Homestyle Automatic Washers

Transcription

1 Homestyle Automatic Washers Parts Refer to Page 3 for Model Numbers W001C_ Part No R5 February 2018

2

3 Table of Contents Title Page Parts Ordering Information... 2 Serial Plate Location... 2 Model Identification... 3 Graphic Panel, Control Support Panel and Controls (Drawing 1 of 2)... 4 Graphic Panel, Control Support Panel and Controls (Drawing 2 of 2)... 6 Lid Switch Assembly... 8 Top, Lid and Hood Back Panel Fill Hose, Mixing Valve-to-Tub Cover Hose, Mixing Valve and Bracket Motor, Mounting Bracket, Belt, Pump and Idler Assembly Agitator, Fabric Softener Dispenser, Drive Bell, Hub and Lip Seal Kit and Washtub Outer Tub, Cover, Pressure Hose and Counterweight Outer Tub, Cover, Bearing and Seal Housing, Pressure Hose and Counterweight Drain Hose and Siphon Break Kit Weldment and Bearing Assembly, Brake and Pulley Transmission Assembly Front Panel, Base Assembly and Cabinet Kit Mixing Valve and Motor Connection Blocks, Terminals and Extractor Tool Lead-In Cord and Terminals Terminals Shipping Materials and Special Tools Special Tools Output Board, Wire Harnesses and Wires Parts Index Copyright 2018, Alliance Laundry Systems LLC All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed written consent of the publisher

4 If literature or replacement parts are required, contact the source from whom the machine was purchased or contact Alliance Laundry Systems at (920) for the name and address of the nearest authorized parts distributor. Parts Ordering Information For technical assistance, call the number listed below: (920) Ripon, Wisconsin When calling or writing about your product, be sure to mention model and serial numbers. Model and serial numbers are located on serial plate(s) as shown. Serial Plate Location Serial Plate W429S_

5 Model Identification Information in this manual is applicable to these washer models: LWN432SP113TW01 LWN432SP113TW04 LWN432SP115TW01 LWNA52SP113TW01 LWNE22SP115TW01 LWNE52PP113TW01 LWNE52SP113TW01 LWNE52WP113TW01 PWNE12PP115TG01 PWNE32PP113TG01 YWNE22PP115TW01 YWNE52PP113TW

6 Graphic Panel, Control Support Panel and Controls (Drawing 1 of 2) Models LWN432SP113TW01, LWN432SP113TW04 and LWN432SP115TW01 W320P_

7 Graphic Panel, Control Support Panel and Controls (Drawing 1 of 2) REF PART NO. DESCRIPTION COMMENTS 1 D504009WP End Panel White; Left 2 D Screw W Top Cover White Screw Temperature Switch 3 position Pressure Switch Model LWN432SP115TW Pressure Switch Models LWN432SP113TW01 and LWN432SP113TW P Timer Models LWN432SP113TW04 and LWN432SP115TW P Timer Model LWN432SP113TW01 8 D504008WP End Panel White; Right Hold-Down Clip W Graphic Panel White; Model LWN432SP115TW W Graphic Panel White; All other models Control Support Panel Grounding Clip W Timer Skirt Assembly White W Timer Knob White Knob Assembly White; Models LWN432SP113TW01 and LWN432SP113TW W Knob Assembly White

8 Graphic Panel, Control Support Panel and Controls (Drawing 2 of 2) Models LWNA52SP113TW01, LWNE22SP115TW01, LWNE52PP113TW01, LWNE52SP113TW01, LWNE52WP113TW01, PWNE12PP115TG01, PWNE32PP113TG01, YWNE22PP115TW01 and YWNE52PP113TW01 TLW1784P_

9 Graphic Panel, Control Support Panel and Controls (Drawing 2 of 2) REF PART NO. DESCRIPTION COMMENTS 1 D504007P End Panel Left; Models PWNE12PP115TG01 and PWNE32PP113TG01 1 D504009WP End Panel Left; All other models 2 D Screw DG Top Cover Models PWNE12PP115TG01 and PWNE32PP113TG W Top Cover All other models Screw 5 D504006P End Panel Right; Models PWNE12PP115TG01 and PWNE32PP113TG01 5 D504008WP End Panel Right; All other models Control Support Panel P Control Assembly Includes item 8; Model LWNA52SP113TW Control Assembly Includes item 8; Model PWNE32PP113TG Control Assembly Includes item 8; Models LWNE22SP115TW01 and YWNE22PP115TW Control Assembly Includes item 8; Model PWNE12PP115TG P Control Assembly Includes item 8; All other models Overlay Model LWNA52SP113TW Overlay Model PWNE32PP113TG Overlay Models LWNE22SP115TW01 and YWNE22PP115TW Overlay Model PWNE12PP115TG Control Overlay All other models Graphic Panel Models PWNE12PP115TG01 and PWNE32PP113TG Graphic Panel Models YWNE22PP115TW01 and YWNE52PP113TW Graphic Panel All other models Hold-Down Clip

