UWA520AYM (McQuay Model : MCS380.2FST022) Revised from PL-805

Transcription

1 UWA0AYM (McQuay Model : MCS0.FST0) Revised from PL-0

2 UWA0AYM (McQuay Model : MCS0.FST0) Revised from PL-0

3 UWA0AYM (McQuay Model : MCS0.FST0) Revised from PL-0

4 UWA0AYM (McQuay Model : MCS0.FST0) Revised from PL-0

5 UWA0AYM (McQuay Model : MCS0.FST0) Revised from PL-0

6 UWA0AYM (McQuay Model : MCS0.FST0) Revised from PL-0

7 UWA0AYM (McQuay Model : MCS0.FST0) Revised from PL-0

8 UWA0AYM (McQuay Model : MCS0.FST0) Revised from PL-0

9 UWA0AYM (McQuay Model : MCS0.FST0) Revised from PL-0 0

10 UWA0AYM (McQuay Model : MCS0.FST0) Revised from PL-0

11 UWA0AYM (McQuay Model : MCS0.FST0) Revised from PL-0

12 UWA0AYM (McQuay Model : MCS0.FST0) Revised from PL-0

13 UWA0AYM (McQuay Model : MCS0.FST0) Revised from PL-0 Parts Parts Name Drwg. Parts Model & Specifi cation UWA0AYM A A 00 SCREW COMPRESSOR M000 HSSMIQB-R 00V 0HZ KW SUZHOU A 0000 HEAT EXCHANGER M000 EUII EVEN A A 00 ELECTRICAL EXPANSION VALVE M0000 ETS0 / X / 0G00 DA EXV A FILTER DRIER ASSY. A FILTER DRIER SHELL M0000 SEGMENT D X D QA A- 0 FILTER DRIED CORE M0000 0/B CASTEL/SJ-A BEFORE A- 000 FILTER DRIED CORE M0000 SJ-A HG AFTER A 0000 OIL SEPARATOR M0000 L 0 EVEN A 0 DISCHARGE PIPE ASSY. M0000 A A 0 MOTOR M00000 YDK00-XC 0-V 0HZ YONG 0 M-M0 A 0 FAN BLADE M0000 MM TFE00- XINGCHANG 0 B 0 BASE/ CASTLE SAFETY VALVE M0000 NPT/ B C 0 SAFETY VALVE M000 SFA-C00T.0MPA /NPT BEITING B 00 BASE/ REF. CHARGING VALVE M0000 NPT/B B C 0 CHARGE VALVE M00000 CAV SAE/ X NPT/B LY B 0000 ACCESS VALVE M0000 SAE/B X ODS/B 0 B C 0 BALL VALVE M0000 BALL BV0-A LUYUAN B 0 ANGLE VALVE M00000 AV0 ID X LY B C 0 BALL VALVE M00000 SBV-JAYHOV- ID/ X OD/B SAN B A 0 THERMAL EXPANSION VALVE M00000 B- B 0 EXPANSION VALVE POWER ASSY. M00000 TXV XB-0-JL-IA ALCO B- B 0 EXPANSION VALVE CAGES M00000 TXV X0-C0 ALCO B- B 0 BODY/ EXPANSION VALVE M00000 TXV A / X / ALCO B0 C 0 SIGHT GLASS M0000 KSG-R 0/ CASTEL B 0 ANGLE FITTING M00000 ORJ ID. C 00 PIPE CONNECTING CON. GAS HEADER M00 FBA C 0000 REDUCER M0000 ID X OD C 0 ELBOW M000 COPPER ID X OD C 00 ELBOW M00 ID X OD C 0000 REDUCER M0000 CU OD X ID X T.0 X MM KT/HOJ/DF C 0 REDUCER M00000 CU OD X ID X T.0 X. C 0 ELBOW M000 COPPER ID0 X OD0 X 0DEG. C 0 ELBOW M000 COPPER ID0 X ID0 X 0DEG. C 0000 ELBOW M0000 C0 0 STRAINER M ID. X ID.MM C 0 JOINT M00 TEE CU ID. X ID. X ID.

14 UWA0AYM (McQuay Model : MCS0.FST0) Revised from PL-0 Parts Parts Name Drwg. Parts Model & Specifi cation UWA0AYM C 000 JOINT ELBOW M0000 /-UNF X ODS. STEEL LY C 0 STRAIGHT COUPLING M00000 SRJ LUYUAN C 0000 ACCESS VALVE M0000 NPT/B X SAE/B C C 0 BALL VALVE (ROHS) M00000 SBV-JAYHOV- ID/ X OD/B SAN C 0 JOINT M00 TEE CU ID. X ID. X ID.MM KT C A 0 M RB GS0BF T / X / ALCO C 000 CAPILLARYTUBE A0000 OD.X ID.X 00MM RS C 00 REDUCER M00 CU OD.X ID.X MM C 00 JONIT M00000 BRASS CONNECTION/OIL SEPARATOR HEATER C 00 JOINT M00000 BRASS CONNECTION/OIL TEMP. HEATER C 00 JOINT (ROHS) M0000 CAV(/B) LY D 0 CHECK VALVE ASSY. M0000 DN0 LUYUAN D C 0000 FLANGE M00000 D 0 BUSH M0000 ID0 E 0000 ELECTRONIC EXP. V DERIVE MODULE M000 EVD CAREL EXVB E 000 ELECTRONIC EXP. V BATTERY CHARGE M0000 EVBAT0000 CAREL EVBAT. E B 00 MOTOR THERMAL PROTECTION M0000 MP/MP INT TM 0V (P/N00) KRIWAN MP- BEFORE E B 00 MOTOR THERMAL PROTECTION M0000 DGTBH-0 LDDGT MP- AFTER E A 00 ANALOG DIGITAL BOARD M000 PC0000ALO CAREL CP BEFORE E A 00 CONTROL MODULE M000 PC0QCOALO(MQ LOGO)CAREL CP AFTER E 0 ANALOG DIGITAL BOARD M0000 PC0E000 EXP E A 0 PHASE PROTECTOR M0000 RM-TG0 T.E. PM- E B 000 TIMER M0000 RERAMU V/DC OR 0V/AC TE. SND KT/KT E A 0 BREAKER M0000 CN P C A SCHNEIDER Q E 000 FUSE HOLDER M000 0 X /P A(0) WOHNER F/F0/F E- A 0 FUSE M0000 RT-0 A DELIIXI E- A 0 FUSE M000 RT-0 A DELIXI E0- B 0 RELAY M0000 RXMABF TE. K/KM/K E0-00 RELAY SOCKET M000 RXZEM T.E.SND K/KM/K EA A 0 CONTACTOR M000 LC-D0FC 0V/0HZ T.E. KM-/ BEFORE KM/KM EA A 00 CONTACTOR M00000 LC-D00FC T.E KM-/ KM/KM AFTER EB A 0 CONTACTOR M0000 LC-DFC 0V/0HZ T.E. KM-/ BEFORE KM/KM EB A 00 CONTACTOR M00000 LC-D00FC T.E KM-/KM/ KM AFTER

15 UWA0AYM (McQuay Model : MCS0.FST0) Revised from PL-0 Parts Parts Name Drwg. Parts Model & Specifi cation UWA0AYM E A 0 OVERLOAD RELAY M00000 LRF (00-0A) SCHNEIDER F/F E 00 FUSE HOLDER M000 NH 0A 0 LTJWNE F- E- A 0 FUSE M000 NH GL00V 00A 0 LTJWNE F- E 0 FUSE HOLDER M000 0 D0 (E/A/00V) WNE F00/F00 E A 0 FUSE M00 D0/GLA/00V (0) WOHNER F00/F00 E 000 FUSE HOLDER M000 E/A/00V (0) WOHNER F0 E A 00 FUSE M0000 D0 GL A E (0) WOHNER F0 E B 000 TRANSFER T M0000 ABL-TSB 0VA V T E B 000 TRANSFORMER M00000 ABL-TS0G /V SND T E0 A 0 OVERLOAD PROTECTOR M000 LRD0KN (-A) T.E. 0 OL-0/ OL- E B 000 CONTACTOR M LCD00FC SND 0 KM-0/ BEFORE KM- E B 00 CONTACTOR M0000 LC-D00FN SND 0 KM-0/ KM- AFTER E A 00 SWITCH M000 OETL000K ABB Q0 E B 0 HUMAN MACHINE INTERFACE M0000 PGD0000F00 CAREL PGD BEFORE E B 000 PANEL LCD M000 PGDOQCOFOO(MQ LOGO)CAREL PGD AFTER E B 0 SWITCH M0000 XB-BDC SCHNEIDER Q0 E B 0 SWITCH M0000 XB-BDC SCHNEIDER Q- E A 0 EMERGENCY SWITCH M0000 XB-BSC SCHNEIDER Q E B 00 SWITCH M000 ZB-BE0C SCHNEIDER E 00 MARK/ EMERGENCY BUTTON M000 ZB-BY0 SND E0 A 00 PRESSURE SENSOR (HIGH) M0000 AKS BAR DANFOSS E A 00 PRESSURE SWITCH M0000 PSW PS-GA(.BAR)ALCO E 00 THERMOPLAS HOSE M0000 ID.0X OD.X 00MM K-LCP E A 000 HEATER/ OIL SEPARATOR M00 0W-V TAIYI E 00 JOINT (WATER PROOF) M0000 PG- SLEEVE MHP 0 E A 00 SENSOR/ TEMP. M000 DGT PT000 M LDDGT E A 00 SENSOR/ TEMP. M00000 MF0H M LDDGT E A 00 COIL/ SOLENOID M000 SV ASC 0V 0 ALCO E 00 AIR GRILLE M00000 FS E 000 BATTERY BOX M0000 EVBATBOX00 E0 A 00 SURGE ABSORBER M00000 DRC0 LDDGT 0 E 00 COVER/ ELECTRIC AUX. M00 0 LTJWNE E 000 SUPPORT/ ELECTRIC AUX. M00 0 LTJWNE

