APEX CHAIN AND CABLE INC.
|
|
- Ada Owen
- 6 years ago
- Views:
Transcription
1
2 APEX CHAIN AND CABLE INC. PRODUCT LINE CARD ***PLEASE INQUIRE ABOUT OUR COMPLIMENTARY INSPECTIONS*** ACCO-ANVER ACTEK MFG. BUDGIT CAMPBELL CAN-AM CASTERS / COLSON CARR-LANE COLUMBUS McKINNON CROSBY GLEASON REEL APEX RIGGING APEX SYNTHETIC SLINGS INTER-PRODUCT / RENFROE / MERRILL IGUS SERVICES: CERTIFICATION / PROOFTESTING CERTIFIED CUSTOM DEVICES LIFT ALL McKISSICK TECNOMAGNETE TRACTEL STAINLESS STEEL YOKE THERN VACU-LIFTS, LOUDEN IMPERIAL & METRIC HOIST RINGS CHAIN & WIRE ROPE HOISTS CHAIN, SLINGS, COMPONENTS FULL LINE OF CUSTOM QUALITY CASTERS JIG & FIXTURE TOOLING COMPONENTS CHAIN PULLERS, HOISTS & ALLOY COMPONENTS SHACKLES, WIRE ROPE FITTINGS, HOIST RINGS, HOSE & CABLE REELS COMPONENT CHAIN SLINGS, CRANE CABLES, CUSTOM WIRE ROPE SLINGS, AND GENERAL PURPOSE WIRE ROPE NYLON, POLYESTER, BALLISTIC, AND ROUND SLINGS LIFTING CLAMPS POWER TRACK & IGLIDE CERTIFICATION AND PROOFTESTING OF DEVICES SPECIALIZED LIFTING COMPONENTS MESH SLINGS, LOAD HUGGERS SHEAVES & BLOCKS PERMANENT LIFTING MAGNETS AND WORK HOLDING FALL ARREST, LOAD MEASURE EQUIPMENT FITTINGS, WIRE ROPE, CUSTOM ASSEMBLIES & CUSTOM LIFTING DEVICES ALLOY CHAIN COMPONENTS WINCH SPECIALISTS ***DELIVERED TO YOU BY OUR TRAINED PROFESSIONALS*** ***COMPLETE CATALOGS AVAILABLE UPON REQUEST***
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19 Date 6/3/2014 INSPECTED BY: CHAIN INSPECTION REPORT APEX CHAIN & CABLE Inc. The following items were inspected in accordance with the annual inspection requirement of Regulation 851 of the Ontario Occupational Health and Safety Act. (OHSA) The inspection was done in accordance with the recommendations of ASME Standards B30.20 Below-the-Hook Lifting Devices, B30.26 Rigging Hardware, B30.9 Slings, B30.10 Hooks and B30.16 Hoists. DAMAGE PHN: FAX: ACCEPT REPAIR SCRAP Mast Link Couplings Legs Hooks ID TAG Date Tag Other Location Serial Number W.L.L. Lbs. Type Size Reach RECOMMENDATIONS Date Returned Repair PO# REPAIR STATUS 17
20
21
22
23
24
25
26
27 Lifting Rings DNV Master Links Cer ed to DNV 2.7-1, type approval no. S-7732 For o shore container li ing and cold weather use with Charpy V-notch impact Value s of > 42 Joule At -20 C. All DNV links are specially heat treated a er proof tes ng to minimize the risk of hydrogen embri lement and stress corrosion cracking. Every link is batch coded for cer cate recogni on. Master Links Dimensions mm Type Old Part Number Being replaced Dia. Inside Length Inside Width WLL tonne 5:1 Mass kg/unit Part Number OML220DNV N/A MA22ML OML255DNV N/A MA25ML OML280DNV N/A MA28ML OML320DNV N/A MA32ML OML360DNV N/A MA36ML OML400DNV N/A MA40ML OML450DNV /4 ML MA45ML OML500DNV 28-2 ML MA50ML OML600DNV /4 ML MA60ML OML700DNV /4 ML MA70ML 25
28 Lifting Rings DNV Quad Assemblies Cer ed to DNV 2.7-1, type approval no. S-7732 For o shore container li ing and cold weather use with Charpy V-notch impact Value s of > 42 Joule At -20 C. All DNV links are specially heat treated a er proof tes ng to minimize the risk of hydrogen embri lement and stress corrosion cracking. Every link is batch coded for cer cate recogni on. Master Link - Quad Assemblies Type Old Part Number Being Replaced Dimensions mm D IL IW d il iw WLL tonne 5:1 Mass kg/unit Part Number OSA160DNV MLA MA16QA OSA220DNV 28-5/16MLA MA23QA OSA220SDNV 28-3/8MLA MA22QAS OSA255DNV N/A MA25QA OSA280DNV N/A MA26QA OSA280SDNV 28-1/2MLA MA28QAS OSA320DNV N/A MA32QA OSA360DNV 28-5/8MLA MA36QA OSA400DNV N/A MA40QA OSA450DNV 28-3/4MLA MA45QA OSA500DNV 28-7/8MLA MA50QA OSA600DNV 28-1MLA MA60QA OSA700DNV /4MLA MA70QA Number Size mm ML/SL WLL 45º in tonne WLL 5:1 lbs WLL 5:1 lbs WLL 5:1 lbs WLL 4:1 lbs WLL 4:1 lbs WLL 4: horiz. 