10 Lid Switch Assembly TLW1832B_

11 Lid Switch Assembly REF PART NO. DESCRIPTION COMMENTS Lid Switch Assembly 2 M Screw 3 M Nut Screw Switch

12 Top, Lid and Hood Back Panel TLW1823P_

13 Top, Lid and Hood Back Panel REF PART NO. DESCRIPTION COMMENTS NA Hinge Gasket W Lid White; Model LWNA52SP113TW DG Lid Models PWNE12PP115TG01 and PWNE32PP113TG WP Lid White; All other models Lid Warning Label Pressure Sensor All models except LWN432SP113TW01, LWN432SP113TW04 and LWN432SP115TW Hood Back Panel Model LWN432SP113TW Hood Back Panel Model LWN432SP115TW Hood Back Panel All other models Screw 5 B Pressure Switch Model LWN432SP113TW Tubing Model LWN432SP113TW Barbed Tee Model LWN432SP113TW Screw Bushing 10 D Warning Label Strain Relief Hold-Down Clip Inlet Cover Inlet Deflector Hinge Stop Clip Screw WP Top Assembly White; Model LWNA52SP113TW DG Top Models PWNE12PP115TG01 and PWNE32PP113TG WP Top White; All other models Bleach Dispenser Model LWNA52SP113TW Bleach Dispenser All other models Lid Hinge Right Lid Hinge Left; Model LWNA52SP113TW Lid Hinge Left; All other models Bumper

14 Fill Hose, Mixing Valve-to-Tub Cover Hose, Mixing Valve and Bracket C H TLW1799P_

15 Fill Hose, Mixing Valve-to-Tub Cover Hose, Mixing Valve and Bracket REF PART NO. DESCRIPTION COMMENTS Mixing Valve-to-Tub Cover Hose Model LWNA52SP113TW Valve to Inlet Hose All other models Screw Hose Clamp Mixing Valve Mounting Bracket Washer Filter screen Washer Flow restrictor; Water pressure reducer; Available for water pressure up to but not exceeding 120 psi 6 F Water Hose Washer Mixing Valve Screen P Mixing Valve Model LWNA52SP113TW P Mixing Valve All other models Screw Hose Clamp

16 Motor, Mounting Bracket, Belt, Pump and Idler Assembly TLW1773P_

17 Motor, Mounting Bracket, Belt, Pump and Idler Assembly REF PART NO. DESCRIPTION COMMENTS Motor Shield Screw Motor Assembly 2 speed; 120Volt/60 Hertz; Model LWNA52SP113TW P Motor Kit 2 speed; 120Volt/60 Hertz; All other models Nut Motor Mount Bracket Idler Lever Spring Model LWNA52SP113TW Idler Lever Spring All other models Nut Idler Lever Washer Screw Idler Shaft 12 D Washer Washer Nylatron Retaining Ring P Idler Pulley P3 Idler Lever Kit Includes items 4, 7-8, 11-15, Idler Lever Spring and Agitate and Spin Belt Agitate and Spin Belt Model LWNA52SP113TW Agitate and Spin Belt All other models P Pump P Pump Assembly Heavy duty 19 RB Belt and Pump Kit Includes P Pump and Agitate and Spin Belt Spring Clip Screw Nut Isolator Post Motor Mount Capacitor Screw Screw Motor Drip Shield Capacitor Clamp Washer Motor Mount

18 Agitator, Fabric Softener Dispenser, Drive Bell, Hub and Lip Seal Kit and Washtub TLW1805P_

19 Agitator, Fabric Softener Dispenser, Drive Bell, Hub and Lip Seal Kit and Washtub REF PART NO. DESCRIPTION COMMENTS Screw Washer Rubber; Use with porcelain washtub Balance Ring Assembly P Tub Assembly White porcelain; Model LWNE52WP113TW Tub Assembly Stainless steel; Model LWNA52SP113TW P3 Washtub Kit Stainless steel; Models LWN432SP113TW01, LWN432SP113TW04 and LWNE52SP113TW P Tub Kit Blue porcelain; Models LWNE52PP113TW01, PWNE12PP115TG01, PWNE32PP113TG01 and YWNE52PP113TW Washtub Gasket 6 766P3A Hub and Lip Seal Kit DO NOT use any sealant other than P Sealant; Includes item 10 and installation tool P Sealant Use with hub and lip seal kit Spline Insert Nut Bell and Transmission Tube Seal P Drive Bell and Seal Kit Includes items 9, 11 and Screw Bell Plug Flex Vane Agitator Fabric Softener Dispenser Assembly

