Washer-Extractor. Parts. Pocket Hardmount. Refer to Page 3 for Model Numbers. Models UW35P2 and UW35P3.

Transcription

1 Washer-Extractor Pocket Hardmount Refer to Page 3 for Model Numbers Parts Models UW35P2 and UW35P3 Model UW35B2 PHM1403C_F Part No. F232165R17 December 2014

2

3 Table of Contents Title Page Parts Ordering Information... 2 Serial Plate Location... 2 Model Identification... 3 Pocket Hardmount Washer-Extractor Product Overview... 4 Decals... 6 Control Module - Models UW35P2 and UW35P3 (Drawing 1 of 4)... 8 Control Module - Models UW35P2 and UW35P3 (Drawing 2 of 4) Control Module - Models UW35P2 and UW35P3 (Drawing 3 of 4) Control Module - Models UW35P2 and UW35P3 (Drawing 4 of 4) Control Module - Model UW35B2 (Drawing 1 of 3) Control Module - Model UW35B2 (Drawing 2 of 3) Control Module - Model UW35B2 (Drawing 3 of 3) Supply Dispenser Spray Plumbing - Design 5 UW35P2 and UW35P3 Models Spray Plumbing - Design 7 and 8 UW35P2 and UW35P3 Models Fill Plumbing - Design 5 UW35P2 and UW35P3 Models Through 3/ Fill Plumbing - Design 5 UW35P2 and UW35P3 Models Starting 4/ Fill Plumbing - Design 7 and 8 Models Drain Valve and Hoses Basket and Shell Door and Spray Rinse Door Box Panels Frame Pulley and Trunnion Assembly Motor - Models UW35B2 and UW35P Motor - Model UW35P Steam Heat Option and Transformer Electric Heat Option Security Fasteners Special Tools Parts Index Copyright 2014, Alliance Laundry Systems LLC All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed written consent of the publisher. F

4 If literature or replacement parts are required, contact the source from whom the machine was purchased or contact Alliance Laundry Systems at (920) for the name and address of the nearest authorized parts distributor. Parts Ordering Information For technical assistance, call either of the numbers listed below: (920) Ripon, Wisconsin Wevelgem, Belgium When calling or writing about your product, be sure to mention model and serial numbers. Model and serial numbers are located on serial plate(s) as shown. Serial Plate Location PHM2484P_F F232165

5 Model Identification Information in this manual is applicable to these washer-extractor models: UW35B2 UW35P2 UW35P3 NOTE: This manual applies to models with 5, 7 or 8 in the 9th position in the model number (e.g. UW35P2OU50001) F

6 < < < < Pocket Hardmount Washer-Extractor Product Overview UW60AVXU /3 S N/A N/A 0.0 Drawings: ETL Listed Conforms To ANSI/UL Std. 1206, 3rd Ed Certified To CAN/CSA Std. C22.2 No WASH ADD BLEACH RINSE NORMAL HOT LIGHT SOIL HOT PERM PRESS HOT VISA TM WARM 95C 60C 95C 60C 5 6 SPIN DOOR START HEAVY SOIL HOT UNIFORMS HOT 40C 40C STAINED DELICATE 30C HOT COLD A-Control B-Control (Domestic) B-Control (International) Mechanical Timer WE-6 Control S-Computer V-Computer UniLinc Control PHM2979P_F F232165

7 Pocket Hardmount Washer-Extractor Product Overview REF PART NO. DESCRIPTION COMMENTS 1 - Product Family UW 2 - Capacity (Pounds) Control A (A-Control) B (B-Control) M (Mechanical Timer) P (WE-6 Control) S (S-Computer) V (V-Computer) T (UniLinc Control) 4 - Speed 2 (2-Speed) 3 (3-Speed) 4 (4-Speed) V (Variable-Speed) 5 - Voltage F ( /60/3/3) N ( /50-60/3/3) O ( /60/3/3) P ( /60-60/3/3) Q ( / /50/60/3ph) R ( / /50/60/3ph) X ( / /50/60/1-3) Y ( /60/1/2) 6 - OEM U (Standard Specs) 7 - Design Series 1-8 F

8 Decals COPPER CONDUCTORS ONLY P/N PHM2894P_F F232165

9 Decals REF PART NO. DESCRIPTION COMMENTS Disconnect Power Warning Label 2 F This Machine Must Be Protected Decal 3 F Conductor Decal 4 F External Supply Connection Decal 5 F Hot Surface Warning Decal 6 F Cold Water Valve Decal 7 F Hot Water Valve Decal 8 F Do Not Push Decal 9 F Supply Dispenser Hazard Caution Decal 10 F Before Power Is Connected Tag 11 F Clockwise Spin Rotation Decal 12 F Hot Surface Warning Decal 13 F Personal Injury Warning Decal F

