Nut Belt P U-Bolt Clamp Kit Partition Reinforcing Plate Jackshaft Assembly Partition Reinforcing Plate Front 19 M Key P Belt Poly - V J ; 8 rib; inches P Pulley Kit 22 N/A Drum Idler Spring 23 M Key Cylinder Idler Bracket 25 M Screw Washer N/A = Part no longer available M

26 Blower Housing and Fan TMB2104P_M M412907

27 Blower Housing and Fan REF PART NO. DESCRIPTION COMMENTS NA N/A Cabinet High Limit Harness Fan Shaft Assembly Includes bearing, housing and pulley Washer Nut Nut 5 N/A Sheave with Screw 6 N/A Top and Front Cover P Thimble and Vane Assembly Vane Assembly 2 required Screw 10 M Limit Thermostat 11 M Screw Washer Screw 14 M Bumper Screw Drum Idler Wheel Assembly Drive Idler Arm Screw Idler Pulley Bracket Nut 21 N/A Spacer 22 N/A Spring 23 N/A Idler Spring Tab Screw 25 M Nut 26 M Nut 27 M410088P Fan Includes key 28 N/A Blower Housing Assembly Washer 30 M Thermistor Side and Back Cover N/A = Part no longer available M

28 Motor and Belt Guard TMB2154P_M M412907

29 Motor and Belt Guard REF PART NO. DESCRIPTION COMMENTS NA Belt Guard Cover Later models NA M Motor Capacitor NA N/A Motor Wire Harness Assembly 120 Volt/50 or 60 Hertz; Volt/60 Hertz; 240 Volt/50 Hertz Belt 2 N/A Sheave 60 Hertz; Includes screw 2 N/A Sheave 50 Hertz; Includes screw Screw Lint Drawer Switch Belt guard Belt Guard 6 N/A Belt Guard Wrap Earlier models; Replace using M4612P3 Belt Guard Kit; Includes wrap and cover Belt Guard Wrap Later models 7 M Screw Washer 9 M Washer P Motor 60 Hertz Motor 50 Hertz 11 M Key N/A = Part no longer available M

30 Thermostat and Burner TMB2105P_M M412907

31 Thermostat and Burner REF PART NO. DESCRIPTION COMMENTS NA N/A Airflow Switch Harness NA N/A Stove Wire Harness Assembly Stove Limit Thermostat 2 M Thermostat Cover Screw Screw Burner Plate Cover Screw P Spark Igniter Burner Assembly P Airflow Switch Kit Nut Washer Cotter Pin Airflow Switch Vane 13 M Screw Airflow Switch 15 H Mounting Insulation Airflow Switch Bracket N/A = Part no longer available M

32 Gas Valve TMB2114P_M M412907

33 Gas Valve REF PART NO. DESCRIPTION COMMENTS NA 563P3 Conversion Kit Natural Gas (N.G.) to Liquid Petroleum Gas (L.P.) NA 550P3 Conversion Kit L.P. to N.G P3 N.G. Valve Replacement Kit 1 868P3 L.P. Valve Replacement Kit P Shut-Off Valve Kit A O-Ring P Shut-Off Valve Kit Includes union 5 N/A Gas Valve Spud Burner Orifice N.G.; Models with White Rodgers gas valves; 0-2,000 feet; Drill no Burner Orifice N.G.; Models with White Rodgers gas valves; 2,001-4,000 feet; Drill no Burner Orifice N.G.; Models with White Rodgers gas valves; 4,001-6,000 feet; Drill no N/A Burner Orifice N.G.; Models with White Rodgers gas valves; 6,001-8,000 feet; Drill no N/A Burner Orifice N.G.; Models with White Rodgers gas valves; 8,001-10,000 feet; Drill no Burner Orifice N.G.; Models with White Rodgers gas valves; 0-2,000 feet; Drill no N/A Burner Orifice Town Gas; L.P.; Models with White Rodgers gas valves; 0-2,000 feet; Drill no. V Burner Orifice L.P.; Models with White Rodgers gas valves; 0-2,000 feet; 3/32 inches 6 N/A Burner Orifice L.P.; Models with White Rodgers gas valves; 2,001-6,000 feet; Drill no N/A Burner Orifice L.P.; Models with White Rodgers gas valves; 6,001-8,000 feet; Drill no N/A Burner Orifice L.P.; Models with White Rodgers gas valves; 8,001-10,000 feet; Drill no M Burner Orifice N.G.; Models with GM 7000 gas valves; 0-2,000 feet; Drill no M Burner Orifice N.G.; Models with GM 7000 gas valves; 2,001-4,000 feet; Drill no M Burner Orifice N.G.; Models with GM 7000 gas valves; 4,001-6,000 feet; Drill no M Burner Orifice N.G.; Models with GM 7000 gas valves; 6,001-8,000 feet; Drill no M Burner Orifice N.G.; Models with GM 7000 gas valves; 8,001-10,000 feet; Drill no M Burner Orifice L.P.; Models with GM 7000 gas valves; 0-6,000 feet; Drill no.43 6 M Burner Orifice L.P.; Models with GM 7000 gas valves; 6,001-8,000 feet; Drill no M Burner Orifice L.P.; Models with GM 7000 gas valves; 8,001-10,000 feet; Drill no Screw Screw 9 N/A Gas Valve Bracket 10 M Snap Bushing High Voltage Lead 12 N/A Gas Valve Gasket N/A = Part no longer available M

