McQuay. Cabinet Unit Heater. CHB, CHF Vintage A. FCHB, FCHF Design A (1) Last Manufactured: 2010

Transcription

1 Replacement Parts List No Revision G 05/2017 McQuay Cabinet Unit Heater CHB, CHF Vintage A FCHB, FCHF Design A (1) Last Manufactured: 2010 To find your Daikin Applied parts distributor, call or visit

2 Contents About the Model Number Changes... 2 Parts List Revision History... 3 Nomenclature Serial Number... 4 Model Number... 4 Complete Unit Model Number... 5 Cabinet CHB/FCHB Cabinet... 6, 7 CHF/FCHF Cabinet- Top Discharge CHF/FCHF Cabinet- Front Discharge Blower Assembly... 16, 17 Coils & Manual Air Vent Filters Field Installed Accessories FCHB/FCHF Units CHB/CHF Units About the Model Number Changes In 1999 the model numbering nomenclature for the Cabinet Unit Heaters changed: The CHB "A" Vintage unit is now the FCHB Design "A" unit. The CHF "A" Vintage unit is now the FCHF Design "A" unit. The unit's components did not change when the nomenclature did (a few engineering changes have taken place since this RPL was last issued, and the part number changes are noted). The complete model number nomenclature currently used has been added to this revision. Unless otherwise noted, all components listed in this revision apply to both the current and the original model numbered units. Unit Heater; CHB,CHF Vint. A; FCHB,FCHF Des. A Rev. G 05/17 RPL / Page 2

3 Parts List Revision History Revision Date Description NEW 11/80 New /90 Hard copy scanned in to be an electronic file. A 12/00 New cover page made and rescanned remaining pages so the file wouldn t be so large and slow. NOTE: this is still in hard copy form. B 01/02 Converted to electronic format. Part numbers converted to current McQuay International format. Coil Kits added; Added unit control label; Updated and corrected part numbers for Bar Grilles. Corrected motor HP for Unit Sizes ; Added Unit Model and Serial Number Nomenclature. C 11/02 Added new nomenclature for FCHB/FCHF. Page 4- Added Serial Number for units built after 2/99. Page 5- Added New. Page 6- Added Ref# 97, 98, 191. Page 7- Ref# 7 Desc. changed to 'Grille Support'; P/N changed to Ref# 8 P/N changed to Ref# 24 Note added for sizes Ref# 69 P/N for all sizes changed from 0238***08 to 0238***10. Ref# 93 P/N for sizes changed to Ref# 94 P/N for sizes changed to Ref# 95 P/N for size 010 changed to Ref# 96 Qty. (1) added to size 010. Ref# 97, 98, 191 Added new. Page 8- Added Ref# 7, 20, 97, 98, 191. Page 9- Added Ref# 7 and added notes regarding Italics. Ref# 5 Added P/N's for Antique Ivory parts and added note. Ref# 13 Added P/N's for Antique Ivory parts and added note. Ref# 17, 23, 24 moved to next page. Page 10- Ref# 23 Added P/N's for Antique Ivory parts and added note. Ref# 69 Added P/N's for Antique Ivory parts and added note. Ref# 93 P/N for sizes changed to Ref# 94 P/N for sizes changed to Ref# 121, 122, 126 moved to next page. Page 11- Added new. Page 12- Added Ref# 7, 45, 46, 97, 98, 191. Page 13- Ref# 5 Added P/N for units made after 8/94 and added notes regarding Italics. Ref# 6 Added P/N's for Antique Ivory parts and added note. Ref# 13 Added P/N's for Antique Ivory parts and added note. Ref# 14 Added P/N's for Antique Ivory parts and added note. Ref# 14A Added P/N's for Antique Ivory parts & added note.ref# 16, 17, 23 moved to next page. Page 14- Added Ref# 45, 46 and added notes regarding Italics. Ref# 28, 69 Added P/N's for Antique Ivory parts & added note. Ref# 93 P/N for sizes changed to Ref# 94 P/N for sizes changed to Ref# 95, 96, 121, 122, 126 moved to next page. Page 15- Added new. Page 17- Added Complete Blower Assy for size 015. Ref# 1 P/N for all sizes changed. Ref# 2 P/N for sizes 010,012,015 changed to Ref# 4 P/N for sizes changed to & added wheel hub. Ref# 10 P/N changed to Ref# 13 Note added. Page 18- Added coils for units built 1/99 & later. Changed headings. Added Manual Air vent to coil chart. Pages 19 thru 22- Added new. D 07/05 Page 19 -Damper Motor Kit RH motor pn was changed from to and Left Hand Motor Kits were added. Page 20 - Wall Plate for FCHB units table is for Antique Ivory units. Page 21 - Wall Plate for FCHP units table was added for Soft Gray units. Return Air Bar Grille Kits table was added for all sizes. E 11/08 Pages 9, 10, 13, 14 - Note change from SMG Parts Tech to McQuay Parts. Page 17 - Ref# 3 Motor HP change from.250 to.333. F 02/17 Rebrand to Daikin format. Change "Please contact McQuay Parts" to "Please contact Daikin". All Pages- Update the unit sizes on component lists from (003/S03 thru 015/S15) to (03 thru 15). Page 20- Add "Antigue White" to title for Horizontal Ceiling Conversion Kits & Trim Strips. G 05/17 Pages 9, 10, 13, 14- Change p/ns in italics back to standard. Remove the WDSII Note. Daikin Applied, Industrial Park Blvd., P.O. Box 1551, Minneapolis, MN (763) Unit Heater; CHB,CHF Vint. A; FCHB,FCHF Des. A Rev. G 05/17 RPL / Page 3

