Grade 80 Chain Sling Components. Grade 100 Chain Sling Components
|
|
- Silvester Parsons
- 6 years ago
- Views:
Transcription
1
2 NGER: Overhead lifting presents a very real danger of severe injury or loss of life if lifting equipment is not used properly.lease read and understand all of these instructions prior to using any lifting sling or sling assembly. Sling should only be used by qualified persons who are responsible for the sling selection, inspection and use. Grade 80 Chain Sling Components WORING LO LIMIS IN ONNES acc. to EN1677 Choke endless sling chain size mm onnes Chain Sling Components WORING LO LIMIS IN ONNES acc. to EN Choke endless sling Load Factor chain size mm onnes ** Safety factor 4:1 bove limits are valid for standard use and equally loaded slings. roperly used and maintained your YOE chain slings will give long life and will enable you to carry out your lifting operations efficiently and safety. Warning: Never exceed a sling angle of East McFadden ve. Santa na, C YOE Industrial Corp. oll Free: Local: ll Rights Reserved. 79 WRNING NEVER EXCEE UBLISE WORING LO LIMI
3 SFE USE Never load in excess of the rated capacity for the application. eep a record of all slings in use. User should remove all twists from a chain leg before lifting and, should never knot a chain. lways use YOE shortening hook or clutch when chain slings should be shortened. lways inspect to insure that chain is free from damage or wear before use. lways inspect all sling components prior to each use. Ensure that chain is protected from any sharp corners on the load. Ensure that the master link articulates freely on the hook of the crane or other lifting appliance. Never tip load hooks. he load should always be supported correctly in the bowl of the hook. lways use the correct size sling for the load, allowing for the included angle and the possibility of unequal loading. ersonnel must keep all body parts from between the sling and the load, and from between the sling and the crane/hoist hook. ersons shall never ride the chain sling/rope sling or web sling or the load during lifting or while suspended. ersons must stand clear of all loads while lifting or while suspended. uring lifting, with or without the load, personnel must be alert for possible snagging of the load or the chain sling. MINENNCE thorough examination should be carried out by a competent person at intervals at least every year or more frequently according to statutory regulations, type of use and past records. Chains with bent links or with cracks or gouges in the link should be replaced, as should deformed components such as bent master links, deformed hooks and any fittings showing signs of damage. Chain and components wear should never exceed 10%of the original dimensions. Once a chain sling has been overloaded it must be taken out of service. Store chain slings on a properly designed rack. hey should not be left lying on the floor where they may suffer mechanical or corrosion damage or may be lost. LIMIION ON USE YOE alloy chain or chain slings should not be used in acid or caustic solutions nor in heavily acidic or caustic laden atmospheres. he high tensile strength of the heat treated alloy material in alloy steel chains and components is susceptible to hydrogen embrittlement when exposed to acids. YOE slings must not be heat-treated, galvanized, plated, coated or subject to any process involving heating or picking. Each of these processes can have dangerous effects and will invalidate the manufacturer certificate. YOE slings may be used at temperatures between -40 C to 200 C with no reduction in the working load limit. he use of YOE chain slings within the permissible temperature range in the table below does not require any permanent reduction in working load limit when the chain sling is returned to normal temperatures. sling accidentally exposed to temperatures in excess of the maximum permissible should be withdrawn form service immediately and returned to the distributor for thorough examination. When using YOE slings in exceptionally hazardous conditions, the degree of hazard should be assessed by a competent person and the adjusted accordingly. Examples are lifting of potentially dangerous loads such as molten metals, corrosive materials or fissile material and including certain offshore activities. Sling temperature Reduction in working Load Limit -40 to 200 None 200 to % 300 to % bove 400 o not use. WRNING NEVER EXCEE UBLISE WORING LO LIMI East McFadden ve. Santa na, C YOE Industrial Corp. oll Free: Local: ll Rights Reserved.
4 Examples Of Chain Slings 1600 East McFadden ve. Santa na, C YOE Industrial Corp. oll Free: Local: ll Rights Reserved. 81 WRNING NEVER EXCEE UBLISE WORING LO LIMI
5 Examples Of Wire Rope Sling & Web Sling WRNING NEVER EXCEE UBLISE WORING LO LIMI East McFadden ve. Santa na, C YOE Industrial Corp. oll Free: Local: ll Rights Reserved.
