Washer-Extractor Pocket Hardmount

Transcription

1 Washer-Extractor Pocket Hardmount Refer to Page 3 for Model Numbers Parts UniLinc Models M30 Models PHM1419C_F Part No. F R6 January 2012

2

3 Table of Contents Title Page Parts Ordering Information... 2 Nameplate Location... 2 Model Identification... 3 Pocket Hardmount Washer-Extractor Product Overview - Model UW35TV... 4 Pocket Hardmount Washer-Extractor Product Overview - UWL035, UWN035 and UWU035 Models... 6 Control Module (Drawing 1 of 3)... 8 Control Module (Drawing 2 of 3) Control Module (Drawing 3 of 3) AC Drive Box (Drawing 1 of 2) AC Drive Box (Drawing 2 of 2) Balance Switch, Temperature Probe and Rotation Sensor Panels Drive Box and Water Supply Box - Models Through 10/3/ Drive Box and Water Supply Box - Models Starting 10/4/ Door and Spray Tube Assembly - Models Through 10/3/ Door and Spray Tube Assembly - Models Starting 10/4/ Door Lock Basket Shell and Frame - Models Through 10/3/ Shell and Frame - Models Starting 10/4/ Supply Dispenser Water Supply Valve and Hoses to Supply Dispenser - Models Through 10/3/ Water Supply Valve and Hoses to Supply Dispenser - Models Starting 10/4/ Spray and Fill Plumbing Assemblies - Models Through 10/3/ Fill Plumbing Assembly - Models Starting 10/4/ Fill Plumbing Assembly - Models Through 10/3/ Spray Plumbing Assembly - Models Starting 10/4/ Drain - Models Through 10/3/ Drain - Models Starting 10/4/ Motor, Pulley and Bearings (Drawing 1 of 2) Motor, Pulley and Bearings (Drawing 2 of 2) Electric Heat Option Steam Heat Option - Models Through 10/3/ Steam Heat Option - Models Starting 10/4/ Special Tools Parts Index Copyright 2012, Alliance Laundry Systems LLC All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed written consent of the publisher. F

4 If literature or replacement parts are required, contact the source from whom the machine was purchased or contact Alliance Laundry Systems at (920) for the name and address of the nearest authorized parts distributor. Parts Ordering Information For technical assistance, call either of the numbers listed below: (920) Ripon, Wisconsin Wevelgem, Belgium When calling or writing about your product, be sure to mention model and serial numbers. Model and serial numbers are located on nameplate(s) as shown. Nameplate Location PHM3110P_F F

5 Model Identification Information in this manual is applicable to these washer-extractor models: UW35TV UWL035K12 UWL035K1L UWL035K1M UWL035T3V UWN035K12 UWN035K1L UWN035K1M UWN035K1V UWN035T3V UWU035K12 UWU035K1L UWU035K1M UWU035T3V F

6 < < < < Pocket Hardmount Washer-Extractor Product Overview - Model UW35TV UW60AVXU /3 S N/A N/A 0.0 Drawings: ETL Listed Conforms To ANSI/UL Std. 1206, 3rd Ed Certified To CAN/CSA Std. C22.2 No WASH ADD BLEACH RINSE NORMAL HOT LIGHT SOIL HOT PERM PRESS HOT VISA TM WARM 95C 60C 95C 60C 5 6 SPIN DOOR START HEAVY SOIL HOT UNIFORMS HOT 40C 40C STAINED DELICATE 30C HOT COLD A-Control B-Control (Domestic) B-Control (International) Mechanical Timer WE-6 Control S-Computer V-Computer UniLinc Control PHM2979P_F F

7 Pocket Hardmount Washer-Extractor Product Overview - Model UW35TV REF PART NO. DESCRIPTION COMMENTS 1 - Product Family UW 2 - Capacity (Pounds) Control A (A-Control) B (B-Control) M (Mechanical Timer) P (WE-6 Control) S (S-Computer) T (UniLinc Control) V (V-Computer) 4 - Speed 2 (2-Speed) 3 (3-Speed) 4 (4-Speed) V (Variable-Speed) 5 - Voltage F ( /60/3/3) N ( /50-60/3/3) O ( /60/3/3) P ( /60-60/3/3) Q ( / /50/60/3ph) R ( / /50/60/3ph) X ( / /50/60/1-3) Y ( /60/1/2) 6 - OEM U (Standard Specs) 7 - Design Series 1-8 F

8 Pocket Hardmount Washer-Extractor Product Overview - UWL035, UWN035 and UWU035 Models Model No. Serial No. Voltage Schematic : Supply Water: UWN060T3VXU Hz Phase 3 30 amps 60 LB 27 KG Number of wires : FLA : amps Circuit Breaker Size : Max. Load : psi, BAR M30 Control UniLinc Control PHM3063P_F F

9 Pocket Hardmount Washer-Extractor Product Overview - UWL035, UWN035 and UWU035 Models REF PART NO. DESCRIPTION COMMENTS 1 - Product Family UW 2 - Market Approvals L (International ETL) N (Domestic ETL) U (International CE) 3 - Capacity (Dry Weight in Pounds) Control K (M30 Control) T (UniLinc Control) 5 - Spray/Dispenser Feature 1 (No spray but with dispenser) 3 (With spray and dispenser) 6 - Speed 2 (2-Speed) L (Low-Speed - 100/60) M (Medium-Speed - 180/120/60) V (Variable-Speed - 300/240/180/120/60) 7 - Voltage O (208/ /60/3/3) Q ( / /50/60/3) R ( / /50/60/3) X ( /220/240/50/60/1/3) 8 - OEM U 9 - Design Series Heat Feature 0 (Prep for steam) D (Direct steam) E (Electric heat) P (Prep for electric and steam heat) 11 - Features and Options F

10 H3 6 H1 Control Module (Drawing 1 of 3) WARNING AVERTISSEMENT Electrical shock hazard can cause death or serious injury. To reduce the risk of electric shock, disconnect all electric power to appliance and accessories before servicing. Des décharges électriques peuvent entraîner des blessures graves, voire mortelles. Pour réduire le risque de choc électrique, débrancher toute alimentation électrique de l'appareil et des accessoires avante chaque procédure d'entretien. WARNING AVERTISSEMENT Electrical shock hazard can cause death or serious injury. To reduce the risk of electric shock, disconnect all electric power to appliance and accessories before servicing. Des décharges électriques peuvent entraîner des blessures graves, voire mortelles. Pour réduire le risque de choc électrique, débrancher toute alimentation électrique de l'appareil et des accessoires avante chaque procédure d'entretien. UPPER/SINGLE LOWER PHM3107P_F F