4 Nomenclature Serial Number (until 2/1999) 7 6A Serial Number (2/1999 to present) AUB U Engineering Revision Serial Number Factory 7= Auburn, NY or Spirit Lake, IA Serial Number Year and Month of Manufacture: Year Month J= 1978 Z= 1994 A= Jan. K= = 1995 B= Feb. L= = 1996 C= Mar. M= = 1997 D= Apr. N= = 1998 E= May P= = 1999 F= Jun Q= 1984 G= Jul R= 1986 H= Aug S= 1987 J= Sep. T= 1988 K= Oct. U= 1989 L= Nov. V= 1990 M= Dec. W= 1991 X= 1992 Y= 1993 U= Unit Factory AUB= Auburn, NY Year 99= = = = = = 2004 etc. Month of Manufacture 01= January 02= February 03= March 04= April 05= May 06= June 07= July 08= August 09= September 10= October 11= November 12= December Model Number- Nameplate Original Model CHB= Cabinet Unit Heater- Basic Unit CHF= Cabinet Unit Heater- Floor Unit Unit Size 003= 3,000 Btu 004= 4,000 Btu 006= 6,000 Btu 008= 8,000 Btu 010= 10,000 Btu 012= 12,000 Btu 015= 15,000 Btu Vintage A CHB 003 A Model Number FC HF 1 03 A Unit Type FC= Fan Coil Product Identifier HB= Horizontal, Heater Basic HF= Horizontal, Heater Floor Voltage A= 115/60/1 Nominal Capacity (Hundreds of BTUHS) Design 1= Design A Unit Heater; CHB,CHF Vint. A; FCHB,FCHF Des. A Rev. G 05/17 RPL / Page 4

