ELASTRIX LLC 95,591 + /- Square Feet on /- acres Pilot Mountain, North Carolina

Size: px

Start display at page:

Download "ELASTRIX LLC 95,591 + /- Square Feet on /- acres Pilot Mountain, North Carolina"

Lauren Douglas
5 years ago
Views:

ELASTRIX LLC 95,591 + /- Square Feet on 19.

1 ELASTRIX LLC 95,591 + /- Square Feet on /- acres Pilot Mountain, North Carolina

450 CONDITION OF PROPERTY: Very good DATE OF CONSTRUCTION: 1984 and 1994 CONSTRUCTION:

concrete The addition is 5 concrete reinforced with fiber on 4 stone Walls: Insulated

2 ELASTRIX, LLC 523 SOUTH STEPHENS ST. PILOT MOUNTAIN, NC SIZE: GROUND: NUMBER OF BUILDINGS: DIMENSIONS: Approximately 95,591 sq. ft. Approximately acres One, modern single story industrial facility The main production area is 200 x 450 CONDITION OF PROPERTY: Very good DATE OF CONSTRUCTION: 1984 and 1994 CONSTRUCTION: COLUMN SPACING: CEILING HEIGHT: LIGHTING: Floor: Original building is 6 reinforced concrete The addition is 5 concrete reinforced with fiber on 4 stone Walls: Insulated metal with 7 foot interior metal linerr panel Columns: Steel Roof: Insulated standing seam metal 25 x 50 Approximately 18 clear eaves and 21 clear center below main structural steel T8 and T5 fixtures on sensors installed in 2013

3 ELASTRIX, LLC PILOT MOUNTAIN, NC PAGE 2 WATER: SEWER: POWER: HVAC: SPRINKLER: COMPRESSED AIR: OFFICE: Supplied by Town of Pilot Mountain 8 main; 6 fire line Supplied by Pilot Mountain 18 main; 4 line Supplied by Duke Power Company - Original building has 2,500 AMP, 480/277 volt, 3 phase, 4 wire switch gear served by a company owned 1500 KVA exteriorr pad mounted transformer - Additional 4,000 AMP, 480/277 volt, 3 phase, 4 wire switch gear was added later, served by a 2000 KVA company owned pad mounted exterior transformer AMP, 1,200 AMP, and 2,000 AMP bus bars in the production area Office areas aree heated and cooled by package units. The plant areaa is ventilated by wall fans and louvers. Two 30 ton pad mounted air conditioning units cool a 10,000 sq. ft. interiorr isolated room on the east wall. One unit was purchased in % wet system density is.3/2000 Ingersoll Rand 25HP compressor, air dryer, air tank and air lines throughout the manufacturing area Approximately 2,500 sq. ft. of attached front office including reception area, private offices, conferencee room and open administrative areas. There are additional breakroom and production offices and restrooms inside the plant area.

4 ELASTRIX, LLC PILOT MOUNTAIN, NC PAGE 3 TRUCK LOADING: North wall Four 8 x 10 manual overhead doors with levelers and seals South wall Two 8 x 8 manual overhead doors with levelers and seals; one 8 x 10 dock high door with seal and no leveler and one 10 x 10 manual dock high door with seal and no leveler West wall One 12 x 12 manual drive-in door East wall One 9 x 10 manual drive-in door PARKING: RESTROOMS: Paved and marked parking for approximately 93 cars Office: Men 1 toilet, 1 urinal, 2 sinks Women 2 toilets, 2 sinks Plant: Men 3 toilets, 1 urinal, 4 sinkss Women 4 toilets, 3 sinks FORMER USE: ZONING: TAXES: Textile printing and rubber recycling General Manufacturing Parcel ID # , and Assessedd Value (next assessment 2020) Building and improvements: $534,520 Land: $200,540 Total: $735, Surry County tax rate: 2016 Town of Pilot Mountain tax rate: 2016 Pilot Mountain fire tax rate: $.582/$1000 $.57/$100 $.04/$100

5 ELASTRIX, LLC PILOT MOUNTAIN, NC PAGE 4 RAIL: TRANSPORTATION: MISCELLANEOUS: Yadkin Valley Railroad borders the site and service is possible The facility is located approximately one mile east of exit 134 on Interstate 74 - Extensive process cooling system in place including pumps and a cooling tower - Lined lagoon on site formerly used to aerate process wastewater before discharge into the Town sewer system - The building has an Ethernet network with sufficient repeaters to allow plant wide cable access - The building has a Mitel 5000 PBX and 4 handsets - Four of the seven front offices are fully furnished and offices have Ethernet cabling The building also includes a fully furnished conference room - Access to the building is protected by a fence with a time and remote operated electric gate - Building has a burglar/fire alarm system and an external videoo surveillancee system - Front office has a shower and rec room

2013 LIGHTING REPLACEMENT PROJECT Fixt. KWH Area Qty Rate Watts Front Office *4100k, Univ. Voltage 4' 2L T8 LPB Retro. 12 0.055 39 4' 4L 25w T8 LPB Retro. 40 0.055 78 13w CFL 1 0.

9 2013 LIGHTING REPLACEMENT PROJECT Fixt. KWH Area Qty Rate Watts Front Office *4100k, Univ. Voltage 4' 2L T8 LPB Retro ' 4L 25w T8 LPB Retro w CFL Old Main Factory Section *5000k, Univ. Voltage 4' 4L T5 HPB w/ Sensor ' 4L 25w T8 LPB Retro w CFL Treatment Mfg.Section *5000k, Univ. Voltage 4' 4L T5 HPB w/ Sensor Relamp to 49w 5000k Back Bay *5000k, Univ. Voltage 8' 4L 32w T8 HPB WR Kit Interior Offices *4100k, Univ. Voltage 4' 4L 25w T8 LPB Retro ' 25w T8 LPB Retro New Main Factory Section *5000k, 480v 4' 4L T5 HPB w/ Sensor Up & Down Mixer Room *5000k, Univ. Voltage, redesign 4' 4L T12 Rec ' 2L T *Lamp life iof 35,000+ hours *Higher light levels and better quality of light *Lamp warranty of 2 years and ballast warranty of 5 years *When using a sensor, we have estimated a savings of 50%

CECO BUILDING SYSTEMS

Picture does not reflect current roof condition CECO BUILDING SYSTEMS 249,312 + /- Square Feet on 19.51 + /- acres Rocky Mount, North Carolina PRELIMINARY CECO BUILDING SYSTEMS 100 RED IRON ROAD ROCKY