Capacities and Operating Data
|
|
|
- Lynette Summers
- 5 years ago
- Views:
Transcription
1 CROSSFIRE Line Burner Page 5603 Capacities and Operating Data Performance Data Lineal heat release at high fire Minimum lineal heat release Btu/hr/f t 1,000,000 1,250,000 1,500,000 1,750,000 2,000,000 2,250,000 2,500,000 Btu/hr/f t 100, , , , , , ,000 Turndown ratio 10: : 1 15: : 1 20: : 1 25: 1 Flame length f eet [ 1] P ilot pressure/heat release " w.c. * [ 2] / Btu/hr 5-8" w.c. / 40,000 Btu/hr Combustion air flow SCFM A ir pressure at burner inlet ("w.c. ) [ 3] Air pressure connection Fuel pressure (natural gas) at burner test at burner inlet Fuel pressure at burner test connection (natural gas) ("w.c.)* ("w.c. ) [ 3] ("w.c.)* N Ox emissions [ 4] 3% O < 25 ppm corrected to 3% O dry 2 2 C O emissions [ 4] 3% O < 250 ppm corrected to 3% O dry 2 2 [1] Flame length is based on 50% excess combustion air. Flame length will vary depending on various application parameters (e.g. passing air stream velocity, oxygen content, and combustion air preheat temperature) [2] At inlet of adjustable pilot orifice. [3] Air and gas DP is differential over system static pressure. [4] Emissions stated are not guaranteed. Actual emission performance may vary. Contact Maxon for specific application details. *Differential pressures measured at burner test connections. Air and gas DP is differential over system static pressure. Operating Environment Variable Inlet Combustion Air Temp. Inlet Combustion Air O Level 2 Air Stream Cross Velocity Air Stream Axial Velocity Upstream Air Temperature Downstream Air Temperature Process Air Stream O Level 2 Minimum Maximum F Ambient 200 % O ft/min ft/min F See Chart F Below % O The burner can operate in a variety of environments. Typical operating environments, limits on their variables, and notes concerning operation of the burner are presented at left. It is important to note that inlet combustion variables such as O 2 level and combustion air temperature will change air pressure requirements and/or maximum firing capacity. F 1350 Temperature Operating Envelope Downstream Temperature Consult Maxon Operating Envelope F Upstream Temperature Consult Maxon for operation in shaded region. Ability to operate in shaded region is dependent upon operating conditions. 1/13
2 Page 5604 CROSSFIRE Line Burner Natural Gas Fuel/Air Settings Capacities and Operating Data Lower CO Lower NOx NOTE: Pressure measured at burner test connections; refer to inlet pressure requirements for fan sizing Propane Fuel/Air Settings Lower CO Lower NOx NOTE: Pressure measured at burner test connections; refer to inlet pressure requirements for fan sizing
3 CROSSFIRE Line Burner Page 5605 Side View (back inlet section shown) Coupling required for ISO connection Bottom View end inlet section Coupling required for ISO connection /2 NPT Pipe Fuel Inlet 10.8 mm dia. Combustion Air Inlet Lifting Lugs.5 ft. burner = 4" dia. specified on order 1 ft. & 1.5 ft. burners - 6" dia. Bottom view back inlet section w/round air inlet (Typ.) 6.0 Bottom view back inlet section w/retangular air inlet Gas Inlet 1-1/2" NPT Combustion Air Inlet 8" dia mm dia. Lifting Lugs specified per order Gas Inlet 1-1/2" NPT Combustion Air Inlet 7.5 Pilot End View UV Scanner 3/4" NPT Spark Ignitor 14mm Gas Test Connection 1/8" NPT Pilot Fuel/Air 1/2" NPT Combustion Air Test Connection 1/8" NPT Round air inlet 4" & 6" dia. Round air inlet 8" dia. Rectangular air inlet 6.5" W x 7.5" H 10/03
4 Page 5606 CROSSFIRE Line Burner Straight Burner Sections.5 ft. burner - end inlet 1 ft. burner - end inlet 1.5 ft. burner - end inlet ft. burner - back inlet 3 ft. burner - back inlet ft. burner - back inlet ft. burner - back inlet ft. burner - back inlet
5 CROSSFIRE Line Burner Page 5607 Straight Burner Sections 7 ft. burner - back inlet ft. burner - back inlet ft. burner - back inlet /03
6 Page 5608 CROSSFIRE Line Burner ft. back inlet grid sections BI XF GRD with 12" span 2 BI XF GRD with 18" span BI XF GRD with 24" span 2 BI XF GRD with 30" span BI XF GRD with 36" span 2 BI XF GRD with 48" span
7 CROSSFIRE Line Burner Page ft. back inlet grid sections BI XF GRD with 12" span 3 BI XF GRD with 18" span BI XF GRD with 24" span BI XF GRD with 30" span BI XF GRD with 36" span 3 BI XF GRD with 48" span 10/03
8 Page 5610 CROSSFIRE Line Burner 4 ft. back inlet grid sections BI XF GRD with 12" span 4 BI XF GRD with 18" span BI XF GRD with 24" span 4 BI XF GRD with 30" span BI XF GRD with 36" span 4 BI XF GRD with 48" span
