Harsh Duty Sensors. Washdown. Submersible. Load Dump. High / Low Temperature. Pressure Resistant. Capacitive Noise Immune

Transcription

1 Harsh Duty Sensors Washdown Submersible Load Dump High / Low Temperature Pressure Resistant Capacitive Noise Immune

2 Harsh Duty Sensing from TURCK! Enable your equipment to handle the toughest tasks on the job and continually protect it against the most extreme working conditions by using TURCK's family of reliable, sturdy, and cost effective Harsh Duty sensors and cordsets. Choose TURCK Harsh Duty Sensors to Solve ny Number of Sensor Problems... ü When excessive heat, cold or pressure bring about equipment breakdowns ü When electro static discharge and RFI/EMI make equipment inoperable ü When water and chemical damage produces corrosion and malfunction ü When conventional sensors are not built strong enough for harsh environments, leading to equipment failure TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

3 Important Reasons to Choose TURCK's Harsh Duty Sensors and Cordsets: ü More cost effective compared to other comparable sensors ü Ensures continuous and reliable operation ü Reduces maintenance downtime ü Simplifies field installations ü Environmentally tested and approved ü Variety of innovative, unique sensors and connection solutions for many harsh applications Harsh Duty Products are Immediately vailable to Solve ny of Your Sensing Problems... Even the Most Rigorous: ü Washdown Sensors PVDF front cap is impervious to harsh chemicals Viton O-ring provides a quality seal, impervious to harsh chemicals Stainless steel housings provide corrosion resistance 4-way LED provides visible output indication from any direction IP 68/69K seal ratings withstand submersion and high pressure spray in a washdown environment Extended sensing range picks up targets at longer distances Water tight clear Teflon shrink sleeve over LEDs and label for added protection Typical applications - Car washes, bottling and food processing applications Stainless Steel Barrel PVDF Front Cap 4-way LED Snap-on Connector Clear Shrink Teflon Sleeve Viton O-ring TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

4 ü Submersible Sensors Functional underwater to a depth of 500 meters in oil, water, and sea water Plastic (polypropylene) is highly resistant to shock, vibration, and caustic chemicals Typical applications - Oil rigs, offshore drilling, dams, dikes (locks), ship and sewage tanks Polypropylene Housing ü Load Dump Sensors ESD protection against static discharge prevents sensor damage; up to 30 kv airborne, 8 kv direct RFI protection against radio frequency interference insures no false signals High transient protection Voltage spike protection protects against sensor burnout Surge protection protects sensors against lightening strikes Stainless steel barrels ensure physical durability 3rd party tested to meet SE J3-, IEC and IEC (Immunity to conducted transients on power leads) Typical applications - Battery operated vehicles, utility trucks, military vehicles, fire/garbage/cement trucks ü High and Low Temperature Sensors High and low temperature sensors available with a wide range of uses (-40 C, +00 C, +0 C and +60 C) -40 C - plastic barrel +00 C - plastic, plus new metal barrels in chrome plated brass for added durability +0 C - Stainless Steel barrels with Teflon front cap and cable to resist higher temperatures +60 C - stainless steel barrels with Teflon front cap and cable for additional durability in resisting higher temperatures pproved - CE, UL, CS Typical applications - ovens, freezers, bakeries, curing, semi-conductor, glass and steel mills 3 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

5 ü High Pressure Sensors O-ring in middle of housing to create a tight fit in pressure applications Styles available for up to 500 bar (750 PSI) Stainless steel barrel for durability DC output only High pressure hydraulics Typical applications - hydraulic cylinders on front loaders, hydraulic power units, tool and die, clamping, punch press, stamping plants ü Capacitive Noise Immune Sensors ESD protection-static discharge protection against sensor damage; up to 30 kv airborne, 8 kv direct RFI protection-no radio frequency interference Fast Transient protection Line Coupled Noise, immune from 50 KHz - 30 MHz Surge protection-protects against lightening strikes Typical applications - plastic pellet hoppers, molding machines, or any level detection application TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

6 Cable Solutions to Fit Your Harsh Duty Needs TURCK also provides a wide variety of quality, rugged and durable cordsets that will withstand harsh environments such as cutting fluids, weld slag, abrasion or chemical wash downs. ü eurofast molded cordsets are designed with a standard M thread. ü minifast molded cordsets are made with an industry standard 7/8-6 UN thread. ü microfast molded cordsets have a /-0 UNF thread. ü ll styles above meet the IP 68 seal rated standard and 00 PSI washdown rating. ll TURCK cordsets provide a fast, reliable, and easy installation solution that reduce machine downtime and increase productivity. Cordsets are available in straight and right angle configurations with custom cable materials and lengths. lso available are cable features such as: Plastic, nickel-plated brass, or stainless steel coupling nuts. Option of molding a connector to sensors with potted-in cable. PVC jacket offers an excellent resistance to UV, acids, alkalis, alcohols, most solvents, oils, gasoline, grease and waxes. "/S90" PUR is a polyurethane jacket that provides high resistance to oils, cutting oils, and transmission fluids. Superior cut and abrasion resistance. "/S0" is a high-flex jacket made of TPR or PUR. Excellent for robotics or any continuous motion applications. Withstands over 0 million bend and torsion flex cycles. "/S59" is a double-jacketed cable with a PUR outer jacket and a braided mechanical shield for superior strength and high flexibility. Excellent for applications where cable abrasion or cutting are common. "/S600" is a thermoset CPE jacket that is excellent for use where a high resistance to acids, alkalis, gasoline, degreaser solvents, and weld slag are required. "/S587" is a TPR (thermoplastic rubber) that resists many chemicals and oils. Retains its aesthetic appearance, remains flexible, has a high tear strength and is recyclable. Don't wait for equipment to malfunction or harsh conditions to prevail, choose TURCK Heavy Duty sensor and connection products. If you don't have these features with your current system, you may want to read more about ours in the information that follows. For first class application support to find exactly what you need, please contact us at: Toll free: PROX (7769) Website: t TURCK, we look forward to hearing from you! 5 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

7 Harsh Duty Selection Guide Pages Harsh Duty Technical Information Washdown Sensors Submersible Sensors Load Dump Sensors High / Low Temperature Sensors Pressure Resistant Sensors Capacitive Noise Immune Index TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

8 TURCK Harsh Duty - Sensors Sensors for Washdown Environments (IEC 59) IP 67 Temporary immersion in water, constant temperature meter depth 30 minute duration IP 68 Commonly stands for a higher degree of sealing and is used for reinforced marketing of a product Continuous submersion in water, according to customer agreement TURCK's IP 68 Definition IP 67 Plus 4 hours at 70 C 4 hours at -5 C 7 days at meter under water at a constant temperature 0 cycles +70 C and -5 C, minimum of each temperature TURCK's IP 69K Definition IP 67 Plus IP 68 (as defined by TURCK) Plus Hot steam jet cleaning per EN 6059 (IP enclosure ratings) and DIN DIN test sample is placed in a permanent position between 4 and 6 inches from the water jet nozzle. The sample rotates around the axis parallel to the length of the sensor five times per minute. Water temp is 80 ± 5 C. The spray is then directed at 50 to 500 PSI directly on the sensor in 30 angle increments for 30 seconds at each point (4 points altogether) for a total of 0 seconds ( minutes). Other Testing Procedures: ll wash down sensors were also tested according to the following procedures: Sensors are stored for 3 days in fluid - then test for operation Heat sensors to +85 C and place in fluid- then test for operation Cool sensors to -0 C and place in fluid - then test for operation Fluids Tested Detergents Soda Lye (caustic) 3% KSM 93 R 4% with Ph value of 9. Perchlorethylen (PERC) Grinding Oil Megacut S (Made by Daw erocit) Cutting Oil Megacut (Made by Daw erocit) Coolants Klarol with Ph value of 9. erolan 400 with Ph value of TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

9 "Load Dump" Sensors TURCK has developed the new "Load Dump" sensor to solve application problems in large vehicles that use battery operated systems such as lift equipment, garbage trucks, military vehicles, etc. These applications caused problems due to high voltage transients and engineers had to come up with a solution. There were some solutions available, but they were not always the most reliable and economic solutions. TURCK chose to develop this sensor and test it with an outside testing laboratory to meet existing specifications to ensure the sensor will perform as required given the needed protection in this unique application. The technical name for this type of sensor is "Immunity to Conducted Transients On Power Leads". They have been tested and meet the SE-J3- specs, described as the following: Tests were conducted primarily, but not exclusively, on ignition and battery operated systems of mobile and stationary vehicle systems. The tests for SE-J3- were developed to provide measurable and repeatable test measurements to determine the susceptibility of electrical transients, particularly along battery feed and switched ignition, generated in those systems. Switching devices such as relays, intermittent alternator/generator switching or battery to load switching can cause very high transients up to 600 volts for durations of up to ½ a second. The energy in these transients is often enough to damage unprotected semiconductor devices (like proximity sensors). The tests were established for both and 4 volt systems. Results also meet IEC and specs for radiated and injected noise. There are five basic pulses in these tests of which Pulse and Pulse 5 are the most severe. TURCK passed the tests in both cases. For further data, a copy of the SE specifications can be obtained from SE (this is a proprietary document and cannot be copied) or contact TURCK pplication Support. TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