2-MA16QA 16/ ,070 9,040 6,390 13,830 11,300 7,990 2-MA23QA 22/ ,660 12,780 9,040 19,570 15,980 11,300 2-MA22QAS 22/ ,840 19,460 13,760 29,800 24,330 17,200 2-MA25QA 25/ ,840 19,460 13,760 29,800 24,330 17,200 2-MA26QA 28/ ,860 26,000 18,390 39,820 32,510 22,990 2-MA28QAS 28/ ,150 31,960 22,600 48,930 39,950 28,250 2-MA32QA 32/ ,170 37,700 26,650 57,710 47,120 33,320 2-MA36QA 36/ ,100 50,700 35,850 77,620 63,380 44,810 2-MA40QA 40/ ,870 61,950 43,800 94,840 77,430 54,750 2-MA45QA 45/ ,400 84,430 59, , ,540 74,630 2-MA50QA 50/ ,500 99,200 70, , ,000 87,680 2-MA60QA 60/ , , , , , ,660 2-MA70QA 70/ , , , , , ,630 26
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59 GALVANIZED WIRE ROPE SLINGS Galvanized Wire Rope Slings (5:1 by design API spec. 9a table 3.7) Diameter of Wire Rope vs. standard length for Pricing Length 1/4" 3/8" 1/2" 5/8" 3/4" 7/8" 1" 1-1/8" 1-1/4" 1-1/2" 1-3/ /4 2-1/2 2 ft ft ft ft ft ft P.O.R ft P.O.R ft P.O.R P.O.R ft P.O.R P.O.R P.O.R - 11 ft P.O.R P.O.R P.O.R P.O.R 12 ft P.O.R P.O.R P.O.R P.O.R 15 ft P.O.R P.O.R P.O.R P.O.R 20 ft P.O.R P.O.R P.O.R P.O.R Std. eye 2"x 4" 3"x 6" 4"x 8" 5"x10" 6"x12" 7"x14" 8"x16" 9"x18" 10"x20" 12"x24" 14 x28 16 x32 18 x36 20 x40 WLL (ton) Weight / foot ** All wire rope slings made with EIPS, IWRC Galvanized Wire rope with steel ferrule and Flemish roll splice complete with tag showing size, length, WLL and manufacture. 5 57
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88 Synthetic Rope Oletec-12 meets or exceeds dielectric requirements per ASTM F NovaBlue meets or exceeds (upon request) US MIL Spec # MIL-R Cdn MIL Spec # 40-GP-16M NovaBlue meets or exceeds (upon request) US MIL Spec # MIL-R-24050D Cdn MIL Spec # 40-GP-16M DYNEEMA 12 Dyneema-12 is a hollow braided 12-strand rope made from Dyneema ber. It has a high weight to strength ra o with very li le stretch. Custom slings are available ready made from manufacturer. 86
89
90
Products Services Training
Products Services Training Carl Stahl American Lifting, LLC 800-236-0729 262-786-2710 Fax 262-786-8510 www.americanlifting.com CARL STAHL AMERICAN LIFTING, LLC Material Handling Solutions Made Easy Since
More informationWeb Slings WEB SLING HARDWARE WARNING. Web Slings Steel Unilink Web Sling Hardware Combination Triangle and Choker Fitting U. S. Patent No.
Web Slings Web Slings Steel Unilink Web Sling Hardware Combination Triangle and Choker Fitting U. S. Patent No. 4789193 WE SLING HARDWARE This forged, high carbon steel fitting, functions as both a triangle
More informationSafety is our first priority TM
Safety is our first priority T Catalog No. -2013.YP1 2 3 T YOKE Yellow Point Series NEVER EXCEED PUBLISHED WORKING LOAD LIIT 4 Worldwide Quality Type Approval And Certificate: 5 NEVER EXCEED PUBLISHED
More informationWire rope accessories. 5. Wire rope accessories. Index
Wire rope accessories 5. Wire rope accessories 1 General 1.1 About Hendrik Veder Group 1.2 Trade names 1.3 Certified Quality 1.4 Certificates 1.5 Key suppliers & brands 1.6 Contact information 1.7 Locations
More informationWEIGHT CONTENTS SIZE DESCRIPTION WORKING LOAD LIMIT
rade Chain LENTH S0606 3/8 6 8,800 lbs. 12.5 lbs. S0608 3/8 8 8,800 lbs. 15.5 lbs. S0610 3/8 10 8,800 lbs. 18.5 lbs. S0616 3/8 16 8,800 lbs. 27.3 lbs. S0620 3/8 20 8,800 lbs. 33.3 lbs. S0806 1/2 6 15,000
More informationMINING PRODUCTS FOR HOISTS & RIGGING. Manual Hoists. Chain & Rigging Attachments. Specialized Attachments. Liner Bolts. for THE MINING INDUSTRY
A Complete Line of Products & Solutions for THE MINING INDUSTRY HOISTS & RIGGING PRODUCTS FOR MINING Manual Hoists Chain & Rigging Attachments Specialized Attachments Liner Bolts Columbus McKinnon Family
More informationYellow Point. Catalog No YP.1
