Automatic Washers. Parts. Refer to Page 3 for Model Numbers. W138P_37948

Transcription

1 Automatic Washers Refer to Page 3 for Model Numbers Parts W138P_ Part No R6 July 2016

2

3 Table of Contents Title Page Parts Ordering Information... 2 Serial Plate Location... 2 Model Identification... 3 Timer, Case and Plate... 4 Timer Case... 6 Timer, Meter Case and Service Door (Drawing 1 of 2)... 8 Timer, Meter Case and Service Door (Drawing 2 of 2) Coin Drop, Meter Case and Service Door Security Case, Service Door and Circuit Board Security Case, Service Door and Card Reader Control Panel, Control Hood and Controls (Drawing 1 of 3) Control Panel, Control Hood and Controls (Drawing 2 of 3) Control Panel, Control Hood and Controls (Drawing 3 of 3) Cabinet Top and Loading Door Out-of-Balance Switch Motor, Mounting Bracket, Belt, Pump and Idler Assembly Fill Hose, Mixing Valve-to-Tub Cover Hose and Mixing Valve and Mounting Bracket Agitator, Drive Bell, Seal Kit, Washtub and Hub Outer Tub, Cover and Pressure Hose Transmission Assembly and Balance Ring Transmission Assembly Drain Hose, Strain Relief and Sleeve Hoses and Siphon Break Kit Bearing Housing, Brake, Pulley and Pivot Dome Front Panel, Base Assembly and Cabinet Assembly Mixing Valve and Motor Disconnect Blocks, Terminals and Terminal Extractor Tool Power Cord and Terminals Special Tools (Drawing 1 of 2) Special Tools (Drawing 2 of 2) Wire Harnesses and Wires Parts Index Copyright 2016, Alliance Laundry Systems LLC All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed written consent of the publisher

4 If literature or replacement parts are required, contact the source from whom the machine was purchased or contact Alliance Laundry Systems at (920) for the name and address of the nearest authorized parts distributor. Parts Ordering Information For technical assistance, call either of the numbers listed below: (920) Ripon, Wisconsin Wevelgem, Belgium When calling or writing about your product, be sure to mention model and serial numbers. Model and serial numbers are located on serial plate(s) as shown. Serial Plate Location SERIAL PLATE W138PE3E_

5 Model Identification Information in this manual is applicable to these washer models: EAJ920*A EAJ921*A EA2011*A EA2020*A EA2021*A EA2110*A EA2111*A EA2120*A EA2121*A EA2210*A EA2220*A EA2221*A EA2520*A EA2521*A EA2610*A EA2620*A EA2621*A EA2710*A EA2721*A EA2820*A EA2821*A EA2920*A EA2921*A EA3820*A EA3821*A EA3920*A EA3921*A JA0110* ZA3820*A ZA3821*A * Add Letter To Designate Color. L - Almond W - White

6 Timer, Case and Plate Models EA2011*A, EA2020*A and EA2021*A GROUND WIRE TO TIMER W116PZ3D_

7 Timer, Case and Plate REF PART NO. DESCRIPTION COMMENTS 1 M Washer Screw W Timer Case Assembly Screw Washer Vinyl Bolt Washer Nut P Timer W Timer Plate Screw Timer Knob Assembly Screw Push-to-Start Sticker Screw Washer Washer Nut * Add Letter To Designate Color. L - Almond W - White

8 Timer Case Models EAJ920*A and EAJ921*A W017BE3C_

9 Timer Case REF PART NO. DESCRIPTION COMMENTS 1 M Washer Screw W Timer Case Assembly Screw Washer Nut * Add Letter To Designate Color. L - Almond W - White

10 Timer, Meter Case and Service Door (Drawing 1 of 2) Models EA2110*A, EA2111*A, EA2120*A, EA2121*A, EA2210*A, EA2220*A, EA2221*A, EA2520*A, EA2521*A and JA0110* W117PZ3B_

