Washer-Extractor. Parts. Pocket Hardmount. Refer to Page 3 for Model Numbers. UniLinc Models. M30 Models PHM1419C_F

Transcription

1 Washer-Extractor Pocket Hardmount Refer to Page 3 for Model Numbers Parts UniLinc Models M30 Models PHM1419C_F Part No. F R14 June 2018

2

3 Table of Contents Title Page Parts Ordering Information... 2 Serial Plate Location... 2 Model Identification... 3 Pocket Hardmount Washer-Extractor Product Overview - Model UW125TV... 4 Pocket Hardmount Washer-Extractor Product Overview - UWL125, UWN125 and UWU125 Models... 6 Control Module (Drawing 1 of 3)... 8 Control Module (Drawing 2 of 3) Control Module (Drawing 3 of 3) AC Drive Box (Drawing 1 of 2) AC Drive Box (Drawing 2 of 2) Balance Switch and Rotation Sensor Panels Drive Box and Water Supply Box - Models Through 10/3/ Drive Box and Water Supply Box - Models Starting 10/4/ Door - Models Through 10/3/ Spray Tube Assembly - Models Through 10/3/ Door and Spray Tube Assembly - Models Starting 10/4/ Door Lock Basket, Shell and Frame (Drawing 1 of 2) Basket, Shell and Frame (Drawing 2 of 2) Supply Dispenser Water Supply Valve and Hoses to Supply Dispenser - Models Through 10/3/ Water Supply Valve and Hoses to Supply Dispenser - Models Starting 10/4/ Spray Plumbing Assembly - Models Through 10/3/ Fill Plumbing Assemblies - Models Starting 10/4/ Fill Plumbing Assembly - Models Through 10/3/ Spray Plumbing Assembly - Models Starting 10/4/ Drain Valve and Plumbing - Models Through 10/3/ Drain Valve and Plumbing - Models Starting 10/4/ Motor, Pulley and Bearings Steam Heat Option - Models Through 10/3/ Steam Heat Option - Models Starting 10/4/ Electric Heat Option Special Tools Parts Index Copyright 2018, Alliance Laundry Systems LLC All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed written consent of the publisher. F

4 If literature or replacement parts are required, contact the source from whom the machine was purchased or contact Alliance Laundry Systems at (920) for the name and address of the nearest authorized parts distributor. Parts Ordering Information For technical assistance, call the number listed below: (920) Ripon, Wisconsin When calling or writing about your product, be sure to mention model and serial numbers. Model and serial numbers are located on serial plate(s) as shown. Serial Plate Location PHM3110P_F F

5 Model Identification Information in this manual is applicable to these washer-extractor models: UW125TV UWL125K1M UWL125T3V UWN125K1M UWN125K1V UWN125T3V UWU125K1M UWU125T3V F

6 < < < < Pocket Hardmount Washer-Extractor Product Overview - Model UW125TV UW60AVXU /3 S N/A N/A 0.0 Drawings: ETL Listed Conforms To ANSI/UL Std. 1206, 3rd Ed Certified To CAN/CSA Std. C22.2 No WASH ADD BLEACH RINSE NORMAL HOT LIGHT SOIL HOT PERM PRESS HOT VISA TM WARM 95C 60C 95C 60C 5 6 SPIN DOOR START HEAVY SOIL HOT UNIFORMS HOT 40C 40C STAINED DELICATE 30C HOT COLD A-Control B-Control (Domestic) B-Control (International) Mechanical Timer WE-6 Control S-Computer V-Computer UniLinc Control PHM2979P_F F

7 Pocket Hardmount Washer-Extractor Product Overview - Model UW125TV REF PART NO. DESCRIPTION COMMENTS 1 - Product Family UW 2 - Capacity (Pounds) Control A (A-Control) B (B-Control) M (Mechanical Timer) P (WE-6 Control) S (S-Computer) V (V-Computer) T (UniLinc Control) 4 - Speed 2 (2-Speed) 3 (3-Speed) 4 (4-Speed) V (Variable-Speed) 5 - Voltage F ( /60/3/3) N ( /50-60/3/3) O ( /60/3/3) P ( /60-60/3/3) Q ( / /50/60/3ph) R ( / /50/60/3ph) X ( / /50/60/1-3) Y ( /60/1/2) 6 - OEM U (Standard Specs) 7 - Design Series 1-8 F

8 Pocket Hardmount Washer-Extractor Product Overview - UWL125, UWN125 and UWU125 Models Model No. Serial No. Voltage Schematic : Supply Water: UWN060T3VXU Hz Phase 3 30 amps 60 LB 27 KG Number of wires : FLA : amps Circuit Breaker Size : Max. Load : psi, BAR M30 Control UniLinc Control PHM3063P_F F

9 Pocket Hardmount Washer-Extractor Product Overview - UWL125, UWN125 and UWU125 Models REF PART NO. DESCRIPTION COMMENTS 1 - Product Family UW 2 - Market Approvals N (Domestic ETL) L (International ETL) U (International CE) 3 - Capacity (Dry Weight in Pounds) Control K (M30 Control) T (UniLinc Control) 5 - Spray/Dispenser Feature 1 (No spray but with dispenser) 3 (With spray and dispenser) 6 - Speed 2 (2-Speed) L (Low-Speed - 100/60) M (Medium-Speed - 180/120/60) V (Variable-Speed - 300/240/180/120/60) 7 - Voltage O (208/ /60/3/3) X ( /220/240/50/60/1/3) Q ( / /50/60/3) R ( / /50/60/3) 8 - OEM U 9 - Design Series Heat Feature 0 (Prep for steam) D (Direct steam) E (Electric heat) P (Prep for electric and steam heat) 11 - Features and Options F

10 H3 6 H1 Control Module (Drawing 1 of 3) WARNING AVERTISSEMENT Electrical shock hazard can cause death or serious injury. To reduce the risk of electric shock, disconnect all electric power to appliance and accessories before servicing. Des d charges lectriques peuvent entra ner des blessures graves, voire mortelles. Pour r duire le risque de choc lectrique, d brancher toute alimentation lectrique de l'appareil et des accessoires avante chaque proc dure d'entretien. WARNING AVERTISSEMENT Electrical shock hazard can cause death or serious injury. To reduce the risk of electric shock, disconnect all electric power to appliance and accessories before servicing. Des d charges lectriques peuvent entra ner des blessures graves, voire mortelles. Pour r duire le risque de choc lectrique, d brancher toute alimentation lectrique de l'appareil et des accessoires avante chaque proc dure d'entretien. UPPER/SINGLE LOWER PHM3115P_F F

