Palm Beach County Fleet Management Asset Maintenance History

Transcription

1 GMC YUKON Suv, Large, 4X4, W/Hatchback Workorder Meter 283 In Date 06/01/2005 Closed 06/13/2005 Problem ORDER FLOOR MATS - Parts Only Floor/mats Floor/mats Labor 0.00 Parts Total Workorder Meter 0 In Date 06/14/2005 Closed 06/14/2005 Problem WASH VEHICLE - Wash Vehicle - Pre-delivery Inspection - Make Duplicate Keys For New Vehicle 2.80 Labor Parts 0.00 Total Workorder Meter 0 In Date 06/14/2005 Closed 06/16/2005 Problem 001 WASH TICKET ISSUED OUT 06/14/ Wash Ticket Issued Out 06/14/ Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter 2085 In Date 11/01/2005 Closed 11/02/2005 Problem CHECK ENGINE LIGHT ON - Comp Sys Diagnosis; P0442; Small Leak;clear Code;test Drive 1.00 Labor Parts 2.00 Total Workorder Meter 0 In Date 11/02/2005 Closed 11/03/2005 Problem 003 WASH TICKETS ISSUED OUT 11/02/ Wash Tickets Issued Out 11/02/ Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter 2532 In Date 12/16/2005 Closed 12/19/2005 Problem P.M.SERVICE - Pm Service 10w30 Motor Oil Labor Parts Total

2 Workorder Meter 5695 In Date 07/07/2006 Closed 07/10/2006 Problem P.M.SERVICE - Pm Service 10w30 Motor Oil Labor Parts Total Workorder Meter 0 In Date 07/10/2006 Closed 07/26/2006 Problem ALVIN MATTHEWS PAINT & BODY - Alvin Matthews Paint & Body 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter 8390 In Date 01/24/2007 Closed 01/29/2007 Problem P.M SERVICE - Perform Pm Service Complete - Perform Nitrogen Tires Inflation Service On All Tires. - High Speed Balance All Tires To Correct Vibration Over 45 Mph - Perform Wheel Alignment Complete To Correct Improper Tire Wear On Ront Tires Air Filter Frm Ca8755a Wix w30 Motor Oil Labor Parts Total Workorder Meter 0 In Date 03/09/2007 Closed 03/13/2007 Problem 001 WASH TICKET ISSUED OUT 03/09/ Wash Ticket Issued Out 03/09/ Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 06/13/2007 Closed 06/14/2007 Problem FLAT TIRE IN GOVT CTR. GARAGE 3RD FLOOR - Travel To And From Govt. Center - R/r Left Rear Tire And Mount Spare 1.50 Labor Parts 2.00 Total Workorder Meter In Date 06/15/2007 Closed 06/21/2007 Problem CHECK TIRES - Repair Left Rear Tire 1.00 Labor Parts 2.00 Total 57.00

3 Workorder Meter In Date 07/24/2007 Closed 07/30/2007 Problem FLAT TIRE GOVT CTR GARAGE L/R - Travel To Govt Center Garage Inflate Tire, Return To Lv Shop For Repair 1.50 Labor Parts 2.00 Total Workorder Meter In Date 07/25/2007 Closed 07/27/2007 Problem L/F TIRE FLAT - Pm Service - Repair Left Rear Tire. - Balance All 4 Tires And Refill With Nitro Air Filter Frm Ca8755a Wix Labor Parts Total Workorder Meter In Date 02/27/2008 Closed 03/04/2008 Problem P.M. SERVICE. - Pm Service - Rotate And High Speed Balance Four Tires Refill With Nitrogen Air And Road Test Injector Cleaner Don't Reorder Labor Parts Total Workorder Meter In Date 09/02/2008 Closed 09/09/2008 Problem P.M SERVICE - Perform Pm Service - Rotate & High Speed Balance All 4 Tires. - Complete Front End Alignment Air Filter Frm Ca8755a Wix Labor Parts Total

