L70D VOLVO WHEEL LOADER STARTING WITH SERIAL NUMBER 18093

Transcription

1 VV W R 70 TRTIN WIT RI NUMR ngine output 1995: gross 96 kw (130 hp) I 9249, 1349: net 91 kw (124 hp) perating weight: 10,912,2 t 24,00026,900 ucket volume: 5,0 m yd 3 Volvo high-performance, lowemission engine xcellent low rpm performance Meets all known exhaust emis- sion regulations for offroad vehicles Volvo transmission with II 2nd generation utomatic ower hift with mode selector ptimizes performance Wet disc brakes ully sealed, oil-circulation cooled, outboard mounted Torque arallel inkage igh breakout torque throughout the working range xcellent parallel lift-arm action are ab II ressurized cab with high comfort and safety ontronic II monitoring system oad-sensing working hydraulics and steering system ilot-operated working hydraulics ptional equipment ower take-off for hydraulically powered attachments ydraulic attachment bracket oom uspension ystem omfort rive ontrol ther options, see back page

2 RVI The ontronic II monitoring system provides information on machine condition, routine maintenance schedules and minimizes time required for troubleshooting. ervice accessibility: arge, easy-to-open engine access doors with gas struts. wing-out radiator grille and radiator. Refill capacities.. l U gal uel tank ngine coolant ydraulic tank NIN Refill capacities.. l U gal earbox ngine oil xle front / rear... 24/24 6.3/6.3 The engine offers high torque and quick response at low rpm also under full load. The machine operates at low engine speeds, which contributes to good fuel economy, less noise, less wear and longer life. ngine: igh performance, low emission 6-cylinder, in-line, direct-injected, turbocharged, intercooled 4-stroke diesel engine with wet replaceable cylinder liners. ir cleaning: three-stage. ngine Volvo T 63 Max power at r/s r/min 1995 gross kw 130 hp I 9249, 1349 net kw 124 hp With optional noise reduction kit U kw 126 hp Rated power at... 36,6 r/s r/min 1995 gross kw 128 hp I 9249, 1349 net kw 122 hp With optional Noise reduction kit U kw 125hp Max. torque at... 18,3 r/s r/min 1995 gross Nm 439 f ft I 9249, 1349 net Nm 435 f ft isplacement... 5,48 l 334 in 3 ower hp kw T 63 ower Torque r/min r/s Torque Nm f ft TRI YTM ontronic II monitoring system with increased function control and capability to store data for analysis. lectrical system with circuit boards, well protected by fuses. The system is pre-wired for installation of optional equipment. entral warning system: entral warning light for the following functions (buzzer with gear engaged): ngine oil pressure, transmission oil temperature, brake pressure, parking brake applied, steering system pressure, coolant temperature, transmission oil temperature, hydraulic oil temperature, overspeeding in engaged gear, computer malfunction. Voltage V atteries... 2x12 V attery capacity... 2x105 h old cranking capacity, ea Reserve capacity, ea min lternator rating W / 60 tarter-motor output... 5,4 kw 7.3 hp RIVTRIN The drivetrain and working hydraulics are well-matched to each other and of reliable design. Quick acceleration boosts productivity. Volvo system-compatible design facilitates servicing. Torque converter: ingle-stage Transmission: Volvo ountershaft-type transmission with single-lever control. ast and smooth directional and speed shifting. hifting system: Volvo utomatic ower hift ( II) with mode selector. xles: Volvo axles, fully floating with shafts and planetary-type hub reductions. ast-steel axle housing. ixed front axle and oscillating rear axle. 100% differential lock on front axle. Transmission... Torque multiplication... peeds, max. forward/reverse Measured with tires... ront axle... scillation, rear axle... round clearance at 13 oscillation... Volvo T 90 2,85:1 igh range R YTM ow range (pt.) km/h mph km/h mph 7, , , ,7 26, , , , R25* 2 Volvo / W 15 ± in simple and reliable brake system that ensures high availability and safety. elf-adjusting oil circulation-cooled wet disc brakes give long service intervals. ervice brakes: Volvo, dual-circuit system with nitrogencharged accumulators. ully hydraulically operated, enclosed, internal oil-circulation cooled disc brakes. Transmission declutch during braking can be preselected by a switch on the instrument panel. rake performance test included in the ontronic II system. arking brake: Mechanically operated drum brake on front axle input shaft. lectro-hydraulically operated (option). econdary brake: ither the service brake circuits or the parking brake fullfills the safety requirements. tandards: The brake system complies with the requirements of I 3450, Number of discs/wheel... 1 Number of accumulators... 3 Volume, each... 0,5 l 30.5 in 3