11 Control Module (Drawing 1 of 3) REF PART NO. DESCRIPTION COMMENTS Electrical Shock Label Model UW35TV 2 F External Supply Connection Decal 3 F Screw 4 F Control Box Rear Panel 5 F External Supply Label Models with a K in the 7th position 6 F External Supply Connection Decal Model UW35TV and models with a T in the 7th position 7 F Control Box Top Panel 8 F Warning Label 9 F Control Box Contactor Panel 10 F External Supply Box Models through 10/3/10 11 F Pop Rivet Models through 10/3/10 12 F External Supply Box Cover Models through 10/3/10 13 F Trim 14 F Contact Block Switch 14 F Emergency Stop Harness PC Board Standoff Network models P Communication Board Network models 16 NK205 Network Retrofit Kit Includes item 28, Network Board Assembly, Communication Connector, Screw, Network Wire Harness Assembly and Communication Wire Harness Assembly 16 NK220 Network Controller Kit Includes Network Controller Assembly, Network Controller Power Supply, Ethernet Cable, Network Controller Overlay and Network Controller Assembly 17 F Overlay Models with a K in the 7th position 17 F Control Module Decal All other models 18 F Emergency Stop Pushbutton 19 F Control Assembly Models with a K in the 7th position 19 F P Control Assembly All other models 20 F Control Board Bracket Nut 22 F Contact Switch 23 F Steam-Electric Switch Label Dual heat 24 F Rocker Switch Dual heat 25 F Screw Model UW35TV; Models through 6/30/08 26 F Supply Controls Bracket Model UW35TV; Models through 6/30/08 27 F Clean Filter Daily Decal 28 F Cable Tray Assembly Model UW35TV 29 F Cable Tray Cover Model UW35TV 30 F Screw Expansion Clip F

12 Control Module (Drawing 2 of 3) PHM3035P_F F

13 Control Module (Drawing 2 of 3) REF PART NO. DESCRIPTION COMMENTS NA F Temperature Configuration Harness Models UWL035K12, UWN035K12 and UWU035K12; Heat models NA F P Temperature Configuration Harness All other models with a K in the 7th position NA F CFG Harness Model UW35TV and models with a T in the 7th position NA P Network Wire Harness Assembly NA F Output Auxiliary Power Harness NA F P Power Harness NA F P Control Harness Models with a 2 in the 9th position NA F P Drive Control Harness Model UW35TV and models with an L, M or V in the 9th position NA F P Interlock Switch Harness Models with a K in the 7th position NA F P Interlock Switch Harness Model UW35TV and models with a T in the 7th position NA M Jumper Harness Assembly 208 Volt NA M Jumper Configuration Assembly 240 Volt 1 F Screw Model UW35TV 1 F Screw All other models 2 F980P3 Control Assembly Kit Fuse 2.5 Amp Fuse 5 Amp Expansion Clip 4 F Tubing 5 F Tee 6 F Tubing 7 F P Water Pressure Switch 8 F Connector 9 F Air Trap Hose 10 F Hose Clamp No Transformer External supply P Transformer Kit Machine control voltage Bushing 14 F P Output Assembly Model UW35TV and models with a T in the 7th position Male Tab Terminal Models through 10/3/10 16 M Snap Bushing Models through 10/3/10 17 F Screw Models through 10/3/10 18 F Nut Warning Label 20 F Snap Bushing Models through 10/3/10 21 F Network Board Bracket 22 F Nut 23 F Muffin Fan 24 F Filter Retainer Guard Includes item F Screw 26 F Pop Rivet 27 F P Filter Network Board Assembly Network models 29 F Screw 30 F Auxiliary Control Assembly Models with a K in the 7th position F

14 Control Module (Drawing 3 of 3) PHM3111P_F F

15 Control Module (Drawing 3 of 3) REF PART NO. DESCRIPTION COMMENTS 1 F Cap Plug Model UW35TV 1 F Plug All other models 2 F Plug Model UW35TV 2 M Plug All other models 3 M Snap Bushing Female Pin Terminal Screw 6 M Clip 7 F P External Supply Harness Models with a K in the 7th position 7 F P External Supply Harness All other models 8 F Screw F

16 AC Drive Box (Drawing 1 of 2) PE PHM3108P_F F

17 AC Drive Box (Drawing 1 of 2) REF PART NO. DESCRIPTION COMMENTS NA F Electric Heat Harness Left NA F Electric Heat Harness Middle NA F Electric Heat Harness Right NA F Logic Supply Power Harness NA F Output/Logic Harness NA F Main Power Harness NA F Electric Heat Coils Harness KM8A NA F Electric Heat Coils Harness KM8ABL NA F P Control Harness Models with a 2 in the 9th position 1 F Do Not Tamper Label Terminal Block Shield Terminal Block 4 M Insulator Warning Label 6 F Use Copper Conductors Only Caution Label 7 F Ground Decal 8 F Ground Decal Wire Label P Power Distribution Block Cover Electric heat Screw Electric heat 12 M Terminal Block Electric heat 13 F AC Drive Q and X-voltage 13 F AC Drive R-voltage 13 F P Drive Power Harness Model UW35TV and models with an L, M or V in the 9th position 13 F P Drive Control Harness Model UW35TV and models with an L, M or V in the 9th position 14 M Screw Model UW35TV 14 F Screw All other models 15 F P EMI Filter CE models; Q and X-voltage; Model UW35TV and models with an L, M or V in the 9th position 15 F EMI Filter CE models; R-voltage; Model UW35TV and models with an L, M or V in the 9th position 15 F EMI Filter Power Harness Model UW35TV and models with an L, M or V in the 9th position 16 F Drive Mounting Bracket Models starting 10/4/10; Used in place of item 15 on some models 17 F Drive Bracket Models starting 10/4/10 F