4 Workorder Meter In Date 03/11/2009 Closed 03/16/2009 Problem P.M SERVICE - Pm Service - Ck Battery And Charging System.r&r Defective Battery. - Replace 2 Tires.mount On Front High Speed Balance All 4 Tires.nitro Fill Tires. - Service Trans. Flush & Refill. - Diagnose Knock Noise In Steering.remove Intermediate Steering Shaft.lube & Reinstall.test Drive. Syn/atf Trans Fluid Synthetic Wiper Blades 16" Wiper Blade 1.00 Group 78 Battery (acd 78ps) 1.00 Tire Disposal Fee P245/75r16 Fortera Sil Arm 109t Sl Labor Parts Total Workorder Meter 0 In Date 05/07/2009 Closed 05/08/2009 Problem 002 WASH TICKETS ISSUED OUT 05/07/ Wash Tickets Issued Out 05/07/ Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 12/14/2009 Closed 12/31/2009 Problem P.M service. - Replace and reprogram defective key fob. - Repair one tire,rotate and balance all. Key Fob Transmitter Labor Parts Total Workorder Meter In Date 01/22/2010 Closed 02/11/2010 Problem damage to hhod, grille, bumper rgt lght, rgt frt fender & under hood - damage to hhod, grille, bumper rgt lght, rgt frt fender & under hood 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 06/17/2010 Closed 06/23/2010 Problem Pm service also see notes on flat tire. - Replace and balance four tires. - Pressure test and inspect cooling system.flush and refill system. - Complete front end alignment. Antifreeze Ext/life All Makes (peak 407) P245/75r16 Fortera Sil Arm 109t Sl 2.00 Tire Disposal Fee Labor Parts Total

5 Workorder Meter In Date 07/20/2010 Closed 07/20/2010 Problem 2 - Wash ticket(s) issued Wash ticket(s) issued 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 12/06/2010 Closed 12/14/2010 Problem P.M. service. - Perform pm service. - Rotate and balance all four tires Air Filter Frm Ca8755a Wix Wiper Blades 16" Wiper Blade Labor Parts Total Workorder Meter In Date 02/01/2011 Closed Problem P.M. service Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 03/14/2011 Closed 03/14/2011 Problem 2 - Wash ticket(s) issued Wash ticket(s) issued 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 07/22/2011 Closed 08/04/2011 Problem P.M. service. - Perform pm service. - Rotate and balance all four tires Wiper Blades 16" Wiper Blade Labor Parts Total Workorder Meter In Date 01/31/2012 Closed 02/09/2012 Problem P.M. Service. - Test battery and charging system.replace bad battery. - Rotate and balance all tires. Group 78 Battery (acd 78ps) Labor Parts Total

6 Workorder Meter In Date 04/11/2012 Closed 04/16/2012 Problem Left rear brake light inop. - Replace left brake light bulb Tail Light Bulbs Labor Parts 0.60 Total Workorder Meter In Date 08/03/2012 Closed 08/24/2012 Problem Pm service and burning smell when ac is on #3 speed. - Resurface front and rear brake rotors,replace brake pads.service and lube calipers.flush and bleed system.test drive. - Check burning smell.replace burnt blower resistor and harness.replace blower motor. - Replace rear window washer pump. - Rotate and balance all tires Brake Clean 1.00 Rear Pads 1.00 Front Pads 1.00 W/washer Pump 1.00 Blower Motor 1.00 Resistor 1.00 Pigtail Labor Parts Total 1, Workorder Meter In Date 11/14/2012 Closed 11/14/2012 Problem 0 - Wash ticket(s) issued Wash ticket(s) issued 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 11/14/2012 Closed 11/14/2012 Problem 2 - Wash ticket(s) issued Wash ticket(s) issued 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 02/26/2013 Closed 03/11/2013 Problem P.M. service. - Replace center brake light. - Rotate and balance all tires Wiper Blades Wiper Blades Lamp Labor Parts Total

7 Workorder Meter In Date 04/30/2013 Closed 05/03/2013 Problem Right rear tire flat,damage beyond repairs. - Install two new tires to the rear wheels.nitrogen fill and balance both Lt245-75r Tire Disposal Fee Labor Parts Total Workorder Meter In Date 09/04/2013 Closed 09/20/2013 Problem Pm service - Replace worn out intermediate steering shaft. - Replace left front tire prssure sensor.rotate and balance all four tires. Wiper Blade Wiper Blades Napagold Air Filter 1.00 Inter Steering Shaft 1.00 Heat Ac Actuator Motr 1.00 tire presure sensor Labor Parts Total Workorder Meter In Date 11/06/2013 Closed 11/06/2013 Problem 1 - Wash ticket(s) issued Wash ticket(s) issued 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 11/21/2013 Closed 11/27/2013 Problem Low tire pressure warning light on and secure trim on right of front bumper. - Repair and secure trim on right side of front bumper.set all tire pressure to specs and retrain sensors.add one enginseal oil treatment to crankcase. Engine Seal 12oz Locktite Epoxy Labor Parts Total Workorder Meter In Date 02/10/2014 Closed 02/10/2014 Problem Brakes smoking - Tow From stormwater one east...next to C51 Canal To Lv shop 0.00 Labor 0.00 Parts 0.00 Total 0.00