11 Control Module (Drawing 1 of 3) REF PART NO. DESCRIPTION COMMENTS 1 D Electrical Shock Label 2 F External Supply Connection Decal 3 F Screw 4 F Control Box Rear Panel 5 F External Supply Label Models UWL125K1M, UWN125K1M, UWN125K1V and UWU125K1M 6 F External Supply Connection Decal Models UW125TV, UWL125T3V, UWN125T3V and UWU125T3V 7 F Control Box Top Panel 8 F Warning Label 9 F Control Box Contactor Panel 10 F External Supply Box Models through 10/3/10 11 F Pop Rivet Models through 10/3/10 12 F External Supply Box Cover Models through 10/3/10 13 F Trim 14 F P Contact Block Switch Includes F Contact Switch and F Contact Base 14 F Contact Switch 14 F Contact Base 14 F Emergency Stop Harness PC Board Standoff Network models Network Board Assembly Network models 16 NK205 Network Retrofit Kit Includes item 28, Network Board Assembly, Communication Connector, Network Wire Harness Assembly, Communication Board, Screw, Communication Wiring Harness and Conversion Label 16 NK220 Network Controller Kit 16 NK301 Wireless Network Kit Includes Wireless Transceiver Assembly, Network Wire Harness Assembly, D Electronic Control Shield, Harness Strap, D Screw, F Screw and F43232 Nut 16 NK320 Ethernet Gateway Kit Used with NK301 Wireless Network Kit 16 NK330 USB Gateway Kit Used with NK301 Wireless Network Kit 17 F Control Module Decal Models UW125TV, UWL125T3V, UWN125T3V and UWU125T3V 17 F Overlay All other models 18 F Emergency Stop Pushbutton 19 F982P3 Control Kit Models UW125TV, UWL125T3V, UWN125T3V and UWU125T3V 19 F983P3 Control Kit All other models 20 F Control Board Bracket Nut 22 F Contact Switch 23 F Rocker Switch Dual steam and electric heat 24 F Steam-Electric Switch Label Dual steam and electric heat 25 F Supply Controls Bracket Model UW125TV; Models through 6/30/08 26 F Screw Model UW125TV; Models through 6/30/08 27 F Clean Filter Daily Decal 28 F Control Harness Tray Models through 10/3/10 28 F Control Harness Tray Models starting 10/4/10 29 F Harness Tray Cover Models through 10/3/10 29 F Harness Tray Cover Models starting 10/4/10 30 F Screw Screw Expansion Clip F

12 Control Module (Drawing 2 of 3) PHM3035P_F F

13 Control Module (Drawing 2 of 3) REF PART NO. DESCRIPTION COMMENTS NA F CFG Harness NA P Network Wire Harness Assembly NA F Output Auxiliary Power Harness NA F Power Harness Dual steam and electric heat NA F P Power Harness NA F P Drive Control Harness NA F P Interlock Switch Harness NA M Jumper Harness Assembly 208 Volt NA M Jumper Configuration Assembly 240 Volt 1 F Screw Model UW125TV 1 F Screw All other models 2 F980P3 Control Assembly Kit Fuse 5 Amp Fuse 2.5 Amp Expansion Clip 4 F Tubing 5 F Tee 6 F Tubing 7 F P Water Pressure Switch 8 F Connector 9 F Air Trap Hose 10 F Hose Clamp No P Transformer External supply transformer P Transformer Machine control step-down transformer Bushing 14 F P Output Assembly Male Tab Terminal Models through 10/3/10 16 M Snap Bushing Models through 10/3/10 17 F Screw Models through 10/3/10 18 F Nut Warning Label Shock/pinch 20 F Snap Bushing Models through 10/3/10 21 F Network Board Bracket 22 F Nut 23 F Muffin Fan 24 F Filter Retainer Guard Includes item F Screw 26 F Pop Rivet 27 F P Filter Network Board Assembly Network models 29 F Screw 30 F P Auxiliary Control Assembly Models UWL125K1M, UWN125K1M, UWN125K1V and UWU125K1M F

14 Control Module (Drawing 3 of 3) PHM3111P_F F

15 Control Module (Drawing 3 of 3) REF PART NO. DESCRIPTION COMMENTS 1 F Cap Plug Model UW125TV 1 F Plug All other models 2 F Plug Model UW125TV 2 M Plug All other models 3 M Snap Bushing Female Pin Terminal Screw 6 M Clip 7 F P External Supply Harness Models UW125TV, UWL125T3V, UWN125T3V and UWU125T3V 7 F P External Supply Harness All other models 8 F Screw F

16 AC Drive Box (Drawing 1 of 2) PE PHM3116P_F F

17 AC Drive Box (Drawing 1 of 2) REF PART NO. DESCRIPTION COMMENTS NA F Electric Heat Harness Left NA F Electric Heat Harness Middle NA F Electric Heat Harness Right NA F Logic Supply Power Harness NA F Output/Logic Harness NA F Main Power Harness NA F Electric Heat Coils Harness KM8A NA F Electric Heat Coils Harness KM8ABC 1 F Do Not Tamper Label Terminal Block Shield Terminal Block 4 M Insulator 5 F Ground Decal 6 F Ground Decal Wire Label P Power Distribution Block Cover Electric heat Screw Electric heat 10 M Terminal Block Electric heat 11 F AC Drive Q-voltage 11 F AC Drive R-voltage 11 F Drive Power Harness 11 F P Drive Control Harness 12 M Screw 13 F EMI Filter CE models; Q-voltage 13 F EMI Filter CE models; R-voltage 13 F EMI Filter Power Harness 14 F Drive Mounting Bracket Models starting 10/4/10; Replaces item F Drive Bracket Models starting 10/4/10 F

