Washer-Extractor Pocket Hardmount

Transcription

1 Washer-Extractor Pocket Hardmount Refer to Page 3 for Model Numbers Parts Models UW60P2 and UW60P3 Model UW60B2 PHM1411C_F Part No. F232166R15 November 2013

2

3 Table of Contents Title Page Parts Ordering Information... 2 Nameplate Location... 2 Model Identification... 3 Pocket Hardmount Washer-Extractor Product Overview... 4 Decals... 6 Control Module - Model UW60B2 (Drawing 1 of 3)... 8 Control Module - Model UW60B2 (Drawing 2 of 3) Control Module - Model UW60B2 (Drawing 3 of 3) Control Module - Models UW60P2 and UW60P3 (Drawing 1 of 4) Control Module - Models UW60P2 and UW60P3 (Drawing 2 of 4) Control Module - Models UW60P2 and UW60P3 (Drawing 3 of 4) Control Module - Models UW60P2 and UW60P3 (Drawing 4 of 4) Balance Switch, Temperature Probe and Rotation Sensor Supply Dispenser Water Supply Valve and Hoses to Supply Dispenser Spray Plumbing - Design 5 UW60P2 and UW60P3 Models Spray Plumbing - Design 7 and 8 UW60P2 and UW60P3 Models Fill Plumbing - Design 5 UW60P2 and UW60P3 Models Through 2/29/ Fill Plumbing - Design 5 UW60P2 and UW60P3 Models Starting 3/1/ Fill Plumbing - Design 7 and 8 UW60P2 and UW60P3 Models Fill Plumbing - Model UW60B Drain System, Overflow and Vent Pipes Basket, Shell and Frame Door and Spray Tube Door Lock Front, Side and Rear Panels Motor and Pulley - Models UW60B2 and UW60P Motor and Pulley - Model UW60P Electric Heat Option Steam Heat Option and Transformers Security Fasteners Special Tools Parts Index Copyright 2013, Alliance Laundry Systems LLC All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed written consent of the publisher. F

4 Parts Ordering Information If literature or replacement parts are required, contact the source from whom the machine was purchased or contact Alliance Laundry Systems at (920) for the name and address of the nearest authorized parts distributor. For technical assistance, call either of the numbers listed below: (920) Ripon, Wisconsin Wevelgem, Belgium When calling or writing about your product, be sure to mention model and serial numbers. Model and serial numbers are located on nameplate(s) as shown. Nameplate Location Model No. Serial No. Voltage Amps Required Circuit Breaker Amps. Hz Wire Phase Max. LB KG Max. Load Speed RPM Elec. Heating Steam Press PSI BAR KW Product No. Date Code P U SH PHM2382P_F F232166

5 Model Identification Information in this manual is applicable to these washer-extractor models: UW60B2 UW60P2 UW60P3 NOTE: Models with 5, 7 or 8 in the 9th position in the model number (e.g. UW60P2OU50001). F

6 < < < < Pocket Hardmount Washer-Extractor Product Overview UW60AVXU /3 S N/A N/A 0.0 Drawings: ETL Listed Conforms To ANSI/UL Std. 1206, 3rd Ed Certified To CAN/CSA Std. C22.2 No WASH ADD BLEACH RINSE NORMAL HOT LIGHT SOIL HOT PERM PRESS HOT VISA TM WARM 95C 60C 95C 60C 5 6 SPIN DOOR START HEAVY SOIL HOT UNIFORMS HOT 40C 40C STAINED DELICATE 30C HOT COLD A-Control B-Control (Domestic) B-Control (International) Mechanical Timer WE-6 Control S-Computer V-Computer UniLinc Control PHM2979P_F F232166

7 Pocket Hardmount Washer-Extractor Product Overview REF PART NO. DESCRIPTION COMMENTS 1 - Product Family UW 2 - Capacity (Pounds) Control A (A-Control) B (B-Control) M (Mechanical Timer) P (WE-6 Control) S (S-Computer) V (V-Computer) T (UniLinc Control) 4 - Speed 2 (2-Speed) 3 (3-Speed) 4 (4-Speed) V (Variable-Speed) 5 - Voltage F ( /60/3/3) N ( /50-60/3/3) O ( /60/3/3) P ( /60-60/3/3) Q ( / /50/60/3ph) R ( / /50/60/3ph) X ( / /50/60/1-3) Y ( /60/1/2) 6 - OEM U (Standard Specs) 7 - Design Series 1-8 F

8 Decals COPPER CONDUCTORS ONLY P/N PHM2894P_F F232166

9 Decals REF PART NO. DESCRIPTION COMMENTS Disconnect Power Warning Label 2 F This Machine Must Be Protected Decal 3 F Conductor Decal 4 F External Supply Caution Decal 5 F Hot Surface Warning Decal 6 F Cold Water Valve Decal 7 F Hot Water Valve Decal 8 F Do Not Push Decal 9 F Supply Dispenser Hazard Caution Decal 10 F Before Power Is Connected Tag 11 F Clockwise Spin Rotation Decal 12 F Hot Surface Warning Decal 13 F Personal Injury Warning Decal F

10 Control Module - Model UW60B2 (Drawing 1 of 3) Standard Models Models With Electric Heat PHM2433P_F F232166

11 Control Module - Model UW60B2 (Drawing 1 of 3) REF PART NO. DESCRIPTION COMMENTS 1 F Contact Block Switch 800E-series; Includes F Contact Block Switch 1 F Contact Block Switch 800E-series 1 F P Emergency Stop Button Kit Used to convert from 800E-series to 800F-series; Includes F Contact Block Switch and F Emergency Stop Pushbutton 1 F Contact Block Switch 800F-series; Models starting 10/1/ Screw 3 N/A Control Mounting Panel Assembly Disconnect Power Warning Label 5 F Control Module Cover 6 F Nut 7 F Cable Tray Cover 8 F Washer 9 F Screw 10 N/A Cable Tray Assembly 11 F External Supply Box 12 F External Supply Box Cover 13 F Air Trap Hose 14 F Connector 15 F422404P Tubing 16 F P Water Level Switch 17 F Hose Clamp No F Tee 19 F P Water Pressure Switch 1 level 20 F381723P 4-Way Valve 20 G582P3 Diaphragm and Guide Kit 21 F Snap Bushing 22 F Screw 23 F Nut 24 F Ribbon Cable 26 pin; 8 inch 25 F P Computer 26 F Control Cover 27 F Screw 28 F Washer 29 F Washer 30 F Momentary Switch Models through 5/26/04 30 F Momentary Switch Models starting 5/27/04 31 N/A Emergency Stop Pushbutton 800E-series; Order F P Emergency Stop Button Kit 31 F Emergency Stop Pushbutton 800F-series; Models starting 10/1/07 32 F P Keypad 33 F Control Module Decal N/A = Part no longer available F