10 Control Module - Models UW35P2 and UW35P3 (Drawing 1 of 4) PHM2469P_F F232165

11 Control Module - Models UW35P2 and UW35P3 (Drawing 1 of 4) REF PART NO. DESCRIPTION COMMENTS 1 F Contact Block Switch 800E-series; Models through 9/30/07 1 F Contact Block Switch 800F-series; Models starting 10/1/07; Includes F Contact Switch and F Contact Base 1 F Contact Switch Models starting 10/1/07 1 F Contact Base Models starting 10/1/07 2 N/A Control Mounting Panel Assembly Screw 4 F Control Module Cover Disconnect Power Warning Label 6 F Cable Tray Cover 7 F Screw 8 F Electrical Access Panel Design 5 models 8 F Electrical Access Panel Design 7 and 8 models 9 F Washer 10 F Cable Tray Assembly 11 F External Supply Box 12 F External Supply Box Cover 13 F Screw 14 F Screw 15 F Nut 16 F Computer Cover 17 F Cable Tie 15 inch 18 F Cable Tie 6 inch 19 F Tie Wrap Mounting Clamp 20 F140219P Ribbon Cable 26 pin; 15 inch; Connects microcomputer to output cca 21 F Computer Input Harness 22 F Battery 9 Volt; Backup 23 F Nut 24 F Washer 25 F P WE-6 Computer Standard cycles 26 F Momentary Switch Models through 5/26/04 26 F Momentary Switch Models starting 5/27/04 27 F Washer 28 F Washer 29 F Screw 30 N/A Emergency Stop Pushbutton 800E-series; Models through 9/30/07 30 F P Emergency Stop Button Kit Used to convert from 800E-series to 800F-series; Includes F Contact Block Switch and F Emergency Stop Pushbutton 30 F Emergency Stop Pushbutton 800F-series; Models starting 10/1/07 31 F230724P Keypad Decal 32 F Control Module Decal N/A = Part no longer available F

12 Control Module - Models UW35P2 and UW35P3 (Drawing 2 of 4) PHM2139P_F F232165

13 Control Module - Models UW35P2 and UW35P3 (Drawing 2 of 4) REF PART NO. DESCRIPTION COMMENTS 1 F P Output CCA 2 F140219P Ribbon Cable 26 pin; 15 inch; Connects microcomputer to output cca 3 F784003P Jumper Kit 4 F Fuse 1 Amp; Slo blo 4 F Fuse 1/2 Amp; Fast blo 4 F Fuse 1/8 Amp; Slo blo 5 F330177P Contactor C16 6 F330186P Interlock Contactor 100-MCA00 7 F P Overload Contactor 1 Phase 8 F DIN Contactor Mounting Rail 9 F Screw 10 F Flange Relay 220 Volt 11 F Screw 12 F Circuit Breaker F-voltage 13 F Nut 14 F Screw 15 F Filter Retainer Guard 16 F Nut 1 Phase 17 F Buzzer 220 Volt 18 F Motor Switch 1 Phase 19 F Standoff 20 F Motor Switch Bracket 1 Phase 21 F Screw 1 Phase F

14 Control Module - Models UW35P2 and UW35P3 (Drawing 3 of 4) PHM2548P_F F232165

15 Control Module - Models UW35P2 and UW35P3 (Drawing 3 of 4) REF PART NO. DESCRIPTION COMMENTS 1 F140575P Connector Gray 1 F140576P Connector Blue 2 F P Fuse Holder Models starting 5/12/03 2 F Fuse Models starting 5/12/03; 2 Amp; Slo blo 2 F Circuit Breaker Models through 5/11/03; 1 Amp; Fast blo 3 F Signal Light Red; 220 Volt 4 F Switch Mode Decal Models starting 5/12/03 4 F Switch Mode Decal Models through 5/11/03 5 F Cable Assembly 6 F Nut 7 F Insulator Bushing 8 F Input Block Decal 9 F Input Power Block 10 F Screw 11 F Ground Terminal Lug 12 F Washer 13 F Screw 14 F Resistor 12k; 5w 15 F Terminal Block 8 place 16 F Screw 17 F Ground Decal 18 F Fuse 3 Amp; Fast blo 19 F Fuse Holder 20 F Washer 21 F Nut 22 F Personal Injury Warning Decal 23 F340800P Keymode Run/Program Switch Includes item F Program Key A153 F

16 Control Module - Models UW35P2 and UW35P3 (Drawing 4 of 4) PHM2061P_F F232165

17 Control Module - Models UW35P2 and UW35P3 (Drawing 4 of 4) REF PART NO. DESCRIPTION COMMENTS 1 F P Water Level Switch 2 F422404P Tubing 3 F Connector 4 F Air Trap Hose 5 F Hose Clamp No F381723P 4-Way Valve 220 Volt 6 G582P3 Diaphragm and Guide Kit 7 F Snap Bushing F

18 Control Module - Model UW35B2 (Drawing 1 of 3) Standard Models Models with Electric Heat PHM2439P_F F232165

19 Control Module - Model UW35B2 (Drawing 1 of 3) REF PART NO. DESCRIPTION COMMENTS 1 F Contact Block Switch 800E-series; Models through 9/30/07; Includes F Contact Block Switch 1 F Contact Block Switch 800E-series 1 F Contact Block Switch 800F-series; Models starting 10/1/07; Includes F Contact Switch and F Contact Base 1 F Contact Switch Models starting 10/1/07 1 F Contact Base Models starting 10/1/ Screw 3 N/A Control Mounting Panel Assembly Disconnect Power Warning Label 5 F Control Module Cover 6 F Cable Tray Cover 7 F Screw 8 F Washer 9 F Cable Tray Assembly 10 F External Supply Box 11 F External Supply Box Cover 12 F Air Trap Hose 13 F Connector 14 F422404P Tubing 15 F P Water Level Switch 3 level 16 F Hose Clamp No F Tee 18 F P Water Pressure Switch 1 level 19 F Ribbon Cable 26 pin; 8 inch 20 F P Computer 21 F381723P 4-Way Valve 21 G582P3 Diaphragm and Guide Kit 22 F Snap Bushing 23 F Screw 24 F Nut 25 F Control Cover Screw 27 F Washer 28 F Washer 29 F Momentary Switch Models through 5/26/04 29 F Momentary Switch Models starting 5/27/04 30 N/A Emergency Stop Pushbutton 800E-series; Models through 9/30/07 30 F P Emergency Stop Button Kit Used to convert from 800E-series to 800F-series; Includes F Contact Block Switch and F Emergency Stop Pushbutton 30 F Emergency Stop Pushbutton 800F-series; Models starting 10/1/07 31 F P Keypad 32 F Control Module Decal N/A = Part no longer available F