3 RTIN T, VV 70** NR UR RIN IT MTRI Tires 20.5 R25 Volume, heaped I/ m3 yd 3 Volume at 110% fill factor tatic tipping load, straight *) M *) N *) V *) at 45 dump angle UT TIN RT The choice of bucket is determined by the density of the material and the expected bucket fill factor. The actual bucket volume is often larger than the rated capacity, due to the T linkage features: pen bucket design. Very good roll back in positions. ood bucket fill performance. xample: and and gravel. ill factor ~ 105%. ensity 2865 /yd 3. Result: The yd 3 bucket carries yd 3. or optimum stability, always consult the bucket selection chart. Material arth/lay and/ravel ~ 105 ggregate Rock at 35 turn at full turn reakout force a 1 clearance circle perating weight ucket fill % ~ 110 ~ m 3 yd 3 kn f Material density t/m 3 /yd 3 ~ ~ 1,4 ~ 1,9 ~ 1,5 ~ 1,9 ~ 3035 ~ 2695 ~ 2360 ~ 3200 ~ 2865 ~ 2530 ~ 3200 ~ 2865 ~ 2695 ~ 2865 UMNT RTIN T I/ bucket volume m 3 yd 3 ctual volume m 3 yd 3 ~ ~ ~ 2,2 ~ 1,9 ~ 2,1 ~ ~ ~ ~ ~ 2.9 ~ 2.2 ~ 2.5 ~ 2.7 ~ ~ ~ ~ The size of rock buckets is designed for optimal penetration and filling capability rather than the density of the material. No additional counterweight available 1, , , , ,620 86,9 19, '4'' 990 3'3'' '6'' '7'' 960 3'2'' '1'' '6'' ,980 1, , , , ,650 79,4 17, '8'' '7'' '3'' '10'' '5'' '2'' '8'' ,510 1, , , , ,820 92,5 20, '1'' 920 3'0'' '7'' '5'' 910 3'0'' '0'' '5'' , R25* 2 Teeth , , ,160 88,8 19, '10'' '9'' '2'' '7'' '7'' '3'' '9'' ,290 Tires Teeth , , ,950 91,9 20, '9'' '8'' '3'' '7'' '6'' '3'' '9'' ,850 **) attachment data applies only to original Volvo attachments Type of bucket eneral purpose rading bucket ight material I/ ucket volume m 3 yd 3 m 3 yd 3 Teeth , , ,940 83,6 18, '1'' '11'' '0'' '10'' '9'' '4'' '10'' ,420 m 3 yd 3 m yd 3 ucket fill 110% 105% 100% 95% 70 Material density (t/m 3 ) 0,6 0,9 1,2 1,5 m 3 yd 3 2,2 2.9 m 3 yd 3 m yd ,0 m 3 5,0 6.5 yd * , , , , '6'' '3'' '6'' '11'' '6'' '11'' '9'' , , , , ,670 65,7 14, '6'' '4'' '8'' '2'' '0'' '2'' '4'' '4'' , Material density (/yd 3 ) = ook-on 4.1 3, , , ,750 61,1 13, '10'' '8'' '6'' '4'' '4'' '4'' '4'' '5'' ,900 = in-on dd extended fenders 5, , , , ,640 53,2 11, '7'' '5'' '0'' '0'' '11'' '6'' '8'' ,540 Width over tires round clearance perating weight Tipping load, full turn in in

4 RTIN T & IMNIN Tires: 20.5 R25* 2 R '10" 9'4" 1'5" 10'6" 7'0" 11'9" 12'9" R 1 * 48 T U X Y Z '2" 1'5" 6'1" 7'10" 10'5" a 2 a 3 a '9" '11" ±40 * arry position MTRI NIN RM (ook on) Where applicable, specifications and dimensions are in accordance with I 7131, 732, I 7546, 742, I 5998, 818, and I Z 15ϒ M N T R R 1 U Tires: 20.5 R25* 2 I M N Q R '3" 6'4" 4'8" 10'8" 14'1" 17'10" 3'4" 4'6" 5'9" 7'2" 10'5" 13'11" 4'11" 17'5" 20'4" 23'7" rder No: perating weight: (24,700 ) Max rolack position Max dump position I M N R Q T R (ook on) Tires: 20.5 R25* '9" 5'1" 0'3" 6'0" 12'3" 2'2" ork tine order no. (R/): 93525/93526 ength: '11" ork frame order no: Width: '11" Rated operating load*: ,460 at load center distance: 600 2'0" perating weight: Incl. optional counterweight ,800 * acc. std N 474-3, firm and level ground