18 AC Drive Box (Drawing 2 of 2) PE PHM3116PA_F F

19 AC Drive Box (Drawing 2 of 2) REF PART NO. DESCRIPTION COMMENTS NA F Electric Heat Harness Left NA F Electric Heat Harness Middle NA F Electric Heat Harness Right NA F Logic Supply Power Harness NA F Output/Logic Harness NA F Main Power Harness NA F Electric Heat Coils Harness KM8A NA F Electric Heat Coils Harness KM8ABC 1 M Ground Lug Connector 2 F Screw 3 F Electric Shock Danger Label 4 F Screw 5 F Filter Retainer Guard Includes item 6 6 F P Filter 7 F Clean Filter Daily Decal 8 F Plug 9 F360157P Transformer R-voltage 10 M Screw 11 F DIN Rail Pop Rivet 13 F P Circuit Breaker R-voltage; Electric heat P Circuit Breaker R and Q-voltage; Electric heat 13 F Harness R and Q-voltage 13 F P Harness R and Q-voltage 13 F Step Down Power Harness R-voltage 14 M Screw Model UW125TV Screw All other models 15 F330188P Contactor NX208; R and Q-voltage; Electric heat 16 M Snap Bushing Model UW125TV 16 F Plug All other models 17 F Nut 18 F Muffin Fan 18 F Drive Fan Harness 19 F Hole Plug UWL, UWN and UWU models 20 F Trim Screw Male Tab Terminal 23 M Earth Terminal Sticker 24 F Use Copper Conductors Only Caution Label UWL, UWN and UWU models F

20 Balance Switch and Rotation Sensor PHM2906P_F F

21 Balance Switch and Rotation Sensor REF PART NO. DESCRIPTION COMMENTS 1 M Washer 2 F Nut 3 M Washer Nut Screw 6 F Balance Switch Bracket 7 F Door Switch 8 F Rotation Sensor Harness 9 F Rotation Sensor 10 F Rotation Sensor Bracket 11 F Screw F

22 Panels P U SH PHM3057P_F F

23 Panels REF PART NO. DESCRIPTION COMMENTS 1 F Nut 2 F Screw 3 F Side Panel Cover 4 F P Left Side Panel 5 M Rivet Panel Locator Expansion Clip Screw 9 M Washer Nut 11 F Upper Belt Guard Assembly 12 F Screw Model UW125TV 12 F Screw All other models 13 F Cover Decal Belt Edging Warning Label 15 D Electrical Shock Label Warning Label 17 F Belt Access Guard Panel Screw 19 F Mount on Concrete Warning Label 20 M Screw 21 F Right Side Panel 22 F Lower Belt Guard Assembly 23 F Nut 24 F Washer 25 F Screw 26 F Extrusion Insert Order 4 feet 27 F Rub Rail Screw 29 F Front Panel F

24 Drive Box and Water Supply Box - Models Through 10/3/10 P U SH PHM3088P_F F

25 Drive Box and Water Supply Box - Models Through 10/3/10 REF PART NO. DESCRIPTION COMMENTS Warning Label 2 D Electrical Shock Label 3 F Left Side Cover Model UW125TV 3 F Left Side Cover All other models 4 F Screw Model UW125TV 4 F Screw All other models Expansion Clip 6 F Partition 7 F Drive Box Bottom Model UW125TV 7 F Drive Box Bottom Panel All other models 8 F Rear Drive Box Panel Model UW125TV 8 F Drive Box Rear Panel All other models 9 F Top Center Panel Pop Rivet UWL, UWN and UWU models 11 F Support Bracket UWL, UWN and UWU models Nut Screw 14 F Water Line Caution Decal 15 F Cold Water Valve Decal 16 F Hot Water Valve Decal 17 F Rear Water Box Panel Model UW125TV 17 F Water Box Rear Panel All other models 18 F Support Bracket UWL, UWN and UWU models 19 F Hot Surface Warning Label 20 F Top Support Brace 21 F Right Side Cover Model UW125TV 21 F Right Side Cover All other models 22 F Warning Label 23 F Conversion Label VAC 23 F Conversion Label VAC 24 F Water Box Bottom Model UW125TV 24 F Water Box Bottom Panel All other models 25 F Front Box Panel Model UW125TV 25 F Front Bulkhead Panel All other models 26 F Trim 2 feet required F

26 Drive Box and Water Supply Box - Models Starting 10/4/10 P U SH PHM3127P_F F

27 Drive Box and Water Supply Box - Models Starting 10/4/10 REF PART NO. DESCRIPTION COMMENTS Expansion Clip 2 F Left Side Cover 3 F Screw 4 F Top Center Panel 5 F Drive Box Partition 6 F Drive Mounting Box 7 F Drive Box Rear Panel 8 F Electrical Access Panel 9 F Nut 10 F Conversion Label VAC 10 F Conversion Label VAC Warning Label 12 F Rear Center Panel 13 F Back Water Panel 14 F Right Side Cover 15 F Side Water Box Panel 16 F Front Bulkhead Panel 17 F Side Electrical Box Panel F

28 Door - Models Through 10/3/10 P U SH PHM2913PA_F F

29 Door - Models Through 10/3/10 REF PART NO. DESCRIPTION COMMENTS 1 F Retaining Ring 2 F Door Hinge Pin 3 F Door Butt Shim 4 F Hot Surface Warning Decal 5 F P Shell Front Kit Includes item 4 and F170120RP Shell Band Gasket 5 F Shell Front Assembly Includes items 3, 4, 7, 8, 21, 23-25, F Top Latch Bracket Casting, F Lower Door Latch Bracket Casting, F Door Handle Casting, F Lower Door Latch Casting and F Screw 6 F Screw 7 F Washer 8 F Nut 9 F Door Gasket 10 F Studded Door Assembly 11 F Push Handle Kit Includes item 13, F Magnet, F Nut, F Screw, F Washer, F Washer, F Door Push Brace and F Push Handle 12 F Pop Rivet 13 F Push Decal 14 F Door Glass Gasket 15 F290204P Door Glass Kit With hole; Models UW125TV, UWL125T3V, UWN125T3V and UWU125T3V 15 F290210P Glass Without hole; All other models 16 F Clockwise Spin Rotation Decal 17 F Door Glass Retainer 18 F Door Hinge 19 F Door Assembly With hole; Models UW125TV, UWL125T3V, UWN125T3V and UWU125T3V; Includes items 6-11, 13-15, 17, 25, F Clear Sealant, F Magnet, F Nut and F Screw 19 F Door Assembly Without hole; All other models; Includes items 6-11, 13-15, 17, 25, F Clear Sealant, F Magnet, F Nut and F Screw 20 F Washer 21 F Nut 22 F Screw 23 F Door Bumper Moulding 24 F Door Bumper Bushing 25 F Door Butt F

