Palm Beach County Fleet Management Asset Maintenance History

Transcription

1 FORD F450 Utility Body, Gvwr, W/Heavy Duty Crane Workorder Meter 322 In Date 10/06/2011 Closed 10/07/2011 Problem top off def tank - Parts only Def Diesel Exh Fluid (mtc Pm27jug 2.5, Pm27d 55) 0.00 Labor 0.00 Parts 7.28 Total 7.28 Workorder Meter 0 In Date 10/06/2011 Closed 10/06/2011 Problem Pre Delivery Inspection - Pre Delivery Inspection 4.00 Labor Parts 0.00 Total Workorder Meter 7604 In Date 04/12/2012 Closed 05/18/2012 Problem pm service - Pm Service - Pm Crane - Top Off Def Tank - Replaced missing out rigger pad - Top off compressor and compressor motor - Mount air compressor and hose reel provided by Gua, freed frozen rigging on snatch block of crane - Installed inverter in utility body, secured wirring. provided fused circuit Labor 1, Ph10890 Oil Filter Mtc Fl2051 Wix Fuel Filter Frm K10826 Wix Air Filter Frm Ca10888 Wix w30 Motor Oil Def Diesel Exh Fluid (mtc Pm27jug 2.5, Pm27d 55) Wiper Blades 22" Wiper Blade 2.00 Battery Cable / Circuit Breaker 100amp 1.00 Outrigger Pads / Mounting Bolt / Nut / Air Comp Oil / Sae30 Oil / Parts Total 1, Workorder Meter In Date 08/09/2012 Closed 08/09/2012 Problem 1 - Key(s) issued Key(s) issued Duplicate Vehicle Keys Labor Parts 3.00 Total Workorder Meter In Date 08/27/2012 Closed 09/04/2012 Problem NO TURBO BOOST, WON'T TRAVEL OVER 35 MPH - Tow From Hooker Hwy To Pahokee Fleet 0.00 Labor 0.00 Parts 0.00 Total 0.00

2 Workorder Meter In Date 09/11/2012 Closed 09/19/2012 Problem CHECK TRAILER LIGHT RECEPTACLE, FRONT DIESEL FUEL TANK LEAKS WHEN FULL - Locate Source Of Open Circuit In Trailer Marker Lights And Repair. - Locate Leak In Fuel Tank Fill And Repair Labor Parts 2.00 Total Workorder Meter In Date 09/11/2012 Closed 09/13/2012 Problem WARANTY WORK COMPLETE, TRANSPORT TO PAHOKEE SHOP TO COMPLETE REPAIRS - Tow From Al Packer West To Pahokee Fleet Management 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 09/20/2012 Closed 09/24/2012 Problem WON'T START - Tow From 2016 N.main St, Belle Glade To Pahokee Fleet Mgt 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 10/18/2012 Closed 10/24/2012 Problem P.M. service - pm service done at Al Packer with eng swap - Add Def - Crane pm - Pto not engaging. Repair open in pto circuit Antifreeze Ext-life 1.00 Def Diesel Exh Fluid L Lubriplate 1.00 Def Diesel Exh Fluid Labor Parts Total Workorder Meter In Date 11/13/2012 Closed 11/19/2012 Problem Engine shut off - A/c compressor seized, fan belt damaged. Repaired by Al Packer under warranty. Invoice # Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 11/13/2012 Closed 11/16/2012 Problem Shut off - Tow From Belle Glade To Pahokee shop 0.00 Labor 0.00 Parts 0.00 Total 0.00

3 Workorder Meter In Date 11/19/2012 Closed 11/28/2012 Problem Inverter not working - Replace shorted inverter - Replace missing hitch pin 2000w Power Inverter Pintle Pin Labor Parts Total Workorder Meter In Date 04/15/2013 Closed 04/25/2013 Problem Pm service - Pm service - Crane p.m. - Replace three tires. Rotate and balance. - Test drive Aw68 Hyd Fluid Tank Pahokee Tire Rim And Mount Tire Rim And Mount 2.00 Def Fluid Napa Trans Filter 1.00 Peak Global Wiper Blades Tire Rim And Mount 1.00 Tire Disposal Fee Labor Parts 2, Total 3, Workorder Meter In Date 08/01/2013 Closed 08/12/2013 Problem Flat tire - Replace flat tires on rear axle r19.5 Rc 3.00 Tire Disposal Fee Labor Parts Total

4 Workorder Meter In Date 08/27/2013 Closed 09/11/2013 Problem Pm service - Pm service - Battery failed load test. Replace battery. Repair damaged cable end. - Replace Rr tire. - Tighten fuel filler neck. - Steering wheel loose.remove srs module.retorqued steering wheel bolt to spec. Wiper Blade 2.00 Battery Battery Napa Trans Filter Tire Rim And Mount 1.00 Aw68 Hyd Fluid Tank Pahokee Tire Disposal Fee Labor Parts 1, Total 1, Workorder Meter In Date 09/17/2013 Closed 10/30/2013 Problem Install computer stand. - Assemble and install computer stand.(costomer supplied) 2.00 Labor Parts 2.00 Total Workorder Meter In Date 10/07/2013 Closed 11/12/2013 Problem Control vavle froze up. - Replace rusted outrigger control valve. - Clean outrigger control valve compartment. Control Valve 4 Way L 2 S 1.00 Freight Charge Labor Parts Total Workorder Meter In Date 11/27/2013 Closed 12/12/2013 Problem Won't run. - Diagnose no power complaint. Replace damaged air tube from intercooler to turbo. - From Fm to Gua yard 2x's Air Tube Labor Parts Total