10 TURCK Harsh Duty - Sensors Noise Immune Capacitive Sensors TURCK has developed a completely new circuit for its capacitive sensors. These new "BCF" sensors incorporate a unique filter principle, making them immune to most industrial noise. This principle involves a fixed oscillator frequency combined with a rectifier filter providing superior noise immunity over the competition. TURCK's fixed oscillator allows the sensor to maintain a constant frequency regardless of sensitivity adjustment. This fixed frequency is high enough to ignore most of the "standard" noise levels seen on plant floors. Electrical noise is mostly symmetrical which makes it easier to identify and separate from the sensor's input signal. The TURCK rectifier filter is able to block this noise allowing only the "useful" input signal, which is in phase with the oscillator frequency, to pass. These two innovative electrical techniques give TURCK the best defense against industrial noise. The list of specifications and test results below demonstrates how TURCK meets or exceeds all of the rigid standards established by CE. In fact, the criteria set forth by CE is so stringent that most capacitive sensors offered on the market today cannot pass any or all of these testing requirements. If you have a capacitive sensor application located in a "noisy" environment choose the new "BCF" sensors from TURCK to ensure your process operates smoothly. TURCK BCF capacitive sensors have been tested to a higher standard than required, exceeding most of the specifications listed by CE. Test Type CE Product Standard CE Generic Standard TURCK BCF Noise Immune Capacitive Sensors Immunity to Electrostatic Discharge (ESD) IEC EN kv Direct Contact 8 kv irborne 4 KV Direct Contact 8 KV irborne 8 kv Direct Contact 30 kv irborne Immunity to Radiated Electromagnetic Fields. Radio Frequency Interference (RFI) IEC EN V/M MHz 0V/M MHz 5 V/M MHz Immunity to Electrical Fast Transients (Burst-High Voltage) IEC EN V 000 V 3000 V Immunity to Conducted R.F. Voltage (Line coupled Noise) IEC EN Undefined 0 V 50 khz-80 MHz >0 V 50 khz-30 MHz Immunity to Surges (lightning strike) IEC KV, 500Ω DC Undefined kv, 500Ω DC 5 kv, 500Ω C 9 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

11 Notes: TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

12 TURCK Inductive Sensors 3-Wire DC Washdown Sensors NEW Barrel Barrel Sensors, Metal, Washdown Environments - mphibian TM Quick Disconnect 3-Wire DC eurofast 0-30 VDC, Short-Circuit and Overload Protected Normally Open, NPN (Sinking) or PNP (Sourcing) Sensor Selection Part Number Embeddable Rated Operating Distance (mm) Barrel Diameter (mm) NPN (Sinking) PNP (Sourcing) Drawing # # of LEDs Switching Frequency (Hz) ID Number Connection Bi 3-EMWD-N6X-H4 Bi 7-EM8WD-N6X-H4 Bi-EM30WD-N6X-H4 Ni 5-EMWD-N6X-H4 Ni0-EM8WD-N6X-H4 Ni0-EM30WD-N6X-H4 Bi 3-EMWD-P6X-H4 Bi 7-EM8WD-P6X-H4 Bi-EM30WD-P6X-H4 Ni 5-EMWD-P6X-H4 Ni0-EM8WD-P6X-H4 Ni0-EM30WD-P6X-H B B B B B B M M M M M M M63433 M46453 M46454 M M M46534 eurofast Mating Cordsets WKE 3T-5/S90 or WWKE 3T-5/S90 For other styles see Cordsets catalog Material Connector: Housing: Front Cap: Stainless Steel Stainless Steel PVDF ccessories ccessories and mounting devices can be found in "Sensors" catalog. TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

13 Specifications Ripple % Differential Travel (Hysteresis) % (5% typical) Voltage Drop cross Conducting Sensor....8 V at 00 m Trigger Current for Overload Protection... 0 m Continuous Load Current m Off-State (Leakage) Current < m No-Load Current m Time Delay Before vailability ms Power-On Effect Per IEC Reverse Polarity Protection Incorporated Wire-Break Protection Incorporated Transient Protection Per EN Operating Temperature C to +85 C (-3 F to +85 F) Enclosure Meets NEM,3,4,6,3 and IEC IP 67, 68, and IP 69 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance s NPN (Sinking) B PNP (Sourcing) Dimensions TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

14 TURCK Inductive Sensors 3-Wire DC Washdown Sensors NEW Barrel Barrel Sensors, Metal, Washdown Environments - mphibian TM Potted-In Cable 3-Wire DC 0-30 VDC, Short-Circuit and Overload Protected Normally Open, NPN (Sinking) or PNP (Sourcing) Sensor Selection Part Number Embeddable Rated Operating Distance (mm) Barrel Diameter (mm) NPN (Sinking) PNP (Sourcing) Drawing # # of LEDs Switching Frequency (Hz) ID Number Connection Bi 3-EMWD-N6X Bi 7-EM8WD-N6X Bi-EM30WD-N6X Ni 5-EMWD-N6X Ni0-EM8WD-N6X Ni0-EM30WD-N6X M M M M M M meter cable, PUR jacket Bi 3-EMWD-P6X Bi 7-EM8WD-P6X Bi-EM30WD-P6X Ni 5-EMWD-P6X Ni0-EM8WD-P6X Ni0-EM30WD-P6X B B B B B B M M M M M M Cable/Conductor Cable: Copper Conductor: PUR jacket; meter standard length WG Material Connector: Housing: Front Cap: Stainless Steel Stainless Steel PVDF ccessories ccessories and mounting devices can be found in "Sensors" catalog. 3 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

15 Specifications Ripple % Differential Travel (Hysteresis) % (5% typical) Voltage Drop cross Conducting Sensor....8 V at 00 m Trigger Current for Overload Protection... 0 m Continuous Load Current m Off-State (Leakage) Current < m No-Load Current m Time Delay Before vailability ms Power-On Effect Per IEC Reverse Polarity Protection Incorporated Wire-Break Protection Incorporated Transient Protection Per EN Operating Temperature C to +85 C (-3 F to +85 F) Enclosure Meets NEM,3,4,6,3 and IEC IP 67, 68, and IP 69 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance LED On Output Energized s NPN (Sinking) B PNP (Sourcing) Dimensions TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

16 TURCK Inductive Sensors 3-Wire DC Submersible Sensor P Barrel Barrel, Plastic Submersible Sensor Special Plastic Housing with Potted-In Cable, Full Threading 3-Wire DC 0-30 VDC, Short-Circuit and Overload Protected Normally Open, NPN (Sinking) or PNP (Sourcing) Sensor Selection Part Number Embeddable Rated Operating Distance (mm) Barrel Diameter (mm) NPN (Sinking) PNP (Sourcing) Drawing # # of LEDs Switching Frequency (Hz) ID Number Connection Bi 5-P8-N6/S39-S M66035 meter cable, PUR Jacket Bi 5-P8-P6/S39-S B M This sensor will operate at 75 PSI and is resistant to oil and sea water at 500 meters (64 feet). It is also highly resistant to shock, vibration and caustic chemicals. Cable/Conductor Cable: Copper Conductor: (PVC insulated) PUR jacket; meter standard length 4 WG Material Barrel: End Cap: Locknuts: POM Plastic P 6.6-GF Plastic P 6-GF30 Plastic ccessories ccessories and mounting devices can be found in "Sensors" catalog. 5 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

17 Specifications Ripple % Differential Travel (Hysteresis) % (5% typical) Voltage Drop cross Conducting Sensor....8 V at 00 m Trigger Current for Overload Protection... 0 m Continuous Load Current m Off-State (Leakage) Current <0 µ No-Load Current m Time Delay Before vailability ms Power-On Effect Per IEC Reverse Polarity Protection Incorporated Wire-Break Protection Incorporated Transient Protection Per EN Operating Temperature C to +70 C (-3 F to +58 F) Enclosure Meets NEM,3,4,4x,6,3 and IEC IP 67 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance s NPN (Sinking) B PNP (Sourcing) Dimensions TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

18 TURCK Inductive Sensors -Wire C Submersible Sensor P Barrel Barrel, Plastic Submersible Sensor Special Plastic Housing with Potted-In Cable, Full Threading -Wire C 0-50 VC Normally Open (Z3X) NRTL Sensor Selection Part Number Embeddable Rated Operating Distance (mm) Barrel Diameter (mm) Normally Open Normally Closed Drawing # # of LEDs Switching Frequency (Hz) ID Number Connection Bi 5-P8-Z3/S39-S M meter cable, PUR jacket This sensor will operate at 75 PSI and is resistant to oil and sea water at 500 meters (64 feet). It is also highly resistant to shock, vibration and caustic chemicals. Cable/Conductor Cable: Copper Conductor: (PVC insulated) PUR Jacket; meter standard 4 WG Material Barrel: End Cap: Locknuts: POM Plastic P 6.6-GF Plastic P 6-GF30 Plastic ccessories ccessories and mounting devices can be found in "Sensors" catalog. 7 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

