Drying Tumblers Stack 30 Pound (300 Liter) Capacity

Transcription

1 HIGH TEMP MED TEMP START LOW TEMP 25 C NO HEAT SELECT TEMP INSERT COIN PUSH START SELECT TEMP INSERT COIN PUSH START HIGH TEMP MED TEMP START LOW TEMP 25 C NO HEAT Drying Tumblers Stack 30 Pound (300 Liter) Capacity Refer to Page 3 for Model Numbers Parts T464P_ Part No R6 December 2006

2

3 Table of Contents Title Page Parts Ordering Information... 2 Serial Plate Location... 2 Model Identification... 3 Electronic Coin Drop... 4 Card Reader Control Components... 6 Electromechanical Coin Drop Components... 8 Manual Dual Timer Control NetMaster Card Reader NetMaster Coin Drop NetMaster Network Interface Board NetMaster Network Board Upper Front Panel Components Lower Front Panel Components Upper Cylinder Support Components Lower Cylinder Support Components Lint Drawer Components Door and Hinge Components Cylinder, Trunnion and Bearing Cylinder Channel Components Drive Motor Components Drive Motors Fan and Exhaust Components Fan Motors Gas Burner Housing Gas Burner Components Gas Valve and Piping Gas Valve Assembly Burner Orifices Electric Heater Components Steam Heater Components Rear Control Box - Gas Non-CE Models (Drawing 1 of 2) Rear Control Box - Gas Non-CE Models (Drawing 2 of 2) Rear Control Box - Steam Non-CE Models Rear Control Box - Electric Non-CE Models Rear Control Box - Gas CE Models Rear Control Box - Steam CE Models Rear Control Box - Electric CE Models Through Serial No Rear Control Box - Electric CE Models Starting Serial No Parts Index Copyright 2006, Alliance Laundry Systems LLC All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed written consent of the publisher Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

4 AMPLFIEDRER If literature or replacement parts are required, contact the source from whom the machine was purchased or contact Alliance Laundry Systems at (920) for the name and address of the nearest authorized parts distributor. For technical assistance, call (920) Parts Ordering Information When calling or writing about your product, be sure to mention model and serial numbers. Model and serial numbers are located on serial plate(s) as shown. Serial Plate Location MODEL NO: SERIAL NO: V-/ HERTZ/ PHASE ANS CLOTHES DRYER. VOL II TESTED FOR NATURAL & LIQUID PETROLEUM GASSES CGA 72 AMPS, WIRES + GROUND TOTAL kw, MOTOR kw REQ'D CIRCUIT BREAKER: AMPS FAN "WC STATIC PRESSURE EQUIPPED FOR: GAS@ "WC MANIFOLD PRESS. "WC. MIN SUPPLY MAX SUPPLY PRESSURE: PRESSURE: INPUT: BTU/cu.ft. "WC. MADE IN U.S.A./FABRIQUE AU ETATS UNIS/FABRICADO EN LOS ESTADOS UNIDOS TMB1961P_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

5 Model Identification Information in this manual is applicable to these tumbler models: DC0300DEL DC0300DFG DC0300DRG DC0300DSL DT0300DEL DT0300DFG DT0300DRG DT0300DSH DT0300DSL JA0300DRG JC0300DEL JC0300DFG JC0300DRG JC0300DSH JC0300DSL JT0300DEL JT0300DFG JT0300DRG JT0300DSH JT0300DSL LT0300DRG NT0300DRG PC0300DEL PC0300DFG PC0300DRG PC0300DSL PT0300DEL PT0300DFG PT0300DRG SA0300DRG SC0300DEL SC0300DFG SC0300DRG SC0300DSH SC0300DSL ST0300DEL ST0300DFG ST0300DRG ST0300DSH ST0300DSL Control Suffixes (10th and 11th characters): CD - rotary coin drop MT - manual timer NY - NetMaster prep for card CX - prep for coin OM - OPL micro ZC - NetMaster coin - network ready CY - prep for card NC - NetMaster coin ZR - NetMaster card - network ready EC - electronic coin NR - NetMaster card ZX - NetMaster prep for coin - network ready EX - electronic coin ready NX - NetMaster prep for coin ZY - NetMaster prep for card - network ready EY - electronic card ready Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

6 HIGH TEMP MED TEMP 25 C LOW TEMP NO HEAT Electronic Coin Drop START TMB2069P_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

7 Electronic Coin Drop REF PART NO. DESCRIPTION COMMENTS NA Multiplier Harness Assembly EDC; Dual drop NA CK090 Coin Drop Kit Converts single U.S. $.25 drops to dual drops NA Multiplier Assembly Dual drop NA M4691P3 Electronic Control Kit ST models NA M4692P3 Electronic Control Kit SA and SC models NA M4721P3 Electronic Control Kit JT models NA M4722P3 Electronic Control Kit JA and JC models Overlay Text; ST models; Single Overlay Text with infrared; JT models; Single Overlay Icon; SC models; Single Overlay Infrared; Icon; JC models; Single Overlay Text non-infrared; JT models; Single Overlay Upper; P models; Single Overlay Lower; P models; Single Overlay Upper; P models; Single Overlay Upper; P models; Dual Overlay Lower; P models; Single Overlay Lower; P models; Dual P Dual Overlay Kit Text; SC and ST models P Dual Overlay Kit Icon; SC and ST models P Dual Overlay Kit Text; JC and JT models P Dual Overlay Kit Icon; JC and JT models; Dual Control Door Assembly SC and ST models; Includes studs Control Door Assembly JC and JT models; Includes studs Latch Mounting Bracket Screw Control Door Latch 6 M414049P Control Kit Includes tape; 24 Volt P Coin Drop Assembly Token; Coin Drop Assembly Token; P Coin Drop Assembly Canada; $ P Coin Drop Assembly Canada; $.25 and Coin Drop Assembly Australia; $.20 and P Coin Drop U.S.; $.25; Single P Coin Drop U.S.; $.25 and 1.00; Dual Coin Drop Assembly Japan; 100 and 500 yen Coin Drop Assembly Japan; 100 yen Coin Drop Assembly Korea; 100 and 500 won Coin Drop Assembly New Zealand; $.20 and P Coin Drop Token; Coin Drop Assembly Taiwan; 10NT; Dual drop not available Coin Drop Assembly Israel; Shekel Coin Drop Assembly 5 and 10 Krone Nut Pushbutton Switch Audit Switch Bracket Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

