Daikin McQuay. Vertical Unit Ventilator. UAVS, UAVV, UAVR, UAVB Design F (6) Replacement Parts List No Revision P 10/2018

Transcription

1 Replacement Parts List No Revision P 0/208 Daikin McQuay Vertical Unit Ventilator UAVS, UAVV, UAVR, UAVB 07-5 Design F (6) To find your Daikin Applied parts distributor, call or visit

2 Contents Parts List Revision History...3 Nomenclature Serial Number...4 Model Number...4 Electrical Legend...5 Discharge Air Daigram...6 Components...7 Coil Section Diagram...8 Components Electric Heat Heater Assy... Electric Heaters...2 Damper Section Diagram...3 Components...4 Actuators...5 Controls Overheat Stat (OH), DE Low Limit Control (T4), Hydronic Coil Low Water Temp. Stat (T6)... 6 MicroTech II Controls- Sensors...7, 8 MicroTech II Controls- Circuit Board, Expansion Board, Terminal Block... 9 MicroTech II Controls- Main Box...20, 2 DDC Controls (Code 9= 7)- Terminal Strip, R2 Relay (Damper/Valve Control) DDC Controls (Code 9= 7)- Main Box...23 DDC Controls (Code 9= 7)- Sensors...24 Controls by Others (Code 9= 23)- Main Box...25 Field Installed Accessories Critical Parts List...CPL UV; UAVS,UAVV,UAVR,UAVB 07-5, Des. F(6) Rev. P 0/8 RPL / Page 2

3 ' Parts List Revision History Revision Date Description New /05 New A 02/07 Page 22 - Table heading on bottom of page was changed from with MT II to WITHOUT MT II. B 2/08 Page 2 - Ref #7 & 9-Change part numbers and drawing of Top Panel and. Page 4 - Add note for motor. C 05/09 Page 25 - Remove footnotes 4 & 5 from chart. D 07/09 Page 4 - Change Code 07 '78= Opp. End Steam High Cap.' to '78= Opp. End Steam Low Cap. Change Code 07 '79= Opp. End Steam Low Cap.' to '79= Opp. End Steam High Cap.' E 0/ Reformatted from PM6.5 to CSIV and added CPL. Page 6- Change TX valve p/n to and p/n to Change TX valve p/n to F 0/ Reformatted CPL. G 2/ Page 2- Ref# & 2 Add paint colors. Ref # 7 change top panels center p/n to ; p/n to , p/n to ; p/n to ; Add p/n for S0 Ivory. Ref #9 change grille p/n to ; p/n to ; p/n to ; p/n to Ref#0 add base frame p/ns , , , H 02/2 Title Page- Change Vintage F to Design F (6). Delete the 6 after the models. Page CPL- Change Vintage F to Design F (6). Delete the 6 after the models. I 0/4 Rebrand to Daikin. Page 5- Code 6 add Cooling options -8. Code 8- Add Coil Connections G,R & S. Page - Change all Code 9 to Code 0. Page 4- Ref# 4 change fan shaft p/ns GC8504 to , GC8505 to , GC8506 to & GC06 to J 02/5 Page - Delete Adapter Backs- kits are in field installed accessories. Delete sheetmetal for external cabinetry add footnote to contact Daikin. Page 3- Add X3 ECM & program and footnote #3. Page 4 Change shaft p/n to GC0729. Page 5- Add exp valve p/n for S0. CPL- Add exp valve p/n for S0. Delete Comm cards and add X3 motor. K 02/6 Rebrand Daikin. Delete External Cabinetry section and Unit Ventilator diagram. Page 4- Change Serial Number AUB to STN. Add Code 4- Sizes H07-H5. Code 6 Delete options -8. Code 7 Delete 4= 4-Element Electric Heat. Code 3 Add C= Cupola White. Page 6- Ref# 28 Delete spare motor p/n from field installed accessories. Page 3- Delete Shaft p/n Delete X3 motor. Page 29- Change Sensor p/n & to Add Sensor w/clip p/n CPL- Add sensor p/ns & Add Fan Housing & Wheel Assy p/n Delete Actuator, Transformer & Valve sections. L 08/6 Page 7- Ref# 40- Change Coupling p/n to GC502C. Page 9- Size 0-2 DX coils all the same sizes, change to size 0 to / ; size 3 to / & size 5 to / M 04/7 Page 7-Add size 5 Shaft p/n CPL- Update revision. N 0/7 Page 0- Add LH & RH coil p/ns for 05/ & later. Change Manual Air Vent p/n to Change High Cap steam coil size to p/n CPL- Update revision. O 08/8 Page -Change contactor p/n to CPL-Updae revision. P 0/8 Page 9- Add R22 expansion valves p/ns , , and CPL- Updae revision. Daikin Applied, 3600 Industrial Park Blvd., P.O. Box 55, Minneapolis, MN (763) UV; UAVS,UAVV,UAVR,UAVB 07-5, Des. F(6) Rev. P 0/8 RPL / Page 3