19 Specifications Line Frequency Hz Differential Travel (Hysteresis) % (5% typical) Voltage Drop cross Conducting Sensor V at 500 m Continuous Load Current m Off-State (Leakage) Current m Minimum Load Current m Inrush Current ( 0 ms, 5% Duty Cycle) Time Delay Before vailability ms Power-On Effect Per IEC Transient Protection Per EN Operating Temperature C to +70 C (-3 F to +58 F) Enclosure Meets NEM 4,4X,6,6P,3 and IEC IP 68 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance Normally Open Dimensions TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

20 TURCK Inductive Sensors 3-Wire DC Load Dump NEW EM Barrel Barrel, Metal with Potted-In Cable, Load Dump Partial Threading 3-Wire DC 0-30 VDC, Short-circuit and Overload Protected Transient Noise per SE J 3/ Normally Open, NPN (Sinking) or PNP (Sourcing) Sensor Selection Part Number Embeddable Rated Operating Distance (mm) Barrel Diameter (mm) NPN (Sinking) PNP (Sourcing) Drawing # # of LEDs Switching Frequency (Hz) ID Number Connection Bi 5-EM8-N6XLD Bi0-EM30-N6XLD T T46709 meter cable, PVC jacket Bi 5-EM8-P6XLD Bi0-EM30-P6XLD B B T T Cable/Conductor Cable: Copper Conductor: (PVC insulated) PVC Jacket, meter standard length 8 WG Material Barrel/Locknuts: Sensing Face: End Cap: Stainless Steel P -GF30 Plastic PUR Plastic ccessories ccessories and mounting devices can be found in "Sensors" catalog. 9 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

21 Specifications Ripple % Differential Travel (Hysteresis) % (5% typical) Voltage Drop cross Conducting Sensor....8 V at 00 m Trigger Current for Overload Protection... 0 m Continuous Load Current m Off-State (Leakage) Current <0 µ No-Load Current m Time Delay Before vailability ms Power-On Effect Per IEC Reverse Polarity Protection Incorporated Wire-Break Protection Incorporated Transient Protection Vehicle Transients -4VDC Per SE J 3/ Load Dump -4VDC Per SE J 3/ Protection gainst Transients kv, ms, k Operating Temperature C to +70 C (-3 F to +58 F) Enclosure Meets NEM,3,4,6,3 and IEC IP 67 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance LED On Output Energized s NPN (Sinking) B PNP (Sourcing) Dimensions TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

22 TURCK Inductive Sensors 3-Wire DC High Temperature: 00 C P Barrel High Temperature Sensors Plastic Barrel, Full Threading, Quick Disconnect 3-Wire DC minifast 0-30 VDC, Short-Circuit and Overload Protected Normally Open, NPN (Sinking) or PNP (Sourcing) Sensor Selection Part Number Bi 5-P8-N6X-B34/S00 Bi0-P30-N6X-B4/S00 Bi 5-P8-P6X-B34/S00 Bi0-P30-P6X-B4/S00 Embeddable Rated Operating Distance (mm) Barrel Diameter (mm) NPN (Sinking) PNP (Sourcing) Drawing # B B # of LEDs Switching Frequency (Hz) ID Number M67700 M46974 M46973 M46975 Connection minifast Mating Cordsets RK 40-M ( meter) For other styles consult Cordsets catalog "/S00" - These sensors will operate up to 00 C ( F) Material Barrel: Connector: P -GF30 Plastic Polyamide Plastic ccessories ccessories and mounting devices can be found in "Sensors" catalog. TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

23 Specifications Ripple % Differential Travel (Hysteresis) % (5% typical) Voltage Drop cross Conducting Sensor....8 V at 00 m Trigger Current for Overload Protection... 0 m Continuous Load Current m Off-State (Leakage) Current <0 µ No-Load Current m Time Delay Before vailability ms Power-On Effect Per IEC Reverse Polarity Protection Incorporated Wire-Break Protection Incorporated Transient Protection Per EN Operating Temperature C to +00 C (-3 F to + F) Enclosure Meets NEM,3,4,6,3 and IEC IP 67 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance LED On Output Energized s NPN (Sinking) B PNP (Sourcing) Dimensions TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

24 TURCK Inductive Sensors 3-Wire DC High Temperature: 00 C S Barrel High Temperature Sensors Plastic Barrel, Partial Threading, Potted-In Cable 3-Wire DC 0-30 VDC, Short-Circuit and Overload Protected Normally Open, NPN (Sinking) Sensor Selection Part Number Embeddable Rated Operating Distance (mm) Barrel Diameter (mm) NPN (Sinking) PNP (Sourcing) Drawing # # of LEDs Switching Frequency (Hz) ID Number Connection Ni5-S30-N6X/S M46593 meter cable, PVC jacket "/S00" - These sensors will operate up to 00 C ( F) Cable/Conductor Cable: Copper Conductor: (PVC insulated) PVC Jacket; meter standard WG Material Barrel: End Cap: P -GF30 Plastic PUR Plastic ccessories ccessories and mounting devices can be found in "Sensors" catalog. 3 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

25 Specifications Ripple % Differential Travel (Hysteresis) % (5% typical) Voltage Drop cross Conducting Sensor....8 V at 00 m Trigger Current for Overload Protection... 0 m Continuous Load Current m Off-State (Leakage) Current <0 µ No-Load Current m Time Delay Before vailability ms Power-On Effect Per IEC Reverse Polarity Protection Incorporated Wire-Break Protection Incorporated Transient Protection Per EN Operating Temperature C to +00 C (-3 F to + F) Enclosure Meets NEM,3,4,4x,6,3 and IEC IP 67 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance LED On Output Energized NPN (Sinking) Dimensions TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

26 TURCK Inductive Sensors 3-Wire DC High Temperature: 00 C S Barrel High Temperature Sensors Plastic Barrel, Partial Threading, Potted-In Cable 3-Wire DC 0-30 VDC, TTL Compatible Normally Open, NPN (Sinking) or PNP (Sourcing) Sensor Selection Part Number Embeddable Rated Operating Distance (mm) Barrel Diameter (mm) NPN (Sinking) PNP (Sourcing) Drawing # # of LEDs Switching Frequency (Hz) ID Number Connection Bi -S-N7X/S00 Bi 5-S8-N7X/S00 Bi0-S30-N7X/S00 Ni 4-S-N7X/S00 Ni 8-S8-N7X/S00 Ni5-S30-N7X/S M77300 M M M M77350 M meter cable, PVC jacket Bi -S-P7X/S00 Bi 5-S8-P7X/S00 Bi0-S30-P7X/S00 Ni 4-S-P7X/S00 Ni 8-S8-P7X/S00 Ni5-S30-P7X/S B B B B B B M M75400 M7500 M76800 M M76850 "/S00" - These sensors will operate up to 00 C ( F) Cable/Conductor Cable: Copper Conductor: (PVC insulated) PVC Jacket; meter standard S: 4 WG S8/S30 and all S00 sensors: WG Material Barrel: End Cap: P -GF30 Plastic PUR Plastic ccessories ccessories and mounting devices can be found in "Sensors" catalog. 5 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

27 Specifications Ripple % Differential Travel (Hysteresis) % (5% typical) Voltage Drop cross Conducting Sensor V at 50 m (0.3 V typical) Continuous Load Current m Off-State (Leakage) Current <0 µ No-Load Current m Time Delay Before vailability ms Power-On Effect Per IEC Reverse Polarity Protection Incorporated Wire-Break Protection Incorporated Transient Protection Per EN Operating Temperature C to +00 C (-3 F to + F) Enclosure Meets NEM,3,4,4x,6,3 and IEC IP 67 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance LED On Output Energized s NPN (Sinking) B PNP (Sourcing) Dimensions 3 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

28 TURCK Inductive Sensors 3-Wire DC High Temperature: 00 C NEW M Barrel High Temperature Sensors Metal Barrel, Partial Threading, Potted-In Cable 3-Wire DC 0-30 VDC, Short-Circuit and Overload Protected Normally Open, PNP (Sourcing) Sensor Selection Part Number Embeddable Rated Operating Distance (mm) Barrel Diameter (mm) NPN (Sinking) PNP (Sourcing) Drawing # # of LEDs Switching Frequency (Hz) ID Number Connection Bi -M-P6X/S00 Bi 5-M8-P6X/S00 Bi0-M30-P6X/S00 Ni 4-M-P6X/S00 Ni 8-M8-P6X/S00 Ni5-M30-P6X/S M M46050 M46004 M460 M M46700 meter cable, PVC jacket "/S00" - These sensors will operate up to 00 C ( F) Cable/Conductor Cable: Copper Conductor: (PVC insulated) PVC Jacket; meter standard WG Material Barrel: Connector: Chrome Plated Brass Polyamide Plastic ccessories ccessories and mounting devices can be found in "Sensors" catalog. 7 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

