Zip's Truck Equipment. 316 W. Milwaukee Street New Hampton, Iowa Phone: Fax: Visual Inspection.

Transcription

1 Zip's Truck Equipment 316 W. Milwaukee Street New Hampton, Iowa Phone: Fax: Visual Inspection Page: 1 of 6 Customer: Division: null Address: Phone: Reference #: 1GBKC34J9VJ Equipment Type: Light-Duty Tow Truck Order #: Event Performed: Light Duty Wrecker Inspection Inspected On: 06/06/16 2:19 PM CDT Result: Pass Total Score: Inspected By: : Iowa Inspector Shop Light-Duty Tow Truck- * Year: 1997 * Make: Chevrolet * Model: 3500HD * Engine Make: Vortec * Engine Model: 454 * Fuel Type: Gas * Transmission Type: Automatic * Odometer Reading: 106,112 * GVW: 15,000# * GAWR Front: 5,000# * GAWR Rear: 11,000# * Cab Trim Package: Silverado * Cab to : 84" * Wheel Base: 162" Wheel Type: * Cab Color ONLY: Blue * Body Make: Holmes * Body Model: Body Width: 86" * Beacon/Lightbar Make: * Beacon/Lightbar Model: PTO Type: Switch Panel & # Of Switches: Stainless Steel Wheel Simulators Public Safety Force 4 LP 6000 Hot Shift Switch Panel - 6 * Wrecker Body/Pylon Color: Blue/Red * Brake Type: Hydraulic * Suspension Type: Spring * Air ing: * Radio: AM/FM/Cassette * Driver Seat: Windows: Door Locks: Cruise Control: Tilt Steering Wheel: Flooring: Floor Mats: Split Cloth w/head Rests & Center Console Power Power Rubber or Vinyl * Bumper: Chrome Grille: Cab Fenders: Running Boards/Nerf Bars: Mirrors: Cab Roof Marker Lights: Rubber or Vinyl Chrome Fiberglass Fenderettes Running Boards Below Eye Swing Out * Tire Size-Front: 225/70R19.5 Tire Depth-Front: 7/32" * Tire Size-Rear: 225/70R19.5 Tire Depth-Rear: 12/32" # of Winches: 2 Winch Brand: Winch Clutch Release: Ramsey

2 Page: 2 of 6 Cable Tensioner: Pylon: Work Lights: Stop/Turn/Tail On Pylon: Toolbox System: Standard Steel LH & RH Tunnel Toolbox/Size: - 24" Lighted Toolboxes: Dual Controls: Light Plug Ins: Hook Up Lights: CR6 * Wheel Lift: with L-Arms Wheel Lift Style: Basic L-Arm Style Engine Check Ability to Start Engine Blow-By Check Engine Engine Noise Engine Warning Lights Engine Water Leaks Performance Engine Mounts Other Engine Engine Brake Starts No Noticeable Blow-By Issue Engine sounds are normal No Check Engine Lights are on No Water Leaks -The front and rear of oil pan has a small leak -The throttle sticks Batteries of Cables of Batteries Load Testing Pass Cooling System Radiator Fan Fan Clutch Fan Shroud Water Hoses Fan Belt Other Cooling Automatic Transmission Check Transmission Operation Other Transmission Manual Transmission Check Shifting Clutch Operation Throw-Out Bearing Transmission Noise Other Transmission Overall Body Transmission -It has a leak Overall Body Other Overall Body notes Cab Exterior Hood Right Fender Left Fender Grille Back of Cab Driver Side Door Passenger Side Door Roof Other Cab Exterior Fuel Tank Appearance Entry Steps Head-Light Doors Battery Box Driver Side Door Hinges Passenger Side Door Hinges -It is loose -The bottom left cab corner has a rust hole also both rocker panels are rusty -It is a little loose Glass Windshield Driver Side Window Passenger Side Windw Back Window Other Glass Overall Interior Other Overall Interior -Has a small chip in the middle -Right mirror is loose Interior Drivers Seat Passenger Seat Rear Seat Floor Mat Instrument Cluster Dash Door Panels Electric Door Locks Electric Windows Other Interior Air Vents Door Handles Other Interior Operate Properly -The seat has a cover but there is a tear in the seat left side -It has a hole in it left side also the the floor has a rust hole left side -Gas gauge jumps around -Brake petal is worn Windshield Wipers Wiper Arms Wiper Blades Washer Tank Washer Control Switch