18 AC Drive Box (Drawing 2 of 2) PE PHM3108PA_F F

19 AC Drive Box (Drawing 2 of 2) REF PART NO. DESCRIPTION COMMENTS 1 M Ground Lug Connector 2 F Screw 3 F Electric Shock Danger Label 4 F DIN Rail Models with a 2 in the 9th position 5 F330177P Contactor C16; Models with a 2 in the 9th position Reversing Contactor Jumper Assembly Upper; Models with a 2 in the 9th position 5 F Reversing Contactor Harness Lower; Models with a 2 in the 9th position 5 F P Contactor Power Harness Models with a 2 in the 9th position 6 F330186P Interlock Contactor Models with a 2 in the 9th position 7 F Screw Model UW35TV and models with an L, M or V in the 9th position 8 F Filter Retainer Guard Includes item 5; Model UW35TV and models with an L, M or V in the 9th position 9 F P Filter Model UW35TV and models with an L, M or V in the 9th position 10 F Clean Filter Daily Decal 11 F Plug Model UW35TV 11 F Plug All other models 12 F360157P Transformer R-voltage; Model UW35TV and models with an L, M or V in the 9th position 13 M Screw Model UW35TV and models with an L, M or V in the 9th position 14 F DIN Rail Model UW35TV and models with an L, M or V in the 9th position Pop Rivet 16 F P Circuit Breaker R-voltage; Electric heat; Model UW35TV and models with an L, M or V in the 9th position P Circuit Breaker Q and R-voltage; Electric heat; Model UW35TV and models with an L, M or V in the 9th position 16 F Harness Used with F Circuit Breaker; Model UW35TV and models with an L, M or V in the 9th position 16 F P Harness Used with F Circuit Breaker; Model UW35TV and models with an L, M or V in the 9th position 16 F Step Down Power Harness Used with P Circuit Breaker; Model UW35TV and models with an L, M or V in the 9th position 17 F P Circuit Breaker R-voltage; Model UW35TV and models with an L, M or V in the 9th position 18 M Screw Model UW35TV Screw All other models 19 F330188P Contactor NX208; Q and R-voltage; Electric heat; Model UW35TV and models with an L, M or V in the 9th position 20 M Snap Bushing Model UW35TV 20 F Hole Plug All other models 21 F Nut Model UW35TV and models with an L, M or V in the 9th position 22 F Muffin Fan Model UW35TV and models with an L, M or V in the 9th position 22 F Drive Fan Harness Model UW35TV and models with an L, M or V in the 9th position 23 F Trim Screw Male Tab Terminal 26 M Earth Terminal Sticker F

20 Balance Switch, Temperature Probe and Rotation Sensor PHM2932P_F F

21 Balance Switch, Temperature Probe and Rotation Sensor REF PART NO. DESCRIPTION COMMENTS 1 F Screw Nut 3 F Thermistor Sensor 3 F Reducer Bushing 3 F P Temperature Harness Electric heat 3 F Temperature Harness Standard 4 F Rotation Sensor Harness 5 F Rotation Sensor 6 M Screw 7 F Rotation Sensor Bracket 8 F Door Switch 9 F Screw 10 F Balance Switch Bracket F

22 Panels P U SH PHM3030P_F F

23 Panels REF PART NO. DESCRIPTION COMMENTS 1 F Nut 2 F Screw 3 F Side Panel Cover 4 F Left Side Panel 5 M Rivet Panel Locator Screw 8 M Washer 9 F Lower Belt Guard Assembly 10 F Screw Model UW35TV 10 F Screw All other models 11 F Upper Belt Guard Assembly 12 F Cover Decal Model UW35TV Belt Edging Model UW35TV Electrical Shock Label Model UW35TV Warning Label 16 F Belt Access Guard Panel 17 F Screw 18 F Mount on Concrete Warning Label 19 M Screw Expansion Clip 21 F Right Side Panel 22 F Nut 23 F Washer 24 F Screw 25 F Extrusion Insert Order 4 feet 26 F Rub Rail Screw 28 F Front Panel F

24 Drive Box and Water Supply Box - Models Through 10/3/10 P U SH PHM3064P_F F

25 Drive Box and Water Supply Box - Models Through 10/3/10 REF PART NO. DESCRIPTION COMMENTS 1 F Left Side Cover Model UW35TV 1 F Left Side Cover All other models 2 F Warning Label Electrical Shock Label Model UW35TV 4 F Screw Model UW35TV 4 F Screw All other models Expansion Clip 6 F Top Center Panel 7 F Rear Drive Box Panel Model UW35TV 7 F Drive Box Rear Panel All other models Pop Rivet 9 F Rear Water Box Panel Model UW35TV 9 F Water Box Rear Panel All other models 10 F Nut Screw 12 F Water Line Caution Decal Model UW35TV 13 N/A Cold Water Label Model UW35TV 14 N/A Hot Water Label Model UW35TV 15 F Support Bracket 16 F Conversion Label VAC 16 F Conversion Label VAC Warning Label 18 F Hot Surface Warning Plate 19 F Right Side Cover Model UW35TV 19 F Right Side Cover All other models 20 F Top Support Brace 21 F Water Box Side/Front Model UW35TV 21 F Water Box Bottom Panel All other models 22 F Front Box Cover Model UW35TV 22 F Front Bulkhead Panel All other models 23 F Support Bracket 24 F Control Box Bottom Model UW35TV 24 F Drive Box Bottom Panel All other models 25 F Control Box Partition N/A = Part no longer available F

26 Drive Box and Water Supply Box - Models Starting 10/4/10 UWL, UWN and UWU Models P U SH PHM3123P_F F

27 Drive Box and Water Supply Box - Models Starting 10/4/10 REF PART NO. DESCRIPTION COMMENTS Expansion Clip 2 F Left Side Cover 3 F Screw 4 F Top Center Panel 5 F Control Box Partition 6 F Drive Mounting Box 7 F Back Electrical Panel 8 F Electrical Access Panel 9 F Nut 10 F Conversion Label VAC 10 F Conversion Label VAC Warning Label 12 F Center Back Panel 13 F Back Water Panel 14 F Right Side Cover 15 F Warning Label Shock 16 F Side Water Box Panel 17 F Snap Bushing 18 F Front Bulkhead Panel 19 F Side Electrical Panel F