8 HIGH TEMP MED TEMP LOW TEMP INSERT CARD HERE Card Reader Control Components START CardMate System NO HEAT T429P_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

9 Card Reader Control Components REF PART NO. DESCRIPTION COMMENTS NA Card Reader Harness Assembly Non-networked NA Card Reader Network Harness Assembly Overlay ST models Overlay JT models Control Door Assembly ST models; Includes studs Control Door Assembly JT models; Includes studs Latch Mounting Bracket Screw Control Door Latch 6 M414049P Control Kit 7 M Card Reader Mounting Bracket P Card Reader Nut Chassis Mounting Bracket Screw Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

10 PUSH TO START Electromechanical Coin Drop Components HIGH LOW TEMPERATURE TMB1990P_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

11 Electromechanical Coin Drop Components REF PART NO. DESCRIPTION COMMENTS NA Timer Motor CD control suffix; 24 Volt/60 Hertz NA Timer Motor CD control suffix; 24 Volt/50 Hertz NA M4693P3 Coin Meter Control Kit S models NA M4723P3 Coin Meter Control Kit J models Mounting Bracket Models through Serial No M Screw 3 M Relay P Thermostat Module Circuit Board Support 4 required for models through Serial No ; 8 required for models starting Serial No M Screw Ground 7 M Washer Nut 9 N/A Coin Meter 24 Volt; Australia; $ P Coin Meter 24 Volt; Australia; $ P Coin Meter 24 Volt/60 Hertz; U.S.; $ P Coin Meter 24 Volt/60 Hertz; Standard token; P Coin Meter 24 Volt/60 Hertz; Standard token; P Coin Meter 24 Volt/50 Hertz; U.S.; $ Coin Meter 24 Volt; South Africa;.20 9 M Coin Meter 24 Volt/50 Hertz; Standard token; M Coin Meter 24 Volt/50 Hertz; Standard token; Coin Meter 24 Volt; Euro; Coin Meter 24 Volt; Euro; Rotary Drop Shroud Temperature Knob S models Temperature Knob J models Control Door Assembly S models; Includes studs Control Door Assembly J models; Includes studs Indicator Light Start Switch Overlay JT models Overlay JC models; Icon Overlay S models Latch Mounting Bracket Mounting Bracket Models starting Serial No P Timer Control Assembly Models starting Serial No Control Door Latch Potentiometer Mounting Bracket P Potentiometer Temperature switch; Includes nuts N/A = Part no longer available Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

12 HEAT COOL HIGH Manual Dual Timer Control PUSH TO START 0 DOWN LOW TMB1991P_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

13 Manual Dual Timer Control REF PART NO. DESCRIPTION COMMENTS NA M4694P3 Manual Timer Control Kit SC and ST models NA M4724P3 Manual Timer Control Kit JC and JT models Mounting Bracket Models through Serial No Latch Mounting Bracket Nut Control Door Latch 5 M412080P Timer Heat; 50 Hertz; 60 minute; 24 Volt P Timer Heat; 60 Hertz; 60 minute; 24 Volt Potentiometer Mounting Bracket P Potentiometer Temperature switch; Includes nuts P Thermostat Module Circuit Board Support 4 required for models through Serial No ; 8 required for models starting Serial No P Timer Control Assembly Mounting Bracket Models starting Serial No M Relay 2 required per control 13 M Screw 14 M Screw Ground 15 M412079P Timer Cooling; 50 Hertz; 15 minute; 24 Volt P Timer Cooling; 60 Hertz; 15 minute; 24 Volt Temperature Knob JC and JT models Temperature Knob SC and ST models 17 N/A Control Door Assembly SC and ST models; Includes studs Control Door Assembly JC and JT models; Includes studs Overlay JT models Overlay ST models Overlay Upper; P models 18 N/A Overlay Lower; P models 18 N/A Overlay SC models; Icon Overlay JC models; Icon Start Switch Timer Knob SC and ST models 20 M Knob JC and JT models Indicator Light 22 M Screw N/A = Part no longer available Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

14 NetMaster Card Reader TMB368P_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

15 NetMaster Card Reader REF PART NO. DESCRIPTION COMMENTS NA Card Reader Harness Assembly Non-networked NA Card Reader Network Harness Assembly Overlay Card reader installed Overlay Card reader ready Control Door Assembly Control Plate Assembly Card ready; ST models Control Plate Assembly Card ready; JT models Latch Mounting Bracket Screw Control Door Latch P Control Kit P Card Reader and Bracket Assembly Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

16 25 C NetMaster Coin Drop TMB371P_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

17 NetMaster Coin Drop REF PART NO. DESCRIPTION COMMENTS NA P Opto Coupler Overlay ST models; Single drop Overlay JT models; Single drop Overlay JT models; Dual drop Overlay ST models; Dual drop Control Door Assembly ST models Control Door Assembly JT models Latch Mounting Bracket Screw Control Door Latch P Control Kit P Coin Drop Assembly Token; Coin Drop Assembly Token; P Coin Drop Assembly Canada; $ P Coin Drop Assembly Canada; $.25 and Coin Drop Assembly Australia; $.20 and P Coin Drop U.S.; $.25; Single P Coin Drop U.S;. $.25 and 1.00; Dual Coin Drop Assembly Japan; 100 and 500 yen Coin Drop Assembly Japan; 100 yen Coin Drop Assembly Korea; 100 and 500 won Coin Drop Assembly New Zealand; $.20 and P Coin Drop Token; N/A Coin Drop Assembly Dual; Taiwan Coin Drop Assembly Taiwan; 10NT Coin Drop Assembly Israel; Shekel Coin Drop Assembly 5 and 10 Krone Nut Pushbutton Switch Audit Switch Bracket N/A = Part no longer available Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

