Washer-Extractor. Parts. Twin Tub. UM202 - Design 2 and 3 Models. Design 2 Models. Design 3 Models CAR5C_F232208

Size: px

Start display at page:

Download "Washer-Extractor. Parts. Twin Tub. UM202 - Design 2 and 3 Models. Design 2 Models. Design 3 Models CAR5C_F232208"

Molly French
5 years ago
Views:

1 Washer-Extractor Twin Tub UM202 - Design 2 and 3 Models Parts Design 2 Models Design 3 Models CAR5C_F Part No. F232208R12 November 2014

3 Table of Contents Title Page Parts Ordering Information... 2 Serial Plate Location... 2 Model Identification... 3 Panels, Tub and Frame - Design 2 Models... 4 Panels, Tub and Frame - Design 3 Models... 6 Lid - Models Through June, Lid - Models Starting July, Lid Lock Assembly Lock - Design 2 Models Lock - Design 3 Models Control Panel - Design 2 Models Control Panel - Design 3 Models Electrical Box - Design 2 Models (Drawing 1 of 2) Electrical Box - Design 2 Models (Drawing 2 of 2) Electrical Box - Design 3 Models Spray-Rinse and Fill Plumbing Drain Plumbing Drain Valve Motor - Design 2 Models Motor - Design 3 Models Transmission and Agitator Assembly - Models Through August Transmission and Agitator Assembly - Models Starting September 2003 Through December Transmission and Agitator Assembly - Models Starting January Parts Index Copyright 2014, Alliance Laundry Systems LLC All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed written consent of the publisher. F

4 If literature or replacement parts are required, contact the source from whom the machine was purchased or contact Alliance Laundry Systems at (920) for the name and address of the nearest authorized parts distributor. Parts Ordering Information For technical assistance, call either of the numbers listed below: (920) Ripon, Wisconsin Wevelgem, Belgium When calling or writing about your product, be sure to mention model and serial numbers. Model and serial numbers are located on serial plate as shown. Serial Plate Location Ripon, WI U.S.A. CAR37N_F F232208

5 Model Identification Information in this manual is applicable to this washer-extractor model: UM202 NOTE: Models with a 2 or 3 in the 10th character in the model number (e.g., UM202M1AU20001 or UM202M1AU30001). This character denotes model design series. F

6 Panels, Tub and Frame - Design 2 Models CAR2423P_F F232208

7 Panels, Tub and Frame - Design 2 Models REF PART NO. DESCRIPTION COMMENTS NA F Basket Hub Center Kit Replacement kit for item 1 1 F602568P Basket Assembly 2 F Basketball Slides onto motor shaft 3 F Electrical Back Panel 4 F Tub Assembly 5 F Screw 6 F Washer 7 F Motor Rail 8 F Screw 9 F Screw 10 F Washer 11 F End Wrap 12 F Washer 13 F Screw 14 F Frame Weldment 15 F Nut 16 M Washer 17 F Nut 18 F Skirt Panel 19 F Logo Decal 20 F Screw 21 F Snap Bushing F

8 Panels, Tub and Frame - Design 3 Models CAR2437P_F F232208

9 Panels, Tub and Frame - Design 3 Models REF PART NO. DESCRIPTION COMMENTS NA F Basket Hub Center Kit Replacement kit for item 1 1 F602568P Basket Assembly 2 F Basketball Slides onto motor shaft 3 F Tub Assembly 4 F Rear Panel Right 5 F Screw 6 F Washer 7 F Screw 8 F Washer 9 F Frame Weldment 10 F Side Wrap Right 11 F Washer 12 F Screw 13 F Nut 14 F Nut 15 M Washer 16 F Front Skirt Assembly 17 F Side Wrap Left 18 F Screw 19 F Motor Rail 20 F Rear Panel Left F

