Commercial Frontload Washers

Transcription

1 Commercial Frontload Washers Parts Refer to Page 3 for Model Numbers FLW1510C_ Part No R6 August 2007

2

3 Table of Contents Title Page Parts Ordering Information... 2 Nameplate Location... 2 Model Identification... 3 Control Panel and Controls... 4 Cabinet Top... 6 Control Shield and Motor Control... 8 Control Shield and Other Controls Wrapper Assembly and Coin Drop Electronic Coin Drop Wrapper Assembly Wrapper Assembly and Card Reader Kit Wrapper Assembly and Card Reader Front Panel, Older Style Door Assembly and Door Seal Front Panel, Newer Style Door Assembly and Door Seal Dispenser Assembly Mixing Valve and Fill Hose Outer Tub, Front and Clamp Ring Inner Basket, Trunnion, Bearing Housing and Pulley Motor and Belt Hoses and Pump Base, Panels and Rear Panel Shipping Materials Wire Ties, Harness Clips and Lead-In Cord Special Tools Labels (Drawing 1 of 2) Labels (Drawing 2 of 2) Wire Harnesses and Wires Parts Index Copyright 2007, Alliance Laundry Systems LLC All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed written consent of the publisher

4 If literature or replacement parts are required, contact the source from whom the machine was purchased or contact Alliance Laundry Systems at (920) for the name and address of the nearest authorized parts distributor. For technical assistance, call (920) Parts Ordering Information When calling or writing about your product, be sure to mention model and serial numbers. Model and serial numbers are located on nameplate(s) as shown. Nameplate Location NAMEPLATE LOCATION H129P_

5 Model Identification Information in this manual is applicable to these washer models: HWF561*E1102 HWF561*H1102 HWF761*E1102 HWFB61*J1102 HWFF61*J1102 HWFT61*H HWFT61*H1102 HWFX61*H1102 HWFY61*H1102 HWFZ61*H HWFZ61*H1102 SWF561*E SWF561*H SWF661*E SWF661*H SWF761*E SWF761*H SWFA61*H SWFA61*J SWFB61*H SWFB61*J SWFC61*H SWFC61*J SWFD61*H SWFF61*J SWFH61*J SWFJ61*J SWFT61*H SWFX61*H SWFY61*H SWFZ61*H * Add Letter To Designate Color. L - Almond Q - Bisque W - White

6 Control Panel and Controls FLW970P_

7 Control Panel and Controls REF PART NO. DESCRIPTION COMMENTS P Lock Kit Includes item Lock Cam P Control Assembly Models HWF561*E1102, HWF761*E1102, SWF561*E, SWF661*E and SWF761*E P Control Kit Models HWF561*H1102, HWF761*E1102, HWFB61*J1102, HWFF61*J1102, SWF561*H, SWF661*H, SWF761*H, SWFA61*J, SWFB61*H, SWFB61*J, SWFC61*H, SWFC61*J, SWFD61*H, SWFF61*J, SWFH61*J and SWFJ61*J P Control Assembly Models HWFT61*H, HWFT61*H1102, HWFX61*H1102, HWFY61*H1102, HWFZ61*H, HWFZ61*H1102, SWFT61*H, SWFX61*H, SWFY61*H and SWFZ61*H Diagnostic Wire Harness Assembly Models HWFF61*J1102, HWFY61*H1102, SWFC61*J, SWFF61*J, SWFJ61*J and SWFY61*H Light Models HWF561*E1102, HWF561*H1102, HWF761*E1102, SWF561*E, SWF561*H, SWF661*E, SWF661*H, SWF761*E, SWF761*H, SWFA61*H, SWFB61*H, SWFC61*H and SWFD61*H W Control Panel and Bracket Assembly Models HWF561*E1102, HWF761*E1102, SWF561*E, SWF661*E and SWF761*E W Control Panel and Bracket Assembly White; All other models L Control Panel and Bracket Assembly Almond; All other models Q Control Panel and Bracket Assembly Bisque; All other models Overlay Models SWF561*E, SWF661*E, SWF761*E, SWF561*H, SWF661*H and SWF761*H 7 N/A Overlay Models HWF561*E1102, HWF761*E1102 and HWF561*H Control Panel Overlay Models SWFC61*J, SWFF61*J and SWFJ61*J Control Panel Overlay Models SWFA61*H, SWFA61*J, SWFB61*H, SWFB61*J, SWFC61*H, SWFD61*H and SWFH61*J Control Panel Overlay Model HWFB61*J N/A Overlay Model HWFF61*J Front Overlay Models SWFT61*H, SWFX61*H, SWFY61*H and SWFZ61*H Front Overlay Models HWFT61*H, HWFT61*H1102, HWFX61*H1102, HWFY61*H1102, HWFZ61*H and HWFZ61*H Screw Key 800 * Add Letter To Designate Color. L - Almond Q - Bisque W - White N/A = Part no longer available