11 Timer, Meter Case and Service Door (Drawing 1 of 2) REF PART NO. DESCRIPTION COMMENTS P Timer Models EA2110*A, EA2111*A, EA2120*A, EA2121*A and JA0110* P Timer Models EA2210*A, EA2220*A and EA2221*A P Timer Models EA2520*A and EA2521*A Timer Bracket Screw WP Service Door Assembly White LP Service Door Assembly Almond Screw Washer Metal Washer Vinyl Meter Case Locking Bracket Nut Screw P3W Meter Case and Funnel Kit White; Includes items and P3L Meter Case and Funnel Kit Almond; Includes items and Meter Case Gasket Meter Case Bracket Gasket Meter Case Lockdown Bracket Bolt Nut P Counter Kit Models EA2520*A and EA2521*A Nut Bolt P3 Coin Funnel Kit Screw Clutch Assembly * Add Letter To Designate Color. L - Almond W - White

12 Timer, Meter Case and Service Door (Drawing 2 of 2) Models EA2610*A, EA2620*A, EA2621*A, EA2710*A and EA2721*A W118PZ3B_

13 Timer, Meter Case and Service Door (Drawing 2 of 2) REF PART NO. DESCRIPTION COMMENTS P Timer Models EA2610*A, EA2620*A and EA2621*A 1 N/A Timer Assembly Models EA2710*A and EA2721*A Timer Bracket Screw Magnet WP Service Door Assembly White LP Service Door Assembly Almond Screw Washer Metal Washer Vinyl Meter Case Locking Bracket Nut Screw 12 N/A Wire Harness Clip Reed Switch P3W Meter Case and Funnel Kit White; Includes items and P3L Meter Case and Funnel Kit Almond; Includes items and Meter Case Gasket Bolt Nut Meter Case Lockdown Bracket Meter Case Bracket Gasket Pushbutton Switch Nut P3 Coin Funnel Kit Bolt 24 N/A Audit Sensor Assembly Screw Screw Clutch Assembly * Add Letter To Designate Color. L - Almond W - White N/A = Part no longer available

14 Coin Drop, Meter Case and Service Door Models EA2820*A, EA2821*A, EA2920*A and EA2921*A TLW1606P_

15 Coin Drop, Meter Case and Service Door REF PART NO. DESCRIPTION COMMENTS Rejector Faceplate For use with Coin Drop Expansion Plug For use with Coin Drop 3 N/A Locking Rod P Coin Drop Replaces Airpax rejector and drop assembly P Opto Coupler For use with metal drops only Screw Washer Metal Washer Vinyl WP Service Door Assembly White LP Service Door Assembly Almond Magnet Screw Reed Switch Meter Case Locking Bracket Nut WP Meter Case Kit White LP Meter Case Kit Almond Meter Case Gasket Bolt Nut Meter Case Lockdown Bracket Meter Case Bracket Gasket Switch * Add Letter To Designate Color. L - Almond W - White N/A = Part no longer available

16 Security Case, Service Door and Circuit Board Models EA3920*A and EA3921*A W245PZ3B_

17 Security Case, Service Door and Circuit Board REF PART NO. DESCRIPTION COMMENTS Washer Metal Screw Washer Vinyl WP Service Door Assembly White LP Service Door Assembly Almond Meter Case Locking Bracket Nut Circuit Board Support 8 M Washer Screw 10 M Connector 11 N/A Security Case Security Case Gasket 13 N/A Overlay Screw Washer Nut Screw P Control Board Kit Screw Timer Bracket * Add Letter To Designate Color. L - Almond W - White N/A = Part no longer available