16 UWA0AYM (McQuay Model : MCS0.FST0) Revised from PL-0 Parts Parts Name Drwg. Parts Model & Specifi cation UWA0AYM E 00 SWITCH HANDLE M000 OHBJABB E A 00 CONTACTOR AUX. M AUX. LAD-NC SND E A 000 CONTACTOR AUX. M AUX. LADNC SND E A 00 SURGE ABSORBER M0000 DRC0 LDDGT E 00 INTERLOCK M00 LA-FJ0 SND E A 00 SWITCH ACCESSORY M000 OXP X 0 ABB E 00 COVER/ FUSE STRIP M000 E (00) WOHNER E0 00 FUSE CAP M000 E (0) WOHNER E 00 PLUG/ FUSE BLANKING M0000 E (0) WOHNER E 00 COVER/ FUSE M D0(E MM) LTJMNE E 00 FUSE CAP M (D0/E/00V AC/0V DC) WNE E 00 FUSE ACCESSORY M000 A E (0) WOHNER F 000 CONNECT ELE. CABINET AND COIL L&R M00 MCS0 F 000 CONNECT ELE. CABINET AND COIL L&R M00 MCS0 F 0 CONNECT COIL/ C-BOX TOP M0000 F 00 BACK PANEL/ UNIT M000 F 0 BACK PANEL/ UNIT- M000 F 0 BOARD CONNECTING FILTER DRIER M000 F 00 BOARD SUPPORTING FILTER DRIER M000 F 0 BINDING THE DRY M000 F 0 SUPPORT EXV. M00 F0 00 SUPPORT L-I VALVE M00 (ALCO) VER F 0 SUPPORT INJECTION- SYS. M00 F 0 SUPPORT INJECTION- SYS. M00 F 0 SUPPORT L-I SYS CON. COMP. N M00 F 00 SUPPORT L-I SYS CON. COMP. N M00 F 0 COMPRESSOR SUPPORT M000 F 0 SUPPORT COIL LIQUID PIPE M00 F 0 SUPPORT DISCHARGE PIPE M00 F 0 FRONT HORIZONTAL SUPPORT/ COIL M0000 F 0 CONNECTING HORIZONTAL SUPPORT/ M0000 F0 0 MIDDLE HORIZONTAL SUPPORT/ COIL M0000 F 000 HORIZONTAL SUPPORT/ COIL RD M00 F 000 BACK HORIZONTAL SUPPORT/ COIL M000 MHS F 000 CONNECT TWO SYSTEMS RD M00 F 000 CONNECT TWO SYSTEM RD M000

17 UWA0AYM (McQuay Model : MCS0.FST0) Revised from PL-0 Parts Parts Name Drwg. Parts Model & Specifi cation UWA0AYM F 000 METAL/ BACK COIL COVER & M000 F 0 BOARD SEPARATING COILS M000 0 F 000 METAL/ BACK COIL COVER & M000 F 000 COIL SUPPORT TH M00 F 000 COIL SUPPORT RD M00 F METAL/ MIDDLE COIL COVER & M000 F 0 COIL SUPPORT MIDDLE (RIGHT) M000 F 0 COIL SUPPORT M00 F 0 COIL SUPPORT FRONT (RIGHT) M000 F 000 METAL/ FRONT COIL COVER & M000 F 0 BOARD SEPARATING COILS FRONT M00 F 000 METAL/ FRONT COIL COVER & M0000 F 0 TWO SYSTEM MIDDLE SUPPORT M00 F 0 CONNECT TWO SYSTEM ST M000 F 0 CONNECT TWO SYSTEM ND M000 F0 000 METAL SUPPORTING FOR DRAGGING M00 F 000 METAL STRENGTHEN FOR DRAGGING M00 F 000 METAL SUPPORTING FOR DRAGGING M00 F 000 SUPPORT ELE. CABINET/ FRONT M00 F 00 OUTSIDE STIFFENING STEEVE BOAR M000 0 F 0 ST OUTSIDE BASE FRAME M000 F 0000 BASE RAME M00 F BENDING REVERSE F 000 BASE RAME M00 F BENDING REVERSE F 000 BASE RAME M00 F BENDING REVERSE F 0 STIFFENING STEEVE BOARD M F0 0 STEEVE BOARD RIGGING ASSY. MET M000 F0 BENDING REVERSE 0 F 000 SUPPORT ELE. CABINET/ FRONT M00 F 0 MIDDLE & BACK POST M000 F 0 FRONT BEAM CONNECT POST M00 F 0 FRONT BOARD STRENGTHEN MIDDLE M0000 F 00 ST INSIDE BASE FRAME (REVERSE) M00 F 000 BASE RAME M00 F BENDING REVERSE F 000 BASE RAME M00 F BENDING REVERSE F 000 BASE RAME M000 F BENDING REVERSE F 0 BASE FRAME BACK BEAM M000 F0 0 METAL SUPPORT EVAPORATOR M000

18 UWA0AYM (McQuay Model : MCS0.FST0) Revised from PL-0 Parts Parts Name Drwg. Parts Model & Specifi cation UWA0AYM F 0 METAL SUPPORT EXV. M000 F 0 FRONT BASE BEAM M00 F 0 CABLE CHANNEL FIX M00 F 0 ELECTRICAL CABLE SUPPORTER M000 F 0 CABLE CHANNEL M00 MHS-F F 0 COMP. SUPPORT M00 LN F 00 ST INSIDE BASE FRAME (REVERSE) M00 F 000 BASE RAME M00 F BENDING REVERSE F 000 BASE RAME M00 F BENDING REVERSE F0 000 BASE RAME M000 F BENDING REVERSE F 0 ST OUTSIDE BASE FRAME M000 F 0000 BASE RAME M00 F BENDING REVERSE F 000 BASE RAME M00 F BENDING REVERSE F 000 BASE RAME M00 F BENDING REVERSE F 00 NOZZLE M0000 NOZZLE OD0 X 00 0 F 0 UP CIRCLE M000 0 F 0 FAN FRAME B M000 0 F 0 FAN FRAME M000 0 F 0 BRACKET M F0 0 BOARD LOCKING FAN MOTOR WIRES M F 00 SUPPORT LIQUID INJECTION PIPE M00 G 000 PIPE CLIP M000 D G 0 PIPE CLAMP M000 RoHS (/ID.) LF G 0 VIBRATION PAD/ COMP. M00000 BH- HUAQIAO G 000 CLIP/ PIPE M0000 D G A 00 FLOW SWITCH A0000 WFS-AB INVENSYS G 00 SPRING ISOLATOR M000 I-S MHD-00/ZGT-C - MH/HQ G 00 SPRING ISOLATOR M00 I-S MHD-0/ZGT-C - MH/HQ H 000 COIL ASSY. & M00 MCS0FST0-FCA H 000 COIL ASSY. & M00 MCS0FST0-FCA N 0 SECTIONAL MATERIAL POST M MM A0 0-T 0UM N 0 SECTIONAL MATERIAL FRAME M MM 0MM A0 0-T N 0 SECTIONAL MATERIAL POST M MM A0 0-T 0UM N 0 SECTIONAL MATERIAL FRAME M MM 0MM A0 0-T N 0 SECTIONAL MATERIAL FRAME M MM 0MM A0 0-T N- 0 TOP PLATE / NOISE ISOLATED CA M000 0 X 00 X

19 0 UWA0AYM (McQuay Model : MCS0.FST0) Revised from PL-0 Parts Parts Name Drwg. Parts Model & Specifi cation UWA0AYM N- 0 TOP PLATE / NOISE ISOLATED CA M000 0 X 00 X N- 00 TOP PLATE / NOISE ISOLATED CA M000 0 X 00 X N- 0 TOP PLATE / NOISE ISOLATED CA M000 0 X 00 X N- 0 BACK PLATE / NOISE ISOLATED C M000 0 X 000 X N- 0 BACK PLATE 0/ NOISE ISOLATED M000 0 X 000 X N- 0 BACK PLATE / NOISE ISOLATED C M000 0 X 000 X N- 0 BACK PLATE / NOISE ISOLATED C M000 0 X 000 X N0 FOAMING PLATE 0MM N 0 FOAMING PLATE M000 0 X 0 X 0 N 0 BASE PLATE / NOISE ISOLATED C M000 0 X 0 X 0 N 0 BASE PLATE / NOISE ISOLATED C M X 0 X 0 N 0 CORNER PIECE M MM T 000 ASSY. GAS PIPE & M000 MCS0 T 000 ASSY. LIQUID PIPE & M000 MCS0 T 0000 ASSY. GAS PIPE & M000 MCS0 T 000 ASSY. LIQUID PIPE & M000 MCS0 T 0 TUBE/ EVA. TO COMP. ST SYS/ M000 T 0 TUBE/ EVA. TO COMP. ND SYS/ M000 T 0 TUBE/ EVA. TO COMP. RD SYS M000 T 0 TUBE/ EVA. TO COMP. RD SYS M000 T 0 TUBE/ EVA. TO COMP. TH SYS/ M000 T0 00 TUBE/ EXV. TO EVA. SYS M000 T 0 TUBE/ FILTER TO EXV. ND ST M000 T 00 TUBE/ FILTER TO EXV. ST SYS M000 T 0 TUBE/ COIL OUTLET TH SYS M000 T 0 TUBE/ COIL OUTLET RD SYS& M000 T 000 TUBE/ CONNECT LIQUID PIPE R M00 MCS0 T 000 OIL TUBE/ COPPER FITTING TO T-JOINT M000 T 000 OIL TUBE/ T-JOINT TO ANGLE FITTING M000 ID. T 000 TUBE/ OIL RETURN M000 T 00 T-L-I TXV. INLET / M000 T0 0 T-L-I/ TXV. TO COMP. SYS M0000 T 0 T-L-I/ BALL VALVE TO TXV. ND M0000 BEFORE T 00 T-L-I/ BALL VALVE - TXV. ST M000 SYS MCS(SI AFTER T 0 T-L-I/ BALL VALVE TO TXV. ST M0000 BEFORE T 00 T-L-I/ BALL VALVE - TXV. ST M00 SYS MCS(SI AFTER