30 Spray Tube Assembly - Models Through 10/3/10 Models UW125TV, UWL125T3V, UWN125T3V and UWU125T3V P U SH PHM2913P_F F

31 Spray Tube Assembly - Models Through 10/3/10 REF PART NO. DESCRIPTION COMMENTS 1 F Spray Rinse Nozzle Kit 2 F Elbow 3 F No-Swivel Coupling 4 F Spray Rinse Hose Kit Includes items F O-Ring 6 F Swivel Coupling 7 F Ring Retainer 8 F602901P Spray Rinse Bracket Assembly Includes items 9 and 10 9 F Nut 10 F Screw 11 F Spray Rinse Strap 12 F Spray Pipe Assembly F

32 Door and Spray Tube Assembly - Models Starting 10/4/10 UWL, UWN and UWU Models P U SH PHM3136P_F F

33 Door and Spray Tube Assembly - Models Starting 10/4/10 REF PART NO. DESCRIPTION COMMENTS 1 F Door Spray Nozzle Assembly Models UWL125T3V, UWN125T3V and UWU125T3V 2 F Nut Models UWL125T3V, UWN125T3V and UWU125T3V 3 F Elbow Models UWL125T3V, UWN125T3V and UWU125T3V 4 F Spray Rinse Hose Assembly Includes items 5-8; Models UWL125T3V, UWN125T3V and UWU125T3V 5 F No-Swivel Coupling Models UWL125T3V, UWN125T3V and UWU125T3V 6 F O-Ring Models UWL125T3V, UWN125T3V and UWU125T3V 7 F Swivel Coupling Models UWL125T3V, UWN125T3V and UWU125T3V 8 F Ring Retainer Models UWL125T3V, UWN125T3V and UWU125T3V 9 F Spray Rinse Strap Models UWL125T3V, UWN125T3V and UWU125T3V 10 F Screw Models UWL125T3V, UWN125T3V and UWU125T3V 11 F Spray Pipe Assembly Models UWL125T3V, UWN125T3V and UWU125T3V 12 F602901P Spray Rinse Bracket Assembly Includes items 10 and 13; Models UWL125T3V, UWN125T3V and UWU125T3V 13 F Nut Models UWL125T3V, UWN125T3V and UWU125T3V 14 F P Door Hinge Strap Kit 15 F Door Hinge Pin 16 F Door Butt Shim 17 F Door Bumper Bushing 18 F Door Bumper Moulding 19 F Screw 20 F Nut 21 F Nut 22 F Spray Nozzle Gasket Models UWL125T3V, UWN125T3V and UWU125T3V 23 F Washer 24 F Screw 25 F Hot Surface Warning Decal 26 F P Shell Front Kit Includes item 25 and F170120RP Shell Band Gasket 26 F Shell Front Assembly Includes items 14, 16-18, 21, 23, 25, F Top Latch Bracket Casting, F Lower Door Latch Bracket Casting, F Door Handle Casting, F Lower Door Latch Casting and F Screw 27 F Door Gasket 28 F Studded Door Assembly 29 F Push Handle Kit Includes item 31, F Magnet, F Nut, F Screw, F Washer, F Washer, F Door Push Brace and F Door Push Handle 30 F Pop Rivet 31 F Push Decal 32 F Door Glass Gasket 33 F High Hole Glass Models UWL125T3V, UWN125T3V and UWU125T3V 33 F290210P Glass Without hole; All other models 34 F Door Assembly Models UWL125T3V, UWN125T3V and UWU125T3V; Includes items 20, 22-24, 27-29, 32 and F Door Assembly All other models; Without hole; Includes items 14, 20, 23, 24, 27-29, and F Door Glass Retainer F

34 Door Lock PHM3128P_F F

35 Door Lock REF PART NO. DESCRIPTION COMMENTS NA F Door Lock Harness Models UW125TV, UWL125T3V, UWN125T3V and UWU125T3V NA F P Interlock Switch Harness All other models 1 F Screw 2 F Washer 3 F Screw 4 F Extension Arm Weldment 5 F Screw 6 F Door Handle Casting 7 F150201P Top Latch Bracket Casting 8 F Door Latch Bracket Shim 9 F Washer 10 F Nut 11 F Nut 12 F Lower Door Latch Casting 13 F Nut 14 F Washer 15 F Extension Arm Tab 16 F Lower Door Latch Bracket Casting 17 F Screw 18 F Handle Spacer 19 F Magnet 20 F Door Switch 21 F Interlock Switch Spacer 22 F Nut 23 F Door Lock Cover 24 F P Reed Switch Assembly 25 F Screw 26 F Solenoid Mount Bracket 27 F Door Lock Solenoid Shim 28 F Door Lock Dielectric Shield 29 F300129P Door Lock Solenoid 30 F Screw 31 F Lock Bracket 32 F Screw 33 F Door Lock Mounting Block 34 F Pop Rivet 35 F Door Lock Assembly Includes items 9 and Nut F

36 Basket, Shell and Frame (Drawing 1 of 2) PHM3058P_F F

37 Basket, Shell and Frame (Drawing 1 of 2) REF PART NO. DESCRIPTION COMMENTS 1 F Shell Band Assembly Top 2 F Nut 3 F Washer 4 F Shell Gasket Shield 5 F Shell Band Fastener Kit Includes items 2, 3 and 6 6 F Screw 7 F Nut 8 F Washer 9 F602901P Spray Rinse Bracket Assembly 10 F Spray Rinse Strap 11 F Screw 12 F170120RP Shell Band Gasket Model UW125TV 12 F Shell Band Gasket All other models 13 F P Shell Front Weldment 13 F Shell Front Assembly Includes F Top Latch Bracket Casting, F Lower Door Latch Bracket Casting, F Door Handle Casting, F Lower Door Latch Casting, F Door Butt, F Retaining Ring, F Screw, F Screw, F Nut, F Nut, F Washer, F Door Bumper Bushing, F Screw, F Screw, F Nut, F Nut, F Washer, F Washer, F Washer, F Hot Surface Warning Decal, F Door Bumper Moulding, F Extension Arm Tab, F Door Hinge Pin, F Door Butt Shim, F Door Latch Bracket Shim and F Extension Arm Weldment 14 F Basket Assembly Screw F