18 Security Case, Service Door and Card Reader Models EA3820*A, EA3821*A, ZA3820*A and ZA3821*A W278P_

19 Security Case, Service Door and Card Reader REF PART NO. DESCRIPTION COMMENTS 1 N/A Card Reader Shield WP Service Door Assembly White LP Service Door Assembly Almond Screw Meter Case Locking Bracket Nut L Security Case Assembly 7 M Washer Screw Security Case Gasket Washer Vinyl Washer Bolt Screw Washer Nut Card Reader Instruction Overlay Nut Card Reader Screw * Add Letter To Designate Color. L - Almond W - White N/A = Part no longer available

20 Control Panel, Control Hood and Controls (Drawing 1 of 3) Models EA2011*A, EA2020*A, EA2021*A, EA2110*A, EA2111*A, EA2120*A, EA2121*A, EA2210*A, EA2220*A, EA2221*A, EA2520*A, EA2521*A and JA0110* W119PZ3D_

21 Control Panel, Control Hood and Controls (Drawing 1 of 3) REF PART NO. DESCRIPTION COMMENTS Screw Phillips head Screw Torx head; Refer to Special Tools section for torx bit and holder Washer Switch Screw Washer Nut W Control Hood White L Control Hood Almond Screw Hood Back Panel 10 M Washer Screw Switch 2 speed models Light 4 required; Models EA2011*A, EA2020*A and EA2021*A Light In use; All other models Light Unbalanced load; Rinse or spin; All other models P Pressure Switch WP Control Panel and Bracket Assembly White LP Control Panel and Bracket Assembly Almond Control Panel Bumper Graphic Overlay Models EA2011*A, EA2110*A, EA2111*A and EA2210*A Graphic Overlay Models EA2020*A, EA2021*A, EA2120*A, EA2121*A, EA2220*A, EA2221*A, EA2520*A and EA2521*A 17 N/A Graphic Overlay Model JA0110* Nut 19 N/A Screw Switch Knob * Add Letter To Designate Color. L - Almond W - White N/A = Part no longer available

22 Control Panel, Control Hood and Controls (Drawing 2 of 3) Models EA2610*A, EA2620*A, EA2621*A, EA2710*A and EA2721*A W121PZ3B_

23 Control Panel, Control Hood and Controls (Drawing 2 of 3) REF PART NO. DESCRIPTION COMMENTS Screw Phillips head Screw Torx head Washer Switch Switch Screw Washer Nut W Control Hood White L Control Hood Almond Screw Hood Back Panel Circuit Board Support 12 N/A Audit Control Screw 14 M Washer Light In use Light Unbalanced load; Rinse or spin 16 N/A Nut 17 N/A Washer Push-On Clip P Pressure Switch WP Control Panel and Bracket Assembly White LP Control Panel and Bracket Assembly Almond Control Panel Bumper 22 N/A Graphic Overlay Models EA2610*A and EA2710*A Graphic Overlay Models EA2620*A, EA2621*A and EA2721*A Transmit Light 24 N/A Transmit Switch Nut 26 N/A Screw Switch Knob * Add Letter To Designate Color. L - Almond W - White N/A = Part no longer available

24 Control Panel, Control Hood and Controls (Drawing 3 of 3) Models EAJ920*A, EAJ921*A, EA2820*A, EA2821*A, EA2920*A, EA2921*A, EA3820*A, EA3821*A, EA3920*A, EA3921*A, ZA3820*A and ZA3821*A W385P_

25 Control Panel, Control Hood and Controls (Drawing 3 of 3) REF PART NO. DESCRIPTION COMMENTS P Control, Shield and Tape Kit Screw W Control Panel Assembly White L Control Panel Assembly Almond Nut Washer Screw W Control Hood White L Control Hood Almond Screw Hood Back Panel 10 M Washer Screw P Pressure Switch Control Panel Bumper 14 N/A Overlay Models ZA3820*A and ZA3821*A Control Panel Overlay All other models Screw Phillips head Screw Torx head; Refer to Special Tools section for torx bit and holder * Add Letter To Designate Color. L - Almond W - White N/A = Part no longer available