5 Nomenclature Complete Unit Model Number- Original CHB 003A R Y 1 2 A A Y A Y A Y 1 U Y YYYY 15 Y A A Code Unit Model CHB= Cabinet Unit Heater-Basic Unit CHF= Cabinet Unit Heater-Floor Unit 02 Unit Size (in 100's cfm) & Vintage A 003A= 300 cfm 004A= 400 cfm 006A= 600 cfm 008A= 800 cfm 010A= 1000 cfm 012A= 1200 cfm 015A= 1500 cfm 03 Hand of Unit R= Right Hand L= Left Hand 04 Always Y 05 Unit Coil 1= Combination Steam or Water Y= None 06 Electric Power Supply (Motors) 2= 115/60/1 PSC 07 Speed Control Switch A= Top B= Front Y= None 08 Air Discharge A= Bar Grille- Top (CHF) D= Modular- Top (CHF) E= Bar Grille- Front (CHF) G= Duct Collar w/o Wall Plate (CHB) H= Duct Collar w Wall Plate (CHB) K= Front Discharge on Wall Plate (CHB) 09 Always Y 10 Air Return A= Opening Only- Front B= Duct Opening- Front C= Stamped Grille (CHF only) F= Bar Grille (CHF only) 11 Always Y 12 Cabinet Finish A= Antique Ivory (CHF only) Y= None 13 Cabinet Option Y= none 14 Packaging 1= Corrugated Box 15 Approval U= UL Y= None 16 Miscellaneous Y= None Z= Special 17 Always YYYY 18 Control System YY= None 15= Unit Mtd. Switch/Unit Mtd. Stat 19= Unit Mtd. Switch/Wall Mtd. Stat 23= Wall Mtd. Switch/Wall Mtd. Stat 56= No Switch/Wall & Comb. Sp. C Stat 19 Always Y 20 Extended Warranties A= Standard Warranty C - K= Extended Warranty 21 Always A Complete Unit Model Number- Current FCHB 1 06 A A 00 A 29 AW 15 Z Z A 1 Code & 02 Unit Model FCHB= Cabinet Unit Heater-Basic Unit FCHF= Cabinet Unit Heater-Floor Unit 03 Design Series 1= A Design 04 Unit Size (in 100's cfm) 03= 300 cfm 04= 400 cfm 06= 600 cfm 08= 800 cfm 10= 1000 cfm 12= 1200 cfm 15= 1500 cfm 05 Voltage A= 115/60/1 06 Coil Options A= Standard Coil 07 Heating Options 00= None 08 Hand Orientation A= Same Hand Left 09 Controls 28= Speed Switch- Unit Mounted/ Top Discharge (CHF only) 29= Speed Switch- Unit Mounted/ Front Discharge (CHB& CHF) 10 Discharge AS= TTF/BTF Rotated (C09 must = 28) AW= FTT/FTB Rotated (C09 must = 29) 11 Return Air/Outside Air 15= FTB/FTT Rotated 12 Power Connection Z= None 13 Color I= Antique Ivory Z= None 14 SKU Type A= Stock B= Standard Delivery 15 Style 1= 1st Style Change Unit Heater; CHB,CHF Vint. A; FCHB,FCHF Des. A Rev. G 05/17 RPL / Page 5

6 CHB/FCHB Cabinet Diagram Unit Heater; CHB,CHF Vint. A; FCHB,FCHF Des. A Rev. G 05/17 RPL / Page 6

7 CHB/FCHB Cabinet Components Ref. Part Part Unit Size No. Description Number Grille Support N/A N/A N/A N/A N/A Support Channel N/A N/A N/A N/A N/A Top Panel- Insulated Top Panel- Insulated Top Panel- Insulated Top Panel- Insulated Top Panel- Insulated Top Panel- Insulated Filter Channel Filter Channel Base Plate Base Plate Base Plate Base Plate Base Plate Base Plate End Piece- Left End Piece- Left End Piece- Right End Piece- Right Header Support- Left Header Support- Left Header Support- Right N/A N/A N/A N/A Coil Mounting Plate- LH Coil Mounting Plate- LH Coil Mounting Plate- RH Coil Mounting Plate- RH Coil Blower Assy Back Panel- Insulated Back Panel- Insulated Back Panel- Insulated Back Panel- Insulated Back Panel- Insulated Back Panel- Insulated Filter Stop N/A= Not applicable. 1 The filter channel was once used on unit sizes 03, 04, 06, 08 (P/N , , , respectively). 2 See Coils chart on page following Blower Assy section. 3 See Blower Assembly section following the CHF/FCHF Front Discharge Section for complete assy and component part number. Unit Heater; CHB,CHF Vint. A; FCHB,FCHF Des. A Rev. G 05/17 RPL / Page 7