6 Incorrect Use > East McFadden ve. Santa na, C YOE Industrial Corp. oll ll Free: Rights Reserved. Local: WRNING NEVER EXCEE UBLISE WORING LO LIMI
7 100 G-100 Oblong Master Link. IL IW rade Size Chain Size (inch) imensions (inch) N.W. inch 1-Leg 2-Leg Lbs* tonnes* IL IW Lbs X /8 7/ , X /2 1/4~5/16 7/32 9, X /8 3/8 1/4~5/16 15, X /4 1/ , X /8 1/2 3/8 23, X / , X /8 5/8 1/2 33, X /4 3/ , X /8 7/8 5/8 50, X / , X /8 1 3/4 78, X /4 1-1/4 7/8 105, ged Oblong Master Links. esign factor 4:1 proof tested and certifi ed. G-100 Connecting Link. B Lbs* tonnes* inch B Lbs X , / X , /4~5/ X , / X , / X , / X , / X , / X , X , / esign factor 4:1 proof tested and certifi ed. Connecting Link, acormet surface fi nish.** B special pin and sleeve designed for more often re-use purpose. Lbs* tonnes* inch B Lbs X-M , / X-M , /4~5/ X-M , / X-M , / X-M , / X-M , / X-M , / X-M , X-M , / esign factor 4:1 proof tested and certifi ed. WRNING NEVER EXCEE UBLISE WORING LO LIMI East McFadden ve. Santa na, C YOE Industrial Corp. oll Free: ll Local: Rights Reserved
8 100 G-100 Eye Self Locking ook. Lbs* tonnes* inch Lbs X , / X , /4~5/ X , / X , / X , / X , / X , / X , G-100 Clevis Self Locking ook. Lbs* tonnes* inch Lbs X , / X , /4~5/ X , / X , / X , / X , / X , / G-100 Swivel Self Locking ook, with brass bushing. Lbs* tonnes* inch B Lbs X , / X , /4~5/ X , / X , / X , / X , / X , / X , WRNING INFORMION:his hook is a positioning device and is not intended to rotate under load. swivel hooks designed to rotate under load, see pages 83 X-027N East McFadden ve. Santa na, C YOE Industrial Corp. oll Free: Local: ll Rights Reserved. 85 WRNING NEVER EXCEE UBLISE WORING LO LIMI
9 100 G-100 Swivel Self Locking ook, with ball bearing. Ball bearing performs to fully swivel under load. Lbs* tonnes* inch B Lbs X-027N-06 2, / X-027N-07 5, /4~5/ X-027N-10 8, / X-027N-13 15, / X-027N-16 22, / X-027N-20 35, / X-027N-22 42, / X-027N-26 59, G-100 Eye Sling ook, with latch 1 Lbs* tonnes* inch 1 Lbs X-044/S-06 2, / X-044/S-07 5, /4~5/ X-044/S-10 8, / X-044/S-13 15, / X-044/S-16 22, / X-044/S-20 35, / X-044/S-22 42, / X-044/S-26 59, X-044/S-32 90, / G-100 Clevis Sling ook, with latch 1 Lbs* tonnes* inch 1 Lbs X-043/S-06 2, / X-043/S-07 5, /4~5/ X-043/S-10 8, / X-043/S-13 15, / X-043/S-16 22, / X-043/S-20 35, / WRNING NEVER EXCEE UBLISE WORING LO LIMI East McFadden ve. Santa na, C YOE Industrial Corp. oll Free: ll Local: Rights Reserved
10 100 G-100 lloy Eye oist ook,with latch d 1 ook Load Feature Limit Chain imensions (mm) N.W. Code tonnes* inch 1 d Lbs BB 1.4 7/ CC 2.5 1/4~5/ / EE 6.7 1/ FF / GG / / When using hoist hook with grade 100 chain, YOE hoist hook is recommended to grind the WLL (which is for a safety factor 5:1) off the hook. Minimum Ultimate Load is 4 times the. Maximun roof Load is 2.5 times the Latch its G-100 lloy Swivel oist ook,with brass washer. L B C G 1 ook Feature Code Load Limit tonnes* inch B C G L 1 Lbs BB 1.4 7/ CC 2.5 1/4~5/ / EE 6.7 1/ FF / GG / / Minimum Ultimate Load is 4 times the. Maximun roof Load is 2.5 times the. When using hoist hook with grade 100 chain, YOE hoist hook is recommended to grind the WLL (which is for a safety factor 5:1) off the hook. WRNING INFORMION:his hook is a positioning device and is not intended to rotate under load. swivel hooks designed to rotate under load, see pages N. G-100 lloy Swivel Bearing oist ook,with ball bearing. Ball bearing performs to fully swivel under load. L B C G 1 ook Feature Code Load Limit tonnes* inch B C G L 1 Lbs 8-175N-015 BB 1.4 7/ N-02 CC 2.5 1/4~5/ N / N-05 EE 6.7 1/ N-07 FF / N-11 GG / N / When using hoist hook with grade 100 chain, YOE hoist hook is recommended to grind the WLL (which is for a safety factor 5:1) off the hook. Minimum Ultimate Load is 4 times the. Maximun roof Load is 2.5 times the East McFadden ve. Santa na, C YOE Industrial Corp. oll Free: ll Rights Reserved. Local: WRNING NEVER EXCEE UBLISE WORING LO LIMI
11 100 G-100 Eye Grab ook. Not for use with Omega Link. No reduction of working load limit, thanks to supporting wings which prevent chain link deformation. G Lbs* tonnes* inch G F Lbs X , / X , /4~5/ X , / X , / X , / X , / X , / F G-100 Eye Foundry ook. Lbs* tonnes* inch Lbs X , /4~5/ X , / X , / X , / X , / Clevis Foundry ook. Lbs* tonnes* inch Lbs X , /4~5/ X , / X , / X , / X , / WRNING NEVER EXCEE UBLISE WORING LO LIMI East McFadden ve. Santa na, C YOE Industrial Corp. oll Free: ll Rights Local: Reserved
12 100 G-100 Clevis Grab ook. Not for use with Omega Link. No reduction of working load limit, thanks to supporting wings which prevent chain link deformation. L Lbs* tonnes* inch F L Lbs X , / X , /4~5/ X , / X , / X , / X , / F G-100 Clevis Grab ook - Without Cradle. Not for use with Omega Link. F L Lbs* tonnes* inch F L Lbs X , / X , /4~5/ X , / X , / X , / X , / X , / G-100 Clutch Sling ook - Locking Clutch. L C B Grade 100 Lbs* tonnes* inch B C L Lbs X , / X , /4~5/ X , / X , / X , / atent 1600 East McFadden ve. Santa na, C YOE Industrial Corp. oll ll Rights Free: Reserved Local: WRNING NEVER EXCEE UBLISE WORING LO LIMI
13 G-100 Web Sling Connector. 100 W B Lbs* tonnes* inch B W Lbs X , / X , /4~5/ X , / X , / X , / X , / X , / G-100 Web Sling ook. imensions (inch) N.W. Lbs* tonnes* W Lbs X , X , X , X , esign factor 5:1 proof tested and certified. G-100 Round Sling Self Locking ook. W Lbs* tonnes* inch B W Lbs X , / X , /4~5/ X , / X , / X , / X , / X , / WRNING NEVER EXCEE UBLISE WORING LO LIMI East McFadden ve. Santa na, C YOE Industrial Corp. oll Free: Local: ll Rights Reserved.