29 Specifications Ripple % Differential Travel (Hysteresis) % (5% typical) Voltage Drop cross Conducting Sensor....8 V at 00 m Trigger Current for Overload Protection... 0 m Continuous Load Current m Off-State (Leakage) Current <0 µ No-Load Current m Time Delay Before vailability ms Power-On Effect Per IEC Reverse Polarity Protection Incorporated Wire-Break Protection Incorporated Transient Protection Per EN Operating Temperature C to +00 C (-3 F to + F) Enclosure Meets NEM,3,4,6,3 and IEC IP 67 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance LED On Output Energized PNP (Sourcing) Dimensions TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

30 TURCK Inductive Sensors - Harsh Duty 4-Wire DC High Temperature: 00 C S Barrel High Temperature Sensors Plastic Barrel, Partial Threading, Potted-In Cable 4-Wire DC 0-65 VDC, Short-Circuit and Overload Protected Complementary Outputs: One N.O., One N.C. (SPDT) Sensor Selection Part Number Embeddable Rated Operating Distance (mm) Barrel Diameter (mm) NPN (Sinking) PNP (Sourcing) Drawing # # of LEDs Switching Frequency (Hz) ID Number Connection Bi 5-S8-VP4X/S M5340 meter cable, PVC jacket "/S00" - These sensors will operate up to 00 C ( F) Cable/Conductor Cable: Copper Conductor: (PVC insulated) PVC Jacket; meter standard WG Material Barrel: End Cap: P -GF30 Plastic PUR Plastic ccessories ccessories and mounting devices can be found in "Sensors" catalog. 9 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

31 Specifications Ripple % Differential Travel (Hysteresis) % (5% typical) Voltage Drop cross Conducting Sensor....8 V at 00 m Trigger Current for Overload Protection... 0 m Continuous Load Current m Off-State (Leakage) Current <0 µ No-Load Current m Time Delay Before vailability ms Power-On Effect Per IEC Reverse Polarity Protection Incorporated Wire-Break Protection Incorporated Transient Protection Per EN Operating Temperature C to +00 C (-3 F to + F) Enclosure Meets NEM,3,4,6,3 and IEC IP 67 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance LED On Output Energized PNP (Sourcing) Dimensions TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

32 TURCK Inductive Sensors - Harsh Duty 4-Wire DC High Temperature: 00 C CP40 High Temperature Sensors Limit Switch Style combiprox 4-Wire DC 0-65 VDC, Short-Circuit and Overload Protected Complementary Outputs: One N.O., One N.C. (SPDT) Sensor Selection Part Number Embeddable Rated Operating Distance (mm) Housing Square (mm) NPN (Sinking) PNP (Sourcing) Drawing # # of LEDs Switching Frequency (Hz) ID Number Connection Bi5-CP40-VN4X/S00 Ni0-CP40-VN4X/S M54400 M5700 See Quick Disconnect Options below Bi5-CP40-VP4X/S00 Ni0-CP40-VP4X/S B B M50900 M50000 "/S00" - These sensors will operate up to 00 C ( F) Quick Disconnect Options For minifast connector: Suggested cordset: For eurofast connector: Suggested cordset: dd -B4 suffix to part number. RKM 40-M. dd -H4 suffix to part number. RK 4.4T-. Material Housing: Sensing: PBT-GF30-VO Plastic PBT-GF30-VO Plastic ccessories ccessories and mounting devices can be found in "Sensors" catalog. 3 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

33 Specifications Ripple % Differential Travel (Hysteresis) % (5% typical) Voltage Drop cross Conducting Sensor....8 V at 00 m Trigger Current for Overload Protection... 0 m Continuous Load Current m Off-State (Leakage) Current <0 µ No-Load Current m Time Delay Before vailability ms Power-On Effect Per IEC Reverse Polarity Protection Incorporated Wire-Break Protection Incorporated Transient Protection Per EN Operating Temperature C to +00 C (-3 F to + F) Enclosure Meets NEM,3,4,6,3 and IEC IP 67 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance LED On Output Energized s NPN (Sinking) B PNP (Sourcing) Dimensions TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

34 TURCK Inductive Sensors - Harsh Duty -Wire C High Temperature: 00 C P Barrel High Temperature Sensors Plastic Barrel, Full Threading, Quick Disconnect -Wire C minifast 0-50 VC Normally Open (Z3X) or Normally closed (RZ3X) Sensor Selection Part Number Bi 5-P8-Z3X-B33/S00 Bi0-P30-Z3X-B3/S00 Ni0-P8-Z3X-B33/S00 Bi 5-P8-RZ3X-B33/S00 Bi0-P30-RZ3X-B3/S00 Embeddable Barrel Diameter (mm) Normally Open Normally Closed Rated Operating Distance (mm) Drawing # B B # of LEDs Switching Frequency (Hz) ID Number M M35600 M43750 M M3560 Connection minifast Mating Cordsets RK 30-M ( meter) For other styles consult Cordsets catalog "/S00" - These sensors will operate up to 00 C ( F) Material Barrel: Connector: P -GF30 Plastic Polyamide Plastic ccessories ccessories and mounting devices can be found in "Sensors" catalog. 33 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

35 Specifications Line Frequency Hz Differential Travel (Hysteresis) % (5% typical) Voltage Drop cross Conducting Sensor m Continuous Load Current m Off-State (Leakage) Current m Minimum Load Current m Inrush Current ( 0 ms, 5% Duty Cycle) Time Delay Before vailability ms Power-On Effect Per IEC Transient Protection Per EN Operating Temperature C to +00 C (-3 F to + F) Enclosure Meets NEM,3,4,6,3 and IEC IP 67 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance LED On Output Energized s Normally Open B Normally Closed Dimensions TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

36 TURCK Inductive Sensors - Harsh Duty -Wire C High Temperature: 00 C S Barrel High Temperature Sensor Plastic Barrel, Partial Threading, Potted-In Cable -Wire C 0-50 VC Normally Open (Z3X) or Normally closed (RZ3X) Sensor Selection Part Number Bi 5-S8-Z3X/S00 Bi0-S30-Z3X/S00 Ni0-S8-Z3X/S00 Ni5-S30-Z3X/S00 Embeddable Barrel Diameter (mm) Normally Open Normally Closed Rated Operating Distance (mm) Drawing # # of LEDs Switching Frequency (Hz) ID Number M M37900 M37800 M Connection meter cable, PVC jacket Bi 5-S8-RZ3X/S00 Bi0-S30-RZ3X/S B B 0 0 M M37300 "/S00" - These sensors will operate up to 00 C ( F) Cable/Conductor Cable: Copper Conductor: (PVC insulated) PVC Jacket; meter standard WG Material Barrel: End Cap: P -GF30 Plastic PUR Plastic ccessories ccessories and mounting devices can be found in "Sensors" catalog. 35 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

37 Specifications Line Frequency Hz Differential Travel (Hysteresis) % (5% typical) Voltage Drop cross Conducting Sensor m Continuous Load Current m Off-State (Leakage) Current m Minimum Load Current m Inrush Current ( 0 ms, 5% Duty Cycle) Time Delay Before vailability ms Power-On Effect Per IEC Transient Protection Per EN Operating Temperature C to +00 C (-3 F to + F) Enclosure Meets NEM,3,4,6,3 and IEC IP 67 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance LED On Output Energized s Normally Open B Normally Closed Dimensions TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

38 TURCK Inductive Sensors - Harsh Duty -Wire C High Temperature: 00 C CP40 High Temperature Sensors Limit Switch Style combiprox -Wire C 0-50 VC Connection Programmable; Normally Open or Normally closed Sensor Selection Part Number Embeddable Rated Operating Distance (mm) Housing Square (mm) Normally Open Normally Closed Drawing # # of LEDs Switching Frequency (Hz) ID Number Connection Bi5-CP40-FZ3X/S M See Quick Disconnect Options below Ni0-CP40-FZ3X/S B 0 M "/S00" - These sensors will operate up to 00 C ( F) Caution n electrical shock hazard exists inside of terminal chamber style sensors whenever power is applied. Remove all power to the sensor whenever sensor wiring is exposed. Quick Disconnect Options For minifast connector: dd -B3 suffix to part number. Suggested cordset: RKM 30-M. For microfast connector: dd -B33" suffix to part number. Suggested cordset: KB 3T-. Material Housing: Sensing Face: PBT-GF30-VO Plastic PBT-GF30-VO Plastic ccessories Mounting bracket LSP- and other accessories can be found in "Sensors" catalog. 37 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