8 CHF/FCHF Cabinet- Top Discharge Diagram Unit Heater; CHB,CHF Vint. A; FCHB,FCHF Des. A Rev. G 05/17 RPL / Page 8

9 CHF/FCHF Cabinet- Top Discharge Components Ref. Part Part Unit Size No. Description Number Bar Grille (pre 8/94) Bar Grille (8/94 & later) Bar Grille (pre 8/94) Bar Grille (8/94 & later) Bar Grille (pre 8/94) Bar Grille (8/94 & later) Bar Grille (pre 8/94) Bar Grille (8/94 & later) Bar Grille (pre 8/94) Bar Grille (8/94 & later) Bar Grille (pre 8/94) Bar Grille (8/94 & later) Grille Support Grille Support Grille Support Grille Support Grille Support Grille Support Gasket Gasket Top Panel- Painted Top Panel- Painted Top Panel- Painted Top Panel- Painted Top Panel- Painted Top Panel- Painted End Panel- Painted End Panel- Painted Front Panel- Insulated Front Panel- Insulated Front Panel- Insulated Front Panel- Insulated Front Panel- Insulated Front Panel- Insulated Right Hand Left Hand Access Door- LH Plastic Aluminum These part numbers are for Antique Ivory colored parts. Antique Ivory has been used since the early 1990's. Prior to that the units were offered in Mist Gray, and they also had the option of being unpainted. Mist Gray panels from the factory are no longer available. However, unpainted panels are available. The unpainted top panels are the same P/N as the ones listed above except the last two digits are 01 instead of 90; the unpainted end panels are the same P/N as those listed above except the last two digits are 10 instead of 90. Unit Heater; CHB,CHF Vint. A; FCHB,FCHF Des. A Rev. G 05/17 RPL / Page 9

10 CHF/FCHF Cabinet- Top Discharge Components, Continued Ref. Part Part Unit Size No. Description Number Access Door- RH Plastic Aluminum Gasket- Access Panel Corner- Painted Corner- Painted Reinforcing Angle Reinforcing Angle Reinforcing Angle Reinforcing Angle Reinforcing Angle Reinforcing Angle Mullion Assy- Insulated N/A N/A N/A N/A N/A Support- Mullion, Painted N/A N/A N/A N/A N/A Support- Channel N/A N/A N/A N/A N/A Base Plate- Painted Base Plate- Painted Base Plate- Painted Base Plate- Painted Base Plate- Painted Base Plate- Painted End Piece- LH End Piece- LH End Piece- RH End Piece- RH Header Support- LH Header Support- LH Header Support- RH N/A N/A N/A N/A These part numbers are for Antique Ivory colored parts. Antique Ivory has been used since the early 1990's. Prior to that the units were offered in Mist Gray, and they also had the option of being unpainted. Mist Graycorners from the factory are no longer available. However, unpainted corners are available. The unpainted corners are the same P/N as the ones listed above except the last two digits are 10 instead of This part number is for an Antique Ivory colored mullion. Antique Ivory has been used since the early 1990's. Prior to that the units were offered in Mist Gray, and they also had the option of being unpainted. Mist Gray mullions from the factory are no longer available. However, unpainted mullions are available. The unpainted mullion is P/N These part numbers are for Antique Ivory colored parts. Antique Ivory has been used since the early 1990's. Prior to that the units were offered in Mist Gray, and they also had the option of being unpainted. Mist Gray base plates from the factory are no longer available. However, unpainted base plates are available. The unpainted base plates P/N are: (03), (04), (06), (08), (10), (12/15). Unit Heater; CHB,CHF Vint. A; FCHB,FCHF Des. A Rev. G 05/17 RPL / Page 10

11 Ref. Part Part Unit Size No. Description Number Coil Mounting Plate- LH Coil Mounting Plate- LH Coil Mounting Plate- RH Coil Mounting Plate- RH Coil Blower Assy 9 CHF/FCHF Cabinet- Top Discharge Components, Continued 126 Back Panel- Insulated Back Panel- Insulated Back Panel- Insulated Back Panel- Insulated Back Panel- Insulated Back Panel- Insulated Filter Stop See Coils chart on page following Blower Assy section. 9 See Blower Assembly section following the CHF/FCHF Front Discharge Section for complete assy and component part number. Unit Heater; CHB,CHF Vint. A; FCHB,FCHF Des. A Rev. G 05/17 RPL / Page 11

12 CHF/FCHF Cabinet- Front Discharge Diagram A 15 Unit Heater; CHB,CHF Vint. A; FCHB,FCHF Des. A Rev. G 05/17 RPL / Page 12