18 NetMaster Network Interface Board H UPPER/SINGLE LOWER H TMB1993P_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

19 NetMaster Network Interface Board REF PART NO. DESCRIPTION COMMENTS NA Communication Harness Assembly Communication Board PC Board Standoff 4 required Communication Board Bracket Communication Connector Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

20 1 2 3 SELECT TEMP INSERT COIN PUSH START SELECT TEMP INSERT COIN PUSH START NetMaster Network Board TMB1992P_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

21 NetMaster Network Board REF PART NO. DESCRIPTION COMMENTS NA Network Wire Harness Assembly P Network Board Assembly Control Housing Cover Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

22 1 2 3 SELECT TEMP INSERT COIN PUSH START SELECT TEMP INSERT COIN PUSH START Upper Front Panel Components TMB1994P_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

23 Upper Front Panel Components REF PART NO. DESCRIPTION COMMENTS NA Emergency Stop Switch Harness DC, JC, PC and SC models with MT control suffix Assembly NA P Front Panel Filler NA M Shadow Box Clip NA Pushbutton JC and SC models with MT control suffix; If replacing this part, also order Contact Block and Contact Block NA M Emergency Stop Label JC and SC models with MT control suffix NA Contact Block JC and SC models with MT control suffix *P Upper Front Panel Assembly JT and ST models; Includes items 2 and P Upper Front Panel Assembly Stainless steel; JT and ST models; Includes items 2 and * Upper Front Panel Assembly JC and SC models; Includes items 2 and P Upper Front Panel Assembly JC and SC models; Includes items 2 and 3 2 M Door Latch 3 M Pop Rivet Screw JC and SC models 5 F Washer JC and SC models Door Switch Bracket JC and SC models Nut JC and SC models Door Switch JC and SC models 9 M Screw JC and SC models Control Housing Control Trim Right; S models Control Trim Left and right; J models Overlay S models Overlay P models Control Trim Left; S models Control Trim Center; S models Pushbutton Switch 16 M Screw Key Refer to note; RL P Lock, Key and Nut Kit Refer to note; RL Screw NOTE: Locks with key codes H2133, H2141 are no longer available. When replacing these items, order both lock and key. * Add Letter To Designate Color. B - Battina Green H - Harvest Gold K - Red L - Almond P - Turquoise V - Orange W - White X - Electric Blue Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

24 1 2 3 SELECT TEMP INSERT COIN PUSH START SELECT TEMP INSERT COIN PUSH START Lower Front Panel Components TMB1994P_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

25 Lower Front Panel Components REF PART NO. DESCRIPTION COMMENTS NA P Front Panel Filler NA Screw Mounted vertically to secure top of lower front panel Screw 2 M Door Latch 3 M Pop Rivet Door Switch Bracket JC and SC models Nut JC and SC models Door Switch JC and SC models 7 M Screw JC and SC models 8 F Washer JC and SC models Screw JC and SC models *P Lower Front Panel Assembly JT and ST coin models; Includes items 2 and P Lower Front Panel Assembly Stainless steel; JT and ST coin models; Includes items 2 and *P Lower Front Panel Assembly JT and ST OPL models; Includes items 2 and P Lower Front Panel Assembly Stainless steel; JT and ST OPL models; Includes items 2 and *P Lower Front Panel Assembly JC and SC coin models; Includes items 2 and Lower Front Panel Assembly Stainless steel; JC and SC coin models; Includes items 2 and *P Lower Front Panel Assembly JC and SC OPL models; Includes items 2 and Lower Front Panel Assembly Stainless steel; JC and SC OPL models; Includes items 2 and Pop Rivet Pushbutton Switch Kickplate S models Kickplate J models 14 M Screw Coin Vault Trim Gray; J models Coin Vault Trim Black; S models 15 N/A Coin Vault Trim White; P models * Add Letter To Designate Color. B - Battina Green H - Harvest Gold K - Red L - Almond P - Turquoise V - Orange W - White X - Electric Blue N/A = Part no longer available Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

26 Upper Cylinder Support Components TMB2204P_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

27 Upper Cylinder Support Components REF PART NO. DESCRIPTION COMMENTS NA Coin Vault Switch Harness Assembly EDC; Coin NA Pop Rivet 31 per side panel Partition Baffle Upper left Partition Baffle Upper left; Models starting Serial No Thermal Shield Discontinued after Serial No Baffle Gasket inches Partition Baffle Upper right Partition Baffle Upper right; Models starting Serial No Coin Vault Assembly *P Side Panel P Rear Panel Gas models Rear Panel Electric or steam models Center Cylinder Seal Assembly Expansion Clip Lint Drawer Switch Partition Baffle Lower right Partition Baffle Lower right; Models starting Serial No Nut Baffle Gasket 8.75 inches Baffle Gasket Models starting Serial No Nut Roller Shaft Roller Shaft Models starting Serial No Retaining Ring P Roller Bearing Assembly Roller Support Bracket Roller Support Bracket Models starting Serial No Partition Baffle Lower left Partition Baffle Lower left; Models starting Serial No * Add Letter To Designate Color. B - Battina Green H - Harvest Gold K - Red L - Almond P - Turquoise V - Orange W - White X - Electric Blue Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