8 Cabinet Top FLW858P_

9 Cabinet Top REF PART NO. DESCRIPTION COMMENTS Bumper Pad Use with item Screw Models SWF561*E, SWF661*E and SWF761*E Screw All other models Bolt WP Top and Gusset Assembly White; Includes (1) * Top Panel, (10) Nut, (10) Screw, (2) Bracket and (2) each of items 6 and LP Top and Gusset Assembly Almond; Includes (1) * Top Panel, (10) Nut, (10) Screw, (2) Bracket and (2) each of items 6 and QP Top and Gusset Assembly Bisque; Includes (1) * Top Panel, (10) Nut, (10) Screw, (2) Bracket and (2) each of items 6 and Pop Rivet Hinge Top Mounting Bracket Nut 9 N/A Security Top Panel All models except HWFF61*J1102, HWFY61*H1102, SWFC61*H, SWFC61*J, SWFD61*H, SWFF61*J, SWFJ61*J and SWFY61*H Nut Screw * Add Letter To Designate Color. L - Almond Q - Bisque W - White N/A = Part no longer available

10 Control Shield and Motor Control Models HWF561*E1102, HWF761*E1102, SWF561*E, SWF661*E and SWF761*E FLW971P_

11 Control Shield and Motor Control REF PART NO. DESCRIPTION COMMENTS Control Shield Screw Snap Bushing Models through Serial Nos. beginning P Pressure Switch 5 M Snap Bushing Hose Clip P Motor Control Assembly Screw Screw Door Switch Bracket Switch 12 F Fuse 7 Amp; 1.25 x.25 * Add Letter To Designate Color. L - Almond Q - Bisque W - White

12 Control Shield and Other Controls All Models Except HWF561*E1102, HWF761*E1102, SWF561*E, SWF661*E and SWF761*E FLW972P_

13 Control Shield and Other Controls REF PART NO. DESCRIPTION COMMENTS Screw Network Wire Harness Assembly Models SWFH61*J and SWFJ61*J P Transformer Models HWFB61*J1102, HWFF61*J1102, HWFT61*H, HWFT61*H1102, HWFZ61*H, HWFZ61*H1102, SWFA61*H, SWFB61*H, SWFB61*J, SWFC61*H, SWFD61*H, SWFF61*J, SWFH61*J, SWFJ61*J, SWFT61*H and SWFZ61*H P Transformer Models HWFX61*H1102, HWFY61*H1102, SWFA61*J, SWFC61*J, SWFX61*H and SWFY61*H P Network Board Assembly Models SWFH61*J and SWFJ61*J Network Cable Wire Harness Models SWFH61*J and SWFJ61*J Assembly Control Shield Snap Bushing Models through Serial Nos. beginning P Pressure Switch 9 M Snap Bushing Hose Clip P Motor Control Assembly Screw 13 F Fuse 7 Amp; 1.25 x Communication Connector Models SWFH61*J and SWFJ61*J PC Board Standoff Models SWFH61*J and SWFJ61*J P Communication Board Models SWFH61*J and SWFJ61*J Screw Audit Switch Bracket Switch * Add Letter To Designate Color. L - Almond Q - Bisque W - White

14 Wrapper Assembly and Coin Drop Models HWF561*E1102, HWF561*H1102, HWFB61*J1102, HWFT61*H, HWFT61*H1102, HWFX61*H1102, HWFZ61*H, HWFZ61*H1102, SWF561*E, SWF561*H, SWFA61*H, SWFA61*J, SWFB61*H, SWFB61*J, SWFH61*J, SWFT61*H, SWFX61*H and SWFZ61*H FLW973P_