GRADE 80 LIFTING CHAIN & FITTINGS
GRE 80 LIFING CIN & FIINGS PWB nchor Gr8 Range Component selection guide Single Leg Multi Leg Chain Gr8 Couplok Regular Series Oblong Link Large Series Oblong Link Regular Series Oblong Link Large Series
More informationWEIGHT CONTENTS SIZE DESCRIPTION WORKING LOAD LIMIT
rade Chain LENTH S0606 3/8 6 8,800 lbs. 12.5 lbs. S0608 3/8 8 8,800 lbs. 15.5 lbs. S0610 3/8 10 8,800 lbs. 18.5 lbs. S0616 3/8 16 8,800 lbs. 27.3 lbs. S0620 3/8 20 8,800 lbs. 33.3 lbs. S0806 1/2 6 15,000
More informationGrade 80 & 100 Alloy Chain
Grade 80 & 100 Alloy Chain General Information WORKING LOAD LIMIT The Working Load Limit is the maximum load in pounds which should ever be applied to chain, when the chain is new or in as-new condition,
More informationPWB Anchor Grade 100 Range
PWB Anchor Grade 100 Range Component selection guide Single Leg Multi Leg Eye Foundry Hook Eye Self- Locking Hook Swivel Self Locking Hook Clevis Self Locking Hook Clevis Sling Hook Clevis Grab Hook Chain
More informationCare, Use & Inspection
Care, Use & Inspection The life and strength of erc-alloy 1000 chain slings depend on proper inspection, maintenance and use. For additional information, refer to ASE 30.9 and OSA 1910.184. Care Chain
More informationGunnebo Lifting Offshore programme - accessories. High consistent quality generates long durability and safety
Gunnebo Lifting Offshore programme - accessories High consistent quality generates long durability and safety DNV 2.7-1 certificate We are certified by DNV to make type approval in 271 quality (Offshore
More informationCare, Use & Inspection Herc-Alloy 800 Chain...35 Herc-Alloy 800 Slings Herc-Alloy 800 Components Master Link...
are, Use & Inspection....................... 34 Herc-lloy 800 hain.........................35 Herc-lloy 800 Slings......................36-37 Herc-lloy 800 omponents................38-39 Master Link................................40
More informationCHAIN SLING USAGE 2, 3 ORDERING SLINGS AND CHAIN STYLES 4 GRADE 80 WORKING LOAD LIMITS 5, 6 GRADE 80 CHAIN AND ATTACHMENTS 7-17
TABLE OF CONTENTS CHAIN SLING USAGE 2, 3 ORDERING SLINGS AND CHAIN STYLES 4 GRADE 80 WORKING LOAD LIMITS 5, 6 GRADE 80 CHAIN AND ATTACHMENTS 7-17 EUROPEAN GRADE 80 CHAIN ATTACHMENTS 18-23 GRADE 100 CHAIN
More information#908C. Weatherly Index #148. For Transportation and Industry Lifting / Cargo Control / Hardware / Winter Traction Products
#0C Weatherly Index #4 For Transportation and Industry Lifting / Cargo Control / Hardware / Winter Traction Products General Warnings & Information for SCC Products WARNING: The products in this catalog
More informationThe all-inclusive chain sling system for coupling, shortening and lifting in grade 10
GrabiQ components The all-inclusive chain sling system for coupling, shortening and lifting in grade 10 Our GrabiQ sling system is designed to improve and make your lifting as quick and easy as possible.
More informationCare, Use & Inspection Herc-Alloy 1000 Chain...19 Herc-Alloy 1000 Slings Herc-Alloy 1000 Components Master Link...