39 Specifications Line Frequency Hz Differential Travel (Hysteresis) % (5% typical) Voltage Drop cross Conducting Sensor V at 00 m Continuous Load Current m Off-State (Leakage) Current m Minimum Load Current m Inrush Current ( 0 ms, 5% Duty Cycle) Time Delay Before vailability ms Power-On Effect Per IEC Transient Protection Per EN Operating Temperature C to +00 C (-3 F to + F) Enclosure Meets NEM,3,4,6,3 and IEC IP 67 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance LED On (Red) Output Energized LED On (Green) Power On Programmable Dimensions TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

40 TURCK Inductive Sensors - Harsh Duty -Wire DC High Temperature: 00 C P Barrel High Temperature Sensors Plastic Barrel, Full Threading, Potted-In Cable -Wire DC, Requires Remote mplifier 5-30 VDC Variable Resistance Output, NMUR (EN 507) NRTL Sensor Selection Part Number Embeddable Rated Operating Distance (mm) Barrel Diameter (mm) Drawing # # of LEDs FM pproved Division ** Time Delay Before vailability (ms) Switching Frequency (Hz) ID Number Connection Bi -P-Y0/S00 Bi 5-P8-Y0/S00 Bi0-P30-Y0/S M03000 M04500 M03300 meter cable, PVC jacket Ni 5-P-Y0/S00 Ni0-P8-Y0/S00 Ni5-P30-Y0/S M0400 M03700 M0700 "/S00" - These sensors will operate up to 00 C ( F) ** Factory Mutual approval applies only when used with Factory Mutual approved switching amplifiers. Note: Y0 and Y have identical electrical properties. See Sensors Catalog for differences in European approvals. Cable/Conductor Cable: Copper Conductor: (PVC insulated) PVC Jacket; meter standard length WG Material Barrel: End Cap: P -GF30 Plastic PUR Plastic ccessories ccessories and mounting devices can be found in "Sensors" catalog. Remote mplifier required. Consult TURCK Isolated Barriers and mplifiers catalog. 39 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

41 Specifications Differential Travel (Hysteresis) % (5% typical) Nominal Voltage VDC (EN 507) Resistance Change from Nonactivated to ctivated k to >8.0 k Resulting Current Change m to.0 m Recommended Switching Point for Remote mplifier m Power-On Effect Realized in mplifier Reverse Polarity Protection Incorporated Wire-Break Protection Realized in mplifier Transient Protection Realized in mplifier Operating Temperature C to +00 C (-3 F to + F) Enclosure Meets NEM,3,4,6,3 and IEC IP 67 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance Dimensions NMUR Output 3 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

42 TURCK Inductive Sensors - Harsh Duty -Wire DC High Temperature: 00 C CP80 High Temperature Sensors Modular Construction -Wire DC, Requires Remote mplifier 5-30 VDC Variable Resistance Output, NMUR (EN 507) NRTL Sensor Selection Part Number Embeddable Rated Operating Distance (mm) Housing Diameter (mm) Drawing # # of LEDs FM pproved Division ** Time Delay Before vailability (ms) Switching Frequency (Hz) ID Number Connection Ni40-CP80-Y0/S M See Quick Disconnect Options below "/S00" - These sensors will operate up to 00 C ( F) ** Factory Mutual approval applies only when used with Factory Mutual approved switching amplifiers. Note: Y0 and Y have identical electrical properties. See Sensors Catalog for differences in European approvals. Quick Disconnect Options For minifast connector:a dd -B4 suffix to part number. Suggested cordset: RKM 40-M For eurofast connector: dd -H4 suffix to part number. Suggested cordset: RK 4.T- Material Housing: PBT-GF30-VO Plastic Terminal Chamber Cover: Trogamid T ccessories ccessories and mounting devices can be found in "Sensors" catalog. Remote mplifier required. Consult TURCK Isolated Barriers and mplifiers catalog. 4 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

43 Specifications Differential Travel (Hysteresis) % (5% typical) Nominal Voltage VDC (EN 507) Resistance Change from Nonactivated to ctivated k to >8.0 k Resulting Current Change m to.0 m Recommended Switching Point for Remote mplifier m Power-On Effect Realized in mplifier Reverse Polarity Protection Incorporated Wire-Break Protection Realized in mplifier Transient Protection Realized in mplifier Operating Temperature C to +00 C (-3 F to + F) Enclosure Meets NEM,3,4,6,3 and IEC IP 67 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance Dimensions NMUR Output TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

44 TURCK Inductive Sensors 3-Wire DC High Temperature: 0 C NEW EM Barrel High Temperature Sensors Metal Barrel, Partial Threading, Potted-In Cable 3-Wire DC 0-30 VDC, Short-Circuit and Overload Protected Normally Open, PNP (Sourcing) Sensor Selection Part Number Embeddable Rated Operating Distance (mm) Barrel Diameter (mm) NPN (Sinking) PNP (Sourcing) Drawing # # of LEDs Switching Frequency (Hz) ID Number Connection Bi -EMD-P6/S0 Bi 5-EM8D-P6X/S0 Bi0-EM30D-P6X/S0 Ni 4-EMD-P6/S0 Ni 7-EM8D-P6X/S0 Ni5-EM30D-P6X/S M4645 M46450 M M6330 M M meter cable, PTFE jacket "/S0" - These sensors will operate up to 0 C (48 F) Cable/Conductor Cable: Copper Conductor: PTFE Jacket; meter standard EM: 4 WG EM8/EM30 WG Material Barrel: Front Cap: Stainless Steel PTFE ccessories ccessories and mounting devices can be found in "Sensors" catalog. 43 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

45 Specifications Ripple % Differential Travel (Hysteresis) % (5% typical) Voltage Drop cross Conducting Sensor V at 50 m (0.3 V typical) Continuous Load Current m Off-State (Leakage) Current <0 µ No-Load Current m Time Delay Before vailability ms Power-On Effect Per IEC Reverse Polarity Protection Incorporated Wire-Break Protection Incorporated Transient Protection Per EN Operating Temperature C to +0 C (-3 F to +48 F) Enclosure Meets NEM,3,4,4x,6,3 and IEC IP 67 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance LED On Output Energized Dimensions PNP (Sourcing) TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

46 TURCK Inductive Sensors 3-Wire DC High Temperature: 60 C NEW EM Barrel High Temperature Sensors Metal Barrel, Partial Threading, Potted-In Cable 3-Wire DC 0-30 VDC, Short-Circuit and Overload Protected Normally Open, PNP (Sourcing) Sensor Selection Part Number Embeddable Rated Operating Distance (mm) Barrel Diameter (mm) NPN (Sinking) PNP (Sourcing) Drawing # # of LEDs Switching Frequency (Hz) ID Number Connection Bi 5-EM8-P6/S907 Bi0-EM30-P6/S M46745 M46453 meter cable, PTFE jacket "/S907" - These sensors will operate up to 60 C (30 F) Cable/Conductor Cable: Copper Conductor: PTFE Jacket; meter standard 4 WG Material Barrel: Connector: Front Face: Stainless Steel Polyamide Plastic PTFE ccessories ccessories and mounting devices can be found in "Sensors" catalog. 45 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

47 Specifications Ripple % Differential Travel (Hysteresis) % (5% typical) Voltage Drop cross Conducting Sensor V at 50 m (0.3 V typical) Continuous Load Current m Off-State (Leakage) Current <0 µ No-Load Current m Time Delay Before vailability ms Power-On Effect Per IEC Reverse Polarity Protection Incorporated Wire-Break Protection Incorporated Transient Protection Per EN Operating Temperature C to +60 C (-3 F to +30 F) Enclosure Meets NEM,3,4,4x,6,3 and IEC IP 67 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance LED On Output Energized PNP (Sourcing) Dimensions TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

48 TURCK Inductive Sensors 3-Wire DC Low Temperature: -40 C S Barrel Low Temperature Sensors Plastic Barrel, Partial Threading, Potted-In Cable 3-Wire DC 0-30 VDC, Short-Circuit and Overload Protected Normally Open, PNP (Sourcing) Sensor Selection Part Number Embeddable Rated Operating Distance (mm) Barrel Diameter (mm) Sinking Sourcing Drawing # # of LEDs Switching Frequency (Hz) ID Number Connection Bi -S-P6X/S97 Bi 5-S8-P6X/S97 Bi0-S30-P6X/S M M M meter cable, Silicon jacket Ni 4-S-P6X/S97 Ni 8-S8-P6X/S97 Ni5-S30-P6X/S M4653 T46560 M46580 "/S97" - These sensors will operate down to -40 C (-40 F) Cable/Conductor Cable: Copper Conductor: Silicon Jacket; meter standard WG Material Barrel: Connector: P -GF30 Plastic Polyamide Plastic ccessories ccessories and mounting devices can be found in "Sensors" catalog. 47 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