5 TRIN YTM ow effort steering provides fast work cycle times. owerefficient system provides good fuel economy, good directional stability and smooth ride. teering system: oad-sensing hydrostatic articulated steering. ystem supply: The steering system has priority feed from a load-sensing axial piston pump. ump: ouble variable-flow axial piston pump. ylinders: Two double-acting cylinders. teering cylinders... ore... iston rod diameter... troke... Relief pressure... Max. flow... rticulation in in in 21 Ma 3046 psi 80 l/min U gpm ±40 YRUI YTM The oad-ensing hydraulic system delivers the exact amount of oil required for the function used. t the same time, complete control of the hydraulics is achieved throughout the entire lifting range. The high capacity of the pumps results in quick and smooth movements. ystem supply: ne load-sensing double axial piston pump with variable displacement. The steering function always has priority. Valves: ouble-acting 2-spool valve. The main valve is contolled by a 2-spool pilot valve. ift function: The valve has four positions: raise, hold, lower and float position. Inductive/magnetic automatic boom kickout can be switched on and off and is adjustable to any position between maximum reach and full lifting height. Tilt function: The valve has three functions: rolack, hold and dump. Inductive/magnetic automatic bucket positioner, can be switched on and off. ylinders: ouble-acting cylinders for all functions. ilter: ull-flow filtration through 20 micron (absolute) filter cartridge. are ab II with easy entry and wide door opening. Inside of cab lined with noise-absorbent materials. ound and vibration suppressing suspension. ood all-round visibility through large glass areas. urved front windshield of green-tinted glass. rgonomically positioned controls and instruments permit a comfortable operating position. Instrumentation: ll important information is centrally located in the operator s field of vision. enter console display for ontronic II monitoring system. eater and defroster: eating element with filtered fresh air and fan with four speeds. efroster vents for all window areas. perator s seat: perator s seat with adjustable suspension and retractable seatbelt. The seat is mounted on a bracket on the rear cab wall. The forces from the retractable seatbelt are absorbed by the seat rails. Meets I/I tandard: Tested and approved according to the following standards: R (I/ 3471, 1040), (I 3449, 231). omplies with verhead guards for rider lift trucks (I 6055) and perator Restrain ystem ( 386). mergency exits... 2 ound level in cab I d () xternal sound level ccording to I w 106 d () ccording to U 2002 requirements... w 104 d () ccording to lue ngel... w 101 d () Ventilation... 9 m 3 /min 318 ft 3 /min eating capacity kw 37,500 tu/h ir conditioning (optional)... 8 kw 27,300 tu/h xial piston pump Relief pressure... low... at... and engine speed... ilot system Relief pressure... ycle times Raise*... ump*... ower, empty... Total cycle time... * with load as per I 5998 and 818 IT-RM YTM The T inkage combines high breakout torque throughout the working range with parallel lift-arm action. These features together with high lift height and long reach make the lift-arm system equally as good in bucket loading as in work with fork attachments and material handling arms. ift cylinder... ore... iston rod diameter... troke... Tilt cylinder... ore... iston rod diameter... troke... 26,0 Ma 3771 psi 160 l/min 4 U gpm 10 Ma 1450 psi 36,7 r/s rpm 3,0 Ma 435 psi 5,4 s 1,1 s 3,0 s 9,5 s in in in in in in