28 Lower Cylinder Support Components T435PZ3B_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

29 Lower Cylinder Support Components REF PART NO. DESCRIPTION COMMENTS NA Coin Vault Switch Harness Assembly EDC; Coin NA Pop Rivet 13 per coin vault NA Pop Rivet 31 per side panel NA Coin Chute Assembly NA Clip Center seal Baffle Gasket inches Partition Baffle Upper left Partition Baffle Upper left; Models starting Serial No Baffle Gasket 8.75 inches Baffle Gasket Models starting Serial No Thermal Shield Partition Baffle Lower left Partition Baffle Lower left; Models starting Serial No Nut Partition Baffle Upper right Partition Baffle Upper right; Models starting Serial No F Coin Box Includes lock and key Coin Vault Assembly Cabinet Strap Center Cylinder Seal Assembly Center *P Side Panel Leveling Leg Nut Lint Drawer Switch Partition Baffle Lower right Partition Baffle Lower right; Models starting Serial No Expansion Clip P Roller Bearing Assembly Retaining Ring Roller Shaft Roller Shaft Models starting Serial No Roller Support Bracket Roller Support Bracket Models starting Serial No * Add Letter To Designate Color. B - Battina Green H - Harvest Gold K - Red L - Almond P - Turquoise V - Orange W - White X - Electric Blue Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

30 1 2 3 SELECT INSERT PUSH TEMP COIN START SELECT INSERT PUSH TEMP COIN START Lint Drawer Components TMB1995P_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

31 Lint Drawer Components REF PART NO. DESCRIPTION COMMENTS Lint Screen Assembly Nut Lint Screen Bracket Overlay ST models; Lower lint drawer Overlay JT models; Lower lint drawer Overlay JC models; Lower lint drawer Overlay SC models; Lower lint drawer P Lint Drawer Gasket Screw Overlay ST models; Upper lint drawer Overlay JT models; Upper lint drawer Overlay SC models; Upper lint drawer Overlay JC models; Upper lint drawer Key RL001; For use on top access panel only; Refer to note Key RL002; For use on top access panel and lint drawer; Refer to note P Lock, Key and Nut Kit RL001 key code; For use on top access panel only; Refer to note P Lock, Key and Nut Kit RL002 key code; For use on top access panel and lint drawer; Includes spring clip; Refer to note Lint Screen Panel Assembly J models; Includes studs Lint Screen Panel Assembly S models; Includes studs Lint Drawer Handle Plate Lint Frame Gasket NOTE: Locks with key codes H2133, H2141 are no longer available. When replacing these items, order both lock and key Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

32 Door and Hinge Components TMB1996P_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

33 Door and Hinge Components REF PART NO. DESCRIPTION COMMENTS NA P Replacement Door Handle Kit J models Door Assembly S models Door Assembly J models Door Assembly P models Door Ring Gasket 3 M Nut For door strike; Mounts between door strike screw and door handle Nut * Door Hinge Door Hinge Stainless steel Screw 7 M Screw 8 M4771P3 Door Hinge Cam Assembly Kit Door Hinge Lug Assembly Screw Pop Rivet P Door Glass Seal Kit P Door Glass J models 13 M400784P Door Glass S models P Door Switch Actuator Kit Door Handle S models 15 M Door Handle P models Screw Use with Door Handle 16 M Screw Use with Door Handle 16 M Screw Use with M Door Handle 17 M Screw * Add Letter To Designate Color. B - Battina Green H - Harvest Gold K - Red L - Almond P - Turquoise V - Orange W - White X - Electric Blue Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

34 Cylinder, Trunnion and Bearing T390PZ3C_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

35 Cylinder, Trunnion and Bearing REF PART NO. DESCRIPTION COMMENTS NA Rear Cylinder Seal Support NA Pop Rivet 10 required; For cylinder seal support NA 263P4 Cylinder Guide Tool End Cap Cylinder baffle P Cylinder Kit Galvanized P Cylinder Kit Stainless steel; Includes channel; Perforated rib; Models starting Serial No P Cylinder Kit Galvanized; Models starting Serial No P Cylinder Kit Stainless steel; Models starting Serial No Screw P Rear Cylinder Seal Use Adhesive P Trunnion and Seal Kit Felt Seal All models except RG models; Not used on models starting Serial No Cylinder Bearing Stud Plate Assembly Support Bearing Rear Cylinder Bearing Housing 10 M Washer 11 M Nut 12 M Nut 13 M Nut Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

36 Cylinder Channel Components Models Starting Serial No TMB1670B_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

37 Cylinder Channel Components REF PART NO. DESCRIPTION COMMENTS NA M4762P3 Cylinder Channel Kit Screw 10 required Rear Cylinder Channel Plate P Trunnion and Seal Kit Rear Cylinder Channel Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

38 Drive Motor Components T522P_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

39 Drive Motor Components REF PART NO. DESCRIPTION COMMENTS NA Motor Capacitor For a 20 Amp tumbler with P Drive Motor NA Motor Capacitor For a 20 Amp tumbler with P Drive Motor NA Idler Lock Bracket NA Idler Spring Tab P Belt Motor Pulley 50 Hertz Motor Pulley 60 Hertz Bolt Drive Access Cover Nut 6 M Nut Motor Mount Bracket Motor Channel Nut Cylinder Idler Bracket Washer Drum Idler Spring Washer 14 M Screw Screw P Idler Wheel Assembly Cylinder Idler Arm Nut Idler Assembly Service Kit Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

40 Drive Motors T522PA_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

41 Drive Motors REF PART NO. DESCRIPTION COMMENTS P Drive Motor Gas and steam models with: 100 Volt/50 or 60 Hertz/1 Phase, 120 Volt/60 Hertz/1 Phase, 120, 208 or 240 Volt/60 Hertz/1 Phase*; Electric models with: Volt/60 Hertz/1 or 3 Phase, 200 Volt/50 Hertz/1 or 3 Phase, 240 Volt/60 Hertz/1 or 3 Phase P Drive Motor Gas and steam models with: 200 Volt/50 Hertz/3 Phase, Volt/50 Hertz/3 Phase, 240 Volt/60 Hertz/3 Phase, 380 Volt/50 Hertz/3 Phase, Volt/60 Hertz/3 Phase; Electric models with: 380 Volt/50 Hertz/3 Phase, Volt/50 Hertz/3 Phase, Volt/60 Hertz/3 Phase P Drive Motor Kit Gas and steam models with: Volt/50 Hertz/1 Phase; Electric models with: Volt/50 Hertz/1 or 3 Phase P Drive Motor Kit Volt/60 Hertz/1 Phase; Low Amp * NOTE: Models starting Serial No Amp motor Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