15 Wrapper Assembly and Coin Drop REF PART NO. DESCRIPTION COMMENTS P Coin Drop Assembly Dual drop; Models HWF561*E1102, HWF561*H1102, HWFB61*J1102, HWFT61*H1102 and HWFZ61*H P Coin Drop Single drop; All other models P Opto Coupler Multiplier Assembly Models HWF561*E1102, HWF561*H1102, HWFB61*J1102, HWFT61*H1102 and HWFZ61*H P Coin Drop Harness Models HWFT61*H, HWFZ61*H, SWFB61*H, SWFB61*J, SWFH61*J, SWFT61*H and SWFZ61*H P Dual Coin Harness Models HWFB61*J1102, HWFT61*H1102, HWFX61*H1102, HWFZ61*H1102, SWFA61*H, SWFA61*J and SWFX61*H Nut P Wire Guard Anti-stringing security device; Add to coin drops manufactured starting January WP Wrapper and Channel Assembly White LP Wrapper and Channel Assembly Almond QP Wrapper and Channel Assembly Bisque Screw Screw Panel Locator Instruction Label Dual Overlay Dual drop; Models HWF561*E1102, HWF561*H1102, HWFB61*J1102, HWFT61*H1102, HWFX61*H1102 and HWFZ61*H Single Overlay Single drop; All other models WP Security Cabinet Front Assembly White LP Security Cabinet Front Assembly Almond QP Security Cabinet Front Assembly Bisque Coin Identification Paper * Add Letter To Designate Color. L - Almond Q - Bisque W - White

16 Electronic Coin Drop Models HWFX61*H1102, SWFA61*H, SWFA61*J and SWFX61*H FLW961P_

17 Electronic Coin Drop REF PART NO. DESCRIPTION COMMENTS 1 CK095 Electronic Coin Drop Kit P Electronic Coin Drop Assembly Nut Coin Drop Wire Harness Clip Overlay Coin Identification Paper * Add Letter To Designate Color. L - Almond Q - Bisque W - White

18 Wrapper Assembly Models SWFC61*H and SWFC61*J FLW904P_

19 Wrapper Assembly REF PART NO. DESCRIPTION COMMENTS WP Security Cabinet Front Assembly White LP Security Cabinet Front Assembly Almond WP Wrapper and Channel Assembly White LP Wrapper and Channel Assembly Almond QP Wrapper and Channel Assembly Bisque Screw Screw Panel Locator Instruction Label * Add Letter To Designate Color. L - Almond Q - Bisque W - White

20 Wrapper Assembly and Card Reader Kit Models HWF761*E1102, SWF661*E, SWF661*H, SWF761*E, SWF761*H and SWFD61*H FLW933P_

21 Wrapper Assembly and Card Reader Kit REF PART NO. DESCRIPTION COMMENTS 1 876P3 Card Reader Kit Models HWF761*E1102, SWF661*E, SWF661*H, SWF761*E and SWF761*H 1 885P3 Card Reader Kit Model SWFD61*H Screw Card Reader Wire Harness Assembly Use with Card Reader; Models HWF761*E1102, SWF761*E and SWF761*H 3 N/A Card Reader Harness Assembly Use with Card Reader; Model SWFD61*H WP Wrapper and Channel Assembly White LP Wrapper and Channel Assembly Almond QP Wrapper and Channel Assembly Bisque Screw Screw Panel Locator Instruction Label 9 N/A Card Reader Overlay Use with Card Reader; Model HWF761*E Card Reader Instruction Overlay Use with Card Reader; All other models W Security Cabinet Front Assembly Use with Card Reader WP Security Cabinet Front Assembly White; Use with card reader kits LP Security Cabinet Front Assembly Almond; Use with card reader kits Power Supply Models HWF761*E1102, SWF661*E, SWF661*H, SWF761*E and SWF761*H Power Supply Model SWFD61*H Card Reader P Programming Card Bolt Harness Models HWF761*E1102, SWF661*E, SWF661*H, SWF761*E and SWF761*H Harness Model SWFD61*H * Add Letter To Designate Color. L - Almond Q - Bisque W - White N/A = Part no longer available

22 Wrapper Assembly and Card Reader Models HWFF61*J1102, HWFY61*H1102, SWFF61*J, SWFJ61*J and SWFY61*H FLW898P_

23 Wrapper Assembly and Card Reader REF PART NO. DESCRIPTION COMMENTS WP Security Cabinet Front Assembly White L Security Cabinet Front Assembly Almond Q Security Cabinet Front Assembly Bisque P Card Reader and Bracket Assembly Nut P Card Reader Wire Harness Assembly Models HWFF61*J1102 and SWFF61*J WP Wrapper and Channel Assembly White LP Wrapper and Channel Assembly Almond QP Wrapper and Channel Assembly Bisque Screw Screw Panel Locator Instruction Label Card Insert Overlay Model SWFY61*H Card Insert Overlay Model HWFY61*H Card Reader Overlay All other models * Add Letter To Designate Color. L - Almond Q - Bisque W - White