4 Plant Identification Abbreviation AUB= Auburn STN = Staunton U= Unit Nomenclature Serial Number STN U Year of Manufacture 05= = 2006 etc. Model Number Serial Number (build sequence) Week of Manufacture U AVV 6 S0 A S 68 A 23 AL 22 G W Code Code 0: Product Category U= Unit Ventilator Code 02: Product Identifier AVS= Floor, Face & Bypass Damper, Heat/Cool, Heat & Cool Only AVV= Floor, Valve Control Hydronic or Electric Heat/Cool,Heat & Cool AVR= Floor, Valve Control, Hydronic or Electric Reheat/Dehumid AVB= Floor, Face & Bypass Damper, Hydronic Heat Code 03: Unit Design (Vintage) 6= Design F Code 04: Size (000's BTUH) S07= 750 H07= 750 S0= 000 H0= 000 S3= 250 H3= 250 S5= 500 H5= 500 Code 05: Voltage A= 5/60/ D= 208/60/3 C= 208/60/ H= 230/60/3 G= 230/60/ K= 460/60/3 J= 265/60/ Code 06: Coil Options U= 2 Row CW/HW 2 pipe V= 2 Row CW D= 3 Row CW/HW 2 pipe S= 3 Row CW E= 4 Row CW/HW 2 pipe W= 4 Row CW F= 5 Row CW/HW 2 pipe Y= 5 Row CW G= DX Z= None Code 07: Heating Coil Options 00= None 65= HW- -Row 2= Low Electric (3 elements) 66= HW- 2-Row 3= High Electric (6 elements) 67= HW- 3-Row 68= Steam- Low Capacity 69= Steam- High Capacity 78= Steam- Low Capacity, Opposite End Drain 79= Steam- High Capacity, Opposite End Drain Code 08: Hand Orientation A= Same Hand Left B= Same Hand Right D= RH Elect. Heat Coil E= LH Heating/RH Cooling F= RH Heating/LH Cooling G= RH Elec. Ht/LH Cooling R= Single Coil LH S= Single Coil RH Code 09: Controls 7= DDC w/o Control Board 23= Field Installed Controls by Others Basic Stand- Alone Controls B= w/o TC BA= Master w/o TC w/co2 B2= Master w/o TC BB= Slave w/o TC w/co2 B3= Slave w/o TC BC= BACnet MS/TP w/o TC w/co2 B4= BACnet MS/TP w/o TC BD= LonMark SCC w/o TC w/co2 B5= LonMark SCC w/o TC BE= Metasys N2 w/o TC w/co2 B6= Metasys N2 open w/o TC BF= w/tc w/co2 B7= with TC BG= Master w/tc w/co2 B8= Master with TC B9= w/o TC w/co2 Expanded Stand- Alone Controls E= w/o TC EA= Master w/o TC w/co2 E2= Master w/o TC EB= Slave w/o TC w/co2 E3= Slave without TC EC= BACnet MS/TP w/o TC w/co2 E4= BACnet MS/TP w/o TC ED= LonMark SCC w/o TC w/co2 E5= LonMark SCC w/o TC EE= Metasys N2 w/o TC w/co2 E6= Metasys N2 open w/o TC EF= w/tc w/co2 E7= with TC EG= Master w/tc w/co2 E8= Master with TC E9= w/o TC w/co2 Leading Stand- Alone Controls L= w/o TC LA= Master w/o TC w/co2 L2= Master w/o TC LB= Slave w/o TC w/co2 L3= Slave without TC LC= BACnet MS/TP w/o TC w/co2 L4= BACnet MS/TP w/o TC LD= LonMark SCC w/o TC w/co2 L5= LonMark SCC w/o TC LE= Metasys N2 w/o TC w/co2 L6= Metasys N2 open w/o TC LF= w/tc w/co2 L7= with TC LG= Master w/tc w/co2 L8= Master with TC L9= w/o TC w/co2 Code 0: Discharge AB= 2-7/8" Top Bar Full Adapter Back, Solid Back AK= 2-7/8" Top Bar Partial ABack, Open Pipe Tunnel AL= 6-5/8" Top Bar Unit AM= 2-7/8" Top Bar 2" Step Full Adapter Back AN= 2-7/8" Top Bar Full A Back AP= 2-7/8" Top Bar Partial ABack, Top Duct Code : Return Air/ Outdoor Air 22= RA Bottom Front/ OA Rear 24= Recirculation RA Bottom Front/ No OA/RA Dampers 30= RA Bottom Front with Draft Stop/ OA Rear Code 2: Power Connection G= Box w/switch Code 3: Color C= Cupola White I= Antique Ivory B= Putty Beige W= Off White G= Soft Gray Code 4: SKU Code 5: Product Style UV; UAVS,UAVV,UAVR,UAVB 07-5, Des. F(6) Rev. P 0/8 RPL / Page 4