26 Cabinet Top and Loading Door GROUND WIRE W123PZ3B_

27 Cabinet Top and Loading Door REF PART NO. DESCRIPTION COMMENTS NA Lid Plug Use on lid WP Lid White; Porcelain LP Lid and Carton Assembly Almond; Porcelain Screw Screw Optional for added security Washer Metal; Optional for added security Washer Vinyl; Optional for added security Hinge Gasket Screw Disconnect Power Warning Label Strain Relief WP Top Assembly White; Metered models LP Top Assembly Almond; Metered models WP Top Assembly White; Nonmetered models LP Top Assembly Almond; Nonmetered models Nut Optional for added security Director Bracket Screw 14 N/A Screw Support Barrel Nut Hinge Bushing Lid Hinge Right Lid Hinge Left Bumper * Add Letter To Designate Color. L - Almond W - White N/A = Part no longer available

28 Out-of-Balance Switch W246PZ3A_

29 Out-of-Balance Switch REF PART NO. DESCRIPTION COMMENTS Switch Models EAJ920*A, EAJ921*A, EA2820*A, EA2821*A, EA2920*A, EA2921*A, EA3820*A, EA3821*A, EA3920*A, EA3921*A, ZA3820*A and ZA3821*A Snap Switch All other models Screw P Switch Holder Kit Includes (2) Screws Actuator Arm Unbalanced Load Lever Spring Screw * Add Letter To Designate Color. L - Almond W - White

30 Motor, Mounting Bracket, Belt, Pump and Idler Assembly W263PZ3A_

31 Motor, Mounting Bracket, Belt, Pump and Idler Assembly REF PART NO. DESCRIPTION COMMENTS Motor Shield Screw P Motor Kit 1 speed; Model JA0110* P Motor Kit 1 speed; Models EA2011*A, EA2110*A, EA2111*A, EA2210*A, EA2610*A and EA2710*A P Motor Kit 2 speed; All other models 4 N/A Roll Pin Nut Motor Mounting Bracket Screw Nut Idler Lever Washer Screw P Idler Shaft Washer Felt Retaining Ring Spring Clip P Idler Pulley Washer Nylatron Screw P Pump Belt Agitate and spin Nut Idler Lever Spring Motor Mount Post Motor Mount Rubber Capacitor Capacitor Clamp Screw 28 N/A Motor Pulley Gold P Motor Switch * Add Letter To Designate Color. L - Almond W - White N/A = Part no longer available

32 Fill Hose, Mixing Valve-to-Tub Cover Hose and Mixing Valve and Mounting Bracket H C C H W125PZ3B_

33 Fill Hose, Mixing Valve-to-Tub Cover Hose and Mixing Valve and Mounting Bracket REF PART NO. DESCRIPTION COMMENTS Hose Clamp Mixing Valve-to-Tub Cover Hose Screw Hose Clamp Gold 5 F Water Hose 5 feet Fill Hose 8 feet Fill Hose 10 feet Washer Mixing Valve Mounting Bracket P Mixing Valve Screw Backflow Preventer

34 Agitator, Drive Bell, Seal Kit, Washtub and Hub W227P_

35 Agitator, Drive Bell, Seal Kit, Washtub and Hub REF PART NO. DESCRIPTION COMMENTS Agitator Clothes Guard Screw Washer Washtub Gasket Bell and Transmission Tube Seal 7 495P3 Hub and Seal Kit Includes Cover Gasket, item 8 and item Spline Insert Nut P Tub Assembly Porcelain P Tub Assembly Stainless steel P Drive Bell and Seal Kit Includes items 6, 13 and O-Ring Screw Bell Plug