12 Control Module - Model UW60B2 (Drawing 2 of 3) PHM2128P_F F232166

13 Control Module - Model UW60B2 (Drawing 2 of 3) REF PART NO. DESCRIPTION COMMENTS 1 F Screw 2 F Output Board Cover 3 F Nut 4 F Output CCA 5 F Ribbon Cable 26 pin; 8 inch 6 F Fuse 1 Amp; Slo blo 6 F Fuse 1/2 Amp; Fast blo 6 F Fuse 1/8 Amp; Slo blo 7 F330177P Contactor 8 F330186P Interlock Contactor 9 F DIN Contactor Mounting Rail 10 F Screw 11 F Circuit Breaker C and F-voltage 12 F Flange Relay 220 Volt 13 F Screw 14 F Standoff F

14 Control Module - Model UW60B2 (Drawing 3 of 3) PHM1934P_F F232166

15 Control Module - Model UW60B2 (Drawing 3 of 3) REF PART NO. DESCRIPTION COMMENTS 1 F Insulator Bushing 2 F Ground Terminal Lug 3 F Input Power Decal 4 F Input Power Block 5 F Nut 6 F Washer 7 F Nut 8 F Ground Decal 9 F Nut 10 F Terminal Block 11 F External Supply Connection Decal O-voltage 11 F External Supply Connection Decal F-voltage 12 F Screw 13 F Screw 14 F Screw F

16 Control Module - Models UW60P2 and UW60P3 (Drawing 1 of 4) PHM2343P_F F232166

17 Control Module - Models UW60P2 and UW60P3 (Drawing 1 of 4) REF PART NO. DESCRIPTION COMMENTS NA F Main Harness 1 N/A Control Mounting Panel Assembly Screw 3 F Control Module Cover Disconnect Power Warning Label 5 F Cable Tray Cover 6 F Nut 7 F Screw 8 F Electrical Access Panel Design 5 models 8 F Electrical Access Panel Design 7 and 8 models 9 F Washer 10 N/A Cable Tray Assembly 11 F External Supply Box 12 F External Supply Box Cover 13 F Screw 14 F Screw 15 F Nut 16 F Computer Cover 17 F Cable Tie 15 inch 18 F Cable Tie 6 inch 19 F Tie Wrap Mounting Clamp 20 F140219P Ribbon Cable 26-pin; 15 inch; Connects computer to output cca 21 F Computer Input Harness 22 F Battery 9 Volt; Backup 23 F Nut 24 F Washer 25 F P WE-6 Computer 26 F Momentary Switch Models through 5/26/04 26 F Momentary Switch Models starting 5/27/04 27 F Washer 28 F Washer 29 F Screw 30 N/A Emergency Stop Pushbutton 800E-series; Order F P Emergency Stop Button Kit 30 F Emergency Stop Pushbutton 800F-series; Models starting 10/1/07 31 F230724P Keypad Decal 32 F Control Module Decal 33 F Contact Block Switch 800E-series; Includes F Contact Block Switch 33 F Contact Block Switch 800E-series 33 F P Emergency Stop Button Kit Used to convert from 800E-series to 800F-series; Includes F Contact Block Switch and F Emergency Stop Pushbutton 33 F Contact Block Switch 800F-series; Models starting 10/1/07 N/A = Part no longer available F

18 Control Module - Models UW60P2 and UW60P3 (Drawing 2 of 4) PHM2650P_F F232166

19 Control Module - Models UW60P2 and UW60P3 (Drawing 2 of 4) REF PART NO. DESCRIPTION COMMENTS 1 F Standoff 2 F140219P Ribbon Cable 26-pin; 15 inch; Connects computer to output cca 3 F P Output CCA 4 F330177P Contactor 5 F330186P Interlock Contactor 6 F Fuse 1 Amp; Slo blo 6 F Fuse 1/2 Amp; Fast blo 6 F Fuse 1/8 Amp; Slo blo 7 F DIN Contactor Mounting Rail 8 F Screw 9 F Flange Relay 220 Volt 10 F Screw 11 F P Circuit Breaker F-voltage 12 F Nut 13 F Screw 14 F Filter Retainer Guard 15 F Buzzer 220 Volt F

20 Control Module - Models UW60P2 and UW60P3 (Drawing 3 of 4) PHM2548P_F F232166

21 Control Module - Models UW60P2 and UW60P3 (Drawing 3 of 4) REF PART NO. DESCRIPTION COMMENTS 1 F140575P Connector Gray 1 F140576P Connector Blue 2 F Circuit Breaker 1 Amp; Models through 5/11/03 2 F P Fuse Holder Models starting 5/12/03 2 F Fuse 2 Amp; Slo blo; Models starting 5/12/03 3 F Signal Light Red; 220 Volt 4 F Switch Mode Decal Models through 5/11/03 4 F Switch Mode Decal Models starting 5/12/03 5 F Cable Assembly 6 F Nut 7 F Insulator Bushing 8 F Input Block Decal 9 F Input Power Block 10 F Screw 11 F Ground Terminal Lug 12 F Washer 13 F Screw 14 F Resistor 12k, 5w 15 F Terminal Block 8 place 16 F Screw 17 F Ground Decal 18 F Fuse 3 Amp; Fast blo 19 F Fuse Holder 20 F Washer 21 F Nut 22 F Personal Injury Warning Decal 23 F340800P Keymode Run/Program Switch Includes item F Program Key A153 F