5 Electrical Legend Sch. Sym. Description Location A Actuator- OA/RA OA Damper A2 Actuator- F & B Damper F & B Damper CEH Contactor- Electric Heat E.H. Control Box F2A/F3C Fuse- Electric Heat E.H. Control Box FA/FB Fuse- Control Main Control Box FC/FD Fuses- Electric Heat 460V E.H. Control Box HTR-6 Electric Heaters Electric Heat Section M Fan Motor Right End MV Valve- Modulating Steam Coil OH Overheat Stat Electric Heat Section R,2,3 Relay- Electric Heat Backup E.H. Control Box R0,,2 Relay- Electric Heat E.H. Control Box R2 Relay- Actuator Valve DDC Control Box R4 Relay- Fan Main Control Box S Sensor- Room Air Left End Compartment S2 Sensor- Discharge Air Fan Deck S3 Sensor- Outside Air L.H. Lower Partition S4 Sensor- DE Coil Temp. DE Coil- Hairpin End S6 Sensor- Indoor Humidity Left End Compartment S7 Sensor- CO2 Below Fan Motor S8 Sensor- Outdoor Humidity Lower Partition- Left Hand SW Disconnect Switch Main CB or EH Control Box SW2 Switch- On/Off Fan Speed Main Control Box SW3 Tenant Override Switch Top Right of Unit T4 Freezestat- DX Coil Left End Compartment T6 Thermostat- Low Limit Hyd. Coil Left End Compartment TB-3 Terminal Boards Controller TB3A/TB3B Terminal Block- Main Power Main Control Box TB-DE Terminal Block- DE Contactor Main Control Box TC Time Clock Top Right of Unit TDR Anti- Short Timer Main Control Box TDR2 Low Voltage Protector E.H. Control Box TS Terminal Strip E.H. Control Box V Valve- End Of Cycle Coil X Transformer- Motor Speed Main Control Box X2 Transformer- Class 2 Main Control Box X3 Transformer- 75VA Main Control Box X4 Transformer- 460V Below Motor X5 Transformer- 460V EH E.H. Control Box UV; UAVS,UAVV,UAVR,UAVB 07-5, Des. F(6) Rev. P 0/8 RPL / Page 5

6 Discharge Air Components Fan Deck, Wheel, Motor, Bearing, Drain Pans Diagrams 0 Motor Cabinet/Chassis components 2 Motor and Bearing Detail UV; UAVS,UAVV,UAVR,UAVB 07-5, Des. F(6) Rev. P 0/8 RPL / Page 6

7 Ref. No. Discharge Air Components Fan Housing Assy, Motor, Bearing, Access Panels Components Part Number Unit Size N/S Top Panel 0 Access Door Assy, 2" Fan Housing and Wheel Assy (until 3/) Fan Housing and Wheel Assy (3/ & later) Wheel, Blower N/S Screen Shaft (until 4/06) GC8504 Shaft (4/06 & later) Shaft (until 4/06) GC8505 Shaft (4/06 & later) Shaft (until 4/06) GC8506 Shaft (4/06 & later) Shaft (until 4/06) GC0729 Shaft (4/06 & later) Bearing Mounting Plate, Sleeve GC Bearing Flange Sleeve, -/4" 4ACE2556A N/S Bearing Flange Ball, -/4" Indoor Fan Motor, /4HP N/S Motor Mount Coupling- Motor to Shaft GC502C N/S Gasket, Motor N/S Grommet N/S Grommet N/S = Not shown on diagram. Please contact Daikin with unit model and serial number for part numbers on cabinet/chassis components. 2 Motors are 5/60/ regardless of unit voltage. It is important that the correct transformer be installed (see Code 5 for voltage). NP WARNING LABEL Motor Nameplate Ref. No. Part Number Unit Size N/S ECM Motor & Program 3 See motor nameplate 3 The PN for the motor is found on the name plate label on the motor. You may also contact Daikin with the Unit Model & Serial Number to get the Motor part number. UV; UAVS,UAVV,UAVR,UAVB 07-5, Des. F(6) Rev. P 0/8 RPL / Page 7