20 Control Module - Model UW35B2 (Drawing 2 of 3) PHM2122P_F F232165

21 Control Module - Model UW35B2 (Drawing 2 of 3) REF PART NO. DESCRIPTION COMMENTS NA F P Computer and Door Lock Harness 1 F Screw 2 F Output Board Cover 3 F Nut 4 F Output CCA 5 F Ribbon Cable 26 pin; 8 inch 6 F Standoff 7 F Fuse 1.6 Amp; Slo blo 7 F Fuse 1/2 Amp; Fast blo 7 F Fuse 1/8 Amp; Slo blo 8 F Screw 1 Phase 9 F Switch Clamp 1 Phase 10 F330177P Contactor 11 F330186P Interlock Contactor 12 F DIN Contactor Mounting Rail 13 F Screw 14 F P Circuit Breaker F-voltage 15 F Flange Relay 16 F Nut 1 Phase 17 F Screw 18 F Motor Switch 1 Phase F

22 Control Module - Model UW35B2 (Drawing 3 of 3) PHM1934P_F F232165

23 Control Module - Model UW35B2 (Drawing 3 of 3) REF PART NO. DESCRIPTION COMMENTS 1 F Insulator Bushing 2 F Ground Terminal Lug 3 F Input Power Decal 4 F Input Power Block 5 F Nut 6 F Washer 7 F Nut 8 F Ground Decal 9 F Nut 10 F Terminal Block 11 F External Supply Connection Decal O-voltage 11 F External Supply Connection Decal F-voltage 12 F Screw 13 F Screw 14 F Screw F

24 Supply Dispenser PHM3243P_F F232165

25 Supply Dispenser REF PART NO. DESCRIPTION COMMENTS 1 F Screw 2 F Washer 3 F Dispenser Lid 4 F Plug Cap 5 F Strain Relief Adapter Kit Includes items 6 and 7 6 F O-Ring 7 F140340P Strain Relief Connector Includes F Nut and F Strain Relief Connector 8 F Chemical Supply Cup 20 ounce; 3 used 9 F Supply Dispenser Spacer 10 F Chemical Supply Cup 32 ounce; 2 used 11 F Hose Clamp No F Chemical Supply Hose 13 F Nut Loctite 262 required for installation 14 F Washer 15 F Supply Dispenser Hazard Caution Decal 16 F Soap Dispenser Shroud Weldment 17 F170158P Gasket 18 F170400RP Trim 19 F P Dispenser Assembly Includes items 3 and F Injection Nozzle 21 F O-Ring Nut 23 F Injection Nozzle Kit Includes items F

26 Spray Plumbing - Design 5 UW35P2 and UW35P3 Models PHM1930P_F F232165

27 Spray Plumbing - Design 5 UW35P2 and UW35P3 Models REF PART NO. DESCRIPTION COMMENTS NA F141901P DIN Harness Assembly Use with F381703P Valve NA F DIN Valve Adapter Kit Use with F Valve NA F P Valve Transition Kit Use with F Valve 1 F Street Elbow 2 F Nipple 3 F Tube Connector 4 F P Vacuum Breaker Valve 3/4 inch; F380965P Repair Kit 5 F Tee 6 F Nipple 7 F P Valve Replaces F381703P Valve; Includes F Valve, F DIN Valve Adapter Kit and F Coil 8 F380987P DIN Coil 220 Volt; Use with F381703P Valve 8 F Coil Use with F Valve 9 F Hose Adapter Standard thread 9 F Nipple Metric thread Washer Washer 12 F Water Hose Standard thread 12 F Water Hose Metric thread 13 F200401P U-Bolt Clamp Includes hardware 14 F Nipple 15 F Street Elbow 16 F Spray Plumbing Assembly 220 Volt; Includes items 1-9, 14 and F Spray Plumbing Assembly 220 Volt; Metric thread; Includes items 1-9, 14 and 15 F

28 Spray Plumbing - Design 7 and 8 UW35P2 and UW35P3 Models PHM2062P_F F232165

29 Spray Plumbing - Design 7 and 8 UW35P2 and UW35P3 Models REF PART NO. DESCRIPTION COMMENTS NA F141901P DIN Harness Assembly Use with F381703P Valve NA F DIN Valve Adapter Kit Use with F Valve NA F P Valve Transition Kit Use with F Valve 1 F Elbow 2 F Nipple 3 F Tube Connector 4 F Screw 5 F Vacuum Breaker Cap 6 F Containment Device 7 F O-Ring 8 F P Vacuum Breaker Valve 3/4 inch; Includes items 4-7; F380965P Repair Kit 8 F Vacuum Breaker Kit Includes items F Nipple 10 F Tee 11 F P Valve Replaces F381703P Valve; Includes F Valve, F DIN Valve Adapter Kit and F Coil 12 F380987P DIN Coil 220 Volt; Use with F381703P Valve 12 F Coil Use with F Valve 13 F Hose Adapter Standard thread 13 F Nipple Metric thread Washer Washer 16 F Water Hose Standard thread 16 F Water Hose Metric thread 17 F200401P U-Bolt Clamp Includes hardware 18 F Nipple 19 F Street Elbow 20 F Spray Plumbing Assembly 220 Volt; Includes items 1-13, 18 and F Spray Plumbing Assembly 220 Volt; Metric thread; Includes items 1-13, 18 and 19 F