Care, Use & Inspection....................... 18 erc-alloy 1000 Chain........................19 erc-alloy 1000 Slings.....................20-21 erc-alloy 1000 Components...............22-23 aster Link................................24
More informationGeneral Information/Alloy Chain and Slings
General Information/Alloy Chain and Slings Performance Characteristics of Chain Slings Safeway Gold Standard Alloy Chain Slings utilize grade 80, 100 and 120 lifting chain, manufactured from special analysis
More informationA guide for the selection of alloy steel chain slings DLHONLINE. DLH Online Guides 02/14
A guide for the selection of alloy steel chain slings DLHONLINE Contents Page 3. Overview 4. Chain Systems 5. Stock chain and Components 6. Sling Loadings 7. Certification 8. Identification 9. Chain sling
More informationGRADE 8O ALLOY STEEL CHAIN CARE, USE & INSPECTION OF GRADE 80 CHAIN & SLINGS
GRADE 8O ALLOY STEEL CHAIN CARE, USE & INSPECTION OF GRADE 80 CHAIN & SLINGS CARE 1. WORKING LOAD LIMIT - Select the proper size chain for the job keeping within the working load limits shown. The angle
More informationWe have the right product, at the right price, when you need it, on-time, every time
Standard features & benefits Herc-Alloy 800 Easily the best lift in the Grade 80 class When it comes to lifting, you want to be 100% sure that you re using the best there is. And with PWB Anchor s Herc-Alloy
More informationSafety is our first priority TM
Safety is our first priority T Catalog No. -2013.YP1 2 3 T YOKE Yellow Point Series NEVER EXCEED PUBLISHED WORKING LOAD LIIT 4 Worldwide Quality Type Approval And Certificate: 5 NEVER EXCEED PUBLISHED
More informationYellow Point. Catalog No YP.1
Yellow Point Catalog No. -2014.YP.1 2 3 T YOKE Yellow Point Series NEVER EXCEED PUBLISHED WORKING LOAD LIIT 4 Worldwide Quality Type Approval And Certificate: 5 NEVER EXCEED PUBLISHED WORKING LOAD LIIT
More informationov-lifting_bolts_divider - Updated Lifting Bolts
ov-lifting_bolts_divider - Updated - 09-01-2017 Lifting Bolts Technical Information roduct information Lifting Bolts roduct marking Compliant with 2006/42/EC, and with individual date of manufacture and
More informationYellow Point. Catalog No YP.2
Yellow Point Catalog No. 8-15.YP.2 2 3 T YOKE Yellow Point Series NEVER EXCEED PUBLISHED WORKING LOAD LIIT 4 Worldwide Quality Type Approval And Certificate: 5 NEVER EXCEED PUBLISHED WORKING LOAD LIIT
More informationMaximum Work Load [lbs] of Various Chain Sling Applications
pewag Maximum Work Load [lbs] of Various Sling Applications Factor 4: Grade 20 Alloy Winner Pro Grade 00 Alloy Winner Grade 80 Alloy Grade 50 Stainless Steel.7.7.7.7.4.4.4.4 2. 2. 2. 2..45.45.45.45 NI720
More information6-A SECTION INDEX
Buffalo - Headquarters: 71.82.23 FAX: 71.82.4412 SECTION INDEX SECTION ALUMINUM Chain...-20 BINDER Chain Assemblies...-19 (Grade 70) Chain...-18 CHAIN Adjuster, Tire...-22 Aluminum...-20 Attachments...-17
More informationFrom on-site to on-line
Catalogue Alloy G80 On completion of testing, The Rigging Shed will issue you with a test certificate and add the item to our online database which can be accessed by our customers 24/7. For any enquiries
More informationMaterial Handling - Cranes, Hoists, Slings, Chain Falls, and Ratchet Hoists
Material Handling - Cranes, Hoists, Slings, Chain Falls, and Ratchet Hoists University Facilities Internal Procedure: July 1, 2013 Effective date: July 1, 2013 Last Modified: April 2013 Approved by: Bob
More informationLifting Chain & Components
Lifting Chain & Components 1 IWR LIFTING Herc-Alloy 800 Chain Combining the qualities of high strength, low weight and durability resulting in easy, safe handling, Alloy 800 chain is manufactured to the
More informationTOOL BOX TALK - SAFE USE OF LIFTING EQUIPMENT
TOOL BOX TALK - SAFE USE OF LIFTING EQUIPMENT Golden Rule 6 Mechanical Lifting Do not operate any lifting equipment unless It has been approved for use The lift has been assessed by a competent person
More informationov-lifting_bolts_divider - Updated Lifting Bolts
ov-lifting_bolts_divider - Updated - 09-01-2017 Lifting Bolts Technical Information roduct information Lifting Bolts roduct marking Compliant with 2006/42/EC, and with individual date of manufacture and
More informationWeb Slings WEB SLING HARDWARE WARNING. Web Slings Steel Unilink Web Sling Hardware Combination Triangle and Choker Fitting U. S. Patent No.
Web Slings Web Slings Steel Unilink Web Sling Hardware Combination Triangle and Choker Fitting U. S. Patent No. 4789193 WE SLING HARDWARE This forged, high carbon steel fitting, functions as both a triangle
More informationContent. Super Alloy G 80 Quality tested for your safety. Super Alloy Grade 80 37
Content Super Alloy Grade 80 37 Characteristics of Super Alloy G 80 38 Sling Examples 39 Synoptical Table of Available Products 40-41 Super Alloy 42 Super Alloy G 80 Working s 42 Master Links, Sub-Assemblies
More information1 Clearheart Construction Co., Inc. Mobile Crane - Onshore MOBILE CRANES Cranes and derricks
Mobile Crane - Onshore MOBILE CRANES Cranes and derricks. - 1926.550 Cranes, like all pieces of heavy equipment, if not properly operated, inspected and maintained have a potential for causing major bodily
More informationSafety guidelines. General Safety Guidelines. Working Load Limit (WLL) Proof Test. Minimum Breaking Force
Safety guidelines General Safety Guidelines Peerless Industrial Group, as a manufacturer of chain, can only control the specifications of our chain products in accordance with industry and governmental
More informationAlloy Chain Slings WIRE ROPE LP. HOW TO ORDER THE PROPER CHAIN SLING When ordering, please be sure to include the following:
Chain WIRE ROPE LP Alloy Chain Slings HOW TO ORDER THE PROPER CHAIN SLING When ordering, please be sure to include the following: SIZE means diameter of the material from which the link of the body chain
More informationPolyester Lifting. Technical Information. Roundslings 7:3. Webbing Slings 7:4-7:5. Protective Sleeve, Polyurethane 7:5
Polyester Lifting Roundslings 7:3 Webbing Slings 7:4-7:5 Protective Sleeve, Polyurethane 7:5 Protective Sleeve, Polyester 7:5 Technical Information Recommended Contact Surface for Roundslings 7:6 Safe
More information11 Webbing Sling System 12 Chain Sling Configurations 13 Wire Rope Sling Configurations. 19 Bolt & Nut Anchor Shackle 20 Bolt & Nut Chain Shackle
TM INTRODUCTION 03 MORDEC INTERNATIONAL MORDEC CERTIFICATES 05 Certificate of ABS Consulting 06 Certificate of Compliance, Test & Inspection MORDEC GENERAL INFORMATION & WARNING 7 Definition of Terms Used
More informationOVERHEAD & GANTRY CRANE / RIGGING
Overhead & Gantry Crane / Rigging OVERHEAD & GANTRY CRANE / RIGGING Overhead and gantry cranes - 1910.179 Crawler locomotive and truck cranes. - 1910.180 Slings. 1910.184 Cranes, like all pieces of heavy
More informationYellow Point WARNING NEVER EXCEED PUBLISHED WORKING LOAD LIMIT. Catalog No YP. Copyright 2017 YOKE Industrial Corp. All Rights Reserved.