Yellow Point Catalog No. -2014.YP.1 2 3 T YOKE Yellow Point Series NEVER EXCEED PUBLISHED WORKING LOAD LIIT 4 Worldwide Quality Type Approval And Certificate: 5 NEVER EXCEED PUBLISHED WORKING LOAD LIIT
More information2018 PRODUCT CATALOGUE herculesslr.com
2018 PRODUCT CATALOGUE 1-877-461-4876 herculesslr.com Message From the President Since 1985 Hercules SLR Inc has been supplying quality securing, lifting & rigging products to a broad range of industries
More informationYellow Point. Catalog No YP.2
Yellow Point Catalog No. 8-15.YP.2 2 3 T YOKE Yellow Point Series NEVER EXCEED PUBLISHED WORKING LOAD LIIT 4 Worldwide Quality Type Approval And Certificate: 5 NEVER EXCEED PUBLISHED WORKING LOAD LIIT
More informationClick. Campbell Fittings Table of Contents. on the section you want
Campbell Fittings Table of Contents Click on the section you want Contents Clips, Forged Wire Rope Eyebolts Eyes, Lifting Hooks, Grab/Slip Hooks, Hoist Hooks, Latch Kits For Links Links, Clevis Links,
More informationfor CONSTRUCTION PROJECTS HOISTS & RIGGING PRODUCTS FOR CONSTRUCTION Power Plants Commercial Construction Wind Energy Bridges & Highways
A Complete Line of Products & Solutions for CONSTRUCTION PROJECTS HOISTS & RIGGING CONSTRUCTION Power Plants Commercial Construction Wind Energy Bridges & Highways TOUGH. RELIABLE. STRONG. Keeping Projects
More information1 Clearheart Construction Co., Inc. Mobile Crane - Onshore MOBILE CRANES Cranes and derricks
Mobile Crane - Onshore MOBILE CRANES Cranes and derricks. - 1926.550 Cranes, like all pieces of heavy equipment, if not properly operated, inspected and maintained have a potential for causing major bodily
More informationHoists & Rigging Products for Construction Projects
Manual Hoists Have a special application? Our full line of material handling products allows us to create complete solutions rather than just offering single products. Now you have one point of contact
More informationWhen buying Crosby you re buying more than product, you re buying Quality.
From a 2 ton capacity snatch to a 6000 metric ton capacity crane, McKissick can make a McKissick s major involvement in the block McKissick When buying Crosby you re buying more than product, you re buying
More informationSHANK HOOKS SPECIALTY HOOKS & RIGGING PRODUCTS
SHANK HOOKS SPECIALTY HOOKS & RIGGING PRODUCTS CO O LL U UM MB BU U SS C M cc KK II NN NN OO NN CC OO RR PP OO RR AA TT II OO NN M Columbus McKinnon has provided quality material handling products and
More informationGrade 80 Chain Sling Components. Grade 100 Chain Sling Components
NGER: Overhead lifting presents a very real danger of severe injury or loss of life if lifting equipment is not used properly.lease read and understand all of these instructions prior to using any lifting
More informationCumberland SaleS. Company. Serving the industry for over 30 years! Cumberland Sales Co. 30th Anniversary
Cumberland SaleS Company Serving the industry for over 30 years! Cumberland Sales Co. 30th Anniversary Durable. Since 1979, Cumberland Sales Company has offered dependable service and durable products
More informationRigging - Offshore OFFSHORE CRANES API RP 2D Operation and Maintenance of Offshore Cranes
Clearheart Construction Co., Inc. Rigging - Offshore OFFSHORE CRANES API RP 2D Operation and Maintenance of Offshore Cranes Cranes, like all pieces of heavy equipment, if not properly operated, inspected
More informationJEFFERSON JOBOY. 27 November 2018
JEFFERSON JOBOY 27 November 2018 1 LIFTING AWARENESS 2 GROUND RULES 3 What is a lifting operation? An operation concerned with the lifting or lowering of a load'. A 'load' is the item or items being lifted,
More informationSLINGS NYLON SLINGS NYLON SLINGS TWIN PATH SLINGS WIRE ROPE SLINGS CHAIN SLINGS. Your Sling and Rigging Specialists!