8 Coil Section Diagrams HW or Steam Coil 2 CW or CW/HW Coil Hydronic Heat Unit (UAVV or UAVB shown) 3 Drain Pan Electric Heat Coil 6 Cooling Coil 5 EH Controls Electric Heat Unit UAVS or UAVR Drain Pan 3 4B 4A F & B Damper 4C Cooling Coil 6 Electric Heat Coil Electric Heat Unit UAVV or UAVB Drain Pan 3 5 EH Controls UV; UAVS,UAVV,UAVR,UAVB 07-5, Des. F(6) Rev. P 0/8 RPL / Page 8

9 Ref. No. Coil Section Drain Pan, Face & Bypass Damper Components Part Number Unit Size Coil See table below and on next page. 2 HW or Steam Heat Coil See table on next page. 3 Drain Pan Assy Drain Pan Assy Drain Pan Assy Drain Pan Assy A Shaft, F&B Damper Shaft, F&B Damper Shaft, F&B Damper Shaft, F&B Damper B Bearing, F&B Damper 4ACN C Damper Assy, F&B Damper Damper Assy, F&B Damper Damper Assy, F&B Damper Damper Assy, F&B Damper Coil, Electric Heat See Electric Heat Section 6 Controls, Electric Heat See Electric Heat Section Some units may have an insulated steel drain pan p/n (07), (0), (3) or (5). Ref. No. Coil Section DX Cooling Coils, Expansion Valves Code 6= Code 8= Part Number DX Coil, LH G A or F DX Coil, RH G B or E DX Coil, LH G A or F DX Coil, RH G B or E Unit Size DX Coil, LH G A or F DX Coil, RH G B or E DX Coil, LH G A or F DX Coil, RH G B or E N/S Expansion Valve, R22 2T G ALL Expansion Valve, R22 3T G ALL Expansion Valve, R22 4T G ALL Expansion Valve, R40A.5T G ALL Expansion Valve, R40A 2T G ALL Expansion Valve, R40A 3T G ALL Expansion Valve, R40A 4T G ALL UV; UAVS,UAVV,UAVR,UAVB 07-5, Des. F(6) Rev. P 0/8 RPL / Page 9

10 Ref. No. 2 HW or 2 or 2 Coil Section Chilled Water (CW) Cooling Coils (Code 06= S, V, W, Y) Chilled Water/Hot Water (CW/HW) Coils (Code 06= D, E, F, U) Hot Water Coils (HW) (Code 07= 65, 66, 67) Coil Description CW or CW/HW or HW CW or CW/HW or HW CW or CW/HW CW or CW/HW Rows Code 6= Code 7= until 05/ Part Number LH 05/ & later G,S,V,W,Y G,S,V,W,Y RH Unit Size G,S,V,W,Y G,S,V,W,Y U or V U or V U or V U or V D or S D or S D or S D or S E or W any E or W any E or W any E or W any Y or F any Y or F any Y or F any Y or F any N/S Manual Air Valve ALL ALL ALL Ref. No. 2 Coil Description Coil Section Steam Coils (Code 07= 68, 69, 78, 79) Capacity Code 7= Part Number Steam Low 68 or Steam Low 68 or Unit Size Steam Low 68 or Steam Low 68 or Steam High 69 or Steam High 69 or Steam High 69 or Steam High 69 or N/S Check Valve ALL ALL UV; UAVS,UAVV,UAVR,UAVB 07-5, Des. F(6) Rev. P 0/8 RPL / Page 0

11 Electric Heat Electric Heat Control Box Control Box Face & Bypass Units General Layout 344 Control Box Valve Control Units General Layout 423 Ref. Sch. Part Part Unit Size No. Sym. Description Number SW2 Toggle Switch 4EAL SW3 Switch 4EAL R() Relay * * * * 397 X5 Transformer, 208/230V X5 Transformer, 277V X5 Transformer, 460V 4EPC9056 N/S X5 Relay, DPST, 30A SW Switch- Disconnect 4EUL6509A 40 Fuse Block 208/230/60/ 4EHC Fuse Block 208/230/60/3 4EHC4506 Fuse Holder 460/60/3 4EHB F2A/ Fuse 208/230/60/ 4EHG F3C Fuse 208/230/60/3 4EHG Fuse 460/60/3 4EHG TDR2 Relay- Anti Short 4EWS7798 N/S TS Terminal Board, 3Ø Units TS Terminal Board, Ø Units 4ECA8877 N/S CEH Contactor, 24V, 60A until 7/ N/S CEH Contactor, 24V, 60A 7/8 & later N/S= Not shown on diagram. * Quantity may be 3 or 6. R, R2, R3 (Electric Heat Backup), R0, R, R2 (Electric Heat). SW to Contact Harness. UV; UAVS,UAVV,UAVR,UAVB 07-5, Des. F(6) Rev. P 0/8 RPL / Page