28 Door and Spray Tube Assembly - Models Through 10/3/10 P U SH PHM2939P_F F

29 Door and Spray Tube Assembly - Models Through 10/3/10 REF PART NO. DESCRIPTION COMMENTS 1 F Spray Rinse Nozzle Kit Model UW35TV and models with a 3 in the 8th position 2 F Elbow Model UW35TV and models with a 3 in the 8th position 3 F No-Swivel Coupling Model UW35TV and models with a 3 in the 8th position 4 F Spray Rinse Hose Kit Includes items 3 and 5-7; Model UW35TV and models with a 3 in the 8th position 5 F O-Ring Model UW35TV and models with a 3 in the 8th position 6 F Swivel Coupling Model UW35TV and models with a 3 in the 8th position 7 F Ring Retainer Model UW35TV and models with a 3 in the 8th position 8 F602901P Spray Rinse Bracket Assembly Includes items 9 and 10; Model UW35TV and models with a 3 in the 8th position 9 F Nut Model UW35TV and models with a 3 in the 8th position 10 F Screw Model UW35TV and models with a 3 in the 8th position 11 F Spray Rinse Strap Model UW35TV and models with a 3 in the 8th position 12 F Spray Pipe Assembly Model UW35TV and models with a 3 in the 8th position 13 F Door Bumper Moulding 14 F Door Bumper Bushing 15 F P Door Hinge Strap Kit Includes items 33 and F Door Hinge Pin 17 F Door Butt Shim 18 F Hot Surface Warning Decal 19 F P Shell Front Kit Includes item 18 and F170120RP Shell Band Gasket 19 F Shell Front Assembly Includes items 13-15, 17, 18, 22, 24, 31, F Top Latch Bracket Casting, F Lower Door Latch Bracket Casting, F Door Handle Casting, F Lower Door Latch Casting and F Screw 20 F Door Gasket Black 20 F Door Gasket Gray 21 F Stud Weldment 22 F Washer 23 F Door Glass Gasket 24 F Nut 25 F Push Decal 26 F Pop Rivet 27 F Push Handle Kit Includes item 25, F Magnet, F Nut, F Screw, F Washer, F Washer, F Door Push Brace and F Door Push Handle 28 F290203P Glass Models with a 1 in the 8th position 28 F290202P Glass Kit All other models 29 F Clockwise Spin Rotation Decal 30 F Retainer Ring Spinning 31 F Nut 32 F Screw 33 F Door Hinge Strap 34 F Screw 35 F Door Butt Hinge 36 F Door Assembly Includes items 20-24, 27, 28, 30, 33 and 34; Models with a 1 in the 8th position 36 F P Door Assembly Includes items 20-25, 27-30, 34 and 35; All other models F

30 Door and Spray Tube Assembly - Models Starting 10/4/10 UWL, UWN and UWU Models P U SH PHM3113P_F F

31 Door and Spray Tube Assembly - Models Starting 10/4/10 REF PART NO. DESCRIPTION COMMENTS 1 F Door Spray Nozzle Assembly Models UWL035T3V, UWN035T3V and UWU035T3V 2 F Nut Models UWL035T3V, UWN035T3V and UWU035T3V 3 F Elbow Models UWL035T3V, UWN035T3V and UWU035T3V 4 F Spray Rinse Hose Assembly Includes items 5-8; Models UWL035T3V, UWN035T3V and UWU035T3V 5 F No-Swivel Coupling Models UWL035T3V, UWN035T3V and UWU035T3V 6 F O-Ring Models UWL035T3V, UWN035T3V and UWU035T3V 7 F Swivel Coupling Models UWL035T3V, UWN035T3V and UWU035T3V 8 F Ring Retainer Models UWL035T3V, UWN035T3V and UWU035T3V 9 F Spray Rinse Strap Models UWL035T3V, UWN035T3V and UWU035T3V 10 F Screw Models UWL035T3V, UWN035T3V and UWU035T3V 11 F Spray Pipe Assembly Models UWL035T3V, UWN035T3V and UWU035T3V 12 F602901P Spray Rinse Bracket Assembly Includes items 10 and 13; Models UWL035T3V, UWN035T3V and UWU035T3V 13 F Nut Models UWL035T3V, UWN035T3V and UWU035T3V 14 F P Door Hinge Strap Kit Includes item F Door Hinge Pin 16 F Door Butt Shim 17 F Door Bumper Bushing 18 F Door Bumper Moulding 19 F Screw 20 F Nut 21 F Nut 22 F Spray Nozzle Gasket Models UWL035T3V, UWN035T3V and UWU035T3V 23 F Washer 24 F Screw 25 F Hot Surface Warning Decal 26 F P Shell Front Kit Includes item 25 and F170120RP Shell Band Gasket 26 F Shell Front Assembly Includes items 14, 16-18, 21, 23, 25, F Top Latch Bracket Casting, F Lower Door Latch Bracket Casting, F Door Handle Casting, F Lower Door Latch Casting and F Screw 27 F Door Gasket Black 27 F Door Gasket Gray 28 F Door Kit Studded 29 F Push Handle Kit Includes item 31, F Magnet, F Nut, F Screw, F Washer, F Washer, F Door Push Brace and F Door Push Handle 30 F Pop Rivet 31 F Push Decal 32 F Door Glass Gasket 33 F High Hole Glass Models UWL035T3V, UWN035T3V and UWU035T3V 33 F290203P Glass All other models 34 F Door Assembly Models UWL035T3V, UWN035T3V and UWU035T3V; Includes items 20, 22-24, 27-29, 32 and F Door Assembly All other models; Includes items 14, 20, 22, 23, 25-27, and F Retainer Ring Spinning F

32 Door Lock PHM3124P_F F

33 Door Lock REF PART NO. DESCRIPTION COMMENTS NA F Door Lock Harness Models with a 2 in the 9th position NA F Door Lock Harness All other models 1 F Screw 2 F Washer 3 F Screw 4 F Extension Arm Kit Includes items 1-3, 12 and F Screw 6 F Door Handle Casting 7 F150201P Top Latch Bracket Casting 8 F Door Latch Bracket Shim 9 F Door Bracket Latch Shim 10 F Washer 11 F Nut 12 F Nut 13 F Lower Door Latch Casting 14 F Nut 15 F Washer 16 F Extension Arm Tab 17 F Lower Door Latch Bracket Casting 18 F Nut 19 F Magnet 20 F Handle Spacer 21 F Screw 22 F Door Switch CE models 22 F Interlock Switch All other models 23 F Interlock Switch Spacer 24 F Nut 25 F Door Lock Cover 26 F P Reed Switch Assembly 27 F Screw 28 F Solenoid Mount Bracket 29 F Door Lock Solenoid Shim 30 F Door Lock Dielectric Shield 31 F300129P Door Lock Solenoid 32 F Screw 33 F Lock Bracket 34 F Screw 35 F Pop Rivet 36 F Door Lock Assembly Includes items 18 and Nut F