8 Workorder Meter In Date 02/19/2014 Closed 02/27/2014 Problem Towed in brakes smoking. - Resurface rear brake rotors.replace frozen brake calipers and pads.service and lube slides,flush and bleed system and test drive. Reman Brake Caliper 1.00 Reman Brake Caliper 1.00 Brake Pads Brake Fluid Bra Labor Parts Total Workorder Meter In Date 03/31/2014 Closed 04/15/2014 Problem P.M. service. - Perform pm service. - Remove left front door.fabricate and replace upper and lower door hinge bushings with new. - Inspect and replace both serpentine belt and ac compressor belt with new. - Inspect and replace broken left headlamp housing/bracket with new.fabricate mounting brackets and adjust beam. - Rotate and balance all four tires. Wiper Blade 2.00 Wiper Blade 1.00 Fleetrunner Belt 1.00 Fleetrunner Belt 1.00 Pin Kit 2.00 Bracket Labor Parts Total 1, Workorder Meter In Date 05/07/2014 Closed 05/08/2014 Problem Left turnsignal lights inop - Test and replace failed left turnsignal lamp bulb with new. Bulb Labor Parts 0.99 Total Workorder Meter In Date 09/05/2014 Closed 09/05/2014 Problem 1 - Key(s) issued Key(s) issued Duplicate Vehicle Keys Labor Parts 3.00 Total 15.00

9 Workorder Meter In Date 09/30/2014 Closed 10/27/2014 Problem Pm service. - Test battery and charging system.replace bad battery. - Replace two tires and one defective Tpms.rotate and balance all four and retrain sensor. - Complete wheel alignment.test drive. Wiper Blade 2.00 Mac Wite Lithium Gres 1.00 Group 78 Battery 1.00 Lt245 75r tire presure sensor 1.00 Tire Disposal Fee Labor Parts Total 1, Workorder Meter In Date 04/15/2015 Closed 04/28/2015 Problem Pm service. - Pm service. - Test and replace defective left backup lamp bulb. - Rotate and balance all four tires. Wiper Blade 2.00 Wiper Blade 1.00 Washer Fluid Concentr 1.00 Bulb Labor Parts Total Workorder Meter In Date 04/17/2015 Closed 05/11/2015 Problem damage to lft frt door - damage to lft frt door 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 05/14/2015 Closed 05/27/2015 Problem remove decals/ get ready for surplus - Remove decals and get ready for transfer 2.00 Labor Parts 2.00 Total Workorder Meter In Date 05/14/2015 Closed 05/14/2015 Problem 1 - Detail Vehicle Wash Ticket(s) Issued Detail Vehicle Wash Ticket(s) Issued 0.00 Labor 0.00 Parts 0.00 Total 0.00

10 Workorder Meter In Date 05/14/2015 Closed 05/14/2015 Problem Transition Prep Charge - Transition Prep Charge 2.00 Labor Parts 0.00 Total Workorder Meter In Date 06/24/2015 Closed 06/30/2015 Problem radio antenna broken - R/r broken radio antenna base and missing antenna - Repair short back up ramp Antenna 1.00 Base 1.00 Bulb Labor Parts Total Workorder Meter In Date 06/30/2015 Closed 06/30/2015 Problem 1 - Detail Vehicle Wash Ticket(s) Issued Detail Vehicle Wash Ticket(s) Issued 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 07/29/2015 Closed 07/31/2015 Problem alignment - alignment - car wash 3.50 Labor Parts 0.00 Total Workorder Meter In Date 08/05/2015 Closed 08/05/2015 Problem 1 - Wash ticket(s) issued Wash ticket(s) issued 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 09/17/2015 Closed 09/24/2015 Problem pm service - Pm - Clean an d readjust parking brake - Wash 4.75 Labor Parts Total Workorder Meter In Date 09/24/2015 Closed 09/24/2015 Problem 1 - Wash ticket(s) issued Wash ticket(s) issued 0.00 Labor 0.00 Parts 0.00 Total 0.00