9 CROSSFIRE Line Burner Page ft. back inlet grid sections BI XF GRD with 12" span BI XF GRD with 18" span BI XF GRD with 24" span BI XF GRD with 30" span BI XF GRD with 36" span BI XF GRD with 48" span 10/03
10 Page 5612 CROSSFIRE Line Burner 6 ft. back inlet grid sections BI XF GRD with 12" span 6 BI XF GRD with 18" span BI XF GRD with 24" span 6 BI XF GRD with 30" span BI XF GRD with 36" span 6 BI XF GRD with 48" span
11 CROSSFIRE Line Burner Page ft. back inlet grid sections BI XF GRD with 12" span 7 BI XF GRD with 18" span BI XF GRD with 24" span 7 BI XF GRD with 30" span BI XF GRD with 36" span 7 BI XF GRD with 48" span 10/03
12 Page 5614 CROSSFIRE Line Burner 8 ft. back inlet grid sections BI XF GRD with 12" span BI XF GRD with 18" span BI XF GRD with 24" span BI XF GRD with 30" span BI XF GRD with 36" span BI XF GRD with 48" span
13 CROSSFIRE Line Burner Page ft. back inlet grid sections BI XF GRD with 12" span 9 BI XF GRD with 18" span BI XF GRD with 24" span 9 BI XF GRD with 30" span BI XF GRD with 36" span BI XF GRD with 48" span 10/03
14 Page 5616 CROSSFIRE Line Burner Horizontal spacing of CROSSFIRE ladders typ. 4 ft. CROSSFIRE Ladder typ. 5 ft. CROSSFIRE Ladder typ. 6 ft. CROSSFIRE Ladder typ. 7 ft. CROSSFIRE Ladder typ. 8 ft. CROSSFIRE Ladder typ. 9 ft. CROSSFIRE Ladder
15 CROSSFIRE Line Burner Page 5617 Vertical spacing of CROSSFIRE ladders Dim. A Dim. B Designation Cross Member Description Dim. A (inches) Dim. B (inches) " spacing " spacing " spacing " spacing Dim. A Dim. B Designation Cross Member Description Dim. A (inches) Dim. B (inches) " spacing " spacing " spacing " spacing Dim. A Dim. B Designation Cross Member Description Dim. A (inches) Dim. B (inches) " spacing " spacing " spacing " spacing Dim. A Dim. B Designation Cross Member Description Dim. A (inches) Dim. B (inches) " spacing " spacing " spacing " spacing See page 5616 for horizontal spacing of CROSSFIRE ladders 10/02
16 Page 5618 CROSSFIRE Line Burner Notes
Design and Application Details
LO-NOX Line Burners Page 5803 Design and Application Details Total heat release and LO-NOX Burner footage are normally selected from the tables given in the Series HG Mixing Tube section of the Maxon catalog
Eclipse Vortometric Burners Series HI
Version Burner Model Parameter 6V 8V V V V 6V 8V V V 8V 3V 36V Max. Input MM BTU/hr (MW) (.8).5 (3.) 7 (5.0) 3 (6.7) 3 (9.) () (6.) 78 (3) 90 (6) 5 (37) (7) (6) Min. Input MM BTU/hr (MW) (Natural Gas)
Field proven low emissions. State-of-the-art low NOx firing - adjustable for application flexibility
-.9- KINEDIZER LE High capacity low NOx gas burners Field proven low emissions. State-of-the-art low NOx firing - adjustable for application flexibility Lower NOx and less excess air than standard KINEDIZER
Eclipse RatioAir Burners
Parameter Maximum Input, BTU/hr (kw) 1, Minimum Input, BTU/hr (kw) Lower inputs may be achieved. Contact factory. Main Gas Inlet Pressure, "w.c. (mbar) 3 Fuel pressure at ratio regulator inlet. High Fire
Eclipse RatioAir Burners
Data 115-1 10/1/07 Eclipse RatioAir Burners Main Specifications - RA0 PARAMETER Maximum input, () at neutral chamber conditions 60Hz Packaged Maximum input, () at neutral chamber conditions 50Hz Packaged
KINEMAX. Medium velocity gas or oil burners
KINEMAX Medium velocity gas or oil burners High Temperature Burners - KINEMAX -.- Exit velocities up to 00 km/h (8 m/s) to promote workload heat penetration and better furnace temperature uniformity Operate
Design and Application Details
Model 400 OVENPAK -II Gas Page 2153 Design and Application Details OVENPAK -II s are nozzle-mixing gas burners for many industrial direct-fired applications where clean combustion and high turndown are
Data /1/07 Eclipse RatioAir Burners Model RA0040
Maximum input, () at neutral chamber conditions 60Hz Packaged Maximum input, () at neutral chamber conditions 50Hz Packaged Minimum input, () Lower inputs may be achieved. Contact factory. Main Gas Inlet
RatioAir Burners. Model RA0750. Data /31/05. Main Specifications - RA0750
Main Specifications - RA0750 PARAMETER Maximum input, Btu/hr (kw) at neutral chamber conditions. (Natural Gas) 60Hz Packaged 50Hz Packaged Minimum input, Btu/hr (kw) Lower inputs may be achieved. Contact
RatioAir Burners. Model RA1000. Data /31/05. Main Specifications - RA1000
Main Specifications - RA1000 PARAMETER Maximum input, Btu/hr (kw) at neutral chamber conditions. (Natural Gas) 60Hz Packaged Blower 50Hz Packaged Blower Minimum input, Btu/hr (kw) Lower inputs may be achieved.
Performance Selection Data
Series "NP" & "RG" AIRFLO Burners Page 5505 Performance Selection Data Operation in shaded area requires special considerations Optimum Design Area Operation in shaded area requires special considerations
TriOx Triple Air Staged Ultra Low NOx Burner
Triple Air Staged Ultra Low NOx Burner TriOx-1 Edition 09-08 Ultra low NOx emissions of 20 ppm or less Invisiflame mode offers positive UV flame supervision throughout entire operating range for excellent
1630 SERIES CYCLOPS TM ULTRA 4 LOW NOX TM HOT AIR BAFFLE BURNER
CAPABILITIES Industry leading low NOx emissions High momentum. luminous flames at all furnace temperatures High release rates with moderate main combustion air pressure Good turndown with flame characteristics
MULTIFIRE. High temperature dual fuel burner
MULTIFIRE High temperature dual fuel burner High temperature burners - MULTIFIRE 3-11.3-1 Operates on-ratio or with excess air to meet the specific demands of your combustion process needs Burns most clean,
Design and Application Details
Model 400 OVENPAK Gas Page 2105 Design and Application Details OVENPAK s are nozzle-mixing gas burners for many industrial direct-fired applications where clean combustion and high turndown are required.
Data 330-3 9/15/07 Eclipse ImmersoJet Burners Model 3 IJ Version 2 Main Specifications PARAMETER BLOWER SIZE Blower Type 6" w.c. Packaged (60Hz) 10" w.c. Packaged (60Hz) Remote Blower Maximum Input (Btu/hr)
Specifications of OPTIMA SLS Burners
1.1.9-4 Low emperature urners - PIM L pecifications of PIM L urners ypical burner data Fuel: natural gas at 60 F with 1000 tu/ft 3 (st) HH - sg = 0.6 (1) ombustion air: 60 F - 21% 2-50% humidity - sg =
Design and Application Details
Model 400 OVENPAK Gas Page 2153 Design and Application Details OVENPAK s are nozzle-mixing gas burners for many industrial direct-fired applications where clean combustion and high turndown are required.
NOx-Beta Ultra Low NOx Burners
NOx-Beta Ultra Low NOx s February NOx-Beta Features Ultra low NOx without any performance loss Staged air principle no external NOx reducing devices or FGR needed Robust, well engineered construction Cost
Start-up Instructions
RadMax Burners Page 400-S- Start-up Instructions Read complete instructions before proceeding and familiarize yourself with all the system s equipment and components. Verify that all equipment has been
Specifications of LVDT/HC-pilot burner. Materials of construction. Duct burners - LVDT/HC-pilot burner. combustion systems for industry
4-22.4-4 Specifications of LVDT/HC-pilot burner Typical burner data 15 C 21 % O 2 combustion air 50 % humidity natural gas with 10.9 kwh/m³(st) HHV - sg = 0.6 [1] Stated pressures are indicative - actual
North American 4575 HiRAM
Combustion North American 4575 HiRAM The quality and performance of our Tempest, but bigger. Low NOx burner High Velocity - High Turndown Inputs to 4-25 million Btu/hr Direct Spark or Pilot Lighting Furnace
VALUPAK. Packaged gas burners
VALUPAK Packaged gas burners 1-1.5-1 E - i - 11/14 High turndown. Available in 6 sizes. Capacities: 0.007 MBtu/hr - 4 MBtu/hr. Stable and clean combustion. Suitable for UV scanner and flame rod. Natural
LVDT/HC PILOT BURNER. External raw gas pilot burner
4-22.4-1 LVDT/HC PILOT URNER External raw gas pilot burner Stable pilot flame in combination with MXON IRFLO LV, HC, DELT-TE and COMUSTIFUME burners Rugged design urns natural gas, propane and LPG Suitable
North American 4485 Tempest SE
Combustion North American 4485 Tempest SE Medium/High Velocity Gas Burner Low NOx gas burner, durable construction and flexible desgin to fit a variety of applications. NPT or BSP air/gas inlets, adjustable
ECLIPSE AIR HEAT BURNERS Series AH, DAH, TAH & CAH
Info 140 11/4/03 ECLIPSE AIR HEAT BURNERS Series AH, DAH, TAH & CAH U.S. Reissue Pat. No. 26,244 Canadian Pat. No. 743,782 AH, Front View Data 140-1 AH, Back View Data 140-1 TAH Data 140-3 DAH, Blower
Assembly Numbers Style A, B & C LINOFLAME Burners
Premix-type Line Burners Page 00-A/P-1 Style A, B & C LINOFLAME Burners S tyle A, B & C LINOFLAME Burners with cast iron ignition rails L INOFLAME Burner Section Description straight section (Code) S tyle
Low Temperature Burners - STICKTITE and PILOTPAK Nozzles
Low Temperature Burners - STICKTITE and PILOTPK Nozzles STICKTITE & PILOTPK Flame retention nozzles -.- For open-port firing or open environment firing Provides positive flame retention and stable clean
Specifications of STICKTITE and PILOTPAK Nozzles
Low Temperature urners - STICKTITE and PILOTPK Nozzles 1-1.1-5 Specifications of STICKTITE and PILOTPK Nozzles This graph indicates the relationship between capacity and applied mixture differential pressure
PROFIRE V SERIES TECHNICAL DATA INFORMATION PACKET
PROFIRE V SERIES TEHNIA DATA INFORMATION PAKET Technical Data Uncontrolled Emissions onfiguration (VG, V, VG) 1.3-16.8 MM BTU/H NG; 9.3-120 GPH #2 OI U listed with choice of NFPA, SD-1, GAP, and FM for
Assembly Numbers. For these products, please order per the following product numbers: (configured products are those with alphanumeric text)
Series 67 TUBE-O-FLAME Burners Page 2200-A/P-1 For these products, please order per the following product numbers: (configured products are those with alphanumeric text) Size Packaged Burner 6-08 608 TOF
Low emissions, high performance natural gas burners
-.6- OVENPAK LE Burners Low emissions, high performance natural gas burners Burns any clean fuel gas Operates on low gas supply pressures Provides clean combustion with low NOx and CO levels Compact burner
Pilot Capacities/Specifications
s Page 9505 Capacities/Specifications Maxon offers a wide range of gas pilots to meet the specific needs of each of its burner product lines. In most cases, the appropriate burner catalog section will
APX Nozzle-mix line burner
Duct urners - PX urners 1 E-i-03/16 PX Nozzle-mix line burner Nozzle-mixing line burner for use with low pressure natural gas, propane and butane Eliminates leakage with its single-piece, aluminum extrusion
VALUPAK. Packaged gas burners
VALUPAK Packaged gas burners Low Temperature Burners - VALUPAK 1-1.5-1 High turndown. Available in 6 sizes. Capacities: 2 kw -1124 kw (HHV). Stable and clean combustion. Suitable for UV scanner and flame
MAXON OVENPAK LE LOW EMISSIONS, HIGH PERFORMANCE GAS BURNERS
LOW EMIION, HIGH PERFORMANCE GA BURNER TECHNICAL CATALOG Fuel and air pressures for the burner are balanced (always equal). This unique design provides simple operation and adjustment throughout the operational
M/MR Modulating Valves TABLE OF CONTENTS DESCRIPTION SPECIFICATIONS. For Atmospheric, Infrared, and Direct Fired Burners
M/MR Modulating Valves design certified For Atmospheric, Infrared, and Direct Fired urners TALE OF CONTENTS Description/Specifications... 1 Introduction... 2 Direct Fired Applications (Negative Pressure)...
GAS BURNERS TYPE JR Forced Draft Burners 3450 RPM motor and squirrel cage blower Leakage test, pilot and main gas cocks Gas electric pilot and gas ign
3450 RPM Motor, squirrel cage blower, panel with 2 lights (power and main fuel) and control switch Gas electric pilot and gas ignition transformer Leakage test cock, pilot cock and main gas cock Pilot
Economite RE Series. Power Gas Burners. MADE in the USA
Economite RE Series MADE in the USA Economite RE 4000 Series MADE in the USA Midco s Economite Family of Burners Backed by 60 Years of Experience 4.00" 6.00" 12.00" RE 4400DS 9.00" 15.75" 20.50" 8.44"
KINEMAX MEDIUM VELOCITY GAS OR OIL BURNERS PRODUCT DESCRIPTION TECHNICAL CATALOG
KINEMAX MEDIUM VELOCITY GAS OR OIL BURNERS TECHNICAL CATALOG PRODUCT DESCRIPTION The KINEMAX burner is a nozzle-mixing, medium velocity burner. It provides a stream of hot combustion gases that promote
Burner Capacity Information, BBC 1110/2110. Burner Capacity Information, BBC 3110
NOTES: Burner Capacity Information, BBC 111/211 NATURAL GAS, AMBIENT COMBUSTION AIR OPERATION, LOW PRESSURE ATOMIZATION Capacity (at 1% Excess Air) Gas Inlet Pressure Flame Length (at 1% Excess Air) Flame
BBC Multi-fuel Combination Beta Burner
BBC Multi-fuel Combination Beta Burner BBC-1 Edition 11-08 Designed for low pressure air operation Rugged heavy gauge steel construction Converging tile provides higher velocity flames for higher convective
Specifications of STICKTITE and PILOTPAK Nozzles
-.-5 Specifications of STICKTITE and PILOTPK Nozzles This graph indicates the relationship between capacity and applied mixture differential pressure for STICKTITE and PILOTPK nozzles when fed with an
APX Nozzle-mix line burner
Nozzle-mix line burner TECHNICL CTLOG Nozzle-mixing line burner for use with low pressure natural gas, propane and butane Eliminates leakage with its single-piece, aluminum extrusion body design Cooler
S1 SERIES TECHNICAL DATA INFORMATION PACKET
S1 SERIES TECHNICAL DATA INFORMATION PACKET Table of Contents Uncontrolled Emissions S1G, S1L, S1LG Technical Data Sheet...3 Ratings Table...4 Dimensions Table...5 Uncontrolled Emissions S1E, S1EG Technical
BBG Gas Beta Burner. Designed for low pressure air operation. Rugged heavy gauge steel construction
BBG Gas Beta Burner BBG-1 Edition 02-08 BBG shown with pilot ignition and converging tile options. Designed for low pressure air operation Rugged heavy gauge steel construction Alloy or refractory tile
PROFIRE E SERIES TECHNICAL DATA INFORMATION PACKET
PROFIRE E SERIES TECHNICAL DATA INFORMATION PACKET Technical Data Uncontrolled Emissions Configuration (EG, EL, ELG) 8.4-42.0 MM BTU/H NG; 60-300 GPH #2 OIL UL listed with choice of NFPA, CSD-1, GAP, and
INDUSTRIAL MICRODIFFUSION DUAL-FUEL BURNERS
Operations and Maintenance Manual for INDUSTRIAL MICRODIFFUSION DUAL-FUEL BURNERS Models MD-25-OG MD-7500-OG December 2012 Copyright 2012 Periflame, Design Guide 113 Industrial Dual-Fuel Burners, 12/01/2012
Burner Selection Criteria
UNI-RAD Radiant Tube Burners Page 4803 Burner Selection Criteria Combustion Air View Port/Optic Flame Sensor Mount Gas Inlet 3"- 4" Burner Selection The UNI-RAD Burner can be used with various radiant
Airejet. Low NOx Coal Burner. Type: Design features: NO X removal efficiencies:
Airejet Low NOx Coal Burner Unique low NO X coal burner with center air jet for use with overfire air (OFA) systems. Sleeve Damper Actuator Core Air Inlet Duct and Damper Pitot Grid Outer Spin Vanes Inner
MAXON OVENPAK LE LOW EMISSIONS, HIGH PERFORMANCE GAS BURNERS
LOW EMIION, HIGH PERFORMANCE GA BURNER TECHNICAL CATALOG Fuel and air pressures for the burner are balanced (always equal). This unique design provides simple operation and adjustment throughout the operational
OT LE 600/900/1200 GAS
OXYTHERM LE Burners Configured Item Number: OT LE for configured item number OT LE ASSEMBLY NUMBER PAGES SERIES FUEL Choice of burner series Choice of fuel 12 1200 Series 6 600 Series 9 900 Series G Gas
D SERIES TECHNICAL DATA INFORMATION PACKET
D SERIES TECHNICAL DATA INFORMATION PACKET Table of Contents D Series Uncontrolled Emissions DG, DL, DLG Technical Data Sheet...3 Ratings Table...4 Dimension Table...5 D Series Uncontrolled Emissions DM,
Product Information. Model: LNVG, LNVLG Burner Sizes: 13, 15, 17, 20, 21, 25 GENERAL DESCRIPTION U.L. STANDARD EQUIPMENT
The LNV/Series gas, oil, and combination gas/oil burner is a forced draft packaged burner system. A balanced blower wheel mounted in a fabricated housing provides combustion air for various furnace pressures
GEMINI GAS CONTROL PRODUCT INFORMATION
GEMINI GAS CONTROL PRODUCT INFORMATION The Gemini (6G) combination gas control valve is a versatile multifunction control designed to meet the requirements for use with non-piloted intermittent ignition
Packaged Gas Burner. Low CO and NOx emissions. Direct spark ignition. Factory pre-set for ease of start-up and operation
PBGII Packaged Gas Burner PBGII-1 Edition 08-11 Many standard and configurable options available to suit a wide variety of applications Choose from three standard fuel manifolds for natural gas and vaporous
D SERIES TECHNICAL DATA INFORMATION PACKET
D SERIES TECHNICAL DATA INFORMATION PACKET Table of Contents Uncontrolled Emissions DG, DL, DLG Technical Data Sheet...3 Ratings Table...4 Dimension Table...5 Uncontrolled Emissions DM, DMG Technical Data
Info 110 4/98. RatioMatic Burners. RM Series version through 600 Sizes. 750 through 2000 Sizes
Info 110 4/98 RatioMatic Burners RM Series version 1.01 50 through 600 Sizes 750 through 2000 Sizes For Ratiomatic Serial Numbers 95-5500 and Above Version 1.01 7/97 Contents 1.0 Operating Parameters &
GAS FURNACES CLASSIC SERIES SUPER QUIET 80 80% A.F.U.E. DOWNFLOW GAS FURNACES
FORM NO. G11-487 REV. 1 Supersedes Form No. G11-487 Rev. 8 GAS FURNACES RGLN- SERIES Models with Input Rates from 50,000 to 150,000 BTU/HR [15 to 44 kw] (U.S. & Canadian Models) Annual Fuel Utilization
1070 SERIES ULTRA LOW NO X
CAPABILITIES High release rates with moderate air Good turndown with flame characteristics and direction maintained Stable flames can be from highly oxidizing for tempered flame operation to highly reducing
UNI-RAD GAS FIRED RADIANT TUBE BURNER SYSTEM TECHNICAL CATALOG 32M
UNI-RAD GAS FIRED RADIANT TUBE BURNER SYSTEM TECHNICAL CATALOG 32M-02007-01 TABLE OF CONTENTS Product Description... 3 Features and Benefits... 3 Applications... 3 Modes of Operation... 3 Burner Selection
APX Nozzle-mix line burner
Nozzle-mix line burner TECHNICL CTLOG Nozzle-mixing line burner for use with low pressure natural gas, propane and butane Eliminates leakage with its single-piece, aluminum extrusion body design Cooler
2.0 Burner Operating Parameters and Requirements
ECLIPSE INFORMATION GUIDE Silicon Carbide Radiant Auto-Recupes Info 322 2/99 WARNING Handle silicon carbide tubes carefully. Do not drop them or hammer on them. Although they feature excellent mechanical
North American Combustion Burners
Combustion North American Combustion Burners 4441 North American Tempest High Velocity Gas Burner Jet action burner offering superior recirculation Slotted tile produces exceptional temperature uniformity
M SERIES TECHNICAL DATA INFORMATION PACKET
M SERIES TECHNICAL DATA INFORMATION PACKET Table of Contents Uncontrolled Emissions MG, MM#2, MMG#2 Technical Data Sheet... Ratings Table...4 Dimensions Table...5 Uncontrolled Emissions MM, MMG Technical
Burner Settings. How to Set and Adjust Burners Why It s Necessary
Burner Settings How to Set and Adjust Burners Why It s Necessary Basics Gas Laws Equipment Required Excess Air Definitions More air than necessary to combust the fuel Stoichiometry The exact amount of
North American Combustion Burners
Combustion North American Combustion Burners 4441 North American Tempest High Velocity Gas Burner Jet action burner offering superior recirculation Slotted tile produces exceptional temperature uniformity
W801S (Downflow) SERIES Models with Input Rates from 50 to 150 kbtu [15 to 44 kw] (80% A.F.U.E. )
![W801S (Downflow) SERIES Models with Input Rates from 50 to 150 kbtu [15 to 44 kw] (80% A.F.U.E. )](/thumbs/81/82939397.jpg "W801S (Downflow) SERIES Models with Input Rates from 50 to 150 kbtu [15 to 44 kw] (80% A.F.U.E. )")
FORM NO. G66-547 REV. 4 Supersedes Form No. G66-536 Rev. 3 DOWNF GAS FURNACE Features 80% residential Gas Furnace CSA certified 7 Segment LED all units Direct spark ignition for reliability and longevity
Model CBLE Boilers HP
Boilers 125-800HP CONTENTS FEATURES AND BENEFITS.....................................................4 True Boiler/Burner/Low NOx Package................................................4 PRODUCT OFFERING.........................................................4
GAS FURNACES CLASSIC SERIES SUPER QUIET % A.F.U.E. UPFLOW/ HORIZONTAL GAS FURNACES
FORM NO. G11-485 REV. 5 Supersedes Form No. G11-485 Rev. 4 GAS FURNACES RGPN- SERIES Models with Input Rates from 50,000 to 150,000 BTU/HR [15 to 44 kw] (U.S. & Canadian Models) ISO 9001:2000 Annual Fuel
GF802D SERIES Models with Input Rates from 50 to 150 kbtu [15 to 44 kw] (U.S. & Canadian Models)
![GF802D SERIES Models with Input Rates from 50 to 150 kbtu [15 to 44 kw] (U.S. & Canadian Models)](/thumbs/74/71367959.jpg "GF802D SERIES Models with Input Rates from 50 to 150 kbtu [15 to 44 kw] (U.S. & Canadian Models)")
FORM NO. GSC-515 GF802D SERIES Models with Input Rates from 50 to 150 kbtu [15 to 44 kw] (U.S. & Canadian Models) TWO STAGE DOWNFLOW GAS FURNACES The Sure Comfort 2-Stage line of downflow gas furnaces
The World s First Flameless Crude Heater
AFRC 2013 Industrial Combustion Symposium Kauai, HI September 23-25, 2013 The World s First Flameless Crude Heater Great Southern Flameless, LLC Presented by Great Southern Flameless, LLC GSF One of the
1500 Group Tips One-Piece Acetylene
One-Piece Acetylene 502 Series Hand or Machine Tips Preheat Cleaning in. mm in. mm Holes Preheat in. m /4 6 /4 6 08Z67 6 69 68.7 /2 3 /2 24 5Z7 6 66 60.5 -/2 38 -/2 38 5Z8 6 65 53.3 2-4 50-00 4 02 5Z9
PROFIRE TO 92.4 mmbtu/hr High turndown burner for large firetube and watertube applications.
PROFIRE xl Series burners 37.8 TO 92.4 mmbtu/hr High turndown burner for large firetube and watertube applications. Innovative Technology. Superior performance a technician can trust. The ProFire XL series,
Ruud Ultra Series Communicating Two-Stage Variable Speed Downflow Gas Furnace
Gas Furnaces Ruud Ultra Series Communicating Two-Stage Variable Speed Downflow Gas Furnace U802V Downflow Series 80% A.F.U.E. Input Rates 75-125 kbtu A.F.U.E. (Annual Fuel Utilization Efficiency) calculated
FD68 Series Axial-Flow Packaged Burners MODELS: FD68 / FD68-LN / FD68-RF SIZE RANGE: 50-1,500 HP
FD68 Series Axial-Flow Packaged Burners MODELS: FD68 / FD68-LN / FD68-RF SIZE RANGE: 50-1,500 HP Features of the FD68 Series RUGGED INDUSTRIAL DESIGN SUPERIOR HOUSING Cylindrical windbox design provides
1470 SERIES HOT AIR GAS BURNER
1 SERIES HOT AIR GAS BURNER CAPABILITIES High or low temperature furnace High excess air 800% or more Ratio or tempered flame operation Nominal capacity range 0,000 to 3.5 MM Btu/hour Suitable for light
Assembly Numbers. Approximate net ship weight (in pounds) shown in parentheses
Page 5700-A/P-1 Burner Sections Back Inlet Feed Sections (each requires inlet flange from Page 5700-A/P-2) C OMBUSTIFUME Line Burners Material Specifications > w/#310 SS mixing plates w/ Hastelloy X mixing
Clean Burning Technology
The MTC Clean and Superclean burners were developed to provide the Well testing market with a compact, lightweight and practical clean up and separated oil burning solution with a complete combustion system
TORCH BURNERS LOW, MEDIUM, AND HI-PRESSURE SERIES DESCRIPTION LOW-PRESSURE SERIES MODEL : T,TA,TB,RTA,RTB ET,ETA,ETB,RETA,RETB 12 ET 12 RETB
TORCH BURNERS LOW, MEDIUM, AND HIPRESSURE SERIES MODEL : T,TA,TB,RTA,RTB ET,ETA,ETB,RETA,RETB Revision: 0 BULLETIN 325, 32, 327 2 ET 2 RETB DESCRIPTION Torches are made up in three series LowPressure,
XID ENHANCEMENT SYSTEM IMPROVED EFFICIENCY AND PERFORMANCE
IMMERSION FIRED HOT WATER BOILER April 1, 2003 GENERAL DESCRIPTION The Sellers immersion fired hot water boiler is a horizontal, single pass, firetube boiler designed to burn natural gas. The unique burner
1466 SERIES COLD AIR GAS/OIL BURNER
CAPABILITIES High or low temperature furnace High excess air 800% or more Ratio or tempered flame operation Nominal capacity range 0,000 to 3.5 MM Btu/hour Suitable for light wall construction FEATURES
Hamilton 3VO Submittal
Job RESET FORM Engineer Hamilton 3VO Submittal BOILER s H3H 750 WATER HEATER s H3D 750 Contractor Prepared By Date Input 100% factory fire tested Efficiency: up to 99.8% (based on incoming water) Maximum
14 SEER R -410A PACKAGE GAS / ELECTRIC UNIT 2 to 5 TON
14 SEER R -410A PACKAGE GAS / ELECTRIC UNIT 2 to 5 TON Two -Stage Gas Heating/Two -Stage Electric Cooling REFRIGERATION CIRCUIT All models are equipped with high efficiency two--stage Copeland UltraTech
Replacement Parts List. Knight Fire Tube Boilers KHB 055 thru 285 Series 100 & _ _Rev B
Replacement Parts List PARTS & SERVICE DEPARTMENT Nashville, Tennessee 877-554-5544 Fax: 615-882-2918 parts_team@lochinvar.com www.lochinvar.com Knight Fire Tube Boilers KHB 055 thru 285 Series 100 & 101
Co Gen liner upgrade project Jan 2014 Huntsman 6 B conversion to Power System Manufacturing Low emissions combustion system
Co Gen liner upgrade project Jan 2014 Huntsman 6 B conversion to Power System Manufacturing Low emissions combustion system 1- This Presentation is not to be construed as an endorsement to PSM it is just
PT-M90 Automatic Full-Sequence Modulation Gas Control System
PT-M90 PT-M90 Automatic Full-Sequence Modulation Gas Control System PT-M90 Module System Illustration Pucada.Tech M901-0316 Gas Valve (PT-V1C-with step motor) A Profile Dimension: Length(84mm) * Width(40mm)
Rheem Classic Series Downflow Gas Furnace
Gas Furnaces Rheem Classic Series Downflow Gas Furnace R801S (Downflow) Series 80% A.F.U.E. Input Rates 50-150 kbtu A.F.U.E. (Annual Fuel Utilization Efficiency) calculated in accordance with Department
Up to 96% AFUE, Single Stage, PSC Gas Furnace EASIER TO SELL
N9MSE Product Specifications Up to 96% AFUE, Single Stage, PSC Gas Furnace EASIER TO SELL Up to 96% AFUE in upflow and horizontal positions, Up to 96% AFUE in downflow positions California NOx approved
MAXON OVENPAK LE. Low emissions, high performance gas burners. Technical Catalog
MXON OVENPK LE Low emissions, high performance gas burners Technical Catalog TBLE OF CONTENT Features & Benefits... Product description... Typical applications... Typical emissions... Intelligent Model
GAS FURNACES QUIET 80 80% A.F.U.E. UPFLOW/ HORIZONTAL GAS FURNACES
FORM NO. G11-486 REV. 3 Supersedes Form No. G11-486 Rev. 2 GAS FURNACES RGPP- SERIES Models with Input Rates from 50,000 to 150,000 BTU/HR [15 to 44 kw] (U.S. & Canadian Models) ISO 9001:2000 Annual Fuel
VENTING & COMBUSTION AIR GUIDE
PRE-INSTALLATION APPLICATION GUIDE VENTING & COMBUSTION AIR GUIDE Natural Gas, Propane and Dual Fuel Modulating and Condensing BOILER BODY VENT STARTER SECTION APPLIES TO MODELS: BMK 750 BMK 1000 BMK 1500
Rheem Value Series Upflow/Horizontal Gas Furnace
THIS MODEL Gas Furnaces Rheem Value Series Upflow/Horizontal Gas Furnace RGPS- Series 80% A.F.U.E. Input Rates 50-150 kbtu ENER UIDE Annual Fuel Utilization Efficiency - AFUE 80.0% MID HIGH 78% 82% 88%
DUAL COMFORT CONTROL TWO-STAGE DOWNFLOW/HORIZONTAL GAS FURNACES WITH
FORM NO. GSC-531 REV. 1 Supersedes Form No. GSC-488 Rev. 7 GF902D SERIES Models with Input Rates from 60 to 120 kbtu [17.58 to 35.17 kw] (All Models 92% A.F.U.E. or Above) TWO-STAGE DOWNFLOW/HORIZONTAL
D-GASIFIER. The ultimate solution for the replacement of gaseous and liquid fuels
The ultimate solution for the replacement of gaseous and liquid fuels Cost Reduction and TOP PERFORMANCE The D-GASIFIER is an innovative equipment patented by Dynamis that allows the use of 100% solid
LANDFILL GAS ELEVATED (CANDLESTICK) FLARE SYSTEM
LANDFILL GAS ELEVATED (CANDLESTICK) FLARE SYSTEM Part 1. General 1.01 Description A. This section describes a candlestick flare system for the combustion of landfill gases. The flare system must be of
W801T (Downflow) Series Models with Input Rates from 75 to 125 kbtu [15 to 37 kw] (80% A.F.U.E. )
![W801T (Downflow) Series Models with Input Rates from 75 to 125 kbtu [15 to 37 kw] (80% A.F.U.E. )](/thumbs/89/98206847.jpg "W801T (Downflow) Series Models with Input Rates from 75 to 125 kbtu [15 to 37 kw] (80% A.F.U.E. )")
FORM NO. G66-549 REV. 3 Supersedes Form No. G66-536 Rev. 3 DOWNFLOW GAS FURNACE Features 80% residential Gas Furnace CSA certified 7 Segment LED all units Direct Spark Ignition System for reliability and
The New Coen Micro-NOx
COEN The New THE COST-EFFECTIVE SOLUTION FOR FIRETUBE & INDUSTRIAL BURNER APPLICATIONS FOR TODAY S TOUGH APPLICATIONS THE NEW MICRO-NOX SOLUTION Performance Coen s New Micro-NOx burner is specifically
FORM NO. GTZ-542 Supersedes Form No. GTZ-503 Rev. 1
FORM NO. GTZ-542 Supersedes Form No. GTZ-503 Rev. 1 TZ80MSS (UPFLOW/ HORIZONTAL) SERIES Models with Input Rates from 50 to 150 kbtu [15 to 44 kw] UPFLOW/ HORIZONTAL GAS FURNACES Features 80% residential
Power Flame Incorporated
Power Flame Incorporated SUGGESTED SPECIFICATION FOR MODEL HP COMBINATION GAS/OIL BURNERS THE POWER TO MANAGE ENERGY 2001 South 21st Street, Parsons, Kansas 67357 Telephone 316-421-0480, Fax 316-421-0948