5 Workorder Meter In Date 01/13/2014 Closed 01/15/2014 Problem Flat Tire - R&r Both Rr tires Tire Disposal Fee 2.00 Mnt225/70r195rc Mounted 225/70r195 Recap Labor Parts Total Workorder Meter In Date 03/18/2014 Closed 03/26/2014 Problem Pm service - Intermittent power for crane. Disassemble swivel and clean contacts. Wiper Blade Labor Parts Total Workorder Meter In Date 04/24/2014 Closed 05/01/2014 Problem Flat tire - Replace Lr tire. Check and adjust all tire pressures r19.5 Rc 1.00 Tire Disposal Fee Labor Parts Total

6 Workorder Meter In Date 06/04/2014 Closed 06/25/2014 Problem Pm service and list. - Pm crane. - Add def. - Replace shorted lights in rear light bar and tail lights. Repair taillight wire harness. - Fuel hose loose on filler neck. Def hose cut. Remove hose and clean filler neck. Reinstall hose with new clamp. Replace def hose. - Complaint of a/c not cooling. Check a/c system performance.evacuate,vacuum test and refill a/c system. No leak found. - Trailer plug and reverse alarm hanging. Remount to rear bumper. - Crane working intermittently. Remove crane swivel and clean corroded power circuit connections Labor 1, Wiper Blade 2.00 Napa Trans Filter 1.00 Hyd Fluid Tank Pahokee 5.00 Led Sup Mdl Dio 2.00 Bat Term Protector 1.00 Parts Total 1, Workorder Meter In Date 09/30/2014 Closed 10/10/2014 Problem Pm service. - Add def. - Replace front brake pads. - Replace 2 Rr tires. - Replace damaged tailpipe. - Repair broken/leaking fuel filler hose - Replace broken grease fittings on crane Labor 1, Wiper Blade 2.00 Def Fluid r19.5 Rc 2.00 Macs Chain Cable Lube 1.00 Brake Pads 1.00 Rear Exhaust Dual Outlet Pipe 1.00 Aw68 Hyd Fluid Tank Pahokee 3.00 Tire Disposal Fee 2.00 Parts 1, Total 2,555.82

7 Workorder Meter In Date 01/15/2015 Closed 02/13/2015 Problem go light - Install Go Light - R&r both batteries Led Golight With Remote 1.00 Hitch Mount Light Pole 1.00 Fuse Holder 1.00 Power Cord 1.00 Trailer Wire Battery 2.00 Fuel Line Hose Labor Parts 1, Total 2, Workorder Meter In Date 02/12/2015 Closed 02/13/2015 Problem LRIO tires - Lrio tires 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 02/23/2015 Closed 02/26/2015 Problem Pm service. - Replace missing hitch pin. - Replace damaged light bar on body. - Replace lf tire. Air Filter (gold), Air Panel 1.00 Wiper Blade 2.00 Pintle Pin W/chain 1.00 Def Fluid Led Id Bar 6 Ctrs r19.5 New w/rim 1.00 Tire Disposal Fee Labor Parts Total 1, Workorder Meter In Date 05/21/2015 Closed 05/26/2015 Problem tires - Replace Rr tires r19.5 New w/rim 2.00 Tire Disposal Fee Labor Parts Total

8 Workorder Meter In Date 06/09/2015 Closed 06/16/2015 Problem Pm service. - Battery failed load test. Replace battery. - Check a/c system. A/c clutch cycling. Poor airflow from vents. Remove blower housing and clean evap. - Add def. Wiper Blade 1.00 Def Fluid Pahokee Shop Freon 3.00 Battery 2.00 Wiper Blade Labor Parts Total 1, Workorder Meter In Date 06/29/2015 Closed 06/29/2015 Problem A/c not working. - Tow From Pa shop To Al Packer 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 06/29/2015 Closed 08/27/2015 Problem Repair a/c by Al Packer. - Repair leaking evap. by Al Packer. - Repair loose connections at power inverter. - Adjust door locks as needed. - Extend vise mount and install new vise Combo Vise Rigid Labor Parts Total 1, Workorder Meter In Date 07/13/2015 Closed 07/16/2015 Problem Transport. - Tow From Al Packer To Pa shop 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 09/03/2015 Closed 09/10/2015 Problem Check engine light. - Check dtc's. P02033, P246e,p2479 present. Clear dtc's. Check egt sensor pids. - Replace #2 egt sensor. Sensor Labor Parts Total

