Stand-On Spreader/Sprayer

Transcription

1 Form No Rev A Stand-On Spreader/Sprayer Model No Serial No and Up Register at Original Instructions (EN) * * A

2 Ordering Replacement Parts To order replacement parts, please supply the part number, the quantity, and the description of each part desired. Understanding Reference Numbers Each identified part in an illustration has a reference number. The reference number for a part also appears in the parts list, along with other information about the part. This catalog uses two special reference number formats, one to indicate parts in a service assembly and another to indicate the quantity of a given part in an illustration. Service Assembly Reference Numbers Parts in service assemblies have reference numbers in the form a:b. The a represents the reference number of the entire service assembly and the b represents a sequential number unique to each part within the service assembly. For example, a wheel assembly might be identified by reference number 6, the tire by 6:1, the valve by 6:2, and the wheel by 6:3. When you order the assembly identified by reference number 6, you receive all parts identified by reference numbers 6:1,6:2, and 6:3. However, you may also order any part individually. Reference numbers of this type appear in illustration and in parts lists. Reference Numbers Indicating Quantity In an illustration, if a reference number indicates more than one part, the reference number has the form nx y. The n represents the quantity of the part, the X is the multiplication symbol, and the y represents the reference number. For example, in an illustration, the reference number 2X 37 means that two of the parts identified by reference number 37 are indicated. List of Abbreviations AR: as required ASM: assembly BBC: blade brake control BHTF: button head thread forming CARR: carriage CCW: counter clockwise CW: clockwise DEG: degrees DPA: Dual Point Adjustment ECM: electronic control module EXT: external FH: flat head GA: gauge HD: heavy-duty HF: hex flange HH: hex head HHF: hex head flange HHFTF: hex head flange thread forming HJ: hex jam HLH: hex lag head HOC: height-of-cut HP: high pressure HSBH: hex socket button head HSFH: hex socket flat head HSH: hex socket head HWH: hex washer head HWHTF: hex washer head thread forming HYD: hydraulic LH: left hand LP: low pressure LPG: Liquefied Petroleum Gas NI: nylon insert NPTF: national pipe thread fine PFH: phillips flat head PPH: phillips pan head PPHTF: phillips pan head thread forming PRH: phillips round head PTH: phillips truss head PTO: power-take-off RH: right hand ROPS: roll-over protection system RRB: rear roller brush SFH: slotted fillister head SHH: slotted hex head SHWH: slotted hex washer head SPH: slotted pan head SQH: square head SRH: slotted round head STD: standard TAP: self tapping TTH: torx truss head 2

3 Contents Frame Assembly Knee Pad Assembly Steering Assembly Steering Linkage Assembly No Ground Drive Assembly Transaxle Cover Assembly No Engine Assembly Electrical Assembly Spray System Assembly Sprayer Tank Assembly No Strainer Assembly No Control Valve Manifold Assembly Spray Manifold Assembly No Hose Assembly No Hose Assembly No Left Nozzle Assembly No Right Nozzle Assembly No Center Nozzle Assembly No Spreader Assembly Spreader Hopper Assembly Side Deflector Assembly The Toro Company 8111 Lyndale Avenue South Bloomington, MN Contact us at Printed in the USA. All Rights Reserved

4 Frame Assembly A 4 A2

5 Frame ASM 1: Bearing-Flanged 1: Bearing-Flanged 1: Decal-Tie Down Control Tower ASM 2: Decal-Control 2: Decal-Service Aid 2: Decal-Logo, Toro 2: Access Panel W/ Decal 2:5: Panel-Access 2:5: Decal-Toro 2: Screw-HWH Washer Screw-HH Nut-HF Screw-HWH Guard-Lower Frame Assembly (continued) Screw-CARR Nut-HF Bumper-Rubber Bumper-Rubber Operator Platform ASM Bushing-Pivot, Platform Screw-CARR Spring Pin-Latch Knob-Ball Mount-Pad, Knee Receptacle-Clip, Mini 20 1 Knee Pad ASM Shield-Dust Grommet Grommet Plug-Tube Not serviced separately A

