L70C VOLVO WHEEL LOADER. Contronic monitoring system

Transcription

1 VOVO W OR 70 ngine output S J1349: gross 96 kw (130 hp) net 90 kw (122 hp) Operating weight: 10,51 t ucket volume: 5,0 m 3 Volvo transmission with S II 2nd generation utomatic ower Shift with mode selector optimises performance Wet disc brakes fully sealed oil-circulation cooled, outboard mounted Torque arallel inkage high breakout torque throughout the working range excellent parallel lift-arm action are ab pressurized cab with high comfort and safety ontronic monitoring system oad-sensing working hydraulics and steering system ilot-operated working hydraulics Optional equipment ydraulic attachment bracket ower take-off for hydraulically powered attachments oom Suspension System

2 SRVI ontronic monitoring system provides information on machine condition, routine maintenance schedules and minimizes time required for troubleshooting. Service accessibility: arge, easy-to-open engine access doors with gas struts. Swing-out radiator grille and radiator. uel tank... ngine coolant... ydraulic tank l 40 l 65 l NGIN Transmission... ngine oil... xle front / rear l 16 l 24/24 l ngine delivers high torque and quick response at low rpm even under full load. The machine can work at low engine speeds, which contributes to good fuel economy, less noise, less wear and longer life. ngine: igh performance, low emission 6-cylinder, in-line, direct-injected, turbocharged, intercooled 4-stroke diesel engine with wet replaceable cylinder liners. ir cleaning: three-stage. ngine Volvo T 63 K lywheel output at... S J1349 gross... S J1349 net... Max. torque at... S J1349 gross... S J1349 net... isplacement r/s (2 100 r/min) 96 kw (130 hp) 90 kw (122 hp) 18,3 r/s (1 100 r/min) 615 Nm 610 Nm 5,48 l TRI SYSTM ontronic monitoring system with complete information on the status of the machine s various systems is standard. lectrical system with circuit board is well protected by fuses. repared for retrofitting of optional equipment. entral warning: entral warning lamp for the following functions: engine oil pressure, engine coolant temperature (with buzzer), hydraulic oil pressure in transmission, transmission oil temperature, brake pressure, parking brake (buzzer), hydraulic oil level. Nm Volvo T 63 K r/min r/s Voltage... atteries... attery capacity... old cranking capacity, ea... Reserve capacity, ea... lternator rating... Starter-motor output V 2x12 V 2x105 h min W / 60 5,4 kw (7,3 hp) RIVTRIN rivetrain and working hydraulics well-matched to each other. Reliable design. Quick acceleration boosts productivity. Volvo system-compatible design facilitates servicing. Torque converter: Single-stage Transmission: Volvo ower Shift transmission of countershaft type with single-lever control. ast and smooth forward/ reverse shifting. Shifting system: Volvo utomatic ower Shift (S II) with mode selector. xles: Volvo, fully floating axle shafts with planetary-type hub reductions. ast-steel axle housing. ixed front axle and oscillating rear axle. 100 % differential lock on front axle (option). Transmission... Torque multiplication... Speeds, max forward/reverse (forward only)... Measured with tires... ront axle... Oscillation, rear axle... Ground clearance at 13 oscillation... RK SYSTM Volvo T 90 2,85:1 igh ow (option) 7,0 km/h km/h 14,0 km/h 3,7 km/h 26,0 km/h 7,3 km/h 44,0 km/h 13,6 km/h 20.5 R25* 2 Volvo / W 15 ± Simple, reliable system with few parts ensures high availability and safety. Self-adjusting internal oil circulationcooled disc brakes give long service intervals. Service brakes: Volvo, dual-circuit system with nitrogencharged accumulators. ully hydraulically operated enclosed internal oil circulation-cooled disc brakes. Transmission declutch during braking can be preselected by a switch on the instrument panel. arking brake: Mechanically operated drum brake on front axle input shaft. Secondary brake: ither of the service brake circuits or the parking brake fullfills the safety requirements. Standards: The brake system complies with the requirements of ISO 3450, S J1473 Number of discs/wheel... Number of accumulators... Volume, each ,5 l