9 Workorder Meter In Date 12/21/2015 Closed 12/31/2015 Problem Pm service. - Add def. Air Filter (gold), Air Panel " Wiper Blade Labor Parts Total Workorder Meter In Date 12/29/2015 Closed 01/05/2016 Problem Trailer plug - Check trailer plug circuit and wiring. Replace shorted fuse for trailer plug. Replace lh turn signal bulb. - Air compressor won't run. Remove and clean carb and fuel tank. - Test run air compressor. Bulb Labor Parts 2.75 Total Workorder Meter In Date 03/11/2016 Closed 03/11/2016 Problem 1 - Key(s) issued Key(s) issued Duplicate Vehicle Keys Labor Parts 3.00 Total Workorder Meter In Date 03/30/2016 Closed 04/05/2016 Problem Flat tire - Replace lf tire. - Check engine light on. P21bo dtc present. Clear dtc. Replace dpf pump and sending unit r19.5 G Tire New 1.00 Reservoir 1.00 Def Pump 1.00 Tire Disposal Fee Labor Parts 1, Total 1, Workorder Meter In Date 03/31/2016 Closed 03/31/2016 Problem Flat tire. - Tow From Gua yard To Pa shop 0.00 Labor 0.00 Parts 0.00 Total 0.00

10 Workorder Meter In Date 06/02/2016 Closed 06/08/2016 Problem Pm Service - Replaced damaged taillights. Air Filter (gold), Air Panel " Wiper Blade 2.00 Lamp Kit Labor Parts Total Workorder Meter In Date 06/28/2016 Closed 07/11/2016 Problem List. - Add def. - Golight not working. Replace shorted fuse. - Crane not working. Replace broken crane power switch. - Replace broken tailgate hinge. Toggle Switch 1.00 Tailgate Knee Brace /2x1/2 Shldr Bolt 2.00 Washer 2.00 Lock N Ut 3/ Freight Charge Labor Parts Total Workorder Meter In Date 08/15/2016 Closed 08/17/2016 Problem Cranne not working,taillight not working. - Repair damaged crane wiring harness. - Repair damaged taillight wiring harness. - Test run to check crane operation Labor Parts 2.00 Total Workorder Meter In Date 09/27/2016 Closed 10/12/2016 Problem Low tire. Compressor pull rope. - Replace Rf tire. - Repair pull starter for air compressor. Sarter Handle r19.5 New w/rim 1.00 Tire Disposal Fee Labor Parts Total

11 Workorder Meter In Date 10/04/2016 Closed 10/04/2016 Problem transport - Tow From Al Packer To Pa shop 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 10/17/2016 Closed 10/20/2016 Problem Check brakes,add def. - Replace worn rear brake pads,rotors and wheel seals. - Crane Pm. - Crane power fuse shorted. Replace fuse. Repair damaged crane power wire. Ford Original Brake Pads 1.00 Brrf3 Rear Rotor Moto 2.00 Napa Oil Seal " Wiper Blade 2.00 Used Fire X Refurbished qt Syngear Oil Labor Parts Total 1, Workorder Meter In Date 12/20/2016 Closed 12/27/2016 Problem Add DEF - Top Def Blue Df Labor Parts Total Workorder Meter In Date 01/09/2017 Closed 01/10/2017 Problem Add DEF. - Add def. Def Fluid Labor Parts Total 78.94

12 Workorder Meter In Date 02/17/2017 Closed 03/31/2017 Problem Mount Compressor - Install aircompressor/ generator, and reels. Plumbed it all in - Def - Pulled and cleared codes Labor 1, Tube-nylon-black ext cord 10' 12/3ga 1.00 Bulk Battery Cable Fab/loom Fab Loom-split Poly Cb Cir Brkr 1.00 Push Pull Switch 2.00 Lh Drill Bit ext cord 25' 12/3ga 1.00 Clr Rtv Silcn Sealant 1.00 Def Bulk Qts Parts Total 1, Workorder Meter In Date 03/30/2017 Closed 04/18/2017 Problem Pm service, check engine light. - Replace cracked power cord for spotlight. - Batteries failed load test. Replace batteries. - Check engine light on. Check dtc's. Dtc Po272 present. Sent to Al Packer for repair. - Fm to Al Packer. 22" Wiper Blade 2.00 Air Filter (gold), Air Panel 1.00 Def Fluid Lift-support 2.00 Battery 2.00 Power Cord 1.00 Freight Charge Labor Parts Total 1, Workorder Meter In Date 04/11/2017 Closed 05/10/2017 Problem Engine running rough. - Repair by Al Packer 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 04/25/2017 Closed 04/25/2017 Problem Transport - Tow From Al Packer To Pa shop 0.00 Labor 0.00 Parts 0.00 Total 0.00

13 Workorder Meter In Date 05/24/2017 Closed 05/24/2017 Problem Running rough - Tow From Pa shop To Al Packer 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 07/03/2017 Closed 07/03/2017 Problem Transport. - Tow From Al Packer To Vista 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 08/01/2017 Closed 08/01/2017 Problem Transition Prep Charge - Transition Prep Charge 2.00 Labor Parts 0.00 Total