22 Control Module - Models UW60P2 and UW60P3 (Drawing 4 of 4) PHM2061P_F F232166

23 Control Module - Models UW60P2 and UW60P3 (Drawing 4 of 4) REF PART NO. DESCRIPTION COMMENTS 1 F P Water Level Switch 2 F422404P Tubing 3 F Connector 4 F Air Trap Hose 5 F Hose Clamp No F381723P 4-Way Valve 220 Volt 6 G582P3 Diaphragm and Guide Kit 220 Volt 7 F Snap Bushing F

24 Balance Switch, Temperature Probe and Rotation Sensor PHM2499P_F F232166

25 Balance Switch, Temperature Probe and Rotation Sensor REF PART NO. DESCRIPTION COMMENTS 1 H Nut Models UW60P2 and UW60P3; Models through 10/14/ Nut Models UW60P2 and UW60P3; Models starting 10/15/07 2 F Bolt Models UW60P2 and UW60P3; Models through 10/14/07 2 F Screw Models UW60P2 and UW60P3; Models starting 10/15/07 3 M Washer Models UW60P2 and UW60P3 4 M Washer Models UW60P2 and UW60P Nut Models UW60P2 and UW60P3; Models through 10/14/ Nut Models UW60P2 and UW60P3; Models starting 10/15/ Screw Models UW60P2 and UW60P3; Models through 10/14/07 6 F Screw Models UW60P2 and UW60P3; Models starting 10/15/07 7 F P Rotation Sensor PCB Models UW60P2 and UW60P3 8 F Standoff Models UW60P2 and UW60P3 9 F370606P Temperature Probe 10 F Nut Models UW60P2 and UW60P3 11 F Screw Models UW60P2 and UW60P3 12 F Rotation Sensor Harness Models UW60P2 and UW60P3 13 F P Rotation Sensor Assembly Models UW60P2 and UW60P3 13 F Rotation Sensor Retrofit Kit Includes items 7, 8, and 14; Models UW60P2 and UW60P3 14 F Rotation Sensor Bracket Models UW60P2 and UW60P3 15 F Interlock Switch Models UW60P2 and UW60P3 16 F Balance Switch Bracket Models UW60P2 and UW60P3; Models through 10/14/07 16 F Balance Switch Bracket Models UW60P2 and UW60P3; Models starting 10/15/07 F

26 Supply Dispenser PHM3158P_F F232166

27 Supply Dispenser REF PART NO. DESCRIPTION COMMENTS 1 F Screw 2 F Washer 3 F Dispenser Lid 4 F Plug Cap 5 F Strain Relief Adapter Kit Includes items 6 and 7 6 F140340P Strain Relief Connector 7 F O-Ring 8 F Chemical Supply Cup 32 ounce; 2 used 9 F Supply Dispenser Spacer 10 F Chemical Supply Cup 20 ounce; 3 used 11 F Hose Clamp No F Chemical Supply Hose 13 F Nut 14 F Washer 15 F Washer 16 F Supply Dispenser Hazard Caution Decal 17 F Soap Dispenser Shroud Weldment 18 F170158P Gasket 19 F170400RP Trim 20 F P Dispenser Assembly Includes items 3 and F Injection Nozzle 22 F O-Ring Nut 24 F Injection Nozzle Kit Includes items F

28 Water Supply Valve and Hoses to Supply Dispenser PHM2618P_F F232166

29 Water Supply Valve and Hoses to Supply Dispenser REF PART NO. DESCRIPTION COMMENTS 1 F Screw 2 N/A Flow Restrictor 3 F Strainer 4 F381724P 4-Way Valve 120 Volt 4 F381723P 4-Way Valve 220 Volt 4 G582P3 Diaphragm and Guide Kit 5 F Hose Connector Hose Clamp No. 6 7 F200110P Water Hose 8 F Y Connector N/A = Part no longer available F

30 Spray Plumbing - Design 5 UW60P2 and UW60P3 Models PHM1930P_F F232166

31 Spray Plumbing - Design 5 UW60P2 and UW60P3 Models REF PART NO. DESCRIPTION COMMENTS 1 F Spray Plumbing Assembly 220 Volt; Standard thread; Includes items 2-10, 15 and 16 1 F Spray Plumbing Assembly 220 Volt; Metric thread; Includes items 2-10, 15 and 16 2 F Street Elbow 3 F Nipple 4 F Tube Connector 5 F380800P Vacuum Breaker Valve 3/4 inch; F Repair Kit 6 F Tee 7 F Nipple 8 F381703P Valve 220 Volt; With DIN; 1/2 inch; F Valve Repair Kit 8 F141901P DIN Harness Assembly 9 F380987P DIN Coil 220 Volt 10 F Hose Adapter Standard thread 10 F Nipple Metric thread Washer Washer 13 F Water Hose Standard thread 13 F Water Hose Metric thread 14 F200401P U-Bolt Clamp Includes hardware 15 F Nipple 16 F Street Elbow F

32 Spray Plumbing - Design 7 and 8 UW60P2 and UW60P3 Models PHM2062P_F F232166

33 Spray Plumbing - Design 7 and 8 UW60P2 and UW60P3 Models REF PART NO. DESCRIPTION COMMENTS 1 F Spray Plumbing Assembly 220 Volt; Standard thread; Includes items 2-5, 11-16, 20 and 21 1 F Spray Plumbing Assembly 220 Volt; Metric thread; Includes items 2-5, 11-16, 20 and 21 2 F Elbow 3 F Nipple 4 F Tube Connector 5 F P Vacuum Breaker Valve 3/4 inch; Includes item 10; F Repair Kit 6 F O-Ring 7 F Containment Device 8 F Vacuum Breaker Cap 9 F Screw 10 F Vacuum Breaker Kit Includes items 6-9 and installation instructions 11 F Nipple 12 F Tee 13 F381703P Valve 220 Volt; 1/2 inch; F Valve Repair Kit 13 F141901P DIN Harness Assembly 14 F380987P DIN Coil 220 Volt 15 F Hose Adapter Standard thread 15 F Nipple Metric thread Washer Washer 18 F Water Hose Standard thread 18 F Water Hose Metric thread 19 F200401P U-Bolt Clamp Includes hardware 20 F Nipple 21 F Street Elbow F