Yellow Point Catalog No. 8-2017.YP 2 3 Yellow Point 4 Worldwide Quality Type Approval And Certificate: 5 Quality Control, Testing, and Detecting during manufacturing YOKE runs a constant and strict production
More informationRoughneck Mesh Slings
Roughneck Slings Roughneck WIRE MESH SLINGS Specialty Slings with Particular Properties and Uses Widely used in metalworking shops and steel warehouses where loads are abrasive, hot or tend to cut web
More informationCHAIN & HOOKS. Proof Coil Chain Grade 28. Transport Chain Grade 70
Proof Coil Chain Grade 28 Proof coil chain is suitable for use as towing chain, logging,fencing, trailer safety chain, boat anchors, security barriers or other general purposes where chain of high tensile
More informationJEFFERSON JOBOY. 27 November 2018
JEFFERSON JOBOY 27 November 2018 1 LIFTING AWARENESS 2 GROUND RULES 3 What is a lifting operation? An operation concerned with the lifting or lowering of a load'. A 'load' is the item or items being lifted,
More informationHOOKS HOOKS. VANGUARD STEEL LTD.
www.vanguardsteelvancouver.com www.vanguardsteel.com TABLE OF CONTENTS Page Alloy Clevis Grab 1 Alloy Clevis Slip 2 Alloy Clevis Slip with Latch Kit 3 Barrel 4 Carbon Clevis Grab 5 Carbon Clevis Slip 6
More informationAmerica s Largest Importer/Wholesaler of Wire Rope, Chain and Fittings!
America s Largest Importer/Wholesaler of Wire Rope, Chain and Fittings BLOCKS BINDERS Failure to design and use tackle block systems properly may cause a load to slip or fall - the result could be serious
More informationSlinger/signaller Note: It is recommended that you read the Supporting Information page before you read this factsheet.
Slinger/signaller Note: It is recommended that you read the Supporting Information page before you read this factsheet. Preparation and completing work (Preparation) The role of the slinger/signaller is
More informationSafety is our first priority
8-2014 TM Safety is our first priority General Catalog No. 8-2014 General Catalog No. 8-2014/1040312/210X297 Europe-100 General Catalog No. 8-2014 Producer logo Product code Size Working Load Limit size
More informationCPCS renewal test factsheet
CPCS renewal test factsheet Introduction to the CPCS renewal test The industry-led CPCS Management Committee has determined that key safety-related knowledge must be checked on each category prior to the
More information2018 PRODUCT CATALOGUE herculesslr.com
2018 PRODUCT CATALOGUE 1-877-461-4876 herculesslr.com Message From the President Since 1985 Hercules SLR Inc has been supplying quality securing, lifting & rigging products to a broad range of industries
More informationINSTRUCTION MANUAL. Pacific Self-locking Beam Trolleys Pacific Adjustable Angle Clamps Pacific Top Girder Clamps
INSTRUCTION MANUAL Pacific Self-locking Beam Trolleys Pacific Adjustable Angle Clamps Pacific Top Girder Clamps IMPORTANT Please read this instruction manual before using these products. This manual contains
More informationSafelift jib cranes are available with either manual, electric, or pneumatic hoists with push, geared, or powered trolleys.
Specification Safelift Jib Cranes Safelift jib cranes are Safelift products, produced by the Rossendale Group, backed by the Safelift Guarantee. GENERAL PRODUCT DESCRIPTION Safelift jib cranes provide
More informationSWIVELS- HD-LINK, HEAVY DUTY (ANGULAR CONTACT)
SWIVELS- HD-LINK, HEAVY DUTY (ANGULAR CONTACT) Heavy Duty (HD) barrel for maximized swivel life in rough conditions Thick-walled barrel protects bearings and seals from shock and dust Equipped with low
More informationSHOP RIGGING & OVERHEAD HOIST SAFETY PROGRAM
Purpose & Scope CLIMATE ENGINEERS, INC. (CE) is dedicated to the protection of our employees from occupational injuries and illnesses. The purpose of this program is to provide procedures to be followed
More informationTiger Lifting Home of the Tiger hoisting, winching and height safety ranges
Tiger Corrosion Resistant Chain Block Model No. SS12 with clevis adaptor and shackle Spark resistant option Main Features Suitable for use in multi-immersion applications DNV GL Verification tested according
More informationGunnebo Lifting. Широкий выбор компонентов и решений для любых условий
Gunnebo Lifting 8 Gunnebo класс прочности Classic Широкий выбор компонентов и решений для любых условий Gunnebo Lifting ваш партнер в безопасной грузообработке Цепь и компоненты сделаны из rom special
More informationXL by THIELE. Lifting Products Grade 100
Lifting Products Grade 100 s u p e r i o r Product Overview TWN 1805 TWN 0072 Page 28 29 Round Steel Link Chains TWN 1807 TWN 1808 TWN 1809 TWN 1795 TWN 1810/1 TWN 1810/2 TWN 1810/4 Page 30 33 Suspension
More informationBolt-on Swivel Load Rings with Link - RUD VLBG with optional bolt lengths.