6 Knee Pad Assembly A 6 A2A1

7 Bracket-Pad, Knee Pad-Knee, Center Pad-Knee, Side (LH) Pad-Knee, Side (RH) Knee Pad Assembly (continued) Screw-HHF Washer-Flat Stud-1/4 Turn Retainer-Stud A

8 Steering Assembly A 8 B2

9 Front Axle ASM 1: Bearing-Sleeve 1: Zerk-Grease Washer-Flat Nut-Hex, NI Steering Shaft ASM 4: Zerk-Grease Washer-Thrust Front Axle ASM Arm-Steering Washer Steering Linkage ASM Screw-HH, Lock Washer-Belleville Wheel And Tire ASM 13: Wheel ASM 13:1: Bearing-Ball 13:1: Spacer 13: Tire 13: Stem-Valve 13: Fitting-Grease Bumper-Front Steering Assembly (continued) Screw-CARR Nut-HF Key-Woodruff Motion Handle ASM 18: Decal-Warning Motion Handle ASM 19: Bearing Shaft-Pivot, Speed Control Spacer-Shaft, Drive Lever Screw-HHF Panel-Rear, Steering Screw-HWH Rod End-Ball Joint Screw-HH Nut-HF Cable-Motion Tie-Plastic Bumper-Rubber Screw-HH Nut-Hex Spacer-Relief A

10 Steering Linkage Assembly No A 10 B2A2

11 Steering Linkage Assembly No (continued) Rod-Linkage, Steering Rod-End, RH Nut-Hex Rod-End, LH Nut-Hex, LH A

12 Ground Drive Assembly A 12 C2

13 Ground Drive Assembly (continued) Transaxle Screw-CARR Nut-HF Wheel And Tire ASM 4: Wheel 4: Tire 4: Stem-Valve Washer-Nylon Screw-HH, Lock Spacer-Shaft, Input Washer-Spring Hub-Shaft, Transaxle Washer-Plain Ring-Retaining Spacer-Coupling, Rubber Coupling-Rubber Screw-HH Washer-Flat Nut-Hex Shaft-Drive Spacer-Coupler, Rubber Screw-HH Hub-Shaft, Engine Setscrew Arm-Motion Pin-Spiral Arm-Release Screw-HH Nut-HF Arm-Brake Screw-HH Nut-HF Brake Lever ASM 30: Bearing-Flange Bolt-Shoulder Rod End-Ball Joint Washer-Spring Screw-HH Nut-Jam Washer-Flat Spring-Compression Spacer Screw-HH Bracket-Mount, Tank Screw-CARR Fitting-90 DEG Tank ASM 43: Cap-Tank Hose-Expansion Clamp Receptacle-Clip, Mini Transaxle Cover ASM Fan-7 Inch Spacer-Wheel Screw-Set, SQH Spacer-Transaxle Nut-Flange, NI A

14 Transaxle Cover Assembly No A 14 C2A3

15 Transaxle Cover Assembly No (continued) 1 1 Cover-Transaxle Washer-Flat Stud-1/4 Turn Retainer-Stud Decal-Brake, Park Decal-Release, Drive Not serviced separately A

16 Engine Assembly A 16 D2

17 1 1 Engine-Subaru, Ex Key-Crankshaft Extender-Dipstick Regulator Screw-HHF Nut-HF Valve-Oil Drain Heat Shield ASM Screw-HHF, Lock Engine Assembly (continued) Screw-HHF Screw-CARR Nut-HF Control-Throttle Bolt-CARR Nut-Lock, NI Cable-Choke, Push/Pull Decal-Arrester, Spark Not serviced separately A