34 Basket PHM3032P_F F

35 Basket REF PART NO. DESCRIPTION COMMENTS 1 F Nut 2 F Washer 3 F Shell Band Fastener Kit Includes items 1, 2 and 4 4 F Screw 5 F Shell Band Kit Includes items 1, 2 and 4 6 F Shell Gasket Shield 7 F Nut 8 F Washer 9 F602901P Spray Rinse Bracket Assembly 10 F Spray Rinse Strap 11 F Screw Screw 13 F P Shell Band Gasket 14 F Shell Front Assembly Includes F Door Latch Bracket Shim, F Door Butt Shim, F Top Latch Bracket Casting, F Lower Door Latch Bracket Casting, F Door Butt Hinge, F Nut, F Nut, F43100 Washer, F Door Bracket Latch Shim, and F Shell Front Weldment 15 F Basket Assembly F

36 Shell and Frame - Models Through 10/3/10 PHM3109P_F F

37 Shell and Frame - Models Through 10/3/10 REF PART NO. DESCRIPTION COMMENTS 1 F Shell Weldment Standard 1 F Shell Weldment Electric heat 2 F Trim 4 feet required 3 F Plug 4 F Shell Reinforcement Plate Includes items 15 and 16 5 F Hose Clamp 6 F Vent Hose 7 F Pipe 8 F Bushing 9 F Elbow 10 F Adapter 11 F Vacuum Breaker 12 F Vent Assembly Includes items F Face Seal Standard 13 F Face Seal Viton 13 F Seal Kit Includes items 14, 33, 34, F Clear Sealant, F Pop Rivet, F Nut, F Washer, F Screw and F170120RP Shell Band Gasket 14 F Slinger 15 F Pop Rivet 16 F Scupper 17 F Frame Weldment Model UW35TV and models with an L, M or V in the 9th position 18 M Washer 19 N/A Nut Warning Label Models starting 6/1/09 21 F Frame Weldment Models with a 2 in the 9th position 22 F Tee 23 F200107P Water Hose Hose Clamp No F Hose Barb 26 F Moving Parts Plug Warning Decal 27 F Drip Rail Nut 29 M Washer 30 M Washer 31 F Shell Mounting Bracket 32 F Screw 33 F Screw 34 F Washer 35 F Washer N/A = Part no longer available F

38 Shell and Frame - Models Starting 10/4/10 PHM3132P_F F

39 Shell and Frame - Models Starting 10/4/10 REF PART NO. DESCRIPTION COMMENTS 1 F Shell Weldment Standard 1 F Shell Weldment Electric heat 2 F Trim 4 feet required 3 F Plug 4 F Shell Reinforcement Plate Includes items 9 and 10 5 F Hose Clamp 6 F Vent Hose 7 F Face Seal Standard 7 F Face Seal Viton 7 F Seal Kit Includes items 8, 27, 28, F Clear Sealant, F Pop Rivet, F Nut, F Washer, F Screw and F170120RP Shell Band Gasket 8 F Slinger 9 F Pop Rivet 10 F Scupper 11 F Frame Weldment Model with an L, M or V in the 9th position 12 M Washer 13 N/A Nut Warning Label Models starting 6/1/09 15 F Frame Weldment Models with a 2 in the 9th position 16 F Tee 17 F200107P Water Hose Hose Clamp No F Hose Barb 20 F Moving Parts Plug Warning Decal 21 F Drip Rail Nut 23 M Washer 24 M Washer 25 F Shell Mounting Bracket 26 F Screw 27 F Screw 28 F Washer 29 F Washer N/A = Part no longer available F

40 Supply Dispenser PHM3153P_F F

41 Supply Dispenser REF PART NO. DESCRIPTION COMMENTS 1 F Screw 2 F Washer 3 F Dispenser Lid 4 F Plug Cap 5 F140340P Strain Relief Connector 6 F Strain Relief Adapter Kit Includes items 5 and 7 7 F O-Ring 8 F Hose Clamp No F Chemical Supply Hose 10 F Nut 11 F Washer 12 F Washer 13 F Hot Water and Chemical Caution Decal 14 F Spin Warning Decal 15 F Soap Dispenser Shroud Weldment 16 F170158P Gasket 17 F170400RP Trim 18 F Chemical Supply Cup 32 ounce; 2 used 19 F Supply Dispenser Spacer 20 F Chemical Supply Cup 20 ounce; 3 used 21 F P Dispenser Assembly Includes items 3 and F Injection Nozzle 23 F O-Ring Nut 25 F Injection Nozzle Kit Includes items F

42 Water Supply Valve and Hoses to Supply Dispenser - Models Through 10/3/10 PHM3037P_F F

43 Water Supply Valve and Hoses to Supply Dispenser - Models Through 10/3/10 REF PART NO. DESCRIPTION COMMENTS 1 G582P3 Diaphragm and Guide Kit 2 F Strainer 3 N/A Flow Restrictor 8 liter 4 F381723P 4-Way Valve 220 Volt 4 F P Dispenser Valve Harness 5 F Screw 6 F Hose Connector 7 F Water Valve Assembly Decal Hose Clamp No. 6 9 F200110P Water Hose 10 F Y Connector N/A = Part no longer available F

44 Water Supply Valve and Hoses to Supply Dispenser - Models Starting 10/4/10 UWL, UWN and UWU Models PHM3117P_F F

45 Water Supply Valve and Hoses to Supply Dispenser - Models Starting 10/4/10 REF PART NO. DESCRIPTION COMMENTS 1 F Way Valve 240 Volt; Includes regulator 1 F Dispenser Valve Harness 2 G582P3 Diaphragm and Guide Kit 3 F Screw 4 F Valve Mounting Bracket Hose Clamp No. 6 6 F200110P Water Hose 7 F Y Connector F

46 AVERTISSEMEN T Spray and Fill Plumbing Assemblies - Models Through 10/3/10 Model UW35TV and Models with a 3 in the 8th Position WARNING PHM3040P_F F

