MDG25PRAWW0 : 01 - TOP AND CONSOLE PARTS [1/6]

Transcription

1 MDG25PRAWW0 : 01 - TOP AND CONSOLE PARTS [1/6] Page 1 of 12

2 MDG25PRAWW0 : 01 - TOP AND CONSOLE PARTS [1/6] Ref # Part Number Qty. Description 1 W Installation Instruction 1 W INSTALLATION INSTRUCTIONS, CARD READER 1 W TECH SHEET 1 W PARTS LIST 2 W Top 3 W HARNESS, MAIN 4 W Console (Outer) Bracket, Console SCREW 12 W Console (Inner) 13 W USER-INTERFACE ASSEMBLY SCREW 16 W Ground Wire Assembly 17 W Nut Hinge & Pin Assembly SCREW 20 W Membrane Switch with Backer Plate 21 W FACIA-DISPENSER 22 W BRACKET - TOP PANEL, LEFT SCREW 24 W BRACKET - TOP PANEL, RIGHT 25 W SCREW 26 W Bezel, Card Reader 27 W HARNESS, WIRING CARD READER 28 W COVER, DISPLAY 29 W Brass Washer Tab-Grounding 31 W Console Seal SCREW 33 W COVER, CARD READER 34 W FASCIA-CONSOLE 35 W Push Button 36 W Harness, Communication 37 W INSERTS 40 W JUMPER, SERVICE 41 W CARD READER, CONVERSION KIT VAULT SWITCH Page 2 of 12

3 MDG25PRAWW0 : 02 - CABINET PARTS [2/6] Page 3 of 12

4 MDG25PRAWW0 : 02 - CABINET PARTS [2/6] Ref # Part Number Qty. Description Cover, Terminal Block Screw SCREW GROUND Panel, Side (R.H.) ASSEMBLY, SWITCH & ACTUATOR Clip, Toe Panel Panel, Side (L.H.) Foot, Dryer NI FOOT, OPTIONAL (EXTENDED LENGTH PACKAGE OF 2) Clamp, Motor Spring, Idler Retainer, Idler Plug, Multivent Pulley Assembly Bracket, Gas Pipe Bracket, Switch 16 W Wire, Belt Switch Screw Washer, Thrust 19 W Assembly, Door Switch Tri-Ring COVER PLATE RAMP,DOOR STRIKE, DOOR WIRE-MOTOR TO-BELT-SWITCH Base, Cabinet Panel, Rear 27 W MOTOR ASSEMBLY 60 HZ. 28 W Sound Pad, Motor PULLEY 30 W Belt, Drive BRACKET, BURNER 32 W Bracket, Motor Cord, Power `` - 90 ELBOW SCREW Exhaust Pipe & Bracket Exhaust Pipe (Short) Exhaust Pipe (Long) 39 W Idler Bracket Toe Panel SCREW 42 W SCREW SCREW Seal, Front Panel SCREW 46 W CONTROL BOARD Control Bracket Plug, Strip Front Panel Screw 50 W Front Panel (Includes Illus. 44) 51 W SWITCH, ASSEMBLY FOAM-SEAL (IEC) Boot, Foot BELT, POLY V 55 W STOP, TOP PANEL SCREW 57 W TRANSFORMER 120 TO 22.5 VAC SCREW BELT RESTRAINER NI DRYER EXHAUST KIT (FOR SIDE & BOTTOM VENTING) ( Page 4 of 12

5 MDG25PRAWW0 : 03 - BULKHEAD PARTS [3/6] Page 5 of 12

6 MDG25PRAWW0 : 03 - BULKHEAD PARTS [3/6] Ref # Part Number Qty. Description Shaft, R.H. Thread SCREW 3 W Door, Lint Screen THERMAL FUSE (91 C) Air Duct Assembly FOAM-SEAL Seal, Drum Front NUT,3/8 X 16(R.H.) 9 W Lint Screen Lens, Drum Light SCREW Clip, Exhaust Pipe SCREW SCREW 16 W Nut, 3/8-16 (L.H.) 17 W Bulkhead, Rear Washer, Support Shaft, L.H. Thread Ring, Tri 21 W ROLLER, SUPPORT Exhaust Pipe 23 W Housing, Outlet Assembly Screw 25 W Complete Drum Assembly 26 W SCREW 27 W Seal, Drum CLIP, SPRING Screw WIRE JUMPER 33 W Baffle, Drum Bulkhead, Front Bracket, Drum Light 36 W Grille, Outlet 37 W WHEEL, BLOWER Thermal Cut-Off Spring, Lint Screen Door FOAM-SEAL SCREW THERMISTOR SCREW Housing, Blower Lint Duct Assembly FUNNEL-BURNER THERMOSTAT, HIGH-LIMIT 255 F Sensor, Radiant SCREW Page 6 of 12

7 MDG25PRAWW0 : 04 - W BURNER ASSEMBLY [4/6] Page 7 of 12

8 MDG25PRAWW0 : 04 - W BURNER ASSEMBLY [4/6] Ref # Part Number Qty. Description 1 W Burner Assembly 60 Hz. (Type 1, 2 & 3) (White Rodgers) Tube, Burner Bracket, Ignitor Ignitor Screw & Washer (8-32 x 5/8) Screw, x 1/ Base, Burner SCREW, X 1/ Orifice, Burner (Type 1) Orifice, Burner (Type 2) 10 W VALVE, GAS (60 HZ COMPLETE) SCREW, 8-32 X 1/ Bracket, Coil Coil, 60 Hz. (2 Terminal) (Main) COIL, 60 HZ (SPLIT) (3 TERMINAL) (PILOT POSITION) Leak, Limiter Screw, Regulator Adjustment Spring, Regulator Plug, Pipe 21 W Pipe, Gas Supply Valve & Union Shut-Off Pipe, Tail Nut, Compression Clamp, Pipe Bracket, Support NI W CONVERSION KIT (TYPE 1 AND 2) TO TYPE (4) L.P.G. Page 8 of 12

9 MDG25PRAWW0 : 05 - DOOR PARTS [5/6] Page 9 of 12

10 MDG25PRAWW0 : 05 - DOOR PARTS [5/6] Ref # Part Number Qty. Description HINGE HOLE COVER (INNER DOOR) 2 W DOOR HINGE ASSEMBLY 3 W Assembly, Door Intermediate Screw SCREW Seal, Window 7 W Handle, Door (Includes Illus. 20.) 8 W SCREW Screw 10 W DOOR ASSEMBLY (INNER) (INCLUDES ILLUS. 1,14 & 19) SCREW 12 W DOOR, OUTER RING 13 W WINDOW Door Catch Assembly Retainer-Lower Door, Intermediate SCREW Retainer, Upper 19 W DOOR SEAL 20 W Pad, Door Handle Page 10 of 12

11 MDG25PRAWW0 : 06 - OPTIONAL PARTS (NOT INCLUDED) [6/6] Page 11 of 12

12 MDG25PRAWW0 : 06 - OPTIONAL PARTS (NOT INCLUDED) [6/6] Ref # Part Number Qty. Description NI PAINT, TOUCH-UP (1/2oz.) (White) NI PAINT, PRESSURIZED SPRAY (12OZ. WHITE) NI PAINT, PRESSURIZED SPRAY (12 OZ.) (PRIMER, GRAY) NI PAINT, BULK (1 qt.) (White (Uncut)) NI Hold Down Kit NI Kit, Dryer Repair Page 12 of 12