13 CHF/FCHF Cabinet- Front Discharge Components Ref. Part Part Unit Size No. Description Number Bar Grille (until 8/94) Bar Grille (8/94 & later) Bar Grille (until 8/94) Bar Grille (8/94 & later) Bar Grille (until 8/94) Bar Grille (8/94 & later) Bar Grille (until 8/94) Bar Grille (8/94 & later) Bar Grille (until 8/94) Bar Grille (8/94 & later) Bar Grille (until 8/94) Bar Grille (8/94 & later) Grille Support- Painted Grille Support- Painted Grille Support- Painted Grille Support- Painted Grille Support- Painted Grille Support- Painted Gasket Gasket Top Panel- Painted Top Panel- Painted Top Panel- Painted Top Panel- Painted Top Panel- Painted Top Panel- Painted End Panel, Left- Painted End Panel- Left- Painted A End Panel- Right- Painted End Panel- Right- Painted Front Panel- Insul Front Panel- Insul Front Panel- Insul Front Panel- Insul Front Panel- Insul Front Panel- Insul, RH Front Panel- Insul, LH Front Panel- Insul, RH Front Panel- Insul, LH These part numbers are for Antique Ivory colored parts. Antique Ivory has been used since the early 1990's. Prior to that the units were offered in Mist Gray, and they also had the option of being unpainted. Mist Gray parts from the factory are no longer available. However, unpainted parts are available. The unpainted parts are the same P/N as the ones listed above except the last two digits are 01 instead of These part numbers are for Antique Ivory colored parts. Antique Ivory has been used since the early 1990's. Prior to that the units were offered in Mist Gray, and they also had the option of being unpainted. Mist Gray panels from the factory are no longer available. However, unpainted parts are available. The unpainted panels are the same P/N as the ones listed above except the last two digits are 10 instead of 90. Unit Heater; CHB,CHF Vint. A; FCHB,FCHF Des. A Rev. G 05/17 RPL / Page 13

14 CHF/FCHF Cabinet- Front Discharge Components, Continued Ref. Part Part Unit Size No. Description Number Access Door- LH Plastic Aluminum Access Door- RH Plastic Aluminum Corner- Cabinet Base Corner- Cabinet Base Reinforcing Angle Reinforcing Angle Reinforcing Angle Reinforcing Angle Reinforcing Angle Reinforcing Angle Mullion Assy- Insulated N/A N/A N/A N/A N/A Support, Mullion- Painted N/A N/A N/A N/A N/A Support- Channel N/A N/A N/A N/A N/A Offset Bracket- LH Offset Bracket- LH Offset Bracket- RH Offset Bracket- RH Base Plate Only- Painted Base Plate Only- Painted Base Plate Only- Painted Base Plate Only- Painted Base Plate Only- Painted Base Plate Only- Painted End Piece- LH End Piece- LH End Piece- RH End Piece- RH These part numbers are for Antique Ivory colored parts. Antique Ivory has been used since the early 1990's. Prior to that the units were offered in Mist Gray, and they also had the option of being unpainted. Mist Gray panels from the factory are no longer available. However, unpainted parts are available. The unpainted corner P/N's are (03-08), (10-15). 13 This part number is for an Antique Ivory colored part. Antique Ivory has been used since the early 1990's. Prior to that the units were offered in Mist Gray, and they also had the option of being unpainted. Mist Gray parts from the factory are no longer available. However, unpainted parts are available. The unpainted mullion is P/N These part numbers are for Antique Ivory colored parts. Antique Ivory has been used since the early 1990's. Prior to that the units were offered in Mist Gray, and they also had the option of being unpainted. Mist Gray panels from the factory are no longer available. However, unpainted parts are available. The unpainted base plate P/N's are (03), (04), (06), (08), (10), (12/15). Unit Heater; CHB,CHF Vint. A; FCHB,FCHF Des. A Rev. G 05/17 RPL / Page 14