1 of 5 11/03/2015 11:15 (/) RUD "VLBG" Bolt-on Swivel Hoisting Rings, Rotating Swivel Eye Bolts. Metric & Imperial Thread - Range from 300kg to 20,000kg Model: RUD VLBG / BSLR-56 Quick Ref: BSLR-56 Bolt-on
More informationOperating Instructions Hoist Chains EN 818-7
Operating Instructions Hoist Chains EN 818-7 THIELE GmbH & Co. KG Werkstraße 3 Phone: +49 (0) 2371 / 947-0 58640 Iserlohn www.thiele.de B08285-B Page 1 EN-170114 Table of Contents 1 Introduction... 2 2
More informationAMY SAYS: Drop Forged Pear Link. Eyes are tapered and an eye buffer is sewn in the eye for better fit and wear. Anatomy of an
AMY SAYS: Drop Forged Pear Link Eyes are tapered and an eye buffer is sewn in the eye for better fit and wear. AMY Anatomy of an V Sling Full two-ply web bodies which allow for only one splice. (no edge
More informationRyko Solutions, Inc. Crane and Jib Safety Program
Ryko Solutions, Inc. Crane and Jib Safety Program CONTENTS PURPOSE...3 POLICY...3 SCOPE...3 RESPONSIBILITIES...3 FITNESS FOR DUTY...4 INSPECTIONS...4 FREQUENT INSPECTION...4 PERIODIC INSPECTIONS...5 RATED
More informationGrade 80 Chain & Lifting Accessories. Reputation, Quality, Trust...
Grade 80 & Lifting Accessories Reputation, Quality, Trust... August 2012 From humble beginnings, but with a clear concept of quality production, the founders of PWB Anchor Limited established the chain
More informationCompany Profile. Our parent Company. KWS A member of the THIELE-Group
Company Profile Our parent Company The company was founded in 935 by August Thiele. Chains were even welded in forge with only 8 employees. Later on automatic bending and welding machines facilitated the
More informationPackage Contents Part A (3) I-Beam (1) Base (2) Other parts
Page 1 Installation Instructions for 81245 Adjustable Height Gantry Crane 1-Ton Capacity Table of Contents Important Safety Information pg. 2 Specific Operation Warnings pg. 2 Main Parts of Product pg.
More informationPRESENTER'S GUIDE "CRANE SAFETY" Part of the "SAFETY MEETING KIT" Series Quality Safety and Health Products, for Today...
PRESENTER'S GUIDE "CRANE SAFETY" Part of the "SAFETY MEETING KIT" Series Quality Safety and Health Products, for Today...and Tomorrow OUTLINE OF MAJOR PROGRAM POINTS OUTLINE OF MAJOR PROGRAM POINTS The
More informationGreat Western Painting Crane Operator - Offshore CRANE OPERATOR - OFFSHORE
Crane Operator - Offshore CRANE OPERATOR - OFFSHORE Cranes, like all pieces of heavy equipment, if not properly operated, inspected and maintained have a potential for causing major bodily injury or property
More informationTiger Lifting Home of the Tiger hoisting range & Tiger subsea lifting products
Tiger Lever Hoist Model No PROLH (with overload protection) Main Features Now available with slipping clutch overload protection Range 750kg - 10.0t Equipped with our unique dual brake mechanism New twin
More informationGK8. G r a d e 8 0 by THIELE. The Name for Safety.