10 Lid - Models Through June, 2007 CAR2422P_F F232208

11 Lid - Models Through June, 2007 REF PART NO. DESCRIPTION COMMENTS 1 F Screw 2 F Washer 3 F Lid Hinge Assembly 4 F Magnetic Switch Assembly 5 F Washer 6 F Nut 7 F Washer 8 F Gasket 9 F Magnetic Switch Magnet 10 F Rivet Post 11 F Extractor Lid Kit 12 F P Lid Handle Weldment 13 F Washer 14 F Screw 15 F Machine May Be Hot Warning Decal 16 F Rotation Decal 17 F Screw 18 F Nut 19 F340403P Switch 20 F Pushbutton Boot F

12 Lid - Models Starting July, 2007 CAR2438P_F F232208

13 Lid - Models Starting July, 2007 REF PART NO. DESCRIPTION COMMENTS 1 F Screw 2 F Washer 3 F Nut 4 F Lid Hinge Assembly 5 F Screw 6 F Washer 7 F Rivet Post 8 F Extractor Lid Kit Includes F Extractor Lid and items 6 and 14 9 F Magnetic Switch Magnet 10 F Screw 11 F P Lid Handle Weldment 12 F Washer 13 F Screw 14 F Machine May Be Hot Warning Decal Models through 1/10/12 14 F Warning Label Models starting 1/11/12 15 F Rotation Decal Models through 1/10/12 16 F Warning Label Models starting 1/11/12 F

14 Lid Lock Assembly CAR2428P_F F232208

15 Lid Lock Assembly REF PART NO. DESCRIPTION COMMENTS 1 F Screw 2 F Lid Lock Slide Carrier 3 F Lid Lock Spring 4 F Lid Lock Slide 5 F Cotter Pin 6 F Support Bracket 7 F Nut 8 F Nut Models starting 7/10/07 9 F Washer Models starting 7/10/07 10 F Spacer Models starting 7/10/ Grommet Models starting 7/10/07 through 1/10/12 11 F Grommet Models starting 1/11/12 12 F P Magnetic Sensor Switch Assembly Models starting 7/10/07 through 1/10/12 12 F Magnetic Sensor Switch Assembly Models starting 1/11/12 13 F Screw Models starting 7/10/07 14 F Lid Lock Cable 15 F Pop Rivet 16 F730368P Lid Lock and Cable Kit Includes items 2-6, 8-9 and 11-15; Old style 17 F605423P Lid Lock Assembly Includes items 1-16 and the lid handle assembly; New style; Models through 1/10/12 17 F Lid Lock Assembly Includes items 1-15; Models starting 1/11/12 F

16 Lock - Design 2 Models CAR1711P_F F232208

17 Lock - Design 2 Models REF PART NO. DESCRIPTION COMMENTS 1 F Nut 2 F Cap 3 F Nut 4 F Solenoid Spring 5 F Nut 6 F Lid Lock Solenoid 220 Volt 7 F Screw 8 F Nut 9 F Washer 10 F Lid Lock Mounting Bracket Assembly 11 F Screw 12 F Lid Lock Cable Grommet 14 F Screw F

18 Lock - Design 3 Models CAR2439P_F F232208

19 Lock - Design 3 Models REF PART NO. DESCRIPTION COMMENTS Grommet 2 F Lid Lock Cable 3 F Nut 4 F Screw 5 F Nut 6 F Solenoid Bracket Screw 8 F Cap 9 F Solenoid Spring 10 F Lid Lock Solenoid 220 Volt F