30 Fill Plumbing - Design 5 UW35P2 and UW35P3 Models Through 3/02 PHM2293P_F F232165

31 Fill Plumbing - Design 5 UW35P2 and UW35P3 Models Through 3/02 REF PART NO. DESCRIPTION COMMENTS NA F141901P DIN Harness Assembly Use with F381703P Valve NA F DIN Valve Adapter Kit Use with F Valve NA F P Valve Transition Kit Use with F Valve 1 F Street Elbow 2 F Nipple 3 F P Valve Replaces F381703P Valve; Includes F Valve, F DIN Valve Adapter Kit and F Coil 3 F381703P Valve 220 Volt; 1/2 inch; F380993P Valve Repair Kit; Parker 4 F380987P DIN Coil 220 Volt; Use with F381703P Valve 4 F Coil Use with F Valve 5 F Tee 6 F Plug 7 F Hose Adapter Standard thread 7 F Nipple Metric thread Washer Washer 10 F Water Hose Standard thread 10 F Water Hose Metric thread 11 F Hose Barb 12 F Gate Valve 13 F Nipple 14 F Water Hose 15 F Hose Clamp No F200401P U-Bolt Clamp Includes hardware 17 F Hose Clamp No F200104P Hose 19 F Hose Barb 20 F380801P Antisiphon Valve 1/2 inch; Vacuum breaker valve; F380964P Repair Kit 21 F Fill Plumbing Assembly Standard thread; Includes items 1-7, 11-13, 19 and F Fill Plumbing Assembly Metric thread; Includes items 1-7, 11-13, 19 and 20 F

32 Fill Plumbing - Design 5 UW35P2 and UW35P3 Models Starting 4/02 PHM1776P_F F232165

33 Fill Plumbing - Design 5 UW35P2 and UW35P3 Models Starting 4/02 REF PART NO. DESCRIPTION COMMENTS NA F Fill Plumbing Assembly 220 Volt; Standard thread; Includes items 9, 12-16, 20-24, 27 and 28 NA F Fill Plumbing Assembly 220 Volt; Metric thread; Includes items 9, 12-16, 20-24, 27 and 28 NA F Fill Plumbing Assembly 220 Volt; Standard thread; Starch; Includes items 3-10, 12-16, 20-24, 27 and 28 NA F Fill Plumbing Assembly 220 Volt; Metric thread; Starch; Includes items 3-10, 12-16, 20-24, 27 and 28 NA F141901P DIN Harness Assembly Use with F381703P Valve NA F380993P Valve Repair Kit Starch models; 1/2 inch; Use with F381703P Valve NA F DIN Valve Adapter Kit Use with F Valve NA F P Valve Transition Kit Use with F Valve Washer 2 F Water Hose Standard thread 2 F Water Hose Metric thread 3 F380987P DIN Coil 220 Volt; Starch models; Use with F381703P Valve 3 F Coil Use with F Valve 4 F Gate Valve Starch models 5 F Street Elbow Starch models 6 F Nipple Starch models 7 F P Valve Replaces F381703P Valve; Includes F Valve, F DIN Valve Adapter Kit and F Coil 8 F Hose Barb Starch models 9 N/A Nipple Starch models Washer 11 F Hose Adapter Standard thread 11 F Nipple Metric thread 12 F Tee Starch models 13 F Nipple Starch models 14 F Nipple 15 F200401P U-Bolt Clamp Includes hardware 16 F Hose Clamp No F200104P Hose 18 F Street Elbow 19 F380801P Antisiphon Valve 1/2 inch; Vacuum breaker 19 F380964P Repair Kit 1/2 inch 20 F Hose Barb 21 F Water Hose 22 F Hose Clamp No F Gate Valve N/A = Part no longer available F

34 Fill Plumbing - Design 7 and 8 Models PHM2063P_F F232165

35 Fill Plumbing - Design 7 and 8 Models REF PART NO. DESCRIPTION COMMENTS NA N/A Fill Plumbing Assembly 220 Volt; Standard thread; Includes items 9, 12, 15, 16, 20-31, 34 and 35 NA F Fill Plumbing Assembly 220 Volt; Metric thread; Includes items 9, 12, 15, 16, 20-31, 34 and 35 NA N/A Fill Plumbing Assembly 220 Volt; Standard thread; Starch; Includes items 3-16, 20-31, 34 and 35 NA N/A Fill Plumbing Assembly 220 Volt; Metric thread; Starch; Includes items 3-16, 20-31, 34 and 35 NA F141901P DIN Harness Assembly Use with F381703P Valve NA F380993P Valve Repair Kit Starch models; 1/2 inch; Use with F381703P Valve NA F DIN Valve Adapter Kit Use with F Valve NA F Valve Transition Kit Use with F Valve Washer 2 F Water Hose Standard thread 2 F Water Hose Metric thread 3 F380987P DIN Coil 220 Volt; Starch models; Use with F381703P Valve 3 F Coil Use with F Valve 4 F Gate Valve Starch models 5 F Street Elbow Starch models 6 F Nipple Starch models 7 N/A Nipple Starch models 8 F P Valve Replaces F381703P Valve; Includes F Valve, F DIN Valve Adapter Kit and F Coil 9 F Hose Barb Starch models Washer 11 F Hose Adapter Standard thread 11 F Nipple Metric thread 12 F Tee Starch models 13 F Nipple 14 F200401P U-Bolt Clamp Includes hardware 15 F Hose Clamp No F200104P Hose 17 F Elbow 18 F Nipple 19 F P Vacuum Breaker Valve 3/4 inch; Includes item 29; F380965P Repair Kit 20 F O-Ring 21 F Containment Device 22 F Vacuum Breaker Cap 23 F Screw 24 F Vacuum Breaker Kit Includes items and installation instructions 25 F Hose Barb 26 F Street Elbow 27 F Water Hose 28 F Hose Clamp No F Gate Valve N/A = Part no longer available F

