Drying Tumblers 110 Pound Capacity Refer to Page 3 for Model Numbers. Parts

Transcription

1 Drying Tumblers 0 Pound Capacity Refer to Page 3 for Model Numbers Parts Part No. M444R April 000

2 Table of Contents Title Page Parts Ordering Information... Nameplate Location... Model Identification... 3 Single Timer Control... 4 Dual Timer Controls... Temperature Controls... 8 Access and Lint Panels... 0 Front Panel... Door Assembly... 4 Lint Screen and Drive Guard... Drive Sheave, Step Pulley and Belts... 8 Trunnion Bearings... 0 Cylinder Drive Motor... 0 Hertz Fan and Motor Assembly Hertz Fan and Motor Assembly... Cylinder and Trunnion Shaft... 8 Gas Valve and Piping Gas Burner and Igniter... 3 Steam Heating Unit Reversing Controls... 3 Air Flow Switch Assembly Parts Index... 4 Copyright 000, Alliance Laundry Systems LLC All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed written consent of the publisher. M444

3 If literature or replacement parts are required, contact the source from whom the machine was purchased or contact Alliance Laundry Systems LLC at (90) for the name and address of the nearest authorized parts distributor. For technical assistance, call (90) Parts Ordering Information When calling or writing about your product, be sure to mention model and serial numbers. Model and serial numbers are located on nameplate(s) as shown. Nameplate Location NAMEPLATE WIRING DIAGRAM T00I M444

4 Model Identification Information in this manual is applicable to these drying tumblers: JT0CG JTD0CG ST0CG STD0CG JT0CSH JTD0CSH ST0CSH STD0CSH JT0GH4 JTS0CG ST0GH4 STS0CG JT0SH JTS0CSH ST0SH STS0CSH M444 3

5 Notes

6 Single Timer Control 3 NUT (Included with M40094) LOAD READY COOL DOWN NON REV AIR FLOW REV 8 7 PUSH TO START 4 T33P 4 M444

7 Single Timer Control REF PART NO. DESCRIPTION COMMENTS H940 Cool Down Light H940 Ready Light 3 H Three Cycle Timer 0 Hertz H94038 Three Cycle Timer 0 Hertz 4 H94 Air Flow Light M Timer Label H83907 Timer Knob 7 M40988 Push-to-Start Label 8 M40094 Reversing Switch Toggle H9443 Reversing Switch Rocker M444

8 Dual Timer Controls PUSH TO START 3 0 COOLING DRYING T39P M444

9 Dual Timer Controls REF PART NO. DESCRIPTION COMMENTS M40094 Push-to-Start Switch M4099 Resistor 3 M Relay Screw M40007 Screw M4004 Screw 7 M4090P Cooling Timer minute 0 Hertz M40900P Cooling Timer minute 0 Hertz 8 M4044 Insulator 9 M40903P Drying Timer 0 minute 0 Hertz M4090P Drying Timer 0 minute 0 Hertz 0 M Light M40 Screw M Timer Knob 3 M40007 Screw 4 M40 Timer Graphics Plate M4074 Timer Bracket M Terminal Bracket M444 7

10 Temperature Controls M444

11 Temperature Controls REF PART NO. DESCRIPTION COMMENTS M407 Graphics Panel Reversing Models, Silver M40330 Graphics Panel Nonreversing Models, Silver 77 Temperature Switch 3 M4370 Reversing/Nonreversing Switch 4 97 Lockwasher 40 Knurled Nut M Temperature Knob 7 M Light M444 9

12 Access and Lint Panels 3 4 NAMEPLATE T47P 0 M444

13 Access and Lint Panels REF PART NO. DESCRIPTION COMMENTS H Screw H88908 Nylon Washer 3 M4090 Screw 4 H948073* Top Access Panel Gas Models, Painted H Top Access Panel Gas Models, Stainless Steel H94894* Top Access Panel Steam Models, Painted H Top Access Panel Steam Models, Stainless Steel 39 Nut H87000 Roller Catch 7 M Screw 8 H948* Lint Panel Painted H94873 Lint Panel Stainless Steel 9 H84P Rubber Trim * Add letter to designate color: L - Almond W - White V - Orange K - Red B - Battina Green H - Harvest Gold X - Electric Blue P - Turquoise M444