34 Fill Plumbing - Design 5 UW60P2 and UW60P3 Models Through 2/29/02 PHM1931P_F F232166

35 Fill Plumbing - Design 5 UW60P2 and UW60P3 Models Through 2/29/02 REF PART NO. DESCRIPTION COMMENTS 1 F Street Elbow 2 F Nipple 3 F381701P Valve 220 Volt; With DIN; 3/4 inch; F Valve Repair Kit 3 F141901P DIN Harness Assembly 4 F380987P DIN Coil 220 Volt 5 F Tee 6 F Plug 7 F Hose Adapter Standard thread 7 F Adapter Metric thread Washer Washer 10 F Water Hose Standard thread 10 F Water Hose Metric thread 11 F Street Elbow 12 F Hose Barb 13 F Gate Valve 14 F Nipple 15 F Nipple 16 F Water Hose 17 F Hose Clamp No F200401P U-Bolt Clamp 19 F Hose Clamp No F200104P Hose 21 F Elbow 22 F Hose Barb 23 F380800P Vacuum Breaker Valve 3/4 inch; F Repair Kit 24 F Fill Plumbing Assembly Standard thread; Includes items 1-7, and F Fill Plumbing Assembly Standard thread; Starch; Includes items 1-7, and F Fill Plumbing Assembly Metric thread; Includes items 1-7, and F Fill Plumbing Assembly Metric thread; Starch; Includes items 1-7, and F

36 Fill Plumbing - Design 5 UW60P2 and UW60P3 Models Starting 3/1/02 PHM1775P_F F232166

37 Fill Plumbing - Design 5 UW60P2 and UW60P3 Models Starting 3/1/02 REF PART NO. DESCRIPTION COMMENTS NA F Fill Plumbing Assembly 220 Volt; Standard thread; Includes items 9, 11, 12, 14, 17, 18, and NA F Fill Plumbing Assembly 220 Volt; Metric thread; Includes items 9, 11, 12, 14, 17, 18, and NA F Fill Plumbing Assembly 220 Volt; Standard thread; Starch; Includes items 3-12, 14-18, and NA F Fill Plumbing Assembly 220 Volt; Metric thread; Starch; Includes items 3-12, 14-18, and Washer 2 F Water Hose Standard thread 2 F Water Hose Metric thread 3 F380987P DIN Coil 220 Volt; Starch models 4 F Gate Valve Starch models 5 F Street Elbow Starch models 6 F Nipple Starch models 7 N/A Nipple Starch models 8 F381703P Valve 220 Volt; Starch models; 1/2 inch 8 F141901P DIN Harness Assembly 8 F380993P Valve Repair Kit Starch models; 1/2 inch 9 F380987P DIN Coil 220 Volt 10 F Hose Barb Starch models 11 F Street Elbow 12 F Hose Barb Washer 14 F Hose Adapter Standard thread 14 F Adapter Metric thread 15 F Tee Starch models 16 F Nipple Starch models 17 F381701P Valve 220 Volt; 3/4 inch 17 F141901P DIN Harness Assembly 17 F380991P Water Valve Repair Kit 3/4 inch 18 F Nipple 19 F200401P U-Bolt Clamp 20 F Hose Clamp No F200104P Hose 22 F Elbow 23 F Nipple 24 F380800P Vacuum Breaker Valve 3/4 inch 24 F380965P Repair Kit 3/4 inch 25 F Tee 26 F Water Hose 27 F Hose Clamp No F Hose Barb 29 F Street Elbow 30 F Gate Valve 31 F Nipple N/A = Part no longer available F

38 Fill Plumbing - Design 7 and 8 UW60P2 and UW60P3 Models PHM2069P_F F232166

39 Fill Plumbing - Design 7 and 8 UW60P2 and UW60P3 Models REF PART NO. DESCRIPTION COMMENTS NA F Fill Plumbing Assembly 220 Volt; Standard thread; Includes items 8, 10-18, and NA N/A Fill Plumbing Assembly 220 Volt; Metric thread; Includes items 8, 10-18, and NA N/A Fill Plumbing Assembly 220 Volt; Standard thread; Starch; Includes items 3-18, and NA N/A Fill Plumbing Assembly 220 Volt; Metric thread; Starch; Includes items 3-18, and Washer 2 F Water Hose Standard thread 2 F Water Hose Metric thread 3 F380987P DIN Coil 220 Volt; Starch models 4 F Gate Valve Starch models 5 F Street Elbow Starch models 6 F Nipple Starch models 7 F381703P Valve 220 Volt; Starch models; 1/2 inch 7 F141901P DIN Harness Assembly 7 F380990P Valve Repair Kit Starch models; 1/2 inch 8 F380987P DIN Coil 220 Volt 9 F Hose Barb Starch models 10 F Screw 11 F Vacuum Breaker Cap 12 F Containment Device 13 F O-Ring 14 F P Vacuum Breaker Valve 3/4 inch; Includes items 10-13; F Repair Kit 15 F Vacuum Breaker Kit Includes items and installation instructions 16 F Nipple 17 F Street Elbow 18 F Hose Barb Washer 20 F Hose Adapter Standard thread 20 F Adapter Metric thread 21 F Tee 22 F381701P Valve 220 Volt; 3/4 inch 22 F141901P DIN Harness Assembly 22 F Valve Repair Kit 3/4 inch 23 F Nipple 24 F200401P U-Bolt Clamp 25 F Hose Clamp No F200104P Hose 27 F Elbow 28 F Water Hose 29 F Hose Clamp No F Hose Barb 31 F Nipple N/A = Part no longer available F