20 UWA0AYM (McQuay Model : MCS0.FST0) Revised from PL-0 Parts Parts Name Drwg. Parts Model & Specifi cation UWA0AYM T 0 T-L-I/ FILTER INLET SYS M0000 T 000 T-L-I/ TXV. TO COMP. SYS M000 T 0 TUBE/ COIL TO WV SYS ST M000 T 0 TUBE/ OIL SERP. TO BALL VALVE M000 T 0 T-L-I/ FILTER INLET SYS M0000 T 0 TUBE/ COMP. DISCHARGE RD SYS M000 T 0 TUBE/ COMP. DISCHARGE ND SYS M000 T0 0 TUBE/ COMP. DISCHARGE ST SYS M000 T 0 TUBE/ COMP. DISCHARGE ND SYS M000 T 0 TUBE/ COIL TO WV SYS ST M000 T 000 TUBE/ CONNECT LIQUID PIPE L M000 MCS0 T 0 TUBE/ COIL OUTLET TH SYS M000 T 000 TUBE/ ANGEL VALVE TO FILTER M000 T 0 TUBE/ FILTER TO EXV. ST SYS M0000 T 00 TUBE M00 T-L-I BALL TO TXV. ND SYS& T 00 TUBE/ LIQ-INJ. M00 SLV TO SUCTION SYS T TUBE/ LIQ-INJ. M00 SLV TO SUCTION SYS K 000 LABEL FOR RIGING M0000 PET 0MM X.MM K 0 DAIKIN LOGO M000 PET UM X 0MM X 0MM

21 00AY / 00AYZ / 0AY / 0AYZ / 0AY / 0AYZ / AY / AYZ 00AY / 00AYZ / 0AY / 0AYZ / 0AY / 0AYZ / AY / AYZ Diagram POWER SUPPLY 0Hz 0V R S T HF () TR (R) POWER SUPPLY LAMP WL MCCB () NF () HF 0/00V () HF (0) (S) L L L RPP() (00) () (00) SEQUENCE 0 0 CT U V W - U V W M Z Y X () () C - - Y Z X CT U V W U V W Y M Z X - - NOTES a. For indicated on the lower side of each relay coil, the contact configuration is shown with Sequance. Wire /Terminal used: R,S,-,0-,00-,0-,-0 0-,00-,00-.: Internal connecting terminals of the chiller unit..: Connecting terminal etween monitor panel and auxiliary equipment panel.. The CT circuit shall e mm.. Where the remote pulse run/stop signal is used,no normally "a"contact run signal at no voltage can e used. - C () () Y Z X () () C C 0 0 () OIL 0 0 OIL HEATER HEATER CH CH CH WE WE - C - X- C CH - X- 0 CN (0) () CN0 (0) () (0) (0) () RL RL R R R R CH WE R - - (00) (00) (00) (00) () SEQUENCE 0 - X RUNNING OIL RETURN RUN/STOP REMOTE DISPLAY CN0 STOP X - OIL RETURN COMMON ERROR REMOTE DISPLAY COMMON ERROR RESET a 0 X - 0 COMP. CIRCUIT ERROR REMOTE DISPLAY X - PBS COMP. CIRCUIT ERROR REMOTE DISPLAY a 0 WCX CONDENSER WATER PUMP RUN/STOP WEX CHILLED WATER PUMP RUN/STOP DRIER LINE CN0 COMP. RUNNNING LAMP COMP. RUNNNING LAMP 0 0 REMOTE RUN/STOP 0 PUMP INTERLOCK AXP AXP a a 00 0 DEMAND CONTROL ON/OFF 0 X - () X - () () 0 R (00) CN0 (00) EQUALIZING OIL LEVEL CN0 0 R 0 EQUALIZING OIL LEVEL Normally "a" contact output at no voltage (The contact capacity should e 0mA A / contact.) Normally "a" contact input at no voltage (For contact input,use a contact for micro current.) (Min. applicale load V DC,0mA or less. ) VG0A

22 00AY / 00AYZ / 0AY / 0AYZ / 0AY / 0AYZ / AY / AYZ 00AY / 00AYZ / 0AY / 0AYZ / 0AY / 0AYZ / AY / AYZ Diagram () (00) AC00V/DCV COMPRESSOR FORCELY CLOSED EJECTER COMPRESSOR FORCELY CLOSED FLOAT CHAMBER GAS PURGING REMOTE OPERATION LAMP ERROR LAMP CHILLER RUN LAMP CHILLER STOP LAMP a R 0 R 0 R 0 R RL OL RL GL - X (00) () (0) (0) (0) (0) (0) (0) (0) (0) (0) (0) CN0 CN 0 CN 0 (S) (R) 00 OUTPUT SOLID STATE RELAY OUTPUT CN L L L L CN CN CN () CH X () () - 0 WE () X- () X- 0 () 0 () - 0 () A - A () - () A - A X (0) - - () X- () X- () () - () A - A () - () A - A X () - A - A CN (00) () () () () () () () 0 X - X - WEX WCX () R-() X- CAPACITY CONTROL MOTOR X- 00 SEQUENCE 00 a 0 COMPRESSOR LOAD COMPRESSOR UNLOAD CHILLED WATER PUMP RUN/STOP CONDENSER WATER PUMP RUN/STOP COMMON ERROR COMPRESSOR STAR OPERATION 0 a COMPRESSOR 0 DELTA OPERATION a 0 a a COMRESSOR 0 STAR OPERATION COMPRESSOR LOAD COMPRESSOR UNLOAD a a (0) R- () 0 a COMPRESSOR 0 CIRCUIT ERROR (00) CAPACITY CONTROL MOTOR 00 () 0 a a 0 0 a 0 0 a COMPRESSOR CIRCUIT ERROR (0) REMOTE RUN/STOP Noamally "a" contact SWITCHING POWER SUPPLY CN SEQUENCE POWER SUPPLY HIGH DISCHARGE PRESSURE CHILLED WATER OVERCOOLING Within dotted lines: CHILLED WATER Condenser water INTERRUPTION interruption relay CONDENSER WATER Only when an option is INTERRUPTION selected MOTOR OVERLOAD STANDARD: 00 0 MOTOR OVERLOAD DEMAND CONTROL COMP. LOCAL STOP BUTTON DELTA OPERATION (Effective regardless of the remote/local modes) a LOCAL RUN BUTTON (Effective only when the local operation modes is selected) 0 GP + - SIO -phase asymmetry,phase sequence,phase lose relay TWIST (0) () () PUMP INTERLOCK REMOTE RUN REMOTE STOP () () TWIST () () TWIST SUCTION LOW PRESSURE SUCTION LOW PRESSURE TWIST CN WEL 0 (00) 0 CT- T CT- + T - R- (0) AXP 0 (0) (0) CH(0) WE(0) WCL 0 R- (0) X- (0) - (0) X- () - () BS () BS () NF NF AXP NF 0 L- 0 L- () () () () F CN () (0) CN CN CN DC INPUT 0 TO V DC INPUT 0 TO V CN CN0 CN CN CN () CN () () () CN0 () () CN CN CN DC INPUT 0 TO V THERMISTOR INPUT CN CN0 CN CN CN CN CN TWIST CN (DC V) (+) (-) WHITE BLACK RED WHITE BLACK RED Th Th Th Th Th Th Th SEN H SEN L KP KP COMPRESSOR DISCHARGE GAS TEMPERATURE SENSOR COMPRESSOR DISCHARGE GAS TEMPERATURE SENSOR DISCHARGE GAS TEMPERATURE SENSOR CHILLED WATER INLET TEMPERATURE SENSOR CHILLED WATER OUTLET TEMPERATURE SENSOR CONDENSER WATER INLET TEMPERATURE SENSOR CONDENSER WATER OUTLET TEMPERATURE SENSOR DISCHARGE PRESSURE SENSOR SUCTION PRESSURE SENSOR COMPRESSOR SLIDE VALVE POSITION SENSOR COMPRESSOR SLIDE VALVE POSITION SENSOR VG0A

23 00AY / 00AYZ / 0AY / 0AYZ / 0AY / 0AYZ / AY / AYZ

24 00AY / 00AYZ / 0AY / 0AYZ / 0AY / 0AYZ / AY / AYZ Parts Parts Name Drwg. Parts Model & Specifi cation A A 00 SCREW COMPRESSOR ZHAWLGYE A A 00 SCREW COMPRESSOR ZHAMSGYE A A 00 SCREW COMPRESSOR ZHALSGYE A A 00 SCREW COMPRESSOR ZHAWSGYE A A 00 SCREW COMPRESSOR ZHAWLGYE A A 00 SCREW COMPRESSOR ZHAMSGYE A A 00 SCREW COMPRESSOR ZHALSGYE A A 00 SCREW COMPRESSOR ZHAWSGYE A 0 FRONT PLATE/ TERMINAL COVER R- A C 000 PACKING/ BLIND COVER P0- A A 0 OIL HEATER PY- 0W 00V A 0 CABLE CONNECTOR PA- SCL-0B A 0 CABLE CONNECTOR PA- SCL-0C B 00 CONDENSER ASSY. P- B 00 CONDENSER ASSY. P- B 00 CONDENSER ASSY. P- B- 00 COVER/ FRONT ASSY. P- B- 00 COVER/ REAR ASSY. P- B- C 00 GASKET/ FRONT COVER P- ODX ID0X T.0 B- C 00 GASKET/ REAR COVER P- ODX ID0X T.0 B- 00 BLIND PLUG NI0- PTG-/ /B B- 00 BLIND PLUG NI0- PTG-/ /B B- 00 SIGHT GLASS ME0- D B- C 0 O-RING PY0-0 NOK-G B-0 00 STOP VALVE ASSY. P- B- 00 COMPANION FLANGE PF00- VSVPX B- 0 GAUGE JOINT WITH CHECK VALVE PF00- VCGDA NPTF/- D.CUT B- 00 SAFETY VALVE P- B- 000 FLOAT VALVE ASSY. P- B- C 00 PACKING/ VALVE CAP P0- ODX ID0X T.0 B-0 0 PACKLESS VALVE ACSY00 FNL- B- 00 HEAT EXCHANGER TUBE P0- DX L B 00 EVAPORATOR ASSY. P00- B 00 EVAPORATOR ASSY. P00- B 00 EVAPORATOR ASSY. P00- B 00 EVAPORATOR ASSY. P00-00A Y 00A YZ 0A Y 0A YZ 0A Y 0A YZ A Y A YZ