20 Control Panel - Design 2 Models CAR2429P_F F232208

21 Control Panel - Design 2 Models REF PART NO. DESCRIPTION COMMENTS NA F Clock Panel Harness Models through 7/9/07 NA F P Clock Panel Harness Models starting 7/10/07 1 F Timer Assembly 220 Volt/60 Hertz; Includes items 16 and 17 1 F952P3 Timer Kit 230 Volt/50/60 Hertz; Includes Terminal 1 F Timer and Terminal Assembly 220 Volt/50 Hertz; Includes Terminal 1 F Timer Assembly 220 Volt/50 Hertz; Includes items 16 and 17 2 F Selector Switch Models starting 1/1/08; 800 F-series; Temperature; Includes items F Contact Block Switch Includes F Contact Switch and F Contact Base 3 F Contact Base 4 F Contact Block Switch Models through 12/31/07; 800 E-series; Temperature; Order F P Selector Switch Kit 4 F Contact Switch Models starting 1/1/08; 800 F-series; Temperature 5 F Selector Switch Models starting 1/1/08; 800 F-series 6 F Washer P Pressure Switch 8 F Nut 9 F340403P Switch 10 F Pushbutton Boot 11 F Nut 12 F Relay 13 F Screw 14 F Wash/Rinse Decal Right 15 F Signal Light 16 F Screw 17 JA Timer Knob 18 F Screw 19 F Knob 20 F Wash/Extract Decal Left F

22 Control Panel - Design 3 Models CAR2446P_F F232208

23 Control Panel - Design 3 Models REF PART NO. DESCRIPTION COMMENTS NA F Clock Panel Harness Models through 7/9/07 NA F P Clock Panel Harness Models starting 7/10/ P Timer 24 Volt/50 or 60 Hertz Switch 3 F Washer 4 F Nut P Pressure Switch 6 F340403P Switch 7 F Pushbutton Boot 8 F Control Overlay Right Indicator Light 10 JA Timer Knob 11 F Screw Nut 13 F Screw 14 F Knob Nut 16 F Control Overlay Left F

24 Electrical Box - Design 2 Models (Drawing 1 of 2) CAR2435P_F F232208

25 Electrical Box - Design 2 Models (Drawing 1 of 2) REF PART NO. DESCRIPTION COMMENTS NA F P Control Box Harness Models through 7/9/07 NA F P Control Box Harness Models starting 7/10/07 NA F P Valve Transition Kit Use with F Valve NA F DIN Valve Adapter Kit Use with F Valve NA F Coil Use with F Valve NA G582P3 Diaphragm and Guide Kit Use with F P 3-Way Valve 1 F Motor Drip Shield 2 F Screw 3 F Screw 4 F Input Power Block 4 terminal; C-voltage 4 F Input Power Block 3 terminal; All other voltage models 5 F Input Power Block Insulator 6 F Input Power Block Decal 7 F Ground Decal 8 F Clinch Plate Assembly 9 F Nut 10 F Ground Terminal Lug 11 F Screw 12 F Washer 13 F Ground Decal 14 F Nut 15 J Fuse Holder 16 J Fuse 17 F Nut 18 F Electrical Control Box Wrap Screw 20 F Screw 20 J Screw Screw 22 F P 3-Way Valve 22 F P Valve Replaces F381703P Valve; Includes F Valve and F Coil 23 F Cap 3 required 24 F Clinch Plate Assembly 25 F Screw Hose Clamp 3 required 27 F Contactor Mounting Plate F

26 Electrical Box - Design 2 Models (Drawing 2 of 2) CAR 2436P_F F232208

27 Electrical Box - Design 2 Models (Drawing 2 of 2) REF PART NO. DESCRIPTION COMMENTS 1 M Relay 2 F Screw 3 F Standoff 3 F Screw 4 F Fuse Holder Expansion Clip 6 F Fuse 1 Amp; Slo blo P Transformer 8 F Screw Screw 10 F Snap Bushing 11 F330177P Contactor C16 12 F330185P Auxiliary Contactor 100-FA11 13 F Cold Water Valve Decal 14 F Hot Water Valve Decal 15 F This Machine Must Be Protected Decal 16 F Motor Equipped with Auto Decal Disconnect Power Warning Label 18 F Electrical Box Cover 19 F Screw 20 F Flange Relay Screw 22 F Fuse 1/4 Amp; Fast blo 23 F P Rotation Detection CCA 24 F Standoff 25 F360156P Transformer F-voltage F