40 Fill Plumbing - Model UW60B2 PHM2045P_F F232166

41 Fill Plumbing - Model UW60B2 REF PART NO. DESCRIPTION COMMENTS Washer 2 F Water Hose Standard thread 2 F Water Hose Metric thread 3 F380987P DIN Coil 220 Volt; F141901P DIN Harness 4 F Street Elbow 5 F Hose Barb Washer 7 F Hose Adapter Standard thread 7 F Adapter Metric thread 8 F381701P Valve 220 Volt; 3/4 inch 8 F380991P Water Valve Repair Kit 3/4 inch 9 F Nipple 10 F200401P U-Bolt Clamp 11 F Hose Clamp No F200104P Hose 13 F Elbow 14 F Nipple 15 F P Vacuum Breaker Valve 3/4 inch; Includes item 20; F Repair Kit 16 F O-Ring 17 F Containment Device 18 F Vacuum Breaker Cap 19 F Screw 20 F Vacuum Breaker Kit Includes items F Tee 22 F Water Hose 23 F Hose Clamp No F Hose Barb 25 F Street Elbow 26 F Gate Valve 27 F Nipple 28 F Fill Plumbing Assembly 220 Volt; Standard thread; Includes items 3-5, 7-9, 13-19, 21 and N/A Fill Plumbing Assembly 220 Volt; Metric thread; Includes items 3-5, 7-9, 13-19, 21 and N/A = Part no longer available F

42 Drain System, Overflow and Vent Pipes PHM2630P_F F232166

43 Drain System, Overflow and Vent Pipes REF PART NO. DESCRIPTION COMMENTS 1 F Drain Valve Kit Includes item 5 2 F Overflow Plug Model UW60B2 3 F Hose Clamp Model UW60B2; No F380933P Drain Valve Motor Model UW60B2; 220 Volt 5 F Drain Valve Cover 6 F Vacuum Breaker 7 F Adapter 8 F Tee 9 F Pipe 10 F Hose Clamp No F Soap Dispenser Hose 12 F Pipe 13 F Shell Reinforcement Plate Assembly Includes item F Pop Rivet 15 F Scupper 16 F200107P Water Hose Hose Clamp No F Hose Barb 19 F Drain Hose 20 F Hose Clamp No F Reducer Bushing 22 F Pipe 23 F Tee 24 F Pipe 25 F Drain Hose Rear 26 F Drain Hose Front 27 F Main Drive Kit F

44 Basket, Shell and Frame PHM2926P_F F232166

45 Basket, Shell and Frame REF PART NO. DESCRIPTION COMMENTS 1 F602901P Spray Rinse Bracket Assembly Models UW60P2 and UW60P3 2 F603344P Shell Band Assembly 3 F170120RP Shell Band Gasket 4 F609200P Shell Front Weldment 4 F P Shell Front Assembly Includes item 4, top latch bracket casting, lower door latch bracket casting, door butt, bushing, door latch shim, door butt shim and door bumper moulding 5 F Basket Assembly Nut 7 M Washer 8 F Frame Assembly Models UW60B2 and UW60P2 8 F Frame Assembly Models UW60B2 and UW60P2; Close mount 8 F Frame Assembly Model UW60P3 8 F Frame Assembly Model UW60P3; Close mount 9 F Hose Barb Hose Clamp No F200107P Water Hose 12 F Scupper 13 F Pop Rivet 14 F Slinger 15 F Face Seal Standard 15 F Seal Kit Standard; Includes items 3, 14, 27, 28 and 30-32, sealant and installation instructions 15 F Face Seal Viton 16 F Shell Reinforcement Plate Assembly Includes items F Plug 18 F Plug Removal Warning Decal 19 F Drip Rail Attach with silicone 20 F Nut 21 M Washer 22 M Washer Screw 24 F Shell Mounting Bracket 25 F Washer 26 F Screw 27 F Screw 28 F Washer 29 F Shell Weldment Standard 29 F Shell Weldment Standard with starch 29 F Shell Weldment Electric heat 29 N/A Shell Weldment Electric heat with starch 30 F Nut 31 F Washer 32 F Screw 32 F Shell Band Fastener Kit Includes items 30 and F Shell Gasket Shield 34 N/A Screw N/A = Part no longer available F

46 Door and Spray Tube PHM2943P_F F232166

47 Door and Spray Tube REF PART NO. DESCRIPTION COMMENTS 1 F Screw Models UW60P2 and UW60P3 2 F Spray Rinse Strap Models UW60P2 and UW60P3 3 F Spray Rinse Tube Assembly Models UW60P2 and UW60P3 4 F Door Gasket Black 4 F Door Gasket Gray 5 F Door Kit Includes studs 6 F Nut 7 F Washer 8 F Door Glass Gasket 9 F290201P Glass Model UW60B2; Without hole 9 F290200P Door Glass Kit Models UW60P2 and UW60P3; With hole 10 F Rotation Decal 11 F Door Glass Retainer 12 F940P3 Door Kit Model UW60B2; Inlcudes items 4-11, 25, 28, F Push Decal, F Clear Sealant, F Magnetic Position Magnet, F Nut, F Screw, F Washer, F Washer, F Rivet and F Push Handle Weldment 12 F Door Kit Models UW60P2 and UW60P3; Includes items 4-11, 25, 28, magnet, door push handle and door push brace 13 F No-Swivel Coupling Models UW60P2 and UW60P3 14 F Spray Rinse Nozzle Kit Models UW60P2 and UW60P3 15 F Elbow Models UW60P2 and UW60P3 16 F Spray Rinse Hose Assembly Includes items 13 and 17; Models UW60P2 and UW60P3 17 F Swivel Coupling Models UW60P2 and UW60P3 18 F O-Ring Models UW60P2 and UW60P3 19 F Ring Retainer Models UW60P2 and UW60P3 20 F Screw 21 F602901P Spray Rinse Bracket Assembly Models UW60P2 and UW60P3 22 F Nut Models UW60P2 and UW60P3 23 F Door Bumper Moulding 24 F Door Bumper Bushing 25 F P Door Hinge Strap Kit 26 F Door Hinge Pin 27 F Door Butt Shim 28 F Screw Nut F