A N D Hanes Supply of South Carolina, Inc. DBA Coastal Construction Industrial Supply Co. SLINGS Your and Rigging Specialists! NYLON SLINGS NYLON SLINGS TWIN PATH SLINGS WIRE ROPE SLINGS CHAIN SLINGS HEADQUARTERS/BUFFALO:
More informationGreat Western Painting Crane Operator - Offshore CRANE OPERATOR - OFFSHORE
Crane Operator - Offshore CRANE OPERATOR - OFFSHORE Cranes, like all pieces of heavy equipment, if not properly operated, inspected and maintained have a potential for causing major bodily injury or property
More informationUTILITY PRODUCT GUIDE
UTILITY PRODUCT GUIDE The best way to make sure you re using genuine Samson Utility Ropes is to Ask for it. Winch Lines Lifting or shifting dead weight loads calls for lines that have the strength to perform,
More informationCHAIN & HOOKS. Proof Coil Chain Grade 28. Transport Chain Grade 70
Proof Coil Chain Grade 28 Proof coil chain is suitable for use as towing chain, logging,fencing, trailer safety chain, boat anchors, security barriers or other general purposes where chain of high tensile
More informationOVERHEAD & GANTRY CRANE / RIGGING
Overhead & Gantry Crane / Rigging OVERHEAD & GANTRY CRANE / RIGGING Overhead and gantry cranes - 1910.179 Crawler locomotive and truck cranes. - 1910.180 Slings. 1910.184 Cranes, like all pieces of heavy
More informationPolyester Lifting Slings
Est. 969 Polyester Lifting Slings FASTLIFT Endless Roundsling (ERS) Roundslings with seamless single cover and protected label WLL Colour Weight Rec. min Rec. min Standard size range available (tonnes)
More informationINSTRUCTIONS FOR USE CAUTIONS AND WARNINGS
SECTION 3 General INSTRUCTIONS FOR USE CAUTIONS AND WARNINGS Commercial shackles are not to be used for lifting purposes. Should extreme circumstances or shock loadings be applicable, this must be taken
More informationGlobal technology leader in the manufacture of wire and fibre rope solutions for the world s most demanding applications
Oil and Gas Global technology leader in the manufacture of wire and fibre rope solutions for the world s most demanding applications Bridon Neptune Quay, a state-of-the-art manufacturing facility that
More information6-A SECTION INDEX
Buffalo - Headquarters: 71.82.23 FAX: 71.82.4412 SECTION INDEX SECTION ALUMINUM Chain...-20 BINDER Chain Assemblies...-19 (Grade 70) Chain...-18 CHAIN Adjuster, Tire...-22 Aluminum...-20 Attachments...-17
More informationNRCT NATIONAL RIGGING & CRANE TRAINING LLC. Contact : CONSTRUCTION-INDUSTRIAL-SAFETY SERVICES
NRCT NATIONAL RIGGING & CRANE TRAINING LLC CONSTRUCTION-INDUSTRIAL-SAFETY SERVICES Contact : 716-818-4720 Peter.Cooke@nrctpro.com www.nrctpro.com About US Why Choose NRCT? NRCT is owned and operated by
More informationNOVABLUE TM ,175 1, ,589 2,225 2,815 4,720 4,901 7,037 8,172 10,896 14,528 17,933
NOVABLUE TM NOVABLUE is our premium double braided polyester rope designed for general marine, industrial, and commercial use where low elongation, high strength, and abrasion resistance are required.
More informationHi- Tech Lifting Equipment
+91-8071803675 Hi- Tech Lifting Equipment https://www.indiamart.com/hitechliftingequipment/ We HI- TECH LIFTING EQUIPMENT are organization involved in Wholesaling, Trading & Importer an impeccable gamut
More informationLonger lifting chain available on request
CHAIN HOIST Air Chain Hoist 248 Single Chain Fall with Pendant Control Single Chain Fall with Cord Control Double Chain Fall with Pendant Control Single Chain Fall with Cord Control Model No. Model Control
More informationTiger Lifting Home of the Tiger hoisting range & Tiger subsea lifting products
Tiger SS11 Subsea Lever Hoist with overload protection with overload protection with clevis adaptor and shackle Main Features DNV GL Verification tested according to NORSOK R-002 Available with slipping
More informationELECTRONIC OVERHEAD TRAVELLING CRANE DIMENSIONS & LOAD DATA
ELECTRONIC OVERHEAD TRAVELLING CRANE DIMENSIONS & LOAD DATA FOR ESTIMATING PURPOSES ONLY CONTENTS TOP RUNNING SINGLE GIRDER CRANES 2, 3 & 5 Ton 7.5 & 10 Ton PAGE 2-5 TOP RUNNING DOUBLE GIRDER CRANES 5,
More informationTiger Lifting Home of the Tiger hoisting, winching and height safety ranges
Tiger Subsea Lever Hoist Model No. SS11 Unique torsion brake with clevis adaptor and shackle Main Features Suitable for use in multi-immersion applications DNV GL Verification tested according to NORSOK
More informationServices. Rental Equipment RENTAL DIVISION PRODUCT LINES. LOAD RESTRAINTS Load Binders (Lever & Ratchet) Truck Tie-down Assemblies Boomer Chains
RENTAL DIVISION PRODUCT LINES In a continuing effort to give the customer the opportunity to get an assortment of equipment, services and products from one supplier, our rental division was established
More informationTiger Lifting Home of the Tiger hoisting, winching and height safety ranges
Tiger Professional Lever Hoist Model No. PROLH with optional travelling end stop with spark resistant components with overload protection Main Features DNV GL Verification tested according to NORSOK R-002
More informationToll-free:
Toll-free: 1.800.362.4601 CRANES CRANE SERVICE WIRE ROPE ENGINEERED PRODUCTS HARDWARE SLINGS TRAINING CAPABILITIES BROCHURE >> www.progressivecrane.com Cranes: Progressive Crane is a leading manufacturer
More information2016 MASTER CATALOGUE
2016 2016 MASTER CATALOGUE ALLOY LIFTING 2 www.vanguardsteelvancouver.com www.vanguardsteel.com ALLOY LIFTING TABLE OF CONTENTS Page Chain 1 Clevis Grab Hook 2 Clevis Slip Hook 3 Connecting Links 4 Master
More informationMaximum Work Load [lbs] of Various Chain Sling Applications
pewag Maximum Work Load [lbs] of Various Sling Applications Factor 4: Grade 20 Alloy Winner Pro Grade 00 Alloy Winner Grade 80 Alloy Grade 50 Stainless Steel.7.7.7.7.4.4.4.4 2. 2. 2. 2..45.45.45.45 NI720
More informationTie Downs and Heavy Haul Equipment
Tie Downs and Heavy Haul Equipment Binder Chains Load Binders Web Straps Winches & Winch Bars Roll-Off s Winch Lines Crane & Wrecker Outrigger Pads Snatch Blocks SkyBlock ASSOCIA TED BUILDERS AND CONTRA
More informationRoughneck Mesh Slings
Roughneck Slings Roughneck WIRE MESH SLINGS Specialty Slings with Particular Properties and Uses Widely used in metalworking shops and steel warehouses where loads are abrasive, hot or tend to cut web
More informationTiger Lifting Home of the Tiger hoisting, winching and height safety ranges
Tiger Corrosion Resistant Chain Block Model No. SS12 with clevis adaptor and shackle Spark resistant option Main Features Suitable for use in multi-immersion applications DNV GL Verification tested according
More informationTRANSPORT & 4WD EQUIPMENT
6 TRANSPORT & 4WD EQUIPMENT TIRFOR WIRE ROPE WINCHES...133 LOAD CHOKER LOAD RESTRAINTS...134 SYNTHETIC TOW SLINGS...134 TRANSPORT CHAIN & FITTINGS...135 LOAD RESTRAINT KITS...135 RATCHET LOAD BINDERS...135
More informationChain Products, Ropes, Accessories, Clamps and Fittings
Chain Products, Ropes, Accessories, Clamps and Fittings Campbell Table of Contents Contents Page No. Chains 9 2 Ropes 4 Tie Downs & Slings 5 Accessories 6 20 Hooks 2 22 Latch Kits for Hooks 2 Swivels 24
More informationFrom on-site to on-line
Catalogue Alloy G80 On completion of testing, The Rigging Shed will issue you with a test certificate and add the item to our online database which can be accessed by our customers 24/7. For any enquiries
More informationINSPECTIONS TESTING TRAINING & REPAIRS
11 INSPECTIONS - TESTING - TRAINING - REPAIRS LIFTING EQUIPMENT INSPECTIONS... 222-223 ANCHOR POINT INSTALLATIONS...223 REPAIRS & SERVICE...224 HEIGHT SAFETY TRAINING...224 CRANE INSTALLATIONS...225 CRANE
More informationMaterial Handling Inventory Sheet
Material Handling Inventory Sheet Hand Chain Hoists/Lever Hoists 1/2 Ton Hoist - 10' of lift 1 Ton - m/n CF4260-21' of lift 5 Ton - m/n CF4699-7' of lift Little Mule 2 Ton hoist OZ Hoist OZ075CHOP - 1/2
More informationProduct Catalogue Specialists in the Lifting Equipment and Non Destructive Testing Industry for Over 30 Years
Product Catalogue 2017 Specialists in the Lifting Equipment and Non Destructive Testing Industry for Over 30 Years Interactive Text Page Company Introduction Page 4 Green Pin Grade 6 G-4163 Safety Bow
More informationA guide for the selection of alloy steel chain slings DLHONLINE. DLH Online Guides 02/14
A guide for the selection of alloy steel chain slings DLHONLINE Contents Page 3. Overview 4. Chain Systems 5. Stock chain and Components 6. Sling Loadings 7. Certification 8. Identification 9. Chain sling
More informationCOLUMBUS McKINNON CORPORATION
COLUMBUS McKINNON CORPORATION TM TM TM TM RATCHET LEVER HOIST The CM Bandit is one of the most compact and durable ratchet lever hoists in the industry. Its lightweight and portable design, easy free-chaining
More informationIC-20-J. Tech Spec. Industrial Crane. Features the exclusive rotating boom
Tech Spec IC-20-J Industrial Crane Features the exclusive rotating boom Capacity on Outriggers... 5,000 lbs (2,270 kg) Pick and Carry Capacity... up to 2,500 lbs (1,130 kg) Height... 5 6 (1.66 m) w/o Operator
More information2016 MASTER CATALOGUE
2016 2016 MASTER CATALOGUE 2 www.vanguardsteelvancouver.com www.vanguardsteel.com TABLE OF CONTENTS Page Criteria 1 'Golden Pin' Anchor 2 'Golden Pin' Chain 3 'Golden Pin' Safety Anchor 4 Golden Pin Super
More informationM.K.Forge ISO 9001:2008 CERTIFIED. Specialist in: transmission stringing line, lifting tackles and all types of Forging
M.K.Forge ISO 9001:2008 CERTIFIED Specialist in: transmission stringing line, lifting tackles and all types of Forging Company Profile Mr late Shri Mukarab Khilji was the founder of M. K. Forge in the
More informationB L A C K R AT 4 W D 11
11 Recreational 4 wheel driving should be challenging and enjoyable and for the professional it can be a necessity to get across some wild and difficult terrain, so when you get into a jam you need to
More informationToll Free:
PRODUCTS & SERVICES Toll Free: 1-877-461-4876 www. info@ UTILITY INDUSTRY Toll Free: 1-877-461-4876 LIFTING & RIGGING SERVICES & SOLUTIONS YOU CAN COUNT ON. Hercules SLR is an essential part of your workplace.