28 Electrical Box - Design 3 Models CAR2441P_F F232208

29 Electrical Box - Design 3 Models REF PART NO. DESCRIPTION COMMENTS NA F P Control Box Harness Models through 7/9/07 NA F P Control Box Harness Models starting 7/10/07 NA G582P3 Diaphragm and Guide Kit Use with F P 3-Way Valve Screw Expansion Clip 3 M414228P Transformer 4 F Electrical Plate 5 M Ground Lug Connector 6 F Screw Screw Male Tab Terminal 9 F Nut 10 F Use Copper Conductors Only Caution Label 11 M Earth Terminal Sticker 12 F Ground Decal Wire Label Terminal Block 15 M Insulator Terminal Block Shield Screw Bushing 19 F P 3-Way Valve 19 F DIN Valve Kit Screw 21 F Valve Box 22 F Cap 3 required Hose Clamp 3 required 24 F Screw 25 F Electrical Box 26 F Control Assembly 27 F330176P Contactor 28 F330186P Interlock Contactor 29 F Pushmount Clamp Pop Rivet 31 F DIN Rail F

30 Spray-Rinse and Fill Plumbing CAR2413P_F F232208

31 Spray-Rinse and Fill Plumbing REF PART NO. DESCRIPTION COMMENTS 1 F Screw 2 F Washer 3 F Spout Weldment 4 F Rinse Nozzle Assembly 5 F Hose Clamp No F200128P Water Hose Hose Clamp No. 6 8 F Manifold 9 F200108P Water Hose Washer 11 F Water Hose 3/8 inch; Standard thread 11 F Water Hose 3/8 inch; Metric thread 12 F Nipple 13 J Pipe Elbow 14 F Washer Models through 10/13/2006 F

32 Drain Plumbing CAR2448P_F F232208

33 Drain Plumbing REF PART NO. DESCRIPTION COMMENTS 1 F Screw 2 F Flanged Elbow Gasket 3 F Drain Elbow 4 F Washer 5 F Nut 6 F Hose Clamp No F Hose 8 F Hose Clamp No F Hose Clamp 10 F Air Trap Hose 11 F Hose 12 F200114P Hose Order 1 foot 13 F Drain Valve Manifold 14 F200114P Hose F

34 Drain Valve CAR2449P_F F232208

35 Drain Valve REF PART NO. DESCRIPTION COMMENTS 1 F Insulator Bushing 2 F Push-Pull Knob 3 F Pipe 4 F Screw 5 F Washer 6 F Drain Valve Flange Assembly Includes items 1 and 3 7 F Hose Clamp 8 F Air Trap Hose 9 F Screw 10 F Drain Valve Gasket 2 required 11 F Drain Valve 12 F Washer 13 F Nut 14 F Nut 15 F Washer 16 F Drain Valve Disc 17 F Drain Valve Rod 18 F Cotter Pin 19 F Drain Valve/Air Trap Assembly Includes items 2-6 and F

36 Motor - Design 2 Models CAR 2415P_F F232208

37 Motor - Design 2 Models REF PART NO. DESCRIPTION COMMENTS NA F Rotation Sensor Kit Includes F Connector, F Connector, F Cable Tie, F Connector, F Bushing, F Rotation Sensor Harness Assembly, F Proximity Gauge, F Proximity Wheel, F Screw, F Drip Cover Assembly, J Flexible Conduit 1 F Flinger 2 F Screw 3 M Washer 4 F Trunnion Cap 5 F Screw 6 M Washer 7 F Trunnion 8 F Z-Clip 9 F Motor Support Ear 9 F Motor Mount Bracket Weldment 10 F P Motor Kit Includes F Motor; Replaces F Motor 11 F Extract Motor Harness 12 M Washer 13 F Nut 14 F Washer 15 F Trunnion Frame 16 F Trunnion Frame Angle 17 F Screw 18 F Sponge Rubber 19 F Basketball F