38 Basket, Shell and Frame (Drawing 2 of 2) PHM3058PA_F F

39 Basket, Shell and Frame (Drawing 2 of 2) REF PART NO. DESCRIPTION COMMENTS 1 F Shell Weldment Model UW125TV; Standard and steam heat 1 F Shell Weldment Model UW125TV; Electric heat 1 F Shell Weldment UWL, UWN and UWU models; Standard and steam heat; Models through 10/3/10 1 F Shell Weldment UWL, UWN and UWU models; Standard; Models starting 10/4/10 1 F Shell Weldment UWL, UWN and UWU models; Steam heat; Models starting 10/4/10 2 F Plug 3 F Shell Reinforcement Plate Includes items 7 and 8 Assembly 4 F Face Seal Standard 4 F Face Seal Viton 5 F Slinger 6 F Seal Kit Standard; Includes items 4 and 5, F170120RP Shell Band Gasket and sealant 6 F Seal Kit Viton; Includes items 4 and 5, F170120RP Shell Band Gasket and sealant 7 F Scupper 8 F Pop Rivet 9 F Frame Weldment 10 M Washer Nut Warning Label Shock/pinch 13 F Tee Hose Clamp No F Hose Barb 16 F200107P Water Hose 17 F170400RP Trim 2 feet required 18 F Moving Parts Plug Warning Decal 19 F Drip Rail 20 F Washer 21 F Shell Adjusting Bracket Left Assembly 21 F Shell Adjusting Bracket Right Assembly 22 F Shell Bracket Support 23 F Nut 24 M Washer 25 M Washer Screw 27 F Washer 28 F Screw 29 F Washer F

40 Supply Dispenser PHM3239P_F F

41 Supply Dispenser REF PART NO. DESCRIPTION COMMENTS 1 F Screw 2 F Washer 3 F Dispenser Lid 4 F Plug Cap 5 F140340P Strain Relief Connector 6 F Strain Relief Adapter Kit Includes items 5 and 7 7 F O-Ring 8 F Hose Clamp No F Chemical Supply Hose Model UW125TV 9 F Chemical Supply Hose All other models 10 F Nut Loctite 262 required 11 F Washer 12 F Hot Water and Chemical Caution Decal 13 F Spin Warning Decal 14 F Dispenser Shroud Weldment 15 F170400RP Trim 16 F Chemical Supply Cup 32 ounce; 2 used 17 F Supply Dispenser Spacer 18 F Chemical Supply Cup 20 ounce; 3 used 19 F P Dispenser Assembly Includes items 3 and F Injection Nozzle 21 F O-Ring Nut 23 F Injection Nozzle Kit Includes items F

42 Water Supply Valve and Hoses to Supply Dispenser - Models Through 10/3/10 PHM3061P_F F

43 Water Supply Valve and Hoses to Supply Dispenser - Models Through 10/3/10 REF PART NO. DESCRIPTION COMMENTS 1 G582P3 Diaphragm and Guide Kit 2 F Strainer 3 N/A Flow Restrictor 8 liter 4 F381723P 4-Way Valve 220 Volt 4 F P Dispenser Valve Harness 5 F Screw 6 F Hose Connector 7 F Water Valve Assembly Decal Hose Clamp No. 6 9 F200110P Water Hose 10 F Y Connector N/A = Part no longer available F

44 Water Supply Valve and Hoses to Supply Dispenser - Models Starting 10/4/10 UWL, UWN and UWU Models PHM3117P_F F

45 Water Supply Valve and Hoses to Supply Dispenser - Models Starting 10/4/10 REF PART NO. DESCRIPTION COMMENTS 1 F Way Valve 240 Volt; Includes regulator 1 F Dispenser Valve Harness 2 G582P3 Diaphragm and Guide Kit 3 F Screw 4 F Valve Mounting Bracket Hose Clamp No. 6 6 F200110P Water Hose 7 F Y Connector F

46 AVERTISSEMENT Spray Plumbing Assembly - Models Through 10/3/10 Models UW125TV, UWL125T3V, UWN125T3V and UWU125T3V WARNING PHM3065P_F F

47 Spray Plumbing Assembly - Models Through 10/3/10 REF PART NO. DESCRIPTION COMMENTS NA F P Supply/Fill Module Harness NA F P Fill/Spray Valve Harness NA F P Coil 220 Volt; Use with F Valve NA F DIN Valve Adapter Kit Use with F Valve NA F P Valve Transition Kit Use with F Valve 1 F Screw 2 F Containment Device 3 F Hose Barb 4 F380800P Vacuum Breaker Valve Includes items 1, 2, 25 and 26 5 F Nipple 6 F Catch Basin 7 F Elbow 8 F Reducer Bushing 9 F200401P U-Bolt Clamp 10 F Nipple 11 F P Valve 220 Volt; Replaces F381703P Valve; Includes F P Coil 12 F Nipple 13 F Warning Label 14 F Coupling 15 F200104P Hose Order 3 feet 16 F Hose Adapter Standard thread; 1 1/2 inch 16 F Hose Adapter Standard thread; 3/4 inch 16 F Adapter Metric thread Washer 18 F Water Hose Standard thread 18 F Water Hose Metric thread 19 F Strainer Filter 20 F Cold Spray Plumbing Assembly Includes items 11, 12, 14 and F Hose Barb 22 F Hose Clamp No F Hose 24 F Street Elbow 25 F O-Ring 26 F Vacuum Breaker Cap 27 F Hot Spray Plumbing Assembly Includes items 3-8, 10-12, 14, 24, F Nipple and F Hose F

48 Fill Plumbing Assemblies - Models Starting 10/4/10 UWL, UWN and UWU Models PHM3139P_F F

49 Fill Plumbing Assemblies - Models Starting 10/4/10 REF PART NO. DESCRIPTION COMMENTS NA F Fill/Supply Harness NA F Fill Valve Harness 1 F Hose Hose Clamp No. 8 3 F Hose Barb 4 F P Valve 3/4 inch; Brass 4 F P Valve Transition Kit 5 C Nipple 1/2 inch; Brass 6 N/A Tee 7 F Coupling 3/4 inch 8 F Hose Barb 9 F Hose Clamp No F Hose 11 F Water Hose 12 F Fill Port Screw Screw Washer 16 F Hose Adapter Standard thread; 1 inch 16 F Adapter Metric thread 17 F Water Hose Standard thread 17 F Water Hose Metric thread 18 F Strainer Filter N/A = Part no longer available F