49 Specifications Ripple % Differential Travel (Hysteresis) % (5% typical) Voltage Drop cross Conducting Sensor....8 V at 00 m Trigger Current for Overload Protection... 0 m Continuous Load Current m Off-State (Leakage) Current <0 µ No-Load Current m Time Delay Before vailability ms Power-On Effect Per IEC Reverse Polarity Protection Incorporated Wire-Break Protection Incorporated Transient Protection Per EN Operating Temperature C to +70 C (-40 F to +58 F) Enclosure Meets NEM,3,4,6,3 and IEC IP 67 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance LED On Output Energized PNP (Sourcing) Dimensions 3 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

50 TURCK Inductive Sensors 4-Wire DC Low Temperature: -40 C S Barrel Low Temperature Sensors Plastic Barrel, Partial Threading, Potted-In Cable 4-Wire DC 0-65 VDC, Short-Circuit and Overload Protected Normally Open, PNP (Sourcing) Sensor Selection Part Number Embeddable Rated Operating Distance (mm) Barrel Diameter (mm) Sinking Sourcing Drawing # # of LEDs Switching Frequency (Hz) ID Number Connection Bi 5-S8-VP4X/S97 Bi0-S30-VP4X/S M5340 M5 meter cable, Silicon jacket Ni 8-S8-VP4X/S97 Ni5-S30-VP4X/S M535 M540 "/S97" - These sensors will operate down to -40 C (-40 F) Cable/Conductor Cable: Copper Conductor: Silicon Jacket; meter standard WG Material Barrel: Connector: P -GF30 Plastic Polyamide Plastic ccessories ccessories and mounting devices can be found in "Sensors" catalog. 49 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

51 Specifications Ripple % Differential Travel (Hysteresis) % (5% typical) Voltage Drop cross Conducting Sensor....8 V at 00 m Trigger Current for Overload Protection... 0 m Continuous Load Current m Off-State (Leakage) Current <0 µ No-Load Current m Time Delay Before vailability ms Power-On Effect Per IEC Reverse Polarity Protection Incorporated Wire-Break Protection Incorporated Transient Protection Per EN Operating Temperature C to +70 C (-40 F to +58 F) Enclosure Meets NEM,3,4,6,3 and IEC IP 67 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance LED On Output Energized PNP (Sourcing) Dimensions TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

52 TURCK Inductive Sensors 4-Wire DC Low Temperature: -40 C CP40 Low Temperature Sensors Limit Switch and Long Range Style 4-Wire DC 0-65 VDC, Short-Circuit and Overload Protected Complementary Outputs: One N.O., One N.C. (SPDT) CP80 Sensor Selection Part Number Embeddable Rated Operating Distance (mm) Barrel Diameter (mm) Sinking Sourcing Drawing # # of LEDs Switching Frequency (Hz) ID Number Connection Bi5-CP40-VP4X/S M See Quick Disconnect Options below Ni0-CP40-VP4X/S97 Ni40-CP80-VP4X/S M5690 M5695 "/S97" - These sensors will operate down to -40 C (-40 F) Quick Disconnect Options For minifast connector: dd -B4 suffix to part number. Suggested cordset: RKM 40-M For eurofast connector: dd -H4 suffix to part number. Suggested cordset: RK 4.4T- Material Housing: PBT-GF30-VO Plastic Sensing: CP40: PBT-GF30-VO Plastic Terminal Chamber Cover: CP80: Trogamid T ccessories ccessories and mounting devices can be found in "Sensors" catalog. 5 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

53 Specifications Ripple % Differential Travel (Hysteresis) % (5% typical) Voltage Drop cross Conducting Sensor....8 V at 00 m Trigger Current for Overload Protection... 0 m Continuous Load Current m Off-State (Leakage) Current <0 µ No-Load Current m Time Delay Before vailability ms Power-On Effect Per IEC Reverse Polarity Protection Incorporated Wire-Break Protection Incorporated Transient Protection Per EN Operating Temperature C to +70 C (-40 F to +58 F) Enclosure Meets NEM,3,4,6,3 and IEC IP 67 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance LED On Output Energized PNP (Sourcing) Dimensions TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

54 TURCK Inductive Sensors -Wire C Low Temperature: -40 C S Barrel Low Temperature Sensors Plastic Barrel, Partial Threading, Potted-In Cable -Wire C 0-50 VC Normally Open Sensor Selection Part Number Embeddable Rated Operating Distance (mm) Barrel Diameter (mm) Normally Open Normally Closed Drawing # # of LEDs Switching Frequency (Hz) ID Number Connection Bi -S-Z3X/S97 0 M3000 meter cable, Silicon jacket Ni 4-S-Z3X/S M300 "/S97" - These sensors will operate down to -40 C (-40 F) Cable/Conductor Cable: Copper Conductor: Silicon Jacket; meter standard WG Material Barrel: Connector: P -GF30 Plastic Polyamide Plastic ccessories ccessories and mounting devices can be found in "Sensors" catalog. 53 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

55 Specifications Line Frequency Hz Differential Travel (Hysteresis) % (5% typical) Voltage Drop cross Conducting Sensor....0 V at 00 m Trigger Current for Overload Protection... 0 m Continuous Load Current m Off-State (Leakage) Current m Minimum Load Current m Inrush Current ( 0 ms, 5% Duty Cycle) Time Delay Before vailability ms Power-On Effect Per IEC Transient Protection Per EN Operating Temperature C to +70 C (-40 F to +58 F) Enclosure Meets NEM,3,4,6,3 and IEC IP 67 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance LED On Output Energized Normally Open Dimensions TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

56 TURCK Inductive Sensors -Wire C Low Temperature: -40 C CP40 Low Temperature Sensors Limit Switch and Long Range Style -Wire C 0-50 VC Connection Programmable; Normally Open or Normally Closed CP80 Sensor Selection Part Number Embeddable Rated Operating Distance (mm) Barrel Diameter (mm) Normally Open Normally Closed Drawing # # of LEDs Switching Frequency (Hz) ID Number Connection Bi5-CP40-FZ3X/S M3405 See Quick Disconnect Options below. Ni0-CP40-FZ3X/S97 Ni40-CP80-FZ3X/S M3403 M34050 "/S97" - These sensors will operate down to -40 C (-40 F) Caution n electrical shock hazard exists inside of terminal chamber style sensors whenever power is applied. Remove all power to the sensor whenever sensor wiring is exposed. Quick Disconnect Options For minifast connector: dd -B3 suffix to part number. Suggested cordset: RKM 30-M For eurofast connector: dd -B33 suffix to part number. Suggested cordset: KB 3T-. Material Housing: PBT-GF30-VO Plastic Sensing: CP40: PBT-GF30-VO Plastic Terminal Chamber Cover: CP80: Trogamid T ccessories ccessories and mounting devices can be found in "Sensors" catalog. 55 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

57 Specifications Line Frequency Hz Differential Travel (Hysteresis) % (5% typical) Voltage Drop cross Conducting Sensor....0 V at 00 m Trigger Current for Overload Protection... 0 m Continuous Load Current m Off-State (Leakage) Current m Minimum Load Current >5.0 m Inrush Current ( 0 ms, 5% Duty Cycle) Time Delay Before vailability ms Power-On Effect Per IEC Transient Protection Per EN Operating Temperature C to +70 C (- F to + F) Enclosure Meets NEM,3,4,6,3 and IEC IP 67 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance LED On Output Energized Normally Open Dimensions TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

58 TURCK Inductive Sensors -Wire DC Low Temperature: -40 C P Barrel Low Temperature Sensors Plastic Barrel, Full Threading -Wire DC, Requires Remote mplifier 5-30 VDC Variable Resistance Output, NMUR (EN 507) NRTL Sensor Selection Part Number Embeddable Rated Operating Distance (mm) Barrel Diameter (mm) Drawing # # of LEDs FM pproved Division ** Switching Frequency (Hz) ID Number Connection Bi -P-YX/S97 Bi 5-P8-YX/S M40300 M04504 meter cable, Silicon jacket Ni 5-P-YX/S97 Ni0-P8-YX/S M00940 M4035 "/S97" - These sensors will operate down to -40 C (-40 F) ** Factory Mutual approval applies only when used with Factory Mutual approved switching amplifiers. Note: Y0 and Y have identical electrical properties. See Sensors Catalog for differences in European approvals. Cable/Conductor Cable: Copper Conductor: Silicon Jacket; meter standard length P: 4 WG P8: WG Material Barrel: End Cap: P -GF30 Plastic PUR Plastic ccessories ccessories and mounting devices can be found in "Sensors" catalog. Remote mplifier required. Consult TURCK Isolated Barriers & mplifiers catalog. 57 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

59 Specifications Differential Travel (Hysteresis) % (5% typical) Nominal Voltage VDC (EN 507) Resistance Change from Nonactivated to ctivated k to >8.0 k Resulting Current Change m to.0 m Recommended Switching Point for Remote mplifier m Power-On Effect Realized in mplifier Reverse Polarity Protection Incorporated Wire-Break Protection Realized in mplifier Transient Protection Realized in mplifier Operating Temperature C to +70 C (- F to + F) Enclosure Meets NEM,3,4,6,3 and IEC IP 67 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance LED On Output Energized NMUR Output Dimensions TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