12 Electric Heat Heater Assembly 9 25 Ref. Sch. Unit Voltage No. Sym. Unit Sizes 208V 230V 460V 265V Qty N/S --- Channel, Top & Bottom Unit Sizes S07/H Unit Sizes S0/H Unit Sizes S3/H Unit Sizes S5/H Element Seperator Unit Sizes S07-S0/H07-H0 GR2044 GR2044 GR2044 GR Unit Sizes S3-S5/H3-H5 GR2044 GR2044 GR2044 GR HTR -6 Heater Element Unit Sizes S07/H /6 Unit Sizes S0/H /6 Unit Sizes S3/H /6 Unit Sizes S5/H /6 N/S = Not shown on diagram UV; UAVS,UAVV,UAVR,UAVB 07-5, Des. F(6) Rev. P 0/8 RPL / Page 2

13 Damper Section Outdoor Air & Return Air Dampers, Stops, Linkage Diagrams Upper and Lower Damper Stop Detail OA Detail OA & RA Dampers Detail 3 RA Detail Right Hand Linkage Assembly Detail Left Hand Linkage Assembly Detail UV; UAVS,UAVV,UAVR,UAVB 07-5, Des. F(6) Rev. P 0/8 RPL / Page 3

14 Damper Section Outdoor Air & Return Air Dampers, Stops, Linkage, Draft Stop, Blockoffs Components Ref. Part Part Unit Size No. Description Number Partition, Damper- LH, 2, Partition, Damper- RH, 2, Linkage- RA to OA 2, Linkage Assy- OA Damper 2, 3 Right Hand Linkage Assy- RA Damper 2, 3 Left Hand Linkage Assy- RA Damper 2, 3 Right Hand Shaft- OA 2, Screw 2, Stop- Upper RA, 2, Stop- Upper RA, 2, Stop- Upper RA, 2, Stop- Upper RA, 2, Stop- Lower MB, 2, Stop- Lower MB, 2, Stop- Lower MB, 2, Stop- Lower MB, 2, Damper- OA Cold Weather 2, Damper- OA Cold Weather 2, Damper- OA Cold Weather 2, Damper- OA Cold Weather 2, Damper- RA Cold Weather 2, Damper- RA Cold Weather 2, Damper- RA Cold Weather 2, Damper- RA Cold Weather 2, Spring- Damper Shaft- OA Damper 2, Bearing- Sleeve 2, 3 4ACN Screw 4SBA Screw 2, 3 4SBA Hook- Damper Screw 2, 3 4SAJ Nut- Lock 2, 3 4NHA72A Nut- Cap 2, 3 4NKZ N/S Blockoff- Draft Stop N/S Angle- Draft Stop Angle- Draft Stop Angle- Draft Stop Angle- Draft Stop N/S Panel- OA Blockoff Panel- OA Blockoff Panel- OA Blockoff Panel- OA Blockoff N/S= Not shown on diagram. Recirculation only units. Code = RA Bottom Front/OA Rear units. Code = RA Bottom Front/OA Rear with Draft Stop units. Code = 30. UV; UAVS,UAVV,UAVR,UAVB 07-5, Des. F(6) Rev. P 0/8 RPL / Page 4

15 Actuators Outdoor/Return Air Damper Actuator Face & Bypass Damper Actuator Components Front View of Unit (less panels) Ref. Sch. Part Part Unit Size No. Sym. Description Number A2 Actuator- Face & Bypass Damper A Outdoor/Return Air Damper Actuator UAVR, UAVS Units. Actuators- Units with MicroTech II Controls UAVR, UAVS Units. Actuators- Units without MicroTech II Controls Ref. Sch. Part Part Unit Size No. Sym. Description Number A2 Actuator- Face & Bypass Damper A Outdoor/Return Air Damper Actuator UV; UAVS,UAVV,UAVR,UAVB 07-5, Des. F(6) Rev. P 0/8 RPL / Page 5

16 Controls Unit Mounted Limit Controls Overheat Stat (OH), DE Low Limit Control (T4), Hydronic Coil Low Water Temp. Stat (T6) Hydronic Coil Low Water Temp. Stat. (T6) Direct Expansion Coil Low Limit Control (T4) Left End Compartment Overheat Stat (OH) (Electric Heat Units) Left End Compartment 20 0 Outdoor Air Actuator Assembly Ref. Sch. Part Part Unit Size No. Sym. Description Number OH Thermosat- Overheat w/manual Reset, Bracket Manual Reset Switch GE T6 Thermostat- Low Water Temp. 3 4ELN T4 Control- Low Limit, DE Coil 4 4ELN7604 Code 7= 2 or 3. 2 Overheat switch with automatic reset is p/n 4ELN Code 6= U, D, E, V, W, S, F, Y. 4 Code 6= G. UV; UAVS,UAVV,UAVR,UAVB 07-5, Des. F(6) Rev. P 0/8 RPL / Page 6