38 Motor - Design 3 Models CAR2442P_F F232208

39 Motor - Design 3 Models REF PART NO. DESCRIPTION COMMENTS NA F Rotation Sensor Kit Includes F Connector, F Connector, F Cable Tie, F Connector, F Bushing, F Rotation Sensor Harness Assembly, F Proximity Gauge, F Proximity Wheel, F Screw, F Drip Cover Assembly, J Flexible Conduit NA F Motor Wrap Bracket Weldment 1 F Basketball 2 F Flinger 3 F Screw 4 M Washer 5 F Trunnion Cap 6 F Trunnion 7 F Z-Clip 8 F Motor Mount Bracket Weldment 9 F P Motor Kit Includes F Motor; Replaces F Motor 10 F Extract Motor Harness 10 F Extract Motor Harness Use with F Extract Motor 11 M Washer 12 F Screw 12 F Screw Use with F Extract Motor 13 M Washer 14 F Nut 14 F Nut Use with F Extract Motor 15 F Washer 15 M Washer Use with F Extract Motor 16 F Trunnion Frame 17 F Trunnion Frame Angle 18 F Screw 18 M Screw Use with F Extract Motor 19 F Sponge Rubber F

40 Transmission and Agitator Assembly - Models Through August 2003 CAR2426P_F F232208

41 Transmission and Agitator Assembly - Models Through August 2003 REF PART NO. DESCRIPTION COMMENTS 1 F Screw 2 F Washer 3 F Transmission Adaptor Plate 4 F Screw 5 F Washer Agitator Bell Plug Screw P Drive Bell and Seal Kit Includes items 7, 8 and Bell and Transmission Tube Seal Nut 12 F Spacer 13 F Nut 14 F Spacer 15 F Screw P Transmission Assembly 17 F Motor/Transmission Plate Assembly Includes items 27-29, 31 and F Washer 19 F Nut 20 F Nut Pulley Assembly 22 F Belt Helix 24 F Motor and Transmission Cover Washer Screw 27 F Screw 28 F Washer 29 F Motor/Transmission Bracket 30 F Screw 31 F Washer 32 F Nut 33 F Motor Pulley AS2.30 x 1/2 34 F Screw 35 F P Motor 208 or 220 Volt/50 or 60 Hertz/3 Phase 36 F Transmission Motor Clamp 37 F Transmission Motor Base 38 F Nut 39 F Drain Elbow 40 F Flanged Elbow Gasket 41 F P Wash Motor Harness F

42 Transmission and Agitator Assembly - Models Starting September 2003 Through December 2011 CAR2434P_F F232208

43 Transmission and Agitator Assembly - Models Starting September 2003 Through December 2011 REF PART NO. DESCRIPTION COMMENTS 1 F Screw 2 F Washer 3 F Transmission Adaptor Plate 4 F Screw 5 F Washer Agitator Bell Plug Screw P Drive Bell and Seal Kit Includes items 7, 8 and Bell and Transmission Tube Seal Nut Spline Insert Models starting 10/14/ F Spacer 14 F Nut 15 F Spacer 16 F Screw P Transmission Assembly 18 F Motor/Transmission Plate Assembly 19 F Nut 20 F Nut 21 F Washer Pulley Assembly 23 F Belt Helix 25 F Motor and Transmission Cover Washer Screw 28 F Screw 29 F Motor Pulley AS2.30 x 1/2 30 F Screw 31 F P Motor 208 or 220 Volt/50 or 60 Hertz/3 Phase 32 F Transmission Motor Clamp 33 F Transmission Motor Base 34 F Nut 35 F Drain Elbow 36 F Flanged Elbow Gasket 37 F P Wash Motor Harness F