20 Outer Tub, Cover, Pressure Hose and Counterweight Model LWNA52SP113TW01 TLW1806P_

21 Outer Tub, Cover, Pressure Hose and Counterweight REF PART NO. DESCRIPTION COMMENTS Tub Cover and Gasket Assembly Includes item Tub Cover Gasket P Tub Assembly Includes 28944RP Lower Bearing Leg Spring Use to replace two rear springs (closest to counterweight) Leg Plate Screw Leg Spring Screw Counterweight Assembly Washer 11 D Warning Label Grommet Pressure Bulb Hose Clamp Hose Clip Cable Clip Tubing

22 Outer Tub, Cover, Bearing and Seal Housing, Pressure Hose and Counterweight Models LWN432SP113TW01, LWN432SP113TW04, LWN432SP115TW01, LWNE22SP115TW01, LWNE52PP113TW01, LWNE52SP113TW01, LWNE52WP113TW01, PWNE12PP115TG01, PWNE32PP113TG01, YWNE22PP115TW01 and YWNE52PP113TW01 TLW1464P_

23 Outer Tub, Cover, Bearing and Seal Housing, Pressure Hose and Counterweight REF PART NO. DESCRIPTION COMMENTS Tub Cover Assembly Includes item Tub Cover Gasket P Outer Tub Assembly Leg Plate Screw Leg Spring Screw Counterweight Assembly Washer P3A Hub and Lip Seal Kit P Sealant Use with hub and lip seal kit 11 D Warning Label Grommet Pressure Bulb Hose Clamp Hose Clip Cable Clip Tubing Model LWN432SP113TW Tubing All other models

24 Drain Hose and Siphon Break Kit Standpipe W329P_

25 Drain Hose and Siphon Break Kit REF PART NO. DESCRIPTION COMMENTS NA 451P3 Drain Extension Kit 1 562P3 Siphon Break Kit Siphon break kit MUST be installed in drain hose if drain receptacle is lower than cabinet top of washer Standpipe Strap Drain Hose Sleeve Standpipe Adapter Strain Relief Drain Hose Hose Stand 8 F Hose Clamp Tub-to-Pump Hose Retainer Clip

26 Weldment and Bearing Assembly, Brake and Pulley TLW1841P_

27 Weldment and Bearing Assembly, Brake and Pulley REF PART NO. DESCRIPTION COMMENTS Weldment and Bearing Assembly P Brake Kit 3 735P3 Brake Pad Kit Includes 3 pads and 6 of item P Silicone Grease Apply small amount to each new brake pad Screw Washer Thin Washer Thick Washer For machines experiencing squeaking during agitation; Through Serial Nos. beginning Washer Starting Serial Nos. beginning P Silicone Grease Apply small amount to washer Pulley Washer Screw Helix RP Lower Bearing

28 Transmission Assembly TLW1720P_

29 Transmission Assembly REF PART NO. DESCRIPTION COMMENTS NA 27604P Anti-Seize Compound Apply to smooth area of both the upper and lower transmission tube that will be contacting the upper and lower bearings and apply to spline area of upper and lower transmission tube that will be contacting the washtub NA 37577P Transmission Sealant Use between transmission case and cover P Output Shaft Hub Spacer Included in 766P3A Hub and Lip Seal Kit 3 RB Transmission Rebuild Kit Includes items 4, 17 and 37577P Transmission Sealant P Transmission Oil 1 fill Gear and Stud Assembly Screw Washer P Drive Pinion Use with 38826P Transmission Assembly Drive Pinion P Input Shaft Screw P Transmission Assembly Transmission Cover Assembly P Reduction Gear Use with 38826P Transmission Assembly P Reduction Gear Washer Screw Slide Rack Retaining Ring Agitator Pinion Washer Gear Sleeve Transmission Case Assembly

30 Front Panel, Base Assembly and Cabinet Kit GROUND WIRE TLW1842P_

31 Front Panel, Base Assembly and Cabinet Kit REF PART NO. DESCRIPTION COMMENTS NA 122P4P Porcelain Touch-Up Paint White NA P Paint Dark gray Bumper Pad Panel Locator Screw Bumper Pad Screw 6 D Screw Hold-Down Lug Hinge Warning Label DG Service Cabinet Kit Models PWNE12PP115TG01 and PWNE32PP113TG WP Service Cabinet Kit White; All other models Screw Leg and Stabilizer Assembly Screw Bracket Right Rubber Foot Base Assembly Leveling Leg Nut Friction Ring P3 Adjustable Leg Extension Kit Bracket Left Foam Pad Front Panel Pad Panel Locator Foam Pad Screw DG Front Panel Models PWNE12PP115TG01 and PWNE32PP113TG WP Front Panel White; All other models Hold-Down Clip Front Panel Brace