14 Front Panel T4P M444

15 Front Panel REF PART NO. DESCRIPTION COMMENTS M40979 Wire Set For Door Switch M408* Front Panel Models 0CG and 0CSH, Painted M409 Front Panel Models 0CG and 0CSH, Stainless Steel H94788* Front Panel Models 0GH4 and 0SH4, Painted M409 Control Trim 3 M4089 Warning Label 4 H9409 Insulation H94878 Insulator H944 Door Switch 7 H88 Lockwasher 8 H Nut 9 M4009 Hinge Pin 0 M4004 Upper Panel Hinge H Screw M4004 Lower Panel Hinge 3 M4093 Warning Label 4 M40997 Actuator M40007 Screw M403 Door Catch 7 H8807 Screw 8 H Screw 9 H88908 Nylon Washer * Add letter to designate color: L - Almond W - White V - Orange K - Red B - Battina Green H - Harvest Gold X - Electric Blue P - Turquoise M444 3

16 Door Assembly T48P 4 M444

17 Door Assembly REF PART NO. DESCRIPTION COMMENTS M4089* Door Assembly Painted M4090 Door Assembly Stainless Steel M400 Door Strike Screw 3 M4000 Nut 4 M9409 Door Gasket Not Included with Door Assembly H88978 Hinge Mounting Screw Not Included with Door Assembly M Hinge Mounting Screw Not Included with Door Assembly 7 M4003 Upper Door Hinge Not Included with Door Assembly 8 M40030 Lower Door Hinge Not Included with Door Assembly 9 M4007 Washer Not Included with Door Assembly Nut M Door Glass Seal M Door Glass 3 M40033 Door Handle 4 M40938 Screw * Add letter to designate color: L - Almond W - White V - Orange K - Red B - Battina Green H - Harvest Gold X - Electric Blue P - Turquoise M444

18 Lint Screen and Drive Guard T4P M444

19 Lint Screen and Drive Guard REF PART NO. DESCRIPTION COMMENTS H94779 Drive Guard Side Left H93904 Drive Guard Top 3 M4088 Screw 4 M4090 Screw H88703 Screw H9388 Drive Guard Side Right 7 H9477 Drive Guard Cover 8 M40977 Lint Screen Frame Models 0CG and 0CSH H949 Lint Screen Frame Models 0GH4 and 0SH4 9 M409 Lint Screen Models 0CG and 0CSH H9407 Lint Screen Models 0GH4 and 0SH Nut M40004 Washer M444 7

20 Drive Sheave, Step Pulley and Belts T49P 3 8 M444

21 Drive Sheave, Step Pulley and Belts REF PART NO. DESCRIPTION COMMENTS H87784 Step Pulley Bearings Outer H Step Pulley Bearings Inner H Retainer Ring Required H87N Sheave H Tube 3 H8800 Bolt 4 M4337 Eye Bolt M Nut M Washer 7 M40004 Lockwasher Nut 9 H9377 Jackshaft Assembly 0 0 Screw H Belt H94804 Step Pulley 3 H8803 Retainer Ring 4 H87338P Belt Set of 3 H8798H Bushing M444 9

22 Trunnion Bearings T40P 0 M444

23 Trunnion Bearings REF PART NO. DESCRIPTION COMMENTS M40008 Washer H8744H Trunnion Bearing Nut 4 H88399 Screw M40004 Lockwasher H88703 Screw 7 H Nut 8 H888 Lockwasher 9 H94008 Mounting Bracket 0 88 Screw M444

24 Cylinder Drive Motor T37P M444

25 Cylinder Drive Motor REF PART NO. DESCRIPTION COMMENTS H8799 Taper Bushing 0 Hertz H879 Taper Bushing 0 Hertz H8704 Drive Sheave 0 Hertz H Drive Sheave 0 Hertz 3 H837044H Cylinder Drive Motor Volt, 0 Hertz, 3 Phase H837047H Cylinder Drive Motor Volt, 0 Hertz, 3 Phase 4 H8700H Key 0 Screw M Washer 7 H94893 Bracket 8 88 Screw 9 H9484 Motor Base Nut M40004 Lockwasher H Nut 3 H888 Lockwasher 4 M Nut H Tube H8800 Screw M444 3

26 0 Hertz Fan and Motor Assembly T3P 9 4 M444

27 0 Hertz Fan and Motor Assemblys REF PART NO. DESCRIPTION COMMENTS H87084 Motor Sheave Nonreversing only H879 Hub for Motor Sheave Nonreversing only H83708 Motors Volt, 0 Hertz, 3 Phase, Nonreversing ( Horsepower) H83709H Motors Volt, 0 Hertz, 3 Phase, Reversing ( Horsepower) H8700H Key 3 H8790 Bushing For Fan, Nonreversing H879 Bushing For Fan, Reversing 4 H93830 Fan H89003H Thermostats High H89007 Thermostats High Limit H89003 Thermostats Medium H Thermostats Low H890030H Thermostats Load Ready H884 Screw 7 H Fan Cover Lockwasher Nut 0 H93703 Motor Bracket H83374 Screw 8 Screw M444