17 Controls- MicroTech II Controls Sensors- Unit Mounted Room, Discharge Air, Return Air, DE, CO 2 Sensor Diagrams Unit Mounted Room (S) & 2. Optional Indoor Humidity (S6) 853A Unit Front View (less panels) 3. Discharge Air (S2) Left End Compartment Fan Deck Outdoor Air (S3) & 5. Outdoor Air Humidity (S8) 9 9A 6. CO 2 (S7) View E-E 92 R.H. End L.H. Lower Partition 5 Outdoor Air Actuator Assembly Mounting Plate Hair Pin End 7. Direct Expansion (S4) 0 UV; UAVS,UAVV,UAVR,UAVB 07-5, Des. F(6) Rev. P 0/8 RPL / Page 7

18 Controls MicroTech II Controls Sensors- Unit Mounted Room, Discharge Air, Return Air, DE, CO 2 Sensor Components Sensors- MicroTech II Controls Ref. Sch. Part Part Unit Size No. Sym. Description Number S7 Sensor- CO VDC S4 Sensor Assy- DE, Sensor Only S3 Sensor Assy- Outdoor Air 80" Sensor Only A S8 Sensor Assy, Humidity- Outdoor Air 50" Sensor Only Mount- Sensor GC S2 Sensor Assy- Discharge Air Sensor Only Bracket- Sensor GC S Sensor Assy- Room A S6 Sensor Assy, Humidity- Indoor Air Sensor Only Gasket ft. 2 ft. 2 ft. 2 ft. Sensor Assy includes sensor and receptacle. 2 Code 6= G. 3 Code 9= B9, BA, BB, BC, BD, BE, BF, BG, E9, EA, EB, EC, ED, EE, EF, EG, E9, EA, EB, EC, ED, EE, EF, EG. UV; UAVS,UAVV,UAVR,UAVB 07-5, Des. F(6) Rev. P 0/8 RPL / Page 8

19 Controls MicroTech II Controls Circuit Board, Expansion Board, Terminal Block Ref. Part Part Unit Size No. Description Number Circuit Board- MicroTech II Expansion Board Modtac Stand Off Terminal Block 2 pin UV; UAVS,UAVV,UAVR,UAVB 07-5, Des. F(6) Rev. P 0/8 RPL / Page 9

20 Controls MicroTech II Controls Communication Module Options, Local User Interface, Time Clock, Tenant Override switch, Transformers, Fusing, Terminal Boiard, Power Switch Diagrams X Unit Front View (less panels) 3 SW LUI TC Unit Top View 30 SW X X X FA/FB X4 transformer (460V units only) Main Control Box Detail (5V unit shown) UV; UAVS,UAVV,UAVR,UAVB 07-5, Des. F(6) Rev. P 0/8 RPL / Page 20

21 Controls MicroTech II Controls Communication Module Options, Local User Interface, Time Clock, Tenant Override switch, Transformers, Fusing, Terminal Boiard, On/Off Switch Components Ref. Sch. Part Part Voltage No. Sym. Description Number 5 208/ Circuit Board- MicroTech II Communication Module- LonMark Spacer for LonMark Board Communication Module- Matasys Spacer for Metasys Board Communication Module- BACnet Spacer for BACnet Board SW Switch- Unit On/Off Hydronic Heat TC Time Clock SW3 Switch- Tenant Override SPDT 4EAL LUI Interface- Local User Angle- Transformer Mount Receptacle GES9 636 Fuse Holder 4EHB Fuse Holder 4EHB FA/FB Fuse- 3.5A FNQ 4EHG FA Fuse- 5.0A FNQ 4EHG X Transformer Transformer Housing- Plug X3 Transformer- 75VA Transformer- 75VA 4EPC977 Transformer- 75VA Terminal Board X4 Transformer 500VA 4EPC6552A Code 9= B5, BD, E5, ED, L5, LD. 2 Code 9= B6, BE, E6, EE, LE, LE. 3 Code 9= B 4, BC, E4, EC, L4, LC. UV; UAVS,UAVV,UAVR,UAVB 07-5, Des. F(6) Rev. P 0/8 RPL / Page 2

22 Controls DDC Controls (Code 9= 7) Terminal Strip, R2 Relay (Damper/Valve Control) Left Hand End of Unit Ref. Sch. Part Part Unit Size No. Sym. Description Number Bracket TB-3 Terminal Strip R2 Relay- Actuator/Valve 24VAC/2PDT UV; UAVS,UAVV,UAVR,UAVB 07-5, Des. F(6) Rev. P 0/8 RPL / Page 22