44 Transmission and Agitator Assembly - Models Starting January 2012 CAR2443P_F F232208

45 Transmission and Agitator Assembly - Models Starting January 2012 REF PART NO. DESCRIPTION COMMENTS 1 F Transmission Adaptor Plate 2 F Washer 3 F Screw 4 F Screw 5 F Washer Agitator Bell Plug Screw P Drive Bell and Seal Kit Includes items 7, 8 and Bell and Transmission Tube Seal Nut Spline Insert Models starting 10/14/ F Spacer 14 F Nut 15 F Spacer 16 F Screw P Transmission Assembly 18 F Motor/Transmission Plate Assembly 19 F Nut Isolator Post Motor Mount 22 F Motor Support Cover 23 F Nut Motor Mount Nut Pulley Assembly 27 F Belt Helix Washer Screw 31 F Screw 32 F Nut 33 F Drain Elbow 34 F Flanged Elbow Gasket P Motor Assembly 208 or 220 Volt/50 or 60 Hertz/3 Phase 36 F P Agitator Harness F

46 Notes 44 F232208

47 Parts Index A Agitator , 41, 43 Agitator Harness F P Air Trap Hose F , 33 Auxiliary Contactor F330185P B Basket Assembly F602568P... 5, 7 Basket Hub Center Kit F , 7 Basketball F , 7, 35, 37 Bell and Transmission Tube Seal , 41, 43 Bell Plug , 41, 43 Belt F , 41, 43 Bushing C Cap F , 17 F , 27 Clinch Plate Assembly F F Clock Panel Harness F , 21 F P... 19, 21 Coil F Cold Water Valve Decal F Contact Base F Contact Block Switch F F Contact Switch F Contactor F330176P F330177P Contactor Mounting Plate F Control Assembly F Control Box Harness F P...23, 27 F P...23, 27 Control Overlay F F Cotter Pin F F D Diaphragm and Guide Kit G582P3...23, 27 DIN Rail F DIN Valve Adapter Kit F DIN Valve Kit F Disconnect Power Warning Label Drain Elbow F , 39, 41, 43 Drain Valve F Drain Valve Disc F Drain Valve Flange Assembly F Drain Valve Gasket F Drain Valve Manifold F Drain Valve Rod F Drain Valve/Air Trap Assembly F Drive Bell and Seal Kit 39508P...39, 41, 43 E Earth Terminal Sticker M Electrical Back Panel F Electrical Box F Electrical Box Cover F Electrical Control Box Wrap F Electrical Plate F End Wrap F N/A items do not appear in index. F

48 Expansion Clip , 27 Extract Motor Harness F , 37 F Extractor Lid Kit F , 11 F Flange Relay F Flanged Elbow Gasket F , 39, 41, 43 Flinger F , 37 Frame Weldment F , 7 Front Skirt Assembly F Fuse F F J Fuse Holder F J G Gasket F Grommet F , Ground Decal F F , 27 Ground Lug Connector M Ground Terminal Lug F H Helix , 41, 43 Hose F200114P F F Hose Clamp F F F F , , 27, 29 Hot Water Valve Decal F I Indicator Light Input Power Block F F Input Power Block Decal F Input Power Block Insulator F Insulator M Insulator Bushing F Interlock Contactor F330186P...27 Isolator Post K Knob F , 21 L Lid Handle Weldment F P...9, 11 Lid Hinge Assembly F F Lid Lock and Cable Kit F730368P...13 Lid Lock Assembly F605423P...13 F Lid Lock Cable F , 15, 17 Lid Lock Mounting Bracket Assembly F Lid Lock Slide F Lid Lock Slide Carrier F Lid Lock Solenoid F , 17 Lid Lock Spring F Logo Decal F M Machine May Be Hot Warning Decal F , 11 Magnetic Sensor Switch Assembly F P...13 F N/A items do not appear in index. 46 F232208