G r a d e 8 0 The Name Company Profile Our parent Company THIELE is an innovative manufacturer with a long tradition in the production of round steel chains and forged parts for the Conveying and Lifting
More information1000 PRODUCT OVERVIEW
RI IN & TT E ENT NTS olumbus cinnon has a long history of developing innovative products that have changed the material handling industry including the development of the first alloy chain in 1933. This
More information2016 MASTER CATALOGUE
2016 2016 MASTER CATALOGUE ALLOY LIFTING 2 www.vanguardsteelvancouver.com www.vanguardsteel.com ALLOY LIFTING TABLE OF CONTENTS Page Chain 1 Clevis Grab Hook 2 Clevis Slip Hook 3 Connecting Links 4 Master
More informationCompany Profile. Our parent Company. KWS A member of the THIELE-Group
G r a d e 8 0 Company Profile Our parent Company The company was founded in 935 by August Thiele. Chains were even welded in forge with only 8 employees. Later on automatic bending and welding machines
More informationCrane, Hoist, and Sling Safety Program October 24, 2017
1. INTRODUCTION Crane, Hoist, and Sling Safety Program October 24, 2017 1.1. Purpose Indiana University has developed the Crane, Hoist, and Sling Safety Program to protect employees against the hazards
More informationCumberland SaleS. Company. Serving the industry for over 30 years! Cumberland Sales Co. 30th Anniversary
Cumberland SaleS Company Serving the industry for over 30 years! Cumberland Sales Co. 30th Anniversary Durable. Since 1979, Cumberland Sales Company has offered dependable service and durable products
More informationSafelift Overhead Runway Beams & Rolling Beam Cranes
Operation & Maintenance Instructions Instructions for Safe Use Safelift Overhead Runway Beams & Rolling Beam Cranes Certification Safelift overhead runway beams and rolling beam cranes are lifting appliances
More informationPipeline Slings Catalog
Bishop Lifting Pipeline Slings Catalog Lowering-in Belts Head Irons Lined Steel Choker Belts Roundslings Rigging Accessories M E M B E R Code of Ethics Bishop Lifting has adopted the Code of Ethics of
More informationServices. Rental Equipment RENTAL DIVISION PRODUCT LINES. LOAD RESTRAINTS Load Binders (Lever & Ratchet) Truck Tie-down Assemblies Boomer Chains
RENTAL DIVISION PRODUCT LINES In a continuing effort to give the customer the opportunity to get an assortment of equipment, services and products from one supplier, our rental division was established
More information"CRANE SAFETY IN CONSTRUCTION ENVIRONMENTS"
PRESENTER'S GUIDE "CRANE SAFETY IN CONSTRUCTION ENVIRONMENTS" Part of the "CONSTRUCTION SAFETY KIT" Series Quality Safety and Health Products, for Today...and Tomorrow OUTLINE OF MAJOR PROGRAM POINTS OUTLINE
More informationPLATE CLAMPS INSTRUCTION MANUAL
PLATE CLAMPS INSTRUCTION MANUAL Imported exclusively by Pacific Hoists Pty. Ltd. & Pacific Hoists Ltd. In support of cancer charities in Australia & New Zealand Universal Plate Clamp 1 Horizontal Plate
More informationTRANSPORT & 4WD EQUIPMENT
6 TRANSPORT & 4WD EQUIPMENT TIRFOR WIRE ROPE WINCHES...133 LOAD CHOKER LOAD RESTRAINTS...134 SYNTHETIC TOW SLINGS...134 TRANSPORT CHAIN & FITTINGS...135 LOAD RESTRAINT KITS...135 RATCHET LOAD BINDERS...135
More informationCHAIN SPECIFICATIONS
CHAIN SPECIFICATIONS Peerless, the Largest U.S. Chain Manufacturer Peerless Chain, established as a manufacturer of tire chains in 1917 eventually expanded into hardware and industrial chain manufacturing,
More information34 Sterling Place Mills River, NC (828)
34 Sterling lace Mills iver, N 259 (2) 654-000 rigging@bellsouth.net elow are chain sling components that we sell as part of an assembled chain sling. For pricing on individual parts or specialty assemblies,
More informationAPEX CHAIN AND CABLE INC.
APEX CHAIN AND CABLE INC. PRODUCT LINE CARD ***PLEASE INQUIRE ABOUT OUR COMPLIMENTARY INSPECTIONS*** ACCO-ANVER ACTEK MFG. BUDGIT CAMPBELL CAN-AM CASTERS / COLSON CARR-LANE COLUMBUS McKINNON CROSBY GLEASON
More informationLonger lifting chain available on request
CHAIN HOIST Air Chain Hoist 248 Single Chain Fall with Pendant Control Single Chain Fall with Cord Control Double Chain Fall with Pendant Control Single Chain Fall with Cord Control Model No. Model Control
More informationTiger Lifting Home of the Tiger hoisting, winching and height safety ranges
Tiger Professional Lever Hoist Model No. PROLH with optional travelling end stop with spark resistant components with overload protection Main Features DNV GL Verification tested according to NORSOK R-002
More informationCargo Control. Tie Down Straps & Transport Chain
Cargo Control Tie Down Straps & Transport Chain CARGO CONTROL WARNINGS & INFORMATION Quality assurance and general information: We at Super Slings Inc. offer a full line of ratchet straps, tie downs, e-track
More informationOSHA PART 1: PREPARING FOR THE SESSION. 1. Training Booklet. 2. Why This Session Is Important. 3. Purpose and Objectives of the Session
Crane, Derrick, and ling afety 5145A OHA A R N I G N I PAR 1: PRPARING FOR H ION 1. raining Booklet here is no training booklet that goes along with this ession. rainers should review other written material
More informationVanguard Steel Ltd. Grade 100 Lifting
Vanguard Steel Ltd Grade 100 Lifting GRADE 100 ALLOY TABLE OF CONTENTS Page Chain 1 Clevis Grab Hook 3 Clevis Slip Hook 4 Connecting Links 2 Master Link 5 Master Link Sub-Assembly 6 SC Clevis Hook 7 SL
More informationNRCT NATIONAL RIGGING & CRANE TRAINING LLC. Contact : CONSTRUCTION-INDUSTRIAL-SAFETY SERVICES
NRCT NATIONAL RIGGING & CRANE TRAINING LLC CONSTRUCTION-INDUSTRIAL-SAFETY SERVICES Contact : 716-818-4720 Peter.Cooke@nrctpro.com www.nrctpro.com About US Why Choose NRCT? NRCT is owned and operated by
More informationLifting Beams & Custom Engineered Lifting Devices
Lifting Beams & Engineered Lifting BASIC INFORMATION Lift-All can provide a unique engineered device for your production requirements. Our custom devices range from large capacity beams to control and
More informationRigging - Offshore OFFSHORE CRANES API RP 2D Operation and Maintenance of Offshore Cranes
Clearheart Construction Co., Inc. Rigging - Offshore OFFSHORE CRANES API RP 2D Operation and Maintenance of Offshore Cranes Cranes, like all pieces of heavy equipment, if not properly operated, inspected
More informationLifting Points Rotating Ball-bearing De-centered Weldable Screw-on
ifting Points Rotating Ball-bearing De-centered Weldable Screw-on ifting Points ifting Points Information 3:2 Rotating Eye ifting Point - REP 3:4 Rotating ifting Point - RP 3:5 Decentered ifting Point
More informationWARNINGS... 4 SHACKLES CHAIN COMPARISON HERC-ALLOY OVERHEAD LIFTING HEAVY DUTY TIEDOWNS... 52
hain & ttachments Table of ontents WRNINGS.......................................... 4 SHKES....................................... 5-15 HIN OMPRISON................................ 16 HER-OY 1000................................