25 00AY / 00AYZ / 0AY / 0AYZ / 0AY / 0AYZ / AY / AYZ Parts Parts Name Drwg. Parts Model & Specifi cation 00A Y 00A YZ 0A Y B- 00 COVER/ FRONT ASSY. P- B- 00 COVER/ REAR ASSY. P- B- C 00 GASKET/ FRONT COVER P- ODX ID0X T.0 B- C 00 GASKET/ REAR COVER P- ODX ID0X T.0 B- 00 BLIND PLUG NI0- PTG-/ /B B- 00 BLIND PLUG NI0- PTG-/ /B B- 00 STOP VALVE ASSY. PF00- VSVPX B- 0 GAUGE JOINT WITH CHECK VALVE PF00- VCGDA NPTF/- D.CUT B- 000 HEAT EXCHANGED TUBE P0- DX L B 0 STOP VALVE PF000- VSL0D B0 DISCHARGE PIPE ASSY. P- B0 DISCHARGE PIPE ASSY. P- B0 DISCHARGE PIPE ASSY. P- B0-0 CHECK VALVE ASSY. PY0- VCZ0AV YVCZ0AH B0-00 CHECK VALVE ASSY. PY0- B0- C 0 PACKING/ CONNECTING FLANGE P- ODX IDX T0. NONASBESTOS V0 B0- C 00 PACKING/ CONNECTING FLANGE P- OD00X ID0X T0. NONASBESTOS V0 B0- C 00 PACKING/ CONNECTING FLANGE P- OD00X ID0X T0. NONASBESTOS V0 B0- C 0 PACKING/ CONNECTING FLANGE P- OD0X IDX T.0 NONASBESTOS V0 B0-00 CONNECTING FLANGE P0-0 B0-00 CONNECTING FLANGE P0- B0-00 COMPANION FLANGE P0-0 B0-00 COMPANION FLANGE P0- B DISCHARGE PIPE ASSY. P- B DISCHARGE PIPE ASSY. P- B DISCHARGE PIPE ASSY. P- B- 0 BODY/ PY0- VCZ0AV B- 00 BODY/ PY0- B- C 0 PACKING/ CONNECTING FLANGE P- ODX IDX T0. NONASBESTOS V0 B- C 00 PACKING/ CONNECTING FLANGE P- OD00X ID0X T0. NONASBESTOS V0 B- C 00 PACKING/ CONNECTING FLANGE P- OD00X ID0X T0. NONASBESTOS V0 B- C 0 PACKING/ CONNECTING FLANGE P- OD0X IDX T.0 NONASBESTOS V0 B- 00 CONNECTING FLANGE P0-0 B- 00 CONNECTING FLANGE P0- B- 00 COMPANION FLANGE P0-0 B- 00 COMPANION FLANGE P0-0A YZ 0A Y 0A YZ A Y A YZ

26 00AY / 00AYZ / 0AY / 0AYZ / 0AY / 0AYZ / AY / AYZ Parts Parts Name Drwg. Parts Model & Specifi cation 00A Y 00A YZ B LIQUID PIPE ASSY. P0- B LIQUID PIPE ASSY. P0- B- 00 CONNECTING FLANGE P0-0 B- 00 CONNECTING FLANGE P0- B- GAUGE JOINT WITH CHECK VALVE SA0- VCGSA /B D.X L B- B BODY/ SA0- SB-A B- B BODY/ SA0- SB-A B- STOP VALVE ASSY. PF000- VSL0D B- DRYER FILTER ACSY00 B-0 0 GAUGE JOINT WITH CHECK VALVE PF00- VCGDA NPTF/- D.CUT B- C 0 PACKING/ CONNECTING FLANGE P- ODX IDX T0. NONASBESTOS V0 B SUCTION PIPE ASSY. P- B SUCTION PIPE ASSY. P- B SUCTION PIPE ASSY. P0- B- 00 CONNECTING FLANGE P0- B- 00 CONNECTING FLANGE P00- B- 00 FLANGE P- A B- 00 FLANGE P- 0A B- C 00 PACKING P0- OD00X IDX T. B- C 0000 PACKING P0- ODX IDX T. B- C 00 PACKING/ CONNECTING FLANGE P- OD00X ID0X T0. NONASBESTOS V0 B- C 0 PACKING/ CONNECTING FLANGE P- OD0X IDX T.0 NONASBESTOS V0 B- 0 GAUGE JOINT WITH CHECK VALVE PF00- VCGDA NPTF/- D.CUT B OIL RETURN PIPE () P0- B OIL RETURN PIPE () P0- B OIL RETURN PIPE () P0- B- C 0 STRAINER TACS0- B- ACSY00--KA B- VALVE ACSY00- B OIL RETURN PIPE () P0- B OIL RETURN PIPE () P0- B OIL RETURN PIPE () P0- B- 00 EJECTOR/ OIL RECOVERY SYSTEM TR-.0DX B- B BODY/ SA0- SB-A B- C 0 STRAINER TACS0- B- VALVE ACSY00-0A Y 0A YZ 0A Y 0A YZ A Y A YZ

27 00AY / 00AYZ / 0AY / 0AYZ / 0AY / 0AYZ / AY / AYZ Parts Parts Name Drwg. Parts Model & Specifi cation 00A Y B OIL PRESSURE EQUALIZER ASSY. P- B OIL PRESSURE EQUALIZER ASSY. P- B OIL PRESSURE EQUALIZER ASSY. P- B- B BODY/ SA0- SB-A B- 0 GAUGE JOINT WITH CHECK VALVE PF00- VCGDA NPTF/- D.CUT B- 0 MALE CONNECTOR TR0-.DFORC0T B OIL PRESSURE EQUALIZER ASSY. P0- B OIL PRESSURE EQUALIZER ASSY. P0- B OIL PRESSURE EQUALIZER ASSY. P0- B- 0 MALE CONNECTOR TR0- (/B) B B 000 PRESSURE SWITCH (WATER INTERRUPTION) P- B B 000 PRESSURE SWITCH (WATER INTERRUPTION) P- B B 000 PRESSURE SWITCH (WATER INTERRUPTION) P- B- B 00 HIGH PRESSURE SWITCH ACS0Y0 B- B 00 LOW PRESSURE SWITCH TACS00- FNS-C0 B- A 0 THERMOSTAT TR00 TNS-C0QX B- HIGH PRESSURE GAUGE SK000- DT0X.MPA(KG) B- 00 LOW PRESSURE GAUGE SK000- DU/ D0X -0.-.MPA(KG) B- 0 STOP VALVE R- E 000 SWITCH BOX ASSY. P- E 000 SWITCH BOX ASSY. P- E 000 SWITCH BOX ASSY. P- E 000 SWITCH BOX ASSY. P- E 000 SWITCH BOX P0- E 000 COVER/ SWITCH BOX (LEFT) P0- E 000 COVER/ SWITCH BOX (RIGHT) P0- E CONTROL PANEL ASSY. ACS0Y00 GP0-LG-V E 0 CABLE ACS0Y00 L=000 E B 00 MAGNETIC SWITCH ACS000- AC00V 0/0HZ E B 00 MAGNETIC SWITCH ACS000- AC00V 0/0HZ E B 00 MAGNETIC SWITCH ACS000- AC00V 0/0HZ E B 00 MAGNETIC SWITCH ACS000- AC00V 0/0HZ E B 00 MAGNETIC CONTACTOR ACS000- AC00V 0/0HZ E B 00 MAGNETIC CONTACTOR ACS000- AC00V 0/0HZ E B 00 MAGNETIC CONTACTOR ACS000- AC00V 0/0HZ E B 00 MAGNETIC CONTACTOR ACS000- AC00V 0/0HZ 00A YZ 0A Y 0A YZ 0A Y 0A YZ A Y A YZ

28 00AY / 00AYZ / 0AY / 0AYZ / 0AY / 0AYZ / AY / AYZ Parts Parts Name Drwg. Parts Model & Specifi cation 00A Y 00A YZ 0A Y E B 00 MAGNETIC CONTACTOR ACS000- AC00V 0/0HZ E0 B 00 AUXILIARY RELAY ACS000- AC00/0V 0/0HZ E B 000 AUXILIARY RELAY ACS000- AC00/0V 0/0HZ E A 00 REVERES PHASE PROTECTOR P00- AC00V 0/0HZ E B 00 THERMISTOR ACS0Y0- L=.M E B THERMISTOR ACS0Y0- L=.M E B THERMISTOR ACS0Y0- L=.M E B 00 THERMISTOR ACS0Y0- L=.M E B THERMISTOR ACS0Y0- L=.M E B 0 THERMISTOR (FOR WATER) PY00- Y Y00- E 0 EXTENSION WIRE/ THERMISTOR PS00- E0 A HIGH PRESSURE SENSOR P0- L=00 E A LOW PRESSURE SENSOR P0- L=00 E A BOARD SEQUENCER P0- AC00V 0/0HZ E 00A FUSE ASSY. MI00- C- A E- 00 FUSE MI00- AFA-C YAFAC- 00V A E A 00A FUSE ASSY. MI00- C-0 00V 0A E- 00 FUSE MI00- AFAC- 00V A E0 00 TERMINAL STRIP FOR CONTROL ACS000- AC00V-0A E 00 TERMINAL BLOCK ACS000- AC00V-0A E 00 TERMINAL BLOCK ACS000- AC00V-0A E 00 TERMINAL BLOCK ACS000- AC0V-0A E B 00 BUTTON SWITCH ACS000- AC0V-A/B E B 00 BUTTON SWITCH ACS000- AC0V-A/B E B 00 BUTTON SWITCH ACS000- AC0V-A/B E0 B 000 PILOT LAMP ACS000- AC00V E B 00 PILOT LAMP ACS000- AC00V E B 00 PILOT LAMP ACS000- AC00V E B 00 PILOT LAMP ACS000- AC00V E B 00 CURRENT TRANSFORMER ACS000-00/A VA E B 00 CURRENT TRANSFORMER ACS000-0/A VA E A 00 CIRCUIT BREAKER ACS000- P 0/AT E B AC CONVERSION ACS0Y00 TZ-D- DCV E B 00 TRANSFORMER ACS V/00V 00VA E C FERRITE CORE ACS000- E0 A COIL/ SA0- SBP-B AC00V 0A YZ 0A Y 0A YZ A Y A YZ