15 Ref. Part Part Unit Size No. Description Number Header Support- LH Header Support- LH Header Support- RH N/A N/A N/A N/A Coil Mounting Plate- LH Coil Mounting Plate- LH Coil Mounting Plate- RH Coil Mounting Plate- RH Coil (see last page) Blower Assy 16 (see Blower Assy section) CHF/FCHF Cabinet- Front Discharge Components, Continued 126 Back Panel- Insulated Back Panel- Insulated Back Panel- Insulated Back Panel- Insulated Back Panel- Insulated Back Panel- Insulated Filter Stop N/S Access Door Parts Sleeve Bearing Hook and Loop Assy N/S Magnetic Latch N/S Bracket- Latch N/S Strike Plate N/A= Not applicable. N/S= Not Shown on Diagram. 15 See Coils chart on page following Blower Assy section. 16 See Blower Assembly section following the CHF/FCHF Front Discharge Section for complete assy and component part number. Unit Heater; CHB,CHF Vint. A; FCHB,FCHF Des. A Rev. G 05/17 RPL / Page 15

16 Blower Assembly Diagrams 1 One Fan Configuration Sizes 03, Two Fan Configuration Sizes Unit Heater; CHB,CHF Vint. A; FCHB,FCHF Des. A Rev. G 05/17 RPL / Page 16

17 Blower Assembly Components Ref. Part Part Unit Size No. Description Number Complete Blower Assy Complete Blower Assy Complete Blower Assy Complete Blower Assy Complete Blower Assy Complete Blower Assy Complete Blower Assy Panel- Fan Deck Panel- Fan Deck Panel- Fan Deck Panel- Fan Deck Panel- Fan Deck Panel- Fan Deck Motor Mount Motor Mount Motor Mount Motor-.083 HP Motor-.143 HP Motor-.250 HP Motor-.333 HP Fan Wheel, Plastic- CCW Hub for Plastic Wheel Fan Wheel- CCW Fan Wheel- CW Housing- Discharge Half Housing- Discharge Half Housing- Access Half Housing- Access Half Motor Clamp Motor Base N/A N/A N/A N/A N/A= Not Applicable 17 These are aluminum wheels. Some units originally had plastic wheels, which are replaced directly by these aluminum wheels. 18 No longer used. Unit Heater; CHB,CHF Vint. A; FCHB,FCHF Des. A Rev. G 05/17 RPL / Page 17

18 Coils & Manual Air Vent Ref. Part Part Unit Size No. Description Number Coil 1 Row- 1/99 & later 19 9" X 19" " X 25" " X 34" " X 44" " X 44" " X 56" Coil 1 Row- until 1/99 20 Left Hand Unit 9" X 19" K 1 9" X 25" K 1 9" X 34" K 1 9" X 44" K 1 12" X 44" K 1 12" X 56" K 1 1 Right Hand Kit 9" X 19" K 1 9" X 25" K 1 9" X 34" K 1 9" X 44" K 1 12" X 44" K 1 12" X 56" K 1 1 N/S Manual Air Vent N/S= Not Shown on Diagram. 19 LH Units only. RH is no longer an option. 20 These kits contain a coil and end brackets to retrofit original coil (RH coil is not offered on FCHB/FCHF). Filters Ref. Part Part Unit Size No. Description Number N/S Filter- Throwaway- 1" Filter- Throwaway- 1" Filter- Throwaway- 1" Filter- Throwaway- 1" Filter- Throwaway- 1" Filter- Throwaway- 1" N/S Filter- Cleanable- ½" Filter- Cleanable- ½" Filter- Cleanable- ½" Filter- Cleanable- ½" Filter- Cleanable- ½" Filter- Cleanable- ½" Unit Heater; CHB,CHF Vint. A; FCHB,FCHF Des. A Rev. G 05/17 RPL / Page 18

19 Field Installed Accessories FCHB/FCHF Units Aluminum Wall Box Description Unit Size Part Number 4¾" X 16¾" X 4" ¾" X 33½" X 4" 12, Changeovers and Limit Controls Description Kit PN Control PN Limit Control (Aquastat)- Strap On Thermostats- Unit Mounted Description Kit PN T-Stat Knob Bulb Hsg. Fan Cycle Face Plate for Wall Mounting Speed Switch Description Kit PN Control PN Face Plate Levelling Legs Kit Description Unit Size Part Number Levelling Leg Kit 0" to 1" adjustment Levelling Leg Kit 0" to 1" adjustment Perimeter Gasketing Description Unit Size Part Number 60' Roll, Adhesive Back All Transformer Description Kit PN Transformer Transformer 120/24V- 75 VA Transformer 265/120V- 300 VA Damper Motor Kit (Unit Sizes S03 - S10 only) (converts manual damper to automatic- order opposite coil hand) Description Kit PN Motor Damper Rod Coupling Right Hand Motor (LH unit) Left Hand Motor (RH unit) Manual Damper- Installs in Subbase Description Unit Size Part Number Manual Damper 03, Manual Damper 06, Manual Damper Unit Heater; CHB,CHF Vint. A; FCHB,FCHF Des. A Rev. G 05/17 RPL / Page 19