More informationOperating Instructions Hoist Chains EN 818-7
Operating Instructions Hoist Chains EN 818-7 THIELE GmbH & Co. KG Werkstraße 3 Phone: +49 (0) 2371 / 947-0 58640 Iserlohn www.thiele.de B08285-A Page 1 EN-051110 Table of Contents 1 Introduction... 2 2
More informationTHE PLATINUM LINE SETTING THE STANDARD FOR PREMIUM CHAIN FITTINGS. Featuring: CROSBY SPECTRUM 10 GRADE 100 CHAIN FITTINGS
THE PLATINUM LINE SETTING THE STANAR FOR PREMIUM CHAIN FITTINGS Featuring: CROSBY SPECTRUM 10 GRAE 100 CHAIN FITTINGS Scan this QR Code with your smart device to view this brochure electronically. Crosby
More informationThe All-Inclusive Chain Sling System for Coupling and Shortening. GrabiQ. by Gunnebo Lifting
2013 The All-Inclusive Chain Sling System for Coupling and Shortening GrabiQ by Gunnebo ifting The Flexible and Cost fficient Chain Sling System. GrabiQ stands for: Grab - Built in shortening function
More informationOwner s Manual for Bethlehem Equipment Company Burial Vault Handler
Owner s Manual for Bethlehem Equipment Company Burial Vault Handler Safe and proper operation of a Burial Vault Handler is similar to learning to drive a car for the first time. All the manuals, videos,
More informationThe All-Inclusive Chain Sling System for Coupling and Shortening. GrabiQ. by Gunnebo Lifting
The All-Inclusive Chain Sling System for Coupling and Shortening GrabiQ by Gunnebo ifting The Flexible and Cost fficient Chain Sling System. GrabiQ stands for: Grab - Built in shortening function allows
More informationPolyester Lifting Slings
Est. 969 Polyester Lifting Slings FASTLIFT Endless Roundsling (ERS) Roundslings with seamless single cover and protected label WLL Colour Weight Rec. min Rec. min Standard size range available (tonnes)
More information2nd EDITION STEVPRIS FLIPPER DELTA DANFORTH AC-14 SWIVEL SHACKLE DETACHABLE PEARLINK HINGE LINK LINK
STEVPRIS FLIPPER DELTA DANFORTH AC-14 SWIVEL SHACKLE DETACHABLE PEARLINK HINGE LINK LINK SHACKLE GOLDNOSE CLOSED/OPEN SOCKET GRAPNEL J CHASER 2nd EDITION JS OFFSHORE SUPPLY PTE LTD 7500A Beach Road #13-304
More informationClick. Campbell Fittings Table of Contents. on the section you want
Campbell Fittings Table of Contents Click on the section you want Contents Clips, Forged Wire Rope Eyebolts Eyes, Lifting Hooks, Grab/Slip Hooks, Hoist Hooks, Latch Kits For Links Links, Clevis Links,
More informationQuick-find Index. Lifting & Rigging
Burncrete s core business is the supply of lifting, rigging, pulling and lashing equipment to the mining, industrial, construction, transport, railways and harbours sectors, via re sellers, agents and
More informationINSULATING LINKS, ISO/LINK AC & DC
INSULATING LINKS, ISO/LINK AC & DC INDUSTRIAL UTILITY & CONSTRUCTION 800.733.7071-1.508.248.3941 - Fax 1.508.248.0639 74 INSULATING LINKS, ISO/LINK AC & DC Proven Performance in Hi-Voltage & Hi-Current
More informationPOLYESTER GRIZZLY-EDGE
Safeway Engineered Specialty Web Sling Products Safeway Engineered Specialty Web Sling Products POLYESTER GRIZZLY-EDGE New Hi-Performance Sling Product Offers Superior Cut and Abrasion Resistance at Lower
More informationINSTRUCTIONS FOR USE CAUTIONS AND WARNINGS
SECTION 3 General INSTRUCTIONS FOR USE CAUTIONS AND WARNINGS Commercial shackles are not to be used for lifting purposes. Should extreme circumstances or shock loadings be applicable, this must be taken
More informationHOIST ARMY TYPE HOIST IMPORTANT
AA-93 15 SECTION AT/A/15 Service Instructions and Maintenance Manual 18:i!ii il HOIST ARMY TYPE HOIST IMPORTANT Keep for Future Reference SERVICE INSTRUCTIONS AND MAINTENANCE MANUAL 1 METRIC TON CAUTION:
More information