29 0 00AY / 00AYZ / 0AY / 0AYZ / 0AY / 0AYZ / AY / AYZ Parts Parts Name Drwg. Parts Model & Specifi cation E A 00 COIL/ PY--KA SXPA-0B AC00V L00 E C NOISE FILTER ACS000- AC0V-A E SUPPORTER/ PRINTED CIRCUIT MI0- KGLS-S BEHIND E K 00 NAMEPLATE DAIKIN SA0- K 00 VIBRATION ISOLATING PAD P0- K REPAIR PAINT (IVORY WHITE) PA0- Y./ 0CC K 0 CAUTION LABEL PB00-00A Y 00A YZ 0A Y 0A YZ 0A Y 0A YZ A Y A YZ

30 00AY / 00AYZ / 0AY / 0AYZ / 0AY / 0AYZ / 00AY / 00AYZ 00AY / 00AYZ / 0AY / 0AYZ / 0AY / 0AYZ / 00AY / 00AYZ Diagram POWER SUPPLY 0Hz 0V R S T HF () TR (R) POWER SUPPLY LAMP WL MCCB () NF () HF 0/00V () HF (0) (S) L L L RPP() (00) () (00) SEQUENCE 0 0 CT U V W - U V W M Z Y X () () C - - Y Z X CT U V W U V W Y M Z X - - NOTES a. For indicated on the lower side of each relay coil, the contact configuration is shown with Sequance. Wire /Terminal used: R,S,-,0-,00-,0-,-0 0-,00-,00-.: Internal connecting terminals of the chiller unit..: Connecting terminal etween monitor panel and auxiliary equipment panel.. The CT circuit shall e mm.. Where the remote pulse run/stop signal is used,no normally "a"contact run signal at no voltage can e used. - C () () Y Z X () () C C 0 0 () OIL 0 0 OIL HEATER HEATER CH CH CH WE WE - C - X- C CH - X- 0 CN (0) () CN0 (0) () (0) (0) () RL RL R R R R CH WE R - - (00) (00) (00) (00) () SEQUENCE 0 - X RUNNING OIL RETURN RUN/STOP REMOTE DISPLAY CN0 STOP X - OIL RETURN COMMON ERROR REMOTE DISPLAY COMMON ERROR RESET a 0 X - 0 COMP. CIRCUIT ERROR REMOTE DISPLAY X - PBS COMP. CIRCUIT ERROR REMOTE DISPLAY a 0 WCX CONDENSER WATER PUMP RUN/STOP WEX CHILLED WATER PUMP RUN/STOP DRIER LINE CN0 COMP. RUNNNING LAMP COMP. RUNNNING LAMP 0 0 REMOTE RUN/STOP 0 PUMP INTERLOCK AXP AXP a a 00 0 DEMAND CONTROL ON/OFF 0 X - () X - () () 0 R (00) CN0 (00) EQUALIZING OIL LEVEL CN0 0 R 0 EQUALIZING OIL LEVEL Normally "a" contact output at no voltage (The contact capacity should e 0mA A / contact.) Normally "a" contact input at no voltage (For contact input,use a contact for micro current.) (Min. applicale load V DC,0mA or less. ) VG0A

31 00AY / 00AYZ / 0AY / 0AYZ / 0AY / 0AYZ / 00AY / 00AYZ 00AY / 00AYZ / 0AY / 0AYZ / 0AY / 0AYZ / 00AY / 00AYZ Diagram () (00) AC00V/DCV COMPRESSOR FORCELY CLOSED EJECTER COMPRESSOR FORCELY CLOSED FLOAT CHAMBER GAS PURGING REMOTE OPERATION LAMP ERROR LAMP CHILLER RUN LAMP CHILLER STOP LAMP a R 0 R 0 R 0 R RL OL RL GL - X (00) () (0) (0) (0) (0) (0) (0) (0) (0) (0) (0) CN0 CN 0 CN 0 (S) (R) 00 OUTPUT SOLID STATE RELAY OUTPUT CN L L L L CN CN CN () CH X () () - 0 WE () X- () X- 0 () 0 () - 0 () A - A () - () A - A X (0) - - () X- () X- () () - () A - A () - () A - A X () - A - A CN (00) () () () () () () () 0 X - X - WEX WCX () R-() X- CAPACITY CONTROL MOTOR X- 00 SEQUENCE 00 a 0 COMPRESSOR LOAD COMPRESSOR UNLOAD CHILLED WATER PUMP RUN/STOP CONDENSER WATER PUMP RUN/STOP COMMON ERROR COMPRESSOR STAR OPERATION 0 a COMPRESSOR 0 DELTA OPERATION a 0 a a COMRESSOR 0 STAR OPERATION COMPRESSOR LOAD COMPRESSOR UNLOAD a a (0) R- () 0 a COMPRESSOR 0 CIRCUIT ERROR (00) CAPACITY CONTROL MOTOR 00 () 0 a a 0 0 a 0 0 a COMPRESSOR CIRCUIT ERROR CN CN SEQUENCE NF POWER SUPPLY -phase asymmetry,phase sequence,phase lose relay CH HIGH DISCHARGE PRESSURE (0) CHILLED WATER OVERCOOLING WE(0) Within dotted lines: CHILLED WATER 00 WEL 0 Condenser water INTERRUPTION interruption relay CONDENSER WATER WCL 0 Only when an option is INTERRUPTION selected R- (0) MOTOR OVERLOAD STANDARD: 00 0 MOTOR OVERLOAD R- (0) (0) REMOTE RUN/STOP Noamally "a" contact DEMAND CONTROL COMP. LOCAL STOP BUTTON DELTA OPERATION (Effective regardless of the remote/local modes) a LOCAL RUN BUTTON (Effective only when the local operation modes is selected) 0 GP + - SIO TWIST (0) () () PUMP INTERLOCK REMOTE RUN REMOTE STOP () () TWIST () () TWIST SWITCHING POWER SUPPLY SUCTION LOW PRESSURE SUCTION LOW PRESSURE TWIST (00) 0 CT- T CT- + T - AXP 0 (0) (0) X- (0) - (0) X- () - () BS () BS () NF AXP NF 0 L- 0 L- () () () () F CN () (0) CN CN CN DC INPUT 0 TO V DC INPUT 0 TO V CN CN0 CN CN CN () CN () () () CN0 () () CN CN CN DC INPUT 0 TO V THERMISTOR INPUT CN CN0 CN CN CN CN CN TWIST CN (DC V) (+) (-) WHITE BLACK RED WHITE BLACK RED Th Th Th Th Th Th Th SEN H SEN L KP KP COMPRESSOR DISCHARGE GAS TEMPERATURE SENSOR COMPRESSOR DISCHARGE GAS TEMPERATURE SENSOR DISCHARGE GAS TEMPERATURE SENSOR CHILLED WATER INLET TEMPERATURE SENSOR CHILLED WATER OUTLET TEMPERATURE SENSOR CONDENSER WATER INLET TEMPERATURE SENSOR CONDENSER WATER OUTLET TEMPERATURE SENSOR DISCHARGE PRESSURE SENSOR SUCTION PRESSURE SENSOR COMPRESSOR SLIDE VALVE POSITION SENSOR COMPRESSOR SLIDE VALVE POSITION SENSOR VG0A

32 00AY / 00AYZ / 0AY / 0AYZ / 0AY / 0AYZ / 00AY / 00AYZ

33 00AY / 00AYZ / 0AY / 0AYZ / 0AY / 0AYZ / 00AY / 00AYZ Parts Parts Name Drwg. Parts Model & Specifi cation 00A Y A A 00 SCREW COMPRESSOR ZHALSGYE A A 000 SCREW COMPRESSOR ZHAWSGYE A A 00 SCREW COMPRESSOR ZHALFYE A A 00 SCREW COMPRESSOR ZHALFYE A A 00 SCREW COMPRESSOR ZHALSGYE A A 000 SCREW COMPRESSOR ZHAWSGYE A A 00 SCREW COMPRESSOR ZHASFYE A A 00 SCREW COMPRESSOR ZHALFYE A 00 FRONT PLATE/ TERMINAL COVER R- A C 000 PACKING/ BLIND COVER P0- A 0 OIL HEATER PY- 0W 00V A 0 CABLE CONNECTOR PA- SCL-C B 00 CONDENSER ASSY. P- B 00 CONDENSER ASSY. P- B 00 CONDENSER ASSY. P0- B- 00 COVER/ FRONT ASSY. P0- B- 00 COVER/ FRONT ASSY. P0- B- 00 COVER/ FRONT ASSY. P- B- 00 COVER/ REAR ASSY. P00- B- 000 COVER/ REAR ASSY. P0- B- 00 COVER/ REAR ASSY. P- B- C 00 GASKET/ FRONT COVER P- OD0X ID00X T B- C 00 GASKET/ FRONT COVER P- ODX ID0X T B- C 00 GASKET/ FRONT COVER P- OD0X ID00X T B- C 00 GASKET/ REAR COVER P- OD0X ID00X T B- C 00 GASKET/ REAR COVER P- ODX ID0X T B- C 00 GASKET/ REAR COVER P- OD0X ID00X T B- 00 BLIND PLUG NI0- PTG-/ /B B- 00 BLIND PLUG NI0- PTG-/ /B B- 00 SIGHT GLASS ME0- D B- C 0 O-RING PY0-0 NOK-G B-0 00 STOP VALVE ASSY. P- B- 00 COMPANION FLANGE PF00- VSVPX B- 0 GAUGE JOINT WITH CHECK VALVE PF00- VCGDA NPTF/- D.CUT B- 00 SAFETY VALVE P- B- 000 FLOAT VALVE ASSY. P- 00A YZ 0A Y 0A YZ 0A Y 0A YZ 00A Y 00A YZ