34 Gas Valve Coils BLK BLK BLK WHT WHT WHT TMB2115P_M M412907

35 Gas Valve Coils REF PART NO. DESCRIPTION COMMENTS 1 M409253P Instant Electronic Ignition Valve Coil Kit Single input M

36 Junction Box - 120, 208 or 240 Volt/60 Hertz TMB2120P_M M412907

37 Junction Box - 120, 208 or 240 Volt/60 Hertz REF PART NO. DESCRIPTION COMMENTS NA Instant Electronic Ignition Wire Harness Assembly 1 M Snap Bushing 2 N/A Jumper Block Terminal Block 120 Volt Terminal Block 208 or 240 Volt Screw Junction Box Cover Screw 7 M406789P Ignition Control N/A = Part no longer available NOTE: Individual wires are not available separately. Order complete harness, or order wire by the foot. When applying terminals to wires, it is recommended that the terminals be soldered to the wires. M

38 Junction Box Volt/50 Hertz or 220 Volt/60 Hertz 2 Wire TMB2150P_M M412907

39 Junction Box Volt/50 Hertz or 220 Volt/60 Hertz REF PART NO. DESCRIPTION COMMENTS NA N/A Transformer NA Instant Electronic Ignition Wire Harness Assembly P Fuse Receptacle Located in upper junction box only Fuse Located in upper junction box only; 3/4 Amp; 250 Volt 3 M Snap Bushing 4 N/A Jumper Block Terminal Block Screw Junction Box Cover Screw 9 M406789P Ignition Control N/A = Part no longer available NOTE: Individual wires are not available separately. Order complete harness, or order wire by the foot. When applying terminals to wires, it is recommended that the terminals be soldered to the wires. M

40 5 Contactor Box CE Models 230 Volt/50 Hertz/1 Phase T1 T2 T3 NO 14 L1 L2 L3 13 NO TMB2107P_M M412907

41 Contactor Box REF PART NO. DESCRIPTION COMMENTS NA M Nut NA Fuse.4 Amp NA M End Barrier 1 M Finger Guard Upper unit only 2 M Mounting Switch Base Upper unit only; Disconnect 3 M Terminal Block 1 circuit 4 M Terminal Block End Stop 230 Volt 6 M Ground Buss Assembly 7 M412477P Transformer 230 Volt Screw 9 M Snap Bushing 10 M Din Rail 88.9 mm 11 M Terminal Block 2 circuit Modified Extension 13 N/A Din Rail 127 mm 14 M412404P Contactor Motor; 9 Amp N/A = Part no longer available M

42 Stickers and Labels - Front of Machine T310P_M M412907

43 Stickers and Labels - Front of Machine REF PART NO. DESCRIPTION COMMENTS 1 M Warning Label Drying warning; Located on front panel behind door Warning Label Located under lint drawer M

44 Never operate tremoved. Never operate the washer with the front panel removed Never aa the washer with the front panel removed This unit requires a SINGLE power source. Make electrical connections through top junction box. Remove junction box cover to make electrical connections. Replace junction box cover after making electrical connections. Stickers and Labels - Rear of Machine SERIAL PLATE GAS SUPPLY PIPE TAG NOTICE WARNING AVERTISSEMENT NOTICE Never operate the front panel Never operate with the fron Never aathe the front panel WARNING AVERTISSEMENT NOTICE WARNING NOTICE WARNING AVERTISSEMENT NOTICE Never operate the front panel Never operate with the front Never aathe the front panel WARNING NOTICE AVERTISSEMENT GAS SUPPLY PIPE TAG WARNING WIRING DIAGRAMS (Refer to Serial No./ Wiring Tables) TMB2116P_M M412907

45 Stickers and Labels - Rear of Machine REF PART NO. DESCRIPTION COMMENTS 1 N/A Installation Notice Warning Label 3 N/A Junction Box Notice Sticker 4 M Secure Ground Label Electrical ground marker 5 N/A Wire Marker 6 N/A Power Source Notice Sticker Single 7 N/A Belt Warning Sticker 8 M Vent and Thimble Caution Label Venting warning 9 N/A Thimble Notice N/A = Part no longer available M