24 Front Panel, Older Style Door Assembly and Door Seal Models HWF561*E1102, HWF761*E1102, SWF561*E, SWF661*E and SWF761*E INNER DOOR WITH GLASS H049PZ3A_

25 Front Panel, Older Style Door Assembly and Door Seal REF PART NO. DESCRIPTION COMMENTS 1 N/A Low Sudsing Label Door Locked Label WP Front Panel Assembly White; Includes items 4, 5, 7, Hinge Plate, * Front Panel and * Door Assembly LP Front Panel Assembly Almond; Includes items 4, 5, 7, Hinge Plate, * Front Panel and * Door Assembly QP Front Panel Assembly Bisque; Includes items 4, 5, 7, Hinge Plate, * Front Panel and * Door Assembly Panel Locator Screw Screw Door Latch/Switch Assembly Door Seal and Hose Assembly Harness Strap Hose Clamp P Door Seal Clamp 12 N/A Foam Tape Front panel door opening Wire Clamp Ring Extension Spring Door Hinge Assembly Screw 17 M Washer Nut Screw Hinge Plate Screw 22 N/A Foam Tape 1 inch by 26 inches WP Access Panel White LP Access Panel Almond QP Access Panel Bisque 24 N/A Door Bezel Replace using *P Front Panel Assembly Nut Door Handle Nut 28 N/A Bumper Locking Catch Screw Door Switch * Add Letter To Designate Color. L - Almond Q - Bisque W - White N/A = Part no longer available

26 Front Panel, Newer Style Door Assembly and Door Seal H134P_

27 Front Panel, Newer Style Door Assembly and Door Seal REF PART NO. DESCRIPTION COMMENTS W Door Bezel White L Door Bezel Almond Q Door Bezel Bisque Door Handle Nut Nut Inner Door Bezel Screw Screw Locking Catch Screw Door Hinge Screw Nut P Door Glass Hold-Down Clip Panel Locator Screw Door Latch/Switch Assembly Door Seal and Hose Assembly Cable Tie Hose Clamp P Door Seal Clamp Wire Clamp Ring Extension Spring Hinge Plate Screw 26 N/A Foam Tape Access Panel Damper 1 inch by 26 inches Screw WP Access Panel White LP Access Panel Almond QP Access Panel Bisque WP Front Panel White LP Front Panel Almond QP Front Panel Bisque Door Switch WP Door Assembly White; Includes items LP Door Assembly Almond; Includes items QP Door Assembly Bisque; Includes items 1-14 * Add Letter To Designate Color. L - Almond Q - Bisque W - White N/A = Part no longer available

28 Dispenser Assembly FLW820P_

29 Dispenser Assembly REF PART NO. DESCRIPTION COMMENTS Door Seal and Hose Assembly Wire Clip Cable Tie Hose Clamp Valve-to-Dispenser Inlet Hose Hose Clamp Backflow Preventer P Valve Kit Dispenser-to-Tub Hose Hose Clamp 11 F Hose Clamp Use if pump-to-dispenser hose is removed Cap Use if pump-to-dispenser hose is removed P Dispenser Includes items 8, 14 and P Dispenser Assembly Includes item Screw W Dispenser Drawer Front White L Dispenser Drawer Front Almond Q Dispenser Drawer Front Bisque Insert Detergent Cover Dispenser Plate Screw

30 Mixing Valve and Fill Hose H077P_

31 Mixing Valve and Fill Hose REF PART NO. DESCRIPTION COMMENTS Hose Clamp Valve-to-Dispenser Inlet Hose Hose Clamp Backflow Preventer Mixing Valve Plate Screw Washer P Fill Hose Kit Includes 2 of item Washer 9 F Filter Screen Washer Water pressure reducer; Available for water pressure up to but not exceeding 120 psi Screw 11 F Strainer P Mixing Valve