50 AVERTISSEMENT Fill Plumbing Assembly - Models Through 10/3/10 WARNING PHM3062P_F F

51 Fill Plumbing Assembly - Models Through 10/3/10 REF PART NO. DESCRIPTION COMMENTS NA F P Supply/Fill Module Harness Models UW125TV, UWL125T3V, UWN125T3V and UWU125T3V NA F P Fill Valve Harness All other models NA F P Fill/Supply Harness All other models NA F P Fill/Spray Valve Harness NA F P Water Valve Repair Kit Use with item 15 1 F Coupling 2 F Street Elbow 3 F Fill Plumbing Connection Assembly Includes items 1, 2 and 4 4 F Hose Barb 5 F Hose Clamp No F Hose 7 F Warning Label 8 F Hose Adapter Standard thread; 1 1/2 inch 8 F Hose Adapter Standard thread; 3/4 inch 8 F Adapter Metric thread Washer 10 F Water Hose Standard thread 10 F Water Hose Metric thread 11 F Strainer Filter 12 F Elbow 13 F Nipple 14 F200401P U-Bolt Clamp 15 F381733P Valve 16 F Cold Fill Plumbing Assembly Includes items 2, 4 and F Hose Barb 18 F Tee 19 F Nipple 20 F Gate Valve 21 F Water Hose 22 C Hose 23 F Hot Fill Plumbing Assembly Includes items 2, 4, 12, 13, 15 and F

52 Spray Plumbing Assembly - Models Starting 10/4/10 Models UWL125T3V, UWN125T3V and UWU125T3V PHM3122P_F F

53 Spray Plumbing Assembly - Models Starting 10/4/10 REF PART NO. DESCRIPTION COMMENTS NA F Fill/Supply Harness NA F Fill Valve Harness 1 F Hose Hose Clamp No. 8 3 F Hose Barb 4 F P Valve 3/4 inch; Brass 4 F P Valve Transition Kit 5 F Coupling 3/4 inch 6 F Manifold 7 F Fill Plumbing Assembly F

54 U SH Drain Valve and Plumbing - Models Through 10/3/10 P PHM2916P_F F

55 Drain Valve and Plumbing - Models Through 10/3/10 REF PART NO. DESCRIPTION COMMENTS 1 F Hose Clamp No F Overflow Hose 3 F Pipe 4 F Elbow 5 F Pipe 6 F Elbow 7 F Pipe 8 F Tee 9 F Pipe 10 F Drain Hose 11 F Hose Clamp No F Pipe 13 F Hose Barb 14 F Pipe 15 F Drain Valve Kit Includes item F P Drain Valve Harness Standard 15 F Drain Valve Harness Steam heat 15 F Dual Drain Harness 16 F Drain Hose 17 F Drain Valve Cover 18 F Drain Hose 19 F Drain Hose 20 F Pipe F

56 U SH Drain Valve and Plumbing - Models Starting 10/4/10 UWL, UWN and UWU Models P PHM3195P_F F

57 Drain Valve and Plumbing - Models Starting 10/4/10 REF PART NO. DESCRIPTION COMMENTS 1 F Hose Clamp No F Overflow Hose 3 F Pipe 4 F Molded Drain 5 F Drain Elbow Hose 6 F Drain Hose 7 F Hose Clamp No F Hose Barb 9 F Drain Hose 10 F Drain Valve Kit Includes item F P Drain Valve Harness Standard 10 F Drain Valve Harness Steam heat 10 F Dual Drain Harness 11 F Drain Hose 12 F Drain Valve Cover 13 F Drain Hose 14 F Pipe F

58 Motor, Pulley and Bearings PHM2909P_F F

59 Motor, Pulley and Bearings REF PART NO. DESCRIPTION COMMENTS NA F P Shaft Lift Tool Kit Used to reset bearings 1 F Belt BX110; 2 required 2 F280294P Basket Pulley Bushing Includes screws and key; 2-7/16 inch 3 F Pulley 2B305F 4 F Front Bearing Kit Includes F Slinger, F Washer, F Screw, F Pop Rivet, F Key, F Nut, F Washer, F Washer, F Nut, F Screw, F Bearing, F Clear Sealant, F170120RP Shell Band Gasket and F P Face Seal 5 F Rear Bearing Kit Includes F Bearing, F Screw, F Nut, F Washer and F Key 6 F Air Coupling 7 F Washer 8 F Grease Instruction Decal Lubrication 9 F Grease Fitting 9 F Manual Bearing Greasing Retrofit Kit Includes items 10 and 11, F Grease Manifold Bracket, F Lubrication Instruction Decal, F Grease Manifold, F Nut, F Washer, F Screw, F Screw and F Nut 10 J Connector 11 C000628P Tubing 12 F Cable Tie 6 inch 13 M Washer 14 F Washer 15 F Screw 16 N/A Motor Order F Motor Conversion Kit 16 F Motor Conversion Kit AC drive parameters must be compatible with the motor and motor pulley. Please request the AC drive parameter illustration for parameter verification when ordering a motor. 16 F Motor Models that have been retrofitted with F Motor Conversion Kit 16 F Motor Harness 17 F P Sheave Pulley 18 F Motor Bushing Includes screws and item 19; H - 1-3/8 19 F Key 20 M Washer 21 F Nut N/A = Part no longer available F

60 Steam Heat Option - Models Through 10/3/10 PHM2011K_F F

61 Steam Heat Option - Models Through 10/3/10 REF PART NO. DESCRIPTION COMMENTS 1 F200401P U-Bolt Clamp 2 F Plug 3 F Steam Filter 4 F Elbow 5 H Nipple 6 M Pipe Nipple 7 F DIN Valve Kit 3/4 inch; 220 Volt; F380984P Steam Valve Repair Kit 8 M Street Elbow 9 F Steam Hose 10 F Street Elbow 11 F Steam Injector Tube Assembly 12 F635754P Steam Kit Includes items F948P3 Steam Heat Kit Includes items 1-11 and F P Drain Valve Harness (steam heat) F