36 Outer Tub, Cover and Pressure Hose W182PZ3C_

37 Outer Tub, Cover and Pressure Hose REF PART NO. DESCRIPTION COMMENTS P Tub Cover Kit Includes item Tub Cover Gasket P Outer Tub Kit Leg Plate Screw Tub Spring Warning Label Grommet Pressure Bulb Tubing Models EAJ920*A, EAJ921*A, EA2820*A, EA2821*A, EA2920*A, EA2921*A, EA3820*A, EA3821*A, EA3920*A, EA3921*A, ZA3820*A and ZA3821*A Tubing All other models Cable Clip * Add Letter To Designate Color. L - Almond W - White

38 Transmission Assembly and Balance Ring W234PZ3E_

39 Transmission Assembly and Balance Ring REF PART NO. DESCRIPTION COMMENTS NA 27604P Anti-Seize Compound Apply to both the upper and lower transmission shafts Nut 2 M Screw P Transmission Assembly Refer to Transmission Assembly section for component parts 4 N/A Screw P Balance Ring Assembly Bearing Housing Assembly Flinger Models through Serial No N/A = Part no longer available

40 Transmission Assembly W132PZ3A_

41 Transmission Assembly REF PART NO. DESCRIPTION COMMENTS NA 37577P Transmission Sealant Use between transmission case and cover Retaining Ring P Output Shaft Washer P Transmission Oil 1 fill Screw Washer P Reduction Gear Gear and Stud Assembly Screw Washer Washer P Drive Pinion P Input Shaft 14 N/A Dowel Pin Screw P Transmission Cover Assembly Slide Rack Agitator Pinion P Transmission Case Assembly N/A = Part no longer available

42 Drain Hose, Strain Relief and Sleeve Model JA0110* Stand Pipe W016B_

43 Drain Hose, Strain Relief and Sleeve REF PART NO. DESCRIPTION COMMENTS Drain Hose Sleeve Strain Relief Hose Retainer Clip Drain Hose Hose Support Hose Clamp Tub-to-Pump Hose * Add Letter To Designate Color. L - Almond W - White

44 Hoses and Siphon Break Kit All Models Except JA0110* W219PZ3A_

45 Hoses and Siphon Break Kit REF PART NO. DESCRIPTION COMMENTS 1 562P3 Siphon Break Kit Siphon break kit MUST be installed in drain hose if drain receptacle is lower than cabinet top of washer Pump-to-Drain Elbow Hose Hose Clamp Drain Hose Elbow Screw Hose Clamp Drain Hose Hose Coupler If drain hose must be shortened, cut hose between molded end and molded elbow; Use (1) Hose Coupler to splice hose Hose Support Hose Clamp Tub-to-Pump Hose Hose Retainer Clip * Add Letter To Designate Color. L - Almond W - White

46 Bearing Housing, Brake, Pulley and Pivot Dome W130PZ3F_

47 Bearing Housing, Brake, Pulley and Pivot Dome REF PART NO. DESCRIPTION COMMENTS NA 26594P Silicone Grease Apply a small amount to each new brake pad Bearing Housing Assembly RP Lower Bearing 3 N/A Support Leg Spring Washer Thick Washer Screw Pivot Dome Screw Helix Pulley Assembly P3 Brake Pad Kit Includes 3 pads, sleeves and screws Washer Thin P Brake Kit N/A = Part no longer available

48 Front Panel, Base Assembly and Cabinet Assembly GROUND WIRE W133PZ3A_

49 Front Panel, Base Assembly and Cabinet Assembly REF PART NO. DESCRIPTION COMMENTS Bumper Pad Thin Panel Locator Screw Bumper Pad Thick Screw Screw Hold-Down Lug Hinge Meter Case Mounting Bracket Assembly Screw Leg and Stabilizer Assembly Screw Bracket Right P Base Kit Includes items 10-12, 15, 16, 19 and Rubber Foot Leveling Leg Nut Screw Slotted hex head Screw Torx head; Refer to Special Tools section for torx bit and holder WP Front Panel Assembly White; Includes items 23, 24 and attaching hardware LP Front Panel Assembly Almond; Includes items 23, 24 and attaching hardware Snubber Pad Assembly Panel Locator Screw Bracket Left Front Panel Brace Hold-Down Clip WP Service Cabinet Kit White LP Service Cabinet Kit Almond