More informationLever Hoist Beam Trolley Beam Clamp Lifting Clamps Tirfors Hand Winches Wire Grips Load Binder...
INDEX Chain... 3 Ropes... 6 Hooks... 9 Master Links... 11 Chain Slings... 13 Ferrules... 17 Thimbles... Sockets... 21 Carbon Steel Hooks... 24 Work Load Limits of Slings... 26 Steel Wire Rope Slings...
More informationINSULATING LINKS, ISO/LINK AC & DC
INSULATING LINKS, ISO/LINK AC & DC INDUSTRIAL UTILITY & CONSTRUCTION 800.733.7071-1.508.248.3941 - Fax 1.508.248.0639 80 INSULATING LINKS, ISO/LINK AC & DC Proven Performance in Hi-Voltage & Hi-Current
More informationYellow Point WARNING NEVER EXCEED PUBLISHED WORKING LOAD LIMIT. Catalog No YP. Copyright 2017 YOKE Industrial Corp. All Rights Reserved.
Yellow Point Catalog No. 8-2017.YP 2 3 Yellow Point 4 Worldwide Quality Type Approval And Certificate: 5 Quality Control, Testing, and Detecting during manufacturing YOKE runs a constant and strict production
More informationRigging Overview. Rigging Overview. Rigging. All rental equipment is available throughout North America.
IGGING igging Overview All rental equipment is throughout North America. igging Overview igging For specific product information, refer to the group of equipment within this section s overview on the following
More information364 RTE.122 ST.GERMAIN DE GRANTHAM, QUÉBEC J0C 1K0 TEL: (819) Fax (819) CHAIN ASSEMBLIES
0 ARTHUR STREET NORTH, ELMIRA, ONTARIO N3B 1Z9 TEL: (519) 669-405 FAX: (519) 669-1436 PAGE 1 CHAIN ASSEMBLIES ITEM # G-7 TIE DOWN CHAIN - 3150 LBS. RATED W.L.L. LIST PRICE 601068 1/4 Gr. 70 x 1' c/w Grab
More informationRyko Solutions, Inc. Crane and Jib Safety Program
Ryko Solutions, Inc. Crane and Jib Safety Program CONTENTS PURPOSE...3 POLICY...3 SCOPE...3 RESPONSIBILITIES...3 FITNESS FOR DUTY...4 INSPECTIONS...4 FREQUENT INSPECTION...4 PERIODIC INSPECTIONS...5 RATED
More informationMATERIALS HANDLING MATERIALS HANDLING
7 MATERIALS HANDLING SPREADER BAR END CAPS & EQUALISERS...142 SPREADER BARS...143 CONTAINER LIFTERS 20 & 40FT...144 PERSONNEL WORK CAGES...145 LOAD ROLLERS & LOAD SKATES...146 HAND PALLET TRUCK & LIFTING
More informationFor Use in CCO Written Examinations REFERENCE BOOKLET. This supplement is not to be used for any other purpose.
For Use in CCO Written Examinations REFERENCE BOOKLET RIGGER This Reference Booklet has been produced and adapted from various manufacturers data and is for use in CCO Written Examinations. This supplement
More informationLifting Beams & Custom Engineered Lifting Devices
Lifting Beams & Engineered Lifting BASIC INFORMATION Lift-All can provide a unique engineered device for your production requirements. Our custom devices range from large capacity beams to control and
More informationMaasdam The Original. Often Imitated...Never Duplicated
Table of Contents......... Cable Pow R Pulls LIFETIME WARRANTY 1 Ton Cable Puller Model #: 144S-6 Weight: 7.63 lbs Cable Length: 12 ft. Cable Lift: 12 ft. Leverage: 15:1 Heavy-Duty Pow R Pulls 3 Ton Cable
More informationLOAD RATED FITTINGS STAINLESS STEEL LOAD RATED COMPONENTS HEIGHT SAFETY FITTINGS
LOAD RATED GRADE 316 STAINLESS STEEL FITTINGS STAINLESS STEEL LOAD RATED COMPONENTS HEIGHT SAFETY FITTINGS 37 Taree Street Burleigh QLD 4220 Telephone: (07) 55 935 688 Fax: (07 55 935 872 Email: bridge@bridco.com.au
More informationCOLUMBUS McKINNON CORPORATION
COLUMBUS McKINNON CORPORATION RATCHET LEVER HOIST The CM Bandit is one of the most compact and durable ratchet lever hoists in the industry. Its lightweight and portable design, easy free-chaining feature
More informationCare, Use & Inspection Herc-Alloy 800 Chain...35 Herc-Alloy 800 Slings Herc-Alloy 800 Components Master Link...