62 Steam Heat Option - Models Starting 10/4/10 PHM3148_F F

63 Steam Heat Option - Models Starting 10/4/10 REF PART NO. DESCRIPTION COMMENTS NA F P Coil 220 Volt; Use with F P Valve NA F DIN Valve Adapter Kit Use with F P Valve NA F P Valve Kit Use with F P Valve NA F945P3 Steam Heat Kit Includes items 2-11, 13 and F Drain Valve Harness, insulation and labels 1 F Shell Weldment 2 F Steam Injector Tube Assembly 3 F Street Elbow 4 F Steam Hose 5 F Coupling Models starting 1/4/11 6 F Nipple Models starting 1/4/11 7 F DIN Valve Adapter Kit 8 F P Valve 3/4 inch; Brass; 220 Volt; Replaces F Steam Valve; Includes F P Coil; For models that have been upgraded with F DIN Valve Kit 8 F DIN Valve Kit 220 Volt; Replaces F Steam Valve; Includes F P Valve, F DIN Valve Adapter Kit and F P Coil 9 F Coupling 10 F Plug 11 F Steam Filter Pipe Nipple Screw F

64 Electric Heat Option PHM3119P_F F

65 Electric Heat Option REF PART NO. DESCRIPTION COMMENTS NA F P Electric Heat Harness NA F Jumper Wire NA F P Drain Valve Harness 1 F360203P Heating Element 12 required 2 F Shell Weldment Electric heat 3 F Reducer Bushing 4 F Thermistor Sensor F

66 Special Tools PHM2988P_F F

67 Special Tools REF PART NO. DESCRIPTION COMMENTS NA F Mounting Bolt Kit Includes F Bolts, F Washers, F Washers and F Nuts NA F923P3 Wet-Clean Kit Model UW125TV NA 925P3 Wet-Clean Kit All other models NA F924P3 Reuse Kit NA USB IR Interface Kit NA F UniLinc PC and PDA Software CD UniLinc models NA F UniLinc PC and PDA Software CD UniLinc models; Programmer s version NA 1113P Concrete Hardware Kit 1 F Alignment Shaft Assembly 2 F Seal Alignment Tool Assembly 2 F Shaft Seal Alignment Fixture 3 N/A Bearing Removal Tool 4 F601862P Rebar Frame Template 5 F Grease Gun Kit Includes items 5 and 6 6 F210206P Bearing Grease 7 F210207P Grease Gun N/A = Part no longer available F

68 Notes 66 F

69 Parts Index A AC Drive F F Adapter F , 49 F Air Coupling F Air Trap Hose F Alignment Shaft Assembly F Auxiliary Control Assembly F P B Back Water Panel F Balance Switch Bracket F Basket Assembly F Basket Pulley Bushing F280294P Bearing Grease F210206P Belt F Belt Access Guard Panel F Belt Edging Warning Label Bushing C Cable Tie F Cap Plug F Catch Basin F CFG Harness F Chemical Supply Cup F F Chemical Supply Hose F F Circuit Breaker F P P Clean Filter Daily Decal F , 17 Clip M Clockwise Spin Rotation Decal F Coil F P...45, 61 Cold Fill Plumbing Assembly F Cold Spray Plumbing Assembly F Cold Water Valve Decal F Concrete Hardware Kit 1113P...65 Connector F J Contact Base F Contact Block Switch F P...9 Contact Switch F Contactor F330188P...17 Containment Device F Control Assembly Kit F980P Control Board Bracket F Control Box Contactor Panel F Control Box Rear Panel F Control Box Top Panel F Control Harness Tray F F Control Kit F982P3...9 F983P3...9 Control Module Decal F Conversion Label F , 25 F , 25 Coupling F F F F F , 51 Cover Decal F N/A items do not appear in index. F

70 D Diaphragm and Guide Kit G582P , 43 DIN Rail F DIN Valve Adapter Kit F , 61 DIN Valve Kit F , 61 Dispenser Assembly F P Dispenser Lid F Dispenser Shroud Weldment F Dispenser Valve Harness F P F Do Not Tamper Label F Door Assembly F F , 31 F Door Bumper Bushing F , 31 Door Bumper Moulding F , 31 Door Butt F Door Butt Shim F , 31 Door Gasket F , 31 Door Glass Gasket F , 31 Door Glass Kit F290204P Door Glass Retainer F , 31 Door Handle Casting F Door Hinge F Door Hinge Pin F , 31 Door Hinge Strap Kit F P Door Latch Bracket Shim F Door Lock Assembly F Door Lock Cover F Door Lock Dielectric Shield F Door Lock Harness F Door Lock Mounting Block F Door Lock Solenoid F300129P...33 Door Lock Solenoid Shim F Door Spray Nozzle Assembly F Door Switch F , 33 Drain Elbow Hose F Drain Hose F , 55 F , 55 F , 55 F , 55 Drain Valve Cover F , 55 Drain Valve Harness F P...53, 55 F P...63 F , 55 Drain Valve Kit F , 55 Drip Rail F Drive Box Bottom F Drive Box Bottom Panel F Drive Box Partition F Drive Box Rear Panel F F Drive Bracket F Drive Control Harness F P...11 F P...15 Drive Fan Harness F Drive Mounting Box F Drive Mounting Bracket F Drive Power Harness F Dual Drain Harness F , 55 E Earth Terminal Sticker M Elbow F F F , 31 F F F Electric Heat Coils Harness F , 17 N/A items do not appear in index. 68 F

71 F , 17 Electric Heat Harness F , 17 F , 17 F , 17 F P Electric Shock Danger Label F Electrical Access Panel F Electrical Shock Label D , 21, 23 Emergency Stop Harness F Emergency Stop Pushbutton F EMI Filter F F EMI Filter Power Harness F Ethernet Gateway Kit NK Expansion Clip , 11, 21, 23, 25 Extension Arm Tab F Extension Arm Weldment F External Supply Box F External Supply Box Cover F External Supply Connection Decal F F External Supply Harness F P F P External Supply Label F Extrusion Insert F Fill/Supply Harness F P...49 F , 51 Filter F P...11, 17 Filter Retainer Guard F , 17 Frame Weldment F Front Bearing Kit F Front Box Panel F Front Bulkhead Panel F F Front Panel F Fuse G Gate Valve F Glass F290210P...27, 31 Grease Fitting F Grease Gun F210207P...65 Grease Gun Kit F Grease Instruction Decal F Ground Decal F F Ground Lug Connector M F Face Seal F F Female Pin Terminal Fill Plumbing Assembly F Fill Plumbing Connection Assembly F Fill Port F Fill Valve Harness F P F F Fill/Spray Valve Harness F P... 45, 49 H Handle Spacer F Harness F F P...17 Harness Tray Cover F F Heating Element F360203P...63 High Hole Glass F Hole Plug F Hose C F200104P...45 F N/A items do not appear in index. F