48 Door Lock PHM2157P_F F232166

49 Door Lock REF PART NO. DESCRIPTION COMMENTS 1 F Screw 2 F Door Handle Casting 3 F150201P Top Latch Bracket Casting 4 F Door Latch Bracket Shim 5 F Washer 6 F Nut 7 F Nut 8 F Lower Door Latch Casting 9 F Lower Door Latch Bracket Casting 10 F Nut 11 F Washer 12 F Door Box Mounting Plate Assembly 13 F Push Decal 14 F Handle Weldment 14 F Push Handle Kit Includes items and F Handle Spacer Use as needed 16 F Magnet 17 F Nut 18 F Magnetic Switch Assembly 19 F Screw 20 F Screw 21 F Pop Rivet 22 F Interlock Switch Spacer 23 F Interlock Switch 24 F330217P RC Network Filter 25 F Screw 26 F300129P Door Lock Solenoid 220 Volt 27 F Solenoid Spacer 28 F Door Box 28 F603666P Door Box Assembly Includes items 17-19, 26 and F Screw 30 F Screw 31 F Screw 32 F Washer 33 F Extension Arm Tab 34 F Screw 35 F Extension Arm Kit Includes items 7, 17, and F Washer F

50 Front, Side and Rear Panels P U SH PHM2489P_F F232166

51 Front, Side and Rear Panels REF PART NO. DESCRIPTION COMMENTS 1 F Screw 2 F Trim Seal Order 2 feet 3 F170400RP Trim 4 F Cage Wrap Weldment 5 F Hose Strap 6 F Nut Plastic insert 7 F Cap Plug 8 F Nut Tinnerman Screw 10 F Belt Inspection Port Cover 11 F P Rear Panel 12 F Do Not Push Decal 13 F Screw 14 F Side Panel Bracket 15 F Nut 16 F Washer 17 F635648P Side Panel Reversible 18 F Pin 19 F Nut 20 F Washer 21 F Screw 22 F Extrusion Insert Order 3 feet 23 F Rub Rail 24 F635649P Front Panel 25 F Sponge 26 F Side Panel Cover F

52 Motor and Pulley - Models UW60B2 and UW60P2 PHM2511P_F F232166

53 Motor and Pulley - Models UW60B2 and UW60P2 REF PART NO. DESCRIPTION COMMENTS 1 F Front Bearing Kit Includes seal and hardware 2 F Rear Bearing Kit Includes hardware 3 F Motor Adjustment Strap 4 F Motor Support Bushing 2 required; Used with F220303P Motor 5 F Motor Drip Shield 6 F Grease Instruction Decal Lubrication 7 F Grease Fitting 8 F Washer 9 F Air Coupling 10 J Connector 11 C000628P Tubing 12 F Cable Tie 6 inch 13 F Cotter Pin 14 F Motor Support Rod Kit Includes items 13 and Washer 16 F P Motor 208 or 240 Volt/3 Phase 16 F P Motor 380 or 415 Volt/50 Hertz/3 Phase; 440 or 480 Volt/60 Hertz/3 Phase; Includes item 4 17 F280146P Pulley BK34H 18 F Motor Bushing H F Key 20 F280409P Bushing 2-7/16; Includes item F Spring 22 F Key 23 F Bolt 24 M Washer 25 F Nut 26 F Belt BX F Pulley 1B255K F

54 Motor and Pulley - Model UW60P3 PHM2944P_F F232166

55 Motor and Pulley - Model UW60P3 REF PART NO. DESCRIPTION COMMENTS 1 F Front Bearing Kit Includes seal and hardware 2 F Rear Bearing Kit Includes hardware 3 F P Motor 208 or 240 Volt; Wash 3 F220425P Motor 380, 415, 440 or 480 Volt; Wash 4 F Pulley Bushing SH; 1-1/8; Extract; Inside 5 M Washer 6 F Screw Screw 8 F Air Coupling 9 F Grease Instruction Decal Lubrication 10 F Grease Fitting 11 F Washer 12 J Connector 13 C000628P Tubing 14 F Belt 60 Hertz; 3V355; 2 required 14 F Belt 50 Hertz; 3V375; 2 required 15 F Cable Tie 6 inch 16 F220413P Motor 208 or 240 Volt; Extract 16 F P Motor 380 or 415 Volt/50 Hertz; 440 or 480 Volt/60 Hertz; Extract 17 F280132P Pulley BK45H; Extract; Outside; 60 Hertz applications only 18 F280211P Motor Pulley Bushing H-1-1/8; Extract; Outside; Includes hardware and key 19 F Key 20 F Pulley 2GR3V6SH; Extract; Inside; 2 groove; 6 inch OD 21 F280298P Pulley Bushing JA 7/8; Includes item 19 and hardware; Wash 22 F Pulley 2G3V28JA; Wash; 2 groove; 2.8 inch OD 23 F Key 24 F Cable Tie 25 F Motor Drip Shield 26 F Key 27 F280409P Bushing 2-7/16; Includes item 26 and hardware 28 F Belt BX F Pulley 1B255K F

56 Electric Heat Option PHM2074P_F F232166

57 Electric Heat Option REF PART NO. DESCRIPTION COMMENTS 1 F360203P Heating Element 6 required 2 F370606P Temperature Probe 3 F Nut 4 F Nut 5 F Screw 6 F Box 7 M Terminal Block O and Q-voltage 7 F Input Power Block F, N and P-voltage 8 F Screw 9 F330188P Contactor 220 Volt 10 F Washer F