42 Fan and Exhaust Components TMB2068P_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

43 Fan and Exhaust Components REF PART NO. DESCRIPTION COMMENTS NA Exhaust Damper Models through Serial No NA Exhaust Thimble 6 inch NA Rear Stabilizer Bracket NA Leveling Leg NA Nut NA Motor Capacitor For a 20 Amp tumbler with P Motor Key Screw Thermistor Cover 4 M Thermistor 5 M Manual Reset Thermostat JA and SA models 5 M Limit Thermostat All other models Blower Motor Mounting Plate P Blower Assembly 8 M Nut 9 M Nut Blower Housing Blower Inlet Cone Screw Blower Housing Scroll Washer Blower Housing Cover Assembly Duct Cover Exhaust Duct Assembly Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

44 Fan Motors TMB2068PA_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

45 Fan Motors REF PART NO. DESCRIPTION COMMENTS P Blower Motor Gas and steam models with: 100 Volt/50 or 60 Hertz/1 Phase, 120 Volt/60 Hertz/1 Phase; Electric models with: Volt/60 Hertz/1 or 3 Phase, 200 Volt/50 Hertz/1 or 3 Phase, 240 Volt/60 Hertz/1 or 3 Phase P Blower Motor Gas and steam models with: 200 Volt/50 Hertz/3 Phase, Volt/50 Hertz/3 Phase, 230 Volt/50 Hertz/3 Phase, 240 Volt/60 Hertz/3 Phase, 380 Volt/50 Hertz/3 Phase, Volt/60 Hertz/3 Phase; Electric models with: 380 Volt/50 Hertz/3 Phase, Volt/50 Hertz/3 Phase, Volt/60 Hertz/3 Phase P Blower Motor Kit Gas and steam models with: Volt/50 Hertz/1 Phase; Electric models with: Volt/50 Hertz/1 or 3 Phase P Blower Motor Kit Gas and steam models with: 120, 208 or 240 Volt/60 Hertz/1 Phase* * NOTE: Models starting Serial No Amp motor Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

46 Gas Burner Housing T465P_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

47 Gas Burner Housing REF PART NO. DESCRIPTION COMMENTS 1 M4747P3 Valve Bracket and Cover Kit Upper; FG models through Serial No Gas Valve Cover Lower; FG models through Serial No M4746P3 Valve Bracket and Cover Kit RG models starting Serial No Screw 3 N/A Stove Top and Sides Burner Grill Stove Back N/A = Part no longer available Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

48 Gas Burner Components TMB1998P_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

49 Gas Burner Components REF PART NO. DESCRIPTION COMMENTS NA M Gas Valve Harness Assembly NA M4707P3 L.P. Conversion Kit Models DT0300DFG, JT0300DFG, PT0300DFG and ST0300DFG; 0-2,000 feet; Contains parts to convert both gas valves; For models with 176,000 Btu input order 2 of M4729P3 Down Rated Burner Kit in addition to the M4707P3 L.P. Conversion Kit. For altitudes higher than 2,000 feet refer to Installation Manual for proper orifices. NA P Airflow Switch Kit Includes items 2-7 NA M4733P3 N.G. Valve Conversion Kit FG models; Original burner is replaced by M4729P3 Down Rated Burner Kit on FG models Screw 2 M Screw Airflow Switch Plate Airflow Switch Bracket 5 M Nut Airflow Switch Vane Airflow Switch Gas Burner RG models starting Serial No ; Downrated FG models Screw P Spark Electrode 11 M Screw Manual Reset Thermostat JA and SA models 12 M Limit Thermostat All other models Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

50 Gas Valve and Piping TMB1999P_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

51 Gas Valve and Piping REF PART NO. DESCRIPTION COMMENTS NA M Gas Valve Harness Assembly NA Elbow 90 degree; Lower unit NA O-Ring Spud adapter to valve NA M4733P3 N.G. Valve Conversion Kit Regulated NA M4734P3 L.P. Valve Conversion Kit Unregulated 1 M Gas Shut-Off Valve Upper unit 2 F Nipple 3 H Union Upper unit Pipe Nipple 9.5; Upper unit Tee Upper unit Gas Connector Assembly Lower to upper gas valve; Models through Serial No Gas Line Assembly Models starting Serial No Adapter BPT to NPT; 2 required Screw Screw Screw Spud Adapter Gas Valve Coil 24 Volt P N.G. Valve P L.P. Valve Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

52 Gas Valve Assembly Starting Serial No TMB2027P_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

53 Gas Valve Assembly REF PART NO. DESCRIPTION COMMENTS Pipe Pipe Tee Orifice Keeper Bracket Orifice Holder Bracket Tailpiece Orifice Adapter 7 M Nut Pop Rivet 9 M Snap Bushing Screw Rear Valve Cover 12 M414445P N.G. Gas Valve 12 M414446P L.P. Gas Valve Tube Forward Valve Cover Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