49 Magnetic Switch Assembly F Magnetic Switch Magnet F , 11 Male Tab Terminal Manifold F P , 41, Pipe F Motor F P... 39, 41 Motor and Transmission Cover F , 41 Motor Assembly 35030P Motor Drip Shield F Motor Equipped with Auto Decal F Motor Kit F P... 35, 37 Motor Mount Motor Mount Bracket Weldment F , 37 Motor Pulley F , 41 Motor Rail F , 7 Motor Support Cover F Motor Support Ear F Motor Wrap Bracket Weldment F Motor/Transmission Bracket F Motor/Transmission Plate Assembly F , 43 F N Pipe Elbow J Pop Rivet F Pressure Switch 35889P...19, 21 Pulley Assembly , 41, 43 Pushbutton Boot F , 19, 21 Pushmount Clamp F Push-Pull Knob F R Rear Panel F F Relay F M Rinse Nozzle Assembly F Rivet Post F , 11 Rotation Decal F , 11 Rotation Detection CCA F P...25 Rotation Sensor Kit F , 37 Nipple F Nut F , 39, 41, 43 F , 17 F , 37 F , 7, 39, 41, 43 F , 7 F F F , 41, 43 F , 15, 19, 21 F , 41, 43 F , 17, 33, 39 F , 27 F , 15, 19 F F F F , S Screw F F , 37 F , 37 F F , 7, 39, 41 F F , 37 F , 33 F , 7 F , 11, 15, 19, 21 F , 39, 41, 43 F F , 41, 43 F , 11 F N/A items do not appear in index. F

50 F , 11, 15 F , 7, 23 F F , 25 F , 7, 39 F , 41, 43 F , 27 F , 39, 41, 43 F F , 17 F , 21 F , 19 F F F J M , 25, , 41, , 41, Selector Switch F F Side Wrap F F Signal Light F Skirt Panel F Snap Bushing F , 25 Solenoid Bracket F Solenoid Spring F , 17 Spacer F , 41, 43 F , 41, 43 F Spline Insert , 43 Sponge Rubber F , 37 Spout Weldment F Standoff F F Support Bracket F Switch F340403P... 9, 19, This Machine Must Be Protected Decal F Timer P...21 Timer and Terminal Assembly F Timer Assembly F F Timer Kit F952P Timer Knob JA , 21 Transformer F360156P...25 M414228P P...25 Transmission Adaptor Plate F , 41, 43 Transmission Assembly 38165P...39, 41, 43 Transmission Motor Base F , 41 Transmission Motor Clamp F , 41 Trunnion F , 37 Trunnion Cap F , 37 Trunnion Frame F , 37 Trunnion Frame Angle F , 37 Tub Assembly F F U Use Copper Conductors Only Caution Label F V Valve F P...23 Valve Box F Valve Transition Kit F P...23 Valve, 3-Way F P...23, 27 T Terminal Block Terminal Block Shield N/A items do not appear in index. 48 F W Warning Label F F Wash Motor Harness F P...39, 41

51 Washer F , 7, 33, 39, 41 F , 35, 37 F F , 11 F , 7 F , 11, 15, 19, 21, 23 F F , 7, 31, 39, 41, 43 F F , 41, 43 F F F F F , 13 M , 37 M , 37 M , 7, 35, , 41, Wash/Extract Decal F Wash/Rinse Decal F Water Hose F200108P F F200128P F Wire Label Z Z-Clip F , 37 N/A items do not appear in index. F

52 Notes 50 F232208

Washer-Extractor. Parts. Twin Tub. Refer to Page 3 for Model Numbers. UM100 UM202 UM1202 U061C_F232115

Washer-Extractor. Parts. Twin Tub. Refer to Page 3 for Model Numbers. UM100 UM202 UM1202 U061C_F232115 Washer-Extractor Twin Tub Refer to Page 3 for Model Numbers Parts UM100 UM202 UM1202 U061C_F232115 www.alliancelaundry.com Part No. F232115R15 December 2014 Table of Contents Title Page Parts Ordering