20 Field Installed Accessories FCHB/FCHF Units Horizontal Ceiling Conversion Kit- Antique Ivory Description Unit Size Part Number Kit- includes Finished Bottom Panel, Return Air Grille, Wall Switch Plate Kit- includes Finished Bottom Panel, Return Air Grille, Wall Switch Plate Kit- includes Finished Bottom Panel, Return Air Grille, Wall Switch Plate Kit- includes Finished Bottom Panel, Return Air Grille, Wall Switch Plate Kit- includes Finished Bottom Panel, Return Air Grille, Wall Switch Plate Kit- includes Finished Bottom Panel, Return Air Grille, Wall Switch Plate 12, Keylock Kit- Metal Door (FCHF Only) (see Electric Heat section for component part numbers) Description Unit Sizes Kit PN LH Door RH Door Lock Only Keylock Kit Keylock Kit Trim Strips- Antique Ivory Description Unit Size Part Number Kit- provides finished look to sides and top of rough opening Kit- provides finished look to sides and top of rough opening Kit- provides finished look to sides and top of rough opening Kit- provides finished look to sides and top of rough opening Kit- provides finished look to sides and top of rough opening Kit- provides finished look to sides and top of rough opening 12, Wall Plate for FCHB Units- Antique Ivory Unit Wall Plate Intake Access Bumper Spring Hinge Gasket Size Kit PN Grille (1) Panel (2) (4) Hinge (2) Pin (2) (2) (2) (2) (2) (2) (2) (2) (2) (2) (2) , (2) (2) Unit Heater; CHB,CHF Vint. A; FCHB,FCHF Des. A Rev. G 05/17 RPL / Page 20

21 Field Installed Accessories FCHB/FCHF Units Wall Plate for FCHB Units- Soft Gray Unit Wall Plate Intake Access Bumper Spring Hinge Gasket Size Kit PN Grille (1) Panel (2) (4) Hinge (2) Pin (2) (2) (2) (2) (2) (2) (2) (2) (2) (2) (2) , (2) (2) Wall Mounted Thermostats Application Unit Sizes Part Number 2 or 4 Pipe, 24 Volt, with On/Off or 3 Wire Floating, All Auto Changeover Thermister Probe for All or 4 Pipe, Fan/Valve Cycle, 3 Speed Switch, All Auto Changeover 2 or 4 Pipe, Fan/Valve Cycle, 3 Speed Switch, All Manual Changeover 2 or 4 Pipe, Fan/Valve Cycle, No Speed Switch, All Auto Changeover 2 or 4 Pipe, Fan/Valve Cycle, No Speed Switch, All Manual Changeover 2 Pipe, SPDT, 2" X 4" All " X 4" Adapter Plate All Return Air Bar Grille Kit* Description Unit Size Kit Part No. Grille Part No. Return Air Bar Grille Kit Return Air Bar Grille Kit Return Air Bar Grille Kit Return Air Bar Grille Kit Return Air Bar Grille Kit Return Air Bar Grille Kit 12, * All kits include (1) bracket p/n and (1) gasket p/n Unit Heater; CHB,CHF Vint. A; FCHB,FCHF Des. A Rev. G 05/17 RPL / Page 21

22 Field Installed Accessories CHB/CHF Units CHB & CHF Speed Controller Ref. Part Part Unit Size No. Description Number N/S Speed Controller K N/S Knob- Speed Controller N/S Wall Plate- Speed Controller N/S Label- Unit Control Plate Unit Heater; CHB,CHF Vint. A; FCHB,FCHF Des. A Rev. G 05/17 RPL / Page 22