32 Outer Tub, Front and Clamp Ring FLW866P_

33 Outer Tub, Front and Clamp Ring REF PART NO. DESCRIPTION COMMENTS Nut Washer Screw Screw Out-of-Balance Switch Assembly Screw 7 M Washer Switch Mounting Bracket Warning Label Grommet Pressure Bulb Tubing Hose Clamp P Outer Tub Assembly P Tub Shock Absorber Kit P Base Shock Absorber Kit Grounding Clip Ballast Weight Tub Front Assembly P Tub Front Seal Clamp Ring

34 Inner Basket, Trunnion, Bearing Housing and Pulley FLW865P_

35 Inner Basket, Trunnion, Bearing Housing and Pulley REF PART NO. DESCRIPTION COMMENTS NA 27604P Anti-Seize Compound Pulley to inner basket shaft NA 838P3 Hardware Kit Includes (8) of item 6, (7) each of items 7 and 13, (6) of item 10, (1) each of items 12,14,17, 18 and 27604P Anti- Seize Compound Tension Rod Assembly P Inner Basket Kit Includes (3) each of items 1, 5, 6, and 838P3 Hardware Kit P Trunnion Shaft and Hardware Kit Includes (3) each of items 1, 5, 6, and 838P3 Hardware Kit P Inner Basket Assembly Includes items 2, 3, (3) each of items 1, 5, 6, and 838P3 Hardware Kit Nut Washer Nut Hose Mounting Plate Hose Clip Pop Rivet Driven Pulley Screw Left hand thread 13 M Washer Washer 15 M Screw P Bearing Housing Kit Includes 838P3 Hardware Kit P Tub Front Seal Screw

36 Motor and Belt FLW937P_

37 Motor and Belt REF PART NO. DESCRIPTION COMMENTS Expansion Clip 2 M Washer 3 M Screw P Transformer Screw 6 N/A Transformer Bracket 7 M Screw Washer 9 M Washer P Motor Assembly 230 Volt; Includes items 12 and 2 of P Drive Belt P3 Motor Brush Kit Motor Mount Rod N/A = Part no longer available

38 Hoses and Pump Standpipe FLW974P_

39 Hoses and Pump REF PART NO. DESCRIPTION COMMENTS NA 27615P Sealant Tub-to-pump hose to outer tub Drain Hose Standpipe Strap Hose Clamp Drain Hose Elbow Screw Hose Clamp Pump-to-Elbow Hose Backflow Preventer Hose Clamp Screw Metric; Use with Drain Pump Screw Use with Drain Pump Washer Use with and Drain Pump Grommet Use with and Drain Pump Pump Bracket Use with and Drain Pump Pump Mount Bracket Use with Drain Pump Screw Wire Tie Push mount Pump-to-Dispenser Hose Assembly Use with Drain Pump 17 F Hose Clamp Use with Drain Pump Nozzle Cap Use with Drain Pump Pump Shield Use with Drain Pump Screw Use with and Drain Pump Pump Mount Use with Drain Pump P3 Drain Pump Kit Includes wire harness adapter Screw Use with and Drain Pump O-Ring Use with Drain Pump O-Ring Use with and Drain Pump Pump Housing Assembly Includes items 25-27; Use with Drain Pump Pump Housing Assembly Includes items 25-27; Use with and Drain Pump Pump Housing Use with Drain Pump Pump Housing Use with and Drain Pump O-Ring Use with Drain Pump Gasket Use with and Drain Pump P Lid Assembly Includes filter; Use with Drain Pump P Lid Assembly Includes filter; Use with and Drain Pump Tub-to-Pump Hose

40 Base, Panels and Rear Panel FLW975P_

41 Base, Panels and Rear Panel REF PART NO. DESCRIPTION COMMENTS Bumper Pad Panel Locator Screw WP Cabinet Panel Kit White; Left; Includes corner gusset with hardware LP Cabinet Panel Kit Almond; Left; Includes corner gusset with hardware QP Cabinet Panel Kit Bisque; Left; Includes corner gusset with hardware Screw Rear Panel Includes corner gusset with hardware Screw Label Left hand thread Rear Service Panel WP Side Panel Kit White; Right; Includes Dispenser Plate with hardware LP Side Panel Kit Almond; Right; Includes Dispenser Plate with hardware QP Side Panel Kit Bisque; Right; Includes Dispenser Plate with hardware Nut For 1/2 inch leveling leg Leveling Leg 1/2 inch leveling leg P3 Anchor Includes 4 rubber discs with adhesive backing Rubber Foot For 1/2 inch leveling leg Rubber Foot For 3/8 inch leveling leg Leveling Leg 3/8 inch leveling leg Nut For 3/8 inch leveling leg Leveling Leg Spacer For 3/8 inch leveling leg Base Assembly Uses 1/2 inch leveling leg