58 Steam Heat Option and Transformers PHM2075P_F F232166

59 Steam Heat Option and Transformers REF PART NO. DESCRIPTION COMMENTS NA F Pipe Insulation 1 F Plug 2 F Steam Injector Tube Assembly 3 F Street Elbow 4 F Steam Hose 5 F Nipple 6 F Plug 7 H Street Elbow 8 F380787P Steam Valve 1/2 inch; 220 Volt; F Steam Valve Repair Kit 9 F380987P DIN Coil 220 Volt 10 F Control Transformer Cover 11 F360156P Transformer F-voltage 12 F Screw 13 N/A Nipple Elbow 15 F Nipple 16 F200401P U-Bolt Clamp Includes washers and nuts 17 F Steam Filter 18 F Steam Bracket Weldment 19 F635653P Steam Plumbing Assembly 220 Volt; Includes items 2-9, 13-15, 17 and pipe insulation N/A = Part no longer available F

60 Security Fasteners Option One Option Two PHM2181P_F F232166

61 Security Fasteners REF PART NO. DESCRIPTION COMMENTS 1 F Screw No. 8; 32 x 1/2 inch; Used in place of F Screw; Typical location is the side panels and module cover 1 F Screw No. 10; 32 x 3/8 inch; Used in place of F Screw; Typical location is the module to the shell 1 F Hex Bit 2 F Screw 1/4 inch; 20 x 2-1/2 inch; Used in place of F Screw; Typical location is the door box to the bracket 2 F Screw 1/4 inch; 20 x 1-1/2 inch; Used in place of F Screw; Typical location is the side panel to the bracket 2 F Screw 1/4 inch; 20 x 1/2 inch; Used in place of F Screw; Typical location is the drive box or the cover 2 F Spanner Bit 3 F Screw 1/4 inch; 20 x 2-1/2 inch; Used in place of F Screw; Typical location is the door box to the bracket 3 N/A Phillips Bit 4 N/A Screw 1/4 inch; 20 x 1/2 inch; Used in place of F Screw; Typical location is the drive box or cover 4 N/A Hex Bit 5 F Screw No. 8; 32 x 1/2 inch; Used in place of F Screw; Typical location is the side panels and module cover 5 281P4 Torx Bit N/A = Part no longer available F

62 Special Tools PHM2981P_F F232166

63 Special Tools REF PART NO. DESCRIPTION COMMENTS NA F Rebar Frame Kit Order with equipment NA F Mounting Bolt Kit NA 1113P Concrete Hardware Kit 1 F Grease Gun Kit Includes items 2 and 3 2 F210206P Bearing Grease 3 F210207P Grease Gun 4 F Alignment Shaft Assembly 5 F Shaft Seal Alignment Fixture 6 F Rebar Frame Template F

64 Notes 62 F232166

65 Parts Index A Adapter F F , 35, 37, 39 Air Coupling F , 53 Air Trap Hose F , 21 Alignment Shaft Assembly F B Balance Switch Bracket F F Basket Assembly F Battery F Bearing Grease F210206P Before Power Is Connected Tag F Belt F , 53 F F Belt Inspection Port Cover F Bolt F F Box F Bushing F280409P... 51, 53 Buzzer F C Cable Assembly F Cable Tie F , 51, 53 F Cable Tray Cover F F Cage Wrap Weldment F Cap Plug F Chemical Supply Cup F F Chemical Supply Hose F Circuit Breaker F F F P...17 Clockwise Spin Rotation Decal F Cold Water Valve Decal F Computer F P...9 Computer Cover F Computer Input Harness F Concrete Hardware Kit 1113P...61 Conductor Decal F Connector F140575P...19 F140576P...19 F , 21 J , 53 Contact Block Switch F , 15 F , 15 F , 15 Contactor F330177P...11, 17 F330188P...55 Containment Device F , 37, 39 Control Cover F Control Module Cover F , 15 Control Module Decal F F Control Transformer Cover F Cotter Pin F D Diaphragm and Guide Kit G582P3...9, 21, 27 DIN Coil F380987P...29, 31, 33, 35, 37, 39, 57 DIN Contactor Mounting Rail F , 17 DIN Harness Assembly F141901P...29, 31, 33, 35, 37 Disconnect Power Warning Label , 9, 15 Dispenser Assembly F P...25 N/A items do not appear in index. F

66 Dispenser Lid F Do Not Push Decal F , 49 Door Box F Door Box Assembly F603666P Door Box Mounting Plate Assembly F Door Bumper Bushing F Door Bumper Moulding F Door Butt Shim F Door Gasket F F Door Glass Gasket F Door Glass Kit F290200P Door Glass Retainer F Door Handle Casting F Door Hinge Pin F Door Hinge Strap Kit F P Door Kit F F F940P Door Latch Bracket Shim F Door Lock Solenoid F300129P Drain Hose F F F Drain Valve Cover F Drain Valve Kit F Drain Valve Motor F380933P Drip Rail F E Emergency Stop Button Kit F P...9, 15 Emergency Stop Pushbutton F , 15 Extension Arm Kit F Extension Arm Tab F External Supply Box F , 15 External Supply Box Cover F F External Supply Caution Decal F External Supply Connection Decal F F Extrusion Insert F F Face Seal F F Fill Plumbing Assembly F , 39 F , 35 F , 35 F , 35 F , 35 Filter Retainer Guard F Flange Relay F , 17 Frame Assembly F F F F Front Bearing Kit F , 53 Front Panel F635649P...49 Fuse F , 17 F , 17 F , 17 F F Fuse Holder F F P...19 Elbow F F , 35, 37, 39 F Electrical Access Panel F F G Gasket F170158P...25 Gate Valve F , 35, 37, 39 N/A items do not appear in index. 64 F232166