32 Mixing Valve and Motor Connection Blocks, Terminals and Extractor Tool W134PZ3A_

33 Mixing Valve and Motor Connection Blocks, Terminals and Extractor Tool REF PART NO. DESCRIPTION COMMENTS Circuit Plug Motor Female Terminal For 1 or 2 wire application Female Spade Terminal 1/4 inch Mixing Valve Plug Natural Mixing Valve Plug Red 5 283P4 Terminal Extractor Tool

34 Lead-In Cord and Terminals GROUND WIRE TLW1518P_

35 Lead-In Cord and Terminals REF PART NO. DESCRIPTION COMMENTS Position Housing Right; Black Female Terminal For 1 or 2 wire application SG Terminal 3 D Screw Insulated Female Spade Terminal Lead-In Cord Male Pin Terminal Circuit Plug Cable Clip Circuit Receptacle SG Female Pin Terminal Harness Strap Wire Tie

36 Terminals TLW1780P_

37 Terminals REF PART NO. DESCRIPTION COMMENTS Grounding Clip SG Terminal Grounding Clip Wire Clip 2 D Wire Clip Female Spade Terminal Large spade Terminal Tab Ring Terminal Small shank Ring Terminal Pressure Switch Terminal

38 Shipping Materials and Special Tools TLW1678P_

39 Shipping Materials and Special Tools REF PART NO. DESCRIPTION COMMENTS Shipping Brace Install whenever moving washer; Remove before use; Model LWNA52SP113TW Shipping Brace Install whenever moving washer; Remove before use; All other models Shipping Plug Install before moving washer to prevent tub from damaging cabinet 3 294P4 Agitator Drive Bell Puller For removal and installation of drive bell to transmission shaft 4 294P4B Bolt Use to update item P4A Drive Bell Puller Arm Use to update item

40 Special Tools TLW1794P_

41 Special Tools REF PART NO. DESCRIPTION COMMENTS 1 725P3 Tool Kit Includes items P4 Spring Hook Tool For removal of module springs from outer tub 3 293P4 Drive Bell Seal Tool For installation of Bell and Transmission Tube Seal 4 273P4 Tub Cover Removal Tool Use to install Tub Cover Gasket in outer tub cover 5 306P4 Hex Wrench Tool For removal of locknut from washtub hub 6 254P4P Agitator Hook Set of 2; Use to remove agitator from drive bell 7 282P4 Torx Bit T25; For removal and installation of pump attaching screws

42 Output Board, Wire Harnesses and Wires TLW1793P_

43 Output Board, Wire Harnesses and Wires REF PART NO. DESCRIPTION COMMENTS NA Gauge Wire Black; Order wire by foot and terminals as required NA Gauge Wire Orange; Order wire by foot and terminals as required Hood Timer Harness Model LWN432SP115TW Hood Timer Harness Model LWN432SP113TW Hood Timer Harness Model LWN432SP113TW P Wire Harness Assembly Models LWN432SP113TW01, LWN432SP113TW04 and LWN432SP115TW Control Harness All models except LWN432SP113TW01, LWN432SP113TW04 and LWN432SP115TW Pressure Sensor Harness All models except LWN432SP113TW01, LWN432SP113TW04 and LWN432SP115TW Screw All models except LWN432SP113TW01, LWN432SP113TW04 and LWN432SP115TW Output Control Shield All models except LWN432SP113TW01, LWN432SP113TW04 and LWN432SP115TW Shield Assembly Includes items 7 and 9; All models except LWN432SP113TW01, LWN432SP113TW04 and LWN432SP115TW Output Board Cover Gasket All models except LWN432SP113TW01, LWN432SP113TW04 and LWN432SP115TW P Output Board Control Assembly All models except LWN432SP113TW01, LWN432SP113TW04 and LWN432SP115TW01 NOTE: Individual wires are not available separately. Order complete wire harness, or order wire by the foot. When applying terminals to wires, it is recommended that the terminals be soldered to the wires