54 Burner Orifices FG and RG Models TMB1999PA_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

55 Burner Orifices REF PART NO. DESCRIPTION COMMENTS Burner Orifice Liquid Petroleum Gas (L.P.); FG models; 0-2,000 feet; 7/64 (2.8 mm) 1 M Burner Orifice L.P.; FG models; 2,001-4,000 feet; Drill no. 36 (2.7 mm) 1 M Burner Orifice L.P.; FG models; 4,001-6,000 feet; Drill no. 37 (2.6 mm) 1 M Burner Orifice L.P.; FG models; 6,001-8,000 feet; Drill no. 38 (2.6 mm) 1 M Burner Orifice L.P.; FG models; 8,001-10,000 feet; Drill no. 40 (2.5 mm) 1 M Burner Orifice Natural Gas (N.G.); FG models; 0-2,000 feet; Drill no. 15 (4.6 mm) 1 M Burner Orifice N.G.; FG models; 2,001-4,000 feet; Drill no. 16 (4.5 mm) 1 M Burner Orifice N.G.; FG models; 4,001-6,000 feet; Drill no. 17 (4.4 mm) 1 M Burner Orifice N.G.; FG models; 6,001-8,000 feet; Drill no. 19 (4.2 mm) 1 M Burner Orifice N.G.; FG models; 8,001-10,000 feet; Drill no. 20 (4.1 mm) 1 M Burner Orifice L.P.; RG models; 0-2,000 feet; Drill no. 40 (2.5 mm) 1 M Burner Orifice L.P.; RG models; 2,001-6,000 feet; Drill no. 42 (2.4 mm) 1 M Burner Orifice L.P.; RG models; 6,001-8,000 feet; Drill no. 43 (2.3 mm) 1 M Burner Orifice L.P.; RG models; 8,001-10,000 feet; Drill no. 44 (2.2 mm) 1 M Burner Orifice N.G.; RG models; 0-2,000 feet; Drill no. 20 (4.1 mm) 1 M Burner Orifice N.G.; RG models; 2,001-4,000 feet; Drill no. 22 (4.0 mm) 1 M Burner Orifice N.G.; RG models; 4,001-6,000 feet; Drill no. 24 (3.9 mm) 1 M Burner Orifice N.G.; RG models; 6,001-8,000 feet; Drill no. 26 (3.7 mm) 1 M Burner Orifice N.G.; RG models; 8,001-10,000 feet; Drill no. 28 (3.6 mm) Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

56 Electric Heater Components T443P_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

57 Electric Heater Components REF PART NO. DESCRIPTION COMMENTS Screw 2 M Limit Thermostat Stove Grill P Heater Element 7 kw; 208 Volt P Heater Element 7 kw; Volt P Heater Element 7 kw; 230, 240, 415 or 480 Volt 5 M Jumper Strip 6 Q6163 Nut Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

58 Steam Heater Components TMB2205P_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

59 Steam Heater Components REF PART NO. DESCRIPTION COMMENTS NA M Limit Thermostat P Steam Coil 2 row; SL models P Steam Coil 4 row; SH models Air Filter P Steam Valve 60 Hertz P Steam Valve 50 Hertz P Solenoid Valve DIN Connector Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

60 Rear Control Box - Gas Non-CE Models (Drawing 1 of 2) TMB2369P_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

61 Rear Control Box - Gas Non-CE Models (Drawing 1 of 2) REF PART NO. DESCRIPTION COMMENTS NA M Jumper Harness Assembly 120 Volt/50 or 60 Hertz/1 Phase; OM and RM control suffixes NA M Jumper Harness Assembly 100 Volt/50 or 60 Hertz/1 Phase NA M Jumper Configuration Assembly 480 Volt/60 Hertz/3 Phase NA M Jumper Harness Assembly 415 Volt/50 Hertz/3 Phase NA M Jumper Harness Assembly 380 Volt/50 Hertz/3 Phase NA M Jumper Harness Assembly 208 Volt/60 Hertz/1 or 3 Phase NA P High Limit Harness NA Main Harness Assembly NC, NR, NX, NY, ZC, ZR, ZX and ZY control suffixes NA Main Remote Interface Harness Assembly NA Jumper Calibration Assembly NC, NR, NX, NY, ZC, ZR, ZX and ZY control suffixes NA Ignition Control Harness Assembly DT, JT, LT, NT, PT and ST models NA P Ignition Control Harness JA and SA models NA Junction Box Harness Assembly NA Control Panel Harness Assembly NC, NR, NX, NY, ZC, ZR, ZX and ZY control suffixes NA Control Panel Harness Assembly MT control suffix NA Control Panel Harness Assembly JA and SA models with NC, NR, NX, NY, ZC, ZR, ZX and ZY control suffixes NA P Control Wire Harness Assembly EDC NA P Control Panel Harness Assembly CD control suffix NA Jumper Bypass Assembly MT and OM control suffixes NA M Pushbutton Switch JA and SA models 1 M414312P Transformer 120 Volt/60 Hertz/1 Phase; NC, NR, NX, NY, ZC, ZR, ZX and ZY control suffixes 1 M414230P Transformer 120 Volt/60 Hertz/1 Phase; All other control suffixes 1 M414228P Transformer Volt/60 Hertz/3 Phase; Volt/50 Hertz/1 or 3 Phase 1 M414229P Transformer Volt/50 or 60 Hertz/3 Phase 2 M Screw Terminal Block 4 M Insulator Expansion Clip 6 M Fuse 2 Amp; 100 Volt 6 M Fuse 2 Amp; 120 to 240 Volt 6 M Fuse 0.5 Amp; 380 Volt and higher 6 M Fuse 3.5 Amp; All other voltages P Fuse Receptacle 7 M413544P Fuse Holder 380 Volt and higher Fuse Bracket Low voltage Fuse Bracket 380 Volt and higher Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

62 Rear Control Box - Gas Non-CE Models (Drawing 2 of 2) TMB2369PA_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

63 Rear Control Box - Gas Non-CE Models (Drawing 2 of 2) REF PART NO. DESCRIPTION COMMENTS Pop Rivet Screw Fuse Cover Screw Junction Box Cover 6 M Screw Screw For relay Screw For contactor P Relay 1 Phase 8 M413614P Fan Contactor 3 Phase 9 M413433P Ignition Control JA and SA models P Ignition Control 50 Hertz; All other models High Voltage Lead Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