47 Spray and Fill Plumbing Assemblies - Models Through 10/3/10 REF PART NO. DESCRIPTION COMMENTS NA F P Supply/Fill Module Harness NA F P Fill/Spray Valve Harness 1 F Screw 2 F Containment Device 3 F Hose Barb 4 F Street Elbow 5 F Coupling 6 F200104P Hose 2 feet used 7 F P Vacuum Breaker Valve Includes items 1, 2 and F Catch Basin 9 F Elbow 10 F Reducer Bushing 11 F200401P U-Bolt Clamp 12 F Fill Plumbing Connection Includes items F Hose Clamp No F Hose 15 F Nipple 16 F381703P Valve F380996P Water Valve Repair Kit 17 F Warning Label 18 F Nipple 19 F Coupling 20 F Hose Adapter Standard thread; 3/4 inch 20 F Hose Adapter Standard thread; 1 1/2 inches 20 F Adapter Metric thread 21 F Water Hose Standard thread 21 F Water Hose Metric thread Washer Washer Filter 24 F Cold Spray Plumbing Assembly Includes items 16, 18, 19 and F P Fill Plumbing Assembly Includes items F Water Hose 5 used 27 F Hose Barb 28 F Gate Valve 29 F Nipple 30 F Hose Barb 31 F Street Elbow 32 F Tee 33 F Elbow 34 F Nipple 35 F381703P Valve F380996P Water Valve Repair Kit 36 F Nipple 37 C Hose 38 F Hose Barb 39 F Hose 40 F380800P Vacuum Breaker Valve 41 F O-Ring 42 F Vacuum Breaker Cap 43 F Hot Spray Plumbing Assembly Includes items 1-3, 7-10, 15, 16, 18, 19, 29 and F

48 Fill Plumbing Assembly - Models Starting 10/4/10 UWL, UWN and UWU Models PHM3118P_F F

49 Fill Plumbing Assembly - Models Starting 10/4/10 REF PART NO. DESCRIPTION COMMENTS NA F Valve Kit 1/2 inch NA F Fill/Supply Harness NA F Fill Valve Harness 1 F Hose Hose Clamp No. 8 3 F Hose Barb 4 F P Valve 1/2 inch; Brass 5 F Nipple 1/2 inch; Brass 6 F Tee 7 F Coupling 1/2 inch 8 F Hose Barb 9 C Hose Order 2 feet 10 F Fill Port Screw 12 F Hose Clamp No F Hose 14 F Manifold Washer Filter 16 F Water Hose Standard thread 16 F Water Hose Metric thread 17 F Hose Adapter Standard thread; 3/4 x 1/2 inches 17 F Adapter Metric thread Washer Screw F

50 AVERTISSEMENT Fill Plumbing Assembly - Models Through 10/3/10 Models with a 1 in the 8th Position WARNING PHM3038P_F F

51 Fill Plumbing Assembly - Models Through 10/3/10 REF PART NO. DESCRIPTION COMMENTS NA F P Supply/Fill Module Harness NA F P Fill/Supply Harness NA F P Fill Valve Harness 1 F Coupling 2 F Street Elbow 3 F Hose Barb 4 F Fill Plumbing Connection Includes items F Hose Clamp No F Hose 7 F Warning Label 8 F Hose Adapter Standard thread; 3/4 inch 8 F Hose Adapter Standard thread; 1 1/2 inches 8 F Adapter Metric thread Washer 10 F Water Hose Standard thread 10 F Water Hose Metric thread Washer Filter 12 F Hose Barb 13 F Street Elbow 14 F Tee 15 F Elbow 16 F Nipple 17 F200401P U-Bolt Clamp 18 F381703P Valve F380996P Water Valve Repair Kit 19 F Nipple 20 F Nipple 21 F Gate Valve 22 F Hose Barb 23 F P Fill Plumbing Assembly Includes items F Water Hose 5 used 25 C Hose F

52 Spray Plumbing Assembly - Models Starting 10/4/10 Models with a 3 in the 8th Position PHM3122P_F F

53 Spray Plumbing Assembly - Models Starting 10/4/10 REF PART NO. DESCRIPTION COMMENTS NA F Fill/Supply Harness NA F Fill Valve Harness 1 F Hose Hose Clamp No. 8 3 F Hose Barb 4 F P Valve 3/4 inch; Brass 5 F Coupling 3/4 inch 6 F Manifold 7 F Fill Plumbing Assembly Includes items 3-5 F

54 Drain - Models Through 10/3/10 PHM2931P_F F

55 Drain - Models Through 10/3/10 REF PART NO. DESCRIPTION COMMENTS Gravity Drain Valve 1 F P Drain Valve Harness R-voltage 1 F Drain Valve Harness Q-voltage 1 F Dual Drain Harness 2 F Drain Valve Cover 3 F Hose Clamp No F Upper Overflow Hose 5 F Pipe 6 F Tee 7 F Pipe 8 F Elbow 9 F Pipe 10 F Lower Overflow Hose 11 F Drain Hose 12 F Hose Clamp No F Drain Connector Tee 14 F Drain Hose 15 F Vacuum Breaker Hose F

56 Drain - Models Starting 10/4/10 UWL, UWN and UWU Models PHM3120P_F F

57 Drain - Models Starting 10/4/10 REF PART NO. DESCRIPTION COMMENTS NA F P Drain Valve Harness Standard and electric heat NA F Drain Valve Harness Steam heat Gravity Drain Valve 2 F380933P Drain Valve Motor 220 Volt; Keyed shaft 3 F Drain Valve Cover 4 F Shell Reinforcement Plate Assembly Includes items 10 and 11 5 F Pop Rivet 6 F Scupper 7 F200107P Water Hose 8 F Tee Hose Clamp No F Hose Barb 11 F Hose Clamp No F Overflow Hose 13 F Molded Drain 14 F Drain Hose 15 F Hose Clamp No F Drain Hose F

58 Motor, Pulley and Bearings (Drawing 1 of 2) Model UW35TV and Models with an L, M or V in the 9th Position PHM2934P_F F