60 TURCK Inductive Sensors -Wire DC Low Temperature: -40 C CP40 Low Temperature Sensors Rectangular Style -Wire DC, Requires Remote mplifier 5-30 VDC Variable Resistance Output, NMUR (EN 507) NRTL CP80 Sensor Selection Part Number Embeddable Rated Operating Distance (mm) Housing Diameter (mm) Drawing # # of LEDs FM pproved Division ** Switching Frequency (Hz) ID Number Connection Bi5-CP40-Y0X/S M03970 See Quick Disconnect Options below Ni0-CP40-Y0X/S97 Ni40-CP80-Y0/S M04300 M04000 "/S97" - These sensors will operate down to -40 C (-40 F) ** Factory Mutual approval applies only when used with Factory Mutual approved switching amplifiers. Note: Y0 and Y have identical electrical properties. See Sensors Catalog for differences in European approvals. Quick Disconnect Options For minifast connector: dd "-B4" suffix to part number. Suggested cordset: RKM 40-M For eurofast connector: dd "-H4" suffix to part number. Suggested cordset: RK 4.T Material Housing: PBT-GF30-VO Plastic Sensing: CP40: PBT-GF30-VO Plastic Terminal Chamber Cover: CP80: Trogamid T ccessories ccessories and mounting devices can be found in "Sensors" catalog. Remote mplifier required. Consult TURCK Isolated Barriers & mplifiers catalog. 59 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

61 Specifications Differential Travel (Hysteresis) % (5% typical) Nominal Voltage VDC (EN 507) Resistance Change from Nonactivated to ctivated k to >8.0 k Resulting Current Change m to.0 m Recommended Switching Point for Remote mplifier m Power-On Effect Realized in mplifier Reverse Polarity Protection Incorporated Wire-Break Protection Realized in mplifier Transient Protection Realized in mplifier Operating Temperature C to +70 C (- F to + F) Enclosure Meets NEM,3,4,6,3 and IEC IP 67 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance LED On Output Energized NMUR Output Dimensions TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

62 TURCK Inductive Sensors 3-Wire DC Pressure Resistant G Barrel Pressure Resistant Barrel Sensors, Metal Potted-In Cable and Quick Disconnect 3-Wire DC eurofast 0-30 VDC, Short-Circuit and Overload Protected Normally Open, NPN (Sinking) or PNP (Sourcing) Sensor Selection Part Number Embeddable Rated Operating Distance (mm) Barrel Diameter (mm) NPN (Sinking) PNP (Sourcing) Drawing # # of LEDs Switching Frequency (Hz) ID Number Connection BID-G80-N6/S M68805 meter cable, PVC Jacket BID-G80-P6/S0 8 B M BID-G80-P6-H4/S0 8 C M68850 eurofast Mating Cordsets RK 4T- ( meter) For other styles see Cordsets catalog "/S0" - Potted oscillator head Cable/Conductor Cable: Copper Conductor: PVC jacket; meter standard length 4 WG Material Barrel: End Cap: Stainless Steel P -GF30 Plastic ccessories ccessories and mounting devices can be found in "Sensors" catalog. 6 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

63 Specifications Ripple % Differential Travel (Hysteresis) % (5% typical) Voltage Drop cross Conducting Sensor....8 V at 00 m Continuous Load Current m Off-State (Leakage) Current <0 µ No-Load Current m Pressure Static (.../S) bar (.../S0) Pressure Dynamic (.../S) (.../S0) Power-On Effect Per IEC Reverse Polarity Protection Incorporated Wire-Break Protection Incorporated Transient Protection Per EN Operating Temperature (.../S) C to +70 C (4 F to +58 F) (.../S0) C to +70 C (-3 F to +58 F) Enclosure Meets NEM,3,4,4x,6,3 and IEC IP 67 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance s NPN (Sinking) B PNP (Sourcing) C PNP (Sourcing) Dimensions TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

64 TURCK Inductive Sensors -Wire DC Pressure Resistant G80 Barrel Pressure Resistant Barrel Sensor, Metal Potted-In Cable -Wire DC, Requires Remote mplifier 5-30 VDC Variable Resistance Output, NMUR (EN 507) NRTL Sensor Selection Part Number Embeddable Rated Operating Distance (mm) Barrel Diameter (mm) Drawing # # of LEDs Switching Frequency (Hz) ID Number Connection BID-G80-Y/S M meter cable, PVC jacket BID-G80-Y/S M "/S" - New manufacturing technology (core and coil potted differently) "/S0" - Potted oscillator head Cable/Conductor Cable: Copper Conductor: PVC Jacket; meter standard length Material Barrel: End Cap: P -GF30 Plastic PUR Plastic ccessories ccessories and mounting devices can be found in "Sensors" catalog. Remote mplifier required. Consult TURCK Isolated Barriers & mplifiers catalog. 63 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

65 Specifications Differential Travel (Hysteresis) % (5% typical) Nominal Voltage VDC (EN 507) Resistance Change from Nonactivated to ctivated k to >8.0 k Resulting Current Change m to.0 m Recommended Switching Point for Remote mplifier m Pressure Static (.../S) (.../S0) Pressure Dynamic (.../S) (.../S0) Power-On Effect Realized in mplifier Reverse Polarity Protection Incorporated Wire-Break Protection Realized in mplifier Transient Protection Realized in mplifier Operating Temperature (.../S) C to +70 C (-4 F to +58 F) C to +70 C (-3 F to +58 F) Enclosure Meets NEM,3,4,6,3 and IEC IP 67 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance LED On Output Energized NMUR Output Dimensions TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

66 TURCK Capacitive Sensors 3-Wire DC Noise Immune S Barrel Noise Immune Capacitive Sensors, Plastic Barrel, Partial Threading, Potted-In Cable 3-Wire DC 0-65 VDC, Short-Circuit and Overload Protected Normally Open, NPN (Sinking) or PNP (Sourcing) Sensor Selection Part Number Embeddable NON Embeddable Range Rated Operating Distance (mm) Barrel Diameter (mm) NPN (Sinking) PNP (Sourcing) Drawing # # of LEDs Switching Frequency (Hz) ID Number Connection BCF 5-S8-N4X M5030 meter cable, PVC Jacket BCF 5-S8-P4X B 00 M5030 Cable/Conductor Cable: Copper Conductor: PVC jacket; meter standard length WG, PVC insulated Material Barrel: Sensing Face: End Cap: P -GF30 Plastic P -GF30 Plastic PUR Plastic ccessories ccessories and mounting devices can be found in "Sensors" catalog. 65 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

67 Specifications Ripple % Differential Travel (Hysteresis) % (5% typical) Voltage Drop cross Conducting Sensor....8 V at 00 m Trigger Current for Overload Protection... 0 m Continuous Load Current m Off-State (Leakage) Current <00 µ No-Load Current m Time Delay Before vailability ms Power-On Effect Per IEC Reverse Polarity Protection Yes Wire-Break Protection Yes Transient Protection Per EN Operating Temperature C to +70 C (-3 F to +58 F) Enclosure Meets NEM, 3, and 3 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance Temperature Drift <±0% of Rated Operating Distance LED On Output Energized Immunity to ESD kv Direct/ 30 kv irborne Immunity to RFI V/M, MHz Immunity to Electrical Fast Transients V Immunity to Line Coupled Noise >0 V, 50 khz-30 MHz Immunity to Surges kv, 500 Ω DC s NPN (Sinking) B PNP (Sourcing) Dimensions TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

68 TURCK Capacitive Sensors 4-Wire DC Noise Immune S Barrel Noise Immune Capacitive Sensors, Plastic Barrel, Partial Threading, Potted-In Cable 4-Wire DC 0-65 VDC, Short-Circuit and Overload Protected Complementary Outputs: One N.O., One N.C. (SPDT) Sensor Selection Part Number Embeddable NON Embeddable Range Rated Operating Distance (mm) Barrel Diameter (mm) NPN (Sinking) PNP (Sourcing) Drawing # # of LEDs Switching Frequency (Hz) ID Number Connection BCF0-S30-VN4X M5060 meter cable, PVC jacket BCF0-S30-VP4X B 00 M506 Cable/Conductor Cable: Copper Conductor: PVC jacket; meter standard length WG, PVC insulated Material Barrel: Sensing Face: End Cap: P -GF30 Plastic P -GF30 Plastic P 66-GF5-VO ccessories ccessories and mounting devices can be found in "Sensors" catalog. 67 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