67 Glass F290201P Grease Fitting F , 53 Grease Gun F210207P Grease Gun Kit F Grease Instruction Decal F , 53 Ground Decal F , 19 Ground Terminal Lug F , 19 H Handle Spacer F Handle Weldment F Heating Element F360203P Hex Bit F Input Power Decal F Insulator Bushing F , 19 Interlock Contactor F330186P...11, 17 Interlock Switch F , 47 Interlock Switch Spacer F K Key F , 53 F , 53 F Keymode Run/Program Switch F340800P...19 Keypad F P...9 Keypad Decal F230724P...15 Hose F200104P... 33, 35, 37, 39 Hose Adapter F , 31 F , 35, 37, 39 Hose Barb F , 43 F , 35, 37, 39 F , 35, 37, 39 Hose Clamp F F , 35, 37, 39 F , 41 F , 21, 41 F , 35, 37, , 41, 43 Hose Connector F Hose Strap F Hot Surface Warning Decal F F Hot Water Valve Decal F I Injection Nozzle F Injection Nozzle Kit F Input Block Decal F Input Power Block F F , 19 N/A items do not appear in index. F L Lower Door Latch Bracket Casting F Lower Door Latch Casting F M Magnet F Magnetic Switch Assembly F Main Drive Kit F Main Harness F Momentary Switch F , 15 F , 15 Motor F220413P...53 F220425P...53 F P...51 F P...51, 53 F P...53 Motor Adjustment Strap F Motor Bushing F Motor Drip Shield F F Motor Pulley Bushing F280211P...53 Motor Support Bushing F

68 Motor Support Rod Kit F Mounting Bolt Kit F N Nipple F , 31, 33, 35, 37, 39 F , 31, 33, 35, 37 F , 31, 33, 35, 37, 39 F , 37, 39 F F F , 31 No-Swivel Coupling F Nut F F F F , 47, 49, 55 F F , 15, 17, 47, 55 F F F , 13, 15, 19 F F F , 45 F , 15, 45, 47 F H , O O-Ring F , 37, 39 F F F Output Board Cover F Output CCA F F P Overflow Plug F P Personal Injury Warning Decal F , 19 Pin F Pipe F F F F Pipe Insulation F Plug F F F F Plug Cap F Plug Removal Warning Decal F Pop Rivet F , 43, 47 Program Key F Pulley F280132P...53 F280146P...51 F F F , 53 Pulley Bushing F F280298P...53 Push Decal F Push Handle Kit F N/A items do not appear in index. 66 F R RC Network Filter F330217P...47 Rear Bearing Kit F , 53 Rear Panel F P...49 Rebar Frame Kit F Rebar Frame Template F Reducer Bushing F Repair Kit F380965P...35 Resistor F Ribbon Cable F140219P...15, 17 F , 11 Ring Retainer F Rotation Decal F Rotation Sensor Assembly F P...23 Rotation Sensor Bracket F Rotation Sensor Harness F Rotation Sensor PCB F P...23

69 Rotation Sensor Retrofit Kit F Rub Rail F S Screw F F F F F F F F F F F , 17, 19 F F , 17, 19, 55 F F , 15, 25, 45, 47 F F F F , 47 F , 11, 15, 17 F , 57 F , 31, 37, 39, 55 F F , 49 F F , 47 F F F F F F F F , , 15, , 43, 53 Scupper F , 43 Seal Kit F Shaft Seal Alignment Fixture F Shell Band Assembly F603344P Shell Band Fastener Kit F Shell Band Gasket F170120RP Shell Front Assembly F P Shell Front Weldment F609200P Shell Gasket Shield F Shell Mounting Bracket F Shell Reinforcement Plate Assembly F , 43 Shell Weldment F F F Side Panel F635648P...49 Side Panel Bracket F Side Panel Cover F Signal Light F Slinger F Snap Bushing F , 21 Soap Dispenser Hose F Soap Dispenser Shroud Weldment F Solenoid Spacer F Spanner Bit F Sponge F Spray Plumbing Assembly F F F F Spray Rinse Bracket Assembly F602901P...43, 45 Spray Rinse Hose Assembly F Spray Rinse Nozzle Kit F Spray Rinse Strap F Spray Rinse Tube Assembly F Spring F Standoff F , 23 F Steam Bracket Weldment F Steam Filter F Steam Hose F Steam Injector Tube Assembly F Steam Plumbing Assembly F635653P...57 Steam Valve F380787P...57 Strain Relief Adapter Kit F Strain Relief Connector F140340P...25 N/A items do not appear in index. F

70 Strainer F Street Elbow F , 31, 33, 35, 37, 39 F , 33, 35, 37, 39 F H Supply Dispenser Hazard Caution Decal F , 25 Supply Dispenser Spacer F Switch Mode Decal F F Swivel Coupling F T Tee F , 33 F F , 37, 39 F F F Temperature Probe F370606P... 23, 55 Terminal Block F , 19 M This Machine Must Be Protected Decal F Tie Wrap Mounting Clamp F Top Latch Bracket Casting F150201P Torx Bit 281P Transformer F360156P Trim F170400RP... 25, 49 Trim Seal F Tube Connector F , 31 Tubing C000628P... 51, 53 F422404P... 9, 21 U U-Bolt Clamp F200401P... 29, 31, 33, 35, 37, 39, 57 V Vacuum Breaker F Vacuum Breaker Cap F , 37, 39 Vacuum Breaker Kit F , 37, 39 Vacuum Breaker Valve F P...31, 37, 39 F380800P...29, 33, 35 Valve F381701P...33, 35, 37, 39 F381703P...29, 31, 35, 37 Valve Repair Kit F F380990P...37 F380993P...35 Valve, 4-Way F381723P...9, 21, 27 F381724P...27 W Washer F F , 49 F , 53 F , 45, 47, 49 F , 19 F , 15, 19, 47 F F , 15 F F F , 15 F F F F M M , 43, 53 M M , , 31, 33, 35, 37, , 31, 33, 35, 37, Water Hose F200107P...41, 43 F200110P...27 F , 31, 33, 35, 37, 39 F , 31, 33, 35, 37, 39 F , 35, 37, 39 Water Level Switch F P...9, 21 Water Pressure Switch F P...9 Water Valve Repair Kit F380991P...35, 39 WE-6 Computer F P...15 N/A items do not appear in index. 68 F232166

71 Y Y Connector F N/A items do not appear in index. F

72 Notes 70 F232166