42 Shipping Materials H087P_

43 Shipping Materials REF PART NO. DESCRIPTION COMMENTS 1 M Screw 2 M Washer Shipping Bracket P Shipping Cord and Brace Assembly Warning Label 6 728P3 Shipping Materials Kit Includes items 1-4 and Shipping Bracket Label

44 Wire Ties, Harness Clips and Lead-In Cord H130P_

45 Wire Ties, Harness Clips and Lead-In Cord REF PART NO. DESCRIPTION COMMENTS Wire Tie Push mount Harness Strap Wire Clip Hose Clip Wire Clip Small Wire Clip Large Nut Washer 9 N/A Screw Strain Relief Lead-In Cord N/A = Part no longer available

46 Special Tools FLW874P_

47 Special Tools REF PART NO. DESCRIPTION COMMENTS 1 CK096 Mounting Tool Kit Use to install and remove electronic coin drop 2 310P4 Ratchet Extension Tool 1/4 inch; Use to install and remove non-electronic coin drop 3 318P4 Dispenser Drawer Tool Use to remove dispenser drawer

48 2 3 1 Labels (Drawing 1 of 2) Models HWF561*E1102, HWF761*E1102, SWF561*E, SWF661*E and SWF761*E H068P_

49 Labels (Drawing 1 of 2) REF PART NO. DESCRIPTION COMMENTS Door Locked Label Oversudsing Label English Oversudsing Label Quebec French Oversudsing Label Spanish Disconnect Power Warning Label English Warning Label Quebec French Warning Label English Warning Label Quebec French * Add Letter To Designate Color. L - Almond Q - Bisque W - White

50 Labels (Drawing 2 of 2) All Models Except HWF561*E1102, HWF761*E1102, SWF561*E, SWF661*E and SWF761*E H132P_

51 Labels (Drawing 2 of 2) REF PART NO. DESCRIPTION COMMENTS Door Locked Label Oversudsing Label English Oversudsing Label Quebec French Oversudsing Label Spanish Disconnect Power Warning Label English Warning Label Quebec French Warning Label English Warning Label Quebec French * Add Letter To Designate Color. L - Almond Q - Bisque W - White

52 2 3 1 Wire Harnesses and Wires FLW936P_

53 Wire Harnesses and Wires REF PART NO. DESCRIPTION COMMENTS NA Gauge Wire Black; Order wire by foot and terminals and connectors as required NA Gauge Wire Orange; Order wire by foot and terminals and connectors as required 1 N/A Control Harness Models HWF561*E1102, HWF561*H1102, HWF761*E1102 and SWF761*E P Wire Harness Assembly Models SWF561*E, SWF661*E, SWF661*H and SWF761*H P Control Wire Harness Assembly All other models P Harness Assembly P Base Wire Harness * Add Letter To Designate Color. L - Almond Q - Bisque W - White N/A = Part no longer available NOTE: Individual wires are not available separately. Order complete harness, or order wire by the foot. When applying terminals to wires, it is recommended that the terminals be soldered to the wires

54 Notes

55 Parts Index A Access Panel LP... 23, QP... 23, WP... 23, 25 Access Panel Damper Anchor Kit 155P Anti-Seize Compound 27604P Audit Switch Bracket B Backflow Preventer , Ballast Weight Base Assembly Base Shock Absorber Kit P Base Wire Harness P Bearing Housing Assembly P Bolt Bumper Pad , 39 C Cabinet Panel Kit LP QP WP Cable Tie , 27 Cap Card Insert Overlay Card Reader Card Reader and Bracket Assembly P Card Reader Instruction Overlay Card Reader Kit 876P P Card Reader Overlay Card Reader Wire Harness Assembly P...21 Clamp Ring Clip Coin Drop 38479P...13 Coin Drop Assembly P...13 Coin Drop Harness P...13 Coin Drop Wire Harness Coin Identification Paper , 15 Communication Board P...11 Communication Connector Control Assembly P P...5 Control Kit P...5 Control Panel and Bracket Assembly W L Q W...5 Control Panel Overlay Control Shield , 11 Control Wire Harness Assembly P...51 N/A items do not appear in index D Detergent Cover Diagnostic Wire Harness Assembly Disconnect Power Warning Label , 49 Dispenser P...27 Dispenser Assembly P...27 Dispenser Drawer Front L Q W...27 Dispenser Drawer Tool 318P4...45