23 Controls DDC Controls (Code 9= 7) Switches, Transformers, Fuses, Relays, Terminal Strip, Time Delay 2 X X4 752 X X SW2 8 X4 transformer (460V units only) TB-DE 0 TDR 4 R FA/FB DDC Control Box Detail 8 Ref. Sch. Part Part Voltage No. Sym. Description Number 5 208/ Angle- X3 Transformer Mount X Transformer X Transformer R4 Relay PDT 4EWJ TDR Timer- Anti Short 5 min SW2 Switch- Rotary 2 Pole/4 Pos SW2 Switch- Rotary 3 Pole/4 Pos Fuse Holder 4EHB933 Fuse Holder 4EHB Knob- SW TB-DE Terminal Strip Receptacle GES9 6 Plug 8 ckt FA Fuse 5.0A FNQ 4EHG8089 FA Fuse 3.25A FNQ 4EHG773 FA/FB Fuse 3.25A FNQ 4EHG Label- SW X2 Transformer 4EPC X3 Transformer X3 Transformer X3 Transformer 4EPC X4 Transformer 500VA 4EPC6552A N/S SW Switch- Unit Power 20A DP N/S= Not Shown on diagram. Units with DE Cooling only (Code 6= G). UV; UAVS,UAVV,UAVR,UAVB 07-5, Des. F(6) Rev. P 0/8 RPL / Page 23

24 Controls DDC Controls (Code 9= 7) S, S2, S3 Sensors Unit Mounted Room Sensor (S) Left End Compartment Discharge Air Sensor (S2) Outdoor Air Sensor (S3) Fan Deck 97 9 View E-E L.H. Lower Partition A Outdoor Air Actuator Assembly Sensors- DDC Controls Ref. Part Part Unit Size No. Description Number N/S Sensor w/clip C Air/Water Temp Sensor 0K Mount- Sensor GC Sensor C Sensor 0K A Sensor C Bracket GC Sensor 0K Gasket Foam ft. 2 ft. 2 ft. 2 ft. 857 Sensor C UV; UAVS,UAVV,UAVR,UAVB 07-5, Des. F(6) Rev. P 0/8 RPL / Page 24

25 Controls Controls by Others (Code 9= 23) Switches, Transformers, Fuses, Relays, Terminal Strip, Time Delay 2 X X X SW2 8 X4 transformer (460V units only) TB-DE 0 TDR FA/FB CBO Control Box Detail 8 Ref. Sch. Part Part Voltage No. Sym. Description Number 5 208/ X Transformer 5V, 265V, 460V units X Transformer 208V, 230V units TDR Timer- Anti Short 5 min SW2 Switch- Rotary 2 Pole/4 Pos SW2 Switch- Rotary 3 Pole/4 Pos Fuse Holder 4EHB933 Fuse Holder 4EHB Knob- SW TB-DE Terminal Strip Receptacle GES9 6 Plug 8 ckt FA Fuse 5.0A FNQ 4EHG8089 FA Fuse 3.25A FNQ 4EHG773 FA/FB Fuse 3.25A FNQ 4EHG Label- SW X2 Transformer 4EPC X4 Transformer 500VA 4EPC6552A N/S SW Switch- Unit Power 20A DP N/S= Not Shown on diagram. Units with DE Cooling only (Code 6= G). UV; UAVS,UAVV,UAVR,UAVB 07-5, Des. F(6) Rev. P 0/8 RPL / Page 25

26 Ventimatic Shutter Field Installed Accessories Description Part No. 24" Shutter Only GP256 36" Shutter Only GP257 Vertical Louver for Ventimatic Shutter /- ½ Mesh Bird Screen on Room Side Description Part No. Autumn Brown Clear Anodized Dark Bronze Unfinished Interior Steel Wall for Ventimatic Shutter Unit Size Antique Ivory Off White Putty Beige Soft Gray Remote Wall Thermostats and Tstat Guard Description Part No. Deluxe Room Sensor w/ override & 55 F- 85 F Setpoint Adj Expanded Microtech II Wall Sensor Sensor, +/- 3 F Setpoint Adj Standard Room Sensor w/ override 0480 Metal Guard for Thermostats Communications Modules- MicroTech II Description Part No. Kit * Card Only Mounting Spacer BACnet MS/TP (4) LonWorks SCC (4) Metasys N2 Open (4) * Kit includes IM Auxiliary Drain Pan Description Part No. Drain Pan UV; UAVS,UAVV,UAVR,UAVB 07-5, Des. F(6) Rev. P 0/8 RPL / Page 26