69 Specifications Ripple % Differential Travel (Hysteresis) % (5% typical) Voltage Drop cross Conducting Sensor....8 V at 00 m Trigger Current for Overload Protection... 0 m Continuous Load Current m Off-State (Leakage) Current <00 µ No-Load Current m Time Delay Before vailability ms Power-On Effect Per IEC Reverse Polarity Protection Yes Wire-Break Protection Yes Transient Protection Per EN Operating Temperature C to +70 C (-3 F to +58 F) Enclosure Meets NEM, 3, and 3 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance Temperature Drift <±0% of Rated Operating Distance LED On Output Energized Immunity to ESD kv Direct/ 30 kv irborne Immunity to RFI V/M, MHz Immunity to Electrical Fast Transients V Immunity to Line Coupled Noise >0 V, 50 khz-30 MHz Immunity to Surges kv, 500 Ω DC s NPN (Sinking) B PNP (Sourcing) Dimensions TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

70 TURCK Capacitive Sensors -Wire C Noise Immune NEW S Barrel Noise Immune Capacitive Sensors, Plastic Barrel, Partial Threading, Potted-In Cable and Quick Disconnect -Wire C microfast 0-50 VC Normally Open (Z3X) or Normally Closed (RZ3X) Sensor Selection Part Number Embeddable NON Embeddable Range Rated Operating Distance (mm) Barrel Diameter (mm) Normally Open Normally Closed Drawing # # of LEDs Switching Frequency (Hz) ID Number Connection BCF0-S30-Z3X M50605 meter cable, PVC jacket BCF0-S30-RZ3X B 0 M50603 BCF0-S30-Z3X-B C 0 M5060 microfast BCF0-S30-RZ3X-B D 0 M50604 Mating Cordsets KB 3T- ( meter) For other styles see Cordsets catalog Cable/Conductor Cable: Copper Conductor: PVC jacket; meter standard length WG, PVC insulated Material Barrel: Sensing Face: End Cap: P -GF30 Plastic P -GF30 Plastic P 66-GF5-VO ccessories ccessories and mounting devices can be found in "Sensors" catalog. 69 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

71 Specifications Line Frequency Hz Hysteresis (Differential Travel) % (5% typical) Voltage Drop cross Conducting Sensor V at 500 m Continuous Load Current m Off-State (Leakage) Current m Minimum Load Current m Inrush Current ( 0 ms, 5% Duty Cycle) Time Delay Before vailability ms Power-On Effect Per IEC Transient Protection Per EN Operating Temperature C to +70 C (-3 F to +58 F) Enclosure Meets NEM, 3, and 3 Shock g, ms Vibration Hz, mm mplitude in all 3 Planes Repeatability % of Rated Operating Distance Temperature Drift <±0% of Rated Operating Distance LED On Output Energized Immunity to ESD kv Direct/30 kv irborne Immunity to RFI V/M, MHz Immunity to Electrical Fast Transients V Immunity to Line Coupled Noise >0 V, 50 khz-30 MHz Immunity to Surges kv, 500 ΩC s Normally Open B Normally Closed C Normally Open Dimensions D Normally Closed TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

72 TURCK Inductive Sensors Index BCF 5-S8-N4X BCF 5-S8-P4X BCF0-S30-Z3X BCF0-S30-Z3X-B BCF0-S30-RZ3X BCF0-S30-RZ3X-B BCF0-S30-VN4X BCF0-S30-VP4X Bi -EMD-P6/S Bi -M-P6X/S Bi -P-Y0/S Bi -P-YX/S Bi -S-N7X/S Bi -S-P6X/S Bi -S-P7X/S Bi -S-Z3X/S Bi 3-EMWD-N6X Bi 3-EMWD-N6X-H Bi 3-EMWD-P6X Bi 3-EMWD-P6X-H Bi 5-EM8-N6XLD Bi 5-EM8-P6/S Bi 5-EM8-P6XLD Bi 5-EM8D-P6X/S Bi 5-M8-P6X/S Bi 5-P8-N6/S39-S Bi 5-P8-N6X-B34/S Bi 5-P8-P6/S39-S Bi 5-P8-P6X-B34/S Bi 5-P8-Z3/S39-S Bi 5-P8-Z3X-B33/S Bi 5-P8-RZ3X-B33/S Bi 5-P8-Y0/S Bi 5-P8-YX/S Bi 5-S8-N7X/S Bi 5-S8-P6X/S Bi 5-S8-P7X/S Bi 5-S8-Z3X/S Bi 5-S8-RZ3X/S Bi 5-S8-VP4X/S Bi 5-S8-VP4X/S Bi 7-EM8WD-N6X Bi 7-EM8WD-N6X-H Bi 7-EM8WD-P6X Bi 7-EM8WD-P6X-H Bi0-EM30-N6XLD Bi0-EM30-P6/S Bi0-EM30-P6XLD Bi0-EM30D-P6X/S Bi0-M30-P6X/S Bi0-P30-N6X-B4/S Bi0-P30-P6X-B4/S Bi0-P30-Z3X-B3/S Bi0-P30-RZ3X-B3/S Bi0-P30-Y0/S Bi0-S30-N7X/S Bi0-S30-P6X/S Bi0-S30-P7X/S Bi0-S30-Z3X/S Bi0-S30-RZ3X/S Bi0-S30-VP4X/S Bi-EM30WD-N6X Bi-EM30WD-N6X-H Bi-EM30WD-P6X Bi-EM30WD-P6X-H Bi5-CP40-FZ3X/S Bi5-CP40-FZ3X/S Bi5-CP40-VN4X/S Bi5-CP40-VP4X/S Bi5-CP40-VP4X/S Bi5-CP40-Y0X/S BID-G80-N6/S BID-G80-P6/S BID-G80-P6-H4/S BID-G80-Y/S BID-G80-Y/S Ni 4-EMD-P6/S Ni 4-M-P6X/S Ni 4-S-N7X/S Ni 4-S-P6X/S Ni 4-S-P7X/S Ni 4-S-Z3X/S Ni 5-EMWD-N6X Ni 5-EMWD-N6X-H Ni 5-EMWD-P6X Ni 5-EMWD-P6X-H Ni 5-P-Y0/S Ni 5-P-YX/S Ni 7-EM8D-P6X/S Ni 8-M8-P6X/S Ni 8-S8-N7X/S Ni 8-S8-P6X/S Ni 8-S8-P7X/S Ni 8-S8-VP4X/S Ni0-EM8WD-N6X Ni0-EM8WD-N6X-H Ni0-EM8WD-P6X Ni0-EM8WD-P6X-H Ni0-P8-Z3X-B33/S Ni0-P8-Y0/S Ni0-P8-YX/S Ni0-S8-Z3X/S Ni5-EM30D-P6X/S Ni5-M30-P6X/S Ni5-P30-Y0/S Ni5-S30-N6X/S Ni5-S30-N7X/S Ni5-S30-P6X/S Ni5-S30-P7X/S Ni5-S30-Z3X/S Ni5-S30-VP4X/S Ni0-CP40-FZ3X/S Ni0-CP40-FZ3X/S Ni0-CP40-VN4X/S Ni0-CP40-VP4X/S Ni0-CP40-VP4X/S Ni0-CP40-Y0X/S Ni0-EM30WD-N6X Ni0-EM30WD-N6X-H Ni0-EM30WD-P6X Ni0-EM30WD-P6X-H Ni40-CP80-FZ3X/S Ni40-CP80-VP4X/S Ni40-CP80-Y0/S Ni40-CP80-Y0/S TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

73 Notes: TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

74 TURCK Inductive Sensors Notes: 73 TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

75 TURCK Inc. sells its products through uthorized Distributors. These distributors provide our customers with technical support, service and local stock. TURCK distributors are located nationwide - including all major metropolitan marketing areas. For pplication ssistance or for the location of your nearest TURCK distributor, call: PROX ( ) Specifications in this manual are subject to change without notice. TURCK also reserves the right to make modifications and makes no guarantee of the accuracy of the information contained herein. Literature and Media questions or concerns? Contact Marketing Services TURCK US - media@turck.com TURCK Inc Campus Drive Minneapolis, MN 5544 pplication Support: PROX Fax: (763)

76 The Industry Leader in Proximity Sensing, Cordsets and Interface Technology Flow and Temperature Monitors Pressure Sensors Proximity Sensors Cordsets RFID Order B055 Order B058 EZ-track Encoders Order B000 Picoprox Order B00 Order B4900 Capacitive WeldGuard Order B030 Order B3050 Order B047 Contact TURCK for the Latest Literature: Sensors Division - sensors@turck.com Cordset Division - cordset@turck.com Intrinsic Safety Division - barriers@turck.com Toll Free PROX (7769) Order B049 Order B078 TURCK US TURCK Canada TURCK Mexico TURCK Inc Campus Drive Minneapolis, MN 5544 CHRTWELL ELECTRONICS, INC. 40 Duffield Drive TURCK Mexico S. de R.L. de C.V. Carr. Saltillo-Zacatecas km 4.5 s/n Parque Industrial La ngostura Phone: (763) Markham, Ontario Saltillo, COH. CP FX: (763) Canada, L6G B5 Phone: 0 5 (844) pplication Support: Phone: (905) FX: 0 5 (844) PROX (7769) FX: (905) Toll Free: TURCK (Mexico only) ( ) B065 6/03