3 Page: 3 of 6 Heating Heater Controls Fan Motor Heater Other Heat Heats Appropriately Air ing Air ing Controls Electrical System- Chassis Interior lights Turn Signals Head Lights Alternator Guages Dash Lights Cab Marker Lights Back-Up Lights Back-Up Alarm 4-Way Flashers Windshield Wipers Other Electrical System Cruise Control Engine Throttle All Interior Light Operate Operate Operate Performs Dash Lights Perform Marker Lights Perform Operate Performs Perform -Don't work -Gas gauge jumps around -Don't work Drive-Line U-Joints Rear Differential Transfer Case Other Drive-Line Hangar Bearings Brakes Air Compressor System Air Leaks Applied Brakes Brake Adjusters Air Lines Low Air Pressure Warning Front Brake Drums Pusher Brake Drums Front Brake Calipers Front Drive Brake Drums Front Brake Linings Rear Drive Brake Drums Rear Brake Calipers Pusher Brake Linings Front Drive Brake Linings Rear Drive Brake Linings Emergency Brake Brake apply normally 60 or Better Performs -It might make the throttle stick -Has some oil in the front by drive shaft -Have to pull wheels to check Brakes ABS Light Brake Pedal Pads Other Brake Air Dryer Showing Normal (Not on) -It is worn Wheels Front Rims/Wheels Pusher Rims/Wheels Front Drive Rims/Wheels Rear Drive Rims/Wheels Fronts Nut and Studs Pusher Nut and Studs Wheel In Good Wheel In Good Front Drive Nuts and Studs (2) (2) Rear Drive Nuts and Studs Wheel Simulators Front Wheel Simulators Pusher Wheel Simulators Front Drive Wheel Simulators Rear Drive Aluminum Wheels Front Aluminum Wheels Pusher Aluminum Wheels Front Drive Aluminum Wheels Rear Drive Wheel Hubs Front Wheel Seals Front Drive Wheel Bearings Front Wheel Bearings Pusher Wheel Seals Front Drive Wheel Seals Oil Filled Hubs Front Drive Rear Drive Wheel Seals Oil Filled Hubs Front Pusher Wheel Bearings Oil Filled Hubs Pusher Oil Filled Hubs Rear Drive Rear Drive Wheel Bearings Not Adjusted but No Issue Visible Checked In Good Tires Front Pusher Front Drive Rear Drive on Tires Tread is less than 50% 60% or Better Exhaust Systen Manifold Exhaust Tubing Muffler DPF System Emnsions Warning Light Showing Normal -Rear down spout is missing

4 Page: 4 of 6 Exhaust Systen Exhaust Shield Exhaust Stack Exhaust Mounting Bracket In Good Condtiion Frame Integrity of Frame In good Suspension Air Bags Air Leaks Air Lines Spring Packs Front Spring Hangars Rear Spring Hangars Radius Arms Rear Suspension Bushings Air Leveling Valve Steering and Front Steering Pump Steering Lines Steering Sector King Pins/Ball Joints Steering Shaft Pitman Arm Drag Link Tie Rod Toe in Check 4x4 Hubs Steering Wheel Steering Wheel Position In Good Operating In Good Operating Not Checked Wheel In Good Condtion Wheel is Centered When Driven -The cross member behind the tranny has a rust hole -It has some wear Fuel System Fuel Gauge Fuel Tank Fuel Fill Fuel Lines Fuel Filter Glow Plugs or Exhaust Heater Glow Plug Operation Intake Manifold Heater Fills Not Replaced -It jumps around Fluids Windshield Washer Engine Oil Radiator Anti-Freeze Transmission Fluid Transfer Case Oil Front Drive Rear Drive Battery Acid Levels Hydraulic Oil Brake Fluid Not Checked Appears That It Needs to be Changed also check to -20 Fluids Power Steering Fluid Winch 1 Oil Winch 2 Oil Winch 3 (Above Cab) Oil Filters Water Filter Engine Oil Filter Transmission Oil Filter Fuel Filter Carrier Hydraulic System Overall Wrecker Body Overall Condtion Wrecker Body Body Sides Condtion Body Deck Front of Body Conditon Body Side Side Rail Cap Conditon (2) Driver Side Tool Box 1 Conditon Passenger Side Tool Box 1 Conditon Tunnel Tool Box 1 Conditon Tail-Board Not Changed Power Take-Off Operation PTO Warning Light Shifting Mechanism Air Leaks No In Good Operating Electrical Switch Working Properly Hyraulic Pump Operation Pump Pressure Pump Flow No Pump Not Tested Controls & Valve Operation Control Levers and Rods Knobs Hydraulic System Hoses Hydraulic System Leaks Winch Hoses Boom Lift Cylinder Hoses Boom Extension Cylinder Hoses Wheel-Lift Tilt Cylinder Hoses Wheel-Lift Extend Cylinder Hoses (2) Leaks From Fittings In Operating No No No No No