59 Motor, Pulley and Bearings (Drawing 1 of 2) REF PART NO. DESCRIPTION COMMENTS 1 F Belt B86 2 F280409P Bushing Includes screws and key; 2-7/16 inch 3 F Pulley 4 F Front Bearing Kit Includes F Face Seal, F Slinger, F170120R Shell Band Gasket, F Shell Band Seal, F Shell Band Gasket, F Clear Sealant, F Screw, F Nut, F Nut, F Washer, F Washer, F Screw, F Screw, F Nut, F Washer, F Washer, F Pop Rivet and F Key 4 F100150P Bearing 5 F Rear Bearing Kit Includes F Screw, F Key, F Nut and F Washer 5 F100150P Bearing 6 F Air Coupling 7 F Washer 8 F Grease Instruction Decal Lubrication 9 F Grease Fitting 9 F Manual Bearing Greasing Retrofit Kit Includes items 10 and 11, F Grease Manifold Bracket, F Bearing Lubrication Instruction Decal, F Grease Manifold, F Nut, F Washer, F Screw, F Screw and F Nut 10 J Connector 11 C000628P Tubing 12 F Cable Tie 6 inch 13 M Washer 14 F Washer 15 F Screw 16 F Motor Kit AC drive parameters must be compatible with the motor and motor pulley. Please request the AC drive parameter illustration for parameter verification when ordering a motor. 16 F Motor Harness 17 F280146P Pulley 18 F280211P Motor Pulley Bushing Includes item 19 and screws 19 F Key 20 M Washer Nut F

60 Motor, Pulley and Bearings (Drawing 2 of 2) Models with a 2 in the 9th Position PHM3162P_F F

61 Motor, Pulley and Bearings (Drawing 2 of 2) REF PART NO. DESCRIPTION COMMENTS 1 F Belt B86 2 F280409P Bushing Includes screws and key; 2-7/16 inch 3 F Pulley 4 F Front Bearing Kit Includes F Face Seal, F Slinger, F170120R Shell Band Gasket, F Shell Band Seal, F Shell Band Gasket, F Clear Sealant, F Screw, F Nut, F Nut, F Washer, F Washer, F Screw, F Screw, F Nut, F Washer, F Washer, F Pop Rivet and F Key 4 F100150P Bearing 5 F Rear Bearing Kit Includes F Screw, F Key, F Nut and F Washer 5 F100150P Bearing 6 F Bolt 7 M Washer 8 F Nut 9 F Air Coupling 10 F Washer 11 F Grease Fitting 11 F Manual Bearing Greasing Retrofit Kit Includes items 13 and 14, F Grease Manifold Bracket, F Bearing Lubrication Instruction Decal, F Grease Manifold, F Nut, F Washer, F Screw, F Screw and F Nut 12 F Grease Instruction Decal Lubrication 13 J Connector 14 C000628P Tubing 15 F Cable Tie 6 inch 16 F Cotter Pin 17 F Motor Support Rod Kit Includes item F Clip 19 F Spring 20 F Key 21 F280211P Motor Pulley Bushing Includes item 20 and screws 22 F Sheave 23 F P Motor 23 F Motor Harness 24 F Motor Drip Shield F

62 Electric Heat Option PHM2935P_F F

63 Electric Heat Option REF PART NO. DESCRIPTION COMMENTS NA F P Electric Heat Harness R-voltage NA F Electric Heat Harness Q-voltage 1 F360203P Heating Element 6 required 1 F Electric Heat Harness 6 element to ground 2 F Heating Element Plug 3 F Shell Weldment Electric heat; Models through 10/3/10 3 F Shell Weldment Electric heat; Models starting 10/4/10 F

64 Steam Heat Option - Models Through 10/3/10 PHM2999P_F F

65 Steam Heat Option - Models Through 10/3/10 REF PART NO. DESCRIPTION COMMENTS 1 F Shell Weldment 2 F Steam Injector Tube Assembly 3 F Street Elbow 4 F Steam Hose 5 H Street Elbow 6 F380987P DIN Coil 220 Volt 7 F380787P Steam Valve 1/2 inch; 220 Volt; F Steam Valve Repair Kit 8 F200401P U-Bolt Clamp Pipe Nipple Elbow 11 F Plug 12 F Steam Filter Pipe Nipple 14 F Steam Assembly Includes items 2-7, 9, 10 and F947P3 Steam Heat Kit Includes items 2-13 and F Drain Valve Harness F

66 Steam Heat Option - Models Starting 10/4/10 PHM2132K_F F

67 Steam Heat Option - Models Starting 10/4/10 REF PART NO. DESCRIPTION COMMENTS NA F Steam Assembly Includes items 2-11 NA F943P3 Steam Heat Kit Includes items 2-11 and F Drain Valve Harness 1 F Shell Weldment 2 F Steam Injector Tube Assembly 3 F Street Elbow 4 F Steam Hose 5 F Adapter 6 F P Valve 1/2 inch; 220 Volt 7 F Coupling 8 F Plug 9 F Steam Filter Pipe Nipple Screw F

68 Special Tools PHM2981P_F F

69 Special Tools REF PART NO. DESCRIPTION COMMENTS NA F923P3 Wet-Clean Kit NA F922P3 Reuse Kit NA F USB IR Device Assembly NA F UniLinc PC and PDA Software CD NA F UniLinc PC and PDA Software CD Programmer s version 1 F Shaft Seal Alignment Fixture 2 F Rebar Frame Template 3 F Grease Gun Kit Includes items 4 and 5 4 F210206P Bearing Grease 5 F210207P Grease Gun 6 F Alignment Shaft Assembly F

70 Notes 68 F

71 Parts Index A AC Drive F F Adapter F F , 47, 49 F Air Coupling F , 59 Air Trap Hose F Alignment Shaft Assembly F Auxiliary Control Assembly F B Back Electrical Panel F Back Water Panel F Balance Switch Bracket F Basket Assembly F Bearing F100150P... 57, 59 Bearing Grease F210206P Belt F , 59 Belt Access Guard Panel F Belt Edging Bolt F Bushing F280409P... 57, 59 F C Cable Tie F , 59 Cable Tray Assembly F Cable Tray Cover F Cap Plug F Catch Basin F Center Back Panel F CFG Harness F Chemical Supply Cup F F Chemical Supply Hose F Circuit Breaker F P P...17 Clean Filter Daily Decal F , 17 Clip F M Clockwise Spin Rotation Decal F Cold Spray Plumbing Assembly F Communication Board P...9 Connector F J , 59 Contact Block Switch F Contact Switch F Contactor F330177P...17 F330188P...17 Contactor Power Harness F P...17 Containment Device F Control Assembly F F P...9 Control Assembly Kit F980P Control Board Bracket F Control Box Bottom F Control Box Contactor Panel F Control Box Partition F F Control Box Rear Panel F Control Box Top Panel F Control Harness F P...15 F P...11 Control Module Decal F N/A items do not appear in index. F