are, Use & Inspection....................... 34 Herc-lloy 800 hain.........................35 Herc-lloy 800 Slings......................36-37 Herc-lloy 800 omponents................38-39 Master Link................................40
More informationForce Control Switches
Force Control Switches Simple and ultra-reliable passive sensors provide switch contacts that open or close at your specified loads. Overload protection Slack-line detection Up to four switches on a single
More informationShop Supplies. Shop Supplies. To order call: Fax:
1 Hose Reels Jack Stands Air Hose Reels - Heavy Duty Steel Frame Corrosion resistant powder coat finish. Features spring tension brake and solid brass swivel. Mounts on floor, wall or workbench. REEL CAPACITY
More informationQuick-find Index. Lifting & Rigging
Burncrete s core business is the supply of lifting, rigging, pulling and lashing equipment to the mining, industrial, construction, transport, railways and harbours sectors, via re sellers, agents and
More informationAlloy Chain Slings WIRE ROPE LP. HOW TO ORDER THE PROPER CHAIN SLING When ordering, please be sure to include the following:
Chain WIRE ROPE LP Alloy Chain Slings HOW TO ORDER THE PROPER CHAIN SLING When ordering, please be sure to include the following: SIZE means diameter of the material from which the link of the body chain
More informationov-lifting_bolts_divider - Updated Lifting Bolts
ov-lifting_bolts_divider - Updated - 09-01-2017 Lifting Bolts Technical Information roduct information Lifting Bolts roduct marking Compliant with 2006/42/EC, and with individual date of manufacture and
More informationtruck crane 140 tons link-belt htc-3140lb BOOM LENGTHS: 42 to 195 ft JIB LENGTHS: 38 to 109 ft JIB OFFSETS:
truck crane 140 tons link-belt htc-3140lb BOOM LENGTHS: 42 to 195 ft JIB LENGTHS: 38 to 109 ft JIB OFFSETS: 2-15 - 30-45 NOTES: Technical Data Specifications & Capacities Telescopic Boom Truck Crane 140
More informationCare, Use & Inspection
Care, Use & Inspection The life and strength of erc-alloy 1000 chain slings depend on proper inspection, maintenance and use. For additional information, refer to ASE 30.9 and OSA 1910.184. Care Chain
More informationLifting Devices Catalog
Lifting Devices Catalog Spreader Bars Lifting Beams Special Lifters Material Baskets Personnel Baskets Cranes Rigging Components Storage M E M B E R Quality Statement Bishop Lifting Products, Inc. (BLP)
More informationGRADE 8O ALLOY STEEL CHAIN CARE, USE & INSPECTION OF GRADE 80 CHAIN & SLINGS
GRADE 8O ALLOY STEEL CHAIN CARE, USE & INSPECTION OF GRADE 80 CHAIN & SLINGS CARE 1. WORKING LOAD LIMIT - Select the proper size chain for the job keeping within the working load limits shown. The angle
More informationJOHNSON SNATCH BLOCKS BLOCKS FOR CONSTRUCTION, OILFIELD, AND TOWING
JOHNSON SNATCH BLOCKS BLOCKS FOR CONSTRUCTION, OILFIELD, AND TOWING Single Johnson Snatch Blocks 2 30 METRIC TONS WLL SINGLE SHEAVE W/SHACKLE SINGLE SHEAVE W/HOOK & OPTIONAL LATCH SINGLE SHEAVE TAILBOARD
More informationTiger Lifting Home of the Tiger hoisting range & Tiger subsea lifting products
Tiger Lever Hoist Model No PROLH (with overload protection) Main Features Now available with slipping clutch overload protection Range 750kg - 10.0t Equipped with our unique dual brake mechanism New twin
More informationMaasdam The Original. Often Imitated...Never Duplicated
Maasdam The Original. Often Imitated...Never Duplicated Table of Contents......... 1-888-797-7855 www.maasdam.com www.pullr.com Maasdam The Original. Often Imitated...Never Duplicated Cable Pow R Pulls
More informationCHAIN SLING USAGE 2, 3 ORDERING SLINGS AND CHAIN STYLES 4 GRADE 80 WORKING LOAD LIMITS 5, 6 GRADE 80 CHAIN AND ATTACHMENTS 7-17
TABLE OF CONTENTS CHAIN SLING USAGE 2, 3 ORDERING SLINGS AND CHAIN STYLES 4 GRADE 80 WORKING LOAD LIMITS 5, 6 GRADE 80 CHAIN AND ATTACHMENTS 7-17 EUROPEAN GRADE 80 CHAIN ATTACHMENTS 18-23 GRADE 100 CHAIN
More informationSwing blocks for wire rope
EC Swing blocks for wire rope T 6055 GB 1 June 05 1/2 Applications The swing blocks of EC type are mainly used for temporary applications for lifting or pulling. They can be su spended to a fi xed or mobi
More informationSS11 Tiger Subsea Lever Hoist
SS11 Tiger Subsea Lever Hoist Main Features Range from 800kg 10000kg *NEW* Twin Cam shaped pawl design Proven track record Double switch brake mechanism Marine specific friction discs Meets and exceeds
More informationGrade 80 & 100 Alloy Chain