44 Notes

45 Parts Index A Adjustable Leg Extension Kit 566P Agitate and Spin Belt Agitator Drive Bell Puller 294P Agitator Hook 254P4P Agitator Pinion Anti-Seize Compound 27604P Capacitor Clamp Control Assembly P P Control Harness Control Overlay Control Support Panel Counterweight Assembly , 21 B Balance Ring Assembly Barbed Tee Base Assembly Bell and Transmission Tube Seal Bell Plug Belt and Pump Kit RB Bleach Dispenser Bolt 294P4B Bracket Brake Kit 38505P Brake Pad Kit 735P Bumper Bumper Pad Bushing C Cable Clip , 21, 33 Capacitor D Drain Extension Kit 451P Drain Hose Drain Hose Sleeve Drive Bell and Seal Kit 39508P...17 Drive Bell Puller Arm 294P4A...37 Drive Bell Seal Tool 293P Drive Pinion P...27 E End Panel D504006P...7 D504007P...7 D504008WP...5, 7 D504009WP...5, 7 F Fabric Softener Dispenser Assembly Female Pin Terminal 00574SG...33 Female Spade Terminal Female Terminal , 33 Flex Vane Agitator N/A items do not appear in index

46 Foam Pad Friction Ring Front Panel 38335DG WP Front Panel Brace Front Panel Pad G Gear and Stud Assembly Gear Sleeve Graphic Panel W W... 5 Grommet , 21 Grounding Clip , 35 H Harness Strap Helix Hex Wrench Tool 306P Hinge Gasket Hinge Stop Clip Hold-Down Clip , 7, Hold-Down Lug Hinge Hood Back Panel Hood Timer Harness Hose Clamp F , Hose Clip , 21 Hose Stand Housing, 24 Position Hub and Lip Seal Kit 766P3A...17, 21 Hub Spacer I Idler Lever Idler Lever Kit 959P Idler Lever Spring Idler Pulley 38225P...15 Idler Shaft Inlet Cover Inlet Deflector Input Shaft 38268P...27 Insulated Female Spade Terminal Isolator Post K Knob Assembly W...5 L Lead-In Cord Leg and Stabilizer Assembly Leg Plate , 21 Leg Spring , 21 Leveling Leg Lid 33450W DG WP...11 Lid Hinge N/A items do not appear in index

47 Lid Switch Assembly Lid Warning Label Lower Bearing 28944RP M Male Pin Terminal Mixing Valve P P Mixing Valve Mounting Bracket Mixing Valve Plug Mixing Valve Screen Mixing Valve-to-Tub Cover Hose Motor Assembly Motor Drip Shield Motor Kit 38034P Motor Mount Motor Mount Bracket Motor Shield N Nut O M Outer Tub Assembly P Output Board Control Assembly P Output Board Cover Gasket Output Control Shield Output Shaft 36570P Overlay P Paint P...29 Panel Locator Plug, 10 Circuit Plug, 9 Circuit Porcelain Touch-Up Paint 122P4P...29 Pressure Bulb , 21 Pressure Sensor Pressure Sensor Harness Pressure Switch B Pressure Switch Terminal Pulley Pump P...15 Pump Assembly P...15 R Rack Receptacle, 9 Circuit Reduction Gear 37403P P...27 Retainer Clip Retaining Ring Ring Terminal Rubber Foot S Screw D , 7, 29 N/A items do not appear in index

48 D M , 7, 9, , , 19, , Sealant P... 17, 21 Service Cabinet Kit 38612DG WP Shield Assembly Shipping Brace Shipping Plug Silicone Grease 26594P Siphon Break Kit 562P Slide Spline Insert Spring Clip Spring Hook Tool 321P Standpipe Adapter Standpipe Strap Strain Relief Switch T Temperature Switch Terminal 00568SG...33 Terminal Extractor Tool 283P Terminal Grounding Clip 00569SG...35 Terminal Tab Timer P P...5 Timer Knob W...5 Timer Skirt Assembly 36700W...5 Tool Kit 725P Top 37992WP...11 Top Assembly WP...11 Top Cover 39905DG W...5, 7 Torx Bit 282P Transmission Assembly 38165P...27 Transmission Case Assembly Transmission Cover Assembly Transmission Oil 27243P...27 Transmission Rebuild Kit RB Transmission Sealant 37577P...27 Tub Assembly P P...17 Tub Cover and Gasket Assembly Tub Cover Assembly Tub Cover Gasket , 21 Tub Cover Removal Tool 273P Tub Kit 39250P...17 Tubing , Tub-to-Pump Hose N/A items do not appear in index V Valve to Inlet Hose

49 W Warning Label D , 19, Washer D , , Washtub 719P Washtub Gasket Water Hose F Weldment and Bearing Assembly Wire Clip D Wire Harness Assembly 38661P Wire Tie Wire, 12 Gauge Wire, 18 Gauge N/A items do not appear in index

50 Notes