72 Conversion Label F , 25 F , 25 Cotter Pin F Coupling F F , 49 F , 51, 65 Cover Decal F D Diaphragm and Guide Kit G582P , 43 DIN Coil F380987P DIN Rail F F Dispenser Assembly F P Dispenser Lid F Dispenser Valve Harness F P F Do Not Tamper Label F Door Assembly F , 29 F P F Door Bracket Latch Shim F Door Bumper Bushing F , 29 Door Bumper Moulding F , 29 Door Butt Hinge F Door Butt Shim F , 29 Door Gasket F , 29 F , 29 Door Glass Gasket F , 29 Door Handle Casting F Door Hinge Pin F , 29 Door Hinge Strap F Door Hinge Strap Kit F P... 27, 29 Door Kit F Door Latch Bracket Shim F Door Lock Assembly F Door Lock Cover F Door Lock Dielectric Shield F Door Lock Harness F F Door Lock Solenoid F300129P...31 Door Lock Solenoid Shim F Door Spray Nozzle Assembly F Door Switch F , 31 Drain Connector Tee F Drain Hose F F , 55 F Drain Valve Cover F , 55 Drain Valve Harness F P...53 F P...55 F , 55 Drain Valve Motor F380933P...55 Drip Rail F , 37 Drive Box Bottom Panel F Drive Box Rear Panel F Drive Bracket F Drive Control Harness F P...11 F P...15 Drive Fan Harness F Drive Mounting Box F Drive Mounting Bracket F Drive Power Harness F P...15 Dual Drain Harness F N/A items do not appear in index. 70 F E Earth Terminal Sticker M Elbow F , 49 F F , 29 F F

73 Electric Heat Coils Harness F F Electric Heat Harness F F F F P F F Electric Shock Danger Label F Electrical Access Panel F Electrical Shock Label , 21, 23 Emergency Stop Harness F Emergency Stop Pushbutton F EMI Filter F P F EMI Filter Power Harness F Expansion Clip , 11, 21, 23, 25 Extension Arm Kit F Extension Arm Tab F External Supply Box F External Supply Box Cover F External Supply Connection Decal F F External Supply Harness F P F P External Supply Label F Extrusion Insert F F Face Seal F , 37 F , 37 Female Pin Terminal Fill Plumbing Assembly F P... 45, 49 F Fill Plumbing Connection F , 49 Fill Port F Fill Valve Harness F P F , 51 Fill/Supply Harness F P...49 F , 51 Fill/Supply Valve Harness F P...45 Filter F P...11, 17 Filter Retainer Guard F , 17 Frame Weldment F F F F Front Bearing Kit F , 59 Front Box Cover F Front Bulkhead Panel F F Front Panel F Fuse G Gasket F170158P...39 Gate Valve F , 49 Glass F290203P...27, 29 Glass Kit F290202P...27 Gravity Drain Valve , 55 Grease Fitting F , 59 Grease Gun F210207P...67 Grease Gun Kit F Grease Instruction Decal F , 59 Ground Decal F F Ground Lug Connector M H Handle Spacer F Harness F F P...17 Heating Element F360203P...61 N/A items do not appear in index. F

74 Heating Element Plug F High Hole Glass F Hole Plug F Hose C , 49 C F200104P F , 49 F F F , 51 Hose Adapter F , 47, 49 F , 49 Hose Barb F , 37, 55 F , 47, 49 F , 49 F , 47, 49, 51 Hose Clamp F F , 53, 55 F , 37, 53 F , 45, 47, , 37, 41, 43, 47, 51, 55 Hose Connector F Hot Spray Plumbing Assembly F Hot Surface Warning Decal F , 29 Hot Surface Warning Plate F Hot Water and Chemical Caution Decal F I Injection Nozzle F Injection Nozzle Kit F Insulator M Interlock Contactor F330186P Interlock Switch F Interlock Switch Harness F P F P Interlock Switch Spacer F J Jumper Configuration Assembly M Jumper Harness Assembly M K Key L F , 59 Left Side Cover F F F Left Side Panel F Lock Bracket F Logic Supply Power Harness F Lower Belt Guard Assembly F Lower Door Latch Bracket Casting F Lower Door Latch Casting F Lower Overflow Hose F M Magnet F Main Power Harness F Male Tab Terminal , 17 Manifold F , 51 Manual Bearing Greasing Retrofit Kit F , 59 Molded Drain F Motor F P...59 Motor Drip Shield F Motor Harness F , 59 Motor Kit F Motor Pulley Bushing F280211P...57, 59 Motor Support Rod Kit F Mount on Concrete Warning Label F Moving Parts Plug Warning Decal F , 37 N/A items do not appear in index. 72 F

75 Muffin Fan F , 17 N Network Board Assembly Network Board Bracket F Network Controller Kit NK Network Retrofit Kit NK Network Wire Harness Assembly P Nipple F F , 49 F F , 49 F , 49 F No-Swivel Coupling F , 29 Nut F F F F , 17, 31 F F F , 23, 25, 31 F , 29, 39 F , 29, 33 F , 29, 31 F , 37, O O-Ring F F , 29 F F Output Assembly F P Output Auxiliary Power Harness F Output/Logic Harness F Overflow Hose F Overlay F P Panel Locator PC Board Standoff Pipe F , 53 F F Pipe Nipple , 65 Plug F , 37 F F , 65 F F , 17 M Plug Cap F Pop Rivet F , 11, 27, 29, 31 F , 37, , 23 Power Distribution Block Cover P...15 Power Harness F P...11 Pulley F280146P...57 F , 59 Push Decal F , 29 Push Handle Kit F , 29 R Rear Bearing Kit F , 59 Rear Drive Box Panel F Rear Water Box Panel F Rebar Frame Template F Reducer Bushing F F Reed Switch Assembly F P...31 Retainer Ring Spinning F , 29 Reuse Kit F922P Reversing Contactor Harness F Reversing Contactor Jumper Assembly N/A items do not appear in index. F