36 Drain Valve and Hoses PHM2612P_F F232165

37 Drain Valve and Hoses REF PART NO. DESCRIPTION COMMENTS 1 F Overflow Hose 2 F Hose Clamp No F Drain Connector Tee 4 F Hose Clamp No F Overflow Hose 6 F Nut 7 F Screw 8 F Washer 9 F Drain Hose Rear 10 F Nut Gravity Drain Valve 220 Volt 11 F Drain Valve Body 11 F Main Drive Kit 11 F380933P Drain Valve Motor 220 Volt 12 F Drain Valve Cover 13 F Drain Hose 14 M Washer F

38 Basket and Shell PHM2549P_F F232165

39 Basket and Shell REF PART NO. DESCRIPTION COMMENTS 1 F Shell Front Assembly Includes shell front weldment, door bumper moulding, door bumper bushing, top latch bracket casting, lower door latch bracket casting, door latch bracket shim, door butt and door butt shim 1 F Shell Front Kit Includes shell front weldment and F Hot Surface Warning Decal 2 F Shell Front Gasket Kit Includes items 4-6, F170125P Shell Band Seal, F P Shell Band Gasket and F Clear Sealant 3 F Shell Band Kit Includes items 4-6 and F Shell Band Assembly 4 F Nut 5 F Washer 6 F Screw 7 N/A Screw 8 F Basket Assembly Models UW35B2 and UW35P2; Includes item 9 8 F Basket Assembly Model UW35P3; Includes item 9 9 F P Shaft Seal Sleeve Models UW35B2 and UW35P2 9 F P Shaft Seal Sleeve Model UW35P3 10 F Control Transformer Cover F-voltage 11 F Screw F-voltage 12 F360156P Transformer F-voltage 13 F Nut 14 M Washer 15 F Shell Mounting Bracket 16 F Shell Assembly Models UW35B2 and UW35P2; Standard 16 F Shell Weldment Models UW35B2 and UW35P2; Electric heat 16 F Shell Assembly Model UW35P3; Standard 16 F Shell Weldment Model UW35P3; Starch 16 F Shell Weldment Model UW35P3; Electric heat 17 F Shell Band Fastener Kit Includes items 4-6 N/A = Part no longer available F

40 Door and Spray Rinse PHM2703P_F F232165

41 Door and Spray Rinse REF PART NO. DESCRIPTION COMMENTS 1 F Screw Models UW35P2 and UW35P3 2 F Spray Rinse Strap Models UW35P2 and UW35P3 3 F Spray Rinse Tube Assembly Models UW35P2 and UW35P3 4 F Ring Retainer Models UW35P2 and UW35P3 5 F Swivel Coupling Models UW35P2 and UW35P3 6 F602901P Spray Rinse Bracket Assembly Includes items 1 and 7; Models UW35P2 and UW35P3 7 F Nut Models UW35P2 and UW35P3 8 F O-Ring Models UW35P2 and UW35P3 9 F Retainer Ring Spinning 10 F290203P Glass Without hole; Model UW35B2 10 F290202P Glass Kit With hole; Models UW35P2 and UW35P3 11 F Spray Rinse Nozzle Kit Models UW35P2 and UW35P3 12 F Door Glass Gasket 13 F Nut 14 F P Door Hinge Strap Kit Includes item F Door Hinge Pin 16 F Door Butt Shim 17 F Door Hinge Strap 18 F Stud Weldment 18 F P Door Assembly Includes items 9, 10, 13, 17, 21, 23, F Handle Assembly, F Door Glass Gasket, F Screw and F Washer; Models UW35P2 and UW35P3 19 F Door Bracket Latch Shim 20 F Door Latch Bracket Shim 21 F Washer 22 F150201P Top Latch Bracket Casting 23 F Door Gasket Black 23 F Door Gasket Gray 24 F Lower Door Latch Bracket Casting 25 F Nut 26 F Lower Door Latch Casting 27 F Screw 28 F Washer 29 F Screw 30 F Extension Arm Kit Includes items 25, 28 and F Door Handle Casting 32 F Elbow Models UW35P2 and UW35P3 33 F No-Swivel Coupling Models UW35P2 and UW35P3 34 F Spray Rinse Hose Kit Includes items 4, 5, 8 and 33; Models UW35P2 and UW35P3 35 F Extension Models UW35P2 and UW35P3 F

42 Door Box PHM2053P_F F232165

43 Door Box REF PART NO. DESCRIPTION COMMENTS 1 F Screw 2 F Screw 3 F Interlock Switch 4 F Nut 5 F Washer 6 F Washer 7 F Magnetic Switch Assembly 8 F Nut 9 F Door Box Mounting Plate Assembly 10 F300129P Door Lock Solenoid 220 Volt 11 F330217P RC Network Filter Includes F Connector and F Connector 12 F Solenoid Spacer 13 F Door Box 14 F Interlock Switch Spacer 15 F Washer 16 F Nut 17 F Door Box Assembly 18 F Magnet 19 F Nut 20 F Screw 21 F Push Decal 22 F Push Handle Kit F