56 Dispenser Plate Dispenser-to-Tub Hose Door Assembly LP QP WP Door Bezel L Q W Door Glass P Door Handle Door Hinge Door Hinge Assembly Door Latch/Switch Assembly , 25 Door Locked Label , 47, 49 Door Seal and Hose Assembly , 25, 27 Door Seal Clamp P... 23, 25 Door Switch , 25 Door Switch Bracket Drain Hose Drain Hose Elbow Drain Pump Kit 888P Drive Belt P Driven Pulley Dual Coin Harness P Dual Overlay E Electronic Coin Drop Assembly P Electronic Coin Drop Kit CK Expansion Clip Extension Spring , 25 F Fill Hose Kit 28330P...29 Filter Screen F Front Overlay Front Panel LP QP WP...25 Front Panel Assembly LP QP WP...23 Fuse F , 11 G Gasket Grommet Ground Clip H Hardware Kit 838P Harness Harness Assembly P...51 Harness Strap , 43 Hinge Hinge Plate Hold-Down Clip Hose Clamp F , , 25, 27, , 29 Hose Clip , 11, N/A items do not appear in index

57 Hose Mounting Plate I Inlet Screen F Inner Basket Assembly P Inner Basket Kit P Inner Door Bezel Insert Instruction Label , 17, 19, 21 K Key L Lead-In Cord Leveling Leg Leveling Leg Spacer Lid Assembly P P Light Lock Cam Lock Kit 27260P... 5 Locking Catch , 25 M Mixing Valve P Mixing Valve Plate Motor Assembly P Motor Brush Kit 738P Motor Control Assembly P... 9, 11 Motor Mount Rod Mounting Tool Kit CK Multiplier Assembly N/A items do not appear in index N Network Board Assembly P...11 Network Cable Wire Harness Assembly Network Wire Harness Assembly Nozzle Cap Nut , , , 33 O Opto Coupler P...13 O-Ring Outer Tub Assembly P...31 Out-of-Balance Switch Assembly Overlay Oversudsing Label , , , 49 P Panel Locator , 17, 19, 21, 23, 25, 39 PC Board Standoff Pop Rivet , 33 Power Supply

58 Pressure Bulb Pressure Switch P... 9, 11 Programming Card P Pump Bracket Pump Housing Pump Housing Assembly Pump Mount Pump Mount Bracket Pump Shield Pump-to-Dispenser Hose Assembly Pump-to-Elbow Hose R Ratchet Extension Tool 310P Rear Panel Rear Service Panel Rivet Rubber Foot S Screw M , 41 M M , 17, 19, 21, 23, 25, , 9, 11, , 11, 23, 25, 29, 31, 35, 37, , 11, 13, 17, 19, , , 25, , Screw Label Sealant 27615P...37 Security Cabinet Front Assembly W LP...17, WP...17, L Q WP LP QP WP...13 Shipping Bracket Shipping Bracket Label Shipping Cord and Brace Assembly P...41 Shipping Materials Kit 728P Side Panel Kit LP QP WP...39 Single Overlay Snap Bushing M , , 11 Standpipe Strap Strain Relief Switch , 11 Switch Mounting Bracket N/A items do not appear in index T Tension Rod Assembly Top and Gusset Assembly LP QP WP...7 Top Mounting Bracket Transformer P P P...35 Trunnion Shaft and Hardware Kit P...33 Tub Front Assembly

59 Tub Front Seal P... 31, 33 Tub Shock Absorber Kit P Tubing Tub-to-Pump Hose V Valve Kit P Valve-to-Dispenser Inlet Hose , 29 W Warning Label , 41, 47, , , 49 Washer M , 41 M M M M , Wire Clamp Ring , 25 Wire Clip , 43 Wire Guard P Wire Harness Assembly P Wire Tie , 43 Wire, 12 Gauge Wire, 18 Gauge Wrapper and Channel Assembly LP... 13, 17, 19, QP... 13, 17, 19, WP... 13, 17, 19, 21 N/A items do not appear in index

60 Notes