64 Rear Control Box - Steam Non-CE Models TMB2370P_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

65 Rear Control Box - Steam Non-CE Models REF PART NO. DESCRIPTION COMMENTS NA M Jumper Harness Assembly 120 Volt/50 or 60 Hertz/1 Phase; OM and RM control suffixes NA M Jumper Harness Assembly 100 Volt/50 or 60 Hertz/1 Phase NA M Jumper Configuration Assembly 480 Volt/60 Hertz/3 Phase NA M Jumper Harness Assembly 415 Volt/50 Hertz/3 Phase NA M Jumper Harness Assembly 380 Volt/50 Hertz/3 Phase NA P High Limit Harness NA Main Harness Assembly NC, NR, NX, NY, ZC, ZR, ZX and ZY control suffixes NA Main Remote Interface Harness Assembly NA Steam Jumper Assembly NA Jumper Calibration Assembly NC, NR, NX, NY, ZC, ZR, ZX and ZY control suffixes NA Junction Box Harness Assembly NA Control Panel Harness Assembly NC, NR, NX, NY, ZC, ZR, ZX and ZY control suffixes NA Control Panel Harness Assembly MT control suffix NA P Control Wire Harness Assembly EDC NA P Control Panel Harness Assembly CD control suffix NA Jumper Bypass Assembly MT and OM control suffixes 1 M414312P Transformer 120 Volt/60 Hertz/1 Phase; NC, NR, NX, NY, ZC, ZR, ZX and ZY control suffixes 1 M414230P Transformer 120 Volt/60 Hertz/1 Phase; All other control suffixes 1 M414228P Transformer Volt/60 Hertz/3 Phase, Volt/50 Hertz/1 or 3 Phase 1 M414229P Transformer Volt/50 or 60 Hertz/3 Phase 2 M Screw Terminal Block 4 M Insulator Expansion Clip 6 M Fuse 2 Amp; 100 Volt 6 M Fuse 2 Amp; 120 to 240 Volt 6 M Fuse 0.5 Amp; 380 Volt and higher 6 M Fuse 3.5 Amp; All other voltages P Fuse Receptacle 7 M413544P Fuse Holder 380 Volt and higher Fuse Bracket Low voltage Fuse Bracket 380 Volt and higher P Relay 1 Phase 9 M413614P Fan Contactor 3 Phase Screw For relay Screw For contactor 11 M Screw Junction Box Cover Screw Fuse Cover Screw Pop Rivet Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

66 Rear Control Box - Electric Non-CE Models TMB2371P_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

67 Rear Control Box - Electric Non-CE Models REF PART NO. DESCRIPTION COMMENTS NA M Jumper Configuration Assembly 480 Volt/60 Hertz/3 Phase NA M Jumper Harness Assembly 415 Volt/50 Hertz/3 Phase NA M Jumper Harness Assembly 380 Volt/50 Hertz/3 Phase NA M Jumper Harness Assembly 208 Volt/60 Hertz/1 or 3 Phase NA P High Limit Harness NA Main Harness Assembly NC, NR, NX, NY, ZC, ZR, ZX and ZY control suffixes NA Main Remote Interface Harness Assembly NA M Jumper Harness Assembly Volt NA Jumper Assembly 11 inches; 1 Phase; 8 gauge NA M Jumper Cable Assembly 7.5 inches; Volt; 8 gauge; 2 required for 1 Phase; 3 required for 3 Phase NA Jumper Assembly 10 inches; Volt; 8 gauge; 2 required for 1 Phase; 3 required for 3 Phase NA Jumper Calibration Assembly NC, NR, NX, NY, ZC, ZR, ZX and ZY control suffixes NA Junction Box Harness Assembly NA Junction Box Harness Assembly NA Control Panel Harness Assembly NC, NR, NX, NY, ZC, ZR, ZX and ZY control suffixes NA Control Panel Harness Assembly MT control suffix NA P Control Wire Harness Assembly EDC NA P Control Panel Harness Assembly CD control suffix NA Jumper Bypass Assembly MT and OM control suffixes 1 M414228P Transformer Volt/60 Hertz/3 Phase, Volt/50 Hertz/1 or 3 Phase 1 M414229P Transformer Volt/50 or 60 Hertz/3 Phase Screw 3 M Terminal Block 4 M413616P Electric Contactor Kit 2 required for Volt models; 1 required for Volt models Expansion Clip 6 M Fuse 2 Amp; 240 Volt and lower 6 M Fuse 3.5 Amp; All other voltages 6 M Fuse 0.5 Amp; 380 Volt and higher P Fuse Receptacle 7 M413544P Fuse Holder 380 Volt and higher Fuse Bracket Low voltage Fuse Bracket 380 Volt and higher 9 M413614P Fan Contactor Screw For contactor Junction Box Cover Screw Fuse Cover Pop Rivet Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

68 Rear Control Box - Gas CE Models TMB2001P_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

69 Rear Control Box - Gas CE Models REF PART NO. DESCRIPTION COMMENTS NA M Jumper Harness Assembly 120 Volt/50 or 60 Hertz/1 Phase; OM and RM control suffixes NA M Jumper Harness Assembly 100 Volt/50 or 60 Hertz/1 Phase NA M Jumper Configuration Assembly 480 Volt/60 Hertz/3 Phase NA M Jumper Harness Assembly 415 Volt/50 Hertz/3 Phase NA M Jumper Harness Assembly 380 Volt/50 Hertz/3 Phase NA M Jumper Harness Assembly 208 Volt/60 Hertz/1 or 3 Phase NA M Jumper Configuration Assembly 230 Volt/50 Hertz/1 Phase or 230, 240 Volt/50 or 60 Hertz/3 Phase NA P High Limit Harness NA Main Harness Assembly NC, NR, NX, NY, ZC, ZR, ZX and ZY control suffixes NA Main Remote Interface Harness Assembly NA Jumper Disconnect Assembly NA Jumper Calibration Assembly NC, NR, NX, NY, ZC, ZR, ZX and ZY control suffixes NA P Ignition Control Harness NA Junction Box Harness Assembly NA Control Panel Harness Assembly NC, NR, NX, NY, ZC, ZR, ZX and ZY control suffixes NA Control Panel Harness Assembly MT control suffix NA P Control Panel Harness Assembly EDC NA Control Panel Harness Assembly NC, NR, NX, NY, ZC, ZR, ZX and ZY control suffixes NA P Control Wire Harness Assembly EDC NA P Control Panel Harness Assembly CD control suffix NA Junction Box Cover NA High Voltage Lead NA M Pushbutton Switch Fuse Bracket 240 Volt and lower Fuse Bracket 380 Volt and higher P Fuse Holder Kit 2 M413544P Fuse Holder 380 Volt and higher 3 M Fuse 0.5 Amp; 2 required; 380 Volt and higher 3 M Fuse 2 Amp; 2 required; 240 Volt and lower 3 M Fuse 4 Amp; 1 required; All other voltages 4 M413614P Fan Contactor Screw 6 M414228P Transformer 230 Volt 6 M414229P Transformer Volt/50 or 60 Hertz/3 Phase 7 M Extension Handle 8 M Handle End Stop 3 required End Cover 1 required Terminal Block 3 required per machine 12 M Mounting Switch Base 13 M Door Interlock 20 Amp 14 M Finger Guard 15 N/A Din Rail 101 mm Screw 17 M413433P Ignition Control 18 M Screw N/A = Part no longer available Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