6 TNR QUIMNT ngine igh performance, low emission Volvo T 63 ual fuel filters old starting aid ir cleaner, dry type, dual element, exhaust-aspirated precleaner oolant level, sight gauge Muffler, spark arresting oolant filter an guard rimary fuel filter with water separator lectrical ystem 24 V prewired for optional accessories lternator, 24 V, 60 attery disconnect switch auges: uel gauge ngine coolant temperature gauge Transmission oil temperature gauge ourmeter orn, electric Instrument panel with symbols ights: riving (2-front), halogen head lights with high/low beam arking lights top/tail combination (2 rear) Turn signals with separate hazard warning switch alogen working lights (2 front/2 rear) Instrument lighting Reverse alarm ( 994) ontronic II Monitoring ystem, U with log and analysis system ontronic II display ngine shutdown to idle igh engine coolant temperature ow engine oil pressure igh transmission oil temperature Neutral start feature rake performance test function Test function for warning and indicator lights Warning and indicator lights: lternator malfunction il pressure, engine il pressure, transmission rake pressure arking brake applied ydraulic oil level ydraulic oil temperature xle oil temperature rimary steering igh beams Turn signals Rotating beacon reheating coil ifferential lock (front axle) oolant temperature Transmission oil temperature rake charging ir cleaner restriction ydraulic oil level igh speed/gear verspeed engine rivetrain Transmission: modulated with single lever control, utomatic ower hift ( II) with mode selector and operator-controlled declutch orward and reverse switch on hydraulic control console Tires 17.5R % differential lock, front axle rake ystem Wet, internal oil-circulation cooled, outboard-mounted disc brakes, 4-wheel, dual circuit brake system econdary brake system, accumulator supplied arking brake ab R ( 1040) (I 3471), ( 231) (I 3449). coustical lining shtray igarette lighter ab access steps and handrails ual service brake pedals oor lockable (left side) eater/defroster/pressurizer with four speed blower fan iltered air loor mat ome light 2 interior rearview mirrors 2 exterior rearview mirrors penable window, right-hand side teering wheel, adjustable tilt and telescopic, adjustable lever console Tinted safety glass Retractable seat belt ( 386) rgonomically designed operator s seat with adjustable suspension torage compartment un visor everage holder Windshield wiper, front and rear Intermittent wiper, front Windshield washer, front and rear ydraulic ystem Main valve, 2-spool, pilot-operated ilot valve, 2-spool oom-lowering, stopped engine ual axial piston pump ucket lever detent ydraulic control lever safety latch ydraulic pressure test ports, quick connect ydraulic fluid level, sight gauge ydraulic oil cooler ucket leveler, automatic with position indicator, adjustable oom lever detents oom kickout, automatic, adjustable ydraulic pressure test port, quick connect xternal quipment ttachment bracket, hydraulic, with separate locking system Isolation mounts: cab, engine, transmission, radiator ifting and tie-down lugs ide panels, engine hood teering frame lock Vandalism lock, provison for: batteries, engine oil rawbar hitch enders front/rear uel fill strainer TIN QUIMNT (tandard in certain markets) ervice and Maintenance Tool box utomatic lube system ngine oolant pre-heater (120 V/750 W) or (240 V/750 W) re-cleaner, oil bath type re-cleaner, turbo type lectrical ystem lternator 100 Working lights front, extra Working lights rear, extra Rotating beacon, amber with collapsible mount rivetrain Transmission, 8-speed imited slip differential, rear imited slip differential, front and rear ab Installation kit for radio M/M radio with tape deck eated operator seat rmrest, left side eat belt, 3 in, extended length liding window, right side and throttle ir suspended operator's seat ir conditioner Noise reduction kit, cab arking brake alarm pen R version unblinds Ventilation filter for asbestos environment ydraulic ystem ydraulic control, 3rd function ydraulic control, 4th function ydraulic controls, 5th/6th function ydraulic power take off, heavy duty ydraulic single-acting lifting function oom uspension ystem iodegradeable hydraulic fluid ever detent 3rd function rtic kit ingle lever control xternal quipment enders, axle-mounted rear ender wideners ther quipment omfort rive ontrol () low moving vehicle sign econdary steering lectro-hydraulically operated parking brake Tires , 20.5R25*, 555/70 R25 rotective quipment uards for: eadlights Rear working lights Rear lights Windshield ir cleaner restriction over plate under cab elly guards, front and rear ttachments uckets: traight with/without teeth pade nose with/without teeth igh tip ight material Three piece, reversible bolt-on cutting and weld-on bucket teeth og grapples ork equipment Material handling arm iagonal snow blade room ttachment rib kit Under our policy of continuous product improvement, we reserve the right to change specifications and design without prior notice. The illustrations do not necessarily show the standard version of the machine. Volvo onstruction quipment North merica Inc. ne Volvo rive, sheville, N Ref. No rinted in U 03/01-5,0