44 Panels PHM2474P_F F232165

45 Panels REF PART NO. DESCRIPTION COMMENTS 1 F Screw 2 F P Side Panel Reversible 3 F Nut Tinnerman Screw 5 F Control Module Cover 6 F170400RP Trim 7 F Cage Wrap Weldment 8 F Nut 9 F Hose Strap 10 F Screw 11 F P Rear Panel 12 F Belt Inspection Port Cover 13 F Nut 14 F Washer 15 F Screw 16 F Nut 17 F Washer 18 F635660P Front Panel 19 F Screw 20 F Extrusion Insert Order 3 feet 21 F Rub Rail F

46 Frame PHM1924P_F F232165

47 Frame REF PART NO. DESCRIPTION COMMENTS 1 M Washer 2 F Screw 3 F Frame Assembly Models UW35B2 and UW35P2 3 F Frame Assembly Model UW35P3 4 F Nut 5 M Washer Nut 7 F Screw 8 F Shell Mounting Bracket F

48 Pulley and Trunnion Assembly PHM1695P_F F232165

49 Pulley and Trunnion Assembly REF PART NO. DESCRIPTION COMMENTS 1 F Screw 2 F Triple Lip Seal Models UW35B2 and UW35P2 2 F Triple Lip Seal Model UW35P3 3 F100123P Bearing Models UW35B2 and UW35P2; RS C3; Front 3 F Bearing Model UW35P3; RS C3; Front 4 F Trunnion Kit Models UW35B2 and UW35P2; Includes F Shell Front Gasket Kit and items 1, 5 and 6 4 F Trunnion Kit Model UW35P3; Includes F Shell Front Gasket Kit and items 1, 5 and 6 5 F Washer 6 F Nut 7 F Bearing Models UW35B2 and UW35P2; RS C3; Rear 7 F100123P Bearing Model UW35P3; RS C3; Rear 8 F Key 9 F Sheave Pulley Models UW35B2 and UW35P2; 3V220 9 F Pulley Model UW35P3; 2G3V F Belt Models UW35B2 and UW35P2; 1 required; 3V F Belt Model UW35P3; 2 required; 3V F Screw 12 F Washer F

50 Motor - Models UW35B2 and UW35P2 PHM2824P_F F232165

51 Motor - Models UW35B2 and UW35P2 REF PART NO. DESCRIPTION COMMENTS Washer 2 F Cotter Pin 3 F Nut 4 F Motor Drip Shield All voltage models except for Y-voltage 4 F Motor Drip Shield Y-voltage 5 F Motor Support Rod Model UW35B2 5 F Motor Support Rod Model UW35P2 6 F Screw 7 F Capacitor Bracket 8 F730344P Capacitor Kit 1 Phase; 160 MFD and 15K resistor 9 F Capacitor 1 Phase; 50 MFD 10 F Capacitor 1 Phase; 25 MFD 11 F Capacitor 1 Phase; 20 MFD 12 F Motor Support Bushing Nylon 13 F Key 14 F Motor Pulley 1DP-GR3V300X.875; Includes screw; 60 Hertz; 1 groove; 3.24 inch OD 15 F Extension Spring 16 F Clip 17 F P Motor Volt/60 Hertz/1 Phase; Includes item F P Motor Volt/60 Hertz/3 Phase; Includes item F P Motor Volt/50 Hertz/3 Phase; Volt/60 Hertz/3 Phase; Includes item N/A Motor Cover N/A = Part no longer available F

52 Motor - Model UW35P3 PHM2825P_F F232165

53 Motor - Model UW35P3 REF PART NO. DESCRIPTION COMMENTS 1 F Key 2 F Motor Drip Shield 3 F Cable Tie 4 F220410P Motor Wash; Volt 4 N/A Motor Harness Kit Wash; Volt 5 F Splice Harness Wash 6 F Key 7 F Splice Harness Extract 8 F Washer 9 M Washer Screw 11 F Motor Extract; Volt 11 N/A Motor Harness Kit Extract; Volt 12 M Washer 13 F Screw 14 F Pulley Extract; 4GR3V4.12; SH; 60 Hertz; 4 groove; 4.12 inch OD 15 F Pulley Bushing Extract; 1-1/8; SH 16 F280298P Pulley Bushing Wash; JA; 7/8 17 F Pulley Wash; 2GR3V3.15JA; 60 Hertz; 2 groove; 3.15 inch OD 18 F Belt 3VX315; 2 required N/A = Part no longer available F

54 Steam Heat Option and Transformer PHM2067P_F F232165

55 Steam Heat Option and Transformer REF PART NO. DESCRIPTION COMMENTS NA F Pipe Insulation NA F DIN Valve Adapter Kit Use with F P Valve NA F Valve Kit Use with F P Valve 1 F Plug 2 F Steam Injector Tube Assembly 3 F Steam Hose 4 H Street Elbow 5 F P Valve Replaces F380787P Steam Valve; Includes F Coil; For models that have been upgraded with F DIN Valve Kit 5 F DIN Valve Kit Replaces F380787P Steam Valve; Includes F Valve, F DIN Valve Adapter Kit and F Coil 6 F380987P DIN Coil 220 Volt; Use with F380787P Steam Valve 6 F Coil Use with F P Valve 7 F Control Transformer Cover 8 F360156P Transformer Control; F-voltage 9 F Screw 10 F200401P U-Bolt Clamp Includes hardware 11 F Nipple Models UW35B2 and UW35P2 11 F Nipple Model UW35P3 12 F Plug 13 F Steam Filter 14 F Nipple 15 F Steam Bracket Weldment 16 F Nut 17 F Steam Kit Models UW35B2 and UW35P2; Includes items 2-6 and F Steam Kit Model UW35P3 F