50 Mixing Valve and Motor Disconnect Blocks, Terminals and Terminal Extractor Tool W134PZ3B_

51 Mixing Valve and Motor Disconnect Blocks, Terminals and Terminal Extractor Tool REF PART NO. DESCRIPTION COMMENTS Circuit Plug Motor Female Terminal For 1 or 2 wire application Female Spade Terminal 1/4 inch Mixing Valve Plug Natural Mixing Valve Plug Red 5 283P4 Terminal Extractor Tool

52 Power Cord and Terminals GROUND WIRE MOLEX W135PZ3A_

53 Power Cord and Terminals REF PART NO. DESCRIPTION COMMENTS Position Housing Right hand Position Housing Left hand Female Terminal Used for 1 or 2 wire application Lead-In Cord Models EAJ920*A, EAJ921*A, EA2011*A, EA2020*A, EA2021*A, EA2820*A, EA2821*A, EA2920*A, EA2921*A, EA3820*A, EA3821*A, EA3920*A, EA3921*A, ZA3820*A and ZA3821*A Lead-In Cord All other models Nut Washer Screw Harness Strap Female Pin Terminal Circuit Receptacle Circuit Receptacle Circuit Receptacle Circuit Plug Circuit Plug Circuit Plug Male Pin Terminal Insulated Female Spade Terminal Wire Clip 14 N/A Wire Clip Grounding Clip Wire Clip Wire Clip Insulator Female Flag Terminal 20 N/A Female Spade Terminal 1/4 inch Female Spade Terminal Large spade Female Spade Terminal Small spade Ring Terminal 1/4 inch ring Ring Terminal Small shank Connector Terminal Adapter * Add Letter To Designate Color. L - Almond W - White N/A = Part no longer available

54 Special Tools (Drawing 1 of 2) TLW1666P_

55 Special Tools (Drawing 1 of 2) REF PART NO. DESCRIPTION COMMENTS 1 294P4 Agitator Drive Bell Puller Replaces 253P4 Bell Tool; For removal and installation of drive bell to transmission shaft 2 294P4B Bolt 3 294P4A Drive Bell Puller Arm 4 N/A T-Handle Allen Wrench For removal and installation of 3 pump assembly attaching screws 5 242P4 Spring Installer Use to install brake spring N/A = Part no longer available

56 Special Tools (Drawing 2 of 2) TLW1818P_

57 Special Tools (Drawing 2 of 2) REF PART NO. DESCRIPTION COMMENTS 1 725P3 Tool Kit Includes items P4 Spring Hook Tool For removal of centering springs on outer tub 3 293P4 Drive Bell Seal Tool For installation of Bell and Transmission Tube Seal 4 273P4 Tub Cover Removal Tool Use to remove 36025P Tub Cover Kit and install Tub Cover Gasket 5 306P4 Hex Wrench Tool Use to remove locknut from washtub hub 6 254P4P Agitator Hook Use to remove agitator from drive bell; Set of P4 Torx Bit For removal and installation of control hood security screws 7 282P4 Torx Bit For removal and installation of pump and front panel security screws