18 Electrical Assembly A 18 E2

19 Ignition Switch ASM 1: Nut-Mounting 1: Ignition Key Set 1: Washer-Backup Hour Meter Controller-Dc Screw-HWHTF Switch-Bail Fuse Bracket ASM 6: Decal-Fuse Harness-Wire 7: Fuse-Mini Blade, 20 Amp 7: Relay-Micro 7: Cap-Power Distribution Module Electrical Assembly (continued) 7: Clip-Power Distribution Module 7: Block-Foam Tie-Plastic Battery Box 10 1 Battery (300 Cca, Wet) Cable-Battery, Positive 11: Insulator-Solenoid 11: Insulator-Battery Cable-Battery, Negative Screw-HHF Nut-HF Screw-HHF Not serviced separately Use dielectric grease on all unsealed connectors and terminals only. Do not apply in sealed connectors A

20 Spray System Assembly A 20 F2

21 Spray System Assembly (continued) Tank-Sprayer Bumper-Rubber (W/ Stud) Nut-HF Clamp Screw-HHF Nut-HF Pump-Diaphragm, 3.8 Gpm Screw-SHWH Nut-HF Fitting-Elbow, Barbed Strainer ASM Screw-HHF Hose-Water Clamp Hose-Water Gauge-Pressure Fitting-Tee 18 1 Wand Control ASM 18: Valve-Ball 18: Fitting-Elbow-90 18: Fitting-Elbow Bracket-Valve Bolt-CARR Nut-Lock, NI 22 1 Control Valve Manifold ASM Screw-HWH Spacer-Mount, Manifold Clamp Cover-Controls 28: Decal-Control, Lever Hose-Water, 3/8 Pvc Red Hose-Coiled Clamp-R Spray Wand ASM 32: Strainer-Nozzle, 50M 5Psi Check Clamp Holder-Wand Tie-Plastic Left Nozzle Sub ASM Hose ASM 37: Hose-Water 37: Fitting-Tee 37: Clamp Right Nozzle Sub ASM Center Nozzle Sub ASM Clamp-R, Double Screw-HHF Clip-Loom Clamp-Hose Elbow-90 DEG Microvalve Plug Elbow-Hosebarb Washer-Flat Screw-HH Screw-TAP Clamp Fitting-Elbow Sleeve-Corrugated, Split Grommet Not serviced separately A

22 Sprayer Tank Assembly No A 22 F2A4

23 Sprayer Tank Assembly No (continued) 1 1 Tank-Sprayer Cap-Water, 5 Inch Vent Fitting-Bulkhead Fitting-Bulkhead Elbow-90 DEG Nipple Tee Elbow-90 DEG Nipple-Short Nozzle-Agitation Nut Lanyard-Cap, Self Anchoring (12 Inch) Not serviced separately A

24 Strainer Assembly No A 24 F2A5

25 Strainer Assembly No (continued) Strainer-Line 1: Gasket-Head, Line Strainer 1: Screen-Strainer, 30 Mesh Ss 1: Bowl-Strainer Elbow-Hosebarb Elbow Valve-Ball A

26 Control Valve Manifold Assembly A 26 F2A6

27 Control Valve Manifold Assembly (continued) Spray Manifold Assembly Crossmember-Column Screw-HWH Hose ASM Clamp Clamp Hose ASM Hose-Water Hose-Water Nut-HF Clip-Loom A

28 Spray Manifold Assembly No A 28 F2A7

29 Spray Manifold Assembly No (continued) Regulator Flynut Assembly 2: O-Ring Kit, Regulator Inlet Barb Flynut Assembly 3: O-Ring Kit, Regulator Outlet Barb Valve Assembly W/ O-Ring 4: O-Ring Kit, Valve Inlet 4: Lever And Pin Assembly 4: Wireform Retainer Kit Hose Barb O-Ring Kit, Regulator Flange O-Ring Kit, Valve Outlet Barb A