Grade 80 & 100 Alloy Chain General Information WORKING LOAD LIMIT The Working Load Limit is the maximum load in pounds which should ever be applied to chain, when the chain is new or in as-new condition,
More informationMarine Blocks. Copyright 2002 The Crosby Group, Inc. 315 All Rights Reserved
Marine s s kc o l B e n i r a M Marine s Copyright 2002 The Crosby Group, Inc. 315 Western Lead s s k c o l B d a e L n r e t s e W Horizontal Lead s Available painted or galvanized. Fitted with steel
More informationGunnebo Lifting Offshore programme - accessories. High consistent quality generates long durability and safety
Gunnebo Lifting Offshore programme - accessories High consistent quality generates long durability and safety DNV 2.7-1 certificate We are certified by DNV to make type approval in 271 quality (Offshore
More information2nd EDITION STEVPRIS FLIPPER DELTA DANFORTH AC-14 SWIVEL SHACKLE DETACHABLE PEARLINK HINGE LINK LINK
STEVPRIS FLIPPER DELTA DANFORTH AC-14 SWIVEL SHACKLE DETACHABLE PEARLINK HINGE LINK LINK SHACKLE GOLDNOSE CLOSED/OPEN SOCKET GRAPNEL J CHASER 2nd EDITION JS OFFSHORE SUPPLY PTE LTD 7500A Beach Road #13-304
More informationEasily Moved Equipment Aluminum Gantry Cranes. Maintenance Manual Contents
Easily Moved Equipment Aluminum Gantry Cranes Maintenance Manual Contents Pg. 1 Gantry Models Technical Specifications Pg. 2 Gantry Primary Specifications Pg. 3 Gantry Crane Dimensions (Models 1100 to
More informationCHAIN SPECIFICATIONS
CHAIN SPECIFICATIONS Peerless Industrial Group, Your Link to Quality, Strength & Service Since 1917 Peerless, established as a manufacturer of tire chains in 1917 eventually expanded into hardware and
More informationI M P O R T E R S & D I S T R I B U T O R S
A L I V E I M P O R T E R S & D I S T R I B U T O R S O f Q u a l i t y P r o d u c t s T o I n d u s t r y Company Profile HES New Zealand Limited was established in October 2011 selling First Aid, Survival
More informationPROCEDURE. Operative Date: 22/12/2016 Department: HSEC. Revision: Author: D Steel CONTENTS
Title: Cranes - Inspection and Maintenance PROCEDURE Procedure No: P314.422 Issue: 1 Revision: 0 Operative Date: 22/12/2016 Department: HSEC Sect./Classification: Safety / Gear & Equipment Author: D Steel
More informationSECTION 12. Lifting & Spreader Beams
SECTION Lifting & Spreader Beams Lifting beams and spreader bars are below the hook equipment that facilitates safe lifting by spreading the attachment points and allowing for better sling angles. Even
More information00000 Series Clevis Pin Slotted Hexagon Hex Key Recommended Corresponding Part No. Part No. Size Torque Preload SLT* SLT* HEX
00000 Series Clevis Pin All clevis pins are manufactured from heat treated 416 stainless steel to provide superior strength and wear. Hardness is between 37-40 Rc. The DCD Clevis Pin is a shouldered type
More informationINDUSTRIAL, MILITARY, AND SEVERE DUTY WINCHES AND HOISTS
I N D U S T R I AL W I N C H AC C ES S O R I ES INDUSTRIAL, MILITARY, AND SEVERE DUTY WINCHES AND HOISTS 10 WAR N C U S T O M ER S ER VI C E: ( 8 0 0 ) 5 43-9 2 7 6 WARN: BUILT TO WORK In Clackamas, Oregon,
More information7 Hazard assessment 8 Worker participation 9 Hazard elimination and control
This document is a guideline only. Employers have a responsibility of assessing all applicable occupational health and safety legislation, for the tasks they are performing. Employers in this industry
More informationAmerica s Largest Importer/Wholesaler of Wire Rope, Chain and Fittings!
America s Largest Importer/Wholesaler of Wire Rope, Chain and Fittings BLOCKS BINDERS Failure to design and use tackle block systems properly may cause a load to slip or fall - the result could be serious
More informationAWRF Associated Wire Rope Fabricators
AWRF Associated Wire Rope Fabricators Recommended Practice and Guideline Disclaimer for version of AWRF Recommended Guideline for Proof Test Procedures for Slings Part I: Alloy Chain Slings Associated
More informationCare, Use & Inspection Herc-Alloy 1000 Chain...19 Herc-Alloy 1000 Slings Herc-Alloy 1000 Components Master Link...
Care, Use & Inspection....................... 18 erc-alloy 1000 Chain........................19 erc-alloy 1000 Slings.....................20-21 erc-alloy 1000 Components...............22-23 aster Link................................24
More informationHOOKS HOOKS. VANGUARD STEEL LTD.
www.vanguardsteelvancouver.com www.vanguardsteel.com TABLE OF CONTENTS Page Alloy Clevis Grab 1 Alloy Clevis Slip 2 Alloy Clevis Slip with Latch Kit 3 Barrel 4 Carbon Clevis Grab 5 Carbon Clevis Slip 6
More information