56 Electric Heat Option PHM1927P_F F232165

57 Electric Heat Option REF PART NO. DESCRIPTION COMMENTS 1 F360205P Element 6 required 2 F370606P Temperature Probe 3 F Nut 4 F Screw 5 F Box 6 F Input Power Block Volt 6 M Terminal Block Volt 7 F Screw 8 F330188P Contactor 220 Volt; NX208 9 F Washer F

58 Security Fasteners Option One Option Two PHM2181P_F F232165

59 Security Fasteners REF PART NO. DESCRIPTION COMMENTS 1 F Screw No. 8; 32 x 1/2 inch; Used in place of F Screw; Typical location is the side panels and module cover 1 F Screw No. 10; 32 x 3/8 inch; Used in place of F Screw; Typical location is the module to the shell 1 F Hex Bit 2 F Screw 1/4 inch; 20 x 2-1/2 inch; Used in place of F Screw; Typical location is the door box to the bracket 2 F Screw 1/4 inch; 20 x 1-1/2 inch; Used in place of F Screw; Typical location is the side panel to the bracket 2 F Screw 1/4 inch; 20 x 1/2 inch; Used in place of F Screw; Typical location is the drive box or the cover 2 F Spanner Bit 3 F Screw 1/4 inch; 20 x 2-1/2 inch; Used in place of F Screw; Typical location is the door box to the bracket 3 N/A Phillips Bit 4 N/A Screw 1/4 inch; 20 x 1/2 inch; Used in place of F Screw; Typical location is the drive box or cover 4 N/A Hex Bit 5 F Screw No. 8; 32 x 1/2 inch; Used in place of F Screw; Typical location is the side panels and module cover 5 281P4 Torx Bit N/A = Part no longer available F

60 Special Tools PHM2978P_F F232165

61 Special Tools REF PART NO. DESCRIPTION COMMENTS NA 1113P Concrete Hardware Kit 1 F Alignment Shaft Assembly 2 F Shaft Seal Alignment Fixture 3 F Bearing Removal Tool 4 F Rebar Frame Template 5 F Grease Gun Kit Includes items 6 and 7 6 F210206P Bearing Grease 7 F210207P Grease Gun F

62 Notes 60 F232165

63 Parts Index A Air Trap Hose F , 17 Alignment Shaft Assembly F Antisiphon Valve F380801P... 29, 31 B Basket Assembly F F Battery F Bearing F F F100123P Bearing Grease F210206P Bearing Removal Tool F Before Power Is Connected Tag F Belt F F F Belt Inspection Port Cover F Box F Buzzer F C Cable Assembly F Cable Tie F , 51 F Cable Tray Assembly F , 17 Cable Tray Cover F , 17 Cage Wrap Weldment F Capacitor F F F Capacitor Bracket F Capacitor Kit F730344P Chemical Supply Cup F F Chemical Supply Hose F Circuit Breaker F F F P...19 Clip F Clockwise Spin Rotation Decal F Coil F , 27, 29, 31, 33, 53 Cold Water Valve Decal F Computer F P...17 Computer and Door Lock Harness F P...19 Computer Cover F Computer Input Harness F Concrete Hardware Kit 1113P...59 Conductor Decal F Connector F140575P...13 F140576P...13 F , 17 Contact Base F , 17 Contact Block Switch F , 17 F F , 17 Contact Switch F , 17 Contactor F330177P...11, 19 F330188P...55 Containment Device F , 33 Control Cover F Control Module Cover F , 17, 43 Control Module Decal F F Control Transformer Cover F , 53 Cotter Pin F N/A items do not appear in index. F

64 D Diaphragm and Guide Kit G582P , 17 DIN Coil F380987P... 25, 27, 29, 31, 33, 53 DIN Contactor Mounting Rail F , 19 DIN Harness Assembly F141901P... 25, 27, 29, 31, 33 DIN Valve Adapter Kit F , 27, 29, 31, 33, 53 DIN Valve Kit F Disconnect Power Warning Label , 9, 17 Dispenser Assembly F P Dispenser Lid F Do Not Push Decal F Door Assembly F P Door Box F Door Box Assembly F Door Box Mounting Plate Assembly F Door Bracket Latch Shim F Door Butt Shim F Door Gasket F F Door Glass Gasket F Door Handle Casting F Door Hinge Pin F Door Hinge Strap F Door Hinge Strap Kit F P Door Latch Bracket Shim F Door Lock Solenoid F300129P Drain Connector Tee F Drain Hose F F Drain Valve Body F Drain Valve Cover F Drain Valve Motor F380933P E Elbow F , 33 F Electrical Access Panel F F Element F360205P...55 Emergency Stop Button Kit F P...9, 17 Emergency Stop Pushbutton F , 17 Extension F Extension Arm Kit F Extension Spring F External Supply Box F , 17 External Supply Box Cover F F External Supply Connection Decal F F F Extrusion Insert F F Fill Plumbing Assembly F F , 31 F , 31 F F Filter Retainer Guard F Flange Relay F , 19 Frame Assembly F F Front Panel F635660P...43 Fuse F , 19 F , 19 F F F F Fuse Holder F F P...13 N/A items do not appear in index. 62 F232165