30 Hose Assembly No A 30 F2A8

31 Hose Assembly No (continued) Hose-Water Hose-Water Fitting-Tee Hose-Water Clamp Clamp A

32 Hose Assembly No A 32 F2A9

33 Hose Assembly No (continued) Fitting-Elbow Connector-Tee Hose-Water Hose-Water Hose-Water Clamp Clamp A

34 Left Nozzle Assembly No A 34 F2B1

35 Left Nozzle Assembly No (continued) LH Nozzle Body ASM 1: Nut-Nylon Strainer-Tip Gasket-Seal Nozzle-Spray, White Cap-Nozzle Nozzle-Spray, Blue Nozzle-Spray, Brown Nozzle-Spray, Gray Nozzle-Spray, Red Not illustrated Sold separately A

36 Right Nozzle Assembly No A 36 F2B2

37 Right Nozzle Assembly No (continued) RH Nozzle Body ASM 1: Nut-Nylon Strainer-Tip Gasket-Seal Nozzle-Spray, White Cap-Nozzle Nozzle-Spray, Blue Nozzle-Spray, Brown Nozzle-Spray, Gray Nozzle-Spray, Red Not illustrated A

38 Center Nozzle Assembly No A 38 F2B3

39 Center Nozzle Assembly No (continued) RH Nozzle Body ASM 1: Nut-Nylon Strainer-Tip Gasket-Seal Nozzle-Spray, Red Cap-Nozzle Nozzle-Spray, Gray Nozzle-Spray, White Nozzle-Spray, Brown Nozzle-Spray, Blue Not illustrated Sold separately A

40 Spreader Assembly A 40 G2

41 Spreader Assembly (continued) 1 1 Spreader Hopper ASM Washer Washer-Lock Screw-HH Spinner-Spreader Spinner Clip 7 1 Side Deflector ASM Pin-Deflector Washer-Flat Pin-Cotter, Hair Spring-Extension Rod-Control, Deflector Nut-HF Knob-Rate, Flow Grommet Bracket-Cover, Front (LH) Bracket-Cover, Front (RH) Screw-CARR Nut-HF Cover-Front, Spreader/Sprayer Mount-Handle Screw-HWH Lever-Spread, Wide Lever-Spread, Narrow Spacer Nut-HF Screw-HH Link-Adjust, Narrow Spring-Compression, Bail Stop-Spread, Narrow Nut-Coupler Knob Rod End-Ball Joint Screw-HH Ball-Joint Nut-Hex, NI Cable Cover-Hopper Knob-T Nut-Retainer, U Style Nut-Retainer, U Style Washer-Flat Pin-Cotter Cable-Control, Turn Lock Washer-Flat Post-Hex, Diffuser Guide Screw-HH Not serviced separately A

42 Spreader Hopper Assembly A 42 G2B4

43 Spreader Hopper Assembly (continued) Hopper-Spreader Bracket-Mount, Motor Washer-Flat Screw-HH Nut-HF Spreader Motor ASM 6: Spacer-Flanged 6: Washer-Flat 6: Washer-Lock, Int 6: Screw-SHWH Spacer Cover-Motor Agitator Mulch Plate W/ Bearing ASM 11: Bearing-Bottom, Hopper Washer-Lock, Int Bracket-Hopper, Gate Controls Washer Spacer Bracket-Diffuser Nut-HJ, NI Rod-Control, Diffuser Screw-PPH Bracket-Spring, Hopper Deflector Screw-HH Bracket-Lever, Hopper Gate Washer-Felt Guide-Rate, Gate Diffuser Pin-Clevis Pin-Cotter, Hair Rate Dial ASM 30: Mount-Dial 30: Dial 30:3 1 Rate Gate Link ASM 30:3: Link-Gate, Rate 30:3: Screw-Shoulder, Slotted 30: Clip Gate-Rate Lever-Gate Screen-Hopper-Large Hole Screen-Hopper-Medium Hole Screen-Hopper-Small Hole Clamp-Loop Washer-Flat Not serviced separately A

44 Side Deflector Assembly A 44 G2B5

45 Side Deflector Assembly (continued) Bracket-Deflector, Side Screw-HH Deflector-Side Nut-HF Washer-Flat A

46 Notes:

47 Notes:

48