46 Notes 44 M412907

47 Parts Index A Actuator Switch Block Airflow Switch Airflow Switch Bracket Airflow Switch Kit P Airflow Switch Vane B Belt , P Belt Guard Belt Guard Cover Belt Guard Wrap Blind Rivet Bracket Bumper M Burner Assembly Burner Orifice M M M M M M M M Burner Plate Cover C Circuit Board Support Coin Drop M P P Coin Drop Key Coin Meter M M M M M405138P...9 Coin Vault Assembly Contactor M412404P...39 Control Harness Assembly P...5 Control Housing Seal Control Kit M411883P...5 M414050P...5 Control Mounting Bracket Control Panel Door Control Panel Door Assembly Control Panel Overlay Conversion Kit 550P P Cotter Pin Cylinder and Trunnion Assembly P...21 Cylinder Assembly P...21 Cylinder Bearing Stud Plate Assembly Cylinder Idler Arm Cylinder Idler Bracket D Din Rail M Door Assembly M Door Glass M400784P P...17 N/A items do not appear in index. M

48 Door Glass Seal Kit P... 15, 17 Door Handle Door Hinge Assembly M402714*... 15, 17 Door Latch M , 15, 17 Door Plug Door Ring Gasket M , 17 Door Switch M Door Switch Bracket Door Switch Tab , 17 Drive Idler Arm Drum Idler Wheel Assembly E End Barrier M End Stop F Fan M410088P Fan Shaft Assembly Felt Pad M Finger Guard M Front Cylinder Seal Strap P Front Plate Front Seal Kit P Fuse Fuse Receptacle 91024P G Graphic Overlay M Ground Buss Assembly M H High Voltage Lead Hinge Assembly M , 17 Hinge Bracket *...11, 15, , 15, 17 Hinge Pin M , 17 I Idler Pulley Bracket Ignition Control M406789P...35, 37 Instant Electronic Ignition Valve Coil Kit M409253P...33 Instant Electronic Ignition Wire Harness Assembly , 37 J Jackshaft Assembly Jumper Harness Assembly Junction Box Cover , 37 K Key M M , 27 Kickplate Extension Knob M M L Limit Thermostat M Lint Compartment Label Lint Drawer Overlay Lint Drawer Seal P...11, 19 Lint Drawer Switch , 19, 27 Lint Screen Bracket N/A items do not appear in index. 46 M412907

49 Lint Screen Frame Assembly Lock and Key P Lock, Key and Nut Kit P... 5, P... 5, 19 L.P. Valve Replacement Kit 868P M Magnet Main Wire Harness Assembly P... 5, P... 5, 9 Microprocessor Control Shadow Box Microprocessor Door Lock P... 5, 9 Microprocessor Wire Harness Assembly P... 5, 9 Microprocessor Wire Harness Kit 613P3... 5, 9 Modified Extension Motor P Motor Capacitor M Mounting Insulation H Mounting Switch Base M N Nut F M , 23, 25 M , 23, 25 M M M Q , , N.G. Valve Replacement Kit 867P O Opto Coupler P P...7 O-Ring A...31 P Panel Key M Partition Reinforcing Plate Plate M Pop Rivet M , 15, 17, 21 M , 15, 17 Pulley Kit P...23 Pushbutton Switch R Reed Switch Relay Replacement Door Handle Kit P...17 Retaining Ring Rib Assembly Roller Bearing Assembly Roller Shaft Roller Shaft Retainer S Screw M , 17 M , 27 M M M M M , 17 M M , 17 M M , 31 N/A items do not appear in index. M

50 , , 15, 17, 27, 29, 31, 35, , , , , , , Seal Kit P Seal Strap P Secure Ground Label M Shadow Box and Clip M400131P Shadow Box Clip M Sheave P Shut-Off Valve Kit P Side and Back Cover Snap Bushing M , 31, 35, 37, 39 Spacer M Spark Igniter P Spring Stove Limit Thermostat Support Housing Bearing Assembly P Sweep Sheet Kit P Switch Conversion Kit 601P P Switch Mounting Plate M Thermistor M Thermostat Cover M Thermostat Module P...9 Thimble and Vane Assembly P...25 Timer M400791P...9 Transformer M412477P...39 Trunnion Assembly U U-Bolt Clamp Kit P...23 V Vane Assembly Vent and Thimble Caution Label M W Warning Label M , 43 Washer M M M , 17 M M , 23, 25, , T Temperature Knob Temperature Switch P... 9 Terminal Block M M M , 37 N/A items do not appear in index. 48 M412907