58 Wire Harnesses and Wires PART NO. DESCRIPTION COMMENTS 36278P Base Wire Harness Assembly Model JA0110* N/A Base Harness All other models Timer Wire Harness Assembly Model EA2011*A 34092P Wire Harness Assembly Timer; Models EA2020*A and EA2021*A 39806P Timer Harness Assembly Models EA2110*A, EA2111*A, EA2210*A and JA0110* 29281P Timer Harness Assembly Models EA2120*A, EA2121*A, EA2220*A and EA2221*A 34175P Timer Wire Harness Assembly Models EA2520*A, EA2521*A, EA2620*A, EA2621*A and EA2721*A Timer Wire Harness Assembly Models EA2610*A and EA2710*A N/A Meter Case Harness Assembly Models EAJ920*A, EAJ921*A, EA2820*A, EA2821*A, EA2920*A and EA2921*A Circuit Board Harness Assembly Models EA3820*A, EA3821*A, EA3920*A, EA3921*A, ZA3820*A and ZA3821*A 33805P Wire Harness Assembly Hood; Models EA2020*A and EA2021*A 33758P Wire Harness Assembly Hood; Models EA2120*A, EA2121*A, EA2220*A, EA2221*A, EA2520*A, EA2521*A and EA2721*A N/A Wire Harness Assembly Hood; Models EA2610*A and EA2710*A Wire Harness Assembly Hood; Models EA2620*A and EA2621*A N/A Wire Harness Assembly Hood; Models EA2011*A, EA2110*A, EA2111*A, EA2210*A and JA0110* 36093P Wire Harness Assembly Hood; All other models Card Reader Wire Harness Assembly Models EA3820*A, EA3821*A, ZA3820*A and ZA3821*A Security Wire Harness Assembly Models EAJ920*A and EAJ921*A Gauge Wire Black; Order wire by foot and terminals and connectors as required Gauge Wire Orange; Order wire by foot and terminals and connectors as required * Add Letter To Designate Color. L - Almond W - White N/A = Part no longer available NOTE: Individual wires are not available separately. Order complete wire harness, or order wire by the foot. When applying terminals to wires, it is recommended that the terminals be soldered to the wires

59 Parts Index A Actuator Arm Agitator Agitator Drive Bell Puller 294P Agitator Hook 254P4P Agitator Pinion Anti-Seize Compound 27604P B Backflow Preventer Balance Ring Assembly 34731P Base Kit 36599P Base Wire Harness Assembly 36278P Bearing Housing Assembly Bell and Transmission Tube Seal Bell Plug Belt Bolt , 9, 11, 13, P4B , 11 Bracket Brake Kit 38505P Brake Pad Kit 548P Bumper Bumper Pad C Cable Clip Capacitor Capacitor Clamp Card Reader Card Reader Instruction Overlay Card Reader Wire Harness Assembly Circuit Board Harness Assembly Circuit Board Support Clothes Guard Clutch Assembly , 11 Coin Drop 39873P...13 Coin Funnel Kit 523P3...9, 11 Connector M Control Board Kit 37386P...15 Control Hood 37075L...19, 21, W...19, 21, 23 Control Panel and Bracket Assembly 36521LP...19, WP...19, 21 Control Panel Assembly 36097L W...23 Control Panel Bumper , 21, 23 Control Panel Overlay Control, Shield and Tape Kit 38188P...23 Counter Kit 62113P...9 D Director Bracket Disconnect Power Warning Label Drain Hose Drain Hose Elbow Drain Hose Sleeve Drive Bell and Seal Kit 39508P...33 N/A items do not appear in index

60 Drive Bell Puller Arm 294P4A Drive Bell Seal Tool 293P Drive Pinion 36562P E Expansion Plug F Female Flag Terminal Female Pin Terminal Female Spade Terminal Female Terminal , 51 Fill Hose Flinger Front Panel Assembly 34656LP WP Front Panel Brace G Gear and Stud Assembly Graphic Overlay Grommet Grounding Clip H Harness Strap Helix Hex Wrench Tool 306P Hinge Bushing Hinge Gasket Hold-Down Clip Hold-Down Lug Hinge Hood Back Panel , 21, 23 Hose Clamp , 43 Hose Coupler Hose Retainer Clip , 43 Hose Support , 43 Housing, 24 Position Hub and Seal Kit 495P I Idler Lever Idler Lever Spring Idler Pulley 28800P...29 Idler Shaft 28802P...29 Input Shaft 34853P...39 Insulated Female Spade Terminal Insulator L Lead-In Cord Leg and Stabilizer Assembly Leg Plate Leveling Leg Lid WP...25 Lid and Carton Assembly LP...25 Lid Hinge Lid Plug N/A items do not appear in index