72 F F F F Hose Adapter F , 49 F , 49 F Hose Barb F , 53, 55 F , 49 F , 49 F , 47, 51 Hose Clamp F , 55 F F , 55 F , 45, 47, , 41, 43, 47, 51 Hose Connector F Hot Fill Plumbing Assembly F Hot Spray Plumbing Assembly F Hot Surface Warning Decal F , 31 Hot Surface Warning Label F Hot Water and Chemical Caution Decal F Hot Water Valve Decal F I Injection Nozzle F Injection Nozzle Kit F Insulator M Interlock Switch Harness F P F P Interlock Switch Spacer F J Jumper Configuration Assembly M Jumper Harness Assembly M Jumper Wire F K Key F L Left Side Cover F F F Left Side Panel F P...21 Lock Bracket F Logic Supply Power Harness F , 17 Lower Belt Guard Assembly F Lower Door Latch Bracket Casting F Lower Door Latch Casting F M Magnet F Main Power Harness F , 17 Male Tab Terminal , 17 Manifold F Manual Bearing Greasing Retrofit Kit F Molded Drain F Motor F Motor Bushing F Motor Conversion Kit F Motor Harness F Mount on Concrete Warning Label F Mounting Bolt Kit F Moving Parts Plug Warning Decal F Muffin Fan F , 17 N Network Board Assembly , 11 Network Board Bracket F Network Controller Kit NK Network Retrofit Kit NK N/A items do not appear in index. 70 F

73 Network Wire Harness Assembly P Nipple C F F F F F F H No-Swivel Coupling F , 31 Nut F , 57 F F F F , 17, 33 F F , 25, 33 F , 31 F , 31, 35 F F F F , 31, , O O-Ring F F , 31 F F Output Assembly F P Output Auxiliary Power Harness F Output/Logic Harness F , 17 Overflow Hose F F Overlay F P Panel Locator Partition F PC Board Standoff Pipe F , 55 F F F F F , 55 F Pipe Nipple M Plug F F F F F F , 17 M Plug Cap F Pop Rivet F , 11, 27, 31, 33 F , 23 Power Distribution Block Cover P...15 Power Harness F P...11 F Pulley F Push Decal F , 31 Push Handle Kit F , 31 R Rear Bearing Kit F Rear Center Panel F Rear Drive Box Panel F Rear Water Box Panel F Rebar Frame Template F601862P...65 Reducer Bushing F F Reed Switch Assembly F P...33 Retaining Ring F Reuse Kit F924P Right Side Cover F F F Right Side Panel F Ring Retainer F , 31 N/A items do not appear in index. F

74 Rivet M Rocker Switch F Rotation Sensor F Rotation Sensor Bracket F Rotation Sensor Harness F Rub Rail F S Screw F , 31 F F F , 31 F F , 11, 17 F F F F F , 31, 33, 35, 39 F F , 33 F F , 41, 43 F , 33 F F F , 11, 21, 23 F F F , 21, 23, 25 M , 17, 21 M , 23, , , 37 Scupper F Seal Alignment Tool Assembly F Seal Kit F F Shaft Lift Tool Kit F P Shaft Seal Alignment Fixture F Sheave Pulley F P Shell Adjusting Bracket Assembly F F Shell Band Assembly F Shell Band Fastener Kit F Shell Band Gasket F170120RP...35 F Shell Bracket Support F Shell Front Assembly F , 31 F Shell Front Kit F P...27, 31 Shell Front Weldment F P...35 Shell Gasket Shield F Shell Reinforcement Plate Assembly F Shell Weldment F F F F F F , 63 Side Electrical Box Panel F Side Panel Cover F Side Water Box Panel F Slinger F Snap Bushing F M , 17 M Solenoid Mount Bracket F Spin Warning Decal F Spray Nozzle Gasket F Spray Pipe Assembly F , 31 Spray Rinse Bracket Assembly F602901P...29, 31, 35 Spray Rinse Hose Assembly F Spray Rinse Hose Kit F Spray Rinse Nozzle Kit F Spray Rinse Strap F , 31, 35 Steam Filter F , 61 Steam Heat Kit F945P N/A items do not appear in index. 72 F

75 F948P Steam Hose F , 61 Steam Injector Tube Assembly F , 61 Steam Kit F635754P Steam-Electric Switch Label F Step Down Power Harness F Strain Relief Adapter Kit F Strain Relief Connector F140340P Strainer F F , 47, 49 Street Elbow F , 61 F , 49 M Studded Door Assembly F , 31 Supply Controls Bracket F Supply Dispenser Spacer F Supply/Fill Module Harness F P... 45, 49 Support Bracket F F Swivel Coupling F , 31 T Tee F F F F Terminal Block M Terminal Block Shield Thermistor Sensor F Top Center Panel F F Top Latch Bracket Casting F150201P Top Support Brace F Transformer F360157P P Transformer Kit P Trim F170400RP...37, 39 F F F Tubing C000628P...57 F F N/A items do not appear in index. F U U-Bolt Clamp F200401P...45, 49, 59 UniLinc PC and PDA Software CD F F Upper Belt Guard Assembly F USB Gateway Kit NK USB IR Interface Kit Use Copper Conductors Only Caution Label F V Vacuum Breaker Cap F Vacuum Breaker Valve F380800P...45 Valve F381733P...49 F P...45 F P...61 F P...47, 51 Valve Kit F P...61 Valve Mounting Bracket F Valve Transition Kit F P...45 F P...47, 51 Valve, 4-Way F381723P...41 F W Warning Label F , 23, 45, , 21, 23, 25, 37 Washer F F F , 27, 31, 33 F F F F F