34 00AY / 00AYZ / 0AY / 0AYZ / 0AY / 0AYZ / 00AY / 00AYZ Parts Parts Name Drwg. Parts Model & Specifi cation 00A Y 00A YZ 0A Y B- C 00 PACKING/ VALVE CAP P0- ODX ID0X T.0 B- 00 MALE CONNECTOR NI0-0 UFD-E / B- 00 HEAT EXCHANGER TUBE P0- DX L B 00 EVAPORATOR ASSY. P- B 00 EVAPORATOR ASSY. P- B 000 EVAPORATOR ASSY. P- B- 00 COVER/ FRONT ASSY. P0- B- 00 COVER/ FRONT ASSY. P- B- 00 COVER/ REAR ASSY. P0- B- 00 COVER/ REAR ASSY. P- B- C 00 GASKET/ FRONT COVER P- OD0X ID00X T B- C 00 GASKET/ FRONT COVER P- ODX ID0X T B- C 00 GASKET/ REAR COVER P- OD0X ID00X T B- C 00 GASKET/ REAR COVER P- ODX ID0X T B- 00 BLIND PLUG NI0- PTG-/ /B B- 00 BLIND PLUG NI0- PTG-/ /B B- 00 COMPANION FLANGE PF00- VSVPX B- 0 GAUGE JOINT WITH CHECK VALVE PF00- VCGDA NPTF/- D.CUT B- 000 HEAT EXCHANGED TUBE P0- DX L B STOP VALVE PF000- VSL0D B0 DISCHARGE PIPE ASSY. P0- B0 DISCHARGE PIPE ASSY. P0- B0 DISCHARGE PIPE ASSY. P- B0-00 BODY/ PY0- B0- BODY/ P0- B0- C 0 PACKING/ CONNECTING FLANGE P- OD0X IDX T.0 NONASBESTOS V0 B0- C 00 PACKING/ CONNECTING FLANGE P- OD0X ID0X T. NONASBESTOS B0- C 0 PACKING/ CONNECTING FLANGE P- OD0X IDX T.0 NONASBESTOS V0 B0- C 00 PACKING/ CONNECTING FLANGE P- OD0X ID0X T. NONASBESTOS B0-00 CONNECTING FLANGE P0- B0-00 CONNECTING FLANGE P00- B0-00 CONNECTING FLANGE P0- B0-00 COMPANION FLANGE P0- B0-000 COMPANION FLANGE P0- B DISCHARGE PIPE ASSY. P0- B DISCHARGE PIPE ASSY. P0-0A YZ 0A Y 0A YZ 00A Y 00A YZ

35 00AY / 00AYZ / 0AY / 0AYZ / 0AY / 0AYZ / 00AY / 00AYZ Parts Parts Name Drwg. Parts Model & Specifi cation 00A Y 00A YZ 0A Y B DISCHARGE PIPE ASSY. P- B- 00 BODY/ PY0- B- BODY/ P0- B- C 0 PACKING/ CONNECTING FLANGE P- OD0X IDX T.0 NONASBESTOS V0 B- C 00 PACKING/ CONNECTING FLANGE P- OD0X ID0X T. NONASBESTOS B- C 0 PACKING/ CONNECTING FLANGE P- OD0X IDX T.0 NONASBESTOS V0 B- C 00 PACKING/ CONNECTING FLANGE P- OD0X ID0X T. NONASBESTOS B- 00 CONNECTING FLANGE P0- B- 00 CONNECTING FLANGE P00- B- 00 CONNECTING FLANGE P0- B- 00 COMPANION FLANGE P0- B- 000 COMPANION FLANGE P0- B LIQUID PIPE ASSY. P00- B LIQUID PIPE ASSY. P00- B LIQUID PIPE ASSY. P00- B- 00 CONNECTING FLANGE P0-0 B- 00 CONNECTING FLANGE P0- B- GAUGE JOINT WITH CHECK VALVE SA0- VCGSA /B D.X L B- B BODY/ SA0- SB-A B- B BODY/ SA0- SB-A B- STOP VALVE ASSY. PF000- VSL0D B- STOP VALVE ASSY. PF000- VSL0D B- VALVE ACSY00- B- DRYER FILTER ACSY00 B-0 0 GAUGE JOINT WITH CHECK VALVE PF00- VCGDA NPTF/- D.CUT B- C 0 PACKING/ CONNECTING FLANGE P- ODX IDX T0. NONASBESTOS V0 B SUCTION PIPE ASSY. P- B SUCTION PIPE ASSY. P- B SUCTION PIPE ASSY. P- B SUCTION PIPE ASSY. P- B- 00 FLANGE P- B- 00 FLANGE P- B- 00 FLANGE P- 0A B- 00 FLANGE P- B- C 0000 PACKING P0- ODX IDX T. B- C 00 PACKING P0- OD0X IDX T. 0A YZ 0A Y 0A YZ 00A Y 00A YZ

36 00AY / 00AYZ / 0AY / 0AYZ / 0AY / 0AYZ / 00AY / 00AYZ Parts Parts Name Drwg. Parts Model & Specifi cation 00A Y 00A YZ B- C 0 PACKING/ CONNECTING FLANGE P-0 ODX IDX T.0 NONASBESTOS B- C 00 PACKING/ CONNECTING FLANGE P- ODX IDX T.0 NONASBESTOS B- 0 GAUGE JOINT WITH CHECK VALVE PF00- VCGDA NPTF/- D.CUT B OIL RETURN PIPE () P0- B OIL RETURN PIPE () P0- B OIL RETURN PIPE () P0- B- C 0 STRAINER TACS0- B- ACSY00--KA SEVBXF B- VALVE ACSY00- B OIL RETURN PIPE () P0- B OIL RETURN PIPE () P0- B OIL RETURN PIPE () P0- B- 00 EJECTOR/ OIL RECOVERY SYSTEM TR-.0DX B- B BODY/ SA0- SB-A B- C 0 STRAINER TACS0- B- VALVE ACSY00- B OIL PRESSURE EQUALIZER ASSY. P- B OIL PRESSURE EQUALIZER ASSY. P- B OIL PRESSURE EQUALIZER ASSY. P- B- B BODY/ SA0- SB-A B- 0 GAUGE JOINT WITH CHECK VALVE PF00- VCGDA NPTF/- D.CUT B- 0 MALE CONNECTOR TR0-.DFORC0T B OIL PRESSURE EQUALIZER ASSY. P0- B OIL PRESSURE EQUALIZER ASSY. P0- B OIL PRESSURE EQUALIZER ASSY. P0- B- 0 MALE CONNECTOR TR0- (/B) B B 00 PRESSURE SWITCH (WATER INTERRUPTION) P- B B 00 PRESSURE SWITCH (WATER INTERRUPTION) P- B B 00 PRESSURE SWITCH (WATER INTERRUPTION) P- B- B 00 HIGH PRESSURE SWITCH ACS0Y0 B- B 00 LOW PRESSURE SWITCH TACS00- FNS-C0 B- A 0 THERMOSTAT TR00 TNS-C0QX B- HIGH PRESSURE GAUGE SK000- DT0X.MPA(KG) B- 00 LOW PRESSURE GAUGE SK000- DU/ D0X -0.-.MPA(KG) B- 0 STOP VALVE R- E 00 SWITCH BOX ASSY. P- 0A Y 0A YZ 0A Y 0A YZ 00A Y 00A YZ

37 00AY / 00AYZ / 0AY / 0AYZ / 0AY / 0AYZ / 00AY / 00AYZ Parts Parts Name Drwg. Parts Model & Specifi cation 00A Y 00A YZ 0A Y E 000 SWITCH BOX ASSY. P- E 00 SWITCH BOX ASSY. P- E 00 SWITCH BOX P0- E 00 SWITCH BOX P0- E 000 COVER/ SWITCH BOX (LEFT) P0- E 00 COVER/ SWITCH BOX (LEFT) P0- E 000 COVER/ SWITCH BOX (RIGHT) P0- E 00 COVER/ SWITCH BOX (RIGHT) P0- E CONTROL PANEL ASSY. ACS0Y00 GP0-LG-V E 0 CABLE ACS0Y00 RSC L=000 E B 00 MAGNETIC SWITCH ACS000- AC00V 0/0HZ E B 00 MAGNETIC SWITCH ACS000- AC00V 0/0HZ E B 00 MAGNETIC SWITCH ACS000- AC00V 0/0HZ E B 00 MAGNETIC CONTACTOR ACS000- AC00V 0/0HZ E B 00 MAGNETIC CONTACTOR ACS000- AC00V 0/0HZ E B 000 MAGNETIC CONTACTOR ACS000- AC00V 0/0HZ E0 B 00 AUXILIARY RELAY ACS000- AC00/0V 0/0HZ E B 000 AUXILIARY RELAY ACS000- AC00/0V 0/0HZ E A 00 REVERES PHASE PROTECTOR P00- AC00V 0/0HZ E B THERMISTOR ACS0Y0- L=.M E B THERMISTOR ACS0Y0- L=.M E B THERMISTOR ACS0Y0- L=.M E B THERMISTOR ACS0Y0- L=.M E B THERMISTOR ACS0Y0- L=.M E B 0 THERMISTOR (FOR WATER) PY00- Y Y00- E 0 EXTENSION WIRE/ THERMISTOR PS00- E0 A HIGH PRESSURE SENSOR P0- L=00 E A LOW PRESSURE SENSOR P0- L=00 E A BOARD SEQUENCER P0- AC00V 0/0HZ E 00A FUSE ASSY. MI00- C- 00V A E- A 00 FUSE MI00- AFA-C YAFAC- 00V A E 00A FUSE ASSY. MI00- C-0 00V 0A E- A 00 FUSE MI00- AFAC- 00V A E0 00 TERMINAL STRIP FOR CONTROL ACS000- AC00V-0A E 00 TERMINAL BLOCK ACS000- AC00V-0A E 00 TERMINAL BLOCK ACS000- AC00V-0A 0A YZ 0A Y 0A YZ 00A Y 00A YZ