28 0 Hertz Fan and Motor Assembly T3P M444

29 0 Hertz Fan and Motor Assembly REF PART NO. DESCRIPTION COMMENTS H Sheave H83708H Fan Motor Volt, 0 Hertz, 3 Phase 3 H9484 Motor Base 4 H94893 Bracket H8790 Bushing M40997 Damper and Hinge 7 H93830 Fan 8 H89003H Thermostats High H89007 Thermostats High Limit H89003 Thermostats Medium H Thermostats Low H890030H Thermostats Load Ready 9 H Cover 0 H87830H Flangette Required (Not Shown) H878H Bearing Insert H94787 Base for Fan Shaft 3 H8700H Pillow Block Bearing 4 H Tube H8700H Key H87084 Sheave 7 H9483 Fan Shaft 8 H87370H Belt 9 M4337 Eye Bolt 0 H879 Bushing M444 7

30 Cylinder and Trunnion Shaft 3 4 T78P 8 M444

31 Cylinder and Trunnion Shaft REF PART NO. DESCRIPTION COMMENTS H9473 Cylinder Galvanized M Cylinder Stainless Steel M4099 Cylinder Poly Coated H Trunnion Assembly 3 M Nut 4 H88304 Rib Rod H94003 Cylinder and Shaft Assembly Galvanized M Cylinder and Shaft Assembly Stainless Steel M Cylinder and Shaft Assembly Poly Coated M444 9

32 Gas Valve and Piping WARNING: T0P 30 M444

33 Gas Valve and Piping REF PART NO. DESCRIPTION COMMENTS H804 Nipple M43 Shut-off Valve 3 H93780 Inlet Pipe 4 M44 Clamp 0937 Screw H89007H Ignition Control Natural Gas H89008H Ignition Control L.P. (Liquefied Petroleum) Gas 7 H88374 Screw 8 H88497H Speed Nut 9 H807 Nipple 0 M40973 Pilot Tube M40097 Tubing Nut H Bushing 3 H80 Nipple 4 H80003 Elbow H H Burner Orifice Natural Gas; (0 000 feet) No. 7 M43 Burner Orifice Natural Gas; ( feet) No. 0 H H Burner Orifice Natural Gas; ( feet) No. M40999 Burner Orifice Natural Gas; ( feet) No. H890007H Burner Orifice L.P. Gas; (0 999 feet) No. 3 H9370 Manifold Pipe 7 H800 Nipple 8 H898H Gas Valve Order Part No. H890009H Conversion Kit when using the valve with L.P. Gas 9 M449 Union 0 H Elbow M444 3

34 Gas Burner and Igniter TU4-PT- 3 M444

35 Gas Burner and Igniter REF PART NO. DESCRIPTION COMMENTS H H Pilot Orifice Natural Gas Q8 Pilot Orifice L.P. (Liquefied Petroleum) Gas M409 Burner Wire Set H89009 Thermostat Stove High Limit M4004 Screw M40973 Pilot Tube 3 H8894 Sensor Wire 4 H Pilot and Electrode Assembly With Spark Plug Terminal M4083 Pilot and Electrode Assembly With Quick Connect Terminal H88497H Speed Nut M4009 Flame Sensor 7 M40340 Snap Bushing 8 M407 Bracket 9 M Main Burner Assembly Natural Gas H Main Burner Assembly L.P. Gas 0 H93770 Pilot Shield Q9 Screw H8844H Screw 3 M40990 Flash Shield 4 M40097 Tubing Nut M444 33

36 Steam Heating Unit T44P 34 M444

37 Steam Heating Unit REF PART NO. DESCRIPTION COMMENTS H Bearing Flangette Required H Bearing Insert 3 M489 Steam Solenoid Valve 4 H Housing Cover H93880 Damper Link H Damper Shaft 7 H Counterweight 4 Required 8 H93870 Actuator Arm 9 H93888 Chain 0 H93807 Connecting Link H Damper Drive Wheel H93884 Bracket 3 H93803 Steam Coil Required 4 H93880 Actuator H9389 Filter Required M444 3

38 Reversing Controls T43P 3 M444

39 Reversing Controls REF PART NO. DESCRIPTION COMMENTS H83904 Control Transformer 480 Volt Models Only H H Fan Contactor Models 0CG and 0CSH H9433 Fan Contactor Models 0GH4 and 0SH4 H830083H Reversing Contactor 3 M40938 Locknut 4 H Fuse Holder H Ignition Transformer H Fuse Amp, 0 VAC 7 H Buzzer 8 H94399 Reversing Timer 9 H83034 Terminal Strip 0 H83000H Overload Relay Models 0CG and 0CSH, Volt H830007H Overload Relay Models 0CG and 0CSH, Volt H940 Overload Relay Models 0GH4 and 0SH4, All Voltages H Time Delay Relay M444 37