11 Workorder Meter In Date 11/17/2015 Closed 11/30/2015 Problem check eng light, front brakes pulsate - Ck engine light on. Computer scan & Road Test, perform evap sys test and replace canister vent solenoid and gas cap - Brake pulsation, replace frt rotors pads calipers and bleed sys. Road Test Brake Rotor 2.00 Reman Brake Caliper 1.00 Reman Brake Caliper Brake Fluid Bra 1.00 Brake Cleaner 1.00 Disc Brake Pads 1.00 fuel vent valve 1.00 cap asm Labor Parts Total Workorder Meter In Date 12/03/2015 Closed 12/03/2015 Problem 1 - Wash ticket(s) issued Wash ticket(s) issued 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 01/14/2016 Closed 01/29/2016 Problem pm service - Pm - r/r rear window and hatch lift struts - Travel to carwash and back 22" Wiper Blade 2.00 Washer Fluid Concentr 1.00 Lift-support 2.00 Lift Support Liftgate 2.00 U-groove Spark Plug 1.00 Wiper 1.00 Napagold Air Filter 1.00 Lift Strut 1.00 Lift Strut Labor Parts Total Workorder Meter In Date 01/21/2016 Closed 01/21/2016 Problem 1 - Wash ticket(s) issued Wash ticket(s) issued 0.00 Labor 0.00 Parts 0.00 Total 0.00

12 Workorder Meter In Date 06/28/2016 Closed 07/11/2016 Problem pm service - Pm - Left rear tire repair - Wash - Alignment Service 22" Wiper Blade 2.00 Washer Fluid Concentr 1.00 Wd40 16oz Labor Parts Total Workorder Meter In Date 08/18/2016 Closed 08/24/2016 Problem front end shakes & check tires - Replace 2 frt tires mount and balance and nitro - Repalce all four camber bolts and nuts - Alignment service - Wash - Replace right rear brake light bulbs Lt245 75r Camber Adjust Kit 2.00 Bulb 2.00 Tire Disposal Fee Labor Parts Total Workorder Meter In Date 08/25/2016 Closed 08/25/2016 Problem 1 - Wash ticket(s) issued Wash ticket(s) issued 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 02/23/2017 Closed 02/27/2017 Problem pm service, low tire light, cant fuel, gas comes out while fueling - Pm - Replace tire pressure sensor and Retrain all sensors - R&r fule vent hose between tank and filler neck and cleared out and top off fuel tank Napagold Air Filter " Wiper Blade 2.00 Wiper 1.00 Napa 10w30 Qt 6.00 tire presure sensor Labor Parts Total Workorder Meter In Date 06/08/2017 Closed 06/15/2017 Problem List. - No start. Battery failed load test. Replace battery. - Can't fuel vehicle. Checked fuel tank vent and evap lines. Replace clogged emissions canister. - Test drive 2x's. Battery 1.00 Charcoal Caniser Labor Parts Total

13 Workorder Meter In Date 08/29/2017 Closed 08/30/2017 Problem Pm service, list. - Pm service. - Replace Rf tpms sensor. Sensor not communicating. Rotate and balance tires - Idler pulley squealing. Replaced idler pulley. - Check a/c operation. Temp actuator working intermittently. Replaced temp actuator. - Test run. Napa 10w30 Qt 6.00 Washer Fluid Concentr " Wiper Blade 2.00 Wiper 1.00 tire presure sensor 1.00 Pulley Idler 1.00 Actuator Labor Parts Total Workorder Meter In Date 04/10/2018 Closed 04/16/2018 Problem Pm service. - Pm service. - Rotate and balance tires. - Test drive. Napa 10w30 Qt 6.00 Napagold Air Filter 1.00 Washer Fluid Concentr " Wiper Blade 2.00 Wiper Labor Parts Total Workorder Meter In Date 07/25/2018 Closed 08/02/2018 Problem Oil leak, no steering. - Replace leaking power steering cooler. - Test drive. Power Steering Oil Cooler Labor Parts Total Workorder Meter In Date 07/26/2018 Closed 07/26/2018 Problem No steering. - Tow From Us27 South Bay To Pa shop 0.00 Labor 0.00 Parts 0.00 Total 0.00 Workorder Meter In Date 09/21/2018 Closed 09/21/2018 Problem Transition Prep Charge - Transition Prep Charge 2.00 Labor Parts 0.00 Total