38 00AY / 00AYZ / 0AY / 0AYZ / 0AY / 0AYZ / 00AY / 00AYZ Parts Parts Name Drwg. Parts Model & Specifi cation E B 00 BUTTON SWITCH ACS000- AC0V-A/B E B 00 BUTTON SWITCH ACS000- AC0V-A/B E B 00 BUTTON SWITCH ACS000- AC0V-A/B E0 B 000 PILOT LAMP ACS000- AC0V-A/B E B 00 PILOT LAMP ACS000- AC00V E B 00 PILOT LAMP ACS000- AC00V E B 00 PILOT LAMP ACS000- AC00V E B 00 CURRENT TRANSFORMER ACS000-0/A VA E B 00 CURRENT TRANSFORMER ACS000-00/A VA E B 00 CURRENT TRANSFORMER ACS000-0/A VA E A 00 CIRCUIT BREAKER ACS000- P 0/AT E B AC CONVERSION ACS0Y00 TZ-D- DCV 0-A/-V DC E B 00 TRANSFORMER ACS V/00V 00VA E C FERRITE CORE ACS000- E0 A COIL/ SA0- SBP-B AC00V E A 0 COIL/ (UNLOADER) PY--KA SXPA-0B AC00V L00 E C NOISE FILTER ACS000- AC0V-A E SUPPORTER/ PRINTED CIRCUIT MI0- KGLS-S BEHIND E K 00 NAMEPLATE DAIKIN SA0- AC0V-A K 00 VIBRATION ISOLATING PAD P0- K 0 REPAIR PAINT (IVORY WHITE) PA0- Y./ 0CC K 0 CAUTION LABEL PB00-00A Y 00A YZ 0A Y 0A YZ 0A Y 0A YZ 00A Y 00A YZ

39 0 0AY / 0AYZ / 00AY / 00AYZ 0AY / 0AYZ / 00AY / 00AYZ Diagram POWER SUPPLY 0Hz 0V R S T HF TR (R) POWER SUPPLY LAMP WL MCCB () NF () COPPER STICK HF 0 /00V () HF (0) (S) () RPP L L L (00) () (00) SEQUENCE 0 0 U U V V K X U () OIL HEATER (00) C C W W M CT Y Z X L k Y Z () () INTERTWIST LINE U V W V W M CT Y Z X K L k Y Z X () () INTERTWIST LINE OIL HEATER CH - - NOTES a. For indicated on the lower side of each relay coil, the contact configuration is shown with Sequance. Wire /Terminal used: R, S, -, 0-, -, 00-, -, 0-, -0, , 0-0, - 00-, -.: Internal connecting terminals of the chiller unit..: Connecting terminal etween monitor panel and auxiliary equipment panel.. The CT circuit shall e mm.. Input signal to chiller shall e used for micro current. (Minimum applicale load DCV,0mA or less). Where the remote pulse run/stop signal is used,no normally "a"contact run signal at no voltage can e used. Expect the option loop,there are no "a" normally contact run sigal at no voltage can e used. - 0 OIL HEATER - CH - 0 CH - - OIL HEATER- CH - - OIL RETURN SEQUENCE 0 R 0 00 CN0 CN0 OIL RETURN 0 0 R - X STOP RUN/STOP REMOTE RUNNING DISPLAY - 0 CN0 CN0 0 OIL RETURN 0 R 00 X - 0 R OIL RETURN COMMON ERROR REMOTE DISPLAY X - a 0 COMP. CIRCUIT ERROR REMOTE DISPLAY COMMON ERROR RESET X - COMP. CIRCUIT ERROR REMOTE DISPLAY WE WEX CONDENSER WATER PUMP RUN/STOP CHILLED WATER PUMP RUN/STOP Normally "a" contact output at no voltage (The contact capacity should e 0mA A / contact.) CH 0 0 CH () PBS CH (0) WCX a 0 WE WE () () DRIER LINE 0 R - - CN0 CN0 RL (0) X- COMP. RUNNNING LAMP REMOTE RUN/STOP COMP. RUNNNING LAMP RL 0 0 () X- 0 PUMP INTERLOCK AXP AXP a 00 DEMAND CONTROL ON/OFF Normally "a" contact input at no voltage (For contact input,use a contact for micro current.) (Min. applicale load V DC,0mA or less. ) R C C () R - C 0 C 0 a 0 0 R X - (0) OR OIL RETURN CN0 CN0 0 R X - () OR OIL RETURN RL () THE CHILLER OPERATING LAMP - X GL () THE CHILLER STOP LAMP VG0A

40 0AY / 0AYZ / 00AY / 00AYZ 0AY / 0AYZ / 00AY / 00AYZ Diagram COMPRESSOR FORCELY CLOSED EJECTER COMPRESSOR FORCELY CLOSED FLOAT CHAMBER GAS PURGING REMOTE OPERATION LAMP ERROR LAMP CHILLER STOP LAMP a Within dotted lines: Dual setpoint Only when an option is selected RUN/STOP MONITOR a 0 () (00) 0 0 R 0 R 0 R 0 R RL OL OR - X CN CN CN CN0 CN0 (S) (R) CN (00) (00) SEQUENCE () () CN SEQUENCE NF ATTACH TO BS CN CN POWER SUPPLY () a CHILLED WATER PUMP WEX RUN/STOP -phase asymmetry,phase sequence,phase lose relay CN 0 () CH (0) HIGH DISCHARGE PRESSURE () a CONDENSER WATER PUMP WE WCX (0) RUN/STOP CHILLED WATER OVERCOOLING () 00 CN CN Within dotted lines: CHILLED WATER WEL 0 () X () R- () a Condenser water INTERRUPTION 00 COMPRESSOR WCL 0 - CONDENSER WATER 0 CIRCUIT ERROR Only when an option is INTERRUPTION selected R- (0) CN R- () (0) X () MOTOR OVERLOAD a 0 COMPRESSOR STANDARD: R- - (0) 0 CIRCUIT ERROR 00 0 MOTOR OVERLOAD (00) CN0 CN REMOTE RUN/STOP NF 0 AC () () CH X () (Noamally "a" contact) 0 a COMMON ERROR 0 AXP AXP (0) WE 00 PUMP INTERLOCK 0 CN 0 0 (0) X- () X- V () () DEMAND CONTROL () - () 0 a COMPRESSOR CN OUTPUT A - A 0 STAR OPERATION X- CN (0) CN (0) - 0 (0) (0) () - () a COMPRESSOR 0 A A - 0 DELTA OPERATION X- () write X a () lack (0) a CN A A - (0) red (0) () X- () X- () 0 (0) () - NF () a COMRESSOR write 0 A - A 0 STAR OPERATION CN lack L (0) () - () BS 0 a COMP. LOCAL STOP BUTTON () A red - A 0 DELTA OPERATION (Effective regardless of the remote/local modes) BS (0) 0 X a LOCAL RUN BUTTON () - (Effective only when the local operation modes is selected) () CN () a A - A () CN () 0 L- CN (00) () SUCTION LOW PRESSURE () 0 L- CAPACITY CONTROL SUCTION LOW PRESSURE 0 MOTOR COMPRESSOR () L (0) CN0 LOAD () 00 COMPRESSOR () UNLOAD () L () + SOLID X- CT- CN CN 0 (0) () STATE + - RELAY T CAPACITY CONTROL () OUTPUT MOTOR COMPRESSOR - L LOAD TWIST 00 COMPRESSOR () () (+) CN UNLOAD TWIST () X- CT- + L CN (-) (0) () T - (DC V) () + - SIO interruption relay AC00V/DCV TWIST TWIST SWITCHING POWER SUPPLY CN + - F () (0) CN DC INPUT 0 TO V DC INPUT 0 TO V THERMISTOR INPUT DC INPUT 0 TO V CN TWIST Th Th Th Th Th Th Th SEN H SEN KP KP COMPRESSOR DISCHARGE GAS TEMPERATURE SENSOR COMPRESSOR DISCHARGE GAS TEMPERATURE SENSOR DISCHARGE GAS TEMPERATURE SENSOR CHILLED WATER INLET TEMPERATURE SENSOR CHILLED WATER OUTLET TEMPERATURE SENSOR CONDENSER WATER INLET TEMPERATURE SENSOR CONDENSER WATER OUTLET TEMPERATURE SENSOR DISCHARGE PRESSURE SENSOR SUCTION PRESSURE SENSOR COMPRESSOR SLIDE VALVE POSITION SENSOR COMPRESSOR SLIDE VALVE POSITION SENSOR VG0A