3 STRING SYSTM ow-effort steering gives short work cycle times. owerefficient system provides good fuel economy, good directional stability and smooth ride. Steering system: oad-sensing hydrostatic articulated steering. System supply: The steering system has prioritized feed from the machine s load-sensing axial piston pump. ump: ouble variable-flow axial piston pump. ylinders: Two double-acting cylinders. Steering cylinders... ore... iston rod diameter... Stroke... Relief pressure... Max. flow... rticulation... are ab with easy entry and wide door opening. ined with sound-absorbent material. Sound- and vibration-suppressing suspension. Good all round visibility, large glass areas. urved windshield of laminated, green-tinted glass. rgonomically located controls and instruments permit a comfortable operating position. Instrumentation: ll information important to the operator is readily visible in front of him. ab display* for ontronic monitoring system. (*Option) eater and defroster: eating element with filtered fresh air and four-speed fan. efroster outlets for all windows. Operator s seat: Spring suspended, adjustable operator s seat with belt. The seat is mounted on a bracket on the rear wall. The force from the belt is absorbed by the seat rails. Standards: Tested and approved according to the following standards: ROS (ISO/ 3471, S J1040), OS (ISO 3449, S J231). omplies with Overhead guards for rider lift trucks (ISO 6055) and Operator Restraint System (S J386). mergency exits... Sound level in cab... as per ISO 6396, max fan position... fan position 2... Ventilation... eating capacity... ir conditioning (optional) Ma 80 l/min ± d () 68 d () 10 m 3 /min 11 kw ( tu/h) 8 kw ( tu/h) YRUI SYSTM oad-sensing hydraulics distribute exactly the quantity of oil required for the function used. oad-sensing gives precise control of the hydraulics throughout the lifting range. igh pump capacity provides quick movements. ump: The load-sensing double axial piston pump adjusts the oil requirements of the function used via indication through a load-sensing line. The flow is directed to the function used via a central valve block. Steering function always has priority. Valve: ouble-acting 2-spool valve. The control valve is actuated by a 2-spool pilot valve. ift function: The valve has four functions: raise, hold, lower and float. Inductive/magnetic automatic boom kickout can be switched on and off and is adjustable to any position between maximum reach and full lift height. Tilt function: The valve has three functions: rollback, hold and dump. Inductive/magnetic automatic bucket positioner, that can be switched on and off. ylinders: ouble-acting ilter: ull-flow filtration through 20 µm (absolute) filter cartridge. xial piston pump Relief pressure... low... at... and engine speed... ilot system Relief pressure... ycle times Raise*... ump*... ower, empty... Total cycle time... * with load as per ISO 5998 and S J818 IT-RM SYSTM 26,0 Ma 160l/min 10 Ma 36,7 r/s (2 200 r/min) 3,0 Ma 5,1 s 1,3 s 3,0 s 9,4 s T inkage combines high breakout torque throughout the working range with nearly exact parallel lift-arm action. These features together with high lift height and long reach make the lift-arm system equally as good in bucket loading as in work with fork attachments and material handling arms. ift cylinder... 2 ore iston rod diameter Stroke Tilt cylinder... 1 ore iston rod diameter Stroke

4 ORTION T, VOVO 70 GNR UROS IGT MTRI Tires 20.5 R25 Teeth Teeth Teeth Teeth Volume, heaped ISO/S m 3 1,7 1,7 3,1 5,0 Volume at 110% fill factor m 3 2,1 2,1 3,4 5,5 Static tipping load, straight at 35 turn at full turn reakout force kn 87,9 80,3 93,6 85,0 92,8 84,3 99,1 89,5 6 53, *) M*) N*) V a 1 clearance circle Operating weight *) at 45 tipping angle Including counterweight 1 UKT STION RT The choice of bucket is determined by the density of the material and the bucket fill factor. The T inkage uses a very open bucket design, has very good roll back in all positions plus fills the bucket very well. This means that the actual volume carried is often larger than the rated capacity of the bucket. ucket fill factor in different materials and how they affect the actual bucket volume are shown below. xample: Sand and gravel. ill factor ~ 105%. ensity 1,7 t/m 3. Result: The m 3 bucket carries m 3. or optimum stability always consult the bucket selection chart. Material arth/lay Sand/Gravel ggregate Rock ucket fill, % ~ 110 ~ 105 ~ Material density, t/m 3 ~ ~ ~ 1,4 ~ ~ 1,5 ~ ~ ISO/S bucket volume, m 3 ctual volume, m 3 ~ ~ ~ 2,2 ~ ~ 2,1 ~ ~ ~ ~ The size of rock buckets is optimized for optimal penetration and filling capability rather than the density of the material. Type of bucket SUMNT ORTING T General purpose ight material ISO/S 70 Material density (t/m 3 ) ucket volume 0,4 0,6 0,8 1,0 1,2 1,4 m yd 3 m yd 3 m yd 3 3,1 m yd 3 ucket fill 110% 105% 100% 95% m yd 3 2, , Material density (lb/yd 3 ) = ook-on = in-on Tires 17.5 R25* ounterweight 2 xcl. ounterweight 1 xtended fenders Width over tires Ground clearance Operating weight Tipping oad, full turn ounterweight 1 may be used in rehandling, pallet and material arms operations. ounterweight 2, and combinations of counterweight 1 and 2, may be used within pallet and material arms handling arms operations for stabilizing purposes on firm and level ground. ounterweight 2 replaces hydroinflation of rear tires and must never be combined with tire chains. ounterweight 2 is not allowed in combination with tires.