5 Page: 5 of 6 Hydraulic System Leaks Wheel-Lift Up/Down Cylinder Hoses (2) Hydraulic Pump Hoses Hydraulic Filter Bed Lift Cylinders Extend Cylinder Wheel-Lift Tilt Cylinder Wheel-Lift Extend Cylinder Wheel-Lift Claw Cylinder Drivers Side Wheel-Lift Claw Cylinder Passenger Side No No No No No Cylinder Conditon Boom Lift Cylinder Boom Extend Cylinder Wheel-Lift Extend Cylinder Wheel-Lift Tilt Cylinder Wheel-Lift Lift Cylinder Wheel-Lift Lift Claw Cylinders Pylon Winch Free-Wheel Mechanism Winch 1 Free-Wheel Mechanism Winch 2 Free-Wheel Mechanism Winch 3 Housing Winch 1 Housing Winch 2 Housing Winch 3 Operation Without Load Operation Without Load Test Operation Loaded Test Operation Winch 1 Cable Winch 2 Cable Winch 3 Cable No Performs Wheel-Lift L-Arms/Scoops L-Arm Straps L-Arm Storage Driver Side Claw Passenger Side Claw Driver Side Slide Tray Passenger Side Slide Tray Passenger Side Slide Tray Locks Driver Side Slide Tray Locks Driver Side Front Stops (Vulcan) Passenger Side Front Stops (Vulcan) Driver Side L-Arm Swivel Passenger Side L-Arm Swivel Center Pivot Pin and Bushing -They are missing Wheel-Lift Wheel-Lift Cross-Bar Pins and Bushings Extension Tube Outer Wheel-Lift Assembly Wheel-Lift Swivel Lock Pins Wheel-Lift Swive Removeable Lock Pins Scoop Locking Pins and Chains Driver Side Claw Cylinders Main Pivot Pin for Tilting Wrecker Electrical Systems Switch Panel Overall Wiring Bed Wiring Harness Junction Boxes Marker Lights Driver Side Turn Signals Upper Passenger Side Turn Signals Upper Driver Side Turn Signals Upper Lower Passenger Side Turn Signals Lower Extra Warning Lights Extra Clearance Lights UpperWork Lights Lower Work Lights Work Lights Mounted Near Winch Beacon Light 2 Beacon Light 3 Beacon Light 1 Tow Light Plug at Tail-Board Not Checked -One out right side Tool Boxes Box Driver Side 1 Box Driver Side 2 Box Passenger Side 1 Box Passenger Side 2 Fenderettes Drivers Side Passenger Side Wrecker Lubrication Lift Cylinder Pins Tilt Cylinder Pins Wheel-lift Tilt Pin Wheel-Lift Cross-Bar Pivot Pin Upper Wheel-Lift Extension Slide Pads Lower Wheel-Lift Extension Slide Pads (2) Wheel-Lift Lift Tower Wear Pads Wheel-Lift Arm Pins and Bushings Tool Box Hinges and Latches In Need of Lubrication -It needs mudflaps -They are worn -They are worn Chains

6 Page: 6 of 6 Chains Rear Safety Chains J-Hook Chains Tow Sling Sling Arms Sling Belts Top Lift Bar Lower Lift Bar Chassis Lubrication King Pins/Ball Joints Tie-Rod Ends Drag Link Steering Shaft Drive-Line U-Joints Spring Shackles Door Locks and HInges -Need to lube and check keys Wrecker Mounting System Front Bed Mounting Brackets Rear Bed Mounting Brackets (2) Brackets and Bolts in Good Brackets and Bolts in Good Shock Absorbers Front Shocks Rear Shocks Rusty