27 Field Installed Accessories Louver- Vertical Aluminum w/horizontal blades, ½ mesh bird screen on room side; bottom lip drains moisture Unit Size S07 (Louver size 0"H x 36" L) Autumn Brown Clear Anodized Dark Bronze Unfinished Unit Size S0 (Louver size 0"H x 48" L) Autumn Brown Clear Anodized Dark Bronze Unfinished Unit Size S3 (Louver size 0"H x 36" L) Autumn Brown Clear Anodized Dark Bronze Unfinished Unit Size S5 (Louver size 0"H x 36" L) Autumn Brown Clear Anodized Dark Bronze Unfinished UV; UAVS,UAVV,UAVR,UAVB 07-5, Des. F(6) Rev. P 0/8 RPL / Page 27

28 Field Installed Accessories Louver- Horizontal Aluminum w/horizontal blades, ½ mesh bird screen on room side; bottom weep holes drain moisture Unit Size S07-S5 (Louver size 0"H x 24" L) Autumn Brown Clear Anodized Dark Bronze Unfinished Unit Size S07 (Louver size 0"H x 36" L) Autumn Brown Clear Anodized Dark Bronze Unfinished Unit Size S0 (Louver size 0"H x 48" L) Autumn Brown Clear Anodized Dark Bronze Unfinished Unit Size S3 (Louver size 0"H x 60" L) Autumn Brown Clear Anodized Dark Bronze Unfinished Unit Size S5 (Louver size 0-3/8"H x 72" L) Autumn Brown Clear Anodized Dark Bronze Unfinished UV; UAVS,UAVV,UAVR,UAVB 07-5, Des. F(6) Rev. P 0/8 RPL / Page 28

29 End Panels- " Field Installed Accessories Cupola White Antique White Off White Color Putty Beige Soft Gray 6-5/8" Deep, Solid /8" Deep, Solid, w/ 2½ x 7" cutout /8" Deep, Solid, w/ 4" x 8" cutout /8" Deep, Solid, w/ 4" x 22" cutout /8" Deep, Solid /8" Deep, Solid, 2" stepdown /8" Deep, Solid, w/ 2½ x 7" cutout /8" Deep, Solid, w/ 4" x 8" cutout /8" Deep, Solid, w/ 4" x 22" cutout " Deep, Solid " Deep, Solid, w/ 4" x 22" cutout End Panels- 6" Cupola White Antique White Off White Color Putty Beige Soft Gray 6-5/8" Deep, Solid /8" Deep, Solid " Deep, Solid N/A Subbase: 6-5/8" Deep Units Unit Size " High Subbase " High Subbase " High Subbase " High Subbase " High Subbase Subbase: 2-7/8" Deep Units Unit Size " High Subbase " High Subbase " High Subbase " High Subbase " High Subbase UV; UAVS,UAVV,UAVR,UAVB 07-5, Des. F(6) Rev. P 0/8 RPL / Page 29

30 Field Installed Accessories Touch Up Paint Description Part No. Oxford Brown Antique Ivory Off White GXA60208 Putty Beige GXA60203 Soft Gray GXA60204 Adapter Backs Type Unit Size /8" Top Bar FABack, Closed Pipe AB /8" Top Bar PABack, Open Tunnel AK /8" Top Bar 2" Step, FABack, Closed Tunnel AM /8" Top Bar FABack, Closed Tunnel AN /8", Top Bar FABack Top Duct AP Way and 3-Way Valves Kit Number Actuator Valve Body 2-Way Valve, Two-Position, 24V, NC, ", 8.0Cv HW/ST Way Valve, Two-Position, 24V, NC, 3/4", 7.5Cv CW Way Valve, Two-Position, 24V, NC,3/4", 5.0Cv HW/CW Filters Unit Size Throwaway, 2/Box Permanent Mesh, 25/Box Renewable, 2/Box Renewable- Media Only N/A UV; UAVS,UAVV,UAVR,UAVB 07-5, Des. F(6) Rev. P 0/8 RPL / Page 30

31 Critical Daikin Applied OEM Parts Are What Your HVAC Unit Needs! Daikin Vertical Unit Ventilator McQuay Vertical Unit Ventilator UAVS, UAVV, UAVR, UAVB 07-5 Design F (6) Critical Components Unit Sizes Voltage Part Number Control Control Board, MicroTech II ALL ALL Blower Motor Motor, /4HP ALL 5V ECM & Program ALL ALL See motor nameplate Fan Housing and Wheel Fan Housing and Wheel Assy ALL N/A Wheel, Blower ALL N/A Sensor Temp Sensor, F ALL N/A Temp Sensor w/clip, F ALL N/A Air/Water Temp Sensor, 0K ALL N/A Call Your Local Daikin Applied Parts Distributor For All Your Parts Needs. To Locate A Distributor, Go To or Call PARTS Rev. P 0/208 CPL Page of