65 G Gasket F170158P Gate Valve F , 31, 33 Glass F290203P Glass Kit F290202P Gravity Drain Valve Grease Gun F210207P Grease Gun Kit F Ground Decal F , 21 Ground Terminal Lug F , 21 H Hex Bit F Hose F200104P... 29, 31, 33 Hose Adapter F , 27, 29, 31, 33 Hose Barb F , 31, 33 F F , 33 Hose Clamp F , 31, 33 F , 35 F , 17, 35 F , 31, 33 Hose Strap F Hot Surface Warning Decal F F Hot Water Valve Decal F I Injection Nozzle F Injection Nozzle Kit F Input Block Decal F Input Power Block F F , 21 Input Power Decal F Insulator Bushing F , 21 Interlock Contactor F330186P...11, 19 Interlock Switch F Interlock Switch Spacer F J Jumper Kit F784003P...11 K Key F F , 51 F Keymode Run/Program Switch F340800P...13 Keypad F P...17 Keypad Decal F230724P...9 L Lower Door Latch Bracket Casting F Lower Door Latch Casting F M Magnet F Magnetic Switch Assembly F Main Drive Kit F Momentary Switch F , 17 F , 17 Motor F220410P...51 F F P...49 F P...49 F P...49 Motor Drip Shield F , 51 F Motor Pulley F Motor Support Bushing F N/A items do not appear in index. F

66 Motor Support Rod F F Motor Switch F , 19 Motor Switch Bracket F N Nipple F , 27, 29, 31, 33 F , 27, 29, 31, 33 F , 27, 33 F F F F , 27, 29, 31, 33 No-Swivel Coupling F Nut F F , 45 F , 43 F , 41, 43, 49, 53, 55 F , 11, 21, 41 F , 19, 41 F F F , 13, 17, 21 F F F F , 39 F F F O O-Ring F , 33 F F F Output Board Cover F Output CCA F F P Overflow Hose F F Overload Contactor F P P Personal Injury Warning Decal F , 13 Pipe Insulation F Plug F F F Plug Cap F Program Key F Pulley F F F Pulley Bushing F F280298P...51 Push Decal F Push Handle Kit F N/A items do not appear in index. 64 F R RC Network Filter F330217P...41 Rear Panel F P...43 Rebar Frame Template F Repair Kit F380964P...31 Resistor F Retainer Ring Spinning F Ribbon Cable F140219P...9, 11 F , 19 Ring Retainer F Rub Rail F S Screw F F F F F F F , 51 F F F F , 13, 19 F F , 13, 21 F , 17, 23, 39, 41 F F

67 F F , 47 F , 11, 17, 19 F , 49, 53 F , 27, 33, 55 F F F F F F F F F F , 17, Shaft Seal Alignment Fixture F Shaft Seal Sleeve F P F P Sheave Pulley F Shell Assembly F F Shell Band Fastener Kit F Shell Band Kit F Shell Front Assembly F Shell Front Gasket Kit F Shell Front Kit F Shell Mounting Bracket F , 45 Shell Weldment F F F Side Panel F P Signal Light F Snap Bushing F , 17 Soap Dispenser Shroud Weldment F Solenoid Spacer F Spanner Bit F Splice Harness F F Spray Plumbing Assembly F F F F Spray Rinse Bracket Assembly F602901P...39 Spray Rinse Hose Kit F Spray Rinse Nozzle Kit F Spray Rinse Strap F Spray Rinse Tube Assembly F Standoff F F Steam Bracket Weldment F Steam Filter F Steam Hose F Steam Injector Tube Assembly F Steam Kit F F Strain Relief Adapter Kit F Strain Relief Connector F140340P...23 Street Elbow F , 27, 29, 31, 33 F H Stud Weldment F Supply Dispenser Hazard Caution Decal F , 23 Supply Dispenser Spacer F Switch Clamp F Switch Mode Decal F F Swivel Coupling F N/A items do not appear in index. F T Tee F , 29, 31, 33 F F Temperature Probe F370606P...55 Terminal Block F , 21 M This Machine Must Be Protected Decal F Tie Wrap Mounting Clamp F Top Latch Bracket Casting F150201P...39

68 Torx Bit 281P Transformer F360156P... 37, 53 Trim F170400RP... 23, 43 Triple Lip Seal F F Trunnion Kit F F Tube Connector F , 27 Tubing F422404P... 15, 17 F M , 45, 51 M , 45, , 27, 29, 31, , 27, 29, 31, Water Hose F , 27, 29, 31, 33 F , 27, 29, 31, 33 F , 31, 33 Water Level Switch F P...15, 17 Water Pressure Switch F P...17 WE-6 Computer F P...9 U U-Bolt Clamp F200401P... 25, 27, 29, 31, 33, 53 V Vacuum Breaker Cap F , 33 Vacuum Breaker Kit F , 33 Vacuum Breaker Valve F P... 25, 27, 33 Valve F381703P F P F P... 25, 27, 29, 31, 33 Valve Kit F Valve Repair Kit F380993P... 31, 33 Valve Transition Kit F F P... 25, 27, 29, 31 Valve, 4-Way F381723P... 15, 17 W Washer F F F F , 43 F , 41, 43 F F , 21 F , 13, 17 F , 17 F F , 17 F F F F , 35 N/A items do not appear in index. 66 F232165