5 ORTION T & IMNSIONS Tires: 20.5 R25* G J K O R 44 R 1 * 48 S 78 T 30 U 450 X Y Z a 2 a 3 a ±40 * arry position S a 1 V a 3 a 2 a 4 X Y Where applicable, specifications and dimensions are in accordance with ISO 7131, S J732, ISO 7546, S J742, ISO 5998, S J818, ISO Z 1 M 15 N O S T R R 1 U G K J MTRI NING RM (ook on) G I J K M N O Q R S Tires: Order No: Operating weight: 20.5 R25* and counterweight 1 G J K I M N O R Q S T ORK (ook on) Tires: ork tine order no. (per tine): enght: ork frame order no: Width: Rated operating load*: at load center distance: Operating weight: 20.5 R25* and counterweight 1 * acc. std N 474-3, firm and level ground

6 STNR QUIMNT ngine ow emission engine Volvo T 63 K ir cleaner, dry type, dual element, exhaust aspirated precleaner oolant level, sight gauge Muffler, spark arresting ngine intake manifold pre-heater lectrical System 24 V prewired for optional accessories lternator, 24 V, 60 attery disconnect switch uel gauge ourmeter orn, electric Instrument panel with symbols ights: driving (2-ront), halogen with high/low beam parking lights stop/tail combination (2 rear) turn signals with hazard warning switch working lights, halogen (2 rear) Instrument lighting ontronic monitoring system Shut down to idle at: high engine coolant temp low engine oil pressure high transm. oil temp Neutral start feature Test function for warning & monitoring lights Warning & monitoring lights: engine oil pressure engine coolant temperature air cleaner restriction alternator malfunction working lights high beam driving lights direction indicator, hazard transmission oil pressure transmission oil temperature brake system pressure parking brake applied hydraulic oil level entral warning (with buzzer): engine oil pressure engine coolant temperature (buzzer) transmission oil pressure transmission oil temperature brake system pressure (buzzer) parking brake applied and transmission in forward or reverse (buzzer) hydraulic oil level rivetrain Transmission: modulated with single lever control, utomatic ower Shift, and operator controlled declutch Tires *2 rake System Wet, internal oil circulation cooled disc brakes, 4-wheel, dual circuit brake system Secondary brake system, accumulator supplied arking brake alarm ab ROS (S J1040) (ISO 3471), OS (S J 231) (ISO 3449). coustical lining shtray igarette lighter oor lockable (left side access) eater/defroster/pressurizer 11 kw tu/h with four speed blower fan iltered air loor mat Interior light Interior rearview mirror Openable window, right-hand side Safety glass, tinted Seat belt (S J386) Seat, ergonomically designed, suspension adjustable Storage compartment Sun visor Windshield wiper, front Intermittent wiper, front ab access steps and handrails xterior rear view mirrors, 2 ydraulic System Main valve, 2-spool, pilot-operated ilot valve, 2-spool ual axial piston pump ydraulic control lever safety latch ydraulic pressure test ports, Quick connect ydraulic fluid level, sight gauge ydraulic oil cooler oom lowering system xternal quipment Isolation mounts: cab, engine, transmission ifting lugs Side panels, engine hood Steering frame lock Vandalism lock, provison for: batteries, engine oil OTION QUIMNT (Standard in certain markets) Service and maintenance Tool box Tool kit Wheel nut wrench kit ngine old starting aid, engine coolant pre-heater oolant filter re-cleaner, oil bath type lectrical system Working lights front, on cab Working lights front, extra Working lights rear, extra Rotating beacon, amber with collapsible mount Reverse alarm (S J994) ontronic display rivetrain orward and reverse switch Transmission, 8-speed 100 % ifferential lock, front axle ab Installation kit for radio and throttle Sliding ventilation window Speedometer Operator s seat, heated ir suspended operator's seat Retractable seat belt ir conditioner 8 kw, tu/h Noise reduction kit, cab Steering wheel, adjustable tilt, telescopic Windshield washer, front & rear Mudguards, front & rear with antiskid-tape ual service brake pedals ydraulic System ydraulic control, 3rd function ydraulic control, 4th function ydraulic controls, 5th/6th function ydraulic power take off G.. ydraulic power take off heavy duty.. ydraulic single acting lifting function oom Suspension System ttachment bracket with separate locking system ucket leveler, automatic with position indicator, adjustable boom lever detents oom kickout, automatic, adjustable iodegradeable hydraulic fluid Single lever control xternal equipment Mudguards, extended Mudguards widener ounterweight 1, 190 ounterweight 2, 360 rawbar with pin Other equipment omfort rive ontrol () Slow moving vehicle emblem Secondary steering uel fill strainer lectro-hydraulic operated park brake Tires R25* 20.5R25* Twin rotective equipment rotective guards for front running light rotective guards for rear working lights rotective guards for rear lights ttachments uckets ork equipment Material handling arm Timber grapples iagonal snow blade room utting edge, 3 pc reversible, bolt-on ucket teeth, bolt-on ucket spillguard ale clamp rum rotator ttachment rib kit Under our policy of continuous product improvement, we reserve the right to change specifications and design without prior notice. The illustrations do not necessarily show the standard version of the machine. Volvo onstruction quipment Group Ref. No rinted in Sweden ,0 nglish WO