70 Rear Control Box - Steam CE Models TMB2002P_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

71 Rear Control Box - Steam CE Models REF PART NO. DESCRIPTION COMMENTS NA M Jumper Harness Assembly 120 Volt/50 or 60 Hertz/1 Phase; OM and RM control suffixes NA M Jumper Harness Assembly 100 Volt/50 or 60 Hertz/1 Phase NA M Jumper Configuration Assembly 480 Volt/60 Hertz/3 Phase NA M Jumper Harness Assembly 415 Volt/50 Hertz/3 Phase NA M Jumper Harness Assembly 380 Volt/50 Hertz/3 Phase NA M Jumper Configuration Assembly 230 Volt/50 Hertz/1 Phase or 230, 240 Volt/50 or 60 Hertz/3 Phase NA P High Limit Harness NA Main Harness Assembly NC, NR, NX, NY, ZC, ZR, ZX and ZY control suffixes NA Main Remote Interface Harness Assembly NA Steam Jumper Assembly NA Jumper Disconnect Assembly NA Jumper Calibration Assembly NC, NR, NX, NY, ZC, ZR, ZX and ZY control suffixes NA Junction Box Harness Assembly NA Control Panel Harness Assembly NC, NR, NX, NY, ZC, ZR, ZX and ZY control suffixes NA Control Panel Harness Assembly NC, NR, NX, NY, ZC, ZR, ZX and ZY control suffixes NA Control Panel Harness Assembly MT control suffix NA P Control Panel Harness Assembly EDC NA Control Panel Harness Assembly NC, NR, NX, NY, ZC, ZR, ZX and ZY control suffixes NA P Control Wire Harness Assembly EDC NA P Control Panel Harness Assembly CD control suffix NA Junction Box Cover Fuse Bracket 240 Volt and lower Fuse Bracket 380 Volt and higher P Fuse Holder Kit 2 M413544P Fuse Holder 380 Volt and higher 3 M Fuse 0.5 Amp; 2 required; 380 Volt and higher 3 M Fuse 2 Amp; 2 required; 240 Volt and lower 3 M Fuse 4 Amp; 1 required; All other voltages 4 M413614P Fan Contactor Screw 6 M414228P Transformer 230 Volt 6 M414229P Transformer Volt/50 or 60 Hertz/3 Phase 7 M Extension Handle 8 M Handle End Stop 3 required End Cover 1 required Terminal Block 3 required per machine 12 M Mounting Switch Base 13 M Door Interlock 20 Amp 14 M Finger Guard 15 N/A Din Rail 101 mm Screw N/A = Part no longer available Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

72 Rear Control Box - Electric CE Models Through Serial No TMB2003P_ Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT

73 Rear Control Box - Electric CE Models Through Serial No REF PART NO. DESCRIPTION COMMENTS NA M Jumper Configuration Assembly 480 Volt/60 Hertz/3 Phase NA M Jumper Harness Assembly 415 Volt/50 Hertz/3 Phase NA M Jumper Harness Assembly 380 Volt/50 Hertz/3 Phase NA M Jumper Harness Assembly 208 Volt/60 Hertz/1 or 3 Phase NA M Jumper Configuration Assembly 230, 240 Volt/50 or 60 Hertz/3 Phase NA P High Limit Harness NA Main Harness Assembly NC, NR, NX, NY, ZC, ZR, ZX and ZY control suffixes NA Main Remote Interface Harness Assembly NA M Jumper Harness Assembly Volt NA Jumper Assembly 3 Phase; 6 gauge NA Jumper Calibration Assembly NC, NR, NX, NY, ZC, ZR, ZX and ZY control suffixes NA Junction Box Harness Assembly NA Junction Box Harness Assembly NA Control Panel Harness Assembly NC, NR, NX, NY, ZC, ZR, ZX and ZY control suffixes NA Control Panel Harness Assembly MT control suffix NA P Control Panel Harness Assembly EDC NA Control Panel Harness Assembly NC, NR, NX, NY, ZC, ZR, ZX and ZY control suffixes NA P Control Wire Harness Assembly EDC NA P Control Panel Harness Assembly CD control suffix NA Junction Box Cover NA N/A Din Rail For circuit breaker; 51 mm NA M Din Rail For terminal blocks; 89 mm Fuse Bracket P Fuse Holder Kit 250 Volt 2 M413544P Fuse Holder 600 Volt 3 M Fuse 0.5 Amp; 600 Volt 3 M Fuse 4 Amp; 250 Volt 4 M414229P Transformer Screw 6 M Buss Bar Assembly 9 position 7 M Circuit Breaker 8 Amp 8 M Terminal Block 3 Pole; 2 required on Volt models Handle 10 M Disconnect Switch Gasket 11 M Extension Handle 12 M Door Interlock 13 M Mounting Switch Base 14 M413616P Electric Contactor Kit Heater 15 M413614P Fan Contactor Screw N/A = Part no longer available Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT