2010 Irrigation Products Illustrated Parts Breakout

Transcription

1 00 Irrigation Products Illustrated Parts Breakout Res/Com Controllers Section

2 GENERAL INFORMATION Please note the following usage guidelines: When dashes ( ) are shown in place of a part number, the part is either not available for sale or not sold separately. Refer to the accompanying Service Items listing for availability. An asterisk ( ) preceding a part number indicates the item is only available through the Toro Finished Goods Distribution System and must be ordered accordingly. This book is updated annually. The published part numbers and descriptions are subject to change. If changes and/or corrections are required, the updated information will be made available through the Toro Distributor Operations Bulletin and/or Tech Tip communications. Common abbreviations used within this publication: A = Ampere Amp = Ampere Assy. = Assembly ADJ = Adjustable B = Barbed BSP = British Standard Pipe COM = Check-O-Matic CR = Contamination Resistant CSA = Canadian Standards Association EL = Electric Elec = Electric Exp = Export F = Female FC = Full Circle (Sprinkler) FC = Flow Control (Valve) GPM = Gallons Per Minute Hyd. = Hydraulic Hz = Hertz in. = Inch Int. = Internal Int. T = Internal Tooth L/ = Less lbs. = Pounds M = Male M/F = Male/Female N/I = Not Indicated NC = Normally Closed (Hydraulic) NC = Normally Closed (Micro Switch) NO = Normally Open (Hydraulic) NO = Normally Open (Micro Switch) NPT = National Pipe Thread PC = Part Circle Pot. = Potentiometer PV = Pilot Valve PHPH = Pan Head Phillips Head PHFH = Pan Head Fillister Head PT = Pin Type (Hydraulic) PR = Pressure Regulated Prog. = Program RC = Rubber Cover RPD = Revolutions Per Day RPM = Revolutions Per Minute S = Slip SST = Stainless Steel SI = Side Inlet Svc = Service TM = Timing Mechanism V = Volts VAC = Volts Alternating Current VDC = Volts Direct Current VA = Volt Amps VIH = Valve In Head w/ = with w/o = without " = Inches ' = Feet

3 TIS- Indoor Controller 0- Case, Indoor *TIS-0-MOD Timing Mechanism Module, -Station *TIS-0-MOD Timing Mechanism Module, -Station *TIS--MOD Timing Mechanism Module, -Station 0- Output Board, -Station 0- Output Board, -Station 0- Output Board, -Station 0-0 Fuse, Amp, 0V, Slow-blow (0-pack) 0- Transformer, 0V, 0 Hz * Order Through Finished Goods Distribution System Minneapolis

4 TIS- Outdoor Controller 0-0 Outer Door and Case (Includes Items and ) 0- Lockset (Includes Item ) 0-0 Keys, w/ring Faceplate *TIS-0-MOD Timing Mechanism Module, -Station *TIS-0-MOD Timing Mechanism Module, -Station *TIS--MOD Timing Mechanism Module, -Station 0- Output Board, -Station 0- Output Board, -Station 0- Output Board, -Station 0-0 Fuse, Amp, Slow-blow (0-pack) 0- Transformer, 0 V a.c., 0 Hz - Screwdriver, Toro * Order Through Finished Goods Distribution System Minneapolis

5 TIS-0 Outdoor Controller 0 - Case, Back, Plastic Cover, Case, Plastic - Pin, Hinge - Lock Assy. 0-0 Keys, Lock - Faceplate 0-0 Timing Mechanism Module 0- PCB Assy., -Station 00 Cable Assy. 0 - Transformer Assy., 0 V a.c., 0VA Terminal Block 00 Switch, Slide - Screwdriver, Toro

6 TIS-0/0 Outdoor Controller, Metal Cabinet C B C A B A 0 0- Cover, Outer Door (Includes items and ) 0- Lock Assy., Door w/keys 0-0 Keys, w/ring Rear Case *TIS-ANT0 Antenna Assy., Pancake Type Cover, Inner Door 00 Switch, Bypass 00 Cable Assembly (Bypass Switch) 0- Timing Mechanism Module, -Station 0- Timing Mechanism Module, -Station 0 0- Output Board Assy., -Station 0 0- Output Board Assy., -Station 0-0 Fuse, Amp, Slow-blow (0-pack) - Lug, Grounding Remote Board Assy. 0- Transformer, 0 VAC, 0 Hz, 0 VA Terminal Block, -position 0- Cover, Power Supply * Order Through Finished Goods Distribution System-Minneapolis

7 TMC-E through Stations, Modular 0- Cover, Cabinet Outdoor Cabinet, Plastic 0- Timing Mechanism Module 0- Transformer Assy., 0VAC, VA (TMC-E) - Transformer, 0VAC, Plug-In (TMC- Indoor Model Only) *TSM- -Station Expansion Module, Gray ** *TSM-F -Station Expansion Module w/ Flow, Blue ** *TSM-H -Station Expansion Module, High Surge, White ** *TSM- -Station Expansion Module, Gray ** *TSM-F -Station Expansion Module w/ Flow, Blue ** *TSM-H -Station Expansion Module, High Surge, White ** * Order Through Finished Goods Distribution System Minneapolis ** Quantity Varies with Model

8 TMC-, GreenKeeper Indoor Controller + ON Next OFF TMC- 0- Front Plate *TSM-0 Two-station Module - Transformer, 0 V a.c., V a.c. - Transformer, 0 V a.c., V a.c. (Europe) - Transformer, 0 V a.c., V a.c. (Australia) 0- Mounting Plate

9 TMC-, GreenKeeper Outdoor & Outdoor High Surge Controller 0-0 Transformer, 0 V a.c., 0 Hz (Domestic Models Only) 0- Transformer, 0/0 V a.c., 0 Hz, (Export Models Only) Timing Mechanism Module, Svc. (Does Not Include Station Modules) *TSM-0 Two-station Module *TSM-0-H Two-station Module, High Surge 0- Cover, Lower Cabinet, Svc. 0- Cover, Transformer, Svc. 0- Door, Cabinet, Svc. * Order Through Finished Goods Distribution System Minneapolis

10 CC-P P, Custom Command through Station Plastic Cabinet 0 - Case, Back, Plastic - Cover, Case, Plastic - Pin, Hinge - Lock Assy. 0-0 Keys, Lock - Faceplate Timing Mechanism Module, -Station 0-0 Timing Mechanism Module, -Station 0-0 Timing Mechanism Module, -Station 0-0 Timing Mechanism Module, -Station 0-0 Timing Mechanism Module, -Station 0-0 Timing Mechanism Module, -Station - PCB Assy., -Station - PCB Assy., -Station - PCB Assy., -Station -0 PCB Assy., -Station - PCB Assy., -Station - PCB Assy., -Station 00 Cable Assy. 0 - Transformer Assy., 0 V a.c., 0VA 0 - Transformer Assy., 0 0 V a.c., 0VA Terminal Block 00 Switch, Slide - Screwdriver, Toro SERVICE ITEMS 0- Surge Board, -Station (Export Models Only) 0- Surge Board, -Station ( Export Models Only)

11 CC-M M, Custom Command through Station Metal Cabinet 0 - Lock Assy. w/keys 00 Cable Harness - Surge Board, -Station -0 Surge Board, -Station - Surge Board, -Station - Surge Board, -Station Screw 00 Wire Harness Screw 00 Slide Switch - Panel, Mounting - PCT Connector to Terminal Board Timing Mechanism Module, -Station Timing Mechanism Module, -Station Timing Mechanism Module, -Station Timing Mechanism Module, -Station 0-H Transformer, 0 V a.c. 000 Case Assy., Metal (0 V a.c. Models Only) 0 Washer Nut, Conduit 0-0 Fuse, Amp, Slow-blow (0-pack) SERVICE ITEMS 0- Kit, Service, Surge Board, -Station (Export Models Only) 0- Kit, Service, Surge Board, -Station (Export Models Only) R- Kit, Transformer, 0 V a.c. 0 Hz, 0 VA (Export Models Only) 0

12 CC-M M, Custom Command & Station Metal Cabinet A A B B 0 0- Cover, Outer Door (Includes Items and ) 0- Lockset (Includes Item ) 0-0 Keys, w/ring 0- Cover, Inner Door 0-0 Timing Mechanism Module, -Station 0- Timing Mechanism Module, -Station 00 Slide Switch 00 Cable Assembly 0- Cover, Power Supply Terminal Block, -Position 0 0- Transformer, 0 V a.c., 0 Hz (Domestic Model) 0 R- Transformer, 0 V a.c., 0 Hz (International Model) 0-0 Fuse, Amp, 0V, Slow-blow (0-pack) 0- Output Board, -Station 0- Output Board, -Station 0- Rear Case (Includes Items and )

13 Sentinel Central Control System 0 *0- Central Interface Module Assembly 0- CPU Cable Assembly 0- Power Supply, Central Interface Module, / V a.c., Amp 0- Antenna Assy.,Base (Includes Items & and Wall-mount Brackets) 0-0 Grounding Assy., Antenna (Includes Item and Insulation Kit) - Lug, Grounding 0- Antenna Cable, 0' 0- Phone Modem Assy. (Includes Items ) Power Supply, Telephone Modem Computer Cable Assy., Telephone Modem Computer Cable Assy., Adapter Cable Assy., Telephone 0-0 Fuse, Amp, Slow-blow (0-pack) ACCESSORIES 0- Tripod Stand, Antenna *0- Programming Kit, Radio Frequency * Order Through Finished Goods Distribution System Minneapolis

14 Sentinel Satellite, MapTo Assembly Wall Mount B 0 B B A A A 0-0 Enclosure, Tall Wall Mount w/o Backplate (Includes Items ) 0- Door Assy., w/lock Mechanism (Includes Items & ) 0- Lock Assy., Door (Includes Lock, Keys and Rod Mechanism) - Keys, Lock 0- Antenna Assy., Pancake Type 0- Filter, Enclosure Vent Louver 0-0 Back Plate Assy. (Includes Items ) Mounting Bracket, Junction Box - Lug, Grounding 0 - Toggle Switch w/receptacle 0- Power Transformer, / V a.c., 0 VA 0- Mounting Bracket, Satellite Module *0- Output PC Board *0- Output Cable, ", -Station *0- Output Cable, ", -Station *0- Output Cable, ", -Station *0- Control Module Assy., Satellite, -Station *0- Control Module Assy., Satellite, -Station *0- Control Module Assy., Satellite, -Station *0- Control Module Assy., Satellite, -Station *0- Control Module Assy., MapTo, -Station *0- Control Module Assy., MapTo, -Station *0- Control Module Assy., MapTo, -Station *0-0- Control Module Assy., MapTo, -Station Cable Assy., Data Retrieval (Includes Item ) Terminal Strip 0-0 Fuse, Amp, Slow-blow (0-pack) * Order Through Finished Goods Distribution System Minneapolis

15 Sentinel Satellite, MapTo Assembly Pedestal Mount A B A B 0 B A 0- Enclosure, Pedestal w/o Backplate (Includes Items ) 0- Door Assy., Pedestal Enclosure w/lock (Includes Items & ) 0-0 Lock Assy., Door w/keys - Keys, Lock 0- Top Assy., Pedestal Enclosure w/antenna (Includes Item ) 0- Antenna Assy., Pancake Type 0- Filter, Enclosure Vent Louver 0-0 Back Plate Assy., (Includes Items & ) Mounting Bracket, Junction Box 0 - Toggle Switch w/receptacle 0- Transformer, Power, / V a.c., 0 VA *0- Output PCB Assy., *0- Output Cable, ", -Station *0- Output Cable, 0", -Station *0- Control Module Assy., Satellite, -Station *0- Control Module Assy., Satellite, -Station *0- Control Module Assy., Satellite, -Station *0- Control Module Assy., Satellite, -Station *0- Control Module Assy., MapTo, -Station *0- Control Module Assy., MapTo, -Station *0- Control Module Assy., MapTo, -Station *0- Control Module Assy., MapTo, -Station 0-0 Fuse, Amp, Slow-blow (0-pack) 0- Cable Assembly, Data Retrieval (Includes Item ) Terminal Strip - Lug, Grounding N/I 0-0 Fuse, Amp, Slow-blow (0-pack) (Used In Control Module Assembly) * Order Through Finished Goods Distribution System Minneapolis

16 Sentinel Satellite, MapTo Assembly Wall Mount, Small Metal Cabinet C A B A A 0 B C C B 0- Cover, Outer Door (Includes items and ) 0- Lock Assy., Door w/keys 0-0 Keys, w/ring 0- Rear Case (Includes items and ) 0- Cover, Power Supply Terminal Block, -position 0- Transformer, 0 VAC, 0 Hz, 0 VA Cover, Inner Door Output Board 0 *0- Control Module Assy., Satellite, -Station 0 *0- Control Module Assy., Satellite, -Station 0 *0- Control Module Assy., Satellite, -Station 0 *0- Control Module Assy., Satellite, -Station *0- Control Module Assy., MapTo, -Station *0- Control Module Assy., MapTo, -Station *0- Control Module Assy., MapTo, -Station *0- Control Module Assy., MapTo, -Station 0- Cable Assembly, Output, " 0- Cable Assembly, Data Retrieval 0- Antenna Assy., Pancake Type - Grounding Lug 0-0 Fuse, Amp, Slow-blow (0-pack) * Order Through Finished Goods Distribution System Minneapolis

17 Sentinel Satellite, MapTo Assembly Plastic Pedestal Cabinet B A 0 B A

18 . *0- Control Module Assy., Satellite, -Station *0- Control Module Assy., Satellite, -Station *0- Control Module Assy., Satellite, -Station *0- Control Module Assy., Satellite, -Station *0- Control Module Assy., MapTo, -Station *0- Control Module Assy., MapTo, -Station *0- Control Module Assy., MapTo, -Station *0- Control Module Assy., MapTo, -Station 0-0 Fuse, Amp, Slow-blow (0-pack) *0- Cable Assembly, Output, " *0- Cable Assembly, Output, 0" *0- Cable Assembly, Data Retrieval (Includes Item ) Mounting Bracket Assy., Control Module Back Plate Assembly Terminal Strip - Toggle Switch w/receptacle 0 0- Power Transformer, 0/ VAC, 0 Hz, 0 VA *0- Output PCB Assembly ** - Grounding Lug 0- Antenna Assy., Pancake Type Ground Plane, Antenna Satellite Plastic Pedestal & Components (See p. xx xx for Parts List) * Order Through Finished Goods Distribution System Minneapolis ** Quantity Varies with Model

19 TDC -Wire Decoder Systems 0

20 0-0SK Door, Gateway Decoder 0-0SK Cabinet, Gateway Decoder 0-SK Timing Mechanism Assy., Gateway (Stand Alone Models Only) -0 Fuse,.A 0-SK Ribbon Cable Assy., Mother Board to Daughter Board - Power Connector, 00V - Power Connector, 0V - Power Connector, 0V 0-0SK PCB Assy., Gateway Motherboard 0-0SK Cable Assy., Timing Mechanism to Motherboard (Stand Alone Models Only) 0-SK PCB Assy., Gateway Daughterboard 0 - Fuse, A, Daughterboard Power Transformer (See Item 0-SK) - Switch, Circuit Breaker,.A 0-SK Wire Harness, Terminal Block to Switch Surge Arrestor (See Item 0-SK) - Lock Assy. w/ Keys -00 Plug, POS - Plug, POS 0-SK 0-SK 0-SK SERVICE ITEMS Power Supply Assy. (Includes Item and Associated Cable Assy.) Harness, Surge, Service (Includes Item and Associated Cable Assy.) Battery, V

21 Vision I Old Style Cabinet 0 0 0

22 - Door, Plastic -00 Latch, Door -0 Card, Instruction, Operating -0 Gasket, Door -0 Cover, Terminal - Screw, Tap, # - Housing, Controller -0 Cover, Transformer - Screw, Tap, # 0-0 Retainer, Transformer -0 Transformer, 0 V a.c., V a.c., - Transformer, 0/0 V a.c., V a.c. (Export Models Only) - Screw, Tap, # -0 Cable, Power Interconnect, Plug-In Models - Transformer, Plug-In, 0 V a.c., V a.c. -0 Screw, - x /" -0 Knob, Station (One Per Station) - Knob, Slide Pot PCB Assy. (See Service Items) - Screw, Tap # 0-0 Fuse, Amp - Fuse, 0. Amp Plate, Front,,, and Station (See Service Items) SERVICE ITEMS -0 Barrier Strip, P, Input Power, Export -0 Kit, Installation, Vision I - Block, Terminal, Position - Timing Mechanism, -Station (Includes Items ) - PCB, -Station (Includes Items, 0 & ) - Timing Mechanism, -Station (Includes Items ) - PCB, -Station (Includes Items, 0 & ) - Timing Mechanism, -Station (Includes Items ) - PCB, -Station (Includes Items, 0 & ) - Timing Mechanism, -Station, Export (Includes Items ) - PCB, -Station, Export (Includes Items, 0 & ) - Timing Mechanism, -Station, Export (Includes Items ) - PCB, -Station, Export (Includes Items, 0 & ) -0 Timing Mechanism, -Station, Export (Includes Items ) - PCB, -Station, Export (Includes Items, 0 & )

23 Vision I New-Style Plastic Cabinet 0 WARNING

24 - Cover, Beige -00 Decal, Instruction - Housing, Beige -0 Front Plate, -Station -00 Front Plate, -Station -0 Front Plate, -Station PCB Assy., -Station (See Service Items) PCB Assy., -Station (See Service Items) PCB Assy., -Station (See Service Items) -0 Knob, Station Extender, Slide Switch - Fuse, 0. Amp -0 Fuse, Amp 0 - Knob, Slide Pot - Cover, Terminal, Beige - Cover, Transformer, Beige -0 Transformer, 0 V a.c., V a.c. - Transformer, 0/0 V a.c., V a.c. (Export Models Only) - Transformer, Plug-In, 0 V a.c., V a.c. -0 Cable, Power Interconnect, Plug-In Models - Screw, Tap # x." - Screw, Tap, # SERVICE ITEMS -0 Barrier Strip, P, Input Power, Export -0 Kit, Installation, Vision I - Block, Terminal, -Position - Timing Mechanism Assy., -Station (Includes Items ) - PCB Assy., -Station (Includes Items, 0 & ) - Timing Mechanism Assy., -Station (Includes Items ) - PCB Assy., -Station (Includes Items, 0 & ) - Timing Mechanism Assy., -Station (Includes Items ) - PCB Assy., -Station (Includes Items, 0 & ) - Timing Mechanism, -Export (Includes Items, 0 & ) - Timing Mechanism, -Station, Export (Includes Items ) - PCB Assy., -Station, Export (Includes Items, 0 & ) -0 Timing Mechanism, -Station, Export (Includes Items ) - PCB Assy., -Station, Export (Includes Items, 0 & )

25 Vision II Old-Style Plastic Cabinet 0 0

26 -00 Door, Plastic -00 Latch, Door -00 Card, Instruction -0 Gasket, Door -000 Cover, Terminal - Screw, Tap, # -00 Housing, Controller -00 Cover, Transformer - Screw, Tap, # 0-0 Retainer, Transformer -0 Transformer, 0 V a.c., V a.c. - Transformer, 0/0 V a.c., V a.c. (Export Models Only) - Screw, Tap, # -0 Cable, Power Interconnect, Plug-in Models - Transformer, Plug-In, 0 V a.c., V a.c. -0 Screw, - x /" -00 Knob, Station (One Per Station) -00 Knob, Slide Pot. -00 Knob, Slide Pot PCB Assy. (See Service Items) 0 - Screw, Tap # 0-0 Fuse,. Amp 0- Fuse, 0. Amp (0-pack) Plate, Front,,, and -Station (See Service Items) SERVICE ITEMS -0 Barrier Strip, P, Input Power, Export -00 Kit, Accessory, Vision II - Timing Mechanism, -Station (Includes Items ) - Timing Mechanism, -Station (Includes Items ) - Timing Mechanism, -Station (Includes Items ) - Timing Mechanism, -Station, Export (Includes Items ) - PCB Assy., -Station, Export (Includes Items, & ) - Timing Mechanism, -Station, Export (Includes Items ) - PCB Assy., -Station, Export (Includes Items, & ) - Timing Mechanism, -Station, Export (Includes Items ) - PCB Assy., -Station, Export (Includes Items, & )

27 Vision II New Style Plastic Cabinet 0 WARNING

28 - Cover, Gray -00 Decal, Instruction - Housing, Gray -0 Front Plate, -Station -0 Front Plate, -Station -0 Front Plate, -Station PCB Assy., -Station (See Service Items) PCB Assy., -Station (See Service Items) PCB Assy., -Station (See Service Items) -00 Knob, Station Extender, Slide Switch -00 Knob, Slide -00 Knob, Slide Fuse,. Amp 0- Fuse, 0. Amp (0-pack) - Cover, Terminal, Gray - Cover, Transformer, Gray - Transformer, 0 V a.c., V a.c. - Transformer, 0/0 V a.c., V a.c. (Export Models Only) - Transformer, Plug-in, 0 V a.c., V a.c. -0 Cable, Power, Interconnect, Plug-in Models - Screw, Tap, # x." - Screw, Tap, # SERVICE ITEMS -0 Barrier Strip, P, Input Power, Export -00 Kit, Accessory, Vision II - Timing Mechanism, -Station (Includes Items ) - Timing Mechanism, -Station (Includes Items ) - Timing Mechanism, -Station (Includes Items ) - Timing Mechanism, -Station, Export (Includes Items ) - PCB Assy., -Station, Export (Includes Items, 0 & ) - Timing Mechanism, -Station, Export (Includes Items ) - PCB Assy., -Station, Export (Includes Items, 0 & ) - Timing Mechanism, -Station, Export (Includes Items ) - PCB Assy., -Station, Export (Includes Items, 0 & )

29 Vision II Metal Cabinet 0 0

30 Item No. Part No. Nomenclature Quantity -00 Cabinet (Includes Door Assy.) - Lock Assy. (Includes Item ) - Key, CH- -00 Card, Instruction -000 Cover, Access - Screw, Tap, # -00 Cover, Transformer - Screw, Tap, # - Transformer, 0 V a.c., V a.c. - Transformer, 0/0 V a.c., V a.c. (Export Models Only) 0-0 Screw, - x /" -0 Plate, Front, -Station, Domestic - Plate, Front, -Station, Export -00 Plate, Front, -Station, Domestic -0 Plate, Front, -Station, Export -0 Plate, Front, -Station, Domestic - Plate, Front, -Station, Export -00 Knob, Slide Pot -00 Knob, Slide Pot -00 Knob, Station (One Per Station) PCB Assy. (See Service Items) - Screw, Tap # 0-0 Fuse,. Amp 0- Fuse, 0. Amp (0-pack) -0 Screw, - x /" Nut, - SERVICE ITEMS -0 Strip, Barrier, P, Input Power, Export -00 Kit, Accessory, Vision II -0 Timing Mechanism, -Station (Includes Items ) - Timing Mechanism, -Station (Includes Items ) - Timing Mechanism, -Station (Includes Items ) - Timing Mechanism, -Station, Export (Includes Items ) - Timing Mechanism, -Station, Export (Includes Items ) - Timing Mechanism, -Station, Export (Includes Items ) - PCB, -Station, Export (Includes Item, & ) - PCB, -Station, Export (Includes Item, & ) - PCB, -Station, Export (Includes Item, & )

31 Vision II Plus Plastic Cabinet 0 WARNING -0 Housing -0 Cover Quick Reference Guide Decal (English) - Timing Mechanism Assy., -station - Timing Mechanism Assy., -station - Timing Mechanism Assy., -station 0-0 Fuse,.A, Fast-Blow -00 Cover, Terminal - Cover, Transformer - Screw, Tap # x 0." -0 Transformer Assy., 0 V a.c. - Transformer Assy., 0/0 V a.c. (Export Models Only) 0 - Screw, Tap, # x." -0 Screw, Tap, # x 0." - AC Terminal Bracket - Transformer, External (Plug-in Models Only) -0 Cable, Power Interconnect (Plug-in Models Only) - Battery, V, Rechargeable 0

32 Vision II Plus Metal Cabinet 0 WARNING -00 Housing Quick Reference Guide Decal (English) - Lock w/key - Timing Mechanism Assy., -station - Timing Mechanism Assy., -station - Timing Mechanism Assy., -station -0 Screw, Tap, # x 0." 0-0 Fuse,. Amp, Fast-blow - Cover, Terminal, Metal - Cover, Transformer - Screw, Tap # x 0." 0-0 Transformer Assy., 0 V a.c. 0 - Transformer Assy., 0/0 V a.c. (Export Models Only) - Screw, Tap, # x." AC Terminal Bracket - Battery, V, Rechargeable

33 The Toro Company Irrigation Division An ISO 000-certified Company P.O. Box Riverside, CA 0-0 (00) -0 Form No. 0-0-IRC 00 The Toro Company All Rights Reserved

34 00 Irrigation Products Illustrated Parts Breakout Res/Com Sprinklers Section

35 GENERAL INFORMATION Please note the following usage guidelines: When dashes ( ) are shown in place of a part number, the part is either not available for sale or not sold separately. Refer to the accompanying Service Items listing for availability. An asterisk ( ) preceding a part number indicates the item is only available through the Toro Finished Goods Distribution System and must be ordered accordingly. This book is updated annually. The published part numbers and descriptions are subject to change. If changes and/or corrections are required, the updated information will be made available through the Toro Distributor Operations Bulletin and/or Tech Tip communications. Common abbreviations used within this publication: A = Ampere Amp = Ampere Assy. = Assembly ADJ = Adjustable B = Barbed BSP = British Standard Pipe COM = Check-O-Matic CR = Contamination Resistant CSA = Canadian Standards Association EL = Electric Elec = Electric Exp = Export F = Female FC = Full Circle (Sprinkler) FC = Flow Control (Valve) GPM = Gallons Per Minute Hyd. = Hydraulic Hz = Hertz in. = Inch Int. = Internal Int. T = Internal Tooth L/ = Less lbs. = Pounds M = Male M/F = Male/Female N/I = Not Indicated NC = Normally Closed (Hydraulic) NC = Normally Closed (Micro Switch) NO = Normally Open (Hydraulic) NO = Normally Open (Micro Switch) NPT = National Pipe Thread PC = Part Circle Pot. = Potentiometer PV = Pilot Valve PHPH = Pan Head Phillips Head PHFH = Pan Head Fillister Head PT = Pin Type (Hydraulic) PR = Pressure Regulated Prog. = Program RC = Rubber Cover RPD = Revolutions Per Day RPM = Revolutions Per Minute S = Slip SST = Stainless Steel SI = Side Inlet Svc = Service TM = Timing Mechanism V = Volts VAC = Volts Alternating Current VDC = Volts Direct Current VA = Volt Amps VIH = Valve In Head w/ = with w/o = without " = Inches ' = Feet

36 0Z-P, 0Z-P, 0Z-P, 0Z-PRX-P & 0Z-XF-P Nozzle (See p. ) - Screen, Filter, SST - Screen, Riser (White Plastic, Regular Mesh) - Screen, Riser (Red Plastic, Fine Mesh) 0- Flush Cap 0-0 Flush Plug, PRX & XF - Cap -0 Cap, COM 0- Cap, Lavender 0- Seal, Cap -0 Spring, 0-P -0 Spring, 0-P, COM - Spring, 0-P 0-0 Spring, 0-P, COM -0 Spring, 0-P 0- Spring, 0-P, COM -0 Retainer, Spring - Riser, P -0 Riser, P -0 Riser, P 0 - COM Assy. - Body, P -0 Body, P -0 Body, P SERVICE ITEMS - Cap Assy. (Includes Items & ) - Cap Assy., COM (Includes Items & ) 0- Cap Assy., Lavender (Includes Items & ) 0-0 PRX Riser Assy., P (Includes Items & ) 0-0 PRX Riser Assy., P, COM (Includes Items, & 0) 0- XF Riser Assy., P (Includes Items & ) 0- XF Riser Assy., P, COM (Includes Items, & 0) Note: All 0 nozzles must be ordered through the Finished Goods Distribution System.

37 0Z-P, 0Z-P SI, 0Z-PRX-P & 0Z-XF-P Nozzle (See p. ) - Screen, Filter, SST - Screen, Riser (White Plastic, Regular Mesh) - Screen, Riser (Red Plastic, Fine Mesh) 0- Flush Cap 0-0 Flush Plug, PRX & XF - Cap -0 Cap, COM 0- Cap, Lavender 0- Seal, Cap 0- Spring, Return, 0-P 0- Spring, Return, 0-P COM -0 Retainer, Spring -0 Riser, P 0 - COM Assy. -00 Body, P -0 Body, P,SI - Plug, /" NPT SERVICE ITEMS - Body Assy., P, SI w/plug (Includes Items & ) - Cap Assy. (Includes Items & ) - Cap Assy., COM (Includes Items & ) 0- Cap Assy., Lavender (Includes Items & ) 0-0 PRX Riser Assy., P (Includes Items & ) 0-0 PRX Riser Assy., P, COM (Includes Items, & 0) 0- XF Riser Assy., P (Includes Items & ) 0- XF Riser Assy., P, COM (Includes Items, & 0) Note: All 0 nozzles must be ordered through the Finished Goods Distribution System.

38 0Z-P, 0Z-P SI, 0Z-PRX-P & 0Z-XF-P Nozzle (See p. ) - Screen, Filter, SST - Screen, Riser (White Plastic, Regular Mesh - Screen, Riser (Red Plastic, Fine Mesh) 0- Flush Cap 0-0 Flush Plug, PRX & XF - Cap, 0-0 Cap, 0Z 0- Cap, Lavender 0- Seal, Cap 0- Spring, Return, 0-P 0- Spring, Return, 0-P, COM -0 Ratchet -0 Ratchet, SI 0- Riser 0 - COM Assy. - Body, P - Body, P, SI - Plug, /" NPT SERVICE ITEMS - Cap, Assy. - Cap Assy., COM (Includes Items & ) 0- Cap Assy., Lavender (Includes Items & ) 0- PRX Riser Assy., P (Includes Items & ) 0- PRX Riser Assy., P COM (Includes Items, & 0) 0- XF Riser Assy., P (Includes Items & ) 0- XF Riser Assy., P COM (Includes Items, & 0) 0- Cap & Riser Kit, 0-P 0- Cap & Riser Kit, 0 Side Inlet-P Note: All 0 nozzles must be ordered through the Finished Goods Distribution System.

39 00 Shrub Plug, Cap, Nozzle (See p. ) Nozzle Assy. (See p. ) (Includes Items & ) 0-0 Screw, Machine, Nozzle, - x /" Disc, Arc (See p. ) - Seal, Nozzle -0 Body, Shrub - Drive Assy., 00 Series - Stator Assy., Shrub 0-0 Spring, COM Screen, Basket, COM - Seal, COM - Screen, Basket - Seal -0 Threaded Insert, /" & /" 0-0 Threaded Insert, /" & /", COM -0 Base, Shrub SERVICE ITEMS -0 Base, Shrub (Pre-0/) - Insert, /" - Insert, /"

40 00 Lawn Plug, Cap, Nozzle (See p. ) Nozzle Assy. (See p. ) (Includes Items & ) 0-0 Screw, Machine, Nozzle, - x /" Disc, Arc (See p. ) - Seal, Nozzle - Cap - Seal, Riser - Spring, Retraction - Riser 0 - Drive Assy. - Stator Assy. - Screen, Basket - Body SERVICE ITEMS - Riser Assy. (Includes Items, 0 & )

41 00 High-pop Plug, Cap, Nozzle (See p. ) Nozzle Assy. (See p. ) (Includes Items & ) 0-0 Screw, Machine, Nozzle, - x /" Disc, Arc (See p. ) - Seal, Nozzle -0 Cap Assy., High-pop (Includes Item ) 0-0 Screw, Set, Half-dog Point, - x /" - Seal, Riser - Spring, Retraction 0-0 Riser - Drive Assy. - Stator Assy. - Screen, Basket -0 Body, HP w/side Inlet - Plug, /" NPT SERVICE ITEMS -0 Riser Assy. (Includes Items 0, & )

42 00/0 Series Nozzle and Arc Disc Components Nozzle Assembly - Lawn and Shrub (Nozzle Only) Order No. Description - Nozzle Assy., Small (0) - Nozzle Assy., Medium (0) - Nozzle Assy., Large (0) -00 Nozzle Assy., Low Gallonage, -Port () -0 Nozzle Assy., Low Gallonage, -Port () Nozzle Cap Plug Order No. Description - Plug, Cap, Nozzle, No. - Plug, Cap, Nozzle, No. - Plug, Cap, Nozzle, No. - Plug, Cap, Nozzle, No. -0 Plug, Cap, Nozzle, Blank - Plug, Cap, Nozzle, Effluent, Lavender Nozzle Assembly - Lawn and Shrub (Includes Nozzle, Cap Plug and Screw) Order No. Description *00- Nozzle Assy., 0 w/blank Cap Plug *00- Nozzle Assy., 0 w/blank Cap Plug *00- Nozzle Assy., 0 w/blank Cap Plug *00-- Nozzle Assy., w/blank Cap Plug *00-- Nozzle Assy., w/blank Cap Plug *0-0 Nozzle Assy., 0 w/no. Cap Plug *0-0 Nozzle Assy., 0 w/no. Cap Plug *0-0 Nozzle Assy., 0 w/no. Cap Plug *-0 Nozzle Assy., 0 w/no. Cap Plug *-0 Nozzle Assy., 0 w/no. Cap Plug *-0 Nozzle Assy., 0 w/no. Cap Plug Nozzle Assembly - High-pop (Includes Nozzle, Cap Plug and Screw) Arc Disc - Stainless Steel (See Note Below) Order No. Description *0-00 Disc, Arc, 0 *0-00 Disc, Arc, *0-00 Disc, Arc, *0-00 Disc, Arc, *0-00 Disc, Arc, 0 *0-00 Disc, Arc, 0 *0-00 Disc, Arc, *-00 Disc, Arc, 0 *-00 Disc, Arc, 0 Note: Nozzle Seal - must be used with stainless steel Arc Disc. Arc Disc Tree- Plastic (See Note Below) Order No. Description *0-0 Tree, Plastic Arc Disc (Includes all discs) Note: Nozzle seal - is not used with plastic Arc Disc. Arc Disc Organizer Order No. Description *0- Stream Rotor Arc Disc Organizer Effluent Water Indicators Order No. Description *- Omni Nozzle Cover (Lawn and Shrub) *- Omni Nozzle Cover (High-pop) *- 00 Stream Rotor Plug (Fixed Radius Nozzles) *-0 Base, Shrub Order No. Description *00- Nozzle Assy., 0 w/blank Cap Plug *00- Nozzle Assy., 0 w/blank Cap Plug *00- Nozzle Assy., 0 w/blank Cap Plug *00-- Nozzle Assy., w/blank Cap Plug *00-- Nozzle Assy., w/blank Cap Plug Omni Nozzle Assembly (Adjustable) Order No. Description *00- Adjustable Stream Rotor Nozzle Standard and Shrub *00- Adjustable Stream Rotor Nozzles High Pop -0 Cover, Cap, Omni Nozzle * Order Through Finished Goods Distribution System Minneapolis

43 0 Shrub Plug, Cap, Nozzle (See p. ) 0-0 Screw, Machine, Nozzle, - x /" Nozzle Assy. (See p. ) (Includes Items & ) Disc, Arc (See p. ) -0 Body, Shrub -0 Drive Assy., 0/XP00 - Stator Assy., Shrub 0-0 Spring, COM - Screen, Basket Screen, COM - Seal, COM - Seal -0 Threaded Insert, /" & /" 0-0 Threaded Insert, /" & /", COM -0 Base, Shrub

44 TORO 0 Lawn TORO Plug, Cap, Nozzle (See p. ) 0-0 Screw, Machine, Nozzle, - x /" Nozzle Assy. (See p. ) (Includes Items & ) Disc, Arc (See p. ) - Cap, Lawn -0 Seal, Riser -0 Spring, Return -0 Riser -0 Drive Assy., 0/XP Stator Assy., Variable, 0 (Includes Service - [Stator Housing] & - [Stator Diaphragm]) -0 Screen, Basket - Seal, Check - Body 0

45 0 High-pop Plug, Cap, Nozzle (See p. ) 0-0 Screw, Machine, Nozzle, - x /" Nozzle Assy. (See p. ) (Includes Items & ) Disc, Arc (See p. ) -0 Cap Assy., High-pop, (Includes Item ) 0-0 Screw, Set, Half-dog Point, - x /" - Seal, Riser - Spring, Return -0 Riser 0-0 Drive Assy., 0/XP00 - Stator Assy., Variable - Screen, Basket -0 Body, HP w/side Inlet - Plug, /" NPT

46 XP-00 Shrub 0 *-0 Nozzle Assy.,.0 GPM *XP00-0 Nozzle Assy.,.0 GPM *XP00-0 Nozzle Assy.,.0 GPM *XP00-0 Nozzle Assy., 0.0 GPM 0-0 Screw, Set, Half-dog Point, - x /" *XP0-00 Disc, Arc, 0 *XP0-00 Disc, Arc, *XP0-00 Disc, Arc, 0 *XP0-00 Disc, Arc, *XP0-00 Disc, Arc, 0 *XP0-00 Disc, Arc, *XP0-00 Disc, Arc, 0 *XP-00 Disc, Arc, *XP-00 Disc, Arc, 0 *XP-00 Disc, Arc, 0 *XP-00 Disc, Arc, 0 - Seal - Body, Shrub -0 Drive Assy., 0/XP00 - Stator Assy. 0-0 Spring, COM 0-0 Screen, Basket, COM 0 - Seal, Check, COM - Screen, Basket - Seal -0 Threaded Insert, /" & /" 0-0 Threaded Insert, /" & /", COM -0 Base, Shrub SERVICE ITEMS -0 Base, Shrub (Pre-0/) - Insert, /" - Insert, /" - Cover, Lavender, XP00/S00/S00 * Order Through Finished Goods Distribution System Minneapolis

47 XP-00 Lawn 0 - Plug, Retainer, Rubber Cover (See Service Item 00-0) - Cover, Rubber (See Service Item 00-0) *-0 Nozzle Assy.,.0 GPM *XP00-0 Nozzle Assy.,.0 GPM *XP00-0 Nozzle Assy.,.0 GPM *XP00-0 Nozzle Assy., 0.0 GPM 0-0 Screw, Set, Half-dog Point, - x /" *XP0-00 Disc, Arc, 0 *XP0-00 Disc, Arc, *XP0-00 Disc, Arc, 0 *XP0-00 Disc, Arc, *XP0-00 Disc, Arc, 0 *XP0-00 Disc, Arc, *XP0-00 Disc, Arc, 0 *XP-00 Disc, Arc, *XP-00 Disc, Arc, 0 *XP-00 Disc, Arc, 0 *XP-00 Disc, Arc, 0 - Seal - Cap - Seal, Riser - Spring, Return 0 - Riser -0 Drive Assy., 0/XP00 - Stator Assy. - Screen, Basket - Body SERVICE ITEMS 00-0 Kit, Rubber Cover (Includes Items, and ) - Cover, Lavender, XP00/S00/S00 (Replaces Item ) * Order Through Finished Goods Distribution System Minneapolis

48 XP-00 High-pop 0 *-0 Nozzle Assy.,.0 GPM *- HP Nozzle Sleeve *XP-0 Nozzle Assy., with sleeve,.0 (Includes Items ) *XP-0 Nozzle Assy., with sleeve,.0 (Includes Items ) *XP-0 Nozzle Assy., with sleeve, 0.0 (Includes Items ) 0-0 Screw, Set, Half-dog Point, - x /" - Sleeve, Nozzle *XP0-00 Disc, Arc, 0 *XP0-00 Disc, Arc, *XP0-00 Disc, Arc, 0 *XP0-00 Disc, Arc, *XP0-00 Disc, Arc, 0 *XP0-00 Disc, Arc, *XP0-00 Disc, Arc, 0 *XP-00 Disc, Arc, *XP-00 Disc, Arc, 0 *XP-00 Disc, Arc, 0 *XP-00 Disc, Arc, 0 - Seal - Cap, Locking w/set Screw 0-0 Screw, Set, Half-dog Point, - x /" -0 Seal, Riser - Spring, Retraction 0 - Riser -0 Drive Assy., 0/XP00 - Stator Assy. - Screen, Basket -0 Body, HP w/side Inlet - Plug, /" NPT SERVICE ITEMS - Cover, Lavender, XP00/S00/S00 (Inserts in Top of Nozzle) * Order Through Finished Goods Distribution System Minneapolis

49 S00 Series 0 - Nozzle Assy., PC. (Includes Items ) - Nozzle Assy., PC. (Includes Items ) - Nozzle Assy., PC.0 (Includes Items ) - Nozzle Assy., FC. (Includes Items ) - Nozzle Assy., FC. (Includes Items ) - Nozzle Assy., FC.0 (Includes Items ) 0-0 Screw, Set, Half-dog Point, - x /" 0-0 Screw, Set, Half-dog Point, - x /" - Seal, Nozzle - Cap (S00) - Seal, Riser - Spring, Retraction - Drive Assy., FC - Drive Assy., PC - Stator Assembly, Variable 0 - Screen - Body SERVICE ITEMS 00-0 Kit, Rubber Cover 0-0 Kit, Check Valve -0 Restrictor, Low Pressure - Cap Assy., Locking (S00C) - Cover, Lavender, XP00/S00/S00 (Inserts in Top of Nozzle)

50 S00 Shrub Nozzle Assy. (Includes Items, see p. ) Lock, Nozzle Pin (See p. ) Screw, Set, Half-dog, - x /" (See p. ) O-Ring,.00" x." x." (White) (See p. ) - Body Assy., PC - Body Assy., FC - Stator Assy., Variable - Screen, S00 Shrub - Seal 0-00 Spring, COM Screen, COM - Seal, Check, COM -0 Threaded Insert, /" & /" 0-0 Threaded Insert, /" & /", COM -0 Base, Shrub SERVICE ITEMS -0 Base, Shrub (Pre-0/) - Threaded Insert, /" - Threaded Insert, /" - Cover, Lavender, XP00/S00/S00 (Inserts in Top of Nozzle). SERVICE TOOLS - Nozzle Tool & Wrench

51 SUPER 00 TORO TORO S00 Lawn 00 SUPER TORO TORO Nozzle Assy. (Includes Items, see p. ) Lock, Nozzle Pin (See p. ) Screw, Set, Half-dog, - x /" (See p. ) O-Ring, 0.00" x 0." x 0." (White) (See p. ) - Cap, Lawn - Seal, Riser -0 Sleeve, Spring -0 Spring, Retraction - Riser Assy., FC - Riser Assy., PC 0 - Stator Assy., Variable - Screen -0 Check Valve (COM Models Only) - Body SERVICE ITEMS 00-0 Kit, Cover, Rubber -0 Cover, Nozzle (For Use with Non-locking Nozzles Only) -00 Restrictor, Low Pressure - Cover, Lavender, XP00/S00/S00 (Inserts in Top of Nozzle) SERVICE TOOLS - Nozzle Tool & Wrench

52 SUPER 00 TORO TORO S00 Commercial 00 SUPER TORO TORO Nozzle Assy. (Includes Items, see p. ) Lock, Nozzle Pin (See p. ) Screw, Set, Half-dog, - x/" (See p. ) O-Ring, 0.00" x 0." x 0." (White) (See p. ) - Cap Assy., 00C Locking 0-0 Screw, Set, Half-dog Point, - x /" - Seal, Riser (S00C) -0 Sleeve, Spring -0 Spring, Retraction 0 - Riser Assy., PC (w/stainless Steel Sleeve) 0 - Riser Assy., FC (w/stainless Steel Sleeve) - Stator Assy., Variable - Screen -0 Check Valve - Body SERVICE ITEMS 00-0 Kit, Cover, Rubber -0 Cover, Nozzle (For Use with Non-locking Nozzles Only) -00 Restrictor, Low Pressure - Cover, Lavender, XP00/S00/S00 (Inserts in Top of Nozzle) SERVICE TOOLS - Nozzle Tool & Wrench

53 S00 High-Pop TORO SUPER SUPER TORO TORO Nozzle Assy. (See p., Includes Items ) Lock, Nozzle Pin (See p. ) Screw, Set, Half-dog, - x /" (See p. ) O-Ring, 0.00" x 0." x 0." (White) (See p. ) -0 Cap, 00 Locking 0-0 Screw, Set, Half-dog Point, - x /" - Seal, Riser -0 Sleeve, Spring - Spring, Retraction 0 - Riser Assy., PC 0 - Riser Assy., FC - Stator Assy., Variable - Screen -0 Check Valve -0 Body, HP w/side Inlet - Plug, /" NPT Male SERVICE ITEMS 00-0 Kit, Cover, Rubber -0 Cover, Nozzle (For Use with Non-locking Nozzles Only) -00 Restrictor, Low Pressure - Cover, Lavender, XP00/S00/S00 (Inserts in Top of Nozzle) SERVICE TOOLS - Nozzle Tool & Wrench

54 S00 Nozzles 00 SUPER TORO STANDARD ANGLE *-0L Kit, Nozzle,., Orange (Includes Items ) *-0L Kit, Nozzle,.0, Red (Includes Items ) *-0L Kit, Nozzle,.0, Black (Includes Items ) *-0L Kit, Nozzle,., Blue (Includes Items ) *-0L Kit, Nozzle,.0, Green (Includes Items ) *-0L Kit, Nozzle,., Tan (Includes Items ) *-0L Kit, Nozzle,.0, Gray (Includes Items ) -00 Lock, Nozzle Pin, Standard Angle, Black 0-0 Screw, Set, Half-dog Point, - x /" 0-0 O-Ring,.00" x." x." (White) LOW ANGLE *-0L Kit, Nozzle,., Orange(Includes Items ) *-0L Kit, Nozzle,.0, Red (Includes Items ) *-0L Kit, Nozzle,.0, Black (Includes Items ) *-0L Kit, Nozzle,., Blue (Includes Items ) *-0L Kit, Nozzle,.0, Green (Includes Items ) *-0L Kit, Nozzle,., Tan (Includes Items ) *-0L Kit, Nozzle,.0, Gray (Includes Items ) - Lock, Nozzle Pin, Low Angle, Gray 0-0 Screw, Set, Half-dog Point, - x /" 0-0 O-Ring,.00" x." x." (White) FLAT ANGLE *-L Kit, Nozzle,., Orange (Includes Items ) *-L Kit, Nozzle,.0, Red (Includes Items ) *-0L Kit, Nozzle,.0, Black (Includes Items ) *-L Kit, Nozzle,., Blue (Includes Items ) *-L Kit, Nozzle,.0, Green (Includes Items ) *-L Kit, Nozzle,., Tan (Includes Items ) *-L Kit, Nozzle,.0, Gray (Includes Items ) - Lock, Nozzle Pin, Flat Angle, Beige - Screw, Set, Half-dog, -0 x /" (Black) 0-0 O-Ring,.00" x." x." (White) * Order Through Finished Goods Distribution System Minneapolis 0

55 V-0-Shrub *V-0-S Body Assy., PC (Includes Items ) *V-0-SF Body Assy., FC (Includes Items ) *V-0-SL Body Assy., PC (w/low-pressure Nozzle) (Includes Items ) *V-0-SFL Body Assy., FC (w/low-pressure Nozzle) (Includes Items ) *V-0 SCOM, Body Assy., PC (w/com) *V-0 SFCOM, Body Assy., FC (w/com) - Screen 0-0 Spring, COM 0-0 Screen, COM - Seal, Check, COM - Seal -0 Threaded Insert, /" & /" 0-0 Threaded Insert, /" & /", COM -0 Base, Shrub SERVICE TOOLS -0 Adjustment Key * Order Through Finished Goods Distribution System Minneapolis

56 V Rubber Cover, Body - Snap Ring - O-Ring Retainer (See Service Items) Riser Assy. (See Service Items) - Screen - Seal, Check - Body SERVICE ITEMS - Spring Retainer (LFLP Model) 0-0 Seal Retainer (LFLP Model) 0- Riser Seal (LFLP Model) 0-0 Spring Retainer & Seal Kit, V0 0- Retainer w/ O-Ring (Includes Items and ) 0- V-0-FLFLP Riser Assy. (Full Circle, Low Flow, Low Pressure) 0- V-0-LFLP Riser Assy. (Part Circle, Low Flow, Low Pressure) SERVICE TOOLS -0 Adjustment Key - Multi-purpose Tool

57 V Rubber Cover, Body - Snap Ring - O-Ring Retainer (See Service Items) Riser Assembly (See Service Items) - Screen - Seal, Check - Body - /" NPT Plug SERVICE ITEMS - Spring Retainer (LFLP Model) 0-0 Seal Retainer (LFLP Model) 0- Riser Seal (LFLP Model) 0-0 Spring Retainer & Seal Kit, V0 0- Retainer w/ O-Ring (Includes Items and.) 0-00 V-0-FLFLP Riser Assy. (Full Circle, Low Flow, Low Pressure) 0-0 V-0-LFLP Riser Assy. (Part Circle, Low Flow, Low Pressure) - V-0- Riser Assy. (Part Circle, Standard) - V-0-F Riser Assy. (Full Circle, Standard SERVICE TOOLS -0 Adjustment Key - Multi-purpose Tool

58 T Shrub Item No. Part No. Nomenclature Quantity Shrub Body Assembly (Order Finished Good TS) 0-0 Check, Spring 0-0 Screen - Check Seal - Seal 0-0 Threaded Inlet, /" / /" -0 Base 0- Nozzle Tree SERVICE TOOLS 0- Adjustment Tool

59 T, " Pop Item No. Part No. Nomenclature Quantity Riser Assembly (Order Finished Good TP) 0- Screen - Check Seal (Optional, Not Included with the Riser Assembly) 0- Body 0- Nozzle Tree SERVICE TOOLS 0- Adjustment Tool

60 T, High-Pop Item No. Part No. Nomenclature Quantity Riser Assembly (Order Finished Good THP) 0- Screen - Check Seal (Optional, Not Included with the Riser Assembly) 0-0 Body - Plug, /" 0- Nozzle Tree SERVICE TOOLS 0- Adjustment Tool

61 TR0 Shrub - Cap and Seal Assy. - Ring, Retaining - Spring, Shrub Riser Assy. (Order Finished Goods Models TR0S or TR0SE [Effluent]) - Screen - Seal, Check 0- Tree, Nozzle -0 Body, Shrub SERVICE TOOLS 0-0 Adjustment Tool

62 TR0 Lawn 0 - Cap and Seal Assy. 0-0 Cap, Stainless Steel Riser - O-Ring, Stainless Steel Riser 0- Seal w/ Retainer, Stainless Steel Riser - Ring, Retaining - Spring, Retraction Riser Assy. Order the Following Finished Goods Models: TR0P, TR0PE (Effluent), TR0PSS (Stainless Steel Riser) or TR0PSSE (Stainless Steel Riser, Effluent) - Screen - Seal, Check 0 - Body 0- Tree, Nozzle SERVICE TOOLS 0-0 Adjustment Tool

63 TR0 High-Pop - Cap and Seal Assy. - Ring, Retaining - Spring, Retraction, " Riser Assy. (Order Finished Goods Models TR0HP or TR0HPE [Effluent]) - Screen - Seal, Check 0- Tree, Nozzle - Body, " - Plug, /" NPT SERVICE TOOLS 0-0 Adjustment Tool

64 TR0XT Shrub - Cap and Seal Assy. - Ring, Retaining - Spring, Shrub Riser Assy. (Order Finished Goods Models TR0XTS or TR0XTSE [Effluent]) - Screen - Seal, Check 0- Tree, Nozzle -0 Body, Shrub SERVICE TOOLS 0-0 Adjustment Tool 0

65 TR0XT Lawn 0 - Cap and Seal Assy. 0-0 Cap, Stainless Steel Riser - O-Ring, Stainless Steel Riser 0- Seal w/ Retainer, Stainless Steel Riser - Ring, Retaining - Spring, Retraction Riser Assy. Order the Following Finished Goods Models: TR0XTP, TR0XTPE (Effluent), TR0XTPSS (Stainless Steel Riser) or TR0XTPSSE (Stainless Steel Riser, Effluent) - Screen - Seal, Check 0 0- Tree, Nozzle - Body SERVICE TOOLS 0-0 Adjustment Tool

66 TR0XT High-Pop - Cap and Seal Assy. - Ring, Retaining - Spring, Retraction, " Riser Assy. (Order Finished Goods Models TR0XTHP or TR0XTHPE [Effluent]) - Screen - Seal, Check 0- Tree, Nozzle - Body, " - Plug, /" NPT SERVICE TOOLS 0-0 Adjustment Tool

67 TR0P & TR0XT 0 0- Cap and Seal Assy. 0-0 Cap, Stainless Steel Riser - O-Ring, Stainless Steel Riser 0- Seal w/ Retainer, Stainless Steel Riser 0-0 Set Screw, Cap - Ring, Retaining 0-0 Spring, Retraction Riser Assy. Order the Following Finished Goods Models: TR0P-0, TR0P-0E (Effluent), TR0PSS-0 (Stainless Steel Riser), TR0PSS-0E (Stainless Steel Riser, Effluent), TR0XTP-0, TR0XTP-0E (Effluent), TR0XTPSS-0 (Stainless Steel Riser), or TR0XTPSS-0E (Stainless Steel Riser, Effluent) - Screen 0 - Seal, Check 0- Tree, Nozzle 0-0 Body Assy., NPT Threads 0-00 Body Assy., BSP Threads SERVICE TOOLS 0-0 Adjustment Tool

68 0 - Cap Assy., 0 Service (Includes Item ) - Set Screw, /-0 - Seal, Nozzle Container - Retainer -000 Rubber Cover, Nozzle (For or Later Models) -00 Rubber Cover, Nozzle, Effluent (For or Later Models) 0-0 Screw, Set, Half-dog Point, - x /" Nozzle Assy. (See Service Items: Nozzle/Stator Assy.) -0 Screw, Half-dog Point, - x /" x Seal, (Nozzle to Spindle) 0 *0-00 Drive Assy., 0, 0 *0-000 Drive Assy., 0, 0 0 *0-000 Drive Assy., 0, 0 0 *0-00 Drive Assy., 0, 0 0 *0-00 Drive Assy., 0, 0 0 *0-00 Drive Assy., 0, 0 0 *0-00 Drive Assy., 0, 0 0 *0-0 Drive Assy., 0, 0 *0-0 Drive Assy., 0,

69 0 *0-0 Drive Assy., 0, 0 *0-0 Drive Assy., 0, 0 *0-0 Drive Assy., 0, Seal Assy. (See Service Item -0) - Stator Assy., #0 (Includes Items and ) - Stator Assy., # (Includes Items and ) - Stator Assy., # (Includes Items and ) - Stator Assy., # (Includes Items and ) -0 Stator Assy., # (Includes Items and ) -0 Screen - Seat, COM -0 Snap Ring, Valve - Cylinder Assy., Hyd., NO - Spring, Valve, Hyd., NO -0 Piston Assy., Hyd., NO -0 Body Assy., COM -0 Body Assy., COM (BSP) -0 Body Assy., Hyd., NO (Includes Item 0 ) -0 Body Assy., Hyd., NO (BSP) (Includes Item 0 ) 0-00 /" Tubing Adapter, Threaded - Cap, Poly *00-0 Retainer, Tube SERVICE PARTS AND ASSEMBLIES -0 Valve Assy.,.0" Hyd., NO, (Includes Items ) - /" Tubing Adapter, Oversize Threads -0 Seal Assembly Replacement Kit -0 Stator Assy., Fast, # (Includes Items ) -0 Stator Assy., Fast, #/ (Includes Items ) *0-0 #0 Nozzle/Stator Assy. (Includes Items and ) *0- # Nozzle/Stator Assy. (Includes Items and ) *0- # Nozzle/Stator Assy. (Includes Items and ) *0- # Nozzle/Stator Assy. (Includes Items and ) *0- # Nozzle/Stator Assy. (Includes Items and ) *0-0E #0 Nozzle/Stator Assy., Effluent (Includes Items and ) *0-E # Nozzle/Stator Assy., Effluent (Includes Items and ) *0-E # Nozzle/Stator Assy., Effluent (Includes Items and ) *0-E # Nozzle/Stator Assy., Effluent (Includes Items and ) *0-E # Nozzle/Stator Assy., Effluent (Includes Items and ) *0-0 Body Package, 0, Hyd., NO (Includes Items and ) *0- Body Package, 0, Hyd., NO, BSP (Includes Items and ) *0-0 Body Package, 0, COM (Includes Items and ) *0- Body Package, 0, COM, BSP (Includes Items and ) -00 Rubber Cover Upgrade Kit #0 (Includes Items, and ) -0 Rubber Cover Upgrade Kit # (Includes Items, and ) -0 Rubber Cover Upgrade Kit # (Includes Items, and ) -0 Rubber Cover Upgrade Kit # (Includes Items, and ) -0 Rubber Cover Upgrade Kit # (Includes Items, and ) - Container, Nozzle (Pre- Models) - Container, Nozzle (Without Set Screw Hole, Pre- Models) -0 Rubber Cover, Nozzle (Pre- Models) - Retainer, Rubber Cover - Rubber Cover, Cap SERVICE TOOLS -00 Snap Ring Pliers -0 Valve Removal Tool - Valve Insertion Tool - Seal Installation Tool - 0 Canister Removal Tool - Cap Removal Tool * Order Through Finished Goods Distribution System Minneapolis

70 00

71 - Cap, Rubber 0-00 Seal, Debris - Snap Ring - Screw, 0 x.0", Phpnh, HLXA 0-00 O-Ring, 0.00" x0." x 0." - Nozzle Top Assy., PC - Nozzle Top Assy., FC - Nozzle Top Assy., PC, Effluent - Nozzle Top Assy., FC, Effluent - Nozzle Base Retainer -0 O-Ring, 0.0" x." x." O-Ring Retainer (See Service Item -) 0 - Spring - Shaft (PC Pin) -0 Arm, Clutch (PC Models Only) - Spring, Clutch (PC Models Only) - Nut, Nozzle Base - Base, Nozzle - Nozzle, Main,.0, Yellow - Nozzle, Main,.0, Orange - Nozzle, Main,.0, Brown - Nozzle, Main,.0, Gray - Nozzle, Main,.0, Blue - Nozzle, Main,.0, Green - Nozzle, Lower, Small (White) -0 Nozzle, Lower, Large (Red) -0 O-Ring, #, 0.0" x.0" x." (Yellow) - Riser 0-0 Brake -0 Gear Drive Assy., 00 (Includes Item ) - Holder, Stator Stator (See Service Item -0) - Screen - Check Valve - Body Assy., BSP - Body Assy., NPT SERVICE ITEMS -0 Stator Assy., 00 (Includes Item & ) - COM Assy., 00 (Includes Items and ) - O-Ring Retainer Assy., SVC (Includes Items & ) - Ring, Seal Support (Pre-/) - Seal, Riser (Pre-/) -0 Spring Retainer (Pre-/) - Spring (Pre-/) - Cover, Vandal Resistant 0-0 Tree, Nozzle, Colored SERVICE TOOLS - Adjustment Tool - Multi-purpose Tool

72 00 LIFT S00 0 LIFT 00 LIFT 0

73 - Cap, Rubber 0-00 Seal, Debris - Snap Ring - Screw, #0 x.0" Phpnh, HLXA 0-00 O-Ring, 0.00" x 0." x 0." - Nozzle Top Assy., PC - Nozzle Top Assy., FC - Nozzle Top Assy., PC, Effluent - Nozzle Top Assy., FC, Effluent - Nozzle Base Retainer -0 O-Ring, 0.0" x." x." O-Ring Retainer (See Service Item -) 0 - Spring - Shaft (PC Only) -0 Arm, Clutch (PC Only) - Spring, Clutch (PC Only) - Nut, Nozzle Base -0 Nozzle Base Assy. - Nozzle, Main,.0, Yellow - Nozzle, Main,.0, Orange - Nozzle, Main,.0, Brown - Nozzle, Main,.0, Gray - Nozzle, Main,.0, Blue - Nozzle, Main,.0, Green - Nozzle, Lower, Small (White) -0 Nozzle, Lower, Large (Red) -0 O-Ring, #, 0.0" x.0" x." (Yellow) - Riser Assy. 0-0 Brake -0 Gear Drive Assy., 00 (Includes Item ) - Holder, Stator Stator (See Service Item -0) - Screen - Check Valve - Body Assy., BSP - Body Assy., NPT SERVICE ITEMS -0 Stator Assy., 00 (Includes Item & ) - COM Assy., 00 (Includes Items &) - O-Ring Retainer Assy., SVC (Includes Items & ) - Ring, Seal Support (Pre-/) - Seal, Riser (Pre-/) -0 Spring Retainer (Pre-/) - Spring (Pre-/) - Cover, Vandal Resistant 0-0 Nozzle Tree, Colored SERVICE TOOLS - Adjustment Tool - Multi-purpose Tool

74 The Toro Company Irrigation Division An ISO 000-certified Company P.O. Box Riverside, CA 0-0 (00) -0 Form No. 0-0-IRC 00 The Toro Company All Rights Reserved

75 00 Irrigation Products Illustrated Parts Breakout Valves Section

76 GENERAL INFORMATION Please note the following usage guidelines: When dashes ( ) are shown in place of a part number, the part is either not available for sale or not sold separately. Refer to the accompanying Service Items listing for availability. An asterisk ( ) preceding a part number indicates the item is only available through the Toro Finished Goods Distribution System and must be ordered accordingly. This book is updated annually. The published part numbers and descriptions are subject to change. If changes and/or corrections are required, the updated information will be made available through the Toro Distributor Operations Bulletin and/or Tech Tip communications. Common abbreviations used within this publication: A = Ampere Amp = Ampere Assy. = Assembly ADJ = Adjustable B = Barbed BSP = British Standard Pipe COM = Check-O-Matic CR = Contamination Resistant CSA = Canadian Standards Association EL = Electric Elec = Electric Exp = Export F = Female FC = Full Circle (Sprinkler) FC = Flow Control (Valve) GPM = Gallons Per Minute Hyd. = Hydraulic Hz = Hertz in. = Inch Int. = Internal Int. T = Internal Tooth L/ = Less lbs. = Pounds M = Male M/F = Male/Female N/I = Not Indicated NC = Normally Closed (Hydraulic) NC = Normally Closed (Micro Switch) NO = Normally Open (Hydraulic) NO = Normally Open (Micro Switch) NPT = National Pipe Thread PC = Part Circle Pot. = Potentiometer PV = Pilot Valve PHPH = Pan Head Phillips Head PHFH = Pan Head Fillister Head PT = Pin Type (Hydraulic) PR = Pressure Regulated Prog. = Program RC = Rubber Cover RPD = Revolutions Per Day RPM = Revolutions Per Minute S = Slip SST = Stainless Steel SI = Side Inlet Svc = Service TM = Timing Mechanism V = Volts VAC = Volts Alternating Current VDC = Volts Direct Current VA = Volt Amps VIH = Valve In Head w/ = with w/o = without " = Inches ' = Feet

77 TPV Series Valves, Inch Male 0 Item No. 0 Part No EFF-Kit-0Hz EFF-Kit-0Hz Description Quantity Solenoid Assy., VAC, 0 Hz Solenoid Assy., VAC, 0 Hz Solenoid Assy., DC, Latching Handle, Bleed Plug Bleed Plug Assy. Handle, Flow Control (Flow Control Models) Screw Cover Assy. (w/o Flow Control) Cover Assy. (Flow Control Models) External Bleed Screw O-Ring, Stem Assembly (Flow Control Models) Stem Assembly (Flow Control Models) Spring Diaphragm Assy. Divider O-Ring, Body Body Assy., ", M x M, NPT Body Assy., ", M x M, BSP Body Assy., ", M x B, NPT Plunger O-Ring SERVICE Items Reclaimed Water Solenoid Kit, Effluent, 0Hz, Domestic Reclaimed Water Solenoid Kit, Effluent, 0Hz, International

78 TPV Series Valves, Inch Female 0 Item No. 0 Part No EFF-Kit-0Hz EFF-Kit-0Hz Description Quantity Solenoid Assy., VAC, 0 Hz Solenoid Assy., VAC, 0 Hz Solenoid Assy., DC, Latching Handle, Bleed Plug Bleed Plug Assy. Handle, Flow Control (Flow Control Models) Screw Cover Assy. (w/o Flow Control) Cover Assy. (Flow Control Models) External Bleed Screw O-Ring, Stem Assembly (Flow Control Models) Stem Assembly (Flow Control Models) Spring Diaphragm Assy. Divider O-Ring, Body Body Assy., ", F x F, NPT Body Assy., ", F x F, BSP Body Assy., ", S x S Plunger O-Ring SERVICE Items Reclaimed Water Solenoid Kit, Effluent, 0Hz, Domestic Reclaimed Water Solenoid Kit, Effluent, 0Hz, International