41 0AY / 0AYZ / 00AY / 00AYZ

42 0AY / 0AYZ / 00AY / 00AYZ

43 0AY / 0AYZ / 00AY / 00AYZ Parts Parts Name Drwg. Parts Model & Specifi cation 0A Y A A 00 SCREW COMPRESSOR ZHAVHYE A A 00 SCREW COMPRESSOR ZHAWHYE A 0 FRONT PLATE/ TERMINAL COVER R- A C 0 PACKING/ BLIND COVER R0- A A 0 OIL HEATER PY- 0W 00V A 0 SAFETY VALVE PA- SCL-0C A 00 TERMINAL COVER P- A 00 COVER/ TERMINAL (UPPER) P- B 00 CONDENSER ASSY. P0- B 00 CONDENSER ASSY. P0- B STOP VALVE ASSY. P- B- 000 FLOAT VALVE ASSY. P- B- C 00 PACKING/ VALVE CAP P0- ODX ID0X T.0 B- 000 COVER/ FRONT ASSY. P0- B- 00 BLIND PLUG NI0- PTG-/ /B B- 000 COVER/ REAR ASSY. P- B- 00 BLIND PLUG NI0- PTG-/ /B B- C 000 GASKET/ FRONT COVER P- OD0X ID00X T B-0 C 000 GASKET/ REAR COVER P- ODX ID0X T B- 000 SAFETY VALVE P- B- 00 MALE CONNECTOR NI0-0 UFD-E / B- 00 SIGHT GLASS ME0- D B- C 0 O-RING PY0-0 NOK-G B- 00 COMPANION FLANGE PF00- VSVPX B-0 0 GAUGE JOINT WITH CHECK VALVE PF00- VCGDA NPTF/- D.CUT B- 000 HEAT EXCHANGER TUBE P0- B 000 EVAPORATOR ASSY. P- B 000 EVAPORATOR ASSY. P- B- 000 COVER/ FRONT ASSY. P- B- 00 BLIND PLUG NI0- PTG-/ /B B- 000 COVER/ REAR ASSY. P0- B- 00 BLIND PLUG NI0- PTG-/ /B B- C 00 GASKET/ FRONT COVER P- OD0X ID00X T B- C 00 GASKET/ REAR COVER P- ODX ID0X T B- 0 GAUGE JOINT WITH CHECK VALVE PF00- VCGDA NPTF/- D.CUT B- 00 COMPANION FLANGE PF00- VSVPX 0A YZ 00A Y 00A YZ

44 0AY / 0AYZ / 00AY / 00AYZ Parts Parts Name Drwg. Parts Model & Specifi cation 0A Y B- 00 HEAT EXCHANGER TUBE P0- B 00 OIL COLLECTOR P- B- 00 COMPANION FLANGE (FEMALE) P- B- 00 OIL FILTER P0- B- C 00 PACKING/ CONNECTING FLANGE P- ODX IDX T.0 NONASBESTOS B- 0 MALE CONNECTOR TR0- (/B) B- 00 SIGHT GLASS ME0- D B- C 0 O-RING PY0-0 NOK-G B- 00 COMPANION FLANGE PF00- VSVPX B- 00 STOP VALVE ASSY. P- B- C 0 FLANGE PACKING R0- OD0X IDX T. B-0 00 SAFETY VALVE P- B EXHAUST PIPE ASSY. P0- B- 00 COMPANION FLANGE P- B- 00 COMPANION FLANGE P- B- 0 GAUGE JOINT WITH CHECK VALVE PF00- VCGDA NPTF/- D.CUT B- DISCHARGE PIPE P0- B- 00 COMPANION FLANGE P- B- 00 COMPANION FLANGE P- B- C 00 PACKING/ CONNECTING FLANGE P- OD0X ID0X T. NONASBESTOS B- C 0 GASKET P-0 ODX IDX T.0 NONASBESTOS B- 00 CHECK VALVE P- 00A B EXHAUST PIPE P0- B- 00 COMPANION FLANGE P- B- 00 COMPANION FLANGE P- B- 0 GAUGE JOINT WITH CHECK VALVE PF00- VCGDA NPTF/- D.CUT B- DISCHARGE PIPE P0- B- 00 COMPANION FLANGE P- B- 00 COMPANION FLANGE P- B- C 00 PACKING/ CONNECTING FLANGE P- OD0X ID0X T. NONASBESTOS B- C 0 PACKING/ CONNECTING FLANGE P-0 ODX IDX T.0 NONASBESTOS B- 00 CHECK VALVE P- 00A B LIQUID PIPE ASSY. P- B- LIQUID PIPE P- B- 00 COMPANION FLANGE P0- B- 00 CONNECTING FLANGE P0-0A YZ 00A Y 00A YZ

45 0AY / 0AYZ / 00AY / 00AYZ Parts Parts Name Drwg. Parts Model & Specifi cation 0A Y B- B BODY/ SA0- SB-A B- 000 REDUCING UNION JOINT NI0-0 USSB- B- GAUGE JOINT WITH CHECK VALVE SA0- VCGSA /B D.X L B- 00 GAS VENT PIPE P- B- B BODY/ SA0- SB-A B- 0 GAUGE JOINT WITH CHECK VALVE PF00- VCGDA NPTF/- D.CUT B-0 VALVE ACSY00- B- C 0 PACKING/ CONNECTING FLANGE P- OD0X IDX T.0 NONASBESTOS V0 B- DRYER FILTER ACSY00 B- LIQUID PIPE () P- B- 00 CONNECTING FLANGE P0- B- STOP VALVE PY-KE B SUCTION PIPE P0- B- 00 FLANGE P- B- 00 FLANGE P- B- C 00 PACKING P0- OD0X IDX T. B- C 00 PACKING/ CONNECTING FLANGE P- ODX IDX T.0 NONASBESTOS B- 0 GAUGE JOINT WITH CHECK VALVE PF00- VCGDA NPTF/- D.CUT B OIL RETURN PIPE () P0- B- C 0 STRAINER TACS0- B- 0 ASSY. ACSY00-KA SEV0BXF 00V RA B- PACKLESS VALVE ACSY00- B0 OIL RETURN PIPE () P- B0- B BODY/ SA0- SB-A B0-00 EJECTOR NOZZLE TR.D B0- C 0 STRAINER TACS0- B0- VALVE ACSY00- B OIL RETURN PIPE () P- B- GAUGE JOINT WITH CHECK VALVE SA0- VCGSA /B D.X L B- GAUGE JOINT WITH CHECK VALVE SA0- VCGSA /B D.X L B- 0 ASSY. ACSY00-KA SEV00BXF B- 0 ASSY. ACSY00-KA SEV0BXF 00V RA B- 0 MALE CONNECTOR TR-.DFORC0T B- 00 COMPANION FLANGE PF00- VSVPX B- C 0 STRAINER TACS0- B 000 OIL PIPING P0-0A YZ 00A Y 00A YZ

46 0AY / 0AYZ / 00AY / 00AYZ Parts Parts Name Drwg. Parts Model & Specifi cation 0A Y B- 0 MALE CONNECTOR TR0- (/B) B B 00 PRESSURE SWITCH (WATER INTERRUPTION) P- B- B 00 HIGH PRESSURE SWITCH ACS0Y0- B- A 0 THERMOSTAT TR00 TNS-C0QX B- HIGH PRESSURE GAUGE SK000- DT0X.MPA(KG) B- 00 LOW PRESSURE GAUGE SK000- DU/ D0X -0.-.MPA(KG) B- 0 STOP VALVE R- B0 B 00 LOW PRESSURE SWITCH TACS00- FNS-C0 E 00 SWITCH BOX ASSY. P- E 00 SWITCH BOX ASSY. P- E 00 SWITCH BOX P- E 00 COVER/ SWITCH BOX (LEFT) P- E 00 COVER/ SWITCH BOX (RIGHT) P- E CONTROL PANEL ASSY. ACS0Y00 GP0-LG-V E 0 CABLE ACS0Y00 RSC L=000 E B 00 MAGNETIC SWITCH ACS00- AC00V 0/0HZ A/B E B 00 MAGNETIC SWITCH ACS00- AC00V 0/0HZ A/B E B 00 MAGNETIC CONTACTOR ACS000- AC00V 0/0HZ A/B E B 000 MAGNETIC CONTACTOR ACS000- AC00V 0/0HZ A/B E0 B 00 AUXILIARY RELAY ACS000- AC00/0V 0/0HZ C E B 000 AUXILIARY RELAY ACS000- AC00/0V 0/0HZ C E A 00 REVERES PHASE PROTECTOR P00- AC00V 0/0HZ E B THERMISTOR ACS0Y0- L=.M E B 00 THERMISTOR ACS0Y0- L=.M E B THERMISTOR ACS0Y0- L=.M E B 0 THERMISTOR (FOR WATER) PY00- Y Y00- E 00 EXTENSION WIRE/ THERMISTOR PS00- E0 A HIGH PRESSURE SENSOR P0- L=00 E A LOW PRESSURE SENSOR P0- L=00 E A BOARD SEQUENCER P0- AC00V 0/0HZ E 00A FUSE ASSY. MI00- C- 00V A E- A 00 FUSE MI00- AFA-C YAFAC- 00V A E 00A FUSE ASSY. MI00- C-0 00V 0A E- A 00 FUSE MI00- AFAC- 00V A E0 00 TERMINAL STRIP FOR CONTROL ACS000- AC00V-0A E 00 TERMINAL BLOCK ACS000- AC00V-0A 0A YZ 00A Y 00A YZ

47 0AY / 0AYZ / 00AY / 00AYZ Parts Parts Name Drwg. Parts Model & Specifi cation E B 00 BUTTON SWITCH ACS000- AC0V-A/B E B 00 BUTTON SWITCH ACS000- AC0V-A/B E B 00 BUTTON SWITCH ACS000- AC0V-A/B E0 B 000 PILOT LAMP ACS000- AC0V-A/B E B 00 PILOT LAMP ACS000- AC00V E B 00 PILOT LAMP ACS000- AC00V E B 00 PILOT LAMP ACS000- AC00V E B 00 CURRENT TRANSFORMER ACS000-0/A VA E A 00 CIRCUIT BREAKER ACS000- P 0/AT E B AC CONVERSION ACS0Y00 TZ-D- DCV 0-A/-V DC E B 00 TRANSFORMER ACS V/00V 00VA E C FERRITE CORE ACS000- E0 A COIL/ SA0- SBP-B AC00V E A 0 COIL/ (UNLOADER) PY--KA SXPA-0B AC00V L00 E C NOISE FILTER ACS000- AC0V-A E SUPPORTER/ PRINTED CIRCUIT MI0- KGLS-S BEHIND E E0 00 TERMINAL BLOCK P- E 00 TERMINAL BLOCK P- R E 00 TERMINAL BLOCK P- S E 00 TERMINAL BLOCK P- T K 00 NAMEPLATE DAIKIN SA0- AC0V-A K 00 VIBRATION ISOLATING PAD P0- K 0 REPAIR PAINT (IVORY WHITE) PA0- Y./ 0CC K 0 CAUTION LABEL PB00-0A Y 0A YZ 00A Y 00A YZ