61 Light , , 21 Lower Bearing 28944RP , , 11, 13, 15, , 7, 15, 17, 19, 21, 23, 29 M Magnet , 13 Male Pin Terminal Meter Case and Funnel Kit 524P3L... 9, P3W... 9, 11 Meter Case Bracket Gasket , 11, 13 Meter Case Gasket , 11, 13 Meter Case Kit 38542LP WP Meter Case Lockdown Bracket , 11, 13 Meter Case Locking Bracket , 11, 13, 15, 17 Meter Case Mounting Bracket Assembly Mixing Valve 34963P Mixing Valve Mounting Bracket Mixing Valve Plug Mixing Valve-to-Tub Cover Hose Motor Kit 38034P P P Motor Mount Motor Mount Post Motor Mounting Bracket Motor Shield Motor Switch 35632P N Nut , , , 9, 11, 13, 17 O Opto Coupler P...13 O-Ring Outer Tub Kit 34439P...35 Output Shaft 36570P...39 P Panel Locator Pivot Dome Plug, 1 Circuit Plug, 10 Circuit Plug, 6 Circuit Plug, 9 Circuit Pressure Bulb Pressure Switch 35889P...19, 21, 23 Pulley Assembly Pump P...29 Pump-to-Drain Elbow Hose Pushbutton Switch Push-On Clip Push-to-Start Sticker R Rack Receptacle, 1 Circuit Receptacle, 6 Circuit Receptacle, 9 Circuit N/A items do not appear in index

62 Reduction Gear 29161P Reed Switch , 13 Rejector Faceplate Retaining Ring Ring Terminal Rubber Foot S Screw M , 7, 15, 17, 19, 21, , , 21, , 15, 17, 19, 21, 23, 27, 31, , , 21, , 9, 11, 13, , 21, , , , 11, 13, 15, 17, , 25, 29, Security Case Assembly 38145L Security Case Gasket , 17 Security Wire Harness Assembly Service Cabinet Kit 38612LP WP Service Door Assembly 35798LP... 9, 11, 13, 15, WP...9, 11, 13, 15, 17 Silicone Grease 26594P...45 Siphon Break Kit 562P Slide Snap Switch Snubber Pad Assembly Spline Insert Spring Spring Clip Spring Hook Tool 321P Spring Installer 242P Strain Relief Support Barrel Switch , , Switch Holder Kit 36497P...27 Switch Knob , 21 N/A items do not appear in index T Terminal Adapter Terminal Extractor Tool 283P Timer 28716P P P P...9, 11 Timer Bracket , Timer Case Assembly 37733W...5, 7 Timer Harness Assembly 29281P P...56 Timer Knob Assembly Timer Plate 31864W...5 Timer Wire Harness Assembly 34092P P...56

63 Tool Kit 725P Top Assembly 36122LP WP LP WP Torx Bit 281P P Transmission Assembly 34526P Transmission Case Assembly 33223P Transmission Cover Assembly 38290P Transmission Oil 27243P Transmission Sealant 37577P Transmit Light Tub Assembly 39252P P Tub Cover Gasket Tub Cover Kit 36025P Tub Cover Removal Tool 273P Tub Spring Tubing Tub-to-Pump Hose , , , 11, 13, 15, , 11, 13, 15, , 21 Washtub Gasket Water Hose F Wire Clip Wire Harness Assembly 33758P P P Wire, 12 Gauge Wire, 18 Gauge U Unbalanced Load Lever W Warning Label Washer M , 7, 15, 17, 19, 21, , 7, 15, 17, 19, 21, , , N/A items do not appear in index

64 Notes