40 Air Flow Switch Assembly (Mounted on Upper Right Cabinet Back) TP 38 M444

41 Air Flow Switch Assembly (Mounted on Upper Right Cabinet Back) REF PART NO. DESCRIPTION COMMENTS M40938 Screw H830 Switch with Lever 3 H88 Lockwasher 4 H Nut H94894 Air Flow Vane 0470 Cotter Pin M444 39

42 Parts Index A Actuator H M Actuator Arm H Air Flow Light H94... Air Flow Vane H B Base for Fan Shaft H Bearing Flangette H Bearing Insert H878H... 7 H Belt H87370H... 7 H H87338P... 9 Bolt H Bracket H H , 7 M Burner Orifice H890007H... 3 H H... 3 H H... 3 M M Burner Wire Set M Bushing H879..., 7 H H H8798H... 9 H Buzzer H C Chain H Clamp M Connecting Link H Control Transformer H Control Trim M Cool Down Light H Cooling Timer M40900P...7 M4090P...7 Cotter Pin Counterweight H Cover H Cylinder H M M Cylinder and Shaft Assembly H M M Cylinder Drive Motor H837044H...3 H837047H...3 D Damper and Hinge M Damper Drive Wheel H Damper Link H Damper Shaft H Door Assembly M M Door Catch M Door Gasket M Door Glass M Door Glass Seal M Door Handle M Door Strike Screw M Door Switch H Drive Guard Cover H Drive Guard Side H Drive Guard Top H M444 4

43 Drive Sheave H H Drying Timer M4090P... 7 M40903P... 7 E Elbow H H Eye Bolt M , 7 F Fan H , 7 Fan Contactor H H H Fan Cover H Fan Motor H83708H... 7 Fan Shaft H Filter H Flame Sensor M Flangette H87830H... 7 Flash Shield M Front Panel H M M Fuse H Fuse Holder H G Gas Valve H898H... 3 Graphics Plate M M H Hinge Mounting Screw H M Hinge Pin M Housing Cover H Hub for Motor Sheave H I Ignition Control H89007H...3 H89008H...3 Ignition Transformer H Inlet Pipe H Insulation H Insulator H M J Jackshaft Assembly H K Key H8700H...3,, 7 Knurled Nut L Light M , 9 Lint Panel H H Lint Screen H M Lint Screen Frame H M Locknut M Lockwasher H888..., 3 H88...3, 39 M ,, Lower Door Hinge M Lower Panel Hinge M M444

44 M Main Burner Assembly H M Manifold Pipe H Motor Base H , 7 Motor Bracket H Motor Sheave H Motors H H83709H... Mounting Bracket H N Nipple H H H H Nut H H , 3 H M M , 3, , 9,, Nylon Washer H , 3 O Overload Relay H83000H H830007H H P Pillow Block Bearing H8700H... 7 Pilot and Electrode Assembly H M Pilot Orifice H H Q Pilot Shield H Pilot Tube M , 33 Push-to-Start Label M Push-to-Start Switch M R Ready Light H Relay M Resistor M Retainer Ring H H Reversing Contactor H830083H...37 Reversing Switch H M Reversing Timer H Reversing/Nonreversing Switch M Rib Rod H Roller Catch H Rubber Trim H84P... S Screw H H H H , H8844H...33 H H H , 3 H H M M M , 3 M , 33 M , 7 M M M M Q , , Sensor Wire H M444 43

45 Sheave H H H87N... 9 Shut-off Valve M Snap Bushing M Speed Nut H88497H... 3, 33 Steam Coil H Steam Solenoid Valve M Step Pulley H Step Pulley Bearings H H Switch with Lever H T Taper Bushing H H Temperature Knob M Temperature Switch Terminal Bracket M Terminal Strip H Thermostat Stove High Limit H Thermostats H , 7 H , 7 H , 7 H890030H..., 7 H89003H..., 7 Three Cycle Timer H H Time Delay Relay H Timer Bracket M Timer Graphics Plate M Timer Knob H M Timer Label M Top Access Panel H H H H Trunnion Assembly H Trunnion Bearing H8744H... Tube H H , 3 Tubing Nut M , 33 U Union M Upper Door Hinge M Upper Panel Hinge M W Warning Label M M Washer M M , 3 M M Wire Set M M444